- PTAB · Jun 18, 2025 · IPR2025-00311 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR of claims 1, 3–11, and 17–22 on all asserted grounds because Petitioner showed a reasonable likelihood of prevailing on claim 1 over Mazumder and Mori.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“based on Petitioner’s first stipulation filed on December 18, 2024.15 Prelim. Resp. 13–15. Patent Owner does not address Petitioner’s updated second stipulation filed on April 8, 2025. This updated second stipulation mitigates any concerns of duplicative efforts between the district court and the Board, as well as concerns of any potentially conflicting decisions. See Sand at 12. We therefore find that this factor weighs against exercising discretion to deny institution. See id., n.5. 5. Whether Petitioner and the Defendant in the Parallel Proceeding are the Same Party Whereas Petitioner does not address factor 5, Patent Owner argues that the parties to this proceeding are both in the related district court litigation. Pet. 98–99; Prelim. Resp. 15. While it is common in IPR proceedings for the petitioner and patent owner to also be parties in a related district court proceeding, this factor weighs slightly in favor of discretionary denial. Fintiv, Paper 11 at 13–14.” slip op. at 15
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“c) Conclusion Regarding Claim 1 Based on the current record, we determine that there is a reasonable likelihood that Petitioner will prevail in demonstrating that claim 1 is unpatentable as obvious over the combination of Mazumder and Mori. Accordingly, we institute inter partes review with respect to all claims and all grounds asserted in the Petition. 5. Claims 3, 5–7, 9, 10, and 19–22 Because Petitioner demonstrates a reasonable likelihood of success in proving that at least one claim of the ’324 patent is unpatentable, we institute on all grounds and all claims raised in the Petition. See 37 C.F.R. § 42.108(a). Therefore, at this stage of the proceeding, it is not necessary for us to provide an assessment of every challenge raised by Petitioner, especially, as in this case, when Patent Owner does not separately argue those claims. See Prelim. Resp. 28–46. Those challenges, in our view, are best left for trial after full development of the record.” slip op. at 27
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“reference must be analogous art to the claimed invention. In re Bigio, 381 F.3d 1320, 1325 (Fed. Cir. 2004). For a reference to be analogous art, it must be “either in the field of the applicant's endeavor or [be] reasonably pertinent to the problem with which the inventor was concerned.” In re Kahn, 441 F.3d 977, 986-87 (Fed. Cir. 2006) (citing In re Oetiker, 977 F.2d 1443, 1447 (Fed. Cir. 1992)). “A reference is reasonably pertinent if, even though it may be in a different field from that of the inventor's endeavor, it is one which, because of the matter with which it deals, logically would have commended itself to an inventor's attention in considering his problem.” In re Clay, 966 F.2d 656, 659 (Fed. Cir. 1992).” slip op. at 20
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“Mazumder because “the presentation of both image types would have beneficially aided the remote user to more easily visually compare the actual image and virtual image to quickly identify any defects or problems with the fabrication process.” Pet. 23–24 (citing Ex. 1003 ¶ 113). Patent Owner argues that “it is hindsight to use ‘the invention to define the problem the invention solves.’” Prelim. Resp. 43 (quoting Mintz v. Dietz & Watson, Inc., 679 F.3d 1372, 1377 (Fed. Cir. 2012); citing AT&T Services Inc. et. al. v. Innovative Sonic Ltd., IPR2024-001143 (PTAB Feb. 11, 2025)). According to Patent Owner, because neither Mazumder nor Mori teaches visual comparison of image types, the idea to improve the Mazumder-Mori combination by simultaneously displaying different image types and thus permitting visual comparison must be driven by hindsight. Id. at 44–45. But Petitioner cites evidence other than the ’324 patent to support the person of ordinary skill in the art having a desire to visually compare the different images presented in the Mazumder-Mori combination. Pet. 23–24 (citing Ex. 1003 ¶ 113). Specifically, Dr. Wolfe testifies that “the presentation of the actual images captured by the camera and the virtual images simultaneously within the user interface would have beneficially aided the remote user to more easily visually compare the actual image and virtual image to quickly identify any defects or problems with the fabrication process” and that a person of ordinary skill in the art would have recognized this. Ex. 1003 ¶ 113. Thus, Petitioner has shown sufficiently for the purpose of the present decision that Mori teaches or suggests the disputed limitation of claim 1. We encourage the parties to develop the arguments and the record surrounding this issue further during the trial.” slip op. at 26
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,562,324 - PTAB · Jun 11, 2025 · IPR2025-00263 · APJ Barry L Grossman · IPR · Institution
Instituted IPR for claims 1–30 on all asserted grounds; the Board found a reasonable likelihood that claims would be unpatentable over Haley and Lai.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“III. CONCLUSION We have determined that there is a reasonable likelihood that Petitioner will prevail on at least one challenged claim. Accordingly, we institute an inter partes review on all challenged claims on each asserted ground. PGS Geophysical, 891 F.3d at 1360 (A decision to institute is a “yes-or-no institution choice respecting a petition, embracing all challenges included in the petition.”).” slip op. at 42
