- PTAB · Feb 27, 2025 · IPR2024-01227 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR on all grounds for claims 1–5 and 8–13, finding a reasonable likelihood that claim 8 is anticipated by Fukui and claims 1 and 8 are obvious over Fukui-based grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this preliminary stage, we determine whether the information presented shows a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been unpatentable over the proposed prior art. We analyze the asserted grounds with the above-noted principles in mind.” slip op. at 10
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“Patent Owner contends that we should deny institution under 35 U.S.C. § 325(d) “because the Petition presents ‘the same or substantially the same prior art or arguments previously . . . presented to the Office.’” Prelim. Resp. 25–31 (alteration in original). Specifically, Patent Owner explains, the Office previously considered Sedor during the ’542 patent’s prosecution, and Sauter was made of record but not considered during prosecution. Id. Patent Owner, however, states that it “recognizes that this argument only reaches Sauter-based grounds, not Fukui-based grounds. This argument thus only needs to be addressed after the Board confirms the fundamental deficiencies in Petitioner’s Fukui-based grounds.” Id. at 25 n.3. Because, as set forth below, we do not, on the present record, find any “fundamental deficiencies in Petitioner’s Fukui-based grounds” that inhibit institution of trial, we regard Patent Owner’s § 325 request as moot, and we need not consider it further.” slip op. at 10
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have [had] a B.S. degree or equivalent in mechanical or electrical engineering or similar fields, in addition to a minimum of two years of professional experience with or graduate studies involving design, development, and/or utilization of optical communication systems.” Pet. 26. On the present record, Patent Owner does not dispute this proposed level of skill. Prelim. Resp. 1–31. Neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears consistent with the ’542 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“enough to resolve . . . the lead Fukui ground” but that “[t]here are two disputes relevant to the alternative Sauter ground.” Pet. 22. With respect to the first of these “disputes,” Petitioner presents two claim constructions for the claim term or phrase “cassette width as measured between outer side edges thereof of one of one, two, three, four and six standard width units.” Id. at 23. The constructions are said to be from “the co-pending litigation,” with one characterized as “Patent Owner’s proposed construction”6 and the other as “CommScope’s proposed construction.”7 Of note is Petitioner’s 6 The claim construction attributed to Patent Owner is: “cassette width as measured between the outer side edges thereof that accommodates one of one, two, three, four, or six receptable modules.” Pet. 23. 7 Petitioner’s construction is: “The cassette width as measured between the outer side edges thereof equals one, two, three, four, or six times the contention that “[Patent Owner]’s construction cannot be correct,” and accompanying explanation in that respect. Id. at 22–23, 24. Patent Owner acknowledges that there is a dispute between the parties as to the noted claim construction but urges that “[t]he Board, however, need not fully resolve this claim construction dispute,” as, in Patent Owner’s view, the grounds based on Sauter are deficient based on either construction. Prelim. Resp. 21–22. We are mindful of Petitioner’s view that Patent Owner’s litigation construction is not correct. We also question whether that construction adds clarity in substituting “width that accommodates” for “width of,” and replacing “standard width units” with “receptable modules,” without, on this record, support for such word variations. Nevertheless, our determination whether to institute trial does not require resolution of any claim construction dispute, nor does it necessitate that we adopt any particular construction for the pertinent claim term. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). We invite the parties to develop the record more fully on this claim- construction issue during trial.” slip op. at 12
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,435,542 - PTAB · Feb 27, 2025 · IPR2024-01218 · APJ Josiah C Cocks · IPR · Institution
The Board instituted IPR of claims 1–5 and 8–13 on all petitioned grounds, finding a reasonable likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“institute an inter partes review. The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted unless “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a).” slip op. at 2
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“Stated somewhat generally, the core question underlying Patent Owner’s challenge to Petitioner’s Fukui-based grounds is whether a conversion module (e.g., 20) that is formed by coupling together two unit modules establishes that conversion module as a new structure identifiable as a unitary cassette. We discern that Fukui uses the term “conversion module” to refer to component 10, and uses that same term, i.e., “conversion module” to refer to component 20. See, e.g., Ex. 1004, 6:33–35, 7:23–25. The components 10A and 10B that make-up conversion module 20 are characterized as each being a “unit module.” See, e.g., id. at 7:25–27. Thus, once unit modules 10A and 10B are coupled together to form the structure that is “conversion module 20,” the current record reasonably suggests that the conversion module 20 is a component analogous to conversion module 10, but with a larger width, i.e., two times the width. Further, Fukui also characterizes unit modules 10A and 10B as being “fixed” to one another via coupling member 21 (see, e.g., id. at 10:11–16) and forming “one body” (see, e.g., id. at 8:2–3). Further still, as described and shown in Fukui (e.g., Figure 5), conversion module 20 is structured to operate via a singular multicore optical connector 16 from which optical fibers F1 extend to all of the single-core optical connectors 17 of the conversion module. Id. at 7:52– 8:6. Thus, conversion module 20 is recognizable has having a singular system of fiber optic components within its body. At this time, we regard such characterization of the coupled unit modules 10A and 10B as reasonably giving rise to an understanding that the resulting conversion module 20 constitutes a unitary module or cassette component.” slip op. at 20
