- Innoscience America, Inc. v. Infineon Technologies Americas Corp.Institution deniedPTAB · May 16, 2025 · IPR2025-00010 · APJ Michelle N Wormmeester · IPR · Institution
The Board denied institution of IPR challenging claims 1–14, exercising § 314(a) discretion under Fintiv because the balance of factors favored denial.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“2. Factor 2: ITC Final Determination Date Fintiv provides that an ITC trial date that is earlier than the Board’s projected statutory deadline for a final written decision may favor discretionary denial if the ITC is going to decide the same or substantially similar issues to those presented in the petition. Fintiv, Paper 11 at 8. The Guidance Memo further provides that “the Board is more likely to deny institution where the ITC’s projected final determination date is earlier than the Board’s deadline to issue a final written decision.” Guidance Memo 2. Here, the ITC has set the target date for its final determination to March 2, 2026. Ex. 2010, 3 (ITC Order Amending the Procedural Schedule). Our final written decision would be due almost three months later, in late May 2026, should we institute inter partes review.” slip op. at 8
Discretionary denialPatents in suitUS 9,070,755 - PTAB · Apr 30, 2025 · IPR2024-01493 · APJ John D Hamann · IPR · Institution
The Board instituted IPR on claims 1–15 and all asserted grounds after finding a reasonable likelihood that claim 1 was obvious over Bowen and Sunai.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2024); see 37 C.F.R. § 42.108 (2024). Upon consideration of the papers, we conclude that the information presented shows that there is a reasonable likelihood that Petitioner would prevail in establishing the unpatentability of at least one challenged claim of the ’167 patent.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner argues that one of ordinary skill in the art would have had “a Ph.D. in electrical engineering, physics, materials science, or a related field, and at least one year of experience in the research, design, and/or development of magnetic/spintronic devices, or the equivalent,” or “a Master’s degree in electrical engineering, physics, materials science, or a related field, and four years of experience in the research, design, and/or development of magnetic/spintronic devices, or the equivalent.” Pet. 20 (citing Ex. 1024 ¶ 25). Petitioner adds that “[l]ess work experience may be compensated by a higher level of relevant education, and vice versa.” Id. Patent Owner does not identify a level of skill in the art that one would have had at the time of the invention of the ’167 patent or identify any shortcoming in Petitioner’s formulation. Prelim. Resp. 18. For purposes of this Decision, we adopt Petitioner’s definition of the level of skill for one of ordinary skill in the art. Pet. 20. We view this definition for the level of ordinary skill to be consistent with the ’167 patent and the asserted prior art, and we apply it in our analysis below.” slip op. at 6
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for petitioner
“same claim construction standard that would be used in a civil action under 35 U.S.C. § 282(b), following the standard articulated in Phillips v. AWH Corp., 415 F.3d 1303 (Fed. Cir. 2005) (en banc). 37 C.F.R. § 42.100(b); 83 Fed. Reg. 51,340, 51,340–41, 51,343 (Oct. 11, 2018). In applying such standard, claim terms generally are given their ordinary and customary meaning, as would be understood by a person of ordinary skill in the art, at the time of the invention and in the context of the entire patent disclosure. Phillips, 415 F.3d at 1312–13. “In determining the meaning of the disputed claim limitation, we look principally to the intrinsic evidence of record, examining the claim language itself, the written description, and the prosecution history, if in evidence.” DePuy Spine, Inc. v. Medtronic Sofamor Danek, Inc., 469 F.3d 1005, 1014 (Fed. Cir. 2006) (citing Phillips, 415 F.3d at 1312–17). Here, neither party sets forth any term for claim construction. Pet. 17; see generally Prelim. Resp. Thus, for purposes of this Decision, we afford the claim terms their plain and ordinary meaning. See, e.g., Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’”)).” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“Second, on this record we agree that one of ordinary skill in the art would have been motivated to substitute Sunai’s CoFeB layer for Bowen’s Fe layer to increase the tunnel magnetoresistance ratio (“TMR”) of Bowen’s MTJ. Pet. 24; Ex. 1055,9 2269–70 (“The benefit of using CoFeB” includes “a higher TMR value.”), 2270 (“[I]t is natural to replace both the free and pinned layers to CoFeB to further increase the TMR value.”); Ex. 105610 ¶ 39 (“[A]n amorphous layer comprised of a CoFeB alloy . . . exhibits a larger TMR ratio.”), ¶¶ 67–68 (“In the construction[,] . . . ferromagnetic layers 5, 7 are made of an FeCoB[11] . . . material containing B so as to have 9 Dexin Wang et al., 70% TMR at room temperature for SDT sandwich junctions with CoFeB as free and reference layers, 40 IEEE Trans. Magn. 2269–71 (July 2004). 