- PTAB · May 26, 2026 · IPR2025-00425 · APJ Kristina M Kalan · IPR · Remand
The Board denied institution of IPR2025-00425 because it instituted the earlier-considered IPR2025-00424 challenging the same patent.
RulingsRemand decision- RemandOther
“Request for Director Review. See Paper 35; IPR2025-00424, Paper 35. The request was denied without prejudice and the cases were remanded to the Board to “allow discovery, narrowly tailored to resolve the RPI and privity issues.” Paper 41, 4. Following such discovery, we were instructed to “then determine on the full record whether Petitioners have met their burden of demonstrating that the Petitions are not time-barred under § 315(b), applying the framework set forth in Worlds Inc. v. Bungie, Inc., 903 F.3d 1237, 1242– 44 (Fed. Cir. 2018).” Id. A later-issued Order Supplementing Director Review Decision instructed that “if the Board determines that Petitioners met their burden to identify all RPIs in the Petitions, then the Board should maintain at most one IPR challenging” the ’225 patent. Paper 64, 3. Concurrently herewith, we issue a decision in IPR2025-00424 finding that Petitioner has met its burden of demonstrating that the Petition in that case is not time-barred under 35 U.S.C. § 315(b).” slip op. at 3
- Other 314aInstitution denied discretionary otherInstitution denied
“In connection with the ’225 patent, Petitioner filed two petitions requesting inter partes review: the petition in this proceeding (IPR2025- 00425), and the petition in IPR2025-00424. In this proceeding and in IPR2025-00424, Petitioner filed an Explanation regarding the necessity of multiple petitions. Paper 2; IPR2025-00424, Paper 2. Petitioner requested that, “if the Board uses its discretion to institute the Petitions, the Board consider the merits of IPR2025-00424 . . . before IPR2025-00425.” Paper 2,” slip op. at 2
Discretionary denialPatents in suitUS 10,589,225 - Berkshire Hathaway Energy Company / Pacificorp v. Birchtech Corp.Institution deniedPTAB · May 20, 2026 · IPR2025-00423 · APJ Zhenyu Yang · IPR · Institution
The Board denied institution of IPR challenging claims 1–4 and 6–29 because it instituted the ranked IPR2025-00422 under the Director’s instruction to maintain at most one IPR.
RulingsInstitution decision- Parallel petitionsInstitution denied discretionary otherDenied
“Paper 34. Birchtech Corp. (“Patent Owner”) filed a Request for Director Review in each case. See Paper 40; IPR2025-00422, Paper 39. The Director denied the request without prejudice in each case and remanded the cases to the Board to “allow discovery, narrowly tailored to resolve the RPI and privity issues.” Paper 49, 4. The Director later issued an Order Supplementing Director Review Decision in each case, instructing that “if the Board determines that Petitioners met their burden to identify all RPIs in the Petitions, then the Board should maintain at most one IPR challenging” the ’430 patent. Paper 72, 3.” slip op. at 2
Discretionary denialPatents in suitUS 10,668,430 - Berkshire Hathaway Energy Company / Pacificorp v. Birchtech Corp.Institution deniedPTAB · May 18, 2026 · IPR2025-00278 · APJ David Cotta · IPR · Institution
The Board denied institution of Berkshire Hathaway Energy Company and PacifiCorp’s petition because it had instituted the earlier-filed IPR2025-00274 challenging the same patent.
