• Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentable
  PTAB · Jan 17, 2025 · IPR2024-00597 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9–10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “We also agree with Patent Owner that the charge cut-off voltage is not necessarily the applied voltage during charging. PO Resp. 20. Rather, depending on the charging protocol used and when in the charging cycle the voltage is applied, the applied voltage could be higher than the battery voltage. Ex. 2013; Ex. 2006 ¶ 91. For example, as discussed in more detail below with respect to the Uemura grounds, when fast charging using constant current is used and the charging rate is not slow, the applied voltage will be higher than the battery voltage when the constant current charging phase is stopped. Ex. 2006 ¶ 91; Ex. 2013. Likewise, during constant current/constant voltage charging, the applied voltage approximates the battery voltage only when the battery is nearly completely charged. Ex. 2013; Ex. 2006 ¶ 91. Thus, the applied voltage may be, but is not necessarily, the charge cut-off voltage. In view of the foregoing, we construe “charge cut-off voltage” in claims 1 and 5 as “the maximum value to which the battery is configured to be charged.” PO Resp. 18; Ex. 2008, 217:6–11; Pet. Reply 5. Contrary to Patent Owner’s arguments, however, we do not understand the phrase “configured to be charged” to necessarily represent a single voltage for the battery that is determined based on the structure and chemistry of the battery. Pet. Reply 4–5. Rather, the charge cut-off voltage is a selected potential, or voltage, of the battery or cell at the end of charging that is controlled by a circuit or device, such as a charger or control circuit within the battery. Ex. 1001, 9:50–55; Ex. 1048, 2, 7–8; Ex. 1008, 3:9–13. And, for the reasons discussed herein, the charge cut-off voltage may be, but is not necessarily, the same as the applied voltage during charging. PO Resp. 20.” slip op. at 15

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16

  • Expert testimonyPatent owner expert creditedDecided for patent owner

    “Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122.” slip op. at 21

  Patent outcomesUS 7,749,641 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,749,641
• Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentable
  PTAB · Jan 17, 2025 · IPR2023-01183 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9 and 10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “constructions. First, we agree with Petitioner that the ’641 patent indicates that the charge cut-off voltage selected for a particular battery need not be a fixed property of the battery or something that is set by the design and chemistry of the battery. Consistent with this conclusion, the ’641 patent discloses that a “charging device controls the charge cut-off voltage of the single lithium-ion cell within a range from 4.3 V to 5.8 V.” Ex. 1001, 9:50– 55. This strongly suggests that the charge cut-off voltage is controlled by the charger and is not necessarily an inherent property of the battery. Patent Owner contends that this is merely an unclaimed embodiment, but the relevant disclosure states that the charging device for the “present invention” may be any type of device “with the proviso that said charging device controls the charge cut-off voltage.” Id. at 9:50–53.” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16

  • Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner

    “Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122. Petitioner argues that because the battery of Uemura is charged “to” a maximum voltage of 4.3 V, Uemura discloses the claimed charge cut-off voltage under either Petitioner’s or Patent Owner’s construction of the term. Pet. Reply 11–12 (citing Ex. 1009 ¶ 81; Ex. 1044 ¶¶ 56–59). This argument is not persuasive because Mr. Juzkow unambiguously testified that charging in Uemura stopped when the applied voltage reached 4.3 V, and Uemura discloses that the battery was charged “at” a voltage ranging from 4.3 V to 2.0 V, not “to” such a voltage. Ex. 1009 ¶ 81; Ex. 2008, 113:2–13; Ex. 2006 ¶ 119 n.64; Sur-reply 9. In view of the foregoing, we determine that Petitioner has not demonstrated by a preponderance of the evidence that Uemura anticipates independent claims 1 and 5 of the ’641 patent.” slip op. at 21

  Patent outcomesUS 7,749,641 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,749,641
• Alivecor, Inc. v. Apple Inc.Some claims unpatentable
  PTAB · Jan 7, 2025 · IPR2023-00949 · APJ Scott A Daniels · IPR · Final written decision

  Claims 11–14 and 16–20 are unpatentable over Kim; claim 15 was not shown unpatentable over Chang.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Patent Owner’s asserted level of ordinary skill in the art is essentially the same as Petitioner’s, for example requiring a bachelor’s degree in science or engineering and “at least two years of relevant work experience with capture and processing of data or information, including but not limited to physiological information.” Id.; Pet. 9. In view of the similarity, our record now before us, and as we did in our Institution Decision, we rely on Petitioner’s proposed level of ordinary skill in the art as it is essentially the same as that proposed by Patent Owner. Petitioner’s asserted level of ordinary skill in the art is consistent with our review and understanding of the technology and descriptions in the ’619 patent and the asserted prior art references. Okajima, 261 F.3d at 1355.” slip op. at 10

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “C. Claim Construction We interpret a claim “using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” 37 C.F.R. § 42.100(b) (2020). Under this standard, we construe the claim “in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id. Furthermore, “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Neither Patent Owner nor Petitioner indicate that any claim terms require construction. See generally Petition; PO Resp. For purposes of this Decision where no claim terms are in dispute, we need not explicitly construe any claim terms.” slip op. at 11

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “What these cases and examples clearly articulate, is that whether there is sufficient description in an anticipation reference for linking different disclosures, elements, and embodiments, is particularly case and fact dependent. Moreover, a finding of anticipation resting upon a reference’s disclosures of elements in different embodiments turns on whether an ordinarily skilled artisan would understand that the reference suggests arranging the elements of the embodiments to one another in the same way as the challenged claims. For the reasons that follow, we determine that there is sufficient description and teaching in Kim such that the “combined button” disclosed by Kim, for example in Figure 10(b), can be the same “combined button” as discussed in the embodiment of Figure 18.” slip op. at 28

