- Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - PTAB · Oct 6, 2025 · IPR2025-00611 · APJ Christopher L Ogden · IPR · Institution
The Board instituted IPR of claims 1–10, 12, 13, 19, and 20 on all petition grounds after finding a reasonable likelihood that claim 1 was obvious over Douglas and Mark.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“A claim is unpatentable under § 103 “if the differences between the claimed invention and the prior art are such that the claimed invention as a whole would have been obvious before the effective filing date of the claimed invention to a person having ordinary skill in the art to which the claimed invention pertains.” 35 U.S.C. § 103; see KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 406 (2007). When a ground in a petition is based on a combination of references, we consider “whether there was an apparent reason to combine the known elements in the fashion claimed by the patent at issue.” KSR, 550 U.S. at 418 (citing In re Kahn, 441 F.3d 977, 988 (Fed. Cir. 2006)).” slip op. at 8
- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties agree that experience could substitute for a degree, and vice versa. Pet. 3 (citing Ex. 1003 ¶¶ 19–21); Prelim. Resp. 9. The parties’ proposed levels of ordinary skill are substantially similar. Although we discern no difference in the outcome of this decision from choosing one over the other, we adopt Petitioner’s proposal for this decision. Only Petitioner’s proposed level is supported by testimonial evidence on the preliminary record, and it appears to be consistent with the problems addressed in the ’774 patent. See Ex. 1001, 1:16–52. Therefore, we adopt Petitioner’s proposal for this decision.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“CLAIM CONSTRUCTION B. In an IPR, we construe a patent claim “using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” 37 C.F.R. § 42.100(b). This generally includes “construing the claim in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id. The ordinary and customary meaning of a claim term “is its meaning to the ordinary artisan after reading the entire patent,” and “as of the effective filing date of the patent application.” Phillips, 415 F.3d at 1313, 1321. Neither Petitioner nor Patent Owner argues that we need to construe any claim terms explicitly. See Pet. 2–3; Prelim. Resp. 9. However, the parties’ positions depend on interpreting the claim language in a particular way, and we discuss the relevant claim language below in the context of the parties’ arguments regarding the prior art. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“At this stage, we find Petitioner’s arguments persuasive and disagree with Patent Owner. Patent Owner appears to equate a “fabrication profile” with a toolpath description, but nothing in the plain language of claim 1 supports that narrow interpretation. The ’774 patent describes a “fabrication profile” broadly and states that the profile can simply “include the dictionary [of configuration information],” or be “used to determine which machineready representation is available or suitable for a target printer.” Ex. 1001, 23:49–52. The preliminary evidence suggests that Douglas’s “operational parameters” would count as a “fabrication profile” because it is “the basis for generation of a machine-ready representation of the three-dimensional model that is executable on the target printer.” Id. at 23:37–39; see infra Section III.C.8. We also disagree that Petitioner’s argument is impermissible hindsight, because it is based on the disclosures in Douglas and Mark, and Petitioner has articulated a sufficiently persuasive reason to combine those references without referring to the ’774 patent itself. See In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971) (an obvious rationale is not improper hindsight if it “takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure”). Finally, Petitioner appears to rely on Mark for providing a particular example of a fabrication profile, not to replace Douglas’s overall system in which the 3D printer can receive “operational parameters” rather than just G-code. See Pet. 8–10, 17–23; see also Ex. 1005 ¶ 41 (the print queue, which stores tool instructions, may be maintained locally on printers 204 or on print servers 208); see In re Mouttet, 686 F.3d 1322, 1332 (Fed. Cir. 2012) (“[A] determination of obviousness based on teachings from multiple references does not require an actual, physical substitution of elements.” (citing In re Etter, 756 F.2d 852, 859 (Fed. Cir. 1985) (en banc))).” slip op. at 19
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,886,774 - PTAB · Oct 3, 2025 · IPR2025-00680 · APJ Karl D Easthom · IPR · Institution