RulingsInstitution decision- PTAB / AIA Trials › Real party in interest / privityRpi dispute resolved for petitionerDecided for petitioner
“request from Patent Owner for Director Review, finding that Patent Owner introduced “evidence sufficient to put RPI and privity at issue” and remanding with instructions to “allow discovery, narrowly tailored to resolve the RPI and privity issues” including “at least materials sufficient to clarify the evidence the Board found to be ‘ambiguous’ and to avoid the need for the Board to ‘speculate as to the nature of the redacted material.’” Paper 57 (Decision on Request for Director Review). The Director instructed that after allowing such discovery, we “should then determine on the full record whether Petitioners have met their burden of demonstrating that the Petitions are not time-barred under § 315(b), applying the framework set forth in Worlds Inc. v. Bungie, Inc., 903 F.3d 1237, 1242–44 (Fed. Cir. 2018). Concurrently herewith, we issue a decision in IPR2025- 00278 finding that Petitioner has met its burden of demonstrating that its Petition is not time-barred under 35 U.S.C. § 315(b).” slip op. at 2
- Other 314aInstitution denied discretionary otherInstitution denied
“Review Decision instructing that “if the Board determines that Petitioners met their burden to identify all RPIs in the Petitions, then the Board should maintain at most one IPR challenging each of the ’114 patent, the ’517 patent, the ’430 patent, and the ’225 patent.” Paper 79, 3. Together with its Petition in this proceeding and the proceeding in IPR2025-00274, Petitioner filed an Explanation Regarding the Necessity of Multiple Petitions. Paper 2 (“Explanation”); IPR2025-00274, Paper 2. In the Explanation, Petitioner “request[s] that, if the Board uses its discretion to institute the Petitions, the Board consider the merits of IPR2025-00274 . . . before IPR2025-00278.” Explanation, 3. Further to Petitioner’s request, we first considered the merits of IPR2025-00274. For the reasons discussed in our concurrently issued decision in IPR2025-00274, we institute inter partes review on the grounds set forth in the Petition in IPR2025-00274. Further to the Director’s instruction that we “maintain at most one IPR challenging . . . the ’114 patent,” and the Petitioner’s request that we consider the merits of IPR2025-00274 before IPR2025-00278, we deny institution of the Petition in this proceeding.” slip op. at 3
Discretionary denialPatents in suitUS 10,343,114 - Berkshire Hathaway Energy Company / Pacificorp v. Birchtech Corp.Institution deniedPTAB · May 18, 2026 · IPR2025-00281 · APJ David Cotta · IPR · Institution
The Board denied institution because it had instituted IPR2025-00280 challenging the same patent, consistent with the Director’s instruction to maintain at most one IPR.
RulingsInstitution decision- Other 314aInstitution denied discretionary otherInstitution denied
“Review Decision instructing that “if the Board determines that Petitioners met their burden to identify all RPIs in the Petitions, then the Board should maintain at most one IPR challenging each of the ’114 patent, the ’517 patent, the ’430 patent, and the ’225 patent.” Paper 79, 3. Together with its Petition in this proceeding and the proceeding in IPR2025-00280, Petitioner filed an Explanation Regarding the Necessity of Multiple Petitions. Paper 2 (“Explanation”); IPR2025-00281, Paper 2. In the Explanation, Petitioner “request[s] that, if the Board uses its discretion to institute the Petitions, the Board consider the merits of IPR2025-00280 . . . before IPR2025-00281.” Explanation, 3. Further to Petitioner’s request, we first considered the merits of IPR2025-00280. For the reasons discussed in our concurrently issued decision in IPR2025-00280, we institute inter partes review on the grounds set forth in the Petition in IPR2025-00280. Further to the Director’s instruction that we “maintain at most one IPR challenging . . . the ’517 patent,” and the Petitioner’s request that we consider the merits of IPR2025-00280 before IPR2025-00281, we deny institution of the Petition in this proceeding.” slip op. at 3
Discretionary denialPatents in suitUS 10,596,517 - BMW Of North America, LLC v. Foras Technologies Ltd.No claims unpatentablePTAB · Mar 5, 2026 · IPR2024-01347 · APJ Russell E Cass · IPR · Final written decision
Claims 1–27 were not shown unpatentable because the asserted combinations did not teach switching the boot-processor role to a spare processor.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art The level of skill in the art is “a prism or lens” through which we view the prior art and the claimed invention. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). “This reference point prevents . . . factfinders from using their own insight or, worse yet, hindsight, to gauge obviousness.” Id.” slip op. at 17
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownOther
“processor” to the spare processor, we determine that the claim is describing this transfer of identification of “boot processor,” which is required when transferring a boot processor’s functions to a spare because of the “problems [that] arise in attempting to idle (or eject) the boot processor.” Id. at 6:25– 27. This is confirmed by the language of limitation [1d], stating that the switching of the role of boot processor involves “changing a system identifier of the spare processor to that of the boot processor.” Thus, the firmware and operating system exchange this information identifying the boot processor, which is described in the specification as a device tree. See, e.g., id. at 13:21–35. The ’302 patent makes clear that accurate identification of which processor is the boot processor remains critical during runtime. See, e.g., id. at 6:25–27. Thus, Patent Owner is correct in requiring the system to have a way to identify the boot processor and to transfer this identification during runtime. However, as made clear in the embodiments described in the ’302 patent discussed above, this identification is for runtime purposes to accommodate runtime problems, not for booting purposes. Although Patent Owner may be correct that a function of the boot processor is to boot the system (PO Sur-reply 5), the problem identified in the ’302 patent is a problem relating to the runtime reassignment of the boot processor identity, to address a runtime need to identify the boot processor. See, e.g., Ex. 1001, 11:6–9. Accordingly, based on our analysis of the claims and specification, we determine that “switching the role of boot processor to a spare processor without shutting down the system’s operating system” means causing the system to identify the spare processor as the boot processor (e.g., in a device tree), which then causes the spare processor to appear as the boot processor to the system during runtime. Ex. 1001, 6:25–41, 11:4–18 (describing why boot processors are treated differently even after the boot process has completed); compare id. at 9:65–11:3 (process for recovering from loss of lockstep of a non-boot processor without using a spare), with id. at 11:4–43 (process for recovering from loss of lockstep of a boot processor using a spare because boot processors, during runtime, need special treatment); see also 14:66–15:21 (emphasizing that spares are only needed for recovering boot processors). We construe switching a “role of boot processor” to mean transferring an identification in the system of which processor is the boot processor. This construction comports with the embodiments described in the specification. We do not adopt an additional requirement that this procedure also requires designating which processor will boot the system in the next reboot, which is not disclosed in the specification.” slip op. at 24
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“may swap processors that are failing, and perform the necessary bookkeeping to keep the operating system informed as to how to address the processors available, nothing in the Petition persuasively explains whether this generic processor swapping switches the boot processor role. As we explained in our claim construction section, the term “boot processor” is not merely a label of convenience to describe the processor that happened to have earlier booted the system. The role of boot processor is specifically switched to the spare; it is a piece of information tracked by the system. As we explain below, Petitioner does not adequately address the transfer of this information to make the system aware of which processor has the boot processor role. Petitioner asserts that “the BSP flag” of the IA-32 system is used to “determine whether a processor is the boot processor.” Pet. 17–18. Petitioner here is relying on a register used in IA-32 processors to identify whether or not they are the boot processor. This register is used during booting so that only the boot processor boots the system. See, e.g., Ex. 1008, 238–40, 710. This register does not appear to serve any further role, and Petitioner offers no persuasive evidence or argument that the processor register flag is exposed or copied to the operating system or APIC table. Petitioner’s proposed combination does not involve updating this register, nor does Petitioner explain how, even if the register were updated, it would meet the “switching” a “role of boot processor” in limitation [1d].” slip op. at 32
- ExcludeOther
“The USPTO has established Rules for objecting to and challenging evidence. 37 C.F.R. § 42.64. This process sets various timeframes and permits briefing and curative actions, all of which are designed to crystallize 5 We follow the parties’ convention of citing to the later-added “Page X of Y” pagination rather than the native pagination. the issues and ensure a full and fair opportunity for the parties to be heard. See id. In this instance, Patent Owner’s evidentiary arguments regarding Exhibits 1008 and 1028 are untimely. Accordingly, we will not exclude Exhibits 1008 or 1028 on the basis of their authenticity, admissibility, or for any reason that should have been raised under the proper procedures. See, e.g., PO Resp. 7–8; PO Sur-reply 7–8; see also Pet. Reply 11 (asserting that “Patent Owner has not filed any objection to or a motion to exclude these references”). We consider Petitioner’s citations to these documents in our prior art analysis below. Notwithstanding, as is clear from our patentability analysis below, Exhibits 1008 and 1028 do not serve to demonstrate the unpatentability of any claim.” slip op. at 26
Patent outcomesUS 7,624,302 not shown unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,624,302 - BMW Of North America, LLC v. Foras Technologies Ltd.No claims unpatentablePTAB · Mar 5, 2026 · IPR2024-01346 · APJ Russell E Cass · IPR · Final written decision
Claims 1–30 were not shown unpatentable because the prior-art combinations did not establish transfer of the role of boot processor during system runtime.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for patent owner
