• Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentable
  PTAB · Jan 17, 2025 · IPR2024-00597 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9–10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “We also agree with Patent Owner that the charge cut-off voltage is not necessarily the applied voltage during charging. PO Resp. 20. Rather, depending on the charging protocol used and when in the charging cycle the voltage is applied, the applied voltage could be higher than the battery voltage. Ex. 2013; Ex. 2006 ¶ 91. For example, as discussed in more detail below with respect to the Uemura grounds, when fast charging using constant current is used and the charging rate is not slow, the applied voltage will be higher than the battery voltage when the constant current charging phase is stopped. Ex. 2006 ¶ 91; Ex. 2013. Likewise, during constant current/constant voltage charging, the applied voltage approximates the battery voltage only when the battery is nearly completely charged. Ex. 2013; Ex. 2006 ¶ 91. Thus, the applied voltage may be, but is not necessarily, the charge cut-off voltage. In view of the foregoing, we construe “charge cut-off voltage” in claims 1 and 5 as “the maximum value to which the battery is configured to be charged.” PO Resp. 18; Ex. 2008, 217:6–11; Pet. Reply 5. Contrary to Patent Owner’s arguments, however, we do not understand the phrase “configured to be charged” to necessarily represent a single voltage for the battery that is determined based on the structure and chemistry of the battery. Pet. Reply 4–5. Rather, the charge cut-off voltage is a selected potential, or voltage, of the battery or cell at the end of charging that is controlled by a circuit or device, such as a charger or control circuit within the battery. Ex. 1001, 9:50–55; Ex. 1048, 2, 7–8; Ex. 1008, 3:9–13. And, for the reasons discussed herein, the charge cut-off voltage may be, but is not necessarily, the same as the applied voltage during charging. PO Resp. 20.” slip op. at 15

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16

  • Expert testimonyPatent owner expert creditedDecided for patent owner

    “Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122.” slip op. at 21

  Patent outcomesUS 7,749,641 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,749,641
• Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentable
  PTAB · Jan 17, 2025 · IPR2023-01183 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9 and 10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “constructions. First, we agree with Petitioner that the ’641 patent indicates that the charge cut-off voltage selected for a particular battery need not be a fixed property of the battery or something that is set by the design and chemistry of the battery. Consistent with this conclusion, the ’641 patent discloses that a “charging device controls the charge cut-off voltage of the single lithium-ion cell within a range from 4.3 V to 5.8 V.” Ex. 1001, 9:50– 55. This strongly suggests that the charge cut-off voltage is controlled by the charger and is not necessarily an inherent property of the battery. Patent Owner contends that this is merely an unclaimed embodiment, but the relevant disclosure states that the charging device for the “present invention” may be any type of device “with the proviso that said charging device controls the charge cut-off voltage.” Id. at 9:50–53.” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16

  • Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner

    “Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122. Petitioner argues that because the battery of Uemura is charged “to” a maximum voltage of 4.3 V, Uemura discloses the claimed charge cut-off voltage under either Petitioner’s or Patent Owner’s construction of the term. Pet. Reply 11–12 (citing Ex. 1009 ¶ 81; Ex. 1044 ¶¶ 56–59). This argument is not persuasive because Mr. Juzkow unambiguously testified that charging in Uemura stopped when the applied voltage reached 4.3 V, and Uemura discloses that the battery was charged “at” a voltage ranging from 4.3 V to 2.0 V, not “to” such a voltage. Ex. 1009 ¶ 81; Ex. 2008, 113:2–13; Ex. 2006 ¶ 119 n.64; Sur-reply 9. In view of the foregoing, we determine that Petitioner has not demonstrated by a preponderance of the evidence that Uemura anticipates independent claims 1 and 5 of the ’641 patent.” slip op. at 21

