• Nintendo Co., Ltd. / Nintendo Of America Inc. v. American GNC CorporationAll claims unpatentable
  PTAB · Aug 20, 2025 · IPR2024-00667 · APJ Jennifer S Bisk · IPR · Final written decision

  Claims 1 and 3 are unpatentable under § 103 over Fujiyoshi, Kumar, Cox, and Townsend, and independently over Mitamura and Townsend.

  RulingsFinal written decision

  • PTAB / AIA Trials › Real party in interest / privityRpi dispute resolved for petitionerNot time barredDecided for petitioner

    “other things, it “identifies all real parties in interest.” 35 U.S.C. § 312(a)(2). “[T]he IPR petitioner bears the burden of persuasion to demonstrate that its petitions are not time-barred under § 315(b) based on a complaint served on a real party in interest more than a year earlier.” Worlds Inc. v. Bungie, Inc., 903 F.3d 1237, 1242 (Fed. Cir. 2018). However, “an IPR petitioner’s initial identification of the real parties in interest should be accepted unless and until disputed by a patent owner,” who, in turn, “must produce some evidence that tends to show that a particular third party should be named a real party in interest.” Id. at 1242, 1244 (footnote omitted). Whether a non-party is a real party in interest is a “highly fact-” slip op. at 11

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “would have possessed a bachelor’s degree in electrical engineering or similar degree, with two to three years of practical experience designing and/or implementing systems that include sensors for measuring movement, such as acceleration and rotational position. . . . A skilled artisan could also have had more formal education and less practical experience, or vice versa. Pet. 5 (citing Ex. 1002 ¶¶ 12–14). Patent Owner states that “[a] person of ordinary skill in the art with respect to the ’122 Patent would have at least a five years of relevant experience in the development of control systems for inertial navigation, MEMS semiconductor processing, and analog circuit design.” PO Resp. 18 (citing Ex. 2019 ¶ 57). We adopt Petitioner’s articulation of the level of ordinary skill in the art, which is consistent with our review and understanding of the technology and descriptions in the ’122 patent and prior art of record, and we apply it in our obviousness evaluations below. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). We note, however, that we would reach the same conclusions applying either Petitioner’s or Patent Owner’s definition of the level of skill in the art.” slip op. at 13

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” 37 C.F.R. § 42.100(b) (2019). In this context, claim terms “are generally given their ordinary and customary meaning” as understood by a person of ordinary skill in the art in question at the time of the invention. Phillips v. AWH Corp., 415 F.3d 1303, 1312–13 (Fed. Cir. 2005) (citations omitted) (en banc). “The Board is required to construe ‘only those terms ... that are in controversy, and only to the extent necessary to resolve the controversy.’” Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng'g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Neither party argues that any claim term requires construction. Pet. 6; PO Resp. 18. Accordingly, we do not explicitly construe any term.” slip op. at 14

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner

    “Record evidence supports Petitioner’s contentions that a skilled artisan would have had reason to look to Kumar for further implementation details of a circuit that performs functions like those performed by Fujiyoshi. See Pet 24–26. For example, Dr. Young testifies that a person of ordinary skill in the art would have recognized that Kumar discloses the details, at a granular level, of Fujiyoshi’s capacitive sensing systems and would have looked to Kumar for understanding of how to implement Fujiyoshi’s system. Ex. 1002 ¶ 145. Patent Owner does not point to persuasive evidence to rebut this opinion. Moreover, Petitioner cites to Kumar, not only for an explicit disclosure of capacitive pickoff signals, but also for its disclosure of both DC bias and AC carrier signals and recognizing the applicability of an AC carrier pickoffs that operates without DC bias. Pet. 24–26 (citing Ex. 1005 3:65–4:2, 6:29–36). We credit Dr. Young’s testimony on this issue and agree with Petitioner that a person of ordinary skill in the art, looking at Fujiyoshi’s description of capacitive sensing systems, would be motivated to look to Kumar for its more detailed teachings of the implementation details of such systems and would combine these details to arrive at limitation 1(a). We determine that Petitioner has shown, by a preponderance of the evidence, that one of ordinary skill in the art would have been motivated to combine Fujiyoshi and Kumar in the manner argued by Petitioner.” slip op. at 37

  Patent outcomesUS 6,508,122 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 6,508,122
• Lululemon USA Inc. v. Nike, Inc.All claims unpatentable
  PTAB · Aug 6, 2025 · IPR2024-00460 · APJ Ken B Barrett · IPR · Final written decision

  Claims 1–21 are unpatentable: claims 1–21 under Nishida grounds and claims 11 and 21 also over Nishida with Zuckerman; Zuckerman-only grounds fail for lack of a surrounding structure.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that: A hypothetical person of ordinary skill in the art (“POSA”) would have had at least a bachelor’s degree in textile engineering, mechanical engineering, or similar technical degree and at least 3 years of experience working with knitted textiles for use in fabric-based articles, including apparel such as footwear. Ex.1003, ¶¶34-37. For individuals with different educational backgrounds, a person could still be of ordinary skill in the art provided that person’s additional experience compensates for any differences in that person’s education as stated above. Id., ¶37. Pet. 14–15. Patent Owner states that, “[f]or purposes of this proceeding, Nike applies lululemon’s proposed level of skill in the art.” PO Resp. 13. Petitioner’s definition is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For purposes of this decision, we apply Petitioner’s definition of the person of ordinary skill in the art.” slip op. at 9

  • Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “Id. at 99:12–25. Dr. Brookstein stated during his deposition that he has “49 years of experience of teaching textile engineering.” Id. at 97:6–8. We credit Dr. Brookstein’s testimony over that of Dr. Pastore’s because it is consistent with the reference and based on decades of experience in the textile field. Nishida’s claim 1 states that, “during the production of the material web (1), [shoe patterns] . . . are produced by . . . a textile production method within the material web.” Ex. 1005, 9. We find that Nishida’s claim language discloses the recited, “simultaneously knitting a textile element with a surrounding textile structure.”” slip op. at 22

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “We find the District Court’s reasoning persuasive, and we, like the District Court, decline to adopt Petitioner’s overly broad proposed construction. However, for purposes of deciding the dispositive fact issue before us, we need not determine the precise boundaries of “surrounding textile structure,” for example whether it completely or mostly encircles the textile element, and if “mostly,” what percentage of encircling is required. See Pet. Reply 2 (Petitioner characterizing Patent Owner’s position as “mostly” means over 50%); id. at 4 (Petitioner impliedly arguing that the “surrounding” need not be complete, i.e., 100%); PO Sur-reply 3–4 (Patent Owner arguing that “Zuckerman’s textile structures . . . each abut only about 25% of the periphery of Zuckerman’s blank.”). We find that a person of ordinary skill in the art would not understand the portion of Zuckerman’s strip 13 in purple to surround the green blank 11 (textile element) under any reasonable construction of “surrounding textile structure.” Dr. Pastore testifies that “Zuckerman discloses two separate textile structures adjacent the blank—one on each side . . . they abut only two sides of Zuckerman’s blank, with each structure abutting only about a quarter of the blank’s periphery,” and opines that “a POSITA would not have understood these two separate structures, designated by purple in the figure above, to be a textile structure ‘surrounding’ the blank [shown in green].” Ex. 2003 ¶ 54. We find Dr. Pastore’s tesimony credible as it is consistent with Zuckerman’s Figure and with the plain and ordinary meaning of “surrounding” and with the Specification of the ’749 patent (particularly Figure 9). Dr. Brookstein’s testimony, on the other hand, is based on Petitioner’s overly broad proposed construction—that any part of a textile area that is not a textile element is “surrounding textile structure”—” slip op. at 44

  Patent outcomesUS 8,266,749 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,266,749
• Fox Factory, Inc. v. Sram, LLCAll claims unpatentable
  PTAB · Aug 4, 2025 · IPR2024-00492 · APJ Hyun J Jung · IPR · Final written decision

  Claims 1–3, 7, 8, and 10–12 are unpatentable over Yi, JP’279, and Nagai; the Board did not reach the Fox-based grounds.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “Based on the full record, we find that Patent Owner’s proposed level of ordinary skill in the art is consistent with the ’207 patent and the asserted prior art. PO Resp. 17 (citing Ex. 2016 ¶ 48). Our analysis below, however, would not change if we applied Petitioner’s proposed level of ordinary skill in the art, because it specifies experience in design work related to bicycle suspension technology, instead of the more general design of vehicle components or like technology.” slip op. at 9

  • Expert testimonyPetitioner expert creditedDecided for petitioner

    “Petitioner’s declarant has a Ph.D. in Mechanical Engineering with “over 30 years of experience in teaching and directing research related to mechanical engineering and precision machine design.” Ex. 1003 ¶ 4. Based on the full record, we find that his experience “related to mechanical engineering and precision machine design” sufficiently meets or exceeds “experience in design of vehicle components or like technology,” as proposed by Patent Owner (PO Resp. 17). Petitioner’s declarant would, thus, be a person of ordinary skill in the art under either party’s proposed level of ordinary skill in the art. Therefore, we see no reason to give less weight to the opinions of Petitioner’s declarant. See also Tr. 39:21–40:22 (confirming that the argument is about how much weight to give to the testimony).” slip op. at 10

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Petitioner states that “[n]o terms need construction to resolve the controversy in this forum.” Pet. 8 (citing Ex. 1003 ¶ 32). “Patent Owner agrees that the ’207 Patent’s claim terms require no special claim construction.” PO Resp. 16. Based on the full record, we determine that express claim interpretation is not necessary to resolve the parties’ dispute. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 11

  • Obviousness (§103) › Analogous artAnalogous artDecided for petitioner

    “d) Petitioner’s Asserted Reason for Combining Petitioner argues that Yi, JP’279, and Nagai are in the same technical field. Pet. 70 (citing Ex. 1006, code (57), 1:7–8; Ex. 1007, 1; Ex. 1008, 1:10–13). We agree, and find, that Yi, JP’279, and Nagai are in the same field of endeavor. Ex. 1006, code (57), 1:7–8; Ex. 1007, 1; Ex. 1008, 1:10– 13. Patent Owner does not dispute that the references are analogous art. See PO Resp.” slip op. at 22

  Patent outcomesUS 7,147,207 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 7,147,207
• Fox Factory, Inc. v. Sram, LLCAll claims unpatentable
  PTAB · Aug 4, 2025 · IPR2024-00491 · APJ Hyun J Jung · IPR · Final written decision

  Claims 1–4, 6, 8, 10, 12, 14–18, 20, 22, 24, 26–29, 31, 33–38, 40, 42, 44, 46–49, 51, 53, and 56–64 are unpatentable as obvious over Denk and Moechnig, with Schroeder for claims 31, 51, …

