- Apple Inc. / Amazon Web Services, Inc. v. Ziklag IP LLCAll claims unpatentablePTAB · Aug 26, 2026 · IPR2026-00047 · APJ Hung H Bui · IPR · Final written decision
Claims 1–4, 6, 9–14, and 17 are unpatentable as obvious over Yurt and Logan; the Board denied Petitioner’s motion to strike.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Based on the record before us, we are unpersuaded that Patent Owner’s “proposed level of skill” is appropriate in this proceeding for reasons discussed below.” slip op. at 13
- Expert testimonyPatent owner expert creditedDecided for patent owner
“McCulloh’s qualifications are grounded upon Patent Owner’s “proposed level of skill” (which we rejected) that is “higher than Petitioner’s proposed level” (which we adopted for this proceeding) and focus on their level of skill in the late 1990s timeframe (time of the invention), but there is no time requirement on when an expert acquired the requisite level of skill in the art. Osseo Imaging, LLC v. Planmeca USA Inc., 116 F. 4th 1335, 1340–1341 (declining to add a timing requirement to the minimum qualifications necessary to offer expert testimony from the perspective of a person of ordinary skill in the art). “An expert need not have acquired that skill level prior to the time of the invention to be able to testify from the vantage point of a person of ordinary skill in the art. Rather, an expert can acquire the necessary skill level later and develop an understanding of what a person of ordinary skill knew at the time of the invention. In practice, the fact that the expert was not a person of ordinary skill at the time of the invention may well be used during cross examination to undermine the credibility of the expert.” Id. Under Petitioner’s proposed level of skill (which we adopted), Dr. McCulloh is indeed qualified to testify in this proceeding because he has a Ph.D. in Computer Science from Carnegie Mellon University and extensive experience, including “hands-on deployment and academic research in distributed systems operating under real-world constraints” (Ex. 2009, Ex. 2010). See Ex. 2010 (CV) (BSIE, MS Comp. Sci, PhD Comp. Sci, Lieutenant 1994-1999, 10th Mountain Division (“led the army’s first tactical deployment of a distributed computing system”)); Ex. 2009 ¶¶ 6–10. Although Dr. McCulloh’s declaration does not include any searching or analysis of patent literature including Yurt or Logan as part of his analysis of the “background” state of the art, as correctly recognized by Petitioner (Pet. Reply 7–8 (citing Ex. 1017, 74:18–75:14; Ex. 2009 ¶ 3)), we are persuaded that Dr. McCulloh is qualified to address Dr. Lippman’s portrayal of the architecture disclosed in the ’128 patent, as advanced by Patent Owner. Ex. 2009, ¶¶ 3, 5–34; Ex. 2010. Dr. McCulloh does not provide testimony to refute Petitioner’s obviousness analysis based on Yurt and Logan. See Ex. 2009. Mr. Johnson is only offered to refute Petitioner’s obviousness analysis based on Yurt and Logan. Ex. 2007 ¶¶ 3, 18, 29. Under Petitioner’s proposed level of skill (which we adopted), Mr. Johnson, who is a co-inventor of the ’128 patent, is qualified to testify in this proceeding, especially, when his declaration states that (1) he is a POSITA “with more than 30 years of experience building technology-driven media and contentdistribution systems” and (2) he “was actively involved in the development and deployment of digital music and video distribution technologies” since the mid-1990’s, including “real-time and near-real-time electronic delivery of media content.” Ex. 2007 ¶¶ 9–10, 14, 16. Certainly, “[t]he inventor himself may qualify as an expert and testify what his claims would mean in the relevant art.” Markman v. Westview Instruments, Inc., 52 F.3d 967, 991 (Fed. Cir. 1995).” slip op. at 17
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Plain and ordinary meaningNo construction needed
“Plain Meaning of “Substantially Real Time” Instead, the plain meaning of “substantially real time” is readily apparent and understood by a person of skill (POSITA) in the art in the context of data distribution or transmission of the ’128 patent as referring to an acceptable time delay (i.e., “a fraction of real time”) between distribution center 18 and user device 12, via network 14, shown in Figures 1–2 of the ’128 patent and, as such, is consistent with the ‘128 patent’s specification and Dr. Lippman’s Declaration (Ex. 1003, ¶¶ 79, 126). Because the plain meaning of “substantially real time” as understood by a POSITA is readily apparent, there is no reason for the Board to consider Patent Owner’s clarification of “substantially real time” based solely on extrinsic evidence, i.e., counsel argument, Mr. Johnson’s declaration (Ex. 2007, ¶¶ 27, 29–30, 33, 39; Ex. 1018, 38:13–39:20) and Dr. McCulloh’s declaration (Ex. 2009, ¶ 19). For example, Patent Owner, relying upon Mr. Johnson’s testimony, clarifies the term “substantially real time” requires either (1) “playback while transmission is ongoing” (PO Resp. 30), or (2) “[a] coordinated system behavior in response to a user’s request” “in which a user request triggers coordinated operations, including locating content across distributed systems, routing that content, and initiating playback while transmission is ongoing” (PO Sur-Reply 4 (citing Ex. 1001, 2:67–3:2, 6:23–35)). However, Patent Owner’s shifting position regarding “substantially real time” is not commensurate with the plain reading of the term. Based on the plain meaning of “substantially real time,” we are persuaded by Petitioner that Yurt explicitly discloses transmitting data at least in “real time,” preferably “less than real time” or “a fraction of real time” for playback. Pet. Reply 9 (citing Ex.1005, code (57), 1:66–2:4, 4:68– 5:3 (teaching distributing “digital audio” in “less than real time” and in “a fraction of real time,” where the receiving system may “decompress in real time the requested material as it is distributed by transmission system 100”)).” slip op. at 36
