- Apple Inc. v. THL Holding Company, LLCAll claims unpatentablePTAB · Jul 3, 2025 · IPR2024-00399 · APJ Christopher M Kaiser · IPR · Final written decision
Claims 11–19 are unpatentable as obvious: claims 11–14 over Kalliola, Turunen, Oswald, Vauclair, and Kalayjian; claims 15–18 with Thorn; and claim 19 with Thorn and Sharp.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner asserts that the level of ordinary skill in the art corresponds to “a bachelor’s degree in computer science, computer engineering, electrical engineering, or a similar technical field and 2-4 years of experience with wireless ranging and positioning systems, wireless communication devices, and associated computer programming.” Pet. 4 (citing Ex. 1003 ¶ 35). “Patent Owner agrees that this description reasonably represents the level of ordinary skill required to understand and implement the teachings of the ’246 Patent, as well as the prior art cited in the Petition.” PO Resp. 14 (citing Ex. 2002 ¶ 22). Accordingly, we adopt Petitioner’s proposed level of skill.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“device.” This term appears twice in claim 11, once in the phrase “an orientation sensor to detect rotation of the mobile communication device,” and once in the phrase “rotation of the mobile communication device detected by the orientation sensor.” Ex. 1001, 39:13–14, 39:36–38. Patent Owner argues that we should construe this term as limited to “detecting the rotation of the mobile communication device as a whole, not the movement of individual components.” PO Resp. 15–18. Petitioner disputes this, arguing that “rotation of the mobile communication device” should be construed not only to cover rotation of the device as a whole but also should “encompass[] any rotation of the mobile communication device relative to any object, including itself,” which would extend to rotation of “any component of the device.” Reply 4–5. We need not resolve this dispute to determine the outcome of Petitioner’s asserted challenges to the ’246 patent. As discussed more fully below, under either party’s proposed construction of “rotation of the mobile communication device,” Petitioner has shown by a preponderance of the evidence that the challenged claims are unpatentable. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (noting that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 9
- Expert testimonyOther
“On the record developed during trial, we are persuaded that Petitioner has shown by a preponderance of the evidence that Kalliola teaches “an orientation sensor to detect rotation of the mobile communication device,” where “rotation of the mobile communication device” includes rotation of the device as a whole, regardless of whether it also includes rotation of one portion of the device relative to another. Kalliola teaches “motion sensors integrated in WCD 100” that are “used to detect when WCD 100 is being moved,” as well as to detect “when user 110 moves WCD 100 too quickly for an accurate DoA estimation.” Ex. 1004 ¶¶ 84, 86. Although Patent Owner argues that Kalliola’s motion sensors do not detect rotation of the device, this is incorrect on the record as developed at trial. Kalliola teaches that the motion sensor may take “the form of a semiconductor gyroscope chip.” Id. ¶ 84. There is ample evidence that gyroscopes detect rotation. Ex. 1013, 38 (identifying as an “orientation sensor” a “[t]hree-axis gyro” and a “[d]ynamic [h]igh [r]ange [gyro]”); Ex. 1046, 49:18–20 (Dr. Feuerstein testifying that gyroscopes “can be used to detect angular velocity”); Ex. 1047 ¶ 47 (citing Ex. 1051, 170; Ex. 1053, 9) (Dr. Buehrer testifying that a person of ordinary skill in the art “would understand that gyroscopes are well-known inertial sensors that specifically detect rotational motion”). Thus, by a preponderance of the evidence, Petitioner has shown that Kalliola teaches the “orientation sensor to detect rotation of the mobile communication device” of this limitation.” slip op. at 17
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“whether Kalliola’s teaching of pausing and resuming its DoA estimation based on detected rotational motion, or Kalliola’s teaching of speeding up its DoA estimation based on detected rotational motion, amounts to determining direction based on rotation. Pet. 63–64; PO Resp. 25–27; Reply 24–27; Sur-Reply 11–14. On the record developed during trial, we are persuaded that the preponderance of the evidence supports a finding that Kalliola teaches determining direction based on rotation. First, Kalliola discloses “pausing a DoA estimation until the motion of the WCD is detected by the motion sensors,” then resuming “the updating of the DoA estimation” when motion is detected. Ex. 1004 ¶¶ 14, 84. Second, Kalliola discloses a “correction or compensation mode” that is “employed when user 110 moves WCD 100 too quickly for an accurate DoA estimation,” with this “increase[d] speed of the DoA estimation” being triggered by the “[i]ncreased activity detected by motion sensors in WCD 100.” Id. ¶ 86. As discussed above with respect to limitation 11(d), the detected motion that triggers either of these modes can be rotational motion of the WCD detected by a gyroscope.” slip op. at 22
