• Intel Corporation v. Besang Inc.No claims unpatentable
  PTAB · Dec 11, 2024 · IPR2023-00991 · APJ Jon B Tornquist · IPR · Final written decision

  The Board held claims 1 and 13–17 not unpatentable, finding the asserted obviousness grounds deficient in claim limitations or motivation to combine.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “The parties proposed definitions differ in that Petitioner would permit a degree in “materials science” and require three years, as opposed to two years, of relevant experience. Compare Pet. 9 with PO Resp. 14. On this record, we adopt Patent Owner’s proposed definition, as it is more consistent with the prior art of record and the disclosures of the ’702 patent. We note, however, that neither party contends that the outcome of this case depends on the slight differences in the proposed definitions of a person of ordinary skill in the art.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner

    “1996) (“It is well-settled that, in interpreting an asserted claim, the court should look first to the intrinsic evidence of record, i.e., the patent itself, including the claims, the specification and, if in evidence, the prosecution history.”). Upon review of the parties’ arguments and the intrinsic record, we agree with Petitioner that the ’702 patent does not support a construction of “stackable add-on layer” that encompasses memory cells formed by sequential deposition on a substrate without being formed and then added to a separately formed substrate. Pet. 11–12. First, the plain language of the claim does not require merely a “layer” having a plurality of vertically oriented semiconductor memory cells, but rather “a stackable add-on layer” having a plurality of vertically oriented semiconductor memory cells; that plurality is bonded to the dielectric layer. Ex. 1001, 12:29–32. A construction that gives meaning to all words of the claim is preferred. Merck & Co., Inc. v. Teva Pharm. USA, Inc., 395 F.3d 1364, 1372 (Fed. Cir. 2005) (“A claim construction that gives meaning to all the terms of the claim is preferred over one that does not do so.”).” slip op. at 12

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “As discussed above, we do not understand a “stackable add-on layer” to include memory cells that are formed by sequential deposition on or above a substrate without being added to a separately formed substrate. It is undisputed, and indeed it is Petitioner’s assertion, that Lee’s memory devices are formed by sequential deposition. Pet. 16, 29 n.11, 51 (“In Lee, each level 3104 is deposited on the underlying level of array 3101.”). Therefore, Petitioner has not shown that Lee discloses every limitation of independent claim 13 under our claim construction. Thus, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious in view of Lee. 3. Analysis: Claims 14–17 Claims 14–17 each depend, directly or indirectly, from claim 13. Petitioner’s arguments with respect to these claims do not remedy the deficiencies noted above with respect to claim 13. Pet. 31–41. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 14–17 would have been obvious over Lee.” slip op. at 19

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable

    “We agree with Patent Owner that Petitioner has not demonstrated that Aspar would improve Lee, would solve a problem in Lee, and that Petitioner is proposing to use Aspar in a way that is not disclosed in the reference. PO Resp. 49–50 (citing Ex. 2029 ¶¶ 153–162); Tr. 57:24–58:12; Pet. 61; KSR, 550 U.S. at 417 (asking whether a technique “would improve similar devices in the same way”), 420 (asking whether there was a known problem in the art), 421 (asking whether one of ordinary skill in the art had reason to “pursue the known options”); Intel, 61 F.4th at 1381 (explaining that obviousness may be demonstrated by showing that there was a known problem in the art (“cache coherency in multiprocessor systems”) and that a person of ordinary skill in the art would recognize that that the prior art solution to this problem (“global segmented secondary cache”) would improve the system of another prior art reference). Petitioner does not persuasively show that there was any known problem in the art with respect to Lee or its monolithic method of constructing memory arrays. Nor does Petitioner provide persuasive argument or evidence that Aspar’s wafer bonding would improve Lee’s memory device.10 For example, Petitioner states in a conclusory fashion that Aspar would address the known problem of “fabricating 3D structures,” but does not explain what those problems were or why Lee fails to solve them. Pet. 61. Dr. Sechen’s testimony merely parrots the Petition, providing no further analysis or explanation of what problem might exist in Lee when fabricating its 3D structures. Ex. 1003 ¶ 212. The Petition notes that Aspar transfers “thin layers of very good thickness homogeneity and with a high crystalline quality,” but the Petition never asserts that Lee’s direct deposition method fails to provide these same or similar qualities. Pet. 60–61.” slip op. at 27

  Patent outcomesUS 7,378,702 not shown unpatentable
  Claim construction§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,378,702
• Chongqing Yanmei Technology Co., Ltd. v. Terves, LLCSome claims unpatentable
  PTAB · Aug 27, 2024 · IPR2023-00521 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 19–61, 63–77, and 79 are unpatentable as anticipated by Doud; claims 78, 80, and 81 are not shown unpatentable. The contingent motion to amend is granted in part and denied in part.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have at least a Ph.D. in chemistry, metallurgy, or material science or material engineering” or, in the alternative, “would have a Bachelor of Science or Master of Science degree in one of these disciplines plus experience involving the use and design of dissolvable metal alloys for use in creating tools and other downhole parts for well drilling or completion activities.” Pet. 13–14. Patent Owner does not oppose Petitioner’s contentions regarding the level of ordinary skill in the art. PO Resp. 12 n.4. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the ordinarily skilled artisan as it is consistent with the prior art of record.” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner

    “With respect to claim 19, Petitioner proposes constructions for the terms “in situ precipitate” and “a plurality of particles of said in situ precipitate having a size of no more than 50 µm.” Pet. 11–12. With respect to claims 76–81, Petitioner proposes a construction for the term “wherein said additive material includes one or more metal materials selected from the group consisting of 0.1–35 wt. % copper, 0.1–24.5 wt. % nickel and 0.1–20 wt. % cobalt.” Id. at 13. Patent Owner contends no claims require construction for purposes of this Decision. PO Resp. 12 n.4, 17–18; Mot. 16–17. Upon review of the prior art of record, we determine that no claim terms require express construction for purposes of this Final Written Decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 8

  • Disclosure Requirements (§112) › Written description (Ariad)Written description inadequateWritten description adequateMixed

    “Ex. 2027, 20:25–21:5 (emphasis added). The disclosure that the “magnesium composite” of “[t]he present invention” “includes at least 50 wt% magnesium” is unambiguous and constitutes strong evidence that the inventors were not in possession of a magnesium composite with less than 50 wt. % magnesium, or additive concentrations above 50 wt. %. See SciMed Life Systems, Inc. v. Advanced Cardiovasular Systems, Inc., 242 F.3d 1337, 1343 (Fed. Cir. 2001) (noting that a description of the “present invention” as having a particular structure “is strong evidence that the claims should not be read to encompass the opposite structure”). Consistent with this conclusion, the original claims of the ’295 application all limited the additive material in the composite to 0.05 wt %–45 wt %. Ex. 2027, 26:1– 13, 29:9–15. Likewise, in each example where copper, nickel, or cobalt additives are used in the range recited in the proposed substitute claims, the magnesium composite is “over 50 wt% magnesium,” and any claims that do not require this range of magnesium are limited to an additive range of “about 0.05 wt%–45 wt% of said mixture.”8 Ex. 2027, 6:13–7:4, 7:16–19, 8 Written description support is considered from the view point of the ordinarily skilled artisan. Ariad Pharms., Inc. v. Eli Lilly and Co., 598 F.3d 1336, 1351 (Fed. Cir. 2010) (en banc). Patent Owner, bearing the burden to show written description support in any priority application for which it seeks the benefit of its filing date, provides no testimony from an ordinarily skilled artisan regarding written description support in the ’295 application, or any evidence to show what such an artisan would conclude from the express disclosures of the ’295 application. Lectrosonics, Paper 15 at 7; In re NTP, 654 F.3d 1268, 1276 (Fed. Cir. 2011) (noting that “a patent’s claims are not entitled to an earlier priority date merely because the patentee claims priority . . . Rather, for a patent’s claims to be entitled to an earlier priority date, the patentee must demonstrate that the claims meet the requirements of 35 U.S.C. § 120”). Where there is any ambiguity in the disclosures of the ’295 application, the absence of supporting testimony tends to cut against 26:2–31:2; see Ex. 1005 ¶¶ 12, 13, 18, 19, 16–21, 26, 28, claims 16–21, 26– 28. In view of the foregoing, we are not persuaded that Patent Owner has demonstrated that the inventors of the priority applications were in possession of a magnesium cast composite that included less than 50 wt. % magnesium, or greater than 50 wt. % additives. As proposed substitute claim 104 encompasses a magnesium cast composite with up to 90 wt. % additives, and therefore as little as 10 wt. % magnesium, Patent Owner has not demonstrated that the full scope of this claim finds written description support in any application prior to the ’915 application, filed on October 12, 2018.” slip op. at 17

  • Disclosure Requirements (§112) › Definiteness (Nautilus)DefiniteIndefiniteMixed

    “The definiteness requirement of § 112(a) is satisfied when “a patent’s claims, viewed in light of the specification and prosecution history, inform those skilled in the art about the scope of the invention with reasonable clarity.” Nautilus, Inc. v. Biosig Instruments, Inc., 572 U.S. 898, 910 (2014); see 37 C.F.R. § 42.100(b) (changing the claim construction standard used to review a claim proposed in a motion to amend from the broadest reasonable construction to the “same construction standard that would be used to construe the claim in a civil action under 35 U.S.C. [§] 282(b)”). Proposed substitute claim 104 generically requires “in situ precipitate” and also a specific type of in situ precipitate: “in situ galvanically-active intermetallic precipitate.” Mot. Appendix A. Although this claim would have best been clarified by Patent Owner after seeking preliminary guidance on its Motion to Amend, upon review of the written description, claims, and figures of the ’740 patent, as well as Patent Owner’s clarification in its Reply to the Opposition, we agree with Patent Owner that one of ordinary skill in the art would have understood that the “in situ galvanically-active intermetallic precipitate” is merely a more complete description of the “in situ precipitate” mentioned earlier in the sentence. Mot. Reply 4. As such, we do not find that this part of proposed substitute claim renders claim 104 indefinite.” slip op. at 22

