- Apple Inc. v. Geoscope Technologies Pte. Ltd.All claims unpatentablePTAB · May 7, 2025 · IPR2024-00032 · APJ Brian D Range · IPR · Final written decision
Claims 2–5, 9, 11, 12, 14–16, 18–22, 27, 29, 31, and 32 are unpatentable over the asserted anticipation and obviousness grounds; claims 1, 25, and 35 were disclaimed.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“The ’494 patent is directed to locating a wireless mobile device in a geographic region. Ex. 1001, 1:20–27; PO Resp. 45. Bhattacharya is directed to estimating the geographic location of a wireless terminal. Ex. 1005, code (57), ¶¶ 1, 13; PO Resp. 44–45. Spain is directed to a method for locating the concentration of mobile radio traffic in a coverage area. Ex. 1006, code (54), ¶¶ 1, 11; PO Resp. 45. We find that there is support in the ’494 patent and prior art consistent with Patent Owner’s assertion that the qualifications of a person of skill would include knowledge of radio navigation and mobile communications technology. Accordingly, we adopt Patent Owner’s proposed qualifications for a person of ordinary skill.” slip op. at 9
- BurdenDecided for petitioner
“Patent Owner, however, has not identified any language in the Petition that explicitly incorporates by reference Dr. Sundaresan’s testimony. See generally PO Resp.; PO Sur-Reply. Nevertheless, to the extent that the Petition purportedly incorporates by reference Dr. Sundaresan’s testimony, we do not find such incorporation sufficiently extensive to merit disregarding the testimony. Typically, an incorporation by reference is deemed improper in instances in which large portions of a declaration are incorporated—particularly where the incorporation serves to circumvent a word-count limit. See, e.g., Cisco Systems, Inc. v. C-Cation Techs., LLC, IPR2014-00454, Paper 12 at 10 (PTAB Aug. 29, 2014) (informative). In this case, however, Dr. Sundaresan’s testimony describing the level of ordinary skill in the art is short. Ex. 1003 ¶ 8. The amount of testimony is not extensive and, thus, its purported incorporation into the Petition presents little or no imposition on Patent Owner or the Board.” slip op. at 12
- Expert testimonyPetitioner expert creditedDecided for petitioner
“In reply, Petitioner argues that “under any reasonable read of the Sundaresan Declaration, Dr. Sundaresan implied agreement with the POSITA definition based on its inclusion in a signed declaration.” Pet. Reply 15. We agree with Petitioner. Although Dr. Sundaresan does not state explicitly that the proposed definition of the ordinary skill in the art is his opinion, we are persuaded that the manner in which the definition is set forth in his declaration indicates that he agrees with the definition. Patent Owner attempts to make much of Dr. Sundaresan’s statement that he had been informed of the qualifications of a person of ordinary skill in the art. See PO Resp. 41–43. Dr. Sundaresan’s testimony, however, set forth this understanding of the requisite level of skill in the art (Ex. 1003 9 Dr. Sundaresan has a doctoral degree in electrical and computer engineering and has extensive experience in wireless communications. Ex. 1003 ¶¶ 75–78. Dr. Sundaresan also has experience with navigation and geolocation systems such as development of wireless tracking systems, as evidenced by his experience in companies such as NavigateIO Inc. Id. at ¶¶ 77–78. Patent Owner does not argue that Dr. Sundaresan fails to meet requirements for the level of qualifications of one of ordinary skill in the art under its proposed qualifications, which we adopt here. See generally PO Resp.; PO Sur-reply. Based on a review of his qualifications, we determine that Dr. Sundaresan qualifies as a person of ordinary skill at the time of the invention. ¶ 8). In his supplemental declaration, Dr. Sundaresan testifies: I agreed with this POSITA definition when preparing the Declaration, and I continue to hold the opinion that the POSITA definition is both correct and appropriate based on the disclosures of the ’358 patent and the prior art analyzed in the Declaration. Ex. 1055 ¶ 17. Dr. Sundaresan further testifies that “[i]f I did not agree with the POSITA definition, then it would not have been included [] in paragraph 8 of the Declaration.” Id. ¶ 18. Dr. Sundaresan’s inclusion of the definition of the level of ordinary skill in his original declaration indicates that he agrees with the definition, as confirmed by his cited subsequent testimony. We note that, even with Patent Owner’s arguments, the record is clear that Patent Owner was on notice of Petitioner’s proposed definition of the level of ordinary skill at the time of the Petition. Pet. 6; cf. Corephotonics, Ltd. v. Apple Inc., 84 F.4th 990, 1006 (Fed. Cir. 2023) (holding that Petitioner is not required to anticipate all arguments in its Petition and allowing consideration of reply where patent owner had sufficient notice of petitioner’s position and adequate opportunity to respond).” slip op. at 13
