- PTAB · Oct 11, 2024 · IPR2024-00774 · APJ Jon B Tornquist · IPR · Institution
The Board instituted IPR on all challenged claims and petition grounds, and granted Texas Instruments’ motion to join the Cirrus IPR.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“IPR. Compare id., with IPR2024-00019, Paper 46 at 1–4, 6–22 (Patent Owner’s response in the Cirrus IPR) (public version). We decline to resolve the material issue of fact surrounding this limitation on this preliminary record, because the trial in the Cirrus IPR is the better proceeding in which to do so. Specifically, as compared to the preliminary phase of this case, the instituted trial in the Cirrus IPR affords the parties a better opportunity to fully and fairly brief, argue, and develop evidence in support of their positions, and, in particular, to address Cirrus Logic’s alleged admission that the existence of a gradient alone is insufficient to disclose the “aid carrier movement” limitations of independent claims 1 and 21. We observe only that, on this record, the disputed issue of material fact is not sufficient to undermine the sufficiency of Petitioner’s evidence supporting institution of review.” slip op. at 16
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 15– 35. The one-year time bar under § 315(b), however, “shall not apply to a request for joinder under subsection (c).” 35 U.S.C. § 315(b); see 37 C.F.R. § 42.122(b). And, because the Petition is accompanied by a timely request for joinder (Paper 1) to the instituted proceeding (IPR2024-00019), which we grant as further discussed below, Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 8
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“Based on the facts and circumstances discussed above, we determine Petitioner has established good cause for joining the Cirrus IPR. Specifically, we find that joining Petitioner to the Cirrus IPR is unlikely to require any delay or modification to the scheduling order already in place for that proceeding. We also determine that Patent Owner will not be prejudiced unduly by the joinder of this proceeding. Thus, we determine that granting the Motion for Joinder would help “secure the just, speedy, and inexpensive resolution” of these proceedings. See 37 C.F.R. § 42.1(b). Accordingly, we grant Petitioner’s Motion for Joinder and join Petitioner as a party to the Cirrus IPR.” slip op. at 19
NonePatents in suitUS 11,316,014 - PTAB · Oct 11, 2024 · IPR2024-00773 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted review of claims 7–12 on all asserted grounds and granted Texas Instruments’ motion to join the Cirrus IPR in an understudy role.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Rather than pointing to anything in the prior art that would teach this claim limitation, the Petition assumes that any “graded concentration of dopants” would necessarily “aid the movement of minority carriers.” The Petition contains no analysis explaining why the “graded concentration of dopants” in the prior art meet the “aid the movement of minority carriers” limitation, apart from the fact that they are “graded concentration of dopants.” In other words, Petitioner reads the “aid the movement of minority carriers” limitation out of the claims completely.” slip op. at 13
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b)” slip op. at 7
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“joinder is discretionary. See 35 U.S.C. § 315(c); 37 C.F.R. § 42.122. A motion for joinder should (1) set forth reasons why joinder is appropriate; (2) identify any new grounds of unpatentability asserted in the petition; (3) explain what impact (if any) joinder would have on the trial schedule for 7 Available at https://www.uspto.gov/TralPracticeGuideConsolidated. the existing review; and (4) address specifically how briefing and discovery may be simplified. See, e.g., Kyocera Corp. v. Softview LLC, IPR2013- 00004, Paper 15 (PTAB April 24, 2013). As the moving party, Petitioner bears the burden of proving that it is entitled to the requested relief. 37 C.F.R. § 42.20(c).” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of successInstituted