10 US 2004/0136232 A1, published July 15, 2004. 11 We are persuaded by Dr. Bokor’s testimony that “a skilled artisan [would have] understood that CoFeB and FeCoB refer to the same alloy.” Ex. 1024 ¶ 121. ratio.”); Ex. 1024 ¶ 129. Moreover, as Petitioner explains, “[r]esearchers were . . . interested in optimizing MTJs to improve MRAM performance,” and “[h]igher TMRs long promised improved performance for MRAM.” Pet. 6 (citing Ex. 1026, 1655; Ex. 1045,12 1; Ex. 1049,13 186; Ex. 1024 ¶¶ 31, 36–44) (emphasis omitted). In addition, on this record we agree with Petitioner that Bowen and Sunai teach forming an MgO barrier layer and ferromagnetic alloy electrodes. Pet. 25–26 (citing Ex. 1026, 1655, Abstract; Ex. 1030 ¶¶ 24, 35; Ex. 1024 ¶ 126). And we also agree that one of ordinary skill in the art would have had a reasonable expectation of success in modifying Bowen as forming electrodes with CoFeB alloys was known. Id. at 26.” slip op. at 12
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 10,680,167 - PTAB · Apr 30, 2025 · IPR2024-01494 · APJ Justin T Arbes · IPR · Institution
The Board instituted review of claims 5, 6, and 9–20 on all asserted grounds after finding a reasonable likelihood that claim 5 would have been obvious over Bowen and Soukup.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Pursuant to 35 U.S.C. § 314(a), the Director may not authorize an inter partes review unless the information in the petition and preliminary response “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” See 37 C.F.R. § 42.4(a) (“The Board institutes the trial on behalf of the Director.”). For the reasons that follow, we institute an inter partes review as to claims 5, 6, and 9–20 of the ’909 patent on all grounds of unpatentability asserted with respect to those claims in the Petition.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“We disagree with Patent Owner’s arguments based on the current record. Dr. Bokor testifies that “as is evident from the TMR equation, . . . lowering the resistance (barrier height) for parallel spin electrons [(i.e., Rp)] compared to antiparallel [(i.e., Rap)] improved TMRs.” Ex. 1024 ¶ 169 (citing Ex. 1035, 3273) (emphasis added). Dr. Bokor’s testimony is consistent with the TMR equation above, which has Rp as the only term in the denominator, and reflects that Rp would be lowered disproportionally, or otherwise the TMR would not have “improved.” Id. It also appears to be supported by other evidence of record. See Ex. 1035, 3273 (noting the” slip op. at 17
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element) › Inherent disclosureInherency not foundNot shown unpatentable
“Finally, we note that, although Petitioner has made a sufficient showing with respect to obviousness, we are not persuaded by Petitioner’s inherency argument. See Pet. 36. Specifically, Petitioner has not established that a barrier height of 0.1–0.85 eV is necessarily present in, or the natural result of, a tunnel barrier layer having some amount of oxygen vacancy defects. See Hospira, Inc. v. Fresenius Kabi USA, LLC, 946 F.3d 1322, 1329 (Fed. Cir. 2020) (“When the prior art does not expressly disclose a claim limitation, ‘inherency may supply a missing claim limitation in an obviousness analysis.’ . . . Inherency is established in the context of obviousness when ‘the limitation at issue necessarily must be present, or the natural result of the combination of elements explicitly disclosed by the prior art.’”). Petitioner points to the ’909 patent’s statement that “[w]hen there are oxygen vacancy defects, the potential barrier height of the MgO tunnel barrier is thought to decrease (such as in the range of 0.10 to 0.85 eV; more specifically, 0.2 to 0.5 eV), which is thought to result in an increase in the tunneling current.” Ex. 1017, col. 7, ll. 19–23; see Pet. 36. Bowen, however, has “oxygen vacancy defects” in its MgO layer and “[o]xygen vacancies are naturally present in every oxide” according to Petitioner, but Bowen discloses a barrier height of 0.9 eV, which is outside the claimed range (albeit only slightly). Pet. 13, 23–24. Thus, Bowen contradicts Petitioner’s assertion that a barrier height within the claimed range of 0.1–0.85 eV is inherent when there are oxygen vacancy defects.” slip op. at 23
- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art Petitioner argues that at the time of the ’909 patent (2004), a person of ordinary skill in the art would have had “a Ph.D. in electrical engineering, physics, materials science, or a related field, and at least one year of experience in the research, design, and/or development of magnetic/spintronic devices, or the equivalent,” or “a Master’s degree in electrical engineering, physics, materials science, or a related field, and four years of experience in the research, design, and/or development of magnetic/spintronic devices, or the equivalent,” where “[l]ess work experience may be compensated by a higher level of relevant education, and vice versa.” Pet. 18–19 (citing Ex. 1024 ¶ 25). Patent Owner applies Petitioner’s definition of the level of ordinary skill in the art for purposes of its Preliminary Response. Prelim. Resp. 17. Based on the record presented, including our review of the ’909 patent and the types of problems and solutions described in the ’909 patent and cited prior art, we agree with Petitioner’s proposed definition of the level of ordinary skill in the art and apply it for purposes of this Decision.” slip op. at 9
Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,968,909 - Lam Research Corp. v. Inpria Corp.All claims unpatentablePTAB · Apr 18, 2025 · IPR2024-00033 · APJ Grace Karaffa Obermann · IPR · Final written decision
Claims 1–12 are unpatentable as anticipated by the ’888 Publication; Patent Owner’s motion to add substitute claims 13–23 is granted.
RulingsFinal written decision- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportDecided for petitioner
“priority issue are based on the cited disclosures of the ’867 application discussed above. Ex. 2009 ¶ 29. For the reasons discussed above, we do not view the cited disclosures as sufficiently supporting Dr. Banerjee’s conclusion that the ’867 application provides support for claim 1’s average thickness range (id.) and, therefore, give this testimony little weight. Stated somewhat differently, Dr. Banerjee’s advances an opinion (really a legal one) that is not supported by the facts and not in line with the caselaw discussed in this section (such as RAI).” slip op. at 26
- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityReference is prior artPrinted publication establishedDecided for petitioner
“priority issue are based on the cited disclosures of the ’867 application discussed above. Ex. 2009 ¶ 29. For the reasons discussed above, we do not view the cited disclosures as sufficiently supporting Dr. Banerjee’s conclusion that the ’867 application provides support for claim 1’s average thickness range (id.) and, therefore, give this testimony little weight. Stated somewhat differently, Dr. Banerjee’s advances an opinion (really a legal one) that is not supported by the facts and not in line with the caselaw discussed in this section (such as RAI).” slip op. at 26
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“d) Conclusion For the reasons discussed above, Petitioner has demonstrated by a” slip op. at 30
- PTAB / AIA Trials › Motions to amend / substitute claimsMotion to amend, grantedGranted
“For these reasons, Patent Owner has met its burden to show by a” slip op. at 34
Patent outcomesUS 9,823,564 unpatentable§ 102 anticipationcites Phillips · KSR · Graham · NautilusPatents in suitUS 9,823,564 - PTAB · Apr 10, 2025 · IPR2024-01431 · APJ Brian D Range · IPR · Institution
The Board instituted review of claims 2–6, 28, and 33–37 based on all petition grounds, finding a reasonable likelihood that Haddad138 renders claims 2–6 and 33–37 obvious and Yap anticipates or renders claim 28 obvious.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“arguments, and evidence presented in the parallel proceeding.” Fintiv at 12 (emphasis added). Here, due to Petitioner’s stipulation, the record does not 9 To the extent Patent Owner’s argument emphasizes that the parties have completed substantial work regarding references asserted in the petition here (PO Fintiv Surreply 1–3), this argument addresses to Fintiv factor three rather than factor four. support that the Petition’s invalidity grounds have been or will be presented to the ITC for consideration on the merits. The record also does not support that the ITC will ever adjudicate the invalidity grounds raised here10 and does not support that the ITC will ever address the dependent claims at issue here. This is, therefore, not a situation where the ITC Investigation will “resolve key issues in the petition.” Fintiv at 13. Thus, this factor weighs against discretionary denial. 7. Fintiv Factor Five: Overlapping Parties Petitioner is the same party as the respondent in the ITC investigation,” slip op. at 15