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “Both parties’ proposals require a Bachelor’s degree or a Master’s degree in Mechanical Engineering but differ on the number of years of experience (“1–2 years of experience” versus “three years’ experience”) and from where the experience comes (“design work related to optimal mechanical and structural design” or “design of mechanical elements and structures” versus “vehicle component design and like technology” or “design of vehicle components or like technology”). Pet. 8; PO Resp. 14. Based on the full record, we find that Patent Owner’s proposed level of ordinary skill in the art is consistent with the ’993 patent and the asserted prior art. PO Resp. 17 (citing Ex. 2016 ¶ 48). Our analysis below, however, would not change if we applied Petitioner’s proposed level of ordinary skill in the art, because it specifies experience in “optimal mechanical and structural design,” which would be a part of the “design of vehicle components and like technology.”” slip op. at 9

  • Expert testimonyPetitioner expert creditedDecided for petitioner

    “Petitioner’s declarant has a Ph.D. in Mechanical Engineering with “over 30 years of experience in teaching and directing research related to mechanical engineering and precision machine design.” Ex. 1003 ¶ 4. Based on the full record, we find that his experience “related to mechanical engineering and precision machine design” sufficiently meets or exceeds “experience in design of vehicle components or like technology,” as proposed by Patent Owner (PO Resp. 14). Petitioner’s declarant would, thus, be a person of ordinary skill in the art under either party’s proposed level of ordinary skill in the art. Therefore, we see no reason to give less weight to the opinions of Petitioner’s declarant. See also Tr. 39:21–40:22 (confirming that the argument is about how much weight to give to the testimony).” slip op. at 10

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction needed

    “Petitioner states that “[n]o terms need construction to resolve the controversy in this forum.” Pet. 9 (citing Ex. 1003 ¶ 30). We did not need to interpret expressly any claim term for institution. Inst. Dec. 14. “Patent Owner agrees that the ’993 Patent’s claim terms require no special claim construction for purposes of denying this Petition.” PO Resp. 13. Petitioner states that “a vertical plane of travel of the bicycle” and “a thickness of the wall at any point in the lower section of the body varying as a function of the cross-sectional angle of the point relative to the plane of travel” have been construed in related litigation. Pet. Reply 2–5 (citing Ex. 1001, 1:8–14, Fig. 1; Ex. 1024 ¶¶ 18, 20, 22, 24, 52–53; Ex. 1025, 8, 10; Ex. 2021 ¶ 43). Petitioner, however, contends that “the Board need not expressly construe these terms.” Id. at 2. Based on the full record, we determine that express claim interpretation is not necessary to determine whether Petitioner shows a reasonable likelihood of prevailing. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 11

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner

    “(c) Petitioner Shows a Motivation to Combine Because Petitioner cites a portion of Denk that states, “for the same overall strength and rigidity, the weight may be reduced, or for the same weight, the strength and rigidity may be significantly increased in the load direction specified by the design,” we find that Denk provides a motivation to use its tubular component in the bicycle of Moechnig. Pet. 13–14; Ex. 1006, col. 2. We also credit Petitioner’s testimonial evidence regarding the motivation to combine because the record supports it. Ex. 1003 ¶ 57; Ex. 1006, cols. 1–2; Ex. 1007, 1:10–14; Ex. 1008 ¶¶ 1, 9, 49; Ex. 1010, 6:22–26. The record shows that lightweight components were desirable. See, e.g., Ex. 1006, col. 1; Ex. 1008 ¶ 1. We also agree with Petitioner that one of ordinary skill in the art would have reduced weight or improved strength relative to Moechnig, because Denk describes reducing weight or increasing strength as “specified by the design,” indicating that it is a matter of ordinary skill in the art to achieve less weight or more strength when applying Denk to Moechnig. Ex. 1006, col. 2. how Denk combined with Moechnig would have reduced weight or increased strength, because Denk itself indicates it would have done so. PO Resp. 24–25; Ex. 1006, col. 2 (“for the same overall strength and rigidity, the weight may be reduced”). We also do not agree with Patent Owner that “Denk provides no indication that it would be more lightweight than a standard steerer tube with equal wall thickness and circular profile,” because Denk provides an indication. PO Resp. 25; Ex. 1006, col. 2. Based on the full record, Petitioner persuades us, and we determine, that one of ordinary skill in the art would have been motivated to combine Denk and Moechnig.” slip op. at 26

  Patent outcomesUS 10,328,993 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 10,328,993
• Tesla, Inc. v. Graphite Charging Company, LLCAll claims unpatentable
  PTAB · Jul 31, 2025 · IPR2024-00387 · APJ Ken B Barrett · IPR · Final written decision

  Claims 1–20 are unpatentable: claims 1, 4–8, 11–15, and 18–20 over Kimura; claims 2, 5, 9, 12, and 16 over Kimura and Hotta; claims 3, 10, and 17 over Kimura and King.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “We understand Petitioner’s phrase “experience working on software and/or hardware used to manage charging processes for electric vehicles” to encompass data processing systems similar to that proposed by Patent Owner, but with a slightly narrower area of application. We determine that Petitioner’s definition, as set out in the block quote above, is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For the purposes of this decision, we apply Petitioner’s definition, as block quoted above, of the person of ordinary skill in the art. We note, however, that were we to adopt Patent Owner’s assessment, the outcome of this Decision would be the same. Cf. Pet. Reply 15 (Petitioner asserting that “[Patent Owner] takes issue with the level of ordinary skill in the art . . ., but never argues that the level impacts how the Board should understand the arguments. Petitioner’s positions apply regardless.”).” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Lexicography (patentee as own lexicographer)Plain and ordinary meaningDecided for petitioner