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“IV. REQUEST FOR DENIAL UNDER 35 U.S.C. § 325 Patent Owner contends that the Board should exercise its discretion to deny under 35 U.S.C. § 325(d) on the theory that the Petitioner relies on substantially the same prior art and arguments that were previously considered by the Office. See Prelim. Resp. 31–37. Patent Owner, however, states the following: “Patent Owner recognizes that this argument only reaches Sauter-based grounds, not Fukui-based grounds. This argument thus only needs to be addressed after the Board confirms the fundamental deficiencies in Petitioner’s Fukui-based grounds.” Id. at 31, n.4. Because, as set forth above, we do not agree at this time as to any “fundamental deficiencies in Petitioner’s Fukui-based grounds” that inhibit institution of trial, we regard Patent Owner’s § 325 request as moot, and need not consider it further.” slip op. at 23
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“We are mindful of Petitioner’s view that Patent Owner’s litigation construction is not correct. We also question whether that construction adds clarity in substituting “width that accommodates” for “width of,” and replacing “standard width units” with “receptable modules,” without, on this record, support for such word variations. Nevertheless, our determination whether to institute trial does not require resolution of any claim construction dispute or necessitate that we adopt any particular construction for any claim term. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the controversy (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). 9 The claim construction attributed to Patent Owner is: “cassette width that accommodates one of one, two, three, four, or six receptable modules.” Pet. 21. 10 Petitioner’s construction is: “The cassette width equals one, two, three, four, or six times the standard width unit, without an additional amount. This means the cassette width must be evenly divisible by the standard width unit.” Pet. 21.” slip op. at 12
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · GrahamPatents in suitUS 10,795,107 - Biofrontera Inc. / Biofrontera Bioscience GmbH et al. v. Sun Pharmaceutical Industries, Inc.InstitutedPTAB · Feb 24, 2025 · IPR2024-01312 · APJ Erica A Franklin · IPR · Institution
The Board instituted review of claims 1, 2, 4-6, 16, 17, and 19-21 on all asserted grounds, finding a reasonable likelihood of unpatentability over Lundahl and Larsen.
RulingsInstitution decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“justification for requiring a POSITA to have both an engineering degree and a medical degree. We agree, insofar as Petitioner has not clearly set out any particular explanation or evidence in support of its dual-degree requirement. In all other respects, we note that the parties’ proposed definitions are largely similar. Because we determine that Patent Owner’s proposed definition is reasonable and consistent with the ’028 patent and the cited art, we adopt Patent Owner’s definition for purposes of this Decision. In any event, our decision whether to institute does not turn on this level of skill determination.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“used to construe the claim in a civil action under 35 U.S.C. § 282(b); 37 C.F.R. § 100(b). Under that standard, claim terms “are generally given their ordinary and customary meaning” as understood by a person of ordinary skill in the art at the time of the invention. Phillips v. AWH Corp., 415 F.3d 1303, 1312–13 (Fed. Cir. 2005) (en banc) (quoting Vitronics Corp. v. Conceptronic, Inc., 90 F.3d 1576, 1582 (Fed. Cir. 1996)). See Wellman, Inc. v. Eastman Chem. Co., 642 F.3d 1355, 1361 (Fed. Cir. 2011) (“[C]laim terms need only be construed ‘to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Petitioner and Patent Owner assert that the Board need not construe any claims for the purpose of deciding whether to institute an inter partes review. Pet. 12; Prelim. Resp. 24. We agree.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“Based on our review of the Petition, Petitioner explains that a driving motivation for a POSITA to modify Lundahl to include Larsen’s five panels is “to increase the flexibility of the device to ensure the light panels could be maintained at a distance of 2-4′′ from surface of the treatment area, whether the face, arm, or back, etc.” Pet. 29 (emphasis added). As Lundahl’s device is not flexible, and such flexibility would improve its ability to treat areas other than an average sized face, we determine, at this stage in the proceeding, that this motivation for the combination is sufficient.” slip op. at 20
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightInstituted
“would have been motivated to modify Lundahl’s device by incorporating Larsen’s use of LEDs on the surface of the light applicators in place of Lundahl’s fluorescent tubes with a reasonable expectation of success. Prelim. Resp. 55. Patent Owner argues that Petitioner’s modification is based on improper hindsight bias because “Petitioner cherry-picks Larsen’s LEDs (together with the five panels) and purports to arrange them according to the [sic] ‘the uneven spacing’ of Lundahl’s fluorescent tubes.” Id. at 56 (citing Pet. 46–49; Ex. 1015 ¶¶ 175–80). According to Patent Owner, “Petitioner cannot on the one hand argue that a ‘POSITA would have understood that Larsen’s applicator is configured to uniformly illuminate a treatment surface of the patient,’ while on the other ignore Larsen’s teaching that the ‘light sources 17 are placed in regular row arrangements.’” Id. Patent Owner asserts that Petitioner’s proposed modification “mish-mashes aspects of Lundahl and Larsen ([while] avoiding the overall teachings of [challenged] claims.” Id. at 56–57. As discussed above, based on our consideration of the current record, Petitioner has provided sufficient motivation for employing Larsen’s flexible five panel configuration. These panels in Larsen already use LEDs as their light source. So, in our view, Petitioner’s incorporation of the five panels includes the lighting source, i.e., LEDs, for those panels taught by Larsen. Further, we note that Petitioner has persuasively asserted that a skilled artisan would have been motivated to use Larsen’s LEDs as they are more cost-efficient and last longer. See Pet. 31.” slip op. at 20
