• Cisco Systems, Inc. v. Portsmouth Network Corp.No claims unpatentable
  PTAB · Mar 31, 2026 · IPR2024-01450 · APJ Peter D Shapiro · IPR · Final written decision

  Claims 1–4, 6–11, and 13–20 were not shown unpatentable because Dziong and Sathyanath do not teach the claimed sharing definition for existing connections with allocated bandwidth.

  RulingsFinal written decision

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “First, the claims use present-tense language, “one or more other connections, which have respective bandwidths and which are permitted to share a bandwidth allocation with the new connection.”3 Ex. 1001, claim 1 (emphasis added). The exclusive use of the present tense have indicates “other connections” must have current possession of the bandwidth. For these other connections to share bandwidth with a newly established connection, they must already exist and have bandwidth ready for immediate use, rather than merely holding a dormant “reservation” pending a network failure. See PO Supp. Br. 1. The Federal Circuit addressed a similar situation where the Court found the present-tense limitation “is connected to the computer network” means a device was required to be connected at the” slip op. at 15

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “combination, do not teach or suggest limitations 1.2 and 1.3 requiring: providing a sharing definition specifying one or more other connections, which have respective bandwidths and which are permitted to share a bandwidth allocation with the new connection, such that a total bandwidth allocated jointly to the new connection and to the other connections in any given segment is equal to a maximum of the requested bandwidth and of the bandwidths of the other connections in the given segment Ex. 1001, limitations 1.2, 1.3 (emphasis added); see PO Resp. 17–22; Sur-reply 4–5, 12–14. As discussed above in Section II.C.2, we interpret “other connections” to mean “existing connections in the network that already have bandwidth allocated to them.” Because the information shared in Dziong and Sathyanath, described below, relates to reserved protection paths, rather than existing connections that have bandwidth that can currently transmit network traffic, the references do not teach or suggest the “other connections” part of the sharing definition in limitations 1.2 and 1.3. Dziong describes advertising, across the network, the amount of bandwidth reserved for recovery on each link that would be activated when a protected link fails. See, e.g., Ex. 1005 ¶ 60; Pet. 36. Once activated, network traffic from a “primary path” failure is rerouted to these recovery paths. See Ex. 1005 ¶¶ 7–9, 70, 83. Petitioner points to this advertising of the reserved bandwidth information as teaching the claimed “sharing definition.” Pet. 33–36 (arguing that the “protection paths [in Dziong] have bandwidth reservations” and “share an overall protection bandwidth reservation”); Reply 21–23. However, since the advertised information only contains information about the recovery paths “that would be activated” upon a primary path failure, such paths are not existing connections that already have bandwidth allocated to them, and therefore do not teach the claimed “other connections” that are part of the sharing definition. See, e.g., Ex. 1005 ¶ 60.” slip op. at 43

  Patent outcomesUS 7,596,088 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 7,596,088
• Juniper Networks, Inc. v. Portsmouth Network Corp.Some claims unpatentable
  PTAB · Jan 13, 2026 · IPR2024-00913 · APJ Justin T Arbes · IPR · Final written decision

  Claims 1, 2, 4, 6, 7, 11, 12, 14, 16, and 17 are unpatentable over Blease, Weyman, and Hu, with some claims also over Deng; claims 8–10 and 18 were not shown unpatentable.

  RulingsFinal written decision

  • Expert testimonyPetitioner expert discountedOther

    “disclosure in Weyman (or Blease) for deactivating and activating ports, or performing certain actions in the time between such actions. Again, the only portion of Weyman cited pertains to a request to join the fabric from a processing unit having a “default” configuration, which does not relate to the timing or sequence of events in initialization. See Ex. 1006 ¶¶ 69, 156, 161–162; Ex. 1103 ¶¶ 93–94. Nor does Dr. Lavian point to any other evidence in the record supporting his conclusion that a person of ordinary skill in the art would have “ensure[d] that the processing unit is deactivated prior to being updated for use . . . and then activate[d] the processing unit after updating.” See Ex. 1103 ¶ 94. Accordingly, we give little weight to Dr. Lavian’s conclusory opinion” slip op. at 75