“Patent Owner asserts that: A person of ordinary skill in the art in the field of the ’781 patent would have been a person with at least a bachelor’s degree in Electrical Engineering, Computer Engineering, or equivalent, and at least two years of prior work experience with computer architecture, including experience relating to fault tolerant computer architecture, as of the earliest priority date of the ’781 patent—October 25, 2004. If a person did not have a bachelor’s degree, additional relevant and practical experience with fault tolerant computer systems could provide an acceptable substitute. Likewise, further education beyond a bachelor’s degree could compensate for a deficiency in practical experience. See EX2004, Declaration of Nigel A. Jones (“Jones”), ¶ 26. PO Resp. 3. Patent Owner further notes that its position is “similar, but not identical to, Petitioner’s [position]” but that “the analysis [of the claims] is identical for both proposed determinations.” Id. We agree that our analysis would not differ based on choosing one proposed level of skill over the other, but as the losing party, we select Petitioner’s proposed level of skill.” slip op. at 20
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner
“Accordingly, based on our analysis of the claims and specification, we determine that “logic . . . for transferring, during system runtime, the role of boot processor” means logic that causes the system to identify the spare processor as the boot processor (e.g., in a device tree) which then causes the spare processor to appear as the boot processor to the system during runtime. Ex. 1001, 5:39–55, 10:43–67 (describing why boot processors are treated differently even after the boot process has completed); compare id. at 9:37– 10:42 (process for recovering from loss of lockstep of a non-boot processor without using a spare), with id. at 10:43–11:42 (process for recovering from loss of lockstep of a boot processor using a spare because boot processors, during runtime, need special treatment); see also 15:21–42 (emphasizing that spares are only needed for recovering boot processors). We construe transferring a “role of boot processor” to mean transferring an identification in the system of which processor is the boot processor. This construction comports with the embodiments described in the specification. We do not adopt an additional requirement that this procedure also requires designating which processor will boot the system in the next reboot, which is not disclosed in the specification.” slip op. at 26
- Expert testimonyPetitioner expert discountedDecided for patent owner
“Based on the clear support in the specification for the above interpretation, we see no need to resort to extrinsic evidence. Seabed Geosolutions (US) Inc. v. Magseis FF LLC, 8 F.4th 1285, 1287 (Fed. Cir. 2021) (“If the meaning of a claim term is clear from the intrinsic evidence, there is no reason to resort to extrinsic evidence.”) (citing Profectus Tech. LLC v. Huawei Techs. Co., 823 F.3d 1375, 1380 (Fed. Cir. 2016) (“Extrinsic evidence may not be used ‘to contradict claim meaning that is unambiguous in light of the intrinsic evidence.’” (quoting Phillips, 415 F.3d at 1324)). In general, the cited portions of testimony from the declarants from both parties in the briefs do little more than point to the portions of the ’781 patent described above or argue about what a boot processor does during booting. See, e.g., Pet. Reply 2–8. The specification makes clear that it is focused on the role of boot processor during runtime because of problems encountered during runtime; it is not focused on the boot processor during booting. Ex. 1001, 5:39–55, 10:43–67. Thus, the testimony about what a boot processor does during booting, or that the primary function of the boot processor is to boot, is not particularly pertinent, and does not undo the unambiguous discussion in the ’781 patent.” slip op. at 27
- BurdenDecided for patent owner
“whether they are the boot processor or not (Ex. 1008, 238, 710), Petitioner does not explain how such information is exposed to the BIOS or operating system, nor how it is changed during runtime, after its purpose has been fulfilled. In sum, even if Petitioner’s proposed combination swaps the spare processor for the processor that booted the system, Petitioner’s proposed combination does not appear to transfer the role of boot processor to the spare processor. At best, Petitioner’s proposed combination transfers the tasks of one processor to another. See Ex. 1005 ¶¶ 15 (Fox describing its disclosure as “updat[ing] the ‘active’ processor list” and “[re-]allocat[ing] the threads that were running on the failing processor”), 46 (transferring “processes (instructions, threads, etc.) initially allocated to the failing processor” to the spare processor)). Of the art of record, we are only aware of the ’781 patent transferring a designation of which processor is the boot processor during the swap to a spare processor. See, e.g., Ex. 1001, 10:43– 55, 11:10–12, 16:19–21, 17:51–55; claims 1, 9, 16, 25. In conclusion, we find that Petitioner has not shown, by a preponderance of the evidence, how the prior art teaches “transferring” a “role of boot processor” as required by limitation 1[c].” slip op. at 40
Patent outcomesUS 7,627,781 not shown unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,627,781 - Qualcomm Incorporated v. Cobblestone Wireless, LLCSome claims unpatentablePTAB · Mar 5, 2026 · IPR2024-01336 · APJ Russell E Cass · IPR · Final written decision
Claims 1–4, 6–9, 24, and 25 are unpatentable; claims 10, 13, 14, 17, and 21–23 were not shown unpatentable, principally due to missing limitations or insufficient motivation to combine.
