- Micron Technology, Inc. v. Yangtze Memory Technologies Company, Ltd.Institution deniedPTAB · Aug 12, 2025 · IPR2025-00294 · APJ Kimberly Mcgraw · IPR · Institution
The Board denied institution because Patent Owner statutorily disclaimed all challenged claims: claims 6, 7, 10, and 20.
RulingsInstitution decision- Adverse judgmentAdverse judgmentDenied
“A disclaimer is “recorded” pursuant to 35 U.S.C. § 253(a) on the date that the Office receives a disclaimer meeting the above-listed requirements of 37 C.F.R. § 1.321(a) – no further action is required in the Office for a disclaimer to be “recorded.” Vectra Fitness, Inc. v. TNWK Corp., 162 F.3d 1379, 1382 (Fed. Cir. 1998).” slip op. at 3
NonePatents in suitUS 10,886,291 - Micron Technology, Inc. v. Yangtze Memory Technologies Co., Ltd.Institution deniedPTAB · Aug 8, 2025 · IPR2025-00244 · APJ Kimberly Mcgraw · IPR · Institution
The Board denied institution because the petition did not sufficiently show that Costa disclosed or suggested claim 11.H’s required arrangement, and the dependent claims did not cure that deficiency.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“In view of these deficiencies, the Petition fails to identify the proposed grounds for review with particularity as required by 35 U.S.C. § 312(a)(3) with respect to the limitations of independent claim [11.H]. Petitioner presents no arguments or evidence with respect to the dependent claims challenged under this ground that would remedy the defects noted above with respect to independent claim 11. See generally Pet. Thus, Petitioner has failed to demonstrate a reasonable likelihood that the subject matter of claims 11, 12, or 14–19 would have been obvious over Costa.” slip op. at 23
- BurdenDenied
“3. Analysis A petition is required to identify “with particularity[ ] the grounds on which the challenge to each claim is based, and the evidence that supports the grounds for the challenge.” 35 U.S.C. § 312(a)(3). The “petition . . . must include . . . [a] full statement of the reasons for the relief requested, including a detailed explanation of the significance of the evidence”). 37 C.F.R. § 42.22(a)(2). Our rules require that a petition include fully developed arguments. See 37 C.F.R. § 42.22(a)(2) (the “petition . . . must include . . . [a] full statement of the reasons for the relief requested, including a detailed explanation of the significance of the evidence”). The petition must include both an adequate explanation of how the claims should be construed as well as how the construed claims are unpatentable over the asserted prior art. 37 C.F.R. § 42.104(b)(3), (b)(4). Additionally, the “petition must specify where each element of the claim is found in the prior art.” 37 C.F.R. § 42.104(b)(4). A petition should also “explain why a person of ordinary skill in the art would have combined elements from specific references in the way the claimed invention does.” ActiveVideo Networks, Inc. v. Verizon Comm'ns, Inc., 694 F.3d 1312, 1328 (Fed. Cir. 2012). Thus, based on our rules, we only consider fully developed arguments set forth in the petition.” slip op. at 16
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITANot reached
“arguments. See, e.g., id. at 34–35 (arguing that “on” does not require overlap in the Z direction but “includes both objects that are merely touching (in any dimension) and objects that are in proximity to each other but not touching” (citing Ex. 1078, 1; Ex. 1001, 8:3–12)); see also id. at 36–38 (arguing that if “on” is construed to mean “directly on or on with an intermediate feature or layer therebetween,” then Costa’s second stacked layer 232, 242 and third channel structure (173) are “directly on” each other, because their edges are directly touching each other). The Petition, however, does not clearly present any of the claim construction arguments set forth in the Opposition Brief. See Paper 22 (not clearly identifying where the Petition provides the proposed claim construction); see generally Pet.; see also Pet. 33, 43, 56 (arguing “on” does not require “directly on” and permits intermediate layers but not presenting any of the other claim construction arguments set forth in the Opposition Brief). Nor did the Petition provide any particularized argument as to how Costa discloses or suggests a second stacked layer disposed on the third channel structure applying any of the claim constructions proposed in the Opposition Brief. See generally Pet. (presenting no argument that Costa’s second stacked layer 232, 242 is “on” semiconduction portion layer 173 (the asserted third channel structure) because they touch each other as shown above in Petitioner’s annotation of Costa Figure 21A). We will not consider any arguments not sufficiently set forth in the Petition. See 37 C.F.R. § 42.104(b)(3) (“the petition must set forth . . . [h]ow the challenged claim is to be construed”); 37 C.F.R. § 42.104(b)(4) (“the petition must set forth . . . [h]ow the construed claim is unpatentable”).” slip op. at 19