  Patent outcomesUS 7,749,641 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,749,641
• Chongqing Yanmei Technology Co., Ltd. v. Terves, LLCSome claims unpatentable
  PTAB · Aug 27, 2024 · IPR2023-00521 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 19–61, 63–77, and 79 are unpatentable as anticipated by Doud; claims 78, 80, and 81 are not shown unpatentable. The contingent motion to amend is granted in part and denied in part.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have at least a Ph.D. in chemistry, metallurgy, or material science or material engineering” or, in the alternative, “would have a Bachelor of Science or Master of Science degree in one of these disciplines plus experience involving the use and design of dissolvable metal alloys for use in creating tools and other downhole parts for well drilling or completion activities.” Pet. 13–14. Patent Owner does not oppose Petitioner’s contentions regarding the level of ordinary skill in the art. PO Resp. 12 n.4. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the ordinarily skilled artisan as it is consistent with the prior art of record.” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner

    “With respect to claim 19, Petitioner proposes constructions for the terms “in situ precipitate” and “a plurality of particles of said in situ precipitate having a size of no more than 50 µm.” Pet. 11–12. With respect to claims 76–81, Petitioner proposes a construction for the term “wherein said additive material includes one or more metal materials selected from the group consisting of 0.1–35 wt. % copper, 0.1–24.5 wt. % nickel and 0.1–20 wt. % cobalt.” Id. at 13. Patent Owner contends no claims require construction for purposes of this Decision. PO Resp. 12 n.4, 17–18; Mot. 16–17. Upon review of the prior art of record, we determine that no claim terms require express construction for purposes of this Final Written Decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 8

  • Disclosure Requirements (§112) › Written description (Ariad)Written description inadequateWritten description adequateMixed

    “Ex. 2027, 20:25–21:5 (emphasis added). The disclosure that the “magnesium composite” of “[t]he present invention” “includes at least 50 wt% magnesium” is unambiguous and constitutes strong evidence that the inventors were not in possession of a magnesium composite with less than 50 wt. % magnesium, or additive concentrations above 50 wt. %. See SciMed Life Systems, Inc. v. Advanced Cardiovasular Systems, Inc., 242 F.3d 1337, 1343 (Fed. Cir. 2001) (noting that a description of the “present invention” as having a particular structure “is strong evidence that the claims should not be read to encompass the opposite structure”). Consistent with this conclusion, the original claims of the ’295 application all limited the additive material in the composite to 0.05 wt %–45 wt %. Ex. 2027, 26:1– 13, 29:9–15. Likewise, in each example where copper, nickel, or cobalt additives are used in the range recited in the proposed substitute claims, the magnesium composite is “over 50 wt% magnesium,” and any claims that do not require this range of magnesium are limited to an additive range of “about 0.05 wt%–45 wt% of said mixture.”8 Ex. 2027, 6:13–7:4, 7:16–19, 8 Written description support is considered from the view point of the ordinarily skilled artisan. Ariad Pharms., Inc. v. Eli Lilly and Co., 598 F.3d 1336, 1351 (Fed. Cir. 2010) (en banc). Patent Owner, bearing the burden to show written description support in any priority application for which it seeks the benefit of its filing date, provides no testimony from an ordinarily skilled artisan regarding written description support in the ’295 application, or any evidence to show what such an artisan would conclude from the express disclosures of the ’295 application. Lectrosonics, Paper 15 at 7; In re NTP, 654 F.3d 1268, 1276 (Fed. Cir. 2011) (noting that “a patent’s claims are not entitled to an earlier priority date merely because the patentee claims priority . . . Rather, for a patent’s claims to be entitled to an earlier priority date, the patentee must demonstrate that the claims meet the requirements of 35 U.S.C. § 120”). Where there is any ambiguity in the disclosures of the ’295 application, the absence of supporting testimony tends to cut against 26:2–31:2; see Ex. 1005 ¶¶ 12, 13, 18, 19, 16–21, 26, 28, claims 16–21, 26– 28. In view of the foregoing, we are not persuaded that Patent Owner has demonstrated that the inventors of the priority applications were in possession of a magnesium cast composite that included less than 50 wt. % magnesium, or greater than 50 wt. % additives. As proposed substitute claim 104 encompasses a magnesium cast composite with up to 90 wt. % additives, and therefore as little as 10 wt. % magnesium, Patent Owner has not demonstrated that the full scope of this claim finds written description support in any application prior to the ’915 application, filed on October 12, 2018.” slip op. at 17

