- PTAB · Dec 16, 2024 · IPR2024-01011 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted IPR on claims 1–5 under all asserted grounds, finding a reasonable likelihood of prevailing on at least one claim and no basis for discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the arguments and evidence set forth by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’924 patent. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review as to all of the challenged claims of the ’924 patent on all of the grounds of unpatentability set forth therein.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“Although the parties appear to agree that this factor is neutral, we note that a district court denial of a motion to stay without prejudice, accompanied by an indication that the district court would consider a renewed motion, “suggests the district court may be willing to avoid duplicative efforts and await the PTAB’s final resolution of the patentability issues raised in the petition before proceeding with the parallel litigation.” Fintiv at 6–7. “This fact has usually weighed against exercising authority to deny institution.” Id. (also noting that factors 2 and 3 are relevant to how much weight to give to the court’s willingness to reconsider a stay); see also T-Mobile, Paper 16 at 12 (noting that a stay was unlikely in that case given the proximity of the trial date to the entry of the institution decision). In view of the forgoing, we determine that Fintiv factor 1 weighs against exercising our authority to deny institution.” slip op. at 39
- Skill levelSkill level petitioner adoptedDecided for petitioner
“had at least a Master’s degree in materials science, chemistry, chemical engineering, a field relevant to polymer science and engineering, or the equivalent, and at least three years of experience in nanomaterials, electrochemistry, batteries, or polymer related activities” and that “[a]dditional work experience can compensate for less formal education, and vice versa.” Pet. 8 (citing Ex. 1003 ¶ 11). For purposes of its Preliminary Response, Patent Owner “does not dispute the Petition’s definition of [the] level of ordinary skill in the art.” Prelim. Resp. 2. On this record, we preliminarily adopt Petitioner’s definition of the person of ordinary skill in the art because it appears consistent with the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner argues that “no formal claim constructions are necessary.” Pet. 9. Patent Owner contends that all claim terms should be interpreted “in accordance with their ordinary and customary meaning.” Prelim. Resp. 2. Upon review of the record, we determine that no claim terms require express construction for purposes of this Decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 8
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,968,924 - PTAB · Dec 16, 2024 · IPR2024-01006 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted IPR of claims 1–8 on all petitioned grounds, finding a reasonable likelihood of success on the Ohata–Kavan obviousness challenge and no basis for discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the arguments and evidence set forth by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’909 patent. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review as to all of the challenged claims of the ’909 patent on all of the grounds of unpatentability set forth therein.” slip op. at 2
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“Contrary to Patent Owner’s arguments, the law on overlapping ranges in obviousness challenges is clear. See In re Peterson, 315 F.3d 1325, 1329 (Fed. Cir. 2003) (“A prima facie case of obviousness typically exists when the ranges of a claimed composition overlap the ranges disclosed in the prior art.”). Here, Petitioner directs us to evidence of an overlapping range, which is not meaningfully disputed by Patent Owner. As to Patent Owner’s arguments regarding the lower end of the claimed range of aspect ratios and Ohata’s warning about aspect ratios below 100, we note that Ohata states that its carbon nanotubes “preferably have an aspect ratio . . . of not less than 100,” and expressly includes examples with an aspect ratio of 50. Ex. 1004 ¶ 20 (emphasis added), Table 2 (Examples 12 and 14). Patent Owner also criticizes Petitioner for relying on oxidizing Ohata’s nanotubes in view of Kavan (discussed in more detail below). Prelim. Resp. 6. According to Patent Owner, oxidation is known to shorten the length of nanotubes, which would impact the aspect ratio of the nanotubes in the proposed combination. Prelim. Resp. 6. Specifically, Patent Owner contends that oxidizing Ohata’s nanotubes will reduce the aspect ratio below 100, and argues that “Petitioner has not explained why a [person of ordinary skill in the art] would ignore Ohata’s warning nor has Petitioner provided evidence that the resulting combination will perform as Petitioner alleges.” Prelim. Resp. 7; see also Prelim. Resp. 8 (arguing Petitioner has not explained why a person of ordinary skill in the art would try to retain Ohata’s aspect ratio and expect success when Ohata is altered in view of Kavan). Even giving Patent Owner’s arguments their full weight, there is no evidence on the present record as to how much the aspect ratio of Ohata’s nanotubes would be reduced as a result of oxidation. Rather, based on the present record, namely, the broad range of aspect ratios disclosed in Ohata (preferably 100–1000), it seems reasonably likely that the aspect ratio of at least some of the oxidized nanotubes in the proposed composition would remain within the range disclosed in Ohata and overlap the claimed range, as Petitioner asserts. Nevertheless, the parties may address during trial the expected level of carbon nanotube shortening in the proposed combination of Ohata and Kavan.” slip op. at 21
