- PTAB · Feb 6, 2025 · IPR2024-01211 · APJ John G New · IPR · Institution
The Board instituted IPR on claims 18–47 and 53–74 and all petition grounds, finding a reasonable likelihood that claims 18–25, 27, and 29–33 are obvious over Racz, Fitz, and Lee.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“§ 314. An inter partes review may not be instituted unless “the information presented in the petition … and any response … shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Further, a decision to institute may not do so on fewer than all of the claims challenged in the petition. SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018); 37 C.F.R. § 42.108(a); see also PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018) (interpreting the statute to require “a simple yesor-no institution choice respecting a petition, embracing all challenges included in the petition”).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Absent evidence or argument to the contrary, we apply Petitioner’s proposed definition, as it appears to be consistent with the level of skill of the prior art and is supported by the presently unopposed testimony of Dr. Tucker. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the level of ordinary skill in the art may be reflected in the prior art itself). We note, however, that the open-ended language ‘at least’ expands the ranges of education and experience indefinitely with no upper bound, thereby also encompassing those of extraordinary skill as well. Therefore, we do not adopt this aspect of Petitioner’s formulation.” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“With respect to the challenged claims, Petitioner contends that no claim term requires express construction. Pet. 11 (citing Ex. 1033 ¶ 120 (Dr. Tucker’s testimony that “the terms in the Challenged Claims would be understood by a POSA to have their plain and ordinary meaning and do not require a special construction or definition”)). We agree with Petitioner that, on the record presently before us, no claim term requires express construction.” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“Petitioner argues that, in view of these teachings in Racz and Lee, a skilled artisan would have found implementing Lee’s perimeter filaments (22/1622) on Racz’s distal tip (14/38) to be a routine engineering task. Pet. 39 (citing Ex. 1033 ¶ 179). According to Petitioner, a person of ordinary skill in the arts would have recognized that it would be appropriate to implement Lee’s perimeter filaments (22/1622) without including Lee’s central filament. Id. Petitioner asserts that Lee discloses that any number and arrangement of filaments may be implemented to provide a desired ablation volume. Id. at 38 (citing Ex. 1010 ¶¶ 103, 105, 106). Additionally, Petitioner argues, because Racz’s tip (14/38) is already active, a skilled artisan would have recognized that Lee’s central filament would not be necessary. Id. (citing Ex. 1009, col. 3, ll. 60–63, col. 4, ll. 18–23; Ex. 1033 ¶ 179). Petitioner therefore argues that a person of ordinary skill in the art a person of ordinary skill in the art would have been motivated to implement Lee’s perimeter deployable filaments (22/1622) on the distal tip (14/38) of Racz’s cannula (10/33) for the purpose of expanding and controlling the energy coverage area of Racz’s device. Pet. 40. Specifically, Petitioner asserts that a skilled artisan would have been motivated to implement Lee’s perimeter filaments (22/1622) around Racz’s tip (14/38) to provide a desired ablation volume (e.g., in a full or partial “cone” shape) and omit Lee’s central filament. Pet. 38 (citing Ex. 1033 ¶¶ 179, 73–75, 79–83). Petitioner contends that, as both Lee and Fitz confirm, this would improve Racz’s device by providing an expanded and controlled energy coverage area. Id. (citing Ex. 1011 ¶¶ 9–10, Abstr.; Ex. 1010 ¶¶ 12, 84, 123–131; Ex. 1033 ¶ 179). Petitioner argues further that, in implementing Lee’s perimeter filaments (22/1622) on Racz’s distal tip (14/38), a person of ordinary skill in the art would have found it obvious to modify Racz’s tip (14/38) to include internal deflection surfaces (12/1612) (e.g., channels and ramps as disclosed in Lee) to guide the perimeter filaments (22/1622) outwardly around Racz’s tip (14/38). Pet. 41 (citing Ex. 1010 ¶¶ 16, 18, 92, 102, claims 8, 10; Ex. 1033 ¶ 180). Petitioner asserts that it would have been obvious to provide openings in Racz’s distal tip (14/38) (e.g., in communication the internal deflection surfaces as disclosed in Lee) such that Lee’s perimeter filaments (22/1622) can, when deployed, exit Racz’s distal tip (14/38). Id. (citing Ex. 1010 ¶ 92, 102; Ex. 1033 ¶ 180). Furthermore, argues Petitioner, and to preserve the functionality of Racz’s removable electrical probe (22/52) and active tip (14/38) (and consistent with Lee’s teachings) a