Patent outcomesUS 11,350,246 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,350,246 - Apple Inc. v. DH International Ltd.InstitutedPTAB · Jun 25, 2025 · IPR2025-00172 · APJ Brian P Murphy · IPR · Institution
The Board instituted IPR of claims 1–20 on all petition grounds, finding a reasonable likelihood that claims 1, 10–12, and 19 are obvious over Suga and Gorsuch.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Under § 314, the Board may not institute review on fewer than all claims challenged in the petition. SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018). If the Board institutes a review, it will institute “on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a). Upon consideration of the Petition, the Preliminary Response, and the evidence of record, for the reasons set forth below, we conclude the Petition demonstrates a reasonable likelihood that Petitioner would prevail in showing the unpatentability of at least one challenged claim in the ’294 patent. Accordingly, we institute an inter partes review of claims 1–20 of the ’294 patent.” slip op. at 2
- Skill levelSkill level board ownOther
“II. ANALYSIS A. Level of Ordinary Skill in the Art Petitioner contends: A person of ordinary skill in the art at the time of the alleged invention of the ’294 Patent (“POSITA”) would have had a bachelor’s degree in Electrical Engineering, Computer Engineering, or in a similar discipline with at least two years of experience with wireless communication devices and networks. More education can substitute for practical experience and vice versa. Pet. 10 (citing Ex. 1004 ¶ 34). Patent Owner states that it “agrees with Petitioner on the level of ordinary skill in the art.” Prelim. Resp. 8 (citing Ex. 2001 ¶¶ 26–29).” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“Both parties rely on the language of claim 1 and the ’294 patent specification to support their respective constructions, and they emphasize that a user’s selective triggering of the control device does not issue different activation commands or control which data conveyance operation is used. Claim 1 recites an “invariable activation command” as a command that is “issued when said control device is selectively triggered by the user.” selectively trigger a control device “via one of a button, a keypad, a tactile screen, and a biometric parameter detector,” e.g., by entering a PIN that is authenticated, in order for an invariable activation command to be issued. Id. at 8:43–50, 10:26–29, 19:3–5. The claimed function of an invariable activation command is to “initiate[]” either a “first data conveyance operation” or a “second data conveyance operation” depending on whether “said switching element is in said first state” or “in said second state.” As explained above, the state of the switching element depends on whether or not an “activation cue” has been received by a “cue receiver.” The ’294 patent specification confirms the operation. Id. at 10:26–36, 15:14–28. The parties joust over the proper terminology for characterizing an “invariable” activation command, but they appear to agree on how the claimed cell phone and method work. The ’294 patent specification makes clear that the activation command is “invariable” in the sense that whenever a user selectively triggers the control device on the cell phone, for example by pressing a button on a keypad, the same command is issued to initiate a data conveyance operation regardless of the “state” of the “switching element” (i.e., in a “first state” or “second state”). The user cannot select or issue different activation commands. The selection of which of the two possible data conveyance operations will be initiated by selectively triggering the control device depends not on the activation command—it is always the same—but on whether the switching element has received an activation cue (“first state”) or not (“second state”). The ’294 patent neatly summarizes that “[t]he same invariable activation command will thus be issued upon [the] control device being triggered, and it is the state of [the]” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“The ’294 patent claims and specification make clear that the switching element switches between a “first state” and a “second state” depending on whether or not an activation cue is received. Ex. 1001, 9:28–41, 14:53–59. The state of the switch, in turn, “allow[s] data to be conveyed according to alternate data conveyance operations.” Id. (emphasis added). Thus, the claim limitation is recited as a “data conveyance switching element,” not a “data switch,” because the switching element allows the device to switch between alternate operations for conveying data from the cellular phone to an external data exchange device. Id. Patent Owner’s proposed construction “conflicts with the express disclosure of the ’294 Patent.” See Phillips v. AWH Corp., 415 F.3d 1303, 1315 (Fed. Cir. 2005) (en banc) (The “specification ‘is always highly relevant to the claim construction analysis. Usually, it is dispositive; it is the single best guide to the meaning of a disputed term.’”) (citation omitted). On the present record, we determine that no further construction of claim terms is necessary to determine whether to institute a trial in this case. See, e.g., Wellman, Inc. v. Eastman Chem. Co., 642 F.3d 1355, 1361 (Fed. Cir. 2011) (“[C]laim terms need only be construed ‘to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. &” slip op. at 16
