- Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Solus’s rehearing request, leaving institution denied for claims 1–8 because the petition did not adequately show motivation to combine Hanafusa and Dobashi.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve Dobashi’s RSm values. Dobashi teaches that because RSm “can be adopted as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66–3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66– 3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 4
§ 103 obviousnessPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - Mercedes-Benz USA, LLC v. Carucel Investments, L.P.Rehearing deniedPTAB · Mar 3, 2021 · IPR2019-01298 · APJ Thomas L Giannetti · IPR · Rehearing
The Board denied Patent Owner’s rehearing request, leaving in place its decision that all challenged claims were unpatentable.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“set forth in 37 C.F.R. § 42.71(d), which provides in relevant part: The burden of showing a decision should be modified lies with the party challenging the decision. The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply. A rehearing request is not an opportunity for the requesting party to reargue its case or merely to express disagreement with the Final Written Decision. Nor is it an opportunity for the moving party to present new arguments that were not in its original submissions.” slip op. at 3
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for petitioner
“As discussed further below, after considering all the evidence, we provided in the Final Written Decision a detailed analysis of Patent Owner’s arguments, and rejected Patent Owner’s proposed limitations for “mobile unit,” determining that the ordinary meaning should apply and no further construction was necessary. Final Dec. 14–26. D. The Final Written Decision Our analysis of “mobile unit” in the Final Written Decision was guided by Phillips v. AWH Corp., 415 F.3d 1303, 1312–13 (Fed. Cir. 2005) (en banc). Final Dec. 11. In summary, for the reasons that follow, we are not persuaded that our analysis of “mobile unit” under Phillips was incorrect, or that we overlooked or misapprehended Patent Owner’s arguments or evidence in that analysis.” slip op. at 5
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 7,221,904 - Mercedes-Benz USA, LLC v. Carucel Investments, L.P.Rehearing deniedPTAB · Mar 3, 2021 · IPR2019-01404 · APJ Daniel J Galligan · IPR · Rehearing
The Board denied Patent Owner’s rehearing request, leaving claims 1, 4–11, and 14–23 unpatentable based on its construction of “mobile device” and findings on combining CDMA and TDMA.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“The burden of showing a decision should be modified lies with the party challenging the decision. The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply. A rehearing request is not an opportunity for the requesting party to reargue its case or merely to express disagreement with the Final Written Decision. Nor is it an opportunity for the moving party to present new arguments that were not in its original submissions.” slip op. at 3
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“We disagree that we misapprehended or overlooked any matters in addressing Patent Owner’s proposed construction for “mobile device.” Rather, we provided a comprehensive analysis of the term “mobile device.” anything that was overlooked or misapprehended in this analysis, as required by 37 C.F.R. § 42.71(d). Instead, Patent Owner merely expresses its disagreement with our conclusions and proceeds to reargue points and evidence already considered and rejected in the Final Written Decision. This approach is not proper in a rehearing request. Furthermore, Patent Owner’s own arguments show the error in its proposed construction. For example, Patent Owner argues that the recited “mobile device” “must register with and be able to directly communicate with the cellular network.” PO Resp. 13; Req. Reh’g 1 n.1. Yet, Patent Owner acknowledges that “the claims of the ’023 Patent require the apparatus/movable base station to communicate directly with the cellular network (and not the ‘mobile device’).” Req. Reh’g 3 (emphasis added). As we pointed out in the Final Decision, the only claimed communication involving the mobile device is between the claimed “apparatus” (the mobile base station) and the mobile device, and Patent Owner acknowledges that this communication need not be cellular. Final Dec. 14 (citing PO Sur-reply 9). Thus, Patent Owner’s arguments undermine its proposed construction.” slip op. at 3
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundOther
“[t]he Board erred in finding that that ‘CDMA and TDMA are not incompatible’ by improperly disregarding substantial evidence set forth by Patent Owner and its expert—that undermines any expectation of success and would have discouraged a [person of ordinary skill in the art] from attempting Petitioner’s combinations.” Req. Reh’g 14 (citing Final Dec. 79). Patent Owner does not attempt to identify any specific errors in citing pages from Patent Owner’s written submissions and testimony from its declarant. Req. Reh’g 14 n.31. We disagree that we misapprehended or overlooked any matters in this regard. Rather, we considered Patent Owner’s submissions and disagreed with them, finding instead that the record demonstrated that CDMA and TDMA can be combined, and we relied on, among other evidence, a prior art reference that expressly discloses a combination of CDMA and TDMA. Final Dec. 56–57 (citing Ex. 1033), 79. We further found that a person of ordinary skill in the art would have had reason to make the proposed combinations and would have had a reasonable expectation of success in doing so. Final Dec. 57–58, 79–81. slip op. at 6
