- PTAB · Nov 6, 2025 · IPR2025-00820 · APJ Neil T Powell · IPR · Institution
The Board instituted IPR on claims 1–11 on all petition grounds, finding a reasonable likelihood that claim 1 would have been obvious over Tadros, Porter, Kalili, and Texin 990R.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). To institute an inter partes review, we must determine that the information presented in the Petition and the Preliminary Response shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that there is a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim. We institute an inter partes review of claims 1–11 based on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Pet. 17–18 (citing Ex. 1007 ¶¶ 13–15). Patent Owner does not dispute Petitioner’s explanation of the level of skill in the art. See generally Prelim. Resp. At this stage of the proceeding and on the present record, we adopt Petitioner’s uncontested proposed level of ordinary skill in the art, which we find consistent with the level of ordinary skill in the art reflected by the ’090 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Additionally, only terms that are in controversy need to be construed, and these need be construed only to the extent necessary to resolve the controversy. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Both parties indicate that no claim terms need to be expressly construed. Pet. 29–30; Prelim. Resp. 5. Consistent with that, we determine that we need not construe any claim terms expressly in order to resolve the parties’ dispute regarding whether Petitioner has demonstrated a reasonable likelihood of prevailing.” slip op. at 8
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“Weighing the parties’ arguments and evidence, we find Petitioner’s arguments and evidence sufficient at this stage to demonstrate a reasonable likelihood of prevailing. Pet. 8–17, 30–49. For example, regarding whether of Porter’s disclosure to the problem faced by inventor of the ’090 patent. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 144–164. The ’090 patent illustrates that its inventor faced the problem of selecting desirable materials for an aligner, including selecting a desirable material for an aligner’s hard layer. Ex. 1001, 5:44–59. Petitioner and Dr. Osswald provide significant evidence and reasoning tending to show that Porter’s discussion of Tritan logically would have commended itself to the attention of an inventor facing the problem of selecting an aligner hard layer. Pet. 8 (citing Ex. 1007 ¶¶ 98–108, 125–127, 144–164). For example, Dr. Osswald explains that “because Tritan copolyesters are BPA-free, Rafih specifically discloses Tritan EX401 as an exemplary material” for its oral appliance. Id. ¶ 99 (citing Ex. 1104, 5:4–64, claims 2, 9, 10). In view of this, Dr. Osswald testifies that “Rafih would inform a [person of ordinary skill in the art] that Porter’s guidance regarding replacing polycarbonate with Tritan applies to dental appliances.” Ex. 1007 ¶ 146. At this stage, weighing Petitioner’s evidence against Patent Owner’s contrary attorney argument that Porter focuses on dishware, we determine Petitioner has shown sufficiently that Porter is analogous art. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 144–164; Prelim. Resp. 1, 9–10, 18–21.” slip op. at 11
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 11,648,090 - PTAB · Nov 6, 2025 · IPR2025-00821 · APJ Neil T Powell · IPR · Institution
The Board instituted review of claims 1–23, 25, and 26 on all asserted grounds, finding a reasonable likelihood that claim 1 would have been obvious over Tadros, Porter, Kalili, and Texin 990R.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a). To institute an inter partes review, we must determine that the information presented in the Petition and the Preliminary Response shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that there is a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim. We institute an inter partes review of claims 1–23, 25, and 26 based on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Pet. 17 (citing Ex. 1007 ¶¶ 13–15). Patent Owner does not dispute Petitioner’s explanation of the level of skill in the art. See generally Prelim. Resp. At this stage of the proceeding and on the present record, we adopt Petitioner’s uncontested proposed level of ordinary skill in the art, which we find consistent with the level of ordinary skill in the art reflected by the ’090 patent and the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995); In re Oelrich, 579 F.2d 86, 91 (CCPA 1978).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Additionally, only terms that are in controversy need to be construed, and these need be construed only to the extent necessary to resolve the controversy. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Neither party indicates that we need to construe expressly any claim terms. Pet. 27–28; Prelim. Resp. 5. Consistent with that, we determine that we need not construe any claim terms expressly in order to resolve the parties’ dispute regarding whether Petitioner has demonstrated a reasonable likelihood of prevailing.” slip op. at 8