- BurdenInstituted
“limitations of clauses 1.3 and 1.4, but concedes that Haley does not disclose that its driver member has “at least one longitudinal edge with a plurality of spaced-apart protrusions,” as required by clause 1.4. Petitioner further asserts, however, that it would have been obvious “to replace Haley’s hydraulic lifter with the claimed ‘lifter,’ disclosed by [Lai]”. Pet. 13. (citing Ex. 1003 ¶ 54). Dr. Vallee’s cited Declaration testimony provides his opinion on this issue, which is consistent with Petitioner’s argument. Petitioner also asserts that “Lai discloses an electrically-powered, mechanical lifting mechanism with a structure that is essentially identical to the ‘lifter member’ disclosed in the ’776 patent. Pet. 13. Petitioner provides side-by-side colored figures from the ’776 patent and from Lai, reproduced below, to illustrate its argument. Pet. 14. According to Petitioner, the side-by-side comparison of Petitioner’s colored versions of Fig. 12, from the ’776 patent, with Petitioner’s colored versions of Figs. 4 A–D, reproduced above, illustrate why and how the proposed modification would have been obvious. As described by Petitioner, the “lifter member” of the ’776 patent includes a rotatable cam lifter 100 (yellow), with pins 104, 106, and 108 (green) on its face surface that engage protrusions 92 (blue) on the driver member 90 (orange). Pet. 13 (citing Ex. 1001, 9:30–46, 16:34–48, Fig. 12). Petitioner also cites the “two-pin variants: lifter members 465 and 480” shown in Figs. 31, 33 of the ’776 patent. Id. Petitioner also asserts that, as shown in the side-by-side comparison” slip op. at 33
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)No construction neededOther
“Petitioner asserts the term “lifter member” in the claims of the ’776 patent is “a means-plus-function term” because the claims “lack any ‘recital of structure, material, or acts in support thereof’ for the ‘lifter’ element.” Pet. 7 (citing 35 U.S.C. § 112(f)). Petitioner also asserts “[t]he Federal Circuit held that the term ‘lifter member’ in the related patents is a means-plus-function term subject to §112(f).” Pet. 7. Petitioner cites no authority for this assertion. We understand this assertion to refer to the decision in Kyocera Senco Indus. Tools Inc. v. Int’l Trade Comm’n, 22 F.4th 1369 (Fed. Cir. 2022), identified by Petitioner as a related matter. Pet. 2. In this case, which involved patents from the same family as the ’776 patent (see Section I.C of this Decision), the Federal Circuit concluded that “§ 112 ¶ 6 applies to the ‘lifter member’ limitation, and it must be construed to cover only ‘the structure, materials, or acts described in the specification as corresponding to the claimed function and equivalents thereof.’” Id. at 22 F.4th 1379–1381. “Where multiple patents derive from the same parent application and share many common terms, we must interpret the claims consistently across all asserted patents.” Samsung Elecs. Co. v. Elm 3DS Innovations, LLC, 925 F.3d 1373, 1378 (Fed. Cir. 2019) (citing SightSound Techs., LLC v. Apple Inc., 809 F.3d 1307, 1316 (Fed. Cir. 2015) (internal quotation marks omitted). Patent Owner asserts that Petitioner: fails to comply with the requirement of 37 C.F.R. § 42.104(b)(3) to specifically identify the structure in the specification associated with that element. As ‘lifter’ is present in every challenged claim under all four grounds, Petitioner’s failure to provide a claim construction for ‘lifter’ is fatal to its Petition. Prelim. Resp. 13. We disagree. First, the claims in the ’776 patent do not use the single word “lifter” alone. The term used in some of the claims, see, e.g., independent claims 1 and 17, and the claims dependent from claims 1 or 17, is “lifter member.” We recognize that the written description in the ’776 patent states “the rotary-to-lifter 100 is also sometimes referred to herein as a ‘lifter member,’ or simply as a ‘lifter.’” Ex. 1001, 9:5–7. This suggests that that term “lifter” is intended to mean the “lifter member,” which makes the use of either term a distinction without a substantive difference. Moreover, neither independent claims 9 or 24, nor the claims dependent from claims 9 and 24, use the word “lifter” or “lifter member. Second, as stated in Petitioner’s Preliminary Reply, the Petition “identifies the portions of the specification that describe the corresponding structure for the ‘lifter’ when comparing its structure to that of the Lai prior art.” Prelim. Reply 1. The Petition provides a colored version of Figure 12 from the ’776 patent (reproduced below) and identifies the following corresponding structures from the Specification of the ’776 Patent: The “lifter member” of the ’776 patent includes a rotatable cam lifter 100 (yellow [ ]), with pin 104, 106, and 108 (green) on its face surface that engage protrusions 92 (blue) on the driver member 90 (orange). ’776 patent, 9:30–46, 16:34–48, Fig. 12. The ’776 patent also discloses two-pin variants: lifter members 465 and 480 in Figs. 31, 33. [citing] ’776 patent, 32:15–30, 32:48–63. Petition at 13. Based on the record before us, we determine that this identification of corresponding structure is sufficient to satisfy 37 C.F.R. § 42.104(b)(3). We also note that at this stage of the proceeding, Patent Owner does not dispute that Petitioner has identified the correct corresponding structure. To the extent the parties wish to further address the construction of this claim limitation, they may do so during trial, as permitted by our rules.” slip op. at 16