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner

    “As to Patent Owner’s first and second arguments, as we discussed in detail above with respect to anticipation, we find that there is sufficient evidence in Kim itself of contextual and even express links between the various combined button embodiments and Figure 18. Section II.D.2.b)(1)– (4). We have already determined “that one of ordinary skill in the art would understand Kim to disclose the ‘combined button’ structure and function that could be implemented on the face or sidewall of a device.” Id. We likewise determine, based on the same evidence, that a person of ordinary skill in the art would have understood Kim to suggest that the combined button structure and function, for example in the embodiment of Figure 10(b), could be implemented in an opening on the face or sidewall of a device. Obviousness does not require an instruction manual on how to physically incorporate or combine the disclosures of two embodiments in a reference. As KSR informs us, “in many cases a person of ordinary skill will be able to fit the teachings of multiple patents together like pieces of a puzzle.” KSR, 550 U.S. at 420. Moreover, in this case we have only one prior art patent, Kim, so at least the pieces of the puzzle are all in the same box. The persuasive testimony of Dr. Berger that “a person of ordinary skill in the art would have been familiar with electronic devices with sealed and/or insulated button assemblies, and would understand that those assemblies were not limited to the front face of a device,” is unrebutted in this case. Ex. 1003 ¶ 110. “A person of ordinary skill is also a person of ordinary creativity, not an automaton.” KSR, 550 U.S. at 421. Given the background knowledge of a person of ordinary skill in the art in conjunction with the motivation and teachings in Kim itself for placing sufficient motivation to support the combination of Kim’s Figure 10(b) embodiment with the sidewall placement of the combined button taught in Figure 18 for obviousness purposes. It is well-settled that a single prior art obviousness reference itself can provide motivation for the combination. See General Elec. Co. v. Raytheon Techs. Corp., 983 F.3d 1334, 1352 (Fed. Cir. 2020) (Reversing the Board’s finding of nonobviousness over a single prior art reference, the Court explained that “the Board’s approach would require a motivation to combine each element of the claim—even those present together in a reference. This analysis unduly dissects prior art references into collections of individual elements, requiring a party showing obviousness to re-do the work already done in the prior art reference.”). Patent Owner’s third argument is unavailing because although Dr. Anthony testifies that “implementing the fingerprint sensor assembly of Kim’s Figure 10 embodiment in the ‘lateral surface’ of Kim’s Figure 18 embodiment would have complicated the manufacturing process for the resulting mobile device,” Dr. Anthony does not provide testimony or evidence that implementing the combined button on the sidewall would have been difficult or beyond the level of ordinary skill in the art. Ex. 2009 ¶ 73. We credit Dr. Berger who explains persuasively that “[p]rior to the ’619 patent’s earliest alleged priority date of June 19, 2017, a person of ordinary skill in the art would have known that a mobile electronic device could include one or more button assemblies in a sidewall.” Ex. 1003 ¶ 47 (citing Ex. 1013, 4:40, 19:42–20:4, Figs. 13B, 17, 19A, 19B). It is well-settled that a person of ordinary skill can use his or her ordinary skill, creativity, and common sense to make the necessary adjustments and further modifications to result in a properly functioning device. See KSR, 550 U.S. at 418 (“the specific subject matter of the challenged claim, for a court can take account of the inferences and creative steps that a person of ordinary skill in the art would employ.”).” slip op. at 43

  Patent outcomesUS 10,866,619 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 10,866,619
• Alivecor, Inc. v. Apple Inc.Some claims unpatentable
  PTAB · Dec 23, 2024 · IPR2023-00950 · APJ Josiah C Cocks · IPR · Final written decision

  Claims 1–14 were not shown unpatentable; claims 15–22 were shown unpatentable over Markel. The revised contingent motion to amend was dismissed as moot.

  RulingsFinal written decision

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed petitioner constructionDecided for petitioner

    “In carefully and faithfully wrangling the parties’ views and explanation as to the meaning of limitation [1.c.iii], we conclude that Petitioner’s “correct interpretation” of that limitation is that a first pad is recognized as a distinct structure or component from a first portion of an enclosure, and that the pad is positioned underneath that first portion in a manner such that the pad is concealed from a user. We adopt that interpretation. We determine that it is unnecessary to discuss an express construction for any other term to resolve this proceeding. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Matal, 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 19

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Patent Owner’s proposed level of ordinary skill in the art is somewhat broader in both education and proposed work experience. Patent Owner’s proposed work experience is somewhat vague and potentially outside the scope of the claimed invention. For example, the requirement that the person of ordinary skill in the art have experience with the “capture and processing of data or information, including but not limited to physiological information,” would seemingly encompass data processing areas that do not relate to the scope of the claimed invention. We adopt Petitioner’s level of the level of ordinary skill in art because it is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). Nevertheless, our analysis and the end result are the same under either proposed definition.” slip op. at 13

  • Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner

    “Patent Owner makes a more persuasive case as to what a person of ordinary skill in the art reasonably would have understood from Markel’s disclosure. In particular, we agree with Patent Owner that the record before us readily conveys that a skilled artisan would have followed Markel’s practice of forming or molding electrodes from conductive plastic rather than locating a separate electrode component underneath a conductive plaster layer. See, e.g., PO Resp. 30–31 (“[a] POSITA would find nothing in cited portions of Markel to inform or encourage placement of an electrode underneath an exterior layer.”). Indeed, as Patent Owner articulates, Petitioner “fails to provide any reasoning as to why a POSITA would have found Markel’s method of concealment to be deficient, or why a POSITA would have been motivated in light of Markel’s manner of concealment to nevertheless place an electrode underneath the exterior portion of the device.” Id. To that end, we credit Dr. Kenny’s supporting testimony as consistent with Markel’s express teachings. See, e.g., Ex. 2001 ¶¶ 77–83; Ex. 2004 ¶¶ 81–88. We credit that testimony over the countervailing testimony of Petitioner’s declarant, Dr. Berger (see, e.g., Ex. 1003 ¶¶ 122, 135–139), as we agree with Patent Owner that Dr. Berger’s testimony “is not supported by Markel’s actual disclosures.” PO Resp. 31.” slip op. at 33

  • Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightNot shown unpatentableMotivation not foundNot shown unpatentable

    “Petitioner does not appear to disagree that Markel, itself, does not convey that an electrode, or any structure identifiable as a “pad,” is positioned underneath any surface of any enclosure. Rather, Petitioner’s theory of unpatentability is premised on modification of Markel to so position such a pad. Although seemingly acknowledging that Markel contemplates a concealment technique involving molding an electrode into an exterior surface, Petitioner extrapolates from that disclosure that a skilled artisan would be motivated to try an alternative means of concealing an electrode pad by placing the pad underneath an outer layer or portion, i.e., “audio output portion 610.” See Pet. 20 (citing Ex. 1003 ¶ 135). Neither Petitioner, nor Dr. Kenny, however, meaningfully explains why a skilled artisan would have deviated from Markel’s express teachings of concealing an electrode via molding techniques to then arrive at an entirely different concealment approach of placing an electrode pad underneath the audio output portion. Petitioner’s modification proposal in that regard appears borne of hindsight bias based on the disclosure of the ’257 patent rather than any dutiful consideration of what Markel’s actual teachings would have conveyed to a skilled artisan. See Ex. 2004 ¶ 84 (Dr. Kenny explaining why Petitioner’s proposed modification to Markel to hide the electrode underneath a plastic conductive layer was based on improper hindsight). Such hindsight bias is impermissible. See, e.g., Metalcraft of Mayville, Inc. v. The Toro Co., 848 F.3d 1358, 1367 (Fed. Cir. 2017) (“[W]e cannot allow hindsight bias to be the thread that stitches together prior art patches into something that is the claimed invention.”). Patent Owner makes a more persuasive case as to what a person of ordinary skill in the art reasonably would have understood from Markel’s disclosure. In particular, we agree with Patent Owner that the record before us readily conveys that a skilled artisan would have followed Markel’s practice of forming or molding electrodes from conductive plastic rather than locating a separate electrode component underneath a conductive plaster layer. See, e.g., PO Resp. 30–31 (“[a] POSITA would find nothing in cited portions of Markel to inform or encourage placement of an electrode underneath an exterior layer.”). Indeed, as Patent Owner articulates, Petitioner “fails to provide any reasoning as to why a POSITA would have found Markel’s method of concealment to be deficient, or why a POSITA would have been motivated in light of Markel’s manner of concealment to nevertheless place an electrode underneath the exterior portion of the device.” Id. To that end, we credit Dr. Kenny’s supporting testimony as consistent with Markel’s express teachings. See, e.g., Ex. 2001 ¶¶ 77–83; Ex. 2004 ¶¶ 81–88. We credit that testimony over the countervailing testimony of Petitioner’s declarant, Dr. Berger (see, e.g., Ex. 1003 ¶¶ 122, 135–139), as we agree with Patent Owner that Dr. Berger’s testimony “is not supported by Markel’s actual disclosures.” PO Resp. 31.” slip op. at 32

  Patent outcomesUS 10,076,257 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR
  Patents in suitUS 10,076,257
• Masimo Corporation v. Apple Inc.Some claims unpatentable
  PTAB · Sep 23, 2024 · IPR2023-00634 · APJ Ken B Barrett · IPR · Final written decision

  Claims 1–5, 9, 10, 14, 15, and 17–20 are unpatentable as obvious; claims 6–8, 11–13, and 16 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “We discern no material difference between the parties’ definitions. Cf. PO Resp. 16 (Patent Owner stating that “[t]he analysis presented [in the Response] remains unchanged even if [Petitioner’s proposed] skill level is applied.”). Petitioner’s definition is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For purposes of this decision, we apply Petitioner’s definition of the person of ordinary skill in the art. We note, however, that were we to adopt Patent Owner’s assessment, the outcome of this Decision would be the same.” slip op. at 11

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “We find Patent Owner’s position to be persuasive. Not only are the cover and biosensor module recited separately in the list of components of the device of claim 9, we also agree that the “disposed over” claim language establishes the configuration of two separate components relative to each other. Additionally, the claim language that requires the cover to be “configured to pass optical signals to and from the biosensor module” supports an interpretation where the cover is separate from the biosensor module, otherwise it seemingly would be passing signals to and from itself. The understanding that the cover is separate from the biosensor module in claim 9 is consistent with the Specification’s description of an embodiment that tracks the language of claim 9 and speaks of the two elements as separate, individual components, namely the statement that “[a] biosensor module may be disposed within the opening of the housing” and “[a] rear cover may be disposed over the biosensor module.” Ex. 1001, 2:59–62; see also id. at 2:56 (the same paragraph beginning with “Some embodiments . . .”). Petitioner asserts that its proposed construction is consistent with the claim language, arguing that “the word ‘cover’ naturally suggests that its role is to be ‘disposed over,’” and that “[a] cover can be part of a module just as a clear plastic lid can be both disposed over, and part of, a container, allowing a view of its contents.” Pet. Reply 4. We disagree with Petitioner’s analogy. Although a clear lid may be over a jar, it cannot be said to be “disposed over” the container consisting of both the jar and the lid because it then would be disposed over itself.” slip op. at 14

