• Bio-Rad Laboratories, Inc. v. California Institute Of TechnologyNo claims unpatentable
  PTAB · Mar 23, 2026 · IPR2024-01451 · APJ Tawen Chang · IPR · Final written decision

  Claims 1–19 were not shown unpatentable: Larson did not establish the claimed detection in a single sample volume, and the asserted obviousness combinations did not cure the deficiencies.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Patent Owner states that, “[f]or purposes of this IPR proceeding, PO does not contest Petitioner’s description of qualifications for a person of ordinary skill in the art (POSA) set forth [above].” PO Resp. 23. In view of the above, and because Petitioner’s uncontested description of one of ordinary skill in the art is reasonable and consistent with the ’921 patent and the cited art, we adopt Petitioner’s definition of a POSA for purposes of this Decision, except that we replace the phrase “at least a year of experience in quantitative and/or dPCR and fluorescence-based analyte detection” with “around a year of experience in quantitative and/or dPCR and fluorescence-based analyte detection.” Pet. 9 (emphasis added).13” slip op. at 14

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “We begin with “the context in which a term is used in the asserted claim,” which can be “highly instructive.” Phillips, 415 F.3d at 1314. In this case, claim 1 recites that the claimed assay is “capable of unambiguously detecting the presence or absence of each of said at least M analytes, in any combination of presence or absence, in a single sample volume, . . . wherein the analytes are amplified in the single sample 15 In this regard, we note that Petitioner’s claim construction position is not predicated on the collection of droplets being reconstituted into its original, pre-partition form prior to amplification; rather, the droplets remain compartmentalized from each other in the PCR thermal cycling tube. Tr. 65:21–66:9 (Petitioner’s counsel explaining that the droplets do not combine in the PCR thermal cycling tube but, rather, are “suspended in an immiscible fluid and analyzed en masse”). indicates that the first instance of single sample volume, i.e., the single sample volume in which the presence or absence of each M analytes are to be detected, is the antecedent basis for the second instance of “single sample volume,” i.e., the single sample volume in which the analytes are amplified. Thus, as the parties appear to agree, the single sample volume in which amplification takes places must be the same single sample volume in which the presence or absence of analytes are to be detected. We are not persuaded that, when accorded its plain and ordinary meaning, a single sample volume divided into a collection of droplets would be considered the “same” single sample volume prior to its partition.” slip op. at 17

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable

    “With respect to the limitation, “wherein the analytes are amplified in the single sample volume,” Petitioner asserts that “Larson discloses PCR assays that amplify target polynucleotide in a single sample volume, specifically a portion of the reaction mixture that is subsequently partitioned into droplets.” Pet. 31 (emphasis added). There is no dispute that the amplification of the analytes in Larson occurs in the droplets. Larson ¶¶ 6–7 (explaining that “[d]igital PCR (dPCR) is an alternative quantitation method in which dilute sample are divided into many separate reactions” and that “[t]he template is amplified in the droplet for detection”) (emphasis added). Because the claims require that amplification of the analytes be in the same sample volume in which the at least M analytes, in any combination of presence or absence, is unambiguously detected, and because the pre-partition single sample volume is not the same single sample volume as the collection of droplets after partition under our claim construction set forth above, we find Petitioner has not shown, by a preponderance of evidence, that claims 1–10 and 13–19 are anticipated by Larson.17 Tr. 68:12–69:14 (Petitioner’s counsel” slip op. at 27

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “Although we agree with Petitioner that Larson contemplates scenarios in which droplets may contain more than one target molecule and does not require the exclusion of such multiple occupancy droplets in all embodiments, we are nevertheless not persuaded Petitioner has shown, based on a preponderance of evidence, that Larson renders obvious an assay capable of unambiguously detecting, in such multiple occupancy droplets, the presence or absence of each of at least M analytes, in any combination of presence or absence, when M is greater than F and F is at least 2.” slip op. at 32

  Patent outcomesUS 11,827,921 not shown unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,827,921
• Inergy Technology, Inc. v. Force Mos Technology Co., Ltd.No claims unpatentable
  PTAB · May 16, 2025 · IPR2024-00093 · APJ Grace Karaffa Obermann · IPR · Final written decision

  Claims 1–9 were not proven unpatentable because the asserted references did not establish the claimed epitaxial layer or the required coverage of the trench sidewalls.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner defines a person of ordinary skill in the art as having “a Master’s degree in electrical engineering, and at least two years of relevant work experience in the field of integrated circuit design and manufacturing.” Pet. 13 (citing Ex. 1003 ¶¶ 32–37, 57). Patent Owner does not dispute Petitioner’s definition. PO Resp. 6. We adopt Petitioner’s proposed definition of the level of ordinary skill in the art because it is supported by unopposed declaration testimony and appears to be consistent with the disclosures of the ’634 patent and the asserted prior art references. See Ex. 1001, 1:6–2:33 (describing the invention and related art in terms of integrated circuit design and fabrication); see also Ex. 1006 ¶¶ 1–6 (Hirler); Ex. 1008 ¶¶ 1–37 (Kobayashi); Ex. 1009 ¶¶ 2–29 (Shiraishi). Neither party, moreover, indicates the overall result would change based on a different definition.” slip op. at 7

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner

    “Petitioner argues that “the sidewalls of said trenches in said base layer are covered” should be construed to mean that “the entire sidewalls of” those trenches are covered. Pet. 18–19. We refer to this as “the sidewall limitation.” Petitioner shows persuasively that the disclosure and file history of the ’634 patent support its position on the sidewall limitation. Id. Patent Owner, for its part, observes that, after the filing of the Petition. two District Courts adopted the construction proposed by Petitioner.” PO Resp. 21 (citing Ex. 2010, 6–9; Ex. 2011, 23). Patent Owner also agrees to apply Petitioner’s construction for purposes of this proceeding. Id. We agree with Patent Owner that an express construction of the sidewall limitation is necessary to this Decision, id., and adopt Petitioner’s undisputed definition because it is supported by the record. No other claim term requires express construction for purposes of this Decision.” slip op. at 8

  • BurdenNot shown unpatentable

    “On this record, Petitioner fails to demonstrate that any claim is unpatentable under any ground asserted in the Petition. IV. CONCLUSION For the above reasons, we determine that Petitioner fails to establish by a preponderance of the evidence that claims 1–9 of the ’634 patent are unpatentable.” slip op. at 34

  • Expert testimonyPetitioner expert discountedPatent owner expert creditedDecided for patent owner