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“teaches or renders obvious all limitations of claim 1, Petitioner also provides sufficient motivation or reasoning with a rational underpinning to combine Yurt and Logan. Specifically, Petitioner, relying on Dr. Lippman’s declaration (Ex. 1003, ¶¶ 62–73), asserts “a POSITA would have been motivated to combine Yurt with Logan for several reasons, discussed further below. Combining Logan’s usage log teachings with Yurt’s improved audio file accessibility (e.g., via popularity) to track additional user request information would have been obvious, beneficial, and predictable.” Pet. 19 (citing Ex. 1003, ¶¶ 62–72). According to Petitioner, because “Logan teaches implementation details for tracking user/usage data for billing purposes and adapting preferences ‘based on actual usage,’” “[a] POSITA would have thus been motivated to combine Yurt’s teachings (e.g., tracking information about requested items like item popularity) with Logan’s teachings (e.g., storing user data and usage information in response to user requests).” Id. at 19–20. “This would have been merely the use of a known technique (Logan’s tracking of user and usage data in response to user requests) to improve a similar method in the same way (Yurt’s tracking of information about user-requested items).” Id. at 20 (citing Ex. 1003, ¶¶ 67– 68). According to Petitioner, [T]he combination is straightforward: use Logan’s known technique for recording user data with Yurt’s existing item database teachings. See Ex. 1005, 12:28–57, 10:66–11:4; Ex. 1006, 5:33–42, 6:27–35, 8:49–58; Pet. 19–23. Since Yurt already teaches using its item database to track item popularity and request information, no modification to Yurt’s architecture is necessary. Logan merely confirms when and how to store the user information. Pet. 19–21. A POSITA would have found the combination obvious for all the reasons Dr. Lippman provided. See, e.g., Ex.1003, ¶¶ 71–72.” slip op. at 58
Patent outcomesUS 6,182,128 unpatentableClaim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 6,182,128 - Apple Inc. / Amazon Web Services, Inc. v. Ziklag IP LLCAll claims unpatentablePTAB · Aug 26, 2026 · IPR2025-00700 · APJ Hung H Bui · IPR · Final written decision
Claims 1–4, 6, 9–14, and 17 are unpatentable as obvious over Yurt and Logan; Petitioner’s motion to strike is denied.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Based on the record before us, we are unpersuaded that Patent Owner’s “proposed level of skill” is appropriate in this proceeding for reasons discussed below.” slip op. at 13
- Expert testimonyPatent owner expert creditedDecided for patent owner
“Under Petitioner’s proposed level of skill (which we adopted), Dr. McCulloh is indeed qualified to testify in this proceeding because he has a Ph.D. in Computer Science from Carnegie Mellon University and extensive experience, including “hands-on deployment and academic research in distributed systems operating under real-world constraints” (Ex. 2009, Ex. 2010). See Ex. 2010 (CV) (BSIE, MS Comp. Sci, PhD Comp. Sci, Lieutenant 1994-1999, 10th Mountain Division (“led the army’s first tactical deployment of a distributed computing system”)); Ex. 2009 ¶¶ 6–10. Although Dr. McCulloh’s declaration does not include any searching or analysis of patent literature including Yurt or Logan as part of his analysis of the “background” state of the art, as correctly recognized by Petitioner (Pet. Reply 7–8 (citing Ex. 1017, 74:18–75:14; Ex. 2009 ¶ 3)), we are persuaded that Dr. McCulloh is qualified to address Dr. Lippman’s portrayal of the architecture disclosed in the ’128 patent, as advanced by Patent Owner. Ex. 2009, ¶¶ 3, 5–34; Ex. 2010. Dr. McCulloh does not provide testimony to refute Petitioner’s obviousness analysis based on Yurt and Logan. See Ex. 2009. Mr. Johnson is only offered to refute Petitioner’s obviousness analysis based on Yurt and Logan. Ex. 2007 ¶¶ 3, 18, 29. Under Petitioner’s proposed level of skill (which we adopted), Mr. Johnson, who is a co-inventor of the ’128 patent, is qualified to testify in this proceeding, especially, when his declaration states that (1) he is a POSITA “with more than 30 years of experience building technology-driven media and contentdistribution systems” and (2) he “was actively involved in the development and deployment of digital music and video distribution technologies” since the mid-1990’s, including “real-time and near-real-time electronic delivery of media content.” Ex. 2007 ¶¶ 9–10, 14, 16. Certainly, “[t]he inventor himself may qualify as an expert and testify what his claims would mean in the relevant art.” Markman v. Westview Instruments, Inc., 52 F.3d 967, 991 (Fed. Cir. 1995). The fact that Johnson is a co-inventor is not in and of itself sufficient to discredit his testimony. “That an expert may have a bias or self-interest towards a party on whose behalf he or she is offering testimony, without more, generally does not require disqualifying the expert so long as the expert appears to be providing an objective analysis. Bias goes to the weight of the testimony, not necessarily its admissibility.” Apple, Inc. v. Motorola, Inc., 757 F. 3d 1286, 1321–22 (Fed. Cir. 2014). Nevertheless, the Board has broad discretion to assign weight to be accorded expert testimony. Yorkey v. Diab, 601 F.3d 1279, 1284 (Fed. Cir. 2010) (“[T]he Board was well within its discretion to give more credibility to [one expert over another] unless no” slip op. at 18
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Plain and ordinary meaningDecided for patent owner