skilled artisan would have arranged the perimeter filaments, channels, and ramps around the internal perimeter of Racz’s cannula (10/33). Pet. 41 (citing Ex. 1010 ¶¶ 91, 92, 98, 102; Ex. 1033 ¶ 181). Petitioner recapitulates that Racz’s probe (22/52) is configured to extend the full length of the cannula’s shaft (12/34) to supply RF energy to the tip (14/38) and measure tissue temperature. Pet. 42. According to Petitioner, by omitting Lee’s central filament and arranging the perimeter filaments, channels, and ramps around the inner perimeter of Racz’s cannula (10/33), a skilled artisan could have implemented Lee’s perimeter filaments (22/1622) without obstructing Racz’s cannula (10/33). Id. at 40. Petitioner contends that this modification would preserve the functionality of Racz’s electrical probe (22/52), which is needed to transmit RF energy. Id. (citing Ex. 1033 ¶ 181–182).” slip op. at 29
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 10,736,688 - PTAB · Feb 6, 2025 · IPR2024-01210 · APJ John G New · IPR · Institution
The Board instituted IPR on claims 1–17 and 48–52 on all asserted grounds, finding a reasonable likelihood that at least one claim was obvious over Racz, Fitz, and Lee.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“§ 314. An inter partes review may not be instituted unless “the information presented in the petition … and any response … shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Further, a decision to institute may not do so on fewer than all of the claims challenged in the petition. SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018); 37 C.F.R. § 42.108(a); see also PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018) (interpreting the statute to require “a simple yesor-no institution choice respecting a petition, embracing all challenges included in the petition”).” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“Absent evidence or argument to the contrary, we apply Petitioner’s proposed definition, as it appears to be consistent with the level of skill of the prior art and is supported by the presently unopposed testimony of Dr. Tucker. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the level of ordinary skill in the art may be reflected in the prior art itself). We note, however, that the open-ended language ‘at least’ expands the ranges of education and experience indefinitely with no upper bound, thereby also encompassing those of extraordinary skill as well. Therefore, we do not adopt this aspect of Petitioner’s formulation.” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“With respect to the challenged claims, Petitioner contends that no claim term requires express construction. Pet. 11 (citing Ex. 1032 ¶ 120 (Dr. Tucker’s testimony that “the terms in the Challenged Claims would be understood by a POSA to have their plain and ordinary meaning and do not require a special construction or definition”)). We agree with Petitioner that, on the record presently before us, no claim term requires express construction.” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“person of ordinary skill in the art would have been motivated to implement Lee’s perimeter deployable filaments (22/1622) on the distal tip (14/38) of Racz’s cannula (10/33) for the purpose of expanding and controlling the energy coverage area of Racz’s device. Pet. 35. Specifically, Petitioner asserts that a skilled artisan would have been motivated to implement Lee’s perimeter filaments (22/1622) around Racz’s tip (14/38) to provide a desired ablation volume (e.g., in a full or partial “cone” shape) and omit Lee’s central filament. Pet. 38 (citing Ex. 1032 ¶¶ 179, 73–75, 79–83). Petitioner contends that, as both Lee and Fitz confirm, this would improve Racz’s device by providing an expanded and controlled energy coverage area. Id. (citing Ex. 1011 ¶¶ 9–10, Abstr.; Ex. 1010 ¶¶ 12, 84, 123–131; Ex. 1032 ¶ 179). Petitioner argues further that, in implementing Lee’s perimeter filaments (22/1622) on Racz’s distal tip (14/38), a person of ordinary skill in the art would have found it obvious to modify Racz’s tip (14/38) to include internal deflection surfaces (12/1612) (e.g., channels and ramps as disclosed in Lee) to guide the perimeter filaments (22/1622) outwardly around Racz’s tip (14/38). Pet. 39 (citing Ex. 1010 ¶¶ 16, 18, 92, 102, claims 8, 10; Ex. 1032 ¶ 180). Petitioner asserts that it would have been obvious to provide openings in Racz’s distal tip (14/38) (e.g., in communication the internal deflection surfaces as disclosed in Lee) such that Lee’s perimeter filaments (22/1622) can, when deployed, exit Racz’s distal tip (14/38). Id. (citing Ex. 1010 ¶ 92, 102; Ex. 1032 ¶ 180).” slip op. at 29
Claim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 10,736,688 - PTAB · Feb 6, 2025 · IPR2024-01209 · APJ Robert A Pollock · IPR · Institution
