- Caption Health, Inc v. University Of British ColumbiaInstitution deniedPTAB · Dec 19, 2025 · IPR2025-01066 · APJ Mary C Hoffman · IPR · Institution
Institution was denied because Petitioner did not show a reasonable likelihood that any challenged claim was unpatentable, including failure to show the claimed image-receiving quality-assessment neural network.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). Under 35 U.S.C. § 314(a), an inter partes review may not be instituted “unless . . . the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Based on the current record and for the reasons explained below, Petitioner has not demonstrated a reasonable likelihood of prevailing with respect to at least one of the challenged claims of the ’591 patent. Thus, we do not institute this inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Because Petitioner’s formulation is supported by declaratory testimony and appears consistent with the level of skill reflected in the asserted prior art and the ’591 patent, and because Patent Owner does not provide any supporting evidence, we adopt Petitioner’s formulation of the level of ordinary skill in the art. See Ex. 1002 ¶¶ 31–33. Our decision would be the same regardless of the differences between Petitioner’s and Patent Owner’s formulations.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“The parties do not propose any express claim construction. Pet. 11– 12; Prelim Resp. 17. We also determine that no express claim construction is necessary for our Decision, apart from that discussed in our below analysis. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only terms in controversy must be construed “and only to the extent necessary to resolve the controversy”) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 11
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundReasonable expectation not foundNot shown unpatentable
“Petitioner also fails to provide sufficient rationale and a reasonable expectation of success in combining Krishnan and Lee to arrive at a quality assessment neural network configured to receive an image. See Pet. 34–37. For example, the Petition lacks an explanation of why a POSITA would have been motivated to modify Krishnan’s quality assessment neural network to be configured to receive an image, instead of extracted features, in view of Lee’s image-receiving category classifying neural network. Id. Without such further explanation, Petitioner’s challenge falls short. Petitioner’s argument that neural networks for image quality assessment were “well-known” is not persuasive—it does not address the particular scope of limitation 1i, which also requires that the neural network is configured to receive images. Pet. 35 (citing Ex. 1002 ¶¶ 47–51, 118; Exs. 1017, 1023, 1024, 1026). Petitioner’s argument that combining Krishnan and Lee “would merely amount to applying known work from the field . . . to yield predictable results” is not persuasive because the Petition ties this reasoning to modifying Krishnan with Lee’s view-category-specific assessment parameters, not modifying Krishnan’s quality assessment neural network to receive images instead of extracted features. Id. at 37 (citing Ex. 1002 ¶ 126). Lastly, we note Petitioner’s expert’s discussion regarding neural networks for image quality assessments. Ex. 1002 ¶¶ 43–53 (citing Exs. 1010, 1015, 1016, 1017, 1018, 1023, 1024, 1026). However, the Petition does not explain how this evidence demonstrates that the proposed combination teaches or suggests a quality assessment neural network configured to receive images, or that such would have been obvious in the context of the claimed invention. See Pet. 32–37.” slip op. at 19
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,129,591 - PTAB · Dec 12, 2025 · IPR2025-00763 · APJ Christopher L Ogden · IPR · Institution
The Board instituted IPR of claims 1–10 on all asserted grounds, finding a reasonable likelihood that Zeira alone or Zeira with Yi renders at least one challenged claim obvious.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“institute an inter partes review when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a); see also 37 C.F.R. § 42.108(c). Applying that standard, we institute an inter partes review of all the challenged claims of the ’838 patent based on all grounds set forth in the Petition for the reasons explained below. This is a preliminary decision, and we will base our final written decision on the full trial record.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“had “a bachelor’s degree in electrical engineering, computer engineering, computer science, or a related field and at least two years of practical experience with design or development of telecommunication and/or wireless communications systems, or the equivalent.” Pet. 10 (citing Ex. 1003 ¶ 21). Patent Owner does not contest this at this stage. See Prelim. Resp. Petitioner’s proposed level of ordinary skill appears to be consistent with the problems addressed in the ’838 patent. See Ex. 1001, 1:30–2:48. Therefore, we adopt it for this decision.” slip op. at 6
- Expert testimonyPetitioner expert creditedDecided for petitioner