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“arguments and evidence sufficient at this stage to demonstrate a reasonable likelihood of prevailing. Pet. 8–17, 53–71. For example, regarding whether Porter is analogous art, Petitioner sufficiently shows reasonable pertinence of Porter’s disclosure to the problem faced by inventor of the ’091 patent. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 146–165. The ’091 patent illustrates that its inventor faced the problem of selecting desirable materials for an aligner, including selecting a desirable material for an aligner’s hard layer. Ex. 1001, 5:44–59. Petitioner and Dr. Osswald provide significant evidence and reasoning tending to show that Porter’s discussion of Tritan logically would have commended itself to the attention of an inventor facing the problem of selecting an aligner hard layer. Pet. 8 (citing Ex. 1007 “because Tritan copolyesters are BPA-free, Rafih specifically discloses Tritan EX401 as an exemplary material” for its oral appliance. Id. ¶ 99 (citing Ex. 1104, 5:4–64, claims 2, 9, 10). In view of this, Dr. Osswald testifies that “Rafih would inform a [person of ordinary skill in the art] that Porter’s guidance regarding replacing polycarbonate with Tritan applies to dental appliances.” Ex. 1007 ¶ 147. At this stage, weighing Petitioner’s evidence against Patent Owner’s countervailing attorney argument that Porter focuses on dishware, we determine Petitioner has shown sufficiently that Porter is analogous art. Pet. 8; Ex. 1007 ¶¶ 98–108, 125–127, 146–165; Prelim. Resp. 1–2, 9–10, 34–36.” slip op. at 13
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 11,648,091 - PTAB · Nov 6, 2025 · IPR2025-00819 · APJ Kristina M Kalan · IPR · Institution
The Board instituted IPR on all challenged claims based on both obviousness grounds, finding a reasonable likelihood of success on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground.” slip op. at 14
- Skill levelSkill level petitioner adoptedDecided for petitioner
“would have had at least a four-year undergraduate degree in materials science, mechanical engineering, chemical engineering, or a related field and at least two years of experience in the field of polymer science, combined with at least two years of experience in the field of design, manufacture, and processing of thermoformable polymer sheets for use in various applications, such as in orthodontic and dental appliances. Additional education could substitute for professional experience and vice versa. Pet. 18–19 (citing Ex. 1007 ¶¶ 13–15). At this stage, Patent Owner does not dispute Petitioner’s proposal or offer an alternative proposal. See generally Prelim. Resp. Because Petitioner’s proposed level of ordinary skill in the art appears to be consistent with the cited prior art and is undisputed on this record, we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (indicating that the prior art itself may reflect an appropriate skill level).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Only claim terms in controversy need be construed. Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”). For purposes of this Decision, we determine that no claim term requires express construction.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground. We disagree that Petitioner fails to meet its burden as to the motivation to combine arguments. Petitioner persuasively maps the limitations of the challenged claims to portions of the references relied upon. Pet. 28–38 (claim 1), 38–51. Petitioner also, on this record, provides adequate statements of motivation to combine with a reasonable expectation of success. See, e.g., id. at 34–36 (citing Ex. 1007 ¶¶ 31, 39–42, 147–151, 174–176). The Petition’s reliance on supporting testimony and related corroborating evidence to support the combination does not amount to impermissible hindsight, as that testimony takes into account “knowledge which was within the level of ordinary skill in the art at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure.” In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971). Without further clarification or support from Patent Owner, and in the absence of testimony to support the assertion that a POSITA would not have combined the cited references in the manner proposed with a reasonable expectation of success, we are unpersuaded by Patent Owner’s arguments in this regard.” slip op. at 14
Claim construction§ 103 obviousnesscites KSRPatents in suitUS 11,154,384 - PTAB · Nov 6, 2025 · IPR2025-00818 · APJ Kristina M Kalan · IPR · Institution
The Board instituted IPR on all challenged claims 1–22 based on all three asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority under 35 U.S.C. § 314(a), which provides that inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” After considering the briefing and cited evidence of record, we institute inter partes review because we find that Petitioner establishes a reasonable likelihood that it will prevail with respect to at least one of the claims challenged in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“understanding of a person of ordinary skill in the art at the time the invention was made. See Graham, 383 U.S. at 17–18. Petitioner proposes that a person of ordinary skill in the art (sometimes referred to herein as a “POSITA”) would have had at least a four-year undergraduate degree in materials science, mechanical engineering, chemical engineering, or a related field and at least two years of experience in the field of polymer science, combined with at least two years of experience in the field of design, manufacture, and processing of thermoformable polymer sheets for use in various applications, such as in orthodontic and dental appliances. Additional education could substitute for professional experience and vice versa. Pet. 18 (citing Ex. 1007 ¶¶ 13–15). At this stage, Patent Owner does not dispute Petitioner’s proposal or offer an alternative proposal. See generally Prelim. Resp. Because Petitioner’s proposed level of ordinary skill in the art appears to be consistent with the cited prior art and is undisputed on this record, we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (indicating that the prior art itself may reflect an appropriate skill level).