  Patent outcomesUS 10,689,740 mixed
  Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Graham · Nautilus
  Patents in suitUS 10,689,740
• Edwards Lifesciences Corporation / Edwards Lifesciences LLC v. Aortic Innovations LLCInstitution denied
  PTAB · Jan 9, 2024 · IPR2023-01151 · APJ Timothy G Majors · IPR · Institution

  The Board denied institution on all asserted grounds because Petitioner did not show a reasonable likelihood that any challenged, undisclaimed claim was unpatentable.

  RulingsInstitution decision

  • PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsDenied

    “Under 35 U.S.C. § 314(a), inter partes review may not be instituted unless the Petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For reasons discussed below, we do not institute review of claims 2, 9, 17, and 18 of the ’834 patent.” slip op. at 2

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner proposes that the person of ordinary skill in the art (“POSA”) in November 2012 “would have been an interventional cardiologist with a working knowledge of heart valve designs and endovascular prostheses. This [POSA] would, where necessary, work with a medical device engineer to experiment with or manufacture a prosthetic heart valve.” Pet. 21 (citing Ex. 1003 ¶ 49). Patent Owner does not expressly contest Petitioner’s proposed definition. For this Decision, we apply Petitioner’s proposed POSA level, which appears to be consistent with the level of skill shown in the prior art of record. See Daiichi Sankyo Co. v. Apotex, Inc., 501 F.3d 1254, 1256 (Fed. Cir. 2007). This POSA level is also consistent with the level the Board applied in earlier decisions involving the same parties and related patents. See, e.g., Ex. 2124, 11; Ex. 1120, 11–12.” slip op. at 16

  • Expert testimonyPetitioner expert discountedPatent owner expert creditedMixed

    “during prosecution. Pet. 18, 99. According to Petitioner, Spenser II never describes its compressible material as including “tightly knitted fibers” and a POSA would, instead, have understood Spenser II’s compressible material as comprising “loose, porous materials.” Pet. 18, 99. We agree with Petitioner that the phrases “tightly knitted” and “tightly knitted fibers” do not appear in Spenser II. At the same time, neither does Spenser II describe its compressible material as being “loose” and “porous.” Notably, in prior proceedings before the Board, Petitioner’s declarant Dr. Buller testified that Spenser II’s compressible material “includes a plurality of PET fibers on the inward-facing surface of the compressible material” (i.e., the “base layer” and alleged “second plurality” of fibers here; Paper 9, 5), that is “sufficiently dense to prevent blood from leaking through the cloth/fabric.” Ex. 2128 ¶ 222; see also Ex. 2122, 20:2–22:18 (testifying that “nonporous” as used in the Specification means “that fluid would not pass through it” and such fluid includes “all components of blood”). We find that Dr. Buller’s description of Spenser II as having a dense, blood impermeable base layer is, on balance, more consistent with applicant’s characterization of Spenser II as having an arrangement of “tightly-knitted fibers”—even if some imagined or microscopic spaces between fibers might still exist in a base layer. Ex. 2128 ¶ 222; see also Ex. 2002 (Brecker testimony) ¶¶ 42–45 (testifying, inter alia, that the description of a “tight fitted outer seal is . . . consistent with Spenser II’s Figure 22” and “knitted” is consistent with Buller’s testimony describing Spenser II’s compressible material as “velour-like woven or knitted” PET (citing Ex. 1003 ¶ 162; Ex. 2134 ¶ 56). We are, thus, unpersuaded on this record that applicant mischaracterized Spenser II.” slip op. at 38

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “Altogether, the parties’ alleged “plain meaning” yet otherwise undefined interpretation of the “spacing” limitations leaves the Board with insufficient clarity about what the claimed “spacing” means in the affirmative. Paper 9, 3 (arguing “plain meaning”); Paper 11, 3 (arguing applicant’s arguments are in “full harmony with the plain meaning”). The intrinsic evidence is minimally helpful: the Specification does not use the term “spacing” in relation to the positioning of adjacent fibers; the drawings might be helpful but neither party proposes a specific construction that is reliant on them.15 The prosecution history provides clues, but portions of the prosecution record are arguably confounding. The applicant distinguished 15 For example, Dr. Brecker, in support of Patent Owner’s argument, identifies several of the patent drawings and testifies that, “as is particularly clear in Figure 13 (but also present elsewhere), there are gaps and spaces between the fibers that extend to the frame” and then proceeds to testify that prior art, like Spenser II’s compressible material, “bears no resemblance” to the “exemplary” spacings identified in prosecution. See, e.g., Ex. 2002 ¶¶ 42–43. Dr. Brecker’s articulation of a “spacing” does not seem to add anything meaningful beyond the language of the claim as written. And, simply comparing the patent drawings to the prior art drawings presumes a sort of “know-it when you see it” interpretation—it is not an affirmative construction for a “spacing” as claimed. the claimed “spacings” from “tightly knitted fibers.” Ex. 1002, 1001. At what point, however, does a cloth of “tightly knitted fibers” qualify as more “loosely defined” and come within the scope of the claimed “spacing?”16 Id. The applicant also described the “spacing” in semi-functional terms based on “advantages” provided by the claim feature. See, e.g., id. (asserting, e.g., that the spacing permits “expansion and contraction” with “lesser rigidity”); see also id. at 1133, 1140 (asserting, e.g., “reduce[d] restrictions” and avoidance of “restrained valve foreshortening” with the then-claimed “openings”). It is not, however, evident where the Specification supports such “advantages”—no citations were given in prosecution. And, in prosecution of related applications, applicant argued, for example, that “[w]hile all fibers have some degree of being spaced-apart, the construction from Applicant’s claimed invention clearly requires some level more spacing.” Ex. 1149, 13–14 (assertion differences over “Dehdashtian” (alias to Spenser II)) (emphasis added). On this record, what would suffice as “some level more spacing” is unclear. Id.” slip op. at 39