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The following findings of fact and conclusions of law are not final, but are made for the sole purpose 1 Petitioner calls “IPR2024-01431 (‘Petition B’).” See Paper 3 (PETITIONER’S EXPLANATION OF PARALLEL PETITIONS CHALLENGING U.S. PATENT NO. 11,069,737), 1. of determining whether Petitioner meets the threshold for instituting review. Any final decision shall be based on the full trial record, including any response timely filed by Patent Owner. Any arguments not raised by Patent Owner in a timely filed response may be forfeited. For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We hereby institute an inter partes review as to claims 2–6, 28, and 33–37 of the ’737 patent based upon Petitioner’s asserted challenges to patentability.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“Patent Owner argues11 that Petitioner “offers no motivation to modify Haddad138.” Prelim. Resp. 7–8. Patent Owner specifically argues that 11 Patent Owner also argues that Petitioner does not establish that Haddad138 anticipates claim 2. Prelim. Resp. 5–7. We do not address the anticipation challenge at this time. “Petitioner does not offer any showing on any motivation to modify Figure 9 of Haddad138 to change the configuration from a FSI to BSI architecture.” Id. at 8. On this record, Patent Owner’s argument does not undermine Petitioner’s persuasive showing. As Petitioner argues (Pet. 29), Haddad138 teaches that its “present disclosure” (which would include the Figure 9 disclosure) can be adapted for a front side illumination (FSI) or back side illumination (BSI) configuration. Ex. 1012 ¶ 48. The express teaching of Haddad138 provides motivation to modify Figure 9 of Haddad138. Patent Owner also argues that Petitioner “offers no showing that a POSITA would be able to modify the embodiment of Figure 9 to be back side illuminated with a reasonable expectation of success.” Prelim. Resp. 9. Patent Owner’s argument again does not undermine Petitioner’s persuasive showing. Petitioner cites Haddad138 expressly teaching a FSI or BSI configuration. Pet. 29 (citing Ex. 1012 ¶ 48). Haddad138’s teaching is sufficient, on this record, to establish a reasonable likelihood of Petitioner establishing a reasonable expectation of success at trial. Conclusion as to claim 2” slip op. at 23
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner asserts that a person of ordinary skill in the art (POSITA) would have had a Bachelor’s degree in engineering, physics, or a related or equivalent field, and two or more years of experience researching, developing, designing, and/or evaluating image sensors using photonics. Ex-1004 ¶50. A person with less or different education but more relevant practical experience, or vice versa, may also meet this standard. Ex-1004 ¶50. Pet. 9. Patent Owner does not dispute the level of ordinary skill in the art at this time. For purposes of this Decision, we adopt Petitioner’s proposal as reasonable and consistent with the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art may reflect an appropriate level of skill in the art).” slip op. at 8
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,069,737 - PTAB · Mar 20, 2025 · IPR2024-01406 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board instituted IPR on claims 1, 3, 4, 8–13, and 15 on all asserted grounds, finding a reasonable likelihood that Takeuchi anticipates those claims.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2018); see also 37 C.F.R. § 42.4 (2023). For the reasons discussed below, we determine that Petitioner establishes a reasonable likelihood of prevailing with respect to the unpatentability of at least one claim of the ’202 patent. Accordingly, we institute an inter partes review of claims 1, 3, 4, 8–13, and 15 of the ’202 patent. A. Real Parties in Interest” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“or “POSITA”) would have had “a bachelor’s degree in mechanical engineering, electrical engineering, or a related field, and three to four years of experience, or a master’s degree in mechanical engineering, electrical engineering, or a related field, and one to two years of experience.” Pet. 6 (citing Ex. 1003 ¶ 13). Petitioner further contends that “[s]uch experience would include a familiarity with thermal fluid delivery devices and/or the components and underlying technology used therein, and a higher level of 1 US 5,249,586, issued Oct. 5, 1993 (Ex. 1004, “Morgan”). 2 EP 0 845 220 B1, published Jan. 26, 1998 (Ex. 1006, “Susa”). 3 US 2005/0205084 A1, published Sept. 22, 2005 (Ex. 1007, “Gupta”). 4 US 6,155,268, issued Dec. 5, 2000 (Ex. 1009, “Takeuchi”). at 6–7 (citing Ex. 1003 ¶ 13). Patent Owner states that, for purposes of the Preliminary Response, “Patent Owner maintains that Petitioners’ arguments fail even under Petitioners’ POSA definition.” Prelim. Resp. 13. On this record, we preliminarily adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’202 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))). B. Claim Construction” slip op. at 6
- Prior constructionPrior construction adoptedDecided for petitioner