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“to mean “a chamber that is distinct from the displacement volume of the hollow cylinder and contains part of the working air volume during operation.” Pet. 8. According to Petitioner “there is nothing in the intrinsic record or any of the claims of the ’776 patent that prevents the ‘main storage chamber’ from being in the hollow cylinder, so long as it is distinct from its separately-recited ‘displacement volume.’” Id. at 9 (emphases added). Patent Owner asserts that “[g]rounds 2 and 4 each requires this Board to interpret the ‘storage chamber’ to be the same structure as the hollow cylinder.” Prelim. Resp. 31. According to Patent Owner, “[t]he Federal Circuit, considering both parties’ claim construction arguments, rejected that construction.” Id. Patent Owner does not provide any citation to support its reference to the Federal Circuit decision. It appears to be a reference to the Kyocera decision considering review of the ITC determination. See Kyocera, 22 F.4th at 1383. That decision, however, construed claims in a related patent to “require two distinct structures: the main storage volume and a smaller “hollow cylinder” contained within the main storage volume. Based on the record before us, Petitioner’s proposed construction is consistent with the Federal Circuit’s construction, which states two structures can be distinct even if one distinct structure is “contained within” the other distinct structure. Although the parties dispute the construction of the “storage chamber” claim limitation, this dispute relates only to Grounds 2 and 4. See Prelim. Resp. 31. We need not resolve it to determine whether to institute review. The parties are welcome to develop their arguments regarding this claim limitation during trial. 3. Conclusion Regarding Claim Construction Our claim construction analyses in this decision to institute a trial do not preclude the parties from arguing their proposed constructions of the claims during trial. Indeed, the parties are hereby given notice that claim construction, in general, is an issue to be addressed at trial. Claim construction will be determined at the close of all the evidence and after any hearing. The parties are expected to assert all their claim construction arguments and evidence in the Petition, Patent Owner’s Response, Petitioner’s Reply, or otherwise during trial, as permitted by our rules.” slip op. at 19
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,241,776 - PTAB · Jun 11, 2025 · IPR2025-00264 · APJ Scott C Moore · IPR · Institution
The Board instituted IPR of claims 1–15 on all asserted grounds, finding a reasonable likelihood that Koki would prove the claims obvious over Haley and Lai.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We may institute an inter partes review when “the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). If we institute an inter partes review, the trial must encompass all claims and grounds identified in the Petition. 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”). For the reasons set forth below, we conclude that there is a reasonable likelihood that Petitioner will prevail in establishing the unpatentability of all challenged claims. We, therefore, institute inter partes review of claims 1–15 on the grounds asserted in the Petition. B.” slip op. at 2
- BurdenInstituted
“not identical” to the structure that Petitioner identifies as corresponding to the “lifter” claim limitation. Prelim. Resp. 19. We agree that these structures are not identical. But on this record, they appear, at least preliminarily, to be equivalent. As Petitioner explains, both structures utilize a rotatable cam with pins to translate a driver (driver member 90 of the ’167 Patent and hammer 6 of Lai) into a position where the driver is ready for use. See Pet. 12–15. Patent Owner does not otherwise contest Petitioner’s showing that Lai teaches or suggests the subject matter set forth in limitations 1.4, 1.5, and 1.6, and we find Petitioner has made a sufficient showing that Lai does so.” slip op. at 20
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesDecided for petitioner
“1. Lifter The Petition explicitly states that the “lifter” limitation is a means- plus-function limitation—a contention Patent Owner does not dispute. See Pet. 6; Prelim. Resp. 9–11. Patent Owner argues, however, that Petitioner has “fail[ed] to identify any structure in the ’007 [sic] Patent to perform the claimed function.” Prelim. Resp. 10. We disagree. The Petition identifies the following corresponding structures from the Specification of the ’167 Patent: The “lifter” of the ’167 patent includes a rotatable cam lifter 100 (yellow, below left), with pin 104, 106, and 108 (green) on its face surface that engage protrusions 92 (blue) on the driver member 90 (orange). ’167 patent, 9:36-52, 16:39-53, Fig. 12. The ’167 patent also discloses two-pin variants: lifter members 465 and 480 in Figs. 31 and 33. ’167 patent, 32:21-36, 32:54- 33:2. satisfy 37 C.F.R. § 42.104(b)(3). We also note that at this stage of the proceeding, Patent Owner does not dispute that Petitioner has identified the correct corresponding structure. To the extent the parties wish to further address the construction of this claim limitation, they may do so during trial.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“Petitioner has identified the storage chamber of Haley as being chamber 85, a volume of space bounded by housing 40, extension cylinder 76, and elongate accumulator shell 80. See Pet. 9–10; Ex. 1004 Fig. 1. Haley’s elongate accumulator shell 80 (which Petitioner identifies as the removal top cap) is not the same as chamber 85; it is merely one component of the structure that encloses chamber 85. See id. And, though the Petitioner-identified removable top caps of Haley (a cylinder-shaped component, see id.) and Saari/Enstrom (a removable sleeve that extends into the interior of Saari/Enstrom’s cylinder, see id. at 48–49) have different Petitioner-identified storage chambers. We, therefore, are not persuaded that Petitioner’s contentions necessarily rely on implicit and inconsistent claim constructions.” slip op. at 10