  Claim construction§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 11,337,834
• Home Depot U.S.A., Inc. v. Lynk Labs, Inc.All claims unpatentable
  PTAB · May 22, 2023 · PGR2022-00009 · APJ Monica S Ullagaddi · PGR · Final written decision

  Claims 1–5, 7–12, and 14–19 are unpatentable based on lack of written description, anticipation by Bruning, or obviousness over Bruning and Kabel.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “lighting device.” Accordingly, we determine that the level of ordinary skill in the art is “a bachelor’s degree in electrical engineering, or similar technical field, with two years of relevant experience in the field of design and/or development of LEDs and circuits,” as Petitioner proposes and that “the field of design and/or development” would be “in the context of lighting devices” as Patent Owner proposes, in which “[a]n increase in experience could compensate for less education.” Id.; Pet. 24 (citing Ex. 1002 ¶ 46).” slip op. at 15

  • Claim Construction › Intrinsic evidence (Phillips canons) › Prosecution history disclaimer / disavowalDisclaimer foundDecided for patent owner

    “theoretically fall under the “or greater” portion of the amended claim limitation “forward voltage of 6V or greater,” Applicant distinguished Colby on the basis that the 120V AC voltage from a wall outlet is not “the minimum voltage difference required between the anode and cathode of the LEDs in the claimed circuit to allow current to flow through the LEDs.” See Ex. 1023, 9 (emphasis added). Applicant’s argument specifically identifies the claim language at issue––“forward voltage of 6V or greater”––and specifically states that it is not disclosed because Colby does not disclose the minimum voltage and instead, discloses something else, something larger–– 120V AC voltage. Accordingly, we conclude that Applicant disclaimed any voltage that is more than “the minimum voltage difference required between the anode and cathode of the LEDs in the claimed circuit to allow current to flow through the LEDs” from the scope of “forward voltage.”” slip op. at 25

  • Disclosure Requirements (§112) › Written description (Ariad)Written description inadequateUnpatentable

    “4. 35 U.S.C. § 112(a) With respect to the written description requirement, we are persuaded” slip op. at 32

  • Disclosure Requirements (§112) › Enablement (Wands, Amgen full scope)Not enabledUnpatentable

    “Basis § Unpatentable Unpatentable Lack of written description, 3, 10, 17 112(a) 3, 10, 17 Lack of enablement 3, 10, 17 112(b) Indefiniteness 3, 10, 17 Lack of written description, 4, 11, 18 112(a) 4, 11, 18 Lack of enablement 4, 11, 18 112(b) indefiniteness 4, 11, 18” slip op. at 77

  Patent outcomesUS 10,932,341 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Phillips · KSR · Graham · Nautilus
  Patents in suitUS 10,932,341
• Samsung Electronics Co., Ltd. v. Lynk Labs, Inc.Some claims unpatentable
  PTAB · May 5, 2023 · IPR2022-00098 · APJ Arthur M Peslak · IPR · Final written decision

  Claims 1, 3, and 4 are unpatentable as obvious over the stated combinations; claim 2 was not shown unpatentable because the driver was not shown configured to receive the rectifier’s forward voltages.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with Patent Owner that a person of ordinary skill in the art would have had experience in LED devices. For this reason, we apply Patent Owner’s proposed level of ordinary skill in the art because it comports with the level of skill reflected in the ’149 patent and the prior art of record. However, if we were to apply Petitioner’s proposed level of skill, our Decision would not be affected.” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Upon review of the entire record, we determine that no claim terms require express construction. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (noting that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’”) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10