    “Alternatively, even if we set aside that timing issue, Dr. Liu’s bare opinion, advanced for the first time during cross-examination, that an epitaxial layer is “obvious” from Hirler’s disclosure is inadequate to support the challenges. Id. at 24–25. We accord little weight to Dr. Liu’s opinion because it is conclusory. See Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 9 at 15 (PTAB Aug. 24, 2022) (precedential). In any event, Petitioner does not meet, on this record, the “high standard” required to establish an inherent disclosure of an epitaxial layer in Hirler. PO Resp. 24.6 Dr. Liu opined for the first time during cross-examination “that it would have been impossible to create Hirler’s more lightly doped n- drift zone layer on top of its more heavily doped n+ substrate layer other than via epitaxy.” Id. at 25 (citing Ex. 2014, 164:16– 165:20). But Patent Owner effectively refutes that proposition with evidence that such a layer “could be created by counter-doping,” even if, as Dr. Liu contends, counter-doping may have been less ideal due to “disadvantageous mobility.” Id. (citing Ex. 2012 ¶ 133; Ex. 2014, 166:15–167:8).” slip op. at 11

  Patent outcomesUS 7,629,634 not shown unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 7,629,634
• Nespresso USA, Inc. v. K-Fee System GMHBNo claims unpatentable
  PTAB · Apr 10, 2024 · IPR2022-01574 · APJ James J Mayberry · IPR · Final written decision

  Claims 1–13 were not shown unpatentable because the asserted combinations did not teach or render obvious the claimed groove entirely to the side of the chamfered mandrel.

  RulingsFinal written decision

  • Skill levelSkill level board ownPatent owner expert discountedDecided for patent owner

    “The Federal Circuit has made clear that, “[t]o offer expert testimony from the perspective of a skilled artisan in a patent case—like for claim construction, validity, or infringement—a witness must at least have ordinary skill in the art.” Kyocera Senco Indus. Tools Inc. v. Int’l Trade Comm’n, 22 F.4th 1369, 1376–77 (Fed. Cir. 2022) (emphasis added). “Without that skill, the witness’[s] opinions are neither relevant nor reliable.” Id. at 1377. The Federal Circuit reasons that “‘[a]dmitting testimony from a person . . . with no skill in the pertinent art serves only to cause mischief and confuse the factfinder.’ . . . That testimony would ‘amount[ ] to nothing more than advocacy from the witness stand.’” Id. (quoting Sundance, Inc. v. DeMonte Fabricating Ltd., 550 F.3d 1356, 1362, 1364–65 (Fed. Cir. 2008)). possesses at least the level of ordinary skill in the art. Our level of ordinary skill in the art requires a bachelor’s degree in engineering plus five years of experience in design of mechanical beverage systems, or similar products, as well as experience with sensors for recognizing an identifier. Patent Owner does not persuasively account for how Dr. Howle’s experience, extensive as it may be, includes five years of experience in design of mechanical beverage systems, or similar products, as well as experience with sensors for recognizing an identifier. Cf. Kyocera, 22 F.4th at 1376 (“Dr. Pratt has advanced degrees in engineering and extensive experience in the design and manufacture of fastener driving tools. But he lacks experience in power nailer design.”).” slip op. at 21

  • Expert testimonyPatent owner expert discountedDecided for petitioner

    “The Federal Circuit has made clear that, “[t]o offer expert testimony from the perspective of a skilled artisan in a patent case—like for claim construction, validity, or infringement—a witness must at least have ordinary skill in the art.” Kyocera Senco Indus. Tools Inc. v. Int’l Trade Comm’n, 22 F.4th 1369, 1376–77 (Fed. Cir. 2022) (emphasis added). “Without that skill, the witness’[s] opinions are neither relevant nor reliable.” Id. at 1377. The Federal Circuit reasons that “‘[a]dmitting testimony from a person . . . with no skill in the pertinent art serves only to cause mischief and confuse the factfinder.’ . . . That testimony would ‘amount[ ] to nothing more than advocacy from the witness stand.’” Id. (quoting Sundance, Inc. v. DeMonte Fabricating Ltd., 550 F.3d 1356, 1362, 1364–65 (Fed. Cir. 2008)). possesses at least the level of ordinary skill in the art. Our level of ordinary skill in the art requires a bachelor’s degree in engineering plus five years of experience in design of mechanical beverage systems, or similar products, as well as experience with sensors for recognizing an identifier. Patent Owner does not persuasively account for how Dr. Howle’s experience, extensive as it may be, includes five years of experience in design of mechanical beverage systems, or similar products, as well as experience with sensors for recognizing an identifier. Cf. Kyocera, 22 F.4th at 1376 (“Dr. Pratt has advanced degrees in engineering and extensive experience in the design and manufacture of fastener driving tools. But he lacks experience in power nailer design.”).” slip op. at 21

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “Based on the information above, we conclude that the limitation “a groove that is laterally offset from the chamfered mandrel” requires the groove to be entirely to the side of any part of the mandrel. This construction is consistent with the words of the claim—the claim states that the groove is laterally offset from, or to the side of, the chamfered mandrel, not merely offset from a portion of or the centerline of the mandrel. This construction is also consistent with the one embodiment describing the relationship between the mandrel and groove containing the seal, which depicts the groove entirely to the side of the chamfered mandrel. We do not accept Mr. Jobin’s testimony that laterally offset is determined relative to the centerline of an object. Neither the intrinsic record nor other extrinsic evidence provides support for Mr. Jobin identifying the centerline of an object as the reference point for determining if a point is laterally offset from the object.” slip op. at 31

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “We do not agree with Petitioner that Yoakim teaches a groove that is laterally offset from the chamfered mandrel. As we indicated in our claim construction section, we construe the claim term to require the groove to be entirely to the side of any part of the mandrel. We agree with Patent Owner that, as depicted in Yoakim’s Figure 35, the alleged groove is not entirely to the side of any part of the mandrel. See Pet. 69; see also Pet. Reply 19 (showing the alleged groove, in red, including a portion over the chamfered mandrel); PO Resp. 55 (same). Even if Petitioner’s position is that all of the groove must be to the side of the centerline of the mandrel, Petitioner fails to prove that Yoakim teaches such a structure. As seen in Petitioner’s illustration at page 19 of Petitioner’s Reply (reproduced above), a small portion of the groove (which Petition colorizes in red) is to the left of the centerline (shown in green). See Pet. Reply 19.” slip op. at 40

  Patent outcomesUS 11,254,491 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,254,491
• 3M Company v. Bay Materials, LLCNo claims unpatentable
  PTAB · Jan 16, 2024 · IPR2022-01214 · APJ Grace Karaffa Obermann · IPR · Final written decision

