- CQV Co., Ltd. v. Merck Patent GmbHNo claims unpatentablePTAB · Oct 14, 2025 · PGR2021-00054 · APJ Kristina M Kalan · PGR · Remand
Claims 1–22 were not shown unpatentable because Sample C was not proven publicly available as prior art, and the original decision found the remaining grounds insufficient.
RulingsRemand decision- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication not establishedNot shown unpatentable
“We agree with Patent Owner that Petitioner’s evidence in Kuntz (Ex. 1026), the Annual Report (Ex. 1028), Masuko (Ex. 1029), and Pfaff (Ex. 1034) is insufficient to show that Xirallic® Sample C was available to the public before the effective filing date of the ’861 patent. Petitioner has not asserted, nor do we find, that any of these documents refer to or describe the lot of Xirallic® from which Sample C was taken. See Final Dec. 26. Kuntz, the Annual Report, Masuko, and Pfaff may support a finding that the Xirallic® line of products was available to the public, but these documents do not support a finding that the lot of Xirallic® from which Sample C was taken was available to the public. We also agree with Patent Owner that the Technical Data Sheets (Exs. 1005–1010), Certificates of Analysis (Exs. 1011–1017), and Material Safety Data Sheet (Ex. 1025) are insufficient to show that Xirallic® Sample C was available to the public. Petitioner has not asserted, nor do we find, that any of these documents refer to or describe the lot of Xirallic® from which Sample C was taken. See Final Dec. 26–27. Regardless of how the Technical Data Sheets were used in the Opposition against the European counterpart of the ’861 patent (Exs. 1040, 1041) and during the prosecution of the application from which the ’861 patent issued (Ex. 1003, 102–104), the Technical Data Sheets do not refer to or describe the lot of Xirallic® from which Sample C was taken. Moreover, as noted by Patent Owner, the Technical Data Sheets (Exs. 1005–1010) indicate that they are “preliminary” and Petitioner has not provided any evidence that the Technical Data Sheets were ever issued to the public, as opposed to just issued internally. See PO Resp. 18–19. We also find persuasive Patent Owner’s argument that the Technical Data Sheets are preliminary because other, later-dated technical data sheets (Exs. 2012, 2013) lack the “preliminary” label and list characteristics that are different from those in Exhibits 1005–1010. See PO Resp. 19 (comparing, e.g., Ex. 1009 and Ex. 2013; Ex. 1005 and Ex. 2012). The Technical Data Sheets may support a finding that the Xirallic® products they describe existed as of the dates on the documents, but they do not support a finding that the lot of Xirallic® from which Sample C was taken was available to the public.” slip op. at 20
- Expert testimonyPetitioner expert discountedPatent owner expert creditedOther
“witnesses. See Elbit Systems of Am., LLC v. Thales Visionix, Inc., 881 F.3d 1354, 1358 (Fed. Cir. 2018) (citing Trs. of Columbia Univ. v. Illumina, Inc., 620 F. App’x 916, 922 (Fed. Cir. 2015); Inwood Labs., Inc. v. Ives Labs., Inc., 456 U.S. 844, 856 (1982)). We have reviewed the witness testimony in the record and, more particularly, Mr. Choi’s deposition answers regarding Petitioner’s purchase of the lot of Xirallic® from which Sample C came. We find that Mr. Choi’s responses cast doubt on the credibility of his declaration testimony, namely with regard to the public availability of Sample C. Mr. Choi represented that he was involved in the purchase of the lot of Xirallic® from which Sample C was taken. Ex. 2011, 48:1–23. Mr. Choi stated that he instructed Petitioner’s marketing team manager to buy the sample from a distributor of Patent Owner’s products located in Europe. Id. at 48:24–49:4. Mr. Choi stated that he has evidence of the transaction, but refused to reveal the name of the company from which Petitioner purportedly purchased the lot of Xirallic® (id. at 49:5–50:3) and refused to produce an email in his possession that would corroborate his testimony regarding Petitioner’s acquisition of the product (id. at 50:8–16, 51:10–23). Mr. Choi represented that he does not remember how much Petitioner paid for Sample B. Id. at 56:4–5. Mr. Choi admitted that the entity from which Petitioner acquired the lot of Xirallic® from which Sample C was taken is “not currently a Merck distributor” (Ex. 2011, 50:4–7) and was not “a Merck distributor at the time” that “samples B and C were purchased” (id. at 51:25–52:2). According to Mr. Choi, the company is a “former distributor” of Patent Owner’s products. Id. at 52:3–6. Mr. Choi