The Board instituted IPR of claims 2 and 3 on all grounds in the Petition and granted Nintendo’s motion to join IPR2024-00807, subject to participation limits.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“II. ANALYSIS A. Institution of Inter Partes Review We instituted an inter partes review in the Apple IPR on all challenged claims and all asserted grounds of unpatentability. Apple IPR, Paper 10 (institution decision); see also Apple IPR, Paper 2 (the “Apple Petition”). Petitioner here challenges the same claims and asserts the same grounds of unpatentability as those on which we instituted the Apple IPR. Compare Pet. 2, with Apple Petition 1; see also Mot. 1 (asserting the instant “Petition is substantively identical to Apple Inc.’s petition (‘Apple Petition’) in the Apple IPR, including that it relies on the same expert declaration,” and asserting “the same grounds presented in the Apple IPR”). As indicated, Petitioner also relies on the same declarant as did the petition in the Apple IPR. Mot. 1; compare Ex. 1003 (Hannaford Declaration), with Apple IPR, Ex. 1003 (same). Because the grounds of unpatentability in the instant Petition are identical to those in the Apple IPR and for the same reasons stated in our Decision to Institute in the Apple IPR, we institute inter partes review in this proceeding on the grounds presented in the Petition. See Apple IPR, Paper 10 (analyzing challenges in the Apple Petition).” slip op. at 7
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“We determine that Petitioner has met its burden of showing that joinder is appropriate because, as set forth above, the Petition (1) is substantially identical to the Apple Petition, (2) contains the same grounds based on the same evidence, and (3) relies on the same declaration, the Hannaford Declaration (Ex. 1003). Mot. 1, 4. Petitioner represents that “joinder will not negatively impact the Apple IPR trial schedule” and “expressly consents to the existing trial schedule.” Id. at 10; see also id. at 7 (“Proceeding with a consolidated inter partes review would avoid potential inconsistency, promote efficient review of the same claims for the same patent under the same grounds, and would result in a final written decision without delay.”). Petitioner also represents that as “long as Apple remains in the joined IPR, Nintendo remains in a limited ‘silent understudy’ role that does not actively participate in the IPR.” Id. at 8. The record supports Petitioner. In addition, the final written decision in the Apple IPR is due to issue on or before October 15, 2025, with the Oral Hearing complete and no further briefing due. See IPR 2024-00807, Paper 15 (Oral Hearing Transcript); Paper 18, 2–3. Therefore, as Petitioner argues, joinder by Petitioner will have little or no impact on the trial schedule in the Apple IPR. On the other hand, if the Board denies joinder, Petitioner submits that it “intends to file a separate petition for IPR (‘Second Petition’) that includes grounds in addition to some (or all) of the grounds in the Apple IPR.” Mot. 14.” slip op. at 10
NonePatents in suitUS 8,860,337 - Cradlepoint, Inc. / Honeywell International, Inc. et al. v. Sisvel S.P.A.No claims unpatentablePTAB · Sep 29, 2025 · IPR2021-00580 · APJ Monica S Ullagaddi · IPR · Remand
On remand, the Board held claims 1–10 not shown unpatentable under the Sachs anticipation and obviousness grounds because Sachs did not disclose the required timer stopping, and the new theories were not considered.
RulingsRemand decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Whether Mr. Bates is a Person of Ordinary Skill in the Art In the Final Written Decision, we adopted Petitioner’s definition because “there does not appear to be a dispute that needs to be resolved.” FWD 8. Here, where Mr. Bates’ qualifications are challenged, we have reviewed the complete record including the parties’ arguments on remand and we find that Mr. Bates does not meet the requirements for a person of ordinary skill in the art according to Petitioner’s definition for level of ordinary skill in the art, which we adopted (see FWD 8). Notably, the panel adopted Petitioner’s definition of the level of ordinary skill in the Institution Decision (Paper 16, 8), and neither party challenged that determination during the trial, although Patent Owner did offer its own definition (PO Resp. 9). Mr. Bates has one degree: “a bachelor’s degree in Business Management.” Ex. 2001 ¶ 7. A degree in Business Management is not “a degree in electrical engineering or a similar discipline.” Pet. 35 (emphasis added). Accordingly, we disregard the testimony of Mr. Bates in rendering our findings and conclusions in this Decision. We note that, even if we did consider Mr. Bates’s testimony, the findings and conclusions rendered in this Decision would not change.” slip op. at 12
- Expert testimonyPatent owner expert discountedDecided for petitioner
