- PTAB · Jun 18, 2025 · IPR2025-00426 · APJ Stephen E Belisle · IPR · Institution
The Board instituted IPR on claims 11–15 over Jarvinen and Fox under § 103 and granted Samsung’s motion to join the T-Mobile IPR.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Because the issues presented in the instant Petition are identical to those in the T-Mobile IPR, we determine for the same reasons that there is a reasonable likelihood that Petitioner would prevail in showing that at least one of the Challenged Claims is unpatentable. Therefore, we institute inter partes review for the same reasons stated in our Decision on Institution in the T-Mobile IPR. See IPR2024-01468, Paper 17.” slip op. at 7
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“Petitioner’s Motion addresses each of these considerations. Mot. 1–8. According to Petitioner, its “[P]etition challenges the validity of the same claims of the ’868 patent on identical grounds to those in the T-Mobile IPR,” “[t]here are no substantive differences between [Petitioner’s] and the T-Mobile IPR Petitioners’ Petition,” and “[Petitioner] also relies on the same supporting evidence.” Id. at 4–5. Petitioner argues that its “petition will not raise any new issues of unpatentability and will not impose any additional burden on the Board or Patent Owner, or add additional complexity to the case,” and that joinder will not unduly burden or negatively impact the trial schedule. Id. at 6. Further, Petitioner agrees to take an “understudy” role, and “[u]nless and until the current Petitioners in [the T-Mobile IPR] cease to participate in the T-Mobile IPR, [Petitioner] will not assume an active role.” Id. at 7–8. Thus, according to Petitioner, Patent Owner will not suffer prejudice if the two proceedings are joined. Id. at 8. Patent Owner has not disputed the above contentions by Petitioner and does not point to any particular prejudice relating to joining the two proceedings. In light of these considerations, Petitioner has shown that joinder to the T-Mobile IPR is appropriate in this case. Therefore, we grant Petitioner’s Motion for Joinder.” slip op. at 8
NonePatents in suitUS 9,094,868 - Digital Global Systems, Inc. v. Deepsig Inc.Institution deniedPTAB · May 28, 2025 · IPR2025-00194 · APJ Robert J Weinschenk · IPR · Institution
The Board denied institution under § 314(a), finding no reasonable likelihood for the remaining claims except claim 13, whose potential success did not justify instituting trial.
RulingsInstitution decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“had “a bachelor’s degree in electrical engineering, computer engineering, or equivalent and at least two years of experience working with radio communication systems and machine learning.” Pet. 3 (citing Ex. 1003 ¶¶ 33–34). Petitioner’s description of the level of ordinary skill in the art is supported by the testimony of Petitioner’s declarant, Dr. Zhi Ding. Ex. 1003 ¶¶ 33–34. Patent Owner does not dispute Petitioner’s description at this stage of the proceeding. We adopt Petitioner’s description for the purposes of this Decision.” slip op. at 4
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“the same standard used in a civil action under 35 U.S.C. § 282(b), including construing the claim in accordance with the ordinary and customary meaning of the claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent. 37 C.F.R. § 42.100(b). Neither party proposes an express construction for any claim terms. Pet. 13; Prelim. Resp. 16. We determine that no claim terms require express construction for purposes of this Decision.” slip op. at 5
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“reasonable likelihood of prevailing in showing that claims 4–6, 12, 14, and 16–22 would have been obvious over Jüschke and Holt. Petitioner may satisfy its burden for claim 13, but, as discussed below, that would not impact our decision to exercise our discretion under § 314(a) to deny institution. See Section II.F.” slip op. at 16
- Other 314aInstitution denied discretionary otherInstitution denied
“inter partes review. SAS Inst. v. Iancu, 584 U.S. 357, 366 (2018). Specifically, “[i]f a panel determines that a petition meets the standards for institution in relation to fewer than all the challenges presented, . . . the panel will evaluate all the challenges and determine whether, in the interests of efficient administration of the Office and integrity of the patent system, the entire petition should be denied.” See Consolidated Trial Practice Guide, 64 (Nov. 2019), available at https://www.uspto.gov/sites/default/files/ documents/tpgnov.pdf. Here, thirteen challenged claims remain after Patent Owner’s statutory disclaimer. Petitioner at most demonstrates a reasonable likelihood of prevailing for one dependent claim, which has no claims depending therefrom. See Sections II.C–II.E. Thus, based on the particular facts of this case, we find that instituting trial would not be an efficient use of the Board’s time and resources, and we exercise our discretion to deny institution under § 314(a). See Deeper, UAB v. Vexilar, Inc., IPR2018- 01310, Paper 7 at 41–43 (PTAB Jan. 24, 2019) (informative); Chevron Oronite Co. LLC v. Infineum USA L.P., IPR2018-00923, Paper 9 at 10–11 (PTAB Nov. 7, 2018) (informative).” slip op. at 16