  Claims 1–4, 7–11, and 13 were not shown unpatentable because Petitioner did not establish the flexural-modulus limitation over Hinz and the Durasoft data sheets, with or without Sun.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “The parties disagree about the appropriate definition of the ordinarily skilled artisan and, in particular, whether that artisan would have had experience or familiarity with processing “thermoformable polymer sheets” to form “orthodontic and dental appliances.” Resp. 8; see Pet. 10–11 n.1 (disagreeing with that proposition). We agree with Patent Owner for the following reasons.” slip op. at 8

  • Expert testimonyPetitioner expert discountedPatent owner expert creditedDecided for patent owner

    “B. Conflicting Opinion Testimony Petitioner’s own witness, Dr. Giacomin, opines that an ordinarily skilled artisan “would have been familiar with various machines and methods that would have enabled the thermoforming of multilayer dental sheets into shapes that conform with the teeth (i.e., creating a dental appliance).” Ex. 1002 ¶ 25. Nonetheless, Petitioner does not contest Patent Owner’s evidence that Dr. Giacomin himself lacks that qualification. Compare Resp. 9–10 (citing Ex. 1002 ¶¶ 1–9, 17 & n.1), with Reply (nowhere contesting that evidence). Petitioner also leaves uncontested Patent Owner’s evidence that Dr. Osswald, by contrast, possesses “the required experience” with dental appliances, including thermoforming processes for their manufacture. Compare Resp. 10 (citing Ex. 2006 ¶¶ 2–8; Ex. 2007), with Reply (nowhere contesting that evidence). Dr. Giacomin possesses excellent qualifications in the field of polymer rheology, but on this record, he demonstrates no, or inadequate, familiarity or experience with methods of thermoforming dental appliances from polymeric materials, which by his own admission is a minimum qualification of the hypothetical person of ordinary skill in the art. Ex. 1002 ¶¶ 1–11 (statement of qualifications), App’x A (curriculum vitae). Patent Owner’s witness, Dr. Osswald, by contrast, has “experience with polymer materials used in dental appliances” and “shaping operations, including thermoforming” processes for such applications. Ex. 2006 ¶¶ 5, 6. Against that backdrop, where the two witnesses’ opinions differ about the level of ordinarily skill in the art of thermoforming processes for dental appliances at the time of the invention, we credit Dr. Osswald’s opinions over those of Dr. Giacomin. We take note, moreover, that Dr. Osswald’s opinions would not change under Petitioner’s somewhat different definition of the level of ordinary skill in the art. Ex. 2006 ¶ 14.” slip op. at 11

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “C. Claim Construction Claim terms are given their ordinary and customary meaning, as understood by one of ordinary skill in the art in the context of the entire disclosure. In re Translogic Tech., Inc., 504 F.3d 1249, 1257 (Fed. Cir. 2007). We construe only terms in controversy and then only to the extent necessary to resolve the controversy. Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017). No claim term requires express construction for purposes of this Decision.” slip op. at 12

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable

    “In the absence of explanation by Petitioner, we are left to wonder why either of those two ranges reported in Sun would have been recognized as applicable, without modification, to the three-layer dental splint of Hinz. Starting with a commercially-available, two-layer sheet of hard-soft PC-TPU or hard-soft PETG-TPU thermoplastic polymers, Hinz bonds a third layer, consisting of hard PC or hard PETG, to the soft TPU layer of the two-layer material by a process of thermoforming. No prior art reference explains how that process would have been understood to affect the overall flexural modulus of the resulting three-layer, hard-soft-hard composition. Petitioner does not supply an adequate reason for combining Sun’s preferred flexural modulus range, reported for Sun’s dental appliances at a temperature of 23˚ C, to dental splints formed by Hinz from fundamentally different polymers and a fundamentally different process. See Pet. 65–68 (entirety of four-page analysis on this ground); Resp. 32–38; Sur-reply 7–14 (well-supported explanation of those fundamental differences); Reply 8–16 (Petitioner’s unpersuasive responsive positions). The flexural modulus of Sun’s dental appliance not only is temperature dependent but also varies with the flexural strength of the polymeric material at hand. Ex. 1018 ¶ 12. Too late in the Reply, Petitioner raises fact-intensive reasons why those differences would not have mattered to an ordinarily skilled artisan. Reply 8–16. In any event, we agree with Patent Owner that Petitioner glosses over “[f]undamental differences” between the polymers and processes of Sun and Hinz, differences that “are central to [the] motivation to combine inquiry” and undercut Petitioner’s view that an ordinarily skilled artisan would have understood either of Sun’s flexural modulus ranges to apply, without modification, to Hinz’s polymers and process. Resp. 33 (quoting Adidas AG v. Nike, Inc., 963 F.3d 1355, 1359 (Fed. Cir. 2020)) (first alteration in original); see Sur-reply 8–16 (Patent Owner’s persuasive arguments and evidence on point). The ground based on Sun is deficient for the above reasons.” slip op. at 25

  Patent outcomesUS 10,946,630 not shown unpatentable
  Claim construction§ 103 obviousnesscites Graham
  Patents in suitUS 10,946,630
• Cisco Systems, Inc. v. Ramot At Tel Aviv University, Ltd.No claims unpatentable
  PTAB · Oct 3, 2023 · IPR2022-00576 · APJ Monica S Ullagaddi · IPR · Final written decision

  Claims 13, 14, and 23–29 were not shown unpatentable as obvious over Roberts and Taraschuk, with or without Wright, because the asserted combinations did not teach or suggest the claimed delta features.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “We do not discern a substantial difference between the parties’ definitions for the level of ordinary skill in the art. Instead, we determine that the parties’ definitions are substantially similar. We adopt Petitioner’s definition of the level of skill in the art, which is consistent with the disclosure of the ’872 patent and asserted prior art of record. The findings and conclusions rendered in this Decision would not change had we adopted Patent Owner’s definition.” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “We need not construe any claim term in our Decision in order to resolve the issues before us. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (explaining that construction is needed only for terms that are in dispute, and only as necessary to resolve the controversy).” slip op. at 9

