- Caption Health, Inc v. University Of British ColumbiaInstitution deniedPTAB · Dec 19, 2025 · IPR2025-01066 · APJ Mary C Hoffman · IPR · Institution
Institution was denied because Petitioner did not show a reasonable likelihood that any challenged claim was unpatentable, including failure to show the claimed image-receiving quality-assessment neural network.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). Under 35 U.S.C. § 314(a), an inter partes review may not be instituted “unless . . . the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Based on the current record and for the reasons explained below, Petitioner has not demonstrated a reasonable likelihood of prevailing with respect to at least one of the challenged claims of the ’591 patent. Thus, we do not institute this inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Because Petitioner’s formulation is supported by declaratory testimony and appears consistent with the level of skill reflected in the asserted prior art and the ’591 patent, and because Patent Owner does not provide any supporting evidence, we adopt Petitioner’s formulation of the level of ordinary skill in the art. See Ex. 1002 ¶¶ 31–33. Our decision would be the same regardless of the differences between Petitioner’s and Patent Owner’s formulations.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“The parties do not propose any express claim construction. Pet. 11– 12; Prelim Resp. 17. We also determine that no express claim construction is necessary for our Decision, apart from that discussed in our below analysis. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only terms in controversy must be construed “and only to the extent necessary to resolve the controversy”) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 11
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundReasonable expectation not foundNot shown unpatentable
“Petitioner also fails to provide sufficient rationale and a reasonable expectation of success in combining Krishnan and Lee to arrive at a quality assessment neural network configured to receive an image. See Pet. 34–37. For example, the Petition lacks an explanation of why a POSITA would have been motivated to modify Krishnan’s quality assessment neural network to be configured to receive an image, instead of extracted features, in view of Lee’s image-receiving category classifying neural network. Id. Without such further explanation, Petitioner’s challenge falls short. Petitioner’s argument that neural networks for image quality assessment were “well-known” is not persuasive—it does not address the particular scope of limitation 1i, which also requires that the neural network is configured to receive images. Pet. 35 (citing Ex. 1002 ¶¶ 47–51, 118; Exs. 1017, 1023, 1024, 1026). Petitioner’s argument that combining Krishnan and Lee “would merely amount to applying known work from the field . . . to yield predictable results” is not persuasive because the Petition ties this reasoning to modifying Krishnan with Lee’s view-category-specific assessment parameters, not modifying Krishnan’s quality assessment neural network to receive images instead of extracted features. Id. at 37 (citing Ex. 1002 ¶ 126). Lastly, we note Petitioner’s expert’s discussion regarding neural networks for image quality assessments. Ex. 1002 ¶¶ 43–53 (citing Exs. 1010, 1015, 1016, 1017, 1018, 1023, 1024, 1026). However, the Petition does not explain how this evidence demonstrates that the proposed combination teaches or suggests a quality assessment neural network configured to receive images, or that such would have been obvious in the context of the claimed invention. See Pet. 32–37.” slip op. at 19
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,129,591 - Seaspine Holdings Corporation v. Roger P. Jackson, M.D.Institution deniedPTAB · Aug 7, 2025 · IPR2025-00773 · APJ Mary C Hoffman · IPR · Institution
The Board denied institution because Patent Owner disclaimed claims 1–19, and declined to enter adverse judgment.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied
“challenged in the Petition and paid the requisite fee. See Ex. 2001; 37 C.F.R. § 1.321 (setting forth requirements for statutory disclaimer). Accordingly, we deny institution of the requested review. 37 C.F.R. § 42.107(e) (“No inter partes review will be instituted based on disclaimed claims.”); General Elec. Co. v. United Techs. Corp., IPR2017-00491, Paper 9 (PTAB July 6, 2017) (precedential) (denying institution based on pre-institution disclaimer of all challenged claims) (“General Electric”).” slip op. at 2