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable

    “Patent Owner argues that the proposed combination will result in a configuration “that is contrary to Honda’s teachings and its stated goals and purpose of achieving quick and efficient wireless charging.” PO Resp. 30– 31. Patent Owner’s focus on these properties is misplaced. We agree with Petitioner that characteristics such as charging speed and efficiency are not claimed. See Pet. Reply 1 (“[T]he ’783 patent does not disclose, let alone claim, sizing or other details [Patent Owner] Apple asserts are necessary for successful wireless charging.”); id. at 6 (“[C]harging speed [is] not claimed.”). Rather, the claim drafter utilized broad language to encompass a biosensor device having the capability to wireless charge through a cover— both good configurations and those that Patent Owner argues are inferior. And, even if the proposed combination does not yield a commercially viable product, as Patent Owner implies, the broad claim scope would hinder an innovating competitor’s ability to utilize and test that purported less desirable combination on the way to development of a better device. Patent Owner argues that a person of ordinary skill in the art would not have been motivated to make the proposed combination and would not have had a reasonable expectation of success in making that combination. See, e.g., PO Resp. 31. These arguments are not persuasive at least because Patent Owner’s motivation requirement and implied definition of success are not sufficiently tied to the claimed invention. See, e.g., Elekta Ltd. v. ZAP Surgical Sys., Inc., 81 F.4th 1368, 1375 (Fed. Cir. 2023) (“Reasonable expectation of success refers to the likelihood of success in combining references to meet the limitations of the claimed invention.”). Patent Owner would require a successful outcome to be “quick and efficient wireless charging.” See PO Resp. 31. In making these arguments, Patent Owner is improperly superimposing the purported goals and purpose of Honda, the secondary reference, onto the ordinary artisan. See, e.g., id. at 37–41. However, the intended purpose of a prior art reference does not control the obviousness inquiry. Intel Corp. v. Qualcomm Inc., 21 F.4th 784, 800 (Fed. Cir. 2021). Our reviewing court recently explained: The [motivation-to-combine] inquiry is not whether a relevant artisan would combine a first reference’s feature with a second reference’s feature to meet requirements of the first reference that are not requirements of the claims at issue. A contrary view would run counter to established principles, including that the claim defines the invention whose obviousness is being assessed and that a skilled artisan may be motivated to combine particular features of different references, e.g., to secure some benefits at the expense of others, even when bodily incorporation would be impossible or inadvisable. Axonics, Inc. v. Medtronic, Inc., 73 F.4th 950, 957 (Fed. Cir. 2023). Petitioner’s combination yields the benefit of the addition of wireless charging capability to a biosensor device. A person of ordinary skill in the art would find that benefit to be a motivating reason to make the combination. See, e.g., Ex. 1003 ¶ 121 (Dr. Duckworth’s motivation opinion based, in part, on “Kotanagi’s own statement that its rechargeable battery can be recharged ‘in a contactless state.’”); id. ¶ 127 (Dr. Duckworth’s describing a motivating factor in Honda’s explanation “that this [charging] station passes wireless power to the wireless charging receiving coil through a rear cover glass (similar to that of Kotanagi), using the physics of induced currents and magnetic flux.”); see also Ex. 1052, 45:16–46:2 (Dr. Anthony, on cross-examination and after being asked whether wireless charging is an improvement over wired charging for a consumer watch, responding that “in some instances it could be, and in others it may not be.”). And, as to a reasonable expectation of success, Patent Owner admits that “Petitioner has presented a device configuration in which a wireless charging coil could be provided in Kotanagi’s through hole 22.” PO Resp. 56; see also id. at 3 (Patent Owner arguing that “the size of coil that could be provided in this allegedly available space would be small and would significantly limit the amount of wireless power signal transmission,” but not arguing that even Patent Owner’s purported size-limited configuration would be inoperative); see, e.g., Ex. 1003 ¶¶ 130–133 (Dr. Duckworth credibly testifying that a person of ordinary skill in the art would have had a reasonable expectation of success in combining the teachings of Kotanagi and Honda).” slip op. at 31

  Patent outcomesUS 10,627,783 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 10,627,783
• Infineon Technologies AG v. Amatech Group LimitedSome claims unpatentable
  PTAB · Dec 1, 2023 · IPR2022-00951 · APJ Stacey G White · IPR · Final written decision

  Claims 1, 2, 4–6, and 8–10 are unpatentable as obvious; claims 3 and 11 were not shown unpatentable, and claim 7 was not reached.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “We find that Petitioner’s description is consistent with the prior art and patent specification currently before us. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself may reflect an appropriate level of skill). For purposes of our Decision, we adopt Petitioner’s definition of the level of ordinary skill in the art as “a Bachelor’s degree in electrical engineering or a similar field, and 1–2 years of experience researching and developing antennas used in RFID applications.” See Pet. 8. In addition, we note that we agree with Patent Owner’s statement that the distinction between the parties’ proposals is not material to any dispute before us and we find that our determinations would be the same under either definition of the person of ordinary skill in the art.” slip op. at 6

  • Expert testimonyPetitioner expert creditedDecided for petitioner

    “We are not persuaded that Dr. van der Weide’s cited testimony is of a nature that should lead us to give his testimony no weight. We note that Patent Owner did not move to strike or exclude Dr. van der Weide’s testimony. When considering credibility and weight of evidence below, we consider Dr. van der Weide’s testimony as a whole as well as all other evidence of record and accord it the appropriate weight.” slip op. at 7

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “provide an express construction of the full breadth of a claim term. “The Board is required to construe ‘only those terms ... that are in controversy, and only to the extent necessary to resolve the controversy.’” Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019). As such, we proceed in line with Federal Circuit case law, which “prescribes—deciding only the issues necessary to resolve the dispute before it.” Nichia Corp. v. DSS, Inc., No. 2022-1704, 2023 WL 7211097, at *3 (Fed. Cir. Nov. 2, 2023) (citing Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017)). The Federal Circuit has long recognized that “[c]laim construction is a matter of resolution of disputed meanings and technical scope” and that claim construction may be required in an obviousness context “when the meaning or scope of technical terms and words of art is unclear and in dispute and requires resolution in order to determine obviousness.” U.S. Surgical Corp. v. Ethicon, Inc., 103 F.3d 1554, 1568 (Fed. Cir. 1997). In order to determine whether Petitioner’s obviousness grounds meet their required burden of proof, we need not expressly state the full scope of this claim term. Thus, we are within our authority to proffer a construction that determines the scope of a claim term in a manner sufficient to determine whether the asserted art teaches the claim. In other words, there may be other ways to meet the disputed limitation, but for the purposes of our Decision, it is proper to expressly determine a claim term’s scope only as much as is required to resolve the disputed issues before us.” slip op. at 17

