- Encube Ethicals PTV. Ltd. v. Dermavant Sciences GmbHAdverse judgmentPTAB · Mar 7, 2025 · IPR2024-00834 · APJ Tawen Chang · IPR · Adverse judgment
The Board entered adverse judgment against Patent Owner on all challenged claims, 1–4, 6–10, 16, 18, 21, and 22, following their disclaimer.
RulingsAdverse judgment- Adverse judgmentAdverse judgmentGranted
“Terminate Proceeding and Parties’ Joint Motion for Entry of Adverse Judgment (collectively “Motion”). The parties jointly request that the Board enter adverse judgment in light of the disclaimer filed by Patent Owner disclaiming all challenged claims. Mot. 1 (citing 37 C.F.R. § 42.73(b)(2)). The Motion attaches as an exhibit a disclaimer under 37 C.F.R. § 1.321(a), filed January 28, 2025, of claims 1–4, 6–10, 16, 18, 21, and 22 of the ’088 patent, which constitute all of the claims challenged in the inter partes review. Ex. 2001; Paper 1, 3.” slip op. at 2
- PTAB / AIA Trials › Other PTAB motions (exclude, strike, seal, additional discovery, rehearing)Denied
“Accordingly, we grant the Parties’ Joint Motion for Entry of Adverse Judgment. This Adverse Judgment is sufficient to dispose of this proceeding and Patent Owner’s Motion to Terminate is denied as moot.1” slip op. at 3
NonePatents in suitUS 11,590,088 - Fusion Orthopedics, LLC v. Extremity Medical, LLCSome claims unpatentablePTAB · Nov 4, 2024 · IPR2023-00894 · APJ Robert A Pollock · IPR · Final written decision
Claims 1–10 and 12–15 are unpatentable; claim 11 was not shown unpatentable. Substitute claims 16–25 and 27–30 are unpatentable over Mazur; claim 26 was not reached.
RulingsFinal written decision- BurdenMixed
“It is of the utmost importance that petitioners in the IPR proceedings adhere to the requirement that the initial petition identify ‘with particularity’ the ‘evidence that supports the grounds for the challenge to each claim.’” Intelligent Bio-Sys., Inc. v. Illumina Cambridge Ltd., 821 F.3d 1359, 1369 (Fed. Cir. 2016) (quoting 35 U.S.C. § 312(a)(3)). Here, however, not until its Reply does Petitioner belatedly suggest that Ferrante’s disclosure of bone screws with self-tapping ends equally meets the limitation of claim 10 (with respect to the first member) as with claim 11 (with respect to the second member), and that both claims are obvious in light of “evidence” from Ferrante “that it was well known to equip bone screws with self-tapping ends.” Reply 26–27. We do not discern these arguments in the Petition, and consider them waived. See Netflix, Inc. v. DivX, LLC, 84 F.4th 1371,1377 (Fed. Cir. 2023) (“While the Board should not take an overly mechanistic view of a petition and decline to address an argument because the petitioner did not present it with ideal vigor and clarity, the Board should also not have to decode a petition to locate additional arguments beyond the ones clearly made.”). In sum, Petitioner’s error in failing to first address limitations of claim 10 in the Petition specific to the Cognet/Ferrante combination indicates a failure to meet the particularity requirements for what must be in the petition and cannot be left to be filled in on reply. See 35 U.S.C. § 312(a)(3); 37 C.F.R. §§ 42.22(a)(2) (requiring, among other things, “a detailed explanation of the significance of the evidence”), 42.104(b)(4)–(5) (requiring that petition “specify where each element of the claim is found in the prior art patents or printed publication relied upon” and, regarding submitted evidence, state “the relevance of the evidence to the challenge raised, including identifying specific portions of the evidence that support the challenge”). Microsoft, 2022 WL 989403, at *6. Accordingly, Petitioner has not shown persuasively that claim 11 would have been obvious in light of Cognet and Ferrante for the reasons set forth in the Petition. slip op. at 41
- Expert testimonyPetitioner expert creditedDecided for petitioner
“We also find persuasive Mr. Dominguez’s explanation that one of ordinary skill in the art would have understood “bore” as including stepped diameter holes, sometimes described as a bore having a counterbore. See generally Ex. 1018 ¶¶ 4–29; Reply 3–10. Three of Mr. Dominguez’s illustrative examples are reproduced in the annotated figures below. The above figures show Mr. Dominguez’s annotated illustrations from the Jackson (Ex. 1019, Fig. 3), Brånemark (Ex. 1021, Fig. 4), and Ray (Ex. 1025, Fig. 1) references as discussed at paragraphs 10, 12, and 13, respectively, of Mr. Dominguez’s Second Declaration. With reference to the above figures, Mr. Dominguez testifies that “Jackson describes a bone repair set screw in which ‘[t]he bore 27 comprises a first bore section 31, a second bore section 32,’ etc. delineated by shoulders 41, 42, etc. (Ex. 1019, 5:24– 43)” (Ex. 1018 ¶ 10); “Brånemark describes an osseous implantation device having body 1ʺ with first and second holding portions 21ʺ, 31ʺ and ‘an inner through bore with a first portion 4ʺ in the first holding portion and a second portion 5ʺ in the second holding portion.’” Ex. 1021, 4:44–46” (id. ¶ 12); and Ray discloses surgical calipers including “handle 12 having ‘stepped cylindrical bore 14,’” wherein “[c]ollar 20 of a shaft inserted in the bore ‘rests against a step of the bore 14’ (2:14–15)” (id. ¶ 13). Patent Owner responds that Mr. Dominguez’s examples “that allegedly show a single bore encompassing two or more stepped-diameter holes or a counterbore . . . . are specific to these references and divorced from the disclosures of the ’166 patent.” Sur-Reply 7. Insofar as the ’166 patent makes no mention of the term “bore” outside the claims, and