- Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - Neurocrine Biosciences, Inc. v. Spruce Biosciences, Inc.Institution deniedPTAB · Oct 3, 2025 · PGR2025-00032 · APJ Susan L C Mitchell · PGR · Institution
The Board denied institution because Patent Owner disclaimed all challenged claims.
RulingsInstitution decision- Adverse judgmentAdverse judgmentDenied
“Section 42.207(e) states that “[n]o post-grant review will be instituted based on disclaimed claims.” 37 C.F.R. § 42.207(e). Because the Patent Owner has disclaimed all claims challenged by the grounds in this Petition, we determine that no trial will be instituted.” slip op. at 2
NonePatents in suitUS 12,115,166 - Front Line Medical Technologies, Inc. v. Prytime Medical Devices, Inc.All claims unpatentablePTAB · Oct 1, 2025 · PGR2024-00028 · APJ Jeffrey N Fredman · PGR · Final written decision
Claims 1–10 are unpatentable as obvious over Fogarty and Chengod; the Board found that combination sufficient for every challenged claim.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“7. Conclusion Based on the entirety of the record, we determine that a person of” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownOther
“3. Analysis In our claim construction analysis “[w]e begin, as we often do, with” slip op. at 18
- Claim Construction › Intrinsic evidence (Phillips canons) › Prosecution history disclaimer / disavowalTerm construed board ownOther
“the feature of the solid wire being “secured at a proximal-most end thereof within the proximal hub” was added during prosecution to overcome a rejection. Ex. 1002, 573-580. The prior art was distinguished because its guidewire “is configured to be steered and manipulated through the blood vessel, and subsequently removed, and, therefore, cannot be secured at a proximal end thereof to the luer hub 310.” Id., 578-79 (emphasis added). Accordingly, the prosecution history further demonstrates “secured” was not intended to cover removable attachment.” slip op. at 35
- Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableMotivation foundUnpatentable
“2. Patent Owner’s Arguments Concerning Claim 1 and Our Analysis a. Reasonable Expectation of Success in modifying catheters to less than 6 Fr Patent Owner asserts “Petitioner has failed to perform a proper obviousness analysis by not adequately demonstrating a reasonable expectation of success in modifying Fogarty.” PO Resp. 35. Patent Owner asserts “the category of ‘Fogarty catheters’ is broad and diverse” and “Dr. Resnick admits he has no idea whether Chengod’s or Deaton’s catheters have interior constructions similar to that of the cited Fogarty reference.” Id. at 35‒36 (citing Ex. 2002, 52:16‒57:1). Patent Owner asserts that Petitioner has therefore not demonstrated that a PHOSITA would have a reasonable expectation of success in modifying the particular catheter taught by the cited Fogarty patent (Ex. 1004) to the claimed size when considering the shaft has a spring coil and braid in addition to the outer tube and lumen. Id. Petitioner responds “(1) Fogarty did not indicate the catheter’s size; (2) Fogarty catheters smaller than 6 Fr were known and disclosed in Chengod (and Deaton); and (3) sizing Fogarty’s catheter less than 6 Fr would work (i.e., reasonable expectation of success) because it did work.” Pet. Reply 19. Petitioner asserts that Yassinzadeh “shows a catheter that is less than 6 Fr and that includes a similar spring coil construction as found in the Fogarty patent” where the “dilator 150 has a diameter of either 5 Fr or 6 Fr.” Id. at 19‒20 (citing Ex. 1033 ¶¶ 86‒97 (“Yassinzadeh”)). Petitioner asserts that Yassinzadeh’s “analogous construction being less than 6 Fr confirms a PHOSITA would have a reasonable expectation of success in sizing the catheter in Fogarty (Ex-1004) less than 6 Fr.” Id. at 20 (citing Ex. 1034 ¶ 97). Patent Owner responds “Petitioner fails to specify what” slip op. at 53
Patent outcomesUS 11,857,737 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,857,737 - Amgen, Inc. v. Bristol-Myers Squibb CompanyAdverse judgmentPTAB · Oct 1, 2025 · IPR2025-00603 · APJ Grace Karaffa Obermann · IPR · Adverse judgment
The Board entered adverse judgment against Patent Owner based on its statutory disclaimer of claims 1–18, then terminated the proceeding.