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,845,167 - PTAB · Jun 11, 2025 · IPR2025-00262 · APJ Mitchell G Weatherly · IPR · Institution
The Board instituted IPR of claims 1–20 on all grounds, finding a reasonable likelihood that Haley and Lai render the claims obvious.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition filed under section 311 and any response filed under section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Based on our review of the record,1 we conclude that Petitioner is reasonably likely to prevail with respect to at least one of the challenged claims.” slip op. at 2
- Other 314aDenied
“Patent Owner argues that we should discretionarily deny the Petition based on alleged deficiencies in the Petition. Specifically, Patent Owner argues that “even if arguments as to a few claims might have been properly presented in the Petition, a decision to institute here would require the Board to address—for the first time and with no Petitioner input—critical claim construction issues affecting nearly every claim” in contravention of the requirements of 37 C.F.R. § 42.104(b)(3). Prelim. Resp. 34–35. For the reasons discussed above, we are not persuaded on the current record that Petitioner has violated 37 C.F.R. § 42.104(b)(3), or that critical and unresolved claim interpretation issues justifying discretionarily denying the Petition exist. We, therefore, decline to deny institution on this basis.” slip op. at 10
- Skill levelSkill level board ownOther
“we view the prior art and the claimed invention. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). The parties’ briefs do not propose a specific definition of a level of ordinary skill in the art. See generally, Pet., Prelim. Resp. Dr. Vallee, however, testifies that one of ordinary skill in the art relevant to the ’954 patent: would have either (i) a Master’s degree in mechanical engineering with at least two years of experience in power nailer design; (ii) a Bachelor’s degree in mechanical engineering with at least five years of experience in powered nailer design; or (iii) ten (or more) years of experience in powered nailer design. This experience in powered nailer design would include mechanical design, tool design, manufacturing, mechanics of materials, stress analysis, ergonomics, and human factors. Ex. 1003, ¶ 49. For purposes of this Decision, we adopt and apply Dr. Vallee’s formulation regarding the level of ordinary skill in the art.” slip op. at 6
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesOther
“1. Lifter The Petition contends that the “lifter” limitation is a means-plus- function limitation, Pet. 7, which Patent Owner does not dispute, Prelim. Resp. 15–26. Patent Owner argues, however, that Petitioner has “fail[ed] to identify any structure in the ’007 [sic, ’954] Patent to perform the claimed function.” Prelim. Resp. 15. We disagree. Petitioner identifies the structures in the Specification corresponding to the “lifter” as follows: The “lifter member” of the ’954 patent includes a rotatable cam lifter 100 (yellow, below left), with pin 104, 106, and 108 (green) on its face surface that engage protrusions 92 (blue) on the driver member 90 (orange). ’954 patent, 9:25–41, 16:32–46, Fig. 12. The ’954 patent also discloses two-pin variants: lifter members 465 and 480 in Figs. 31, 33. ’954 patent, 32:12–27, 32:45–60. Pet. 15. This identification of corresponding structure is sufficient to satisfy 37 C.F.R. § 42.104(b)(3). We also note that at this stage of the proceeding, Patent Owner does not dispute that Petitioner has correctly identified the corresponding structure. The parties may further address the proper interpretation of “lifter” at trial.” slip op. at 7
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · GrahamPatents in suitUS 10,478,954 - PTAB · Jun 11, 2025 · IPR2025-00261 · APJ Mitchell G Weatherly · IPR · Institution
Instituted IPR of claims 1–20 on all grounds after finding a reasonable likelihood that Haley anticipates claims 1, 7, 8, 17, and 20 and Haley with Lai renders the remaining claims obvious.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition filed under section 311 and any response filed under section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Based on our review of the record,1 we conclude that Petitioner is reasonably likely to prevail with respect to at least one of the challenged claims.” slip op. at 2
- Other 314aInstitution denied discretionary otherDenied
“Patent Owner argues that we should discretionarily deny the Petition based on alleged deficiencies in the Petition. Specifically, Patent Owner argues that “even if arguments as to a few claims might have been properly presented in the Petition, a decision to institute here would require the Board to address—for the first time and with no Petitioner input—critical claim construction issues affecting nearly every claim” in contravention of the requirements of 37 C.F.R. § 42.104(b)(3). Prelim. Resp. 33–35. For the reasons discussed above, we are not persuaded on the current record that Petitioner has violated 37 C.F.R. § 42.104(b)(3), or that critical and unresolved claim interpretation issues justifying discretionarily denying the Petition exist. We, therefore, decline to deny institution on this basis. E. Claims 1, 7, 8, 17, and 20: Anticipation by Haley” slip op. at 11