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“explained below, we agree with Petitioner that Patent Owner’s additional requirement of evaluating the calibration data to determine the boundaries of the area represented by a grid point should not be included in the construction of either “grid point” or “non-uniform grid point.” Instead, based on the full record, we discern no reason to alter our prior construction of “grid point” as “a point associated with representative calibration data for an area” and maintain that construction for this Final Written Decision.” slip op. at 27
Patent outcomesUS 8,786,494 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,786,494 - PTAB · Apr 21, 2025 · IPR2024-01447 · APJ Sheila F Mcshane · IPR · Institution
The Board instituted IPR on claims 1–4, finding a reasonable likelihood that claims 1–4 are obvious over at least Bowen and Sunai.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Upon consideration of the Petition, the Preliminary Response, and the evidence of record, we determine that Petitioner has established a reasonable likelihood of prevailing with respect to the unpatentability of at least one claim of the ’134 patent. Accordingly, for the reasons that follow, we institute an inter partes review of claims 1–4 of the ’134 patent.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“In determining the level of ordinary skill in the art, various factors may be considered, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) 5 Nagahama, EP 1391942 A1, published February 25, 2004 (Ex. 1027, “Nagahama”). (citation omitted). The level of ordinary skill in the art is also reflected by the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). For purposes of this Decision, we adopt the assessment offered by Petitioner as it is consistent with the ’134 patent and the asserted prior art.” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“We determine that we need not expressly construe any claim terms to resolve the parties’ disputes on the current record. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“combination of Bowen and Sunai teaches limitation 1[e]. Petitioner asserts, as an initial matter, that a person of ordinary skill would have been motivated to combine Bowen with Sunai because “CoFeB was known to increase TMR compared to CoFe.” Pet. 35. Dr. Bokor provides supporting testimony relying, in part, on reported research publications. Ex. 1024 ¶ 135. For instance, Dr. Bokor refers to Cardoso, which reports that the use of CoFeB-based junctures had improved TMRs compared to CoFe-based junctions. See Ex. 1061, Abstract (“CoFe-based junctions (R x A ~ 500 Ω.μm2) have lower TMR (~35%) and larger Hf (~5–6 Oe) and Hc (~12–14 Oe) [compared to CoFeB-based junctions].”). Wang also discloses that the use of CoFeB offered benefits including “a higher TMR value.” Ex. 1055, 2269–70. Additionally, Hosomi discloses that when a “ferromagnetic layer” is “comprised of a CoFeB alloy,” it “exhibits a larger TMR ratio.” Ex. 1056 ¶ 39. At this juncture, because of this evidentiary support, we find persuasive Dr. Bokor’s testimony that one of ordinary skill in the art would have been motivated to use an CoFeB alloy as disclosed in Sunai in Bowen. Patent Owner argues the motivation to combine Sunai and Bowen is flawed because Sunai, Wang, and Hosomi disclose the use of amorphous CoFeB only and not CoFeB in a crystalline form. See Prelim. Resp. 25–26, 28–29. While Sunai, Wang, and Hosomi disclose the use of amorphous CoFeB, Petitioner relies on these references to only provide support that one of ordinary skill in the art would be motivated to use a CoFeB alloy because of enhanced TMR performance due to the alloy. See Pet. 35–37; Ex. 1024 ¶¶ 135–137. We find that, on this preliminary record, the evidence provides sufficient support for Petitioner’s assertion that one of ordinary skill in the art would have been motivated to use CoFeB as taught in Sunai in Bowen because Sunai, Wang, and Hosomi, as well as Cardoso, provide support that the use of CoFeB improved electrode performance. Petitioner separately asserts that it would have been obvious to one of ordinary skill in the art to then crystallize the CoFeB electrode of the combination, which we discuss in more detail below.” slip op. at 19
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,405,134 - PTAB · Apr 10, 2025 · IPR2024-01431 · APJ Brian D Range · IPR · Institution
The Board instituted review of claims 2–6, 28, and 33–37 based on all petition grounds, finding a reasonable likelihood that Haddad138 renders claims 2–6 and 33–37 obvious and Yap anticipates or renders claim 28 obvious.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“arguments, and evidence presented in the parallel proceeding.” Fintiv at 12 (emphasis added). Here, due to Petitioner’s stipulation, the record does not 9 To the extent Patent Owner’s argument emphasizes that the parties have completed substantial work regarding references asserted in the petition here (PO Fintiv Surreply 1–3), this argument addresses to Fintiv factor three rather than factor four. support that the Petition’s invalidity grounds have been or will be presented to the ITC for consideration on the merits. The record also does not support that the ITC will ever adjudicate the invalidity grounds raised here10 and does not support that the ITC will ever address the dependent claims at issue here. This is, therefore, not a situation where the ITC Investigation will “resolve key issues in the petition.” Fintiv at 13. Thus, this factor weighs against discretionary denial. 7. Fintiv Factor Five: Overlapping Parties Petitioner is the same party as the respondent in the ITC investigation,” slip op. at 15