- Adverse judgmentAdverse judgmentDecided for patent owner
“interpreted Rule 42.73(b) as permitting the Board to enter adverse judgment when a patent owner disclaims all challenged claims prior to institution. See Arthrex, Inc. v. Smith & Nephew, Inc., 880 F.3d 1345, 1350 (Fed. Cir. 2018). But neither Arthrex nor Rule 42.73(b) require the entry of adverse judgment. Instead, under these circumstances, the Board has discretion to decide whether or not to enter adverse judgement. See, e.g., Bestway (USA), Inc. v. Intex Mktg., Ltd., PGR2024-00036, Paper 9, 6 (PTAB Oct. 28, 2024) (“Bestway”). Based on the facts of this case, we believe that efficient administration weighs against entry of adverse judgment. Thus, consistent with Rule 42.107(e) and General Electric, denial of institution is sufficient to dispose of this matter. See, e.g., Bestway at 8; Samsung Electronics Co., Ltd. v. Oura Health OY, IPR2024-00929, Paper 8, 3 (PTAB Dec. 9, 2024); Takeda Vaccines, Inc., v. Valneva Austria Gmbh, IPR2023-00354, Paper 7, 4 (PTAB June 9, 2023); Microsoft Corp. v. Litl, LLC, IPR2021-01011, Paper 11, 3 (PTAB Apr. 5, 2022); Cisco Sys., Inc. v. SecurityProfiling, LLC, IPR2021-01428, Paper 13, 7 (PTAB Mar. 14, 2021).” slip op. at 3
NonePatents in suitUS 11,399,873 - Apple Inc. v. DH International Ltd.Institution deniedPTAB · Jun 25, 2025 · IPR2025-00173 · APJ Brian P Murphy · IPR · Institution
Institution was denied for claims 1–13 because the petition did not show a reasonable likelihood that any challenged claim was unpatentable over the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Under § 314, the Board may not institute review on fewer than all claims challenged in the petition. SAS Inst., Inc. v. Iancu, 584 U.S. 357, 371 (2018). If the Board institutes a review, it will institute “on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a). Upon consideration of the Petition, the Preliminary Response, and the evidence of record, for the reasons set forth below, we conclude the Petition does not demonstrate a reasonable likelihood that Petitioner would prevail in showing the unpatentability of at least one challenged claim in the ’333 patent. Accordingly, we do not institute an inter partes review of claims 1–13 of the ’333 patent.” slip op. at 2
- Skill levelSkill level board ownOther
“prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC, Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citing Custom Accessories, Inc. v. Jeffrey-Allan Indus., Inc., 807 F.2d 955, 962 (Fed. Cir. 1986)). “These factors are not exhaustive but are merely a guide to determining the level of ordinary skill in the art.” Daiichi Sankyo Co. v. Apotex, Inc., 501 F.3d 1254, 1256 (Fed. Cir. 2007). There is uncontested evidence in the record before us that reflects the knowledge and experience of a POSITA. We adopt the parties’ agreed level of ordinary skill in the art, which is consistent with the description in the ’333 patent and the prior art of record.” slip op. at 10
- BurdenNot shown unpatentable
“element” (limitation [1(e)]) onto a McGregor “device” placed in an RF field generated by Palmer’s reader/writer device. Pet. 28–31 (citing Ex. 1003 ¶¶ 95–105), 41–42 (citing Ex. 1003 ¶¶ 125–127). The Petition is unclear as to which McGregor device is being referenced, e.g., the smart card of Figure 2, the wallet embodiment of Figure 4, or some combination of embodiments disclosed in McGregor and Palmer. Id. Regardless, the proposed modification of McGregor in view of Palmer, as we understand it, is based on conclusory reasoning and appears to be motivated by hindsight rather than the teachings of the applied references. Prelim. Resp. 38–40 (citing Ex. 2001 ¶¶ 97–102). 7 Ground 2 challenges independent claim 11 for asserted obviousness over McGregor, Palmer, and Tuttle. The Petition’s reliance on Tuttle for its teaching of distinct data transmitter, data receiver, and cue receiver ports does not alter our analysis for claim 11. Pet. 55–62. POSITA would have understood that a series of instructions would be programmed into McGregor’s microprocessor to function as a switching element (pursuant to Palmer’s teachings), and as described.in the ’333 Patent. See Claim [1(b)]; see ’333 Patent, 6:9-14. Accordingly, McGregor’s microprocessor is a switching element (1) that is placed into an activated state after receiving a handshake signal (an activation cue) that establishes a communication during the handshake process and (2) that remains in an inactivated state if no reader/writer device is detected (no activation cue). Ex. 1003 ¶ 127 (emphases added). Dr. Buehrer’s