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesDecided for petitioner
“1. Lifter The Petition contends that the “lifter” limitation is a means-plus- function limitation, Pet. 7, which Patent Owner does not dispute, Prelim. Resp. 10–14. Patent Owner argues, however, that Petitioner has “fail[ed] to identify any structure in the ’007 Patent to perform the claimed function.” Prelim. Resp. 10. We disagree. Petitioner identifies the structures in the Specification corresponding to the “lifter” as follows: The “lifter” (“lifter member”) of the ’007 patent includes a rotatable cam lifter 100 (yellow below left), with pin 104, 106, and 108 (green) on its face surface that engage protrusions 92 (blue) on the driver member 90 (orange). ’007 patent, 9:36–52, 16:39–53, Fig. 12. The ’007 patent also discloses two-pin variants: lifter members 465 and 480 in Figs. 31, 33. ’007 patent, 32:23–38, 32:56–33:4. Pet. 17. This identification of corresponding structure is sufficient to satisfy 37 C.F.R. § 42.104(b)(3). We also note that at this stage of the proceeding, Patent Owner does not dispute that Petitioner has correctly identified the corresponding structure. The parties may further address the proper interpretation of “lifter” at trial.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“gas pressure system” recited in the preamble of independent claims 1 and 17. Prelim. Resp. 21–22. Patent Owner further argues that Petitioner, through its comparison of claims 1 and 17 to Haley, improperly implies that the “gas pressure system” can be “limited to a distinct portion of a power tool.” Id. at 23. Patent Owner contends that such an interpretation is improper because the “gas pressure system” must refer to “the entire system,” because the “structure of the claims themselves . . . include[s] . . . every component of the tool.” Id. We disagree. The “gas pressure system” recited in the preambles of claims 1 and 17 expressly refers to a system that is “for a power tool” and thus does not necessarily refer to “the entire” tool or “every component of the tool.” Ex. 1001, 39:6 (claim 1), 40:51 (claim 17). Neither claim 1 nor claim 17 recites, for example, the lifter or driver, which are required elements of an “entire” tool. Id. at 39:6–22 (claim 1), 40:51–67 (claim 17). The lifter and driver are introduced in dependent claims 2 and 18. Id. at 39:23–30 (claim 2), 41:1–9 (claim 18). Still other necessary components of a tool, e.g., a motor and power source, are introduced in dependent claims 5 and 19. Id. at 39:40–42 (claim 5), 41:10–13 (claim 19). By contrast to claims 1 and 17, independent claims 9 and 14 recite a “portable fastener driving tool” and expressly recite many necessary components of such a tool including the driver, lifter, prime mover, and power source. Id. at 39:54 (claim 9), 40:20 (claim 14). Accordingly, we find that the “gas pressure system” of claims 1 and 17 broadly refers to a portion of a power tool rather than the “entire system” or “every component of the tool.” slip op. at 8
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSRPatents in suitUS 11,034,007 - PTAB · Jun 6, 2025 · IPR2025-00257 · APJ Lilan Ren · IPR · Institution
The Board instituted IPR on claims 1–15 and all asserted grounds, finding a reasonable likelihood that claim 1 is unpatentable over Cable and Naware and over Comb and Tummala.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“discussed below, we decline to exercise our discretion to deny the Petition.” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2024); 37 C.F.R. § 42.4(a) (2024). Institution of an inter partes review requires that “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that there is a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim, and we institute an inter partes review.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“persuaded that Petitioner has sufficiently shown for purposes of institution that a person of ordinary skill in the art would have been motivated to combine the teachings of Cable and Naware in the manner argued by Petitioner. For example, both references directly relate to 3D printing, and we are persuaded that Cable teaches “a heated build platform and calls on the POSITA to implement this teaching via suitable solutions known in the art.” Pet. 13 (noting that Cable teaches a build platform that can be heated “by any suitable heating elements” (citing 1006 ¶ 45)). The current record also indicates that Naware taught known options in this regard, e.g., where it describes a build plate to be used in a 3D printing process that includes contact plates and temperature control modules. See, e.g., Ex. 1007, code (57). Petitioner additionally argues that there is a reasonable expectation of success in combining Cable with Naware because “3D printers with temperature-controlled heated build plates were well-known technologies at the time of the ’660 patent in 2014, and these technologies had been successfully demonstrated in the real-world by then.” Pet 15 (citing various portions of Ex. 1003). Patent Owner does not contest Petitioner’s arguments with respect to a reasonable expectation of success in combining Cable with Naware. See generally Prelim. Resp. Based on our review and consideration of the current record, we are persuaded that Petitioner has sufficiently shown for the teachings of Cable and Naware in the manner argued by Petitioner.” slip op. at 23