  • Expert testimonyPetitioner expert creditedPatent owner expert discountedMixed

    “Dr. Ducharme’s testimony that “the spacing of the chips in Zhang would not likely be so close as to create overheating issues” (Ex. 2002 ¶ 111) is unsupported by any disclosure of the actual spacing of Zhang’s chips. Consequently, his testimony that there would be no overheating concerns in Zhang due to the spacing of the chips is entitled to little, if any, weight. Dr. Ducharme further testifies that the components of Zhang’s driver “could easily increase the temperature of the LED 19 chips on the circuit board, which can cause LEDs to generate less illumination, burn out and otherwise adversely affect their performance.” Ex. 2002 ¶ 126. Dr. Ducharme further testifies that “[i]t is well-known that excessive operational temperatures can reduce the illumination provided by the LEDs, can decrease the operational lifetime of the LEDs, and if the temperature is sufficiently high, it can cause LED junction failure and a burnt-out LED.” Id. We agree with this testimony, which as discussed below, is consistent with Salam. Dr. Ducharme’s testimony concerning overheating issues caused by the driver components contradicts Patent Owner’s ’s contention that there would not be “an overheating issue with Zhang’s LED exit sign circuit in Figure 2.1.” PO Resp. 30. Regardless of whether Zhang’s LEDs in Figure 2.1 have a heat problem or not, Salam teaches the advantages of using a heat sink. Salam teaches that a heat sink will result in a higher efficiency of the LEDs and improved life. Ex. 1006, 16:38–43. The Federal Circuit, in DyStar Textilfarben GmBH & Co v. C.H. Patrick Co., 464 F.3d 1356 (Fed. Cir. 2006), stated that “the desire to enhance commercial opportunities by improving a product or process is universal–and even common-sensical . . . the proper question is whether the ordinary artisan possesses the knowledge and skills rendering him capable of combining the prior art references.” Id. at 1368. Dr. Ducharme testified that a person of ordinary skill in the art “would have an understanding of the generation of heat and using a heat sink to remove unwanted heat from electronics and LED lighting devices.” Ex. 1102, 23:18–24:3. Dr. Ducharme’s testimony is consistent with Petitioner’s contention that the combination of Zhang and Salam “would have been a straightforward combination of known components and technologies, according to known methods, to produce the predictable result of reducing/ mitigating heat effects in a circuit.” Pet. 17 (citing Ex. 1002 ¶ 106). Patent Owner next contends it would be extremely burdensome and costly to modify Zhang to add a heat sink layer because “each of the multiple chips mounted and epoxied to Zhang’s circuit board in the exit sign would have to be modified.” PO Resp. 30 (citing Ex. 2002 ¶ 112). Dr. Ducharme’s testimony repeats the Patent Owner Response verbatim and is entitled to little, if any, weight. Ex. 2002 ¶ 112. Nonetheless, this contention is unavailing because it is based on Patent Owner’s bodily incorporation of Zhang and Salam. Patent Owner next contends that a person of ordinary skill in the art” slip op. at 27

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable

    “Regardless of whether Zhang’s LEDs in Figure 2.1 have a heat problem or not, Salam teaches the advantages of using a heat sink. Salam teaches that a heat sink will result in a higher efficiency of the LEDs and improved life. Ex. 1006, 16:38–43. The Federal Circuit, in DyStar Textilfarben GmBH & Co v. C.H. Patrick Co., 464 F.3d 1356 (Fed. Cir. 2006), stated that “the desire to enhance commercial opportunities by improving a product or process is universal–and even common-sensical . . . the proper question is whether the ordinary artisan possesses the knowledge and skills rendering him capable of combining the prior art references.” Id. at 1368. Dr. Ducharme testified that a person of ordinary skill in the art “would have an understanding of the generation of heat and using a heat sink to remove unwanted heat from electronics and LED lighting devices.” Ex. 1102, 23:18–24:3. Dr. Ducharme’s testimony is consistent with Petitioner’s contention that the combination of Zhang and Salam “would have been a straightforward combination of known components and technologies, according to known methods, to produce the predictable result of reducing/ mitigating heat effects in a circuit.” Pet. 17 (citing Ex. 1002 ¶ 106).” slip op. at 27

  Patent outcomesUS 10,517,149 mixed
  Claim construction§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 10,517,149
• Ford Motor Company v. Safe Driving Technologies LLCSome claims unpatentable
  PTAB · Mar 10, 2023 · IPR2021-01446 · APJ Alyssa A Finamore · IPR · Final written decision

  Claims 1–4, 6, 10, 12–14, 16, 17, and 19–21 are unpatentable under §103; claim 15 was not shown unpatentable.