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableUnpatentable

    “See Axonics, 73 F.4th at 957; Allied Erecting, 825 F.3d at 1381; Mouttet, 686 F.3d at 1332–33. Petitioner’s position is that, based on the teachings of Weyman, a person of ordinary skill in the art would have modified Blease’s system to distribute the functionality of control unit 44 (including its existing multicast forwarding information 48 used by OIF mapper 50). See Pet. 23–26, 38; Fleming v. Cirrus Design Corp., 28 F.4th 1214, 1222 (Fed. Cir. 2022) (“That the proposed combination of [two references]—rather than one of the individual references—discloses the disputed claim limitations does not defeat the Board’s conclusion of obviousness. In this case, it is sufficient that a person of ordinary skill in the art would have been motivated to combine the prior art in a way such that the combination discloses the claim limitations.”).” slip op. at 55

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “10 In the Cisco IPR, we determined that Cisco had proven claims 8 and 18 to be unpatentable based on a different combination of references (identified as Weyman, Jain, and LeMaire), finding that limitation 8[f.ii] was taught by Jain and LeMaire. IPR2024-00506, Paper 38 at 58–77. As explained herein, we are not persuaded by Petitioner’s arguments in this proceeding that limitation 8[f.ii] is taught or suggested by Weyman. Also, in the Decision on Institution in this proceeding, the Board found that there were questions as to Petitioner’s showing for limitation 8[f.ii] and declined to reach a conclusion on whether Petitioner had shown a reasonable likelihood of prevailing on its asserted ground based on Blease and Weyman. Dec. on Inst. 43.” slip op. at 71

  Patent outcomesUS 8,014,394 mixed
  § 103 obviousnesscites KSR · Graham
  Patents in suitUS 8,014,394
• Juniper Networks, Inc. v. Portsmouth Network Corp.All claims unpatentable
  PTAB · Dec 9, 2025 · IPR2024-00893 · APJ Justin T Arbes · IPR · Final written decision

  Claims 3, 8, 11, 12, 15, 20, 23, and 24 are unpatentable as obvious over Gai and IEEE 1999.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner argues that at the time of the application for the ’986 patent (January 2002), a person of ordinary skill in the art would have had “a bachelor’s degree in electrical engineering or a related field, plus at least two years of industry experience or graduate-level academic experience with computer networking.” Pet. 20. In the Decision on Institution, the Board agreed with and applied Petitioner’s proposed definition, removing the phrase “at least” to avoid unnecessary ambiguity. Dec. on Inst. 18–19. Patent Owner uses Petitioner’s proposed definition for its Response. PO Resp. 5. Neither party made any further argument regarding the level of ordinary skill in the art in its papers during trial. In the Cisco IPR, we adopted a similar definition, determining that a person of ordinary skill in the art would have had “a bachelor’s degree in computer science, computer engineering, electrical engineering, or in an equivalent field, or approximately two years of experience working in the field of information technology and networking,” where “[l]ack of professional experience can be substituted by additional education, and vice versa.” IPR2024-00505, Paper 29 at 10–11 (alteration in original); see Dec. on Inst. 19 n.7 (noting the proposed definition in the Cisco IPR). Based on the full record developed during trial, including our review of the ’986 patent and the types of problems and solutions described in the ’986 patent and cited prior art, we adopt the same definition of the level of ordinary skill in the art as the Cisco IPR and apply it for purposes of this Petitioner’s similar proposed definition in this proceeding.” slip op. at 12

  • Expert testimonyPetitioner expert creditedDecided for petitioner

    “Gai discloses entering an Enable_Uplinkfast command at an access switch (e.g., access switch 114) to block a failed port (e.g., the root port) and configure the access switch to send dummy traffic upstream through a new active port. . . . When modified in view of IEEE 1999’s disclosure that self-healing network traffic can advantageously be sent both upstream and downstream, the command would be entered at a backbone switch (e.g., backbone switch 122) to block a failed port (e.g., a designated port connected to access switch 114) and configure the backbone switch to send dummy traffic downstream to an access switch (e.g. access switch 114) through a new active port. While Gai uses its protocol signaling command, Enable_Uplinkfast, to send dummy traffic through a new root port, [a person of ordinary skill in the art] would deem it an obvious implementation detail to modify the parameters of the port on a backbone switch. See Ex. 1003 ¶ 139 (citing Ex. 1005, col. 6, ll. 39–46).” slip op. at 34