The Board instituted IPR on claims 1–27 and all petition grounds, finding a reasonable likelihood that at least one claim is obvious over Racz, Fitz, and Lee.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“314. An inter partes review may not be instituted unless “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Further, a decision to institute may not do so on fewer than all claims challenged in the petition. SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018); 37 C.F.R. § 42.108(a).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Absent evidence or argument to the contrary, we apply Petitioner’s proposed definition, as it appears consistent with the prior art and is supported by the presently unopposed testimony of Dr. Tucker. See Okajima v. Bourdeau, 261 F.3d 1350, 1355, (Fed. Cir. 2001) (the level of ordinary skill in the art may be reflected in the prior art itself). We note, however, that Petitioner’s open-ended language “at least” expands the ranges of education and experience indefinitely with no upper bound, thereby encompassing those of extraordinary skill. Therefore, we do not adopt this aspect of Petitioner’s formulation. B.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“With respect to the challenged claims, Petitioner contends that no claim term requires express construction. Pet. 11 (citing Ex. 1031 ¶ 106 (Dr. Tucker’s testimony that “the terms in the Challenged Claims would be understood by a POSA to have their plain and ordinary meaning and do not require a special construction or definition”)). On the presents record, we agree with Petitioner that no term requires express construction.” slip op. at 12
Claim constructioncites Phillips · KSRPatents in suitUS 10,966,782 - PTAB · Jan 27, 2025 · IPR2024-00965 · APJ Zhenyu Yang · IPR · Institution
Instituted review of claims 1–6 on all asserted grounds because Petitioner showed a reasonable likelihood of prevailing on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons provided below, we determine Petitioner has satisfied the threshold requirement set forth in 35 U.S.C. § 314(a). Accordingly, we institute inter partes review of all challenged claims based on the ground raised in the Petition.” slip op. at 2
- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedInstituted
“We agree with Patent Owner that testimony from a “custodian with any personal knowledge of arXiv.org or its regular practices” would have strengthened Petitioner’s argument that Gloor is prior art. See Prelim. Resp. 20; see also, e.g., Murray & Poole Enters. LTD v. Institut De Cardiologie De Montreal, IPR2023-01064, Paper 49 (PTAB Jan. 14, 2025) (considering testimony regarding the internet archive service known as the Wayback Machine (https://web.archive.org/) in determining public accessibility). At the institution stage, however, Petitioner needs to show that Gloor qualifies as prior art by “a reasonable likelihood” standard. See Hulu, LLC, v. Sound View Innovations, LLC, IPR2018-01039, Paper 29, 13 (PTAB Dec. 20, 2019) (precedential) (“[A]t the institution stage, the petition must identify, with particularity, evidence sufficient to establish a reasonable likelihood that the reference was publicly accessible before the critical date of the challenged patent and therefore that there is a reasonable likelihood that it qualifies as a printed publication.”). We find that, for purposes of institution, Petitioner has met its burden to show a reasonable likelihood that Gloor was publicly accessible before the priority date of the ’200 patent. To prevail in this inter partes review, Petitioner must meet the preponderance of the evidence standard. See 35 U.S.C. § 316(e). Thus, we encourage the parties to fully develop the record during trial to facilitate the ultimate resolution of this issue.” slip op. at 9
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDecided for petitioner
“institution under § 325(d). Prelim. Resp. 21–29. Under 35 U.S.C. § 325(d), in determining whether to institute an inter partes review, “the Director may take into account whether, and reject the petition or request because, the same or substantially the same prior art or arguments previously were presented to the Office.” Our § 325(d) analysis employs a two-prong framework: (1) whether the arguments presented in the petition are the same or substantially the same as those previously presented to the Office; and (2) if so, whether the petitioner has demonstrated a material error by the Office in its prior consideration of those arguments. Advanced Bionics, LLC v. Med-El Electromedizinishe Gerӓte GmbH, IPR2019-01469, Paper 6 (“Advanced Bionics”), 8 (PTAB Feb. 13, 2020) (precedential).” slip op. at 11
§ 102 anticipationDiscretionary denialcites PhillipsPatents in suitUS 11,768,200 - PTAB · Jan 27, 2025 · IPR2024-00964 · APJ Zhenyu Yang · IPR · Institution