“Regarding the “first static unidirectional electric drift field to aid the movement of minority carriers” limitation, Petitioner relies on the parent file history and cited references, arguing that “Payne’s downward-sloping graded-dopant concentration aids the movement of minority carriers from the surface layer to the substrate to the same extent to which Applicant relied on the prior art and admitted to the Patent Office that such carrier movement would occur under the same scenario.” Pet. 23. Petitioner also asserts that the direction in which carriers are forced with the concentration profile disclosed in Payne is downward, toward the substrate and away from the surface. Pet. 23–28 (quoting and citing Ex. 1046, 237–238, 253–254, 289– 290; citing Ex. 1003 ¶¶ 95–106; Ex. 1005, 5:7–17, 5:44–55; Ex. 1009, 2:11– 16, 2:67–3:18, Fig. 2; Ex. 1010, 2:27–32, 5:14–22; Ex. 1013, 431; Ex. 1030, 24). We find that Petitioner’s challenge to claim 7 based on Payne is sufficiently supported for purposes of institution.” slip op. at 12
§ 103 obviousnessPatents in suitUS 9,190,502 - PTAB · Oct 11, 2024 · IPR2024-00771 · APJ Grace Karaffa Obermann · IPR · Institution
The Board instituted IPR on claims 1–6 of the ’195 patent on all asserted grounds and granted Texas Instruments’ motion to join the Cirrus IPR.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Because the Preliminary Response in the instant case includes arguments pertaining to the sufficiency of the asserted prior art references, which were not raised in the preliminary response in the Cirrus IPR, we briefly address below the patentability of the challenged claims.” slip op. at 6
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“II. TIMELINESS OF THE PETITION UNDER 35 U.S.C. § 315(B) Pursuant to 35 U.S.C. § 315(b), “[a]n inter partes review may not be instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 10– 30. However, 35 U.S.C. § 315(b) also provides that the one-year time bar “shall not apply to a request for joinder under subsection (c).” See also 37 C.F.R. § 42.122(b). Because the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted proceeding (IPR2024-00017), which we grant as further discussed below, Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 5
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“B. Whether to Join Petitioner as a Party to the Cirrus IPR Joinder may be authorized when warranted, but the decision to grant joinder is discretionary. See 35 U.S.C. § 315(c); 37 C.F.R. § 42.122. A motion for joinder should (1) set forth reasons why joinder is appropriate; (2) identify any new grounds of unpatentability asserted in the petition; (3) explain what impact (if any) joinder would have on the trial schedule for the existing review; and (4) address specifically how briefing and discovery may be simplified. See, e.g., Kyocera Corp. v. Softview LLC, IPR2013- 00004, Paper 15 (PTAB April 24, 2013). As the moving party, Petitioner bears the burden of proving that it is entitled to the requested relief. 37 C.F.R. § 42.20(c). As an initial matter, we find the Motion for Joinder meets the timing requirements of 37 C.F.R. § 42.122(b) because Petitioner filed it on April 4, 2024, no later than one month after the Cirrus IPR was instituted on May 1, 2024.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“5. “Aid the Movement of Minority Carriers” Patent Owner argues that the Petition fails to show that the applied prior art references disclose the claim limitations “requiring ‘aid the movement of minority carriers,’” as twice recited in claim 1. Prelim. Resp. 8. Patent Owner summarizes this dispute as follows: The challenged patent discloses and claims a semiconductor device with (among other things) a “drift layer having a graded concentration of dopants . . . [and] further having a first static unidirectional electric drift field to aid the movement of minority carriers.”[] The Petition should not be instituted, because (among other deficiencies) it fails to show that the prior art discloses the “aid the movement of minority carriers” claim limitation. Rather than pointing to anything in the prior art that would teach this claim limitation, the Petition assumes that any “graded concentration of dopants” would necessarily “aid the movement of minority carriers.” The Petition contains no analysis explaining why the “graded concentration of dopants” in the prior art meet the “aid the movement of minority carriers” limitation, apart from the fact that they are “graded concentration of dopants.” In other words, Petitioner reads the “aid the movement of minority carriers” limitation out of the claims completely. Id. at 1–2. Patent Owner includes additional details in support of its view that the asserted prior art fails to establish obviousness of the “aid carrier movement” limitations of claim 1. Prelim. Resp. 1–10.” slip op. at 8
§ 102 anticipation§ 103 obviousnessPatents in suitUS 8,421,195 - PTAB · Sep 27, 2024 · IPR2024-00674 · APJ Monica S Ullagaddi · IPR · Institution
The Board instituted review of claim 44 on all asserted grounds and granted Texas Instruments’ motion to join IPR2023-01244 in an understudy role.