  • Prior constructionPrior construction adoptedDecided for petitioner

    “In the Cisco IPR, we addressed four claim terms in the final written decision: “access switch” and “edge switch,” which appear in independent claims 1 and 13 and various dependent claims, and “downstream” and “upstream,” which appear in claims 11, 12, 23, and 24. IPR2024-00505, Paper 29 at 11–14. We interpreted “access switch” to mean “a switch with ports that connect to LANs and/or to other network endpoints, such as user computer systems,” interpreted “edge switch” to mean “a core switch that is directly connected to an access switch,” interpreted “downstream” to mean “away from the root switch,” and interpreted “upstream” to mean “toward the root switch.” Id. As noted above, Patent Owner did not appeal that decision. We incorporate herein our previous analysis in the Cisco IPR, but note that none of the analysis of the disputed issues below depends on such determine whether Petitioner has met its burden to prove unpatentability of the challenged claims. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“Because we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy,’ we need not construe [a particular claim limitation] where the construction is not ‘material to the . . . dispute.’” (emphasis added) (citation omitted)).” slip op. at 13

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable

    “1999, supported by the testimony of Mr. McNair, which we credit, is persuasive. See Pet. 25–30, 40–46; Ex. 1003 ¶¶ 132–145, 165–174. Based on the full trial record, we find that Gai and IEEE 1999 teach limitation [1E] and that a person of ordinary skill in the art would have been motivated to combine their teachings in the manner described by Petitioner. Based on all of the evidence of record, we determine that Petitioner has proven, by a preponderance of the evidence, that claim 3 would have been obvious over Gai and IEEE 1999 under 35 U.S.C. § 103(a). 4. Claims 8, 15, and 20 Claim 8 depends indirectly from independent claim 1. Claims 15 and 20 depend indirectly from independent claim 13, which is similar to claim 1 but recites a network switching device rather than a method. As to independent claim 13, Patent Owner refers to its earlier arguments regarding claim 1, asserting that limitation [13C] is “substantially similar” to limitation [1E]. PO Resp. 14–15. We disagree with Patent Owner’s arguments for the reasons explained above. See supra Section II.D.3.b. Patent Owner does not argue dependent claims 8, 15, and 20 separately from their respective parent claims 1 and 13. See PO Resp. 19. We have reviewed Petitioner’s contentions and supporting evidence, including the testimony of Mr. McNair, and are persuaded that Petitioner has proven, by a preponderance of the evidence, that claims 8, 15, and 20 would have been obvious based on Gai and IEEE 1999 under 35 U.S.C. § 103(a), for the reasons stated by Petitioner. See Pet. 21–46, 48–52, 55–59; Ex. 1003 ¶¶ 113–175, 179–185, 194–203.” slip op. at 41

  Patent outcomesUS 6,917,986 unpatentable
  Claim construction§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 6,917,986
• CQV Co., Ltd. v. Merck Patent GmbHNo claims unpatentable
  PTAB · Oct 14, 2025 · PGR2021-00054 · APJ Kristina M Kalan · PGR · Remand

  Claims 1–22 were not shown unpatentable because Sample C was not proven publicly available as prior art, and the original decision found the remaining grounds insufficient.

  RulingsRemand decision

  • Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication not establishedNot shown unpatentable