The Board instituted IPR on claims 1–8 based on both asserted obviousness grounds: Parameswaran with Gloor and Parameswaran with Bentley.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons provided below, we determine Petitioner has satisfied the threshold requirement set forth in 35 U.S.C. § 314(a). Accordingly, we institute inter partes review of all challenged claims based on the ground raised in the Petition.” slip op. at 2
- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedDecided for petitioner
“We agree with Patent Owner that testimony from a “custodian with any personal knowledge of arXiv.org or its regular practices” would have strengthened Petitioner’s argument that Gloor is prior art. See Prelim. Resp. 27; see also, e.g., Murray & Poole Enters. LTD v. Institut De Cardiologie De Montreal, IPR2023-01064, Paper 49 (PTAB Jan. 14, 2025) (considering testimony regarding the internet archive service known as the Wayback Machine (https://web.archive.org/) in determining public accessibility). At the institution stage, however, Petitioner needs to show that Gloor qualifies as prior art by “a reasonable likelihood” standard. See Hulu, LLC, v. Sound View Innovations, LLC, IPR2018-01039, Paper 29, 13 (PTAB Dec. 20, 2019) (precedential) (“[A]t the institution stage, the petition must identify, with particularity, evidence sufficient to establish a reasonable likelihood that the reference was publicly accessible before the critical date of the challenged patent and therefore that there is a reasonable likelihood that it qualifies as a printed publication.”). We find that, for the purposes of institution, with Dr. Gloor’s declaration and the supporting exhibits attached therein, Petitioner has met this burden. To prevail in this inter partes review, Petitioner must meet the preponderance of the evidence standard. See 35 U.S.C. § 316(e). Thus, we encourage the parties to fully develop the record during trial to facilitate the ultimate resolution of this issue.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“detailed analysis to support its argument that the combination of Parameswaran and Gloor teaches or suggests each limitation of claim 1. Pet. 23–36. Petitioner also contends that an ordinarily skilled artisan would have been motivated combine the teachings of the two references and would have had a reasonable expectation of success in doing so. Id. at 36–45. Patent Owner counters that the combination does not teach or suggest two limitations, namely the amplifying and discarding steps of the method. Prelim. Resp. 18–24. Patent Owner also challenges Gloor’s prior art status. Id. at 24–28. Based on the current record, we find Petitioner’s argument with respect to the amplifying and discarding steps more persuasive. With respect to the remaining limitations, we find persuasive Petitioner’s analysis on the prior art’s teachings. We also find persuasive Petitioner’s analysis on the motivation to combine and reasonable expectation of success. For the purposes of institution, we adopt those analyses as our own. We address Patent Owner’s counterarguments below.” slip op. at 9
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“cross-over events (id. at 18–21). Based on the current record, we find Petitioner’s argument more persuasive. Petitioner relies on the combination of Parameswaran and Gloor as teaching the amplifying step. See Pet. 31–33. As such, Patent Owner cannot show non-obviousness “by attacking references individually.” In re Keller, 642 F.2d 413, 426 (CCPA 1981). Patent Owner argues that “because Parameswaran used pyrosequencing on the surface of beads in a Roche 454 sequencer, it does not disclose the formation of clusters.” Prelim. Resp. 21 (citing Pet. 31). Petitioner, however, relies on Gloor for teaching “amplifying said nucleic acid templates on a surface of a flow cell thereby to form clusters.” Pet. 31–32. Patent Owner does not challenge this reliance. See generally Prelim. Resp. Patent Owner contends that Petitioner “equat[es] the claimed chimeric sequences with ‘mismatched’ or ‘misassigned’ sequences containing an ‘unexpected’ pair of forward and reverse barcode motifs identified in Parameswaran.” Prelim. Resp. 18–19. But, according to Patent Owner, “Petitioner does not point to any disclosure in Parameswaran identifying these “mismatched” motifs as chimeric sequences—as opposed to mere sequencing or sample handling error—nor does Petitioner cite any disclosure in Parameswaran regarding such sequences resulting from cross-over events.” Id. at 19. We find Patent Owner’s characterization of Petitioner’s argument inaccurate. As we understand it, Petitioner does not “equat[e]” the claimed chimeric sequences with “mismatched” sequences in Parameswaran. Instead, as Patent Owner acknowledges, “Petitioner argues that ‘sequences with mismatched barcode motifs’ in Parameswaran ‘include chimeric sequences resulting from cross-over events.’” Id. (quoting Pet. 32) (emphasis added).” slip op. at 14
