- Palo Alto Networks, Inc. / Cisco Systems, Inc. et al. v. Centripetal Networks, Inc.All claims unpatentablePTAB · Jun 11, 2026 · IPR2022-01199 · APJ Kevin F Turner · IPR · Remand
On remand, the Board held claims 1, 24, and 25 unpatentable as obvious over Buruganahalli; the copying evidence did not outweigh the strong obviousness showing.
RulingsRemand decision- RemandOther
“Scope on Remand On remand, the panel here will not address issues outside the scope of the Federal Circuit’s mandate. See Hayward Indus., Inc. v. Pentair Water Pool & Spa, Inc., 814 F. App’x 592, 597 (Fed. Cir. 2020) (“The Board is bound by the terms of a mandate issued by an appellate court. Aydin Corp. v. Widnall, 121 F.3d 726, 1997 WL 413329, at *3 (Fed. Cir. 1997). ‘Unless remanded by [an appellate] court, all issues within the scope of the appealed judgment are deemed incorporated within the mandate and thus are precluded from further adjudication.’ Engel Indus., Inc. v. Lockformer Co., 166 F.3d 1379, 1383 (Fed. Cir. 1999).”). The sole issue on remand is whether “the evidence of copying” is sufficient to overcome the obviousness ground of unpatentability over Buruganahalli. Centripetal Networks, 19–20. We restate portions of the former Final Written Decision, as an aid to the reader, but substantially incorporate the analysis of the prior Decision below. C.” slip op. at 4
- Director reviewDirector review, deniedDenied
“not object to a new panel of APJs hearing this case if remanded.” Id. at 20. As such, Patent Owner requested Director Review (Paper 74), asking that the Director “de-institute,” based on an abuse of discretion. The Director (Paper 75) denied the request and directed the Board to assign a new panel on remand (see Papers 76, 77). B.” slip op. at 3
- Skill levelOther
“Level of Ordinary Skill in The Art We adopt the level of ordinary skill in the art adopted in the prior Decision. See Decision 25. F.” slip op. at 13
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“This argument is unpersuasive because Buruganahalli uses rules/policies to filter encrypted packets by correlating them with handshaking packets that have unencrypted data, in the same way that is done in the ‘856 Patent. The only “filtering step” in the patent that “use[s] rules to filter encrypted packets without decryption” (PO Resp. 20) is the hello message approach used, for example, at steps 19 and 23 (see id.), which is clearly disclosed in Buruganahalli.7 As explained above, the ‘856 Patent does not describe applying rules to encrypted packets. Instead, it describes (a) filtering encrypted packets by correlating them with unencrypted data in other packets and (b) by decrypting the packets and applying the rules that are recited in the claims to unencrypted data. As also explained above, the amendment added the rules of step 22, which are applied to decrypted data, to a claim that was drafted to cover filtering of encrypted packets. However, among the criteria used in the filtering performed at step 22 is a “uniform resource identifier (URI),” which, we conclude, covers Buruganahalli’s “domain name.” Thus, despite the error made during prosecution, the claims that issued cover Buruganahalli’s method of determining that a session should be filtered based on a domain name in unencrypted handshake data.” slip op. at 28
Patent outcomesUS 9,917,856 unpatentable§ 103 obviousnessPatents in suitUS 9,917,856 - Palo Alto Networks, Inc. / Cisco Systems, Inc. et al. v. Centripetal Networks, Inc.All claims unpatentablePTAB · Jun 11, 2026 · IPR2022-00182 · APJ Kevin F Turner · IPR · Remand
On remand, claims 1, 24, and 25 are unpatentable under § 103 over Buruganahalli; the evidence of copying does not outweigh the strong obviousness showing.