    “We are not persuaded that the Specification evidences a clear intent by the patentees to redefine (either explicitly or by implication) or to otherwise narrow the scope of the claim terms “request” and “response,” as Patent Owner urges. The statements in the Specification upon which Patent Owner relies are referring to “Request 414” and “Response 418.” See PO Resp. 27 (quoting Ex. 1001, 12:3–4, 12:12–14). As indicated by the reference numbers, the Specification is discussing a specific request and a specific response in the context of Figure 4, which is described as depicting “an illustrative embodiment.” See Ex. 1001, 10:51–53 (“FIG. 4 is a system for managing a charging process of an electric vehicle in accordance with an illustrative embodiment.”), 12:1–19, Fig. 4. By stressing the illustrative nature of the embodiment of Figure 4, the patentees indicated an intent for it to not be limiting. See also Ex. 1001, 15:44–47 (the Specification stating: “The description of the present invention has been presented for purposes of illustration and description, but is not intended to be exhaustive or limited to the invention in the form disclosed.”); Hill-Rom Servs., Inc., 755 F.3d at 1373 (“[T]hose terms [including, datalink 39] are used synonymously only in describing a particular numbered component in the figure depicting the preferred embodiment, and never in describing the datalink of the invention generally.”). At oral argument, Patent Owner’s counsel, relying on the opinion of Dr. Cameron, argued that a person of ordinary skill in the art would “read the definition without the reference numbers.” Tr. 43:23–44:9. Thus, we understand Patent Owner to argue that the Specification provides an explicit definition when one reads out a portion of the Specification—converting, for example, “Request 414 is a message” to “Request is a message.” This is not persuasive as it involves editing the evidence to conform to Patent Owner’s argument, rather than an argument supported by the Specification as written by the patentees. Patent Owner does not direct us to any portion of the Specification that clearly defines “request” and “response” generally or, for example, uses phrasing implying that those terms are defined for “the present invention.” See, e.g., Hill-Rom Services, Inc., 755 F.3d at 1372 (“For example, we have held that disclaimer applies when the patentee makes statements such as “the present invention requires . . .’ or ‘the present invention is . . .’ or ‘all embodiments of the present invention are . . . .’”); Astrazeneca, 384 F.3d at 1339 (discussing defining by implication and determining that the “specification’s statement that ‘[t]he solubilizers suitable according to the invention are defined below’ provides a strong signal of lexicography.”).” slip op. at 17

  • Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageDisclaimer not foundDecided for petitioner

    “We fail to discern a clear disparagement of the use of signals in the Specification that would justify excluding signals from the scope of the claimed invention. The Specification does not mention in these excerpts the use of signals, and thus does not characterize “using signals as less ‘complete, flexible, and interoperable,’” as Patent Owner impliedly argues. PO Sur-reply 11. The Specification characterizes “the most rudimentary charging scenarios” as including situations such as a car owner merely plugging the electric vehicle into a common electric outlet at the owner’s house, and suggests that illustrative embodiments are an improvement in that they apply to “much broader and more complex sets of circumstances than this simple scenario.” See Ex. 1001, 6:60–7:2. An example of a “complex transaction[]” is the car owner using a charging station located away from the owner’s house and being required to pay for the charge. See id. at 7:2– 11. To the extent there is any disparagement, it is merely of the simple scenario of the owner plugging the car into the standard household outlet. Cf. Epistar Corp. v. Int’l Trade Comm’n, 566 F.3d 1321, 1336 (Fed. Cir. 2009) ([T]his court also recognizes that disparaging comments alone do not necessarily show a manifest or express disavowal of the criticized subject matter.”). Additionally, Patent Owner does not direct us to any portion of the Specification that indicates, for example, that the use of messages is a very important feature of the claimed invention and that alternatives (e.g., signals) are disparaged. See Hill-Rom Servs., Inc., 755 F.3d at 1372 (citing Inpro II Licensing, S.A.R.L., 450 F.3d at 1354–55); see id. at 1377 (holding that there is no disavowal or lexicography where “[t]here is no language that extolls the virtues of interfaces that both send and receive messages or language that disparages interfaces that only send messages.”).” slip op. at 20