§ 102 anticipation§ 103 obviousnesscites PhillipsPatents in suitUS 11,041,852 - Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentablePTAB · Jan 17, 2025 · IPR2024-00597 · APJ Jon B Tornquist · IPR · Final written decision
Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9–10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“We also agree with Patent Owner that the charge cut-off voltage is not necessarily the applied voltage during charging. PO Resp. 20. Rather, depending on the charging protocol used and when in the charging cycle the voltage is applied, the applied voltage could be higher than the battery voltage. Ex. 2013; Ex. 2006 ¶ 91. For example, as discussed in more detail below with respect to the Uemura grounds, when fast charging using constant current is used and the charging rate is not slow, the applied voltage will be higher than the battery voltage when the constant current charging phase is stopped. Ex. 2006 ¶ 91; Ex. 2013. Likewise, during constant current/constant voltage charging, the applied voltage approximates the battery voltage only when the battery is nearly completely charged. Ex. 2013; Ex. 2006 ¶ 91. Thus, the applied voltage may be, but is not necessarily, the charge cut-off voltage. In view of the foregoing, we construe “charge cut-off voltage” in claims 1 and 5 as “the maximum value to which the battery is configured to be charged.” PO Resp. 18; Ex. 2008, 217:6–11; Pet. Reply 5. Contrary to Patent Owner’s arguments, however, we do not understand the phrase “configured to be charged” to necessarily represent a single voltage for the battery that is determined based on the structure and chemistry of the battery. Pet. Reply 4–5. Rather, the charge cut-off voltage is a selected potential, or voltage, of the battery or cell at the end of charging that is controlled by a circuit or device, such as a charger or control circuit within the battery. Ex. 1001, 9:50–55; Ex. 1048, 2, 7–8; Ex. 1008, 3:9–13. And, for the reasons discussed herein, the charge cut-off voltage may be, but is not necessarily, the same as the applied voltage during charging. PO Resp. 20.” slip op. at 15
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16
- Expert testimonyPatent owner expert creditedDecided for patent owner
“Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122.” slip op. at 21
Patent outcomesUS 7,749,641 mixedClaim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,749,641 - Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentablePTAB · Jan 17, 2025 · IPR2023-01183 · APJ Jon B Tornquist · IPR · Final written decision
Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9 and 10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“constructions. First, we agree with Petitioner that the ’641 patent indicates that the charge cut-off voltage selected for a particular battery need not be a fixed property of the battery or something that is set by the design and chemistry of the battery. Consistent with this conclusion, the ’641 patent discloses that a “charging device controls the charge cut-off voltage of the single lithium-ion cell within a range from 4.3 V to 5.8 V.” Ex. 1001, 9:50– 55. This strongly suggests that the charge cut-off voltage is controlled by the charger and is not necessarily an inherent property of the battery. Patent Owner contends that this is merely an unclaimed embodiment, but the relevant disclosure states that the charging device for the “present invention” may be any type of device “with the proviso that said charging device controls the charge cut-off voltage.” Id. at 9:50–53.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16
- Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner
“Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122. Petitioner argues that because the battery of Uemura is charged “to” a maximum voltage of 4.3 V, Uemura discloses the claimed charge cut-off voltage under either Petitioner’s or Patent Owner’s construction of the term. Pet. Reply 11–12 (citing Ex. 1009 ¶ 81; Ex. 1044 ¶¶ 56–59). This argument is not persuasive because Mr. Juzkow unambiguously testified that charging in Uemura stopped when the applied voltage reached 4.3 V, and Uemura discloses that the battery was charged “at” a voltage ranging from 4.3 V to 2.0 V, not “to” such a voltage. Ex. 1009 ¶ 81; Ex. 2008, 113:2–13; Ex. 2006 ¶ 119 n.64; Sur-reply 9. In view of the foregoing, we determine that Petitioner has not demonstrated by a preponderance of the evidence that Uemura anticipates independent claims 1 and 5 of the ’641 patent.” slip op. at 21
Patent outcomesUS 7,749,641 mixedClaim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,749,641 - Vusiongroup SA v. Hanshow Technology Co., Ltd.Institution deniedPTAB · Jan 14, 2025 · IPR2024-01045 · APJ Patrick R Scanlon · IPR · Institution
