- Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Solus’s rehearing request, leaving institution denied for claims 1–8 because the petition did not adequately show motivation to combine Hanafusa and Dobashi.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve Dobashi’s RSm values. Dobashi teaches that because RSm “can be adopted as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66–3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66– 3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 4
§ 103 obviousnessPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - Solus Advanced Materials Co, Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 22, 2025 · IPR2024-01460 · APJ Jon B Tornquist · IPR · Institution
The Board denied institution of review of claims 1–11 because the Fintiv factors, including the early trial date and close merits case, favored discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied fintivInstitution denied
“whether to institute an inter partes review. Applying the standard set forth in 35 U.S.C. § 314(a), we may not institute an inter partes review unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Institution of inter partes review, however, is discretionary. See Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1367 (Fed. Cir. 2016) (“[T]he PTO is permitted, but never compelled, to institute an IPR proceeding.”). For the reasons stated below, we exercise our discretion not to institute an inter partes review. A. Real Parties-in-Interest” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivDenied
“Board’s projected statutory deadline to issue a final written decision. Fintiv, Paper 11 at 9. “If the court’s trial date is at or around the same time as the projected statutory deadline . . . the decision whether to institute will likely implicate other factors.” Id. Conversely, “[i]f the court’s trial date is earlier than the projected statutory deadline,” this has generally weighed “in favor of exercising authority to deny institution.” Id.” slip op. at 15
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“Petition under 35 U.S.C. § 325(d) because the same or substantially the same art and arguments were before the Examiner during prosecution and Petitioner’s has not demonstrated that the Examiner erred in a material manner when allowing the claims. Pet. 17–18. Given our discretionary denial of the Petition in view of the Fintiv factors, we do not address Petitioner’s further arguments with respect to § 325(d).” slip op. at 32
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner applies Petitioner’s recited level of ordinary skill in the art for purposes of its Preliminary Response. Prelim. Resp. 4. Upon review of the parties’ arguments and the prior art of record, we adopt Petitioner’s unopposed definition of the ordinarily skilled artisan for purposes of this decision as it appears consistent with the disclosures of the ’090 patent and the prior art of record. C. Claim Construction” slip op. at 9
§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,480,090 - Yealink (USA) Network Technology Co. Ltd. / Yealink Network Technology Co., Ltd. v. Barco N.V.InstitutedPTAB · Apr 8, 2025 · IPR2024-01439 · APJ Frederick C Laney · IPR · Institution
The Board instituted IPR of claims 1–11 and 13–21 on all asserted grounds, finding a reasonable likelihood of prevailing on claim 1 over Uchida and Grimshaw.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” After considering the Petition and the evidence of record, and in the absence of any argument or evidence to the contrary, we determine the information presented shows a reasonable likelihood that Petitioner would prevail in establishing the unpatentability of at least one of the challenged claims of the ’951 patent. Accordingly, we institute an inter partes review of claims 1–11 and 13–21 of the ’951 patent on the grounds asserted in the Petition.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDenied
“We do not agree that the references relied upon in the Petition are cumulative of the Banerjee and Epstein references previously considered by the Office. For example, during reexamination Patent Owner represented to the Office that neither Banerjee nor Epstein discloses or suggests “an actuator on the peripheral device, wherein said actuator is arranged in a way to enable the user to carry out a user action by actuating the actuator to trigger the processing device to transfer said user selected arbitrary media content to said wireless transmitter through said port to transmit said user selected arbitrary media content to the display node via the communications network” . . . . [T]he skilled person would have appreciated that Banerjee is directed to the plug-and-play device having code that is automatically executed when the plug-and-play device is connected to the remote computer and the remote computer sending a request to share the screen by the master computer, whereas Epstein is directed to a puck that sends an intention to the switching device or wirelessly through the laptop. Ex. 2001, 124–125 (emphasis added). Here, however, Petitioner relies primarily on the structures and operations disclosed by Ono, Ichieda, and Uchida to demonstrate it would have been known to include an actuator on a wireless peripheral device to trigger the transfer of a user selected arbitrary media content. See Pet. 31–33, 57–59, 77. Importantly, unlike Epstein or Banerjee, each of those references discloses display systems that include wireless peripheral devices that have actuators that are at least related to facilitating the transfer of image data from a personal computer to a projector for display. See id. As such, we find that Ono, Ichieda, and Uchida present information that is neither substantively similar nor cumulative of that disclosed or suggested by Banerjee and Epstein. Accordingly, we decline to exercise discretion to deny institution pursuant to 35 U.S.C. § 325(d).” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Level of Ordinary Skill in the Art Petitioner contends that a person having ordinary skill in the art would have had at least a Master’s Degree in Electrical Engineering with . . . five years of work experience in computer science and embedded systems, or Master’s Degree in Computer Science with . . . five years of work experience in electrical and computer engineering and embedded systems. Additional educational experience could substitute for some of the work experience. Pet. 10 (citing Ex. 1002 ¶¶ 36–37). For purposes of this Decision, we adopt Petitioner’s proposed definition of a person of ordinary skill in the pertinent art, as it is consistent with the ’951 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 9
- BurdenInstituted
“Patent Owner’s assertion fails to undermine Petitioner’s contention because it does not actually address Petitioner’s point, which is that a skilled artisan would recognize, when a user slides switch 140 back to the ‘OFF’ position to allow image transfer to resume, that action would trigger image data transmission of user selected arbitrary media content from wireless through the wireless communications network for display. Instead, Patent Owner’s argument only addresses when a user slides switch 140 to the “ON” position to stop image transmission. On this record, we determine that Petitioner’s evidence and analysis shows sufficiently that Uchida and Grimshaw disclose this last claim element of claim 1. 4. Conclusion After considering Petitioner’s evidence and argument, we determine the information presented shows a reasonable likelihood that Petitioner would prevail in establishing the unpatentability of claim 1 based on the combination of Uchida and Grimshaw (Ground 2). We also note that both parties rely on substantially the same evidence and arguments to address independent claims 9, 16, and 21. See Pet. 49–59 (claim 9), 64–66 (claim 16), 67 (claim 21); Prelim. Resp. 34–47 (claims 9, 16, 21). Therefore, our determination for claim 1 applies equally to claims 9, 16, and 21.” slip op. at 16
§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,422,951 - Innoscience (Zhuhai) Technology Company, Ltd. / Innoscience America, Inc. v. Efficient Power Conversion CorporationNo claims unpatentablePTAB · Mar 18, 2025 · IPR2023-01383 · APJ Kimberly Mcgraw · IPR · Final written decision
Claims 1–5 were not shown unpatentable because Petitioner did not sufficiently establish a reason to modify the asserted prior art.
RulingsFinal written decision- Expert testimonyPatent owner expert creditedDecided for patent owner
“We disagree with Petitioner’s argument because it fails to address Dr. Schubert’s academic and other experience with GaN transistors. Dr. Schubert is currently a tenured full professor in the Department of Electrical Computer, and Systems Engineering at Rensselaer Polytechnic Institute and was previously a tenured full professor in the Department of Electrical and Computer Engineering at Boston University. Ex. 2001, 129. Additionally, Dr. Schubert was the director of Boston University’s Semiconductor Devices Research Laboratory. Ex. 2001, 129. Dr. Schubert persuasively explains that his general expertise is in the field of electrical engineering and applied physics, including semiconductors, processing, and devices and his specific expertise is in the field of semiconductor materials (such as GaN), semiconductor devices, semiconductor integrated circuits, ohmic contacts, Schottky contacts, HEMTs, and optoelectronic devices such as light-emitting diodes (LEDs). Ex. 2001 ¶ 11, App’x A pp.129–137. His experience includes “the design, growth, fabrication, and testing of semiconductor devices as well as the employment of these devices in a variety of applications” and he is “familiar with both the design of such transistors [HEMTs] and the manufacturing processes used for FETs. Ex. 2001 ¶ 11, App’x A, pp. 129–137. He is an author or co-author of numerous text books and articles, and co-inventor of numerous patents, including those dealing with HEMT transistors and GaN devices. Ex. 2001 ¶ 13, App’x A, pp. 129–137. Petitioner fails to present any persuasive argument or evidence that Dr. Schubert’s extensive education and experience regarding GaN transistors is insufficient or lacking such that his testimony should be given little weight. Finally, we disagree with Petitioner’s additional argument that that its expert’s testimony (Dr. Shealy) should be given more weight than Patent Owner’s expert’s testimony (Dr. Schubert) because “[u]nlike Dr. Schubert, Dr. Shealy is one of the pioneer scientists in the field of GaN transistors.” Reply 34 (stating that Dr. Shealy’s research lab built the first GaN HEMT device on silicon in 1999 and citing Ex. 2002, 87:19–238). Obviousness is determined through the lens of a “person of ordinary skill in the art,” not through the lens of a person with extraordinary skill or a pioneer in the field. Given Dr. Schubert’s extensive relevant education and experience, Petitioner does not persuasively explain why Dr. Shealy’s testimony on any specific topic, or his testimony in general, should be given more weight than Dr. Schubert’s.” slip op. at 16
