- Biofrontera Inc. / Biofrontera Bioscience GmbH et al. v. Sun Pharmaceutical Industries, Inc.All claims unpatentablePTAB · Feb 23, 2026 · IPR2024-01312 · APJ Mary C Hoffman · IPR · Final written decision
Claims 1, 2, 4–6, 16, 17, and 19–21 are unpatentable as obvious over Lundahl and Larsen; Ground 2 was conceded, and the motion to exclude was denied.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“Patent Owner asserts that Petitioner has not provided a valid justification for requiring a POSITA to have both an engineering degree and a medical degree. Prelim. Resp. 22. We agree, insofar as Petitioner has not clearly set out any particular explanation or evidence in support of its dual-degree requirement. In all other respects, we note that the parties’ proposed definitions are largely similar. Because we determine that Patent Owner’s proposed definition is reasonable and consistent with the ’028 patent and the cited art, we adopt Patent Owner’s definition. In any event, our Decision does not turn on this level of skill determination. B.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“device “[f]or the treatment of large-area tissues,” such as the backs of human patients, wherein several applicators 13 are “flexibly connected to each other through hinges.” Id. (quoting Ex. 1004 ¶ 72). Petitioner asserts that a POSITA would have been motivated “to incorporate Larsen’s solution of connecting light applicators by hinges, to allow for adjustability of Lundahl’s device to provide the desired irradiance and irradiance uniformity to all target areas during PDT.” Id. (citing Ex. 1015 ¶ 127). According to Petitioner, a “POSITA would have had a reasonable expectation of success in combining Lundahl with Larsen, because both references describe similar illuminators for using light to treat conditions on a patient’s skin.” Id. at 31 (citing Ex. 1015 ¶ 128). Petitioner’s proposed modification of Lundahl also involves using LEDs as a light source instead of Lundahl’s fluorescent tubes. Id. According to Petitioner, a POSITA would have been motivated to make this change because: (1) LEDs had a lower cost and a longer lifetime than fluorescent tubes; (2) fluorescent tubes were known to have inconsistent light output within the tube itself; and (3) “the use of LEDs would be more practical to reduce spacing between light sources and the edges of the panels, as opposed to the bulky metal couplings at the end of fluorescent tubes, to reduce optical dead space across the light surface.” Id. (citing Ex. 1014, 4:41–42, 6:31–42; Ex. 1015 ¶ 129). Petitioner asserts that a POSITA would have had a reasonable expectation of success with this modification because Lundahl and Larsen “describe similar illuminators and the conversion from fluorescent tubes to LEDs was a routine practice prior to 2015.” Id. at 32 (citing Ex. 1015 ¶ 131). Patent Owner does not meaningfully dispute the Petitioner’s proposed reasons to combine Lundahl and Larsen. See generally PO Resp. To the extent Patent Owner argues that a POSITA would not have been motivated to make the combination because it would negatively affecting uniform illumination (PO Resp. 24), the motivating benefit here—using adjustable LED panels instead of monolith fluorescent tubes—outweighs the alleged disadvantages for the many reasons given by Petitioner, including greater adjustability and improved LED performance. See Medichem, S.A. v. Rolabo, S.L., 437 F.3d 1157, 1165 (Fed. Cir. 2006) (“[t]he fact that the motivating benefit comes at the expense of another benefit, however, should not nullify its use as a basis to modify.”); Reply 14. We are persuaded that a POSITA would have been motivated to combine Lundahl and Larsen for the reasons advanced by Petitioner.” slip op. at 20
- Obviousness (§103) › KSR rationalesMotivation foundDecided for petitioner
“Patent Owner further argues that Petitioner’s reasoning (i.e., that it would have been obvious to try placing the hinges on the inner side surfaces) is unsupported and conclusory. PO Reps. 53–54. Patent Owner argues that Petitioner fails to identify a single prior art reference showing hinged structures on inner side surfaces. Id. This argument ignores that Larsen expressly identifies hinges on at least bottom side surfaces, and Petitioner merely proposes modifying their location from the bottom sides to inner sides. We find credible Dr. Grove’s testimony that relocating hinges would have been within the level of ordinary skill in the art. Ex. 1015 ¶ 155. Dr. Jokerst testifies that a POSITA would have been discouraged from placing hinges between Larsen’s adjustable applicators, because the hinges would create gaps that interfere with uniform illumination as well as the panels’ wiring, and create issues with the use and alignment of the panels. Ex. 2050 ¶ 175. However, a system with discrete panels connected by hinges (like in Larsen) will already have wiring, use and alignment technical challenges, regardless of the location of the hinges— the expected consequence of connecting multiple movable electronic panels. Moreover, the ’028 patent acknowledges in its discussion of conventional illuminators that placing hinges between panels was already known. Ex. 1001, 2:7–15. With respect to Dr. Jokerst’s opinion that the hinges would create gaps negatively affecting uniform illumination, we are persuaded that it would have been within the skill of a POSITA to locate the hinges on the inside surfaces “in a nearly flush arrangement,” such that the gaps would be minimized. Id.; Ex. 1015 ¶ 155. We also credit Dr. Grove’s supplemental testimony on this issue, directly refuting Dr. Jokerst’s testimony regarding gaps and uniform illumination (and therefore within the proper scope of reply, contrary to Patent Owner’s argument otherwise (Mot. 9). See Ex. 1026 ¶¶ 17–20 (explaining LED light divergence and that the physical space caused by hinges “is easily addressed” to maintain uniform illumination).9 We further point out that the ’028 patent also suggests that gaps do” slip op. at 24
- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
“Dr. Jokerst testifies that a POSITA would have been discouraged from placing hinges between Larsen’s adjustable applicators, because the hinges would create gaps that interfere with uniform illumination as well as the panels’ wiring, and create issues with the use and alignment of the panels. Ex. 2050 ¶ 175. However, a system with discrete panels connected by hinges (like in Larsen) will already have wiring, use and alignment technical challenges, regardless of the location of the hinges— the expected consequence of connecting multiple movable electronic panels. Moreover, the ’028 patent acknowledges in its discussion of conventional illuminators that placing hinges between panels was already known. Ex. 1001, 2:7–15. With respect to Dr. Jokerst’s opinion that the hinges would create gaps negatively affecting uniform illumination, we are persuaded that it would have been within the skill of a POSITA to locate the hinges on the inside surfaces “in a nearly flush arrangement,” such that the gaps would be minimized. Id.; Ex. 1015 ¶ 155. We also credit Dr. Grove’s supplemental testimony on this issue, directly refuting Dr. Jokerst’s testimony regarding gaps and uniform illumination (and therefore within the proper scope of reply, contrary to Patent Owner’s argument otherwise (Mot. 9). See Ex. 1026 ¶¶ 17–20 (explaining LED light divergence and that the physical space caused by hinges “is easily addressed” to maintain uniform illumination).9” slip op. at 24
Patent outcomesUS 11,697,028 unpatentable§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,697,028 - Cambridge Industries USA, Inc. v. Applied Optoelectronics, Inc.Rehearing deniedPTAB · Dec 19, 2025 · IPR2025-00434 · APJ Mitchell G Weatherly · IPR · Rehearing
The Board denied Petitioner’s rehearing request, leaving institution denied because Shen and Soldano did not establish a reasonable likelihood of anticipating claims 1–7.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“When rehearing a decision on petition, the Board will review the decision for an abuse of discretion. See 37 C.F.R. § 42.71(c). An abuse of discretion may be determined if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors. See Arnold P’ship v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004). The party challenging the decision has the burden of showing the decision should be modified, and the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed” in its papers. 37 C.F.R. § 42.71(d).” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“II. ANALYSIS In our Decision, we concluded that Petitioner had failed to carry its burden of demonstrating a reasonable likelihood of prevailing that either Shen or Soldano anticipated claims 1–7. Dec. 18, 26. Petitioner argues that we should institute review for three reasons. First, Petitioner argues that we abused our discretion by (a) “refusing” to interpret the scope of the claimed” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Owner’s interpretation of “carrier” as meaning “one or more components for supporting ROSA components such as an AWG.” Dec. 9 (quoting Pet. 11). For our analysis of Petitioner’s challenges, we referred to this interpretation of “carrier” as Petitioner’s second alternative construction. Id. We also noted that Petitioner appeared to dispute Patent Owner’s interpretation when it argued that “carrier” should mean “a ceramic or silicon substrate.” Id. (quoting Pet. 10). We referred to this interpretation of “carrier” as the first alternative construction. Id. Rather than resolve this apparent dispute about the meaning of “carrier,” we found that both of Petitioner’s anticipation challenges failed under both interpretations of “carrier.” Id. at 10–26. Because we found that Petitioner had failed to carry its burden regardless of which interpretation of “carrier” applied, we found it unnecessary to resolve the dispute over that interpretation. Id. at 9–10. For the reasons expressed in Parts II.B–C below, we maintain our conclusion that Petitioner has failed to demonstrate a reasonable likelihood of proving that either Shen or Soldano anticipates any claim under either interpretation of “carrier.” Accordingly, Petitioner fails to demonstrate an abuse of discretion in our alleged “refusal” to interpret “carrier.”” slip op. at 3
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“Reh’g Req. 14. We cannot weigh Petitioner’s arguments based on its assertions about “caselaw” because Petitioner cited no cases to support its arguments. See id. Nevertheless, we infer that Petitioner intends its statements of “caselaw” to refer to the requirements to make out a case for anticipation. If so, Petitioner demonstrably miscasts what appear to be the legal principles for proving anticipation. As stated in our Decision: “A claim is anticipated only if each and every element as set forth in the claim is found, either expressly or inherently described, in a single prior art reference.” Verdegaal Bros., Inc. v. Union Oil Co. of California, 814 F.2d 628, 631 (Fed. Cir. 1987).” Dec. 7. Making a showing that a prior art reference anticipates a patent claim thus necessarily requires proof that a single reference “expressly or inherently” describes every element of that claim and with all elements being arranged in the reference as they are in the” slip op. at 7
