- PTAB · Dec 16, 2024 · IPR2024-01011 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted IPR on claims 1–5 under all asserted grounds, finding a reasonable likelihood of prevailing on at least one claim and no basis for discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the arguments and evidence set forth by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’924 patent. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review as to all of the challenged claims of the ’924 patent on all of the grounds of unpatentability set forth therein.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“Although the parties appear to agree that this factor is neutral, we note that a district court denial of a motion to stay without prejudice, accompanied by an indication that the district court would consider a renewed motion, “suggests the district court may be willing to avoid duplicative efforts and await the PTAB’s final resolution of the patentability issues raised in the petition before proceeding with the parallel litigation.” Fintiv at 6–7. “This fact has usually weighed against exercising authority to deny institution.” Id. (also noting that factors 2 and 3 are relevant to how much weight to give to the court’s willingness to reconsider a stay); see also T-Mobile, Paper 16 at 12 (noting that a stay was unlikely in that case given the proximity of the trial date to the entry of the institution decision). In view of the forgoing, we determine that Fintiv factor 1 weighs against exercising our authority to deny institution.” slip op. at 39
- Skill levelSkill level petitioner adoptedDecided for petitioner
“had at least a Master’s degree in materials science, chemistry, chemical engineering, a field relevant to polymer science and engineering, or the equivalent, and at least three years of experience in nanomaterials, electrochemistry, batteries, or polymer related activities” and that “[a]dditional work experience can compensate for less formal education, and vice versa.” Pet. 8 (citing Ex. 1003 ¶ 11). For purposes of its Preliminary Response, Patent Owner “does not dispute the Petition’s definition of [the] level of ordinary skill in the art.” Prelim. Resp. 2. On this record, we preliminarily adopt Petitioner’s definition of the person of ordinary skill in the art because it appears consistent with the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner argues that “no formal claim constructions are necessary.” Pet. 9. Patent Owner contends that all claim terms should be interpreted “in accordance with their ordinary and customary meaning.” Prelim. Resp. 2. Upon review of the record, we determine that no claim terms require express construction for purposes of this Decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 8
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,968,924 - PTAB · Dec 16, 2024 · IPR2024-01006 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted IPR of claims 1–8 on all petitioned grounds, finding a reasonable likelihood of success on the Ohata–Kavan obviousness challenge and no basis for discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the arguments and evidence set forth by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’909 patent. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review as to all of the challenged claims of the ’909 patent on all of the grounds of unpatentability set forth therein.” slip op. at 2
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“Contrary to Patent Owner’s arguments, the law on overlapping ranges in obviousness challenges is clear. See In re Peterson, 315 F.3d 1325, 1329 (Fed. Cir. 2003) (“A prima facie case of obviousness typically exists when the ranges of a claimed composition overlap the ranges disclosed in the prior art.”). Here, Petitioner directs us to evidence of an overlapping range, which is not meaningfully disputed by Patent Owner. As to Patent Owner’s arguments regarding the lower end of the claimed range of aspect ratios and Ohata’s warning about aspect ratios below 100, we note that Ohata states that its carbon nanotubes “preferably have an aspect ratio . . . of not less than 100,” and expressly includes examples with an aspect ratio of 50. Ex. 1004 ¶ 20 (emphasis added), Table 2 (Examples 12 and 14). Patent Owner also criticizes Petitioner for relying on oxidizing Ohata’s nanotubes in view of Kavan (discussed in more detail below). Prelim. Resp. 6. According to Patent Owner, oxidation is known to shorten the length of nanotubes, which would impact the aspect ratio of the nanotubes in the proposed combination. Prelim. Resp. 6. Specifically, Patent Owner contends that oxidizing Ohata’s nanotubes will reduce the aspect ratio below 100, and argues that “Petitioner has not explained why a [person of ordinary skill in the art] would ignore Ohata’s warning nor has Petitioner provided evidence that the resulting combination will perform as Petitioner alleges.” Prelim. Resp. 7; see also Prelim. Resp. 8 (arguing Petitioner has not explained why a person of ordinary skill in the art would try to retain Ohata’s aspect ratio and expect success when Ohata is altered in view of Kavan). Even giving Patent Owner’s arguments their full weight, there is no evidence on the present record as to how much the aspect ratio of Ohata’s nanotubes would be reduced as a result of oxidation. Rather, based on the present record, namely, the broad range of aspect ratios disclosed in Ohata (preferably 100–1000), it seems reasonably likely that the aspect ratio of at least some of the oxidized nanotubes in the proposed composition would remain within the range disclosed in Ohata and overlap the claimed range, as Petitioner asserts. Nevertheless, the parties may address during trial the expected level of carbon nanotube shortening in the proposed combination of Ohata and Kavan.” slip op. at 21
