- Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - Neurocrine Biosciences, Inc. v. Spruce Biosciences, Inc.Institution deniedPTAB · Oct 3, 2025 · PGR2025-00032 · APJ Susan L C Mitchell · PGR · Institution
The Board denied institution because Patent Owner disclaimed all challenged claims.
RulingsInstitution decision- Adverse judgmentAdverse judgmentDenied
“Section 42.207(e) states that “[n]o post-grant review will be instituted based on disclaimed claims.” 37 C.F.R. § 42.207(e). Because the Patent Owner has disclaimed all claims challenged by the grounds in this Petition, we determine that no trial will be instituted.” slip op. at 2
NonePatents in suitUS 12,115,166 - Merck Sharp & Dohme LLC v. The Johns Hopkins UniversityAll claims unpatentablePTAB · Sep 23, 2025 · IPR2024-00649 · APJ Sheridan K Snedden · IPR · Final written decision
Claims 1–28 are unpatentable: claims 1, 2, 4–7, 9–12, 14–17, and 19–28 are anticipated by the MSI-H Study Record; claims 3, 8, 13, and 18 are obvious.
RulingsFinal written decision- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“We agree with Patent Owner that the phrase “in response to” in claim 1 requires a causal relationship wherein the patient must be tested for MSI-H and, if he or she is determined to be MSI-H or dMMR, then the patient is treated with 10 mg/kg of pembrolizumab every 14 days. In claim 1, a biological sample from the patient must be tested to determine if the cancer is MSI-H and, if so, the patient is treated with a therapeutically effective amount of pembrolizumab. For this reason, if the prior art teaches the limitations of 1) testing a biological sample obtained from a patient having cancer to determine that the patient’s cancer is microsatellite instability high or mismatch repair deficient, and 2) treating the patient with a therapeutically effective amount of pembrolizumab if the patient’s cancer is determined to be microsatellite instability high or DNA mismatch repair deficient, the art anticipates claim 1. We are not persuaded that claim 1 requires or excludes anything else because nothing else is recited in the claim.” slip op. at 9
- Skill levelSkill level board ownOther
“In the Decision to institute trial, we adopted Petitioner’s uncontested proposal defining that the level of skill in the art, presented above. Inst. Dec. 7. Neither party directs us to evidence of the level of skill in the art beyond what we considered for institution of trial. Having considered Patent Owner’s positions and evidence of record, however, we determine that the level of skill also includes knowledge of and experience with treating cancer patients with immunotherapy compounds, identifying the conditions these patients may have, and understanding the literature regarding clinical trials for such cancers and the associated conditions and immunotherapy.” slip op. at 15
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“holding is limited to anticipation of a claimed genus through disclosure of individual species, whereas the facts of this case involve the disclosure of a genus. PO Resp. 14. Because the facts before us, including the testimony of Patent Owner’s witness, indicate that one of ordinary skill in the art would have immediately understood that the third arm of the study described in the MSR includes patients with cancers recited in claim 1, including endometrial, gastric, and small-bowel cancers, we are persuaded that one of ordinary skill in the art would have understood that the MSR discloses species that fall within the scope of claim 1. Ex. 2090 ¶ 79; Ex. 1243, 115:5–116:22; Ex. 1085, 673–75; Ex. 1086, 14; Ex. 1003 ¶¶ 25, 63; Ex. 1005, 4. We are not persuaded that where species falling within the scope of claim 1 were previously known and disclosed in MSR, that claim 1 is patentable over the MSR. See Kennametal, Inc. v. Ingersoll Cutting Tool Co., 780 F.3d 1376, 1381 (Fed. Cir. 2015) (“a reference can anticipate a claim even if it ‘d[oes] not expressly spell out’ all the limitations arranged or combined as in the claim, if a person of skill in the art, reading the reference, would ‘at once envisage’” the claimed arrangement or combination.” (quoting In re Petering, 301 F.2d 676, 681 (CCPA 1962)). After considering the parties’ arguments and the evidence presented, we are persuaded that the MSR teaches “testing or having tested a biological sample obtained from a patient” having endometrial, small bowel, or gastric cancer and, thus teaches the corresponding limitation of claim 1.6” slip op. at 29
- Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner
“Regarding the dependent claims that Petitioner challenges only on obviousness grounds (claims 3, 8, 13, 18), Patent Owner must show a nexus between the claimed methods and the evidence of non-obviousness. See Henny Penny Corp. v. Frymaster LLC, 938 F.3d 1324, 1332 (Fed. Cir. 2019) (“to be accorded substantial weight in the obviousness analysis, the evidence of secondary considerations must have a ‘nexus’ to the claims, i.e., there must be ‘a legally and factually sufficient connection’ between the evidence and the patented invention. . . . Ultimately, ‘[t]he patentee bears the burden of showing that a nexus exists.’” (quoting Demaco Corp. v. F. Von Langsdorff Licensing Ltd., 851 F.2d 1387, 1392 (Fed. Cir. 1988), WMS Gaming, Inc. v. Int'l Game Tech., 184 F.3d 1339, 1359 (Fed. Cir. 1999)). Patent Owner does not direct us to evidence of a nexus to limitations recited in the dependent claims, for example to claims 3 and 13, which recite testing a biological sample that is a bodily fluid, claims 8 and 18, which recite testing that comprises assessing one or more markers selected from the group consisting of BAT-25, BAT-26, MONO-27, NR-21 and NR-24. Even if there is a nexus to the Patent Owner’s evidence of secondary considerations, the evidence addresses the methods of independent claims 1 and 11, not the limitations of the claims Petitioner challenges as being obvious. PO Resp. 55–83. Patent Owner directs us only to evidence regarding treating patients determined to have certain MSI-H cancers with pembrolizumab, which we determine to be anticipated by the MSR. Id. at 58. When evidence of a “secondary consideration is exclusively related to a single feature that is in the prior art,” our reviewing court has held the evidence is of no relevance to the obviousness inquiry. See Yita LLC v. MacNeil IP LLC, 69 F.4th 1356, 1363–65 (Fed. Cir. 2023), cert. denied, 144 S. Ct. 499 (2023) (distinguishing WBIP, LLC v. Kohler Co., 829 F.3d 1317, 1330–31 (Fed. Cir. 2016)); see also Ethicon Endo-Surgery, Inc. v. Covidien LP, 812 F.3d 1023, 1034 (Fed. Cir. 2016) (“[I]f the feature that creates the commercial success was known in the prior art, the success is not pertinent.”). In Yita, the prior art taught close-conformance of a floor tray with the walls of a vehicle foot well, which one of ordinary skill in the art would have had reason to use in combination with other prior-art teachings to arrive at the claimed invention. See Yita, 69 F.4th at 1359–61. The court held that because the asserted evidence of secondary consideration related exclusively to close-conformity, the evidence was not persuasive of non-obviousness, even though the claimed floor tray was coextensive with the product that produced the evidence. See id. at 1364–65 (“The coextensiveness inquiry bears only on the presumption of nexus; it does not decide the overall nexus question.”). Because Patent Owner directs us only to evidence that the methods recited in claims 1 and 11 produced evidence of secondary considerations, we are not persuaded that this evidence is persuasive of the non-obviousness of the specific methods recited in the dependent claims. For example, Patent Owner fails to direct us to evidence that a method of treating MSI-H colorectal cancer in a patient “wherein the biological sample is a body fluid from the patient,” as recited in claim 3, or “wherein the at least one marker comprises BAT-25, BAT-26, MONO-27, NR-21 or NR-24,” as recited in claim 8, demonstrated unexpected results or commercial success. Accordingly, having considered the evidence of record as a whole, we determine that Petitioner has demonstrated by a preponderance of the evidence that the methods of claims 3, 8, 13, and 18 would have been obvious. We are not persuaded to the contrary by Patent Owner’s arguments or evidence of second secondary considerations.” slip op. at 47
Patent outcomesUS 11,629,187 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,629,187 - Merck Sharp & Dohme LLC v. The Johns Hopkins UniversityAll claims unpatentablePTAB · Sep 23, 2025 · IPR2024-00647 · APJ Sheridan K Snedden · IPR · Final written decision
Claims 1–36 are unpatentable: claims 1–2, 4–8, 11–12, 14–18, and 21–36 as anticipated, and claims 3, 9, 10, 13, 19, and 20 as obvious.