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner
“To the extent Patent Owner is presenting a teaching away argument, these statements do not rise to the level of criticizing, discrediting, or discouraging investigation into the claimed invention. DePuy Spine, Inc. v. Medtronic Sofamor Danek, Inc., 567 F.3d 1314, 1327 (Fed. Cir. 2009). Indeed, in addition to its statement regarding oxidation not being necessary for anchoring to TiO2, Kavan also states that oxidation of carbon nanotubes “was sometimes mentioned to improve anchoring of TiO2.” Ex. 1005, 2. Moreover, the full statement from Kavan regarding storage capacity reads: “The Li-storage capacity of TiO2 is not enhanced in the composite, but the rate of electrochemical charge transfer is higher due to nanotube networking.” Ex. 1005, 9. Thus, in its entirety, this statement supports Petitioner’s argument that there are advantages to using oxidized nanotubes, and, in turn, provides a reason why a person of ordinary skill in the art would have used oxidized nanotubes. Moreover, the evidence Petitioner presents regarding the use of oxidized nanotubes in combination with TiO2, coupled with Ohata’s statement that the electrode active material to be used can vary depending on the battery type (Ex. 1004 ¶¶ 26–27), undermines Patent Owner’s criticism that Petitioner’s arguments are circular.” slip op. at 24
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“Although the parties appear to agree that this factor is neutral, we note that a district court denial of a motion to stay without prejudice, accompanied by an indication that the district court would consider a renewed motion, “suggests the district court may be willing to avoid duplicative efforts and await the PTAB’s final resolution of the patentability issues raised in the petition before proceeding with the parallel litigation.” Fintiv at 6–7. “This fact has usually weighed against exercising authority to deny institution.” Id. (also noting that factors 2 and 3 are relevant to how much weight to give to the court’s willingness to reconsider a stay); see also T-Mobile, Paper 16 at 12 (noting that a stay was unlikely in that case given the proximity of the trial date to the entry of the institution decision). In view of the forgoing, we determine that Fintiv factor 1 weighs against exercising our authority to deny institution.” slip op. at 37
§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,808,909 - Intel Corporation v. Besang Inc.No claims unpatentablePTAB · Dec 11, 2024 · IPR2023-00991 · APJ Jon B Tornquist · IPR · Final written decision
The Board held claims 1 and 13–17 not unpatentable, finding the asserted obviousness grounds deficient in claim limitations or motivation to combine.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“The parties proposed definitions differ in that Petitioner would permit a degree in “materials science” and require three years, as opposed to two years, of relevant experience. Compare Pet. 9 with PO Resp. 14. On this record, we adopt Patent Owner’s proposed definition, as it is more consistent with the prior art of record and the disclosures of the ’702 patent. We note, however, that neither party contends that the outcome of this case depends on the slight differences in the proposed definitions of a person of ordinary skill in the art.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“1996) (“It is well-settled that, in interpreting an asserted claim, the court should look first to the intrinsic evidence of record, i.e., the patent itself, including the claims, the specification and, if in evidence, the prosecution history.”). Upon review of the parties’ arguments and the intrinsic record, we agree with Petitioner that the ’702 patent does not support a construction of “stackable add-on layer” that encompasses memory cells formed by sequential deposition on a substrate without being formed and then added to a separately formed substrate. Pet. 11–12. First, the plain language of the claim does not require merely a “layer” having a plurality of vertically oriented semiconductor memory cells, but rather “a stackable add-on layer” having a plurality of vertically oriented semiconductor memory cells; that plurality is bonded to the dielectric layer. Ex. 1001, 12:29–32. A construction that gives meaning to all words of the claim is preferred. Merck & Co., Inc. v. Teva Pharm. USA, Inc., 395 F.3d 1364, 1372 (Fed. Cir. 2005) (“A claim construction that gives meaning to all the terms of the claim is preferred over one that does not do so.”).” slip op. at 12
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“As discussed above, we do not understand a “stackable add-on layer” to include memory cells that are formed by sequential deposition on or above a substrate without being added to a separately formed substrate. It is undisputed, and indeed it is Petitioner’s assertion, that Lee’s memory devices are formed by sequential deposition. Pet. 16, 29 n.11, 51 (“In Lee, each level 3104 is deposited on the underlying level of array 3101.”). Therefore, Petitioner has not shown that Lee discloses every limitation of independent claim 13 under our claim construction. Thus, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious in view of Lee. 3. Analysis: Claims 14–17 Claims 14–17 each depend, directly or indirectly, from claim 13. Petitioner’s arguments with respect to these claims do not remedy the deficiencies noted above with respect to claim 13. Pet. 31–41. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 14–17 would have been obvious over Lee.” slip op. at 19