The Board denied institution on all challenged claims because the Petition did not show a reasonable likelihood of prevailing on any of its four § 103 grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that Petitioner has not demonstrated a reasonable likelihood that it would prevail with respect to at least one challenged claim. Accordingly, we do not institute an inter partes review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableNot shown unpatentable
“We agree with Patent Owner. At best, Schwartz’s disclosure cited by Petitioner teaches aggregating product information obtained from different stores, but neither the Petition nor Dr. Wolfe explains sufficiently how aggregating product information would have suggested cross-correlating different product facing bounding boxes to one of ordinary skill in the art. See Pet. 35–37; Ex. 1003 ¶¶ 148–151. We are not persuaded that aggregating product information and cross-correlating different product facing bounding boxes would have been recognized as similar or comparable processes. Moreover, Petitioner does not even assert that one of ordinary skill in the art would have recognized that Schwartz cross-correlates one or more product facing bounding boxes and one or more other product facing bounding boxes as required by limitation [1.5]. Instead, Petitioner asserts only that one of ordinary skill in the art “would have recognized Schwartz . . . cross-correlates that product and affiliated shelf added). Furthermore, limitation [1.5] recites cross-correlating different product facing bounding boxes by matching shelf label content of the different product facing bounding boxes. But Petitioner does not explain adequately how the combination of Schwartz and Katircioglu satisfies this requirement. Pet. 35–37. Although Petitioner asserts that the combination discloses associating shelf label content with product facing bounding boxes (id. at 30–35), we are not directed to any disclosure in either Schwartz or Katircioglu that teaches or suggests matching the shelf label content of different product facing bounding boxes. For the above reasons, Petitioner fails to persuade us that the combination of Schwartz and Katircioglu discloses limitation [1.5]. Therefore, we determine Petitioner has not met its burden to show a reasonable likelihood it would prevail with respect to the contention that claim 1 is unpatentable over the combination of Schwartz and Katircioglu.” slip op. at 13
- Skill levelSkill level petitioner adoptedOther
“Petitioner contends that [a] person of ordinary skill in the art (“POSITA”) in November 2016 would have had a Bachelor’s degree in electrical engineering, computer engineering, computer science, or a related field, and two or more years of work experience or research related to computer vision, image analytics, machine learning, artificial intelligence or automated object recognition methods and systems, or equivalent training and work experience in the field. Formal education can substitute for work experience and relevant work experience could substitute for formal education. Pet. 8–9 (citing Ex. 1003 ¶ 29). Patent Owner indicates it agrees with Petitioner’s definition of a person having ordinary skill in the art. Prelim. Resp. 4–5. Based on our review of the record before us, we determine that Petitioner’s stated level of ordinary skill in the art is reasonable because it appears consistent with the evidence of record, including the asserted prior definition.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner contends that “[n]o formal claim constructions are necessary ‘to resolve the controversy.’” Pet. 9 (quoting Wellman, Inc. v. Eastman Chem. Co., 642 F.3d 1355, 1361 (Fed. Cir. 2011)). Petitioner adds that there is a rebuttable presumption that § 112(f) does not apply because the challenged claims do not recite “means.” Id. In the event the presumption is overcome with respect to the claim terms “processor” and “product classifier,” Petitioner identifies the disclosure describing the corresponding structure for these terms. Id. at 9–10. Patent Owner contends that claim construction is not necessary and the claims should be given their plain and ordinary meaning. Prelim. Resp. 5. Regarding the claim terms “processor” and “product classifier,” Patent Owner argues that Petitioner has not advanced any argument to rebut the presumption that § 112(f) does not apply. Id. at 6. any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 8
Claim construction§ 103 obviousnesscites GrahamPatents in suitUS 11,087,272 - PTAB · Jan 13, 2025 · IPR2024-01156 · APJ Jeffrey N Fredman · IPR · Institution
The Board instituted inter partes review of claims 1–30 on all grounds, finding it more likely than not that the claims are unpatentable.