“person of ordinary skill in the art would have understood that Zeira’s RRC message includes MAC timer information. Zeira explicitly discloses that the calculated duration information is transmitted to the WTRU. Ex. 1005 ¶ 74. Zeira also discloses that information to “[c]onfigure the MAC layer” is transmitted to the WTRU in the form of an RRC message. Id. ¶ 423. Further, the duration is calculated while considering the amount of time that the MAC layer would need to transmit the current buffered data. Id. ¶ 76. Given these disclosures, we find sufficiently credible Dr. Lo’s testimony that a person of ordinary skill in the art would have understood Zeira to disclose that the RRC message received by the WTRU includes MAC timer information, and that the extent it does not, it would have been a predictable variation, at the time of the claimed invention, to implement a timer relating to the duration of network resources at the MAC layer as Yi teaches. Ex. 1003 ¶¶ 74–87, 107–113.” slip op. at 16
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“person of ordinary skill in the art would have understood that Zeira’s RRC message includes MAC timer information. Zeira explicitly discloses that the calculated duration information is transmitted to the WTRU. Ex. 1005 ¶ 74. Zeira also discloses that information to “[c]onfigure the MAC layer” is transmitted to the WTRU in the form of an RRC message. Id. ¶ 423. Further, the duration is calculated while considering the amount of time that the MAC layer would need to transmit the current buffered data. Id. ¶ 76. Given these disclosures, we find sufficiently credible Dr. Lo’s testimony that a person of ordinary skill in the art would have understood Zeira to disclose that the RRC message received by the WTRU includes MAC timer information, and that the extent it does not, it would have been a predictable variation, at the time of the claimed invention, to implement a timer relating to the duration of network resources at the MAC layer as Yi teaches. Ex. 1003 ¶¶ 74–87, 107–113.” slip op. at 16
§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,212,838 - Nokia Of America Corporation / AT&T Services, Inc. v. Iarnach Technologies LimitedSome claims unpatentablePTAB · Dec 10, 2025 · IPR2024-00899 · APJ Christopher L Ogden · IPR · Final written decision
Claims 1–3, 5, 10, 11, and 14 are unpatentable as obvious; claims 4, 12, 13, and 15 were not shown unpatentable under the asserted § 103 grounds.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“(citing Ex. 1003 ¶ 22). Patent Owner does not contest this proposed level of ordinary skill. PO Resp. 5. Also, neither party argues that the precise level of ordinary skill would be dispositive in this proceeding. We adopt Petitioner’s proposed level of ordinary skill because it is undisputed, supported by testimonial evidence, and consistent with the asserted prior art and the types of problems and solutions in the ’892 patent. See, e.g., Ex. 1001, 1:19–2:8.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for petitioner
“We agree with Petitioner. The evidence of record, including the ’892 patent and its prosecution history,9 indicates that the ordinary and customary meaning of “transitioning . . . from . . . to” encompasses both direct and indirect transitions. Looking first to the claim language itself, the word “directly” appears in claims 1, 6, and 10, but not claim 14, presumptively suggesting that claim 14 was intended to more broadly capture systems with either direct or indirect transitions. See CAE Screenplates Inc. v. Heinrich Fiedler GmbH, 224 F.3d 1308, 1317 (Fed. Cir. 2000) (“In the absence of any evidence to the contrary, we must presume that the use of . . . different terms in the claims connotes different meanings.”). Holding otherwise would fail to give any effect to the word “direct” as it appears in claims 1, 6, and 10. See Stumbo v. Eastman Outdoors, Inc., 508 F.3d 1358, 1362 (Fed. Cir. 2007) (denouncing claim constructions methodologies that render phrases in claims superfluous).” slip op. at 12
- Expert testimonyPetitioner expert creditedOther
“predictable and well-motivated variation of G.987.3, at the time of the claimed invention, to include a direct transition between the ONU’s two low-power states. See KSR v. Teleflex, 550 U.S. at 417 (“When a work is available in one field of endeavor, design incentives and other market forces can prompt variations of it, . . . . If a person of ordinary skill can implement a predictable variation, § 103 likely bars its patentability.”). We credit Dr. Sergienko’s testimony that a person of ordinary skill in the art would have been motivated to reduce power consumption and would have looked to ways of modifying G.987.3 to further that design goal. See Ex. 1003 ¶ 70; see also Ex. 1007, 97 (“For a variety of reasons, it is desirable to reduce the power consumed by an ONU as much as possible . . . .”). We also credit Dr. Sergienko’s testimony that there were only a small number of ways to modify the state transitions in G.987.3’s ONU, and that it would have been obvious to consider those possibilities. Ex. 1003 ¶ 70. Patent Owner does not contest this. Dr. Litvin concedes, for Patent Owner, that “there is no conceivable way the [ITU] did not consider the proposed transition” between the ONU’s two low-power states when drafting G.987.3, although he contends the standards body prohibited such direct transitions as “a conscious and reasoned design choice.” Ex. 2007 ¶ 108; see also id. ¶ 109 (opining that there were only four possible choices for transitions in the ONU, and the ITU “undoubtedly considered all of them, including the direct transition from . . . Listen and . . . Asleep”); PO Resp 24 (conceding that “G.987 explicitly considered the very direct transitions that Petitioner say would be used”). We also find persuasive Petitioner’s additional or alternative argument that Röger would have motivated modifying G.987.3 by allowing the ONU, while in sleep mode, to periodically turn on its receiver and check for messages from the OLT, which would have been direct transitions between “first” and “second” states as recited in claim 1. Pet. 20–22 & n.4; Ex. 1003 ¶¶ 82–84. The evidence suggests that modifying G.987 as Petitioner proposes would have been within the abilities of a person of the ordinary skill in the art at the time of the claimed invention—either to add a direct transition between Listen and Asleep states or to allow the ONU, while in its sleep (both transmitter and receiver off) mode, to periodically turn on its receiver temporarily to listen for polling messages from the OLT, as Röger teaches. Pet. 11–12, 14–15, 19; Ex. 1003 ¶¶ 70, 74. We also agree with Petitioner that there would have been motivation” slip op. at 26