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The following findings of fact and conclusions of law are not final, but are made for the sole purpose 1 Petitioner calls “IPR2024-01431 (‘Petition B’).” See Paper 3 (PETITIONER’S EXPLANATION OF PARALLEL PETITIONS CHALLENGING U.S. PATENT NO. 11,069,737), 1. of determining whether Petitioner meets the threshold for instituting review. Any final decision shall be based on the full trial record, including any response timely filed by Patent Owner. Any arguments not raised by Patent Owner in a timely filed response may be forfeited. For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We hereby institute an inter partes review as to claims 2–6, 28, and 33–37 of the ’737 patent based upon Petitioner’s asserted challenges to patentability.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“Patent Owner argues11 that Petitioner “offers no motivation to modify Haddad138.” Prelim. Resp. 7–8. Patent Owner specifically argues that 11 Patent Owner also argues that Petitioner does not establish that Haddad138 anticipates claim 2. Prelim. Resp. 5–7. We do not address the anticipation challenge at this time. “Petitioner does not offer any showing on any motivation to modify Figure 9 of Haddad138 to change the configuration from a FSI to BSI architecture.” Id. at 8. On this record, Patent Owner’s argument does not undermine Petitioner’s persuasive showing. As Petitioner argues (Pet. 29), Haddad138 teaches that its “present disclosure” (which would include the Figure 9 disclosure) can be adapted for a front side illumination (FSI) or back side illumination (BSI) configuration. Ex. 1012 ¶ 48. The express teaching of Haddad138 provides motivation to modify Figure 9 of Haddad138. Patent Owner also argues that Petitioner “offers no showing that a POSITA would be able to modify the embodiment of Figure 9 to be back side illuminated with a reasonable expectation of success.” Prelim. Resp. 9. Patent Owner’s argument again does not undermine Petitioner’s persuasive showing. Petitioner cites Haddad138 expressly teaching a FSI or BSI configuration. Pet. 29 (citing Ex. 1012 ¶ 48). Haddad138’s teaching is sufficient, on this record, to establish a reasonable likelihood of Petitioner establishing a reasonable expectation of success at trial. Conclusion as to claim 2” slip op. at 23
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner asserts that a person of ordinary skill in the art (POSITA) would have had a Bachelor’s degree in engineering, physics, or a related or equivalent field, and two or more years of experience researching, developing, designing, and/or evaluating image sensors using photonics. Ex-1004 ¶50. A person with less or different education but more relevant practical experience, or vice versa, may also meet this standard. Ex-1004 ¶50. Pet. 9. Patent Owner does not dispute the level of ordinary skill in the art at this time. For purposes of this Decision, we adopt Petitioner’s proposal as reasonable and consistent with the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art may reflect an appropriate level of skill in the art).” slip op. at 8
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,069,737 - Sterlite Technologies Inc. v. Afl Telecommunications, LLC.Institution deniedPTAB · Apr 9, 2025 · IPR2025-00127 · APJ Josiah C Cocks · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–4, 8, or 13 were unpatentable over either proposed obviousness ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“At this preliminary stage, we determine whether the information presented shows a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been unpatentable over the proposed prior art. We analyze the asserted grounds with the above-noted principles in mind.” slip op. at 10
- Skill levelOther
“B. Level of Ordinary Skill in the Art As noted above, resolving the question of obviousness requires determination of the level of ordinary skill in the art. Graham, 383 U.S. at 17–18. Here, however, as Patent Owner observes (Prelim. Resp. 10), 8 Patent Owner does not present arguments or evidence of secondary considerations in its Preliminary Response. Therefore, secondary considerations do not constitute part of our analysis herein. Petitioner has provided no assessment as to the level of ordinary skill to be considered in evaluating the grounds of obviousness that are advanced by Petitioner. The absence of such assessment calls into question the fundamental adequacy of Petitioner in carrying its burden to show a reasonable likelihood of success of unpatentability of the challenged claims that necessarily must take into account the level of ordinary skill in the art.