did not know, according to his testimony, when that unnamed entity first obtained the lot of Xirallic® (id. at 52:7–10) and he stated that he did not have personal knowledge of how the entity obtained the lot of Xirallic® (id. at 52:12–19). Instead, Mr. Choi assumed the entity was “able to obtain the sample through the routine course or process” the entity uses “to take samples or get samples.” Id. at 52:12–19. Mr. Choi believed the sample of Xirallic® from which Sample C was taken was sealed when Petitioner received it because samples from dealers are sealed, and he remembered observing that the package was from a dealer. Id. at 52:24– 54:25. However, Mr. Choi admitted that he did not obtain a technical data sheet or certificate of analysis for the lot of Xirallic® from which Samples B and C were taken. Id. at 59:6–11. Mr. Choi also answered questions regarding Petitioner’s purchase of Samples D and H. Ex. 2011, 62:20–66:8, 67:7–9, 73:12–13, 73:17–22. Similar to his testimony regarding Samples B and C, Mr. Choi admitted withholding an email regarding the purchase of the lot of Xirallic® from which Sample D was taken. Id. at 62:20–63:9. Mr. Choi also admitted that he did not know how Akzo USA or Axalta obtained the Xirallic® the companies sold to him, and admitted that Akzo USA was not a distributor of Patent Owner’s products at the time Petitioner purchased the product. Id. at 63:10–66:8, 73:17–22. Mr. Choi also admitted that Petitioner did not pay Akzo USA for the lot of Xirallic® from which Sample D was taken, and did not pay Axalta for the lot of Xirallic® from which Sample H was taken. Id. at 67:7–9, 73:12–13. Although Petitioner presents declaration testimony from Mr. Choi representing that he purchased the lot of Xirallic® from which Samples B and C were taken in October 2011 (Ex. 1004 ¶ 16), Mr. Choi’s declaration testimony lacks corroborating evidence, and his deposition testimony does not support that the product was available to the public, as we found in our Final Written Decision. See Final Dec. 27–28. Notably, Petitioner produced corroborating evidence for Mr. Choi’s acquisition of Samples A, H, and I. See Ex. 1004 ¶¶ 13 (citing Ex. 1047), 18 (citing Exs. 1024, 1025). However, Mr. Choi withheld similar evidence for the Xirallic® lots from which Samples B, C, and D were taken. See Ex. 2011, 50:8–16, 51:10–23, 62:20– 63:9; Final Dec. 28. As Patent Owner argues, there is “no information to determine when a contract was established, that there was consideration for the exchange, that the product was available to be delivered when the alleged transaction took place, or even when the product was delivered. Choi has no memory of what was paid for the product.” Sur-Reply 24–25; see also PO Resp. 13–14; PO Br. Rem. 2–4.” slip op. at 34
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“Based on the evidence discussed above, we are not persuaded that Petitioner has shown by a preponderance of the evidence that Sample C was available to the public. Regardless of whether a company avoids wasting shelf life of its products (Ex. 1004 ¶¶ 15–16), there is no persuasive evidence in the record showing that the lot of Xirallic® from which Sample C was taken was released from quality control and then made available to the public by Patent Owner. Mr. Choi’s testimony shows that Petitioner obtained the lot of Xirallic® from which Sample C was taken in an atypical manner (i.e., not from Patent Owner or one of Patent Owner’s current distributors) (Ex. 2011, 49:5–50:7, 50:8–16, 51:10–23, 51:25–52:6, 52:12– 19), and there is no evidence in the record to show that the lot of Xirallic® was intended for sale, rather than for experimental use only or for some other restricted use. Accordingly, we determine Petitioner has not demonstrated by a preponderance of the evidence that Sample C qualifies as prior art against the ’861 patent, and we determine that Petitioner has not shown by a preponderance of the evidence that the ’861 patent is unpatentable over the grounds relying on Sample C.” slip op. at 38
Patent outcomesUS 10,647,861 not shown unpatentable§ 102 anticipation§ 103 obviousnessPatents in suitUS 10,647,861 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Solus’s rehearing request, leaving institution denied for claims 1–8 because the petition did not adequately show motivation to combine Hanafusa and Dobashi.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve Dobashi’s RSm values. Dobashi teaches that because RSm “can be adopted as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66–3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66– 3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 4