  • Disclosure Requirements (§112) › Definiteness (Nautilus)DefiniteIndefiniteMixed

    “The definiteness requirement of § 112(a) is satisfied when “a patent’s claims, viewed in light of the specification and prosecution history, inform those skilled in the art about the scope of the invention with reasonable clarity.” Nautilus, Inc. v. Biosig Instruments, Inc., 572 U.S. 898, 910 (2014); see 37 C.F.R. § 42.100(b) (changing the claim construction standard used to review a claim proposed in a motion to amend from the broadest reasonable construction to the “same construction standard that would be used to construe the claim in a civil action under 35 U.S.C. [§] 282(b)”). Proposed substitute claim 104 generically requires “in situ precipitate” and also a specific type of in situ precipitate: “in situ galvanically-active intermetallic precipitate.” Mot. Appendix A. Although this claim would have best been clarified by Patent Owner after seeking preliminary guidance on its Motion to Amend, upon review of the written description, claims, and figures of the ’740 patent, as well as Patent Owner’s clarification in its Reply to the Opposition, we agree with Patent Owner that one of ordinary skill in the art would have understood that the “in situ galvanically-active intermetallic precipitate” is merely a more complete description of the “in situ precipitate” mentioned earlier in the sentence. Mot. Reply 4. As such, we do not find that this part of proposed substitute claim renders claim 104 indefinite.” slip op. at 22

  Patent outcomesUS 10,689,740 mixed
  Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Graham · Nautilus
  Patents in suitUS 10,689,740
• Samsung Electronics Co., Ltd. v. Lynk Labs, Inc.Some claims unpatentable
  PTAB · May 5, 2023 · IPR2022-00098 · APJ Arthur M Peslak · IPR · Final written decision

  Claims 1, 3, and 4 are unpatentable as obvious over the stated combinations; claim 2 was not shown unpatentable because the driver was not shown configured to receive the rectifier’s forward voltages.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with Patent Owner that a person of ordinary skill in the art would have had experience in LED devices. For this reason, we apply Patent Owner’s proposed level of ordinary skill in the art because it comports with the level of skill reflected in the ’149 patent and the prior art of record. However, if we were to apply Petitioner’s proposed level of skill, our Decision would not be affected.” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Upon review of the entire record, we determine that no claim terms require express construction. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (noting that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’”) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10