“term “wicked into contact” that the Board adopted in a prior inter partes review proceeding that addressed the same term in an earlier, related patent. Pet. 7 (citing IPR2020-01602, Paper 32 at 8–15 (PTAB March 30, 2022)). ‘wicked into contact’ to mean: ‘wicked into contact (1) with the heater, or (2) with an area in close proximity to, and exposed [to] the heat produced by, the heater,’” and “[t]he present Petition adopts this formal construction for purposes of this IPR proceeding.” Id. (citing IPR2020-01602, Paper 32 at 15). Patent Owner also “adopts this construction for purposes of” the Preliminary Response, and argues that “Petitioner’s grounds fail even under its proposed construction of ‘wicked into contact.’” Prelim. Resp. 13. For purposes of this Decision, we adopt the Board’s prior construction of “wicked into contact,” namely, “wicked into contact (1) with the heater, or (2) with an area in close proximity to, and exposed to the heat produced by, the heater,” which is undisputed on this record. See Philip Morris Products, S.A. v. RAI Strategic Holdings, Inc., IPR2020-01602, Paper 32 at 8–15 (PTAB March 30, 2022). C. Asserted Anticipation by Morgan” slip op. at 7
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot reached
“To establish anticipation, each and every element in a claim, arranged as recited in the claim, must be found in a single prior art reference. Net Karsten Mfg. Corp. v. Cleveland Golf Co., 242 F.3d 1376, 1383 (Fed. Cir. 2001). “A reference may anticipate inherently if a claim limitation that is not expressly disclosed is ‘necessarily present, or inherent, in the single anticipating reference.’” In re Montgomery, 677 F.3d 1375, 1379 (Fed. Cir. 2012) (quoting Verizon Servs. Corp. v. Fibernet Va., Inc., 602 F.3d 1325, 1336–37 (Fed. Cir. 2010)). Based on the current record, we are not persuaded that Petitioner sufficiently establishes that Morgan discloses “a storage compartment . . . being arranged such that the liquid aerosol-forming material can be wicked into contact with the electrical resistance heater to volatilize the liquid aerosol-forming material” as recited in claim 1.” slip op. at 12
Claim construction§ 102 anticipationcites PhillipsPatents in suitUS 11,925,202 - Western Digital Technologies, Inc. v. Godo Kaisha IP Bridge 1Institution deniedPTAB · Mar 13, 2025 · IPR2024-01384 · APJ Sheila F Mcshane · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–8 were unpatentable over the asserted obviousness combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Upon consideration of the Petition, the Preliminary Response, and the evidence of record, we determine that Petitioner has not established a reasonable likelihood of prevailing with respect to the unpatentability of at least one claim of the ’403 patent. Accordingly, for the reasons that follow, we decline to institute an inter partes review of claims 1–8 of the ’403 patent.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“had a “Ph.D. in electrical engineering, physics, materials science, or a related field, and at least one year of experience in the research, design, and/or development of magnetic/spintronic devices, or the equivalent,” or “a Master’s degree in electrical engineering, physics, materials science, or a related field, and four years of experience in the research, design, and/or development of magnetic/spintronic devices, or the equivalent.” Pet. 29 (citing Ex. 1024 ¶ 25). Patent Owner “does not challenge Petitioner’s POSA [person of ordinary skill in the art] definition.” Prelim. Resp. 17. In determining the level of ordinary skill in the art, various factors may be considered, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citation omitted). The level of ordinary skill in the art is also reflected by the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). For purposes of this Decision, we adopt the assessment offered by Petitioner, as it is consistent with the ’403 patent and the asserted prior art.” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner “submits the claim terms should be given their plain and ordinary meaning and no claim construction is necessary to find the claims unpatentable.” Pet. 26. Patent Owner does not address claim construction in its Preliminary Response. See generally Prelim. Resp. We determine that we need not expressly construe any claim terms to resolve the parties’ disputes on the current record. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Importantly, Soukup indicates a different relationship between the amount of oxygen vacancy defects in the barrier layer and the barrier height, depending on which method is used. Specifically, Soukup explicitly found that “[t]he apparent barrier height determined from the zero-field intercept went up for increasing oxygen pressure [(i.e., less oxygen vacancy defects)] and the barrier height determined from the Arrhenius plot went down.” Ex. 1028, 3229 (Abstract) (emphasis added).15 That disclosure is reflected in Table I, where Soukup shows the results for three fabricated samples with increasing oxygen pressure during MgO deposition. Id. at 3233. Patent Owner provides another annotated version of Table I below (Prelim. Resp. 45): 15 Soukup’s conclusion appears to refer to the trend of the respective increasing or decreasing barrier heights values under the two different mathematical analyses methods. Annotated Table I above shows (in red) that the barrier height decreases as oxygen vacancies increase (i.e., as the oxygen pressure admitted during MgO deposition, shown in the PO2 column, decreases) using the zero-field intercept method, and shows (in blue) that the barrier height increases as oxygen vacancies increase (i.e., as the oxygen pressure admitted during MgO deposition decreases) using the Arrhenius plot method. Prelim. Resp. 45. In other words, Petitioner’s alleged inverse relationship is present for the zero-field intercept method, but not for the Arrhenius plot method. See id.; Pet. 37–38. “The barrier height cannot both increase and decrease with more oxygen vacancy defects,” and Petitioner does not attempt to reconcile or explain Soukup’s disparate teachings. See Prelim. Resp. 45 (emphasis omitted). We agree with Patent Owner that Petitioner is inconsistent in relying on one method as allegedly teaching a barrier height within the claimed range, while at the same time relying on the other method for a motivation under its obviousness theory. Prelim. Resp. 45–49. If a person of ordinary skill in the art would have understood that the Arrhenius plot method was the appropriate method for determining barrier height, as Petitioner argues in asserting that Soukup teaches a barrier height of 0.33 eV, that person would have understood that “the barrier height increases as oxygen vacancies increase” (in blue above), and Petitioner’s obviousness theory of adding oxygen vacancies to lower Bowen’s barrier height is incorrect. See id. at 47. If, however, a person of ordinary skill in the art would have looked to the zero-field intercept method, that person “would have understood that all of Soukup’s tested samples . . . had barrier heights” (in yellow above) “above the claimed range of 0.2–0.5 eV.” See id. at 48. Petitioner cannot have it both ways. Based on the record before us, Petitioner has not shown sufficiently” slip op. at 23
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,884,403 - Western Digital Technologies, Inc. v. Godo Kaisha IP Bridge 1Institution deniedPTAB · Mar 13, 2025 · IPR2024-01385 · APJ Sheila F Mcshane · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–4 would have been obvious over the asserted combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Upon consideration of the Petition, the Preliminary Response, and the evidence of record, we determine that Petitioner has not established a reasonable likelihood of prevailing with respect to the unpatentability of at least one claim of the ’263 patent. Accordingly, for the reasons that follow, we decline to institute an inter partes review of claims 1–4 of the ’263 patent.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“person of ordinary skill in the art at the time of the ’263 patent would have had a “Ph.D. in electrical engineering, physics, materials science, or a related field, and at least one year of experience in the research, design, and/or development of magnetic/spintronic devices, or the equivalent,” or “a Master’s degree in electrical engineering, physics, materials science, or a related field, and four years of experience in the research, design, and/or development of magnetic/spintronic devices, or the equivalent.” Pet. 29 (citing Ex. 1024 ¶ 25).” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“We determine that we need not expressly construe any claim terms to resolve the parties’ disputes on the current record. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 7
- BurdenNot shown unpatentable
“As discussed above, Petitioner fails to explain why one of ordinary skill in the art would have selected the barrier height value it relies upon. And given the disparity of Soukup’s barrier tunnel values under the different methods of analyses, the reference is, at best, ambiguous as to which values are accurately representative of barrier height. Additionally, the evidence supports that the apparent barrier height value that Petitioner relies upon (“about 0.33 eV”) will be a different higher value, so the actual value of the barrier height is uncertain. Accordingly, we do not find that Petitioner has met its burden to sufficiently demonstrate that a person of ordinary skill in the art would have understood Soukup to teach or suggest the claimed range of limitation 1[e] in that there is insufficient evidence presented that supports that the selected Soukup barrier height value represents an accurate value.” slip op. at 20