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,697,028 - Penumbra, Inc. v. Rapidpulse, Inc.InstitutedPTAB · Feb 21, 2025 · IPR2024-01261 · APJ Jamie T Wisz · IPR · Institution
Instituted IPR of claims 1–20 on all petitioned grounds after finding a reasonable likelihood that the challenged claims would have been obvious over the cited combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), the Board “may not authorize an inter partes review to be instituted unless . . . the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” After considering the Petition, the Preliminary Response, and the evidence of record, we determine that Petitioner has demonstrated a reasonable likelihood of prevailing with respect to at least one claim challenged in the Petition. Accordingly, we institute an inter partes review of claims 1–20 of the ’402 patent, based on all of the grounds identified in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner, relying on the testimony of Mr. Brown, contends that a person of ordinary skill in the art (“POSA” or “POSITA”) as of the relevant date would be either: (1) a person with a B.S. in engineering or an equivalent field, with two-four years of academic or industry experience in aspiration embolectomy and thrombectomy or comparable industry experience who would, where appropriate, work or consult with others, including a physician, to develop embolectomy or thrombectomy devices; or (2) an interventional neurosurgeon with at least three years of experience developing and/or using medical devices in embolectomy or thrombectomy procedures, and who would, where appropriate, work or consult with others, including an engineer, to develop such a medical device. Pet. 11 (citing Ex. 1005 ¶ 48). Petitioner also contends that, “[a] person with less education but more relevant practical experience, or more relevant education but less practical experience, may also meet this standard.” Id. Patent Owner states that for purposes of its Preliminary Response, it accepts Petitioner’s proposed definition of POSA, but “reserves the right to propose its own description of a POSA if the Board institutes review.” Prelim. Resp. 8 n.3. For purposes of this Decision, we adopt Petitioner’s characterization because it is consistent with the level of skill in the art at the time of the invention as reflected by the ’402 patent and the cited prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown”” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner provides a proposed construction for the term “[limited/limiting] to a positive amount of exit flow” recited in claims 3, 4, 13, and 15, as “the maximum permitted amount of positive exit flow in the distal direction, including no exit flow.” Pet. 15–16. Patent Owner asserts that “Petitioner’s proposed construction of ‘a positive amount of exit flow’ as ‘including no exit flow’ is plainly wrong.” Prelim. Resp. 9 (citing Pet. 15–16). Patent Owner also asserts that to the extent Petitioner “view[s] the claim term ‘flow in and out’ as encompassing only flow in or no flow at all, that would be plainly wrong too.” Id. Having evaluated the arguments and evidence before us on this record, we determine that construction of “[limited/limiting] to a positive amount of exit flow” is not necessary for purposes of this Decision. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)). Turning to a different claim term, we note that neither party provided an explicit construction for the limitation in claim 1 of “control[ling] fluid address the proper claim construction for this term and to specifically discuss what is encompassed by “flow . . . out from the distal end.” We note that in the related cases (IPR2021-01466 and IPR2022-00608), we construed the term, “forward flow” to mean “an amount of liquid in the lumen that exits the distal end in the distal direction that is greater than 6 microliters of fluid.” Ex. 2007, 15; Ex. 2011, 13–14. Upon review of the parties’ arguments and the evidence of record, we determine that no terms require express construction for purposes of this Decision. See Nidec Motor Corp, 868 F.3d at 1017.” slip op. at 9
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“c) Analysis On the current record, we are persuaded that Petitioner has demonstrated a reasonable likelihood that the subject matter of claim 1 would have been obvious over the combined disclosures of Yang and Mullins. First, Patent Owner asserts that Yang does not disclose the limitation of “a controller . . . to control fluid flow in and out from the distal end.” Prelim. Resp. 21– 32. On the current record, we agree with Patent Owner that introducing a positive pressure pulse such as through the water hammer effect does not necessarily mean that there will be an overall distal end. See Ex. 2001 ¶¶ 53–54; Ex. 2005 ¶ 60; Ex. 2007, 51 n.12. This is especially true if an overall vacuum state is maintained in the catheter. See Ex. 2001 ¶ 56; Ex. 2007, 43; Ex. 2010, 125:11–18. Further, on the current record, we credit the testimony of Patent Owner’s declarant, Mr. Culbert, that to have flow out of the catheter’s distal end when it is in a patient, the pressure in the catheter needs to exceed mean arterial pressure. See Ex. 2001 ¶ 59; Ex. 2010, 126:15–21. Therefore, on the current record, we agree with Patent Owner that Yang may not explicitly disclose flow out from the distal end of the catheter. Whether Yang alone renders this limitation obvious may be explored further on a full trial record; however, because this limitation appears to be taught by Mullins and Petitioner has shown on this record that a POSA would have been motivated to combine the disclosures of Yang and Mullins, we are sufficiently persuaded that Petitioner has met its burden to show a reasonable likelihood that this limitation is rendered obvious by the combined disclosures of Yang and Mullins.” slip op. at 18
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,406,402 - PTAB · Feb 19, 2025 · IPR2023-01424 · APJ Lynne H Browne · IPR · Final written decision
The Board canceled original claims 1–16 and 18–20 and denied substitute claims 21–39 because they broadened the challenged claims by removing the second-aperture limitation.