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable

    “Sur-reply 15 (citing Ex. 1021, 161:5–21). Patent Owner overstates that testimony, which is that “[t]here’s actually disincentive for using messages all together.” Ex. 1021, 161:17–18. Regardless, even if correct, the existence of some disincentives does not necessarily negate a motivation to make the proposed combination. Medichem, S.A. v. Rolabo, S.L., 437 F.3d 1157, 1165 (Fed. Cir. 2006) (“[A] given course of action often has simultaneous advantages and disadvantages, and this does not necessarily obviate motivation to combine.”). We find that Petitioner’s assertion—that a person of ordinary skill in the art would be motivated by a desire to assure a safe and commercially-desirable system (Pet. 53)—to have rational underpinning. See In re Kahn, 441 F.3d 977, 988 (Fed. Cir. 2006). Patent Owner argues that Dr. Cameron “explained [that] . . . it would not be simple because Hotta uses two-stage charging subroutines.” PO Sur-reply 16 (citing Ex. 2005 ¶ 118). We disagree with Patent Owner’s characterization of Dr. Cameron’s testimony. The cited paragraph 118 states that Hotta’s figures depict “two-stage charging subroutines different from both the ’391 patent and Kimura,” and that there are “fundamental differences.” Ex. 2005 ¶ 118. Dr. Cameron does not go so far as to opine that combining the teachings as Petitioner’s proposes would not be considered simple by a person of ordinary skill in the art. See id.; see also Leapfrog Enters., Inc. v. Fisher-Price, Inc., 485 F.3d 1157, 1162 (Fed. Cir. 2007) (“Leapfrog presents no evidence that the inclusion of a reader in this type of device was uniquely challenging or difficult for one of ordinary skill in the art.”). Dr. MacCarley, on the other hand, credibly testifies that “making use of Hotta’s command keys in Kimura’s system . . . would have been a simple substitution of one known element (Kimura’s lightly- described main switch) for another known element (Hotta’s command keys) to achieve predictable results (a charging process that can be stopped by pressing Hotta’s charging stop command key . . .).” Ex. 1009 ¶ 147. We credit Dr. MacCarley’s testimony over that of Dr. Cameron’s because it is consistent with a sufficiently reasoned rationale of a simple substitution and is supported by the references.” slip op. at 48

  Patent outcomesUS 8,103,391 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,103,391
• Microchip Technology Inc. v. Aptiv Technologies AGAll claims unpatentable
  PTAB · Jul 30, 2025 · IPR2024-00230 · APJ John D Hamann · IPR · Final written decision

  Claim 1 is unpatentable as obvious over Chang and Chang II; the Board did not reach the Chang, Chang II, and Chutorash ground.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with Patent Owner and find that “computer network protocols” is correct in light of the ’072 patent’s disclosure and claim 1. In particular, the ’072 patent teaches that it “generally relates to [USB] connectivity between, for example, mobile consumer devices and vehicle electronic systems.” Ex. 1009, 1:21–23. And the ’072 patent’s teachings focus on common network components (e.g., hub, bridge, ports) and common networking concepts (e.g., master/slave network architecture and bridging) which are used in the USB context, rather than detailed aspects (e.g., signal timing, signal levels, power levels) of the USB protocol. See generally Ex. 1009; see also Ex. 1084, 103:21–104:2, 104:24–105:4; Pet. Reply 4 (citing Ex. 1084,7 100:17–101:12 (acknowledging that Dr. Houh testifies that one of ordinary skill in the art “would know basic USB concepts like bridging, master/slave architecture, etc.”), 102:3–8, 103:21– 104:2, 104:24–105:4). Likewise, claim 1 repeatedly recites “USB,” but does so to identify that all of the components of the data system (i.e., USB ports, USB hub, USB bridge, USB host, USB multiplexing switches) employ the USB protocol. Ex. 1009, 9:15–10:18. As the ’072 patent teaches, “USB 7 Houh Deposition Tr. (2024/12/18, Day 1). technology . . . [wa]s commonly available, familiar to the end user, cost effective and ubiquitous.” Id. at 1:35–37. Thus, although the ’072 patent is taught in the USB context, “computer network protocols” concepts are the focus. For these same reasons, we find unavailing Petitioner’s argument that one of ordinary skill in the art “would have been well-versed in USB standards (including the USB 2.0 and 3.0 Specifications and the OTG Supplement) and the design/deployment of USB hosts, USB devices, and USB hubs, including suitable environments for USB systems.” Pet. 26.” slip op. at 11

  • Expert testimonyPetitioner expert discountedOther

    “Lastly, we give little weight to Mr. Welch’s testimony regarding the level of one of ordinary skill as he does not indicate what precisely constitutes the basis of his testimony on this issue. See Ex. 1013 ¶ 47.” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Here, Petitioner argues that “embedded USB host” means “USB host physically embedded in a vehicle.” See Pet. 27–28. “Patent Owner does not contend that any claim construction is required.” PO Resp. 5. We agree with Patent Owner that we do not need to construe any term to resolve the disputes between the parties. See, e.g., Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’”). And we afford the claim terms their plain and ordinary meaning.” slip op. at 13

  • Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner

    “that the asserted objective evidence is tied to a specific product that ‘embodies the claimed features, and is coextensive with them.’” Id. (quoting Brown & Williamson Tobacco Corp. v. Philip Morris, Inc., 229 F.3d 1120, 1130 (Fed. Cir. 2000)). In other words, “[a] presumption of nexus requires both that the product embodies the invention and is coextensive with it.” Id. at 1211 (citing Brown, 229 F.3d at 1130). Patent Owner fails to show either of these requirements. First, Patent Owner argues that in his Supplemental Declaration, Dr. Houh “provides on a per limitation basis how [Patent Owner]’s dual role hub meets all limitations of claim 1.” PO Resp. 73 (citing Ex. 2019 ¶ 136). Notably, Patent Owner cites to a single paragraph in this declaration, without providing any specific arguments in its Response that its product practices claim 1. Id. Rather, Patent Owner incorporates its arguments by reference, which is not permitted. See 37 C.F.R. § 42.6(a)(3) (“Arguments must not be incorporated by reference from one document into another document.”). Thus, we do not consider these arguments, and we are not persuaded that Patent Owner’s product practices claim 1. Consolidated Trial Practice Guide November 2019,8 35–36 (citing Cisco Systems, Inc. v. C-Cation Techs., LLC, IPR2014-00454, Paper 12 (PTAB Aug. 29, 2014) (informative)) (“[P]arties that incorporate expert testimony by reference in their petitions . . . without providing explanation of such testimony risk having the testimony not considered by the Board.”).” slip op. at 16

  Patent outcomesUS 11,176,072 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · Graham
  Patents in suitUS 11,176,072
• Samsung Electronics Co. Ltd. / Google LLC et al. v. Headwater Research LLCAll claims unpatentable
  PTAB · Jul 23, 2025 · IPR2024-00341 · APJ Hyun J Jung · IPR · Final written decision

  Claims 1–17, 19, 21–27, 29, and 30 are unpatentable as obvious over TS-23.140 and Ogawa.