  RulingsFinal written decision

  • ExcludeMotion to exclude, grantedGranted

    “Our rules and Consolidated Trial Practice Guide are clear on this prohibition. And, the Consolidated Trial Practice Guide explains: “[w]here a party believes it has a basis to request relief on a ground not identified in the rules, the party should contact the Board and arrange for a conference call with the Board and opposing party to discuss the requested relief with the judge handling the proceeding.” CTPG 75. Thus, the Board identifies appropriate ways for a party to address matters that it considers to be beyond the specific procedures outlined in the rules. Merely submitting new evidence was not authorized by Board rules or guidance and Patent Owner did not seek authorization to file the new evidence. The facts warrant excluding Exhibits 2030–2032 and we grant the Motion. See CTPG 81.” slip op. at 83

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableNot shown unpatentableMixed

    “underpinnings, why a person of ordinary skill would have been motivated to modify the prior art to achieve the claimed invention. In re Magnum Oil Tools Int’l, Ltd., 829 F.3d 1364, 1380 (Fed. Cir. 2016) (“To satisfy its burden of proving obviousness, a petitioner . . . must . . . articulate specific reasoning, based on evidence of record, to support the legal conclusion of obviousness.” (citing KSR, 550 U.S. at 418)). Nonetheless, “a disclosure that anticipates under § 102 also renders the claim invalid under § 103, for ‘anticipation is the epitome of obviousness.’” Connell v. Sears, Roebuck & Co., 722 F.2d 1542, 1548 (Fed. Cir. 1983) (quoting In re Fracalossi, 681 F.2d 792 (CCPA 1982)); see also Application of Pearson, 494 F.2d 1399, 1402 (CCPA 1974) (“[T]his court has sanctioned the practice of nominally basing rejections on § 103 when, in fact, the actual ground of rejection is that the claims are anticipated by the prior art. The justification for this sanction is that a lack of novelty in the claimed subject matter, e.g., as evidenced by a complete disclosure of the invention in the prior art, is the ‘ultimate or epitome of obviousness.’” (citations and footnote omitted)).” slip op. at 14

  Patent outcomesUS 9,047,170 mixed
  § 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,047,170
• Allstate Insurance Company v. Atos, LLCSome claims unpatentable
  PTAB · Jan 24, 2023 · IPR2021-01209 · APJ Richard H Marschall · IPR · Final written decision

  Claims 1–4, 6, and 9–25 are unpatentable; claims 5, 7, and 8 are not shown unpatentable, based on anticipation by Kim and obviousness grounds.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “B. Level of Ordinary Skill in the Art The level of ordinary skill in the art is “a prism or lens” through which” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other

    “C. Claim Construction In inter partes reviews, we interpret claims under the same standard” slip op. at 10

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableNot shown unpatentableMixed

    “Accordingly, Petitioner fails to establish that Kim discloses “determining that the individual is a driver of the vehicle based at least in part on acceleration, forces, velocity, the at least one location point, and time.”” slip op. at 46

  • Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner

    “nexus and therefore fails to establish that any alleged evidence of objective indicia supports a finding of non-obviousness. Accordingly, we give Patent Owner’s reliance on objective indicia of non-obviousness no weight in our obviousness analysis.” slip op. at 65

  Patent outcomesUS 9,152,609 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,152,609
• Shenzen Chic Electrics Co., Ltd. v. Pilot, Inc.Some claims unpatentable
  PTAB · Jan 9, 2023 · IPR2021-01232 · APJ Jeffrey W Abraham · IPR · Final written decision

  Claims 1 and 4–20 are unpatentable as obvious; claim 3 was not shown unpatentable because Petitioner presented no evidence under the adopted construction.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “of battery charging systems.” Pet. 8. Patent Owner states that it adopts this definition for purposes of its Response. PO Resp. 4. In light of the record before us, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art. Based on our review of the ’653 patent and the prior art of record, we determine that the definition offered by Petitioner comports with the qualifications a person would have needed to understand and implement the teachings of the ’653 patent and the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown”) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)). It is also consistent with the level of skill in the art adopted in the 777 IPR, which also involves the ’653 patent. IPR2021-00777, Paper 7 at 6–7.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “construction “contradicts the technical disclosure of the ’653 patent” and that “[t]he proper construction of this term is ‘switching circuit under control of the microcontroller that selectively conducts power supply or power outage for the load.’” Pet. Suppl. Br. 3.10 In particular, Petitioner contends that claim 3, through claim 1, only recites one connection between the microcontroller and the first battery, such that the connections in claim 3 do not allow the power supply from the first battery to pass through the microcontroller to the load. Pet. Suppl. Br. 4–5. Claim 1, however, recites “an automobile charger, comprising . . .” which is an open-ended term, meaning that claim 1 is not limited to only the connections expressly recited therein. Petitioner’s arguments do not address this open-ended aspect of the plain language of the claims. Petitioner also argues that the language of claim 3 is consistent with its construction because claim 3 “places the switching circuit between the second pole of the first battery . . . and the second lead of the load.” Pet. Suppl. Br. 5. Although Petitioner’s interpretation may be consistent with the language in claim 3, we discern nothing in claim 3 that expressly limits the placement of the switching circuit, especially considering the open-ended “comprising” language used in claims 1 and 3.” slip op. at 11