Mr. Dominguez’s examples are all taken from the field of orthopedic surgery, we do not find this argument persuasive. Patent Owner further appears to contend that exemplary references to a “cylindrical stepped down bore” or a “stepped cylindrical bore” are too specific to be within the scope of the term “bore.” Sur-Reply 7–8. As these terms merely describe species within a larger genus, and Patent Owner presents no cogent reason to exclude them, we do not find this argument availing. Relatedly, we are also not persuaded by Patent Owner’s argument that “the prior art treats a ‘bore’ as an element that is distinct from a ‘counterbore.’” Id. at 8. Rather, we credit Mr. Dominguez’s testimony that “[a] counterbore is not a structure unto itself, a counterbore is part of a larger structure” as exemplified by numerous examples including Laps (Ex. 1028 ¶ 33 (sensor assembly wherein “bore 16 includes a counterbore 18”)); Martinez (Ex. 1029, 3:61 (surgical cutting instrument wherein “bore 56 has a counterbore 64”)); Zang (Ex. 1030, 2:49 (bone anchor having a “bore [that] includes a counterbore”)); Ledet (Ex. 1022, 29:3–5 (vertebral fixation plate having “through holes . . . . countersunk, or counterbored to accommodate the head of a bone screw”)); Seo (Ex. 1031, 3:45 (chair leg employing “counterbored bore 23”)); and Exner (Ex. 1032, 2:16 (extrusion press including “counterbored axial bore 6”)). Ex. 1018 ¶¶ 17–23. That a reference may refer to a figure as showing “bore 103” with “counterbore 105 . . . formed on one end” does not indicate that they are distinct structures as Patent Owner contends, but merely that the focus of each term is directed to the entire bore or to a particular aspect of the bore, i.e., its counterbore. See” slip op. at 22
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner subsequently proposed an alternative definition, as a person having “[a] Bachelor’s Degree in biomedical and/or mechanical engineering or similar training and . . . at least three years of experience with implant devices used for internal fixation of bones.” POR 5 (citing Ex. 2012 ¶¶ 32–33). According to Patent Owner, “[t]his hypothetical person would be capable of performing various design tasks and would understand the basic mechanical features and operation of orthopaedic implant devices [and] have an appreciation for orthopaedic fusion techniques and the medical issues and concerns faced by a doctor/surgeon charged when performing operations to implant orthopaedic devices.” Id. Despite some differences in wording, Patent Owner asserts (and Petitioner does not contest) that any “distinction between the parties’ proposed definitions of a POSITA does not affect the arguments set forth herein.” Id. (citing Ex. 2012 ¶ 34). Consistent with this view, we find the parties’ constructions equally applicable in light of the prior art of record and the disclosure of the ’166 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“the prior art itself [may] reflect[] an appropriate level” as evidence of the ordinary level of skill in the art) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)). We adopt, for convenience, Petitioner’s definition, but our analysis does not change depending on which of the two articulations are applied here. H.” slip op. at 12
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“one of ordinary skill in the art would understand that “bore,” as used in the context of claims 1 and 12, encompasses a multi-diameter passage, and in particular, one having stepped longitudinal cross sections such as that shown in Cognet’s Figure 1. See generally DI 11–13. For the reasons that follow, we conclude that one of ordinary skill in the art would have understood “bore” as such. Relying on the testimony of Mr. Dominguez, Petitioner initially proposed a construction of “bore” as “a usually cylindrical hole made by or as if by the turning or twisting movement of a tool.” Pet. 16 (citing Ex. 1002 ¶ 58). Petitioner’s proposal relied on Mr. Dominguez’s testimony that “[a] bore is a cylindrical hole made by the spinning rotation of a twist drill cutting tool. It is typically made by removing material from a solid or hollow object, similar to a tunnel or orifice.” Ex. 1002 ¶ 58. Pointing to its annotation of Cognet’s Figure 1, above, Patent Owner argued that that the term “bore” excludes a tunnel made by “two adjacent bores.” See Prelim. Resp. 21–25. In view of the then-available evidence, we provisionally construed “bore” as a hole or passage made by or as if by the turning or twisting movement of a tool such that its interior walls have cylindrical lateral cross-sections, and which do not exclude holes or passages having tapered or stepped longitudinal cross-sections. DI 13.” slip op. at 19
Patent outcomesUS 11,298,166 mixedClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,298,166 - PTAB · Oct 11, 2024 · IPR2024-00772 · APJ Monica S Ullagaddi · IPR · Institution
