- Syngenta Crop Protection AG v. Inflexion Point Technologies, LLCInstitution deniedPTAB · Dec 1, 2025 · PGR2025-00045 · APJ Debra L Dennett · PGR · Institution
The Board denied institution because Petitioner did not show it was more likely than not that any challenged claim was unpatentable under the asserted grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“We have authority to determine whether to institute a post-grant review under 35 U.S.C. § 324. Institution of a post-grant review is authorized by statute only when “the information presented in the petition . . . would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). The burden is on Petitioner to show that the challenged patent is eligible for postgrant review. Mylan Pharms. Inc. v. Yeda Research & Dev. Co., PGR2016- 00010, Paper 9 at 10 (PTAB Aug. 15, 2016) (holding that the ultimate burden of persuasion remains with a petitioner to demonstrate that the challenged patent is eligible for post-grant review). Upon consideration of the Petition, Preliminary Response, and the cited evidence, we determine that Petitioner has not shown that it is more likely than not that any of the challenged claims are unpatentable. We thus determine to not institute a post-grant review of the ’027 patent based on the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“a Bachelor of Science degree in Agricultural or Mechanical Engineering with 2–4 years of practical, applied experience in the field of agricultural machinery, including systems integration and fluid handling and sprayer control systems, or equivalent experience. Prelim. Resp. 12 (citing Ex. 2001, ¶ 59). Patent Owner states that the differences in the asserted levels of ordinary skill should not change the outcome of the Petition. Id. For the purposes of this decision, we adopt Petitioner’s definition, which appears consistent with the level of skill shown in the prior art references of record and the ’027 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))). Our analysis, however, would not change were we to adopt Patent Owner’s definition.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Lexicography (patentee as own lexicographer)Term construed board ownDecided for patent owner
“Patent Owner contends that claim construction is necessary for the “seed-applied substance” term because Petitioner allegedly ignores the teaching of the specification in evaluating the term. Prelim. Resp. 12. Patent Owner points to the specification, which defines a “seed-applied substance” as “includ[ing] any composition applied to seeds prior to the seeds being planted (e.g., when the seed comes in contact with the soil in a field).” Id. at 13 (quoting Ex. 1001, 7:45-48). Patent Owner contends that the term means “a substance that is applied directly to the seed before the seed comes into contact with the soil in a field.” Id. (citing Ex. 2001, ¶ 55). According to Patent Owner, Petitioner erroneously uses a definition that “allows the ‘seedapplied substance’ to be applied to the seed (and soil) as the seed lay planted in the soil.’” Id. For the purpose of addressing Petitioner’s grounds, we use the definition of “seed-applied substance” provided in the ’027 patent, i.e., “any composition applied to seeds prior to the seeds being planted (e.g., when the seed comes in contact with the soil in a field).” Vitronics Corp. v. Conceptronic, Inc., 90 F.3d 1576, 1582 (Fed. Cir. 1996) (“[A] patentee may choose to be his own lexicographer and use terms in a manner other than their ordinary meaning, as long as the special definition of the term is clearly stated in the patent specification or file history.”).” slip op. at 7
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“3. Analysis Our analysis of whether Wagers discloses the limitation “individually applying the desired application amount of the selected type of the seed-applied substance to each seed as it is being delivered to the soil” is dispositive of Petitioner’s challenge to claim 1 as anticipated.” slip op. at 10
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites GrahamPatents in suitUS 12,102,027 - PTAB · Nov 19, 2025 · IPR2025-00948 · APJ Michael J Fitzpatrick · IPR · Institution
The Board instituted IPR on all claims 1–23, finding a reasonable likelihood that claim 11 would have been obvious over Herrstedt, Bös, and Herrington.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review requires that “the information presented in the petition filed under section 311 and any response filed under section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Determining whether to institute has been delegated to the Board. See 37 C.F.R. § 42.4(a) (“The Board institutes the trial on behalf of the Director.”). Upon consideration of the Petition and the Preliminary Response, and for the reasons explained below, we determine that there is a reasonable likelihood that Petitioner would prevail with respect to at least one claim. Accordingly, we grant the Petition.” slip op. at 2
- Skill levelOther
“At this stage, we need not resolve the parties’ dispute with regard to the requisite level of skill in the art, as our analysis would be the same under either party’s definition of a POSA. We note, however, that Petitioner’s definition seems to be overly broad insofar as it would only require the POSA to be skilled in one of several broad fields, including “statistics” and “medical policy and decision making,” that do not directly relate to the claimed subject matter. At the same time, we do not agree with Patent Owner that the POSA needs specific clinical experience in the field of oncology. The claimed subject matter relates to the treatment of a side-effect associated with cancer therapy (CINV), and not the cancer itself. We also recognize that the prior art and the ’357 patent itself reflect the level of skill in the art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“[T]he absence of specific findings on the level of skill in the art does not give rise to reversible error where the prior art itself reflects an appropriate level and a need for testimony is not shown.”). We further find, based on the present record, that both parties’ experts are qualified to testify from the perspective of a POSA in this proceeding. See Ex. 1009 ¶¶ 1–7 (Dr. Peroutka’s