RulingsFinal written decision- ScopeMotion to amend granted in partGranted in part
“1. Statement of Law A motion to amend “may not enlarge the scope of the claims of the patent or introduce new matter.” 35 U.S.C. § 316(d)(3). “Before considering the patentability of any substitute claims . . . the Board first must determine whether the motion to amend meets the statutory and regulatory requirements set forth in § 316(d) and 37 C.F.R. § 42.121.” Lectrosonics, Inc. v. Zaxcom, Inc., IPR2018-01129, Paper 15 at 4 (PTAB Feb. 25, 2019) (precedential, “Lectrosonics”) (emphases added). This includes the prohibition against enlarging the scope of the claims. See Lectrosonics, at 6–7. “[T]he patent owner must satisfy the Board that the statutory criteria in [35 U.S.C.] § 316(d)(3) are met and that any reasonable procedural obligations imposed by the Director are satisfied.” Aqua Prods., Inc. v. Matal, 872 F.3d 1290, 1305–06 (Fed. Cir. 2017) (emphasis added) (lead plurality opinion by J. O’Malley); see also id. at 1341 (“There is no disagreement that the patent owner bears a burden of production in accordance [with] 35 U.S.C. § 316(d).”) (majority opinion by J. Reyna). Accordingly: “Any motion to amend may be denied where . . . [t]he amendment seeks to enlarge the scope of the claims of the patent.” 37 C.F.R. § 42.121(a)(2)(ii); see also PTAB Consolidated Trial Practice Guide (Nov. 2019), 69, 71.1 “[I]f a substitute claim is broader in any respect it is considered to be” slip op. at 8
- ExcludeNot reached
“We do not rule on Patent Owner’s Objection to Evidence Submitted with Petitioner’s Opposition to the Motion and Patent Owner’s Motion to Exclude Evidence, because we do not rely on the cited Evidence in formulating our Decision below.” slip op. at 3
Nonecites PhillipsPatents in suitUS 11,536,632 - Apple Inc. v. RJ Technology LLCSome claims unpatentablePTAB · Feb 18, 2025 · IPR2023-01350 · APJ Jon B Tornquist · IPR · Final written decision
Claims 5–10 are unpatentable as obvious; claims 11–14 were not shown unpatentable because the evidence did not establish the claimed capacity retention after 400 cycles.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends a person of ordinary skill in the art “would have held a Bachelor’s degree in chemistry or chemical engineering, with at least 4 years of experience in cell design, electrochemical techniques, and battery materials development.” Pet. 4. Petitioner further contends that a “Master’s Degree can substitute[] for some of the relevant experience,” and “[e]quivalent training with battery specific experience can accommodate other degreed fields.” Id. 9 The parties here do not address objective evidence of nonobviousness. Patent Owner does not dispute Petitioner’s definition of the ordinarily skilled artisan. PO Resp. 20. We adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the ’641 patent, the prior art of record, and the parties’ arguments.” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“The parties agree that the term “charge cut-off voltage” is “the maximum voltage to which the battery is configured to be charged.” PO Resp 21–22; Pet. Reply 1. The parties dispute, however, whether the “charge cut-off voltage” is a “battery property” or “the voltage applied to the battery during charging.” PO Resp. 21–24; Pet. Reply 1–6. We need not resolve the precise meaning of “charge cut-off voltage” because there is no dispute that Yamaki discloses this limitation under either party’s interpretation of the claim term. Upon review of the prior art and the parties’ arguments, we determine that no terms of the ’641 patent require express construction. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))); Pet. Reply 1 (asserting that the challenged claims are unpatentable under either parties’ construction of “charge cut-off voltage”).” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableMotivation foundUnpatentable
“Patent Owner’s arguments do not persuasively undermine Petitioner’s position. Sakamoto expressly discloses setting the ratio of negative to positive electrode active material in the range of 1.05 to 1.30. Ex. 1005 ¶ 8. Sakamoto also explains why this range is preferable, i.e., if the ratio is roughly equal “the charge-discharge cycle performance is insufficient due to significant deterioration from charging and discharging,” and if the ratio is 10 Citations to the prosecution history of Yamaki are to the page numbers added to the lower right corner of the document. too high “too much of the compound does not participate in charging and discharging.” Id. ¶¶ 6, 8. These disclosures are sufficient to explain why one of ordinary skill in the art would have found it obvious to select the ratios disclosed in Sakamoto in Yamaki. Id. ¶ 8 (providing a secondary battery with a capacity ratio between 1.05 and 1.30 and noting that by setting the ratio within this range the resulting secondary lithium battery is “safe due to low risk of heat being generated and an explosion occurring”). We also disagree that Sakamoto teaches