“Based on the record before us, we determine that neither Patent Owner’s proposed clarification nor an express construction of “substantially real time” is necessary for our proceeding. Plain Meaning of “Substantially Real Time” Instead, the plain meaning of “substantially real time” is readily apparent and understood by a person of skill (POSITA) in the art in the context of data distribution or transmission of the ’128 patent as referring to an acceptable time delay (i.e., “a fraction of real time”) between distribution center 18 and user device 12, via network 14, shown in Figures 1–2 of the ’128 patent and, as such, is consistent with the ‘128 patent’s specification and Dr. Lippman’s Declaration (Ex. 1003, ¶¶ 79, 126). Because the plain meaning of “substantially real time” as understood by a POSITA is readily apparent, there is no reason for the Board to consider Patent Owner’s clarification of “substantially real time” based solely on extrinsic evidence, i.e., counsel argument, Mr. Johnson’s declaration (Ex. 2007, ¶¶ 27, 29–30, 33, 39; Ex. 1018, 38:13–39:20) and Dr. McCulloh’s declaration (Ex. 2009, ¶ 19). For example, Patent Owner, relying upon Mr. Johnson’s testimony, clarifies the term “substantially real time” requires either (1) “playback while transmission is ongoing” (PO Resp. 30), or (2) “[a] coordinated system behavior in response to a user’s request” “in which a user request triggers coordinated operations, including locating content across distributed systems, routing that content, and initiating playback while transmission is ongoing” (PO Sur-Reply 4 (citing Ex. 1001, 2:67–3:2, 6:23–35)). However, Patent Owner’s shifting position regarding “substantially real time” is not commensurate with the plain reading of the term.” slip op. at 36
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“Conclusion as to Claim 1 Petitioner has shown that (1) Yurt and Logan teach or suggest all the limitation of claim 1 and (2) reasons sufficiently existed with a rational underpinning to support the combination of Yurt and Logan.” slip op. at 63
Patent outcomesUS 6,182,128 unpatentableClaim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 6,182,128 - Bizlink Technology, Inc. v. Anderson Power Products, Inc.Some claims unpatentablePTAB · Nov 7, 2025 · IPR2024-00687 · APJ Lisa L Tsang · IPR · Final written decision
Claims 1–3 and 7–12 are unpatentable; claim 4 is not shown unpatentable because Winkler does not establish that its insulating barriers press against each other when partially disconnected.
RulingsFinal written decision- Skill levelSkill level board ownDecided for patent owner
“We agree with Patent Owner’s first argument that a level of ordinary skill in the art that encompasses an individual having experience with electrical circuits but not electrical connectors is not consistent with the technology and descriptions in the ’017 patent. See PO Resp. 7. The field of the invention of the ’017 patent is “electrical connectors, and more particularly, . . . an electrical connector that suppresses arcing if connected or disconnected while current is flowing.” Ex. 1001, 1:7–9. Consistent therewith, the challenged claims are directed to “[a]n electrical connector pair” and recite structural features of the electrical connector pair. Id. at 4:20–56, 5:1–20.” slip op. at 10
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“We find that the intrinsic evidence supports maintaining our construction in the Institution Decision that “insulating” means “electrically insulating.” See Dec. 11–12. In particular, we agree with Patent Owner’s argument that the insulating barriers would be unable to be configured to “block[] substantially all through-air arcing paths between the first and second electrical contacts,” as claimed, unless they were electrically insulating. See Ex. 1001, 4:36–44. Moreover, as Patent Owner avers, our interpretation of “insulating” as it applies to the first and second insulating barriers should be the same as for the first and second housings. See Digital Biometrics, 149 F.3d at 1345 (“whatever interpretation we assign [to a word used in a claim] should encompass both uses because the same word appearing in the same claim should be interpreted consistently” (citation omitted)).” slip op. at 15
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“Ex. 2001 ¶ 102. Accordingly, we find Dr. Eldering’s testimony persuasive as to this issue and determine that the diagram shows what an ordinarily skilled artisan would have reasonably inferred Winkler to disclose when the connectors are partially disconnected. Compare Ex. 1004, Fig. 2, with Pet. 33; see also Ex. 1004, 3:14–27 (discussing the process by which the connectors are engaged with each other).” slip op. at 44
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable
“Id. at 3:27–37 (emphasis added). These wall portions 58 are located between the distal ends of the terminals and where Petitioner proposes to add a printed circuit board or wiring board to Winkler. See id. at Fig. 2; Pet. 44–46 (diagrams showing Winkler as modified to have a printed circuit board or wiring board). As such, movement of Winkler’s terminals appears to be mostly limited to within their respective receiving pockets. Given the above teachings, we fail to see how Petitioner’s proposed modification would have meaningfully interfered with the degree of freedom of movement required by Winkler’s terminals. Notably, Mr. Locati’s testimony regarding this issue is conclusory. See Ex. 2001 ¶ 120. Because movement of Winkler’s terminals occurs primarily in the receiving pockets, we also do not discern how the solder joint of Petitioner’s proposed modification would experience undue stress or risk breaking due to that movement. See Ex. 1004, 1:47–55, 3:14–37, Fig. 2; Pet. 44–46. This is particularly true in view of Winkler’s teaching that each cylindrical end portion may be soldered to a cable. See id. at 2:6–10; see also Pet. 43 (arguing that Winkler teaches soldering to a cable but not specifically to a printed circuit or wiring board). Accordingly, we determine that Petitioner has shown by a preponderance of the evidence that claim 8 would have been obvious over the combined teachings of Winkler and Handbook.” slip op. at 55