    “We agree with Patent Owner that Petitioner’s evidence in Kuntz (Ex. 1026), the Annual Report (Ex. 1028), Masuko (Ex. 1029), and Pfaff (Ex. 1034) is insufficient to show that Xirallic® Sample C was available to the public before the effective filing date of the ’861 patent. Petitioner has not asserted, nor do we find, that any of these documents refer to or describe the lot of Xirallic® from which Sample C was taken. See Final Dec. 26. Kuntz, the Annual Report, Masuko, and Pfaff may support a finding that the Xirallic® line of products was available to the public, but these documents do not support a finding that the lot of Xirallic® from which Sample C was taken was available to the public. We also agree with Patent Owner that the Technical Data Sheets (Exs. 1005–1010), Certificates of Analysis (Exs. 1011–1017), and Material Safety Data Sheet (Ex. 1025) are insufficient to show that Xirallic® Sample C was available to the public. Petitioner has not asserted, nor do we find, that any of these documents refer to or describe the lot of Xirallic® from which Sample C was taken. See Final Dec. 26–27. Regardless of how the Technical Data Sheets were used in the Opposition against the European counterpart of the ’861 patent (Exs. 1040, 1041) and during the prosecution of the application from which the ’861 patent issued (Ex. 1003, 102–104), the Technical Data Sheets do not refer to or describe the lot of Xirallic® from which Sample C was taken. Moreover, as noted by Patent Owner, the Technical Data Sheets (Exs. 1005–1010) indicate that they are “preliminary” and Petitioner has not provided any evidence that the Technical Data Sheets were ever issued to the public, as opposed to just issued internally. See PO Resp. 18–19. We also find persuasive Patent Owner’s argument that the Technical Data Sheets are preliminary because other, later-dated technical data sheets (Exs. 2012, 2013) lack the “preliminary” label and list characteristics that are different from those in Exhibits 1005–1010. See PO Resp. 19 (comparing, e.g., Ex. 1009 and Ex. 2013; Ex. 1005 and Ex. 2012). The Technical Data Sheets may support a finding that the Xirallic® products they describe existed as of the dates on the documents, but they do not support a finding that the lot of Xirallic® from which Sample C was taken was available to the public.” slip op. at 20

  • Expert testimonyPetitioner expert discountedPatent owner expert creditedOther

    “witnesses. See Elbit Systems of Am., LLC v. Thales Visionix, Inc., 881 F.3d 1354, 1358 (Fed. Cir. 2018) (citing Trs. of Columbia Univ. v. Illumina, Inc., 620 F. App’x 916, 922 (Fed. Cir. 2015); Inwood Labs., Inc. v. Ives Labs., Inc., 456 U.S. 844, 856 (1982)). We have reviewed the witness testimony in the record and, more particularly, Mr. Choi’s deposition answers regarding Petitioner’s purchase of the lot of Xirallic® from which Sample C came. We find that Mr. Choi’s responses cast doubt on the credibility of his declaration testimony, namely with regard to the public availability of Sample C. Mr. Choi represented that he was involved in the purchase of the lot of Xirallic® from which Sample C was taken. Ex. 2011, 48:1–23. Mr. Choi stated that he instructed Petitioner’s marketing team manager to buy the sample from a distributor of Patent Owner’s products located in Europe. Id. at 48:24–49:4. Mr. Choi stated that he has evidence of the transaction, but refused to reveal the name of the company from which Petitioner purportedly purchased the lot of Xirallic® (id. at 49:5–50:3) and refused to produce an email in his possession that would corroborate his testimony regarding Petitioner’s acquisition of the product (id. at 50:8–16, 51:10–23). Mr. Choi represented that he does not remember how much Petitioner paid for Sample B. Id. at 56:4–5. Mr. Choi admitted that the entity from which Petitioner acquired the lot of Xirallic® from which Sample C was taken is “not currently a Merck distributor” (Ex. 2011, 50:4–7) and was not “a Merck distributor at the time” that “samples B and C were purchased” (id. at 51:25–52:2). According to Mr. Choi, the company is a “former distributor” of Patent Owner’s products. Id. at 52:3–6. Mr. Choi did not know, according to his testimony, when that unnamed entity first obtained the lot of Xirallic® (id. at 52:7–10) and he stated that he did not have personal knowledge of how the entity obtained the lot of Xirallic® (id. at 52:12–19). Instead, Mr. Choi assumed the entity was “able to obtain the sample through the routine course or process” the entity uses “to take samples or get samples.” Id. at 52:12–19. Mr. Choi believed the sample of Xirallic® from which Sample C was taken was sealed when Petitioner received it because samples from dealers are sealed, and he remembered observing that the package was from a dealer. Id. at 52:24– 54:25. However, Mr. Choi admitted that he did not obtain a technical data sheet or certificate of analysis for the lot of Xirallic® from which Samples B and C were taken. Id. at 59:6–11. Mr. Choi also answered questions regarding Petitioner’s purchase of Samples D and H. Ex. 2011, 62:20–66:8, 67:7–9, 73:12–13, 73:17–22. Similar to his testimony regarding Samples B and C, Mr. Choi admitted withholding an email regarding the purchase of the lot of Xirallic® from which Sample D was taken. Id. at 62:20–63:9. Mr. Choi also admitted that he did not know how Akzo USA or Axalta obtained the Xirallic® the companies sold to him, and admitted that Akzo USA was not a distributor of Patent Owner’s products at the time Petitioner purchased the product. Id. at 63:10–66:8, 73:17–22. Mr. Choi also admitted that Petitioner did not pay Akzo USA for the lot of Xirallic® from which Sample D was taken, and did not pay Axalta for the lot of Xirallic® from which Sample H was taken. Id. at 67:7–9, 73:12–13. Although Petitioner presents declaration testimony from Mr. Choi representing that he purchased the lot of Xirallic® from which Samples B and C were taken in October 2011 (Ex. 1004 ¶ 16), Mr. Choi’s declaration testimony lacks corroborating evidence, and his deposition testimony does not support that the product was available to the public, as we found in our Final Written Decision. See Final Dec. 27–28. Notably, Petitioner produced corroborating evidence for Mr. Choi’s acquisition of Samples A, H, and I. See Ex. 1004 ¶¶ 13 (citing Ex. 1047), 18 (citing Exs. 1024, 1025). However, Mr. Choi withheld similar evidence for the Xirallic® lots from which Samples B, C, and D were taken. See Ex. 2011, 50:8–16, 51:10–23, 62:20– 63:9; Final Dec. 28. As Patent Owner argues, there is “no information to determine when a contract was established, that there was consideration for the exchange, that the product was available to be delivered when the alleged transaction took place, or even when the product was delivered. Choi has no memory of what was paid for the product.” Sur-Reply 24–25; see also PO Resp. 13–14; PO Br. Rem. 2–4.” slip op. at 34