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“We find persuasive Petitioner’s arguments that it would have been a predictable and well-motivated variation of G.987.3, at the time of the claimed invention, to include a direct transition between the ONU’s two low-power states. See KSR v. Teleflex, 550 U.S. at 417 (“When a work is available in one field of endeavor, design incentives and other market forces can prompt variations of it, . . . . If a person of ordinary skill can implement a predictable variation, § 103 likely bars its patentability.”). We credit Dr. Sergienko’s testimony that a person of ordinary skill in the art would have been motivated to reduce power consumption and would have looked to ways of modifying G.987.3 to further that design goal. See Ex. 1003 ¶ 70; see also Ex. 1007, 97 (“For a variety of reasons, it is desirable to reduce the power consumed by an ONU as much as possible . . . .”). We also credit Dr. Sergienko’s testimony that there were only a small number of ways to modify the state transitions in G.987.3’s ONU, and that it would have been obvious to consider those possibilities. Ex. 1003 ¶ 70. Patent Owner does not contest this. Dr. Litvin concedes, for Patent Owner, that “there is no conceivable way the [ITU] did not consider the proposed transition” between the ONU’s two low-power states when drafting G.987.3, although he contends the standards body prohibited such direct transitions as “a conscious and reasoned design choice.” Ex. 2007 ¶ 108; see also id. ¶ 109 (opining that there were only four possible choices for transitions in the ONU, and the ITU “undoubtedly considered all of them, including the direct transition from . . . Listen and . . . Asleep”); PO Resp 24 (conceding that “G.987 explicitly considered the very direct transitions that Petitioner say would be used”). We also find persuasive Petitioner’s additional or alternative argument that Röger would have motivated modifying G.987.3 by allowing the ONU, while in sleep mode, to periodically turn on its receiver and check for messages from the OLT, which would have been direct transitions between “first” and “second” states as recited in claim 1. Pet. 20–22 & n.4; Ex. 1003 ¶¶ 82–84. The evidence suggests that modifying G.987 as Petitioner proposes would have been within the abilities of a person of the ordinary skill in the art at the time of the claimed invention—either to add a direct transition between Listen and Asleep states or to allow the ONU, while in its sleep (both transmitter and receiver off) mode, to periodically turn on its receiver temporarily to listen for polling messages from the OLT, as Röger teaches. Pet. 11–12, 14–15, 19; Ex. 1003 ¶¶ 70, 74.” slip op. at 26
Patent outcomesUS 9,806,892 mixedClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,806,892 - PTAB · Dec 9, 2025 · IPR2025-00756 · APJ Thu A Dang · IPR · Institution
The Board instituted IPR on claims 1, 2, 5–8, 11, and 12 on three §103 grounds, finding a reasonable likelihood of unpatentability over the asserted combinations.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“III. CONCLUSION Because we determine that Petitioner has demonstrated a reasonable likelihood that it would prevail in showing at least one of the challenged claims is unpatentable, we institute inter partes review as to all challenged claims and grounds presented in the Petition. At this stage of the proceeding, we have not made a final determination as to the patentability of any of these challenged claims. ORDER For the reasons given, it is ORDERED that pursuant to 35 U.S.C. § 314, an inter partes review is instituted as to claims 1, 2, 5–8, 11, and 12 of the ’803 patent to determine whether: 1) claims 1, 5–7, 11, and 12 are unpatentable under 35 U.S.C. § 103 as obvious over TS 36.300, TS 36.321, and TS 36.331; 2) claims 1, 2, 5–8, 11, and 12 are unpatentable under 35 U.S.C. § 103 as obvious over Ericsson and TS 25.331; and 3) claims 5, 6, 11, and 12 are unpatentable under 35 U.S.C. § 103 as obvious over Ericsson, TS 25.331, and Sebire; and” slip op. at 27
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“ordinary meaning, “primary” and “non-primary” cells are all cells that the WTRU is connected to (PO Resp. 16), the plain language in claim 1, and similarly in claim 7, does not require a “primary” node or “non-primary” cell to have a connection to the WTRU. See Ex. 1001, 10:38−56; 11:11–26. We find unavailing Patent Owner’s contention that the claims require that the WTRU “be connected to more than one cell,” wherein cells that are “associated with a wireless network node,” but are not connected to the WTRU “at the same time” cannot be “primary” or “non-primary” cells. PO Resp. 16. In the ’803 patent, nothing in the Specification clearly limits “primary” and “non-primary” cells as Patent Owner proposes. Prelim. Resp. 16. Patent Owner points to the Specification of the ’803 patent to show that, for softer handover, the WTRU is connected “with more than one cell [] which are controlled by the same Node-B,” and “[o]ne of the[se] cells 808 may be designated as a primary cell 808a, while other cells are designated as a non-primary cells 808b.” Id. (alterations in original) (citing Ex. 1001, 8:44–46, 9:4–6, Figs. 8A–B). However, this portion of the Specification (describing a softer handover embodiment in which a cell “may be designated” as a primary while other as non-primary) does not provide a clear definition to warrant interpreting the “primary” and “non-primary” cells as requiring “connection” to the WTRU “at the same time.” Id. That is, nothing in the Specification clearly precludes “primary” and “non-primary” cells from being “source” and “target” cell, as Patent Owner contends. PO Resp. 16. and the Specification, we determine that the terms “primary” and “non-primary” recited in claims 1 and 7 are not limited to cells connected to a WRTU at the same time. We determine no further explicit construction of this term is necessary to resolve the controversy. See Vivid Techs., 200 F.3d at 803.” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“f) Motivation to combine Ericsson and TS 25.331 Petitioner contends that a “POSITA would have been motivated to combine Ericsson and TS 25.331 because they are directed to similar technologies and a skilled artisan would have understood the benefits of combining these two references,” and “would have understood that there was a high likelihood of success in making the combination.” Pet. 34 (citing Ex. 1003 ¶¶ 156–157). In particular, the references “are both reasonably pertinent to the problem faced by the inventor, namely protocols for handover in a telecommunications system.” Id. (citing Ex. 1003 ¶ 158). According to Petitioner, the combination “involves the predictable use of interchangeable prior art elements according to their established functions” more than routine engineering.” Id. at 37 (citing Ex. 1003 ¶ 174). At this stage of the proceeding, Patent Owner does not present arguments in the Preliminary Response addressing the specific merits of Petitioner’s contentions with respect to the motivation to combine Ericsson and TS 25.331. See generally Prelim. Resp. 15–18. We find availing Petitioner’s contention that Ericsson and TS25.331 are “directed to similar technologies,” and that a “skilled artisan would have understood the benefits of combining these two references.” Pet. 34. On this preliminary record, we are persuaded that Petitioner has made a sufficient showing that a POSITA would have had a reason to combine the teachings of Ericsson and TS 25.331.” slip op. at 20
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner, relying on the testimony of Dr. Kakaes, contends that a person of ordinary skill in the art (POSITA) “would have had a B.S. in Electrical Engineering or a related field with at least three years of experience designing, developing, and/or testing telecommunication systems,” and “would also have familiarity with the wireless standards and well-known protocols for accessing wireless networks existing at the relevant time,” wherein “[m]ore education may supplement practical experience or vice versa.” Pet. 12–13. At this stage in the proceeding, Patent Owner does not contest Petitioner’s proposal or offer an alternative. On this record, we are persuaded that Petitioner’s proposal is consistent with the technology described in the Specification and the cited prior art. For purposes of this Decision, we adopt Petitioner’s proposed level of skill.” slip op. at 10
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 10,764,803 - PTAB · Nov 10, 2025 · IPR2025-00878 · APJ Carl M Defranco · IPR · Institution
The Board instituted review of claims 1–3 and 11 after finding a reasonable likelihood that claim 1 is anticipated by Cleveland or obvious over Nakagawa.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“contentions, the cited portions of Cleveland, and the testimony of Clearwater’s expert), we find, preliminarily, that Cleveland discloses each claim element in the manner recited by claim 1. Thus, on the current record, Clearwater demonstrates a reasonable likelihood that challenged claim 1 is unpatentable as anticipated by Cleveland.” slip op. at 6
- Novelty / Anticipation (§102) › Prior-art status of a reference › Patents / published applications (effective date, provisional support)Reference is prior artDecided for petitioner
“5 Clearwater argues that Cleveland qualifies as prior art under 35 U.S.C. § 102(e)(1) “based on both its provisional and non-provisional filing dates.” Pet. 17. In support, Clearwater asserts that Cleveland’s provisional (Ex. 1006) is “virtually identical” to Cleveland itself (id. at 18) and submits claim charts to demonstrate that the Cleveland provisional provides written support for: (1) at least claim 1 of Cleveland (id. at 18–21); and (2) the subject matter relied upon in Cleveland (id. at 21–40 (citing Ex. 1006 throughout)). Based on our review of the Cleveland provisional, as well as Clearwater’s claim charts, we are persuaded that the current record demonstrates that Cleveland is prior art to the challenged patent. See Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1381 (Fed. Cir. 2015).” slip op. at 4
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“satisfies each claim element as identified above in Section I.D, i.e., elements [1.pre]–[1.6]. See id. at 22–40. Clearwater also submits annotated Figure 3 of Cleveland, reproduced below, to further illustrate the specific laminate structure of Cleveland’s coffee cup. See id. at 39.” slip op. at 5
- Obviousness (§103) › Motivation to combine / reasonable expectation of successInstituted