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“In any event, we do not discern that there is any apparent dispute between the parties as to the meaning of any claim term. In considering the record at hand, we determine that it is unnecessary to make explicit, or further address, any claim term in deciding whether or not to institute trial. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the 9 Throughout their briefings, the parties refer to the limitations designated [1.1] through [1.7] using the term “element,” e.g., “element [1.7]” (see, e.g., Pet. 23; Prelim. Resp. 23). For consistency with the parties’ chosen nomenclature, we do the same in this Decision. controversy (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundReasonable expectation not foundNot shown unpatentable
“A POSITA would have been motivated to modify Summers’ fiber optic cable 50 to include Kaji’s intermittently-fixed optical fiber tape 2A to obtain the predictable result of enabling a higher density of optical fibers to be packed in Summers’ fiber optic cable 50, as contemplated by Kaji. *** a POSITA would have had a reasonable expectation of success because such modification would amount to nothing more than a simple substitution of Summers’ four-fiber ribbons 52 with Kaji’s intermittently-fixed optical fiber tape 2A by known methods of cable manufacturing. ***” slip op. at 20
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,287,591 - Uatp IP LLC v. Slick Slide LLCInstitutedPTAB · Apr 8, 2025 · PGR2024-00054 · APJ Julia Heaney · PGR · Institution
The Board instituted PGR on claims 1–17 and 22–28 and all asserted grounds, finding a sufficient likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of a post-grant review is authorized by statute when “the information presented in the petition . . . would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a) (2018). Upon consideration of the parties’ submissions and the evidence of record, we determine that Petitioner has demonstrated that it is more likely than not that at least one claim challenged in the Petition is unpatentable. Further, Patent Owner has not persuaded us that it is appropriate to exercise our discretion not to institute review. Accordingly, we institute a post-grant review of all claims and all grounds asserted in the Petition.1” slip op. at 2
- Skill levelSkill level patent owner adoptedOther
“On this record, we do not find Patent Owner’s proposed experience level of at least five years in measurement and analysis of coefficient of friction to be supported. As to the necessity of experience in textile engineering and fiber science, Patent Owner’s position, although not supported by declarant analysis of the factors listed above, is consistent with the disclosure of the ’854 patent, which describes features of a mesh layer in textile and fiber terms. See e.g., Ex. 1001, 10:17–11:14, 12:65–13:8, 14:20–24. On the whole, however, we do not discern on this record how specific experience in textile engineering and fiber science of a person of ordinary skill would materially alter the outcome at this stage of the proceeding. For purposes of this decision only, we apply Patent Owner’s proposed definition of a person of ordinary skill in the art, except for the requirement of five years of experience in measurement and analysis of coefficient of friction. The level of skill in the art remains an open issue in this proceeding. Further submissions by the parties may include argument and evidence that would assist in the resolution of this issue at the close of trial.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner contends “no formal claim construction is necessary in this proceeding.” Pet. 10; Reply 1, 4. Patent Owner contends the terms “mesh layer” and “coefficient of friction” require construction. Prelim. Resp. 14–16; Sur-reply 2–5. We have considered the parties’ arguments and discuss them below with regard to each of the terms Patent Owner contends should be construed. Because our determination that Petitioner demonstrates at least one challenged claim meets the threshold for institution (see SAS Inst., 138 S. Ct. at 1359–60) is not based on construing the term “mesh layer” or “coefficient of friction,” we determine we need not construe either claim term at this stage of the proceeding. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)). As further discussed below, we invite the parties to address claim construction at trial.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageDisclaimer not foundDecided for petitioner