RulingsInstitution decision- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“On the current record, there is no controversy over the meaning of any of the claim terms and neither party identifies a claim construction that would impact our analysis. We therefore find that, at this stage of the proceeding, there are no terms that need claim construction. See, e.g., Wellman, Inc. v. Eastman Chem. Co., 642 F.3d 1355, 1361 (Fed. Cir. 2011) (“[C]laim terms need only be construed ‘to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“VIII. LEVEL OF ORDINARY SKILL IN THE ART Petitioner asserts (without opposition): A person of ordinary skill in the art (“POSA”) at the time of invention would have a working knowledge of microbiology and would have been involved in developing testing methodologies for analysis of samples such as food products (“validation methodologies”). The POSA would most likely have an advanced degree in microbiology, food science, or animal science and at least two years of work experience but may alternatively have a bachelor’s degree in those areas and at least four years of experience with validation methodologies. The POSA would have been familiar with relevant scientific literature and industry regulations, directives, and guidelines relating to validation methodologies.” slip op. at 8
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“Determining whether claims are anticipated involves a two-step analysis. The first step involves construction of the claims of the patent at issue. Claim construction is a question of law reviewed de novo.” In re Aoyama, 656 F.3d 1293, 1296 (Fed.Cir.2011). “The second step [of an anticipation analysis] involves comparing the claims to the prior art. Anticipation is a question of fact reviewed for substantial evidence.” In re Aoyama, 656 F.3d at 1296. “A prior art reference anticipates a patent claim under 35 U.S.C. § 102(b) if it discloses every claim limitation.” In re Montgomery, 677 F.3d 1375, 1379 (Fed. Cir. 2012). A reference may anticipate inherently if a claim limitation that is not expressly disclosed “is necessarily present, or inherent, in the single anticipating reference.” Verizon Servs. Corp. v. Cox Fibernet Va., Inc., 602 F.3d 1325, 1337 (Fed. Cir. 2010). slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“The motivation-to-combine analysis is a flexible one. “[A]ny need or problem known in the field of endeavor at the time of invention and addressed by the patent can provide a reason for combining the elements in the manner claimed,” [but the] “analysis ‘need not seek out precise teachings directed to the specific subject matter of the challenged claim, for a court can take account of the inferences and creative steps that a person of ordinary skill in the art would employ.’” Intel Corp. v. PACT XXP Schweiz AG, 61 F.4th 1373, 1379–80 (Fed. Cir. 2023) (quoting KSR, 550 U.S. at 418, 420 (emphasis added)). “[I]f there’s a known technique to address a known problem using ‘prior art elements according to their established functions,’ then there is a motivation to combine,” because KSR explains that “if a technique has been used to improve one device [or method], and a person of ordinary skill in the art would recognize that it would improve similar devices [or methods] in the same way, using the technique is obvious unless its actual application is beyond his or her skill.” Id. at 1380 (quoting KSR, 550 U.S. at 417; and Intel Corp. v. Qualcomm Inc., 21 F.4th 784, 797 (Fed. Cir. 2021)). If addressing a known problem, the prior art combination need not be “the best option, only . . . a suitable option.” Id. (quoting Intel, 21 F.4th at 800 (emphasis original)).” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,845,486 - PTAB · Jan 13, 2025 · IPR2024-00186 · APJ Jeffrey N Fredman · IPR · Institution
The Board instituted inter partes review on all challenged claims and all grounds, finding a reasonable likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have jurisdiction under 35 U.S.C. § 314, which provides that an inter partes review may not be instituted unless the information presented in the Petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” A decision to institute under § 314 may not institute on fewer than all claims challenged in the petition. SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018). In addition, if the Board institutes trial, it will “institute on all grounds in the petition.” PTAB Consolidated Trial Practice Guide, 5–6 (Nov. 2019); see also PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018) (interpreting the statute to require “a simple yes-or-no institution choice respecting a petition, embracing all challenges included in the petition”). Having considered the arguments and evidence presented in the Petition and the Preliminary Response, for the reasons described below, we institute inter partes review.