Patent outcomesUS 8,808,017 mixedClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,808,017 - Nintendo Co., Ltd. / Nintendo Of America Inc. v. American GNC CorporationAll claims unpatentablePTAB · Aug 20, 2025 · IPR2024-00668 · APJ Lisa L Tsang · IPR · Final written decision
Claims 1 and 4 are unpatentable as obvious over Smith, Chan, and Bernstein (claim 1), Smith, Chan, Bernstein, Irwin, and Merhav (claim 4), and Tingleff, Chan, and Bernstein (claims 1 and 4).
RulingsFinal written decision- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“partes review may not be instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” 35 U.S.C. § 315(b) (emphasis added). Accordingly, a petition for inter partes review may be considered only if, among other things, it “identifies all real parties in interest,” and no real party in interest was served with a complaint alleging infringement of the challenged patent more than one year before the petition was filed. 35 U.S.C. § 312(a)(2). “[T]he IPR petitioner bears the burden of persuasion to demonstrate that its petitions are not time-barred under § 315(b) based on a complaint served on a real party in interest more than a year earlier.” Worlds Inc. v. Bungie, Inc., 903 F.3d 1237, 1242 (Fed. Cir. 2018). However, “an IPR petitioner’s initial identification of the real parties in interest should be accepted unless and until disputed by a patent owner,” who, in turn, “must produce some evidence that tends to show that a particular third party should be named a real party in interest.” Id. at 1242, 1244 (footnote omitted).” slip op. at 8
- PTAB / AIA Trials › Real party in interest / privityRpi dispute resolved for petitionerDecided for petitioner
“Based on the arguments and evidence of record, we determine that Patent Owner has not produced sufficient evidence to support a finding that STMicro should be named a real party in interest to this proceeding. At best, Patent Owner’s evidence and arguments establish only that Patent Owner previously filed a complaint against STMicro, asserting that STMicro infringed patents related to the ’648 patent (see generally Ex. 2012); and that Patent Owner served a subpoena to compel STMicro to testify and produce documents in Patent Owner’s infringement suit against Petitioner (see generally Ex. 2014). The record before us does not demonstrate a relationship between Petitioner and STMicro sufficient to show that STMicro is a real party in interest. See Worlds, 903 F.3d at 1242, 1244 (“[A]n IPR petitioner’s initial identification of the real parties in interest should be accepted unless and until disputed by a patent owner,” who, in turn, “must produce some evidence that tends to show that a particular third party should be named a real party in interest.” (footnote omitted)).” slip op. at 9
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Pet. 5 (citing Ex. 1002 ¶¶ 12–14). Patent Owner counters that the skilled artisan would have had “at least a ‘Master’s Degree in Electrical or Electronics Engineering, and approximately five years of relevant experience in the development of control systems for inertial navigation, MEMS semiconductor processing, and analog circuit design.’” PO Resp. 18 (citing Ex. 2019 ¶ 57). We adopt Petitioner’s articulation of the level of ordinary skill in the art, which is consistent with our review and understanding of the technology and descriptions in the ’648 patent and prior art of record, and we apply it in our obviousness evaluations below. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). We note, however, that we would reach the same conclusions applying either Petitioner’s or Patent Owner’s definition of the level of skill in the art.” slip op. at 11
- Claim Construction › Intrinsic evidence (Phillips canons) › Preamble limiting or notPreamble limitingDecided for patent owner
“We find unavailing Petitioner’s reliance on Catalina to support its claim construction position. See Reply 2. In particular, although Petitioner contends the body of the claims “define[s] a structurally complete invention,” Petitioner does not explain how the claims additionally “use[] the preamble only to state a purpose or intended use for the invention,” as Catalina further requires. See Catalina, 289 F.3d at 808 (“a preamble is not limiting ‘where a patentee defines a structurally complete invention in the claim body and uses the preamble only to state a purpose or intended use for the invention” (emphasis added)). In this regard, we discern no reason to interpret “[a] micro inertial measurement unit” as reciting only a purpose or intended use because the term, on its face, uses “micro inertial measurement” as an adjective that conveys further structural details of the unit. Accordingly, on the complete record, and for the reasons set forth in our Institution Decision, we maintain our construction that “[a] micro inertial measurement unit” recited in the preamble is limiting and requires a micro-sized inertial measurement unit, and that the structures recited in the limitations of the claims are limited to structures implemented as MEMS devices. Dec. 21–24.” slip op. at 14
Patent outcomesUS 6,671,648 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 6,671,648 - Nintendo Co., Ltd. / Nintendo Of America Inc. v. American GNC CorporationAll claims unpatentablePTAB · Aug 20, 2025 · IPR2024-00667 · APJ Jennifer S Bisk · IPR · Final written decision
Claims 1 and 3 are unpatentable under § 103 over Fujiyoshi, Kumar, Cox, and Townsend, and independently over Mitamura and Townsend.