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,022,294 - Apple Inc. v. DH International Ltd.Institution deniedPTAB · Jun 25, 2025 · IPR2025-00173 · APJ Brian P Murphy · IPR · Institution
Institution was denied for claims 1–13 because the petition did not show a reasonable likelihood that any challenged claim was unpatentable over the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Under § 314, the Board may not institute review on fewer than all claims challenged in the petition. SAS Inst., Inc. v. Iancu, 584 U.S. 357, 371 (2018). If the Board institutes a review, it will institute “on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a). Upon consideration of the Petition, the Preliminary Response, and the evidence of record, for the reasons set forth below, we conclude the Petition does not demonstrate a reasonable likelihood that Petitioner would prevail in showing the unpatentability of at least one challenged claim in the ’333 patent. Accordingly, we do not institute an inter partes review of claims 1–13 of the ’333 patent.” slip op. at 2
- Skill levelSkill level board ownOther
“prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC, Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citing Custom Accessories, Inc. v. Jeffrey-Allan Indus., Inc., 807 F.2d 955, 962 (Fed. Cir. 1986)). “These factors are not exhaustive but are merely a guide to determining the level of ordinary skill in the art.” Daiichi Sankyo Co. v. Apotex, Inc., 501 F.3d 1254, 1256 (Fed. Cir. 2007). There is uncontested evidence in the record before us that reflects the knowledge and experience of a POSITA. We adopt the parties’ agreed level of ordinary skill in the art, which is consistent with the description in the ’333 patent and the prior art of record.” slip op. at 10
- BurdenNot shown unpatentable
“element” (limitation [1(e)]) onto a McGregor “device” placed in an RF field generated by Palmer’s reader/writer device. Pet. 28–31 (citing Ex. 1003 ¶¶ 95–105), 41–42 (citing Ex. 1003 ¶¶ 125–127). The Petition is unclear as to which McGregor device is being referenced, e.g., the smart card of Figure 2, the wallet embodiment of Figure 4, or some combination of embodiments disclosed in McGregor and Palmer. Id. Regardless, the proposed modification of McGregor in view of Palmer, as we understand it, is based on conclusory reasoning and appears to be motivated by hindsight rather than the teachings of the applied references. Prelim. Resp. 38–40 (citing Ex. 2001 ¶¶ 97–102). 7 Ground 2 challenges independent claim 11 for asserted obviousness over McGregor, Palmer, and Tuttle. The Petition’s reliance on Tuttle for its teaching of distinct data transmitter, data receiver, and cue receiver ports does not alter our analysis for claim 11. Pet. 55–62. POSITA would have understood that a series of instructions would be programmed into McGregor’s microprocessor to function as a switching element (pursuant to Palmer’s teachings), and as described.in the ’333 Patent. See Claim [1(b)]; see ’333 Patent, 6:9-14. Accordingly, McGregor’s microprocessor is a switching element (1) that is placed into an activated state after receiving a handshake signal (an activation cue) that establishes a communication during the handshake process and (2) that remains in an inactivated state if no reader/writer device is detected (no activation cue). Ex. 1003 ¶ 127 (emphases added). Dr. Buehrer’s citation to the ’333 patent, without explaining his mapping of limitation [1(e)] onto McGregor-Palmer beyond a general reference to 10-plus pages of limitation [1(b)] “control device” analysis, suggests hindsight reasoning. Id; see also Pet. 42 (generally referring to limitation [1(b)]). The Petition’s analysis, moreover, does not address why or how McGregor’s microprocessor would “accordingly” act as a data conveyance switching element or why a POSITA would want to program McGregor’s microprocessor to execute such a switching function in view of Palmer. We find the Petition and Dr. Buehrer’s testimony lacking in articulated reasoning supported by rational underpinnings sufficient to support the conclusion that limitation [1(e)] reads on the proposed McGregor-Palmer combination. See KSR, 550 U.S. at 418 (“there must be some articulated reasoning with some rational underpinning to support the legal conclusion of obviousness”).” slip op. at 16