citation to the ’333 patent, without explaining his mapping of limitation [1(e)] onto McGregor-Palmer beyond a general reference to 10-plus pages of limitation [1(b)] “control device” analysis, suggests hindsight reasoning. Id; see also Pet. 42 (generally referring to limitation [1(b)]). The Petition’s analysis, moreover, does not address why or how McGregor’s microprocessor would “accordingly” act as a data conveyance switching element or why a POSITA would want to program McGregor’s microprocessor to execute such a switching function in view of Palmer. We find the Petition and Dr. Buehrer’s testimony lacking in articulated reasoning supported by rational underpinnings sufficient to support the conclusion that limitation [1(e)] reads on the proposed McGregor-Palmer combination. See KSR, 550 U.S. at 418 (“there must be some articulated reasoning with some rational underpinning to support the legal conclusion of obviousness”).” slip op. at 16
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“element” (limitation [1(e)]) onto a McGregor “device” placed in an RF field generated by Palmer’s reader/writer device. Pet. 28–31 (citing Ex. 1003 ¶¶ 95–105), 41–42 (citing Ex. 1003 ¶¶ 125–127). The Petition is unclear as to which McGregor device is being referenced, e.g., the smart card of Figure 2, the wallet embodiment of Figure 4, or some combination of embodiments disclosed in McGregor and Palmer. Id. Regardless, the proposed modification of McGregor in view of Palmer, as we understand it, is based on conclusory reasoning and appears to be motivated by hindsight rather than the teachings of the applied references. Prelim. Resp. 38–40 (citing Ex. 2001 ¶¶ 97–102). 7 Ground 2 challenges independent claim 11 for asserted obviousness over McGregor, Palmer, and Tuttle. The Petition’s reliance on Tuttle for its teaching of distinct data transmitter, data receiver, and cue receiver ports does not alter our analysis for claim 11. Pet. 55–62. POSITA would have understood that a series of instructions would be programmed into McGregor’s microprocessor to function as a switching element (pursuant to Palmer’s teachings), and as described.in the ’333 Patent. See Claim [1(b)]; see ’333 Patent, 6:9-14. Accordingly, McGregor’s microprocessor is a switching element (1) that is placed into an activated state after receiving a handshake signal (an activation cue) that establishes a communication during the handshake process and (2) that remains in an inactivated state if no reader/writer device is detected (no activation cue). Ex. 1003 ¶ 127 (emphases added). Dr. Buehrer’s citation to the ’333 patent, without explaining his mapping of limitation [1(e)] onto McGregor-Palmer beyond a general reference to 10-plus pages of limitation [1(b)] “control device” analysis, suggests hindsight reasoning. Id; see also Pet. 42 (generally referring to limitation [1(b)]). The Petition’s analysis, moreover, does not address why or how McGregor’s microprocessor would “accordingly” act as a data conveyance switching element or why a POSITA would want to program McGregor’s microprocessor to execute such a switching function in view of Palmer. We find the Petition and Dr. Buehrer’s testimony lacking in articulated reasoning supported by rational underpinnings sufficient to support the conclusion that limitation [1(e)] reads on the proposed McGregor-Palmer combination. See KSR, 550 U.S. at 418 (“there must be some articulated reasoning with some rational underpinning to support the legal conclusion of obviousness”). The Petition does assert an obviousness theory within the analysis of the “control device” limitation [1(b)]. Pet. 25–35 (citing Ex. 1003 ¶¶ 85– 109). The Petition asserts that a “POSITA would have been motivated to implement McGregor’s device pursuant to Palmer such that the security code would be automatically transmitted when the device detects the receive the security code.” Pet. 28; see also id. at 31 (“A POSITA would have been motivated to implement Palmer’s (1) RF field detection and handshake processes and (2) Palmer’s transceiver hardware in McGregor’s device.”) (citing Ex. 1003 ¶¶ 95–105). We find the Petition’s obviousness theory to be inherently inconsistent and non-specific with regard to the “data conveyance switching element” recited in limitation [1(e)].” slip op. at 16
§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,628,333 - PTAB · Jun 25, 2025 · IPR2024-01280 · APJ Jo-Anne M Kokoski · IPR · Remand
On remand, the Board denied institution under § 314(a), finding the Fintiv factors favored denial despite declining to deny under § 325(d).