  • Expert testimonyPetitioner expert creditedPatent owner expert discountedMixed

    “Dr. Ducharme’s testimony that “the spacing of the chips in Zhang would not likely be so close as to create overheating issues” (Ex. 2002 ¶ 111) is unsupported by any disclosure of the actual spacing of Zhang’s chips. Consequently, his testimony that there would be no overheating concerns in Zhang due to the spacing of the chips is entitled to little, if any, weight. Dr. Ducharme further testifies that the components of Zhang’s driver “could easily increase the temperature of the LED 19 chips on the circuit board, which can cause LEDs to generate less illumination, burn out and otherwise adversely affect their performance.” Ex. 2002 ¶ 126. Dr. Ducharme further testifies that “[i]t is well-known that excessive operational temperatures can reduce the illumination provided by the LEDs, can decrease the operational lifetime of the LEDs, and if the temperature is sufficiently high, it can cause LED junction failure and a burnt-out LED.” Id. We agree with this testimony, which as discussed below, is consistent with Salam. Dr. Ducharme’s testimony concerning overheating issues caused by the driver components contradicts Patent Owner’s ’s contention that there would not be “an overheating issue with Zhang’s LED exit sign circuit in Figure 2.1.” PO Resp. 30. Regardless of whether Zhang’s LEDs in Figure 2.1 have a heat problem or not, Salam teaches the advantages of using a heat sink. Salam teaches that a heat sink will result in a higher efficiency of the LEDs and improved life. Ex. 1006, 16:38–43. The Federal Circuit, in DyStar Textilfarben GmBH & Co v. C.H. Patrick Co., 464 F.3d 1356 (Fed. Cir. 2006), stated that “the desire to enhance commercial opportunities by improving a product or process is universal–and even common-sensical . . . the proper question is whether the ordinary artisan possesses the knowledge and skills rendering him capable of combining the prior art references.” Id. at 1368. Dr. Ducharme testified that a person of ordinary skill in the art “would have an understanding of the generation of heat and using a heat sink to remove unwanted heat from electronics and LED lighting devices.” Ex. 1102, 23:18–24:3. Dr. Ducharme’s testimony is consistent with Petitioner’s contention that the combination of Zhang and Salam “would have been a straightforward combination of known components and technologies, according to known methods, to produce the predictable result of reducing/ mitigating heat effects in a circuit.” Pet. 17 (citing Ex. 1002 ¶ 106). Patent Owner next contends it would be extremely burdensome and costly to modify Zhang to add a heat sink layer because “each of the multiple chips mounted and epoxied to Zhang’s circuit board in the exit sign would have to be modified.” PO Resp. 30 (citing Ex. 2002 ¶ 112). Dr. Ducharme’s testimony repeats the Patent Owner Response verbatim and is entitled to little, if any, weight. Ex. 2002 ¶ 112. Nonetheless, this contention is unavailing because it is based on Patent Owner’s bodily incorporation of Zhang and Salam. Patent Owner next contends that a person of ordinary skill in the art” slip op. at 27

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable

    “Regardless of whether Zhang’s LEDs in Figure 2.1 have a heat problem or not, Salam teaches the advantages of using a heat sink. Salam teaches that a heat sink will result in a higher efficiency of the LEDs and improved life. Ex. 1006, 16:38–43. The Federal Circuit, in DyStar Textilfarben GmBH & Co v. C.H. Patrick Co., 464 F.3d 1356 (Fed. Cir. 2006), stated that “the desire to enhance commercial opportunities by improving a product or process is universal–and even common-sensical . . . the proper question is whether the ordinary artisan possesses the knowledge and skills rendering him capable of combining the prior art references.” Id. at 1368. Dr. Ducharme testified that a person of ordinary skill in the art “would have an understanding of the generation of heat and using a heat sink to remove unwanted heat from electronics and LED lighting devices.” Ex. 1102, 23:18–24:3. Dr. Ducharme’s testimony is consistent with Petitioner’s contention that the combination of Zhang and Salam “would have been a straightforward combination of known components and technologies, according to known methods, to produce the predictable result of reducing/ mitigating heat effects in a circuit.” Pet. 17 (citing Ex. 1002 ¶ 106).” slip op. at 27

  Patent outcomesUS 10,517,149 mixed
  Claim construction§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 10,517,149
• Ford Motor Company v. Safe Driving Technologies LLCSome claims unpatentable
  PTAB · Mar 10, 2023 · IPR2021-01446 · APJ Alyssa A Finamore · IPR · Final written decision

  Claims 1–4, 6, 10, 12–14, 16, 17, and 19–21 are unpatentable under §103; claim 15 was not shown unpatentable.

  RulingsFinal written decision

  • ExcludeMotion to exclude, grantedGranted

    “Our rules and Consolidated Trial Practice Guide are clear on this prohibition. And, the Consolidated Trial Practice Guide explains: “[w]here a party believes it has a basis to request relief on a ground not identified in the rules, the party should contact the Board and arrange for a conference call with the Board and opposing party to discuss the requested relief with the judge handling the proceeding.” CTPG 75. Thus, the Board identifies appropriate ways for a party to address matters that it considers to be beyond the specific procedures outlined in the rules. Merely submitting new evidence was not authorized by Board rules or guidance and Patent Owner did not seek authorization to file the new evidence. The facts warrant excluding Exhibits 2030–2032 and we grant the Motion. See CTPG 81.” slip op. at 83