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“We agree with Patent Owner that Petitioner has not demonstrated that Aspar would improve Lee, would solve a problem in Lee, and that Petitioner is proposing to use Aspar in a way that is not disclosed in the reference. PO Resp. 49–50 (citing Ex. 2029 ¶¶ 153–162); Tr. 57:24–58:12; Pet. 61; KSR, 550 U.S. at 417 (asking whether a technique “would improve similar devices in the same way”), 420 (asking whether there was a known problem in the art), 421 (asking whether one of ordinary skill in the art had reason to “pursue the known options”); Intel, 61 F.4th at 1381 (explaining that obviousness may be demonstrated by showing that there was a known problem in the art (“cache coherency in multiprocessor systems”) and that a person of ordinary skill in the art would recognize that that the prior art solution to this problem (“global segmented secondary cache”) would improve the system of another prior art reference). Petitioner does not persuasively show that there was any known problem in the art with respect to Lee or its monolithic method of constructing memory arrays. Nor does Petitioner provide persuasive argument or evidence that Aspar’s wafer bonding would improve Lee’s memory device.10 For example, Petitioner states in a conclusory fashion that Aspar would address the known problem of “fabricating 3D structures,” but does not explain what those problems were or why Lee fails to solve them. Pet. 61. Dr. Sechen’s testimony merely parrots the Petition, providing no further analysis or explanation of what problem might exist in Lee when fabricating its 3D structures. Ex. 1003 ¶ 212. The Petition notes that Aspar transfers “thin layers of very good thickness homogeneity and with a high crystalline quality,” but the Petition never asserts that Lee’s direct deposition method fails to provide these same or similar qualities. Pet. 60–61.” slip op. at 27
Patent outcomesUS 7,378,702 not shown unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,378,702 - PTAB · Dec 10, 2024 · IPR2024-00994 · APJ Ken B Barrett · IPR · Institution
The Board instituted IPR on claims 1–7 and 9–14 on all asserted grounds, finding a reasonable likelihood of success on the Onishi-based obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDenied
“inter partes review, “the Director may take into account whether, and reject the petition or request because, the same or substantially the same prior art or arguments previously were presented to the Office.” 35 U.S.C. § 325(d). The Board uses a two-part framework in determining whether to exercise its discretion under § 325(d), specifically: (1) whether the same or substantially the same art previously was presented to the Office or whether the same or substantially 4 For purposes of this Decision, we assume the challenged claims have an effective filing date prior to March 16, 2013, the effective date of the relevant aspects of the Leahy-Smith America Invents Act, Pub. L. No. 112- 29, 125 Stat. 284 (2011) (“AIA”), and we apply the pre-AIA version of 35 U.S.C. § 103. the same arguments previously were presented to the Office; and (2) if either condition of [the] first part of the framework is satisfied, whether the petitioner has demonstrated that the Office erred in a manner material to the patentability of challenged claims. Advanced Bionics, Paper 6 at 8. The art or arguments presented in the Petition are not “substantially the same” as those previously presented to the Office when there are differences between them that are material to the Office’s prior consideration of the art and arguments. Wolfspeed, Inc. v. Trs. of Purdue Univ., IPR2022-00761, Paper 13 at 7–8 (Vidal Mar. 30, 2023).” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that Petitioner has demonstrated a reasonable likelihood of prevailing on at least one of the challenged claims of the ’696 patent. Further, we decline to discretionarily deny inter partes review. Accordingly, we institute an inter partes review as to all the challenged claims of the ’696 patent on all the grounds of unpatentability set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner, at this stage, does not disagree or propose a different definition of the person of ordinary skill in the art. However, Patent Owner’s declarant, Dr. Mercier, opines that [A]t the time of the ’696 Patent, a POSITA would have a working knowledge of wireless charging and inductive charging. The person would have gained this knowledge through an undergraduate Bachelor of Science degree in electrical engineering, computer engineering, computer science, or a related field, with at least two years of experience working in the field of wireless or inductive charging device design, or testing of such wireless or inductive charging device testing, or 5 The parties have not directed our attention to any objective evidence of obviousness or non-obviousness. an equivalent combination of academic study and work experience. More education (e.g., a Master’s degree) or work experience any relevant field may compensate for a deficit in one of the relevant qualifications stated above. Ex. 2001 ¶ 26. We observe that, in Dr. Mercier’s definition, the undergraduate degree categories are a bit broader and the experience possibly a bit more specific than in Petitioner’s definition. However, at this stage and absent argument to the contrary by the parties, we discern no material difference between the parties’ definitions. Petitioner’s definition is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For purposes of this decision, we apply Petitioner’s definition of the person of ordinary skill in the art. We note, however, that were we to adopt Dr. Mercier’s assessment, the outcome of this Decision would be the same.” slip op. at 15