- Skill levelSkill level petitioner adoptedDecided for petitioner
“understanding of a person of ordinary skill in the art (sometimes abbreviated herein as “POSITA”). Graham, , 383 U.S. at 17–18. Petitioner argued that a person of ordinary skill in the art would have had a “at least a four-year degree in electrical engineering, chemical engineering, physics, or material science or a closely related field and at least two years of experience in semiconductor device design or fabrication, including the processing of semiconductor materials, analysis of device operation, or the development of new device topologies. Additional education could substitute for professional experience and vice versa.” Pet. 11 (citing Ex 1003 ¶ 69). Patent Owner did not dispute this proposed definition prior to institution. See generally Prelim. Resp. In our Decision on Institution, we adopted Petitioner’s proposal. After institution, Patent Owner asserted a slightly different definition of a POSITA, namely someone who “would have possessed at least a four-year degree in electrical engineering, physics, material science, or a closely related field, and three years of professional work experience in the epitaxial growth, design, and fabrication of semiconductor electronic devices, including those of GaN.” Resp. 17. Relevant graduate education could substitute for the professional work experience. Id. Upon review of the full record, we see no reason to modify, and we thus maintain, the definition of a POSITA applied in our Decision on Institution. We also determine that our decision would be the same under either of the parties’ proposed definitions.” slip op. at 14
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Not reached
“During the proceeding, the parties also dispute the proper construction of “etching away the doped GaN layer, except a portion of the doped GaN layer beneath the gate contact” as recited in step [1e4] and provided briefing on this issue. Papers 35, 36, 37, 38. Because, as explained below, our determination rests upon Petitioner’s failure to show a sufficient reason to modify the asserted art, which is not dependent upon any particular claim construction, we need not, and do not, address these claim construction issues. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the controversy).” slip op. at 13
- ExcludeDenied
“III. PETITIONER’S MOTION TO EXCLUDE EXHIBIT 2008 Petitioner filed a Motion to Exclude (Paper 25, “Mot.”) Exhibit 2008, which is a hearing transcript from the parallel ITC investigation. Mot. 1. Because we do not rely upon Exhibit 2008 in our Decision, we dismiss Petitioner’s motion as moot.” slip op. at 47
Patent outcomesUS 8,404,508 not shown unpatentableClaim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 8,404,508 - Apple Inc. v. Proxsense LLCInstitution deniedPTAB · Feb 26, 2025 · IPR2024-01486 · APJ David C Mckone · IPR · Institution
The Board denied institution for claims 1–17 because Apple did not justify a second petition, and denied its motion to join IPR2024-00775.
RulingsInstitution decision- Parallel petitionsInstitution denied discretionary otherInstitution denied
“challenges a subset of the claims of the ’730 patent based on the prior art references Ludtke and Kon, while the instant Petition challenges all 17 claims of the ’730 patent based on the prior art references Burger and Robinson. Id. at 2–3. According to Petitioner, these are “significantly different invalidity grounds.” Id. at 3. However, Petitioner does not explain why challenging the same patent with different invalidity grounds, without more, justifies instituting both petitions.” slip op. at 6
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied discretionary otherInstitution denied
“review. See 35 U.S.C. § 314 (2016); 37 C.F.R. § 42.4(a) (2019). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons explained below, we decline to institute an inter partes review of the ’730 patent. We also deny Petitioner’s Joinder Motion.” slip op. at 2
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, deniedDenied
“IPR2024-00775. Joinder Mot. 1. As the moving party, Petitioner bears the burden of proving that it is entitled to joinder. See 37 C.F.R. § 42.20(c).” slip op. at 8
Discretionary denialPatents in suitUS 8,352,730 - Apple Inc. v. Proxsense LLCInstitution deniedPTAB · Feb 26, 2025 · IPR2024-01485 · APJ David C Mckone · IPR · Institution
The Board denied institution on claims 1–29 under § 314(a), finding insufficient justification for a second petition, and denied Apple’s motion for joinder.