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableNot shown unpatentableMixed

    “underpinnings, why a person of ordinary skill would have been motivated to modify the prior art to achieve the claimed invention. In re Magnum Oil Tools Int’l, Ltd., 829 F.3d 1364, 1380 (Fed. Cir. 2016) (“To satisfy its burden of proving obviousness, a petitioner . . . must . . . articulate specific reasoning, based on evidence of record, to support the legal conclusion of obviousness.” (citing KSR, 550 U.S. at 418)). Nonetheless, “a disclosure that anticipates under § 102 also renders the claim invalid under § 103, for ‘anticipation is the epitome of obviousness.’” Connell v. Sears, Roebuck & Co., 722 F.2d 1542, 1548 (Fed. Cir. 1983) (quoting In re Fracalossi, 681 F.2d 792 (CCPA 1982)); see also Application of Pearson, 494 F.2d 1399, 1402 (CCPA 1974) (“[T]his court has sanctioned the practice of nominally basing rejections on § 103 when, in fact, the actual ground of rejection is that the claims are anticipated by the prior art. The justification for this sanction is that a lack of novelty in the claimed subject matter, e.g., as evidenced by a complete disclosure of the invention in the prior art, is the ‘ultimate or epitome of obviousness.’” (citations and footnote omitted)).” slip op. at 14

  Patent outcomesUS 9,047,170 mixed
  § 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,047,170
• Allstate Insurance Company v. Atos, LLCSome claims unpatentable
  PTAB · Jan 24, 2023 · IPR2021-01209 · APJ Richard H Marschall · IPR · Final written decision

  Claims 1–4, 6, and 9–25 are unpatentable; claims 5, 7, and 8 are not shown unpatentable, based on anticipation by Kim and obviousness grounds.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “B. Level of Ordinary Skill in the Art The level of ordinary skill in the art is “a prism or lens” through which” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other

    “C. Claim Construction In inter partes reviews, we interpret claims under the same standard” slip op. at 10

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableNot shown unpatentableMixed

    “Accordingly, Petitioner fails to establish that Kim discloses “determining that the individual is a driver of the vehicle based at least in part on acceleration, forces, velocity, the at least one location point, and time.”” slip op. at 46

  • Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner

    “nexus and therefore fails to establish that any alleged evidence of objective indicia supports a finding of non-obviousness. Accordingly, we give Patent Owner’s reliance on objective indicia of non-obviousness no weight in our obviousness analysis.” slip op. at 65

  Patent outcomesUS 9,152,609 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,152,609
• Allstate Insurance Company v. Atos, LLCSome claims unpatentable
  PTAB · Jan 9, 2023 · IPR2021-01118 · APJ Richard H Marschall · IPR · Final written decision

  Claims 1–5, 7, 8, 10–16, and 18 are unpatentable; claims 6, 9, and 17 were not shown unpatentable, because the asserted prior art did not establish all limitations.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “B. Level of Ordinary Skill in the Art The level of skill in the art is “a prism or lens” through which we view” slip op. at 9

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “2. Discussion Petitioner argues that Kim discloses every limitation of claim 1, and” slip op. at 23

  • Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner

    “2. Discussion We begin our analysis by addressing Patent Owner’s asserted objective indicia of non-obviousness, and then turn to the merits of Petitioner’s specific obviousness challenges before us.” slip op. at 52

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundMotivation not foundMixed

    “the combination of Kim and Baker discloses “comparing the at least one current geographic location to the first geographic location; setting the location of the individual to the individual is in an outside of the vehicle location, when a distance between the at least one current and the first geographic locations exceeds a predetermined threshold.” Accordingly, we determine that Petitioner has not established by a preponderance of the evidence that claim 6 would have been obvious based on Kim and Baker.” slip op. at 90

  Patent outcomesUS 8,527,140 mixed
  § 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,527,140
• Alcon Inc. / Alcon Vision, LLC et al. v. Amo Development, LLCSome claims unpatentable
  PTAB · Dec 6, 2022 · IPR2021-00856 · APJ Ryan H Flax · IPR · Final written decision

  Claims 1–15 are unpatentable over the asserted §103 grounds; claims 17–23 were not shown unpatentable.