  RulingsFinal written decision

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “Based on the full record, we find that Patent Owner’s proposed level of ordinary skill in the art is consistent with the ’733 patent and the asserted prior art. PO Resp. 5 (citing Ex. 2001 ¶¶ 29–31). We agree with Petitioner that Patent Owner’s proposal is encompassed by Petitioner’s proposed level of ordinary skill in the art. Pet. Reply 4. Our analysis below would not change, if we used Petitioner’s proposal.” slip op. at 8

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “Based on the full record, we do not need to interpret expressly any claim term. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableMotivation foundUnpatentable
  • Obviousness (§103) › Objective indicia / secondary considerationsNot reached

    “o) Objective Indicia of Non-obviousness Patent Owner does not present any arguments or evidence regarding any objective indicia of nonobviousness for any of the challenged claims. See PO Resp.” slip op. at 49

  Patent outcomesUS 8,406,733 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,406,733
• Neurent Medical Inc. / Neurent Medical Ltd. v. The Foundry, LLCAll claims unpatentable
  PTAB · Jul 21, 2025 · IPR2024-00280 · APJ Sheridan K Snedden · IPR · Final written decision

  Claims 1, 2, 5, 8–10, 12, and 14 are unpatentable as obvious over Makower, Fang, and Edwards; the Board did not reach Grounds 1–3.

  RulingsFinal written decision

  • Skill levelSkill level board ownOther

    “Based on the record before us, including the types of problems and solutions described in the ’011 patent and the cited prior art, we find a POSA would have had (1) a Doctor of Medicine (M.D.) or at least a bachelor of science degree in biomedical engineering or a related discipline, (2) at least three years of experience in the clinical use, design, development, and/or testing of medical devices that deliver energy to tissue, and 3) knowledge and experience in treating nasal conditions, or access to a person with that knowledge and experience. Less work experience may be compensated by a higher level of education, and vice versa.” slip op. at 12

  • Expert testimonyPetitioner expert creditedDecided for petitioner

    “We do not agree with Patent Owner that prior experience designing or developing nasal medical devices is required for a POSA. PO Resp. 19–20. A definition inclusive of the clinical use, design, development, and/or testing of nasal medical devices that deliver energy to tissue is consistent with the skill level reflected in the disclosures of the ’011 patent and prior art. Consequently, we disagree with Patent Owner that Dr. Bu-Saba fails to qualify as a POSA because he lacks experience specific to designing medical devices. PO Resp. 19 n.4. Accordingly, we do not agree with Patent Owner that we should discount the testimony of Dr. Bu-Saba and we give Dr. Bu-Saba’s testimony appropriate weight in reaching our conclusions here.” slip op. at 13

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “On the record before us, we conclude that the claims need not be expressly construed to resolve the dispute before us. Insofar as the parties dispute the mapping of the prior art to dependent claim 9, we address that dispute below including, to the extent necessary, any implicit disagreement about the subject matter encompassed by claim 9.” slip op. at 14

  • Obviousness (§103) › Analogous artAnalogous artDecided for petitioner

    “Petitioner contends that Makower and Fang7 are analogous art to the challenged claims. Pet. 77 (arguing Makower and Fang “are in the same field” and are “reasonably pertinent” to solving problems addressed by the claimed invention); Ex. 1002 ¶ 178. According to Petitioner, Makower and 7 Petitioner argues a POSA had reasons for combining Edwards with Makower and Fang with a reasonable expectation of success (see, e.g., Pet. 74–76, 81–85). We find persuasive Petitioner’s reasoning and evidence on the addition of Edwards, and Patent Owner provides no rebuttal about Edwards. energy to tissue and “each uses RF energy to treat tissue.” Pet. 77 (citing, e.g., Ex. 1005 ¶¶ 1, 43, 132, 164, 187; Ex. 1006, 876–877).” slip op. at 25

  Patent outcomesUS 10,894,011 unpatentable
  Claim construction§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 10,894,011
• Interactive Communications International, Inc. v. Blackhawk Network Inc.All claims unpatentable
  PTAB · Jul 14, 2025 · IPR2024-00465 · APJ Bart A Gerstenblith · IPR · Final written decision

  Claims 1–24 are unpatentable: claims 1–10 and 12–24 as obvious over Szrek and Llach, and claim 11 as obvious over Szrek, Llach, and Gilmore.