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“element” (limitation [1(e)]) onto a McGregor “device” placed in an RF field generated by Palmer’s reader/writer device. Pet. 28–31 (citing Ex. 1003 ¶¶ 95–105), 41–42 (citing Ex. 1003 ¶¶ 125–127). The Petition is unclear as to which McGregor device is being referenced, e.g., the smart card of Figure 2, the wallet embodiment of Figure 4, or some combination of embodiments disclosed in McGregor and Palmer. Id. Regardless, the proposed modification of McGregor in view of Palmer, as we understand it, is based on conclusory reasoning and appears to be motivated by hindsight rather than the teachings of the applied references. Prelim. Resp. 38–40 (citing Ex. 2001 ¶¶ 97–102). 7 Ground 2 challenges independent claim 11 for asserted obviousness over McGregor, Palmer, and Tuttle. The Petition’s reliance on Tuttle for its teaching of distinct data transmitter, data receiver, and cue receiver ports does not alter our analysis for claim 11. Pet. 55–62. POSITA would have understood that a series of instructions would be programmed into McGregor’s microprocessor to function as a switching element (pursuant to Palmer’s teachings), and as described.in the ’333 Patent. See Claim [1(b)]; see ’333 Patent, 6:9-14. Accordingly, McGregor’s microprocessor is a switching element (1) that is placed into an activated state after receiving a handshake signal (an activation cue) that establishes a communication during the handshake process and (2) that remains in an inactivated state if no reader/writer device is detected (no activation cue). Ex. 1003 ¶ 127 (emphases added). Dr. Buehrer’s citation to the ’333 patent, without explaining his mapping of limitation [1(e)] onto McGregor-Palmer beyond a general reference to 10-plus pages of limitation [1(b)] “control device” analysis, suggests hindsight reasoning. Id; see also Pet. 42 (generally referring to limitation [1(b)]). The Petition’s analysis, moreover, does not address why or how McGregor’s microprocessor would “accordingly” act as a data conveyance switching element or why a POSITA would want to program McGregor’s microprocessor to execute such a switching function in view of Palmer. We find the Petition and Dr. Buehrer’s testimony lacking in articulated reasoning supported by rational underpinnings sufficient to support the conclusion that limitation [1(e)] reads on the proposed McGregor-Palmer combination. See KSR, 550 U.S. at 418 (“there must be some articulated reasoning with some rational underpinning to support the legal conclusion of obviousness”). The Petition does assert an obviousness theory within the analysis of the “control device” limitation [1(b)]. Pet. 25–35 (citing Ex. 1003 ¶¶ 85– 109). The Petition asserts that a “POSITA would have been motivated to implement McGregor’s device pursuant to Palmer such that the security code would be automatically transmitted when the device detects the receive the security code.” Pet. 28; see also id. at 31 (“A POSITA would have been motivated to implement Palmer’s (1) RF field detection and handshake processes and (2) Palmer’s transceiver hardware in McGregor’s device.”) (citing Ex. 1003 ¶¶ 95–105). We find the Petition’s obviousness theory to be inherently inconsistent and non-specific with regard to the “data conveyance switching element” recited in limitation [1(e)].” slip op. at 16
§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,628,333 - PTAB · Jun 25, 2025 · IPR2024-01280 · APJ Jo-Anne M Kokoski · IPR · Remand
On remand, the Board denied institution under § 314(a), finding the Fintiv factors favored denial despite declining to deny under § 325(d).
RulingsRemand decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDecided for petitioner
“Other than initials on a lengthy IDS, nothing in the record indicates that the Examiner substantively considered Takeuchi, Kim, Pienemann, or among over 1,000 other references listed on the IDS, which, as noted in the Director Review Decision, “is over 40 times the size of a typical IDS.” Pet. Remand Br. 5–6; DR Dec. 7 n.3 (citing Setting and Adjusting Patent Fees During Fiscal Year 2025, 89 FR 91898 at 91924 (Nov. 20, 2024)); Ex. 1002, 228–284. Petitioner also shows that the applicant did not respond to the Examiner’s request that the applicant specifically point out “any particular reference or portion of a reference in the [IDS] which the examiner should take [sic] pay particular attention to.” Ex. 1002, 174, 295– 302.” slip op. at 13
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivInstitution denied
“Patent Owner is likely correct that the ITC would not have been inclined to grant a stay if one had been requested at the time the Institution Decision issued. Moreover, the ITC conducted a full evidentiary hearing a month after the Institution Decision issued, and the target date for the ITC’s final determination is several months before the projected statutory deadline for the Board’s final written decision. PO Remand Br. 7. Accordingly, we determine that Fintiv factor 1 weighs in favor of discretionary denial. See also Klein Tools, Inc. v. Milwaukee Electric Tool Corp., IPR2024-01400, Paper 22 at 2 (PTAB June 9, 2025) (Acting Director Stewart determining that Fintiv factor 1 weighs in favor of discretionary denial when the ITC investigation is unlikely to be stayed, the ITC already conducted a full evidentiary hearing, and the ITC final determination is expected to issue six months before the statutory deadline for the Board’s final written decision).” slip op. at 19
Discretionary denialcites PhillipsPatents in suitUS 11,925,202 - PTAB · Jun 25, 2025 · IPR2024-01406 · APJ Jo-Anne M Kokoski · IPR · Remand
On remand, the Board denied institution of review of claims 1, 3, 4, 8–13, and 15 under § 314(a), finding the Fintiv factors favored discretionary denial.