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner argues that no terms require construction, but that “Petitioner applies the prior art consistent with Patent Owner’s assertions in its Infringement Contentions (EX1014, 6-20.).” Pet. 26. Patent Owner does not propose any express claim constructions. Prelim. Resp. 5. Nor does Patent Owner allege that any of Petitioner’s claim interpretations contradict Petitioner’s position in the related district court litigation. Id. Only claim terms in controversy need be construed. Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”). For purposes of this Decision, we determine that no claim term requires express construction.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“that Petitioner has demonstrated a reasonable likelihood of showing that a person of ordinary skill in the art would have been motivated to combine the teachings of Tadros, Kalili, and Texin 990R to meet the limitations of the claims challenged under this ground. We disagree that Petitioner fails to meet its burden as to the motivation to combine arguments. Petitioner persuasively maps the limitations of the challenged claims to portions of the references relied upon. Pet. 27–36 (claim 1), 36–46. Petitioner also, on this record, provides adequate statements of motivation to combine with a reasonable expectation of success. See, e.g., id. at 32–35 (citing Ex. 1007 ¶¶ 31, 39–41, 57–87, 146–150, 171–172). The Petition’s reliance on supporting testimony and related corroborating evidence to support the combination does not amount to impermissible hindsight, as that testimony takes into account “knowledge which was within the level of ordinary skill in the art at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure.” In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971). Without further clarification or support from Patent Owner, and in the absence of testimony to support the assertion that a POSITA would not have combined the cited references in the manner proposed with a reasonable expectation of success, we are unpersuaded by Patent Owner’s arguments in this regard. We also disagree with Patent Owner’s arguments about “adhesive lamination” using “tie layers” at this point in the proceeding. Prelim. Resp. 15–18. On this record, we are persuaded that Petitioner has adequately supported its arguments that one of ordinary skill in the art would have been motivated to use adhesive lamination to achieve the proposed combination. See, e.g., Pet. 33–35; Ex. 1007 ¶¶ 39–42, 120, 45, 51, 116, 120. Petitioner relies on Kalili as disclosing a hard layer suitable for combination with Tadros’s soft layers (Pet. 32), and more particularly, doing so in the context of a laminated multilayer aligner (Reply 4). To create the laminated multilayer aligner proposed, Petitioner’s suggested use of a particular type of well-known lamination, i.e. adhesive lamination, is sufficiently developed and supported in the Petition. Pet. 32–35. Here, Patent Owner recognizes that Kalili teaches lamination, but suggests that it does not specifically teach using adhesive lamination. Prelim. Sur-reply 5. We note, however, that the parties have identified limited types of known lamination for aligners: coextrusion, extrusion lamination, and adhesive lamination. Prelim Sur-reply 4; Pet. 14–15 n.3, 33. In KSR, the Supreme Court explained that when “there is a design need or market pressure to solve a problem and there are a finite number of identified, predictable solutions, a person of ordinary skill has good reason to pursue the known options within his or her technical grasp.” KSR, 550 U.S. at 421. “If this leads to the anticipated success, it is likely the product not of innovation but of ordinary skill and common sense.” Id. Having reviewed Petitioner’s proffered arguments as to Tadros, Kalili, and Texin 990R, including motivation to combine the references asserted in this ground, with a reasonable expectation of success, we are persuaded on this record that Petitioner has met its burden for institution with respect to Ground 1.” slip op. at 14
Claim construction§ 103 obviousnesscites KSRPatents in suitUS 10,973,613 - Samsung Electronics Co., Ltd. / Samsung Electronics America, Inc. v. Maxell, Ltd.All claims unpatentablePTAB · Nov 6, 2025 · IPR2024-00867 · APJ Kevin C Trock · IPR · Final written decision