Claim construction§ 103 obviousnessPatents in suitUS 7,979,023 - Intel Corporation v. VLSI Technology LLCRehearing deniedPTAB · Feb 19, 2021 · IPR2020-00527 · APJ Kimberly Mcgraw · IPR · Rehearing
The Board denied Intel’s rehearing requests and left in place its § 314(a) denial of institution in both proceedings based on the Fintiv factors.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“decision should be modified. 37 C.F.R. § 42.71(d). “The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id. When rehearing a decision on a petition, we review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c).” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for patent owner
“Petitioner has not shown that this change in circumstance warrants modifying (1) the determination that Fintiv factor 4 weighs in favor of exercising discretion to deny institution or (2) the determination, after weighing all factors and taking a holistic view of the relevant circumstances, to exercise discretion to deny institution. Several of the claims challenged in each Petition are still at issue in the parallel proceeding, and the combinations of references asserted by Petitioner in the district court largely overlap with the combinations of references asserted in the Petitions. Petitioner has not identified any differences among the claims that have been dropped and the claims that remain as a reason to modify our Decision. See Fintiv, Paper 11 at 13 (“if a petition involves the same prior art challenges but challenges claims in addition to those that are challenged in the district court, it may still be inefficient to proceed because the district court may resolve validity of enough overlapping claims to resolve key issues in the petition”).” slip op. at 5
Discretionary denialPatents in suitUS 6,633,187 - Intel Corporation v. VLSI Technology LLCRehearing deniedPTAB · Feb 19, 2021 · IPR2020-00526 · APJ Kimberly Mcgraw · IPR · Rehearing
The Board denied Intel’s rehearing requests, leaving institution denied in both proceedings based on its Fintiv analysis of the parallel litigation.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. ANALYSIS A party requesting rehearing bears the burden of showing that the decision should be modified. 37 C.F.R. § 42.71(d). “The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id. When rehearing a decision on a petition, we review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c).” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for patent owner
“noted that, “[e]ven if Petitioner’s contentions are true, Petitioner has not shown these contentions will avoid adjudication of Intel’s invalidity defenses” in the related Western District of Texas litigation. Dec. Inst. 13. In light of the record at the time, we found that Petitioner’s arguments in connection with Fintiv factor 6 did not weigh against exercising our discretion to deny institution. Id. at 13–15. Accordingly, we maintain our finding that Petitioner’s argument does not weigh against exercising our discretion to deny institution.” slip op. at 4
Discretionary denialPatents in suitUS 6,633,187 - Intel Corporation v. VLSI Technology LLCRehearing deniedPTAB · Feb 11, 2021 · IPR2020-00582 · APJ Bart A Gerstenblith · IPR · Rehearing
The Board denied Intel’s rehearing request and maintained its discretionary denial of institution under Fintiv, despite weighing Factor 6 neutrally.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. ANALYSIS A party requesting rehearing bears the burden of showing that the decision should be modified. 37 C.F.R. § 42.71(d). “The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id. When rehearing a decision on a petition, we review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c).” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivInstitution denied
“The change in circumstances regarding the trial date does not persuade us to change our decision to exercise our discretion to deny institution. Even if we were to institute an inter partes review proceeding, the deadline for issuing a final written decision could be no earlier than February 2022. Thus, at this time, it appears likely that trial will occur many months before any final written decision would likely issue in this proceeding. Therefore, we maintain our finding that Fintiv Factor 2” slip op. at 4
Discretionary denialPatents in suitUS 7,292,485 - U.S. Venture, Inc. v. Sunoco Partners Marketing & Terminals L.P.Rehearing deniedPTAB · Dec 17, 2020 · IPR2020-00728 · APJ Brent M Dougal · IPR · Rehearing
The Board denied rehearing, leaving in place its denial of institution for claims 16–17 based on the Fintiv factors and its § 314(a) discretion.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“When rehearing a decision on institution, the Board reviews the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may arise if the decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if an unreasonable judgment is made in weighing relevant factors. Star Fruits S.N.C. v. U.S., 393 F.3d 1277, 1281 (Fed. Cir. 2005); Arnold P’ship v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004); In re Gartside, 203 F.3d 1305, 1315–16 (Fed. Cir. 2000). The burdens and requirements of a request for rehearing are stated in 37 C.F.R. § 42.71(d): The burden of showing a decision should be modified lies with the party challenging the decision. The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply. Thus, a request for rehearing is not an opportunity to present new arguments or evidence or merely to disagree with the panel’s assessment of the arguments or weighing of the evidence.” slip op. at 3
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for patent owner