RulingsRemand decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDecided for petitioner
“Other than initials on a lengthy IDS, nothing in the record indicates that the Examiner substantively considered Takeuchi, Kim, Pienemann, or among over 1,000 other references listed on the IDS, which, as noted in the Director Review Decision, “is over 40 times the size of a typical IDS.” Pet. Remand Br. 5–6; DR Dec. 7 n.3 (citing Setting and Adjusting Patent Fees During Fiscal Year 2025, 89 FR 91898 at 91924 (Nov. 20, 2024)); Ex. 1002, 228–284. Petitioner also shows that the applicant did not respond to the Examiner’s request that the applicant specifically point out “any particular reference or portion of a reference in the [IDS] which the examiner should take [sic] pay particular attention to.” Ex. 1002, 174, 295– 302.” slip op. at 13
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivInstitution denied
“Patent Owner is likely correct that the ITC would not have been inclined to grant a stay if one had been requested at the time the Institution Decision issued. Moreover, the ITC conducted a full evidentiary hearing a month after the Institution Decision issued, and the target date for the ITC’s final determination is several months before the projected statutory deadline for the Board’s final written decision. PO Remand Br. 7. Accordingly, we determine that Fintiv factor 1 weighs in favor of discretionary denial. See also Klein Tools, Inc. v. Milwaukee Electric Tool Corp., IPR2024-01400, Paper 22 at 2 (PTAB June 9, 2025) (Acting Director Stewart determining that Fintiv factor 1 weighs in favor of discretionary denial when the ITC investigation is unlikely to be stayed, the ITC already conducted a full evidentiary hearing, and the ITC final determination is expected to issue six months before the statutory deadline for the Board’s final written decision).” slip op. at 19
Discretionary denialcites PhillipsPatents in suitUS 11,925,202 - Samsung Electronics Co., Ltd. v. Sionyx, LLCInstitution deniedPTAB · Jun 6, 2025 · IPR2025-00065 · APJ Brian D Range · IPR · Institution
The Board denied institution of IPR challenging claims 1–44 under § 314(a), finding the Fintiv factors favoring denial outweighed the Petition’s strong merits.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivInstitution denied
“stipulation would only eliminate the District Court’s consideration of Haddad204. Despite the stipulation, the District Court would still have to consider invalidity of every claim the Petition addresses and would still have to consider the Alie, Baggenstoss, and Park references. Cf. Stellar at 4 (“Petitioner’s invalidity arguments in the district court are more expansive and include combinations of the prior art asserted in these proceedings with unpublished system prior art, which Petitioner’s stipulation is not likely to moot.”). In other words, “Petitioner’s stipulation does not ensure that [this proceeding] would be a ‘true alternative’ to the district court proceeding.” Id. at 3–4. Because of the remaining overlap between the Petition and the District Court proceeding, Fintiv factor four weighs strongly in favor of discretionary denial.” slip op. at 15
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundOther
“for back side illumination (BSI), which appears to teach or suggest a textured region with surface features “located on the light incident side of the semiconductor layer and configured to interact with incident [EMR].” Pet. 22–27 (citing Ex. 1006, Fig. 5, ¶¶ 53, 68, 96; Ex. 1004 ¶¶ 39–40, 88–95, 101–107). As Petitioner and its expert explain, a person of ordinary skill in the art would have been motivated to modify Figure 5 of Alie into a BSI device because BSI devices allow more incident light to reach the semiconductor layer, resulting in more light being absorbed, an increase in the quantum efficiency, and an improvement in the signal to noise ratio. Pet. 25–26 (citing