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other
“near-linear region—consistent with the quoted applicant’s use of the term “near-linear”—rather than a linear or non-linear region, which seemingly would encompass the entire curve. As to the second part, we understand Patent Owner to be referring to the purported benefit of linear control, and we determine that Patent Owner has not explained adequately why such a benefit should be read into the claim term “substantially different,” particularly where the quoted Specification support does not explicitly mention linear regulation.7 See Ex. 1001, 21:61–63 (“The induced voltage 7 To the extent that Patent Owner relies on its declarant’s testimony as an explanation of Patent Owner’s claim construction position, we remind Patent Owner about the prohibition on incorporation by reference. See 37 C.F.R. § 42.6(a)(3); Consolidated Trial Practice Guide, November 2019, 35–36 can be increased by reducing the transmission frequency and can be reduced by increasing the transmission frequency.”). On this record and for purposes of this decision, we determine that— consistent with the Specification’s description of the frequency that is “[p]referably . . . selected” and applicant’s argument regarding the same during prosecution—“a transmission frequency substantially different from said characteristic resonant frequency of said inductive couple” encompasses frequencies that lie within one of the near-linear regions of a frequency-amplitude graph associated with the inductive couple. See Ex. 1001, 21:20– 24; Ex. 1002, 70. At this time and for purposes of this Decision, we need not and do not reach the issue of the outer bounds of the scope of “substantially different.” We also note that independent claim 1 is an apparatus claim and the subject limitation 1.7 further defines the “driving circuit” recited in limitations 1.5 and 1.6. Specifically, limitation 1.7 requires a driving circuit that is “configured and operable to produce said oscillating driving voltage at a transmission frequency” that is “substantially different” from the inductive couple’s resonant frequency. Ex. 1001, 28:43–46. In future briefing, the parties’ arguments regarding the prior art references should focus on that recited structure, i.e., a circuit that is configured and operable to produce the recited frequency.” slip op. at 21
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 9,048,696 - PTAB · Nov 22, 2024 · PGR2024-00034 · APJ Patrick R Scanlon · PGR · Institution
Instituted PGR on claims 1–19 and all asserted grounds after finding at least one claim more likely than not unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority to determine whether to institute a post-grant review. See 35 U.S.C. § 324 (2018); 37 C.F.R. § 42.4(a) (2022). To institute a post-grant review, we must determine that “the information presented in the petition . . . would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). For the reasons set forth below, we determine that the information presented shows that it is more likely than not that Petitioner would prevail in establishing unpatentability of at least one challenged claim. Accordingly, we institute a post-grant review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“We note that the identification of a Ph.D. as an example of “more formal education” creates a vast range of education relative to a bachelor’s degree. Thus, we treat the identification of a Ph.D. just as it is—an example—and not a requirement. In this case, “more formal education” can be satisfied by a level of education less than a Ph.D (but greater than a bachelor’s degree). Based on our review of the record before us, we determine that Petitioner’s stated level of ordinary skill in the art is reasonable because it appears consistent with the evidence of record, definition, limited as discussed above, for the purposes of this Decision.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“On the present record, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“would have understood Unger’s disclosure to “suggest the use of a torsion spring to facilitate attachment and detachment, because torsion springs are designed to impart this functionality.” Id. (citing Ex. 1002 ¶ 118). Petitioner also asserts that one of ordinary skill in the art would have “understood that there were a limited number of ways to impart the referenced resilient or flexible ‘manipulation,’” and “would have been motivated to look to various known solutions to impart the suggested functionality, including the torsional spring mechanism of Smith that is used in a similar hearing protection device application for a similar purpose as Unger’s mounting arms (to apply a clamping force).” Id. at 32 (citing Ex. 1002 ¶¶ 120–121).” slip op. at 17
Claim construction§ 103 obviousness§ 112 disclosurecites KSR · GrahamPatents in suitUS 11,736,855 - PTAB · Nov 14, 2024 · PGR2024-00026 · APJ Hyun J Jung · PGR · Institution
Instituted PGR on claims 1–7 and all grounds because Petitioner showed it was more likely than not that at least one challenged claim lacks written-description support.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this stage, Petitioner’s arguments, cited portions of the Specification, and supporting testimonial evidence demonstrate that it is more likely than not that claims 1–7 are unpatentable.” slip op. at 20
- Disclosure Requirements (§112) › Written description (Ariad)Written description inadequateDecided for petitioner