  RulingsFinal written decision

  • Skill levelSkill level board ownDecided for petitioner

    “B. Level of Ordinary Skill in the Art Petitioner proposes that the level of ordinary skill in the art is an artisan with a working knowledge of POS activation systems and lottery systems that was gained through a mixture of training and work experience in the relevant field such as (i) having a Bachelor’s degree in computer science, computer communications, electrical engineering, or equivalent degree, coupled with at least three years of work experience; (ii) having a Master’s degree in computer science, computer communications, or electrical engineering, but having less work experience; or (iii) having no formal degree, but having experience in the relevant field of at least six years of work experience. Pet. 2–3 (citing Ex. 1003 ¶¶ 13–14).9 Patent Owner states that, “[f]or the purpose of this proceeding, Patent Owner adopts the Petition’s proposed definition of the level of ordinary skill in the art.” PO Resp. 19 (citing Pet. 2–3). We find that the parties’ agreed-upon level of ordinary skill in the art is consistent with the level of ordinary skill in the art reflected by the ’451 patent and the prior art of record. See Inst. Dec. 14; see Okajima v. 9 Petitioner proposes the same level of ordinary skill in the art that the Board adopted in PGR2020-00084 (Pet. 2–3 (citing Ex. 1008, 11)), and IPR2023- 01235 (see IPR2023-01235, Paper 34 at 12–13). Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978). Therefore, we adopt the parties’ agreed-upon level of ordinary skill in the art, as articulated above, in our consideration of the issues presently before us.” slip op. at 13

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “We need not construe “transaction processor” expressly because its meaning is not in dispute and its construction is not necessary to resolve the controversy before us.” slip op. at 16

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner

    “On balance, we find that even with the alleged disadvantages identified by Patent Owner, one of ordinary skill in the art would have been motivated to modify Szrek with Llach’s third-party transaction processor because the advantage of having a “centralized intermediary” allows Szrek’s system to support different game providers, such as different lottery companies, which would reduce some implementation costs and allow the system to be more easily and cheaply extended. Pet. 47 (citing Ex. 1003 ¶ 181); see Medichem, S.A. v. Rolabo, S.L., 437 F.3d 1157, 1165 (Fed. Cir. 2006) (“a given course of action often has simultaneous advantages and disadvantages, and this does not necessarily obviate motivation to combine”) (citing Winner Int’l Royalty Corp. v. Wang, 202 F.3d 1340, 1349 n.8 (Fed. Cir. 2000)); see also Intel Corp. v. Qualcomm Inc., 21 F.4th 784, 795 (Fed. Cir. 2021) (stating the same). We acknowledge that the combination comes with some disadvantages, including “add[ed] delay, reduce[d] efficiency, and . . . implementation complexities by converting a simple, direct communication exchange into an exchange that traverses multiple systems.” PO Resp. 52 (citing Ex. 2052 ¶ 163). But, “[t]he fact that the motivating benefit comes at the expense of another benefit, however, should not nullify its use as a basis to modify the disclosure of one reference with the teachings of another. Instead, the benefits, both lost and gained, should be weighed against one another.” Winner, 202 F.3d at 1349 n.8. Here, Szrek expressly teaches indirect communication as a possible implementation of its system and Petitioner’s combination—employing Llach’s third-party transaction processor as part of the indirect communication channel—offers the attractive benefit of allowing Szrek’s system to support different game providers, which would reduce some implementation costs even if it might increase other costs, e.g., by having to program certain components (e.g., the cash registers) differently. Specifically, we find that the ability to expand Szrek’s system to support different game providers provides advantages that outweigh the disadvantages discussed above in the circumstance where one desires a more robust and comprehensive system. See Pet. Reply 23 (noting three advantages of the combination— (1) “allow[ing] Szrek’s system to use ‘a centralized system for activating lottery tickets from different retailers and different locations,’” (2) “allow[ing] support for different game providers, such as different lottery companies,” “reduc[ing] implementation costs,” and (3) “allow[ing] Szrek’s system to ‘communicate with individual card” slip op. at 37

  • Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightMotivation foundDecided for petitioner

    “On balance, we find that even with the alleged disadvantages identified by Patent Owner, one of ordinary skill in the art would have been motivated to modify Szrek with Llach’s third-party transaction processor because the advantage of having a “centralized intermediary” allows Szrek’s system to support different game providers, such as different lottery companies, which would reduce some implementation costs and allow the system to be more easily and cheaply extended. Pet. 47 (citing Ex. 1003 ¶ 181); see Medichem, S.A. v. Rolabo, S.L., 437 F.3d 1157, 1165 (Fed. Cir. 2006) (“a given course of action often has simultaneous advantages and disadvantages, and this does not necessarily obviate motivation to combine”) (citing Winner Int’l Royalty Corp. v. Wang, 202 F.3d 1340, 1349 n.8 (Fed. Cir. 2000)); see also Intel Corp. v. Qualcomm Inc., 21 F.4th 784, 795 (Fed. Cir. 2021) (stating the same). We acknowledge that the combination comes with some disadvantages, including “add[ed] delay, reduce[d] efficiency, and . . . implementation complexities by converting a simple, direct communication exchange into an exchange that traverses multiple systems.” PO Resp. 52 (citing Ex. 2052 ¶ 163). But, “[t]he fact that the motivating benefit comes at the expense of another benefit, however, should not nullify its use as a basis to modify the disclosure of one reference with the teachings of another. Instead, the benefits, both lost and gained, should be weighed against one another.” Winner, 202 F.3d at 1349 n.8. Here, Szrek expressly teaches indirect communication as a possible implementation of its system and Petitioner’s combination—employing Llach’s third-party transaction processor as part of the indirect communication channel—offers the attractive benefit of allowing Szrek’s system to support different game providers, which would reduce some implementation costs even if it might increase other costs, e.g., by having to program certain components (e.g., the cash registers) differently. Specifically, we find that the ability to expand Szrek’s system to support different game providers provides advantages that outweigh the disadvantages discussed above in the circumstance where one desires a more robust and comprehensive system. See Pet. Reply 23 (noting three advantages of the combination— (1) “allow[ing] Szrek’s system to use ‘a centralized system for activating lottery tickets from different retailers and different locations,’” (2) “allow[ing] support for different game providers, such as different lottery companies,” “reduc[ing] implementation costs,” and (3) “allow[ing] Szrek’s system to ‘communicate with individual card” slip op. at 37