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner
“To the extent Patent Owner is presenting a teaching away argument, these statements do not rise to the level of criticizing, discrediting, or discouraging investigation into the claimed invention. DePuy Spine, Inc. v. Medtronic Sofamor Danek, Inc., 567 F.3d 1314, 1327 (Fed. Cir. 2009). Indeed, in addition to its statement regarding oxidation not being necessary for anchoring to TiO2, Kavan also states that oxidation of carbon nanotubes “was sometimes mentioned to improve anchoring of TiO2.” Ex. 1005, 2. Moreover, the full statement from Kavan regarding storage capacity reads: “The Li-storage capacity of TiO2 is not enhanced in the composite, but the rate of electrochemical charge transfer is higher due to nanotube networking.” Ex. 1005, 9. Thus, in its entirety, this statement supports Petitioner’s argument that there are advantages to using oxidized nanotubes, and, in turn, provides a reason why a person of ordinary skill in the art would have used oxidized nanotubes. Moreover, the evidence Petitioner presents regarding the use of oxidized nanotubes in combination with TiO2, coupled with Ohata’s statement that the electrode active material to be used can vary depending on the battery type (Ex. 1004 ¶¶ 26–27), undermines Patent Owner’s criticism that Petitioner’s arguments are circular.” slip op. at 24
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“Although the parties appear to agree that this factor is neutral, we note that a district court denial of a motion to stay without prejudice, accompanied by an indication that the district court would consider a renewed motion, “suggests the district court may be willing to avoid duplicative efforts and await the PTAB’s final resolution of the patentability issues raised in the petition before proceeding with the parallel litigation.” Fintiv at 6–7. “This fact has usually weighed against exercising authority to deny institution.” Id. (also noting that factors 2 and 3 are relevant to how much weight to give to the court’s willingness to reconsider a stay); see also T-Mobile, Paper 16 at 12 (noting that a stay was unlikely in that case given the proximity of the trial date to the entry of the institution decision). In view of the forgoing, we determine that Fintiv factor 1 weighs against exercising our authority to deny institution.” slip op. at 37
§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,808,909 - Ascend Elements, Inc. v. Duesenfeld GmbHInstitutedPTAB · Nov 22, 2024 · IPR2024-00948 · APJ Kevin W Cherry · IPR · Institution
Instituted IPR on claims 1–3, 7–10, 12, 13, and 19 on all asserted grounds; Petitioner showed a reasonable likelihood of prevailing on the Hanisch-Dunagan combinations with added references.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“d) Conclusion Regarding Claim 1 Based on the current record, we determine that Petitioner has shown a reasonable likelihood that it will prevail in demonstrating that claim 1 is unpatentable as obvious over Hanisch in view of Dunagan and Hayashi, Meador, or Shin. 5. Claims 2, 3, and 7–10 Because Petitioner demonstrates a reasonable likelihood of success in proving that at least one claim of the ’097 patent is unpatentable, we institute on all grounds and all claims raised in the Petition. See 37 C.F.R. § 42.108(a). Therefore, at this stage of the proceeding, it is not necessary for us to provide an assessment of every challenge raised by Petitioner, especially, as in this case, when Patent Owner does not separately argue those claims. Those challenges, in our view, are best left for trial after full development of the record.” slip op. at 26
- Skill levelSkill level patent owner adoptedDecided for patent owner
“Petitioner contends that one of ordinary skill in the art “would have had at least a master’s degree in chemical engineering, mechanical engineering, materials science/engineering, or a related field, and three to five years of experience in design and implementation of battery recycling processes.” Pet. 15–16. Patent Owner argues to the contrary that a person of ordinary skill in the art “would have [had] at least a Bachelor’s degree in electrical engineering, materials science, chemical engineering, or an equivalent field, as well as at least 2 to 3 years of academic or industry experience in the recycling or processing of lithium-ion batteries.” Prelim. Resp. 13. On the present record, neither party argues that the result would be any different should we adopt a different definition of a person of ordinary skill in the art. For purposes of this Decision, we adopt Patent Owner’s assessment of the level of ordinary skill in the art, as, on the present record, it appears consistent with the ’097 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner