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“Office (“USPTO”) issued a Memorandum titled “Interim Procedure for Discretionary Denials in AIA Post-Grant Proceedings With Parallel District Court Litigation” (“Memorandum”)11, which states, among other things, that “the PTAB will not discretionarily deny institution in view of parallel district court litigation where a petitioner presents a stipulation not to pursue in a parallel proceeding the same grounds or any grounds that could have 11 Available at www.uspto.gov/sites/default/files/documents/interim_proc_ discretionary_denials_aia_parallel_district_court_litigation_memo_2022 0621_.pdf. reasonably been raised before the PTAB.” Memorandum 3 (citing Sotera Wireless, Inc. v. Masimo Corp., IPR2020-01019, Paper 12 (PTAB Dec. 1, 2020) (precedential as to § II.A)). By email dated November 25, 2024, Petitioner requested leave to file a Reply to Patent Owner’s Preliminary Response to address, inter alia, its proposed submission of a Sotera stipulation. Ex. 3001. We denied Petitioner’s request for briefing, but granted its request to submit the stipulation. Id. The Sotera stipulation avers that “if IPR Nos. IPR2024- 00183, IPR2024-00185, and IPR2024-00186 are instituted, National Beef will not pursue in the related district court proceeding, Inst. for Envtl. Health, Inc. v. Nat’ / Beef Packing Co., LLC, No. 1:23-cv-00826 (D. Del. Aug. 1, 2023), any ground National Beef raised or reasonably could have raised in the aforementioned IPRs,” and that the stipulation “binds National Beef in the related district court proceeding, Inst. for Envtl. Health, Inc. v. Nat'l Beef Packing Co., LLC, No. 1:23-cv-00826 (D. Del. Aug. 1, 2023).” Ex. 1064. Applying the guidance provided in the Memorandum, we decline to exercise our discretion to deny institution in this proceeding under Fintiv because Petitioner submitted a Sotera stipulation.” slip op. at 20
- BurdenInstituted
“Thus, Petitioner has accounted for each step/element of independent claims 1 and 37 as taught by the combination of ICMSF and Gombas, and has also provided a reason why, with rational underpinnings, the prior art would have been combined and modified, with a reasonable expectation of success. On the current record, including Patent Owner’s arguments that we considered and are addressed in detail below, Petitioner’s evidence for this ground is sufficient to provide a reasonable likelihood of success in demonstrating unpatentability of at least one claim.” slip op. at 31
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner
“We agree with Patent Owner that the term “lots” does not require construction because on the current record, there is no controversy over the meaning of the term, and neither Petitioner nor Patent Owner identify any way that claim construction may impact our decision. We also agree with Patent Owner that the ’771 patent provides definitions that guide the understanding of the term “lots” including: The term “test lot” or “reportable lot” as used herein to refer to an assemblage of one or more specimens of a medium or process (e.g. assemblage of specimens of air, water, solids or of products of a production process, etc.), where such assemblage can be sampled by taking portions of the one or more specimens thereof, and where the one or more specimens of the assemblage are operationally linked in a manner (e.g., proximity, time, process step, etc.) whereby information derived about sampled portions is operationally applicable to all specimens of the assemblage, and thus to the test lot. In particular instances, portions are synonymous with specimens. Ex. 1003, 5:43‒54. The ’771 patent similarly provides definitions for “product portion,” “test lot sample,” and “composite lot-unit” that provide significant guidance and clarity as to the meaning of these terms. Ex. 1003, 5:60‒6:4, 6:12‒29, 7:49‒63. See, e.g., Wellman, Inc. v. Eastman Chem. Co., 642 F.3d 1355, 1361 (Fed. Cir. 2011) (“[C]laim terms need only be construed ‘to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). We decline to expressly interpret this term at this time.” slip op. at 11
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 9,637,771
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.