RulingsRemand decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“stay or evidence exists that one may be granted if a proceeding is instituted.” Fintiv, Paper 11 at 6. A stay of litigation pending resolution of an inter partes review allays concerns about inefficiency and duplication of efforts, and strongly weighs against exercising our authority to deny institution. Fintiv, Paper 11 at 6. The Guidance Memo states that “the Board will apply the Fintiv factors when there is a parallel proceedings at the International Trade Commission.” Guidance Memo 2. Patent Owner asserts that a stay of the ITC Investigation had not been requested at the time of the Institution Decision,7 and argues that “the ITC does not stay investigations pending IPR.” PO Supp. Br. 4. Patent Owner also notes that the Institution Decision issued “just days before the ITC evidentiary hearing.” Id. Accordingly, Patent Owner argues that this factor favors denial. Id. Patent Owner is likely correct that the ITC would not have been inclined to grant a stay if one had been requested at the time the Institution Decision issued. Moreover, the ITC conducted a full evidentiary hearing less than three weeks after the Institution Decision issued, and the target date for the ITC’s final determination is four months before the statutory deadline for the Board’s final written decision. PO Supp. Br. 5. Accordingly, we” slip op. at 9
Discretionary denialPatents in suitUS 11,925,202 - PTAB · Jun 18, 2025 · IPR2025-00321 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR on claims 1, 2, 5–7, 9, 16, and 17, finding a reasonable likelihood that claim 1 is anticipated by Boyer.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“approximately two weeks before the statutory deadline for a final written decision, but the most recent median time-to-trial statistics for Judge Gilstrap in the Eastern District of Texas indicate that the actual trial date will likely be in July 2026, which is later than the statutory deadline to issue a final written decision in this proceeding in mid-June 2026. See Ex. 2001, 7 (median time from filing to trial of 23.2 months); Prelim. Resp. 10. Thus, we find this factor is neutral or weighs slightly against discretionary denial.” slip op. at 10
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this preliminary stage, we determine whether the information presented shows a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been unpatentable over the proposed prior art. We analyze the asserted grounds with the above-noted principles in mind.” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had (1) at least a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a related field, and (2) at least two years of research or industry experience in 3D printing or materials used for 3D printing.” Pet. 5 (citing Ex. 1003 ¶¶ 14–16). Petitioner also argues that “[a]dditional experience could substitute for a formal degree or formal training (and vice versa).” Id. Patent Owner proposes a slightly different level of skill, arguing that a person of ordinary skill in the art “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 24. Neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears to be consistent with the ’713 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 16
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction needed
“We note that, as discussed below, we are able to determine whether to institute inter partes review of the ’713 patent without expressly construing the term “from multiple print heads or deposition lines.” See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). As for Patent Owner’s argument that Petitioner has failed to carry its burden to identify how the claims are to be construed, we disagree on the present record. Although Petitioner does not provide a preferred construction for the single term it proposes requires construction, Petitioner does identify which of its two alternative constructions applies to each of its asserted grounds of unpatentability. Pet. 6 (“Under the first construction, [the obviousness grounds] are applicable, and [the anticipation ground] would be excluded from the claim scope. Under the alternative construction, all of [the asserted grounds] are applicable.”). In our view, this approach does not fail to satisfy Petitioner’s burden under 37 U.S.C. § 42.104(b)(3).” slip op. at 17