“protective layers have “a coat weight of from 5 to 30 lbs/3000 ft2,” Clearwater submits the declaration of its expert, who explains that, because Nakagawa identifies the specific polymers and the thickness of the coat used for the plastic layers and one skilled in the art “would recognize that the disclosed polymers have a given density,” then “[w]ith these known parameters, the coat weight is easily calculated to be 23.04 lbs./ 3000 ft2 — falling squarely within the claimed range.” Pet. 53–54 (citing Ex. 1003 ¶¶ 132–133; Ex. 1008 ¶ 24; Ex. 1024, at 4). At this stage, we find that testimony credible and supported by the evidence presently of record. After reviewing the preliminary record (including Clearwater’s contentions, the cited portions of Nakagawa, and the testimony of Clearwater’s expert), we find, preliminarily, that Nakagawa discloses or otherwise suggests each claim element in the manner recited by claim 1. Thus, on the current record, Clearwater demonstrates a reasonable likelihood that challenged claim 1 is unpatentable as obvious over Nakagawa. We need not decide Clearwater’s challenge of the dependent claims based on Nakagawa alone nor its challenge of claims 1–3 based on Nakagawa and Tanner. Our analysis of these challenges, in our view, is best left for trial after full development of the record.” slip op. at 8
Claim construction§ 102 anticipation§ 103 obviousnesscites PhillipsPatents in suitUS 8,637,126 - PTAB · Nov 6, 2025 · IPR2025-00820 · APJ Neil T Powell · IPR · Institution
The Board instituted IPR on claims 1–11 on all petition grounds, finding a reasonable likelihood that claim 1 would have been obvious over Tadros, Porter, Kalili, and Texin 990R.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). To institute an inter partes review, we must determine that the information presented in the Petition and the Preliminary Response shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that there is a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim. We institute an inter partes review of claims 1–11 based on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Pet. 17–18 (citing Ex. 1007 ¶¶ 13–15). Patent Owner does not dispute Petitioner’s explanation of the level of skill in the art. See generally Prelim. Resp. At this stage of the proceeding and on the present record, we adopt Petitioner’s uncontested proposed level of ordinary skill in the art, which we find consistent with the level of ordinary skill in the art reflected by the ’090 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Additionally, only terms that are in controversy need to be construed, and these need be construed only to the extent necessary to resolve the controversy. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Both parties indicate that no claim terms need to be expressly construed. Pet. 29–30; Prelim. Resp. 5. Consistent with that, we determine that we need not construe any claim terms expressly in order to resolve the parties’ dispute regarding whether Petitioner has demonstrated a reasonable likelihood of prevailing.” slip op. at 8
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“Weighing the parties’ arguments and evidence, we find Petitioner’s arguments and evidence sufficient at this stage to demonstrate a reasonable likelihood of prevailing. Pet. 8–17, 30–49. For example, regarding whether of Porter’s disclosure to the problem faced by inventor of the ’090 patent. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 144–164. The ’090 patent illustrates that its inventor faced the problem of selecting desirable materials for an aligner, including selecting a desirable material for an aligner’s hard layer. Ex. 1001, 5:44–59. Petitioner and Dr. Osswald provide significant evidence and reasoning tending to show that Porter’s discussion of Tritan logically would have commended itself to the attention of an inventor facing the problem of selecting an aligner hard layer. Pet. 8 (citing Ex. 1007 ¶¶ 98–108, 125–127, 144–164). For example, Dr. Osswald explains that “because Tritan copolyesters are BPA-free, Rafih specifically discloses Tritan EX401 as an exemplary material” for its oral appliance. Id. ¶ 99 (citing Ex. 1104, 5:4–64, claims 2, 9, 10). In view of this, Dr. Osswald testifies that “Rafih would inform a [person of ordinary skill in the art] that Porter’s guidance regarding replacing polycarbonate with Tritan applies to dental appliances.” Ex. 1007 ¶ 146. At this stage, weighing Petitioner’s evidence against Patent Owner’s contrary attorney argument that Porter focuses on dishware, we determine Petitioner has shown sufficiently that Porter is analogous art. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 144–164; Prelim. Resp. 1, 9–10, 18–21.” slip op. at 11
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 11,648,090 - PTAB · Nov 6, 2025 · IPR2025-00821 · APJ Neil T Powell · IPR · Institution