RulingsFinal written decision- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner
“We agree with Patent Owner that the phrase “in response to” in claim 1 requires a causal relationship wherein the patient must be tested for MSI-H and, if he or she is determined to be MSI-H or dMMR, then the patient is treated with 10 mg/kg of pembrolizumab every 14 days. In claim 1, a biological sample from the patient must be tested to determine if the cancer is MSI-H and, if so, the patient is treated with a therapeutically effective amount of pembrolizumab. For this reason, if the prior art teaches the limitations of 1) testing a biological sample obtained from a patient having colorectal cancer to determine that the patient’s colorectal cancer is microsatellite instability high or mismatch repair deficient, and 2) treating the patient with a therapeutically effective amount of pembrolizumab if the patient’s colorectal cancer is determined to be microsatellite instability high or DNA mismatch repair deficient, the art anticipates claim 1. We are not persuaded that claim 1 requires or excludes anything else because nothing else is recited in the claim.” slip op. at 9
- Skill levelSkill level petitioner adoptedDecided for petitioner
“The ’287 patent claims a method of treating a human patient with colorectal cancer having certain characteristics using pembrolizumab and the main prior art reference cited by Petitioner discloses testing pembrolizumab to treat human patients. See Ex. 1001, 24:42–52; Ex. 1005. Accordingly, the relevant field of Patent Owner’s claims is treating human patients, as well as testing existing compounds. In the Decision to institute trial, we adopted Petitioner’s uncontested proposal defining that the level of skill in the art, presented above. Dec. 7– 8. Neither party directs us to evidence of the level of skill in the art beyond what we considered for institution of trial. Having considered Patent Owner’s positions and evidence of record, however, we determine that the level of skill also includes knowledge of and experience with treating cancer patients with immunotherapy compounds, identifying the conditions these patients may have, and understanding the literature regarding clinical trials for such cancers and the associated conditions and immunotherapy.” slip op. at 14
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
- Expert testimonyPetitioner expert creditedDecided for petitioner
“In an anticipation analysis, the dispositive question is whether a skilled artisan would ‘reasonably understand or infer’ from a prior art reference that every claim limitation is disclosed in that single reference.” Acoustic Tech., Inc. v. Itron Networked Sols., Inc., 949 F.3d 1366, 1373 (Fed. Cir. 2020). Extrinsic evidence, such as declarations and depositions may be considered when it is used to explain, but not expand, the meaning of a reference. See In re Baxter Travenol Labs., 952 F.2d 388, 390 (Fed. Cir. 1991) (holding that the depositions and declarations of skilled workers were properly used to show what those skilled in the art would have known about the prior art). We credit Dr. Neugut’s and Dr. Oberstein’s testimony about what one of ordinary skill in the art would have understood after reviewing the MSR. slip op. at 34
Patent outcomesUS 11,649,287 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,649,287 - Merck Sharp & Dohme LLC v. The Johns Hopkins UniversityAll claims unpatentablePTAB · Sep 19, 2025 · IPR2024-00650 · APJ Deborah Katz · IPR · Final written decision
Claims 1–38 are unpatentable: claims 1, 2, 4–7, 11–17, 19–22, and 26–38 are anticipated by the MSR; the remaining claims are obvious over the MSR and cited references.
RulingsFinal written decision- Skill levelSkill level board ownDecided for petitioner
“Petitioner and Patent Owner characterize one of ordinary skill in the art differently. To Petitioner, the ordinarily skilled artisan would be a medical doctor, or a professional in a related field, with experience treating cancer or access to those with experience in clinical studies of therapeutics and to a pathologist with this experience. (See Pet. 11 (citing Ex. 1003 ¶ 19).) To Patent Owner, the ordinarily skilled artisan would have had a medical or graduate-level degree, or equivalent work experience, in the fields of immunology, genetics, or a related field and would have experience (i) conducting immunology research relating to oncology, (ii) conducting genetics research relating to oncology, or (iii) developing and conducting clinical trials on novel cancer therapies in those fields. (See PO Resp. 5–6 (citing Ex. 2072 ¶¶ 31–32, 91–99).) Petitioner emphasizes medical and treatment aspects in its characterization of an ordinarily skilled artisan, whereas Patent Owner emphasizes research aspects. The ’491 patent claims a method of treating a human patient with cancer having certain characteristics using pembrolizumab and the main prior art reference cited by Petitioner discloses testing pembrolizumab to treat human patients. (See Ex. 1001, 25:36–52, 26:24–41, Ex. 1005; see Decision 8–9.) Accordingly, the relevant field of Patent Owner’s claims is treating human patients, as well as testing existing compounds. In light of the extent of the relevant field, we determine that the level of skill in the art relevant to the claims of the ’491 patent is not limited to knowledge of and experience with conducting research relating to oncology or developing and conducting clinical trials, but includes knowledge of and experience with treating cancer patients with immunotherapy compounds, identifying the conditions these patients may have, and understanding the literature regarding clinical trials for such colorectal cancers and the associated conditions and immunotherapy. C. Claim Construction” slip op. at 8
- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
“Dr. Lonberg, Patent Owner’s witness, does not dispute any of Dr. Neugut’s or Dr. Oberstein’s testimony, but asserts only that Dr. Neugut’s testimony relies only on what was generally done, not on what is expressly disclosed in the MSR. (See Ex. 2072 ¶¶ 105–107.) On cross-examination, Dr. Lonberg agreed with Dr. Oberstein that patients who had received prior cancer therapy were not excluded from the study described in the MSR. (See Ex. 1245, 57:5–58:2, 40:5–14, 49:2–12.) Thus, after considering the evidence cited by each party, we find Dr. Neugut’s and Dr. Oberstein’s testimony to be the most directly relevant and persuasive about what one of ordinary skill in the art would have understood from the MSR itself. We are also persuaded by the lack of a specific contradiction regarding the understanding of one of ordinarily skill in the art by Dr. Lonberg. Even if some patients who had been previously treated with specific drugs were excluded from the study described in the MSR, we are persuaded that one of ordinary skill in the art would have understood the MSR as including other patients who have been treated with a prior cancer therapy drug. We are persuaded that Petitioner has met its burden of proving whether a skilled artisan would reasonably understand or infer that the limitations of claims 13, 28, 32, and 36 were disclosed in the MSR. Petitioner demonstrates what one of ordinary skill in the art would have understood from the MSR, not what it inherently discloses. (Contra PO Resp. 19–22.)” slip op. at 38
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“Patent Owner argues that the “in response to” limitation of claim 1 describes administering the claimed treatment only to patients determined to have an MSI-H tumor. (See PO Resp. 6.) But neither claim 1 nor claim 16 includes a limitation excluding the treatment of any patient, such as specifically excluding treatment of any patient who has a tumor that is not MSI-H or dMMR. Neither claim 1 nor claim 16 recites any language differentiating between patients or identifying a patient population to be excluded from treatment. Instead, claims 1 and 16 provide that if the colorectal cancer patient is tested and the cancer is determined to be MSI-H or dMMR, the patient is treated with a therapeutically effective amount of pembrolizumab. We note that the methods of claims 1 and 16 use the open-ended transitional phrase “comprising” that is generally interpreted to not exclude additional, unrecited elements. See Invitrogen Corp. v. Biocrest Mfg., L.P., 327 F.3d 1364, 1368 (Fed. Cir. 2003) (“The transition ‘comprising’ in a method claim indicates that the claim is open-ended and allows for additional steps.”); Genentech, Inc. v. Chiron Corp., 112 F.3d 495, 501 (Fed. Cir. 1997) (“‘Comprising’ is a term of art used in claim language that means that the named elements are essential, but that other elements may be added and still form a construct within the scope of the claim.”). The use of the open-ended transitional phrase “comprising” in claims 1 and 16 further suggests to us that any additional steps taken in conjunction with expressly recited method steps, such as the treatment of patients who are not MSI-H or dMMR, are not excluded from the scope of the claim.” slip op. at 13
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“discloses species that fall within the scope of claim 1. (See Ex. 2090 ¶ 79; Ex. 1243, 115:5–116:22; Ex. 1085, 673–75; Ex. 1086, 14; Ex. 1003 ¶¶ 25, 67; Ex. 1005, 4.) We are not persuaded that where species falling within the scope of claim 1 were previously known and disclosed in MSR, that claim 1 is patentable over the MSR. See Kennametal, Inc. v. Ingersoll Cutting Tool Co., 780 F.3d 1376, 1381 (Fed. Cir. 2015) (“a reference can anticipate a claim even if it ‘d[oes] not expressly spell out’ all the limitations arranged or combined as in the claim, if a person of skill in the art, reading the reference, would ‘at once envisage’” the claimed arrangement or combination.” (quoting In re Petering, 301 F.2d 676, 681 (CCPA 1962)). After considering the parties’ arguments and the evidence presented, we are persuaded that the MSR teaches “testing or having tested a biological sample obtained from a patient” having endometrial, small bowel, or gastric cancer and, thus teaches the corresponding limitation of claim 1. d) Element [1.3]: “thereby determining that the patient’s cancer is” slip op. at 26
Patent outcomesUS 11,634,491 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,634,491 - PTAB · Sep 19, 2025 · PGR2025-00025 · APJ Kimberly Mcgraw · PGR · Institution