RulingsRemand decision- RemandOther
“Scope on Remand On remand, the panel here will not address issues outside the scope of the Federal Circuit’s mandate. See Hayward Indus., Inc. v. Pentair Water Pool & Spa, Inc., 814 F. App’x 592, 597 (Fed. Cir. 2020) (“The Board is bound by the terms of a mandate issued by an appellate court. Aydin Corp. v. Widnall, 121 F.3d 726, 1997 WL 413329, at *3 (Fed. Cir. 1997). ‘Unless remanded by [an appellate] court, all issues within the scope of the appealed judgment are deemed incorporated within the mandate and thus are precluded from further adjudication.’ Engel Indus., Inc. v. Lockformer Co., 166 F.3d 1379, 1383 (Fed. Cir. 1999).”). The sole issue on remand is whether “the evidence of copying” is sufficient to overcome the obviousness ground of unpatentability over Buruganahalli. Centripetal Networks, 19–20. We restate portions of the former Final Written Decision, as an aid to the reader, but substantially incorporate the analysis of the prior Decision below. C.” slip op. at 4
- Obviousness (§103) › Objective indicia / secondary considerations › CopyingObjective indicia outweighedNot shown unpatentable
“given to the Eastern District of Virginia court’s opinion because it was later vacated. The district court considered all of the Read factors (applying Read Corp. v. Portec, Inc., 970 F.2d 816, 826-827 (Fed. Cir. 1992)), of which only the first factor is directed to deliberate copying, although factors 2 and 9 bear indirectly on the issue of copying. The district court determined that “[t]he fact that Cisco released products with Centripetal’s functionality within a year of these meetings goes beyond mere coincidence. Therefore, the fact that Cisco’s system mirrors the functionality of the Centripetal patents is compelling evidence that damages should be enhanced for copying.” Ex. 1027, 157. Without more, it is difficult to evaluate the processes that the district court employed to reach its determination. As the Federal Circuit instructed, we need “not [] go searching throughout the entire litigation record to find the evidence of copying, but [we have] an obligation to consider the specific evidence that was put before” us. Centripetal Networks, 19. We continue to determine that the vacated finding of the district court should be provided little weight, especially in view of the strong case of obviousness discussed above. Examination of Aaron Striegel We also do not find the Aaron Striegel’s testimony to be particularly persuasive. The testimony provides statements such as “I found evidence that it could be plausible,” “[s]o we can see the timeline is very plausible,” and “I found it very plausible that indeed that this technology could have made its way into these respective accused products.” Ex. 1029, 31:12–32:3. This testimony suggests the possibility of copying but does not demonstrate actual evidence of copying. At most, this testimony indicates that further consideration of the underlying evidence is warranted, but does little to support an ultimate finding of copying. Again, even taking this testimony as evidence of copying, it still must stand up against the strong case of obviousness discussed above.” slip op. at 40
- Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner
“The District Court did not provide an element-by-element analysis of how the claims of the ‘856 Patent cover this description. See Ex. 1027, 41. However, from the description, we understand the Court to have concluded that the system receives rules, identifies a set of packets as part of a flow using the NetFlow logs, “determines” that encrypted packets in the flow match known malicious signatures based on unencrypted data in other packets (e.g., data in the SNI), and then filters the flow based in a URI (e.g., that from the SNI), routing it to the null interface. The Court does not describe how the system “determines” that encrypted packets match known malicious signatures based on information in unencrypted packets, but we assume that is done as in the ‘856 Patent, by correlation, i.e., an encrypted packet is “determined” to match a threat indicator if it is in the same flow as a packet with unencrypted information that matches the threat indicator.10 With that understanding, we conclude that the allegedly infringing system operates, as least at the level described in the court’s decision, in the same way Buruganahalli’s system operates, filtering encrypted packets due to their presence in a flow that includes packets with unencrypted data, such as in a handshaking packet. It follows that Patent Owner is unable to establish a nexus, because “[w]here the offered secondary consideration actually results from something other than what is both claimed and novel in the claim, there is no nexus to the merits of the claimed invention.” Novartis AG v. Torrent Pharms. Ltd., 853 F.3d 1316, 1330” slip op. at 38