Claim construction§ 102 anticipationDiscretionary denialcites PhillipsPatents in suitUS 9,421,713 - PTAB · Jun 18, 2025 · IPR2025-00311 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR of claims 1, 3–11, and 17–22 on all asserted grounds because Petitioner showed a reasonable likelihood of prevailing on claim 1 over Mazumder and Mori.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“based on Petitioner’s first stipulation filed on December 18, 2024.15 Prelim. Resp. 13–15. Patent Owner does not address Petitioner’s updated second stipulation filed on April 8, 2025. This updated second stipulation mitigates any concerns of duplicative efforts between the district court and the Board, as well as concerns of any potentially conflicting decisions. See Sand at 12. We therefore find that this factor weighs against exercising discretion to deny institution. See id., n.5. 5. Whether Petitioner and the Defendant in the Parallel Proceeding are the Same Party Whereas Petitioner does not address factor 5, Patent Owner argues that the parties to this proceeding are both in the related district court litigation. Pet. 98–99; Prelim. Resp. 15. While it is common in IPR proceedings for the petitioner and patent owner to also be parties in a related district court proceeding, this factor weighs slightly in favor of discretionary denial. Fintiv, Paper 11 at 13–14.” slip op. at 15
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“c) Conclusion Regarding Claim 1 Based on the current record, we determine that there is a reasonable likelihood that Petitioner will prevail in demonstrating that claim 1 is unpatentable as obvious over the combination of Mazumder and Mori. Accordingly, we institute inter partes review with respect to all claims and all grounds asserted in the Petition. 5. Claims 3, 5–7, 9, 10, and 19–22 Because Petitioner demonstrates a reasonable likelihood of success in proving that at least one claim of the ’324 patent is unpatentable, we institute on all grounds and all claims raised in the Petition. See 37 C.F.R. § 42.108(a). Therefore, at this stage of the proceeding, it is not necessary for us to provide an assessment of every challenge raised by Petitioner, especially, as in this case, when Patent Owner does not separately argue those claims. See Prelim. Resp. 28–46. Those challenges, in our view, are best left for trial after full development of the record.” slip op. at 27
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“reference must be analogous art to the claimed invention. In re Bigio, 381 F.3d 1320, 1325 (Fed. Cir. 2004). For a reference to be analogous art, it must be “either in the field of the applicant's endeavor or [be] reasonably pertinent to the problem with which the inventor was concerned.” In re Kahn, 441 F.3d 977, 986-87 (Fed. Cir. 2006) (citing In re Oetiker, 977 F.2d 1443, 1447 (Fed. Cir. 1992)). “A reference is reasonably pertinent if, even though it may be in a different field from that of the inventor's endeavor, it is one which, because of the matter with which it deals, logically would have commended itself to an inventor's attention in considering his problem.” In re Clay, 966 F.2d 656, 659 (Fed. Cir. 1992).” slip op. at 20
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“Mazumder because “the presentation of both image types would have beneficially aided the remote user to more easily visually compare the actual image and virtual image to quickly identify any defects or problems with the fabrication process.” Pet. 23–24 (citing Ex. 1003 ¶ 113). Patent Owner argues that “it is hindsight to use ‘the invention to define the problem the invention solves.’” Prelim. Resp. 43 (quoting Mintz v. Dietz & Watson, Inc., 679 F.3d 1372, 1377 (Fed. Cir. 2012); citing AT&T Services Inc. et. al. v. Innovative Sonic Ltd., IPR2024-001143 (PTAB Feb. 11, 2025)). According to Patent Owner, because neither Mazumder nor Mori teaches visual comparison of image types, the idea to improve the Mazumder-Mori combination by simultaneously displaying different image types and thus permitting visual comparison must be driven by hindsight. Id. at 44–45. But Petitioner cites evidence other than the ’324 patent to support the person of ordinary skill in the art having a desire to visually compare the different images presented in the Mazumder-Mori combination. Pet. 23–24 (citing Ex. 1003 ¶ 113). Specifically, Dr. Wolfe testifies that “the presentation of the actual images captured by the camera and the virtual images simultaneously within the user interface would have beneficially aided the remote user to more easily visually compare the actual image and virtual image to quickly identify any defects or problems with the fabrication process” and that a person of ordinary skill in the art would have recognized this. Ex. 1003 ¶ 113. Thus, Petitioner has shown sufficiently for the purpose of the present decision that Mori teaches or suggests the disputed limitation of claim 1. We encourage the parties to develop the arguments and the record surrounding this issue further during the trial.” slip op. at 26
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,562,324 - Njoy, LLC / Njoy Holdings, Inc. v. Juul Labs, Inc.No claims unpatentablePTAB · Jun 10, 2025 · IPR2024-00231 · APJ Avelyn M Ross · IPR · Final written decision