The Board instituted PGR on claims 1–19 and all asserted grounds, finding it more likely than not that claim 1 is anticipated by the Gatorade Label.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“if “the information presented in the petition . . . demonstrate[s] that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” Post-grant review is available for patents that issue from applications that at one point contained at least one claim with an effective filing date on or after March 16, 2013. See Leahy-Smith America Invents Act, Pub. L. No. 112-29, 125 Stat. 284 (2011) (“AIA”), §§ 3(n)(1), 6(f)(2)(A). After considering the briefing and the evidence of record, for the reasons set forth below, we determine that Petitioner has shown that the ’422 Patent is eligible for post-grant review and has shown it is more likely than not that at least one challenged claim of the ’422 Patent is unpatentable under § 324(a). Accordingly, we institute a post-grant review of the challenged claims of the ’422 Patent.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art “would possess at least (1) a Bachelor’s degree in chemistry or a related field, with (2) five years of experience in material identification and characterization using multiple analytical methods and field sampling, or equivalent research or professional experience.” Pet. 12 (citing Ex. 1014 ¶ 24). Patent Owner does not dispute Petitioner’s definition for one of ordinary skill in the art nor provide a proposed definition of its own. See generally Prelim. Resp. For the purposes of this Decision, we adopt Petitioner’s undisputed proposal regarding the level of one of ordinary skill in the art.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Prosecution history disclaimer / disavowalDisclaimer foundDecided for patent owner
“336. The applicant explained that not all combinations of shrink films and light blocking materials are recyclable. Id. at 335. The applicant explained that films can be compatible with PET recycling in two ways, (1) the film can float in water and be separated from PET that sinks in water or (2) the PET films crystallize and “can be recovered with the PET stream.” Id. at 336 (citing “A Resource Document by the Association of Plastic Recyclers (APR)”) (found at Ex. 1002, 323–332) (emphasis omitted). The applicant explained that “removing the label before or during the recycling process is not evidence of the recyclability of the label” and that “[r]emoving the label during the recycling process is not equivalent to actually recycling the label.” Id. at 335. As such, a POSITA reading the prosecution history would understand that a label is not recyclable with a PET container, as recited by the independent claims, by removing the label from the PET recycle stream before or during the recycling process.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownOther
“To determine how a person skill in the art would determine if a shrink label is “recyclable” as recited in the independent claims, we look to how the Specification of the ’422 Patent describes or defines recyclable shrink labels. For example, the ’422 Patent states that PET shrink films are generally considered recyclable if no inks are retained on the film after a caustic wash cycle typically used in PET reclaiming processes. Ex. 1001, 6:61–65. The ’422 Patent further states that labels are fully recyclable if the polymers used are clear, preferably clear PET, and the labels include inks that can be washed off in a “typical PET recycling wash (caustic wash).” Id. at 11:44– 49; see also id. at 11:49–54 (describing embodiments in which the labels are free or substantially free of inks that cannot be washed off in a caustic wash or where the labels are free or substantially free of color plastics that cannot be recycled). The ’422 Patent further discusses “industry standards” for determining whether various embodiments of shrink labels are recyclable. See, e.g., id. at 11:29–53. For example, the Specification states that the “Association for Plastic Recyclers (APR) Critical Guidance Protocol for Clear PET Articles with Labels and Closures (PET-CG-02)” (Ex. 1005) can certify that a film is fully recyclable with a container or bottle. Id. at 11:34– 38. Additionally, the Specification states that labels “are recyclable according to the Evaluation of the Near Infrared (NIR) Sorting Potential of a Whole Plastic Article (SORT-B-01)” (Ex. 1010) and/or the “Evaluation of Sorting Potential for Plastic Articles Utilizing Metal, Metalized, or Metallic Printed Components (SORT-B-03)” (Ex. 1011). Ex. 1001, 11:39–44. The ’422 Patent further states that embodiments of the labels “are fully recyclable. For example, the labels may include inks that can be washed off in a typical PET recycling wash (caustic wash) and the polymers” are preferably clear PET. Id. at 11:44–48. The ’422 Patent thus provides various descriptions or standards to determine the recyclability of shrink labels. For the purposes of addressing the anticipation and obviousness grounds, we determine that any of these standards can be used to determine if a shrink label is “recyclable.” We note that our construction is preliminary and is based on the present record. We invite the parties to further the address the construction of “wherein the recyclable shrink label is recyclable with a PET container” during trial.” slip op. at 12
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Phillips · NautilusPatents in suitUS 11,961,422 - Merck Sharp & Dohme LLC v. The Johns Hopkins UniversityAll claims unpatentablePTAB · Sep 18, 2025 · IPR2024-00625 · APJ Deborah Katz · IPR · Final written decision
Claims 1–8 are unpatentable: claims 1–4 and 6–8 are anticipated by MSR, and claim 5 is obvious over MSR with the additional marker-testing teachings of Chapelle.