qualifications); Ex. 2069 ¶¶ 8–15 (Dr. Navari’s qualifications); Kyocera Senco Indus. Tools Inc. v. Int’l Trade Comm'n, 22 F.4th 1369, 1377 (Fed. Cir. 2022) (“[T]o be qualified to offer expert testimony on issues from the vantage point of an ordinarily skilled artisan in a patent case, an expert must at a minimum possess ordinary skill in the art.”). Even if some specific experience with regard to the treatment” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“First, Petitioner proposes that “therapeutically effective amount” (recited in both independent claims) means: an amount sufficient to elicit the desired biological response. Pet. 9 (citing Ex. 1003, 8:13–15). The cited portion of the Specification clearly supports such a construction. Ex. 1003, 8:13–15 (“As used herein, ‘therapeutically effective amount’ refers to an amount sufficient to elicit the desired biological response.”). We adopt it. Second, Petitioner proposes that “the word if in claims 1 and 11 appears from context to mean ‘is’.” Id. (citing Ex parte Tanksley, 26 USPQ2d 1384, 1387 (BPAI 1991)). Both of the independent claims conclude with the following clause: “and said single dose of netupitant or pharmaceutically acceptable salt thereof if effective to treat said nausea and vomiting for said five consecutive days.” (Emphasis added). The word “if” cannot mean “is,” as Petitioner literally proposes. Pet. 9. However, we understand Petitioner to be arguing implicitly that (1) “if” was a typographical or other error in the independent claims and (2) “is” was intended in its place. Such is a reasonable position in the context of the challenged claims. On the instant record, with no argument to the contrary by Patent Owner, we construe claims 1 and 11 such that the word “is” was intended in lieu of the word “if” in the last clause of each claim. Cf. Canatex Completion Sols., Inc., v. Wellmatics, LLC, No. 2024-1466, 2025 WL 3153362, at *5 (Fed. Cir. Nov. 12, 2025) (“[W]e have ruled that a district court may correct obvious minor typographical and clerical errors in patents.”) (cleaned up; citations omitted)).” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Third, Petitioner proposes a construction for “minimum effective dose of dexamethasone.” Pet. 10. That term appears nowhere in the challenged claims. Accordingly, we do not interpret the term.” slip op. at 11
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 9,943,515 - PTAB · Nov 19, 2025 · IPR2025-00945 · APJ Sheridan K Snedden · IPR · Institution
The Board instituted IPR on claims 1–25 after finding a reasonable likelihood that claim 19 would have been obvious over MASCC and Hoffmann.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have the authority to determine whether to institute an inter partes review. 35 U.S.C. § 314; 37 C.F.R. §42.4(a). We may not institute an inter partes review “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Upon consideration of the Petition and the Preliminary Response, and for the reasons explained below, we determine that there is a reasonable likelihood that Petitioner would prevail with respect to at least one claim. Accordingly, we grant the Petition” slip op. at 2
- PTAB / AIA Trials › Real party in interest / privityOther
“Each party identifies itself as the sole real party in interest (RPI). Pet. 69; Paper 4, at 1. There is no dispute over RPIs in this proceeding. B. Related Matters” slip op. at 2
- Skill levelOther
“At this stage, we need not resolve the parties’ dispute with regard to the requisite level of skill in the art, as our analysis would be the same under either party’s definition of a POSA. We note, however, that Petitioner’s definition seems to be overly broad insofar as it would only require the POSA to be skilled in one of several broad fields, including “statistics” and “medical policy and decision making,” that do not directly relate to the claimed subject matter. At the same time, we do not agree with Patent Owner that the POSA needs specific clinical experience in the field of oncology. The claimed subject matter relates to the treatment of a side-effect associated with cancer therapy (CINV), and not the cancer itself. We also recognize that the prior art and the ’826 patent itself reflect the level of skill in the art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“[T]he absence of specific findings on the level of skill in the art does not give rise to reversible error where the prior art itself reflects an appropriate level and a need for testimony is not shown.”). We further find, based on the present record, that both parties’ experts are qualified to testify from the perspective of a POSA in this proceeding. See Ex. 1009 ¶¶ 1–7 (Dr. Peroutka’s qualifications); Ex. 2067 ¶¶ 8–15 (Dr. Navari’s qualifications); Kyocera Senco Indus. Tools Inc. v. Int’l Trade Comm'n, 22 F.4th 1369, 1377 (Fed. Cir. 2022) (“[T]o be qualified to offer expert testimony on issues from the vantage point of an ordinarily skilled artisan in a patent case, an expert must at a minimum possess ordinary skill in the art.”). Even if some specific experience with regard to the treatment of CINV is required, Dr. Peroutka appears to have published in that field. See, e.g., Ex. 1020 at 10, (publication 16: article on “Combination antiemetics” in Cancer Treatment Reports); id. at 11 (publication 37: article on “Neurotransmitter receptor binding studies predict antiemetic efficacy and side effects” in Cancer Treatment Reports); id. at 13 (publication 51: article on “Chemotherapeutic agents do not interact with neurotransmitter receptors” in Cancer Chemotherapy and Pharmacology). B. Claim Construction” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed petitioner constructionNo construction neededOther