Claims 14–16, 18, 27–29, 31, and 32 were not proven unpatentable because the asserted references failed to establish the claimed airflow path or a reason to make the proposed combinations.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner’s and Patent Owner’s proposed levels of skill are similar and differ in that Petitioner’s relevant degrees and corresponding two years of experience additionally includes “industrial design” and “product design” and familiarity with “electrically powered vaporizing articles, their components or the underlying technologies” where Patent Owner requires two years of experience “designing electro-mechanical consumer products or an advanced degree.” Compare Pet. 7, with PO Resp. 2. Patent Owner alleges that “Petitioner has failed to establish unpatentability under either standard,” indicating that the level of skill in the art is not a dispositive issue. PO Resp. 3. In light of the record before us, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art. Based on our review of the ’123 patent and the prior art of record, we determine that the definition offered by Petitioner comports with the qualifications a person would have needed to understand the ’123 patent and the prior art. We note that the outcome of this Decision would be the same under Patent Owner’s proposed definition.” slip op. at 11
- Expert testimonyPetitioner expert creditedOther
“In this case, Mr. McAlexander meets both Petitioner’s and Patent Owner’s proposed level of skill in the art. As a result, we are persuaded Mr. McAlexander has the requisite skill and relevant expertise to offer testimony in this matter. For example, Mr. McAlexander has a Bachelor’s Degree in Electrical Engineering and far more than 2 years of experience in the electrical engineering field. Ex. 1027, 3–6, 7. In addition, Mr. McAlexander has provided expert consulting services in a wide range of technology areas involving the process and design of electro-mechanical consumer products. Ex. 1003 ¶ 5. Through one of Mr. McAlexander’s business ventures, his laboratory has “performed detailed airflow analyses, designing and constructing specialized apparatuses to emulate human breath, allowing for precise activation testing of ENDS devices.” Ex. 1043 ¶ 16. That said, a declarant’s expertise, even clothed as a skilled artisan, does not entitle a naked opinion persuasive weight. Ashland Oil, Inc. v. Delta Resins & Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985). Here, Patent Owner had the opportunity to, and in fact did, thoroughly cross examine Mr. McAlexander about the purported deficiencies in his testimony. See, e.g., Exs. 2052, 2054; Daubert v. Merrell Dow Pharm., Inc., 509 U.S. 579, 595 (1993) (“Vigorous cross examination [and] presentation of contrary evidence . . . are the traditional and appropriate means of attacking shaky but admissible evidence.”). Therefore, to the extent Patent Owner credibly identifies deficiencies in Mr. McAlexander’s testimony or that testimony lacks factual support or is based on broad, conclusory assertions, we will assign appropriate weight. See Velander v. Garner, 348 F.3d 1359, 1371 (Fed. Cir. 2003) (explaining that it is within the Board’s discretion, as the trier of fact, to accord appropriate weight to the evidence presented).” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner contends that the parties proposed a construction for “pressure valve,” a limitation appearing in claims 18 and 31, during the ITC investigation. Pet. 7 (citing Ex. 1001, 41:58–65). Patent Owner contends that the terms of the ’123 patent should be given their plain and ordinary meaning. PO Resp. 4. Because resolution of the issues presented in this case do not require construction of the term “pressure valve,” we do not expressly construe this claim term. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (holding that “only those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs. in the context of an inter partes review).” slip op. at 14
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“We agree with Patent Owner. To anticipate a claim, a reference “must not only disclose all elements of the claim within the four corners of the document, but must also disclose those elements ‘arranged as in the claim.’” Net MoneyIN, 545 F.3d at 1369. “The requirement that the prior art elements themselves be arranged as in the claim means that the claims cannot be treated . . . as mere catalogs of separate parts, in disregard of the part-to-part relationships set forth in the claims.” Therasense, Inc. v. Becton, Dickinson & Co., 593 F.3d 1325, 1332 (Fed. Cir. 2010). Indeed, the prior art reference “must clearly and unequivocally disclose the claimed [invention] or direct those skilled in the art to the [invention] without any need for picking, choosing, and combining various disclosures not directly related to each other by the teachings of the cited reference.” Net MoneyIN, 545 F.3d at 1371 (citation omitted). “[D]ifferences between the prior art reference and the claimed invention, however slight, invoke the question of obviousness, not anticipation.” Id.” slip op. at 20