RulingsFinal written decision- PTAB / AIA Trials › Real party in interest / privityRpi dispute resolved for petitionerNot time barredDecided for petitioner
“other things, it “identifies all real parties in interest.” 35 U.S.C. § 312(a)(2). “[T]he IPR petitioner bears the burden of persuasion to demonstrate that its petitions are not time-barred under § 315(b) based on a complaint served on a real party in interest more than a year earlier.” Worlds Inc. v. Bungie, Inc., 903 F.3d 1237, 1242 (Fed. Cir. 2018). However, “an IPR petitioner’s initial identification of the real parties in interest should be accepted unless and until disputed by a patent owner,” who, in turn, “must produce some evidence that tends to show that a particular third party should be named a real party in interest.” Id. at 1242, 1244 (footnote omitted). Whether a non-party is a real party in interest is a “highly fact-” slip op. at 11
- Skill levelSkill level petitioner adoptedDecided for petitioner
“would have possessed a bachelor’s degree in electrical engineering or similar degree, with two to three years of practical experience designing and/or implementing systems that include sensors for measuring movement, such as acceleration and rotational position. . . . A skilled artisan could also have had more formal education and less practical experience, or vice versa. Pet. 5 (citing Ex. 1002 ¶¶ 12–14). Patent Owner states that “[a] person of ordinary skill in the art with respect to the ’122 Patent would have at least a five years of relevant experience in the development of control systems for inertial navigation, MEMS semiconductor processing, and analog circuit design.” PO Resp. 18 (citing Ex. 2019 ¶ 57). We adopt Petitioner’s articulation of the level of ordinary skill in the art, which is consistent with our review and understanding of the technology and descriptions in the ’122 patent and prior art of record, and we apply it in our obviousness evaluations below. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). We note, however, that we would reach the same conclusions applying either Petitioner’s or Patent Owner’s definition of the level of skill in the art.” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” 37 C.F.R. § 42.100(b) (2019). In this context, claim terms “are generally given their ordinary and customary meaning” as understood by a person of ordinary skill in the art in question at the time of the invention. Phillips v. AWH Corp., 415 F.3d 1303, 1312–13 (Fed. Cir. 2005) (citations omitted) (en banc). “The Board is required to construe ‘only those terms ... that are in controversy, and only to the extent necessary to resolve the controversy.’” Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng'g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Neither party argues that any claim term requires construction. Pet. 6; PO Resp. 18. Accordingly, we do not explicitly construe any term.” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“Record evidence supports Petitioner’s contentions that a skilled artisan would have had reason to look to Kumar for further implementation details of a circuit that performs functions like those performed by Fujiyoshi. See Pet 24–26. For example, Dr. Young testifies that a person of ordinary skill in the art would have recognized that Kumar discloses the details, at a granular level, of Fujiyoshi’s capacitive sensing systems and would have looked to Kumar for understanding of how to implement Fujiyoshi’s system. Ex. 1002 ¶ 145. Patent Owner does not point to persuasive evidence to rebut this opinion. Moreover, Petitioner cites to Kumar, not only for an explicit disclosure of capacitive pickoff signals, but also for its disclosure of both DC bias and AC carrier signals and recognizing the applicability of an AC carrier pickoffs that operates without DC bias. Pet. 24–26 (citing Ex. 1005 3:65–4:2, 6:29–36). We credit Dr. Young’s testimony on this issue and agree with Petitioner that a person of ordinary skill in the art, looking at Fujiyoshi’s description of capacitive sensing systems, would be motivated to look to Kumar for its more detailed teachings of the implementation details of such systems and would combine these details to arrive at limitation 1(a). We determine that Petitioner has shown, by a preponderance of the evidence, that one of ordinary skill in the art would have been motivated to combine Fujiyoshi and Kumar in the manner argued by Petitioner.” slip op. at 37
Patent outcomesUS 6,508,122 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 6,508,122 - PTAB · Jun 25, 2025 · IPR2024-01406 · APJ Jo-Anne M Kokoski · IPR · Remand
On remand, the Board denied institution of review of claims 1, 3, 4, 8–13, and 15 under § 314(a), finding the Fintiv factors favored discretionary denial.