- Parallel petitionsNot reached
“Because we determine that Petitioner did not show a reasonable likelihood that it would prevail on the merits, we do not address Patent Owner’s parallel petitions argument.” slip op. at 23
Claim constructionDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,886,291 - PTAB · Jul 25, 2025 · IPR2025-00191 · APJ Michael T Cygan · IPR · Institution
The Board instituted review on all challenged grounds for non-disclaimed claims 3, 6, 8–20; it found a reasonable likelihood of success for claims 8–12 and 19.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons discussed below, we determine that Petitioner has sufficiently shown a reasonable likelihood that it will prevail as to the unpatentability of claims 8–12 and 19 of the ’322 patent but has not sufficiently shown a reasonable likelihood that it will prevail as to the unpatentability as to claims 3, 6, 13–17, and 20. Because Petitioner has sufficiently shown a reasonable likelihood that at” slip op. at 2
- Adverse judgmentAdverse judgmentOther
“B. Patent Owner’s Disclaimer of Claims 1, 2, 4, 5, and 7 As indicated above, Patent Owner filed a statutory disclaimer of claims 1, 2, 4, 5, and 7 of the ’322 patent. See Ex. 2006. In view of Patent Owner’s statutory disclaimer, we treat claims 1, 2, 4, 5, and 7 as having never been part of the ’322 patent. See Vectra Fitness, Inc. v. TNWK Corp., 162 F.3d 1379, 1383 (Fed. Cir. 1998) (“This court has interpreted the term ‘considered as part of the original patent’ in [35 U.S.C.] § 253 to mean that the patent is treated as though the disclaimed claims never existed.”). Because inter partes review cannot be instituted based on disclaimed claims, claims 1, 2, 4, 5, and 7 are outside the scope of this proceeding. 37 C.F.R. § 42.107(e) (“No inter partes review will be instituted based on disclaimed claims.”); General Elec. Co. v. United Techs. Corp., IPR2017- 00491, Paper 9 (PTAB July 6, 2017) (precedential) (denying institution in view of a statutory disclaimer of all the challenged claims). Thus, we confine our analysis in this Decision to claims 3, 6, and 8–20, the challenged claims that have not been disclaimed.” slip op. at 3
- Other 314aDenied
“Patent Owner filed a Brief on Discretionary Denial, and Petitioner filed a brief in opposition. Papers 10 and 18. The Director considered the briefing and determined that discretionary denial was not warranted. Paper 21.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“at the critical time “would have had a Bachelor of Science degree in electrical engineering or a similar discipline, along with 2–3 years of professional experience working with (e.g., researching, designing, or teaching) monolithic 3D structures and NAND memory devices, or an equivalent level of skill, knowledge, and experience (e.g., an advanced degree may replace some of the professional experience).” Pet. 27 (citing Ex. 1003 ¶¶ 34–38). Petitioner further asserts that a POSITA “would have been aware of and generally knowledgeable about 3D NAND’s structure, how it is manufactured, and its component parts.” Id. Patent Owner does not provide any such assessment in its Preliminary Response. Prelim. Resp. 8; Ex. 2007 ¶ 22 (reserving the right to opine as to an alternative level of a POSITA). For purposes of this Decision, we adopt Petitioner’s proposed level of ordinary skill, as it appears to be consistent with the specification of the ’322 patent and the prior art of record.” slip op. at 8
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 11,581,322 - PTAB · Jun 25, 2025 · IPR2024-01406 · APJ Jo-Anne M Kokoski · IPR · Remand
On remand, the Board denied institution of review of claims 1, 3, 4, 8–13, and 15 under § 314(a), finding the Fintiv factors favored discretionary denial.