Patent outcomesUS 10,130,123 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,130,123 - Precision Cancer Technologies Inc. v. Oncoustics Inc.Institution deniedPTAB · Jun 3, 2025 · IPR2025-00242 · APJ David Cotta · IPR · Institution
The Board denied institution on claims 1–20 because Petitioner did not show a reasonable likelihood of prevailing on any asserted anticipation or obviousness ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Under 35 U.S.C. § 314(a), inter partes review may not be instituted unless the Petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Petitioner has not established a reasonable likelihood of prevailing on its assertion that any of the challenged claims are unpatentable based on the grounds advanced here. Thus, for reasons explained below, we deny institution of inter partes review of claims 1–20 of the ’330 patent.” slip op. at 2
- Claim Construction › Intrinsic evidence (Phillips canons) › Prosecution history disclaimer / disavowalDisclaimer foundDecided for patent owner
“area” in the challenged claims was added by amendment. Ex. 1004, 181.8 In making the amendment, Applicant stated that the language added by amendment was intended to distinguish the pending claims over Uniyal,9 which Applicant characterized as disclosing a “time series” of ultrasound data. Uniyal relies on a time series of ultrasound data. In order to distinguish Uniyal, the claims have been amended to recite a single static set of ultrasound RF data in a single frame of the tissue area. As explained in the Interview, the claims rely on a signle [sic, single] “snapshot” frame of the ultrasound RF data rather than a time series or [sic, of] RF data as disclosed in Uniyal. Applicant respectfully submits the amended claims are allowable over all of the cited reference. Id. at 186–187; see also id. at 185 (Applicant’s remarks accompanying amendment, stating: “As explained in the Interview, a static set of raw ultrasound RF signals is collected for an area. This is a snapshot of the tissue area as opposed to taking a time series of RF signals”), 191 (Examiner interview summary, stating: “Inventor noted that Uniyal uses a time series US [ultrasound] data whereas the invention uses images that are non-coherent in time (e.g., a static frame)”).” slip op. at 9
- Expert testimonyPetitioner expert discountedDecided for patent owner
“transducer, Petitioner points to Hope-Simpson’s teaching that its neural network may be “capable of ‘analyzing patterns using a with a [sic] multi-dimensional (2-or more dimensional) data set, which may also be thought of as localized data sets.’” Id. at 22 (quoting Ex. 1005 ¶ 6; alteration by Petitioner). Petitioner then asserts that “[t]he localized data sets described by Hope-Simpson are equivalent to the claimed ‘single set of raw ultrasound [RF] data forming a single frame of a tissue area.” Pet. 22 (citing Ex. 1002 ¶ 86 (testimony of Dr. Papanicolau)). But Petitioner does not explain why Hope-Simpson’s “localized data sets” equate with a single frame of a tissue area rather than, for example, a time series of frames taken at the same location. Pet. 22. Petitioner cites the testimony of Dr. Papanicolau, but Dr. Papanicolau’s testimony lacks both technical reasoning and evidentiary support; it simply mirrors the statement in Petition. Ex. 1002 ¶ 86. For this reason, we give Dr. Papanicolau’s ipse dixit testimony little weight. Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 9 at 15 (PTAB Aug. 24 ,2022) (Decision Denying Institution) (precedential) (finding that conclusory testimony that “does not cite to any additional supporting evidence or provide any technical reasoning to support [that testimony] . . . is entitled to little weight”); see also, 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”). Accordingly, to the extent this is the data that Hope Simpson provides to the processor, on this record, Petitioner has not sufficiently established that it constitutes a “single static set” of raw RF ultrasound data “forming a single frame.”” slip op. at 15
Claim constructioncites KSR · GrahamPatents in suitUS 11,602,330 - Abbott Laboratories v. Newtonoid Technologies, L.L.C.Adverse judgmentPTAB · May 29, 2025 · IPR2024-00932 · APJ Mary C Hoffman · IPR · Adverse judgment
The Board granted Patent Owner’s request for adverse judgment, terminated the trial, and cancelled claims 1 and 4–20.
RulingsAdverse judgment- Adverse judgmentAdverse judgmentGranted
“Our rules provide that “[a] party may request judgment against itself at any time during a proceeding.” 37 C.F.R. § 42.73(b). We understand Patent Owner’s May 19, 2025 email as a request for judgment against itself. Accordingly, on the record before us, we enter adverse judgment against Patent Owner pursuant to 37 C.F.R. § 42.73(b) and terminate the trial pursuant to 37 C.F.R. § 42.72. Accordingly, it is: ORDERED that Patent Owner’s May 19, 2025 email request for adverse judgment pursuant to 37 C.F.R. § 42.73(b) is granted;” slip op. at 3
NonePatents in suitUS 11,392,818
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.