RulingsRemand decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“stay or evidence exists that one may be granted if a proceeding is instituted.” Fintiv, Paper 11 at 6. A stay of litigation pending resolution of an inter partes review allays concerns about inefficiency and duplication of efforts, and strongly weighs against exercising our authority to deny institution. Fintiv, Paper 11 at 6. The Guidance Memo states that “the Board will apply the Fintiv factors when there is a parallel proceedings at the International Trade Commission.” Guidance Memo 2. Patent Owner asserts that a stay of the ITC Investigation had not been requested at the time of the Institution Decision,7 and argues that “the ITC does not stay investigations pending IPR.” PO Supp. Br. 4. Patent Owner also notes that the Institution Decision issued “just days before the ITC evidentiary hearing.” Id. Accordingly, Patent Owner argues that this factor favors denial. Id. Patent Owner is likely correct that the ITC would not have been inclined to grant a stay if one had been requested at the time the Institution Decision issued. Moreover, the ITC conducted a full evidentiary hearing less than three weeks after the Institution Decision issued, and the target date for the ITC’s final determination is four months before the statutory deadline for the Board’s final written decision. PO Supp. Br. 5. Accordingly, we” slip op. at 9
Discretionary denialPatents in suitUS 11,925,202 - PTAB · Jun 18, 2025 · IPR2025-00321 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR on claims 1, 2, 5–7, 9, 16, and 17, finding a reasonable likelihood that claim 1 is anticipated by Boyer.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“approximately two weeks before the statutory deadline for a final written decision, but the most recent median time-to-trial statistics for Judge Gilstrap in the Eastern District of Texas indicate that the actual trial date will likely be in July 2026, which is later than the statutory deadline to issue a final written decision in this proceeding in mid-June 2026. See Ex. 2001, 7 (median time from filing to trial of 23.2 months); Prelim. Resp. 10. Thus, we find this factor is neutral or weighs slightly against discretionary denial.” slip op. at 10
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this preliminary stage, we determine whether the information presented shows a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been unpatentable over the proposed prior art. We analyze the asserted grounds with the above-noted principles in mind.” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had (1) at least a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a related field, and (2) at least two years of research or industry experience in 3D printing or materials used for 3D printing.” Pet. 5 (citing Ex. 1003 ¶¶ 14–16). Petitioner also argues that “[a]dditional experience could substitute for a formal degree or formal training (and vice versa).” Id. Patent Owner proposes a slightly different level of skill, arguing that a person of ordinary skill in the art “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 24. Neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears to be consistent with the ’713 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 16
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction needed
“We note that, as discussed below, we are able to determine whether to institute inter partes review of the ’713 patent without expressly construing the term “from multiple print heads or deposition lines.” See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). As for Patent Owner’s argument that Petitioner has failed to carry its burden to identify how the claims are to be construed, we disagree on the present record. Although Petitioner does not provide a preferred construction for the single term it proposes requires construction, Petitioner does identify which of its two alternative constructions applies to each of its asserted grounds of unpatentability. Pet. 6 (“Under the first construction, [the obviousness grounds] are applicable, and [the anticipation ground] would be excluded from the claim scope. Under the alternative construction, all of [the asserted grounds] are applicable.”). In our view, this approach does not fail to satisfy Petitioner’s burden under 37 U.S.C. § 42.104(b)(3).” slip op. at 17
Claim construction§ 102 anticipationDiscretionary denialcites PhillipsPatents in suitUS 9,421,713 - Njoy, LLC / Njoy Holdings, Inc. v. Juul Labs, Inc.No claims unpatentablePTAB · Jun 10, 2025 · IPR2024-00231 · APJ Avelyn M Ross · IPR · Final written decision