The Board instituted IPR on all challenged claims and petition grounds, found the merits threshold met, and granted Texas Instruments’ motion to join IPR2024-00001.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“3. Analysis At this stage of the proceeding, we determine that Patent Owner’s statements made during prosecution of the ’195 patent appear to contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support Petitioner’s argument tthat a graded dopant concentration is enough to teach aiding carrier movement in a particular direction. Patent Owner does not dispute that Kawagoe has a graded dopant concentration in the active region at this stage of the proceeding. Id. Patent Owner also does not dispute that Kawagoe’s transistor has carriers in the active region or that the graded dopant concentration of Kawagoe is lowered from the surface to the bottom substrate (Ex. 1007, Fig. 17). Id. At this stage of the proceeding, the evidence of record supports Petitioner’s position sufficiently to meet the reasonable likelihood threshold for institution. We decline to make further determinations, on this preliminary record, regarding the dispute surrounding this limitation, because the trial in the 00001IPR is the better proceeding in which to do so. Specifically, as compared to the preliminary phase of this case, the instituted trial in the 10 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1016, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. 00001IPR affords the parties a better opportunity to fully and fairly brief, argue, and develop evidence in support of their positions. We observe, on this record, the dispute is inadequate to undermine the sufficiency of Petitioner’s evidence to support institution of review.” slip op. at 14
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the 1 The Leahy-Smith America Invents Act (“AIA”), Pub. L. No. 112-29, 125 Stat. 284 (2011), amended 35 U.S.C. § 103, effective March 16, 2013. Because applications from which the ’481 patent claims priority were filed before this date, the pre-AIA version of § 103 applies. 2 U.S. Patent No. 6,043,114, issued Mar. 28, 2000 (Ex. 1007, “Kawagoe”). 3 U.S. Patent No. 6,163,877, issued Dec. 19, 2000 (Ex. 1014, “Gupta”). 4 U.S. Patent Publication No. 2003/0183856 A1, published Oct. 2, 2003 (Ex. 1006, “Wieczorek”). 5 Petitioner cites four volumes for Wolf: Stanley Wolf & Richard Tauber, Silicon Processing For The VLSI Era, Volume 1 – Process Technology, 2nd ed., (Lattice Press 2000) (Ex. 1008A); Stanley Wolf & Richard Tauber, Silicon Processing For The VLSI Era, Volume 2 – Process Integration, (Lattice Press 2000) (Ex. 1008B); Stanley Wolf & Richard Tauber, Silicon Processing For The VLSI Era, Volume 3 – The Submicron MOSFET, (Lattice Press 2000) (Ex. 1008C); and Stanley Wolf & Richard Tauber, Silicon Processing For The VLSI Era, Volume 4 – Deep-Submicron Process Technology, (Lattice Press 2000) (Ex. 1008D). petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 14– 35. However, 35 U.S.C. § 315(b) also provides that the one-year time bar “shall not apply to a request for joinder under subsection (c).” 37 C.F.R. § 42.122(b). Because the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted 00001IPR proceeding, which we grant as further discussed below, Patent Owner’s argument that the Petition is timebarred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 4
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“Based on the facts and circumstances discussed above, having reviewed the briefings of both parties, we determine Petitioner has established good cause for joining the 00001IPR. Specifically, we find that joining Petitioner to the 00001IPR is unlikely to require any delay or modification to the scheduling order already in place for the 00001IPR. We also determine that Patent Owner will not be prejudiced unduly by the joinder of this proceeding. Thus, we determine that granting the Motion for Joinder under these circumstances would help “secure the just, speedy, and inexpensive resolution” of these proceedings. See 37 C.F.R. § 42.1(b). For the above reasons, we grant Petitioner’s Motion for Joinder and join Petitioner as a party to the 00001IPR.” slip op. at 19
NonePatents in suitUS 10,734,481 - PTAB · Oct 11, 2024 · IPR2024-00774 · APJ Jon B Tornquist · IPR · Institution
The Board instituted IPR on all challenged claims and petition grounds, and granted Texas Instruments’ motion to join the Cirrus IPR.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“IPR. Compare id., with IPR2024-00019, Paper 46 at 1–4, 6–22 (Patent Owner’s response in the Cirrus IPR) (public version). We decline to resolve the material issue of fact surrounding this limitation on this preliminary record, because the trial in the Cirrus IPR is the better proceeding in which to do so. Specifically, as compared to the preliminary phase of this case, the instituted trial in the Cirrus IPR affords the parties a better opportunity to fully and fairly brief, argue, and develop evidence in support of their positions, and, in particular, to address Cirrus Logic’s alleged admission that the existence of a gradient alone is insufficient to disclose the “aid carrier movement” limitations of independent claims 1 and 21. We observe only that, on this record, the disputed issue of material fact is not sufficient to undermine the sufficiency of Petitioner’s evidence supporting institution of review.” slip op. at 16
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 15– 35. The one-year time bar under § 315(b), however, “shall not apply to a request for joinder under subsection (c).” 35 U.S.C. § 315(b); see 37 C.F.R. § 42.122(b). And, because the Petition is accompanied by a timely request for joinder (Paper 1) to the instituted proceeding (IPR2024-00019), which we grant as further discussed below, Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 8
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“Based on the facts and circumstances discussed above, we determine Petitioner has established good cause for joining the Cirrus IPR. Specifically, we find that joining Petitioner to the Cirrus IPR is unlikely to require any delay or modification to the scheduling order already in place for that proceeding. We also determine that Patent Owner will not be prejudiced unduly by the joinder of this proceeding. Thus, we determine that granting the Motion for Joinder would help “secure the just, speedy, and inexpensive resolution” of these proceedings. See 37 C.F.R. § 42.1(b). Accordingly, we grant Petitioner’s Motion for Joinder and join Petitioner as a party to the Cirrus IPR.” slip op. at 19