- Obviousness (§103) › Objective indicia / secondary considerations › Long-felt need / failure of othersDecided for petitioner
“need and industry recognition for the technology claimed in the ‘856 Patent because it describes the problem of detecting threats in encrypted traffic as ‘unsolvable.’” PO Resp. 68 (citing Ex. 1027, 64). Given that this is a press release by a company announcing that company’s new commercial product, however, we 8 The concurrence reevaluates Patent Owner’s evidence of industry praise and nexus, but we deem such considerations outside the remit of the Federal Circuit’s remand. are reluctant to give the “unsolvable” characterization much weight, as it may amount to puffery. But beyond that, it appears that the problem identified as “unsolvable” in the press release––“detect[ing] known attack signatures even in encrypted traffic”––had, in fact, already been solved in Buruganahalli, using the very same hello message, flow correlation, and man-in-the-middle techniques described in the ‘856 Patent. We thus cannot say that the press release identifies a long-felt need that was actually unsolved. See ZUP, 896 F.3d at 1374 (explaining that “[w]here the differences between the prior art and the claimed invention are . . . minimal . . . it cannot be said that any long-felt need was unsolved”) (quoting Geo. M. Martin Co. v. All. Mach. Sys. Int’l LLC, 618 F.3d 1294, 1304–05 (Fed. Cir. 2010) (first alteration in original)).” slip op. at 35
Patent outcomesUS 9,917,856 unpatentable§ 103 obviousnessPatents in suitUS 9,917,856 - Apple Inc. v. DH International Ltd.All claims unpatentablePTAB · Apr 16, 2026 · IPR2025-00172 · APJ Brian P Murphy · IPR · Final written decision
Claims 1–20 are unpatentable as obvious over Suga and Gorsuch; the Board denied Patent Owner’s motion to exclude.
RulingsFinal written decision- ExcludeMotion to exclude, deniedDenied
“Patent Owner also asserts prejudice for “not knowing” which Suga Exhibit “the Petitioner and Petitioner’s expert is relying on (see Exhibit 1021 and 1022),” without further explanation. Mot. Reply 6. Exhibit 1022 is a dictionary definition of “node.” How this relates to Patent Owner’s argument of prejudice is not explained. Id. at 5–6. The Board perceives no difficulty following Petitioner’s arguments and evidence, which cite Suga Exhibit 1005, including the testimony of Dr. Buehrer regarding the English language translation of Suga, which is identical in Exhibits 1005 and 1017. Patent Owner, moreover, opted not to depose Dr. Buehrer, did not file a deposition transcript of Dr. Buehrer in this proceeding, and does not allege any difference or substantive deficiency in the English language translation in Suga Exhibits 1005 and 1017, which are identical. We fail to see any prejudice to Patent Owner.” slip op. at 84
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“d. Conclusion for Claim 1 For the reasons given above, we determine the Petition establishes by” slip op. at 60
Patent outcomesUS 9,022,294 unpatentable§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,022,294 - Biofrontera Inc. / Biofrontera Bioscience GmbH et al. v. Sun Pharmaceutical Industries, Inc.All claims unpatentablePTAB · Feb 23, 2026 · IPR2024-01312 · APJ Mary C Hoffman · IPR · Final written decision
Claims 1, 2, 4–6, 16, 17, and 19–21 are unpatentable as obvious over Lundahl and Larsen; Ground 2 was conceded, and the motion to exclude was denied.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“Patent Owner asserts that Petitioner has not provided a valid justification for requiring a POSITA to have both an engineering degree and a medical degree. Prelim. Resp. 22. We agree, insofar as Petitioner has not clearly set out any particular explanation or evidence in support of its dual-degree requirement. In all other respects, we note that the parties’ proposed definitions are largely similar. Because we determine that Patent Owner’s proposed definition is reasonable and consistent with the ’028 patent and the cited art, we adopt Patent Owner’s definition. In any event, our Decision does not turn on this level of skill determination. B.