“We agree with Petitioner that the ’854 patent specification does not include clear and explicit lexicography or a disclaimer that would support requiring “coefficient of friction” to be determined by a specific ASTM test method. The portion of the specification Patent Owner asserts as a definition of “coefficient of friction” (see Ex. 1001, 11:31–42) is a description of an embodiment; we find it does not express patentee intent to redefine the term. Further, the statement that “the coefficient of friction … may be determined using the … ASTM D1894 standard test method” (id. at 11:32–35) indicates that use of that specific test method is optional. Accordingly, in the absence of patentee lexicography or disavowal, we do not limit the scope of the term “coefficient of friction” to require that it be measured by a specific ASTM standard. Luminara Worldwide, LLC v. Liown Elecs. Co., 814 F.3d 1343, 1353 (Fed. Cir. 2016) (“Absent lexicography or disavowal, we do not depart from the plain meaning of the claims.”); In re Am. Acad. Of Sci. Tech Ctr., 367 F.3d 1359, 1369 (Fed. Cir. 2004) (“We have cautioned against reading limitations into a claim from the preferred embodiment described in the specification, even if it is the only embodiment described, absent clear disclaimer in the specification.”). We note that the ’854 patent specification sets forth a definition for the coefficient of friction between the surfaces of the mesh material and the slide surface. Ex. 1001, 4:38–46. As stated above, however, we do not expressly construe any claim term at this stage of the proceeding. Should the parties address the construction of “coefficient of friction” at trial, we will make a determination after the close of evidence and any hearing.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosureDiscretionary denialcites KSR · GrahamPatents in suitUS 11,998,854 - Western Digital Technologies, Inc. v. Godo Kaisha IP Bridge 1Institution deniedPTAB · Mar 26, 2025 · IPR2024-01448 · APJ Justin T Arbes · IPR · Institution
The Board denied institution because claims 1–8 were statutorily disclaimed, and declined to enter adverse judgment against the Patent Owner.
RulingsInstitution decision- Adverse judgmentAdverse judgmentDecided for patent owner
“reissue, or motions to amend” in the related proceedings. Prelim. Reply 1–2. According to Petitioner, we have authority to enter adverse judgment under Arthrex, Inc. v. Smith & Nephew, Inc., 880 F.3d 1345, 1350 (Fed. Cir. 2018), where the Court held that “37 C.F.R. § 42.73(b) permits the Board to enter an adverse judgment when a patent owner cancels all claims at issue after an IPR petition has been filed, but before an institution decision.” Prelim. Reply 1. Patent Owner disputes whether we have authority to enter adverse judgment, as disclaimed claims are treated as if they never existed and the Court in Arthrex only addressed whether “the Board’s interpretation [of 37 C.F.R. § 42.73(b)] is consistent with the language of the regulation” and expressly declined to “reach the questions of whether the regulation is authorized by the statute or whether, if so, it was properly promulgated.” See Arthrex, 880 F.3d at 1350–51; Prelim. Sur-Reply 1–2. Regardless, though, Patent Owner argues that we should deny institution and not enter adverse judgment based on the Board’s precedential decision in General Electric Company v. United Technologies Corporation, IPR2017-00491, Paper 9 at 2–3 (PTAB July 6, 2017) (designated precedential on Sept. 9, 2019). Prelim. Sur-Reply 2–3.” slip op. at 3
NonePatents in suitUS 11,737,372 - PTAB · Mar 20, 2025 · IPR2024-01406 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board instituted IPR on claims 1, 3, 4, 8–13, and 15 on all asserted grounds, finding a reasonable likelihood that Takeuchi anticipates those claims.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2018); see also 37 C.F.R. § 42.4 (2023). For the reasons discussed below, we determine that Petitioner establishes a reasonable likelihood of prevailing with respect to the unpatentability of at least one claim of the ’202 patent. Accordingly, we institute an inter partes review of claims 1, 3, 4, 8–13, and 15 of the ’202 patent. A. Real Parties in Interest” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“or “POSITA”) would have had “a bachelor’s degree in mechanical engineering, electrical engineering, or a related field, and three to four years of experience, or a master’s degree in mechanical engineering, electrical engineering, or a related field, and one to two years of experience.” Pet. 6 (citing Ex. 1003 ¶ 13). Petitioner further contends that “[s]uch experience would include a familiarity with thermal fluid delivery devices and/or the components and underlying technology used therein, and a higher level of 1 US 5,249,586, issued Oct. 5, 1993 (Ex. 1004, “Morgan”). 2 EP 0 845 220 B1, published Jan. 26, 1998 (Ex. 1006, “Susa”). 3 US 2005/0205084 A1, published Sept. 22, 2005 (Ex. 1007, “Gupta”). 4 US 6,155,268, issued Dec. 5, 2000 (Ex. 1009, “Takeuchi”). at 6–7 (citing Ex. 1003 ¶ 13). Patent Owner states that, for purposes of the Preliminary Response, “Patent Owner maintains that Petitioners’ arguments fail even under Petitioners’ POSA definition.” Prelim. Resp. 13. On this record, we preliminarily adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’202 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))). B. Claim Construction” slip op. at 6
- Prior constructionPrior construction adoptedDecided for petitioner