The Board instituted review of claims 1–23, 25, and 26 on all asserted grounds, finding a reasonable likelihood that claim 1 would have been obvious over Tadros, Porter, Kalili, and Texin 990R.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). To institute an inter partes review, we must determine that the information presented in the Petition and the Preliminary Response shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that there is a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim. We institute an inter partes review of claims 1–23, 25, and 26 based on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Pet. 17 (citing Ex. 1007 ¶¶ 13–15). Patent Owner does not dispute Petitioner’s explanation of the level of skill in the art. See generally Prelim. Resp. At this stage of the proceeding and on the present record, we adopt Petitioner’s uncontested proposed level of ordinary skill in the art, which we find consistent with the level of ordinary skill in the art reflected by the ’090 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Additionally, only terms that are in controversy need to be construed, and these need be construed only to the extent necessary to resolve the controversy. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Neither party indicates that we need to construe expressly any claim terms. Pet. 27–28; Prelim. Resp. 5. Consistent with that, we determine that we need not construe any claim terms expressly in order to resolve the parties’ dispute regarding whether Petitioner has demonstrated a reasonable likelihood of prevailing.” slip op. at 8
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“arguments and evidence sufficient at this stage to demonstrate a reasonable likelihood of prevailing. Pet. 8–17, 53–71. For example, regarding whether Porter is analogous art, Petitioner sufficiently shows reasonable pertinence of Porter’s disclosure to the problem faced by inventor of the ’091 patent. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 146–165. The ’091 patent illustrates that its inventor faced the problem of selecting desirable materials for an aligner, including selecting a desirable material for an aligner’s hard layer. Ex. 1001, 5:44–59. Petitioner and Dr. Osswald provide significant evidence and reasoning tending to show that Porter’s discussion of Tritan logically would have commended itself to the attention of an inventor facing the problem of selecting an aligner hard layer. Pet. 8 (citing Ex. 1007 “because Tritan copolyesters are BPA-free, Rafih specifically discloses Tritan EX401 as an exemplary material” for its oral appliance. Id. ¶ 99 (citing Ex. 1104, 5:4–64, claims 2, 9, 10). In view of this, Dr. Osswald testifies that “Rafih would inform a [person of ordinary skill in the art] that Porter’s guidance regarding replacing polycarbonate with Tritan applies to dental appliances.” Ex. 1007 ¶ 147. At this stage, weighing Petitioner’s evidence against Patent Owner’s countervailing attorney argument that Porter focuses on dishware, we determine Petitioner has shown sufficiently that Porter is analogous art. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 146–165; Prelim. Resp. 1–2, 9–10, 34–36.” slip op. at 13
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 11,648,091 - PTAB · Nov 6, 2025 · IPR2025-00819 · APJ Kristina M Kalan · IPR · Institution
The Board instituted IPR on all challenged claims based on both obviousness grounds, finding a reasonable likelihood of success on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground.” slip op. at 14
- Skill levelSkill level petitioner adoptedDecided for petitioner
“would have had at least a four-year undergraduate degree in materials science, mechanical engineering, chemical engineering, or a related field and at least two years of experience in the field of polymer science, combined with at least two years of experience in the field of design, manufacture, and processing of thermoformable polymer sheets for use in various applications, such as in orthodontic and dental appliances. Additional education could substitute for professional experience and vice versa. Pet. 18–19 (citing Ex. 1007 ¶¶ 13–15). At this stage, Patent Owner does not dispute Petitioner’s proposal or offer an alternative proposal. See generally Prelim. Resp. Because Petitioner’s proposed level of ordinary skill in the art appears to be consistent with the cited prior art and is undisputed on this record, we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (indicating that the prior art itself may reflect an appropriate skill level).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Only claim terms in controversy need be construed. Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”). For purposes of this Decision, we determine that no claim term requires express construction.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground. We disagree that Petitioner fails to meet its burden as to the motivation to combine arguments. Petitioner persuasively maps the limitations of the challenged claims to portions of the references relied upon. Pet. 28–38 (claim 1), 38–51. Petitioner also, on this record, provides adequate statements of motivation to combine with a reasonable expectation of success. See, e.g., id. at 34–36 (citing Ex. 1007 ¶¶ 31, 39–42, 147–151, 174–176). The Petition’s reliance on supporting testimony and related corroborating evidence to support the combination does not amount to impermissible hindsight, as that testimony takes into account “knowledge which was within the level of ordinary skill in the art at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure.” In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971). Without further clarification or support from Patent Owner, and in the absence of testimony to support the assertion that a POSITA would not have combined the cited references in the manner proposed with a reasonable expectation of success, we are unpersuaded by Patent Owner’s arguments in this regard.” slip op. at 14
Claim construction§ 103 obviousnesscites KSRPatents in suitUS 11,154,384 - PTAB · Nov 6, 2025 · IPR2025-00818 · APJ Kristina M Kalan · IPR · Institution