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“device “[f]or the treatment of large-area tissues,” such as the backs of human patients, wherein several applicators 13 are “flexibly connected to each other through hinges.” Id. (quoting Ex. 1004 ¶ 72). Petitioner asserts that a POSITA would have been motivated “to incorporate Larsen’s solution of connecting light applicators by hinges, to allow for adjustability of Lundahl’s device to provide the desired irradiance and irradiance uniformity to all target areas during PDT.” Id. (citing Ex. 1015 ¶ 127). According to Petitioner, a “POSITA would have had a reasonable expectation of success in combining Lundahl with Larsen, because both references describe similar illuminators for using light to treat conditions on a patient’s skin.” Id. at 31 (citing Ex. 1015 ¶ 128). Petitioner’s proposed modification of Lundahl also involves using LEDs as a light source instead of Lundahl’s fluorescent tubes. Id. According to Petitioner, a POSITA would have been motivated to make this change because: (1) LEDs had a lower cost and a longer lifetime than fluorescent tubes; (2) fluorescent tubes were known to have inconsistent light output within the tube itself; and (3) “the use of LEDs would be more practical to reduce spacing between light sources and the edges of the panels, as opposed to the bulky metal couplings at the end of fluorescent tubes, to reduce optical dead space across the light surface.” Id. (citing Ex. 1014, 4:41–42, 6:31–42; Ex. 1015 ¶ 129). Petitioner asserts that a POSITA would have had a reasonable expectation of success with this modification because Lundahl and Larsen “describe similar illuminators and the conversion from fluorescent tubes to LEDs was a routine practice prior to 2015.” Id. at 32 (citing Ex. 1015 ¶ 131). Patent Owner does not meaningfully dispute the Petitioner’s proposed reasons to combine Lundahl and Larsen. See generally PO Resp. To the extent Patent Owner argues that a POSITA would not have been motivated to make the combination because it would negatively affecting uniform illumination (PO Resp. 24), the motivating benefit here—using adjustable LED panels instead of monolith fluorescent tubes—outweighs the alleged disadvantages for the many reasons given by Petitioner, including greater adjustability and improved LED performance. See Medichem, S.A. v. Rolabo, S.L., 437 F.3d 1157, 1165 (Fed. Cir. 2006) (“[t]he fact that the motivating benefit comes at the expense of another benefit, however, should not nullify its use as a basis to modify.”); Reply 14. We are persuaded that a POSITA would have been motivated to combine Lundahl and Larsen for the reasons advanced by Petitioner.” slip op. at 20
- Obviousness (§103) › KSR rationalesMotivation foundDecided for petitioner
“Patent Owner further argues that Petitioner’s reasoning (i.e., that it would have been obvious to try placing the hinges on the inner side surfaces) is unsupported and conclusory. PO Reps. 53–54. Patent Owner argues that Petitioner fails to identify a single prior art reference showing hinged structures on inner side surfaces. Id. This argument ignores that Larsen expressly identifies hinges on at least bottom side surfaces, and Petitioner merely proposes modifying their location from the bottom sides to inner sides. We find credible Dr. Grove’s testimony that relocating hinges would have been within the level of ordinary skill in the art. Ex. 1015 ¶ 155. Dr. Jokerst testifies that a POSITA would have been discouraged from placing hinges between Larsen’s adjustable applicators, because the hinges would create gaps that interfere with uniform illumination as well as the panels’ wiring, and create issues with the use and alignment of the panels. Ex. 2050 ¶ 175. However, a system with discrete panels connected by hinges (like in Larsen) will already have wiring, use and alignment technical challenges, regardless of the location of the hinges— the expected consequence of connecting multiple movable electronic panels. Moreover, the ’028 patent acknowledges in its discussion of conventional illuminators that placing hinges between panels was already known. Ex. 1001, 2:7–15. With respect to Dr. Jokerst’s opinion that the hinges would create gaps negatively affecting uniform illumination, we are persuaded that it would have been within the skill of a POSITA to locate the hinges on the inside surfaces “in a nearly flush arrangement,” such that the gaps would be minimized. Id.; Ex. 1015 ¶ 155. We also credit Dr. Grove’s supplemental testimony on this issue, directly refuting Dr. Jokerst’s testimony regarding gaps and uniform illumination (and therefore within the proper scope of reply, contrary to Patent Owner’s argument otherwise (Mot. 9). See Ex. 1026 ¶¶ 17–20 (explaining LED light divergence and that the physical space caused by hinges “is easily addressed” to maintain uniform illumination).9 We further point out that the ’028 patent also suggests that gaps do” slip op. at 24
- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