Claim construction§ 102 anticipationPatents in suitUS 10,379,301 - PTAB · Jun 18, 2025 · IPR2025-00321 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR on claims 1, 2, 5–7, 9, 16, and 17, finding a reasonable likelihood that claim 1 is anticipated by Boyer.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“approximately two weeks before the statutory deadline for a final written decision, but the most recent median time-to-trial statistics for Judge Gilstrap in the Eastern District of Texas indicate that the actual trial date will likely be in July 2026, which is later than the statutory deadline to issue a final written decision in this proceeding in mid-June 2026. See Ex. 2001, 7 (median time from filing to trial of 23.2 months); Prelim. Resp. 10. Thus, we find this factor is neutral or weighs slightly against discretionary denial.” slip op. at 10
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this preliminary stage, we determine whether the information presented shows a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been unpatentable over the proposed prior art. We analyze the asserted grounds with the above-noted principles in mind.” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had (1) at least a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a related field, and (2) at least two years of research or industry experience in 3D printing or materials used for 3D printing.” Pet. 5 (citing Ex. 1003 ¶¶ 14–16). Petitioner also argues that “[a]dditional experience could substitute for a formal degree or formal training (and vice versa).” Id. Patent Owner proposes a slightly different level of skill, arguing that a person of ordinary skill in the art “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 24. Neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears to be consistent with the ’713 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 16
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction needed
“We note that, as discussed below, we are able to determine whether to institute inter partes review of the ’713 patent without expressly construing the term “from multiple print heads or deposition lines.” See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). As for Patent Owner’s argument that Petitioner has failed to carry its burden to identify how the claims are to be construed, we disagree on the present record. Although Petitioner does not provide a preferred construction for the single term it proposes requires construction, Petitioner does identify which of its two alternative constructions applies to each of its asserted grounds of unpatentability. Pet. 6 (“Under the first construction, [the obviousness grounds] are applicable, and [the anticipation ground] would be excluded from the claim scope. Under the alternative construction, all of [the asserted grounds] are applicable.”). In our view, this approach does not fail to satisfy Petitioner’s burden under 37 U.S.C. § 42.104(b)(3).” slip op. at 17
Claim construction§ 102 anticipationDiscretionary denialcites PhillipsPatents in suitUS 9,421,713 - PTAB · Jun 11, 2025 · IPR2025-00262 · APJ Mitchell G Weatherly · IPR · Institution
The Board instituted IPR of claims 1–20 on all grounds, finding a reasonable likelihood that Haley and Lai render the claims obvious.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition filed under section 311 and any response filed under section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Based on our review of the record,1 we conclude that Petitioner is reasonably likely to prevail with respect to at least one of the challenged claims.” slip op. at 2
- Other 314aDenied
“Patent Owner argues that we should discretionarily deny the Petition based on alleged deficiencies in the Petition. Specifically, Patent Owner argues that “even if arguments as to a few claims might have been properly presented in the Petition, a decision to institute here would require the Board to address—for the first time and with no Petitioner input—critical claim construction issues affecting nearly every claim” in contravention of the requirements of 37 C.F.R. § 42.104(b)(3). Prelim. Resp. 34–35. For the reasons discussed above, we are not persuaded on the current record that Petitioner has violated 37 C.F.R. § 42.104(b)(3), or that critical and unresolved claim interpretation issues justifying discretionarily denying the Petition exist. We, therefore, decline to deny institution on this basis.” slip op. at 10
- Skill levelSkill level board ownOther
“we view the prior art and the claimed invention. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). The parties’ briefs do not propose a specific definition of a level of ordinary skill in the art. See generally, Pet., Prelim. Resp. Dr. Vallee, however, testifies that one of ordinary skill in the art relevant to the ’954 patent: would have either (i) a Master’s degree in mechanical engineering with at least two years of experience in power nailer design; (ii) a Bachelor’s degree in mechanical engineering with at least five years of experience in powered nailer design; or (iii) ten (or more) years of experience in powered nailer design. This experience in powered nailer design would include mechanical design, tool design, manufacturing, mechanics of materials, stress analysis, ergonomics, and human factors. Ex. 1003, ¶ 49. For purposes of this Decision, we adopt and apply Dr. Vallee’s formulation regarding the level of ordinary skill in the art.” slip op. at 6
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesOther
“1. Lifter The Petition contends that the “lifter” limitation is a means-plus- function limitation, Pet. 7, which Patent Owner does not dispute, Prelim. Resp. 15–26. Patent Owner argues, however, that Petitioner has “fail[ed] to identify any structure in the ’007 [sic, ’954] Patent to perform the claimed function.” Prelim. Resp. 15. We disagree. Petitioner identifies the structures in the Specification corresponding to the “lifter” as follows: The “lifter member” of the ’954 patent includes a rotatable cam lifter 100 (yellow, below left), with pin 104, 106, and 108 (green) on its face surface that engage protrusions 92 (blue) on the driver member 90 (orange). ’954 patent, 9:25–41, 16:32–46, Fig. 12. The ’954 patent also discloses two-pin variants: lifter members 465 and 480 in Figs. 31, 33. ’954 patent, 32:12–27, 32:45–60. Pet. 15. This identification of corresponding structure is sufficient to satisfy 37 C.F.R. § 42.104(b)(3). We also note that at this stage of the proceeding, Patent Owner does not dispute that Petitioner has correctly identified the corresponding structure. The parties may further address the proper interpretation of “lifter” at trial.” slip op. at 7