NonePatents in suitUS 11,316,014 - PTAB · Oct 11, 2024 · IPR2024-00773 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted review of claims 7–12 on all asserted grounds and granted Texas Instruments’ motion to join the Cirrus IPR in an understudy role.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Rather than pointing to anything in the prior art that would teach this claim limitation, the Petition assumes that any “graded concentration of dopants” would necessarily “aid the movement of minority carriers.” The Petition contains no analysis explaining why the “graded concentration of dopants” in the prior art meet the “aid the movement of minority carriers” limitation, apart from the fact that they are “graded concentration of dopants.” In other words, Petitioner reads the “aid the movement of minority carriers” limitation out of the claims completely.” slip op. at 13
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b)” slip op. at 7
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“joinder is discretionary. See 35 U.S.C. § 315(c); 37 C.F.R. § 42.122. A motion for joinder should (1) set forth reasons why joinder is appropriate; (2) identify any new grounds of unpatentability asserted in the petition; (3) explain what impact (if any) joinder would have on the trial schedule for 7 Available at https://www.uspto.gov/TralPracticeGuideConsolidated. the existing review; and (4) address specifically how briefing and discovery may be simplified. See, e.g., Kyocera Corp. v. Softview LLC, IPR2013- 00004, Paper 15 (PTAB April 24, 2013). As the moving party, Petitioner bears the burden of proving that it is entitled to the requested relief. 37 C.F.R. § 42.20(c).” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of successInstituted
“Regarding the “first static unidirectional electric drift field to aid the movement of minority carriers” limitation, Petitioner relies on the parent file history and cited references, arguing that “Payne’s downward-sloping graded-dopant concentration aids the movement of minority carriers from the surface layer to the substrate to the same extent to which Applicant relied on the prior art and admitted to the Patent Office that such carrier movement would occur under the same scenario.” Pet. 23. Petitioner also asserts that the direction in which carriers are forced with the concentration profile disclosed in Payne is downward, toward the substrate and away from the surface. Pet. 23–28 (quoting and citing Ex. 1046, 237–238, 253–254, 289– 290; citing Ex. 1003 ¶¶ 95–106; Ex. 1005, 5:7–17, 5:44–55; Ex. 1009, 2:11– 16, 2:67–3:18, Fig. 2; Ex. 1010, 2:27–32, 5:14–22; Ex. 1013, 431; Ex. 1030, 24). We find that Petitioner’s challenge to claim 7 based on Payne is sufficiently supported for purposes of institution.” slip op. at 12
§ 103 obviousnessPatents in suitUS 9,190,502 - PTAB · Oct 11, 2024 · IPR2024-00771 · APJ Grace Karaffa Obermann · IPR · Institution
The Board instituted IPR on claims 1–6 of the ’195 patent on all asserted grounds and granted Texas Instruments’ motion to join the Cirrus IPR.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Because the Preliminary Response in the instant case includes arguments pertaining to the sufficiency of the asserted prior art references, which were not raised in the preliminary response in the Cirrus IPR, we briefly address below the patentability of the challenged claims.” slip op. at 6
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“II. TIMELINESS OF THE PETITION UNDER 35 U.S.C. § 315(B) Pursuant to 35 U.S.C. § 315(b), “[a]n inter partes review may not be instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 10– 30. However, 35 U.S.C. § 315(b) also provides that the one-year time bar “shall not apply to a request for joinder under subsection (c).” See also 37 C.F.R. § 42.122(b). Because the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted proceeding (IPR2024-00017), which we grant as further discussed below, Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 5
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“B. Whether to Join Petitioner as a Party to the Cirrus IPR Joinder may be authorized when warranted, but the decision to grant joinder is discretionary. See 35 U.S.C. § 315(c); 37 C.F.R. § 42.122. A motion for joinder should (1) set forth reasons why joinder is appropriate; (2) identify any new grounds of unpatentability asserted in the petition; (3) explain what impact (if any) joinder would have on the trial schedule for the existing review; and (4) address specifically how briefing and discovery may be simplified. See, e.g., Kyocera Corp. v. Softview LLC, IPR2013- 00004, Paper 15 (PTAB April 24, 2013). As the moving party, Petitioner bears the burden of proving that it is entitled to the requested relief. 37 C.F.R. § 42.20(c). As an initial matter, we find the Motion for Joinder meets the timing requirements of 37 C.F.R. § 42.122(b) because Petitioner filed it on April 4, 2024, no later than one month after the Cirrus IPR was instituted on May 1, 2024.