“Dr. Jokerst testifies that a POSITA would have been discouraged from placing hinges between Larsen’s adjustable applicators, because the hinges would create gaps that interfere with uniform illumination as well as the panels’ wiring, and create issues with the use and alignment of the panels. Ex. 2050 ¶ 175. However, a system with discrete panels connected by hinges (like in Larsen) will already have wiring, use and alignment technical challenges, regardless of the location of the hinges— the expected consequence of connecting multiple movable electronic panels. Moreover, the ’028 patent acknowledges in its discussion of conventional illuminators that placing hinges between panels was already known. Ex. 1001, 2:7–15. With respect to Dr. Jokerst’s opinion that the hinges would create gaps negatively affecting uniform illumination, we are persuaded that it would have been within the skill of a POSITA to locate the hinges on the inside surfaces “in a nearly flush arrangement,” such that the gaps would be minimized. Id.; Ex. 1015 ¶ 155. We also credit Dr. Grove’s supplemental testimony on this issue, directly refuting Dr. Jokerst’s testimony regarding gaps and uniform illumination (and therefore within the proper scope of reply, contrary to Patent Owner’s argument otherwise (Mot. 9). See Ex. 1026 ¶¶ 17–20 (explaining LED light divergence and that the physical space caused by hinges “is easily addressed” to maintain uniform illumination).9” slip op. at 24
Patent outcomesUS 11,697,028 unpatentable§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,697,028 - Google LLC v. DH International Ltd.All claims unpatentablePTAB · Feb 10, 2026 · IPR2024-01322 · APJ Brian P Murphy · IPR · Final written decision
Claims 1–20 are unpatentable as obvious over Mooney; the Board also found Mooney combined with Lee renders the disputed limitations obvious.
RulingsFinal written decision- Skill levelSkill level board ownDecided for petitioner
“A person of ordinary skill in the art (“POSITA”) at the time of the alleged invention of the ’294 patent would have had at least a bachelor’s degree in electrical engineering, or a related field, and at least two years of experience in design, development, and/or testing of network-enabled consumer devices, and familiarity with payment cards, or the equivalent, with additional education substituting for experience and vice versa. Pet. 2 (citing Lipoff Decl. Ex. 1003 ¶ 57). “Patent Owner agrees with the Petitioner on the level of ordinary skill in the art.” Resp. 4. Patent Owner adds that a POSITA would have had “at least three years of relevant industry or research experience in wireless communication between devices.” Id. (citing Ex. 2001 ¶¶ 26–29). Mr. Zaheer testifies that a POSITA “would” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“The claim language and specification define and describe an “activation cue” in functional terms: a data communication from an external source is received by the cell phone and recognized as an activation cue if it causes the switching element to be assigned its first (activated) state. Ex. 1001, 9:28–31, 9:42–46, 10:14–16, 13:55–60, 14:53–59, 15:4–6, 19:20–26. Patent Owner agrees that “upon an activation cue being received by portable electronic device 10, switching element 44b switches to its activated state.” Resp. 19 (quoting Ex. 1001, 10:14–16). The activation cue may be a predetermined bit sequence, a predetermined contactless data transmission, continuously emitted, pulsed, or punctual, but these are unclaimed non-limiting embodiments of the preferred form of data transmission. Id. at 9:25–26 (“for example a predetermined bit sequence”), 11:20–22 (“One example . . . emit an activation cue in the form of a predetermined contactless data transmission”), 14:65–15:3 (continuously emitted, pulsed or punctual cue). We will not read such preferred embodiments from the specification into claim language that is not so limited. See SuperGuide Corp. v. DirecTV Enterprises, Inc., 358 F.3d 870, 875 (Fed. Cir. 2004) (care should be taken “not to import into a claim limitations that are not part of the claim”); see also In re Van Geuns, 988 F.2d 1181, 1184 (Fed. Cir. 1993) (“limitations are not to be read into the claims from the specification”); see also IQRIS Techns. LLC v. Point Blank Enterprises, Inc., 2025 WL 727717, *4 (Fed. Cir. 2025) (“It is the claims, not the preferred embodiments, that” slip op. at 15
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) does not applyDecided for petitioner