“cover for his lack of education.” Pet. Remand Br. 4. Patent Owner disagrees and argues, inter alia, that “Mr. Bates was a pioneer in the cellular telecommunications field with more than five decades of practical and teaching experience.” PO Remand Resp. 5 (citing Ex. 2001 ¶¶ 8–23) (emphasis omitted); see id. at 3–4, 6. Whether Mr. Bates is a Person of Ordinary Skill in the Art In the Final Written Decision, we adopted Petitioner’s definition because “there does not appear to be a dispute that needs to be resolved.” FWD 8. Here, where Mr. Bates’ qualifications are challenged, we have reviewed the complete record including the parties’ arguments on remand and we find that Mr. Bates does not meet the requirements for a person of ordinary skill in the art according to Petitioner’s definition for level of ordinary skill in the art, which we adopted (see FWD 8). Notably, the panel adopted Petitioner’s definition of the level of ordinary skill in the Institution Decision (Paper 16, 8), and neither party challenged that determination during the trial, although Patent Owner did offer its own definition (PO Resp. 9). Mr. Bates has one degree: “a bachelor’s degree in Business Management.” Ex. 2001 ¶ 7. A degree in Business Management is not “a degree in electrical engineering or a similar discipline.” Pet. 35 (emphasis added). Accordingly, we disregard the testimony of Mr. Bates in rendering our findings and conclusions in this Decision. We note that, even if we did consider Mr. Bates’s testimony, the findings and conclusions rendered in this Decision would not change.” slip op. at 12
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for patent owner
“C. Claim Construction The Federal Circuit determined that “the plain and unambiguous language of claim 1 requires that a method, to come within the claim, must perform both limitations 1[c] and 1[d] where their preconditions apply.” Sierra Wireless, 130 F.4th at 1022. We interpret the claims and analyze Petitioner’s unpatentability arguments under the Federal Circuit’s determination.” slip op. at 13
- Strike new argumentNew argument disregardedDecided for patent owner
“Petitioner was on notice, when Patent Owner’s Response was filed at the latest, that claim 1 could be construed as unconditionally requiring both limitations 1[c] and 1[d]. Indeed, Petitioner contended that it had shown both limitations “in single references.” Pet. Reply 5. Petitioner now seeks to shift its unpatentability contentions for limitation 1[c] from Figure 5 of Sachs to Figures 6 and 7. Petitioner’s new reliance on Figures 6 and 7 of Sachs is “a meaningfully distinct contention” from its position in both the Petition and the Reply. See Ariosa Diagnostics v. Verinata Health, Inc., 805 F.3d 1359, 1367 (Fed. Cir. 2015). We therefore find that Petitioner impermissibly presents new theories of unpatentability on remand. 3. Independent Claim 1 We decline to address Petitioner’s new theories of unpatentability proposed on remand concerning Sachs’s Figure 7. See Pet. Remand Br. 15– 20. Although Petitioner cites pages 59–61 of the Petition as discussing Figure 7 of Sachs (see Pet. Remand Br. 15), the cited discussion concerns dependent claims 5 and 10, not independent claims 1 and 8.” slip op. at 17
Patent outcomesUS 7,869,396 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,869,396 - PTAB · Sep 15, 2025 · IPR2025-00632 · APJ Mitchell G Weatherly · IPR · Institution
The Board instituted IPR on all challenged claims and grounds, finding a reasonable likelihood that claims 1, 2, 7–9, 11, 12, and 20–24 are obvious over Yamaguchi-727.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Cerebrum Sensor Technologies, Inc. (“Patent Owner”) timely filed a Preliminary Response. Paper 9 (“Prelim. Resp.”).1 Institution of an inter partes review is authorized by statute when “the information presented in the petition filed under section 311 and any response filed under section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Based on our review of the record, we conclude that Petitioner is reasonably likely to prevail with respect to at least one of the challenged claims.” slip op. at 2
- BurdenInstituted
“We disagree. Positioning module 6 to face a “predetermined direction” is a form of preventing movement that falls within the scope of limitation 1b. Moreover, Yamaguchi-727 uses a method for preventing movement of its module 6 in its housing 20, silicone potting material, that is expressly recognized by the Specification of the ’421 patent when it states: “A common technique used to assist in fixturing the electrical sensor device 40 known within the automotive industry is to fill the internal cavity with a coating material such as a neutral silicone or the like for purposes of retaining placement position.” Ex. 1001, 13:56–60. Although the Specification also asserts that the sensor assemblies disclosed in the 421 patent “do not use or require the use of any such coating or filing agents or materials for any fixturing of the electrical sensor device 40,” id. at 13:61–64, limitation 1b merely requires that the “sensor device . . . is disposed within the internal cavity and attached therein to prevent movement of the device within the internal cavity,” id. at 30:25–27. Absent a persuasive argument to the contrary, we preliminarily conclude that Yamaguchi-727’s use of potting material to hold its module 6 in place within its housing 20 meets the requirements of limitation 1b. Both parties are encouraged to adduce intrinsic evidence relating to the meaning of limitation 1b at trial. For all the reasons set forth above, we find that Petitioner has established a reasonable likelihood of proving the Yamaguchi-727 renders claim 1 unpatentable as obvious. 