“First, Petitioner proposes that “therapeutically effective amount” (recited in both independent claims) means: an amount sufficient to elicit the desired biological response. Pet. 9 (citing Ex. 1001, 7:55–57). The cited portion of the Specification clearly supports such a construction. Ex. 1001, 7:55–57 (“As used herein, ‘therapeutically effective amount’ refers to an amount sufficient to elicit the desired biological response.”). We adopt it. Second, Petitioner proposes a construction for “minimum effective dose of dexamethasone.” Pet. 9. That term appears nowhere in the challenged claims. Accordingly, we do not interpret the term. Finally, Petitioner proposes construing the following language appearing in claim 1: “administering to said patient on day one netupitant or a pharmaceutically acceptable salt thereof, in a therapeutically effective amount which enters the systemic circulation, crosses the blood brain barrier and occupies at least 70% of neurokinin-1 (NK1) receptors in the striatum seventy-two hours after said administration.” Pet. 9–10 (emphasis added). Specifically, Petitioner proposes that the italicized language, as introduced by the word “which,” denotes inherent properties (and not further limitations) resulting from the administering of the drug in a therapeutically effective amount. Id. On the instant record, with no argument to the contrary by Patent Owner, we agree with Petitioner. However, we do not explicitly address claim 1 below. Instead, the focus of our institution analysis is independent claim 19. We do not perceive a need to construe expressly any other claim term of the ’826 patent for purposes of determining whether to institute trial. C. Summary of Asserted References” slip op. at 13
Claim construction§ 103 obviousnesscites GrahamPatents in suitUS 8,623,826 - PTAB · Nov 19, 2025 · IPR2025-00947 · APJ Christopher G Paulraj · IPR · Institution
The Board instituted review of all challenged claims and grounds, finding a reasonable likelihood that claim 1 would have been obvious over Herrstedt and Bös.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denialDenied
“II. DISCUSSION A. Discretionary Denial Patent Owner filed a request for discretionary denial of institution. Paper 8. Petitioner opposed. Paper 9. The Acting Director denied the discretionary denial request. Paper 12 (September 19, 2025). Accordingly, we proceed with our analysis of the merits of Petitioner’s patentability” slip op. at 8
- Skill levelOther
“At this stage, we need not resolve the parties’ dispute with regard to the requisite level of skill in the art, as our analysis would be the same under either party’s definition of a POSA. We note, however, that Petitioner’s definition seems to be overly broad insofar as it would only require the POSA to be skilled in one of several broad fields, including “statistics” and “medical policy and decision making,” that do not directly relate to the claimed subject matter. At the same time, we do not agree with Patent Owner that the POSA needs specific clinical experience in the field of oncology. The claimed subject matter relates to the treatment of a side-effect associated with cancer therapy (CINV), and not the cancer itself. We also recognize that the prior art and the ’357 patent itself reflect the level of skill in the art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“[T]he absence of specific findings on the level of skill in the art does not give rise to reversible error where the prior art itself reflects an appropriate level and a need for testimony is not shown.”).” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” 37 C.F.R. § 42.100(b) (2019). This standard requires that we construe claims “in accordance with the ordinary and customary meaning of such claim[s] as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id. Petitioner contends no terms need to be construed to find the claims unpatentable in view of the prior art. Pet. 9. Patent Owner also contends that no claim construction is necessary to resolve the parties’ disputes. Prelim Resp. 14. At this stage, we do not perceive a need to construe expressly any claim terms of the ’357 patent for purposes of determining whether to institute trial.” slip op. at 11
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“Herrstedt taught the use of aprepitant as an NK1 receptor antagonist that could be combined with dexamethasone and palonosetron to treat emesis. Nonetheless, based on Bös’s identification of netupitant (compound Ib) as a “potent and selective” NK1 antagonist with “valuable therapeutic properties,” the present record supports Petitioner’s argument that the POSA would have been motivated to replace aprepitant with netupitant in the combination therapy. Ex, 1014, 14:31–34. Bös indicates that the compounds disclosed therein have utility in the treatment of emesis, and that neutpitant in particular “is a potent antagonist of NK1 induced behaviors in Gerbil and blocks emesis in Ferrets and suncus murinus with similar potency.” Id. at 19:26–30. Bös further indicates that netupitant has a high affinity for the NK1 receptor and a prolonged half-life. Id. at 18:44–48, 19:31–38. In view of these properties, we find a POSA would have had good reason to consider netupitant as a potential replacement for aprepitant in the treatment of CINV.” slip op. at 28
Claim construction§ 103 obviousnessDiscretionary denialcites KSRPatents in suitUS 9,186,357 - PTAB · Nov 19, 2025 · IPR2025-00946 · APJ Christopher G Paulraj · IPR · Institution
The Board instituted inter partes review on all challenged claims and grounds after finding a reasonable likelihood that claims 2 and 4 would have been obvious over Herrstedt and Bös.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. 35 U.S.C. § 314; 37 C.F.R. §42.4(a). We may not institute an inter partes review “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a).” slip op. at 2
- PTAB / AIA Trials › Discretionary denialNot reached
“II. DISCUSSION A. Discretionary Denial Patent Owner filed a request for discretionary denial of institution. Paper 8. Petitioner opposed. Paper 9. The Acting Director denied the discretionary denial request. Paper 12 (September 19, 2025). Accordingly, we proceed with our analysis of the merits of Petitioner’s patentability challenges and do not address the discretionary denial arguments presented by the parties.” slip op. at 8
- Skill levelOther