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “Based on the evidence discussed above, we are not persuaded that Petitioner has shown by a preponderance of the evidence that Sample C was available to the public. Regardless of whether a company avoids wasting shelf life of its products (Ex. 1004 ¶¶ 15–16), there is no persuasive evidence in the record showing that the lot of Xirallic® from which Sample C was taken was released from quality control and then made available to the public by Patent Owner. Mr. Choi’s testimony shows that Petitioner obtained the lot of Xirallic® from which Sample C was taken in an atypical manner (i.e., not from Patent Owner or one of Patent Owner’s current distributors) (Ex. 2011, 49:5–50:7, 50:8–16, 51:10–23, 51:25–52:6, 52:12– 19), and there is no evidence in the record to show that the lot of Xirallic® was intended for sale, rather than for experimental use only or for some other restricted use. Accordingly, we determine Petitioner has not demonstrated by a preponderance of the evidence that Sample C qualifies as prior art against the ’861 patent, and we determine that Petitioner has not shown by a preponderance of the evidence that the ’861 patent is unpatentable over the grounds relying on Sample C.” slip op. at 38

  Patent outcomesUS 10,647,861 not shown unpatentable
  § 102 anticipation§ 103 obviousness
  Patents in suitUS 10,647,861
• Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing denied
  PTAB · Oct 7, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Rehearing

  The Board denied Solus’s rehearing request, leaving institution denied for claims 1–8 because the petition did not adequately show motivation to combine Hanafusa and Dobashi.

  RulingsRehearing decision

  • RehearingRehearing, deniedDenied

    “of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents” slip op. at 2

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable

    “In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve Dobashi’s RSm values. Dobashi teaches that because RSm “can be adopted as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66–3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66– 3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 4

  § 103 obviousness
  Patents in suitUS 11,346,014
• Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing denied
  PTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing

  The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.