RulingsRemand decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“stay or evidence exists that one may be granted if a proceeding is instituted.” Fintiv, Paper 11 at 6. A stay of litigation pending resolution of an inter partes review allays concerns about inefficiency and duplication of efforts, and strongly weighs against exercising our authority to deny institution. Fintiv, Paper 11 at 6. The Guidance Memo states that “the Board will apply the Fintiv factors when there is a parallel proceedings at the International Trade Commission.” Guidance Memo 2. Patent Owner asserts that a stay of the ITC Investigation had not been requested at the time of the Institution Decision,7 and argues that “the ITC does not stay investigations pending IPR.” PO Supp. Br. 4. Patent Owner also notes that the Institution Decision issued “just days before the ITC evidentiary hearing.” Id. Accordingly, Patent Owner argues that this factor favors denial. Id. Patent Owner is likely correct that the ITC would not have been inclined to grant a stay if one had been requested at the time the Institution Decision issued. Moreover, the ITC conducted a full evidentiary hearing less than three weeks after the Institution Decision issued, and the target date for the ITC’s final determination is four months before the statutory deadline for the Board’s final written decision. PO Supp. Br. 5. Accordingly, we” slip op. at 9
Discretionary denialPatents in suitUS 11,925,202 - PTAB · Jun 18, 2025 · IPR2025-00321 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR on claims 1, 2, 5–7, 9, 16, and 17, finding a reasonable likelihood that claim 1 is anticipated by Boyer.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“approximately two weeks before the statutory deadline for a final written decision, but the most recent median time-to-trial statistics for Judge Gilstrap in the Eastern District of Texas indicate that the actual trial date will likely be in July 2026, which is later than the statutory deadline to issue a final written decision in this proceeding in mid-June 2026. See Ex. 2001, 7 (median time from filing to trial of 23.2 months); Prelim. Resp. 10. Thus, we find this factor is neutral or weighs slightly against discretionary denial.” slip op. at 10
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this preliminary stage, we determine whether the information presented shows a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been unpatentable over the proposed prior art. We analyze the asserted grounds with the above-noted principles in mind.” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had (1) at least a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a related field, and (2) at least two years of research or industry experience in 3D printing or materials used for 3D printing.” Pet. 5 (citing Ex. 1003 ¶¶ 14–16). Petitioner also argues that “[a]dditional experience could substitute for a formal degree or formal training (and vice versa).” Id. Patent Owner proposes a slightly different level of skill, arguing that a person of ordinary skill in the art “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 24. Neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears to be consistent with the ’713 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 16
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction needed
“We note that, as discussed below, we are able to determine whether to institute inter partes review of the ’713 patent without expressly construing the term “from multiple print heads or deposition lines.” See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). As for Patent Owner’s argument that Petitioner has failed to carry its burden to identify how the claims are to be construed, we disagree on the present record. Although Petitioner does not provide a preferred construction for the single term it proposes requires construction, Petitioner does identify which of its two alternative constructions applies to each of its asserted grounds of unpatentability. Pet. 6 (“Under the first construction, [the obviousness grounds] are applicable, and [the anticipation ground] would be excluded from the claim scope. Under the alternative construction, all of [the asserted grounds] are applicable.”). In our view, this approach does not fail to satisfy Petitioner’s burden under 37 U.S.C. § 42.104(b)(3).” slip op. at 17
Claim construction§ 102 anticipationDiscretionary denialcites PhillipsPatents in suitUS 9,421,713 - PTAB · Jun 10, 2025 · IPR2025-00098 · APJ Michael T Cygan · IPR · Institution