Ex. 1006 ¶¶ 68, 70; Ex. 1004 ¶¶ 39–40, 92, 95). Patent Owner argues that Alie does teach, suggest, or disclose “a textured region comprising a plurality of shallow trench isolation features.” Prelim. Resp. 9–11. But it appears Petitioner has at least shown Alie teaches or suggests this element. See discussion supra. Patent Owner further argues that Petitioner fails to present any proof that a person of ordinary skill in the art would have been motivated to modify Figure 5 of Alie into a BSI device. Id. at 11–15. But, in our view, Petitioner has provided an adequate motivation to modify Alie—so that more light will be absorbed, yielding an increase in the quantum efficiency and an improvement in the signal to noise” slip op. at 18
- Parallel petitionsNot reached
“17 Petitioner filed petitions for IPR2025-00064 and IPR2025-00065 at the same time. Both petitions address the ’682 patent but apply different art. Patent Owner also argues the second petition (IPR2025-00065) should be denied because one petition is sufficient. Patent Owner’s Response to Petitioner’s Notice Ranking Parallel Petitions, Paper 11. Because we deny institution based on Fintiv discretion, it is not necessary to reach Patent Owner’s multiple petition argument.” slip op. at 20
§ 103 obviousnessDiscretionary denialcites KSRPatents in suitUS 10,347,682 - Precision Cancer Technologies Inc. v. Oncoustics Inc.Institution deniedPTAB · Jun 3, 2025 · IPR2025-00242 · APJ David Cotta · IPR · Institution
The Board denied institution on claims 1–20 because Petitioner did not show a reasonable likelihood of prevailing on any asserted anticipation or obviousness ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Under 35 U.S.C. § 314(a), inter partes review may not be instituted unless the Petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Petitioner has not established a reasonable likelihood of prevailing on its assertion that any of the challenged claims are unpatentable based on the grounds advanced here. Thus, for reasons explained below, we deny institution of inter partes review of claims 1–20 of the ’330 patent.” slip op. at 2
- Claim Construction › Intrinsic evidence (Phillips canons) › Prosecution history disclaimer / disavowalDisclaimer foundDecided for patent owner
“area” in the challenged claims was added by amendment. Ex. 1004, 181.8 In making the amendment, Applicant stated that the language added by amendment was intended to distinguish the pending claims over Uniyal,9 which Applicant characterized as disclosing a “time series” of ultrasound data. Uniyal relies on a time series of ultrasound data. In order to distinguish Uniyal, the claims have been amended to recite a single static set of ultrasound RF data in a single frame of the tissue area. As explained in the Interview, the claims rely on a signle [sic, single] “snapshot” frame of the ultrasound RF data rather than a time series or [sic, of] RF data as disclosed in Uniyal. Applicant respectfully submits the amended claims are allowable over all of the cited reference. Id. at 186–187; see also id. at 185 (Applicant’s remarks accompanying amendment, stating: “As explained in the Interview, a static set of raw ultrasound RF signals is collected for an area. This is a snapshot of the tissue area as opposed to taking a time series of RF signals”), 191 (Examiner interview summary, stating: “Inventor noted that Uniyal uses a time series US [ultrasound] data whereas the invention uses images that are non-coherent in time (e.g., a static frame)”).” slip op. at 9
- Expert testimonyPetitioner expert discountedDecided for patent owner