  RulingsRehearing decision

  • RehearingRehearing, deniedDenied

    “II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable

    “For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable

    “Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8

  • BurdenDecided for patent owner

    “It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5

  § 103 obviousnesscites KSR
  Patents in suitUS 10,811,689
• The Boeing Company v. The Regents Of The University Of CaliforniaNo claims unpatentable
  PTAB · Oct 2, 2025 · IPR2024-00761 · APJ Alyssa A Finamore · IPR · Final written decision

  The Board held claims 1–24 not unpatentable because the asserted references did not show the glass element propagating a modified stress wave to generate tensile stress at the interface.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “Petitioner asserts that a person of ordinary skill in the art (“POSITA”) at the time of the invention of the ’684 patent “would have had an M.S. in Mechanical Engineering or a related field, and at least five years of experience using laser systems to characterize and test mechanical behavior in materials” and that “[m]ore education may supplement practical experience or vice versa.” Pet. 5 (citing Ex. 1003 ¶ 38). Patent Owner” slip op. at 8

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Decided for patent owner

    “Both parties maintain that no claim term needs to be construed. Pet. 4 (citing Ex. 1003 ¶ 40); PO Resp. 20. Patent Owner, however, provides an express construction for limitation [1.d] of independent claim 1 and the similar limitation of independent claim 13, namely limitation [13.c]. PO Resp. 20 (citing Ex. 2011 ¶ 25). To resolve the controversy before us, we determine that these limitations require express construction. 1. “the glass element is configured to propagate and modify a stress wave to the coating/substrate interface to generate a tensile stress between the substrate and the coating” (limitation [1.d]) and “propagating and modifying a stress wave through the glass element to the coating/substrate interface to generate a tensile force between the substrate and the coating” (limitation [13.c]) Patent Owner argues these limitations mean “changing the profile of the laser generated compressive wave and propagating the wave profile as modified to the free surface of the coating, which upon reflection from the free surface as a tension wave generates a tensile stress at the coating/substrate interface.” PO Resp. 20 (citing Ex. 2011 ¶ 25). Petitioner does not refute this proposed construction and, during the oral argument, Petitioner confirmed it agrees with the proposed construction. Tr. 8:16–9:12. We so no reason to depart from the parties agreed-upon construction of limitations [1.d] and [13.c]. Accordingly, for purposes of this Final Written Decision, we adopt the parties’ construction of limitations [1.d] and [13.c].” slip op. at 10

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable

    “a shock in the compression wave in the fused silica substrate. Even if we were to agree with Petitioner that Wang-Dissertation’s fused silica substrate modifies the compression waveform, we would not be persuaded that the fused silica substrate propagates the modified wave to the free surface of the coating, which upon reflection from the free surface as a tension wave generates a tensile stress at the coating/substrate interface, as limitation [1.d] requires. In view of the presence of tension-wave-1 in Wang-Dissertation’s experiments, we find Petitioner has not demonstrated persuasively that the fused silica substrate propagates a modified stress wave to the free surface of the coating to generate a tensile stress at the coating/substrate interface. Also, we find credible Dr. Gupta’s unrebutted testimony that any modified compression wave would attenuate in the substrate and not propagate to the free surface coating or generate a tensile stress at the coating/substrate interface. Ex. 2011 ¶¶ 93–98. Petitioner does not dispute that the experiments in Wang-Dissertation include tension-wave-1. See Ex. 1005, 65 (“The experimental picture is complicated somewhat by the presence of a tensile wave, reflected from the back of the confining layer.”). Nor does Petitioner dispute that Wang-Dissertation discloses that the tension-wave-1 propagates faster than the compression-wave-1 and eventually overtakes compression-wave-1. See id. at 65–66 (“Being tensile, it propagates faster that the peak compressive stress, and faster than the low stress tail of the main pulse. It eventually overtakes the compressive pulse and linear dissipative mechanisms govern the final thickness of the shock.”). Rather, Petitioner relies on Dr. Wang’s testimony regarding the timing of the waves through the sample and argues that tension-wave-1 does not overtake compression-wave-1 in the fused silica substrate. Pet. Reply 17 (citing Ex. 1038 ¶ 5). Dr. Wang testifies that the peak stress from tension-wave-1 is about 2 ns behind the peak of compression-wave-1 and will not reach the interface before the reflected tensile peak of compression-wave-1 reaches the interface in 0.3 ns. Ex. 1038 ¶ 5. However, as Dr. Gupta persuasively explains, the delay between tension-wave-1 and compression-wave-1 depends on the properties of the confining layer, and Wang-Dissertation acknowledges that these properties are not well controlled. Ex. 2011 ¶ 54; see also Ex. 1005, 65 (“The surface properties of that confining layer are not well controlled.”).” slip op. at 19