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable

    “for a LUT having the recited deltas except for Dr. Blumenthal’s analysis. Although Wright generally teaches compensating for mismatches, Dr. Blumenthal’s analysis fills in limitations 13.8 and 13.9––Petitioner does not set forth a sufficiently supported reason for using the specific values recited in limitations 13.8 and 13.9. At best, Petitioner presents an “obvious to try rationale”: In addition to the reasons mentioned above, a POSITA would have found it obvious to try a mapping scheme in which entries in the look-up table as taught by Taraschuk are selected such that successively decreasing inputs correspond to digital output entries with either decreasing, increasing, or similar deltas between their values. . . . Doing so would have involved choosing from a finite number of identified, predictable solutions, with a reasonable expectation of success. In that regard, the deltas between values of the corresponding digital outputs can either increase, decrease, or stay the same. Accordingly, there are only three possible relationships between deltas of successive digital outputs. With so few possibilities, a POSITA would have found it obvious to try each of them. Pet. 59 (citing Ex. 1003 ¶ 265). The analysis for 13.8 is incorporated by reference in 13.9. See Pet. 60. Although there are three possible relationships between two, consecutive deltas, there are many possible sequences of deltas––Petitioner does not sufficiently show a finite number of solutions in its challenge.” slip op. at 30

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “We agree with Patent Owner’s argument that the portions of Taraschuk in column 7, lines 61–67 and column 8, lines 13–15 cited by Petitioner in its challenge to claim 13 teach “an end-to-end approach” “because that calculation involves predistortion of the input M-bit word by subtracting a digitized analog sample of the ultimate output,” and as such, teach “[a]n approach that necessarily does one combined correction for all of the nonlinearities that occur in-between those ends—whether bit mismatches in the digital logic or non-linearities in the Mach-Zehnder modulator.” PO Sur-reply 18 (citing PO Resp. 30–36; Ex. 2018 ¶¶ 48, 49, 85–87, 89, 103; Ex. 1006, 7:34–39, 7:61–67). We further agree with Patent Owner’s assertion that [Patent Owner] and Prof. Dallesasse are not suggesting that Dr. Blumenthal should model the logic-level mismatches. But rather pointing out that calculating an idealized sinusoidal response in isolation is not obvious (or flowing naturally) from a reference that can only deal with compensating the combined response of the modulator and digital logic mismatches together—via real-time pre-distortion fed back from the ultimate output and subtracted from the input. Dallesasse testifies that Dr. Blumenthal starts with the premise that all that is required is deriving a complementary function to the sinusoidal response. . . . But this ignores that the disclosure of Taraschuk describes compensating “the sinusoidal response of the modulator” and “logic level mismatches through the D/A converter” together. . . . Dr. Blumenthal’s complementary sinusoidal correction curve won’t do that. The combined non-linearity from the multiple sources likely won’t simply be evenly sinusoidal. Taraschuk does not disclose, or in my opinion render obvious, any pre-calculation solution. (Taraschuk mentions a real-time analog feedback loop to pre-distort, which would not involve pre-calculation.) And it certainly does not suggest one that could deal with the combined and likely complex non-linearities described.” slip op. at 28

  Patent outcomesUS 11,133,872 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,133,872
• Cisco Systems, Inc. v. Ramot At Tel Aviv University, Ltd.No claims unpatentable
  PTAB · Sep 29, 2023 · IPR2022-00575 · APJ Monica S Ullagaddi · IPR · Final written decision

  Claims 1–12, 15–22, and 30 were not shown unpatentable under § 103 over Roberts and Taraschuk because the combination did not teach or suggest the claimed mapping.

  RulingsFinal written decision

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “Inst. Dec. 25–26 (citing Ex. 1006, 8:2, 8:8, 6:61–65; Ex. 1003 ¶ 147; Prelim. Resp. 46). Based on our review of the complete record developed during trial, we are persuaded to modify our preliminary determinations. For the reasons discussed below, we are persuaded that the scope of claim 1 does not encompass linear compensation methods effected by analog pre-distortion because the ’872 patent specification distinguishes analog pre-distortion (see Ex. 1001, 1:55–2:34) and the prosecution history specifically distinguishes analog pre-distortion from the claimed approach (see Ex. 1002, 172). We find persuasive Dr. Dallesasse’s testimony that “a person of ordinary skill in the art reading the [’872] patent would understand that th[e] [claimed] approach differs from pre-distortion based on real-time measured analog modulator output.” Ex. 2018 ¶ 33 (citing-in-part Ex. 1001, 2:3–7 (’872 patent disclosing common, prior art solutions such as “an analog predistortion circuit to feed the modulator”)); see also Ex. 1001, (the ’872 patent describing the need for a “digital to analog converter” that would “improve[] linearity of response without sacrificing efficiency or dynamic range” as in the common, prior art solutions). Dr. Dallesasse explains how “the prosecution history of the ’872 patent [illustrates] that when [Patent Owner] changed ‘correct for non-linearities’ to the more specific language ‘determined based on a pattern for actuating drive voltages that alters the linearity of an optical response of the modulator,’” “the Examiner then allowed the claims over a rejection based on Roberts, which “suggests that there are ways to ‘correct for non-linearities’ that do not meet the amended Ex. 2009, 2; Ex. 2003). During prosecution, Patent Owner argued: Roberts does not disclose a “digital-to-digital mapping,” where, “for a given plurality of N digital input data bits, the mapping to the corresponding M digital output data bits is determined based on a pattern for actuating drive voltages that alters the linearity of an optical response of the modulator,” as recited in amended claim 1. Instead, the linear compensation in Roberts is performed pursuant to a compensation function c(t) when the Vx(n) multi-bit sample streams are generated. Importantly, this linear compensation in Roberts occurs before the mapping of Vx(n) to Sx(n). As a result, the mapping between Vx(n) to Sx(n) in Roberts, such as the mapping shown in Table 1 of Roberts, is not a part of the linear compensation operation performed in Roberts. Ex. 1002, 172 (emphasis added). We interpret the quoted passage to exclude analog pre-distortion because we interpret the argument distinguishing Robert’s compensation as happening “before the mapping” to refer to pre-distortion techniques––in particular, those accomplished by analog compensation function, c(t). Id. Both the ’872 patent and Patent Owner’s arguments during prosecution support Dr. Dallesasse’s testimony and Patent Owner’s position that the scope of claim 1 does not encompass linear compensation methods effected by analog pre-distortion.” slip op. at 21

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable

    “mapping is based on an analog feedback loop, by . . . quoting from the reference and leaving out the very next sentence” has merit. Sur-Reply 8 (citing Pet. Reply 23). Petitioner does not sufficiently address the cited teachings and in particular, Taraschuk’s teachings of calculating a difference between a “sampled analog output signal (S) and corresponding M-bit word” to a calculate a mapping “required to obtain the desired output analog signal level.” Ex. 1006, 7:34–39. We are persuaded Petitioner does not sufficiently rebut Patent Owner’s contention that Roberts’ and Taraschuk’s teachings of linear compensation are implemented by analog pre-distortion. Petitioner cannot ignore these teachings of Taraschuk and consider only the portions that support its challenge. See Pet. Reply 17 (citing Pet. 43–45; Ex.1006, 7:56–60) (“Patent Owner’s emphasis on Taraschuk’s digital feedback loop is also misplaced because the Petition simply relied on Taraschuk’s linearizer 44 as a discrete, known device for performing non-linear compensation of a Mach-Zehnder modulator.” (emphasis added)). Petitioner cannot set forth the teachings of Taraschuk in such a piecemeal sufficiently explain why the converter of Taraschuk relies on analog pre-distortion, or explain why analog pre-distortion is encompassed by the invention recited in independent claim 1, Petitioner does not sufficiently carry its burden.” slip op. at 25

  • Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightNot shown unpatentableNot shown unpatentable

    “Second, Petitioner concludes that “a POSITA would have found it obvious to map input bits to output bits within the look-up table such that the output bits correspond to voltage values to be transmitted to electrodes of an optical modulator,” but offers no support other than Robert’s teaching that the DSP’s output is a multi-bit parallel binary signal. See id. at 51 (citing Ex. 1005, 6:40–42). That is, the sole basis for Petitioner’s conclusion that it would have been obvious to perform the claimed method is that the output is the same. Id. This is impermissible hindsight. Third, Petitioner essentially argues that a person would have found it obvious to perform the mapping because Taraschuk teaches a look-up table and non-linear compensation. Id. at 51–52. Yet the claim recites how the mapping is performed, which is left unaddressed by Petitioner. Id. That is, Petitioner has not shown where Taraschuck teaches mapping a given number look-up table, so that the output bits compensate for the non-linear effects of the optical modulator. Id. at 52. Rather, Petitioner provides a piecemeal analysis that uses the ’872 patent’s specification as a blueprint to pull together a look-up table, non-linear compensation, and a modulator to arrive at the claimed invention. See id. Thus, all three rationales for limitation 1.9 are deficient. See PO Resp. 27.” slip op. at 30

  • Skill levelSkill level petitioner adoptedOther

    “We do not discern a substantial difference between the parties’ definitions for the level of ordinary skill in the art. Instead, we determine that the parties’ definitions are substantially similar. We adopt Petitioner’s definition of the level of skill in the art, which is consistent with the disclosure of the ’872 patent and asserted prior art of record. The findings and conclusions rendered in this Decision would not change had we adopted Patent Owner’s definition.” slip op. at 8

  Patent outcomesUS 11,133,872 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,133,872
• Markforged Inc. v. Continuous Composites, Inc.No claims unpatentable
  PTAB · Sep 26, 2023 · IPR2022-00679 · APJ Sheldon M Mcgee · IPR · Final written decision

  Claims 1–12, 20, and 21 were not proven unpatentable; the asserted obviousness grounds failed for insufficient motivation to combine, teaching away, or missing claim limitations.

  RulingsFinal written decision

  • Adverse judgmentAdverse judgmentOther

    “Patent Owner statutorily disclaimed claims 13–19 on July 25, 2023, rendering Petitioner’s Grounds 4, 9, and 10 moot. Ex. 2008. Thus, our Final Written Decision does not address Petitioner’s Grounds 4, 9, and 10. The Board heard oral arguments in an in-person hearing conducted on July 27, 2023. See Paper 23.” slip op. at 4

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “(“POSITA”) would have had a master’s or bachelor’s degree in mechanical engineering, materials science, or a related degree, and either at least 3–5 years of experience (with a master’s degree), or at least 5–6 years of experience (with a bachelor’s degree), in composite materials or additive manufacturing. Pet. 13–14 (citing Ex. 1002 ¶ 36). Patent Owner states that it “does not agree that Petitioner’s proposed level of skill in the art accurately reflects the level of ordinary skill in the art as of the priority date . . . [, but r]egardless [of] the level of skill, . . . the Petition does not show the challenged claims are unpatentable.” Resp. 14–15. Patent Owner does not propose a different level of skill in the art. See id. at 15 (“Patent Owner reserves the right to propose a level of ordinary skill in the art later in this proceeding, or in other proceedings.”). On this record, we determine that the level of ordinary skill is reflected in the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (specific findings on the ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))). Although a more specific definition is not necessary, we adopt Petitioner’s proposed definition because, on this record, it is consistent with the disclosures of the asserted prior art references. Neither party, however, advances information explaining how or why the result in this case would change based on the level of ordinary skill determined by the Board.” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Petitioner advances no specific construction of any claim term, but rather proposes that “claim terms should be given their plain and ordinary meaning.” Pet. 14. Patent Owner asserts that the term “anchor” should be construed according to its plain and ordinary meaning, which, according to Patent Owner, is “contact to which the path of composite material is adhered to enable pulling of the path.” Resp. 15 (citing Ex. 2006, 2, 53). Petitioner responds that “[i]n the parallel litigation, the Court has construed ‘anchor point’ and ‘anchor’ as ‘a contact point to which the path is affixed and that serves as an origin point for the formation of the path.’” Reply 3. On the complete record, we determine that no claim term needs an express construction to resolve the controversy. C. GROUND 1 – ALLEGED OBVIOUSNESS OF CLAIMS 20 AND 21 OVER LIPSKER” slip op. at 9

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable

    “combining multiple embodiments from a single prior art reference (Resp. 31), i.e., “there must be a motivation to make the combination and a reasonable expectation that such a combination would be successful, otherwise a skilled artisan would not arrive at the claimed combination.” In re Stepan, 868 F.3d 1342, 1346 n.1 (Fed. Cir. 2017). On this record, Petitioner fails to provide any such motivation to combine the embodiment in Lipsker’s Figure 2 with those of Figures 4A, 4B, 4C, and 5 to arrive at the subject matter of claim 20. Pet. 23–31. Rather, Petitioner merely points to the disparate embodiments of Figures 2, 4A, 4B, 4C, and 5 and portions of Lipsker’s disclosure pertaining to those embodiments, and asserts that Lipsker “discloses” the individual limitations recited in claim 20. See, e.g., id. at 25 (Petitioner, relying on Figure 2, asserting that “Lipsker discloses the preamble of Claim 20”), 27 (Petitioner, relying on Figure 5, asserting that “Lipsker discloses Element 20[a]”), 28 (quoting Lipsker’s descriptions of wire and adhesive dispensed separately as depicted in Figure 2, and asserting “Lipsker discloses Element 20 [c]”), 29 (pointing to Figures 4A, 4B, and 4C and asserting “Lipsker discloses Element 20[d]”). Pointing to disparate embodiments without providing a sufficient motivation to combine them is not enough to establish the obviousness of claim 20 as a whole. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 418 (2007) (holding that a claim “composed of several elements is not proved obvious merely by demonstrating that each of its elements was, independently, known in the prior art”).” slip op. at 14