“Petitioner argues that “[t]he ’097 Patent expressly defines ‘drying’ to mean ‘the removal of at least one solvent in the conducting salt.’” Pet. 16 (quoting Ex. 1001, 2:23–25). Petitioner also argues that “[a]ll other terms should be given their plain and ordinary meaning under Philips and do not need further construction for the purposes of this Petition.” Id. Patent Owner argues that “[n]o claim terms require express construction to determine that the Petition does not establish a reasonable likelihood of unpatentability of any claim and, thus, deny institution.” Prelim. Resp. 13. Based on the present record, we need not expressly construe any claim terms at this time.6 See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 8
- PTAB / AIA Trials › Discretionary denial › General Plastic (serial petitions)Denied
“On the present record, we do not find the relationship between URT and Petitioner to be significant to the degree that raises concerns under Valve and General Plastic. In Valve, two factors affected the determination that there was a significant relationship between the two petitioners at issue: “Valve and HTC were co-defendants in the District Court litigation,” and “the petitions . . . challenge[d] the same claims of the [challenged] patent.” IPR2019-00062, Paper 11, 10. Here, one of these factors is absent, and the other is not entirely present. URT and Petitioner are not co-defendants in the related infringement lawsuit, which accuses only Petitioner. Ex. 2014, 1. As for the claims challenged in the two petitions, Patent Owner is correct that all claims challenged in the present proceeding are also challenged in IPR2024-00887, but the reverse is not true. The petition in IPR2024-00887 challenges claims 15–17 of the ’097 patent, none of which is challenged here. Compare Pet. 3, with IPR2024-00887, Paper 2, 4–5. Thus, there is a significant difference between the present situation and that in Valve.” slip op. at 31
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,050,097 - PTAB · Nov 20, 2024 · IPR2024-00887 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR on claims 1–3, 7–10, 12, 13, and 15–19 on all asserted grounds, finding a reasonable likelihood that claim 12 is anticipated by LithoRec.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“determine whether to institute an inter partes review under 35 U.S.C. § 314 and 37 C.F.R. § 42.4(a). Inter partes review may not be instituted unless “the information presented in the petition filed under [35 U.S.C.] section 311 and any response filed under [35 U.S.C.] section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). “When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a) (2023). For the reasons set forth below, upon considering the briefing and the evidence of record, we determine that the information presented in the Petition establishes a reasonable likelihood that Petitioner will prevail with 1 In the Introduction and section headings of the Petition, Petitioner identifies claims 1–3, 7–9, 12, 13, and 15–19 as the challenged claims. Pet. i–ii. In the substantive content of the Petition, however, Petitioner includes claim 10 as a challenged claim as well. Id. at 34–35. respect to at least one of the challenged claims, and we institute inter partes review on all of the challenged claims based on all of the grounds identified in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had a B.S. degree in electrical engineering, materials science, chemical engineering, or an equivalent field, as well as at least 2 to 3 years of academic or industry [experience] in the recycling or processing of lithiumion batteries.” Pet. 14. On the present record, Patent Owner does not contest Petitioner’s proposed definition of a person of ordinary skill in the art. Prelim. Resp. 19. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as, on the present record, it appears consistent with the ’097 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner argues that “[n]o claim construction is needed,” because “[t]he claims are unpatentable under any reasonable interpretation.” Pet. 15. That said, Petitioner directs us to alleged definitions of several terms in the specification or prosecution history of the ’097 patent. Id. at 15–17. Patent Owner argues that “[c]laim construction is not required to deny the Petition.” Prelim. Resp. 26. Based on the present record, we agree with both parties that we need not expressly construe any claim terms at this time.6 See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 8
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“In order to anticipate a claimed invention, a prior art reference must enable one of ordinary skill in the art to make the invention without undue experimentation.” Impax Labs., Inc. v. Aventis Pharms., Inc., 545 F.3d 1312, 1314 (Fed. Cir. 2008). In addition, “[a]n anticipatory reference need only enable subject matter that falls within the scope of the claims at issue, nothing more.” Schering Corp. v. Geneva Pharms., 339 F.3d 1373, 1381 (Fed. Cir. 2003). slip op. at 10
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,050,097 - Micron Technology, Inc. / Micron Semiconductor Products, Inc. et al. v. Besang Inc.No claims unpatentablePTAB · Nov 13, 2024 · IPR2023-00900 · APJ Jon B Tornquist · IPR · Final written decision
Claims 13–17 were not shown unpatentable: Lee-based grounds fail on the stackable add-on layer limitation, and Watanabe-based grounds fail on nonvolatile memory, enablement, or motivation to combine.