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“5. “Aid the Movement of Minority Carriers” Patent Owner argues that the Petition fails to show that the applied prior art references disclose the claim limitations “requiring ‘aid the movement of minority carriers,’” as twice recited in claim 1. Prelim. Resp. 8. Patent Owner summarizes this dispute as follows: The challenged patent discloses and claims a semiconductor device with (among other things) a “drift layer having a graded concentration of dopants . . . [and] further having a first static unidirectional electric drift field to aid the movement of minority carriers.”[] The Petition should not be instituted, because (among other deficiencies) it fails to show that the prior art discloses the “aid the movement of minority carriers” claim limitation. Rather than pointing to anything in the prior art that would teach this claim limitation, the Petition assumes that any “graded concentration of dopants” would necessarily “aid the movement of minority carriers.” The Petition contains no analysis explaining why the “graded concentration of dopants” in the prior art meet the “aid the movement of minority carriers” limitation, apart from the fact that they are “graded concentration of dopants.” In other words, Petitioner reads the “aid the movement of minority carriers” limitation out of the claims completely. Id. at 1–2. Patent Owner includes additional details in support of its view that the asserted prior art fails to establish obviousness of the “aid carrier movement” limitations of claim 1. Prelim. Resp. 1–10.” slip op. at 8
§ 102 anticipation§ 103 obviousnessPatents in suitUS 8,421,195 - PTAB · Sep 27, 2024 · IPR2024-00674 · APJ Monica S Ullagaddi · IPR · Institution
The Board instituted review of claim 44 on all asserted grounds and granted Texas Instruments’ motion to join IPR2023-01244 in an understudy role.
RulingsInstitution decision- Parallel petitionsDecided for petitioner
“On the present record, we agree with Petitioner that the two petitions filed to challenge the claims of the ’222 patent will not substantially burden the Board or the parties. The petitions in IPR2024-00673 and IPR2024- 00674 challenge different claims, and those claims appear on the present record to have different claim scope, as Petitioner argues. Paper 3, 3–4 (arguing that claim 44, challenged in IPR2024-00674, recites “a ‘surface layer,’ a ‘single drift layer,’ and ‘at least one well region disposed in the single drift layer,’ which are not” recited in the claims challenged in IPR2024-00673); Ex. 1001, 4:39–8:39. In addition, there is little overlap between the prior art asserted in the two petitions, and what overlap there is—the use of Kawagoe in both petitions—is used in different prior-art combinations in each petition. Compare IPR2024-00673, Paper 4, 5 (asserting Kawagoe alone and in combination with Gupta or Silverbrook), with IPR2024-00674, Paper 4, 5 (asserting Kawagoe in combination with Sakai). Accordingly, we do not exercise our discretion to deny either of the petitions challenging the ’222 patent for being parallel petitions.” slip op. at 5
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 16– 37. However, 35 U.S.C. § 315(b) also provides that the one year time bar “shall not apply to a request for joinder under subsection (c).” See also 37 C.F.R. § 42.122(b). Since the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted proceeding (IPR2023-01244), which we grant as further discussed below (see infra § V), Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, regardless of whether Petitioner is in privity with time-barred entities.” slip op. at 5
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“statements made during prosecution of the ’195 patent contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support a preliminary finding that a graded dopant concentration is enough to teach 9 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1020, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. aiding carrier movement in a particular direction. Patent Owner does not dispute that Payne has a drift layer having a static unidirectional electric drift field and a well region having a graded concentration of dopants and a static unidirectional electric drift field at this stage of the proceeding. See generally Prelim. Resp. Patent Owner also does not dispute that Payne’s transistor has a surface layer and a substrate having an area with no active regions. Id. At this stage of the proceeding, Petitioner has the better position.” slip op. at 16
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“statements made during prosecution of the ’195 patent contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support a preliminary finding that a graded dopant concentration is enough to teach 9 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1020, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. aiding carrier movement in a particular direction. Patent Owner does not dispute that Payne has a drift layer having a static unidirectional electric drift field and a well region having a graded concentration of dopants and a static unidirectional electric drift field at this stage of the proceeding. See generally Prelim. Resp. Patent Owner also does not dispute that Payne’s transistor has a surface layer and a substrate having an area with no active regions. Id. At this stage of the proceeding, Petitioner has the better position.” slip op. at 16
§ 103 obviousnessDiscretionary denialPatents in suitUS 11,121,222 - PTAB · Sep 27, 2024 · IPR2024-00673 · APJ Monica S Ullagaddi · IPR · Institution
The Board instituted review of claims 1–9, 13–28, and 32–42 on all asserted grounds and granted Texas Instruments’ motion to join IPR2023-01242 in an understudy role.