§ 103 obviousnessPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - PTAB · Sep 9, 2025 · PGR2025-00023 · APJ Michael J Fitzpatrick · PGR · Institution
Instituted PGR on claims 1–9 because the Board found it more likely than not that at least one challenged claim is unpatentable over the ’629 publication.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of a post-grant review requires that “the information presented in the petition filed under section 321, if such information is not rebutted, would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable” or that “the petition raises a novel or unsettled legal question that is important to other patents or patent applications.” 35 U.S.C. § 324(a)–(b). Determining whether to institute has been delegated to the Board. See 37 C.F.R. § 42.4(a) (“The Board institutes the trial on behalf of the Director.”). Upon consideration of the Petition and the Preliminary Response, and for the reasons explained below, we determine that it is more likely than not that at least 1 of the claims challenged in the Petition is unpatentable. Accordingly, we grant the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“III. LEVEL OF ORDINARY SKILL IN THE ART Petitioner contends a person of ordinary skill in the art (“POSITA”) would have a Ph.D. degree in biological, chemical or biochemical engineering, molecular biology, or biochemistry and at least two years of experience in the field of utilizing or assessing horseshoe crab zymogen proteins (lysate, purified native and/or recombinantly produced) for endotoxin detection and quantitation. More education could substitute for experience to a certain extent, and vice versa. Pet. 22 (citing Ex. 1003 ¶¶48–49). Patent Owner does not dispute Petitioner’s description of a POSITA in its Preliminary Response. Prelim. Resp. 10. 1 In addition to other changes to Title 35, the AIA introduced amendments to 35 U.S.C. § 102. Because Patent Owner concedes that the ’725 application “contains, or contained at any time, a claim to a claimed invention that has an effective filing date on or after March 16, 2013” (Ex. 1022), the AIA version of § 102 applies to the ’109 patent. AIA § 3(n)(1)(B); Ex. 1001, 1:11–14 (claiming priority to the ’725 application). 2 US 2019/0241629 A1, published August 8, 2019 (“the ’629 publication” (Ex. 1015)). At this stage, we find Petitioner’s description of the level of ordinary skill in the art sufficiently supported by the record and apply it for purposes of this decision.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Neither party proposes an express construction of any claim term. See Pet. 22–23; Prelim. Resp. 10. We determine that no express claim construction is necessary based on the present record.” slip op. at 10
- Disclosure Requirements (§112) › Written description (Ariad)Not shown unpatentable
“To show that the claims of the ’109 patent are unpatentable for lack of written description, Petitioner would have needed to show that the specification as filed (i.e., the ’420 application) fails to reasonably convey to those skilled in the art that Patent Owner had possession of the claimed subject matter as of the July 3, 2023, filing date. Petitioner did not. Pet. 23– 24. Nor does Petitioner’s declarant offer testimony that could support such a showing. See Ex. 1003 ¶50 (“I have been asked to provide my opinions as to the state of the art in this field for purposes of determining what the inventors disclosed as their invention as of December 10, 2013.”), ¶51 (“Whenever I offer an opinion in this declaration about the knowledge of a POSA, the manner in which a POSA would have understood the claims of the ’109 patent or its description, the manner in which a POSA would have understood the prior art, or what a POSA would have been led to do based on the prior art, I am referencing the December 10, 2013 timeframe.”). Although the ’420 application is essentially identical to the ’767 application, the person of ordinary skill in 2013 is not the same as in 2023. See Ariad, 598 F.3d at 1351 (“[T]he [written description] test requires an objective inquiry into the four corners of the specification from the perspective of a person of ordinary skill in the art.” (emphasis added)). Thus, the information presented in the Petition, which is limited to the perspective of a 2013 POSITA, does not demonstrate that it is more likely than not that at least 1 of the claims challenged in the Petition is unpatentable for lack of written description.” slip op. at 12