RulingsFinal written decision- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“meaning in the art. See Irdeto Access, Inc. v. Echostar Satellite Corp., 383 F.3d 1295, 1300 (Fed. Cir. 2004) (stating that, absent an accepted meaning in the art, “we construe a claim term only as broadly as provided for by the patent itself”). Thus, we must attempt to discern the meaning of this term from the claim language itself and from the remainder of the intrinsic record. See Vitronics Corp. v. Conceptronic, Inc., 90 F.3d 1576, 1582 (Fed. Cir. 1996) (“It is well-settled that, in interpreting an asserted claim, the court should look first to the intrinsic evidence of record, i.e., the patent itself, including the claims, the specification and, if in evidence, the prosecution history.”). Upon review of the parties’ arguments and the intrinsic record, we agree with Petitioner that the ’702 patent does not support a construction of “stackable add-on layer” that encompasses memory cells formed by sequential deposition on a substrate without being formed and then added to a separately formed substrate.” slip op. at 10
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“As discussed above, we construe “stackable add-on layer” to not include memory cells that are formed by sequential deposition on or above a substrate without being added to a separately formed substrate. It is undisputed, and indeed it is Petitioner’s assertion, that Lee’s memory devices are formed by sequential deposition. See Pet. 52 (asserting that in Lee “the layers of the array are directly deposited on the layers of each underlying level, and the array is deposited on the interlayer insulating layer formed over a substrate”); see also id. at 70 (“Lee discloses forming vertical memory devices through layer-by-layer sequential deposition on the substrate . . . .”). Therefore, Petitioner does not show that Lee discloses every limitation of independent claim 13 under our claim construction. Thus, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious in view of Lee. 3. Claims 14 and 15 Claims 14 and 15 depend from claim 13. Ex. 1001, 12:35–42. Petitioner’s arguments for these claims do not remedy the deficiencies noted above with respect to independent claim 13. Pet. 54–59. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 14 and 15 would have been obvious in view of Lee alone. E. Claims 16 and 17 over Lee and Endoh Petitioner contends the subject matter of claims 16 and 17 would have been obvious over the combined disclosures of Lee and Endoh. Pet. 59–69. Petitioner’s arguments with respect to these claims, however, do not remedy the deficiencies noted above with respect to Lee and its monolithic, sequentially deposited memory array. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 16 and 17 would have been obvious over Lee and Endoh.” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“combined Lee and Watanabe to achieve improved integration density. Pet. 71. Petitioner concedes, however, that the benefits of Lee’s design related to 3-D integration and improved integration density would be obtained if Lee’s memory structures are formed using either Lee’s monolithic construction method or Watanabe’s alternative stacking method. Pet. Reply 13–14 (citing Ex. 1041 ¶ 34). Thus, we are not persuaded that improved integration density provides a sufficient rationale for Petitioner’s combination of Lee’s memory device and Watanabe’s stacking method. Petitioner argues that Watanabe’s stacking method “improves the accuracy of the wiring” because the wiring is made “for each planar member.” Pet. 72 (citing Ex. 1005, 6:1–3). Watanabe also states that its disclosed methods provide “a low interconnection wire resistance.” Ex. 1005, 6:20–23. Petitioner does not, however, explain sufficiently how Watanabe’s stacking method would improve Lee’s device. For example, Petitioner does not address whether the alleged wiring benefit already existed in Lee’s monolithic array or explain how this benefit would also apply to Lee’s particular memory array, which differs in construction and elements from Watanabe’s device. This diminishes Petitioner’s benefits-based motivation to combine arguments. In general, a petitioner need not demonstrate that a particular alternate method would improve a prior art device in order to show a motivation to combine. Intel Corp. v. PACT XPP Schweiz AG, 61 F.4th 1373, 1380–81 (Fed. Cir. 2023); see Pet. Reply 20 (citing Intel). But here, Petitioner affirmatively invokes improvement of Lee’s device as a reason for the combination, and we must evaluate Petitioner’s contention. Moreover, any relative lack of improvement or benefits must be weighed against any problems the alternative method would introduce. See Intel Corp. v. Qualcomm Inc., 21 F.4th 784, 795–96 (Fed. Cir. 2021) (noting that simultaneous advantages and disadvantages to a proposed combination must be analyzed to determine whether the disadvantages “outweighed any reason to combine”). Here, as discussed above in more detail with respect to the ground based on Watanabe, the evidence shows that one of ordinary skill in the art would have expected Watanabe’s bonding temperature of 900– 1000° C to damage the electronic devices in an underlying substrate. Ex. 2029 ¶¶ 75–76; Ex. 2028, 123:13–124:7; Ex. 2027, 715. The expected damage to Lee’s device, when balanced against the limited evidence of a benefit to the combination,7 outweighs the reason to combine Lee and Watanabe set forth in the Petition. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious over Lee and Watanabe. 2. Analysis – Claims 14 and 15 Claims 14 and 15 both depend directly from independent claim 13. Ex. 1001, 12:35–42. Petitioner’s arguments with respect to claims 14 and 15 do not remedy the deficiencies noted above with respect to independent claim 13. Pet. 73. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that these claims would have been obvious over Lee and Watanabe.” slip op. at 40
- Expert testimonyPatent owner expert creditedOther
“We credit the testimony of Dr. Przybylski that one of ordinary skill in the art would have understood that Watanabe’s stacked structure would be severely impacted if bonded at a temperature above 900° C, as disclosed in Watanabe. Ex. 2029 ¶¶ 76–77. Dr. Przybylski’s opinion is supported by Dr. Lee’s testimony (Ex. 2028, 123:13–124:7, 125:6–126:7), as well as Watanabe (Ex. 1005, 6:6–14) and Batude (Ex. 2027, 715). As further discussed below, we find that Petitioner has not rebutted Patent Owner’s showing of nonenablement, and Patent Owner has carried its burden to demonstrate that Watanabe was not enabled for bonding temperatures of 900–1000° C, as of the 2004 filing date of the ’702 patent.” slip op. at 32
Patent outcomesUS 7,378,702 not shown unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,378,702 - PTAB · Oct 23, 2024 · IPR2024-00679 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted review of claims 28, 38, 39, 41–43, 53, 56–59, 61–63, and 65–68 on all asserted grounds after finding a reasonable likelihood that claim 28 was obvious over Krantz and Herrmann.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“determine whether to institute an inter partes review under 35 U.S.C. § 314 and 37 C.F.R. § 42.4(a). Inter partes review may not be instituted unless “the information presented in the petition filed under [35 U.S.C.] section 311 and any response filed under [35 U.S.C.] section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). “When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a) (2023).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had a bachelor’s degree in computer science, computer engineering, or an equivalent, and two years of relevant experience in networking and network security, and related fields.” Pet. 4. Petitioner also asserts that “[l]ack of professional experience can be remedied by additional education, and vice versa.” Id. Patent Owner argues that a person of ordinary skill in the art “would have had a bachelor’s degree in computer science, computer engineering, or electrical engineering and at least three years of experience in networking operating systems and cybersecurity.” Prelim. Resp. 1. Alternatively, Patent Owner argues that a person of ordinary skill in the art would have had “a master’s degree in one of the foregoing and at least two years of experience in the aforementioned fields.” Id. On the present record, neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as, on the present record, it appears consistent with the ’484 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownOther
“Based on the present record, we agree with Patent Owner that the recited “reconfiguring the communication port” at least encompasses changing the association between the input port and output port of the access point. This is supported by the specification of the ’484 patent, which states: “Access Control 320 is configured to send commands to Switch Logic 317 in order to reconfigure members of Ports 305A-305G. This reconfiguration includes modifying the association of members of Ports 305A-305G with different members of VLANs 310A-310D.” Ex. 1501, 9:21–25; see also id. at 8:16–21 (similar disclosure with respect to “configuring and reconfiguring”). Notwithstanding, based on the present record, we do not agree with Patent Owner that “reconfiguring the communication port” is limited to changing the connection between the input port and the output port of the access point. Instead, the ’484 patent makes clear that reconfiguration is merely “typically,” not necessarily, of this type. Ex. 1501, 3:20–25. For this reason, we need not and do not adopt Patent Owner’s proposed construction at this juncture.