“transducer, Petitioner points to Hope-Simpson’s teaching that its neural network may be “capable of ‘analyzing patterns using a with a [sic] multi-dimensional (2-or more dimensional) data set, which may also be thought of as localized data sets.’” Id. at 22 (quoting Ex. 1005 ¶ 6; alteration by Petitioner). Petitioner then asserts that “[t]he localized data sets described by Hope-Simpson are equivalent to the claimed ‘single set of raw ultrasound [RF] data forming a single frame of a tissue area.” Pet. 22 (citing Ex. 1002 ¶ 86 (testimony of Dr. Papanicolau)). But Petitioner does not explain why Hope-Simpson’s “localized data sets” equate with a single frame of a tissue area rather than, for example, a time series of frames taken at the same location. Pet. 22. Petitioner cites the testimony of Dr. Papanicolau, but Dr. Papanicolau’s testimony lacks both technical reasoning and evidentiary support; it simply mirrors the statement in Petition. Ex. 1002 ¶ 86. For this reason, we give Dr. Papanicolau’s ipse dixit testimony little weight. Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 9 at 15 (PTAB Aug. 24 ,2022) (Decision Denying Institution) (precedential) (finding that conclusory testimony that “does not cite to any additional supporting evidence or provide any technical reasoning to support [that testimony] . . . is entitled to little weight”); see also, 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”). Accordingly, to the extent this is the data that Hope Simpson provides to the processor, on this record, Petitioner has not sufficiently established that it constitutes a “single static set” of raw RF ultrasound data “forming a single frame.”” slip op. at 15
Claim constructioncites KSR · GrahamPatents in suitUS 11,602,330 - Samsung Electronics Co., Ltd. v. Sionyx, LLCInstitution deniedPTAB · May 21, 2025 · IPR2025-00161 · APJ Monica S Ullagaddi · IPR · Institution
The Board denied institution of IPR challenging claims 1–18 under § 314(a), concluding that the Fintiv factors, viewed holistically, favored discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied fintivInstitution denied
“The standard for institution is set forth in 35 U.S.C. § 314, which provides that an inter partes review may not be instituted unless the information presented in the Petition and the Preliminary Response shows that “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2019); see also 37 C.F.R § 42.4(a) (2019) (“The Board institutes the trial on behalf of the Director.”). Upon consideration of the parties’ contentions and the evidence of record, we exercise our discretion to deny institution.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivInstitution denied
“view of a parallel proceeding, we consider the following factors: 1. whether the court granted a stay or evidence exists that one may be granted if a proceeding is instituted; 2. proximity of the court’s trial date to the Board’s projected statutory deadline for a final written decision; 3. investment in the parallel proceeding by the court and the parties; 4. overlap between issues raised in the petition and in the parallel proceeding; 5. whether the petitioner and the defendant in the parallel proceeding are the same party; and 7 Japanese Unexamined Patent Application Publication No. 2009–188316 A, published Aug. 20, 2009 (Ex. 1011). A certified translation, to which we cite, is provided (Ex. 1012, “Yamada”). 8 E. Fred Schubert, LIGHT-EMITTING DIODES, 2nd ed., 163–190, 2006 (Ex. 1013, “Schubert”). discretion, including the merits. Apple Inc. v. Fintiv, Inc., IPR2020-00019, Paper 11 at 5–6 (PTAB Mar. 20, 2020) (precedential) (“Fintiv”). “These factors relate to whether efficiency, fairness, and the merits support the exercise of authority to deny institution in view of an earlier trial date in the parallel proceeding.” Id. In evaluating these factors, we “take[] a holistic view of whether efficiency and integrity of the system are best served by denying or instituting review.” Id. at 6. We consider each of these factors below.” slip op. at 4
Discretionary denialPatents in suitUS 11,721,714 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 25, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–8 were unpatentable under the asserted obviousness grounds.