“At this stage, we need not resolve the parties’ dispute with regard to the requisite level of skill in the art, as our analysis would be the same under either party’s definition of a POSA. We note, however, that Petitioner’s definition seems to be overly broad insofar as it would only require the POSA to be skilled in one of several broad fields, including “statistics” and “medical policy and decision making,” that do not directly relate to the Owner that the POSA needs specific clinical experience in the field of oncology. The claimed subject matter relates to the treatment of a side-effect associated with cancer therapy (CINV), and not the cancer itself. We also recognize that the prior art and the ’357 patent itself reflect the level of skill in the art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“[T]he absence of specific findings on the level of skill in the art does not give rise to reversible error where the prior art itself reflects an appropriate level and a need for testimony is not shown.”). We further find, based on the present record, that both parties’ experts are qualified to testify from the perspective of a POSA in this proceeding. See Ex. 1009 ¶¶ 1–7 (Dr. Peroutka’s qualifications); Ex. 2068 ¶¶ 8–15 (Dr. Navari’s qualifications); Kyocera Senco Indus. Tools Inc. v. Int’l Trade Comm'n, 22 F.4th 1369, 1377 (Fed. Cir. 2022) (“[T]o be qualified to offer expert testimony on issues from the vantage point of an ordinarily skilled artisan in a patent case, an expert must at a minimum possess ordinary skill in the art.”). Even if some specific experience with regard to the treatment of CINV is required, Dr. Peroutka appears to have published in that field. See, e.g., Ex. 1020 at 10, (publication 16: article on “Combination antiemetics” in Cancer Treatment Reports); id. at 11 (publication 37: article on “Neurotransmitter receptor binding studies predict antiemetic efficacy and side effects” in Cancer Treatment Reports); id. at 13 (publication 51: article on “Chemotherapeutic agents do not interact with neurotransmitter receptors” in Cancer Chemotherapy and Pharmacology).” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“that could be combined with dexamethasone and/or palonosetron to treat emesis. Nonetheless, based on Bös’s identification of netupitant (compound Ib) as a “potent and selective” NK1 antagonist with “valuable therapeutic properties,” the present record supports Petitioner’s argument that the POSA would have been motivated to replace aprepitant with netupitant in the compounds disclosed therein have utility in the treatment of emesis, and that neutpitant in particular “is a potent antagonist of NK1 induced behaviors in Gerbil and blocks emesis in Ferrets and suncus murinus with similar potency.” Id. at 19:26–30. Bös further indicates that netupitant has a high affinity for the NK1 receptor and a prolonged half-life. Id. at 18:44–48, 19:31–38. In view of these properties, we find a POSA would have had good reason to consider netupitant as a potential replacement for aprepitant in the treatment of CINV. Bös also teaches that the daily dosage can be adjusted between 10 to 1000 mg per person, or above that upper limit when necessary, and that the effective amount can be fitted to the individual requirements in each particular case. Id. at 42:5–11. As with palonosetron, given the significant half-life of netupitant, and its administration via the circulatory system, we find that a POSA would also have been motivated to adjust the dose of netupitant to an amount that induces “blood levels” effective to treat CINV.” slip op. at 28
§ 103 obviousnessDiscretionary denialcites KSRPatents in suitUS 9,186,357 - PTAB · Aug 5, 2025 · IPR2025-00249 · APJ Christopher G Paulraj · IPR · Institution
The Board instituted inter partes review of claims 1–8 on all grounds in the Petition, finding a reasonable likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. 35 U.S.C. § 314; 37 C.F.R. §42.4(a). We may not institute an inter partes review “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). In this decision, we address the merits of the issues raised by the parties regarding claims 1–8 of the ’227 patent. For the reasons provided below, we determine Petitioner has satisfied the threshold requirement set forth in 35 U.S.C. § 314(a). Because Petitioner has demonstrated a reasonable likelihood that at least one challenged claim of the ’227 patent is unpatentable, we institute an inter partes review of all challenged claims based on the grounds set forth in the Petition.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“II. ANALYSIS A. Discretionary Denial under 35 U.S.C. § 325(d) Patent Owner filed a request for discretionary denial under 35 U.S.C. § 325(d). Paper 9. Petitioner opposed. Paper 9. The Acting Director denied the discretionary denial request. Paper 12 (June 26, 2025). Accordingly, we proceed with our analysis of the merits of Petitioner’s patentability challenges and do not address the discretionary denial arguments presented by the parties.” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“(“POSITA”) relevant to the ’227 patent “would be a Ph.D. student with a minimum of two years of experience in their faculty advisor’s laboratory” and would have an understanding of “electrospinning fibers, including for tissue engineering, tissue engineering techniques, and using/performing FFT analysis.” Pet. 20–21 (citing Ex. 1003 §II.C). Patent Owner does not dispute this skill level. Prelim. Resp. 10. At this stage of the proceeding and for purposes of our analysis in this Decision, we adopt Petitioner’s definition as that definition is consistent with the level of skill in the art reflected by the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Neither Petitioner nor Patent Owner proposes a construction for any claim terms. Pet. 19; Prelim. Resp. 10. We also do not perceive a need to construe any claim terms of the ’227 patent for purposes of determining whether to institute trial. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 295, 803 (Fed. Cir. 1999) (holding that “only those terms need to be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (applying Vivid Techs. in the context of an inter partes review).” slip op. at 8
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialPatents in suitUS 11,318,227 - PTAB · Aug 5, 2025 · IPR2025-00248 · APJ Christopher G Paulraj · IPR · Institution