  Patent outcomesUS 10,744,708 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · Graham
  Patents in suitUS 10,744,708
• Hope Medical Enterprises, Inc. v. Fennec Pharmaceuticals, Inc.No claims unpatentable
  PTAB · Sep 1, 2023 · IPR2022-00125 · APJ Julia Heaney · IPR · Final written decision

  The Board granted the revised noncontingent motion to amend, canceled claims 18 and 20, and entered substitute claims 28 and 29, which were not proven obvious.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner, relying on the testimony of Dr. Rogers, contends that a person of ordinary skill in the art would have [had] a bachelor’s degree or equivalent in any of the pharmaceutical sciences with at least 5 years of experience in solid state chemistry; a master’s degree in any of the pharmaceutical sciences with at least 3 years of experience in solid state chemistry; or a Ph.D. in any of the pharmaceutical sciences with 1 year of experience in solid state chemistry. Pet. 8 (citing Ex. 1008 ¶¶ 24–28). Petitioner further states that such “[a] person could also have qualified as a [person of ordinary skill in the art] with some combination of (1) more formal education and less technical or professional experience or (2) less formal education and more technical or professional experience.” Id. Patent Owner does not dispute Petitioner’s proposed definition of a person of ordinary skill. See generally MTA, RMTA. Having considered the parties’ arguments and evidence, we adopt the level of ordinary skill in the art proposed by Petitioner, because it is consistent with the disclosures of the ’363 patent and the prior art of record. We note, however, that neither party contends that the outcome of this case would differ based on our adoption of any particular definition of a person of ordinary skill in the art.” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “In our Preliminary Guidance, we construed “for a pharmaceutical composition” to mean “in combination with pharmaceutically acceptable excipients,” based on the ’363 patent’s definition providing that “[t]he terms ‘formulation’ or ‘pharmaceutical composition’ as used herein refers to the drug in combination with pharmaceutically acceptable excipients.” Prelim. Guid. 5–6 (citing Ex. 1001, 12:26–28; Ex. 2010, 17:11–12; Ex. 2011, 26:26– 27). We also encouraged the parties to address whether “for a pharmaceutical composition,” which appears in the preamble of substitute claims 28 and 29, is limiting, as opposed to a statement of intended use or purpose. Id. at 6. Following our Preliminary Guidance, the parties submitted further arguments concerning the term “for a pharmaceutical composition.” Patent Owner argues the term requires that the claimed process provide STS that is sufficiently pure for use in a pediatric patient (see RMTA 8–11) and that the word “drug” in the ’363 patent’s definition of “pharmaceutical composition” requires that the anhydrous STS is of sufficient purity for pharmaceutical use. Reply RMTA 3. Petitioner argues that the construction set forth in our Preliminary Guidance was correct. See Sur-reply RMTA 2–3. Having considered the arguments and evidence, we do not further construe the term “for a pharmaceutical composition” in this Decision because, as discussed in our analysis of obviousness below, it is not necessary to construe the term in order to determine whether Petitioner has met its burden of demonstrating by a preponderance of the evidence that proposed substitute claims 28 and 29 are unpatentable. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 13

  • PTAB / AIA Trials › Motions to amend / substitute claimsMotion to amend, grantedGranted

    “1. Reasonable Number of Substitute Claims A motion to amend must “propose a reasonable number of substitute claims.” 35 U.S.C. § 316(d)(1)(B); see 37 C.F.R. § 42.121(a)(3) (“A motion to amend may cancel a challenged claim or propose a reasonable number of substitute claims.”). Patent Owner proposes the same number of substitute claims as the original challenged claims that are cancelled, i.e., a one-to-one substitution for a total of two substitute claims. MTA 2; RMTA. “There is a rebuttable presumption that a reasonable number of substitute claims per challenged claim is one (1) substitute claim.” Lectrosonics, Paper 15 at 4; see 37 C.F.R. § 42.121(a)(3). Petitioner does not argue otherwise. See generally Opp. RMTA. Therefore, we determine that Patent Owner proposes a reasonable number of substitute claims. 2. Support in the Original Disclosure Patent Owner has identified written description support in the originally filed disclosure of the ’363 patent for the new limitations added for the proposed substitute claims. See RMTA 5–8. We have reviewed Patent Owner’s assertions of support in the original disclosure for the proposed revised substitute claims and determine that sufficient support exists. Petitioner does not argue otherwise. See generally Opp. RMTA. Therefore, we determine that Patent Owner has met this requirement. 3. Respond to a Ground of Unpatentability “A motion to amend may be denied where . . . [t]he amendment does not respond to a ground of unpatentability involved in the trial.” 37 C.F.R. § 42.121(a)(2)(i). Patent Owner asserts that the proposed revised substitute claims are patentable over the combination of references that forms the basis of the obviousness ground on which we instituted trial. RMTA 12–13. Petitioner does not argue otherwise. See generally Opp. RMTA. Therefore, we determine that Patent Owner has met this requirement. 4. Scope of the Claims Patent Owner asserts that the proposed revised substitute claims do not enlarge the scope of original claims 18 and 20. RMTA 5. We have reviewed Patent Owner’s assertion that the purity amendments of proposed revised substitute claims 28 and 29 narrow the claims’ scope. Id. Petitioner does not argue otherwise. See generally Opp. RMTA. Therefore, we determine that Patent Owner has met this requirement.” slip op. at 17