RulingsInstitution decision- Parallel petitionsDecided for petitioner
“On the present record, we agree with Petitioner that the two petitions filed to challenge the claims of the ’222 patent will not substantially burden the Board or the parties. The petitions in IPR2024-00673 and IPR2024- 00674 challenge different claims and, on the present record, those claims 8 Patent Trial and Appeal Board Consolidated Trial Practice Guide (Nov. 2019), available at https://www.uspto.gov/TrialPracticeGuideConsolidated (“CTPG”). appear to have different claim scope, as Petitioner argues. Paper 3, 3–4 (arguing that claim 44, challenged in IPR2024-00674, recites “a ‘surface layer,’ a ‘single drift layer,’ and ‘at least one well region disposed in the single drift layer,’ which are not” recited in the claims challenged in IPR2024-00673); Ex. 1001, 4:39–8:39. In addition, there is little overlap between the prior art asserted in the two petitions, and what overlap there is—reliance on Kawagoe in both petitions—is applied in different prior art combinations in each petition. Compare IPR2024-00673, Paper 4, 5 (asserting Kawagoe alone and in combination with Gupta or Silverbrook), with IPR2024-00674, Paper 4, 5 (asserting Kawagoe in combination with Sakai). Accordingly, we do not exercise our discretion to deny either of the petitions challenging the ’222 patent for being parallel petitions.” slip op. at 5
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“III. WHETHER THE PETITION IS TIME-BARRED Pursuant to 35 U.S.C. § 315(b), “[a]n inter partes review may not be instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 19– 39. However, 35 U.S.C. § 315(b) also provides that the one-year time bar “shall not apply to a request for joinder under subsection (c).” See also 37 C.F.R. § 42.122(b). Because the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted proceeding (IPR2023-01242), which we grant as further discussed below (see infra § V), Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 6
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“statements made during prosecution of the ’195 patent contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support a preliminary finding that a graded dopant concentration is enough to teach 13 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1016, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. aiding carrier movement in a particular direction. Patent Owner does not dispute that Kawagoe has a graded dopant concentration in the active region at this stage of the proceeding. See generally Prelim. Resp. Patent Owner also does not dispute that Kawagoe’s transistor has carriers in the active region or that the graded dopant concentration of Kawagoe is lowered from the surface to the bottom substrate (Ex. 1007, Fig. 17). See generally Prelim. Resp. At this stage of the proceeding, Petitioner has the better position.” slip op. at 19
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“under the pre-AIA version of 35 U.S.C. § 112, first paragraph and found that “movement of minority carriers is affected by multiple forces and fields” and that “it does not appear that simply the presence of ‘a unidirectional drift field’ in itself can achieve ‘drawing all minority carriers from said surface layer to said substrate.’” Ex. 1016, 289 (emphasis added). Patent Owner responded with the following argument: [A] unidirectional drift (electric) field necessarily affects all the present minority carriers in the same way - moving all minority carriers in the same direction because of the unidirectional drift due to the existence of the electric field. See “Physics and Technology of Semiconductor Devices,” A.S. Grove, pp. 224– 225, John Wiley and Sons, Inc., New York, 1st Edition 1967 (“This same electric field will then be of such direction as to aid the motion of injected holes. Thus the injected minority carriers will now move not only by diffusion but also by drift due to the existence of this electric field.”). Depending on the particular slope of the graded concentration of dopant, all minority carriers are either swept “down” (from the surface layer to the substrate) or “up” (from the substrate to the surface layer). See Applicant’s Figs. 5(b) and 5(c). Id. Patent Owner further argued that the Examiner’s finding appears to not consider that the graded dopant concentration itself creates a “built-in” electrical field that forces the movement of carriers into a particular direction, whereby the “direction” of the electrical field and the resulting direction of the carrier movement depends solely on the slope of the graded concentration of dopant. With regard to the existence of a “built-in” electric field created by a graded dopant density, . . . this inherent “built-in” unidirectional electric field is the additional parameter for ensuring that all minority carriers are being moved in one direction and which parameter the Office Action deemed to be missing from the disclosure. Id. at 289–90 (emphases added). Also, “without conceding its position on this issue,” Patent Owner amended claims to eliminate reference to “all carriers” and instead, refer to “carriers.” 13 Id. at 290. 4. Analysis of Claim 1 At this stage of the proceeding, we determine that Patent Owner’s statements made during prosecution of the ’195 patent contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support a preliminary finding that a graded dopant concentration is enough to teach 13 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1016, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. aiding carrier movement in a particular direction. Patent Owner does not dispute that Kawagoe has a graded dopant concentration in the active region at this stage of the proceeding. See generally Prelim. Resp. Patent Owner also does not dispute that Kawagoe’s transistor has carriers in the active region or that the graded dopant concentration of Kawagoe is lowered from the surface to the bottom substrate (Ex. 1007, Fig. 17). See generally Prelim. Resp. At this stage of the proceeding, Petitioner has the better position.” slip op. at 18