RulingsFinal written decision- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“In an anticipation analysis, the dispositive question is whether a skilled artisan would ‘reasonably understand or infer’ from a prior art reference that every claim limitation is disclosed in that single reference.” Acoustic Tech., Inc. v. Itron Networked Sols., Inc., 949 F.3d 1366, 1373 (Fed. Cir. 2020). Extrinsic evidence, such as declarations and depositions may be considered when it is used to explain, but not expand, the meaning of a reference. See In re Baxter Travenol Labs., 952 F.2d 388, 390 (Fed. Cir. 1991) (holding that the depositions and declarations of skilled workers were properly used to show what those skilled in the art would have known about the prior art). Although Patent Owner argues that a missing element cannot be filled by what an ordinarily skilled artisan would have envisioned, Petitioner’s argument is based on what one of ordinary skill in the art would have understood from what the MSR expressly teaches. (See Pet. 20 (“Indeed, prior art concerning the MSI-H Study indicates that the physicians understood postings on clinicaltrials.gov indicated that patients had ‘metastatic tumors.’ (EX1049, 444; see also EX1050, S4; EX1003, ¶62.)”).) Unlike the facts of Nidec, where a missing signal could have been envisioned but was not present, we are persuaded by the evidence Petitioner presents that those of ordinary skill in the art understood the MSR express disclosure to include patients with unresectable or metastatic tumors because references referring to the study underlying the MSR discuss the inclusion of patients with metastatic tumors in the study. Even if Dr. Neugut’s reasoning that the reference to “measurable” disease in the MSR would have indicated patients having metastatic cancer is flawed, we are persuaded by Petitioner’s evidence of publications referring to the MSR as a study of metastatic colorectal cancer, and we are further persuaded that one of ordinary skill in the art would have understood the MSR to disclose treating patients having metastatic colorectal cancer with pembrolizumab. (See Ex. 1049, 444, Ex. 1050, S4.) Patent Owner does not address this evidence. Instead, Patent Owner acknowledges that “the MSR discloses treating cancer patients that could be within the claimed subset,” but argues that the MSR does not inherently anticipate results later obtained by treating only patients within the claimed subset. (See Pet. Sur- Reply 5–6.) We are persuaded, though, that Petitioner’s challenge is based on what one of ordinary skill in the art would have understood from the MSR (that patients who had an unresectable or metastatic tumor were selected), not on what is inherent to the disclosure of the MSR. We are persuaded that one of ordinary skill in the art at the time would have understood the MSR to teach selecting a patient “who has an unresectable or metastatic,” as required in claim 1. c) Element 1.2: “microsatellite instability-high (MSI-H) or mismatch slip op. at 14
- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedDecided for petitioner
“Patent Owner argues further that the MSR discloses an experimental use that does not qualify as prior art. (See PO Resp. 16–23.) Patent Owner argues that an inventor can be granted latitude to experiment in the public eye until her invention is ready for patenting. (See id. at 16 (citing Pfaff v. Wells Elecs., Inc., 525 U.S. 55, 64 (1998).) According to Patent Owner, the experimental use negation applies to the MSR under a 13-factor analysis provided in Allen Eng'g Corp. v. Bartell Indus., Inc., 299 F.3d 1336, 1353 (Fed. Cir. 2002). (See PO Resp. 17–23.) For example, Patent Owner argues that to establish that treatment of MSI-H cancers was effective, the inventors had to test treatment in humans, there being no animal models, and had to publish the MSR on the government website under federal law. (See PO Resp. 18–20.) Patent Owner argues further that the inventors had control over the MSI-H clinical study and that the field of cancer treatment was highly unpredictable, among other facts. (See id. at 19–20.) Patent Owner argues that “[a]t the time of the MSR’s posting, the claimed invention was not, nor could it have been, ready for patenting. The clinical study that ultimately collected the data reported in the patent specification and supporting the patent claims had not and could not have commenced before the MSR was posted.” (Id. at 21.) In City of Elizabeth, the Supreme Court was concerned that “[i]t is sometimes said that an inventor acquires an undue advantage over the public by delaying to take out a patent, inasmuch as he thereby preserves the monopoly to himself for a longer period than is allowed by the policy of the law,” but held that “when the delay is occasioned by a bona fide effort to bring his invention to perfection, or to ascertain whether it will answer the purpose intended,” the experiment use exception can preserve the inventor’s rights. City of Elizabeth v. Am. Nicholson Pavement Co., 97 U.S. 126, 137 (1877). Because we are not persuaded that Patent Owner could not have filed an earlier application, we are not persuaded that the experimental use doctrine is properly applied in this case. Given that clinical trial protocols published on the ClinicalTrials.gov website have been successfully asserted as prior art in other cases, we are not persuaded by Patent Owner’s arguments that the MSR is not available as prior art against the challenged claims. See, e.g., Salix Pharms., Ltd. v. Norwich Pharms. Inc., 98 F.4th 1056, 1061 (Fed. Cir.), cert. denied, 145 S. Ct. 567 (2024), and cert. denied, 145 S. Ct. 983 (2024). After considering the parties’ arguments and evidence, we are” slip op. at 24
- Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner
“In order to show that objective evidence renders the method of claim 5 non-obvious, Patent Owner must show a nexus between the subject matter recited in claim 5 and the evidence of non-obviousness. See Henny Penny Corp. v. Frymaster LLC, 938 F.3d 1324, 1332 (Fed. Cir. 2019) (“to be accorded substantial weight in the obviousness analysis, the evidence of secondary considerations must have a ‘nexus’ to the claims, i.e., there must be ‘a legally and factually sufficient connection’ between the evidence and the patented invention. . . . Ultimately, ‘[t]he patentee bears the burden of showing that a nexus exists.’” (quoting Demaco Corp. v. F. Von Langsdorff Licensing Ltd., 851 F.2d 1387, 1392 (Fed. Cir. 1988), WMS Gaming, Inc. v. Int'l Game Tech., 184 F.3d 1339, 1359 (Fed. Cir. 1999)). Patent Owner argues that there is a nexus between the development and commercialization of pembrolizumab and the patented method of treatment recited in the challenged claims, citing, inter alia, the package insert for Keytruda® (pembrolizumab), but Patent Owner does not direct us to evidence of a nexus to MSI-H or MMR deficient tumors that exhibit instability in the microsatellite markers recited in claim 5 and the unexpected results, commercial success, or other objective measures of non-obviousness flowing from these additional limitations. (See PO Resp. 50–63 (citing Ex. 2129, Ex. 2072 ¶ 190, Ex. 2090 ¶¶ 82–92).) Patent Owner directs us only to evidence regarding determining MSI-H status and then using Keytruda® to treat MSI-H cancer patients, which we determine to be anticipated by the MSR. (See PO Resp. 60.) When evidence of a “secondary consideration [] is exclusively related” slip op. at 34
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable
“(Ex. 1001, 26:19–28.) In Grounds 3 and 5, Petitioner argues, relying on Dr. Neugut’s testimony, that Chapelle teaches standard methods of testing whether a tumor is MSI-H, including determining whether the patient’s tumor exhibits instability in a microsatellite marker, such as BAT-25 or BAT-26. (See Pet. 42 (citing Ex. 1007, 3380, 3383; Ex. 1003 ¶ 107).) For example, Chapelle states that “‘a standard test’ using a ‘[p]anel consisting of … BAT26, BAT25’ has ‘stood the test of time.’” (Ex. 1007 at 3382.) Dr. Neugut testifies that one of ordinary skill in the art would have been motivated to treat a patient with an unresectable or metastatic MSI-H dMMR tumor, wherein the tumor exhibits instability in the BAT-25 and BAT-26 microsatellite marker, and would have expected success in doing so, in light of the teachings of Chapelle. (See Ex. 1003 ¶¶ 105–108.) We find that the record as recounted above supports Petitioner’s challenges of claim 5 in Grounds 3 and 5.” slip op. at 31
Patent outcomesUS 11,339,219 unpatentable§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,339,219 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Sep 15, 2025 · IPR2025-00005 · APJ John G New · IPR · Rehearing
Denied Solus’s rehearing request; the Board maintained its denial of institution because the petition did not show a reasonable likelihood of prevailing on the challenged claims.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“[O]f the 44 specimens tested by Ye, as revealed in Ye’s Table II, only a single specimen, specimen 15, meets the required TC ratios recited in challenged claim 1 of the ’541 patent. Furthermore, none of the references cited by Petitioner teach, or even remotely suggest, the four requisite TC ratios recited by challenged claim 1. We find Petitioner’s argument that a person of ordinary skill in the art would have been motivated to exclusively select Ye’s sample 15, out of the remaining 43, to which to apply the teachings of Hara and Otsuka concerning the requisite tensile strength and weight deviation ranges in the hope of arriving at the claimed invention, is implausible. Indeed, only the ’541 patent, among all of the evidence of record, that actually mentions the required texture coefficient ratios recited in challenged claim 1. Petitioner provides no convincing argument as to why a skilled artisan would have selected sample 15 for combination with Hara and Otsuka.” slip op. at 10
- Expert testimonyPetitioner expert discountedDecided for patent owner
“At the heart of this flaw is Petitioner’s argument, and Dr. Josefowicz’s opinion, that it would have been conventional in the art at the time of filing to vary the electrolyte concentration, electrolysis plating parameters, temperature, and the use of organic and inorganic additives, in order to obtain a copper foil with tensile strength and elongation values falling within the claimed ranges as these ranges were well known, at least since 1974. Ex. 1003 ¶ 63. This statement is largely unsupported by evidence of record, with the sole exception of Table 2 of Lowenheim, which, as Patent Owner points out, provides tensile strengths well outside the claimed range. Petitioner provides insufficient guidance as to how a person of ordinary skill in the art would have known which parameters to vary, or how to vary them, to provide the foil of Hirose with a tensile strength or weight deviation within the claimed range. Dr. Josefowicz’s statement that this would result from routine optimization, and was “conventional” may or may not be true, but it is insufficiently supported by evidence of record to be persuasive.” slip op. at 6