The Board instituted IPR on claims 1–4, 6–10, 12–13, 16–18, 23–26, 28, 30, and 32 on all asserted grounds, finding a reasonable likelihood that claim 1 would have been obvious over Chae.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“1. Legal Standards “In an [inter partes review], the petitioner has the burden from the onset to show with particularity why the patent it challenges is unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016) (citing 35 U.S.C. § 312(a)(3) (requiring inter partes review petitions to identify “with particularity . . . the evidence that supports the grounds for the challenge to each claim”)); see also 37 C.F.R. § 42.104(b) (requiring a petition for inter partes review to identify how the challenged claim is to be construed and where each element of the claim is found in the prior art patents or printed publications relied upon). Anticipation “requires that every element and limitation of the claim was previously described in a single prior art reference, either expressly or inherently, so as to place a person of ordinary skill in possession of the invention.” Sanofi-Synthelabo v. Apotex, Inc., 550 F.3d 1075, 1082 (Fed. Cir. 2008). Anticipation also requires that a reference discloses “all of the limitations arranged or combined in the same way as recited in the claim.” Net MoneyIN, Inc. v. VeriSign, Inc., 545 F.3d 1359, 1371 (Fed. Cir. 2008).” slip op. at 9
- PTAB / AIA Trials › Real party in interest / privityDecided for petitioner
“Even assuming, arguendo, that the “Chinese government” or YMTC Holding constitute an unnamed RPI, Patent Owner does not sufficiently show that the failure identify the RPI is a reason to decline to institute this proceeding. Patent Owner has not asserted that a statutory bar or other 7 Patent Owner refers to the “Chinese government” as an unnamed RPI but does not identify what the “Chinese government” is. See, e.g., Prelim. Resp. 3–5 (referring to “China’s State Council”), 6 (municipal governments), 7–8 (identifying the seven shareholders of YMTC Holding as “state-owned enterprises”), 8 (stating the actual controller of the Yangtze River Industrial Investment Group is the “administration of Wuhan East Lake High-tech Development Zone”), 8 (stating the actual controller of the Yangtze River Industrial Group is the “Hubei Provincial State-owned Assets Supervision and Administration Commission”). 8 More particularly, Patent Owner identifies YMTC’s parent as Yangtze Memory Technologies Holding Co., Ltd. (“YMTC Holding” or “YMTH”). Prelim. Resp. 7 (citing Ex. 2021 (“YMTC’s Corporate Disclosure Statement), 2). estoppel would apply to either the Chinese government or YMTC Holding in this proceeding. 35 U.S.C. § 315(b); SharkNinja Operating LLC v. iRobot Corp., IPR2020-00734, Paper 11, 18 (PTAB Oct. 6, 2020) (precedential); Lumentum Holdings, Inc. v. Capella Photonics, Inc., IPR2015-00739, Paper 38 at 6 (PTAB Mar. 4, 2016) (precedential) (stating that a petition may be corrected, including adding a real party in interest, without assigning a new filing date); see also Paper 9 (granting Petitioner’s unopposed motion to amend its mandatory notices to add a subsidiary of YMTI as an RPI without changing the filing date). Indeed, in Unified Patents, LLC v. MemoryWeb, LLC, the Director instructed that the precedential SharkNinja decision held that it “best serves the Office’s interests in cost and efficiency to not resolve an RPI issue when it would not create a time bar or estoppel under 35 U.S.C. § 315 in that proceeding.” Unified Patents, LLC v. MemoryWeb, LLC, IPR2021-01413, Paper 76 at 4 (PTAB May 22, 2023) (“Unified Patents”) (vacating the Board’s RPI determination in the Final Written Decision as not necessary to resolve the proceeding, such as a time bar under § 315(b) or estoppel under 35 U.S.C. § 315(e)). Here, as neither the Chinese government nor YMTC Holding have been sued for patent infringement, Patent Owner has not shown that a determination of whether the Chinese government or YMTC Holding are an RPI, or are in privity with Petitioner, would impact the underlying proceeding or result in a time bar or estoppel. As such, we do not address Patent Owner’s RPI argument. We have also considered Patent Owner’s contention that the Chinese government may file additional IPR proceedings through other Chinese semiconductor companies, such as Fujian Jinhua Integrated Circuit Co., Ltd., if this petition is denied or unsuccessful and that real party in interest provisions seek to protect patent owners from harassment via “successive petitions by the same or related parties.” Prelim. Resp. 25; see also Unified Patents¸ Paper 76 at 5 (noting Petitioner’s argument that a non-binding advisory opinion on RPI would prejudice the asserted RPI parties by prejudging the issue without their participation). Concerns that future petitions may be filed by parties that are the same or related to Petitioner may be addressed in any such future proceeding. See Patent Trial and Appeal Board Consolidated Trial Practice Guide (Nov. 2019)9 (“Consolidated TPG”), 55–63; General Plastic Co., Ltd. v. Canon Kabushiki Kaisha, IPR2016-01357, Paper 19 at 15–18 (PTAB Sept. 6, 2017) (precedential) (recognizing the “potential for abuse of the review process by repeated attacks on patents” and setting forth factors to consider in exercising discretion on instituting inter partes review as to “follow-on” petitions challenging the same patent previously challenged in an inter partes review proceeding). As such, we do not deny institution for Petitioner’s alleged failure to list all RPIs.” slip op. at 19
- Other 314aInstitution denied discretionary otherDenied