  • BurdenNot shown unpatentable

    “determine the evidence relied on by Petitioner does not support Petitioner’s position that a person of ordinary skill in the art would have been motivated to combine Levenson, Sherman, Edwards, and USP. Petitioner’s contention that it would have been obvious to a person of ordinary skill in the art to combine the teachings of Levenson with Sherman is based on Dr. Rogers’s testimony that “[b]oth references disclose synthesis of sodium thiosulfate pentahydrate.” Ex. 1008 ¶ 151; see Pet. 36, 38. Dr. Rogers further testified it would have been obvious to add Edwards’s dehydrating step to the preparation of STS pentahydrate “which is obtained following the teachings of Levenson and Sherman” because “Edwards itself discloses dehydrating [STS] pentahydrate.” Id. ¶ 154. The Petition included these arguments even though they were inconsistent with Petitioner’s previous statement, during the Sherman prosecution, that Levenson taught STS heptahydrate, and therefore “does not provide any teaching with respect to [STS] pentahydrate.” Ex. 2013, 97. This prior inconsistent statement undercuts Petitioner’s rationale for combining Levenson, Sherman, and Edwards in this proceeding. Moreover, Petitioner’s rationale for combining the references in this proceeding is inconsistent with its statements about Levenson during the Sherman prosecution. Recognizing this inconsistency, Petitioner now takes the position that the Petition and Dr. Rogers’s testimony were incorrect. Paper 32; see Tr. 21:14–22:7, 59:1–2 (reemphasizing that “Petitioner maintains the statements that it made in the Sherman prosecution regarding Levenson”). Petitioner attempts to rationalize the inconsistency between its statements in the Sherman prosecution (including that “Levenson does not provide any teaching with respect to [STS] pentahydrate”) and its position in this proceeding by arguing that Dr. Rogers relies on Levenson as teaching surface activation “regardless of any particular hydrates Levenson discloses.” Tr. 22:8–9. That argument is not persuasive, because Dr. Rogers’s declaration clearly states the primary reason for his opinion that it would have been obvious to a person of ordinary skill in the art to combine the teachings of Levenson with Sherman: “[b]oth references disclose synthesis of sodium thiosulfate pentahydrate.” Ex. 1008 ¶ 151. Contrary to Petitioner’s argument, Dr. Roger’s reliance on the surface activation teachings of Levenson is because he believes that both references pertain to STS pentahydrate; the surface activation teachings are not stated as an independent reason to combine the references. Id. Petitioner provides no further explanation of how a person of ordinary skill in the art would have been motivated to combine Levenson’s teachings regarding manufacture of STS heptahydrate with Sherman’s and Edwards’s teachings regarding STS pentahydrate, or how a person of ordinary skill would have regarded the difference between STS hydrates. Dr. Rogers’s acknowledgement of stability differences among STS hydrates highlights the insufficiency of Petitioner’s showing in this regard. See Ex. 2005, 35, 39. Having changed its position at the close of trial and having effectively withdrawn Dr. Rogers’s testimony as to similarities between Levenson and” slip op. at 24

  Patent outcomesUS 10,792,363 not shown unpatentable
  Claim constructioncites KSR · Graham
  Patents in suitUS 10,792,363
• Sigray, Inc. v. Carl Zeiss X-Ray Microscopy, Inc.No claims unpatentable
  PTAB · May 22, 2023 · IPR2022-00218 · APJ Elizabeth M Roesel · IPR · Final written decision

  Claims 1–15 were not shown unpatentable because the prior art did not establish the claimed projection magnification or scintillator; the revised contingent motion to amend was dismissed as moot.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We determine that the level of ordinary skill in the art, as articulated by Patent Owner, more accurately reflects the subject matter of the ’704 Patent and the asserted prior art than does Petitioner’s articulation. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“the prior art itself reflects an appropriate level” as evidence of the ordinary level of skill in the art) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)). Petitioner does not explain how “control theory” and “applied mathematics” (Pet. 16) relate to the subject matter of the ’704 Patent and the asserted prior art, and Petitioner’s reference to requisite level of skill. Furthermore, whereas Petitioner requires a POSITA to have “x-ray and computing imaging experience” (id.), Patent Owner more particularly specifies “x-ray microtomography experience” (PO Resp. 5), which is the field of art for the ’704 Patent, as well as many of the asserted prior art references. Ex. 1001, code (54) (“High resolution direct-projection type x-ray microtomography system using synchrotron or laboratory-based x-ray source”); Ex. 1007 (discussing X-ray microcomputed tomography); Ex. 1008 (discussing X-ray nanotomography and microtomography); Ex. 1010, code (54) (“Method and apparatus for utilizing an electro-optic detector in a microtomography system”); Ex. 1011 (title: “Three-dimensional X-ray Microtomography”). For these reasons, we apply Patent Owner’s definition of a POSITA. Even if we applied Petitioner’s definition of a POSITA, however, the outcome would be the same because our resolution of the controversy does not turn on the differences between the parties’ contentions about level of ordinary skill in the art.” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “In an inter partes review, we apply the same claim construction standard as would be used by a district court to construe a claim in a civil action involving the validity or infringement of a patent. 37 C.F.R. § 42.100(b). Under that standard, claim terms are given their ordinary and customary meaning, as would have been understood by a person of ordinary skill in the art at the time of the invention, in light of the language of the claims, the specification, and the prosecution history of record. Id.; Phillips v. AWH Corp., 415 F.3d 1303, 1312–19 (Fed. Cir. 2005) (en banc); Thorner v. Sony Comput. Entm’t Am. LLC, 669 F.3d 1362, 1365–66 (Fed. Cir. 2012). (“all claim terms should receive their plain and ordinary meaning”); PO Resp. 5 (applying the same constructions as Petitioner). We determine that no claim term requires express construction for purposes of resolving any controversy between the parties. Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 10

  • Expert testimonyPetitioner expert discountedPatent owner expert creditedDecided for patent owner

    “On balance, we find that the testimony of Drs. Bentley and Arce about Jorgensen is more credible than Dr. Kia’s testimony, which is often conclusory and insufficiently supported by the evidence. Drs. Bentley and Arce do a better job of explaining and reconciling Jorgensen’s varying descriptions of the X-ray beam than does Dr. Kia. For example, although Dr. Kia relies on Jorgensen’s repeated references to a “cone-beam,” we find that Petitioner’s evidence does not outweigh the explanations provided by Drs. Bentley and Arce, particularly in view of Jorgensen’s description of the X-ray beam as “collimated” and “shielded by a lead-wrapped brass tube.” See II.D.2.d. and e., supra. Even if we consider Petitioner’s improper new reply argument about filling the CCD, we find that argument insufficient and does not outweigh Patent Owner’s unrebutted evidence about CCD pixel size. See II.D.2.f. and g., supra. In sum, viewing the record as a whole, we find that Petitioner has not shown persuasively that Jorgensen inherently discloses projection magnification within the claimed range.” slip op. at 38

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element) › Inherent disclosureNot shown unpatentableInherency not foundNot shown unpatentable