away from elevated voltages or from increasing the amount of lithium in circulation. See PO Resp. 29. Contrary to Patent Owner’s arguments, Sakamoto provides no general teaching against using a charge cut-off voltage above 4.2 V, or against increasing the level of lithium in circulation. Nor does Sakamoto “criticize, discredit, or otherwise discourage” the claimed invention. In re Fulton, 391 F.3d 1195, 1201 (Fed. Cir. 2004). Rather, Sakamoto warns against setting the reversible capacities of the positive and negative electrode substantially equal as this may result in excess lithium plating on the surface of the electrode. Ex. 1005 ¶¶ 6, 8. We agree with Petitioner that this disclosure would lead one of ordinary skill in the art to design a battery with a higher capacity in the negative electrode active material than the positive electrode active material. Pet. 11–12.” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner
“We also disagree that Sakamoto teaches away from elevated voltages or from increasing the amount of lithium in circulation. See PO Resp. 29. Contrary to Patent Owner’s arguments, Sakamoto provides no general teaching against using a charge cut-off voltage above 4.2 V, or against increasing the level of lithium in circulation. Nor does Sakamoto “criticize, discredit, or otherwise discourage” the claimed invention. In re Fulton, 391 F.3d 1195, 1201 (Fed. Cir. 2004). Rather, Sakamoto warns against setting the reversible capacities of the positive and negative electrode substantially equal as this may result in excess lithium plating on the surface of the electrode. Ex. 1005 ¶¶ 6, 8. We agree with Petitioner that this disclosure would lead one of ordinary skill in the art to design a battery with a higher capacity in the negative electrode active material than the positive electrode active material. Pet. 11–12.” slip op. at 15
Patent outcomesUS 7,749,641 mixedClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,749,641 - Menard, Inc. v. Signify Holdings B.V.InstitutedPTAB · Feb 14, 2025 · IPR2024-01469 · APJ Steven M Amundson · IPR · Institution
The Board instituted review of claims 1–20 on all petitioned challenges and granted Menard’s motion to join the Luminex IPR.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Here, Petitioner presents substantively identical challenges to claims 1–20 in the ’336 patent based on the same prior art, the same evidence, and the same unpatentability theories as Luminex presents in the Luminex IPR. Compare Pet. 15–89, with IPR2024-00101, Paper 1 (“Luminex Pet.”) at 15–89. According to Petitioner, the Petition differs from Luminex’s petition only because of different party names and updated sections concerning standing, related matters, real parties in interest, and counsel. Mot. 4. Because Petitioner presents substantively identical challenges to claims 1–20 in the ’336 patent based on the same prior art, the same evidence, and the same unpatentability theories as Luminex presents in the Luminex IPR, Petitioner satisfies the “reasonable likelihood” standard for instituting trial for the same reasons Luminex satisfied the “reasonable likelihood” standard for instituting trial. See Luminex Pet. 15–89; Luminex Inst. Dec. 19–64; Pet. 15–89.” slip op. at 14
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“Consistent with § 315(b) and § 315(c), the Board’s rules provide that “[a]ny request for joinder must be filed, as a motion under § 42.22, no later than one month after the institution date of any inter partes review for which joinder is requested.” 37 C.F.R. § 42.122(b). The Board’s rules also provide that § 42.101(b)’s one-year time bar “shall not apply when the petition is accompanied by a request for joinder.” Id. We instituted an inter partes review in the Luminex IPR on September 9, 2024. Luminex Inst. Dec. 1. On September 23, 2024, Petitioner filed the Petition and the Motion for Joinder. Pet. 91; Mot. 7. Under § 42.122(b), Petitioner timely filed the Petition and the Motion for Joinder. See 37 C.F.R. § 42.122(b).” slip op. at 15
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“If joined to the Luminex IPR, Petitioner agrees to take an “understudy” role and only “substantively participate” if Luminex is terminated from the Luminex IPR. Mot. 1, 5–6. Further Petitioner agrees that the following conditions will apply to it in its “understudy” role “so long as Luminex remains an active party”: (1) “all filings by [Petitioner] in the joined proceeding be consolidated with the filings of Luminex, unless a filing solely concerns issues that do not involve Luminex”; (2) Petitioner “shall not be permitted to raise any new grounds not instituted by the Board in the Luminex IPR, or introduce any argument not already introduced by Luminex”; and (3) “with regard to taking of testimony, [Petitioner] will abide by 37 C.F.R. § 42.53 or any agreement between the Patent Owner and Luminex.”” slip op. at 17
- PTAB / AIA Trials › §315(e) estoppelEstoppel appliesOther