2. Dependent Claims 2, 7–9, 11, 12, and 20–24 Petitioner identifies the portions of Yamaguchi-727 that teach the limitations introduced in dependent claims 2, 7–9, 11, 12, and 20–24, all of which ultimately depend from claim 1. Pet. 32–40. Patent Owner relies upon its argument that Petitioner’s showing for claim 1 is deficient as the reason why Petitioner’s challenge to dependent claims 2, 7–9, 11, 12, and 20–24 fails. We reject this argument for the reasons stated in Part II.C.1 above. Based on our review of Petitioner’s otherwise uncontested argument and evidence cited in support, we find that Petitioner also establishes a reasonable likelihood of proving that Yamaguchi-727 renders dependent claims 2, 7–9, 11, 12, and 20–24 unpatentable as obvious. D. Remaining Challenges” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“Petitioner complies with the requirement of identifying “[h]ow the claim language is to be construed” by setting forth proposed interpretations of various claim terms in the table above.7 Both cases cited by Patent Owner relate to an issue presented by a petitioner’s alleged inconsistent handling of whether a claim term is subject to interpretation as a means-plus-function element under 35 U.S.C. § 112(f). Orthopediatrics Corp. v. K2M, Inc., IPR2018-01546, Paper 10 at 11 (PTAB Feb. 14, 2019); 10x Genomics, Inc. v. President and Fellows of Harvard College, IPR2023- 7 Neither party has identified any claim language that might invoke interpretation as a means-plus-function limitation, and we discern no such claim language. Additionally, we do not imply that a petitioner must always propose express interpretations for specific claim language to comply with Rule 42.104(b)(3). Rather, we only note that Petitioner has, by any measure, complied by expressly proposing interpretations for identified claim language.” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“We disagree. Positioning module 6 to face a “predetermined direction” is a form of preventing movement that falls within the scope of limitation 1b. Moreover, Yamaguchi-727 uses a method for preventing movement of its module 6 in its housing 20, silicone potting material, that is expressly recognized by the Specification of the ’421 patent when it states: “A common technique used to assist in fixturing the electrical sensor device 40 known within the automotive industry is to fill the internal cavity with a coating material such as a neutral silicone or the like for purposes of retaining placement position.” Ex. 1001, 13:56–60. Although the Specification also asserts that the sensor assemblies disclosed in the 421 patent “do not use or require the use of any such coating or filing agents or materials for any fixturing of the electrical sensor device 40,” id. at 13:61–64, limitation 1b merely requires that the “sensor device . . . is disposed within the internal cavity and attached therein to prevent movement of the device within the internal cavity,” id. at 30:25–27. Absent a persuasive argument to the contrary, we preliminarily conclude that Yamaguchi-727’s use of potting material to hold its module 6 in place within its housing 20 meets the requirements of limitation 1b. Both parties are encouraged to adduce intrinsic evidence relating to the meaning of limitation 1b at trial. For all the reasons set forth above, we find that Petitioner has established a reasonable likelihood of proving the Yamaguchi-727 renders claim 1 unpatentable as obvious. 2. Dependent Claims 2, 7–9, 11, 12, and 20–24 Petitioner identifies the portions of Yamaguchi-727 that teach the limitations introduced in dependent claims 2, 7–9, 11, 12, and 20–24, all of which ultimately depend from claim 1. Pet. 32–40. Patent Owner relies upon its argument that Petitioner’s showing for claim 1 is deficient as the reason why Petitioner’s challenge to dependent claims 2, 7–9, 11, 12, and 20–24 fails. We reject this argument for the reasons stated in Part II.C.1 above. Based on our review of Petitioner’s otherwise uncontested argument and evidence cited in support, we find that Petitioner also establishes a reasonable likelihood of proving that Yamaguchi-727 renders dependent claims 2, 7–9, 11, 12, and 20–24 unpatentable as obvious. D. Remaining Challenges” slip op. at 11
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,835,421 - Comcast Cable Communications, LLC v. Entropic Communications, LLCSome claims unpatentablePTAB · Sep 5, 2025 · IPR2024-00431 · APJ Jon M Jurgovan · IPR · Final written decision
Claims 1, 3, and 4 are unpatentable as obvious over Afshary and Mirfakhraei; claim 2 was not shown unpatentable over either asserted combination.