  RulingsFinal written decision

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableNot shown unpatentableMixed

    “persuasive and credit Dr. Kang’s testimony that Freedman’s ablating laser is incompatible with laser surgery on the lens or lens capsule during cataract surgery. Ex. 2087 ¶¶ 49–51, 79–82. This is because the ablating laser cannot pass through the cornea to reach the lens without destroying the cornea in the process. Id. ¶¶ 79, 82. In contrast, lasers used to cut internal tissues of the eye use laser photodisruption. Id. ¶ 80. Accordingly, we find that one of ordinary skill in the art would not have used Freedman’s system to perform surgery on the lens or lens capsule, as asserted by Petitioner.” slip op. at 76

  • Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner

    “exhibit provides no context or rationale for the award and, as discussed above, the Catalys product is composed of many components and systems not specifically covered by the challenged claims. Ex. 2043, 3. Patent Owner points also to a report dated June 28, 2012, as evidencing that this award was for the specific features of the Catalys product claimed, but this evidence lacks any identification of the author and the portion identifying features of the product appears to merely be listing features thereof rather identifying than any reason for the award. Ex. 2040. Additionally, the evidence of praise cited by Patent Owner is not specific to the subject matter of claim 1 (and its dependent claims) of the ’724 patent, but general praise for the FLACS system and laser-guided femtosecond laser procedures. See Ex. 2035; Ex. 2037; Ex. 2044; Ex. 2051. For these reasons, we are not persuaded by Patent Owner’s arguments or evidence on industry praise.” slip op. at 51

  Patent outcomesUS 8,500,724 mixed
  § 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,500,724
• Runway Safe Group AB v. Earthstone International LLC And W. Gene RamseySome claims unpatentable
  PTAB · Feb 17, 2021 · IPR2019-01490 · APJ Ryan H Flax · IPR · Final written decision

  Claims 1–11 and 13–16 are unpatentable as obvious; claim 12 was not shown unpatentable because the asserted grounds did not establish its interconnected open porosity limitation.

  RulingsFinal written decision

  • BurdenFwd mixedMixed

    “proving unpatentability of the challenged claims, and the burden of persuasion never shifts to Patent Owner. Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1378 (Fed. Cir. 2015). To prevail, Petitioner must prove unpatentability by a preponderance of the evidence. See 35 U.S.C. § 316(e) (2018); 37 C.F.R. § 42.1(d) (2019). This Final Written Decision is issued pursuant to 35 U.S.C. § 318(a) and 37 C.F.R. § 42.73. After considering the parties’ arguments and supporting evidence, we conclude that Petitioner has proven by a preponderance of the evidence that claims 1–11 and 13–16 of the ’671 patent are unpatentable. 35 U.S.C. § 316(e). Petitioner has not met that burden with respect to claim 12.” slip op. at 2

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner

    “any of Narmo, Hojaji, and Ramsey. Resp. 8, 16–17. On this record, we conclude it would have been obvious to the person of ordinary skill in the art to combine the teachings of ACRP and Narmo, Hojaji, or Ramsey, as asserted by Petitioner. Moreover, we also conclude such combinations merely use specific foamed glass compositions in structures already using foamed glass compositions and that the skilled artisan would have reasonably expected to successfully do so. See Ex. 1002 ¶¶ 78, 81, 84. The simplicity of the technology and the reasonably high level of skill in the art support such a conclusion.” slip op. at 57

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element) › Inherent disclosureInherency not foundNot shown unpatentable