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner

    “the invention(s), but rather as examples of some of the embodiments.” Id. at 25:65–26:1; see also id. at 6:18–20 (embodiments “should be construed as illustrative rather than limiting”), 5:22–24 (“non-limiting example”). The Federal Circuit has noted that “[e]mbodiments in the specification—even if there is only one embodiment—cannot limit the scope of the claims absent the patentee’s ‘words or expressions of manifest exclusion or restriction.’” Apple Inc. v. Wi-LAN Inc., 25 F.4th 960, 967 (Fed. Cir. 2022) (citing Hill- Rom Servs., Inc. v. Stryker Corp., 755 F.3d 1367, 1372 (Fed. Cir. 2014)). After reviewing the complete record, we see no such manifest exclusion or restriction in the ’240 patent specification. We decline Patent Owner’s request to limit the claims to the described single-frequency embodiments. See Phillips, 415 F.3d at 1323. We need not provide further express construction of this claim language for purposes of this Decision.” slip op. at 23

  Patent outcomesUS 9,165,240 mixed
  Claim construction§ 103 obviousnesscites Phillips · KSR
  Patents in suitUS 9,165,240
• Wolfspeed, Inc. / Ideal Industries Lighting, LLC D/B/A Cree Lighting v. Cao Lighting, Inc.Some claims unpatentable
  PTAB · Sep 28, 2023 · IPR2022-00848 · APJ Brian D Range · IPR · Final written decision

  Claims 21, 22, 25, 26, 28–30, 32–36, 40, 42–44, 47–49, 52, 53, 56–59, 62, 63, 65–68, 71–73, 77, 78, 81, 82, 85, 86, and 88–91 are unpatentable under § 103; claim 41 is not shown …

  RulingsFinal written decision

  • ExcludeMotion to exclude, deniedDenied

    “declaration addresses the Patent Owner Response and is relevant to the issues at hand. We start with an important observation: claim 18 (the only independent claim at issue) is an apparatus claim; the claim is directed to a “semiconductor light source.” Ex. 1001, 9:52, EPRC 1:32. One requirement of this apparatus is that it comprise “a semiconductor chip” (id. at 9:66) where “said semiconductor chip is a light emitting diode (LED) chip EPRC, 1:34–36. As we explain when addressing claim construction, infra, we adopt Patent Owner’s proposed construction (Resp. 14) of “said semiconductor chip is a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” as referring to “a semiconductor LED chip capable of emitting light greater than about 40 milliwatts.” See Section III.D, infra (emphasis added). Because of these recitations, Petitioner bears the burden of establishing that the prior art teaches or suggests a semiconductor LED chip “capable of emitting light greater than about 40 milliwatts.” As explained herein, we determine that in the Petition, Petitioner met this burden by establishing by a preponderance of the evidence that the Krames reference teaches an LED chip that has this capability. Pet. 53 (quoting Ex. 1008, 10). Notably, claim 18 does not require actual operation of anything at greater than 40 milliwatts because claim 21 is not a method claim. Petitioner never had a burden of establishing a method of running the Krames reference’s LED at this power output within a semiconductor light source.” slip op. at 9

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with Patent Owner that the challenged claims relate to light fixtures, LED packaging, and LED chip layer structure and that the ’770 patent claims reflect “a hybrid of the light bulb art and semiconductor art.” Resp. 16. The prior art of record, for example, Begemann, likewise reflects “a hybrid of the light bulb art and semiconductor art.” Id. (quoting Pet. 28). Petitioner’s expert, Dr. Lebby, agreed that a person having ordinary skill in 28:16. While Petitioner’s proposed description of a person having ordinary skill in the art could, in some instances, be sufficient to qualify a person as having ordinary skill, Patent Owner’s proposal is a more complete and accurate description of the level of skill commensurate with the scope of the challenged ’770 patent claims. Patent Owner’s description appears consistent with the prior art and patent specification before us and is supported by witness testimony. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself may reflect an appropriate level of skill). For the purpose of this Decision, we adopt Patent Owner’s description. We further note that the outcome of our decision would be the same under either party’s asserted skill level.” slip op. at 15

  • Prior constructionPrior construction adoptedTerm construed patent owner constructionDecided for patent owner

    “Delaware held, with respect to related U.S. Patent 6,465,961, construed “a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” as “at least one LED chip is capable of emitting light greater than about 40 milliwatts.” Resp. 14 (citing Ex. 1024, 15–18). Petitioner responds that the phrase “needs no construction” and that Petitioner’s grounds meet this construction. Reply 1. We note that the language of claim 18 does not precisely match the language the District Court considered, it is substantively the same. The record supports a construction very similar to the construction the District Court adopts, and we reference the District Court’s reasoning. Ex. 1024, 15– 18. We, thus, construe claim 18’s recitation that “said semiconductor chip is a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” as referring to “a semiconductor LED chip that is capable of emitting light greater than about 40 milliwatts.” It is unnecessary to construe any other claim terms in this Decision because none of the parties’ disputes turn on the meaning of other terms. See, e.g., Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017).” slip op. at 17

  • Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedReference is prior artDecided for petitioner