“the evidence laid out an approximate time frame for when the trial would likely be held. Dec. 9 (citing Ex. 2003); see also id. at 8–9 (citing PO Resp. 35; Ex. 1026) (Discussing the Court’s Procedures and timeline for trial after the docket call). Thus, we determined that this factor favored denying institution under our analysis of the factors under Fintiv. Id. at 9.” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“Petitioner acknowledges that the proposed combination of the references relies on “us[ing] the cumulative totals of the flow rates of the unblended components in the Hoffman compensation process” (id.), however Patent Owner identifies that Hoffman appears to teach away from using the flow rates of the unblended components in its calculations because of the uncertainty in the flow rate of the blended line. Prelim. Resp. 19, 21– 22. Contrary to Petitioner’s position, it is not Patent Owner’s burden to show why “a person of ordinary skill in the art would be discouraged from measuring flow rates upstream for use in the Hoffman compensation process” (Reh. Req. 9), but rather, Petitioner bears the burden to show why a person of ordinary skill in the art would measure flow rates upstream for use in the Hoffman compensation process in view of the all of the teachings of the references (35 U.S.C. § 314(a) (Institution only authorized if “the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.”)). Petitioner’s arguments do not show that we misapprehended or” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageNot reached
“argument concerning the construction of the term “in-line blending.” Id. at 13.” slip op. at 6
Claim construction§ 103 obviousnessDiscretionary denialPatents in suitUS 9,207,686 - Netflix, Inc. v. Divx, LLCRehearing deniedPTAB · Dec 2, 2020 · IPR2020-00511 · APJ Bart A Gerstenblith · IPR · Rehearing
The Board denied DivX’s rehearing request, leaving the institution decision in place because the rule remained effective and Dr. McDaniel’s testimony was supported on the record.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. ANALYSIS A party requesting rehearing bears the burden of showing that the decision should be modified. 37 C.F.R. § 42.71(d). “The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id. When rehearing a decision on a petition, we review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c).” slip op. at 2
- Expert testimonyPetitioner expert creditedDecided for petitioner
“assertions regarding Dr. McDaniel’s testimony. Dr. McDaniel testified that (a) Chen teaches video data streams, (b) “[a]s was widely known in the art, for example as disclosed by Grab-333,[1] a [person of ordinary skill in the art] would have understood that video data streams were comprised of a series of video frames,” and (c) a person of ordinary skill in the art “would have understood that Chen teaches a plurality of frames of video are encrypted using at least one scrambling key/control word.” Ex. 1003 ¶ 112;” slip op. at 3
NonePatents in suitUS 9,184,920 - Google LLC v. Uniloc 2017, LLCRehearing deniedPTAB · Oct 16, 2020 · IPR2019-01584 · APJ Kevin F Turner · IPR · Rehearing
The Board denied Google’s rehearing request, finding no abuse of discretion in denying institution of review of claims 1–3, 5, 6, 8, 39, and 41 under its General Plastic analysis.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion occurs when a “decision was based on an erroneous conclusion of law or clearly erroneous factual findings, or . . . a clear error of judgment.” PPG Indus. Inc. v. Celanese Polymer Specialties Co., 840 F.2d 1565, 1567 (Fed. Cir. 1988) (citations omitted). The party requesting rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › General Plastic (serial petitions)Decided for patent owner
“petitions are only relevant if Petitioner was a party to the prior proceedings, or had a relationship with the prior petitioners. Reh’g Req. 7. But a review of the cited precedential decision does not reflect Petitioner’s suggestion. See General Plastic, Paper No. 19 at 15−19 (“Our intent in formulating the factors was to take undue inequities and prejudices to Patent Owner into account.”). General Plastic does not proscribe panels of the Board from considering whether a subsequent petitioner knew of the prior art cited in the subsequent petition at the time of filing of the first petition, per the second factor. Similarly, we are not barred, under General Plastic, from considering the length of time that elapsed between when a petitioner learned of the art and when the petition, based on that art, was filed, or whether petitioner provides an adequate explanation for the time elapsed between the filings of multiple petitions, per the fourth and fifth factors. Additionally, we are not persuaded that the factors enumerated in General Plastic, as viewed through the lens of Valve Corp., must all be limited by any possible relationship between the multiple petitioners. Although the discussion of the first factor in Valve Corp. makes clear that “any relationship between those petitioners when weighing the General Plastic factors” must be considered, the remaining factors take into account the knowledge of the second petitioner irrespective of a specific relationship. See Valve Corp., Paper 11 at 9−15. As such, the relationship between the different petitioners certainly has some bearing on what the second petitioner knew, when they knew it, and when they acted upon it, but the consideration of the second through seventh factors does not require a showing of a specific relationship between the petitioners to consider those factors.” slip op. at 5
Discretionary denialPatents in suitUS 6,519,005
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.