Claim construction§ 102 anticipation§ 112 disclosurePatents in suitUS 11,959,109 - PTAB · Sep 9, 2025 · IPR2025-00440 · APJ Tawen Chang · IPR · Institution
The Board instituted IPR of claim 21 on both asserted § 103 grounds, finding a reasonable likelihood that claim 21 is obvious over Mizumura with the ’498 PCT and over Mizumura with McClymont.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority under 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons discussed below, we determine Petitioner has demonstrated a reasonable likelihood that the challenged claim of the ’318 patent is unpatentable. Accordingly, we institute an inter partes review of the challenged claim on each of the Grounds raised in the Petition. See SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018).” slip op. at 2
- Disclosure Requirements (§112) › Written description (Ariad)Not entitled to earlier dateOther
“Nevertheless, we determine that the contrary evidence Petitioner has cited suffices to establish a reasonable likelihood of success at this preliminary stage of the proceeding. In this regard, we also note Dr. Jain’s testimony — currently unrebutted — that an ordinarily skilled artisan would have known, based on Tokunaga’s sequence comparisons of Factor C proteins, that “certain sequence differences between [Limulus polyphemus] and Tachypleus tridentatus were non-conservative (i.e., potentially giving rise to changes in function in terms of enzymatic activity of Factor C).” Ex. 1002 ¶ 94 (citing Ex. 1022, 157). We likewise note Dr. Jain’s testimony that such artisan would have recognized Tokunaga’s conclusion, regarding “immunological and biochemical properties” of Factor C proteins of the two different horseshoe crab species, to be “based on only gross biophysical-biochemical properties” that are not “granular enough” to predict functional properties such as residual activity in presence of specific ions. Ex. 1002 ¶ 100.” slip op. at 22
- Disclosure Requirements (§112) › Enablement (Wands, Amgen full scope)Not enabledOther
“submitted in a different proceeding and in a different forum, and our rules contemplate objections to admissibility only after institution. See 37 C.F.R. § 42.64(b)(1) (“Any objection to evidence submitted during a preliminary proceeding must be filed within ten business days of the institution of the trial.”); also compare Fed. R. Evid. 801(c) (defining hearsay as a statement, not made at the current trial or hearing, “offer[ed] in evidence to prove the truth of the matter asserted”), with Fed. R. Evid. 801(d)(2) (excluding from hearsay statement offered against an opposing party where statement was made by “a person whom the party authorized to make a statement on the subject” or by a “party’s agent or employee on a matter within the scope of that relationship and while it existed”). Nevertheless, as discussed above, Petitioner has provided contrary evidence, including statements from Patent Owner’s patent application, suggesting that, “due to the various differences and diversity of biomolecules depending on the genus and species of the horseshoe crab,” it had not been possible “to accurately determine the full-length sequence structure, expression, and function of [Limulus] proteins and genes using conventional methods” more than 20 years after complete gene and amino sequences from two Tachypleus horseshoe crab species had been reported. Pet. 35 (citing, e.g., Ex. 1005 ¶¶ 12–17). Thus, even if we were to take the Frohman Declaration into account, we find that Petitioner has established a reasonable likelihood 28 of success that the ’767 application disclosures did not enable an ordinarily skilled artisan to make and use the invention of the challenged claim without undue experimentation. Furthermore, assuming that the disclosures in ’767 application would have enabled an ordinarily skilled artisan to express recombinant Limulus polyphemus Factor C protein in HEK293, we find Petitioner has established, sufficient for purposes of institution, that the disclosures do not enable an ordinarily skilled artisan to make such a protein exhibiting the “full scope” of the claimed residual activity, without undue experimentation. Patent Owner cites to disclosures in the ’767 application that (1) describe how to produce recombinant Factor C in HEK293 cells and measure residual activity, (2) suggest “Factor C expressed in mammalian cells can have low susceptibility to activity inhibition by ions,” and (3) provide examples where residual activity met the required minimum. Prelim. Resp. 26–27, 32–34. Nevertheless, whether an ordinarily skilled artisan would have been able to make, based on these disclosures and without undue experimentation, a recombinant Factor C protein having residual activity encompassed by claim 21 but higher — even significantly higher — than that achieved in the example, is a fact intensive issue that would benefit from further development during trial.15 See, e.g., In re” slip op. at 28