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · GrahamPatents in suitUS 10,478,954 - PTAB · Jun 11, 2025 · IPR2025-00261 · APJ Mitchell G Weatherly · IPR · Institution
Instituted IPR of claims 1–20 on all grounds after finding a reasonable likelihood that Haley anticipates claims 1, 7, 8, 17, and 20 and Haley with Lai renders the remaining claims obvious.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition filed under section 311 and any response filed under section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Based on our review of the record,1 we conclude that Petitioner is reasonably likely to prevail with respect to at least one of the challenged claims.” slip op. at 2
- Other 314aInstitution denied discretionary otherDenied
“Patent Owner argues that we should discretionarily deny the Petition based on alleged deficiencies in the Petition. Specifically, Patent Owner argues that “even if arguments as to a few claims might have been properly presented in the Petition, a decision to institute here would require the Board to address—for the first time and with no Petitioner input—critical claim construction issues affecting nearly every claim” in contravention of the requirements of 37 C.F.R. § 42.104(b)(3). Prelim. Resp. 33–35. For the reasons discussed above, we are not persuaded on the current record that Petitioner has violated 37 C.F.R. § 42.104(b)(3), or that critical and unresolved claim interpretation issues justifying discretionarily denying the Petition exist. We, therefore, decline to deny institution on this basis. E. Claims 1, 7, 8, 17, and 20: Anticipation by Haley” slip op. at 11
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesDecided for petitioner
“1. Lifter The Petition contends that the “lifter” limitation is a means-plus- function limitation, Pet. 7, which Patent Owner does not dispute, Prelim. Resp. 10–14. Patent Owner argues, however, that Petitioner has “fail[ed] to identify any structure in the ’007 Patent to perform the claimed function.” Prelim. Resp. 10. We disagree. Petitioner identifies the structures in the Specification corresponding to the “lifter” as follows: The “lifter” (“lifter member”) of the ’007 patent includes a rotatable cam lifter 100 (yellow below left), with pin 104, 106, and 108 (green) on its face surface that engage protrusions 92 (blue) on the driver member 90 (orange). ’007 patent, 9:36–52, 16:39–53, Fig. 12. The ’007 patent also discloses two-pin variants: lifter members 465 and 480 in Figs. 31, 33. ’007 patent, 32:23–38, 32:56–33:4. Pet. 17. This identification of corresponding structure is sufficient to satisfy 37 C.F.R. § 42.104(b)(3). We also note that at this stage of the proceeding, Patent Owner does not dispute that Petitioner has correctly identified the corresponding structure. The parties may further address the proper interpretation of “lifter” at trial.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“gas pressure system” recited in the preamble of independent claims 1 and 17. Prelim. Resp. 21–22. Patent Owner further argues that Petitioner, through its comparison of claims 1 and 17 to Haley, improperly implies that the “gas pressure system” can be “limited to a distinct portion of a power tool.” Id. at 23. Patent Owner contends that such an interpretation is improper because the “gas pressure system” must refer to “the entire system,” because the “structure of the claims themselves . . . include[s] . . . every component of the tool.” Id. We disagree. The “gas pressure system” recited in the preambles of claims 1 and 17 expressly refers to a system that is “for a power tool” and thus does not necessarily refer to “the entire” tool or “every component of the tool.” Ex. 1001, 39:6 (claim 1), 40:51 (claim 17). Neither claim 1 nor claim 17 recites, for example, the lifter or driver, which are required elements of an “entire” tool. Id. at 39:6–22 (claim 1), 40:51–67 (claim 17). The lifter and driver are introduced in dependent claims 2 and 18. Id. at 39:23–30 (claim 2), 41:1–9 (claim 18). Still other necessary components of a tool, e.g., a motor and power source, are introduced in dependent claims 5 and 19. Id. at 39:40–42 (claim 5), 41:10–13 (claim 19). By contrast to claims 1 and 17, independent claims 9 and 14 recite a “portable fastener driving tool” and expressly recite many necessary components of such a tool including the driver, lifter, prime mover, and power source. Id. at 39:54 (claim 9), 40:20 (claim 14). Accordingly, we find that the “gas pressure system” of claims 1 and 17 broadly refers to a portion of a power tool rather than the “entire system” or “every component of the tool.” slip op. at 8
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSRPatents in suitUS 11,034,007 - PTAB · Jun 6, 2025 · IPR2025-00257 · APJ Lilan Ren · IPR · Institution