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner “does not contest Petitioner’s description of a person of ordinary skill in the art (a ‘POSITA’) having a bachelor’s degree in Mechanical Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 37. Patent Owner does not address the specific knowledge that Petitioner contends that ordinarily skilled artisan would possess. Id. For purposes of this decision, we adopt Petitioner’s unopposed definition of the level of ordinary skill in the art as it appears consistent with the disclosures of the ’660 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 18
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 9,592,660 - PTAB · May 19, 2025 · IPR2025-00032 · APJ Mitchell G Weatherly · IPR · Institution
The Board instituted IPR on all challenged claims and grounds, finding a reasonable likelihood that claims 1, 10, 19, and 28 are obvious.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDecided for petitioner
“At least because of the material differences in Ferro compared to Hafner ’174 and the reliance on Donnelly and Letendre, which were not before the Office, we find that the same or substantially the same art was not previously presented to the Office.” slip op. at 12
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“information presented in the petition filed under section 311 and any response filed under section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Based on our review of the record,1 we conclude that Petitioner is reasonably likely to prevail with respect to at least one of the challenged claims.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“We disagree with Patent Owner. It is true that Oyobe focuses on alerting a vehicle user to a low state of charge by raising a physical indicator on the exterior of the vehicle (i.e., the “informing apparatus 102) when the battery is low. Ex. 1005 ¶ 40. Oyobe explains: even in such a case where the vehicle user exit from the vehicle without checking the SOC of main battery B on the console panel, informing apparatus 102 disposed at a location where it can easily be seen outside the vehicle by the vehicle user allows the vehicle user to easily recognize the necessity of charging main battery B. Id. However, Oyobe’s focus on raising a physical indicator on the vehicle as a reminder does not detract from Oyobe’s unambiguous disclosure that its vehicle also includes position detecting apparatus 108 that uses wireless communication to “sense that the vehicle is parked at the location where charging equipment is installed.” Id. ¶ 142. Oyobe’s ability to sense whether a vehicle is parked next to a charger allows Oyobe’s system to remind the user to charge the battery by raising low battery indicator 102 while the vehicle is located next to a charger but not “where charging cannot be performed.” Id. ¶¶ 143–145. Accordingly, regardless of the reason that Oyobe provides for including its vehicle position detecting apparatus, Oyobe undeniably describes a vehicle sensor that can provide “information indicative of a presence of an electric vehicle in a parking space” near a charging station. And, we find that Petitioner has sufficiently explained why an ordinarily skilled artisan would have been motivated to use Oyobe’s sensor in Ferro’s electric vehicle to “advantageously allows a user to instruct charging without exiting the vehicle and physically interacting with a charging station.” Pet. 11–12 (citing Ex. 1003 ¶¶ 150–152).” slip op. at 20
- Strike new argumentNew argument consideredDecided for petitioner
“Third, Patent Owner argues that Petitioner violates Rule 42.6(a)(3) by improperly incorporating arguments from Mr. Andrews’s Declaration into the Petition to establish that Oyobe teaches sensing the presence of a vehicle in a “parking space” as recited in limitation 1e. Prelim. Resp. 42–43 (citing Pet. 19–20 (citing Ex. 1003 ¶¶ 178–181)). Patent Owner contends that Mr. Andrews’s citation of four references that are not expressly cited in the Petition, Exhibits 1018, 1053, 1057, and 1059, implicitly demonstrates that the Petition incorporates arguments by reference. Id. Not only do we find Petitioner’s reliance on Mr. Andrews’s testimony to be persuasive, but we also find that Mr. Andrews’s citations to Exhibits 1018, 1053, 1057, and 1059 provide strong support for his testimony that an ordinarily skilled artisan would understand that Oyobe teaches that its vehicle is in a parking space when Oyobe’s apparatus 108 detects that “the vehicle is parked” near charging equipment. Far from improperly incorporating arguments by reference, we find Mr. Andrews’s citation to objective evidence to support his opinions on how an ordinarily skilled artisan would read Oyobe’s disclosure to be preferred and highly persuasive.” slip op. at 21
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · GrahamPatents in suitUS 11,563,338 - PTAB · May 14, 2025 · IPR2025-00021 · APJ Barbara A Parvis · IPR · Institution
The Board instituted IPR on claims 1–19 and all asserted grounds, finding a reasonable likelihood that Petitioner would prevail on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“court proceeding to the Northern District of California (Ex[.] 1036[,] 8).” Pet. 73. However, on March 25, 2025, the District Court denied the motion to transfer. Ex. 2026. Thus, we find that factor 2 weighs in favor of exercising discretion.” slip op. at 9
- Skill levelSkill level petitioner adoptedDecided for petitioner
“The level of ordinary skill in the art usually is evidenced by the references themselves. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978). As Petitioner’s description of a person of ordinary skill appears commensurate with the subject matter before us, we apply Petitioner’s definition for purposes of this Decision.” slip op. at 12