RulingsInstitution decision- Other 314aInstitution denied discretionary otherInstitution denied
“According to PTAB guidance, “[b]ased on the Board’s experience, one petition should be sufficient to challenge the claims of a patent in most situations.” Consolidated Trial Practice Guide (“TPG”) 59 (Nov. 2019), available at https://go.usa.gov/xpvPF. “Two or more petitions filed against the same patent at or about the same time (e.g., before the first preliminary response by the patent owner),” the situation we have here, “may place a substantial and unnecessary burden on the Board and the patent owner and could raise fairness, timing, and efficiency concerns.” Id. Thus, “multiple petitions by a petitioner are not necessary in the vast majority of cases.” Id. That said, the Board recognizes that there may be circumstances in which more than one petition may be necessary, including, for example, when the patent owner has asserted a large number of claims in litigation or when there is a dispute about priority date requiring arguments under multiple prior art references. In such cases two petitions by a petitioner may be needed, although this should be rare. Id. In such situations, a petitioner is invited to identify, either in its petition or a separate ranking paper (Petitioner filed the Ranking Notice): (1) a ranking of the petitions in the order in which it wishes the Board to consider the merits, if the Board uses its discretion to institute any of the petitions, and (2) a succinct explanation of the differences between the petitions, why the issues addressed by the differences are material, and why the Board should exercise its discretion to institute additional petitions if it identifies one petition that satisfies petitioner’s burden under 35 U.S.C. § 314(a).” slip op. at 4
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314 (2016); 37 C.F.R. § 42.4(a) (2019). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons explained below, we decline to institute an inter partes review of the ’954 patent. We also deny Petitioner’s Joinder Motion.” slip op. at 2
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, deniedDenied
“(c) JOINDER.—If the Director institutes an inter partes review, the Director, in his or her discretion, may join as a party to that inter partes review any person who properly files a petition under section 311 that the Director, after receiving a preliminary response under section 313 or the expiration of the time for filing such a response, determines warrants the institution of an inter parties review under section 314. “To join a party to an instituted [inter partes review (IPR)], the plain language of § 315(c) requires two different decisions.” Facebook, Inc. v. Windy City Innovations, LLC, 973 F.3d 1321, 1332 (Fed. Cir. 2020). “First, the statute requires that the Director (or the Board acting through a delegation of authority) . . . determine whether the joinder applicant’s petition for IPR ‘warrants’ institution under § 314.” Id. “Second, to effect joinder, § 315(c) requires the Director to exercise h[er] discretion to decide whether to ‘join as a party’ the joinder applicant.” Id. “The statute makes clear that the joinder decision is made after a determination that a petition warrants institution, thereby affecting the manner in which an IPR will proceed.” Id. (citing Thyrv, Inc. v. Click-to-Call Techs., LP, 140 S.Ct. 1367, 1377 (2020)). As we explain above, Petitioner has not shown that we should institute a second Petition by Petitioner challenging the ’954 patent. Instead, we determine that the Petition does not warrant institution. Accordingly, the Joinder Motion fails at the first step, whether the Petition warrants institution, and we need not evaluate further the second step, whether to join Petitioner as a party to IPR2024-00846. Petitioner’s Joinder Motion is denied.” slip op. at 8
Discretionary denialPatents in suitUS 8,886,954 - PTAB · Dec 16, 2024 · IPR2024-01005 · APJ Julia Heaney · IPR · Institution
The Board instituted IPR on claims 1–23 and all asserted grounds, finding a reasonable likelihood that at least one challenged claim would have been shown unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Upon consideration of the Petition, the Preliminary Response, and the evidence of record, we determine that Petitioner has established a reasonable likelihood that it would prevail in showing the unpatentability of at least one claim challenged in the Petition. We also determine that the arguments and evidence of record do not support discretionary denial under 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review of all claims and all grounds asserted in the Petition.1” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“under the sixth Fintiv factor only after a determination that the first five Fintiv factors favor discretionary denial. CommScope, 4–5. Here, we do not find the first five factors cumulatively weigh in favor of discretionary denial. Therefore, we determine that the circumstances here do not warrant an analysis of whether the Petition presents compelling merits, and the considerations of the sixth Fintiv factor weigh against exercising discretionary denial. F. Conclusion Having considered the parties’ arguments in view of the Fintiv factors, and taking into account Petitioner’s stipulation, we determine that the circumstances here do not warrant exercising discretion under § 314(a) to deny institution. IV.” slip op. at 35