Claim construction§ 103 obviousnessDiscretionary denialPatents in suitUS 11,777,540 - PTAB · May 7, 2025 · IPR2024-01468 · APJ Stephen E Belisle · IPR · Institution
Instituted IPR of claims 11–15 based on the asserted obviousness ground over Jarvinen and Fox.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. 35 U.S.C. § 314(b) (2024); 37 C.F.R. § 42.4(a). We may not institute an inter partes review “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). The “reasonable likelihood” standard is “a higher standard than mere notice pleading” but “lower than the ‘preponderance’ standard to prevail in a final written decision.” Hulu, LLC v. Sound View Innovations, LLC, IPR2018-01039, Paper 29 at 13 (PTAB Dec. 20, 2019) (precedential). When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim. 37 C.F.R. § 42.108(a). Applying those standards, and upon consideration of the information presented in the Petition, Preliminary Response, and supplemental briefing, we determine that Petitioner has demonstrated a reasonable likelihood of success in proving that at least one of the Challenged Claims is unpatentable. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). Accordingly, we institute an inter partes review as to all Challenged Claims of the ’868 patent on all relevant grounds raised in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“In determining the level of ordinary skill in the art, various factors may be considered, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citation omitted). Neither party argues, at least at this stage of the proceeding, that the outcome of this case would differ based on our adoption of any particular definition of the level of ordinary skill in the art. Considering the subject matter of the ’868 patent, the background technical field, the prior art, and Petitioner’s proposed and unopposed definition of the skilled artisan (Ex. 1012 ¶ 20), we apply the level of skill set forth above.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Only those claim terms that are in controversy need to be construed, and only to the extent necessary to resolve the controversy. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (stating that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). Petitioner submits that “all claim terms should be given their plain and ordinary meaning” (Pet. 10–11), and “Patent Owner agrees” (Prelim. Resp. 4). In determining at this stage of the proceeding that Petitioner has demonstrated a reasonable likelihood of establishing unpatentability of at least one challenged claim (namely dependent claim 11 in this case), we need not and do not construe expressly any claim terms. Nevertheless, we encourage the parties to submit proposed constructions for the limitation “determining a UE [i.e., User Equipment] environment information,” as recited in dependent claim 11. See Ex. 1001, 49:12–15, 1:40–42 (emphasis added). To the extent that a party proposes that this limitation should have its ordinary and customary meaning, the party should submit and explicitly identify such meaning. O2 Micro Int’l Ltd. v. Beyond Innovation Tech. Co., 521 F.3d 1351, 1361 (Fed. Cir. 2008) (“A determination that a claim term ‘needs no construction’ or has the ‘plain and ordinary meaning’ may be inadequate when a term has more than one ‘ordinary’ meaning or when reliance on a term’s ‘ordinary’ meaning does not resolve the parties’ dispute.”). For example, the parties should discuss (a) the meaning and scope of “determining” as used in the subject limitation; (b) the meaning and scope of “environment information” as used in the subject limitation; (c) any relationship or overlap between “environment information” and “link quality positioning information,” as recited in dependent claims 7 and 11 (see Ex. 1001, 48:62–65, 49:12–15); and (d) whether UE “environment information” includes location or orientation of the UE.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“Petitioner contends the skilled artisan would have had rational reasons to combine the teachings of Jarvinen and Fox to arrive at the invention of dependent claim 11 (which includes the features of independent claim 1 and dependent claim 7) and would have had a reasonable expectation of success in doing so. Pet. 37–41; see, e.g., id. at 38 (“[The skilled artisan] faced with the problem of estimating a UE’s future link quality at a location would have looked to Fox because Fox solves the problem of estimating future link quality with the exact same information available to Jarvinen.”); Ex. 1012 ¶ 70 (Dr. McClellan testifying that “[a]ll of the data upon which Fox relies is already disclosed and linked together in Jarvinen’s database, and it would have been obvious for [the skilled artisan] to combine Fox’s method of looking up previous link quality to estimate future link quality with Jarvinen’s teachings.”); ¶ 72 (Dr. McClellan testifying that “modifying Jarvinen to