- PTAB · Oct 8, 2025 · IPR2025-00530 · APJ Scott C Moore · IPR · Institution
Instituted review of claims 1–9 on all petition grounds after finding a reasonable likelihood that claim 1 is obvious over Whitmarsh.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). If we institute an inter partes review, the trial must encompass all claims and grounds identified in the Petition. 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”). For the reasons set forth below, we conclude that there is a reasonable likelihood that Petitioner will prevail in establishing the unpatentability of at least one of the challenged claims. We, therefore, institute inter partes review of claims 1–9 on the grounds asserted in the Petition. B.” slip op. at 2
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesDecided for petitioner
“permission module,” as used in claim 1, has “a well understood structural meaning in the computer technology field.” 792 F.3d at 1350. Rather, the limitation in question is “drafted in the same format as a traditional means-plus-function limitation, and merely replaces the term ‘means’ with ‘nonce’ word ‘module,’ thereby connoting a generic ‘black box’ for performing the recited computer-implemented functions.” Id. And, while claim 1 recites the “outputs” of the permission module (i.e., a determination regarding the permissions of an aerial system), “the claim does not describe how the [permission module] interacts with other components in the [discrimination system] in a way that might inform the structural character of the limitation- in-question or otherwise impart structure to the [permission module] as recited in the claim.” Id. at 1351. We also reviewed the Specification, and we agree with Petitioner that the Specification identifies the following structure as corresponding to the claimed permission module: “storage on-board the disruption module 105, storage on-board the identification receiver 102, a remote computing system connected to the disruption module…, or [] any other suitable computing system.” See Pet. 12; Ex. 1001, 9:64–10:4. slip op. at 7
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableInstituted
“from nearby UAVs wireless communications that include information or signatures unique to the UAVs, such as a MAC [media access control] address of the UAV, that is used to identify the transmitting UAV.” Pet. 16– 18 (citing Ex. 1005 ¶¶ 20, 27; Ex. 1006 ¶¶ 8, 10, 13, 15–17; Ex. 1003 ¶¶ 117–118). For example, Petitioner cites Whitmarsh’s teachings that “[a]ll drones have a unique identifier, such as a media access control (MAC) address, that can be determined or read by the DDS [drone defense system] and can be used to identify the drone.” Id. at 16 (quoting Ex. 1006 ¶ 13). Based on these teachings, Petitioner submits that the signal received from the UAVs includes an aerial system identifier signal unique to the aerial system. Id. at 17–18 (citing Ex. 1005 ¶ 27; Ex. 1006 ¶ 13).” slip op. at 10
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 10,249,199 - PTAB · Oct 8, 2025 · IPR2025-00525 · APJ Scott C Moore · IPR · Institution
The Board instituted review of claim 21 on all asserted grounds after finding a reasonable likelihood it is obvious over Beard.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). If we institute an inter partes review, the trial must encompass all claims and grounds identified in the Petition. 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”). For the reasons set forth below, we conclude that there is a reasonable likelihood that Petitioner will prevail in establishing the unpatentability of claim 21, the sole challenged claim. We, therefore, institute inter partes review of claim 21 on the grounds asserted in the Petition. B.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“[E]ither (1) a Bachelor of Science in Mechanical Engineering, Electrical Engineering, Aerospace engineering, or an equivalent field, as well as at least 2 years of academic or industry experience in the aerospace, avionics, telecommunications, or electronic device manufacturing industry, or (2) at least four years of industry experience in any of the above industries. Pet. 21 (citing Ex. 1003 ¶ 47). Patent Owner does not presently dispute Petitioner’s proposed formulation. See generally Prelim. Resp. For 3 U.S. Patent App. Pub. No. US 2016/0253907 A1, published Sept. 1, 2016 (Ex. 1010). 4 PCT Pub. No. WO 2016/078093 A1, published May 26, 2016 (Ex. 1011). 5 PCT Pub. No. WO 2016/154949 A1, published Oct. 6, 2016 (Ex. 1012). 6 U.S. Pat. App. Pub. No. US 2016/0127890 A1, published May 5, 2016 (Ex. 1013). 7 PCT Pub. No. WO 2015/043123 A1, published Apr. 2, 2015 (Ex. 1014). purposes of this Decision, we adopt and apply Petitioner’s formulation regarding the level of ordinary skill in the art because it is (1) consistent with the ’959 Patent and the asserted prior art; and (2) it is supported by the testimony of Dr. Chowdhary. B.” slip op. at 5
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner
“But before describing the embodiments cited by Patent Owner, the Specification plainly states: “Any terms not expressly defined herein have their conventional meaning as commonly understood by those having skill in the relevant art(s).” Ex. 1001, 4:64–67. Thus, the Specification itself cautions against construing the claim terms such as “secure identifier” as limited to the scope of the disclosed embodiments. Here, Patent Owner has not cited any express definition of “secure identifier,” or identified any explicit disclaimer of claim scope that might justify narrowing the scope of this claim term to specific embodiments disclosed in the Specification. In the absence of such a definition or disclaimer, we are not persuaded that the scope of the claim term “secure identifier” should be limited to specific aspects of the preferred embodiments cited by Patent Owner. See Prelim. Resp. 7–14. On this record, and at this stage of the proceeding, we decline to adopt Patent Owner’s proposed construction and preliminarily construe “secure identifier” as “a credential that can be used to securely verify the identity of a device, such as an airborne object or ground-based transmitter.”8” slip op. at 10
- Disclosure Requirements (§112) › Written description (Ariad)Written description inadequateNot entitled to earlier dateDecided for petitioner
“’071 Application lack adequate written description support for the “secure identifier” claim limitation. For a patent claim to be entitled to the priority date of an earlier-filed application, the earlier application must provide complete written description support for the claim as required by 35 U.S.C. § 112(a). L.A. Biomedical Rsch. Inst. at Harbor-UCLA Med. Ctr. v. Eli Lilly & Co., 849 F.3d 1049, 1057 (Fed. Cir. 2017) (“L.A. Biomed”). To satisfy this requirement, the written description must “reasonably convey” to a person of ordinary skill in the art that the inventor had possession on the claimed priority date of each limitation of the later-claimed subject matter. L.A. Biomed, 849 F.3d at 1057. It is not enough that an earlier application’s disclosure “renders the later-claimed invention obvious;” as “the disclosure must describe the claimed invention with all its limitations.” L.A. Biomed, 849 F.3d at 1057. On this record, we agree with Petitioner that the ’153 Provisional and ’071 Application lack adequate written description support for the “secure identifier” limitation of claim 21. We have preliminarily construed “secure identifier” as “a credential that can be used to securely verify the identity of a device, such as an airborne object or ground-based transmitter.” See supra § II.B. As discussed above, the Specification of the ’959 Patent does not use the term “secure identifier,” but the Specification contains extensive discussion of the need for an identification credential that is secure (e.g., difficult for a bad actor to clone or impersonate). See, e.g., Ex. 1001, 1:56– 65 (discussing the need for a system that is difficult to “clone”), 10:20–49 (discussing the need “trust” between a drone and ground-based equipment, and the need for a way to verifying the drone’s credentials), 11:5–12:62 (disclosing the use of encryption and a rotating SSID to generate a secure identifier for a drone). None of the portions of the Specification cited above is present in the ’153 Provisional or the ’071 Application. See generally Ex. 1006, 1007. The ’153 Provisional and ’071 Application discuss the need for identifiers for low-altitude aircraft (see, e.g., Ex. 1006, 2; Ex. 1007, 9), but there is no discussion of any need for an identification credential to be secure or resistant to cloning or impersonation. See generally Ex. 1006, 1007. The ’153 Provisional and ’071 Application do not disclose the use of encryption, SSIDs (much less rotating SSIDs), or any other technologies for the purpose of verifying the authenticity of an identification credential. See generally id. Based on our review of the ’153 Provisional and ’071 Application, we preliminarily conclude that neither of these applications would have reasonably conveyed to a person of ordinary skill in the art that the inventor then had possession of the concept of the “secure identifier” that was later claimed in the ’959 Patent.” slip op. at 12
Claim construction§ 103 obviousness§ 112 disclosurecites Phillips · GrahamPatents in suitUS 10,713,959 - Anthony Inc. v. Controltec, LLCInstitutedPTAB · Sep 30, 2025 · IPR2025-00636 · APJ Barry L Grossman · IPR · Institution
The Board instituted IPR on claims 1–20 and all asserted grounds, finding a reasonable likelihood of success on claim 8 over Carter.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). The Board determines whether to institute a trial on behalf of the Director. 37 C.F.R. § 42.4(a).” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDecided for petitioner
“On July 16, 2025, the Acting Director issued her decision, which denied Patent Owner’s request for discretionary denial and referred this case to the Board. Paper 9, 3. The Decision stated “Petitioner provides persuasive reasoning, supported by evidence, that the Office erred in a manner material to the patentability of the challenged patents during patent examination, and, accordingly, discretionary denial under 35 U.S.C. § 325(d) is not appropriate.” Id. The Decision also stated “it is an appropriate use of Office resources to review the potential error.” Id. As stated in the Acting Director’s decision, “the Petitions [in IPR2025-00559; 00636] are referred to the Board to handle the cases in the normal course, including by issuing a decision on institution addressing the merits and other nondiscretionary considerations, as appropriate.” Id. (emphasis added). Thus, the scope of our delegated authority only extends to “the merits and other nondiscretionary considerations.” Accordingly, we do not address the discretionary denial issue raised in the Petition and in the Patent Owner’s Preliminary Response.” slip op. at 6