“term “wicked into contact” that the Board adopted in a prior inter partes review proceeding that addressed the same term in an earlier, related patent. Pet. 7 (citing IPR2020-01602, Paper 32 at 8–15 (PTAB March 30, 2022)). ‘wicked into contact’ to mean: ‘wicked into contact (1) with the heater, or (2) with an area in close proximity to, and exposed [to] the heat produced by, the heater,’” and “[t]he present Petition adopts this formal construction for purposes of this IPR proceeding.” Id. (citing IPR2020-01602, Paper 32 at 15). Patent Owner also “adopts this construction for purposes of” the Preliminary Response, and argues that “Petitioner’s grounds fail even under its proposed construction of ‘wicked into contact.’” Prelim. Resp. 13. For purposes of this Decision, we adopt the Board’s prior construction of “wicked into contact,” namely, “wicked into contact (1) with the heater, or (2) with an area in close proximity to, and exposed to the heat produced by, the heater,” which is undisputed on this record. See Philip Morris Products, S.A. v. RAI Strategic Holdings, Inc., IPR2020-01602, Paper 32 at 8–15 (PTAB March 30, 2022). C. Asserted Anticipation by Morgan” slip op. at 7
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot reached
“To establish anticipation, each and every element in a claim, arranged as recited in the claim, must be found in a single prior art reference. Net Karsten Mfg. Corp. v. Cleveland Golf Co., 242 F.3d 1376, 1383 (Fed. Cir. 2001). “A reference may anticipate inherently if a claim limitation that is not expressly disclosed is ‘necessarily present, or inherent, in the single anticipating reference.’” In re Montgomery, 677 F.3d 1375, 1379 (Fed. Cir. 2012) (quoting Verizon Servs. Corp. v. Fibernet Va., Inc., 602 F.3d 1325, 1336–37 (Fed. Cir. 2010)). Based on the current record, we are not persuaded that Petitioner sufficiently establishes that Morgan discloses “a storage compartment . . . being arranged such that the liquid aerosol-forming material can be wicked into contact with the electrical resistance heater to volatilize the liquid aerosol-forming material” as recited in claim 1.” slip op. at 12
Claim construction§ 102 anticipationcites PhillipsPatents in suitUS 11,925,202 - Posco Co., Ltd. v. ArcelormittalInstitutedPTAB · Mar 18, 2025 · IPR2024-01377 · APJ Brian D Range · IPR · Institution
The Board instituted IPR on claims 1–25 on all petitioned grounds, finding a reasonable likelihood of success, including that GMW14400 likely qualifies as prior art.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review pursuant to 35 U.S.C. § 6(b). Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The Board determines whether to institute a trial on behalf of the Director. 37 C.F.R. § 42.4(a). The following findings of fact and conclusions of law are not final, but are made for the sole purpose of determining whether Petitioner meets the threshold for initiating review. Any final decision shall be based on the full trial record, including any response timely filed by Patent Owner. Any arguments not raised by Patent Owner in a timely-filed response may be deemed waived. For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We hereby institute an inter partes review as to claims 1–25 of the ’227 patent based upon Petitioner’s asserted grounds of unpatentability.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“efficiency and integrity of the system are best served by denying or instituting review.” Fintiv at 6. Here, Fintiv factors one and five are neutral, factors two and three favor discretionary denial, factor four strongly weighs against discretionary denial, and favor six weighs against discretionary denial. The integrity of the system will benefit from institution because of the strong merits the Petition presents (factor six), and the ITC Investigation will not resolve these merits (factor four). This outweighs any potential inefficiency as indicated by factors two and three. We further note that any inefficiency in resolving the grounds the Petition presents is mitigated by the stay of the district court action (factor one). We, thus, decline to exercise discretionary denial under 35 U.S.C. § 314(a).” slip op. at 17
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDenied
“After considering the record as a whole, we determine that Petitioner has adequately demonstrated that the Office erred in a manner material to the patentability of challenged claims. As we explain in Section III(G), infra, Petitioner’s challenges to the ’227 patent appear strong based on the current record, and Patent Owner’s present arguments to the contrary are weak. Given the strength of Petitioner’s challenges on the present record, this is not a situation where we would say that “reasonable minds can disagree regarding the purported treatment of the art,” and we therefore determine that the Examiner erred by not considering the art in substantially the combination Petitioner proposes. Where Patent Owner states that “evidence that the Examiner did not consider these references in combination” is lacking (PO Sur-Reply 5), we disagree. If the Examiner considered these references in combination, the Examiner would have, given the apparent strength of Petitioner’s position on the merits on this record, issued a rejection. The lack of a rejection based on the combination proposed in the Petition provides some evidence that the Examiner did not consider these references in combination (because the lack of such a rejection raises the likelihood that the Examiner did not make such a consideration). 3. Conclusion Because Petitioner adequately made a showing of material error, we decline to exercise discretion not to institute inter partes review under 35 U.S.C. § 325(d). See Advanced Bionics, LLC, IPR2019-01469, Paper 6 at 8–9.” slip op. at 19