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Thus, although both parties indicate that no claim construction is necessary at this stage of the proceeding, it is apparent that they disagree as to the meaning of “discrete carbon nanotubes.” While Petitioner appears to construe “discrete carbon nanotubes” as “nanotubes that are generally individually distinct” (Pet. 13), Patent Owner argues a more restricted construction requiring that “discrete carbon nanotubes” not be reacted with other components. Prelim. Resp. 3. The evidence relating to claim 10 In quotations from the Preliminary Response throughout this Decision, we have retained bolding and underlining added to the text by Patent Owner. construction that Patent Owner offers on the current record, however, does not address its proposed restriction. See id. at 9, n. 4, citing Ex. 1001, 3:9, 5:39–40 (“The ’649 Patent describes the ‘discrete carbon nanotubes’ as, for example, ‘individually dispersed’, ‘individualized carbon nanotubes’, ‘dispersed as individual nanotubes’, and ‘essentially discrete individual fibers, not entangled as a mass.’”). As discussed in Section II.D.2 below, we determine based on the record at this stage of the proceeding that Petitioner demonstrates sufficiently for purposes of institution that Sun discloses or suggests “discrete carbon nanotubes.” Therefore, we do not explicitly construe any claim terms in this Decision. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). If either party intends to argue a claim construction at trial, however, including what is the ordinary meaning of a term, they should do so in a clearly designated section of their briefing. See Patent Trial and Appeal Board Consolidated Trial Practice Guide (Nov. 21, 2019) (“CTPG”), 46, 49 (available at https://www.uspto.gov/TrialPracticeGuideConsolidated); O2 Micro Int’l Ltd. v. Beyond Innovation Tech. Co., 521 F.3d 1351, 1361 (Fed. Cir. 2008) (“A determination that a claim term ‘needs no construction’ or has the ‘plain and ordinary meaning’ may be inadequate when a term has more than one ‘ordinary’ meaning or when reliance on a term’s ‘ordinary’ meaning does not resolve the parties’ dispute.”). Claim construction arguments should not be relegated to patentability arguments on the facts.” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner argues a person of ordinary skill in the art at the time of the invention “would have had at least [a] Master’s degree in materials science, chemistry, chemical engineering, a field relevant to polymer science and engineering, or the equivalent, and at least three years of experience in nanomaterials, electrochemistry, batteries, or polymer related activities.” Pet. 5 (citing Ex. 1003 ¶ 19). Petitioner further argues that “[a]dditional work experience can compensate for less formal education, and vice versa.” Id. Patent Owner does not dispute the level of ordinary skill in the art. Prelim. Resp. 4. For purposes of this decision, we adopt Petitioner’s definition of the level of ordinary skill in the art because it is consistent with the ’649 patent and the asserted prior art.” slip op. at 9
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 9,636,649 - PTAB · Dec 16, 2024 · IPR2024-01006 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted IPR of claims 1–8 on all petitioned grounds, finding a reasonable likelihood of success on the Ohata–Kavan obviousness challenge and no basis for discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the arguments and evidence set forth by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’909 patent. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review as to all of the challenged claims of the ’909 patent on all of the grounds of unpatentability set forth therein.” slip op. at 2