  Patent outcomesUS 11,488,451 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,488,451
• Apple Inc. v. THL Holding Company, LLCAll claims unpatentable
  PTAB · Jul 3, 2025 · IPR2024-00399 · APJ Christopher M Kaiser · IPR · Final written decision

  Claims 11–19 are unpatentable as obvious: claims 11–14 over Kalliola, Turunen, Oswald, Vauclair, and Kalayjian; claims 15–18 with Thorn; and claim 19 with Thorn and Sharp.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner asserts that the level of ordinary skill in the art corresponds to “a bachelor’s degree in computer science, computer engineering, electrical engineering, or a similar technical field and 2-4 years of experience with wireless ranging and positioning systems, wireless communication devices, and associated computer programming.” Pet. 4 (citing Ex. 1003 ¶ 35). “Patent Owner agrees that this description reasonably represents the level of ordinary skill required to understand and implement the teachings of the ’246 Patent, as well as the prior art cited in the Petition.” PO Resp. 14 (citing Ex. 2002 ¶ 22). Accordingly, we adopt Petitioner’s proposed level of skill.” slip op. at 8

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “device.” This term appears twice in claim 11, once in the phrase “an orientation sensor to detect rotation of the mobile communication device,” and once in the phrase “rotation of the mobile communication device detected by the orientation sensor.” Ex. 1001, 39:13–14, 39:36–38. Patent Owner argues that we should construe this term as limited to “detecting the rotation of the mobile communication device as a whole, not the movement of individual components.” PO Resp. 15–18. Petitioner disputes this, arguing that “rotation of the mobile communication device” should be construed not only to cover rotation of the device as a whole but also should “encompass[] any rotation of the mobile communication device relative to any object, including itself,” which would extend to rotation of “any component of the device.” Reply 4–5. We need not resolve this dispute to determine the outcome of Petitioner’s asserted challenges to the ’246 patent. As discussed more fully below, under either party’s proposed construction of “rotation of the mobile communication device,” Petitioner has shown by a preponderance of the evidence that the challenged claims are unpatentable. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (noting that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 9

  • Expert testimonyOther

    “On the record developed during trial, we are persuaded that Petitioner has shown by a preponderance of the evidence that Kalliola teaches “an orientation sensor to detect rotation of the mobile communication device,” where “rotation of the mobile communication device” includes rotation of the device as a whole, regardless of whether it also includes rotation of one portion of the device relative to another. Kalliola teaches “motion sensors integrated in WCD 100” that are “used to detect when WCD 100 is being moved,” as well as to detect “when user 110 moves WCD 100 too quickly for an accurate DoA estimation.” Ex. 1004 ¶¶ 84, 86. Although Patent Owner argues that Kalliola’s motion sensors do not detect rotation of the device, this is incorrect on the record as developed at trial. Kalliola teaches that the motion sensor may take “the form of a semiconductor gyroscope chip.” Id. ¶ 84. There is ample evidence that gyroscopes detect rotation. Ex. 1013, 38 (identifying as an “orientation sensor” a “[t]hree-axis gyro” and a “[d]ynamic [h]igh [r]ange [gyro]”); Ex. 1046, 49:18–20 (Dr. Feuerstein testifying that gyroscopes “can be used to detect angular velocity”); Ex. 1047 ¶ 47 (citing Ex. 1051, 170; Ex. 1053, 9) (Dr. Buehrer testifying that a person of ordinary skill in the art “would understand that gyroscopes are well-known inertial sensors that specifically detect rotational motion”). Thus, by a preponderance of the evidence, Petitioner has shown that Kalliola teaches the “orientation sensor to detect rotation of the mobile communication device” of this limitation.” slip op. at 17

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable

    “whether Kalliola’s teaching of pausing and resuming its DoA estimation based on detected rotational motion, or Kalliola’s teaching of speeding up its DoA estimation based on detected rotational motion, amounts to determining direction based on rotation. Pet. 63–64; PO Resp. 25–27; Reply 24–27; Sur-Reply 11–14. On the record developed during trial, we are persuaded that the preponderance of the evidence supports a finding that Kalliola teaches determining direction based on rotation. First, Kalliola discloses “pausing a DoA estimation until the motion of the WCD is detected by the motion sensors,” then resuming “the updating of the DoA estimation” when motion is detected. Ex. 1004 ¶¶ 14, 84. Second, Kalliola discloses a “correction or compensation mode” that is “employed when user 110 moves WCD 100 too quickly for an accurate DoA estimation,” with this “increase[d] speed of the DoA estimation” being triggered by the “[i]ncreased activity detected by motion sensors in WCD 100.” Id. ¶ 86. As discussed above with respect to limitation 11(d), the detected motion that triggers either of these modes can be rotational motion of the WCD detected by a gyroscope.” slip op. at 22

  Patent outcomesUS 11,350,246 unpatentable
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,350,246

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.