The Board instituted IPR on claims 1–15 and all asserted grounds, finding a reasonable likelihood that claim 1 is unpatentable over Cable and Naware and over Comb and Tummala.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“discussed below, we decline to exercise our discretion to deny the Petition.” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2024); 37 C.F.R. § 42.4(a) (2024). Institution of an inter partes review requires that “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that there is a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim, and we institute an inter partes review.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“persuaded that Petitioner has sufficiently shown for purposes of institution that a person of ordinary skill in the art would have been motivated to combine the teachings of Cable and Naware in the manner argued by Petitioner. For example, both references directly relate to 3D printing, and we are persuaded that Cable teaches “a heated build platform and calls on the POSITA to implement this teaching via suitable solutions known in the art.” Pet. 13 (noting that Cable teaches a build platform that can be heated “by any suitable heating elements” (citing 1006 ¶ 45)). The current record also indicates that Naware taught known options in this regard, e.g., where it describes a build plate to be used in a 3D printing process that includes contact plates and temperature control modules. See, e.g., Ex. 1007, code (57). Petitioner additionally argues that there is a reasonable expectation of success in combining Cable with Naware because “3D printers with temperature-controlled heated build plates were well-known technologies at the time of the ’660 patent in 2014, and these technologies had been successfully demonstrated in the real-world by then.” Pet 15 (citing various portions of Ex. 1003). Patent Owner does not contest Petitioner’s arguments with respect to a reasonable expectation of success in combining Cable with Naware. See generally Prelim. Resp. Based on our review and consideration of the current record, we are persuaded that Petitioner has sufficiently shown for the teachings of Cable and Naware in the manner argued by Petitioner.” slip op. at 23
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner “does not contest Petitioner’s description of a person of ordinary skill in the art (a ‘POSITA’) having a bachelor’s degree in Mechanical Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 37. Patent Owner does not address the specific knowledge that Petitioner contends that ordinarily skilled artisan would possess. Id. For purposes of this decision, we adopt Petitioner’s unopposed definition of the level of ordinary skill in the art as it appears consistent with the disclosures of the ’660 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 18
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 9,592,660 - SAP America, Inc. v. Cyandia, Inc.Institution deniedPTAB · Apr 7, 2025 · IPR2024-01496 · APJ Mitchell G Weatherly · IPR · Institution
The Board denied institution of inter partes review of claims 1–11, 13, 16, 18, and 31–34 under § 314(a), after weighing the Fintiv factors.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“Although Petitioner has filed a Sotera stipulation, we agree with Patent Owner that the stipulation has limited practical effect in reducing the overlapping efforts here and in the Litigation. Petitioner contends in the district court that the system described in the WebSphere materials renders at least some of the challenged claims invalid. Because Petitioner cannot challenge claims in this proceeding based on a public use or sale of the WebSphere system, Petitioner’s Sotera stipulation would not prevent Petitioner from asserting an invalidity defense in the district court based on the public use or sale of the WebSphere system. We understand that, in the Litigation, Petitioner has relied upon the WebSphere publications as prior art, presumably as evidence describing the WebSphere system that was publicly used and on sale. Regardless of any decision rendered in this proceeding on the patentability of the challenged claims based on the WebSphere printed publications, Petitioner may continue to press an invalidity defense based on the same evidence presented here. Additionally, it appears that all claims being contested as invalid in the Litigation are also subject to a challenge in the Petition. The narrowing of asserted claims in the Litigation, if it occurs, will streamline the parties’ overall dispute on invalidity if we decide to discretionarily deny institution. So, a majority of the parties’ work that would be done here will also be required in the Litigation regardless of whether we institute review. Accordingly, we do not consider the presence of the Sotera stipulation in our case to ensure that inter partes review would be a “true alternative” to the Litigation. On balance, we find that Fintiv Factor 4 weighs in favor of discretionarily denying institution. E. Fintiv Factor 5: Whether Petitioner Is Defendant in District Court” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied fintivInstitution denied
“We decline to characterize the merits as sufficiently strong to overcome the other factors. That is not to say we view Petitioner’s case as marginal or close. Rather we determine that the other factors are more persuasive here. Although Petitioner’s challenge is straightforward and definitely meets the standard for institution, even when balanced against Patent Owner’s counterarguments, we do not find the challenge to be sufficiently strong to outweigh the evidence discussed above in connection with Fintiv Factors 1–5. When reviewing all other circumstances, we find that Fintiv Factor 6 is neutral. G. Conclusion” slip op. at 10
Discretionary denialPatents in suitUS 8,595,641 - SAP America, Inc. v. Cyandia, Inc.InstitutedPTAB · Apr 7, 2025 · IPR2024-01433 · APJ Jason W Melvin · IPR · Institution
The Board instituted review of claims 1–7, 10, 11, 13, 18, 19, 23, 29, 35, and 36 based on the PCT publication and Austin-Lane under § 103.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“Petitioner’s Sotera stipulation will eliminate the overlap between this proceeding and invalidity at the district court. Unlike the other, related IPRs for which we discretionarily deny review (e.g., IPR2024-01432, -01495, & -01496), this proceeding does not involve references that fundamentally convey the same information as may be presented as system art in the Texas litigation. In light of the stipulation and nature of the asserted ground, we conclude that this ground strongly favors institution.” slip op. at 12