- Skill levelSkill level petitioner adoptedDecided for petitioner
“For purposes of this Decision, based on the prior art, the sophistication of the disclosed technology in the ’847 patent, and Dr. Henze’s undisputed testimony, we adopt Petitioner’s definition of the level of ordinary skill.8” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Ltd., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). We do not perceive the need to construe any claim limitation at this time. Our conclusion concerning instituting an inter partes review would be unaffected by a determination that the preambles of the claims are limiting. Accordingly, for this initial Decision to institute an inter partes review, the words “display” or “frame,” and the term “display case” will be given their ordinary and customary meaning as would have been understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. slip op. at 15
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 7,421,847 - Samsung Electronics Co., Ltd. / Samsung Electronics America, Inc. et al. v. Chien-Min SungAll claims unpatentablePTAB · Sep 17, 2025 · IPR2024-00533 · APJ Frances L Ippolito · IPR · Final written decision
Claims 1–8 are unpatentable as obvious: claims 1, 3–8 over Chou and Sung ’479; claims 6–7 also over SungECS; and claim 2 over Goers.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“We secondly conclude a POSITA would have had at least two years of experience designing and/or developing CMP technology per Patent Owner’s formulation, but we reject Patent Owner’s additional contention that this experience must include designing and/or developing pad dressers specifically. The ’270 patent claims are directed to the structure of a pad dresser, not to a method of making a pad dresser. See Ex. 1001, 17:35– 18:38. According to the ’270 patent specification, the claimed pad dresser structure is designed to condition a polishing pad so the pad may be used to attain “high performance levels in aspects such as uniformity of polished wafer, smoothness of the IC circuitry, removal rate for productivity, longevity of consumables for CMP economics, etc.” during a CMP process. Id. at 1:20–24 (Background of the Invention). Thus, the ’270 patent’s invention generally focuses on optimizing a pad dresser structure to achieve desired results in a CMP process, not necessarily on how to manufacture a pad dresser. As such, we reject Petitioner’s POSITA formulation requiring “experience in the field of integrated circuit processing and fabrication techniques” (Pet. 19) as too generic in the context of the ’270 patent’s claimed invention. We also conclude, in view of the ’270 patent disclosures discussed above, that Dr. Tsai’s opinion that ordinary skill requires experience with manufacturing pad dressers (see Ex. 2011 ¶ 28) is too conclusory and lacking in evidentiary support to be persuasive. See Best Med. v. Elekta, 46 F.4th at 1353 (“The patent’s purpose can also be informative.”).” slip op. at 9
- ExcludeMotion to exclude, deniedDenied
“The Federal Circuit has held: “To offer expert testimony from the perspective of a skilled artisan in a patent case — like for claim construction, validity, or infringement — a witness must at least have ordinary skill in the art.”9 Kyocera Senco Indus. Tools Inc. v. Int’l Trade Commission, 22 F.4th 1369, 1375–77 (Fed. Cir. 2022); see also Osseo Imaging, LLC v. Planmeca USA Inc., 116 F.4th 1335, 1340–41 (Fed. Cir. 2024) (holding that the proffered expert does not need to have acquired the 9 Petitioner cites the Practice Guide’s statements that there is “no requirement of a perfect match between the expert’s experience and the relevant field” and “[a] person may not need to be a person of ordinary skill in the art in order to testify as an expert under Rule 702, but rather must be ‘qualified in the pertinent art.’” Practice Guide 34 (citing SEB v. Montgomery Ward, 594 F.3d at 1373; Sundance v. DeMonte, 550 F.3d at 1363–64). To the extent there is any tension between the Practice Guide (issued in 2019) and the Kyocera holding (issued in 2022), we apply the latter here.” slip op. at 12
- Expert testimonyPetitioner expert creditedDecided for petitioner
“We determine Dr. Shanfield has sufficient education and experience to qualify as a person of ordinary skill in the art pertaining to the ’270 patent. Dr. Shanfield’s Ph.D. in physics satisfies the educational prerequisite of at least a bachelor’s degree in an engineering related field such as physics. See Ex. 1002 ¶ 2, App. A. Furthermore, his advanced degree (Ph.D. in physics) versus ordinary skill (a bachelor’s degree in an engineering related field) provides considerable leeway when turning to the experiential component for ordinary skill. Nonetheless, Dr. Shanfield also has at least two years of experience with designing and developing CMP technology per the experience prerequisite, as follows. Dr. Shanfield worked at Raytheon Corporation for over 10 years, during which he “worked directly with engineers in the selection, installation, and optimization of several chemo-mechanical polishing systems (CMP), including analysis of operational maintenance and performance monitoring,” and he “directly participated in establishing the required metrology (optical thickness