  • Strike new argumentNew argument consideredDecided for petitioner

    “Specifically, Dr. Kirtley testifies that a person of ordinary skill in the art would have understood that connections between components depicted as single lines in Yu’s figures “may comprise multiple connections, such as multiple signal connections, and common power and ground connections for sensors and microprocessors.” Ex. 1020 ¶ 84 (citing Ex. 1021 (US 7,973,534 B2)). We credit Dr. Kirtley’s testimony, as Patent Owner does not dispute the substance of Dr. Kirtley’s testimony or the supporting exhibit. Instead, Patent Owner argues that Petitioner is attempting to “sneak in new evidence that is improper in a reply” and create a new ground. Sur-reply 13–15. We disagree, as Petitioner and Dr. Kirtley offer this evidence to demonstrate what a person of ordinary skill in the art would have understood in considering Yu—not as a new ground. Moreover, Petitioner properly offered this exhibit and Dr. Kirtley’s testimony in response to Patent Owner’s arguments that claim 1 requires negative side switching, which Yu does not disclose. In its Reply, Petitioner is entitled to “respond to arguments raised in the corresponding . . . patent owner response.” 37 C.F.R. § 42.23(b). A party also may submit rebuttal evidence in support of its reply. See Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1077–78 (Fed. Cir. 2015).” slip op. at 26

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable

    “After considering the parties’ arguments and evidence, we find Petitioner has established, by a preponderance of the evidence, that claim 4 is unpatentable as obvious in view of Yu and Thomason. As discussed above, we disagree with Patent Owner’s arguments regarding negative pole switching, and find that Petitioner presents persuasive evidence that Yu teaches or suggests the limitations of claim 1. Petitioner also presents undisputed evidence that Yu and Thomason teach or suggest the additional limitations in claim 4. Pet. 52–54. Additionally, Petitioner directs us to a disclosure in Thomason itself regarding a protection mechanism to prevent the jump starter from self-destructing, and presents testimony from Dr. Kirtley that a person of ordinary skill in the art would have considered Thomason’s teaching in order to avoid damage to Yu’s internal battery, and would have been able to implement Thomason’s teachings. Pet. 52–54; Reply 20–21; Ex. 1004 ¶¶ 189–192. Patent Owner and Mr. McAlexander do not challenge or otherwise refute this testimony. PO Resp. 9–10. Thus, contrary to Patent Owner’s assertions, Petitioner does direct us to evidence in the asserted prior-art references themselves that provide a reason to combine their teachings, and does not rely solely on conclusory statements regarding the similarities of Yu and Thomason to support its obviousness challenge. In view of Petitioner’s persuasive evidence demonstrating where the prior-art references teach or suggest each limitation in the challenged claims, and explaining why a person of ordinary skill in the art would have had reason to combine the prior-art references with a reasonable expectation of success, we find Petitioner has established, by a preponderance of the evidence, that claim 4 is unpatentable as obvious in view of Yu and Thomason.” slip op. at 33

  Patent outcomesUS 10,046,653 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 10,046,653
• Allstate Insurance Company v. Atos, LLCSome claims unpatentable
  PTAB · Jan 9, 2023 · IPR2021-01118 · APJ Richard H Marschall · IPR · Final written decision

  Claims 1–5, 7, 8, 10–16, and 18 are unpatentable; claims 6, 9, and 17 were not shown unpatentable, because the asserted prior art did not establish all limitations.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “B. Level of Ordinary Skill in the Art The level of skill in the art is “a prism or lens” through which we view” slip op. at 9

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “2. Discussion Petitioner argues that Kim discloses every limitation of claim 1, and” slip op. at 23

  • Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner

    “2. Discussion We begin our analysis by addressing Patent Owner’s asserted objective indicia of non-obviousness, and then turn to the merits of Petitioner’s specific obviousness challenges before us.” slip op. at 52

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundMotivation not foundMixed

    “the combination of Kim and Baker discloses “comparing the at least one current geographic location to the first geographic location; setting the location of the individual to the individual is in an outside of the vehicle location, when a distance between the at least one current and the first geographic locations exceeds a predetermined threshold.” Accordingly, we determine that Petitioner has not established by a preponderance of the evidence that claim 6 would have been obvious based on Kim and Baker.” slip op. at 90

  Patent outcomesUS 8,527,140 mixed
  § 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,527,140
• Alcon Inc. / Alcon Vision, LLC et al. v. Amo Development, LLCNo claims unpatentable
  PTAB · Dec 12, 2022 · IPR2021-00862 · APJ Sheridan K Snedden · IPR · Final written decision

  Claims 1–24 were not shown unpatentable because Petitioner failed to establish the proposed prior-art combinations and the required motivation to combine with a reasonable expectation of success.