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We conclude that the claim language reads on Austin-Lane’s disclosure of determining “a presentation method of the notification” such as “using an instant message to the notebook computer” (Ex. 1105 ¶¶ 39, 46), in combination with teachings regarding the device to which the notification is sent and the protocol used to deliver it. We further conclude that Petitioner has provided an adequate reason that skilled artisans would have looked to Austin-Lane’s teachings and combined them with the system described in the PCT publication, as discussed. We have further reviewed the uncontested aspects of the challenge to claim 1 (Pet. 43–58) and determine that Petitioner is reasonably likely to prevail proving obviousness of claim 1. IV. CONCLUSION For the reasons discussed above, we conclude that Petitioner has shown a reasonable likelihood of prevailing with respect to unpatentability of at least one claim. Accordingly, we institute inter partes review. V. ORDER Accordingly, it is ORDERED that, pursuant to 35 U.S.C. § 314(a), inter partes review of claims 1–7, 10, 11, 13, 18, 19, 23, 29, 35, and 36 of the ’948 patent is instituted on the grounds raised in the Petition; and” slip op. at 26
- Skill levelSkill level petitioner adoptedDecided for petitioner
“of filing “would have had a bachelor’s degree in electrical engineering, computer science, or equivalent, with two or more years of experience developing and implementing graphical user interfaces for controlling server-based applications, including handling asynchronous notifications generated by those applications and web services, such as portal systems, or an equivalent amount of relevant work or research experience” and “would have been familiar with common approaches for presenting information on a graphical user interface, including various layouts for presenting multiple elements, such as icons, widgets, windows, etc.” Pet. 14–15. Petitioner describes further capabilities that such a person of ordinary skill in the art would have had. Id. at 15–16. Patent Owner asserts that a person of ordinary skill in the art at the time of filing “would have had a Bachelor’s degree in electrical engineering, computer science, or the like, and/or four or more years of experience in server-based applications” and that “[a]dditional experience may make up for a lack of education and vice versa.” Prelim. Resp. 14. Because Petitioner’s proposed level of ordinary skill in the art appears to be consistent with the challenged patent and prior art, we adopt it and use “skilled artisans” to refer to people with such skill at the time the invention was filed. We do not perceive a substantive distinction between the parties’ definitions, but note that Petitioner’s definition provides more detail about the capabilities of skilled artisans. Should either party believe that the definition of ordinary skill in the art affects a disputed issue in the trial, it should point out how and identify any potential dispute about the level of skill.” slip op. at 14
- Disclosure Requirements (§112) › Written description (Ariad)Not entitled to earlier dateDecided for petitioner
“We do not agree. Petitioner notes that certain disclosures added to the April 2011 CIP application describe a “notification manager” to “determine the best alert notification method.” Pet. 27 (quoting Ex. 1110 ¶ 131; citing id. ¶¶ 90–93, 130–132, 145–147, 160). That does not mean that Petitioner construes the claim language to require determining the best method, only that disclosing a mechanism that “determine[s] the best alert notification method” provides written-description support for a requirement to “determin[e] a notification method.” Petitioner is clear in its position that the May 2009 application “does not describe how to determine a notification method or how to use ‘session data’ in the manner required by this claim limitation.” Pet. 27–28. Patent Owner asserts that the May 2009 application discloses “determining a notification method” through a channel alert server that can “determine the active devices of the subscriber . . . to provide a visual or auditory alert in the channel.” Prelim. Resp. 32 (quoting Ex. 1106 ¶ 39). That disclosure appears to address the claim language requiring an alert “based on the current state of the at least one external device indicated by the session data.” It does not, however, address the claim language “determining a notification method.” Patent Owner recognizes that Petitioner asserts disclosures in the prior art for “determining which devices to send the alert to, the protocols used to send the alert, and how alerts are presented.” Id. at 34 (emphasis omitted). But when Patent Owner asserts that the May 2009 application discloses determining how alerts are presented, it points to paragraphs that do not support the assertion. Id. at 35 (citing Ex. 1106 ¶¶ 23, 39). The first, paragraph 23, states that a “trigger may cause the information channel to change its appearance or to take other actions that may be implemented by the developer” and that “one action that may be implemented is to provide a notification to the user.” Ex. 1106 ¶ 23. Nothing about that indicates the system determines how an alert is presented. The second, paragraph 39, states that the channel alert server may “provide a visual or auditory alert in the channel” and that the “alert can appear as defined on other platforms.” Nothing about that indicates the system determines how an alert is presented. Patent Owner has not shown how the May 2009 application discloses a determining a notification method, as claimed. In Patent Owner’s view, Petitioner admits that the May 2009 application (which is the same as the asserted PCT publication) describes determining a delivery mechanism because Petitioner compares it to Austin-Lane, stating that the PCT publication “already includes a channel alert server that determines the active devices of the user and delivers an alert to the user’s device” and “discloses setting the same type of alert (stock alert) and presenting it in the same way (visually) as Austin-Lane.” Prelim. Resp. 35 (quoting Pet. 54) (emphasis omitted). But simply delivering an alert does not necessarily mean the notification method for that alert was determined. We conclude that Petitioner’s statement does not show the PCT publication discloses “determining a notification method” as claimed.” slip op. at 20