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,319,263 - Western Digital Technologies, Inc. v. Godo Kaisha IP Bridge 1Institution deniedPTAB · Mar 13, 2025 · IPR2024-01386 · APJ Monica S Ullagaddi · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–6 were unpatentable on any asserted obviousness ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2024). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the parties’ arguments and the evidence of record, we determine that, for the reasons discussed herein, Petitioner does not demonstrate a reasonable likelihood that it would prevail with respect to at least one of the challenged claims. We thus decline to institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“Pet. 28–29 (citing Ex. 1024 ¶ 25). Petitioner further states that “[l]ess work experience may be compensated by a higher level of relevant education, and vice versa” and that “[t]his level of ordinary skill would be the same if the relevant time period were around the March 12, 2004 or October 28, 2004 Japanese priority applications, or the March 10, 2005 PCT filing date.” Id. at 29 (citing Ex. 1024 ¶¶ 24–25). Patent Owner states that “[f]or purposes of this Preliminary Patent Owner Response only, Patent Owner does not challenge Petitioner’s POSA [person of ordinary skill in the art] definition because the Petition fails even if Petitioner’s POSA definition is adopted.” Prelim. Resp. 20 (citing Pet. 28–29). To resolve the institution question, we adopt Petitioner’s proposal regarding the level of one of ordinary skill in the art. The level of ordinary skill in the art is also reflected by the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“claims using the same claim construction standard that would be used in a civil action under 35 U.S.C. § 282(b), as articulated in Phillips v. AWH Corp., 415 F.3d 1303 (Fed. Cir. 2005) (en banc), and its progeny. See 37 C.F.R. § 42.100(b). Petitioner states that “the claim terms should be given their plain and ordinary meaning and no claim construction is necessary to find the claims unpatentable.” Pet. 25. Patent Owner does not directly” slip op. at 7
- BurdenNot shown unpatentable
“Thus, the cited teachings of Sunai support Patent Owner’s position that, even if adding boron into a ferromagnetic layer of CoFe results in a higher TMR as taught by Sunai, the addition suppresses crystallization. As to the issue of the teaching of the BCC structure of the alloy, not only does Petitioner’s challenge applying Bowen and Sunai fail to demonstrate a teaching or even a suggestion of a CoFeB alloy with a BCC cited by Petitioner does not either. Only one of Petitioner’s cited pieces of underlying evidence refers to a BCC lattice structure, Parkin, but Parkin’s BCC structure is disclosed with respect to a CoFe layer, and not a CoFeB layer. Ex. 1062, 18:55–59 (“The simple cubic crystalline MgO layer thus provides a template for the formation of a thin crystalline ferromagnetic layer which has the bcc structure of CoFe and is oriented in the same (100) direction as the MgO layer.” (emphasis added)).” slip op. at 12
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,608,198 - Billerud Aktiebolag (Publ) v. Westrock MWV, LLCSome claims unpatentablePTAB · Mar 12, 2025 · IPR2023-01206 · APJ Elizabeth M Roesel · IPR · Final written decision
Claims 1, 2, and 4–22 are unpatentable as obvious; claim 23 was not shown unpatentable. Substitute claims 25–26 are allowed, while 24 and 27 are denied for lack of written-description support.
RulingsFinal written decision- Expert testimonyPetitioner expert discountedOther
“Exhibits 1013 and 1014 are also not admissible as expert testimony because Mr. Wirén is not “qualified as an expert by knowledge, skill, experience, training, or education.” Fed. R. Evid. 703. “To offer expert testimony from the perspective of a skilled artisan in a patent case—like for claim construction, validity, or infringement—a witness must at least have ordinary skill in the art. Without that skill, the witness’ opinions are neither relevant nor reliable.” Kyocera Senco Indus. Tools Inc. v. Int’l Trade Comm’n, 22 F.4th 1369, 1376–77 (Fed. Cir. 2022). Mr. Wirén does not meet our definition of a person of ordinary skill in the art. See Section II.B, supra. That definition is based on the undisputed testimony of Messrs. Zotterman and Klass. Ex. 1003 ¶ 24; Ex. 2003 ¶ 26. Although Mr. Wirén has a Master’s of Science in chemical engineering, he lacks any experience or specialization in paperboard manufacturing. Ex. 2011, 12:1–10, 19:6–25, 20:2–7. We therefore agree with Patent Owner that Exhibits 1013 and 1014 are the testimony of Mr. Wirén and should be excluded from evidence because Mr. Wirén is not a person of ordinary skill in the relevant art. PO MTE 5–6, 9; Sundance, Inc. v. DeMonte Fabricating Ltd., 550 F.3d 1356, 1362 (Fed. Cir. 2008) (“Unless a patent lawyer is also a qualified technical” slip op. at 61
- Skill levelSkill level board ownOther