“5. CONCLUSION For the reasons discussed above, we determine that it is appropriate under the circumstances here to join Petitioner as a party to the Luminex IPR. See §§ III.D.2–III.D.4. The estoppel provisions of 35 U.S.C. § 315(e) will apply to Petitioner.” slip op. at 18
NonePatents in suitUS 10,299,336 - PTAB · Feb 6, 2025 · IPR2024-01212 · APJ Robert A Pollock · IPR · Institution
The Board instituted IPR of claims 1–27 on all petitioned grounds after finding a reasonable likelihood that claim 1 would be obvious over Racz, Fitz, and Lee.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“§ 314. An inter partes review may not be instituted unless “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Further, a decision to institute may not do so on fewer than all claims challenged in the petition. SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018); 37 C.F.R. § 42.108(a). After considering the evidence and arguments presented in the Petition, we determine that Petitioner demonstrates a reasonable likelihood of prevailing in showing that at least one of the challenged claims of the ’664 patent is unpatentable. Accordingly, we institute an inter partes review as to all the challenged claims of the ’664 patent on all the grounds of unpatentability set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“According to Petitioner, the relevant technical field is “‘thermal ablation systems and methods,’ which includes ‘methods for performing Radio Frequency (RF) neurotomy.”’ Pet. 11 (citing Ex. 1003, 1:24–27). Relying on the testimony of Dr. Tucker, Petitioner contends that the ordinarily skilled artisan in this field would have had at least (i) a bachelor’s degree in biomedical engineering, or a related field, such as mechanical engineering, biomechanical engineering, or bioengineering, who also has at least 3 years of experience with thermal ablation system and methods; or (ii) an advanced degree in the same areas of academic study with at least 1 years of experience with thermal ablation systems and methods. Id. (citing Ex. 1034 ¶ 105) (paragraphing added). Absent evidence or argument to the contrary, we apply Petitioner’s proposed definition, as it appears consistent with the prior art and is supported by the presently unopposed testimony of Dr. Tucker. See Okajima v. Bourdeau, 261 F.3d 1350, 1355, (Fed. Cir. 2001) (the level of ordinary skill in the art may be reflected in the prior art itself). We note, however, that Petitioner’s open-ended language “at least” expands the ranges of education and experience indefinitely with no upper bound, thereby encompassing those of extraordinary skill. Therefore, we do not adopt this aspect of Petitioner’s formulation. B.” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“Claim Construction The Board interprets claim terms in an inter partes review using the same claim construction standard that is used to construe claims in a civil action in federal district court. See 37 C.F.R. § 42.100(b)). In construing claims, district courts give claims their ordinary and customary meaning, which is “the meaning that the term would have to a person of ordinary skill in the art in question at the time of the invention.” Phillips v. AWH Corp., 415 F.3d 1303, 1312–13 (Fed. Cir. 2005) (en banc). With respect to the challenged claims, Petitioner contends that no claim term requires express construction. Pet. 11 (citing Ex. 1034 ¶ 106 (Dr. Tucker’s testimony that “the terms in the Challenged Claims would be understood by a POSA to have their plain and ordinary meaning and do not require a special construction or definition”)). On the presents record, we agree with Petitioner that no term requires express construction. C.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“through [1e]. Pet. 28–30. Petitioner further relies on “Racz as modified in view of Fitz and Lee,” with respect to elements [1e] through [1h]. See generally, id. at 30–47. Supported by the testimony of Dr. Tucker, Petitioner contends that one of ordinary skill in the art would have been motivated to combine the teachings of Racz, Fitz, and Lee with a reasonable expectation of success of arriving at the claimed invention. Id. at 1–6, 21–27; Ex. 1034 ¶¶ 132–149. In short, Petitioner contends that “[m]ost of the recited RF needle features—including an elongate cannula, a removable RF probe, a conductive tip, and a monopolar configuration—are conventional features disclosed in . . . Racz,” whereas Fitz discloses that a single-tip device, such as disclosed in Racz, “would produce limited ablation volumes and would have motivated a POSA to solve this problem by adding deployable filaments,” as recited in claim elements [1e] and [1f]. Id. at 4–5, 21–22. In addition to its reliance on the multiple electrode tips disclosed in Fitz, Petitioner contends that Lee would have “motivate[ed] a POSA to implement deployable filaments on the tip of Racz’s device using channels within the cannula,” and “also shows how the filaments can extend outwardly around the needle’s tip to advantageously expand and control the ablation volume.” Id. at 5–6. Accordingly, Petitioner contends, one of ordinary skill in the art “would have found it obvious to modify Racz’s device to include the well-known deployable filaments described in Fitz and Lee,” and would have implemented this combination as “a matter of routine engineering.” Id. at 6, 27.” slip op. at 20