“patent describes that “angular position transducer 78 is placed on top of swing leg pivot shaft 24” and that “pivot shaft 24 is rotationally fixed to the connector plate and duplicates the angular movements of swing leg 20 about the pivot shaft.” Ex. 1001, 12:15–16, 12:20–22, Figs. 5, 7. The ’723 patent also describes that “[a]ngular position transducer 78 is mounted inside . . . protective can 90 . . . which is bolted to hinge bracket 28 via an upright holding arm 92” and that “trigger pin 94 projects upwardly from the top surface of pivot shaft 24 and cooperates with angular position transducer 78 to generate an angular position signal.” Id. at 12:28–33, Fig. 5. These descriptions expressly convey that angular position transducer 78 is on pivot shaft 24 and mounted inside protective can 90 that is bolted to hinge bracket 28. Id. at 12:15–16, 12:20–22, 12:28–30, Figs. 5, 7; see also Prelim. Resp. 17 (describing the same embodiment shown in Figs. 5 and 7). According to Petitioner, the ’723 patent describes the pivot shaft as part of the hinge bracket, not the modular frame or swing leg. Pet. 109–110 (citing Ex. 1001, 7:42–46, 12:17–22). On the preliminary record, we agree because the cited portions of the Specification describe that a “hinge bracket is interposed between each swing leg and an associated surface of the bolsters and includes a fixed, upright pivot shaft that pivotally engages the swing leg for pivotal movements” and “pivot shaft 24 is rotationally fixed to the connector plate.” Ex. 1001, 7:42–45, 12:20–21. We also agree that “even if one were to find that the hinge bracket is part of either the modular frame or swing leg (contrary to the claims and specification treating these all as separate components), the specification would only provide written description for one of the claimed alternatives.” Pet. 110 (citing Ex. 1002 ¶ 199).” slip op. at 19
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“At this preliminary stage, we determine that express claim interpretation is not necessary to determine whether it is more likely than not that at least one of the claims challenged in the petition is unpatentable. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 16
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDecided for petitioner
“We will also not use our discretion under § 325(d) to deny the Petition based on arguments previously presented in IPR2021-00135, because Petitioner relies on a Board determination regarding claim 8 from IPR2021- 00136, not arguments previously made for claim 1 in IPR2021-00135. Pet. 111–115, 119; Prelim. Resp. 8–9; Prelim. Sur-reply 5. Furthermore, we determined the effective filing date of claim 8 of the ’571 patent without deciding, that other challenged claims, such as claim 1, were entitled to their earliest possible effective filing date. See Godberson-Smith, Paper 61 at 11, 12.” slip op. at 12
Claim construction§ 112 disclosureDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,772,723 - PTAB · Nov 14, 2024 · IPR2024-00835 · APJ Hyun J Jung · IPR · Institution
The Board instituted IPR of claims 1–8 on all asserted grounds, finding a reasonable likelihood that claim 1 would be unpatentable over CIII and Rio.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDecided for petitioner
“Advanced Bionics stated that: If, after review of factors (a), (b), and (d), it is determined that the same or substantially the same art or arguments previously were presented to the Office, then factors (c), (e), and (f) relate to whether the petitioner has demonstrated a material error by the Office. Factor (c) focuses on the record developed by the Office in previously reviewing the art or arguments. It informs, therefore, the petitioner’s showing under factors (e) and (f), which focus on the petitioner’s evidence of previous Office error regardless of the context in which the same or substantially the same art or arguments were previously presented. For example, if the record of the Office’s previous consideration of the art is not well developed or silent, then a petitioner may show the Office erred by overlooking something persuasive under factors (e) and (f). On the other hand, if the alleged error is a disagreement with a specific finding of record by the Office, then ordinarily the petitioner’s required showing of material error must overcome persuasively that specific finding of record. That is, although Becton, Dickinson factor (c) evaluates “the extent to which the asserted art was evaluated during examination, including whether the prior art was the basis for rejection,” the focus should be on the record when determining whether the Office erred in evaluating such art or arguments.” slip op. at 10
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“d) Petitioner Shows a Reasonable Likelihood of Prevailing Based on the preliminary record, Petitioner shows a reasonable likelihood of prevailing in its challenge that CIII and Rio teach, suggest, or would have been understood to disclose the limitations of claim 1 and that one of ordinary skill in the art would have combined the references in the manner asserted with a reasonable expectation of success.” slip op. at 28