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“Contrary to Patent Owner’s arguments, the law on overlapping ranges in obviousness challenges is clear. See In re Peterson, 315 F.3d 1325, 1329 (Fed. Cir. 2003) (“A prima facie case of obviousness typically exists when the ranges of a claimed composition overlap the ranges disclosed in the prior art.”). Here, Petitioner directs us to evidence of an overlapping range, which is not meaningfully disputed by Patent Owner. As to Patent Owner’s arguments regarding the lower end of the claimed range of aspect ratios and Ohata’s warning about aspect ratios below 100, we note that Ohata states that its carbon nanotubes “preferably have an aspect ratio . . . of not less than 100,” and expressly includes examples with an aspect ratio of 50. Ex. 1004 ¶ 20 (emphasis added), Table 2 (Examples 12 and 14). Patent Owner also criticizes Petitioner for relying on oxidizing Ohata’s nanotubes in view of Kavan (discussed in more detail below). Prelim. Resp. 6. According to Patent Owner, oxidation is known to shorten the length of nanotubes, which would impact the aspect ratio of the nanotubes in the proposed combination. Prelim. Resp. 6. Specifically, Patent Owner contends that oxidizing Ohata’s nanotubes will reduce the aspect ratio below 100, and argues that “Petitioner has not explained why a [person of ordinary skill in the art] would ignore Ohata’s warning nor has Petitioner provided evidence that the resulting combination will perform as Petitioner alleges.” Prelim. Resp. 7; see also Prelim. Resp. 8 (arguing Petitioner has not explained why a person of ordinary skill in the art would try to retain Ohata’s aspect ratio and expect success when Ohata is altered in view of Kavan). Even giving Patent Owner’s arguments their full weight, there is no evidence on the present record as to how much the aspect ratio of Ohata’s nanotubes would be reduced as a result of oxidation. Rather, based on the present record, namely, the broad range of aspect ratios disclosed in Ohata (preferably 100–1000), it seems reasonably likely that the aspect ratio of at least some of the oxidized nanotubes in the proposed composition would remain within the range disclosed in Ohata and overlap the claimed range, as Petitioner asserts. Nevertheless, the parties may address during trial the expected level of carbon nanotube shortening in the proposed combination of Ohata and Kavan.” slip op. at 21
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner
“To the extent Patent Owner is presenting a teaching away argument, these statements do not rise to the level of criticizing, discrediting, or discouraging investigation into the claimed invention. DePuy Spine, Inc. v. Medtronic Sofamor Danek, Inc., 567 F.3d 1314, 1327 (Fed. Cir. 2009). Indeed, in addition to its statement regarding oxidation not being necessary for anchoring to TiO2, Kavan also states that oxidation of carbon nanotubes “was sometimes mentioned to improve anchoring of TiO2.” Ex. 1005, 2. Moreover, the full statement from Kavan regarding storage capacity reads: “The Li-storage capacity of TiO2 is not enhanced in the composite, but the rate of electrochemical charge transfer is higher due to nanotube networking.” Ex. 1005, 9. Thus, in its entirety, this statement supports Petitioner’s argument that there are advantages to using oxidized nanotubes, and, in turn, provides a reason why a person of ordinary skill in the art would have used oxidized nanotubes. Moreover, the evidence Petitioner presents regarding the use of oxidized nanotubes in combination with TiO2, coupled with Ohata’s statement that the electrode active material to be used can vary depending on the battery type (Ex. 1004 ¶¶ 26–27), undermines Patent Owner’s criticism that Petitioner’s arguments are circular.” slip op. at 24
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“Although the parties appear to agree that this factor is neutral, we note that a district court denial of a motion to stay without prejudice, accompanied by an indication that the district court would consider a renewed motion, “suggests the district court may be willing to avoid duplicative efforts and await the PTAB’s final resolution of the patentability issues raised in the petition before proceeding with the parallel litigation.” Fintiv at 6–7. “This fact has usually weighed against exercising authority to deny institution.” Id. (also noting that factors 2 and 3 are relevant to how much weight to give to the court’s willingness to reconsider a stay); see also T-Mobile, Paper 16 at 12 (noting that a stay was unlikely in that case given the proximity of the trial date to the entry of the institution decision). In view of the forgoing, we determine that Fintiv factor 1 weighs against exercising our authority to deny institution.” slip op. at 37
§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,808,909 - PTAB · Nov 29, 2024 · IPR2024-00133 · APJ Scott B Howard · IPR · Remand
On remand, the Board instituted IPR on claims 1–10 and all asserted grounds, finding a reasonable likelihood that claim 1 is obvious over Sturman and Ho.