Claim construction§ 103 obviousness§ 112 disclosureDiscretionary denialcites Phillips · GrahamPatents in suitUS 8,751,948 - PTAB · Feb 20, 2025 · IPR2024-00996 · APJ Ken B Barrett · IPR · Institution
The Board instituted review of claims 13–18 on all asserted grounds, finding a reasonable likelihood of prevailing on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDenied
“inter partes review, “the Director may take into account whether, and reject the petition or request because, the same or substantially the same prior art or arguments previously were presented to the Office.” 35 U.S.C. § 325(d). The Board uses a two-part framework in determining whether to exercise its discretion under § 325(d), specifically: (1) whether the same or substantially the same art previously was presented to the Office or whether the same or substantially the same arguments previously were presented to the Office; and (2) if either condition of [the] first part of the framework is satisfied, whether the petitioner has demonstrated that the Office erred in a manner material to the patentability of challenged claims. Advanced Bionics, Paper 6 at 8. The art or arguments presented in the Petition are not “substantially the same” as those previously presented to the Office when there are differences between them that are material to the Office’s prior consideration of the art and arguments. Wolfspeed, Inc. v. Trs. of Purdue Univ., IPR2022-00761, Paper 13 at 7–8 (Vidal Mar. 30, 2023).” slip op. at 9
- Skill levelSkill level petitioner adoptedOther
“Petitioner contends that: [A] person of ordinary skill in the art at the time of the alleged invention (“POSITA”) would have had a bachelor’s degree or higher in electrical engineering, at least 3 years of experience designing or researching electronic circuits, and familiarity with power electronics and inductive power transfer circuits. Pet. 8 (citing Ex. 1003 ¶ 20). Patent Owner states that, “[f]or purposes of this preliminary response, Patent Owner adopts the Petitioner’s proposal.” Prelim. Resp. 17. Petitioner’s definition is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For purposes of this decision, we apply Petitioner’s definition of the person of ordinary skill in the art.” slip op. at 18
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner contends that “[a]ll claim terms should be construed according to the Phillips standard,” and “[h]ere, given the remarkable overlap between the preferred embodiment of the ’461 patent and the prior art/predictable combinations articulated in Grounds 1A–3, Petitioners submit that no claim elements need a formal construction for purposes of resolving the controversy in this proceeding.” Pet. 8. Patent Owner states that, “[t]o simplify the issues before the Board, Patent Owner has not asserted any claim constructions in this preliminary response and adopts the Petitioner’s position that ‘[a]ll claim terms should be construed according to the Phillips standard.’” Prelim. Resp. 17 (quoting Pet. 8). On this record and for purposes of this decision, we determine that no” slip op. at 19
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“At this preliminary stage of the proceeding, we do not agree with Patent Owner’s arguments. Patent Owner does not cite to evidence, such as expert testimony, to support its implied argument that Olson’s measured current is “fundamentally different” from the current received by the primary coil. See Prelim. Resp. 31–32. Petitioner’s declarant, Dr. Woods, on the other hand, testifies, inter alia, that “[t]he ‘[c]urrent measured by current measure block 226 is used in the calculation of power, which as depicted in FIG. 14, measures the ‘power in’ provided to transmit block 214/primary coil 54.” Ex. 1003 ¶ 37 (citing Ex. 1004 ¶¶ 74–75, Fig. 14) (first alteration added); see also, e.g., id. ¶ 42 (Dr. Woods testifying that the measured current to the power supply “is the current driving the external antenna 52, via the transmit block 214 and to the primary coil 54.” (citing Ex. 1004 ¶¶ 74–75, 112, Fig. 14)). Paragraph 75 of Olson, cited in support of that testimony, provides: “The power in is gauged by the power generated by charging unit 50 and is determined by multiplying the voltage of the internal voltage of charging unit 50, e.g., the voltage of a battery or batteries internal to charging unit 50, by the current driving external antenna 52.” Ex. 1004 ¶ 75 (emphasis added). We note that external antenna 52 includes primary coil 54. See, e.g., Fig. 14. Dr. Woods’ testimony is, at this stage, unrebutted. Patent Owner also argues that “Petitioner fails to provide any evidence regarding the function of Olson’s microprocessor 212 in relation to measuring input power,” and that, “[w]hile Olson describes a power calculation in paragraph [0075], Olson does not describe this power calculation as performed by microprocessor 212.” Prelim. Resp. 32 (citing Pet. 16; Ex. 1004 ¶ 72) (first alteration added). At this preliminary stage of the proceeding, we do not agree with Patent