    “standard.” Amgen Inc. v. Sandoz Inc., No. 2022-1147, 2023 WL 2994166, at *10 (Fed. Cir. Apr. 19, 2023). “Inherency . . . may not be established by probabilities or possibilities.” Oelrich, 666 F.2d at 581. “The mere fact that a certain thing may result from a given set of circumstances is not sufficient.” Id. (emphasis added). Rather, the patent challenger must “show that the natural result flowing from the operation as taught would result in the performance of the questioned function.” Id.; see PersonalWeb Technologies, LLC v. Apple, Inc., 917 F.3d 1376, 1382–83 (Fed. Cir. 2019) (determining that the Board’s reliance on inherency was improper because the structure relied upon to meet a claim element “does not necessarily exist” in the reference). As discussed above, it is undisputed that there can be no projection magnification unless the X-ray beam is diverging, and there is a vigorous dispute about whether Jorgensen teaches a diverging X-ray beam. See negatively impacted by Petitioner’s and Dr. Kia’s admittedly incorrect interpretations of Jorgensen’s disclosures concerning “projected at a 4° angle” and “the X-ray beam geometry is used to achieve magnification.” Ex. 1007, H1104; see II.D.2.b. and c., supra. On balance, we find that the testimony of Drs. Bentley and Arce about Jorgensen is more credible than Dr. Kia’s testimony, which is often conclusory and insufficiently supported by the evidence. Drs. Bentley and Arce do a better job of explaining and reconciling Jorgensen’s varying descriptions of the X-ray beam than does Dr. Kia. For example, although Dr. Kia relies on Jorgensen’s repeated references to a “cone-beam,” we find that Petitioner’s evidence does not outweigh the explanations provided by Drs. Bentley and Arce, particularly in view of Jorgensen’s description of the X-ray beam as “collimated” and “shielded by a lead-wrapped brass tube.” See II.D.2.d. and e., supra. Even if we consider Petitioner’s improper new reply argument about filling the CCD, we find that argument insufficient and does not outweigh Patent Owner’s unrebutted evidence about CCD pixel size. See II.D.2.f. and g., supra. In sum, viewing the record as a whole, we find that Petitioner has not shown persuasively that Jorgensen inherently discloses projection magnification within the claimed range.” slip op. at 37

  Patent outcomesUS 7,400,704 not shown unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 7,400,704
• Hanwha Solutions Corporation / Hanwha Q Cells USA, Inc. v. Rec Solar Pte. Ltd.No claims unpatentable
  PTAB · Dec 9, 2022 · IPR2021-00989 · APJ Brian D Range · IPR · Final written decision

  Claims 1–6, 11, and 13 were not shown unpatentable under either obviousness ground because Petitioner did not establish a motivation to combine Yagiura and Shimasaki.

  RulingsFinal written decision

  • ExcludeMotion to exclude, deniedDenied

    “Petitioner’s position is persuasive. We agree that documents from the Japanese Patent Office are self-authenticating official government documents. The technical issues regarding missing pages in the originally filed version of the document do not cause us to question authenticity. We also agree that Petitioner uses the documents to establish what the documents teach rather than establishing the truth of what the documents teach. In Reply, Patent Owner argues that Petitioner relies on the date printed on the document to prove up the truth of when the document was published. Mot. Excl. Reply 1–2. To the extent this is the case, an exception to hearsay applies because the document is a record of a public office. Fed. R. Evid. 803(8)(B) (a record of public office is an exception to the hearsay rule if the opponent does not show that the source of information or other circumstances “indicate a lack of trustworthiness”). Here, Patent Owner does not persuasively demonstrate a lack of trustworthiness; Patent Owner does not identify any substantively meaningful distinction in the missing pages of the originally filed document and does not identify any evidence to suggest that the missing pages were anything more than a harmless clerical error. For the reasons above, Patent Owner’s motion to exclude is denied with respect to these documents. B.” slip op. at 8

  • Skill levelSkill level board ownOther

    “Petitioner’s proposal is too broad. PO Resp. 8. For example, a person who merely installs solar panels for three years (satisfying “professional experience in solar energy”) while having some familiarity with module manufacturing would not be of ordinary skill in the design aspects of the ’060 patent as, for example, reflected by the claims at issue and the ’060 patent’s text and figures. See, e.g., Ex. 1101, Figs. 2a, 2b, 3a, 3b, 4a, 4b, 3:22–7:44. On the other hand, we also determine that Patent Owner’s proposal is too narrow. A person could, for example, have ordinary skill in the art of the ’060 patent by virtue of non-professional experience (for example, academic experience). When assessing relevant experience, research work done for a university (beyond mere classroom study) would have been just as valuable as research work done for a corporation. Also, ordinary skill in the art could be demonstrated by work that requires understanding of the ’060 patent’s field even if not “designing, developing, and/or researching” in the field itself We, thus, determine that a person of ordinary skill in the art of the ’060 patent would have been someone with a bachelor’s degree in electrical engineering, applied physics, or the like, and at least two years of (a) experience designing, developing, and/or researching in the field or (b) experience in solar energy that required an understanding of the ’060 patent’s field. Alternatively, that person would have had an advanced degree in electrical engineering, applied physics, or the like and at least one year of” slip op. at 11

  • Expert testimonyPetitioner expert creditedDecided for petitioner

    “qualifies as evidence in this matter. The Federal Circuit has held that expert testimony about the perspective of person of ordinary skill in the art (as Dr. Kimball provides here) must come from a person having at least ordinary skill in the art. Kyocera Senco Indus. Tools, Inc. v. ITC, 22 F.4th 1369, 1376–78 (Fed. Cir. 2022) (quoting Sundance, Inc. v. DeMonte Fabricating Ltd., 550 F.3d 1356, 1362, 1364–65 (Fed. Cir. 2008)) (holding that ITC Administrative Law Judge abused discretion by admitting expert testimony of witness who lacked the experience of a person having ordinary skill in the art); see Mot. Excl. 6–7 (arguing this point). Patent Owner, however, cites no authority that expert testimony on such matters come from a person having ordinary skill in the art at the time of the invention. Cf. Scentair Tech., LLC v. Prolitiec Inc., IPR2021-00012, Paper 22 at 61 (PTAB Apr. 22, 2022) (similarly noting a party’s lack of authority on this point). Beyond needing to come from a person of ordinary skill in the art, expert testimony is admissible if the expert has the “scientific, technical, or other specialized knowledge [that] will help the trier of fact to understand the evidence or to determine a fact in issue.” Fed. R. Evid. 702. Furthermore, “[t]here is … no requirement of a perfect match between the expert’s experience and the relevant field.” USPTO, Patent Trial and Appeal Board Consolidated Trial Practice Guide, 34 (Nov. 2019). Here, Petitioner adequately establishes that Dr. Kimball qualifies as a” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “The Petition argues that all claim terms should be given their plain and ordinary meaning. Pet. 18. Patent Owner does not dispute this. PO Resp. 13. We determine that no claim term requires express construction for purposes of this Final Written Decision. Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Matal, 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms that are in controversy, and only to the” slip op. at 15

  Patent outcomesUS 10,749,060 not shown unpatentable
  Claim construction§ 103 obviousnesscites Phillips · Graham
  Patents in suitUS 10,749,060

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.