“operatively linked to said electronic circuit” under 35 U.S.C. Section 112, sixth paragraph or not, the result is the same. We note there is no presumption of applying means-plus-function analysis to the switching element, because the limitation does not use the words “means for” that would mandate such claim construction treatment, and “switching” may invoke structure as well as function. See Williamson v. Citrix Online, LLC, 792 F.3d 1339, 1349–1350 (Fed. Cir. 2015) (en banc) (holding that “use of the word ‘means’ creates a presumption that § 112, ¶ 6 applies”). Regardless, we look to the meaning of the claim phrase at issue in view of the specification. We determine that the ’294 patent provides a clear, concise meaning for the switching element upon which both parties rely for construction. Patent Owner’s express agreement with Petitioner, that the claimed switching element is described in the ’294 patent as “any type of device allowing data to be conveyed according to alternate data conveyance operations in response to an activation cue being received by transceiver 18 or not,’” is particularly telling because it is not consistent with Patent Owner’s argument that the switching element means “switching of the data.” Resp. 7, 31 (citing Ex. 1001, 9:28–318). The claim language does not recite, and the specification does not describe, the switching element as a device that switches the data. Therefore, we determine the claimed “data conveyance switching element” means any type of switching device that allows data to be 8 We presume Patent Owner’s citation to “Exh. 2001, 9:28-31” on page 7 was intended to be a citation to the ’294 patent (Ex. 1001), as cited on page 31. whether or not an “activation cue” is received by the cell phone “cue receiver.”” slip op. at 21
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Plain and ordinary meaningDecided for petitioner
“[external] data exchange device” as a device with a data transceiver coupled to a circuit that carries out the function of exchanging data. Pet. 7–8 (citing Ex. 1001, 2:14–17, 4:7–14, 9:3–6; Ex. 1003 ¶¶ 67–68). As above, whether we construe the “[external] data exchange device” under 35 U.S.C. Section 112, sixth paragraph or not, the result is the same. Patent Owner, quoting the description of a data exchange device in the ’294 patent, contends that a “[external] data exchange device” “can be any sort of data exchange device comprising an electronic circuit (not shown) therein and a data transceiver 9a.” Resp. 8 (quoting Ex. 1001, 9:4–6). Patent Owner also responds to the Petition by clarifying that “[a]n external data exchange device is not a transceiver but a device with a transceiver.” Id. (citing Ex. 2001 ¶ 48). Petitioner argues in reply that Patent Owner does not contest Petitioner’s mappings of Mooney’s “cordless telephone base unit” or “cellular network infrastructure” to the claimed data exchange devices, such that no construction is necessary to resolve the dispute. Reply 5 (citing Resp. 16–37; Wellman, Inc. v. Eastman Chem. Co., 642 F.3d 1355, 1361 (Fed. Cir. 2011)). Limitations [1.c] and [1.d] recite “a first [second] data transceiver operatively linked to said electronic circuit [in the cell phone],” both of which are defined functionally as “for exchanging data between said electronic circuit [in the cell phone] and a first [second] external data exchange device over a first [second] communication link.” Nothing in the the other independent claims, further limits the form or function of the “[external] data exchange device,” although a device external to the cell phone may invoke additional structure. We determine the plain meaning of “[external] data exchange device” as claimed and described in the ’294 patent governs: any [external] device that comprises an electronic circuit and data transceiver for exchanging data with the electronic circuit in the cell phone over a communication link. slip op. at 22
Patent outcomesUS 9,022,294 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,022,294 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Solus’s rehearing request, leaving institution denied for claims 1–8 because the petition did not adequately show motivation to combine Hanafusa and Dobashi.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve Dobashi’s RSm values. Dobashi teaches that because RSm “can be adopted as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66–3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66– 3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 4
§ 103 obviousnessPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - PTAB · Jun 25, 2025 · IPR2024-01406 · APJ Jo-Anne M Kokoski · IPR · Remand
On remand, the Board denied institution of review of claims 1, 3, 4, 8–13, and 15 under § 314(a), finding the Fintiv factors favored discretionary denial.