Claims 11, 12, 16, 17, 19, 20, and 84 are unpatentable as obvious over Nozaki and Haitani, alone or combined with Graham or Kim.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties’ descriptions of the level of skill in the art are very similar, with only a slight difference in the number of years of work experience suggested. Petitioner states that “[a]lthough the experts propose slightly different POSITA definitions, the differences are immaterial to the analysis here.” Pet. Reply. 1. Patent Owner does not believe the two definitions are materially different, and states that “the arguments herein do not change under either definition. PO Resp. 8. Petitioner’s description of a person of ordinary skill appears to be consistent with the technical complexity of the subject matter described in the ’848 patent. This understanding is supported by the testimony of Petitioner’s declarant, Dr. Bederson, who states that he is “well acquainted systems and methods described in the ’848 patent.” Ex. 1005 ¶ 36. Accordingly, we continue to use Petitioner’s assessment of a person of ordinary skill for purposes of this Decision. B. Claim Construction” slip op. at 12
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner
“the meaning of the claim term “mode” as it is used in the ’848 patent and as one of ordinary skill in the art would understand it at the time of the invention. First, the parties do not necessarily disagree as to the meaning of the term “mode.” Patent Owner asserts that a person of ordinary skill in the art “would understand ‘mode’ to mean “an operational state that a system has been switched to.” PO Resp. 13. Petitioner “do[es] not necessarily object to the concept of a ‘mode’ as an operational state,” but does object to how Patent Owner applies the term. Pet. Reply 1. Petitioner objects to Patent Owner’s “application of its construction,” which, Petitioner argues, “is far narrower than the words alone suggest.” Id. Second, the intrinsic evidence, including the claims and the ’848 specification, makes it readily apparent what the ordinary and customary meaning of the term “mode” would be to one of ordinary skill in the art at the time of the invention. Based upon our consideration of the claims and the ’848 specification, we find that the term “mode,” as it is used by the ’848 patent, means a “state,” “condition,” or “operational state” of a recording device, such as a video camera, that is selected by a user and may include a selection function using threshold values.” slip op. at 19
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“We disagree with Patent Owner. In determining obviousness, the scope of relevant prior art “necessarily encompasses not only the field of the inventor's endeavor but also any analogous art.” In re GPAC Inc., 57 F.3d 1573, 1577–78 (Fed. Cir. 1995). A reference qualifies as prior art for a determination under § 103(a) when it is analogous to the claimed invention. In re Clay, 966 F.2d 656, 658 (Fed. Cir. 1992). A reference is analogous to the claimed invention when it is from the same field of endeavor, regardless of the problem addressed. In re Klein, 647 F.3d 1343, 1348 (Fed. Cir. 2011). Similarity in the structure and function of the invention and the prior art is indicative that the prior art is within the inventor's field of endeavor.” slip op. at 37
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“Here, Petitioner provides a persuasive rationale as to why a person of ordinary skill in the art would combine the teachings of Nozaki, Haitani, and Graham as described in the Petition. For example, Petitioner explains that a person of ordinary skill in the art would have recognized that Nozaki’s facedetection data could be used as an additional method by which to identify Figure 5 of Nozaki could be configured as a scrollable list of keyframe data similar to Graham. Pet. 37–38 (citing Ex. 1005 ¶ 141). Petitioner also explains that a person of ordinary skill in the art would have been motivated to implement this modification to improve the efficiency of searching for specific moments within a long video file. Pet. 38 (citing Ex. 1005 ¶ 142). Petitioner also explains that Graham’s video segmenting methods address this need and could have been easily implemented in the Nozaki device. Pet. 38 (citing Ex. 1005 ¶ 142). Dr. Bederson testifies that such implementation would have been within the skill of a person of ordinary skill in the art. Ex. 1005 ¶ 142. Accordingly, based upon the complete record, we are persuaded that Petitioner has demonstrated by a preponderance of the evidence that a person of ordinary skill in the art at the time of the claimed invention would have had a reasoned basis to combine the teachings of Nozaki, Haitani, and Graham in the manner described and would have had a reasonable expectation of success in that endeavor.” slip op. at 64
Patent outcomesUS 10,176,848 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,176,848 - Samsung Electronics Co., Ltd. / Samsung Electronics America, Inc. v. Maxell, Ltd.All claims unpatentablePTAB · Nov 6, 2025 · IPR2024-00717 · APJ Kevin C Trock · IPR · Final written decision
Claims 1–11 are unpatentable under § 103 over the Chinn-based and Kim-based combinations listed in the decision.
RulingsFinal written decision- Expert testimonyOther
“Accordingly, based upon the complete record, we are persuaded that” slip op. at 39
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“d. Conclusion as to Independent Claim 1 Based on the complete record, we are persuaded that Petitioner has” slip op. at 73
Patent outcomesUS 11,223,757 unpatentable§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,223,757 - Google LLC / Samsung Electronics Co., Ltd. et al. v. Eyesmatch Ltd.No claims unpatentablePTAB · Nov 4, 2025 · IPR2025-00297 · APJ Thomas L Giannetti · IPR · Final written decision
Claims 1–18 were not shown unpatentable because the prior art did not establish the claimed distance-based variation in the rate of image-processing steps.