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“We disagree with Patent Owner on this record. The language of claim 1 recites “location access rights of said device from said first wireless device.” The claim language does not limit the location access rights to be of only the one other device, at the exclusion of other devices. The ordinary and customary meaning of “location access rights of said device from said first wireless device” encompasses rights that allow other devices, in addition to the recited device, to access location information. The disclosure in the written description is consistent with the ordinary and customary meaning. Although the written description states that an object of the invention is to provide a security feature which allows a user to limit or deny access to a particular user, the written description discusses other purposes served by the assignment of access rights. For example, the written description discloses that “[u]sers may be added, individually or in groups, to a list of users with location access rights to a specific user by that specific user. A specific user may, at any time, modify, delete, or add users allowed to access his or her location.” Ex. 1001, 3:22- 26. The written description further discloses that “a user may organize his/her user list into groups and assign access rights to that group (e.g., family member user group, close friend user group).” Id. at 13:9–12. The fact that the written description of the ’039 patent sets forth multiple objectives to be served by the access rights confirms that these terms should not be construed as limited to a single device. Phillips, 415 F.3d at 1327. Further, because the written description here includes an embodiment where a user assigns access rights to a group, we are persuaded that the scope of the disputed claim terms encompasses a group permission. Vitronics Corp. v. Conceptronic, Inc., 90 F.3d 1576, 1583 (Fed. Cir. 1996) (holding that interpreting a claim to exclude an embodiment disclosed in the written description “is rarely, if ever, correct and would require highly persuasive evidentiary support, which is wholly absent in this case.”). At this stage, we interpret the scope of the “location access rights of said device from said first wireless device” to encompass at least the disclosed embodiment of assigning access rights to a group. Ex. 1001, 13:9– 12.” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“Petitioner argues that a person of ordinary skill in the art would have made Petitioner’s proposed combination of “Degnbol’s disclosure of both selection of location-based events and manual entry using the handset of the phone with Sheha, to improve user ease, given that such techniques were well-known and conventional to POSAs at the time of alleged invention.” Pet. 18 (citing Ex. 1003 ¶ 132). Degnbol describes that “[i]t is an advantage of the present invention that user ‘A’ can be alerted when user ‘B’ arrives or leaves the defined location(s) or area(s)” so as “to enable user ‘A’ to know in advance the proximity or approximate whereabouts of user ‘B’ before possibly acting upon this information by contacting user ‘B’ — or allowing ‘B’ to contact ‘A.’” Ex. 1035, 3:23–27. At this preliminary stage, we find that Petitioner provides sufficient rationale to combine the teachings of Sheha, Degnbol, and McNulty for purposes of institution. Based on the evidence and arguments currently of record, we find that Petitioner demonstrates sufficiently for purposes of institution that the Sheha, Degnbol, and McNulty combination teaches the features recited in claim elements [1D] through [1F] and Petitioner provides sufficient rationale to make its proposed combination. We find that Patent Owner’s arguments do not undermine Petitioner’s showing. c) Conclusion—Claim 1 After consideration of the arguments and the evidence of record at this early stage, we determine that Petitioner has shown sufficiently, for purposes of institution, that the combination of Sheha, Degnbol, and McNulty teaches or suggests all recitations in claim 1. Also, we find that Petitioner provides sufficient rationale to combine the teachings of Sheha, Degnbol, and McNulty for purposes of institution. We find that Patent Owner’s arguments do not undermine Petitioner’s showing. Based on the record at this preliminary stage, we conclude that Petitioner has demonstrated a reasonable likelihood that it would prevail in showing that claim 1 is unpatentable under 35 U.S.C. § 103 as obvious over the combination of Sheha, Degnbol, and McNulty.” slip op. at 28
Claim construction§ 103 obviousnessDiscretionary denialcites PhillipsPatents in suitUS 11,096,039 - PTAB · May 12, 2025 · IPR2025-00018 · APJ Jeffrey S Smith · IPR · Institution
The Board instituted IPR on claims 1–30 on all asserted grounds, finding a reasonable likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“court proceeding to the Northern District of California (Ex[.] 1036[,] 8).” Pet. 75–76. However, on March 25, 2025, the District Court denied the motion to transfer. Ex. 2026. Thus, we find that factor 2 weighs in favor of exercising discretion.” slip op. at 11
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“purposes of institution, we determine that Petitioner demonstrates a reasonable likelihood that independent claim 1 is unpatentable over Sheha.” slip op. at 32
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“permission is operable of being provided by said first wireless device for said second wireless device to access location information about said location.” The claim does not recite that the permission is limited to permission for only the second wireless device. The ordinary and customary meaning of “a permission . . . for said second wireless device to access location information” encompasses a permission that allows other devices, in addition to the “second wireless device,” to access location information.” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successInstituted