RulingsRemand decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“stay or evidence exists that one may be granted if a proceeding is instituted.” Fintiv, Paper 11 at 6. A stay of litigation pending resolution of an inter partes review allays concerns about inefficiency and duplication of efforts, and strongly weighs against exercising our authority to deny institution. Fintiv, Paper 11 at 6. The Guidance Memo states that “the Board will apply the Fintiv factors when there is a parallel proceedings at the International Trade Commission.” Guidance Memo 2. Patent Owner asserts that a stay of the ITC Investigation had not been requested at the time of the Institution Decision,7 and argues that “the ITC does not stay investigations pending IPR.” PO Supp. Br. 4. Patent Owner also notes that the Institution Decision issued “just days before the ITC evidentiary hearing.” Id. Accordingly, Patent Owner argues that this factor favors denial. Id. Patent Owner is likely correct that the ITC would not have been inclined to grant a stay if one had been requested at the time the Institution Decision issued. Moreover, the ITC conducted a full evidentiary hearing less than three weeks after the Institution Decision issued, and the target date for the ITC’s final determination is four months before the statutory deadline for the Board’s final written decision. PO Supp. Br. 5. Accordingly, we” slip op. at 9
Discretionary denialPatents in suitUS 11,925,202 - PTAB · Jun 18, 2025 · IPR2025-00321 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR on claims 1, 2, 5–7, 9, 16, and 17, finding a reasonable likelihood that claim 1 is anticipated by Boyer.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“approximately two weeks before the statutory deadline for a final written decision, but the most recent median time-to-trial statistics for Judge Gilstrap in the Eastern District of Texas indicate that the actual trial date will likely be in July 2026, which is later than the statutory deadline to issue a final written decision in this proceeding in mid-June 2026. See Ex. 2001, 7 (median time from filing to trial of 23.2 months); Prelim. Resp. 10. Thus, we find this factor is neutral or weighs slightly against discretionary denial.” slip op. at 10
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this preliminary stage, we determine whether the information presented shows a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been unpatentable over the proposed prior art. We analyze the asserted grounds with the above-noted principles in mind.” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had (1) at least a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a related field, and (2) at least two years of research or industry experience in 3D printing or materials used for 3D printing.” Pet. 5 (citing Ex. 1003 ¶¶ 14–16). Petitioner also argues that “[a]dditional experience could substitute for a formal degree or formal training (and vice versa).” Id. Patent Owner proposes a slightly different level of skill, arguing that a person of ordinary skill in the art “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 24. Neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears to be consistent with the ’713 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 16
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction needed
“We note that, as discussed below, we are able to determine whether to institute inter partes review of the ’713 patent without expressly construing the term “from multiple print heads or deposition lines.” See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). As for Patent Owner’s argument that Petitioner has failed to carry its burden to identify how the claims are to be construed, we disagree on the present record. Although Petitioner does not provide a preferred construction for the single term it proposes requires construction, Petitioner does identify which of its two alternative constructions applies to each of its asserted grounds of unpatentability. Pet. 6 (“Under the first construction, [the obviousness grounds] are applicable, and [the anticipation ground] would be excluded from the claim scope. Under the alternative construction, all of [the asserted grounds] are applicable.”). In our view, this approach does not fail to satisfy Petitioner’s burden under 37 U.S.C. § 42.104(b)(3).” slip op. at 17
Claim construction§ 102 anticipationDiscretionary denialcites PhillipsPatents in suitUS 9,421,713 - Njoy, LLC / Njoy Holdings, Inc. v. Juul Labs, Inc.No claims unpatentablePTAB · Jun 10, 2025 · IPR2024-00231 · APJ Avelyn M Ross · IPR · Final written decision