RulingsFinal written decision- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“information” should be given its plain and ordinary meaning as “data,” and that Patent Owner’s narrower construction of “first information” and “second information” lacks sufficient support in the intrinsic record. We agree with Petitioner that the ’802 patent Specification defines “information” as data when it uses the phrase “information (i.e., data).” See Ex. 1001, 5:60–62 (“Information (i.e., data) to be transmitted may be received in a baseband digital system 250, such as a wireless digital baseband processor.” (emphasis added)), 11:30–32 (“In this example, the signals 911 and 912 carry the same information (data).” (emphasis added)). As the Federal Circuit has explained, a “specification’s use of ‘i.e.’ signals an intent to define the word to which it refers.” Edwards Lifesciences LLC v. Cook Inc., 582 F.3d 1322, 1334 (Fed. Cir. 2009). slip op. at 13
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableNot shown unpatentableMixed
“argument based on Fernandez alone, we find that Petitioner has not provided a sufficient evidentiary basis to support a motivation to remove the amplification from each of Fernandez’s signal generators 10A-10E and add a single power amplifier instead. See Pet. 76–77 Ex. 1003 ¶ 235. Petitioner’s only rationale for this modification to Fernandez is that “[a] single amplifier has several advantages compared to multiple amplifiers, including lower complexity, a single (vs. multiple) potential point of failure, and lower cost,” and that one of ordinary skill “would have found a single amplifier to be a simple matter of design preference.” Pet. 76–77. Dr. Almeroth simply repeats these cursory allegations without providing any further explanation or evidentiary support. Ex. 1003 ¶ 235. Moreover, Dr. Cooklev provides credible testimony that replacing Fernandez’s amplification in signal generators 10A–10E with a single amplifier would not necessarily have the advantages that Petitioner suggests. See Ex. 2013 ¶¶ 99, 104–105. For example, Dr. Cooklev testifies that a single amplifier would need to have a wider bandwidth than the multiple amplifiers used in Fernandez, which could cause potential stability issues. Id. ¶ 105. According to Dr. Cooklev, this wider bandwidth would require more circuit elements, and thus would not provide the reduction in space usage and power consumption that Petitioner asserts. Id. According to Dr. Cooklev, Montojo also points to several “substantial, and potentially impractical, drawbacks” of using a single amplifier for multiple signal generators, including power constraints imposed by spectral emission requirements and on-board battery capacity. Id. ¶ 104 (citing Ex. 1006 ¶¶ 7– 8). In light of this testimony, which we find credible, Petitioner has failed to provide sufficient explanation or evidence to support its assertion that one of ordinary skill would have found it obvious to replace the multiple amplifiers in Fernandez’s signal generators with a single amplifier.” slip op. at 65
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“argument based on Fernandez alone, we find that Petitioner has not provided a sufficient evidentiary basis to support a motivation to remove the amplification from each of Fernandez’s signal generators 10A-10E and add a single power amplifier instead. See Pet. 76–77 Ex. 1003 ¶ 235. Petitioner’s only rationale for this modification to Fernandez is that “[a] single amplifier has several advantages compared to multiple amplifiers, including lower complexity, a single (vs. multiple) potential point of failure, and lower cost,” and that one of ordinary skill “would have found a single amplifier to be a simple matter of design preference.” Pet. 76–77. Dr. Almeroth simply repeats these cursory allegations without providing any further explanation or evidentiary support. Ex. 1003 ¶ 235. Moreover, Dr. Cooklev provides credible testimony that replacing Fernandez’s amplification in signal generators 10A–10E with a single amplifier would not necessarily have the advantages that Petitioner suggests. See Ex. 2013 ¶¶ 99, 104–105. For example, Dr. Cooklev testifies that a single amplifier would need to have a wider bandwidth than the multiple amplifiers used in Fernandez, which could cause potential stability issues. Id. ¶ 105. According to Dr. Cooklev, this wider bandwidth would require more circuit elements, and thus would not provide the reduction in space usage and power consumption that Petitioner asserts. Id. According to Dr. Cooklev, Montojo also points to several “substantial, and potentially impractical, drawbacks” of using a single amplifier for multiple signal generators, including power constraints imposed by spectral emission requirements and on-board battery capacity. Id. ¶ 104 (citing Ex. 1006 ¶¶ 7– 8). In light of this testimony, which we find credible, Petitioner has failed to provide sufficient explanation or evidence to support its assertion that one of ordinary skill would have found it obvious to replace the multiple amplifiers in Fernandez’s signal generators with a single amplifier.” slip op. at 65
- Expert testimonyPatent owner expert creditedPetitioner expert discountedOther