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“For purposes of this Decision, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,326,227 - Posco Co., Ltd. v. ArcelormittalInstitutedPTAB · Mar 18, 2025 · IPR2024-01376 · APJ Brian D Range · IPR · Institution
The Board instituted review of claims 1–30 on all petitioned grounds, finding a reasonable likelihood of success, including that GMW14400 likely qualifies as prior art.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“IV. CONCLUSION For the reasons above, we determine that the information presented in the Petition establishes that there is a reasonable likelihood that Petitioner would prevail with respect to challenged claims 1–30 of the ’602 patent. At this juncture in the proceeding, we have not made a final determination with respect to the patentability of the challenged claims, or with respect to claim construction. V. ORDER For the foregoing reasons, it is ORDERED that pursuant to 35 U.S.C. § 314(a), an inter partes review of claims 1–30 of the ’602 patent is hereby instituted with respect to all grounds of unpatentability set forth in the Petition; and” slip op. at 36
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivDenied
“efficiency and integrity of the system are best served by denying or instituting review.” Fintiv at 6. Here, Fintiv factors one and five are neutral, factors two and three favor discretionary denial, factor four strongly weighs against discretionary denial, and favor six weighs against discretionary denial. The integrity of the system will benefit from institution because of the strong merits the Petition presents (factor six), and the ITC Investigation will not resolve these merits (factor four). This outweighs any potential inefficiency as indicated by factors two and three. We further note that any inefficiency in resolving the grounds the Petition presents is mitigated by the stay of the district court action (factor one). We, thus, decline to exercise discretionary denial under 35 U.S.C. § 314(a).” slip op. at 17
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDenied
“After considering the record as a whole, we determine that Petitioner has adequately demonstrated that the Office erred in a manner material to the patentability of challenged claims. As we explain in Section III(G), infra, Petitioner’s challenges to the ’602 patent appear strong based on the current record, and Patent Owner’s present arguments to the contrary are weak. Given the strength of Petitioner’s challenges on the present record, this is not a situation where we would say that “reasonable minds can disagree regarding the purported treatment of the art,” and we therefore determine that the Examiner erred by not considering the art in substantially the combination Petitioner proposes. Where Patent Owner states that “evidence that the Examiner did not consider these references in combination” is lacking (PO Sur-Reply 5), we disagree. If the Examiner considered these references in combination, the Examiner would have, given the apparent strength of Petitioner’s position on the merits on this record, issued a rejection. The lack of a rejection based on the combination proposed in the Petition provides some evidence that the Examiner did not consider these references in combination (because the lack of such a rejection raises the likelihood that the Examiner did not make such a consideration). 3. Conclusion Because Petitioner adequately made a showing of material error, we decline to exercise discretion not to institute inter partes review under 35 U.S.C. § 325(d). See Advanced Bionics, LLC, IPR2019-01469, Paper 6 at 8–9.” slip op. at 19
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“For purposes of this Decision, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,961,602 - Western Digital Technologies, Inc. v. Godo Kaisha IP Bridge 1Institution deniedPTAB · Mar 14, 2025 · IPR2024-01449 · APJ Justin T Arbes · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1 and 2 were unpatentable under any of the four asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“inter partes review unless the information in the petition and preliminary response “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” See 37 C.F.R. § 42.4(a) (“The Board institutes the trial on behalf of the Director.”). For the reasons that follow, we do not institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“ordinary skill