§ 103 obviousnessDiscretionary denialPatents in suitUS 11,121,222 - PTAB · Sep 27, 2024 · IPR2024-00672 · APJ Julia Heaney · IPR · Institution
The Board instituted review of claims 1–18 on all asserted grounds and granted Texas Instruments’ motion to join IPR2023-01243 in an understudy role.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this stage of the proceeding, we determine that the arguments and evidence of record favor Petitioner. Both parties agree that a downward-sloping gradient, as disclosed in Kawagoe, will create an electrical field with a force in a direction toward the substrate. See generally Prelim. Resp.; Ex. 1007, 16:7–9. Patent Owner does not meaningfully dispute that Kawagoe has a graded dopant concentration in an active region. See generally Prelim. Resp. Further, Patent Owner contradictorily stated during prosecution of the ’195 patent that a graded dopant concentration itself creates “a built-in electrical field that forces the movement of carriers in a particular direction” (Ex. 1016, 289–290) and is “the additional parameter for ensuring that all minority carriers are being moved in one direction” (id. at 290). In light of this evidentiary record, which at most presents a material issue of fact for resolution at trial, we determine Petitioner establishes a reasonable likelihood of prevailing in its challenge of claim 1. We decline to further discuss the parties’ arguments or resolve any disputed issues as to challenges based on Kawagoe on this preliminary record, because the trial in the 1243 IPR is the better proceeding in which to do so. Specifically, as compared to the preliminary phase of this case, the instituted trial in the 1243 IPR affords the parties better opportunity to brief, argue, and develop evidence in support of their positions. Thus, for the same reasons stated in our Decision on Institution in the 1243 IPR, we determine the Petition here warrants institution.” slip op. at 16
- Obviousness (§103) › Motivation to combine / reasonable expectation of successInstituted
“deficient because Kawagoe’s disclosure of graded dopant concentration teaches impeding carrier movement rather than aiding it, as required by claim element 1.5. Prelim. Resp. 13–14. Patent Owner relies on Kawagoe’s disclosure that the concentration gradient prevents electrons from entering the p-well. Id. at 14 (citing Ex. 1007, 16:7–11). Patent Owner further argues Kawagoe’s carriers are not in the active regions, as required by claim element 1.5. Id. at 14–16 (citing Ex. 1003 ¶ 91, n.5). At this stage of the proceeding, we determine that the arguments and evidence of record favor Petitioner. Both parties agree that a downward-sloping gradient, as disclosed in Kawagoe, will create an electrical field with a force in a direction toward the substrate. See generally Prelim. Resp.; Ex. 1007, 16:7–9. Patent Owner does not meaningfully dispute that Kawagoe has a graded dopant concentration in an active region. See generally Prelim. Resp. Further, Patent Owner contradictorily stated during prosecution of the ’195 patent that a graded dopant concentration itself creates “a built-in electrical field that forces the movement of carriers in a particular direction” (Ex. 1016, 289–290) and is “the additional parameter for ensuring that all minority carriers are being moved in one direction” (id. at 290). In light of this evidentiary record, which at most presents a material issue of fact for resolution at trial, we determine Petitioner establishes a reasonable likelihood of prevailing in its challenge of claim 1.” slip op. at 15
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“II. TIMELINESS OF PETITION UNDER 35 U.S.C. § 315(B) Pursuant to 35 U.S.C. § 315(b), “[a]n inter partes review may not be instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” 1 The Leahy-Smith America Invents Act (“AIA”), Pub. L. No. 112-29, 125 Stat. 284, 287–88 (2011), included revisions to 35 U.S.C. §§ 102 and 103 that became effective in 2013, after the effective filing date of the challenged claims. See Ex. 1001, codes (22), (60). Therefore, we apply the pre-AIA versions of 35 U.S.C. §§ 102 and 103(a). 2 US 6,043,114, issued March 28, 2000 (Ex. 1007, “Kawagoe”). Petitioner asserts that Kawagoe is prior art under 35 U.S.C. § 102(b). Pet. 4. 3 US 6,163,877, issued December 19, 2000 (Ex. 1014, “Gupta”). Petitioner asserts that Gupta is prior art under 35 U.S.C. § 102(b). Pet. 5. 4 US 2003/0183856 A1, published October 2, 2003 (Ex. 1006, “Wieczorek”). Petitioner asserts that Wieczorek is prior art under 35 U.S.C. §§ 102(a),(e). Pet. 4. 5 Stanley Wolf and Richard N. Tauber, Silicon Processing for the VLSI Era, Vols. 1–4, Lattice Press (2000) (Ex. 1008, “Wolf”). Petitioner asserts that Wolf was published and publicly available no later than 2002, and is prior art under 35 U.S.C. § 102(b). Pet. 5 (citing Exs. 1012, 1013, 1036). Exhibit 1008 was submitted in four parts (A–D) and includes selected portions of Wolf. We cite to Wolf using its original page numbers and omit the exhibit part designations. Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 18– 39. However, 35 U.S.C. § 315(b) also provides that the one-year time bar “shall not apply to a request for joinder under subsection (c).” See also 37 C.F.R. § 42.122(b). Because the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted proceeding (IPR2023-01243), which we grant as further discussed below, Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 8