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “claimed subject matter. Pet. 35–38; Pet. Reply 23–24. In doing so, Petitioner continues to rely on Wang-Dissertation to disclose limitation [1.d] of independent claim 1 and limitation [13.c] of independent claim 13. Pet. 35–38; Pet. Reply 23–24. Petitioner does not put forth any further obviousness rationale in this ground based on Wang-Dissertation for teaching these limitations. For the same reasons discussed in sections II.C.2–3, Petitioner has not persuaded us that Wang-Dissertation teaches or suggests limitations [1.d] and [13.c]. Thus, Petitioner has not shown, by a preponderance of the evidence, that Wang-Dissertation renders obvious the subject matter set forth in claims 4, 6, 9, 15, 17, 20, 23, and 24, which depend from independent claims 1 and 13.” slip op. at 24

  Patent outcomesUS 7,487,684 not shown unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips
  Patents in suitUS 7,487,684
• Cisco Systems, Inc. v. Portsmouth Network Corp.All claims unpatentable
  PTAB · Oct 1, 2025 · IPR2024-00506 · APJ Justin T Arbes · IPR · Final written decision

  Claims 1, 2, 4–12, and 14–18 are unpatentable as obvious over the combinations of prior art listed in the decision.

  RulingsFinal written decision

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable

    “d) Conclusion Petitioner has shown sufficiently that Weyman and Li collectively” slip op. at 50

  Patent outcomesUS 8,014,394 unpatentable
  § 103 obviousnesscites KSR · Graham
  Patents in suitUS 8,014,394
• Qualcomm Incorporated v. Unm Rainforest InnovationsAll claims unpatentable
  PTAB · Sep 30, 2025 · IPR2021-00375 · APJ Kristen L Droesch · IPR · Remand

  Proposed substitute claims 44–47, 49, and 50 are unpatentable as obvious under collateral estoppel; the Board denied Patent Owner’s motion to amend.

  RulingsRemand decision

  • RemandOther

    “the Acting Director of the USPTO (Paper 81, “Acting Director’s Order”) and after a decision by the U.S. Court of Appeals for the Federal Circuit (“the Federal Circuit”) in ZyXEL Communications Corp. v. UNM Rainforest Innovations, 107 F.4th 1368 (Fed. Cir. 2024) (“Federal Circuit Decision”) regarding the Board’s original Final Written Decision (Paper 68, “Final Written Decision” or “Final Dec.”) in this proceeding. In particular, the court remanded to the Board to determine if proposed substitute claims 44–47, 49, and 50 are unpatentable as obvious under collateral estoppel based on the court’s holding that claims 1–4 and 6–8 are unpatentable as obvious. ZyXEL, 107 F.4th at 1371, 1384.” slip op. at 2

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable

    “proposed substitute claim 44 presents the same issues as those litigated before the Federal Circuit: whether it would have been obvious to a person of ordinary skill in the art to include the first key element and whether it would have been obvious to a person of ordinary skill in the art to include the second key element.” slip op. at 9

  • PTAB / AIA Trials › Motions to amend / substitute claimsMotion to amend, deniedDenied

    “Final Written Decision, and the Federal Circuit Decision, as well as the postremand briefing, we determine that the application of collateral estoppel to proposed substitute claim 44 is appropriate. It is also appropriate to apply collateral estoppel to substitute claims 45–47, 49, and 50. This is because proposed substitute claims 45–47, 49, and 50 depend from proposed substitute claim 44 and recite identical limitations to dependent claims 2–4, 6, and 7. Therefore, the resolution of the question of obviousness of the subject matter of proposed substitute claims 45–47, 49, and 50 necessarily presents the same issues of whether it would have been obvious to a person of ordinary skill in the art to include the first key element and whether it would have been obvious to a person of ordinary skill in the art to include the second key element.” slip op. at 11

  Patent outcomesUS 8,265,096 unpatentable
  § 103 obviousness
  Patents in suitUS 8,265,096
• Nintendo Co., Ltd. / Nintendo Of America Inc. v. American GNC CorporationAll claims unpatentable
  PTAB · Aug 20, 2025 · IPR2024-00668 · APJ Lisa L Tsang · IPR · Final written decision

  Claims 1 and 4 are unpatentable as obvious over Smith, Chan, and Bernstein (claim 1), Smith, Chan, Bernstein, Irwin, and Merhav (claim 4), and Tingleff, Chan, and Bernstein (claims 1 and 4).