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date, deniedOther
“the proceeding, and for the reasons set forth below, we are persuaded that Petitioner has shown sufficiently, for purposes of institution, that the ’767 application does not provide adequate written description support for claim 21 of the ’318 patent and that, accordingly, Mizumura, the ’498 PCT, and McClymont qualify as prior art to the challenged claim.” slip op. at 19
§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 11,236,318 - Lifevac, LLC v. Dcstar Inc.Institution deniedPTAB · Sep 8, 2025 · IPR2025-00454 · APJ Cynthia M Hardman · IPR · Institution
The Board denied institution on claims 1–17 because Petitioner did not show a reasonable likelihood that Zhongnan qualifies as prior art under the § 102(b)(1)(B) exception.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“to show with particularity why the patent it challenges is unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016) (citing 35 U.S.C. § 312(a)(3) (requiring inter partes review petitions to identify “with particularity . . . the evidence that supports the grounds for the challenge to each claim”)). Petitioner ultimately bears the burden of persuasion to prove unpatentability of each challenged claim by a preponderance of the evidence. 35 U.S.C. § 316(e). This burden never shifts to Patent Owner. See Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1378 (Fed. Cir. 2015). The Board may authorize inter partes review if we determine that the information presented in the Petition and Patent Owner’s Preliminary Response shows a reasonable likelihood that Petitioner will prevail with respect to at least one of the claims challenged in the petition. 35 U.S.C. § 314(a).” slip op. at 8
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportReference not prior artDecided for patent owner
“provides that a disclosure which would otherwise qualify as prior art under AIA 35 U.S.C. 102(a)(1) (patent, printed publication, public use, sale, or other means of public availability) is excepted as prior art if: (1) the disclosure was made one year or less before the effective filing date of the claimed invention; and (2) the subject matter disclosed had been previously publicly disclosed by the inventor, a joint inventor, or another who obtained the subject matter directly or indirectly from the inventor or joint inventor. MPEP § 2153.02 (9th ed. rev. 01.2024 Nov. 2024); see also Sanho, 108 F.4th at 1381. As to point (1), there is no dispute that Zhongnan was published one year or less before the effective filing date of the challenged claims. See, e.g., Ex. 1005, code (43); Pet. 11, 20; Prelim. Resp. 9–10. Thus, we focus on point (2), which requires that IDEAR be previously publicly disclosed by the inventor, and that Zhongnan and IDEAR disclose the same subject matter.” slip op. at 10
- BurdenDecided for patent owner
“Our rules require that in determining whether to institute inter partes review, we “take into account a patent owner preliminary response where such a response is filed, including any testimonial evidence.” 37 C.F.R. § 42.108(c) (emphasis added); Prelim. Sur-reply 3. As Patent Owner correctly notes, “the Board routinely weighs declaratory testimony at the institution[] stage and virtually always makes institution decisions without the benefit of cross-examination.” Prelim. Resp. 19–20 (emphasis omitted) (citing LG Elecs. Inc. v. Wi-LAN Inc., IPR2018-00704, Paper 14 at 13–14 (PTAB 2018); Freebit AS v. Bose Corp., IPR2017-01308, Paper 8 at 28 (PTAB 2017)). For example, in LG Electronics and Freebit, the Board denied institution, finding that the patent owner had provided sufficient evidence to antedate the petitioners’ proffered prior art references. See LG Elecs., IPR2018-00704, Paper 14 at 7; Freebit, IPR2017-01308, Paper 8 at 25, 34.10” slip op. at 23
§ 102 anticipationPatents in suitUS 11,478,575 - Integrated Dna Technologies, Inc. v. Tecan Genomics, Inc.Adverse judgmentPTAB · Aug 11, 2025 · IPR2024-01502 · APJ James A Worth · IPR · Adverse judgment
The Board granted the joint motion for adverse judgment after Patent Owner disclaimed claims 1–3, 5–11, and 14–17, and terminated the inter partes review.