Claims 14–16, 18, 27–29, 31, and 32 were not proven unpatentable because the asserted references failed to establish the claimed airflow path or a reason to make the proposed combinations.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner’s and Patent Owner’s proposed levels of skill are similar and differ in that Petitioner’s relevant degrees and corresponding two years of experience additionally includes “industrial design” and “product design” and familiarity with “electrically powered vaporizing articles, their components or the underlying technologies” where Patent Owner requires two years of experience “designing electro-mechanical consumer products or an advanced degree.” Compare Pet. 7, with PO Resp. 2. Patent Owner alleges that “Petitioner has failed to establish unpatentability under either standard,” indicating that the level of skill in the art is not a dispositive issue. PO Resp. 3. In light of the record before us, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art. Based on our review of the ’123 patent and the prior art of record, we determine that the definition offered by Petitioner comports with the qualifications a person would have needed to understand the ’123 patent and the prior art. We note that the outcome of this Decision would be the same under Patent Owner’s proposed definition.” slip op. at 11
- Expert testimonyPetitioner expert creditedOther
“In this case, Mr. McAlexander meets both Petitioner’s and Patent Owner’s proposed level of skill in the art. As a result, we are persuaded Mr. McAlexander has the requisite skill and relevant expertise to offer testimony in this matter. For example, Mr. McAlexander has a Bachelor’s Degree in Electrical Engineering and far more than 2 years of experience in the electrical engineering field. Ex. 1027, 3–6, 7. In addition, Mr. McAlexander has provided expert consulting services in a wide range of technology areas involving the process and design of electro-mechanical consumer products. Ex. 1003 ¶ 5. Through one of Mr. McAlexander’s business ventures, his laboratory has “performed detailed airflow analyses, designing and constructing specialized apparatuses to emulate human breath, allowing for precise activation testing of ENDS devices.” Ex. 1043 ¶ 16. That said, a declarant’s expertise, even clothed as a skilled artisan, does not entitle a naked opinion persuasive weight. Ashland Oil, Inc. v. Delta Resins & Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985). Here, Patent Owner had the opportunity to, and in fact did, thoroughly cross examine Mr. McAlexander about the purported deficiencies in his testimony. See, e.g., Exs. 2052, 2054; Daubert v. Merrell Dow Pharm., Inc., 509 U.S. 579, 595 (1993) (“Vigorous cross examination [and] presentation of contrary evidence . . . are the traditional and appropriate means of attacking shaky but admissible evidence.”). Therefore, to the extent Patent Owner credibly identifies deficiencies in Mr. McAlexander’s testimony or that testimony lacks factual support or is based on broad, conclusory assertions, we will assign appropriate weight. See Velander v. Garner, 348 F.3d 1359, 1371 (Fed. Cir. 2003) (explaining that it is within the Board’s discretion, as the trier of fact, to accord appropriate weight to the evidence presented).” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner contends that the parties proposed a construction for “pressure valve,” a limitation appearing in claims 18 and 31, during the ITC investigation. Pet. 7 (citing Ex. 1001, 41:58–65). Patent Owner contends that the terms of the ’123 patent should be given their plain and ordinary meaning. PO Resp. 4. Because resolution of the issues presented in this case do not require construction of the term “pressure valve,” we do not expressly construe this claim term. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (holding that “only those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs. in the context of an inter partes review).” slip op. at 14
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“We agree with Patent Owner. To anticipate a claim, a reference “must not only disclose all elements of the claim within the four corners of the document, but must also disclose those elements ‘arranged as in the claim.’” Net MoneyIN, 545 F.3d at 1369. “The requirement that the prior art elements themselves be arranged as in the claim means that the claims cannot be treated . . . as mere catalogs of separate parts, in disregard of the part-to-part relationships set forth in the claims.” Therasense, Inc. v. Becton, Dickinson & Co., 593 F.3d 1325, 1332 (Fed. Cir. 2010). Indeed, the prior art reference “must clearly and unequivocally disclose the claimed [invention] or direct those skilled in the art to the [invention] without any need for picking, choosing, and combining various disclosures not directly related to each other by the teachings of the cited reference.” Net MoneyIN, 545 F.3d at 1371 (citation omitted). “[D]ifferences between the prior art reference and the claimed invention, however slight, invoke the question of obviousness, not anticipation.” Id.” slip op. at 20
Patent outcomesUS 10,130,123 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,130,123 - Juul Labs, Inc. v. Njoy, LLCNo claims unpatentablePTAB · May 21, 2025 · IPR2024-00161 · APJ Christopher M Kaiser · IPR · Final written decision
Claims 1–27 were not shown unpatentable because the asserted obviousness grounds failed to establish the claimed central airflow passageway or a reason to combine the references.