monitoring) for maintaining polishing uniformity standards.” Ex. 1002 ¶ 3 (emphasis added). He later joined Draper Laboratory in 2003, where he currently is the Division Leader of Advanced Hardware Development. See id. ¶ 5. During Dr. Shanfield’s time at Draper, the laboratory “acquired several semiconductor-grade CMP systems for the purpose of fabricating multi-chip modules and for planarization operations in MEMS devices,” and he was “involved in their operation and optimization.” Id. (emphasis added). When asked during a deposition whether he is “an expert in CMP equipment design,” Dr. Shanfield stated he is “very familiar with the design of CMP equipment” because he has “seen many systems” and “installed or supervised the installation of systems.” Ex. 2003, 17:22–19:3. He testified he has “designed apparatus that worked with CMP equipment” although he has not “designed the CMP equipment itself.” Id. at 18:13–19. As an example of being “involved in the manufacture of CMP pad dressers” specifically, Dr. Shanfield stated that during his time at Raytheon, he worked with other professionals “to use the CMP system to process MEMS, M-E-M-S, devices” which “needed a certain kind of planarization process [that] required constant conditioning,” so the team “had to try to fabricate something that would provide conditioning that would last longer.” Id. at 19:4–20:9. Thus, we conclude Dr. Shanfield qualifies as a POSITA pertaining to” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“apply the same claim construction standard “used in the federal courts, in other words, the claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. [§] 282(b),” which is articulated in Phillips v. AWH Corp., 415 F.3d 1303 (Fed. Cir. 2005) (en banc). 83 Fed. Reg. 51,340, 51,358 (Oct. 11, 2018) (amending 37 C.F.R. § 42.100(b) effective November 13, 2018) (now codified at 37 C.F.R. § 42.100(b) (2019)). Under the Phillips standard, the “words of a claim are generally given their ordinary and customary meaning,” which is “the meaning that the term would have to a person of ordinary skill in the art in question at the time of the invention, i.e., as of the effective filing date of the patent application.” Phillips, 415 F.3d at 1312–13. Petitioner proposes constructions for terms: “superabrasive,” “protrusion,” “sharp portion,” and “attitude.” Pet. 20–21. Patent Owner does not propose constructions for any claim term. See generally, PO Resp. We discern constructions of these claim phrases or others are not required for the purposes of this Decision. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 15
Patent outcomesUS 8,974,270 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,974,270 - Samsung Electronics Co., Ltd. / Samsung Electronics America, Inc. et al. v. Chien-Min SungSome claims unpatentablePTAB · Sep 17, 2025 · IPR2024-00535 · APJ George R Hoskins · IPR · Final written decision
Claims 1–9 and 12–21 are unpatentable over the asserted grounds; claims 10 and 11 were not shown unpatentable because Tsai and Sung ’026 did not establish the required number of working particles.
RulingsFinal written decision- Skill levelOther
“Level of Ordinary Skill in the Art and Patent Owner’s Motion to Exclude Dr. Shanfield’s Testimony ..................................................... 9 1. Person of Ordinary Skill in the Art Pertaining to the ’802 Patent .................................................................................... 9 2. Patent Owner’s Motion to Exclude Dr. Shanfield’s” slip op. at 2
- ExcludeMotion to exclude, deniedDenied
“Level of Ordinary Skill in the Art and Patent Owner’s Motion to Exclude Dr. Shanfield’s Testimony ..................................................... 9” slip op. at 2
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“16–18 being obvious over Tsai and Sung ’026 as our own in this Decision. See Pet. 56–62, 70–75. We accordingly conclude a preponderance of the evidence presented here establishes the unpatentability of these claims. Patent Owner has waived any opposition other than his filing date priority arguments discussed above. See Inst. Dec. 78; Paper 15, 10.” slip op. at 106
- Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner
“concluded: “It is not clear to us, and Dr. Shanfield does not explain persuasively, how Tsai’s disclosure that its ODD has more cutters (i.e., working particles per claim 9) than the conventional BDD leads to his conclusion that all of the diamond particles in the ODD are cutters.” Inst. Dec. 76 (emphasis added). Patent Owner urges us to maintain that conclusion, for various reasons, including testimony from Dr. Tsai. See PO Resp. 49–52; Ex. 2011 ¶¶ 43–47. Patent Owner also reiterates his opposition to Dr. Shanfield’s “extrapolation” from Tsai’s Figures to reach a conclusion as to the total number of diamond grits in the Tsai ODD, including the “working” particles of claims 8, 9, and 12. See id. at 50–51 (citing Ex. 1002 ¶¶ 186–189).” slip op. at 108
Patent outcomesUS 9,724,802 mixed§ 103 obviousnesscites KSR · GrahamPatents in suitUS 9,724,802 - Samsung Electronics Co., Ltd. / Samsung Electronics America, Inc. et al. v. Chien-Min SungAll claims unpatentablePTAB · Sep 17, 2025 · IPR2024-00534 · APJ Barry L Grossman · IPR · Final written decision
Claims 1–20 are unpatentable: claims 1–6, 9–12, and 20 are anticipated by or obvious over Sung ’026; claims 5–10 and 13–19 are obvious over the listed combinations.