RulingsAdverse judgment- Adverse judgmentAdverse judgmentGranted
“In other words, the Smith & Nephew decision makes plain that entry of adverse judgment (as opposed to a denial without adverse judgment) is appropriate in situations where a patentee seeks to regain, through continued prosecution, subject matter that is patentably indistinct from previously surrendered subject matter. Id. That is precisely the situation at hand. Claim 43, pending in the ’822 continuation application, is of the same or broader scope than disclaimed claim 1 of the ’529 patent, as shown in Petitioner’s claim chart:” slip op. at 4
NonePatents in suitUS 11,332,529 - PTAB · Sep 19, 2025 · PGR2025-00025 · APJ Kimberly Mcgraw · PGR · Institution
The Board instituted PGR on claims 1–19 and all asserted grounds, finding it more likely than not that claim 1 is anticipated by the Gatorade Label.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“if “the information presented in the petition . . . demonstrate[s] that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” Post-grant review is available for patents that issue from applications that at one point contained at least one claim with an effective filing date on or after March 16, 2013. See Leahy-Smith America Invents Act, Pub. L. No. 112-29, 125 Stat. 284 (2011) (“AIA”), §§ 3(n)(1), 6(f)(2)(A). After considering the briefing and the evidence of record, for the reasons set forth below, we determine that Petitioner has shown that the ’422 Patent is eligible for post-grant review and has shown it is more likely than not that at least one challenged claim of the ’422 Patent is unpatentable under § 324(a). Accordingly, we institute a post-grant review of the challenged claims of the ’422 Patent.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art “would possess at least (1) a Bachelor’s degree in chemistry or a related field, with (2) five years of experience in material identification and characterization using multiple analytical methods and field sampling, or equivalent research or professional experience.” Pet. 12 (citing Ex. 1014 ¶ 24). Patent Owner does not dispute Petitioner’s definition for one of ordinary skill in the art nor provide a proposed definition of its own. See generally Prelim. Resp. For the purposes of this Decision, we adopt Petitioner’s undisputed proposal regarding the level of one of ordinary skill in the art.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Prosecution history disclaimer / disavowalDisclaimer foundDecided for patent owner
“336. The applicant explained that not all combinations of shrink films and light blocking materials are recyclable. Id. at 335. The applicant explained that films can be compatible with PET recycling in two ways, (1) the film can float in water and be separated from PET that sinks in water or (2) the PET films crystallize and “can be recovered with the PET stream.” Id. at 336 (citing “A Resource Document by the Association of Plastic Recyclers (APR)”) (found at Ex. 1002, 323–332) (emphasis omitted). The applicant explained that “removing the label before or during the recycling process is not evidence of the recyclability of the label” and that “[r]emoving the label during the recycling process is not equivalent to actually recycling the label.” Id. at 335. As such, a POSITA reading the prosecution history would understand that a label is not recyclable with a PET container, as recited by the independent claims, by removing the label from the PET recycle stream before or during the recycling process.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownOther
“To determine how a person skill in the art would determine if a shrink label is “recyclable” as recited in the independent claims, we look to how the Specification of the ’422 Patent describes or defines recyclable shrink labels. For example, the ’422 Patent states that PET shrink films are generally considered recyclable if no inks are retained on the film after a caustic wash cycle typically used in PET reclaiming processes. Ex. 1001, 6:61–65. The ’422 Patent further states that labels are fully recyclable if the polymers used are clear, preferably clear PET, and the labels include inks that can be washed off in a “typical PET recycling wash (caustic wash).” Id. at 11:44– 49; see also id. at 11:49–54 (describing embodiments in which the labels are free or substantially free of inks that cannot be washed off in a caustic wash or where the labels are free or substantially free of color plastics that cannot be recycled). The ’422 Patent further discusses “industry standards” for determining whether various embodiments of shrink labels are recyclable. See, e.g., id. at 11:29–53. For example, the Specification states that the “Association for Plastic Recyclers (APR) Critical Guidance