RulingsFinal written decision- Prior constructionPrior construction adoptedDecided for patent owner
“Putting aside the controversy over alleged impropriety and sandbagging in connection with the District Court’s Order, which we address infra in connection with Patent Owner’s Motion to Strike, we find the District Court’s “mirror-mimicking” construction to be well-reasoned and supported by the record, and we therefore adopt that construction and its reasoning. As the District Court points out, both the “double the distance” and “same size” aspects of its construction are expressly discussed in the ’109 patent. See Ex. 2008, 16 (citing Ex. 1001, 2:5–27, Figs. 5A, 5B). So, too, is “flipping” or reversing of the image disclosed. Id. at 17 (citing Ex. 1001, 14:46–51, 15:41–47). Petitioner does not dispute that the ’109 patent discloses these aspects of “mirror-mimicking,” or even that the District Court’s claim construction is incorrect. Instead, Petitioner contends that “[t]he Board need not construe ‘mirror mimicking’ [beyond plain meaning] since the prior art expressly discloses mimicking a mirror.” Pet. Reply 6. Further. Petitioner characterizes the claim construction order as “a report and recommendation” by a magistrate judge that “the district court judge has not evaluated or adopted.” Id. at 6 n.2.9 We address infra whether the prior art “expressly” discloses “mirror- mimicking” as construed by the District Court. We, however, disagree with Petitioner that we should not construe this term. Given the controversy over whether Petitioner has argued for a different construction in the District Court, we cannot agree that an explicit construction of “mirror-mimicking” is an unnecessary step toward resolving this controversy. See Vivid Techs., Inc., 200 F.3d at 803. We therefore adopt the District Court’s construction for “mirror-” slip op. at 16
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundMotivation foundDecided for petitioner
“We do not agree. Petitioner demonstrates persuasively that a person of ordinary skill would have combined these references “to reduce distortion and provide a realistic mirror image.” Pet. 14–17; Haram Decl. ¶¶ 110–117. We are not persuaded by Patent Owner that by specifically disclosing “flipping” the image, Rosenberg is discouraging or teaching away from performing other transformations to achieve its objective of “replicat[ing] the performance of a standard household mirror.” See PO Resp. 32–33 (Patent Owner asserting lack of motivation to combine the references). A reference may be said to “teach away” “when a person of ordinary skill, upon reading the reference, would be discouraged from following the path set out in the reference, or would be led in a direction divergent from the path that was taken by the applicant.” Galderma Lab'ys, L.P. v. Tolmar, Inc., 737 F.3d 731, 738 (Fed. Cir. 2013). “A reference does not teach away, however, if it merely expresses a general preference for an alternative invention but does not criticize, discredit, or otherwise discourage investigation into the invention claimed. Id. Further, when conducting an obviousness analysis, the Board must consider a prior art reference “not only for what it expressly teaches, but also for what it fairly suggests.” Bradium Techs. LLC v. Iancu, 923 F.3d 1032, 1049 (Fed. Cir. 2019) (quoting In re Baird, 16 F.3d 380, 383 (Fed. Cir. 1994)). We are not convinced that the references before us “teach away” from performing the other transformations.” slip op. at 30
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
Patent outcomesUS 8,982,109 not shown unpatentableClaim construction§ 103 obviousnesscites PhillipsPatents in suitUS 8,982,109 - Google LLC / Samsung Electronics Co., Ltd. et al. v. Eyesmatch Ltd.No claims unpatentablePTAB · Nov 4, 2025 · IPR2024-00856 · APJ Thomas L Giannetti · IPR · Final written decision
Claims 1–18 were not shown unpatentable because the cited combinations did not teach or suggest varying the rate of the claimed image-processing steps according to user distance.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for patent owner
“Patent Owner states that it “applies Petitioners’ proposed level of skill for purposes of this Response.” PO Resp. 14 (citing Forsyth Decl. ¶¶ 62– 63). For this Decision, we adopt the formulation of the level of ordinary skill in the art proposed by Petitioner and applied by Patent Owner as consistent with the prior art before us in this proceeding.7” slip op. at 13
- Prior constructionPrior construction adoptedDecided for patent owner
“Putting aside the controversy over alleged impropriety and sandbagging in connection with the District Court’s Order, which we address infra in connection with Patent Owner’s Motion to Strike, we find the District Court’s “mirror-mimicking” construction to be well-reasoned and supported by the record, and we therefore adopt that construction and its reasoning. As the District Court points out, both the “double the distance” and “same size” aspects of its construction are expressly discussed in the ’109 patent. See Ex. 2008, 16 (citing Ex. 1001, 2:5–27, Figs. 5A, 5B). So, too, is “flipping” or reversing of the image disclosed. Id. at 17 (citing Ex. 1001, 14:46–51, 15:41–47). Petitioner does not dispute that the ’109 patent discloses these aspects of “mirror-mimicking,” or even that the District Court’s claim construction is incorrect. Instead, Petitioner contends that “[t]he Board need not construe ‘mirror mimicking’ [beyond plain meaning] since the prior art expressly discloses mimicking a mirror.” Pet. Reply 6. Further. Petitioner characterizes the claim construction order as “a report and recommendation” by a magistrate judge that “the district court judge has not evaluated or adopted.” Id. at 6 n.2.9 We address infra whether the prior art “expressly” discloses “mirror- mimicking” as construed by the District Court. We, however, disagree with Petitioner that we should not construe this term. Given the controversy over whether Petitioner has argued for a different construction in the District Court, we cannot agree that an explicit construction of “mirror-mimicking” is an unnecessary step toward resolving this controversy. See Vivid Techs., Inc., 200 F.3d at 803. We therefore adopt the District Court’s construction for “mirror-” slip op. at 16
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundMotivation foundDecided for petitioner
“We do not agree. Petitioner demonstrates persuasively that a person of ordinary skill would have combined these references “to reduce distortion and provide a realistic mirror image.” Pet. 14–17; Haram Decl. ¶¶ 110–117. We are not persuaded by Patent Owner that by specifically disclosing “flipping” the image, Rosenberg is discouraging or teaching away from performing other transformations to achieve its objective of “replicat[ing] the performance of a standard household mirror.” See PO Resp. 32–33 (Patent Owner asserting lack of motivation to combine the references). A reference may be said to “teach away” “when a person of ordinary skill, upon reading the reference, would be discouraged from following the path set out in the reference, or would be led in a direction divergent from the path that was taken by the applicant.” Galderma Lab'ys, L.P. v. Tolmar, Inc., 737 F.3d 731, 738 (Fed. Cir. 2013). “A reference does not teach away, however, if it merely expresses a general preference for an alternative invention but does not criticize, discredit, or otherwise discourage investigation into the invention claimed. Id. Further, when conducting an obviousness analysis, the Board must consider a prior art reference “not only for what it expressly teaches, but also for what it fairly suggests.” Bradium Techs. LLC v. Iancu, 923 F.3d 1032, 1049 (Fed. Cir. 2019) (quoting In re Baird, 16 F.3d 380, 383 (Fed. Cir. 1994)). We are not convinced that the references before us “teach away” from performing the other transformations.” slip op. at 30
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“We find that Petitioner has not demonstrated by a preponderance of evidence that step 1(h) is taught or suggested by the references cited by Petitioner or the testimony of Petitioner’s expert, Dr. Karam. We agree, instead, with Patent Owner’s argument that “a [person of ordinary skill] would regard the disclosures in Rosenberg relating to proximity detection to be in connection with turning on or off various display modes and not in connection with varying the rate of one or more steps that are performed to transform a series of captured images of a user.” PO Resp. 33 (citing Ex.1005, ¶¶ 25, 32, 56, 69, 114). This distinction was explored during the final hearing. Petitioner’s counsel confirmed that in Rosenberg’s mirror mode, the rate of performing the processing steps does not vary: [THE BOARD]: It’s true that when the -- when Rosenberg is acting in the mirror mode, it’s always at the same rate, correct? It’s always performing those three processing steps at the same rate? [COUNSEL]: Correct. Hearing Tr. 34:13–16. We conclude that Rosenberg fails to disclose or suggest step 1(h) for the reasons given by Patent Owner and summarized above. We agree with Patent Owner’s analysis that in Rosenberg, when the mirror is off the processing steps are not performed, and when the mirror is on, the steps are performed “at an invariant rate.” PO Sur-reply 18–19.” slip op. at 33
Patent outcomesUS 8,982,109 not shown unpatentableClaim construction§ 103 obviousnesscites PhillipsPatents in suitUS 8,982,109 - PTAB · Oct 30, 2025 · IPR2025-00817 · APJ Kevin F Turner · IPR · Institution
The Board instituted IPR on claims 1–20, finding a reasonable likelihood of success on the Boerjes-Geng and Boerjes-Geng-Babayoff obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“On this record, we determine that Petitioner has developed this ground sufficiently to meet the reasonable likelihood standard for institution. Having determined that Petitioner has met its burden as to its Ground 2 arguments, and because the Board must institute on all grounds or none, SAS Institute Inc. v. Iancu, 584 U.S. 357, 364–65 (2018) and 37 C.F.R. § 42.108(a), we institute trial in on all grounds presented in this proceeding. Nevertheless, we address the additional grounds below.” slip op. at 24
- Skill levelSkill level petitioner adoptedOther
“Pet. 16 (citing Ex. 1003 ¶¶ 27–30). At this stage, Patent Owner does not dispute Petitioner’s proposal or offer an alternative proposal. See generally Prelim. Resp. Because Petitioner’s proposed level of ordinary skill in the art appears to be consistent with the cited prior art and is undisputed on this record, we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (indicating that the prior art itself may reflect an appropriate skill level).” slip op. at 9
- Prior constructionPrior construction adoptedDecided for petitioner