RulingsAdverse judgment- Adverse judgmentAdverse judgmentGranted
“Section 42.73 provides that “[a] party may request judgment against itself at any time during a proceeding. Actions construed to be a request for adverse judgment include: (2) Cancellation or disclaimer of a claim such that the party has no remaining claim in the trial.” 37 C.F.R. § 42.73(b)(2). We agree that adverse judgment and termination are appropriate in view of the disclaimer because no challenged claim remains.” slip op. at 2
NonePatents in suitUS 9,546,399 - PTAB · Jul 16, 2025 · PGR2025-00012 · APJ Debra L Dennett · PGR · Institution
Instituted PGR on claims 1–3 based on five grounds; the Board found each ground met the institution threshold on the preliminary record.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority to determine whether to institute a post-grant review under 35 U.S.C. § 324. Institution of a post-grant review is authorized by statute when “the information presented in the petition . . . would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). A post-grant review may also be instituted when “the petition raises a novel or unsettled legal question that is important to other patents or patent applications.” See id. § 324(b). Applying that standard on behalf of the Director (37 C.F.R. § 42.4(a)) and in consideration of the Petition, Preliminary Response, and the evidence of record, we determine that the information presented shows that it is more likely than not that Petitioner would prevail in establishing unpatentability of claims 1–3 of the ’201 patent.” slip op. at 2
- Skill levelSkill level board ownOther
“At this stage of the proceedings, neither Petitioner’s nor Patent Owner’s proffered definitions of the level of skill appear appropriate. Petitioner’s proposal requires as little as a bachelor’s degree in organic chemistry and two years of experience as a laboratory technician working on development of molecules with targeted biological activity, and an ambiguous “understanding” of certain processes. Patent Owner’s proposal, other the other hand, requires multiple years of both formal training and actual, practical experience in highly specialized fields that involve detection of optical or radiolabeled compounds and use of molecular imaging techniques such as PET and SPECT. For the purposes of this decision, on the record at this time, we find that a POSA would have had a Ph.D. in chemistry, biochemistry, or a comparable field or an M.D., and at least four years of experience in chemical synthesis of compounds that may be used to target biologically-significant tissues. This definition appears consistent with the level of skill shown in the prior art references of record. See Daiichi Sankyo Co. v. Apotex, Inc., 501 F.3d 1254, 1256 (Fed. Cir. 2007). The parties will have the opportunity to cross-examine Dr. Martin and Dr. VanBrocklin in this proceeding to develop a full record for us to determine the weight that each expert’s testimony should be given. We invite the parties to further brief the definition of a POSA here, and whether we should discount either experts’ testimony due to lack of qualifications.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other
“c) Analysis On the present record, we find that “low molecular weight” is not limited to Patent Owner’s proposed “from about 50 Daltons to about 1,500 Daltons.” The cited evidence relied on in the Pomper Declaration all concerns metabolomics and metabolites, and we find no reason that even a vague definition of metabolites applies to the claimed compounds. See Ex. 1002, ¶ 102. Moreover, the uncontested fact that several of the B moieties alone—without the A moiety or L linker—specifically identified in the ’201 patent fall outside of Patent Owner’s proposed definition is persuasive (see id., ¶ 103), as we normally do not interpret claim terms in a way that excludes examples disclosed in the specification. See, e.g., Verizon Servs. Corp. v. Vonage Holdings Corp., 503 F.3d 1295, 1305 (Fed. Cir. 2007) (rejecting proposed claim interpretation that would exclude disclosed examples in the specification). In addition, the opinion stated in the Pomper Declaration that “the term of ‘low molecular weight’ is well accepted in the chemical arts’” and the declarant “recognize[s] that low molecular weight compounds would have a molecular weight of typically form about 50 Daltons to about 1,500 Daltons” is offered by a co-inventor. We, as factfinder, have discretion to weigh the credibility of expert witnesses and to give each item of evidence such weight as appropriate. See In re Am. Acad. of Sci. Tech Ctr., 367 F.3d 1359, 1368 (Fed. Cir. 2004) (“[T]he Board is entitled to weigh the declarations and conclude that the lack of factual corroboration warrants discounting the opinions expressed in the declarations.”). In this case, we find that the published references on metabolites do not support the opinion. In re Am. Acad. of Sci. Tech Ctr., 367 F.3d at 1368 (Fed. Cir. 2004) (“[T]he Board is entitled to weigh the declarations and conclude that the lack of factual corroboration warrants discounting the opinions expressed in the declarations.”) The Pomper reference (Ex. 1006) also uses the term “low molecular weight”—without further characterization of the term—and is uninformative as to the meaning of the term. See Ex. 2002, ¶ 60; Ex. 1006, ¶ 12. The table giving the molecular weight of a “selection of compounds disclosed by Pomper” (see Ex. 2002, ¶ 62) is not persuasive in defining “low molecular weight,” as it does not explain how those included were “selected” and does not include molecular weights for all of the examples.7 In addition, Patent Owner’s definition does not appear to apply to all claimed compounds.8 7 At least one of the examples (SRV73) not included in the table appears to have a molecular weight well over “about 1,500 Daltons.” 8 See, e.g., claim 113 of Ex. 1006. Patent Owner’s arguments distinguishing “low molecular weight” slip op. at 11