Protocol for Clear PET Articles with Labels and Closures (PET-CG-02)” (Ex. 1005) can certify that a film is fully recyclable with a container or bottle. Id. at 11:34– 38. Additionally, the Specification states that labels “are recyclable according to the Evaluation of the Near Infrared (NIR) Sorting Potential of a Whole Plastic Article (SORT-B-01)” (Ex. 1010) and/or the “Evaluation of Sorting Potential for Plastic Articles Utilizing Metal, Metalized, or Metallic Printed Components (SORT-B-03)” (Ex. 1011). Ex. 1001, 11:39–44. The ’422 Patent further states that embodiments of the labels “are fully recyclable. For example, the labels may include inks that can be washed off in a typical PET recycling wash (caustic wash) and the polymers” are preferably clear PET. Id. at 11:44–48. The ’422 Patent thus provides various descriptions or standards to determine the recyclability of shrink labels. For the purposes of addressing the anticipation and obviousness grounds, we determine that any of these standards can be used to determine if a shrink label is “recyclable.” We note that our construction is preliminary and is based on the present record. We invite the parties to further the address the construction of “wherein the recyclable shrink label is recyclable with a PET container” during trial.” slip op. at 12
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Phillips · NautilusPatents in suitUS 11,961,422 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Sep 15, 2025 · IPR2025-00005 · APJ John G New · IPR · Rehearing
Denied Solus’s rehearing request; the Board maintained its denial of institution because the petition did not show a reasonable likelihood of prevailing on the challenged claims.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“[O]f the 44 specimens tested by Ye, as revealed in Ye’s Table II, only a single specimen, specimen 15, meets the required TC ratios recited in challenged claim 1 of the ’541 patent. Furthermore, none of the references cited by Petitioner teach, or even remotely suggest, the four requisite TC ratios recited by challenged claim 1. We find Petitioner’s argument that a person of ordinary skill in the art would have been motivated to exclusively select Ye’s sample 15, out of the remaining 43, to which to apply the teachings of Hara and Otsuka concerning the requisite tensile strength and weight deviation ranges in the hope of arriving at the claimed invention, is implausible. Indeed, only the ’541 patent, among all of the evidence of record, that actually mentions the required texture coefficient ratios recited in challenged claim 1. Petitioner provides no convincing argument as to why a skilled artisan would have selected sample 15 for combination with Hara and Otsuka.” slip op. at 10
- Expert testimonyPetitioner expert discountedDecided for patent owner
“At the heart of this flaw is Petitioner’s argument, and Dr. Josefowicz’s opinion, that it would have been conventional in the art at the time of filing to vary the electrolyte concentration, electrolysis plating parameters, temperature, and the use of organic and inorganic additives, in order to obtain a copper foil with tensile strength and elongation values falling within the claimed ranges as these ranges were well known, at least since 1974. Ex. 1003 ¶ 63. This statement is largely unsupported by evidence of record, with the sole exception of Table 2 of Lowenheim, which, as Patent Owner points out, provides tensile strengths well outside the claimed range. Petitioner provides insufficient guidance as to how a person of ordinary skill in the art would have known which parameters to vary, or how to vary them, to provide the foil of Hirose with a tensile strength or weight deviation within the claimed range. Dr. Josefowicz’s statement that this would result from routine optimization, and was “conventional” may or may not be true, but it is insufficiently supported by evidence of record to be persuasive.” slip op. at 6
§ 103 obviousnessPatents in suitUS 9,457,541 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Sep 15, 2025 · IPR2025-00005 · APJ John G New · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show a reasonable likelihood of prevailing on claims 1-4.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“In summary, we again conclude that Petitioner has failed to provide sufficient evidence to demonstrate that a person of ordinary skill in the art would have had a reasonable expectation of success in combining the cited prior art references, in combination with Dr. Josefowicz’s relatively unsupported testimony concerning a skilled artisan’s ability to optimize various constituents and conditions, to arrive at the claimed invention. Petitioner has not pointed to any argument or unconsidered evidence of record that is sufficient to show that, in reaching its conclusion, the Board abused its discretion by basing its Decision on an erroneous interpretation of law, a factual finding not supported by substantial evidence, or an unreasonable judgment in weighing relevant factors. Arnold, 362 F.3d at 1340.” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“teaches the tensile strengths of various types of copper-electroplated steel electrical cable wire of different properties, including high strength, hardness, low electrical resistivity, near zero strength, good leveling, and thermal stability, some of which fall within the claimed range of tensile strength of 30 to 40 kgf/mm2. Lowenheim, 196, Table II. However, none of these categories correspond to those copper foil properties recited in the claims, and Dr. Josefowicz’s testimony provides little guidance as to how a person of ordinary skill in the art would have known how to optimize the recited properties, and particularly so in combination with the teachings of Hirose and the other cited prior art references. Furthermore, as we noted in our Decision:” slip op. at 7
- Expert testimonyPetitioner expert discountedDecided for patent owner
“At the heart of this flaw is Petitioner’s argument, and Dr. Josefowicz’s opinion, that it would have been conventional in the art at the time of filing to vary the electrolyte concentration, electrolysis plating parameters, temperature, and the use of organic and inorganic additives, in order to obtain a copper foil with tensile strength and elongation values falling within the claimed ranges as these ranges were well known, at least since 1974. Ex. 1003 ¶ 63. This statement is largely unsupported by evidence of record, with the sole exception of Table 2 of Lowenheim, which, as Patent Owner points out, provides tensile strengths well outside the claimed range. Petitioner provides insufficient guidance as to how a person of ordinary skill in the art would have known which parameters to vary, or how to vary them, to provide the foil of Hirose with a tensile strength or weight deviation within the claimed range. Dr. Josefowicz’s statement that this would result from routine optimization, and was “conventional” may or may not be true, but it is insufficiently supported by evidence of record to be persuasive. Id. (emphasis added) (footnote omitted).” slip op. at 6
§ 103 obviousnessPatents in suitUS 9,457,541 - PTAB · Sep 8, 2025 · PGR2025-00017 · APJ Jeffrey N Fredman · PGR · Institution
The Board instituted PGR on claims 1, 2, 6–15, and 17–30 based on written-description and enablement challenges; it found the obviousness challenge insufficient at this stage.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority to determine whether to institute a post-grant review under 35 U.S.C. § 324. Institution of a post-grant review is authorized by statute when “the information presented in the petition . . . would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). Applying that standard on behalf of the Director (37 C.F.R. § 42.4(a)) and in consideration of the Petition, Preliminary Response, Reply, Sur-Reply, and the cited evidence of record, we determine that the information presented shows that it is more likely than not that Petitioner would prevail in establishing unpatentability of claims 1, 2, 6–15, and 17–30 of the ’520 patent, and therefore, we grant post-grant review for the reasons articulated below.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner’s contentions are, at this stage, unavailing because Patent Owner’s proffered definition of a POSA is too restrictive. Petitioner’s proposal is sufficiently comprehensive to encompass the level of skill reflected in prior art relevant to the ’520 patent. It is reasonably clear that, in indicating that a POSA would have an advanced degree (like a Ph.D.) and years of experience in analysis of protein structure, Petitioner is asserting that knowledge of proteins generally is sufficient to understand the types of problems encountered in the art and the prior art solutions to those problems, and the ordinary artisan need not be an expert in hyaluronidases. See Pet. 15–16. Petitioner requires that the POSA would be able to apply key scientific concepts (e.g., biochemistry, recombinant biology, sequence analysis and protein modeling) to enzymes such as hyaluronidases. See id. Moreover, Patent Owner fails to persuasively explain why Petitioner’s definition that includes a person with expertise in other enzymes is insufficient. Even if we were to apply Patent Owner’s POSA definition, it is not clear on the record before us that Petitioner’s experts lack relevant expertise or qualifications of at least a POSA.” slip op. at 10
- Claim Construction › Intrinsic evidence (Phillips canons) › Lexicography (patentee as own lexicographer)Term construed petitioner constructionDecided for petitioner