    “disclosed foamed glass aggregate bodies to have an “interconnected open porosity” is based on an allegation of inherency, where the open porosity forms because of weathering. See Pet. 38–39 (citing Ex. 1002 ¶ 75). Similar to our conclusion regarding Ground 6, we also find that Petitioner has not demonstrated that the subject matter of claim 12 would have been obvious over ACRP. We are directed to no evidence of record that the interconnected open porosity limitation would necessarily be present or would be the natural result of weathering, as asserted by Petitioner. See Endo Pharm., 894 F.3d at 1381. To the extent that Petitioner’s argument is premised on a KSR “obvious to try” rationale, as with Ground 6, we find Petitioner presents no evidence that a person of ordinary skill in the art would have had any reason to pursue the claimed interconnected open porosity, no evidence of a design need for such a structure, and no evidence of market pressure to solve any problem relating to foamed glass porosity. KSR, 550 U.S. at 421. Indeed, Petitioner failed to clearly articulate any obvious to try rationale in the Petition.” slip op. at 74

  • Strike new argumentNew argument consideredDenied

    “III. PARTIES’ MOTIONS TO STRIKE OR EXCLUDE Petitioner filed a Motion to Strike Patent Owner’s Sur-Reply for” slip op. at 77

  Patent outcomesUS 9,382,671 mixed
  § 102 anticipation§ 103 obviousnesscites Phillips · KSR
  Patents in suitUS 9,382,671
• Renesas Electronics Corporation / Renesas Electronics America, Inc. v. Lone Star Silicon Innovations, LLCSome claims unpatentable
  PTAB · Mar 25, 2019 · IPR2017-01869 · APJ Elizabeth M Roesel · IPR · Final written decision

  Claims 1, 4–6, 9, and 10 are unpatentable as obvious over Igarashi and Tanaka (1999); claims 2 and 7 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “For purposes of our Institution Decision, we accepted the definition of a POSA provided by Dr. Bottoms. Dec. 10–11 (citing Ex. 2001 ¶ 31). Dr. Bottoms provides a “clarification” of the Board’s description, testifying that “[t]he specific industry experience would require process design experience—which is experience beyond managing fabrication equipment.” Ex. 2011 ¶ 36. Dr. Bottoms’ clarification is consistent with the level of skill reflected by the ’330 patent, which discloses process design options for making a low dielectric constant silicon nitride etch stop. Ex. 1001, 5:66-6:24. Dr. Neikirk testifies that, under Dr. Bottoms’ definition, a POSA has a higher degree of skill than under Dr. Neikirk’s definition, and the Board’s adoption of Dr. Bottoms’ definition would not change his opinions regarding obviousness. Ex. 1028 ¶ 14. We find there is little difference between the declarants’ definitions of a POSA, and the outcome of our patentability determinations would be the same, regardless of which definition we accept. For the sake of clarity, we adopt Dr. Bottoms’ definition of a POSA, including the recent clarification. Ex. 2011 ¶¶ 35, 36. We also rely on the cited prior art references as reflecting the level of ordinary skill in the art at the time of the invention. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 12

  • Expert testimonyPetitioner expert creditedPatent owner expert creditedOther

    “After reviewing the qualifications of Dr. Neikirk and Dr. Bottoms, as set forth in each witness’s declaration and curriculum vitae, we find that each of these declarants has sufficient education and experience related to the subject matter of the ’330 patent to testify regarding the perspective of a POSA at the time of the invention. Ex. 1011 ¶¶ 2, 3; Ex. 1012; Ex. 2002; Ex. 2011 ¶¶ 8–20. See Trial Practice Guide Update, 83 Fed. Reg. 39,989 (Aug. 13, 2018), available at https://go.usa.gov/xU7GP (“TPG Update”), 3 (“A person may not need to be a person of ordinary skill in the art in order to testify as an expert under Rule 702, but rather must be ‘qualified in the pertinent art.’” (quoting Sundance, Inc. v. DeMonte Fabricating Ltd., 550 F.3d 1356, 1363–64 (Fed. Cir. 2008))). D.” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “In the Institution Decision, we determined that it was not necessary to resolve the parties’ claim construction dispute. Dec. 9–10. Neither party challenges that determination. Petitioner contends that the asserted grounds of unpatentability apply under either party’s construction for the phrase “etch stop layer of silicon nitride.” Pet. 25 n.3. Patent Owner argues that this phrase is not limited to a layer of pure silicon nitride and allows for the presence of dopants and/or impurities. PO Resp. 8–10. Patent Owner does not, however, rely on its proposed claim construction for any patentability argument. In fact, Patent Owner acknowledges that the silicon nitride materials disclosed in the Low-K References satisfy Patent Owner’s proposed construction. PO Resp. 10. Under these circumstances, we agree with Petitioner that we do not need to resolve the parties’ claim construction dispute. Pet. Reply 2. Accordingly, consistent with the Institution Decision, we determine that we do not need to provide an express construction for any claim term for purposes of resolving the controversy. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). B.” slip op. at 10