RulingsRemand decision- RemandOther
“(“Decision Denying Institution” or “DDI”). Petitioner filed a request for Director Review and the Director vacated and remanded our Decision Denying Institution. Paper 11 (Petitioner’s Request for Director Review); Paper 12 (“Remand Dec.” or “Remand Decision”). Specifically, the Director directed that we: shall issue a new decision on institution resolving the claim construction of “a non-promotional background object.” Consistent with Phillips v. AWH Corp., 415 F.3d 1303, 1313–14 (Fed. Cir. 2005), the Board should resolve the proper meaning of that term by first assessing the intrinsic evidence, and then consulting extrinsic evidence if necessary. See, e.g., Samsung Elecs. Co., Ltd. v. Slyde Analytics, LLC, IPR2024-00040, Paper 14 at 7–8 (Vidal Aug. 2, 2024) (discussing the Phillips framework). The Board shall consider all remaining necessary issues, and determine whether to institute trial consistent with this decision. Id. at 7–8 (footnote omitted).” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“d) Conclusion Regarding Claim 1 Based on the current record, there is a reasonable likelihood that Petitioner will prevail in demonstrating that claim 1 is unpatentable as obvious in view of Sturman and Ho. 4. Analysis of Claims 2–10 Because Petitioner demonstrates a reasonable likelihood of success in proving that at least one claim of the ’089 patent is unpatentable, we institute on all grounds and all claims raised in the Petition. See 37 C.F.R. § 42.108(a). Therefore, at this stage of the proceeding, it is not necessary for us to provide an assessment of every challenge raised by Petitioner, especially, as in this case, when Patent Owner does not separately argue those claims. See Prelim. Resp. 26–36. Those challenges, in our view, are best left for trial after full development of the record.” slip op. at 42
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownOther
“draws a distinction between foreground and background objects. Specifically, the prosecution history makes it clear that foreground objects are “in the forefront of the game play as primary objects to be manipulated or used during game play” and that background objects are “outside the primary focus of game play and as unexpectedly interactive components.” Ex. 1002, 85. However, whether an object is “outside the primary focus of game play and as unexpectedly interactive components” is based solely on the subjective perspective of the user. That is, what one user may consider a primary focus or expected object, another might consider outside the primary focus and unexpected. As the Director made clear in the Remand Decision, it is “improper[]” to have a claim construction “based on the subjective perspective of a user.” Remand Dec. 7; see also Amazon.com, Inc. v. Barnesandnoble.com, Inc., 239 F.3d 1343, 1353 (Fed. Cir. 2001) (“We are not prepared to assign a meaning to a patent claim that depends on the state of mind of the accused infringer.”). Accordingly, we cannot and do not adopt that as our construction of the term background. Not finding a construction of “background” based on the intrinsic evidence, we turn to the extrinsic evidence. See Remand Dec. 7 (“[T]he Board should resolve the proper meaning of that term by first assessing the intrinsic evidence, and then consulting extrinsic evidence if necessary.” (emphasis added)). Specifically, as part of the Decision Denying Institution, we considered various dictionary definitions of the word “background.” According to those definitions, “background” refers to “[t]he part of a pictorial representation that appears to be in the distance and that provides relief for the principal objects in the foreground.” Ex. 3002 (AMERICAN HERITAGE DICTIONARY); see also Ex. 3003 (“the scenery or ground behind something,” “the part of a painting representing what lies behind objects in the foreground”) (MERRIAM-WEBSTER DICTIONARY). Consistent with those dictionary definitions, we construe the term “background” to mean the part of a pictorial representation that is not in the foreground. The prosecution history provides more useful guidance as to what a “non-promotional” object is. As the applicant argued in the Amendment discussed above, a non-promotional object is one “which does not have an ‘area’ in which advertisements directly appear, but instead represents a ‘hot spot’ that, upon activation, causes ‘hidden promotional content’ to then appear.” Ex. 1002, 85–86. In other words, a non-promotional object does not display a promotional message unless the hotspot is