  RulingsFinal written decision

  • Skill levelSkill level board ownDecided for patent owner

    “The parties present compelling argument and evidence that one of ordinary skill in the art would include those with experience in ophthalmology, as well as in the research, manufacture, and design of medical optics or medical lasers. Pet. 25; PO Resp. 9–10. The evidence of record also demonstrates that few individuals actually had such comprehensive experience. Rather, teams of individuals with different expertise and various academic degrees (Ph.D.s, B.S.s, and M.D.s) would work together to design laser surgery systems intended to make incisions in the lens of the eye. See, e.g., Ex. 1041 (several authors are M.D.s); Ex. 1042 (the authors’ degrees include Ph.D.s, an M.D., and a B.S.); see also Ex. 1053; Ex. 1054; Ex. 1055; Ex. 2010; Ex. 2019. Thus, we find that the person of ordinary skill in the art would have been either an ophthalmic surgeon or someone with a Ph.D., M.S., or B.S. degree in physics, biomedical engineering, or a related science such as nuclear engineering, having experience in researching, manufacturing, or designing medical optics or medical lasers (e.g., five years of experience for a Ph.D. or more to compensate for lesser degrees), and that such persons would have worked in collaboration with one another to fill any necessary gaps in knowledge (e.g., the engineer would consult the medical doctor on clinical issues or physiology and the medical doctor would consult the engineer on technical issues). This definition marries the two proposed by the parties.” slip op. at 11

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Petitioner does not assert that any claim term requires express construction. See Pet. 6 (stating that it “reserves the right to respond to any constructions that [Patent Owner] submits”). Patent Owner does not present any remarks regarding claim construction. See generally PO Resp. On this record, we determine that no claim terms require express construction because it is not essential to our conclusions on patentability. See Nidec Motor., 868 F.3d at 1017 (quoting Vivid Techs., 200 F.3d at 803 (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)). To the extent further discussion of the meaning of any claim term is necessary to our decision, we provide that discussion below in our analysis of the asserted grounds of unpatentability.” slip op. at 13

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundReasonable expectation not foundNot shown unpatentable

    “summarized above, we find that the evidence of record does not support a conclusion that it would have been simple, straightforward, or otherwise routine to convert Swinger’s manual HeNe aiming system and Swinger’s surgeon-identification-of-target-tissue step to a computer-controlled, OCT-guided laser system. Even assuming that a person of ordinary skill in the art would have combined the teachings of Swinger and Baikoff to achieve a laser surgical system incorporating an OCT imaging system, that combination still would not have achieved the required “computer system” of the claims and all of its programmed surgical functionality, particularly, using a computer system to construct an anterior capsulotomy cutting region based on the image data. Petitioner relies on the ability of a person of ordinary skill in the art to configure Swinger’s computer control unit with the missing functionality, thus necessitating an electronic conversion of the steps performed using Swinger’s direct visualization method using a HeNe aiming beam to manually identify a surgical treatment region for laser surgery. Ex. 1039, 34:52–57; Ex. 2088 ¶¶ 55–59, 66. That conversion, however, involves the incorporation of OCT imaging technology as the basis for a computer-controlled system to plan and then implement the planned cataract surgery, two technological leaps that the record fails to show were known or suggested. In particular, the evidence of record does not support a conclusion that OCT was a well-known system used routinely, if at all, in the identification of treatment regions in the lens or lens capsule for cataract surgery, and further does not support a conclusion that a computer-controlled system to plan and to implement a planned cataract surgery in the lens was commonplace or even considered before the invention.” slip op. at 25

  • Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightMotivation not foundNot shown unpatentableNot shown unpatentable

    “The evidence of record demonstrates, however, that modifying an existing corneal surgery system to image and perform surgery on the lens was not the simple task asserted by Petitioner. For example, in a patent application filed in November 2009, Petitioner asserted that due to the different depth ranges for the laser’s focus, “laser systems designed for corneal procedures do not offer solution[s] for the considerable challenges of performing surgery on the lens of the eye.” Ex. 2007, 4:65–67, 5:30–36, code (22). Similarly, in a different patent filed in December 2008, Petitioner outlined the various challenges in developing laser surgery systems for creating incisions in the lens, including the difficulty in focusing a laser beam that propagates through regions of the eye with different optical properties and different curvatures. Ex. 2014, 15:51–16:18, code (22). This patent then states: Because of all the described hard challenges, corneal surgical laser systems are qualitatively simpler than lens surgical lasers. This is well supported by the fact that even though corneal surgical systems were suggested about 40 years ago, none have been adapted successfully for lens surgery to date. Id. at 16:13–18. During prosecution of another patent filed in 2008, and in responses to office actions filed in 2012 and 2013, Petitioner argued that a corneal OCT system “simply will not work” on the lens and that it would not have been obvious to modify such an OCT system to image the lens. Ex. 2015, 898, 1591, 1788. This was because OCT systems designed to image the lens would be required to deliver and scan an imaging beam “to a depth ten times bigger and a depth range ten times bigger” than an OCT system designed to image the cornea. Id. at 1591. According to Petitioner, “it is not obvious” to modify an OCT imaging system to achieve a depth and scanning range that is ten times larger than that disclosed in the art. Id. at 898 (“Increasing a system’s performance by an order of magnitude cannot be regarded as obvious.”), 1590–1591. Petitioner’s arguments presented in its own patents and during their” slip op. at 39

  Patent outcomesUS 8,709,001 not shown unpatentable
  Claim construction§ 103 obviousness
  Patents in suitUS 8,709,001

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.