The Board instituted IPR on all challenged claims 1–22 based on all three asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority under 35 U.S.C. § 314(a), which provides that inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” After considering the briefing and cited evidence of record, we institute inter partes review because we find that Petitioner establishes a reasonable likelihood that it will prevail with respect to at least one of the claims challenged in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“understanding of a person of ordinary skill in the art at the time the invention was made. See Graham, 383 U.S. at 17–18. Petitioner proposes that a person of ordinary skill in the art (sometimes referred to herein as a “POSITA”) would have had at least a four-year undergraduate degree in materials science, mechanical engineering, chemical engineering, or a related field and at least two years of experience in the field of polymer science, combined with at least two years of experience in the field of design, manufacture, and processing of thermoformable polymer sheets for use in various applications, such as in orthodontic and dental appliances. Additional education could substitute for professional experience and vice versa. Pet. 18 (citing Ex. 1007 ¶¶ 13–15). At this stage, Patent Owner does not dispute Petitioner’s proposal or offer an alternative proposal. See generally Prelim. Resp. Because Petitioner’s proposed level of ordinary skill in the art appears to be consistent with the cited prior art and is undisputed on this record, we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (indicating that the prior art itself may reflect an appropriate skill level).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner argues that no terms require construction, but that “Petitioner applies the prior art consistent with Patent Owner’s assertions in its Infringement Contentions (EX1014, 6-20.).” Pet. 26. Patent Owner does not propose any express claim constructions. Prelim. Resp. 5. Nor does Patent Owner allege that any of Petitioner’s claim interpretations contradict Petitioner’s position in the related district court litigation. Id. Only claim terms in controversy need be construed. Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”). For purposes of this Decision, we determine that no claim term requires express construction.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground. We disagree that Petitioner fails to meet its burden as to the motivation to combine arguments. Petitioner persuasively maps the limitations of the challenged claims to portions of the references relied upon. Pet. 27–36 (claim 1), 36–46. Petitioner also, on this record, provides adequate statements of motivation to combine with a reasonable expectation of success. See, e.g., id. at 32–35 (citing Ex. 1007 ¶¶ 31, 39–41, 57–87, 146–150, 171–172). The Petition’s reliance on supporting testimony and related corroborating evidence to support the combination does not amount to impermissible hindsight, as that testimony takes into account “knowledge which was within the level of ordinary skill in the art at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure.” In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971). Without further clarification or support from Patent Owner, and in the absence of testimony to support the assertion that a POSITA would not have combined the cited references in the manner proposed with a reasonable expectation of success, we are unpersuaded by Patent Owner’s arguments in this regard. We also disagree with Patent Owner’s arguments about “adhesive lamination” using “tie layers” at this point in the proceeding. Prelim. Resp. 15–18. On this record, we are persuaded that Petitioner has adequately supported its arguments that one of ordinary skill in the art would have been motivated to use adhesive lamination to achieve the proposed combination. See, e.g., Pet. 33–35; Ex. 1007 ¶¶ 39–42, 120, 45, 51, 116, 120. Petitioner relies on Kalili as disclosing a hard layer suitable for combination with Tadros’s soft layers (Pet. 32), and more particularly, doing so in the context of a laminated multilayer aligner (Reply 4). To create the laminated multilayer aligner proposed, Petitioner’s suggested use of a particular type of well-known lamination, i.e. adhesive lamination, is sufficiently developed and supported in the Petition. Pet. 32–35. Here, Patent Owner recognizes that Kalili teaches lamination, but suggests that it does not specifically teach using adhesive lamination. Prelim. Sur-reply 5. We note, however, that the parties have identified limited types of known lamination for aligners: coextrusion, extrusion lamination, and adhesive lamination. Prelim Sur-reply 4; Pet. 14–15 n.3, 33. In KSR, the Supreme Court explained that when “there is a design need or market pressure to solve a problem and there are a finite number of identified, predictable solutions, a person of ordinary skill has good reason to pursue the known options within his or her technical grasp.” KSR, 550 U.S. at 421. “If this leads to the anticipated success, it is likely the product not of innovation but of ordinary skill and common sense.” Id. Having reviewed Petitioner’s proffered arguments as to Tadros, Kalili, and Texin 990R, including motivation to combine the references asserted in this ground, with a reasonable expectation of success, we are persuaded on this record that Petitioner has met its burden for institution with respect to Ground 1.” slip op. at 14
Claim construction§ 103 obviousnesscites KSRPatents in suitUS 10,973,613 - Trove Brands, LLC v. Camelbak Products, LLCNo claims unpatentablePTAB · Oct 28, 2025 · IPR2024-00858 · APJ Carl M Defranco · IPR · Final written decision
Claims 5–7 and 16–19 were not shown unpatentable under § 102 or § 103 because the cited references failed to disclose the claimed closure retention mechanism.