RulingsFinal written decision- Skill levelSkill level board ownDecided for patent owner
“We secondly conclude a POSITA would have had at least two years of experience designing and/or developing CMP technology per Patent Owner’s formulation, but we reject Patent Owner’s additional contention that this experience must include designing and/or developing pad dressers” slip op. at 21
- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
“In his deposition testimony, Dr. Tsai testifies that the Sung ’026 patent application publication “intends to make a diamond disk that has all the protrusion[s] with identical heights and with the same orientation.” Ex. 1049, 50:2–4. Dr. Tsai also testified that “[i]n addition, [Sung ’026] also intends to control the depths of penetrating into the pad. For example, if I want to penetrate 10 micron into the pad, then the protrusion height should be at least 10 micron.” Id. at 50:10–13. So, contrary to Dr. Tsai’s Declaration testimony in Ex. 2011 ¶ 69, Dr. Tsai clarifies in his deposition testimony that Sung ’026 intends to combine three distinct aspects or embodiments. He testifies that “first one is that you need to have the same orientation, same shape so you can have the consistency; and No. 2, you would like to have the same height; and No. 3, you would like to control the penetration depths.” Ex. 1049, 51:2–6. Dr. Tsai was then asked “[s]o Sung ’026 is trying to combine all three of those together, correct?” Id. at 51:9– 10. His answer was “[t]hat’s correct, because if you can have a very good control of those, then -- and that time period back then, then you can make a very perfect diamond disk.” Id. at 51:11–13. Based on the evidence as discussed above, we determine that Sung ’026 discloses the elements and limitations in clause 1[C]. In particular, we credit Dr. Shanfield’s testimony (as summarized above) over Dr. Tsai’s declaration testimony, because Dr. Tsai’s deposition testimony essentially agreed with Dr. Shanfield that Sung ’026 discloses all the aspects recited in claim 1 together in a single embodiment.” slip op. at 48
- ExcludeMotion to exclude, deniedDenied
“Moreover, our general approach for considering challenges to the admissibility of evidence was outlined in Corning Inc. v. DSM IP Assets B.V., IPR2013-00053, Paper 66 at 19 (PTAB May 1, 2014). As stated in Corning, similar to a district court in a bench trial, the Board, sitting as a non-jury tribunal with administrative expertise, is well-positioned to determine and assign appropriate weight to evidence presented. Id. (citing Donnelly Garment Co. v. NLRB, 123 F.2d 215, 224 (8th Cir. 1941) (stating, in the context of reviewing an administrative determination of the National Labor Relations Board based on findings by a Trial Examiner, “We think that experience has demonstrated that in a trial or hearing where no jury is present, more time is ordinarily lost in listening to arguments as to the admissibility of evidence and in considering offers of proof than would be consumed in taking the evidence proffered . . . One who is capable of ruling accurately upon the admissibility of evidence is equally capable of sifting it accurately after it has been received . . . .”)). Moreover, “there is a strong public policy for making all information filed in an administrative proceeding available to the public.” Liberty Mut. Ins. Co. v. Progressive Cas. Ins. Co., CBM2012-00010, Paper 59 at 40 (PTAB February 24, 2014). Rather than excluding evidence that is allegedly hearsay, confusing, misleading, untimely, and/or irrelevant, we will simply not rely on it or give it little or no probative weight, as appropriate, in our analysis. “In an inter partes review, we regard it as the better course to have a complete record of the evidence to facilitate public access, as well as appellate review.” Sony Computer Entm’t Am. LLC v. Game Controller Tech. LLC, IPR2013-00634, Paper 32 at 31 (PTAB Apr. 14, 2015); see also Gnosis S.p.A. v. S. Alabama Med. Sci. Found., IPR2013-00118, Paper 64 at 43 (PTAB June 20, 2014) (citing Donnelly, 123 F.2d at 224 (“If the record on review contains not only all evidence which was clearly admissible, but also all evidence of doubtful admissibility, the court which is called upon to review the case can usually make an end of it, whereas if evidence was excluded which that court regards as having been admissible, a new trial or rehearing cannot be avoided.”)).” slip op. at 32
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“According to Patent Owner, Petitioner’s argument is that “several distinct portions of Sung ’026 purportedly, when viewed together, disclose an embodiment that satisfies the recitation of Claim Limitation [1C].” Id. at 20. Patent Owner asserts, however, that “these individual embodiments of Sung ’026—which it describes in separate portions of the reference as discrete ‘aspects’ of the invention of Sung ’026—cannot not be used collectively to satisfy the anticipation standard.” Id. (citing Net MoneyIN, 545 F.3d at 1371). Simply put, it is Patent Owner’s position that because Sung ’026 fails to disclose these various aspects in a single embodiment as Claim Limitation [1C] recites, Sung ’026 cannot anticipate claim 1. It is Petitioner’s position that Dr. Tsai’s deposition testimony supports Petitioner’s assertions that Sung ’026 anticipates independent claim 1 because the various alleged “individual embodiments” are part of a unified whole that overcome the circumstances discussed in Net MoneyIN. In his deposition testimony, Dr. Tsai testifies that the Sung ’026 patent application publication “intends to make a diamond disk that has all the protrusion[s] with identical heights and with the same orientation.” Ex. 1049, 50:2–4. Dr. Tsai also testified that “[i]n addition, [Sung ’026] also intends to control the depths of penetrating into the pad. For