“We find credible and agree with Dr. Cooklev’s testimony that the predistortion signals from tables 17-1 and 17-2 “are cancelled out by Suzuki’s amplifier” 28. Ex. 2013 ¶ 50. Dr. Cooklev supports his opinion by referring to paragraph 1 of Suzuki, which states that Suzuki’s invention is directed to “a multi-band lookup table type predistorter” (such as the one implemented using lookup tables 17-1 and 17-2 in Figure 6) that “compensates for a distortion of a power amplifier.” Ex. 2013 ¶ 54; Ex. 1004 ¶ 1. Dr. Cooklev’s opinion is also supported by paragraph 3 of Suzuki, which explains that a conventional digital predistorter uses a lookup table “for linearizing non-linear characteristics of an amplifier.” Ex. 1004 ¶ 3; Ex. 2013 ¶ 54. Dr. Cooklev further supports his opinion by relying on Suzuki’s disclosure in paragraph 46 that power amplifier 28 is “subject to distortion compensation” by the predistorter, and that distortion components in the signal output by the amplifier are canceled by “distortion compensation data [that] are read out from the lookup tables 17-1 and 17-2 and provided to the adders 13-1 and 13-2, respectively.” Ex. 1004 ¶ 46; Ex. 2013 ¶ 54. And, Dr. Cooklev’s opinion is supported by Suzuki’s disclosure in paragraph 47 that the distortion compensation added by adders 13-1 and 13-2 add the distortion compensation data from lookup tables 17-1 and 17-2 “to perform distortion compensation (addition of predistortion)” to “signals to be transmitted.” Ex. 1004 ¶ 47; Ex. 2013 ¶ 54. Petitioner agrees that the distortion compensation data from lookup tables 17-1 and 17-2 “are added to the respective frequency band from” input signal ST “in order to predistort the output signal, which is then transmitted,” and does not dispute that the distortion compensation data from lookup tables 17-1 and 17-2 is ultimately cancelled out by the distortion created by amplifier 28. Pet. Reply 8. In light of the above evidence, we agree with Patent Owner that Suzuki’s distortion components from lookup tables 17-1 and 17-2 in Figure 6 (which Petitioner relies on for the first and second digital signals in limitations 10a and 10b) are cancelled out by the distortion created by power amplifier 28 before the signal is ultimately transmitted. We agree with Petitioner that these first and second digital signals include data in the form of distortion compensation data. However, because these signals are cancelled by the distortion from amplifier 28 before transmission, the data from these signals is never transmitted. Thus, the first and second digital signals identified by Petitioner (the distortion compensation data from lookup tables 17-1 and 17-2) do not comprise data “to be transmitted,” as limitations 10a and 10b require.” slip op. at 35
Patent outcomesUS 7,924,802 mixedClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,924,802 - Cisco Systems, Inc. v. Lionra Technologies LimitedAll claims unpatentablePTAB · Mar 4, 2026 · IPR2024-01281 · APJ Steven M Amundson · IPR · Final written decision
Claims 1–3, 5–10, 12–15, and 17–21 are unpatentable as obvious over Cornett, Paatela, and Nelson; claim 8 is also unpatentable with Russell.
RulingsFinal written decision- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable
“been motivated to combine the teachings of Cornett, Paatela, Nelson, and Russell in the way Petitioner proposes and would have had a reasonable expectation of success. See supra §§ III.E.2(a)–(b). Hence, Petitioner has shown by a preponderance of the evidence that claim 8 is unpatentable under § 103(a) because the claim would have been obvious over Cornett, Paatela, Nelson, and Russell.” slip op. at 122
- Skill levelOther
“B. Level of Ordinary Skill in the Art Factors pertinent to determining the level of ordinary skill in the art” slip op. at 13
Patent outcomesUS 7,738,471 unpatentable§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,738,471 - Charter Communications, Inc. v. Iarnach Technologies Ltd.Some claims unpatentablePTAB · Feb 19, 2026 · IPR2024-01287 · APJ Russell E Cass · IPR · Final written decision
Claim 5 is unpatentable over Bernstein alone or with Tsuge; claims 1–3 and 6–11 were not shown unpatentable because the asserted grounds fail to teach required limitations.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner asserts that an ordinarily skilled artisan at the time of the alleged invention “would have at least a bachelor’s degree in electrical engineering, computer science or comparable degree or 2–3 years industry experience designing and/or maintaining back-end networking equipment.” Pet. 11. In the Preliminary Response, Patent Owner stated that it “does not contest Petitioner’s recitation of the level of skill in the art, because even under Petitioner’s proposed level of skill,” Petitioner “has failed to demonstrate a reasonable likelihood of success.” Prelim. Resp. 17. In the Institution Decision, we adopted Petitioner’s proposed definition of a person of ordinary skill in the art, finding that it was consistent with the ’982 patent and the asserted prior art. Inst. Dec. 14 (citing Okajima, 261 F.3d at 1355).” slip op. at 14
- Claim Construction › Intrinsic evidence (Phillips canons) › Preamble limiting or notPreamble limitingDecided for patent owner