RulingsFinal written decision- Skill levelSkill level board ownDecided for petitioner
“Patent Owner’s proposal to limit a POSITA’s education and experience to “broadband networks over coaxial cables” is too narrow. Although Patent Owner points to various parts of the ’518 patent as supporting its restrictive proposal, other parts of the patent are not so limited. For example, the patent’s technical field and summary are not limited to coaxial cable, and the patent discusses twisted pair wiring and satellite communications as media that can be used. See, e.g., Ex. 1001, 1:27–29, 3:33–35, 3:49–50, 3:67–4:3, 5:61–6:3, 8:20–23, 9:28–33. Accordingly, we adopt the following level of ordinary skill in the art for use in this Decision: A POSITA would have a bachelor’s degree in electrical engineering, computer engineering, or a related field, and two to four years of experience with broadband communication networks. Additional professional experience could substitute for education, and additional education could substitute for professional experience. We find that this skill level is consistent with the problems and solutions identified in the ’518 patent and the prior art references asserted by Petitioner. In addition, we find the adopted skill level consistent with the education and experience that a POSITA would have had. See In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citing Custom Accessories, Inc. v. Jeffrey-Allan Indus., Inc., 807 F.2d 955, 962 (Fed. Cir. 1986)) (citing factors to consider when determining level of ordinary skill in the art).” slip op. at 15
- Expert testimonyDecided for petitioner
“We determine that Mr. Bertonis and Mr. Garrett had at least the skill level of a POSITA at the time they submitted their declarations and testimony in this case. Ex. 1002 ¶¶ 4–15, Appx. A; Ex. 2001 ¶¶ 8–12, Appx. A; cf Osseo Imaging, LLC v. Planmeca USA Inc., 116 F.4th 1335 1341 (Fed. Cir. 2024) (“An expert need not have acquired that skill level prior to the time of the invention to be able to testify from the vantage point of a person of ordinary skill in the art.”). Accordingly, we see no reason to disregard the testimony of either on the basis that they do not have a POSITA’s skill level.” slip op. at 45
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesTerm construed petitioner constructionDecided for petitioner
“Because an assessment of whether the prior art discloses a means- plus-function limitation depends not only on the presence of the recited function but also the structure that performs that function as described in the patent’s specification, we address Petitioner’s undisputed contentions for the means-plus-function limitations below.” slip op. at 12
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“We conclude that Petitioner has shown by preponderant evidence that Mirfakhraei is in the same field of endeavor as the ’518 patent, i.e., “broadband communication networks.” Mirfakhraei is thus analogous art because it is in the same field of endeavor as the ’518 patent.” slip op. at 27
Patent outcomesUS 7,295,518 mixedClaim construction§ 103 obviousnesscites GrahamPatents in suitUS 7,295,518 - Comcast Cable Communications, LLC v. Entropic Communications, LLCSome claims unpatentablePTAB · Sep 4, 2025 · IPR2024-00430 · APJ Jon M Jurgovan · IPR · Final written decision
Claims 1–3, 6–10, 14–18, and 22–24 are unpatentable; claims 4–5, 11–13, and 19–21 are not shown unpatentable.