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“track” that “is configured to rotate . . . relative to the jacking column,” Petitioner proposes modifying CIII in view of Rio “by positioning Rio’s rotary actuator 44 between the jacking column and crawler track, and using that rotary actuator to rotate CIII’s crawler track relative to the entire jacking column, rather than just its outer cylinder.” Pet. 45 (citing Ex. 1002 ¶ 89) (emphasis added); see also id. at 47 (citing Ex. 1002 ¶ 92; Ex. 1006, 5:8–11, 6:2–6). Petitioner argues such a modification would have been a design choice, one of a finite number of alternatives, obvious to try, and a known design that provides maneuverability. Id. at 29–31 (citing Ex. 1002 ¶¶ 61–67; Ex. 1006, 5:8–11; Ex. 1007, 5:14–59, Figs. 4–5; Ex. 1008, 7:35– 53, Figs. 7, 20; Ex. 1009 ¶¶ 5, 19–20, Fig. 2; Ex. 1011, 4:7–16, Fig. 3; Ex. 1013 ¶¶ 41, 44–45). At this stage, Petitioner’s arguments and cited evidence sufficiently support for institution that the modification would have been made so that the proposed combination would have had “a crawler track” that “is configured to rotate . . . relative to the jacking column.” Regarding claim 1’s “slew drive,” as discussed above, Petitioner proposes modifying CIII so that rotary actuator 44, the asserted slew drive, would be between the jacking column and crawler track. See Pet. 29–31. Petitioner also argues that, in the proposed combination, “actuating the rotary actuator causes the crawler track to rotate relative to the entire jacking column.” Id. at 47 (citing Ex. 1002 ¶ 92). The present record supports Petitioner’s argument that Rio’s worm gear actuator would have been understood to disclose a slew drive with support from the ’318 patent itself, the opinion of its declarant, and deposition testimony of Patent Owner’s expert in related litigation. Id. at 46–47 (citing Ex. 1001, 11:40–61; Ex. 1002 ¶ 91; Ex. 1006, 4:61–5:3; Ex. 1032, 84:12–86:17). At this stage, the cited evidence sufficiently supports for purposes of institution Petitioner’s argument that the proposed combination would have included the recited “slew drive.”” slip op. at 28
- Skill levelSkill level petitioner adoptedOther
“had at least a four-year degree in mechanical engineering or a closely related field and at least two years of experience designing, developing, or operating heavy machinery, including their components and control systems.” Pet. 8– 9 (citing Ex. 1002 ¶¶ 22–24). Petitioner also argues that “[a]dditional experience could substitute for a formal degree, and an advanced degree could substitute for experience.” Id. at 9 (citing Ex. 1002 ¶¶ 22–25). Petitioner states that “[t]he Board adopted this definition of the level of ordinary skill for the related ’749 patent.” Id. (citing Godberson-Smith Const. Co. v. Guntert & Zimmerman Const. Div., Inc., IPR2020-01698, Paper 80, 21–24 (PTAB Apr. 12, 2022) (Final Written Decision)). For purposes of its Preliminary Response, Patent Owner applies Petitioner’s proposed level of ordinary skill in the art. Prelim. Resp. 13 (quoting Pet. 8–9). Based on the preliminary record, we adopt Petitioner’s asserted level of ordinary skill to determine whether there is a reasonable likelihood that Petitioner would prevail with respect to at least one of the claims challenged in the Petition. Pet. 8–9; Godberson-Smith, Paper 80 at 21–24 (determining level of ordinary skill after considering the parties’ competing proposals and evidence).” slip op. at 13
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,535,318 - Micron Technology, Inc. / Micron Semiconductor Products, Inc. et al. v. Besang Inc.No claims unpatentablePTAB · Nov 13, 2024 · IPR2023-00900 · APJ Jon B Tornquist · IPR · Final written decision
Claims 13–17 were not shown unpatentable: Lee-based grounds fail on the stackable add-on layer limitation, and Watanabe-based grounds fail on nonvolatile memory, enablement, or motivation to combine.
RulingsFinal written decision- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“meaning in the art. See Irdeto Access, Inc. v. Echostar Satellite Corp., 383 F.3d 1295, 1300 (Fed. Cir. 2004) (stating that, absent an accepted meaning in the art, “we construe a claim term only as broadly as provided for by the patent itself”). Thus, we must attempt to discern the meaning of this term from the claim language itself and from the remainder of the intrinsic record. See Vitronics Corp. v. Conceptronic, Inc., 90 F.3d 1576, 1582 (Fed. Cir. 1996) (“It is well-settled that, in interpreting an asserted claim, the court should look first to the intrinsic evidence of record, i.e., the patent itself, including the claims, the specification and, if in evidence, the prosecution history.”). Upon review of the parties’ arguments and the intrinsic record, we agree with Petitioner that the ’702 patent does not support a construction of “stackable add-on layer” that encompasses memory cells formed by sequential deposition on a substrate without being formed and then added to a separately formed substrate.” slip op. at 10
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“As discussed above, we construe “stackable add-on layer” to not include memory cells that are formed by sequential deposition on or above a substrate without being added to a separately formed substrate. It is undisputed, and indeed it is Petitioner’s assertion, that Lee’s memory devices are formed by sequential deposition. See Pet. 52 (asserting that in Lee “the layers of the array are directly deposited on the layers of each underlying level, and the array is deposited on the interlayer insulating layer formed over a substrate”); see also id. at 70 (“Lee discloses forming vertical memory devices through layer-by-layer sequential deposition on the substrate . . . .”). Therefore, Petitioner does not show that Lee discloses every limitation of independent claim 13 under our claim construction. Thus, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious in view of Lee. 3. Claims 14 and 15 Claims 14 and 15 depend from claim 13. Ex. 1001, 12:35–42. Petitioner’s arguments for these claims do not remedy the deficiencies noted above with respect to independent claim 13. Pet. 54–59. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 14 and 15 would have been obvious in view of Lee alone. E. Claims 16 and 17 over Lee and Endoh Petitioner contends the subject matter of claims 16 and 17 would have been obvious over the combined disclosures of Lee and Endoh. Pet. 59–69. Petitioner’s arguments with respect to these claims, however, do not remedy the deficiencies noted above with respect to Lee and its monolithic, sequentially deposited memory array. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 16 and 17 would have been obvious over Lee and Endoh.” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“combined Lee and Watanabe to achieve improved integration density. Pet. 71. Petitioner concedes, however, that the benefits of Lee’s design related to 3-D integration and improved integration density would be obtained if Lee’s memory structures are formed using either Lee’s monolithic construction method or Watanabe’s alternative stacking method. Pet. Reply 13–14 (citing Ex. 1041 ¶ 34). Thus, we are not persuaded that improved integration density provides a sufficient rationale for Petitioner’s combination of Lee’s memory device and Watanabe’s stacking method. Petitioner argues that Watanabe’s stacking method “improves the accuracy of the wiring” because the wiring is made “for each planar member.” Pet. 72 (citing Ex. 1005, 6:1–3). Watanabe also states that its disclosed methods provide “a low interconnection wire resistance.” Ex. 1005, 6:20–23. Petitioner does not, however, explain sufficiently how Watanabe’s stacking method would improve Lee’s device. For example, Petitioner does not address whether the alleged wiring benefit already existed in Lee’s monolithic array or explain how this benefit would also apply to Lee’s particular memory array, which differs in construction and elements from Watanabe’s device. This diminishes Petitioner’s benefits-based motivation to combine arguments. In general, a petitioner need not demonstrate that a particular alternate method would improve a prior art device in order to show a motivation to combine. Intel Corp. v. PACT XPP Schweiz AG, 61 F.4th 1373, 1380–81 (Fed. Cir. 2023); see Pet. Reply 20 (citing Intel). But here, Petitioner affirmatively invokes improvement of Lee’s device as a reason for the combination, and we must evaluate Petitioner’s contention. Moreover, any relative lack of improvement or benefits must be weighed against any problems the alternative method would introduce. See Intel Corp. v. Qualcomm Inc., 21 F.4th 784, 795–96 (Fed. Cir. 2021) (noting that simultaneous advantages and disadvantages to a proposed combination must be analyzed to determine whether the disadvantages “outweighed any reason to combine”). Here, as discussed above in more detail with respect to the ground based on Watanabe, the evidence shows that one of ordinary skill in the art would have expected Watanabe’s bonding temperature of 900– 1000° C to damage the electronic devices in an underlying substrate. Ex. 2029 ¶¶ 75–76; Ex. 2028, 123:13–124:7; Ex. 2027, 715. The expected damage to Lee’s device, when balanced against the limited evidence of a benefit to the combination,7 outweighs the reason to combine Lee and Watanabe set forth in the Petition. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious over Lee and Watanabe. 2. Analysis – Claims 14 and 15 Claims 14 and 15 both depend directly from independent claim 13. Ex. 1001, 12:35–42. Petitioner’s arguments with respect to claims 14 and 15 do not remedy the deficiencies noted above with respect to independent claim 13. Pet. 73. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that these claims would have been obvious over Lee and Watanabe.” slip op. at 40
- Expert testimonyPatent owner expert creditedOther
“We credit the testimony of Dr. Przybylski that one of ordinary skill in the art would have understood that Watanabe’s stacked structure would be severely impacted if bonded at a temperature above 900° C, as disclosed in Watanabe. Ex. 2029 ¶¶ 76–77. Dr. Przybylski’s opinion is supported by Dr. Lee’s testimony (Ex. 2028, 123:13–124:7, 125:6–126:7), as well as Watanabe (Ex. 1005, 6:6–14) and Batude (Ex. 2027, 715). As further discussed below, we find that Petitioner has not rebutted Patent Owner’s showing of nonenablement, and Patent Owner has carried its burden to demonstrate that Watanabe was not enabled for bonding temperatures of 900–1000° C, as of the 2004 filing date of the ’702 patent.” slip op. at 32
Patent outcomesUS 7,378,702 not shown unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,378,702 - Cub Elecparts Inc. v. Orange Electronic Co., Ltd.Institution deniedPTAB · Nov 12, 2024 · IPR2024-00744 · APJ Patrick R Scanlon · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood of prevailing on any challenged claim under the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that Petitioner has not demonstrated a reasonable likelihood that it would prevail with respect to at least one challenged claim. Accordingly, we do not institute an inter partes review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person having ordinary skill in the art (“POSA”) “would have a bachelor’s degree in electrical engineering and at least one year of experience in sensor/detector design or RF communications (RFIDs)” and “would have a working knowledge of tire pressure management systems and, as most POSA would also be automobile owners, would have had personal experience with tire pressure management systems which have been required in all new cars, trucks, and SUVs in the United States since 2007.” Pet. 17. Petitioner adds that “[e]ducation may substitute for experience and vice versa.” Id.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner contends that all claim terms should be given their ordinary and customary meaning. Pet. 17. Petitioner notes that, in the tire pressure detecting field, terms such as “detector,” “sensor,” and “monitor” relate to the same device and can be used interchangeably. Id. at 17–18. Patent Owner contends that no claim term needs construction to resolve the grounds asserted in the Petition. Prelim. Resp. 16. On the present record, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the” slip op. at 13