The Board instituted IPR on claims 1–12 and all petition grounds, finding a reasonable likelihood that at least one claim is unpatentable, including based on Huang2’s inherent FFT symmetry.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. 35 U.S.C. § 314; 37 C.F.R. §42.4(a). We may not institute an inter partes review “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a).” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“II. ANALYSIS F. Discretionary Denial under 35 U.S.C. § 325(d) Patent Owner filed a request for discretionary denial under 35 U.S.C. § 325(d). Paper 8. Petitioner opposed. Paper 10. The Acting Director denied the discretionary denial request. Paper 13 (June 26, 2025). Accordingly, we proceed with our analysis of the merits of Petitioner’s 2 The Leahy-Smith America Invents Act, Pub. L. No. 112-29, 125 Stat. 284 (2011) (“AIA”), amended 35 U.S.C. §§ 102 and 103. Because the’223 patent claims priority to a provisional application filed before the effective date of the applicable AIA amendments (March 16, 2013), we refer to the pre-AIA versions of the statutes throughout this Decision. 3 Huang et al., The involvement of integrin β1 signaling in the migration and myofibroblastic differentiation of skin fibroblasts on anisotropic collagen-containing nanofibers, 33 Biomaterials 1791-1800 (Feb. 2012) (“Huang2”) (Ex. 1005). A different reference by Huang, identified as “Huang1” in the Petition, was considered by the Examiner during prosecution. Pet. 15–17; Ex. 1008. 4 Kumbar et al., Electrospun nanofiber scaffolds: engineering soft tissues, Biomed. Mater. 3 (2008) (“Kumbar”) (Ex. 1006). 5 Lee et al., U.S. Patent Application No. US 2010/0331980 A1, Pub. Date December 1, 2011 (“Lee”) (Ex. 1011). patentability challenges and do not address the discretionary denial arguments presented by the parties.” slip op. at 6
- Skill levelSkill level petitioner adoptedDecided for petitioner
“(“POSITA”) relevant to the ’223 patent “would be a Ph.D. student with a minimum of two years of experience in their faculty advisor’s laboratory” and would have an understanding of “electrospinning fibers, including for tissue engineering, tissue engineering techniques, and using/performing FFT analysis.” Pet. 18–19 (citing Ex. 1003 §II.C). Patent Owner does not dispute this skill level. Prelim. Resp. 10. At this stage of the proceeding and for purposes of our analysis in this Decision, we adopt Petitioner’s definition as that definition is consistent with the level of skill in the art reflected by the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 7
- Expert testimonyPetitioner expert creditedDecided for petitioner
“Simpson’s testimony at this preliminary stage. Dr. Simpson extensively discusses the FFT methodology used in the Ayres papers (for which he is the senior author), and we find these papers provide sufficient underlying facts, data, and technical reasoning to support his opinion regarding the inherent symmetry of the FFT output image. Ex. 1003 ¶¶ 38–51. Contrary to Patent Owner’s argument, the fact that the Ayres 2008 paper uses the term “typically” does not undermine Dr. Simpson’s conclusion. Ex. 1010, 609. In context, it is clear that the refenced statement only speaks to how the data is typically reported rather than whether the result itself would only be typical. Indeed, the same sentence goes on to explain that the reason why the data is typically reported only for 0–180° is because “the frequency plot is symmetric.” Id. We are also not persuaded by Patent Owner’s argument that Ayres 2008 undermines Dr. Simpson’s testimony regarding “typical[] practice” because it presents FFT analysis results plotted to 360°. Rather than undermining his testimony, the plot shown in Figure 1F of Ayres 2008 further confirms the symmetrical nature of the FFT results for aligned fibers. Moreover, the fact that there are minor variations at the tips of the two peaks shown in Figure 1F does not undermine or contradict the conclusion that the major peaks for aligned fibers will necessarily be about 180° apart. The challenged claims do not require a perfect repetition or identity of the major peaks in the FFT output plot. Additionally, Dr. Simpson’s own reproduced FFT analysis of the SEM image in Huang2’s Figure 1B using the methodologies described in the Ayres 2006 and Ayres 2008 papers, which shows major peaks at 90° and 270°, further confirms that the claimed FFT analysis result is an inherent feature of Huang2’s anisotropic fibers. Ex. 1003 ¶¶ 110–111. We do not find that Dr. Simpson’s testing violates 37 C.F.R. § 42.65(b), insofar as Dr. Simpson’s declaration sufficiently explains: (1) “why the test or data is being used”; (2) “how the test was performed and the data was generated”; (3) “how the data is used to determine a value”; (4) “how the test is regarded in the relevant art”; and (5) “any other information necessary for the Board to evaluate the test and data.” See Ex. 1003 ¶¶ 38–51 (explaining FFT methodology used by Dr. Simpson). Although Dr. Simpson’s declaration does not appear to spell out all the details of the particular protocol or the version of the ImageJ software he used, we find his explanation that he used the methodology described in Huang2 (which references the Ayres 2006 paper) and the ’223 patent (which references the Ayres 2008 paper) sufficient for purposes of institution. Even assuming there may be some differences in the specific FFT methodology used in the two Ayres papers, we do not find anything at this stage to indicate that any such differences would matter with regard to the claim requirement that the major peaks are about 180° apart, especially given that both papers confirm the symmetrical nature of the FFT output plot. Furthermore, while Patent Owner argues that Dr. Simpson does not account for certain aspects of the FFT analysis discussed in the Ayres 2006 and Ayres 2008 papers, there is no evidence at this stage that Dr. Simpson did not follow the protocol described in his own papers, or that he failed to account for any specific aspects that could make a meaningful difference with regard to the FFT analysis result.” slip op. at 25
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialPatents in suitUS 10,137,223 - Fusion Orthopedics, LLC v. Extremity Medical, LLCSome claims unpatentablePTAB · Nov 4, 2024 · IPR2023-00894 · APJ Robert A Pollock · IPR · Final written decision
Claims 1–10 and 12–15 are unpatentable; claim 11 was not shown unpatentable. Substitute claims 16–25 and 27–30 are unpatentable over Mazur; claim 26 was not reached.