RulingsFinal written decision- Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageTerm construed board ownDecided for petitioner
“We agree with Petitioner that the ’690 patent does not limit the term “probe” to channel assessment. Pet. Reply 2–4. Reviewing the intrinsic evidence, the “Technical Field” of the ’690 patent states that “some embodiments relate to channel assessment probes,” implying others do not. Ex. 1001, 1:13–14. The ’690 patent further states that “receiver determined probes may be used in a variety of applications” including to “discover hidden nodes” and “off-site network diagnosis.” Id. at 2:20–27. In addition, the ’690 patent states that probes may be used for “network maintenance procedures,” to “replicate a potential problem, reach or discover a distant or previously undetected node on the network, or assist with network admissions procedures.” Id. at 4:25–38. Turning to the claims of the ’690 patent, the evidence of record does not establish that the independent claims recite anything unique or specific to channel assessment (although their scope covers that purpose). Furthermore, dependent claim 7 of the ’690 patent recites that the “probe” is used to diagnose a network problem, and dependent claim 13 recites that the “probe” is used to identify a hidden node. Restricting the independent claims to probes used solely for channel assessment would be contradictory to these dependent claims. Littlefuse, Inc. v. Mersen USA EP Corp., 29 F.4th 1376, 1380 (Fed. Cir. 2022) (construction of term in independent claims should not render dependent claims superfluous or lacking scope).” slip op. at 20
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownDecided for petitioner
“We agree with Petitioner that a “physical layer probe” is “a probe that relates to the physical layer.” The term does not appear per se in the specification of the ’960 patent, nor in the prosecution history, but only in claims 9, 17, and 19. However, the term “physical layer” is well-known and is the first layer in the Open Systems Interconnection (OSI) network model. See, e.g., Ex. 1021, 35–40, 69; Ex. 1002 ¶¶ 49–50. The physical layer is used to transmit digital bits over a network, and defines the timing, mechanical, and physical network characteristics required for transmitting the data bits. Hence, a “physical layer probe” is a probe that relates to the physical layer. We need not, and do not, construe the term further to resolve the parties’ dispute. See Realtime, Vivid Techs., supra. Having decided proper constructions for the disputed terms, we proceed in our analysis to consider the parties’ arguments concerning the challenge grounds. In the following sections, we apply the plain meaning of the claim terms, and as necessary, specify what the plain meanings are.” slip op. at 23
- Skill levelSkill level petitioner adoptedDecided for petitioner
“C. Level of Ordinary Skill in the Art Petitioner contends as follows: A POSITA8 would have had a bachelor’s degree in electrical engineering, computer engineering, or a similar discipline, and three to four years of experience working in signal processing and/or communication systems/networks. Additional education may substitute for experience, and significant work experience may substitute for formal education. Pet. 6 (citing Ex. 1002 ¶¶ 115–120). Patent Owner does not dispute Petitioner’s proposed level of skill in the art. We adopt and apply Petitioner’s proposed skill level because it is consistent with the problems and solutions identified in the ’690 patent and the prior art references asserted by Petitioner. In addition, we find the adopted skill level consistent with the education and experience that a POSITA would have had. See In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citing Custom Accessories, Inc. v. Jeffrey-Allan Indus., Inc., 807 F.2d 955, 962 (Fed. Cir. 1986)) (citing factors to consider when determining level of ordinary skill in the art).” slip op. at 25
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableNot shown unpatentableMixed
“Hence, we determine that Petitioner has shown by preponderant evidence that the Ranging Request (“probe request”) message includes CID and SS MAC address and other parameters (“first plurality of parameters”) which at least specify the CID (“content payload of the probe”) and the SS MAC address (“second node”) of the Ranging Response.12 We thus proceed to consider Petitioner’s contentions for the remaining limitations of claim 1, which are undisputed, and determine that claim 1 is anticipated by IEEE-802.16.” slip op. at 29
Patent outcomesUS 8,284,690 mixedClaim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 8,284,690 - Comcast Cable Communications, LLC v. Entropic Communications, LLCAll claims unpatentablePTAB · Sep 3, 2025 · IPR2024-00441 · APJ Aaron W Moore · IPR · Final written decision