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 10,925,664 - PTAB · Feb 6, 2025 · IPR2024-01211 · APJ John G New · IPR · Institution
The Board instituted IPR on claims 18–47 and 53–74 and all petition grounds, finding a reasonable likelihood that claims 18–25, 27, and 29–33 are obvious over Racz, Fitz, and Lee.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“§ 314. An inter partes review may not be instituted unless “the information presented in the petition … and any response … shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Further, a decision to institute may not do so on fewer than all of the claims challenged in the petition. SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018); 37 C.F.R. § 42.108(a); see also PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018) (interpreting the statute to require “a simple yesor-no institution choice respecting a petition, embracing all challenges included in the petition”).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Absent evidence or argument to the contrary, we apply Petitioner’s proposed definition, as it appears to be consistent with the level of skill of the prior art and is supported by the presently unopposed testimony of Dr. Tucker. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the level of ordinary skill in the art may be reflected in the prior art itself). We note, however, that the open-ended language ‘at least’ expands the ranges of education and experience indefinitely with no upper bound, thereby also encompassing those of extraordinary skill as well. Therefore, we do not adopt this aspect of Petitioner’s formulation.” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“With respect to the challenged claims, Petitioner contends that no claim term requires express construction. Pet. 11 (citing Ex. 1033 ¶ 120 (Dr. Tucker’s testimony that “the terms in the Challenged Claims would be understood by a POSA to have their plain and ordinary meaning and do not require a special construction or definition”)). We agree with Petitioner that, on the record presently before us, no claim term requires express construction.” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“Petitioner argues that, in view of these teachings in Racz and Lee, a skilled artisan would have found implementing Lee’s perimeter filaments (22/1622) on Racz’s distal tip (14/38) to be a routine engineering task. Pet. 39 (citing Ex. 1033 ¶ 179). According to Petitioner, a person of ordinary skill in the arts would have recognized that it would be appropriate to implement Lee’s perimeter filaments (22/1622) without including Lee’s central filament. Id. Petitioner asserts that Lee discloses that any number and arrangement of filaments may be implemented to provide a desired ablation volume. Id. at 38 (citing Ex. 1010 ¶¶ 103, 105, 106). Additionally, Petitioner argues, because Racz’s tip (14/38) is already active, a skilled artisan would have recognized that Lee’s central filament would not be necessary. Id. (citing Ex. 1009, col. 3, ll. 60–63, col. 4, ll. 18–23; Ex. 1033 ¶ 179). Petitioner therefore argues that a person of ordinary skill in the art a person of ordinary skill in the art would have been motivated to implement Lee’s perimeter deployable filaments (22/1622) on the distal tip (14/38) of Racz’s cannula (10/33) for the purpose of expanding and controlling the energy coverage area of Racz’s device. Pet. 40. Specifically, Petitioner asserts that a skilled artisan would have been motivated to implement Lee’s perimeter filaments (22/1622) around Racz’s tip (14/38) to provide a desired ablation volume (e.g., in a full or partial “cone” shape) and omit Lee’s central filament. Pet. 38 (citing Ex. 1033 ¶¶ 179, 73–75, 79–83). Petitioner contends that, as both Lee and Fitz confirm, this would improve Racz’s device by providing an expanded and controlled energy coverage area. Id. (citing Ex. 1011 ¶¶ 9–10, Abstr.; Ex. 1010 ¶¶ 12, 84, 123–131; Ex. 1033 ¶ 179). Petitioner argues further that, in implementing Lee’s perimeter filaments (22/1622) on Racz’s distal tip (14/38), a person of ordinary skill in the art would have found it obvious to modify Racz’s tip (14/38) to include internal deflection surfaces (12/1612) (e.g., channels and ramps as disclosed in Lee) to guide the perimeter filaments (22/1622) outwardly around Racz’s tip (14/38). Pet. 41 (citing Ex. 1010 ¶¶ 16, 18, 92, 102, claims 8, 10; Ex. 1033 ¶ 180). Petitioner asserts that it would have been obvious to provide openings in Racz’s distal tip (14/38) (e.g., in communication the internal deflection surfaces as disclosed in Lee) such that Lee’s perimeter filaments (22/1622) can, when deployed, exit Racz’s distal tip (14/38). Id. (citing