“refers to a PH20 polypeptide that contains at least one amino acid modification, such as at least one amino acid replacement as described herein, in its sequence of amino acids compared to a reference unmodified PH20 polypeptide. A modified PH20 polypeptide can have up to 150 amino acid replacements, so long as the resulting modified PH20 polypeptide exhibits hyaluronidase activity. Typically, a modified PH20 polypeptide contains 1, 2, 3, 4, 5, 6, 7, 8, 9, 10, 11, 12, 13, 14, 15, 16, 17, 18, 19, 20, 21, 22, 23, 24, 25, 26, 27, 28, 29, 30, 31, 32, 33, 34, 35, 36, 37, 38, 39, 40, 41, 42, 43, 44, 45, 46, 47, 48, 49, or 50 amino acid replacements. It is understood that a modified PH20 polypeptide also can include any one or more other modifications, in addition to at least one amino acid replacement as described herein. Id. at 48:38–53 (emphasis added). Based on this express definition, the current record does not support the interpretation of Dr. Triggs-Raine that the “term ‘modified PH20 polypeptide,’ therefore, has a purely structural meaning in the context of the specification.” Ex. 2055 ¶ 68. Indeed, when reproducing the definition from this column of the ’520 patent, Dr. Triggs-Raine does not include any text after the first period, stating that “is not part of the express definition of ‘modified PH20 polypeptide’” and “merely describes an upper limit for the number of modifications possibly allowing a modified PH20 polypeptide to exhibit enzymatic activity.” Ex. 2055 ¶¶ 67, 77–78. On this record, however, we find that this text is part of the definition of “modified PH20 polypeptide” because it continues to detail specific elements required including a requirement that replacements in the PH20 polypeptide are permitted “so long as the resulting modified PH20 polypeptide exhibits hyaluronidase activity.” Ex. 1001, 48:44–47; see Ex. 2055 ¶ 67 (stating a “patent’s definition controls”). And Dr. Triggs-Raine states “the modified PH20 polypeptides have multiple credible uses, including ‘therapeutic uses of modified PH20 polypeptides that have the ability to degrade hyaluronan.’” Ex. 2055 ¶ 115.7 That is, Dr. Triggs-Raine recognizes hyaluronidase as the primary utility for the modified PH20 polypeptides recited in claim 1.” slip op. at 15
- Disclosure Requirements (§112) › Written description (Ariad)Written description inadequateInstituted
“Thus, the ’520 patent evidences that even when only a single mutation is made in the PH20 polypeptide, that single mutation is more likely than not to alter the structure in such a way as to inactivate the hyaluronidase activity found in the native PH20 polypeptide. On this record, Dr. Hecht persuasively demonstrates that when the full scope of claim 1 is addressed, which includes not just single mutations in the PH20 polypeptide, but also multiple mutations, there is no expectation of structural homogeneity, stating that “[i]ntroducing multiple amino acid changes simultaneously . . . could prevent the folding of sequences into secondary structures and structural motifs and can destabilize those structures if they do form.” Ex. 1003 ¶ 59. Dr. Hecht notes that claim 1 allows “21-42 changes, with each additional change (except at position 324) being to 1 of 19 other amino acids. But the up to 21-42 changes also can be at any of between 430 and 465 (or, in the case of the broadest claims, 474) different positions depending on which unmodified PH20 sequence is used.” Id. ¶ 120. Dr. Park calculates that “95% sequence identity to PH201-465 means that the protein can have 23 total changes,” and that where one of those changes is one of five choices at position 324 as required by claim 1, the number of possible PH20 polypeptides with twenty-two additional changes is “extremely large by all accounts, ranging from 1059 to 10112.” See” slip op. at 27
Claim construction§ 103 obviousness§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 12,110,520 - Sarepta Therapeutics, Inc. v. The Trustees Of The University Of PennsylvaniaNo claims unpatentablePTAB · Aug 20, 2025 · IPR2024-00580 · APJ Susan L C Mitchell · IPR · Final written decision