  RulingsFinal written decision

  • PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner

    “partes review may not be instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” 35 U.S.C. § 315(b) (emphasis added). Accordingly, a petition for inter partes review may be considered only if, among other things, it “identifies all real parties in interest,” and no real party in interest was served with a complaint alleging infringement of the challenged patent more than one year before the petition was filed. 35 U.S.C. § 312(a)(2). “[T]he IPR petitioner bears the burden of persuasion to demonstrate that its petitions are not time-barred under § 315(b) based on a complaint served on a real party in interest more than a year earlier.” Worlds Inc. v. Bungie, Inc., 903 F.3d 1237, 1242 (Fed. Cir. 2018). However, “an IPR petitioner’s initial identification of the real parties in interest should be accepted unless and until disputed by a patent owner,” who, in turn, “must produce some evidence that tends to show that a particular third party should be named a real party in interest.” Id. at 1242, 1244 (footnote omitted).” slip op. at 8

  • PTAB / AIA Trials › Real party in interest / privityRpi dispute resolved for petitionerDecided for petitioner

    “Based on the arguments and evidence of record, we determine that Patent Owner has not produced sufficient evidence to support a finding that STMicro should be named a real party in interest to this proceeding. At best, Patent Owner’s evidence and arguments establish only that Patent Owner previously filed a complaint against STMicro, asserting that STMicro infringed patents related to the ’648 patent (see generally Ex. 2012); and that Patent Owner served a subpoena to compel STMicro to testify and produce documents in Patent Owner’s infringement suit against Petitioner (see generally Ex. 2014). The record before us does not demonstrate a relationship between Petitioner and STMicro sufficient to show that STMicro is a real party in interest. See Worlds, 903 F.3d at 1242, 1244 (“[A]n IPR petitioner’s initial identification of the real parties in interest should be accepted unless and until disputed by a patent owner,” who, in turn, “must produce some evidence that tends to show that a particular third party should be named a real party in interest.” (footnote omitted)).” slip op. at 9

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Pet. 5 (citing Ex. 1002 ¶¶ 12–14). Patent Owner counters that the skilled artisan would have had “at least a ‘Master’s Degree in Electrical or Electronics Engineering, and approximately five years of relevant experience in the development of control systems for inertial navigation, MEMS semiconductor processing, and analog circuit design.’” PO Resp. 18 (citing Ex. 2019 ¶ 57). We adopt Petitioner’s articulation of the level of ordinary skill in the art, which is consistent with our review and understanding of the technology and descriptions in the ’648 patent and prior art of record, and we apply it in our obviousness evaluations below. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). We note, however, that we would reach the same conclusions applying either Petitioner’s or Patent Owner’s definition of the level of skill in the art.” slip op. at 11

  • Claim Construction › Intrinsic evidence (Phillips canons) › Preamble limiting or notPreamble limitingDecided for patent owner

    “We find unavailing Petitioner’s reliance on Catalina to support its claim construction position. See Reply 2. In particular, although Petitioner contends the body of the claims “define[s] a structurally complete invention,” Petitioner does not explain how the claims additionally “use[] the preamble only to state a purpose or intended use for the invention,” as Catalina further requires. See Catalina, 289 F.3d at 808 (“a preamble is not limiting ‘where a patentee defines a structurally complete invention in the claim body and uses the preamble only to state a purpose or intended use for the invention” (emphasis added)). In this regard, we discern no reason to interpret “[a] micro inertial measurement unit” as reciting only a purpose or intended use because the term, on its face, uses “micro inertial measurement” as an adjective that conveys further structural details of the unit. Accordingly, on the complete record, and for the reasons set forth in our Institution Decision, we maintain our construction that “[a] micro inertial measurement unit” recited in the preamble is limiting and requires a micro-sized inertial measurement unit, and that the structures recited in the limitations of the claims are limited to structures implemented as MEMS devices. Dec. 21–24.” slip op. at 14

  Patent outcomesUS 6,671,648 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 6,671,648

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.