RulingsFinal written decision- BurdenMixed
“It is of the utmost importance that petitioners in the IPR proceedings adhere to the requirement that the initial petition identify ‘with particularity’ the ‘evidence that supports the grounds for the challenge to each claim.’” Intelligent Bio-Sys., Inc. v. Illumina Cambridge Ltd., 821 F.3d 1359, 1369 (Fed. Cir. 2016) (quoting 35 U.S.C. § 312(a)(3)). Here, however, not until its Reply does Petitioner belatedly suggest that Ferrante’s disclosure of bone screws with self-tapping ends equally meets the limitation of claim 10 (with respect to the first member) as with claim 11 (with respect to the second member), and that both claims are obvious in light of “evidence” from Ferrante “that it was well known to equip bone screws with self-tapping ends.” Reply 26–27. We do not discern these arguments in the Petition, and consider them waived. See Netflix, Inc. v. DivX, LLC, 84 F.4th 1371,1377 (Fed. Cir. 2023) (“While the Board should not take an overly mechanistic view of a petition and decline to address an argument because the petitioner did not present it with ideal vigor and clarity, the Board should also not have to decode a petition to locate additional arguments beyond the ones clearly made.”). In sum, Petitioner’s error in failing to first address limitations of claim 10 in the Petition specific to the Cognet/Ferrante combination indicates a failure to meet the particularity requirements for what must be in the petition and cannot be left to be filled in on reply. See 35 U.S.C. § 312(a)(3); 37 C.F.R. §§ 42.22(a)(2) (requiring, among other things, “a detailed explanation of the significance of the evidence”), 42.104(b)(4)–(5) (requiring that petition “specify where each element of the claim is found in the prior art patents or printed publication relied upon” and, regarding submitted evidence, state “the relevance of the evidence to the challenge raised, including identifying specific portions of the evidence that support the challenge”). Microsoft, 2022 WL 989403, at *6. Accordingly, Petitioner has not shown persuasively that claim 11 would have been obvious in light of Cognet and Ferrante for the reasons set forth in the Petition. slip op. at 41
- Expert testimonyPetitioner expert creditedDecided for petitioner
“We also find persuasive Mr. Dominguez’s explanation that one of ordinary skill in the art would have understood “bore” as including stepped diameter holes, sometimes described as a bore having a counterbore. See generally Ex. 1018 ¶¶ 4–29; Reply 3–10. Three of Mr. Dominguez’s illustrative examples are reproduced in the annotated figures below. The above figures show Mr. Dominguez’s annotated illustrations from the Jackson (Ex. 1019, Fig. 3), Brånemark (Ex. 1021, Fig. 4), and Ray (Ex. 1025, Fig. 1) references as discussed at paragraphs 10, 12, and 13, respectively, of Mr. Dominguez’s Second Declaration. With reference to the above figures, Mr. Dominguez testifies that “Jackson describes a bone repair set screw in which ‘[t]he bore 27 comprises a first bore section 31, a second bore section 32,’ etc. delineated by shoulders 41, 42, etc. (Ex. 1019, 5:24– 43)” (Ex. 1018 ¶ 10); “Brånemark describes an osseous implantation device having body 1ʺ with first and second holding portions 21ʺ, 31ʺ and ‘an inner through bore with a first portion 4ʺ in the first holding portion and a second portion 5ʺ in the second holding portion.’” Ex. 1021, 4:44–46” (id. ¶ 12); and Ray discloses surgical calipers including “handle 12 having ‘stepped cylindrical bore 14,’” wherein “[c]ollar 20 of a shaft inserted in the bore ‘rests against a step of the bore 14’ (2:14–15)” (id. ¶ 13). Patent Owner responds that Mr. Dominguez’s examples “that allegedly show a single bore encompassing two or more stepped-diameter holes or a counterbore . . . . are specific to these references and divorced from the disclosures of the ’166 patent.” Sur-Reply 7. Insofar as the ’166 patent makes no mention of the term “bore” outside the claims, and Mr. Dominguez’s examples are all taken from the field of orthopedic surgery, we do not find this argument persuasive. Patent Owner further appears to contend that exemplary references to a “cylindrical stepped down bore” or a “stepped cylindrical bore” are too specific to be within the scope of the term “bore.” Sur-Reply 7–8. As these terms merely describe species within a larger genus, and Patent Owner presents no cogent reason to exclude them, we do not find this argument availing. Relatedly, we are also not persuaded by Patent Owner’s argument that “the prior art treats a ‘bore’ as an element that is distinct from a ‘counterbore.’” Id. at 8. Rather, we credit Mr. Dominguez’s testimony that “[a] counterbore is not a structure unto itself, a counterbore is part of a larger structure” as exemplified by numerous examples including Laps (Ex. 1028 ¶ 33 (sensor assembly wherein “bore 16 includes a counterbore 18”)); Martinez (Ex. 1029, 3:61 (surgical cutting instrument wherein “bore 56 has a counterbore 64”)); Zang (Ex. 1030, 2:49 (bone anchor having a “bore [that] includes a counterbore”)); Ledet (Ex. 1022, 29:3–5 (vertebral fixation plate having “through holes . . . . countersunk, or counterbored to accommodate the head of a bone screw”)); Seo (Ex. 1031, 3:45 (chair leg employing “counterbored bore 23”)); and Exner (Ex. 1032, 2:16 (extrusion press including “counterbored axial bore 6”)). Ex. 1018 ¶¶ 17–23. That a reference may refer to a figure as showing “bore 103” with “counterbore 105 . . . formed on one end” does not indicate that they are distinct structures as Patent Owner contends, but merely that the focus of each term is directed to the entire bore or to a particular aspect of the bore, i.e., its counterbore. See” slip op. at 22