The Board held claim 8 not shown unpatentable under each of three §103 grounds because Petitioner failed to establish motivation to combine the references with a reasonable expectation of success.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“In addressing the level of ordinary skill in the art, Petitioner contends that a person of ordinary skill in the art (“POSA” or “POSITA”) would have had at least a Ph.D. in biochemistry, molecular biology, or a related field and between one and four years of post-doctoral experience in the field of gene therapy. Alternatively, a POSA would have had at least a Master’s or Bachelor’s Degree in biochemistry, molecular biology, or a related field, with a corresponding number of additional years of experience in the field of gene therapy. Pet. 12 (citing Ex. 1005 ¶¶ 111–115). Patent Owner states that it does not challenge Petitioner’s definition. PO Resp. 10. On this complete record, we accept Petitioner’s proposed definition, as it appears consistent with the level of skill in the art reflected in the prior art of record and the disclosure of the ’274 Patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“the prior art itself [may] reflect[] an appropriate level” as evidence of the ordinary level of skill in the art (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)).” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner asserts that the ’274 patent “does not specify a particular program or set of program parameters that should be used to align sequences and calculate percent identity for purposes of determining whether a particular test sequence falls within the scope of the claims.” Pet. 21. Petitioner asserts that it analyzed the percent identity claim elements, as Patent Owner did in the parallel District Court litigation, Penn-II, “using the Clustal program at default settings to generate amino acid sequence alignments and calculate percent identity values.” Id. at 21–22. Petitioner, however, does not ask for any particular construction of any claim term. See id. Patent Owner states that it “does not challenge Petitioner’s articulation of the lack of a need for claim construction.” PO Resp. 10. Having considered the record, we determine that no express claim construction of any claim term is necessary to reach our decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)); Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Ltd. v. Matal, 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., 200 F.3d at 803)).” slip op. at 12
- Expert testimonyPatent owner expert creditedDecided for patent owner
“According to the import of the complete recitation of paragraph 250 of the ’772 Publication set forth above that Petitioner relies upon for the motivation to improve efficient gene transfer in liver, AAV8 already fulfills this need. See Tr. 28:15–18. We do not read the ’772 Publication as calling for a search for a more efficient variant to improve efficient gene transfer in liver. We credit Dr. Samulski’s testimony that supports this view of the teachings of the ’772 Publication. Dr. Samulski testifies: Additionally, when the inventors compared AAV8’s expression in the liver against new serotypes AAVrh2, AAVrh10, AAVrh13, and AAVrh21, they found that AAV8 remained superior: EX1007, ¶ 253. Notably, AAV8 was shown to have over fifty percent (50%) greater expression in liver than AAVrh10. As I discuss more below, a skilled artisan in 2005 would not have expected a single amino acid substitution to significantly alter tropism in order to target to a different tissue. Thus, in my opinion, in 2005, a skilled artisan with the goal of targeting the liver would have selected the best known vector for delivery to liver at that time—AAV8. Ex. 2027 ¶ 42. We also agree with Dr. Samulski’s opinion that a POSA would have selected the best vector for liver, AAV8, instead of modifying another vector to increase tropism to liver. Dr. Samulski testifies: In my opinion, a skilled artisan in 2005 would not have looked solely to modify a vector to try to improve tropism to a particular tissue. As discussed throughout this declaration, changing tropism is difficult to predict, and a skilled artisan would not have had a reasonable expectation that changes could be made to improve or alter tropism. A skilled artisan would also have been concerned that changes, even small ones, could negatively impact other properties of the capsid protein. Therefore, rather than seek to modify a vector, a skilled artisan” slip op. at 29
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“The ’772 Publication, however, does not indicate as Petitioner asserts that a new variant is necessary to improve the efficiency of gene transfer to liver; the ’772 Publication indicates that AAV8 fulfills that need. See Ex. 1007 ¶ 250. In the paragraph that Petitioner relies upon for the alleged need to improve the efficiency of gene transfer to the liver, the ’772 Publication states in full: The tropism of each new vector is favorable for in vivo applications. AAV2/7 vectors appear to transduce skeletal muscle as efficiently as AAV2/1, which is the serotype that confers the highest level of transduction in skeletal muscle of the primate AAVs tested to date. Importantly, AAV2/8 provides a substantial advantage over the other serotypes in terms of efficiency of gene transfer to liver that until now has been relatively disappointing