- Claim Construction › Intrinsic evidence (Phillips canons) › Lexicography (patentee as own lexicographer)Term construed petitioner constructionDecided for petitioner
“The ’201 patent defines “alkyl” as “a straight (i.e., unbranched) or branched chain, acyclic or cyclic hydrocarbon group, or combination thereof” “ that has “the number of carbon atoms designated (i.e., C1–C10 means one to ten carbons, including 1, 2, 3, 4, 5, 6, 7, 8, 9, and 10 carbons)” and “[i]n particular embodiments, the term ‘alkyl’ refers to C1-20 inclusive, including 1, 2, 3, 4, 5, 6, 7, 8, 9, 10, 11, 12, 13, 14, 15, 16, 17, 18, 19, and 20 carbons” “unless otherwise stated.” Ex. 1001, 39:44–58. Although substituents at the R1x position in the claims are limited to “C1-6alkyl,” those at position R3x are not. Ex. 1001, Certif. Corr. Patent Owner’s representation that “Jansen I provides ‘the following definitions’ stating that ‘alkyls groups of this invention comprise from 1 to 6 carbon atoms’” is inaccurate. See Prelim. Resp. 19. In fact, Jansen I states: The term “alkyl” by itself or as part of another substituent refers to a fully saturated hydrocarbon of Formula CxH2x+1 wherein x is a number greater than or equal to 1. Generally, alkyl groups of this invention comprise from 1 to 6 carbon atoms. Alkyl groups may be linear or branched and may be substituted as indicated herein. When a subscript is used herein following a carbon atom, the subscript refers to the number of carbon atoms that the named group may contain. Ex. 1007, 22:16–23 (emphasis added). Neither the ’201 patent nor its incorporation by reference of Jansen I would have conveyed to a POSA that the “(CO)alkyl” of the substituent in the R3x position in the claims is intended to comprise from one to six carbon atoms or is limited to any particular length and size. “(C(O)alkyl,” having no number of carbon atoms designated, means” slip op. at 15
Claim construction§ 103 obviousness§ 112 disclosurecites Phillips · KSR · Graham · NautilusPatents in suitUS 11,938,201 - Trove Brands, LLC v. Camelbak Products, LLCInstitution deniedPTAB · Jul 8, 2025 · IPR2025-00155 · APJ James A Worth · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1, 3–9, 11–17, or 19 were unpatentable on the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Institution of an inter partes review is authorized by statute when “the information presented in the petition filed under [35 U.S.C. §] 311 and any response filed under [35 U.S.C. §] 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018).1 For the reasons set forth below, we determine that Petitioner has not demonstrated that there is a reasonable likelihood that at least one of claims 1, 3–9, 11–17, and 19 of the ’187 patent is unpatentable based on the grounds set forth in the Petition, and we do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner asserts that a person of ordinary skill in the art (“POSITA”) would have had an undergraduate degree in mechanical engineering or equivalent coursework, and a year or more of experience in designing, prototyping, and/or manufacturing fluid containers or similar products. Pet. 19 (citing Ex. 1003 ¶ 29). Petitioner asserts that more work experience may substitute for a lower level of education, and vice versa. Id. Patent Owner admittedly sets forth “a similar, though slightly different, level of ordinary skill”: a bachelor’s degree in mechanical engineering or the equivalent coursework and approximately one year of experience with liquid-containing devices, with more work experience substituting for less education and vice versa. Prelim. Resp. 27 (citing Ex.2001 ¶¶ 60–64). Patent Owner discerns no material difference between the definitions provided by the parties for purposes of the Board’s decision on whether to institute this proceeding. Id. For purposes of this decision, we adopt Petitioner’s proposed level of skill as being consistent with the prior art, although our conclusion on whether to institute would be unchanged under either definition.” slip op. at 10
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesDecided for petitioner
“The failure to use the word “means” in a claim element creates a rebuttable presumption that § 112 ¶ 6 does not apply. Williamson v. Citrix Online, 792 F.3d 1339, 1348 (Fed. Cir. 2015) (en banc). The presumption can be overcome and § 112 ¶ 6 will apply if the challenger demonstrates that the claim term fails to “recite[ ] sufficiently definite structure” or else recites “function without reciting sufficient structure for performing that function. “Construing a means-plus-function claim term is a two-step process.” Id. at 1351. “The [tribunal] must first identify the claimed function.” Id. “Then, the [tribunal] must determine what structure, if any, disclosed in the specification corresponds to the claimed function.” Id. There may be multiple claimed functions, each with disclosed corresponding structure. See id. at 1351–52.” slip op. at 14