in the art would have had “a Ph.D. in electrical engineering, physics, materials science, or a related field, and at least one year of experience in the research, design, and/or development of magnetic/spintronic devices, or the equivalent,” or “a Master’s degree in electrical engineering, physics, materials science, or a related field, and four years of experience in the research, design, and/or development of magnetic/spintronic devices, or the equivalent,” where “[l]ess work experience may be compensated by a higher level of relevant education, and vice versa.” Pet. 29 (citing Ex. 1024 ¶ 25). Patent Owner applies Petitioner’s definition of the level of ordinary skill in the art for purposes of its Preliminary Response. Prelim. Resp. 17. Based on the record presented, including our review of the ’463 patent and the types of problems and solutions described in the ’463 patent and cited prior art, we agree with Petitioner’s proposed definition of the level of ordinary skill in the art and apply it for purposes of this Decision.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner
“C. Claim Interpretation We interpret each challenged claim using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b), including construing the claim in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent. 37 C.F.R. § 42.100(b). Petitioner argues that “the claim terms should be given their plain and ordinary meaning and no claim construction is necessary.” Pet. 25–26. Patent Owner does not propose interpretations of any claim terms in its Preliminary Response. We conclude that no express interpretation of any claim term is necessary to determine whether to institute an inter partes review in this proceeding. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“Because we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy,’ we need not construe [a particular claim limitation] where the construction is not ‘material to the . . . dispute.’” (citation omitted) (emphasis added)).” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Further, because Bowen’s disclosed barrier height is outside the claimed range, Petitioner relies on Soukup’s purported teaching of a barrier height of “about 0.33 eV” and contends that a person of ordinary skill in the art would have been motivated to “achieve” that barrier height for the MgO barrier of Bowen’s device. Id. at 34–36. The data that Petitioner relies on from Soukup for the “about 0.33 eV” barrier height, though, was determined using the slope of an Arrhenius plot, not Simmons’ formula. Ex. 1028, 3229 (Abstract), 3231–33, Table I. In Soukup, apparent barrier heights for the samples were determined using (1) the slope of an Arrhenius plot, and (2) the zero-field intercept of the straight line logI versus V1/2 plot. Id. at 3229 (Abstract), 3230–32, Fig. 3, Table I. Reproduced below is Table I of Soukup, as annotated by Patent Owner (Prelim. Resp. 39): Annotated Table I of Soukup includes the results of analyses of sample test data, with the column highlighted in yellow showing the barrier heights obtained by a zero-field intercept method and the column highlighted in blue showing barrier heights obtained from the slope of an Arrhenius plot. See Ex. 1028, 3233; Prelim. Resp. 38–39. Dr. Bokor testifies that “Soukup disclosed that Simmons’ formula was used to approximate tunnel barrier height” and “[o]ne of skill would have understood the ‘height and the bias dependence of the insulator potential-energy barrier’ [referenced in Soukup] included the tunnel barrier height.” Ex. 1024 ¶¶ 145–147 (quoting Ex. 1028, 3229; citing Ex. 1024 ¶¶ 45–49). We do not find this testimony persuasive. Although Soukup refers to “Simmons’ model” and the Simmons 1963 paper in its “Introduction,” it does not teach any calculation using Simmons’ formula to obtain a barrier height within the claimed range. See Ex. 1028, 3229, 3236 n.1; Prelim. Resp. 63. Soukup plainly recognizes that there are methods of calculating barrier height other than Simmons’ formula, and discusses at length its calculations using two such methods: the Arrhenius plot method and the zero-field intercept method. See, e.g., Ex. 1028, 3229 (Abstract) (“These results . . . indicate a potential barrier height of about 0.72 eV when determined from the zero-field intercept of the straight line logI vs V1/2 plot and about 0.33 eV when obtained from an Arrhenius plot.”), 3232–33. Petitioner does not address whether the 0.33 eV barrier height it relies on from Soukup (determined using the Arrhenius plot method) would still be within the claimed range if calculated using Simmons’ formula. See Prelim. Resp. 63. Nor does Petitioner rely on any values from Soukup’s disclosure that would be used as the variables in Simmons’ formula—Petitioner relies solely on Bowen. See Pet. 39–42. Thus, Petitioner’s argument that Bowen and Soukup teach a barrier height within the claimed range, obtained using equation (1), is not persuasive. See id. at 34–42.” slip op. at 17
Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 9,123,463
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.