RulingsInstitution decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“experience working on the development of materials or components for electronic devices such as batteries.” Pet. 2. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less work experience, and additional work experience could compensate for less formal education.” Id. Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’014 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” 37 C.F.R. § 42.100(b). Under this standard, claim terms are generally given their plain and ordinary meaning as would have been understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. Phillips v. AWH Corp., 415 F.3d 1303, 1313 (Fed. Cir. 2005) (en banc). Only those terms in controversy need to be construed, and only to the extent necessary to resolve the controversy. Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019). in this proceeding.” Pet. 3. Patent Owner contends that “[t]he Board need not construe any term in order to determine that institution should be denied.” Prelim. Resp. 4. Based on the record before us, we determine that no claim term requires express construction for purposes of this Decision. See Realtime Data, 912 F.3d at 1375.” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“For these reasons, we are not persuaded that Petitioner sufficiently establishes that a POSITA would have been motivated to modify Hanafusa in light of Dobashi with a reasonable expectation of success as Petitioner contends. Accordingly, we determine that Petitioner fails to demonstrate a reasonable likelihood of prevailing in its assertion that the subject matter of claim 1, and claims 4 and 8 that depend therefrom, would have been obvious over the combined teachings of Hanafusa and Dobashi.” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“Petitioner also focuses on Hanafusa’s teaching that all known methods can be used to make a rough surface low-profile, and Dobashi’s teaching that RSm can be used as an indicator for judgment of the surface, to support its contention that a POSITA would have been motivated to apply Dobashi’s RSm to further achieve Hanafusa’s purpose, without explaining how and why that would be the case. In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness and is rough when RSm is small.” Id. at 3:1–3, 6:27–29. Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66– 3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66–3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 14
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 23, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–10 were unpatentable over either asserted § 103 ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2018); see also 37 C.F.R. § 42.4 (2023). For the reasons discussed below, we deny the Petition and do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“II. ANALYSIS A. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art (“POSITA”) “would have had at least an undergraduate degree in materials science, chemical engineering, electrical engineering, or related field, or equivalent knowledge, training, or experience, with at least two years of experience working on the development of materials or components for electronic devices such as batteries.” Pet. 4. Petitioner further contends that “[a]dditional education, such as a graduate degree, could compensate for less 7 We refer to the page numbers added by Petitioner to the bottom-center of the page. formal education.” Id. (citing Ex. 1003 ¶ 10). Patent Owner states that, “[f]or purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art.” Prelim. Resp. 4. For purposes of this Decision, we adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’689 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163–64 (Fed. Cir. 1985))).” slip op. at 10
- Expert testimonyPetitioner expert discountedDecided for patent owner
“We are not persuaded, on this record, that Petitioner adequately establishes that Khatibi discloses a CTE in the claimed range of 16 to 22 µm/(m·°C.). Petitioner’s argument that Khatibi’s reported values meet this claim limitation are based solely on Dr. Randall’s testimony that Khatibi’s measurement method would produce results that would not significantly differ from results determined using the claimed method. See Pet. 16–18 (citing Ex. 1003 ¶¶ 56–60). Dr. Randall’s testimony, however, is largely conclusory and unsupported by adequate explanation and/or objective evidence. For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added). to little weight. See 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 12 at 5 (PTAB Feb. 10, 2023) (finding that “the Board was correct in giving little weight to Petitioner’s expert because the expert declaration merely offered conclusory assertions without underlying factual support”); Upjohn Co. v. Mova Pharm. Corp., 225 F.3d 1306, 1311 (Fed. Cir. 2000) (“Lack of factual support for expert opinion to factual determinations, however, may render the testimony of little probative value in a validity determination.” (quoting Ashland Oil, Inc. v. Delta Resins and Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985))); see also In re Ethicon, Inc., 844 F.3d 1344, 1348, 1352 (Fed. Cir. 2017) (concluding that the Board properly gave “little weight” to conclusory expert testimony of objective indicia). Because Petitioner offers Dr. Randall’s testimony to supply a limitation missing from the prior art, namely, the CTE measurement method, and we give Dr. Randall’s unsupported and conclusory testimony little weight, we are not persuaded that Petitioner establishes a reasonable likelihood of showing that Khatibi discloses limitation [1d].” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“second surfaces of the electrolytic copper foil ranges from 3 to 92.” Ex. 1001, 13:62–63. Petitioner contends that “Kim teaches that the electrolytic copper foil (e.g., untreated or treated copper foil) having Rz less than 2 µm is advantageous toward battery efficiency and performance,” and, similarly, Griesi describes the use of untreated electrolytic copper foil with an Rz value less than 2 µm in printed circuit boards that are compatible with secondary batteries. Pet. 58–59 (citing Ex. 1012, claim 2, ¶¶ 13, 25, 27; Ex. 1003 ¶ 157). In particular, Petitioner notes that Griesi’s Figure 3.16 describes an “Rz value of 1.2 µm.” Id. at 59 (citing Ex. 1015, 53–54; Ex. 1003 ¶ 158). Petitioner asserts that “Dr. Randall explains that a POSITA would have also recognized another surface roughness-related parameter, Rpc, in Griesi as a potentially useful parameter that can be optimized to further enhance uniformity or generally improve Kim’s copper foil surface, for example, to prevent wrinkles or achieve other advantageous effects.” Id. (citing Ex. 1003 ¶ 159). Although Dr. Randall demonstrates that Griesi’s Pc (or Rpc) value is 19.2 over a 4 mm sampling length (Ex. 1003 ¶ 155), Petitioner does not contend that Griesi addresses this value, or indicates any benefit that might be derived from its use. Instead, Griesi’s Pc value appears to be an incidental finding, which is not discussed or analyzed in the reference. See incidental, unexamined finding would lead a POSITA to import Griesi’s Pc value into Kim’s copper foil, absent a hindsight desire to reconstruct the claimed invention. As such, Petitioner’s arguments with respect to Kim and Griesi are not persuasive. See Cheese Sys. Inc. v. Tetra Pak Cheese and Powder Sys., Inc., 725 F.3d 1341, 1352 (Fed. Cir. 2013) (“Obviousness cannot be based on the hindsight combination of components selectively culled from the prior art to fit the parameters of the patented invention.” (internal quotations marks omitted)). Thus, we are not persuaded, on this record, that the combined disclosures of Kim and Griesi teach all of the elements of limitation [1g].” slip op. at 23
§ 103 obviousnesscites PhillipsPatents in suitUS 10,811,689 - Solus Advanced Materials Co, Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 22, 2025 · IPR2024-01460 · APJ Jon B Tornquist · IPR · Institution
The Board denied institution of review of claims 1–11 because the Fintiv factors, including the early trial date and close merits case, favored discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied fintivInstitution denied
“whether to institute an inter partes review. Applying the standard set forth in 35 U.S.C. § 314(a), we may not institute an inter partes review unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Institution of inter partes review, however, is discretionary. See Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1367 (Fed. Cir. 2016) (“[T]he PTO is permitted, but never compelled, to institute an IPR proceeding.”). For the reasons stated below, we exercise our discretion not to institute an inter partes review. A. Real Parties-in-Interest” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivDenied
“Board’s projected statutory deadline to issue a final written decision. Fintiv, Paper 11 at 9. “If the court’s trial date is at or around the same time as the projected statutory deadline . . . the decision whether to institute will likely implicate other factors.” Id. Conversely, “[i]f the court’s trial date is earlier than the projected statutory deadline,” this has generally weighed “in favor of exercising authority to deny institution.” Id.” slip op. at 15
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“Petition under 35 U.S.C. § 325(d) because the same or substantially the same art and arguments were before the Examiner during prosecution and Petitioner’s has not demonstrated that the Examiner erred in a material manner when allowing the claims. Pet. 17–18. Given our discretionary denial of the Petition in view of the Fintiv factors, we do not address Petitioner’s further arguments with respect to § 325(d).” slip op. at 32
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner applies Petitioner’s recited level of ordinary skill in the art for purposes of its Preliminary Response. Prelim. Resp. 4. Upon review of the parties’ arguments and the prior art of record, we adopt Petitioner’s unopposed definition of the ordinarily skilled artisan for purposes of this decision as it appears consistent with the disclosures of the ’090 patent and the prior art of record. C. Claim Construction” slip op. at 9
§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,480,090
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.