perform Fox’s link quality estimation would have constituted a simple substitution of a known element to yield predictable results.”). Patent Owner does not dispute such reasons or expectations at this stage of the proceeding. For the reasons and evidence set forth in pages 37–41 of the Petition, we are persuaded that Petitioner’s cited evidence provides sufficient rational reasons for purposes of institution to combine Jarvinen and Fox to arrive at the invention of claim 11, and to do so with a reasonable expectation of success. c) Summary At this stage of the proceeding and based on the record before us, we are persuaded that Petitioner’s cited evidence provides sufficient rational reasons for purposes of institution to combine Jarvinen and Fox with a reasonable expectation of success, and sufficiently supports Petitioner’s contention that dependent claim 11 would have been unpatentable as obvious over the combination of Jarvinen and Fox. Thus, for the foregoing reasons and those stated in Petitioner’s preliminary briefing (Pet. 17–47, 50–51, 54), we determine that Petitioner has established a reasonable likelihood that it would prevail in showing that claim 11 would have been unpatentable as obvious over the combination of Jarvinen and Fox.” slip op. at 18
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,094,868 - PTAB · Apr 25, 2025 · IPR2024-01463 · APJ David Cotta · IPR · Institution
The Board instituted inter partes review of claims 1–10 on all asserted grounds, finding a reasonable likelihood of success on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“predict how the district court in the related district court litigation will proceed because the court may determine whether or not to stay any individual case . . . based on a variety of circumstances and facts beyond our control and to which the Board is not privy.” Sand Revolution II LLC v. Cont’l Intermodal Grp., IPR2019-01393, Paper 24, 7 (PTAB June 16, 2020) (informative). We decline to speculate on how the court may rule on the pending motion to stay. Accordingly, this factor is neutral.” slip op. at 13
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), inter partes review may not be instituted unless the Petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Petitioner has established a reasonable likelihood of prevailing on its assertion that at least one of the challenged claims is unpatentable based on the grounds advanced here. We decline to deny the Petition on a discretionary basis as requested by Patent Owner. Thus, for reasons explained below, we institute inter partes review of claims 1–10 of the ’706 patent.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“TC(220), and ΔRz/Ra are result effective variables and that copper foils having ΔPD, TC(220), and ΔRz/Ra values that meet the values recited in claim 1 have advantageous properties. See, e.g., Ex. 1005 ¶ 45 (Kim ’761, disclosing that preferably the “difference in peak count roughness Rpc between the shiny surface . . . and the matte surface . . . of the electrolytic copper foil . . . is preferably 60 or less” because “when the difference in the peak count roughness Rpc exceeds 60 capacity maintenance of the secondary battery is deteriorated.”);15 Ex. 1007, 3:16–23, 4:14–23 (Cheng, disclosing that the foils of Cheng’s invention have (220) and (311) surfaces that provide increased elongation and that solve a high roughness problem that rendered traditional products unsuitable for use in a lithium ion secondary battery), 10:27–34 (Cheng, disclosing that in the foils of Cheng’s invention “the roughness difference between both sides was extremely small” and thus “it was . . . not easy for the electrolytic copper foil to break or fracture during the charging-discharging cycles and the life of a battery is thus increased”), Tables 3 & 4 (Cheng, disclosing embodiments and comparative examples with TC(220) values meeting the requirements of claim 1); Ex. 1008, 6:36–44 (Wolski, disclosing that “the surface roughness Rz at the matte side of the untreated copper foil of the present invention is the same or smaller than the surface roughness Rz at the shiny side . . . so that the surface treated copper foil . . . becomes more low-profiled . . . whereby it becomes a foil having a large etching factor”), 9:1–29 & Table 2 (Wolski, disclosing 15 Dr. Randall testifies that “Kim ’761’s peak count roughness Rpc corresponds to the peak density PD of the ’706 patent.” Ex. 1003 ¶ 52. At this stage in the proceeding, this testimony is unrebutted. 