Claims 1–18 are unpatentable over Kamieniecki and Konstantinos; Petitioner did not show claims 1–18 unpatentable over Renken or Renken and Cholas because Renken is not prior art.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Level of Ordinary Skill in The Art Petitioner contends that a person having ordinary skill in the art “would have had a degree in electrical engineering or a similar discipline, and three-to-four years of experience working with television signal processing and communication 1 Because the challenged claims have an effective filing date before the effective date of the AIA, we apply the pre-AIA version of 35 U.S.C. § 103. 2 US 2005/0114879 A1, published May 26, 2005 (Ex. 1009). 3 US 2010/0120386 A1, published May 13, 2010 (Ex. 1010). 4 US 2010/0303181 A1, published Dec. 2, 2010 (Ex. 1016). 5 US 2008/0313691 A1, published Dec. 18, 2008 (Ex. 1017). 6 US 8,649,421 B2, issued Feb. 11, 2014 (Ex. 1011). systems,” and that “[a]dditional education may substitute for professional experience and significant work experience may substitute for formal education.” Pet. 30 (citing Ex. 1002 ¶¶ 40–42). “Patent Owner accepts the Petition’s [description of a person of ordinary skill] solely for purposes of responding to the Petition in this proceeding.” PO Resp. 11. Based on our review of the record before us, we determine that Petitioner’s stated level of ordinary skill in the art is reasonable because it appears consistent with the evidence of record, including the asserted prior art. Accordingly, we apply Petitioner’s definition in this Decision. B.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“On the present record, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). C.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“We agree that the record provides sufficient evidence that one of ordinary skill in the art would have found it advantageous to add a multi-channel receiver to improve monitoring, as Petitioner argues. Having the ability to monitor without waiting for idle or disturbing users would be a clear advantage.” slip op. at 18
- Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner
“We conclude that Patent Owner has not shown a sufficient nexus between the claimed invention and any product embodying the claimed invention that was successful, praised, or solved a long-felt need. Patent Owner identifies five elements allegedly required “[t]o implement MaxLinear’s Remote Spectrum Monitoring in CPE.” See PO Resp. 65. To support this, Patent Owner cites pages 5–7 of Exhibit 2009. See id.7 That exhibit, however, describes requirements for “Full Band Capture,” not MaxLinear’s “Remote Spectrum Monitoring.” To” slip op. at 31
Patent outcomesUS 8,792,008 unpatentableClaim construction§ 102 anticipation§ 103 obviousnessPatents in suitUS 8,792,008 - Comcast Cable Communications, LLC v. Entropic Communications, LLCAll claims unpatentablePTAB · Aug 29, 2025 · IPR2024-00446 · APJ Aaron W Moore · IPR · Final written decision
Claims 1–20 are unpatentable as obvious over the asserted combinations of Rabenko, Gaspar, and Kim, with additional references for certain dependent claims.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“the invention “would have had at least a degree in computer or electrical engineering, computer science, information systems, or a similar discipline, along with three-to-four years of experience with the design and/or implementation of cable modems within network-based content delivery systems” and that “[a]dditional education may substitute for professional experience, and significant work experience [could have] substitute[d] for formal education.” Pet. 12 (citing Ex. 1002 ¶¶ 40–45). Patent Owner does not challenge the level of ordinary skill in the art proposed by Petitioner and its expert, so we adopt Petitioner’s proposal, which we find to be reasonable and consistent with the ’775 patent’s specification and the cited prior art. B.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“Despite some disagreement during the briefing about the meaning of “DOCSIS controller,” the parties now appear to agree that Patent Owner’s suggested construction is generally correct. See PO Resp. 13 (“[T]he claimed DOCSIS controller must control DOCSIS functions. This does not mean that it must control all DOCSIS functions or all DOCSIS functions identified in the specification.”); Sur-reply 1 (“Under its plain meaning, a ‘DOCSIS controller’ must control or implement one or more DOCSIS functions.”); Tr. 66:19–21 ([Q]: “And as long the controller performs one of those functions that of, for DOCSIS, it qualifies as a DOCSIS – [Petitioner’s Counsel]: “It’s a DOCSIS function [sic, controller] in our point of view.”). We accordingly construe “DOCSIS controller” to mean “a physical or functional controller that controls, implements, or performs a DOCSIS function.” It is not limited to a certain number or category of DOCSIS functions.” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableMotivation foundUnpatentable
“We do not agree with Petitioner’s obvious to try theory because Petitioner does not show that the “few finite options” were known in the prior art. However, we nevertheless agree with Petitioner that it would have been obvious for the cable modem engine to have been configured to enable upgrades to its software in a manner that is independent of upgrades to the software of the data networking engine. This is primarily because this limitation appears to require little more than that a software update could change the cable modem functionality (e.g., the PacketCable or DOCSIS functionality) without changing the data networking engine functionality (e.g., the CableHome functionality). See Ex. 1001, 3:49–62. Gaspar, for example, shows that one of ordinary skill would recognize that the evolution of standards in this field requires controller upgrades, and a software update addressing only a change in the PacketCable standard (because only that standard had changed, for example) would be an upgrade to the cable modem software that would be independent of any upgrades to data networking engine software. We credit Dr. Kiaei’s testimony that one of ordinary skill “would have understood that two different engines performing two different functions and using two different protocols (DOCSIS and PNA) should be separately upgradeable to address protocol changes independently.” Ex. 1002 ¶ 123.” slip op. at 27