“Level of Ordinary Skill in the Art Based on the testimony of the parties’ witnesses, we determine that a person of ordinary skill in the art would have had a bachelor’s degree in paper science and engineering, chemical engineering, process engineering, mechanical engineering, or a related degree, with three to five years of experience in paperboard manufacturing, or a master’s degree in paper science and engineering, chemical engineering, process engineering, or mechanical engineering, or a similar field with a specialization in paperboard manufacturing. Ex. 1003 ¶ 24; Ex. 2003 ¶ 26. We find that the level of ordinary skill in the art, as articulated above, is consistent with the level of technical understanding and competence reflected in the ’142 Patent Specification and the asserted prior art references.” slip op. at 10
- Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageTerm construed petitioner constructionDecided for petitioner
“A claim construction that excludes a particular element is viewed as a “negative limitation.” Ethicon LLC v. Intuitive Surgical, Inc., 847 Fed. App’x 901, 907 (Fed. Cir. Mar. 15, 2021). “[S]uch exclusions must find support either in ‘the words of the claim’ or through an ‘express disclaimer or independent lexicography in the written description that would justify adding that negative limitation.’” Id. (citing Omega Eng’g, Inc. v. Raytek Corp., 334 F.3d 1314, 1323 (Fed. Cir. 2003); CCS Fitness, Inc. v. Brunswick Corp., 288 F.3d 1359, 1366–67 (Fed. Cir. 2002)). “The standards for finding lexicography and disavowal are exacting.” GE Lighting Sols., LLC v. AgiLight, Inc., 750 F.3d 1304, 1309 (Fed. Cir. 2014). “To act as its own lexicographer, a patentee must ‘clearly set forth a definition of the disputed claim term,’ and ‘clearly express an intent to define the term.’” Id. (citing Thorner, 669 F.3d at 1365). Similarly, disclaimer or disavowal requires that the specification or prosecution history demonstrate that the invention does not include a particular feature. Id. Here, we find no claim language, lexicography, or disclaimer in the ’142 Patent or its file history that would support defining a “hot-hard calender” as requiring that only one of the two rollers be heated to an elevated temperature.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundUnpatentable
“a contact surface of said thermo-roller is heated to an elevated temperature of at least 250°F.” Petitioner shows persuasively that the temperature limitation is taught by the combination of Fugitt and Papermaking. Pet. 32–34. Fugitt discloses that “[t]he rolls of the calender may be steam heated.” Ex. 1004 ¶ 26. In a section titled “Heated Rolls,” Papermaking discloses that “Steam can be used up to 170°C [338°F] surface temperature.” Ex. 1010, 95, 98. Petitioner is thus correct that, “[w]hile Fugitt teaches that a hot calender may be steam heated, Papermaking clarifies that one of ordinary skill in the art would understand that steam heated thermo-rollers may reach up to 338°F.” Pet. 36. Based on these disclosures, we are persuaded by Mr. Zotterman’s testimony that it would have been “obvious to heat the thermo-roller of Fugitt to at least 250°F.” Ex. 1003 ¶ 159. combine Fugitt and Papermaking because of Papermaking’s status as a “trusted handbook[],” because both references disclose a method of manufacturing a paperboard structure with hot calendering,” and “because of the known advantages of heated rollers.” Pet. 36–37; Ex. 1003 ¶¶ 157, 159, 162. Petitioner’s contention is supported by Papermaking’s disclosures that, for cartonboard, “[p]recalendering is used before the coater to reduce roughness and porosity” and “[h]igh thermo roll temperatures (in some cases over 200°C) result in bulk savings because of the temperature gradient.” Ex. 1005, 80–82; see also Pet. 38; Ex. 1003 ¶ 164 (citing these disclosures). Papermaking’s disclosed range of “up to 170°C [338°F]” for steam- heated rolls (Ex. 1010, 98), overlaps the claimed range of “at least 250°F.” Patent Owner agrees. Tr. 27:11–13. “If the relevant comparison between a disputed claim limitation and the prior art pertains to a range of overlapping values, ‘. . . even a slight overlap in range establishes a prima facie case of obviousness.’” Genentech, Inc. v. Hospira, Inc., 946 F.3d 1333, 1341 (Fed. Cir. 2020) (citing In re Peterson, 315 F.3d 1325, 1329 (Fed. Cir. 2003)). “[S]uch an overlap creates a presumption of obviousness, and . . . the burden of production falls upon the patentee to come forward with pertinent evidence that the overlapping range would not have been obvious in light of the prior art.” Id. (citing E.I. DuPont de Nemours & Co. v. Synvina C.V., 904 F.3d 996, 1006, 1008 (Fed. Cir. 2018)). slip op. at 21
Patent outcomesUS 11,293,142 mixedClaim construction§ 103 obviousness§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 11,293,142
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.