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“Based on the present record, we find Petitioner’s rationale sufficient for institution. Petitioner points to Krantz’s alleged goals of security and automation. Pet. 19. Petitioner (id.) and Dr. Houh (Ex. 1503 ¶ 64) both cite paragraph 19 of Krantz, which states that “[i]f credentials do not authorize full access . . . the server can respond by sending a notification . . . includ[ing] conditions (e.g., signup, renewal etc.) a user must satisfy to become authorized for []full access to resources.” Ex. 1505 ¶ 19. We are persuaded preliminarily that an ordinarily skilled artisan considering Krantz’s teachings of such conditions for full access would have had reason to apply Herrmann’s technique for checking a client’s antivirus security policy in the manner suggested by Petitioner. See, e.g., Ex. 1503 ¶ 64; Ex. 1506 ¶ 68. Krantz’s express teaching of conditions for a client to fully access a network (Ex. 1505 ¶ 19) also undermines Patent Owner’s argument about impermissible hindsight and Patent Owner’s suggestion that Krantz is limited to user authentication. Finally, we are persuaded that Petitioner has shown sufficiently, for purposes of instituting review, that an ordinarily skilled artisan would have expected success in making the combination because it would only require software modifications to Krantz’s system. See, e.g., Ex. 1503 ¶ 64.” slip op. at 20
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 7,523,484 - PTAB · Oct 23, 2024 · IPR2024-00675 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR on claims 1–6, 11–13, 15–19, and 23–25 on all asserted grounds, finding a reasonable likelihood of success at least on obviousness over Krantz and Herrmann.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“e) Conclusion Regarding Claim 1 Based on the current record, we determine that there is a reasonable likelihood that Petitioner will prevail in demonstrating that claim 1 is unpatentable as obvious in view of Krantz and Herrmann. Accordingly, we institute inter partes review with respect to all grounds asserted in the Petition. 5. Claims 2–6, 11–13, 15–19, and 23–25 Because Petitioner demonstrates a reasonable likelihood of success in proving that at least one claim of the ’484 patent is unpatentable, we institute on all grounds and all claims raised in the Petition. See 37 C.F.R. § 42.108(a). Therefore, at this stage of the proceeding, it is not necessary for us to provide an assessment of every challenge raised by Petitioner, especially, as in this case, when Patent Owner does not separately argue those claims. Those challenges, in our view, are best left for trial after full development of the record.” slip op. at 22
- Parallel petitionsDecided for petitioner
“III. PARALLEL PETITIONS As noted above, Petitioner challenges the ’484 patent both in this proceeding and in IPR2024-00679. Petitioner argues that we should institute review in both proceedings because “the analysis of all 33 challenged claims . . . of the 484 Patent could not reasonably fit within the word limit for a single petition.” Paper 4, 2. Petitioner notes further that “addressing different sets of independent claims in each petition was most efficient given the differences between independent claim 1 (Petition 1 - IPR2024-00675) and independent claims 28, 41, 56, and 57 (Petition 2 - IPR2024-00679).” Id. Patent Owner does not argue that we should deny institution either in this proceeding or in IPR2024-00679 due to Petitioner’s having filed parallel petitions challenging the ’484 patent. Prelim. Resp. 1–44. Given Patent Owner’s acquiescence and Petitioner’s arguments, we do not exercise our discretion to deny institution due to the parallel petitions.” slip op. at 23
- Skill levelSkill level petitioner adoptedOther
“in networking operating systems and cybersecurity.” Prelim. Resp. 1. Alternatively, Patent Owner argues that a person of ordinary skill in the art would have had “a master’s degree in one of the foregoing and at least two years of experience in the aforementioned fields.” Id. On the present record, neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as, on the present record, it appears consistent with the ’484 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Based on the present record, we agree with Patent Owner that the recited “reconfigur[ing] the communication device” at least encompasses changing the association between the input port and output port of the access point. This is supported by the specification of the ’484 patent, which states: “Access Control 320 is configured to send commands to Switch Logic 317 in order to reconfigure members of Ports 305A-305G. This reconfiguration includes modifying the association of members of Ports 305A-305G with different members of VLANs 310A-310D.” Ex. 1501, 9:21–25; see also id. at 8:16–21 (similar disclosure with respect to “configuring and reconfiguring”). Notwithstanding, based on the present record, we do not agree with Patent Owner that “reconfigur[ing] the communication device” is limited to changing the connection between the input port and the output port of the access point. Instead, the ’484 patent makes clear that reconfiguration is merely “typically,” not necessarily, of this type. Ex. 1501, 3:20–25. For this reason, we need not and do not adopt Patent Owner’s proposed construction at this juncture. Based on the present record, we need not expressly construe any other claim terms.3 See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 10
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 7,523,484 - PTAB · Oct 23, 2024 · IPR2024-00676 · APJ Aaron W Moore · IPR · Institution