example, if I want to penetrate 10 micron into the pad, then the protrusion height should be at least 10 micron.” Id. at 50:10–13. So, contrary to Dr. Tsai’s Declaration testimony in Ex. 2011 ¶ 69, Dr. Tsai clarifies in his deposition testimony that Sung ’026 intends to combine three distinct aspects or embodiments. He testifies that “first one is that you need to have the same orientation, same shape so you can have the consistency; and No. 2, you would like to have the same height; and No. 3, you would like to control the penetration depths.” Ex. 1049, 51:2–6. Dr. Tsai was then asked “[s]o Sung ’026 is trying to combine all three of those together, correct?” Id. at 51:9– 10. His answer was “[t]hat’s correct, because if you can have a very good control of those, then -- and that time period back then, then you can make a very perfect diamond disk.” Id. at 51:11–13. Based on the evidence as discussed above, we determine that Sung ’026 discloses the elements and limitations in clause 1[C]. In particular, we credit Dr. Shanfield’s testimony (as summarized above) over Dr. Tsai’s declaration testimony, because Dr. Tsai’s deposition testimony essentially agreed with Dr. Shanfield that Sung ’026 discloses all the aspects recited in claim 1 together in a single embodiment.” slip op. at 48
Patent outcomesUS 9,138,862 unpatentable§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 9,138,862 - PTAB · Sep 9, 2025 · IPR2025-00389 · APJ Kevin W Cherry · IPR · Institution
The Board instituted IPR of claims 1–22 on all asserted grounds after finding a reasonable likelihood that at least one challenged claim would be shown unpatentable as obvious.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“institute an inter partes review. The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted unless “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The Supreme Court has held that the Board, in a decision to institute under 35 U.S.C. § 314(b), may not institute review on less than all claims challenged in the petition. SAS Inst. Inc. v. Iancu, 138 S. Ct. 1348, 1355–56 (2018). Moreover, in accordance with our rules, “[w]hen instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a) (2025); see also PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018) (interpreting” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“contends that a person of ordinary skill in the art for the ’498 patent “would have had a Bachelor’s Degree in Physics or an Engineering field relevant to battery technology (e.g., Electrical or Mechanical Engineering) and at least two years of industry experience in lithium-ion battery manufacturing and/or design.” Pet. 3 (citing Ex. 1003 ¶¶ 27–30).” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner “does not believe any claim terms require specific construction.” Pet. 10–11. Patent Owner states “no claim construction is necessary to deny institution because Patent Owner’s arguments for denial do not rely on the outcome of an actual controversy about claim interpretation.” Prelim. Resp. 10. Having considered the record, we determine that no express claim construction is necessary for any claim terms. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the controversy (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 11
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner
“Patent Owner may be correct that the invention Takemura discloses seeks to improve on the “conventional” design disclosed in Figures 8 and 9, and, as part of its description of its inventions, Takemura discloses a variety of benefits to its approach over the approach disclosed in Figures 8 and 9. However, that does not negate the teachings provided in Figures 8 and 9. “A reference must be considered for everything it teaches by way of technology and is not limited to the particular invention it is describing and attempting to protect.” EWP Corp. v. Reliance Universal Inc., 755 F.2d 898, 907 (Fed. Cir. 1985) (emphases in original). As Petitioner explains, Sato discloses the use of tape, but does not provide details regarding its precise size and placement. See Pet. 34–39. Petitioner relies on Takemura for teaching how such tape would be sized and placed. Id. Indeed, Takemura teaches that such a placement was used in “conventional” lithium-ion batteries at the time. “It’s not necessary to show that a combination is “the best option, only that it be a suitable option.” Intel Corp. v. Qualcomm Inc., 21 F.4th 784, 800 (Fed. Cir. 2021) (quoting PAR Pharm., Inc. v. TWI Pharms., Inc., 773 F.3d 1186, 1197–98 (Fed. Cir. 2014)). Here, Petitioner only relies on Takemura for teaching how the tape disclosed in Sato would be sized and placed. Although Takemura might teach a different ultimate approach, that does not diminish Takemura’s teachings of a known size and placement that was conventionally used in the art. “[I]f a technique has been used to improve one device, and a person of ordinary skill in the art would recognize that it would improve similar devices in the same way, using the technique is obvious unless its actual application is beyond his or her skill.” KSR, 550 U.S. at 417. Thus, we are not persuaded, on the current record, that Takemura teaches away from the particular combination that has been proposed.” slip op. at 24
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,923,498 - PTAB · Aug 26, 2025 · IPR2025-00432 · APJ Kevin W Cherry · IPR · Institution