    “The facts above are evidence of the Krames reference’s publication as of June 29, 2000, because the facts tend to make the Krames reference’s publication as of June 29, 2000, more probable than it would be without the evidence. See Fed. R. Evid. 401(a) (defining evidence as relevant “if it has any tendency to make a fact more or less probable than it would be without the evidence”). The evidence is sufficient to support publication. Meanwhile, no evidence of record suggests that Krames was not a printed publication as of June 29, 2000. Thus, a preponderance of the evidence supports Krames’s prior art status. Patent Owner argues that Ms. Watters “never establishes a firm date when Krames was purportedly available to the relevant public.” Resp. 21. Patent Owner bases this argument by taking a tortured reading of Ms. Watters’s statement that “[m]embers of the interested public could locate a copy of [the Proceedings] on or after June 29, 2000, the date it was catalogued.” Id. (quoting Ex. 1020, 3); see also Sur-Reply 12–13. The best understanding of Ms. Watters’s statement, in view of the context of Ms. Watters explaining the library’s cataloguing process, is that a member of the interested public had two options: the person could choose to locate the Proceedings on June 29, 2000, or the person could choose to locate the Proceedings after June 29, 2000. Thus, the statement supports public availability as of June 29, 2000.” slip op. at 21

  Patent outcomesUS 6,634,770 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR
  Patents in suitUS 6,634,770
• Wolfspeed, Inc. / Ideal Industries Lighting, LLC D/B/A Cree Lighting et al. v. Cao Lighting, Inc.Some claims unpatentable
  PTAB · Sep 28, 2023 · IPR2023-00129 · APJ Brian D Range · IPR · Final written decision

  Claims 21–40, 42–44, 47–49, 52–53, 56–59, 62–63, 65–68, 71–73, 77–78, 81–82, 85–86, and 88–91 are unpatentable over Begemann, Krames, and Allen; claim 41 is not shown unpatentable.

  RulingsFinal written decision

  • ExcludeMotion to exclude, deniedDenied

    “In the Reply, Petitioner uses the Krames declaration (Ex. 1028) to argue, for example, that a person of ordinary skill in the art would have used a lower amperage than the 1.5 A dc that Patent Owner’s Response focuses on. Reply 8 (citing Ex. 1028 ¶ 22). This use of the Krames declaration is timely because it responds to an argument Patent Owner makes in the Patent Owner Response. 37 C.F.R. § 42.23(b) (“A reply may only respond to arguments raised in . . . patent owner response.”). As to relevancy and whether the Krames declaration is applicable to the facts of this case, the issues at hand are (1) whether or not a person having ordinary skill would have had reason to use the Krames LED with Begemann with a reasonable expectation of success and (2) whether or not the Krames LED is capable of outputting light at greater than about 40 milliwatts. Again, we emphasize that claim 21 does not recite a method where the LED within the recited semiconductor light source actually outputs greater than about 40 milliwatts. The Krames declaration is relevant to the facts of this case because the declaration has bearing on whether or not a person of ordinary skill in the art would have combined the Krames reference’s LED with Begemann’s lightbulb design. See, e.g., Ex. 1028 ¶ 22. Patent Owner argues that evidence must be relevant to motivation to combine “an LED chip from the Krames article (operating at 1.5 amps to produce 170 milliwatts of output)” but claim 21 has no “operating at 1.5 amps to produce 170 milliwatts of output” requirement. What is relevant is that Krames discloses a single chip that has the capability of outputting more or less light depending on operating conditions. Pet. Opp. 3; see also Ex. 1008, 8 (providing that Figure 12 of the Krames reference is described as illustrating “[l]ight output vs. current characteristic of a blue … 1x1 mm2 AlGaInN LED in a power package, compared to a conventional AlGaInN LED in a 5 mm lamp a package”). Because claim 21 does not require actually running the recited LED at any particular wattage or amperage, it is appropriate for the Krames declaration to rebut Patent Owner’s argument that a person of ordinary skill would not have considered using the Krames LED with Begemann at high amperage by explaining that a person of ordinary skill in the art would have considered using the exact same Krames LED with Begemann at a low amperage instead and that at this lower amperage the Krames LED would generate an amount of heat that would be easily dissipated by Begemann’s lamp while still providing an optical output of “greater than about 40 milliwatts” as recited by claim 21. Ex. 1028 ¶¶ 23–24 (citing Ex. 1008, 8). The fact that the Krames LED is configured to run at the high amperage if desired for a different application does not negate the rationale for combining the Krames LED to run at a lower amperage.” slip op. at 14

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with Patent Owner that the challenged claims relate to light fixtures, LED packaging, and LED chip layer structure and that the ’961 patent claims reflect “a hybrid of the light bulb art and semiconductor art.” Resp. 19. The prior art of record, for example, Begemann, likewise reflects “a hybrid of the light bulb art and semiconductor art.” Id. (quoting Pet. 28). Petitioner’s expert, Dr. Lebby, agreed that a person having ordinary skill in the art would need to be “familiar with thermal issues.” Ex. 2015, 26:15– 28:16. While Petitioner’s proposed description of a person having ordinary skill in the art could, in some instances, be sufficient to qualify a person as having ordinary skill, Patent Owner’s proposal is a more complete and accurate description of the level of skill commensurate with the scope of the challenged ’961 patent claims. Patent Owner’s description appears consistent with the prior art and patent specification before us and is supported by witness testimony. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself may reflect an appropriate level of skill). For the purpose of this Decision, we adopt Patent Owner’s description. We further note that the outcome of our decision would be the same under either party’s asserted skill level.” slip op. at 19

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “particularly relevant.” Resp. 14–15. First, Patent Owner argues that “a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” means “at least one LED chip is capable of emitting light greater 9 Petitioner states that “Patent Owner thus contends the recited ‘reflective layers’ can include transparent or semi-transparent layers that exhibit some reflectivity (e.g., SiO2) or an interface between two layers (e.g., the buffer and substrate layers) that exhibit differing indices of refraction.” Pet. 20. Patent Owner frames this as being Petitioner’s “novel construction” (Resp. 16), but Petitioner does not expressly endorse this Patent Owner contention. than about 40 milliwatts.” Resp. 14–15. Patent Owner notes that a district court already adopted this construction and notes that the “LED chip” includes LEDs, LED modules, and LED arrays but excludes laser chips, laser modules, and VCSEL chips. Id. (citing Ex. 2003, 15–18). Petitioner argues that the phrase “needs no construction” and that Petitioner’s grounds meet this construction. Reply 1–2. We adopt Patent Owner’s proposed construction because it is well supported by the record including the District Court’s reasoning. Ex. 2003, 15–18. slip op. at 20