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner subsequently proposed an alternative definition, as a person having “[a] Bachelor’s Degree in biomedical and/or mechanical engineering or similar training and . . . at least three years of experience with implant devices used for internal fixation of bones.” POR 5 (citing Ex. 2012 ¶¶ 32–33). According to Patent Owner, “[t]his hypothetical person would be capable of performing various design tasks and would understand the basic mechanical features and operation of orthopaedic implant devices [and] have an appreciation for orthopaedic fusion techniques and the medical issues and concerns faced by a doctor/surgeon charged when performing operations to implant orthopaedic devices.” Id. Despite some differences in wording, Patent Owner asserts (and Petitioner does not contest) that any “distinction between the parties’ proposed definitions of a POSITA does not affect the arguments set forth herein.” Id. (citing Ex. 2012 ¶ 34). Consistent with this view, we find the parties’ constructions equally applicable in light of the prior art of record and the disclosure of the ’166 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“the prior art itself [may] reflect[] an appropriate level” as evidence of the ordinary level of skill in the art) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)). We adopt, for convenience, Petitioner’s definition, but our analysis does not change depending on which of the two articulations are applied here. H.” slip op. at 12
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“one of ordinary skill in the art would understand that “bore,” as used in the context of claims 1 and 12, encompasses a multi-diameter passage, and in particular, one having stepped longitudinal cross sections such as that shown in Cognet’s Figure 1. See generally DI 11–13. For the reasons that follow, we conclude that one of ordinary skill in the art would have understood “bore” as such. Relying on the testimony of Mr. Dominguez, Petitioner initially proposed a construction of “bore” as “a usually cylindrical hole made by or as if by the turning or twisting movement of a tool.” Pet. 16 (citing Ex. 1002 ¶ 58). Petitioner’s proposal relied on Mr. Dominguez’s testimony that “[a] bore is a cylindrical hole made by the spinning rotation of a twist drill cutting tool. It is typically made by removing material from a solid or hollow object, similar to a tunnel or orifice.” Ex. 1002 ¶ 58. Pointing to its annotation of Cognet’s Figure 1, above, Patent Owner argued that that the term “bore” excludes a tunnel made by “two adjacent bores.” See Prelim. Resp. 21–25. In view of the then-available evidence, we provisionally construed “bore” as a hole or passage made by or as if by the turning or twisting movement of a tool such that its interior walls have cylindrical lateral cross-sections, and which do not exclude holes or passages having tapered or stepped longitudinal cross-sections. DI 13.” slip op. at 19
Patent outcomesUS 11,298,166 mixedClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,298,166 - Symrise AG / Symrise Inc. v. Inolex Investment CorporationAll claims unpatentablePTAB · Nov 1, 2024 · IPR2023-01035 · APJ Tina E Hulse · IPR · Final written decision
The Board granted cancellation of claims 1–6, 8–10, and 22–28, and denied substitute claims 29–44 because Wright ’451 rendered them obvious.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art at the time of the invention (“POSA” or “POSITA”) would have had “a bachelor’s degree and two or more years of experience or a master’s degree in organic synthesis or chemical engineering, with education substituting for experience and vice versa.” Pet. 15 (citing Ex. 1002 ¶ 16). Patent Owner took no position on the level of ordinary skill in the art in its Preliminary Response. Prelim. Resp. 8. In our Institution Decision, we adopted Petitioner’s definition. Dec. Inst. 6–7. In its Motion to Amend, Patent Owner states that it accepts the Board’s definition for purposes of this proceeding. MTA 24. We, therefore, see no reason to disturb our definition of the level of ordinary skill in the art as it appears to be consistent with the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Although neither party expressly proposes a construction for the term “conversion,” the parties appear to differ in their interpretations of that term. Petitioner interprets “conversion” to mean the percent conversion of the 1- alcohol. See Pet. Opp. RMTA 6–7 (interpreting “conversion” as percentage of remaining 1-alcohol); Ex. 1040, 109:2–11. Patent Owner, on the other hand, interprets “conversion” to mean the total percentage of alkenes that have been produced. Ex. 2010 ¶ 123 (interpreting “conversion” as percentage of total alkenes). During oral argument, counsel for Patent Owner conceded that “conversion can mean either.” Tr. 27:18–28:13. Without the benefit of briefing by the parties, we decline to expressly construe the term “conversion,” as our Decision would be the same under either interpretation, as discussed further below. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (finding only those terms that are in controversy need be construed, and only to the extent necessary to resolve the controversy). Moreover, we do not find it necessary to expressly construe any other claim terms for purposes of this Decision. Id.” slip op. at 10