“We are not persuaded by Patent Owner’s arguments. To date, the Director has not provided any guidance as to when a panel should deny institution based on foreign policy or national security implications, applicable to the facts presented here. To the contrary, the USPTO has expressly determined that Board panels, in considering discretionary denial sought in a Preliminary Response filed on or before March 26, 2025, may not consider such factors. FAQs for Interim Processes for PTAB Workload Management, FAQ 5, https://www.uspto.gov/patents/ptab/faqs/interim-processes-workload-management (stating, “The panel will not address any new factors outlined in the Process Memorandum”). Accordingly, we decline to exercise discretion to deny institution for this requested reason.” slip op. at 22
- Skill levelSkill level petitioner adoptedOther
“time it was made, we consider the level of ordinary skill in the pertinent art at the time of the invention. Graham, 383 U.S. at 17. Petitioner contends that a person of ordinary skill in the art (“POSITA”) would have had a Bachelor’s degree in electrical engineering, materials science, or physics, or a closely related field, along with at least two years of experience in semiconductor fabrication and that a higher level of education might make up for less experience, and vice versa. Pet. 10 (citing Ex. 1003 ¶¶ 57–58). At this stage of the proceeding, Patent Owner neither responds to Petitioner's proposed definition, nor provides a definition of its own. See Prelim. Resp. Petitioner’s undisputed proposed definition appears to be consistent with the cited prior art and the disclosure of the ’996 patent, and we adopt it for purposes of this Decision.” slip op. at 10
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,945,996 - PTAB · Jun 10, 2025 · IPR2025-00189 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board instituted IPR of claim 19 on all asserted grounds because Petitioner showed a reasonable likelihood of prevailing; it declined discretionary denial based on the parallel district court case.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“proceeding was temporarily stayed pending consideration of Petitioner’s motion for a stay in light of the filed inter partes review proceedings. Prelim. Resp. 32 (citing Ex. 2001; Ex. 2003). Subsequently, Patent Owner notified the Board that the parallel proceeding “was stayed pending resolution of related IPR proceedings.” Paper 10, 1; see also Ex. 3001 (district court order granting motion to stay case). Accordingly, we determine that Fintiv factor 1 weighs strongly against exercising our authority to deny institution. See Snap, Inc. v. SRK Technology, Inc., IPR2020-00820, Paper 15 at 9 (PTAB Oct. 21, 2020) (precedential) (“The granting of a stay pending inter partes review has weighed strongly against exercising discretion to deny institution under NHK.”).” slip op. at 8
- Skill levelSkill level petitioner adoptedDecided for petitioner
“(“POSITA”) “would have had a bachelor’s degree in electrical engineering or a similar discipline, along with 2–3 years of professional experience working with (e.g., researching, designing, or teaching) 3D memory devices, or an equivalent level of skill, knowledge and experience (e.g., an advanced degree may substitute for professional experience).” Pet. 24–25 (citing Ex. 1003 ¶¶ 34–37). Petitioner further contends that the “POSITA would also have been aware of and generally knowledgeable about 3D memory’s structure, its component parts, and how it operates.” Id. at 25 (citing Ex. 1003 ¶¶ 34–37). Patent Owner “takes no position on the level of ordinary skill in the art” as this stage of the proceeding. Prelim. Resp. 6. Petitioner’s undisputed proposed definition appears to be consistent with the cited prior art and the disclosure of the ’666 patent, and we adopt it” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“C. Claim Construction We construe each claim “in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” 37 C.F.R. § 42.100(b). Under this standard, claim terms are generally given their plain and ordinary meaning as would have been understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. Phillips v. AWH Corp., 415 F.3d 1303, 1313 (Fed. Cir. 2005) (en banc). Only those terms in controversy need to be construed, and only to the extent necessary to resolve the controversy. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019). Based on the record before us, we determine that no claim term requires express construction for purposes of this Decision.” slip op. at 13
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314; see also 37 C.F.R. § 42.4. For the reasons discussed below, we determine that Petitioner establishes a reasonable likelihood of prevailing with respect to the unpatentability of claim 19. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314. Accordingly, we institute an inter partes review of claim 19 of the ’666 patent.” slip op. at 2
Claim construction§ 103 obviousnessDiscretionary denialcites PhillipsPatents in suitUS 11,145,666 - Njoy, LLC / Njoy Holdings, Inc. v. Juul Labs, Inc.No claims unpatentablePTAB · Jun 10, 2025 · IPR2024-00231 · APJ Avelyn M Ross · IPR · Final written decision