38 embodiments meeting the ΔRz/Ra of claim 1, describing them as having “matte side roughnesses” that are “sufficiently small,” and as having “excellent” “high temperature elongation characteristics”), 11:37–41 (Wolski, describing comparative examples as having “large” matte side roughnesses “whereby etching factors are not good”), 12:12–27 (Wolski, teaching that “as compared with a conventional untreated copper foil, both surfaces of the untreated copper foil obtained by [Wolski’s] invention are flat” resulting in a low profile foil that has “excellent elongations at room temperature and high temperature and also high tensile strength”). The teachings in the prior art support the presently unrebutted testimony of Dr. Randall explaining why the POSA would have been motivated to modify Kim ’761’s copper foil to have the claimed TC(220) and ΔRz/Ra. Ex. 1003 ¶¶ 66–68, 71–74; Pfizer Inc., v. Sanofi Pasteur Inc., 94 F.4th 1341, 1348 (Fed. Cir. 2024) (“Where [a gap in prior art] includes a parameter not necessarily disclosed in the prior art, it is not improper to consider whether or not it would have been recognized as result-effective. If so, then the optimization of that parameter is ‘normally obvious.’”). Accordingly, we are not persuaded by Patent Owner’s argument that Petitioner failed to articulate a sufficient motivation to combine the references. To the contrary, the preliminary record presents a strong showing that the POSA would have been motivated to combine the references in the manner described in the Petition.” slip op. at 38
- Skill levelSkill level petitioner adoptedDecided for petitioner
“At this stage of the proceeding, Patent Owner does not contest Petitioner’s definition of the level of skill in the art. Prelim. Resp. 4 (“For purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art”). Petitioner’s definition appears to be consistent with the field of the invention reflected in the prior art of record and the disclosure of the ’706 patent. Accordingly, for purposes of this Decision, we adopt Petitioner’s proposed definition of the person of ordinary skill in the art.” slip op. at 21
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 11,591,706 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 25, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–8 were unpatentable under the asserted obviousness grounds.
RulingsInstitution decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“experience working on the development of materials or components for electronic devices such as batteries.” Pet. 2. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less work experience, and additional work experience could compensate for less formal education.” Id. Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’014 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” 37 C.F.R. § 42.100(b). Under this standard, claim terms are generally given their plain and ordinary meaning as would have been understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. Phillips v. AWH Corp., 415 F.3d 1303, 1313 (Fed. Cir. 2005) (en banc). Only those terms in controversy need to be construed, and only to the extent necessary to resolve the controversy. Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019). in this proceeding.” Pet. 3. Patent Owner contends that “[t]he Board need not construe any term in order to determine that institution should be denied.” Prelim. Resp. 4. Based on the record before us, we determine that no claim term requires express construction for purposes of this Decision. See Realtime Data, 912 F.3d at 1375.” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“For these reasons, we are not persuaded that Petitioner sufficiently establishes that a POSITA would have been motivated to modify Hanafusa in light of Dobashi with a reasonable expectation of success as Petitioner contends. Accordingly, we determine that Petitioner fails to demonstrate a reasonable likelihood of prevailing in its assertion that the subject matter of claim 1, and claims 4 and 8 that depend therefrom, would have been obvious over the combined teachings of Hanafusa and Dobashi.” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“Petitioner also focuses on Hanafusa’s teaching that all known methods can be used to make a rough surface low-profile, and Dobashi’s teaching that RSm can be used as an indicator for judgment of the surface, to support its contention that a POSITA would have been motivated to apply Dobashi’s RSm to further achieve Hanafusa’s purpose, without explaining how and why that would be the case. In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness and is rough when RSm is small.” Id. at 3:1–3, 6:27–29. Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66– 3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66–3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 14
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 23, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–10 were unpatentable over either asserted § 103 ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2018); see also 37 C.F.R. § 42.4 (2023). For the reasons discussed below, we deny the Petition and do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“II. ANALYSIS A. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art (“POSITA”) “would have had at least an undergraduate degree in materials science, chemical engineering, electrical engineering, or related field, or equivalent knowledge, training, or experience, with at least two years of experience working on the development of materials or components for electronic devices such as batteries.” Pet. 4. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less 7 We refer to the page numbers added by Petitioner to the bottom-center of the page. formal education.” Id. (citing Ex. 1003 ¶ 10). Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’689 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163–64 (Fed. Cir. 1985))).” slip op. at 10