“The parties indicate that in the co-pending litigation in the District Court for the Western District of Texas (see supra Section I.B), the Court provided preliminary constructions of two specific claim limitations. Pet. 16–17; Prelim. Resp. 8. Patent Owner adds that “district court subsequently adopted these constructions in its final claim construction order.” Prelim. Resp. 8 (citing Ex. 2001). We determine that the constructed limitations do not impact the analysis below, but nonetheless, we adopt this those constructions for purposes of this Decision.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“identify areas that need replacing, such as ‘a margin line’ to be removed, ‘areas of poor margin preparation,’ and ‘holes or areas of incomplete scan[s],’” and that the user can identify regions of a prepared tooth surface requiring additional preparations and “supplemental scanning” (Pet. 32 (citing Ex. 1004 ¶¶ 189, 193, 196)), Boerjes is silent with respect to replacing at least a portion of the removed surface portion of the model using the received second scan data of the patient’s teeth, per claim 1. Boerjes certainly contemplates the re-scanning of the dentition, but does not assert partial insertion of new data into an existing 3D model. Even under the “comprising” language of claim 1, for example, the complete replacement of a 3D model cannot teach or suggest “replacing at least a portion of the removed surface portion” without repudiating the language of the claim by making a portion be the entire model. Even if, as Petitioner asserts, “removing portions of a virtual model has been a well-known and routine technique in 3D modeling,” and the “process of replacing a user-identified portion would have been well within the skills of a POSITA” (Pet. 35), the disclosure of Boerjes does not teach or suggest such processes. Although Boerjes allows for the possibility that portions of a model can be identified as needing replacement or supplementation, it does not disclose the partial replacement required by the instant, independent claims. Boerjes’s actual disclosure details that supplemental scanning is used to compensate for an inadequate scan, but not disclosed to be used to stitch together before-and-after models that have undergone an intervening physical change. slip op. at 18
Claim construction§ 103 obviousnesscites KSRPatents in suitUS 10,791,936 - Samsung Electronics Co. Ltd. / Samsung Electronics America, Inc. v. Maxell, Ltd.All claims unpatentablePTAB · Oct 30, 2025 · IPR2024-00828 · APJ Terrence W Mcmillin · IPR · Final written decision
Claims 1, 2, 4–7, and 9–14 are unpatentable as obvious over the Rogers-based combinations with Rosenberg, Rekimoto, and, for claims 9–14, Miyazawa.
RulingsFinal written decision- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
“13 The Court was very critical of Dr. Wobbrock’s testimony in the related district court case. See generally Ex. 1026 (September 18, 2025 Order). With regard to the ’086 patent, the Court found that Dr. Wobbrock’s testimony was not based on any record evidence (id. at 7, 9), arbitrary (id.), contrary to the evidence (id. at 7–8), unjustified (id. at 8), ipse dixit (id. at 9), conclusory (three times) (id.), insufficient to support a jury verdict (three times) (id. at 9, 27), untethered from the Specification (three times) (id. at 28, 30, 31), inconsistent (id. at 29), insufficient to support his opinion (id. at 29–30), unsupported (id. at 30), and not to be credited by a reasonable jury (id. at 31). We have considered this criticism of Dr. Wobbrock’s testimony in view of the September 16, 2025, Memorandum to the Members of the Patent Trial and Appeal Board on the subject of “PTAB consideration of prior findings of fact and conclusions of law” (available at: https://www.uspto.gov/sites/default/files/documents/Memo_re_prior_finding s_of_fact_and_conclusions_of_law_9_16_25.pdf?utm_campaign=subscripti oncenter&utm_content=&utm_medium=email&utm_name=&utm_source=g ovdelivery&utm_term=) and in light of the case law (see, e.g., N.L.R.B. v. Pittsburgh S.S. Co., 337 U.S. 656, 659 (1949) (“[I]n the determination of litigated facts, the testimony of one who has been found unreliable as to one issue may properly be accorded little weight as to the next.”). We have similarly found Dr. Wobbrock’s testimony to be contrary to the plain and ordinary meaning of the claims, untethered from the Specification, unsupported by the evidence, inconsistent, arbitrary, and conclusory. We accord the testimony of Dr. Wobbrock little or no weight. We view the testimony of Petitioner’s expert, Dr. Nielson, as more credible and persuasive as it tracks more closely with the ’086 patent and the cited art. EcoFactor, Inc. v. Google LLC, 137 F.4th 1333, 1339 (Fed. Cir. 2025) (quoting Daubert v. Merrell Dow Parms., Inc., 509 U.S. 579, 597, 589 (1993) (“The Supreme Court has explained ‘that the trial judge plays a “gatekeeping role,’” ‘through which it must “ensure that any and all scientific testimony or evidence admitted is not only relevant, but reliable.’”)).” slip op. at 9
- Skill levelSkill level petitioner adoptedDecided for petitioner