  • Prior constructionPrior construction adoptedDecided for patent owner

    “Patent Owner’s claim construction is well-supported by the record including the reasoning provided by the California and Delaware district courts. Ex. 2002, 19–21 (California district court explaining why the “reflective layers” must be distinct layers based on how claim 8 is structured and also explaining why the amount of reflection must be non-negligible); Ex. 2003, 2, 13 (Delaware district court explaining why reflection has to be more than negligible but need not reflect more light than the light absorbed or transmitted). We, thus, agree that “first and a second reflective layers . . . 10 Patent Owner’s proposed claim construction combines various statements made by the district courts into one statement. Resp. 15 (citing Ex. 2002, 19–21; Ex. 2003, 2, 13). serving to reflect light emitted by said active layer” means that the “first and second reflective layers are distinct from each other and reflect more than negligible light.” We further note that the preponderance of the evidence supports that as little as one percent light reflectance is “non-negligible” in this context. Reply 4; also Ex. 1032, 188:7–14 (Patent Owner’s witness, Dr. Shealy, testifying that reflection “on the order of one percent” would be more than negligible); see also Tr. 53 (counsel for Patent Owner agreeing that Dr. Shealy opined that “three percent reflection is enough to be non-negligible”).” slip op. at 21

  Patent outcomesUS 6,465,961 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 6,465,961
• Wolfspeed, Inc. / Ideal Industries Lighting, LLC D/B/A Cree Lighting et al. v. Cao Lighting, Inc.Some claims unpatentable
  PTAB · Sep 28, 2023 · IPR2023-00123 · APJ Brian D Range · IPR · Final written decision

  Claims 21–40, 42–44, 47–49, 52–53, 56–59, 62–63, 65–68, 71–73, 77–78, 81–82, and 85–91 are unpatentable over Begemann, Krames, and Allen; claim 41 was not shown unpatentable.

  RulingsFinal written decision

  • ExcludeMotion to exclude, deniedDenied

    “declaration addresses the Patent Owner Response and is relevant to the issues at hand. We start with an important observation: claim 21 (the only independent claim at issue) is an apparatus claim; the claim is directed to a “semiconductor light source.” Ex. 1001, 9:52. One requirement of this apparatus is that it comprise “at least one semiconductor chip” (id. at 10:1) where the “at least one semiconductor chip is a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts.” Id. at EPRC, 1:34–36. As we explain when addressing claim construction, infra, we adopt Patent Owner’s proposed construction of “a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” as meaning “at least one LED chip is capable of emitting light greater than about 40 milliwatts.” See Section III.D, infra (emphasis added). Because of these recitations, Petitioner bears the burden of establishing that the prior art teaches or suggests a semiconductor chip “capable of emitting light greater than about 40 milliwatts.” As explained herein, we determine that in the Petition, Petitioner met this burden by establishing by a preponderance of the evidence that the Krames reference teaches an LED chip that has this capability. Pet. 54 (quoting Ex. 1008, 10). Notably, claim 21 does not require actual operation of anything at greater than 40 milliwatts because claim 21 is not a method claim. Petitioner never had a burden of establishing a method of running the Krames reference’s LED at this power output within a semiconductor light source.” slip op. at 12

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with Patent Owner that the challenged claims relate to light fixtures, LED packaging, and LED chip layer structure and that the ’961 patent claims reflect “a hybrid of the light bulb art and semiconductor art.” Resp. 19. The prior art of record, for example, Begemann, likewise reflects “a hybrid of the light bulb art and semiconductor art.” Id. (quoting Pet. 28). Petitioner’s expert, Dr. Lebby, agreed that a person having ordinary skill in the art would need to be “familiar with thermal issues.” Ex. 2015, 26:15– 28:16. While Petitioner’s proposed description of a person having ordinary skill in the art could, in some instances, be sufficient to qualify a person as having ordinary skill, Patent Owner’s proposal is a more complete and accurate description of the level of skill commensurate with the scope of the challenged ’961 patent claims. Patent Owner’s description appears consistent with the prior art and patent specification before us and is supported by witness testimony. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself may reflect an appropriate level of skill). For the purpose of this Decision, we adopt Patent Owner’s description. We further note that the outcome of our decision would be the same under either party’s asserted skill level.” slip op. at 19

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed patent owner constructionDecided for patent owner

    “particularly relevant.” Resp. 14–15. First, Patent Owner argues that “a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” means “at least one LED chip is capable of emitting light greater 9 Petitioner states that “Patent Owner thus contends the recited ‘reflective layers’ can include transparent or semi-transparent layers that exhibit some reflectivity (e.g., SiO2) or an interface between two layers (e.g., the buffer and substrate layers) that exhibit differing indices of refraction.” Pet. 20. Patent Owner frames this as being Petitioner’s “novel construction” (Resp. 16), but Petitioner does not expressly endorse this Patent Owner contention. than about 40 milliwatts.” Resp. 14–15. Patent Owner notes that a district court already adopted this construction and notes that the “LED chip” includes LEDs, LED modules, and LED arrays but excludes laser chips, laser modules, and VCSEL chips. Id. (citing Ex. 2003, 15–18). Petitioner argues that the phrase “needs no construction” and that Petitioner’s grounds meet this construction. Reply 1–2. We adopt Patent Owner’s proposed construction because it is well supported by the record including the District Court’s reasoning. Ex. 2003, 15–18. slip op. at 20

  • Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedDecided for petitioner

    “The facts above are evidence of the Krames reference’s publication as of June 29, 2000, because the facts tend to make the Krames reference’s publication as of June 29, 2000, more probable than it would be without the facts. See Fed. R. Evid. 401(a) (defining evidence as relevant “if it has any tendency to make a fact more or less probable than it would be without the 13 We note that Dr. Lebby does not directly state when the Proceedings were widely available. See Sur-Reply 14. evidence”). The evidence is sufficient to support publication. Meanwhile, no evidence of record suggests that Krames was not a printed publication as of June 29, 2000. Thus, a preponderance of the evidence supports Krames’s prior art status. Patent Owner argues that Ms. Watters “never establishes a firm date when Krames was purportedly available to the relevant public.” Resp. 25. Patent Owner bases this argument by taking a tortured reading of Ms. Watters’s statement that “[m]embers of the interested public could locate a copy of [the Proceedings] on or after June 29, 2000, the date it was catalogued.” Id. (quoting Ex. 1020, 3); see also Sur-Reply 13–14. The best understanding of Ms. Watters’s statement, in view of the context of Ms. Watters explaining the library’s cataloguing process, is that a member of the interested public had two options: the person could choose to locate the Proceedings on June 29, 2000, or the person could choose to locate the Proceedings after June 29, 2000. Thus, the statement supports public availability as of June 29, 2000.” slip op. at 25

  Patent outcomesUS 6,465,961 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 6,465,961
• Wolfspeed, Inc. / Ideal Industries Lighting, LLC D/B/A Cree Lighting et al. v. Cao Lighting, Inc.Some claims unpatentable
  PTAB · Sep 28, 2023 · IPR2022-00847 · APJ Brian D Range · IPR · Final written decision

  Claims 21, 22, 25, 26, 28–30, 32–36, 40, 42–44, 47–49, 52, 53, 56–59, 62, 63, 65–68, 71–73, 77, 78, 81, 82, 85, 86, and 88–91 are unpatentable over Begemann, Krames, and Allen; claim 41 is …

  RulingsFinal written decision

  • ExcludeMotion to exclude, deniedDenied

    “Patent Owner’s argument is unpersuasive because the Krames declaration addresses the Patent Owner Response and is relevant to the issues at hand. We start with an important observation: claim 21 (the only independent claim at issue) is an apparatus claim; the claim is directed to a “semiconductor light source.” Ex. 1001, 9:52. One requirement of this apparatus is that it comprise “at least one semiconductor chip” (id. at 10:1) where the “at least one semiconductor chip is a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts.” Id. at EPRC, 1:34–36. As we explain when addressing claim construction, infra, we adopt Patent Owner’s proposed construction of “a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” as meaning “at least one LED chip is capable of emitting light greater than about 40 milliwatts.” See Section III.D, infra (emphasis added). Because of these recitations, Petitioner bears the burden of establishing that the prior art teaches or suggests a semiconductor chip “capable of emitting light greater than about 40 milliwatts.” As explained herein, we determine that in the Petition, Petitioner met this burden by establishing by a preponderance of the evidence that the Krames reference teaches an LED chip that has this capability. Pet. 54 (quoting Ex. 1008, 10). Notably, claim 21 does not require actual operation of anything at greater than 40 milliwatts because claim 21 is not a method claim. Petitioner never had a burden of establishing a method of running the Krames reference’s LED at this power output within a semiconductor light source.” slip op. at 12

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with Patent Owner that the challenged claims relate to light fixtures, LED packaging, and LED chip layer structure and that the ’961 patent claims reflect “a hybrid of the light bulb art and semiconductor art.” Resp. 19. The prior art of record, for example, Begemann, likewise reflects “a hybrid of the light bulb art and semiconductor art.” Id. (quoting Pet. 28). Petitioner’s expert, Dr. Lebby, agreed that a person having ordinary skill in the art would need to be “familiar with thermal issues.” Ex. 2015, 26:15– 28:16. While Petitioner’s proposed description of a person having ordinary skill in the art could, in some instances, be sufficient to qualify a person as having ordinary skill, Patent Owner’s proposal is a more complete and accurate description of the level of skill commensurate with the scope of the challenged ’961 patent claims. Patent Owner’s description appears consistent with the prior art and patent specification before us and is supported by witness testimony. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself may reflect an appropriate level of skill). For the purpose of this Decision, we adopt Patent Owner’s description. We further note that the outcome of our decision would be the same under either party’s asserted skill level.” slip op. at 19

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “particularly relevant.” Resp. 14–15. First, Patent Owner argues that “a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” means “at least one LED chip is capable of emitting light greater 9 Petitioner states that “Patent Owner thus contends the recited ‘reflective layers’ can include transparent or semi-transparent layers that exhibit some reflectivity (e.g., SiO2) or an interface between two layers (e.g., the buffer and substrate layers) that exhibit differing indices of refraction.” Pet. 20. Patent Owner frames this as being Petitioner’s “novel construction” (Resp. 16), but Petitioner does not expressly endorse this Patent Owner contention. than about 40 milliwatts.” Resp. 14–15. Patent Owner notes that a district court already adopted this construction and notes that the “LED chip” includes LEDs, LED modules, and LED arrays but excludes laser chips, laser modules, and VCSEL chips. Id. (citing Ex. 2003, 15–18). Petitioner argues that the phrase “needs no construction” and that Petitioner’s grounds meet this construction. Reply 1–2. We adopt Patent Owner’s proposed construction because it is well supported by the record including the District Court’s reasoning. Ex. 2003, 15–18. slip op. at 20

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “It is unnecessary to construe any other claim terms in this Decision because none of the parties’ disputes turn on the meaning of other claim terms. See, e.g., Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017).” slip op. at 22

  Patent outcomesUS 6,465,961 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 6,465,961

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.