“On this record, in considering the background knowledge as well as the inferences that an ordinarily skilled artisan would draw from Sheha’s disclosure, we are sufficiently persuaded that a person of ordinary skill in the art would have caused the mobile telephone to display the map of Figure 5. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 418 (2007) (In an obviousness analysis, a court will “look to . . . the background knowledge possessed by a person having ordinary skill in the art” and “can take account of the inferences and creative steps that a person of ordinary skill in the art would employ.”). The references cited by Mr. Williams explicitly show what is already implicitly taught by Sheha, namely, that displaying the map of Figure 5 on a mobile telephone was within the background knowledge of a person of ordinary skill. Ex. 1003 ¶¶ 138–144; Ex. 1007 ¶¶ 2, 21, p. 85; Ex. 1016 ¶ 27; Ex. 1014, 3:28–31, 4:43–58; Fig. 4B; Ex. 1017, 4:38–57, 5:13–17, 6:14–27, 6:59–7:6, Fig. 2; Ex. 1018, 2:2–7, 3:59–67, 5:48–57, Fig. 4B. We agree with Mr. Williams, that a person of ordinary skill in the art, in light of the teachings of Sheha and his or her background knowledge, would have caused a mobile telephone to receive location information without initiating a telephone call and would have used the location information to display a map on the mobile telephone in a form similar to that shown in Figure 5 as taught by Sheha and as was well known in the art. Ex. 1003 ¶¶ 133–144.” slip op. at 31
Claim construction§ 103 obviousnessDiscretionary denialcites KSRPatents in suitUS 11,122,418 - PTAB · May 12, 2025 · IPR2025-00124 · APJ Barbara A Parvis · IPR · Institution
The Board instituted IPR of claims 1–46 on all asserted grounds, finding a reasonable likelihood that Petitioner would prevail on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“WITHOUT PREJUDICE to refiling of the same within fourteen (14) days following the PTAB’s institution decision on the last of the pending IPRs” (Ex. 2008, 3), we decline to speculate whether the district court will grant a stay. Thus, we find that factor 1 is neutral. slip op. at 9
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Upon consideration of the arguments and the evidence of record at this preliminary stage, we determine that Petitioner has demonstrated a reasonable likelihood of prevailing on at least one of the challenged claims of the ’575 patent. Accordingly, we grant Petitioner’s request and institute an inter partes review of all challenged claims of the ’575 patent and with respect to all grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“had a bachelor’s degree in computer science, computer engineering, electrical engineering, or a similar degree, with one or two years of experience with wireless networks and devices, such as cellphones and personal digital assistants (‘PDAs’), as well as wireless positioning technologies, such as GPS or triangulation,” and that “[m]ore education could compensate for less practical experience, and vice versa.” Pet. 4 (citing Ex. 1003 ¶¶ 50–54). At this stage of the proceeding, Patent Owner does not challenge the level of ordinary skill in the art proposed by Petitioner’s expert. See generally Prelim. Resp. For purposes of this Decision, we adopt Petitioner’s proposal as reasonable and consistent with the ’575 patent specification and the prior art.5” slip op. at 12
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for petitioner
“We disagree with Patent Owner on this record. The language of claim 1, quoted above, recites “changing, at the direction of said first wireless telephone, a list of users on said remote server for a profile associated with said first wireless telephone that are allowed to access said location, wherein each user of said list of users is representative of one of a plurality of wireless telephones.” Ex. 1001, 12:65–13:3. The recitation of “said location” derives antecedent basis from element [1A], which recites “obtaining a location of a first wireless telephone,” thus “said location” in element [1C] is the location of the first wireless telephone. Id. at 12:62.7 The claim language does not limit access to the location of the first telephone to one other device, at the exclusion of other devices. Indeed, the claim language specifically recites that “a list of users” are changed “for a profile associated with said first wireless telephone” and that “each user of said list of users is representative of one of a plurality of wireless telephones.” Ex. 1001, 12:65– 13:3 (emphases added). The ordinary and customary meaning of “changing, at the direction of said first wireless telephone, a list of users on said remote server for a profile associated with said first wireless telephone that are allowed to access” to the location of the first wireless device “wherein each user of said list of users is representative of one of a plurality of wireless telephones” (Ex. 1001, 12:65–13:3) encompasses allowing “a list of users,” each having a telephone, access to the location of the “first wireless telephone” and further encompasses allowing other telephones, in addition to the recited plurality of wireless telephones access to the location of the first wireless telephone.” slip op. at 15
Claim construction§ 103 obviousnessDiscretionary denialcites PhillipsPatents in suitUS 8,374,575
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.