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“Patent Owner’s first argument is not persuasive because it is based on speculation that Petitioner “is trying to block settlement with any of these defendants unless [Patent Owner] also settles with” Petitioner. Opp. Mot. Join. 5. As discussed below, we determine that Patent Owner will not be prejudiced unduly by the joinder. Moreover, we note that even in a situation where the petitioner and patent owner in the proceeding to be joined had settled (Code200 v. Bright Data Ltd., IPR2022-00861, Paper 17 at 5 (PTAB July 25, 2022) (vacated)), the Director nevertheless vacated a decision to deny a motion for joinder. Code200 v. Bright Data Ltd., IPR2022-00861, Paper 18 at 7 (Office of the Director of the USPTO Aug. 23, 2022) (precedential); see also eBay, Inc. v. Lexos Media IP, LLC, IPR2024-00336, Paper 11 at 13–15 (PTAB Feb. 23, 2024). Patent Owner’s second argument is moot because Patent Owner’s Request for Director Review has been denied. 1243 IPR, Paper 43 (PTAB Apr. 24, 2024). Based on the facts and circumstances discussed above, we determine Petitioner has established good cause for joining the 1243 IPR. Specifically, we find that joining Petitioner to the 1243 IPR is unlikely to require any delay or modification to the scheduling order already in place for the 1243 IPR. We also determine that Patent Owner will not be prejudiced unduly by the joinder of this proceeding. Thus, we determine that granting the Motion for Joinder would help “secure the just, speedy, and inexpensive resolution” of these proceedings. See 37 C.F.R. § 42.1(b). For the above reasons, we grant Petitioner’s Motion for Joinder and join Petitioner as a party to the 1243 IPR.” slip op. at 19
§ 103 obviousnessPatents in suitUS 10,510,842 - Apotex Inc. v. Novo Nordisk A/SInstitutedPTAB · Sep 11, 2024 · IPR2024-00631 · APJ Susan L C Mitchell · IPR · Institution
The Board instituted review of claims 1–10 on all petitioned grounds, finding a reasonable likelihood of unpatentability, and granted Apotex’s motion to join the Mylan IPR.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“discretionary. See Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1367 (Fed. Cir. 2016); see also 35 U.S.C. § 314(a). In Apple Inc. v. Fintiv, Inc., IPR2020-00019, Paper 11 (PTAB Mar. 20, 2020) (precedential), the Board set forth six non-exclusive factors for determining “whether efficiency, fairness, and the merits support the exercise of authority to deny institution in view of an earlier trial date in the parallel proceeding.” Id. at 6. These factors are as follows: 1. whether the court granted a stay or evidence exists that one may be granted if a proceeding is instituted; 2. proximity of the court’s trial date to the Board’s projected statutory deadline for a final written decision; 3. investment in the parallel proceeding by the court and the parties; 4. overlap between issues raised in the petition and in the parallel proceeding; 5. whether the petitioner and the defendant in the parallel proceeding are the same party; and 6. other circumstances that impact the Board’s exercise of discretion, including the merits. Id. at 5–6. In evaluating these factors, we take a holistic view of whether efficiency and integrity of the system are best served by denying or instituting review. Id. at 6. The Director has also issued interim guidance to the Board on applying the factors. See Katherine K. Vidal, Interim Procedure for Discretionary Denials in AIA Post-Grant Proceedings with” slip op. at 6
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review under 35 U.S.C. § 314 and 37 C.F.R. § 42.4(a). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a).” slip op. at 2
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“Under 37 C.F.R. § 42.5(b), we “may waive or suspend a requirement of [part 42 of the Board’s rules] and may place conditions on the waiver or suspension.” Here, we agree with Petitioner that it has shown sufficient reason for us to waive the one-month from institution joinder motion deadline. See 37 C.F.R. § 42.122(b). Petitioner waited until it had a sufficient business reason to file this Petition, and subsequently promptly filed its Petition and Motion for Joinder. Most critically, Petitioner raises no new unpatentability grounds, the trial schedule for the Mylan IPR need not be adjusted, and Petitioner agrees to serve in a silent understudy role. We determine that joinder with the Mylan IPR is appropriate under the circumstances. Accordingly, we grant Petitioner’s Motion for Joinder.” slip op. at 13
Discretionary denialPatents in suitUS 10,335,462
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.