The Board instituted IPR of claims 1–19 on all asserted grounds after finding a reasonable likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“institute an inter partes review. The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted unless “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The Supreme Court has held that the Board, in a decision to institute under 35 U.S.C. § 314(b), may not institute review on less than all claims challenged in the petition. SAS Inst. Inc. v. Iancu, 138 S. Ct. 1348, 1355–56 (2018). Moreover, in accordance with our rules, “[w]hen instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a) (2020); see also PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018) (interpreting the statute to require “a simple yes-or-no institution choice respecting a petition, embracing all challenges included in the petition”). Applying those standards, and upon considering the Petition, the Preliminary Response, and the evidence of record, we determine the information presented a reasonable likelihood that Petitioner would prevail in establishing the unpatentability of at least one of the challenged claims of the ’148 patent. Accordingly, we institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Relying on the declaration testimony of Dr. Gido, Petitioner contends that an ordinarily skilled artisan for the ’148 patent “would have had at least a bachelor’s degree or equivalent degree from an accredited institution in chemistry, chemical engineering, materials science, or a similar discipline covering relevant principles of organic and inorganic chemistry, polymer processing, ceramic materials, and ceramic processing” and “three or more years of experience in electrochemical energy storage devices, lithium-ion battery technology, separators, characterizations and analyses of particle size, film thickness, and/or materials compositions, battery performance characterization, or other applications of polymer chemistry, ceramic chemistry, and ceramic processing.” Pet. 14. Petitioner additionally contends “[m]ore education could substitute for less experience, and vice versa.” Id. (citing Ex. 1003 ¶ 17). Patent Owner “adopts the definition proposed by the Petitioner.” Prelim. Resp. 14. Based on this record, we adopt Petitioner’s articulation of the level of ordinary skill in the art, which is consistent with the ’148 patent and the asserted prior art, and we apply it in our obviousness evaluations below. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art, itself, can reflect appropriate level of ordinary skill in art). We note that our decision would be the same applying either party’s definition of a person of ordinary skill in the art.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner contends that “[n]o claim terms require express construction.” Pet. 14–15. Patent Owner does not at this time address claim construction. See Prelim. Resp. 14–15. Having considered the record, we determine that no express claim construction is necessary for any claim terms. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the controversy (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). We note, however, there may be some claim terms below whose constructions that the parties may wish to address during trial.” slip op. at 11
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“Petitioner has shown sufficiently that there would be a motivation to combine Murakami and Beard with a reasonable expectation of success. As Petitioner explains, Beard teaches particular benefits of its porous structure that a person of ordinary skill in the art would be motivated to combine with the teachings of Murakami. See Pet. 54–56. At this stage, Patent Owner’s counterarguments do not undermine this showing. To begin with, we note that Patent Owner appears to mischaracterize the combination as incorporating Beard’s cell structure into Murakami, when it is merely to incorporate Beard’s technique of closely packing inorganic particles in the cell walls into Murkami. Thus, at this stage and on the current record, Patent Owner’s arguments about alleged incompatibilities between Beard’s and Murakami’s particle size distributions, amounts of binder, and binding and dispersion processes are not persuasive. As for the contentions regarding Figure 2, we note that Petitioner does not rely on Figure 2, which appears to include the incorporation of fibers. Thus, it is unclear why the pore structure of Figure 2 would be relevant to the combination that Petitioner proposes. Finally, we find that Petitioner has shown sufficiently, on this record, that Petitioner has shown a reasonable expectation of success. As Petitioner and its expert explain, Beard and Murakami teach similar manufacturing techniques (which are also similar to the ’148 patent), and Beard and Murakami provide ample detail on how to implement their techniques. See Ex. 1003 ¶¶ 167–172; Ex. 1010 ¶¶ 57–60; Ex. 1005 ¶¶ 71–72. We find this level of detail adequate, at this stage, to show that a person of ordinary skill would have a reasonable expectation of success in making the combination. See Pfizer Inc. v. Apotex, Inc., 480 F.3d 1348, 1365 (Fed. Cir. 2007) (noting that “the expectation of success need only be reasonable, not absolute”).” slip op. at 37
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,575,148 - Anthony Inc. v. Controltec, LLCInstitutedPTAB · Aug 25, 2025 · IPR2025-00559 · APJ Barry L Grossman · IPR · Institution