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“We agree with Patent Owner that Petitioner’s unsupported assertion that tire pressure sensors typically are programmed with only the ID as part of the factory installation is insufficient to establish obviousness in this instance. Petitioner does not provide adequate reasoning or evidence to 11 Petitioner relies on the same analysis of this claim 26 limitation for the substantially similar limitation of claim 27. Pet. 66. Accordingly, our analysis of the claim 26 limitation applies equally to the corresponding limitation of claim 27. art would have known that tire pressure sensors typically are programmed at the factory with a single ID. Furthermore, even if assuming for the sake of argument that Petitioner’s assertion is correct, the Petition fails to explain adequately how or why one of ordinary skill in the art would have modified the combination of Tang and Lemense to store only the old identification in the old tire pressure detector.” slip op. at 20
Claim construction§ 103 obviousnessDiscretionary denialcites GrahamPatents in suitUS 8,031,064 - PTAB · Oct 11, 2024 · IPR2024-00772 · APJ Monica S Ullagaddi · IPR · Institution
The Board instituted IPR on all challenged claims and petition grounds, found the merits threshold met, and granted Texas Instruments’ motion to join IPR2024-00001.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“3. Analysis At this stage of the proceeding, we determine that Patent Owner’s statements made during prosecution of the ’195 patent appear to contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support Petitioner’s argument tthat a graded dopant concentration is enough to teach aiding carrier movement in a particular direction. Patent Owner does not dispute that Kawagoe has a graded dopant concentration in the active region at this stage of the proceeding. Id. Patent Owner also does not dispute that Kawagoe’s transistor has carriers in the active region or that the graded dopant concentration of Kawagoe is lowered from the surface to the bottom substrate (Ex. 1007, Fig. 17). Id. At this stage of the proceeding, the evidence of record supports Petitioner’s position sufficiently to meet the reasonable likelihood threshold for institution. We decline to make further determinations, on this preliminary record, regarding the dispute surrounding this limitation, because the trial in the 00001IPR is the better proceeding in which to do so. Specifically, as compared to the preliminary phase of this case, the instituted trial in the 10 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1016, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. 00001IPR affords the parties a better opportunity to fully and fairly brief, argue, and develop evidence in support of their positions. We observe, on this record, the dispute is inadequate to undermine the sufficiency of Petitioner’s evidence to support institution of review.” slip op. at 14
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the 1 The Leahy-Smith America Invents Act (“AIA”), Pub. L. No. 112-29, 125 Stat. 284 (2011), amended 35 U.S.C. § 103, effective March 16, 2013. Because applications from which the ’481 patent claims priority were filed before this date, the pre-AIA version of § 103 applies. 2 U.S. Patent No. 6,043,114, issued Mar. 28, 2000 (Ex. 1007, “Kawagoe”). 3 U.S. Patent No. 6,163,877, issued Dec. 19, 2000 (Ex. 1014, “Gupta”). 4 U.S. Patent Publication No. 2003/0183856 A1, published Oct. 2, 2003 (Ex. 1006, “Wieczorek”). 5 Petitioner cites four volumes for Wolf: Stanley Wolf & Richard Tauber, Silicon Processing For The VLSI Era, Volume 1 – Process Technology, 2nd ed., (Lattice Press 2000) (Ex. 1008A); Stanley Wolf & Richard Tauber, Silicon Processing For The VLSI Era, Volume 2 – Process Integration, (Lattice Press 2000) (Ex. 1008B); Stanley Wolf & Richard Tauber, Silicon Processing For The VLSI Era, Volume 3 – The Submicron MOSFET, (Lattice Press 2000) (Ex. 1008C); and Stanley Wolf & Richard Tauber, Silicon Processing For The VLSI Era, Volume 4 – Deep-Submicron Process Technology, (Lattice Press 2000) (Ex. 1008D). petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 14– 35. However, 35 U.S.C. § 315(b) also provides that the one-year time bar “shall not apply to a request for joinder under subsection (c).” 37 C.F.R. § 42.122(b). Because the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted 00001IPR proceeding, which we grant as further discussed below, Patent Owner’s argument that the Petition is timebarred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 4
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“Based on the facts and circumstances discussed above, having reviewed the briefings of both parties, we determine Petitioner has established good cause for joining the 00001IPR. Specifically, we find that joining Petitioner to the 00001IPR is unlikely to require any delay or modification to the scheduling order already in place for the 00001IPR. We also determine that Patent Owner will not be prejudiced unduly by the joinder of this proceeding. Thus, we determine that granting the Motion for Joinder under these circumstances would help “secure the just, speedy, and inexpensive resolution” of these proceedings. See 37 C.F.R. § 42.1(b). For the above reasons, we grant Petitioner’s Motion for Joinder and join Petitioner as a party to the 00001IPR.” slip op. at 19
NonePatents in suitUS 10,734,481
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.