Claims 14–16, 18, 27–29, 31, and 32 were not proven unpatentable because the asserted references failed to establish the claimed airflow path or a reason to make the proposed combinations.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner’s and Patent Owner’s proposed levels of skill are similar and differ in that Petitioner’s relevant degrees and corresponding two years of experience additionally includes “industrial design” and “product design” and familiarity with “electrically powered vaporizing articles, their components or the underlying technologies” where Patent Owner requires two years of experience “designing electro-mechanical consumer products or an advanced degree.” Compare Pet. 7, with PO Resp. 2. Patent Owner alleges that “Petitioner has failed to establish unpatentability under either standard,” indicating that the level of skill in the art is not a dispositive issue. PO Resp. 3. In light of the record before us, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art. Based on our review of the ’123 patent and the prior art of record, we determine that the definition offered by Petitioner comports with the qualifications a person would have needed to understand the ’123 patent and the prior art. We note that the outcome of this Decision would be the same under Patent Owner’s proposed definition.” slip op. at 11
- Expert testimonyPetitioner expert creditedOther
“In this case, Mr. McAlexander meets both Petitioner’s and Patent Owner’s proposed level of skill in the art. As a result, we are persuaded Mr. McAlexander has the requisite skill and relevant expertise to offer testimony in this matter. For example, Mr. McAlexander has a Bachelor’s Degree in Electrical Engineering and far more than 2 years of experience in the electrical engineering field. Ex. 1027, 3–6, 7. In addition, Mr. McAlexander has provided expert consulting services in a wide range of technology areas involving the process and design of electro-mechanical consumer products. Ex. 1003 ¶ 5. Through one of Mr. McAlexander’s business ventures, his laboratory has “performed detailed airflow analyses, designing and constructing specialized apparatuses to emulate human breath, allowing for precise activation testing of ENDS devices.” Ex. 1043 ¶ 16. That said, a declarant’s expertise, even clothed as a skilled artisan, does not entitle a naked opinion persuasive weight. Ashland Oil, Inc. v. Delta Resins & Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985). Here, Patent Owner had the opportunity to, and in fact did, thoroughly cross examine Mr. McAlexander about the purported deficiencies in his testimony. See, e.g., Exs. 2052, 2054; Daubert v. Merrell Dow Pharm., Inc., 509 U.S. 579, 595 (1993) (“Vigorous cross examination [and] presentation of contrary evidence . . . are the traditional and appropriate means of attacking shaky but admissible evidence.”). Therefore, to the extent Patent Owner credibly identifies deficiencies in Mr. McAlexander’s testimony or that testimony lacks factual support or is based on broad, conclusory assertions, we will assign appropriate weight. See Velander v. Garner, 348 F.3d 1359, 1371 (Fed. Cir. 2003) (explaining that it is within the Board’s discretion, as the trier of fact, to accord appropriate weight to the evidence presented).” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner contends that the parties proposed a construction for “pressure valve,” a limitation appearing in claims 18 and 31, during the ITC investigation. Pet. 7 (citing Ex. 1001, 41:58–65). Patent Owner contends that the terms of the ’123 patent should be given their plain and ordinary meaning. PO Resp. 4. Because resolution of the issues presented in this case do not require construction of the term “pressure valve,” we do not expressly construe this claim term. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (holding that “only those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs. in the context of an inter partes review).” slip op. at 14
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“We agree with Patent Owner. To anticipate a claim, a reference “must not only disclose all elements of the claim within the four corners of the document, but must also disclose those elements ‘arranged as in the claim.’” Net MoneyIN, 545 F.3d at 1369. “The requirement that the prior art elements themselves be arranged as in the claim means that the claims cannot be treated . . . as mere catalogs of separate parts, in disregard of the part-to-part relationships set forth in the claims.” Therasense, Inc. v. Becton, Dickinson & Co., 593 F.3d 1325, 1332 (Fed. Cir. 2010). Indeed, the prior art reference “must clearly and unequivocally disclose the claimed [invention] or direct those skilled in the art to the [invention] without any need for picking, choosing, and combining various disclosures not directly related to each other by the teachings of the cited reference.” Net MoneyIN, 545 F.3d at 1371 (citation omitted). “[D]ifferences between the prior art reference and the claimed invention, however slight, invoke the question of obviousness, not anticipation.” Id.” slip op. at 20
Patent outcomesUS 10,130,123 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,130,123 - Juul Labs, Inc. v. Njoy, LLCNo claims unpatentablePTAB · May 21, 2025 · IPR2024-00161 · APJ Christopher M Kaiser · IPR · Final written decision
Claims 1–27 were not shown unpatentable because the asserted obviousness grounds failed to establish the claimed central airflow passageway or a reason to combine the references.