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable

    “copper interconnects need silicon nitride films as an etch stop, but that such films have a high dielectric constant, which causes an undesirable increase in the effective dielectric constant of the interconnect structure and increased parasitic capacitance, as compared with aluminum interconnects. Ex. 1021, 829-1, 829-2; see Pet. 18; Ex. 1011 ¶¶ 92, 93. As Petitioner correctly points out (Pet. 53–54), Tanaka (1999) cites Igarashi as an example of a copper interconnect system that is degraded by parasitic capacitance due to the high permittivity (dielectric constant) of silicon nitride etch stop films. Ex. 1017, 47-1 n.1. Tanaka (1999) discloses a low dielectric constant silicon nitride etch stop film as a solution to the problem of parasitic capacitance in copper damascene interconnect structures, such as Igarashi’s. Id. at 47-1, 47-2 (“New low-k SiN film, with a permittivity of 5.4 . . . should be the solution to realize Cu damascene interconnects . . . .”). Consistent with these express disclosures, Dr. Neikirk persuasively testifies that “Igarashi identifies a need for a low-k dielectric etch stop layer” and “Tanaka (1999) meets this need.” Ex. 1011 ¶ 94; see Pet. 18 (citing Ex. 1011, § VIII.C., which contains paragraph 94 of Dr. Neikirk’s testimony). Accordingly, we find Petitioner has shown by a preponderance of the evidence that a POSA would have been motivated to use the low dielectric constant silicon nitride etch stop film of Tanaka (1999) as the etch stop layer in the interconnect system of Igarashi. Patent Owner disputes whether Petitioner has established a reasonable expectation of success for the combination of Tanaka (1999)’s low dielectric constant silicon nitride etch stop film and Igarashi’s interconnect structure. PO Resp. 65. Although the Petition does not expressly discuss whether one of ordinary skill in the art would have had a reasonable expectation of success in combining Tanaka and Igarashi to arrive at the claimed invention, Petitioner shows a very close relationship between the teachings of Tanaka (1999) and Igarashi. Pet. 12–13, 17–18, 53–62. As discussed above and argued by Petitioner, Tanaka (1999): (1) cites Igarashi as an example of a copper interconnect system that suffers from parasitic capacitance due to the high dielectric constant of silicon nitride etch stop films, and (2) discloses a low dielectric constant silicon nitride etch stop film as a solution to the parasitic capacitance problem exemplified by Igarashi. Pet. 13, 18, 53–54; Ex. 1011 ¶¶ 74–79, 88–94; Ex. 1017, 47-1 & n.1; Ex. 1021, 829-1, 829-2. Petitioner establishes a reasonable expectation of success for the combination of Tanaka (1999) and Igarashi by demonstrating a strong correlation between the problem discussed by Igarashi—the high dielectric constant of silicon nitride films when used as etch stops for copper interconnects—and the solution disclosed by Tanaka (1999)—a low dielectric constant silicon nitride film for use as an etch stop layer in copper damascene interconnect structures. In re Inland Steel Co., 265 F.3d 1354, 1364 (Fed. Cir. 2001) (“[T]he strength of the correlation between the references gives rise to a reasonable expectation of success from combining them.”).” slip op. at 27

  Patent outcomesUS 6,388,330 mixed
  Claim construction§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 6,388,330

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.