“with touch interfaces.” PO Resp. 8 (citing Ex. 2005 ¶¶ 76–77). Although there are minor differences in these definitions of the level of ordinary skill in the art, the parties agree that this issue is not disputed. Tr. 11:24–26 (Petitioner’s counsel); 43:16–22 (Patent Owner’s counsel indicating agreement with Petitioner’s definition); see also Pet. Reply 1 (“The experts agree on the definition of ordinary skill in the art (‘POSITA’).” Determining the level of ordinary skill in the art involves various factors, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995) (citation omitted). The prior art of record also reflects the level of ordinary skill in the art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). We adopt the assessment offered by Petitioner as it is not disputed and is consistent with the ’086 patent and the asserted prior art.” slip op. at 11
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for petitioner
“We find no support in the language of claim 1 for construing the “first registering mode” and the “second registering mode” as “operating modes,” or as “different operational states,” or “sub-operating modes of the ‘said registering mode’” as contended by Patent Owner. There is no express statement in claim 1 that the “first registering mode” and the “second registering mode” are “operating modes,” or are “different operational states,” or are “sub-operating modes of the ‘said registering mode.’” The language of claim 1 is clear that the only two “operating modes” explicitly recited in claim 1 are the “identification mode” and the “registration mode.” Claim 1 recites that these two “modes” are “operating modes,” but does not recite that the “first registering mode” and the “second registering mode” are “operating modes.” The language of claim 1 cannot be read to include the requirements that the “first registering mode” and the “second registering mode” are “operating modes,” or are “different operational states,” or are “sub-operating modes of the ‘said registering mode.’” Rather, we agree with Petitioner that the language of limitation 1c that specifically refers to the “registering mode” as an “operating mode” and the language of limitation 1f that refers to the “first registering mode” and the “second registering mode” as “mode[s] for inputting input information” that are “provided in said registering mode” contradicts Patent Owner’s proposed construction that would require the “first” and “second registering mode[s]” to be “different operational states.” The plain and ordinary meaning of the language of claim 1 provides that the “first registering mode” and the “second registering mode” are “mode[s] for inputting input information” that are “provided in said registering mode” which is one of the two delineated “operating modes.” Both “first” and “second” “registering mode[s]” ”for inputting input information” are recited as “provided in said registering mode,” a single “operating mode.”17” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“Both references are directed to allowing users to input information via touchsurface technology and are analogous art to the ’086 patent. . . . [A] POSITA would have found Rogers and Rosenberg to be compatible because of the technical similarity of their teachings, and a POSITA would have further recognized that Rosenberg’s finger orientation disclosures, applied to Rogers’ graphical passcode disclosures, would facilitate a “natural and intuitive” means of implementing the teachings of Rogers. A POSITA therefore would have been motivated to look to Rosenberg to improve Rogers, and vice-versa. . . . A POSITA . . . would have considered the disclosures in Rosenberg and been motivated to modify Rogers’ “large fingertip and a small stylus tip” example so that it instead used the “natural and intuitive” finger pad versus finger end distinction discussed in Rosenberg. A POSITA would have found this modification to be a simple substitution of elements well known in the art and would have had a reasonable expectation of success in achieving the benefits disclosed in Rosenberg by making the modification, which involved only routine skill. . . . [A]dding finger end and finger pad touch detection to Rogers would involve no more than applying a known technique (i.e., finger end and finger pad touch detection/distinction as taught by Rosenberg) to a known device ready for improvement (Rogers’ apparatus having “large fingertip and a small stylus tip” capabilities) to yield predictable results (simple to use touch screen interface with multipoint targeting and multi-finger gesturing). . . . It also would have been obvious to combine Rogers with Rosenberg because both references disclose touch screen interfaces that detect a contact area of a finger. . . . A POSITA would have considered Rosenberg’s disclosures and been motivated to modify the “graphical passcode” features of Rogers so that the disclosed device is capable of detecting information input by a pad or end of a finger, because it would provide a “generally easily distinguishable” basis upon which to program the device disclosed in Rogers to detect a “measurable parameter” based on “contact area.” A POSITA would have further recognized that these features of Rogers and Rosenberg could be successfully combined because both references teach a “calibration” mode in which the user trains the device to recognize a specific range of input parameters that allows for some variation in input while remaining within acceptable tolerances. . . . A POSITA would have had a reasonable expectation of success in modifying Rogers in this manner for at least the same reasons.” slip op. at 60
Patent outcomesUS 8,982,086 unpatentableClaim construction§ 103 obviousnesscites GrahamPatents in suitUS 8,982,086
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.