Claims 14–16, 18, 27–29, 31, and 32 were not proven unpatentable because the asserted references failed to establish the claimed airflow path or a reason to make the proposed combinations.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner’s and Patent Owner’s proposed levels of skill are similar and differ in that Petitioner’s relevant degrees and corresponding two years of experience additionally includes “industrial design” and “product design” and familiarity with “electrically powered vaporizing articles, their components or the underlying technologies” where Patent Owner requires two years of experience “designing electro-mechanical consumer products or an advanced degree.” Compare Pet. 7, with PO Resp. 2. Patent Owner alleges that “Petitioner has failed to establish unpatentability under either standard,” indicating that the level of skill in the art is not a dispositive issue. PO Resp. 3. In light of the record before us, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art. Based on our review of the ’123 patent and the prior art of record, we determine that the definition offered by Petitioner comports with the qualifications a person would have needed to understand the ’123 patent and the prior art. We note that the outcome of this Decision would be the same under Patent Owner’s proposed definition.” slip op. at 11
- Expert testimonyPetitioner expert creditedOther
“In this case, Mr. McAlexander meets both Petitioner’s and Patent Owner’s proposed level of skill in the art. As a result, we are persuaded Mr. McAlexander has the requisite skill and relevant expertise to offer testimony in this matter. For example, Mr. McAlexander has a Bachelor’s Degree in Electrical Engineering and far more than 2 years of experience in the electrical engineering field. Ex. 1027, 3–6, 7. In addition, Mr. McAlexander has provided expert consulting services in a wide range of technology areas involving the process and design of electro-mechanical consumer products. Ex. 1003 ¶ 5. Through one of Mr. McAlexander’s business ventures, his laboratory has “performed detailed airflow analyses, designing and constructing specialized apparatuses to emulate human breath, allowing for precise activation testing of ENDS devices.” Ex. 1043 ¶ 16. That said, a declarant’s expertise, even clothed as a skilled artisan, does not entitle a naked opinion persuasive weight. Ashland Oil, Inc. v. Delta Resins & Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985). Here, Patent Owner had the opportunity to, and in fact did, thoroughly cross examine Mr. McAlexander about the purported deficiencies in his testimony. See, e.g., Exs. 2052, 2054; Daubert v. Merrell Dow Pharm., Inc., 509 U.S. 579, 595 (1993) (“Vigorous cross examination [and] presentation of contrary evidence . . . are the traditional and appropriate means of attacking shaky but admissible evidence.”). Therefore, to the extent Patent Owner credibly identifies deficiencies in Mr. McAlexander’s testimony or that testimony lacks factual support or is based on broad, conclusory assertions, we will assign appropriate weight. See Velander v. Garner, 348 F.3d 1359, 1371 (Fed. Cir. 2003) (explaining that it is within the Board’s discretion, as the trier of fact, to accord appropriate weight to the evidence presented).” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner contends that the parties proposed a construction for “pressure valve,” a limitation appearing in claims 18 and 31, during the ITC investigation. Pet. 7 (citing Ex. 1001, 41:58–65). Patent Owner contends that the terms of the ’123 patent should be given their plain and ordinary meaning. PO Resp. 4. Because resolution of the issues presented in this case do not require construction of the term “pressure valve,” we do not expressly construe this claim term. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (holding that “only those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs. in the context of an inter partes review).” slip op. at 14
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“We agree with Patent Owner. To anticipate a claim, a reference “must not only disclose all elements of the claim within the four corners of the document, but must also disclose those elements ‘arranged as in the claim.’” Net MoneyIN, 545 F.3d at 1369. “The requirement that the prior art elements themselves be arranged as in the claim means that the claims cannot be treated . . . as mere catalogs of separate parts, in disregard of the part-to-part relationships set forth in the claims.” Therasense, Inc. v. Becton, Dickinson & Co., 593 F.3d 1325, 1332 (Fed. Cir. 2010). Indeed, the prior art reference “must clearly and unequivocally disclose the claimed [invention] or direct those skilled in the art to the [invention] without any need for picking, choosing, and combining various disclosures not directly related to each other by the teachings of the cited reference.” Net MoneyIN, 545 F.3d at 1371 (citation omitted). “[D]ifferences between the prior art reference and the claimed invention, however slight, invoke the question of obviousness, not anticipation.” Id.” slip op. at 20
Patent outcomesUS 10,130,123 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,130,123
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.