The Board instituted review of claims 1–4, 7–10, 14, 16, 22–23, 25, and 27 on the asserted obviousness ground based on Krantz and Herrmann.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“combination of Krantz and Herrmann (see Pet 19–99) and find that, on the record as it now stands, Petitioner has established a reasonable likelihood that it will prevail with respect to at least one claim. As described above,” slip op. at 16
- Skill levelSkill level petitioner adoptedDecided for petitioner
“ordinary skill in the art “would have had a bachelor’s degree in computer science, computer engineering, or an equivalent, and two years of relevant experience in networking and network security, and related fields.” Pet. 4. Petitioner also asserts that “[l]ack of professional experience can be remedied by additional education, and vice versa.” Id.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“combination of Krantz and Herrmann (see Pet 19–99) and find that, on the record as it now stands, Petitioner has established a reasonable likelihood that it will prevail with respect to at least one claim. As described above,” slip op. at 16
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportNot reached
“qualifies as prior art to the ’450 patent “because the InfoExpress inventors conceived of the invention [of the ’450 patent] before the effective dates [of Krantz and Herrmann] and exercised reasonably continuous diligence in reducing the claimed inventions to practice.” Prelim. Resp. 33–45. Petitioner disagrees that the present record sufficiently shows that the inventors of the ’450 patent conceived of the invention before the effective date of Krantz or Herrmann and that the inventors exercised reasonably continuous diligence in reducing that invention to practice. See Prelim. Reply 1–7. In particular, Petitioner raises questions with respect to the independence of Patent Owner’s evidence from the inventor testimony that evidence is intended to corroborate, as well as with respect to whether the evidence offered by Patent Owner sufficiently shows conception, reduction to practice, and reasonably continuous diligence. Id. We do not think the information of record is sufficient to antedate Krantz and Herrmann such that we should deny institution of inter partes review on that basis. First, Patent Owner’s arguments rely on the testimony of inventor Stacey C. Lum, who has not yet been subject to cross-examination. See Prelim. Resp. 35–45 (citing Ex. 2003). Second, Petitioner identifies several issues where further development of the record may be helpful. For example, Patent Owner’s asserted date of conception is associated with the date of an engineering specification included in the record as Exhibit 2011. See Prelim. Resp. 35–36 (citing Ex. 2003 ¶ 12; Ex. 2011; Ex. 2012). We agree with Petitioner (see Prelim. Reply 4–5) that it is unclear, based on the present record, whether Exhibit 2011 corroborates the testimony supporting Patent Owner’s conception date given that the present record does not establish the author of Exhibit 2011. See Ex. 2003 ¶ 22 (inventor Stacey C. Lum testifying only that “InfoExpress personnel drafted EX2011”). These and other issues relating to the prior-art status of Krantz and Herrmann are, in our view, best left for trial after full development of the record.3” slip op. at 15
Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 8,677,450 - PTAB · Oct 11, 2024 · IPR2024-00772 · APJ Monica S Ullagaddi · IPR · Institution
The Board instituted IPR on all challenged claims and petition grounds, found the merits threshold met, and granted Texas Instruments’ motion to join IPR2024-00001.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“3. Analysis At this stage of the proceeding, we determine that Patent Owner’s statements made during prosecution of the ’195 patent appear to contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support Petitioner’s argument tthat a graded dopant concentration is enough to teach aiding carrier movement in a particular direction. Patent Owner does not dispute that Kawagoe has a graded dopant concentration in the active region at this stage of the proceeding. Id. Patent Owner also does not dispute that Kawagoe’s transistor has carriers in the active region or that the graded dopant concentration of Kawagoe is lowered from the surface to the bottom substrate (Ex. 1007, Fig. 17). Id. At this stage of the proceeding, the evidence of record supports Petitioner’s position sufficiently to meet the reasonable likelihood threshold for institution. We decline to make further determinations, on this preliminary record, regarding the dispute surrounding this limitation, because the trial in the 00001IPR is the better proceeding in which to do so. Specifically, as compared to the preliminary phase of this case, the instituted trial in the 10 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1016, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. 00001IPR affords the parties a better opportunity to fully and fairly brief, argue, and develop evidence in support of their positions. We observe, on this record, the dispute is inadequate to undermine the sufficiency of Petitioner’s evidence to support institution of review.” slip op. at 14