in terms of the numbers of hapatocytes stably transduced. AAV2/8 consistently achieved a 10 to 100-fold improvement in gene transfer efficiency as compared to the other vectors. The basis for the improved efficiency of AAV2/8 is unclear, although it presumably is due to uptake via a different receptor that is more active on the basolateral surface of hepatocytes. This improved efficiency will be quite useful in the development of liver-directed gene transfer where the number of transduced cells is critical, such as in urea cycle disorders and familial hypercholesterolemia. Id. (citations omitted) (emphasis added). According to the import of the complete recitation of paragraph 250 of the ’772 Publication set forth above that Petitioner relies upon for the motivation to improve efficient gene transfer in liver, AAV8 already fulfills this need. See Tr. 28:15–18. We do not read the ’772 Publication as calling for a search for a more efficient variant to improve efficient gene transfer in liver. We credit Dr. Samulski’s testimony that supports this view of the teachings of the ’772 Publication. Dr. Samulski testifies: Additionally, when the inventors compared AAV8’s expression in the liver against new serotypes AAVrh2, AAVrh10, AAVrh13, and AAVrh21, they found that AAV8 remained superior:” slip op. at 28
Patent outcomesUS 11,680,274 not shown unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,680,274 - Zhuhai Cosmx Battery Co., Ltd. v. Ninge Amperex Technology LimitedInstitution deniedPTAB · Aug 20, 2025 · IPR2025-00385 · APJ Debra L Dennett · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–10 were anticipated by Nishikawa or obvious over the asserted combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review under 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least [one] of the claims challenged in the petition.” For the reasons set forth below, upon considering the Petition and Preliminary Response, we determine that Petitioner has not established a reasonable likelihood of prevailing with respect to at least one challenged claim. Accordingly, we deny the Petition and decline to institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“Petitioner contends that A person of ordinary skill in the relevant art would typically hold an advanced degree in chemistry, material science, and/or a related discipline, and have at least two years of experience with designing and/or fabricating battery separators or have an equivalent level of education, training, and experience. Pet. 5. Patent Owner “adopts the definition proposed by Petitioner” for the purposes of the Preliminary Response. Prelim. Resp. 22. In light of the record before us, and for purposes of this Decision, we adopt Petitioner’s unopposed definition because it is consistent with the specification. We note that neither party indicated that the result would change under any different definition.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Absolute plastic deformation rate” and “relative plastic deformation rate” are the only claim terms disputed in this proceeding, and are clearly defined in the Specification and in claim 1. See Spec. 4:22–27, 4:47–54; 25:31–37. Because we determine that claim construction is not necessary to decide whether to institute, we do not expressly construe any claim terms. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (holding that “only those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs. in the context of an inter partes review). slip op. at 11
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“Petitioner’s arguments are unconvincing. Petitioner points to nothing in Nishikawa that allows a POSITA to determine L2 (defined as “a length of 4 Tensile strength is measured as force per units area, such as MPa or psi. One MPa equals one N/mm2. Nishikawa Table 1 discloses tensile strength in N/cm. Ex. 1004 Table 1. Petitioner makes calculations to convert the reported N/cm into N/m2 and then to GPa, but provides no explanation for why tensile strength is reported in N/cm or how it was measured. See Pet. 31. the porous substrate after the porous substrate is stretched to breakage and docked along the fracture caused by the breakage and flattened”) or L2 – L0. See generally Pet., Ex. 1004. Petitioner and its expert, Dr. Pecht, fail to adequately explain why tensile strength divided by Young’s modulus is “a proxy for L1 – L2” or why such a proxy is sufficient to disclose the limitation as stated. Instead, we are required to rely on “approximations” and “estimates” with insufficient explanation of why such they are appropriate or adequate. See Pet. 26, 30, 32; see also Ex. 1003 ¶¶ 97, 105–108, 111.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,964,927
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.