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“We are persuaded by Patent Owner that the term “automatically” in “to automatically disengage the first and second catch structures” means that it is not just the force applied by the user that disengages the first and second catch structures, but also the bias of the mouthpiece that helps to disengage the first and second catch structures. In the first instance, we agree with Patent Owner that the claim itself recites that, upon actuation, the mouthpiece assembly is “release[d]” to “move via its bias from the stowed configuration to the dispensing configuration.” See Ex. 1001, 21:59–64. This meaning is supported by the Specification which states: “In some examples, the mouthpiece assembly is biased toward the dispensing configuration and thus moves automatically under its bias upon release by the user-release mechanism.” Ex. 1001, 1:64–67. We further agree with Patent Owner that the plain and ordinary meaning of “automatic” is that the user operation alone is not responsible for the action. For example, in one dictionary cited by Petitioner, “automatic” is defined as “2: having a self-acting or self-regulating mechanism.” See Ex. 2007, 1.11 The district court construction is consistent therewith. The district court identified two functions, the first of which is the same as that of the ’028 patent, i.e., “Automatically disengaging the first and second catch structures upon actuation of the user release mechanism and thereby releasing the mouthpiece assembly to move via its bias from the stowed configuration to the dispensing configuration.” See Section II.C.1, supra. In discussing that function, the district court states: “While a user may impart force upon user engagement portion 260 to release the mouthpiece, the bias of the mouthpiece towards the dispensing configuration causes the mouthpiece to move automatically, satisfying the requirements of Claim 1.” Ex. 2002, 16. We conclude that the term “automatically” in “adapted to” slip op. at 17
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,684,187 - PTAB · Jun 6, 2025 · IPR2025-00140 · APJ James A Worth · IPR · Institution
The Board instituted IPR of claims 1–18 on all petitioned challenges, finding a reasonable likelihood that at least claim 1 is obvious over Nakajima and the knowledge of a person of ordinary skill.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition filed under [35 U.S.C. §] 311 and any response filed under [35 U.S.C. §] 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). For the reasons set forth below, we determine that Petitioner has demonstrated that there is a reasonable likelihood that at least one of claims 1–18 of the ’250 patent is unpatentable, and we institute an inter partes review of claims 1–18 based on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner asserts that a person of ordinary skill in the art (“POSITA”) would have had an undergraduate degree in mechanical engineering or equivalent coursework, and a year or more of experience in designing, prototyping, and/or manufacturing fluid containers or similar products. Pet. 15 (citing Ex. 1002 ¶ 25). Petitioner asserts that more work experience may substitute for a lower level of education, and vice versa. Id. Patent Owner admittedly sets forth “a similar, though slightly different, level of ordinary skill”: a bachelor’s degree in mechanical experience with liquid-containing devices, with more work experience substituting for less education and vice versa. Prelim. Resp. 28 (citing Ex. 2001 ¶ 50). Patent Owner discerns no material difference between the definitions provided by the parties for purposes of the Board’s decision on whether to institute this proceeding. Id. For purposes of this decision, we adopt Petitioner’s proposed level of skill as being consistent with the prior art, although our conclusion on whether to institute would be unchanged under either definition.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“For purposes of this decision on institution, we adopt the proffered dictionary definition of “mouthpiece” as “a part (as of an instrument) that goes in the mouth or to which the mouth is applied” (see Ex. 2005), and we construe this as an intended use of this component of the apparatus, because this definition is consistent with the plain and ordinary meaning of the term which is a compound of “mouth” and “piece” and also because this definition is consistent with the Specification. For example, the Specification describes the use of the mouthpiece as follows: “In use, the mouthpiece is adapted to be configured to the dispensing configuration by a user placing the mouthpiece in the user’s mouth and biting upon or otherwise compressing the appropriate portions of sidewalls 92 of the mouthpiece.” Ex. 1001, 8:45–49. We note that, although the Specification refers to bite-actuation of the mouthpiece, for example in the field of the disclosure and certain embodiments (e.g., Ex. 1001, 1:25–27), the independent claims do not require bite-actuation. The Specification identifies the mouthpiece as item 72 (which is depicted, for example, in Figure 25, reproduced supra). Ex. 1001, 3:7‒8. 7 Exhibit 2005 appears to be from an online Merriam-Webster dictionary accessed March 13, 2025. Ex. 2005, 4. At this time, there is no argument in the preliminary record that this definition would have been different before the critical date of the patent.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Although the construction of this limitation may be helpful in deciding the issues of unpatentability, we determine that the construction of this term would benefit from further briefing during the trial phase of this proceeding, and we invite the parties to continue to brief this issue. Therefore, we do not provide a preliminary construction of the term at this time.” slip op. at 14
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,851,250
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.