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the 1 The Leahy-Smith America Invents Act (“AIA”), Pub. L. No. 112-29, 125 Stat. 284 (2011), amended 35 U.S.C. § 103, effective March 16, 2013. Because applications from which the ’481 patent claims priority were filed before this date, the pre-AIA version of § 103 applies. 2 U.S. Patent No. 6,043,114, issued Mar. 28, 2000 (Ex. 1007, “Kawagoe”). 3 U.S. Patent No. 6,163,877, issued Dec. 19, 2000 (Ex. 1014, “Gupta”). 4 U.S. Patent Publication No. 2003/0183856 A1, published Oct. 2, 2003 (Ex. 1006, “Wieczorek”). 5 Petitioner cites four volumes for Wolf: Stanley Wolf & Richard Tauber, Silicon Processing For The VLSI Era, Volume 1 – Process Technology, 2nd ed., (Lattice Press 2000) (Ex. 1008A); Stanley Wolf & Richard Tauber, Silicon Processing For The VLSI Era, Volume 2 – Process Integration, (Lattice Press 2000) (Ex. 1008B); Stanley Wolf & Richard Tauber, Silicon Processing For The VLSI Era, Volume 3 – The Submicron MOSFET, (Lattice Press 2000) (Ex. 1008C); and Stanley Wolf & Richard Tauber, Silicon Processing For The VLSI Era, Volume 4 – Deep-Submicron Process Technology, (Lattice Press 2000) (Ex. 1008D). petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 14– 35. However, 35 U.S.C. § 315(b) also provides that the one-year time bar “shall not apply to a request for joinder under subsection (c).” 37 C.F.R. § 42.122(b). Because the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted 00001IPR proceeding, which we grant as further discussed below, Patent Owner’s argument that the Petition is timebarred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 4
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“Based on the facts and circumstances discussed above, having reviewed the briefings of both parties, we determine Petitioner has established good cause for joining the 00001IPR. Specifically, we find that joining Petitioner to the 00001IPR is unlikely to require any delay or modification to the scheduling order already in place for the 00001IPR. We also determine that Patent Owner will not be prejudiced unduly by the joinder of this proceeding. Thus, we determine that granting the Motion for Joinder under these circumstances would help “secure the just, speedy, and inexpensive resolution” of these proceedings. See 37 C.F.R. § 42.1(b). For the above reasons, we grant Petitioner’s Motion for Joinder and join Petitioner as a party to the 00001IPR.” slip op. at 19
NonePatents in suitUS 10,734,481 - PTAB · Oct 11, 2024 · IPR2024-00774 · APJ Jon B Tornquist · IPR · Institution
The Board instituted IPR on all challenged claims and petition grounds, and granted Texas Instruments’ motion to join the Cirrus IPR.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“IPR. Compare id., with IPR2024-00019, Paper 46 at 1–4, 6–22 (Patent Owner’s response in the Cirrus IPR) (public version). We decline to resolve the material issue of fact surrounding this limitation on this preliminary record, because the trial in the Cirrus IPR is the better proceeding in which to do so. Specifically, as compared to the preliminary phase of this case, the instituted trial in the Cirrus IPR affords the parties a better opportunity to fully and fairly brief, argue, and develop evidence in support of their positions, and, in particular, to address Cirrus Logic’s alleged admission that the existence of a gradient alone is insufficient to disclose the “aid carrier movement” limitations of independent claims 1 and 21. We observe only that, on this record, the disputed issue of material fact is not sufficient to undermine the sufficiency of Petitioner’s evidence supporting institution of review.” slip op. at 16
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 15– 35. The one-year time bar under § 315(b), however, “shall not apply to a request for joinder under subsection (c).” 35 U.S.C. § 315(b); see 37 C.F.R. § 42.122(b). And, because the Petition is accompanied by a timely request for joinder (Paper 1) to the instituted proceeding (IPR2024-00019), which we grant as further discussed below, Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 8
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“Based on the facts and circumstances discussed above, we determine Petitioner has established good cause for joining the Cirrus IPR. Specifically, we find that joining Petitioner to the Cirrus IPR is unlikely to require any delay or modification to the scheduling order already in place for that proceeding. We also determine that Patent Owner will not be prejudiced unduly by the joinder of this proceeding. Thus, we determine that granting the Motion for Joinder would help “secure the just, speedy, and inexpensive resolution” of these proceedings. See 37 C.F.R. § 42.1(b). Accordingly, we grant Petitioner’s Motion for Joinder and join Petitioner as a party to the Cirrus IPR.” slip op. at 19
NonePatents in suitUS 11,316,014
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.