RulingsFinal written decision- Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner
“Relying on the testimony of Patent Owner’s declarant Dr. Singhose, Petitioner argues that a person of ordinary skill in the art “would have known a central straight path has less airflow resistance than a circuitous one.” Reply 22–23 (citing Ex. 1035, 127:15–128:9). But the same witness also testified that higher airflow resistance might be desirable and explained that providing more resistance to airflow might result in improved mixing. Ex. 1035, 21:21–22:12, 127:20–24, 170:10–14. In addition, Dr. Singhose testifies that the complicated design of the airflow passageway in Xia “serves important functions,” including “allow[ing] large droplets to be reabsorbed by the liquid-guiding mechanism,” allowing “excessive liquid in the airflow [to] condense,” and “prevent[ing] the chemical liquid from being sucked into the mouth.” Ex. 2022 ¶ 183 (citing Ex. 1004, 11, 13–14, 16). Although Petitioner’s declarant Dr. Sturges testifies that a straight airflow passageway “would provide improved, smoother air flow,” he does not provide any evidence supporting the view that the air flow would be improved. Ex. 1007 ¶ 118. We credit the testimony of Dr. Singhose that using a straight passageway in Xia would have been detrimental rather than beneficial. Ex. 2022 ¶ 183. Petitioner also argues that the inventors’ use of a straight path is evidence that the use of a straight passageway was “merely common-sense obviousness.” Reply 22–23. This is hindsight. Otsuka Pharm. Co. v. Sandoz, Inc., 678 F.3d 1280, 1296 (Fed. Cir. 2012) (“The inventor’s own path itself never leads to a conclusion of obviousness; that is hindsight.”). Moreover, it does not address the testimony of Dr. Singhose that the use of a complicated passageway like that in Xia had benefits not present in a straight central passageway.” slip op. at 29
- Skill levelSkill level petitioner adoptedOther
“B. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art (“POSITA”) “would have had a mechanical or electrical engineering degree, industrial design degree, or a similar technical degree, or equivalent work experience, and 5 to 10 years of experience in electromechanical devices.” Pet. 10 (citing Ex. 1007 ¶ 16). Prior to institution, Patent Owner stated that, for “the limited purpose of this Preliminary Response,” it “does not challenge the definition of a POSITA set forth in the Petition.” Prelim. Resp. 9. We adopted Petitioner’s proposed definition in our Decision granting institution. During trial, neither party disputed this definition. Upon a complete record, we see no reason to change the adopted definition.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“Patent Owner argues, however, that this presumption is overcome in the present case, and we agree. PO Resp. 28–32. We note that, although the claims require the first aperture to be “on the first end,” the claims still require that the “housing hav[e] a first aperture.” Thus, the issue is whether the aperture must be on the housing itself or part of the housing, as well as whether the aperture is on the first end of the housing. Although “having” and “includes” are used with respect to the solution holding medium to refer to elements located inside the housing, the specification of the ’881 patent suggests that the ends of the housing are part of the housing itself, rather than located inside the housing. First, “the first end . . . can be integrated into a single assembly as part of the housing.” Ex. 1001, 6:16–17. Second, “the housing . . . may comprise the cylindrical wall and two end-caps,” or “the housing . . . may comprise the cartridge wall and a single end-cap.” Id. at 3:55–59. The only figures of the ’881 patent that depict first end 206 show it at the end of the housing rather than located within the interior of housing 202. Id. at Figs. 2, 3. Moreover, there is no requirement to construe a claim term uniformly across multiple uses in the claims when doing so would be nonsensical. Microprocessor Enhancement Corp. v. Texas Instruments, Inc., 520 F.3d 1367, 1375 (Fed. Cir. 2008). Here, construing a first element that is recited as “having” or “includ[ing]” a second element always as encompassing not only second elements that are part of the first element, but also second elements that are located within the interior of the first element, would lead to nonsensical results. Claim 2 recites an airflow passageway “having a length having a circular cross section.” Ex. 1001, 17:59–60. It would be nonsensical to interpret this claim as encompassing an airflow passageway of non-circular cross section that contains another object that has a circular cross section, and neither party argues in favor of such a reading. Similarly, claim 16 recites an “airflow passageway having an interior having a uniform cross-sectional area,” and there is no reason to interpret this claim as encompassing an airflow passageway of non-uniform cross-sectional area that contains another object that itself has uniform cross-sectional area. Id. at 19:47–48. Thus, the claims do not use “having” or “includes” consistently to refer to elements located within the interior of an object; instead, they sometimes use these terms to refer to elements that are a part of an object. See Epcon Gas Sys., Inc. v. Bauer Compressors, Inc., 279 F.3d 1022, 1030–31 (Fed. Cir. 2002) (terms should be construed based on the context of how the terms are used in the claims).” slip op. at 13