activated. This understanding of the meaning of non-promotional is consistent with an earlier argument (Ex. 1002, 113–25) the applicant made during the prosecution of the ’089 patent.12 At that time, the applicant argued: In an exemplary embodiment, the location in-game may be represented by a non-promotional object, such as a blank chalk board depicted in the background of the gaming environment. See Applicant’s Specification at ¶ [0045]. Upon activating the hot spot (e.g., by throwing a dart at the chalk board), a promotional message may be drawn on the chalk board and displayed to the user. See id. In other words, Applicant’s amended claims 15 and 22, inter alia, may present promotional content once the game user activates, unknowingly, a “hot spot” associated with a non-promotional object—the non-promotional object is not an ordinary or visible place for advertisement, the 12 This argument was made on December 2, 2011, which is prior to the amendment adding the term background on July 15, 2013. Compare Ex. 1002, 117 (then pending claim 15 without the word “background”) with id. at 80 (amendment adding “background” to claim 15). user does not know that the object has a hidden hot spot, and the user does not know that activating the hidden “hot spot” will display promotional content. Ex. 1002, 122 (emphasis added).” slip op. at 15
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDenied
“Moreover, even if we did consider only the specific references addressed in the Preliminary Response, we would not reach a different outcome. Patent Owner focuses on a high-level comparison of the references. See Prelim. Resp. 13–19. Such high-levels of similarity are to be expected as all of the references involve advertising in computer game programs. But such high-level similarity is not sufficient. See Juniper Networks, Inc. v. Swarm Tech. LLC, IPR2021-01445, Paper 15 at 16 (PTAB March 2, 2022) (Institution Decision) (“The issue is not just whether the same elements can be found in each of the references, but whether the elements function the same way. That is, even though Leong and Bates have the same elements, that does not mean that the elements interact with each other the same way or perform the same functions as recited in the claims.”); see also Advanced Bionics, IPR2019-01469, Paper 6 at 15 (holding that prior art is substantially the same if “Petitioner relies on [the new art] in substantially the same manner as the Examiner cited [the previous art] during prosecution such that [the new art] discloses substantially the same information as [the previous art] in relevant part.”); Nokia of Am. Corp. v. Alexander Soto, IPR2023-00680, Paper 18 at 7 (PTAB Mar. 28, 2024) (Vidal) (determining the Board erred when “rather than identify material, substantive overlap between the arguments presented in the Petitions and those previously presented to the Office, the Board’s analysis relied on its discussion of high-level similarities but lacked detailed reasoning”); Wolfspeed, Inc. v . The Trustees of Purdue University, IPR2022-00761, Paper 13 at 7 (PTAB Mar. 30, 2023) (Vidal) (vacating the Board’s decision when the “analysis of the first part of the Advanced Bionics framework did not consider sufficiently the material differences between” the art the Office previously considered and the art the Petition cited). Nor were any of Petitioner’s Reply arguments improper. We expressly authorized Petitioner to respond to Patent Owner’s arguments that the prior art relied on in the Petition was substantially the same as prior art that was considered. Ex. 3005 (Email from the Board to the parties) (“Petitioner is authorized to file a preliminary reply brief addressing 1) Patent Owner’s arguments under 35 U.S.C. 325(d). . . .”). Moreover, given the facts of this proceeding, it is not reasonable to require Petitioner to anticipate “substantially the same prior art” arguments and address them in the Petition. Accordingly, Petitioner’s argument is a proper reply argument. 3. Conclusion Based on our consideration of Becton Dickinson factors (a), (b), and (d), we find that the same or substantially the same art or arguments were not previously presented to the Office. Thus, our analysis ends at this point, and we need not proceed to part two of the Advanced Bionics framework. See Advanced Bionics, IPR2019-01469, Paper 6 at 8. We therefore decline to exercise our discretion to deny institution based on 35 U.S.C. § 325(d).” slip op. at 25
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,688,089
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.