- Expert testimonyPetitioner expert discountedDecided for patent owner
“We are not persuaded, on this record, that Petitioner adequately establishes that Khatibi discloses a CTE in the claimed range of 16 to 22 µm/(m·°C.). Petitioner’s argument that Khatibi’s reported values meet this claim limitation are based solely on Dr. Randall’s testimony that Khatibi’s measurement method would produce results that would not significantly differ from results determined using the claimed method. See Pet. 16–18 (citing Ex. 1003 ¶¶ 56–60). Dr. Randall’s testimony, however, is largely conclusory and unsupported by adequate explanation and/or objective evidence. For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added). to little weight. See 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 12 at 5 (PTAB Feb. 10, 2023) (finding that “the Board was correct in giving little weight to Petitioner’s expert because the expert declaration merely offered conclusory assertions without underlying factual support”); Upjohn Co. v. Mova Pharm. Corp., 225 F.3d 1306, 1311 (Fed. Cir. 2000) (“Lack of factual support for expert opinion to factual determinations, however, may render the testimony of little probative value in a validity determination.” (quoting Ashland Oil, Inc. v. Delta Resins and Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985))); see also In re Ethicon, Inc., 844 F.3d 1344, 1348, 1352 (Fed. Cir. 2017) (concluding that the Board properly gave “little weight” to conclusory expert testimony of objective indicia). Because Petitioner offers Dr. Randall’s testimony to supply a limitation missing from the prior art, namely, the CTE measurement method, and we give Dr. Randall’s unsupported and conclusory testimony little weight, we are not persuaded that Petitioner establishes a reasonable likelihood of showing that Khatibi discloses limitation [1d].” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“second surfaces of the electrolytic copper foil ranges from 3 to 92.” Ex. 1001, 13:62–63. Petitioner contends that “Kim teaches that the electrolytic copper foil (e.g., untreated or treated copper foil) having Rz less than 2 µm is advantageous toward battery efficiency and performance,” and, similarly, Griesi describes the use of untreated electrolytic copper foil with an Rz value less than 2 µm in printed circuit boards that are compatible with secondary batteries. Pet. 58–59 (citing Ex. 1012, claim 2, ¶¶ 13, 25, 27; Ex. 1003 ¶ 157). In particular, Petitioner notes that Griesi’s Figure 3.16 describes an “Rz value of 1.2 µm.” Id. at 59 (citing Ex. 1015, 53–54; Ex. 1003 ¶ 158). Petitioner asserts that “Dr. Randall explains that a POSITA would have also recognized another surface roughness-related parameter, Rpc, in Griesi as a potentially useful parameter that can be optimized to further enhance uniformity or generally improve Kim’s copper foil surface, for example, to prevent wrinkles or achieve other advantageous effects.” Id. (citing Ex. 1003 ¶ 159). Although Dr. Randall demonstrates that Griesi’s Pc (or Rpc) value is 19.2 over a 4 mm sampling length (Ex. 1003 ¶ 155), Petitioner does not contend that Griesi addresses this value, or indicates any benefit that might be derived from its use. Instead, Griesi’s Pc value appears to be an incidental finding, which is not discussed or analyzed in the reference. See incidental, unexamined finding would lead a POSITA to import Griesi’s Pc value into Kim’s copper foil, absent a hindsight desire to reconstruct the claimed invention. As such, Petitioner’s arguments with respect to Kim and Griesi are not persuasive. See Cheese Sys. Inc. v. Tetra Pak Cheese and Powder Sys., Inc., 725 F.3d 1341, 1352 (Fed. Cir. 2013) (“Obviousness cannot be based on the hindsight combination of components selectively culled from the prior art to fit the parameters of the patented invention.” (internal quotations marks omitted)). Thus, we are not persuaded, on this record, that the combined disclosures of Kim and Griesi teach all of the elements of limitation [1g].” slip op. at 23
§ 103 obviousnesscites PhillipsPatents in suitUS 10,811,689 - Solus Advanced Materials Co, Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 22, 2025 · IPR2024-01460 · APJ Jon B Tornquist · IPR · Institution
The Board denied institution of review of claims 1–11 because the Fintiv factors, including the early trial date and close merits case, favored discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied fintivInstitution denied
“whether to institute an inter partes review. Applying the standard set forth in 35 U.S.C. § 314(a), we may not institute an inter partes review unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Institution of inter partes review, however, is discretionary. See Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1367 (Fed. Cir. 2016) (“[T]he PTO is permitted, but never compelled, to institute an IPR proceeding.”). For the reasons stated below, we exercise our discretion not to institute an inter partes review. A. Real Parties-in-Interest” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivDenied
“Board’s projected statutory deadline to issue a final written decision. Fintiv, Paper 11 at 9. “If the court’s trial date is at or around the same time as the projected statutory deadline . . . the decision whether to institute will likely implicate other factors.” Id. Conversely, “[i]f the court’s trial date is earlier than the projected statutory deadline,” this has generally weighed “in favor of exercising authority to deny institution.” Id.” slip op. at 15
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“Petition under 35 U.S.C. § 325(d) because the same or substantially the same art and arguments were before the Examiner during prosecution and Petitioner’s has not demonstrated that the Examiner erred in a material manner when allowing the claims. Pet. 17–18. Given our discretionary denial of the Petition in view of the Fintiv factors, we do not address Petitioner’s further arguments with respect to § 325(d).” slip op. at 32
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner applies Petitioner’s recited level of ordinary skill in the art for purposes of its Preliminary Response. Prelim. Resp. 4. Upon review of the parties’ arguments and the prior art of record, we adopt Petitioner’s unopposed definition of the ordinarily skilled artisan for purposes of this decision as it appears consistent with the disclosures of the ’090 patent and the prior art of record. C. Claim Construction” slip op. at 9
§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,480,090 - Tesla, Inc. v. Autonomous Devices, LLCAll claims unpatentablePTAB · Apr 11, 2025 · IPR2023-01055 · APJ Barbara A Parvis · IPR · Remand
On remand, the Board held claim 12 unpatentable over Grotmol and Hickman and denied the motion to amend because proposed substitute claims 21–29 were unpatentable.
RulingsRemand decision- RemandOther
“Director Review and remanding for further proceedings. Paper 49 (“Acting Director’s Decision” or “DR Dec.”). That Decision states agreement “that the Board’s analysis of claim 12 did not make separate factual findings.” DR Dec. 2. The Decision instructs us on remand “to consider Patent Owner’s arguments as to claim 12 and as to proposed substitute claim 21” and “[r]egardless of the Board’s disposition on remand, the Board should explain more fully its findings as to claim 12 and proposed substitute claim 21.” Id.” slip op. at 3
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Written Decision regarding the level of ordinary skill in the art. See generally DR Req. Upon consideration of the full record including the arguments in Patent Owner’s Request for Director Review, we maintain that determination here. More specifically, considering the subject matter of the ’344 patent, the background technical field, and the asserted prior art, we agree with Petitioner’s proposed qualifications for an ordinary level of skill, except we decline to adopt “at least” as that language is vague and open-ended. See 2024 Final Dec. 10–11. Accordingly, with that exception, we adopt Petitioner’s assessment of the level of skill for one of ordinary skill in the art.” slip op. at 13
- Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableUnpatentable
“the differences as compared to claim 1, including those findings and determinations set forth in a section of the 2024 Final Written Decision titled “Overview—Claims 6, 11, and 12” (id. at 65–67) and in the sections titled “Claim 12” and “Conclusion—Claims 6, 11, and 12” (id. at 83–86). Further, based on the complete record now before us, including Patent Owner’s Request for Director Review, for the reasons given in our 2024 Final Written Decision and our additional reasons given herein, we determine that Petitioner has shown by a preponderance of the evidence that the Grotmol and Hickman combination teaches the limitations of claim 12.” slip op. at 24
- PTAB / AIA Trials › Motions to amend / substitute claimsMotion to amend, deniedDenied
“Director Review and remanding for further proceedings. Paper 49 (“Acting Director’s Decision” or “DR Dec.”). That Decision states agreement “that the Board’s analysis of claim 12 did not make separate factual findings.” DR Dec. 2. The Decision instructs us on remand “to consider Patent Owner’s arguments as to claim 12 and as to proposed substitute claim 21” and “[r]egardless of the Board’s disposition on remand, the Board should explain more fully its findings as to claim 12 and proposed substitute claim 21.” Id.” slip op. at 3
Patent outcomesUS 11,238,344 unpatentable§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,238,344 - Juniper Networks, Inc. v. Monarch Networking Solutions LLCAdverse judgmentPTAB · Apr 1, 2025 · IPR2024-00565 · APJ Brian J Mcnamara · IPR · Adverse judgment
The Board granted Patent Owner’s unopposed motion for adverse judgment after claims 1 and 5-8 were cancelled in reexamination, and terminated the IPR.