Owner’s arguments regarding the microprocessor. Although Patent Owner does not bear the burden to show patentability, we observe that Patent Owner does not suggest that there is another component in Olson’s external charging device that might perform the admittedly-disclosed power calculation. See Prelim. Resp. 32–33. Dr. Woods testifies that microprocessor 212 receives the measured current and the input voltage of the charging device, and, from those values, calculates power in. See Ex. 1003 ¶¶ 43–44 (citing, inter alia, Ex. 1004 ¶¶ 71–78, Fig. 14); see also Ex. 1004 ¶ 74, Fig. 14 (Olson stating that “[c]urrent measured by current measure block 226 is used in the calculation of power in along with the voltage of batteries 160,” and Figure 14 depicting the signal from measure block 226 as an input to microprocessor 212). Dr. Woods’ testimony is, at this stage, unrebutted.” slip op. at 26
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,626,461 - Intel Corporation v. Telefonaktiebolaget LM EricssonInstitution deniedPTAB · Dec 18, 2024 · IPR2024-01008 · APJ Patrick R Scanlon · IPR · Institution
The Board denied institution on all challenged claims because Petitioner did not show a reasonable likelihood of prevailing on any asserted obviousness ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsDenied
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that Petitioner has not demonstrated a reasonable likelihood that it would prevail with respect to at least one challenged claim. Accordingly, we do not institute an inter partes review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner contends that the challenged claims do not need construction to demonstrate unpatentability. Pet. 14. Petitioner, however, notes that the parties in the ITC proceeding identified above dispute the meaning of several claim terms. Id. (citing Ex. 1026). Petitioner specifically notes that “the parties dispute what is required of independent claims 1, 5, and 16 to ‘determin[e] how many pixels’ to filter in each block.” Id. (citing Ex. 1026, 6–7). Petitioner argues that “ITC Respondent Lenovo mathematical basis (no relationship) with the pixel values of the pixels in said neighboring block’” (id. (citing Ex. 1026, 6–7)), but Patent Owner “contends that no construction is necessary,” “and the ‘plain meaning’ does not foreclose some ‘mathematical basis’ existing as long as separate decision values are calculated for each block” (id. (citing Ex. 1027, 14–19)). Petitioner indicates that Ground 1 adopts Patent Owner’s broader construction from the ITC proceeding and Ground 2 adopts Lenovo’s narrower construction. Id. at 14–15. Patent Owner argues that “none of the asserted grounds disclose or render obvious the Challenged Claims under the plain meaning of the claims (which is [Patent Owner’s] proposed construction) or under Lenovo’s narrower proposed construction.” Prelim. Resp. 29. On the present record, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Furthermore, we are not persuaded that modifying Aksu in view of Gonzalez in the manner proposed by Petitioner overcomes this problem. As noted above, Petitioner asserts that, in the proposed combination, one of ordinary skill in the art “would have understood that the Laplacian’s output would be compared directly to a threshold based on β—just like Aksu’s difference calculations—to determine how many pixels to filter.” Pet. 60 (citing Ex. 1019, 13:15–19; Ex. 1003 ¶¶ 406–410). We disagree with this assertion, however, because it relies on erroneously equating the output of calculations (i.e., |r1-rj| and |r1-ri+1|). In other words, Aksu’s difference calculations, although used in setting dr, are not the same as dr; and we are not persuaded that one of ordinary skill in the art would have considered comparing Gonzalez’s Laplacian output to threshold β because Aksu discloses comparing its difference calculations to β. As noted above, we are not directed to any disclosure in Aksu of comparing dr to β. In addition, Dr. Schonfeld’s testimony on this point is not persuasive. Specifically, Dr. Schonfeld testifies that “dr can simply be defined as the output of the Laplacian (dr=|r3-2r2+r1|), and dr could be directly compared to a threshold based on β.” Ex. 1003 ¶ 408 (underline emphasis added). This testimony, however, is entitled to little weight because Dr. Schonfeld fails to provide a sufficient underlying basis for his opinion. See 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); see also Nobel Biocare Services AG v. Instradent USA, Inc., 903 F.3d 1365, 1382 (Fed. Cir. 2018) (explaining that the Board can reject arguments based on expert testimony that lacks specificity or detail). Moreover, opining that output of the Laplacian, dr, could be directly compared to β does not establish sufficiently that one of ordinary skill in the art would have been motivated to do so. See Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1073 (Fed. Cir. 2015) (“[O]bviousness concerns whether a skilled artisan not only could have made but would have been motivated to make the combinations or modifications of prior art to arrive at the claimed invention.”).” slip op. at 26
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“G. Discretion Under 35 U.S.C. § 325(d) Patent Owner argues that we should exercise our discretion to deny institution under § 325(d). Prelim. Resp. 64–66; Paper 8. Petitioner argues that discretionary denial is not appropriate in this case. Pet. 85–86; Paper 7. Because we are not persuaded the Petition demonstrates sufficiently a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim as discussed above, we need not reach Patent Owner’s arguments regarding discretionary denial under § 325(d).” slip op. at 29
Claim construction§ 103 obviousnessDiscretionary denialcites GrahamPatents in suitUS 9,641,841
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.