RulingsFinal written decision- Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner
“Relying on the testimony of Patent Owner’s declarant Dr. Singhose, Petitioner argues that a person of ordinary skill in the art “would have known a central straight path has less airflow resistance than a circuitous one.” Reply 22–23 (citing Ex. 1035, 127:15–128:9). But the same witness also testified that higher airflow resistance might be desirable and explained that providing more resistance to airflow might result in improved mixing. Ex. 1035, 21:21–22:12, 127:20–24, 170:10–14. In addition, Dr. Singhose testifies that the complicated design of the airflow passageway in Xia “serves important functions,” including “allow[ing] large droplets to be reabsorbed by the liquid-guiding mechanism,” allowing “excessive liquid in the airflow [to] condense,” and “prevent[ing] the chemical liquid from being sucked into the mouth.” Ex. 2022 ¶ 183 (citing Ex. 1004, 11, 13–14, 16). Although Petitioner’s declarant Dr. Sturges testifies that a straight airflow passageway “would provide improved, smoother air flow,” he does not provide any evidence supporting the view that the air flow would be improved. Ex. 1007 ¶ 118. We credit the testimony of Dr. Singhose that using a straight passageway in Xia would have been detrimental rather than beneficial. Ex. 2022 ¶ 183. Petitioner also argues that the inventors’ use of a straight path is evidence that the use of a straight passageway was “merely common-sense obviousness.” Reply 22–23. This is hindsight. Otsuka Pharm. Co. v. Sandoz, Inc., 678 F.3d 1280, 1296 (Fed. Cir. 2012) (“The inventor’s own path itself never leads to a conclusion of obviousness; that is hindsight.”). Moreover, it does not address the testimony of Dr. Singhose that the use of a complicated passageway like that in Xia had benefits not present in a straight central passageway.” slip op. at 29
- Skill levelSkill level petitioner adoptedOther
“B. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art (“POSITA”) “would have had a mechanical or electrical engineering degree, industrial design degree, or a similar technical degree, or equivalent work experience, and 5 to 10 years of experience in electromechanical devices.” Pet. 10 (citing Ex. 1007 ¶ 16). Prior to institution, Patent Owner stated that, for “the limited purpose of this Preliminary Response,” it “does not challenge the definition of a POSITA set forth in the Petition.” Prelim. Resp. 9. We adopted Petitioner’s proposed definition in our Decision granting institution. During trial, neither party disputed this definition. Upon a complete record, we see no reason to change the adopted definition.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“Patent Owner argues, however, that this presumption is overcome in the present case, and we agree. PO Resp. 28–32. We note that, although the claims require the first aperture to be “on the first end,” the claims still require that the “housing hav[e] a first aperture.” Thus, the issue is whether the aperture must be on the housing itself or part of the housing, as well as whether the aperture is on the first end of the housing. Although “having” and “includes” are used with respect to the solution holding medium to refer to elements located inside the housing, the specification of the ’881 patent suggests that the ends of the housing are part of the housing itself, rather than located inside the housing. First, “the first end . . . can be integrated into a single assembly as part of the housing.” Ex. 1001, 6:16–17. Second, “the housing . . . may comprise the cylindrical wall and two end-caps,” or “the housing . . . may comprise the cartridge wall and a single end-cap.” Id. at 3:55–59. The only figures of the ’881 patent that depict first end 206 show it at the end of the housing rather than located within the interior of housing 202. Id. at Figs. 2, 3. Moreover, there is no requirement to construe a claim term uniformly across multiple uses in the claims when doing so would be nonsensical. Microprocessor Enhancement Corp. v. Texas Instruments, Inc., 520 F.3d 1367, 1375 (Fed. Cir. 2008). Here, construing a first element that is recited as “having” or “includ[ing]” a second element always as encompassing not only second elements that are part of the first element, but also second elements that are located within the interior of the first element, would lead to nonsensical results. Claim 2 recites an airflow passageway “having a length having a circular cross section.” Ex. 1001, 17:59–60. It would be nonsensical to interpret this claim as encompassing an airflow passageway of non-circular cross section that contains another object that has a circular cross section, and neither party argues in favor of such a reading. Similarly, claim 16 recites an “airflow passageway having an interior having a uniform cross-sectional area,” and there is no reason to interpret this claim as encompassing an airflow passageway of non-uniform cross-sectional area that contains another object that itself has uniform cross-sectional area. Id. at 19:47–48. Thus, the claims do not use “having” or “includes” consistently to refer to elements located within the interior of an object; instead, they sometimes use these terms to refer to elements that are a part of an object. See Epcon Gas Sys., Inc. v. Bauer Compressors, Inc., 279 F.3d 1022, 1030–31 (Fed. Cir. 2002) (terms should be construed based on the context of how the terms are used in the claims).” slip op. at 13
- Prior constructionPrior construction not adoptedDecided for patent owner
“When we instituted trial, we preliminarily construed this phrase to encompass apertures that are located within the first end of the housing, determining on the record available at that time that “[t]he term does not require that the first aperture be located in the housing itself.” Inst. Dec. 16. We invited the parties to “address [the] construction of this term during trial,” id., and, on the full record developed during trial, we reach a different conclusion.” slip op. at 10
Patent outcomesUS 10,334,881 not shown unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,334,881 - Innoscience America, Inc. v. Infineon Technologies Americas Corp.Institution deniedPTAB · May 16, 2025 · IPR2025-00010 · APJ Michelle N Wormmeester · IPR · Institution
The Board denied institution of IPR challenging claims 1–14, exercising § 314(a) discretion under Fintiv because the balance of factors favored denial.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“2. Factor 2: ITC Final Determination Date Fintiv provides that an ITC trial date that is earlier than the Board’s projected statutory deadline for a final written decision may favor discretionary denial if the ITC is going to decide the same or substantially similar issues to those presented in the petition. Fintiv, Paper 11 at 8. The Guidance Memo further provides that “the Board is more likely to deny institution where the ITC’s projected final determination date is earlier than the Board’s deadline to issue a final written decision.” Guidance Memo 2. Here, the ITC has set the target date for its final determination to March 2, 2026. Ex. 2010, 3 (ITC Order Amending the Procedural Schedule). Our final written decision would be due almost three months later, in late May 2026, should we institute inter partes review.” slip op. at 8
Discretionary denialPatents in suitUS 9,070,755
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.