RulingsAdverse judgment- Adverse judgmentAdverse judgmentGranted
“When all claims at issue in an IPR are cancelled in a concurrent reexamination, the Board “construe[s] [the] cancellation of all claims . . . as a request for adverse judgment.” Mercedes-Benz USA, LLC v. Signal IP, Inc., IPR2015-00941, Paper 21 at 2-3 (PTAB Apr. 14, 2016). ORDER In consideration of the foregoing, it is hereby: ORDERED that Patent Owner’s Motion for Adverse Judgment is GRANTED; FURTHER ORDERED that Adverse Judgment is entered; and FURTHER ORDERED that this inter partes review is terminated.” slip op. at 2
NonePatents in suitUS 8,451,845 - Digital Global Systems, Inc. v. Deepsig Inc.Institution deniedPTAB · Mar 27, 2025 · IPR2025-00049 · APJ Robert J Weinschenk · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood of proving any challenged claim obvious over the asserted combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“An inter partes review may not be instituted unless “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Here, Petitioner does not demonstrate a reasonable likelihood of prevailing in showing that at least one of the challenged claims is unpatentable. Thus, the Petition is denied, and no trial is instituted.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“had “a bachelor’s degree in electrical engineering, computer engineering, or an equivalent degree and at least two years of experience working with . . . radio communication systems and machine learning.” Pet. 3 (citing Ex. 1003 ¶¶ 33–34). Petitioner’s description of the level of ordinary skill in the art is supported by the testimony of Petitioner’s declarant, Dr. Zhi Ding. Ex. 1003 ¶¶ 33–34. Patent Owner does not dispute Petitioner’s description at this stage of the proceeding. We adopt Petitioner’s description for the purposes of this Decision.” slip op. at 4
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner
“B. Claim Construction In an inter partes review proceeding, a patent claim is construed using the same standard used in a civil action under 35 U.S.C. § 282(b), including construing the claim in accordance with the ordinary and customary meaning of the claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent. 37 C.F.R. § 42.100(b). Neither party proposes an express construction for any claim terms. Pet. 13; Prelim. Resp. 9–10. We determine that no claim terms require express construction for purposes of this Decision.” slip op. at 5
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“On this record, we agree with Patent Owner. Claim 1 recites “generating a pre-distorted radio signal by processing the transmit radio signal using a nonlinear pre-distortion machine learning model.” Ex. 1001, 14:19–24. This portion of claim 1 requires processing a transmit signal using a machine learning model. Id. Claim 1 also recites “updating the model parameters based on a distance metric computed between the transmit radio signal and a received signal that is obtained from the one or more radio receivers.” Id. at 14:30–35. This portion of claim 1 requires updating model parameters based on a distance metric computed using a received signal obtained from a receiver. Id. Thus, together, these portions of claim 1 require updating parameters for a transmit model based on a distance metric computed using a signal obtained from a receiver.” slip op. at 7
Claim construction§ 103 obviousnessPatents in suitUS 10,581,469
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.