RulingsFinal written decision- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesPrior construction adoptedDecided for petitioner
“1. “closure retention mechanism” Trove proposes that “closure retention mechanism” should be construed as a means-plus-function term under 35 U.S.C. § 112(f). See Pet. 18–19; Pet. Reply 1. CamelBak agrees. See PO Resp. 8. Indeed, subsequent to our institution decision, the district court in the parallel action held that the “closure retention mechanism” is a means-plus-function term governed by 35 U.S.C. § 112(f). See Ex. 2010, at 5–6. We see no reason to depart from that holding and adopt the district court’s reasoning in that regard as our own. See id. at 6–8.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“We agree with CamelBak that the plain language of the claim imposes a temporal condition on when the closure is received by the closure retention mechanism, namely, only after it is removed from the drink spout. In other words, the closure cannot be in engagement with, i.e., “received by,” the closure retention mechanism while it remains on the drink spout. This interpretation is consistent with the specification, which repeatedly states that spaced-apart tabs 56 “engage” the closure when it is removed from the spout and moved to the stowed position. Ex. 1001, 8:58–60 (“tabs 56 . . . are configured to selectively engage and retain, or otherwise grip, the closure in the stowed position”); 9:32–39 (“when the closure is positioned between and/or otherwise in engagement with the tabs, the tabs engage the closure across the maximum width, such as with the tabs resiliently deflecting, bending, or compressing to accommodate the greater width of the closure”); 11:36–39 (“the closure retention mechanism 54 may be configured to engage . . . the closure to operatively retain the closure in its stowed configuration.”); 13:26–31 (“When the closure is operatively positioned within the closed perimeter of the handle into its stowed position . . . such closure is compressed slightly.”) (emphases added). Moreover, the specification describes this engagement as occurring by means of a “friction-fit” or “snap-fit” arrangement (id. at 8:50–52, 14:33– 36), which confirms that the closure is not permanently engaged with the tabs, but rather moved into engagement with the tabs, i.e., “received by the closure retention mechanism” per the plain language of the claim. Thus, the intrinsic evidence—the claim language and the specification—supports a construction that imposes a temporal condition on the recited function of the claimed “closure retention mechanism” such that it receives the closure only after the closure has been removed from the drink spout, meaning the closure is not engaged with the closure retention mechanism before it is selectively removed from the drink spout.” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“3. “retain the closure in a stowed position” CamelBak contends that this limitation should be construed to mean “to hold or keep the closure in a position removed from the drink spout.” PO Resp. 13–14; PO Sur-Reply 4. Although Trove contends that CamelBak’s construction “impermissibly rewrites” the claim language, Trove nonetheless “does not disagree that it encompasses ‘hold or keep the Indeed, the claim language itself already contemplates just such a construction by expressly reciting that the closure retention mechanism “selectively retain[s] the closure in a stowed position relative to the handle when the closure is selectively removed from the drink spout.” Ex. 1001, 18:63–66 (emphasis added). As such, we determine that further construction of this limitation is not necessary to resolve the present dispute.” slip op. at 14
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Trove proposes that one of ordinary skill in the art would have had— an undergraduate degree in mechanical engineering or equivalent coursework, and a year or more of experience in designing, prototyping, and/or manufacturing fluid containers or similar products . . . [and that] [m]ore work experience may substitute for a lower level of education, and vice versa. Pet. 17–18 (citing Ex. 1003 ¶¶ 25–30). 2 US 9,272,822 B2, issued Mar. 1, 2016 (Ex. 1004, “Samartgis”). 3 EP 2 177 447 A1, published Apr. 21, 2010 (Ex. 1011, “Gorskey”). 4 US 2006/0006578 A1, published Jan. 12, 2006 (Ex. 1012, “Johnson”). 5 US 7,753,240 B2, issued July 13, 2010 (Ex. 1005, “Leoncavallo”). 6 US D586,184 S, issued Feb. 10, 2009 (Ex. 1006, “Miller”). A person having ordinary skill in the art would have had a bachelor’s degree in mechanical engineering or the equivalent coursework and approximately one year of experience with liquid-containing devices, with more work experience substituting for less education and vice versa. See PO Resp. 7 (citing Ex. 2009 ¶¶ 61–68). Because CamelBak simply paraphrases Trove’s slightly more detailed definition of the level of skill in the art, we adopt Trove’s definition, as it appears reasonable and consistent with the asserted prior art and the ’252 patent.” slip op. at 6
Patent outcomesUS 8,905,252 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnessPatents in suitUS 8,905,252
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.