- Prior constructionPrior construction not adoptedDecided for patent owner
“When we instituted trial, we preliminarily construed this phrase to encompass apertures that are located within the first end of the housing, determining on the record available at that time that “[t]he term does not require that the first aperture be located in the housing itself.” Inst. Dec. 16. We invited the parties to “address [the] construction of this term during trial,” id., and, on the full record developed during trial, we reach a different conclusion.” slip op. at 10
Patent outcomesUS 10,334,881 not shown unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,334,881 - PTAB · May 16, 2025 · IPR2025-00034 · APJ Michael T Cygan · IPR · Institution
The Board instituted IPR on claims 2–4, 7–15, 17, 18, and 20 under §103 over Nakajima; it found a reasonable likelihood of success for claims 3, 4, 9, 10, 18, and 20.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“exists that one may be granted if a proceeding is instituted. Fintiv, Paper 11 at 6–7. Petitioner asserts that factor 1 is neutral. Pet. 10. Patent Owner contends that factor 1 favors denial because, although an opposed motion to stay has been filed in the parallel litigation, it is unlikely to be granted. Prelim. Resp. 31. However, subsequent to filing its Preliminary Response, Patent Owner notified the Board that the parallel court proceeding has been stayed pending the outcome of the inter partes review. Paper 13, 1. The granting of a stay pending inter partes review “has weighed strongly against exercising discretion to deny institution.” Snap, Inc. v. SRK Technology LLC, IPR2020-00820, Paper 15 at 9 (P.T.A.B. October 16, 2019) (precedential). The stay of the parallel proceeding results in factor 1 weighing strongly against exercising discretion to deny institution.” slip op. at 7
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We determine that Petitioner has not shown a reasonable likelihood of success of proving its obviousness assertions for claim 2 because of insufficiently explained and inadequately supported reasons to combine the knowledge in the art with Nakajima to teach or suggest claim 2’s “dummy channel” limitation. The deficiencies in Petitioner’s showing extend to claim 11, which recites a “dummy channel” limitation, and its dependent claims 12–15 and 17. Ex. 1001, 21:35–22:19, 22:22–26. Consequently, Petitioner has not shown it is likely to succeed on its obviousness challenges to claims 2, 11–15, and 17.” slip op. at 19
- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art Petitioner asserts that a person of ordinary skill in the art (“POSITA”) at the critical time “would have had a bachelor of science degree in electrical engineering or a similar discipline, along with 2–3 years of professional experience working with (e.g., researching, designing, or teaching) monolithic 3D structures and NAND flash memory devices, or an equivalent level of skill, knowledge, and experience (e.g., an advanced degree may replace some of the professional experience).” Pet. 25 (citing Ex. 1003 ¶¶ 34–38). Petitioner further asserts that a POSITA “would have been aware of and generally knowledgeable about 3D NAND’s structure, how it is manufactured, and its component parts.” Id. Patent Owner does not provide any such assessment in its Preliminary Response. Prelim. Resp. 8. For purposes of this Decision, we adopt Petitioner’s proposed level of ordinary skill, as it appears to be consistent with the specification of the ’254 patent and the prior art of record.” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“Claim Construction Neither party proposes any express claim construction. Pet. 35 (stating claims should receive their “plain and ordinary meaning”); Prelim. Resp. 8 (stating that Petitioner’s challenges fail “under any reasonable construction”). In an inter partes review, we construe a patent claim “using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. [§] 282(b).” 37 C.F.R. § 42.100(b). Under this standard, the words of a claim generally are given their “ordinary and customary meaning,” which is the meaning the term would have to a person of ordinary skill at the time of the invention, in the context of the entire patent including the specification. Phillips v. AWH Corp., 415 F.3d 1303, 1312–13 (Fed. Cir. 2005) (en banc). We determine no terms require express construction for purposes of this Decision.” slip op. at 14
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 10,879,254
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.