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“2. Analysis A patent claim is unpatentable under 35 U.S.C. § 103 if the differences between the claimed invention and the prior art are such that the claimed invention as a whole would have been obvious before the effective filing date of the claimed invention to a person having ordinary skill in the art to which said claimed invention pertains. See also KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 406 (2007). The question of obviousness is resolved on the basis of underlying factual determinations, including (1) the scope and content of the prior art; (2) any differences between the claimed subject matter and the prior art; (3) the level of skill in the art; and (4) objective evidence of nonobviousness. Graham v. John Deere Co., 383 U.S. 1, 17–18 (1966). Objective evidence of nonobviousness may include” slip op. at 13
- Obviousness (§103) › Objective indicia / secondary considerationsObjective indicia outweighedDecided for petitioner
“We are not persuaded. “[A]ny superior property must be unexpected to be considered as evidence of non-obviousness.” Pfizer, Inc. v. Apotex, Inc., 480 F.3d 1348, 1371 (Fed. Cir. 2007). We must, therefore, first consider what results were expected to determine what a POSA would have considered to be unexpected. Id. As seen by the table below, Wright ’451’s disclosure fully encompasses the temperature ranges and purported unexpected results recited by substitute claim 29 and shown in Table 2 of the ’048 Patent: Reference Reaction Calcination Conversion Regioselectivity Rate13 Temperature Temperature Wright ’451 about 220 °C about 200 °C greater than about 90% to to about to 600 °C about 95% about 99% 440 °C Substitute 240 °C to about 420 °C at least 95% to about Claim 29” slip op. at 23
Patent outcomesUS 10,995,048 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 10,995,048 - PTAB · Sep 10, 2024 · IPR2024-00563 · APJ Zhenyu Yang · IPR · Institution
The Board instituted IPR on claims 1, 12, and 28 because Petitioner showed a reasonable likelihood of prevailing on obviousness over Gil, Norden, Dean, Alphagan, and Federal Register.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDecided for petitioner
“partes review, “the Director may take into account whether, and reject the petition or request because, the same or substantially the same prior art or arguments previously were presented to the Office.” Our § 325(d) analysis employs a two-prong framework: (1) whether the arguments presented in the petition are the same or substantially the same as those previously presented to the Office; and (2) if so, whether the petitioner has demonstrated a material error by the Office in its prior consideration of those arguments. Advanced Bionics, LLC v. Med-El Electromedizinishe Gerӓte GmbH, IPR2019-01469, Paper 6 (“Advanced Bionics”), 8 (PTAB Feb. 13, 2020) (precedential). “If a condition in the first part of the framework is satisfied and the petitioner fails to make a showing of material error, the Director generally will exercise discretion not to institute inter partes review.” Id. at 8–9. “At bottom, this framework reflects a commitment to defer to previous Office evaluations of the evidence of record unless material error is shown.” Id. at 9.” slip op. at 17
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“the District of New Jersey is more than three years, argues that “a trial may not be held until 2026—well after a FWD would be expected in this proceeding.” Pet. 15 (citing Ex. 1027, 2); Reply 8. Based on this evidence of the median time to trial in the district, we find factor 2 weighs in favor of institution. See Fintiv Memo 3 (“[W]hen considering the proximity of the district court’s trial date to the date when the PTAB final written decision will be due, the PTAB will consider the median time from filing to disposition of the civil trial for the district in which the parallel litigation resides.”)” slip op. at 22
- Claim Construction › Intrinsic evidence (Phillips canons) › Preamble limiting or notPreamble limitingOther
“guidance as to the meaning of particular claim terms.” Phillips, 415 F.3d 1314. Claim 1 is directed to “[a] method for reducing eye redness in a human subject having ocular hyperemia.” The preamble is limiting because (1) it provides the antecedent bases for “said human” and “said reduction of eye redness” recited in the body of the claim; and (2) “it is a statement of the intentional purpose for which the method must be performed.” See Eli Lilly & Co. v. Teva Pharms. Int’l GmbH, 8 F.4th 1331, 1341–43 (Fed. Cir. 2021). The preamble, however, does not require that eye redness is actually reduced. Id. Nor does the body of the claim recite any efficacy requirement.” slip op. at 24
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITADecided for petitioner
“In claim construction, “the claims themselves provide substantial guidance as to the meaning of particular claim terms.” Phillips, 415 F.3d 1314. Claim 1 is directed to “[a] method for reducing eye redness in a human subject having ocular hyperemia.” The preamble is limiting because (1) it provides the antecedent bases for “said human” and “said reduction of eye redness” recited in the body of the claim; and (2) “it is a statement of the intentional purpose for which the method must be performed.” See Eli Lilly & Co. v. Teva Pharms. Int’l GmbH, 8 F.4th 1331, 1341–43 (Fed. Cir. 2021). The preamble, however, does not require that eye redness is actually reduced. Id. Nor does the body of the claim recite any efficacy requirement.” slip op. at 24
Claim construction§ 103 obviousnessDiscretionary denialcites PhillipsPatents in suitUS 11,596,600
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.