“Following the Institution Decision, both parties submitted proposed claim constructions in the district court stating that the preamble is limiting. Ex. 2009, 3–4 (Petitioner’s Preliminary Claim Construction Chart); Ex. 2010, 7 (Patent Owner’s Preliminary Claim Construction Chart). Patent Owner states in the Patent Owner Response that “[t]he parties now agree that the entire preambles of both claims 1 and 6 are limiting.” PO Resp. 17. In its Reply, Petitioner states that “whether the Board finds the phrase ‘service auto-configuration’” in the preamble to be limiting is “immaterial” because it “does not affect the analysis of whether the prior art cited in the petition invalidates [the challenged] claims.” Pet. Reply 5. At the oral hearing, Petitioner acknowledged that it does not dispute that the entire preamble of claims 1 and 6 is limiting. Tr. 20:25–21:17, 23:15–17. Because the parties agreed in district court that the entire preamble of claims 1 and 6 is limiting, and also agree in this proceeding, we find that the preambles of claims 1 and 6 are limiting for purposes of this Decision. We will discuss the meaning of the preamble further in the sections below applying the prior art to the claims. See §§ III.A..4(a), III.A.7, III.C.1(a), III.C.7, infra.” slip op. at 15
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner
“Based on the record before us, and for purposes of this Decision, we do not need to, and do not, construe any other claim terms to resolve the controversy before us. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 16
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableNot shown unpatentableMixed
“Based on the full trial record, we find that Petitioner has failed to meet its burden to show that Bernstein recites a “service auto-configuration” method as recited in the preamble of claim 1. As discussed above, the parties agree that the preamble of claim 1, including the “service auto-configuration method” language, is limiting. See § II.B, supra. As we explained in the Institution Decision, the Petition does not set forth a construction of “service auto-configuration method” or explain how the prior art discloses a “service auto-configuration method.” Pet. 11, 24; Inst. Dec. 32. Instead, the Petition merely explains how Bernstein teaches “a DOCSIS Provisioning of EPON (DPoE) system,” without explaining how it teaches a “service auto-configuration method.” Pet. 24 (citing Ex. 1005 ¶ 59). By failing to offer a construction of “service auto-configuration method” or explain how this limitation is met by the prior art, the Petition fails to show by a preponderance of the evidence that the prior art discloses or suggests this limitation.” slip op. at 34
Patent outcomesUS 9,287,982 mixedClaim construction§ 103 obviousnessPatents in suitUS 9,287,982 - Penumbra, Inc. v. Rapidpulse, Inc.No claims unpatentablePTAB · Feb 17, 2026 · IPR2024-01261 · APJ Jamie T Wisz · IPR · Final written decision
Claims 1–20 were not shown unpatentable because the asserted combinations did not teach the claimed predetermined cycle for controlling distal fluid flow.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“(1) a person with a B.S. in engineering or an equivalent field, with two-four years of academic or industry experience in aspiration embolectomy and thrombectomy or comparable industry experience who would, where appropriate, work or consult with others, including a physician, to develop embolectomy or thrombectomy devices; or (2) an interventional neurosurgeon with at least three years of experience developing and/or using medical devices in embolectomy or thrombectomy procedures, and who would, where appropriate, work or consult with others, including an engineer, to develop such a medical device. Pet. 11 (citing Ex. 1005 ¶ 48). Petitioner also contends that, “[a] person with less education but more relevant practical experience, or more relevant education but less practical experience, may also meet this standard.” Id. Patent Owner states that for purposes of its PO Response, it “accepts ¶ 44). We adopt Petitioner’s characterization because it is consistent with the level of skill in the art at the time of the invention as reflected by the ’402 patent and the cited prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“specification explicitly includes sensors similar to those in the prior art in support of their argument that the claimed “predetermined cycle” must not exclude the use of such sensors. Pet. Reply 15 (citing Ex. 1001, 32:55–33:7, 40:66–41:5, 44:9–29). We reviewed the portions of the specification cited by Petitioner. We agree with Patent Owner that one excerpt discussing sensor use appears to be directed to triggering the predetermined cycle rather than causing timing changes during the cycle itself (Ex. 1001, 32:55–66) (describing use of a pressure sensor to “determine when the vacuum channel 3 is clogged by a thrombus and automatically perform the unclogging procedures described herein”), while another excerpt discusses a sensor that Petitioner that the ’402 patent discusses the use of sensors to “tune” the system and that such “tuning” can be done statically (setting the cycle timing in advance) or dynamically (adjusting the timing during the cycle itself). See Ex. 1001, 48:19–49:50. Overall, we find that these disclosures involving sensors demonstrate that sensors may be used in various ways in different embodiments. However, none of these disclosures explicitly discuss the use of sensors in conjunction with a “pre-determined cycle.” Therefore, we find that the ’402 patent specification’s discussion of “sensors” are not particularly informative as to the appropriate construction of a “predetermined cycle” and do not outweigh the other explicit disclosures of “predetermined cycle” in the patent. We next turn to the other intrinsic evidence discussed by the parties — the prosecution history. As discussed by Patent Owner, in the Notice of Allowance, the Examiner found that Garrison did not teach or suggest a “predetermined cycle” because Garrison’s controller “changed the cycle of opening and closing the valves based on feedback from sensors.” Ex. 1004, 86. We acknowledge that the patent applicant filed subsequent comments during prosecution in which they stated that they “do[] not concede that the Examiner’s characterizations of the terms of the claims and the prior art are correct.” Id. at 29. However, we agree with Patent Owner that the importance of the Examiner’s statement in the Notice of Allowance does not rely on it being an express disclaimer (a standard which it does not meet). PO Sur-reply 8. We also considered Petitioner’s contention that the Examiner’s interpretation of Garrison may have been in error (PO Resp. 16); however, even if this were true, the Examiner’s statement still provides helpful insight into how the Examiner was interpreting the term sensors to change the opening and closing of valves during a cycle was not a “predetermined cycle.” Id. at 86. In sum, we find that Patent Owner’s proposed construction is consistent with the usage of the term “predetermined cycle” in the ’402 patent specification and prosecution history. Thus, after considering all of the cited evidence, we construe “predetermined cycle” to mean that “the timing of the sequence of valve operations in the cycle is determined beforehand, i.e., fixed, rather than varying based on feedback after operation begins.”” slip op. at 14
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“2. Other Terms The parties also provided proposed constructions for the limitations of “[limited/limiting] to a positive amount of exit flow” and “control[ling] fluid flow in and out from the distal end of the catheter.” See Pet. 15–16; Pet. Reply 1–8; PO Resp. 22–24; PO Sur-Reply 2–6. However, having evaluated the arguments and evidence before us, we determine that construction of these terms is not necessary for purposes of this Decision. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableNot shown unpatentable
“We agree with Patent Owner that neither Petitioner nor Mr. Brown propose any combination of Yang and Mullins that does not include Mullins’s pressure sensor in order “to control fluid flow in and out from the distal end of the catheter.” Indeed, in addressing the “predetermined cycle” limitation, Mr. Brown contends that Mullins discloses a “cycling controller that ‘varies aspiration pressure according to sensed pressure within the catheter lumen.’” Ex.1005 ¶¶ 131–32 (citing, e.g., Ex.1008, 27:40–28:20 (“[a] novel aspect of this pump system is the incorporation of feedback into the pump algorithm in order to produce more effective pressure cycling”)). This use of a sensor to change pressure during a cycle, is not a “predetermined cycle” under our construction. combinations is its discussion of distal end flow control, not for its sensors.” Pet. Reply 17 (citing Ex. 1035 ¶ 83). However, Petitioner’s obviousness grounds rely on the combination of Yang and Mullins, especially with regard to Mullins’s disclosure of “a controller” in order “to control fluid flow in and out.” As discussed above, Mullins relies on the sensor-feedback approach in order to control flow and we find that Petitioner has not presented persuasive evidence of how the combined disclosures of Yang and Mullins would control flow without using Mullins’s sensor feedback approach. See W.L. Gore & Assocs., Inc. v. Garlock, Inc., 721 F.2d 1540, 1550 (Fed. Cir. 1983) (error to “consider[] … references in less than their entireties, i.e., in disregarding disclosures in [them] … that diverge from and teach away from the invention”). Therefore, we determine that Petitioner has not sufficiently shown that the combination of Yang and Mullins discloses or renders obvious “a controller configured to open and close the vacuum valve and the vent valve in a predetermined cycle to change a level of vacuum at the distal end of the catheter and to control fluid flow in and out from the distal end of the catheter.” Accordingly, having considered the parties’ respective evidence and arguments, we find that Petitioner has not shown by a preponderance of the evidence that claim 1 of the ’402 patent would have been unpatentable as obvious over the combination of Yang and Mullins.” slip op. at 27
Patent outcomesUS 11,406,402 not shown unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,406,402
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.