Ex. 1010 ¶ 92, 102; Ex. 1033 ¶ 180). Furthermore, argues Petitioner, and to preserve the functionality of Racz’s removable electrical probe (22/52) and active tip (14/38) (and consistent with Lee’s teachings) a skilled artisan would have arranged the perimeter filaments, channels, and ramps around the internal perimeter of Racz’s cannula (10/33). Pet. 41 (citing Ex. 1010 ¶¶ 91, 92, 98, 102; Ex. 1033 ¶ 181). Petitioner recapitulates that Racz’s probe (22/52) is configured to extend the full length of the cannula’s shaft (12/34) to supply RF energy to the tip (14/38) and measure tissue temperature. Pet. 42. According to Petitioner, by omitting Lee’s central filament and arranging the perimeter filaments, channels, and ramps around the inner perimeter of Racz’s cannula (10/33), a skilled artisan could have implemented Lee’s perimeter filaments (22/1622) without obstructing Racz’s cannula (10/33). Id. at 40. Petitioner contends that this modification would preserve the functionality of Racz’s electrical probe (22/52), which is needed to transmit RF energy. Id. (citing Ex. 1033 ¶ 181–182).” slip op. at 29
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 10,736,688 - PTAB · Feb 6, 2025 · IPR2024-01210 · APJ John G New · IPR · Institution
The Board instituted IPR on claims 1–17 and 48–52 on all asserted grounds, finding a reasonable likelihood that at least one claim was obvious over Racz, Fitz, and Lee.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“§ 314. An inter partes review may not be instituted unless “the information presented in the petition … and any response … shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Further, a decision to institute may not do so on fewer than all of the claims challenged in the petition. SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018); 37 C.F.R. § 42.108(a); see also PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018) (interpreting the statute to require “a simple yesor-no institution choice respecting a petition, embracing all challenges included in the petition”).” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“Absent evidence or argument to the contrary, we apply Petitioner’s proposed definition, as it appears to be consistent with the level of skill of the prior art and is supported by the presently unopposed testimony of Dr. Tucker. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the level of ordinary skill in the art may be reflected in the prior art itself). We note, however, that the open-ended language ‘at least’ expands the ranges of education and experience indefinitely with no upper bound, thereby also encompassing those of extraordinary skill as well. Therefore, we do not adopt this aspect of Petitioner’s formulation.” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“With respect to the challenged claims, Petitioner contends that no claim term requires express construction. Pet. 11 (citing Ex. 1032 ¶ 120 (Dr. Tucker’s testimony that “the terms in the Challenged Claims would be understood by a POSA to have their plain and ordinary meaning and do not require a special construction or definition”)). We agree with Petitioner that, on the record presently before us, no claim term requires express construction.” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“person of ordinary skill in the art would have been motivated to implement Lee’s perimeter deployable filaments (22/1622) on the distal tip (14/38) of Racz’s cannula (10/33) for the purpose of expanding and controlling the energy coverage area of Racz’s device. Pet. 35. Specifically, Petitioner asserts that a skilled artisan would have been motivated to implement Lee’s perimeter filaments (22/1622) around Racz’s tip (14/38) to provide a desired ablation volume (e.g., in a full or partial “cone” shape) and omit Lee’s central filament. Pet. 38 (citing Ex. 1032 ¶¶ 179, 73–75, 79–83). Petitioner contends that, as both Lee and Fitz confirm, this would improve Racz’s device by providing an expanded and controlled energy coverage area. Id. (citing Ex. 1011 ¶¶ 9–10, Abstr.; Ex. 1010 ¶¶ 12, 84, 123–131; Ex. 1032 ¶ 179). Petitioner argues further that, in implementing Lee’s perimeter filaments (22/1622) on Racz’s distal tip (14/38), a person of ordinary skill in the art would have found it obvious to modify Racz’s tip (14/38) to include internal deflection surfaces (12/1612) (e.g., channels and ramps as disclosed in Lee) to guide the perimeter filaments (22/1622) outwardly around Racz’s tip (14/38). Pet. 39 (citing Ex. 1010 ¶¶ 16, 18, 92, 102, claims 8, 10; Ex. 1032 ¶ 180). Petitioner asserts that it would have been obvious to provide openings in Racz’s distal tip (14/38) (e.g., in communication the internal deflection surfaces as disclosed in Lee) such that Lee’s perimeter filaments (22/1622) can, when deployed, exit Racz’s distal tip (14/38). Id. (citing Ex. 1010 ¶ 92, 102; Ex. 1032 ¶ 180).” slip op. at 29
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 10,736,688
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.