The Board instituted IPR of claims 1–20 on all asserted grounds after finding a reasonable likelihood that Petitioner would prevail on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“After considering the Petition, the Preliminary Response, and the evidence of record, based on the analysis in this Decision, we determine that Petitioner has demonstrated that there is a reasonable likelihood that at least one of the challenged claims is unpatentable. A decision to institute is “a simple yes-or-no institution choice respecting a petition, embracing all challenges included in the petition.” PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018). Accordingly, we institute an inter partes review of all challenged claims and on all grounds asserted in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“Petitioner asserts that a person of ordinary skill in the art would have had “a bachelor’s degree in mechanical engineering, electrical engineering, or a comparable field and at least three to five years of experience related to heating, ventilating, air conditioning, and refrigeration (HVAC&R) systems.” Pet. 4 (citing Ex. 1003 ¶¶ 31–35). Dr. Henze’s Declaration testimony states he considered some of the factors listed above. Ex. 1003 ¶¶ 31–35). Dr. Henze testifies that, in his opinion, the level of ordinary skill is as stated by Petitioner. Id. at 31. He also states that “[s]uch experience could be obtained through research and study in a graduate program or through comparable exposure through industry employment, and additional years of experience could substitute for the advanced-level degree.” Id. Patent Owner does not assert a level of ordinary skill, nor does Patent Owner dispute Petitioner’s definition of the level of ordinary skill. See generally Prelim. Resp. For purposes of this Decision, based on the prior art, the sophistication of the disclosed technology in the ’181 patent, and Dr. of ordinary skill.9” slip op. at 13
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesTerm construed petitioner constructionDecided for petitioner
“Petitioner asserts that nine terms are “mean-plus-function claim terms.” Pet. 4–10. As required by our rule, (37 C.F.R. § 104(b)(3)), for each of the mean-plus-function claim terms, Petitioner identifies the function as well as the specific portions of the ’181 patent’s specification that describe the corresponding structures. Id. Patent Owner does not comment on Petitioner’s proposed means-plus- function claim constructions. See generally Prelim. Resp. Thus, for purposes of this initial decision, we will adopt the means-plus-function constructions proposed by Petitioner.” slip op. at 14
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededPlain and ordinary meaningOther
“We do not perceive the need to construe any additional claim limitation. Our conclusion concerning instituting an inter partes review would be unaffected by a determination that the preambles of the claims are limiting. Accordingly, for this initial Decision to institute an inter partes review, the words “display” or “frame,” and the term “display case” will be given their ordinary and customary meaning as would have been understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure.” slip op. at 15
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,207,181 - Zhuhai Cosmx Battery Co., Ltd. v. Ninge Amperex Technology LimitedInstitution deniedPTAB · Aug 20, 2025 · IPR2025-00385 · APJ Debra L Dennett · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–10 were anticipated by Nishikawa or obvious over the asserted combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review under 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least [one] of the claims challenged in the petition.” For the reasons set forth below, upon considering the Petition and Preliminary Response, we determine that Petitioner has not established a reasonable likelihood of prevailing with respect to at least one challenged claim. Accordingly, we deny the Petition and decline to institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“Petitioner contends that A person of ordinary skill in the relevant art would typically hold an advanced degree in chemistry, material science, and/or a related discipline, and have at least two years of experience with designing and/or fabricating battery separators or have an equivalent level of education, training, and experience. Pet. 5. Patent Owner “adopts the definition proposed by Petitioner” for the purposes of the Preliminary Response. Prelim. Resp. 22. In light of the record before us, and for purposes of this Decision, we adopt Petitioner’s unopposed definition because it is consistent with the specification. We note that neither party indicated that the result would change under any different definition.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Absolute plastic deformation rate” and “relative plastic deformation rate” are the only claim terms disputed in this proceeding, and are clearly defined in the Specification and in claim 1. See Spec. 4:22–27, 4:47–54; 25:31–37. Because we determine that claim construction is not necessary to decide whether to institute, we do not expressly construe any claim terms. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (holding that “only those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs. in the context of an inter partes review). slip op. at 11
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“Petitioner’s arguments are unconvincing. Petitioner points to nothing in Nishikawa that allows a POSITA to determine L2 (defined as “a length of 4 Tensile strength is measured as force per units area, such as MPa or psi. One MPa equals one N/mm2. Nishikawa Table 1 discloses tensile strength in N/cm. Ex. 1004 Table 1. Petitioner makes calculations to convert the reported N/cm into N/m2 and then to GPa, but provides no explanation for why tensile strength is reported in N/cm or how it was measured. See Pet. 31. the porous substrate after the porous substrate is stretched to breakage and docked along the fracture caused by the breakage and flattened”) or L2 – L0. See generally Pet., Ex. 1004. Petitioner and its expert, Dr. Pecht, fail to adequately explain why tensile strength divided by Young’s modulus is “a proxy for L1 – L2” or why such a proxy is sufficient to disclose the limitation as stated. Instead, we are required to rely on “approximations” and “estimates” with insufficient explanation of why such they are appropriate or adequate. See Pet. 26, 30, 32; see also Ex. 1003 ¶¶ 97, 105–108, 111.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,964,927
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.