- Obviousness (§103) › Analogous artUnpatentableAnalogous artUnpatentable
“We agree with Petitioner that use of these ARM processors would have been an obvious design choice, given that they were known to be useful in applications “that demand the highest levels of performance with small size, low cost, and low power consumption.” Ex. 1016 ¶ 8. 5 Put another way, we conclude that claims limiting an otherwise obvious system to off-the-shelf hardware of the type generally suitable for the purpose does not make the subject matter non-obvious. Regarding whether Klein and Kim ʼ678 are analogous art, we find that they are pertinent to the problem confronting the ’775 patent inventors who would have been looking for processors suitable for implementation of the invention, and Klein and Kim ʼ678 indicate that these processors would be suitable in applications that, though different, also implicated similar size, cost, and power consumption considerations. For these reasons, having carefully considered the fully developed record, we conclude that the Petition has established that the combination of Rabenko, Klein, and Kim ʼ678 teaches or suggests use of the claimed ARM processors.” slip op. at 31
Patent outcomesUS 8,223,775 unpatentableClaim construction§ 103 obviousnessPatents in suitUS 8,223,775 - PTAB · Aug 25, 2025 · IPR2025-00631 · APJ Kevin W Cherry · IPR · Institution
The Board instituted IPR on claims 1–3, 5, 7–9, 11–13, and 15–22 on all five asserted § 103 grounds, finding a reasonable likelihood of success on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“institute an inter partes review. The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted unless “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The Supreme Court has held that the Board, in a decision to institute under 35 U.S.C. § 314(b), may not institute review on less than all claims challenged in the petition. SAS Inst. Inc. v. Iancu, 138 S. Ct. 1348, 1355–56 (2018). Moreover, in accordance with our rules, “[w]hen instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a) (2020); see also PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018) (interpreting the statute to require “a simple yes-or-no institution choice respecting a petition, embracing all challenges included in the petition”). Applying those standards, and upon considering the Petition, the Preliminary Response, and the evidence of record, we determine the information presented shows a reasonable likelihood that Petitioner would prevail in establishing the unpatentability of at least one of the challenged claims of the ’027 patent. Accordingly, we institute an inter partes review of all challenged claims (i.e., 1–3, 5, 7–9, 11–13, and 15–22) of the ’027 patent, based on the grounds asserted in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art would have “possessed an undergraduate degree in chemistry, polymers, materials science, chemical engineering (or related field) and one to two years of experience with constructing and manufacturing tires, tire patches, tire decals/stickers and/or the like.” Pet. 8 (citing Ex. 1003 ¶¶ 6–11). According to Petitioner, “Additional education could compensate for less practical experience. Conversely, additional practical experience could compensate for less education.” Id. Patent Owner does not provide an alternate definition, but, “Patent Owner does not acquiesce to, and reserves the right to address, [Petitioner’s] definition of a POSA.” Prelim. Resp. 6 n.6. Petitioner’s proposed definition appears to be consistent with the disclosure of the ’027 patent, and we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that the prior art itself may “reflect[] an appropriate level” of ordinary skill in the art) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“Having considered the record, we determine that no express claim construction is necessary for any claim terms. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“We disagree with Patent Owner’s contentions that these disclosures indicate that Wilson’s patch would not meet the construction of “barrier material composition.” None of these disclosures even suggests that the base of Wilson’s patch is rigid as Patent Owner suggests. To begin with, the fact that the housing is “more rigid” provides no information about the absolute rigidness of the patch. See Ex. 1009, 9:16–21. As for the disclosure that the patch is contoured (id. at 3:35–67), Patent Owner provides only attorney argument to support its contention that the contour demonstrates that Wilson’s patch must be so rigid that it cannot be meet the claim limitation. In contrast, Petitioner demonstrates that Wilson discloses using the exact same materials described in the challenged patent (see Ex. 1001, 6:33–58 (noting “[e]lastomeric materials useful for forming the intermediate layer 24 include but are not limited to gum rubber, vulcanized natural rubber SBR . . . or comparable materials”); Ex. 1009, 3:49–55 (noting the patch may be constructed from natural rubber (NR), a preferred mixture of chlorobutyl rubber and natural rubber (CR/NR), or a preferred mixture of SBR and natural rubber (SBR/NR)), and provides detailed testimony from its expert to support its contentions (see Ex. 1003 ¶¶ 114–119). On the current record, we find Petitioner’s reasoning and evidence to be persuasive, and find that Petitioner has shown sufficiently that Willson discloses or teaches this limitation.” slip op. at 20
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,124,027
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.