§ 103 obviousnessPatents in suitUS 9,457,541 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Sep 15, 2025 · IPR2025-00005 · APJ John G New · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show a reasonable likelihood of prevailing on claims 1-4.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“In summary, we again conclude that Petitioner has failed to provide sufficient evidence to demonstrate that a person of ordinary skill in the art would have had a reasonable expectation of success in combining the cited prior art references, in combination with Dr. Josefowicz’s relatively unsupported testimony concerning a skilled artisan’s ability to optimize various constituents and conditions, to arrive at the claimed invention. Petitioner has not pointed to any argument or unconsidered evidence of record that is sufficient to show that, in reaching its conclusion, the Board abused its discretion by basing its Decision on an erroneous interpretation of law, a factual finding not supported by substantial evidence, or an unreasonable judgment in weighing relevant factors. Arnold, 362 F.3d at 1340.” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“teaches the tensile strengths of various types of copper-electroplated steel electrical cable wire of different properties, including high strength, hardness, low electrical resistivity, near zero strength, good leveling, and thermal stability, some of which fall within the claimed range of tensile strength of 30 to 40 kgf/mm2. Lowenheim, 196, Table II. However, none of these categories correspond to those copper foil properties recited in the claims, and Dr. Josefowicz’s testimony provides little guidance as to how a person of ordinary skill in the art would have known how to optimize the recited properties, and particularly so in combination with the teachings of Hirose and the other cited prior art references. Furthermore, as we noted in our Decision:” slip op. at 7
- Expert testimonyPetitioner expert discountedDecided for patent owner
“At the heart of this flaw is Petitioner’s argument, and Dr. Josefowicz’s opinion, that it would have been conventional in the art at the time of filing to vary the electrolyte concentration, electrolysis plating parameters, temperature, and the use of organic and inorganic additives, in order to obtain a copper foil with tensile strength and elongation values falling within the claimed ranges as these ranges were well known, at least since 1974. Ex. 1003 ¶ 63. This statement is largely unsupported by evidence of record, with the sole exception of Table 2 of Lowenheim, which, as Patent Owner points out, provides tensile strengths well outside the claimed range. Petitioner provides insufficient guidance as to how a person of ordinary skill in the art would have known which parameters to vary, or how to vary them, to provide the foil of Hirose with a tensile strength or weight deviation within the claimed range. Dr. Josefowicz’s statement that this would result from routine optimization, and was “conventional” may or may not be true, but it is insufficiently supported by evidence of record to be persuasive. Id. (emphasis added) (footnote omitted).” slip op. at 6
§ 103 obviousnessPatents in suitUS 9,457,541 - Synaffix B.V. v. Hangzhou Dac Biotech Co., Ltd.Some claims unpatentablePTAB · Aug 26, 2025 · IPR2022-01531 · APJ Devon Zastrow Newman · IPR · Final written decision
Claims 1–17, 20, 21, 24, 26, and 29–31 are unpatentable; claims 25 and 32–34 were not shown unpatentable, and the motion to exclude was dismissed as moot.
RulingsFinal written decision- RemandOther
“review of claims 1–17, 20, 21, 24–26, and 29–34 of the ’682 patent. Paper 2 (“Pet.”), 1, 3. Patent Owner, Hangzhou DAC Biotech Co., Ltd., filed a Preliminary Response (Paper 9, “Prelim. Resp.”). We initially determined that the information presented in the Petition did not establish a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims, and did not institute inter partes review. Paper 17. Petitioner requested Director review of our decision denying institution (Paper 18 (“Request”)). The Director delegated review of the decision to a Delegated Rehearing Panel (“DRP”). Paper 19. Patent Owner was granted the option to file a response to Petitioner’s Request (Paper 22 (“Request Resp.”)). The Delegated Review Panel vacated our decision and remanded the case to this panel with a revised claim construction for claim 1. Paper 23 (“DRP Dec.”). On August 30, 2024, we instituted an inter partes review after remand from the Director. Paper 25 (“Inst. Dec.”). Patent Owner subsequently filed a Patent Owner Response (Paper 31, “Resp.”), Petitioner filed a Reply (Paper 36, “Reply”), Patent Owner filed a Sur-reply (Paper 44, “Sur-reply”), and Petitioner filed a Sur-sur-reply (Paper 48, “Sur-sur-reply”).” slip op. at 2
- PTAB / AIA Trials › Motions to amend / substitute claimsOther
“I. Patent Owner’s Motion to Exclude Evidence Patent Owner moves to exclude Exhibits 1089 and 1090. Paper 50. As we did not rely on either of Exhibits 1089 or 1090 in deciding this matter, Patent Owner’s motion is dismissed as moot.” slip op. at 96
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableMixed
“For these reasons, Patent Owner’s arguments and cited evidence also” slip op. at 31
- Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableNot shown unpatentableMixed
“function as R2, and the ethyl group may function as R4, which can be a linear alkyl having 1–6 carbon atoms. We note that claim 3 permits R5 and R6 to be absent. For these reasons, the arguments presented in the Petition demonstrate that claim 3 would have been obvious over Singh’s Compound 3 when modified in view of Harris.” slip op. at 73
Patent outcomesUS 10,131,682 mixed§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,131,682
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.