RulingsInstitution decision- Parallel petitionsDecided for petitioner
“On the present record, we agree with Petitioner that the two petitions filed to challenge the claims of the ’222 patent will not substantially burden the Board or the parties. The petitions in IPR2024-00673 and IPR2024- 00674 challenge different claims, and those claims appear on the present record to have different claim scope, as Petitioner argues. Paper 3, 3–4 (arguing that claim 44, challenged in IPR2024-00674, recites “a ‘surface layer,’ a ‘single drift layer,’ and ‘at least one well region disposed in the single drift layer,’ which are not” recited in the claims challenged in IPR2024-00673); Ex. 1001, 4:39–8:39. In addition, there is little overlap between the prior art asserted in the two petitions, and what overlap there is—the use of Kawagoe in both petitions—is used in different prior-art combinations in each petition. Compare IPR2024-00673, Paper 4, 5 (asserting Kawagoe alone and in combination with Gupta or Silverbrook), with IPR2024-00674, Paper 4, 5 (asserting Kawagoe in combination with Sakai). Accordingly, we do not exercise our discretion to deny either of the petitions challenging the ’222 patent for being parallel petitions.” slip op. at 5
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 16– 37. However, 35 U.S.C. § 315(b) also provides that the one year time bar “shall not apply to a request for joinder under subsection (c).” See also 37 C.F.R. § 42.122(b). Since the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted proceeding (IPR2023-01244), which we grant as further discussed below (see infra § V), Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, regardless of whether Petitioner is in privity with time-barred entities.” slip op. at 5
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“statements made during prosecution of the ’195 patent contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support a preliminary finding that a graded dopant concentration is enough to teach 9 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1020, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. aiding carrier movement in a particular direction. Patent Owner does not dispute that Payne has a drift layer having a static unidirectional electric drift field and a well region having a graded concentration of dopants and a static unidirectional electric drift field at this stage of the proceeding. See generally Prelim. Resp. Patent Owner also does not dispute that Payne’s transistor has a surface layer and a substrate having an area with no active regions. Id. At this stage of the proceeding, Petitioner has the better position.” slip op. at 16
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“statements made during prosecution of the ’195 patent contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support a preliminary finding that a graded dopant concentration is enough to teach 9 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1020, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. aiding carrier movement in a particular direction. Patent Owner does not dispute that Payne has a drift layer having a static unidirectional electric drift field and a well region having a graded concentration of dopants and a static unidirectional electric drift field at this stage of the proceeding. See generally Prelim. Resp. Patent Owner also does not dispute that Payne’s transistor has a surface layer and a substrate having an area with no active regions. Id. At this stage of the proceeding, Petitioner has the better position.” slip op. at 16
§ 103 obviousnessDiscretionary denialPatents in suitUS 11,121,222 - PTAB · Sep 27, 2024 · IPR2024-00673 · APJ Monica S Ullagaddi · IPR · Institution
The Board instituted review of claims 1–9, 13–28, and 32–42 on all asserted grounds and granted Texas Instruments’ motion to join IPR2023-01242 in an understudy role.
RulingsInstitution decision- Parallel petitionsDecided for petitioner
“On the present record, we agree with Petitioner that the two petitions filed to challenge the claims of the ’222 patent will not substantially burden the Board or the parties. The petitions in IPR2024-00673 and IPR2024- 00674 challenge different claims and, on the present record, those claims 8 Patent Trial and Appeal Board Consolidated Trial Practice Guide (Nov. 2019), available at https://www.uspto.gov/TrialPracticeGuideConsolidated (“CTPG”). appear to have different claim scope, as Petitioner argues. Paper 3, 3–4 (arguing that claim 44, challenged in IPR2024-00674, recites “a ‘surface layer,’ a ‘single drift layer,’ and ‘at least one well region disposed in the single drift layer,’ which are not” recited in the claims challenged in IPR2024-00673); Ex. 1001, 4:39–8:39. In addition, there is little overlap between the prior art asserted in the two petitions, and what overlap there is—reliance on Kawagoe in both petitions—is applied in different prior art combinations in each petition. Compare IPR2024-00673, Paper 4, 5 (asserting Kawagoe alone and in combination with Gupta or Silverbrook), with IPR2024-00674, Paper 4, 5 (asserting Kawagoe in combination with Sakai). Accordingly, we do not exercise our discretion to deny either of the petitions challenging the ’222 patent for being parallel petitions.” slip op. at 5
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“III. WHETHER THE PETITION IS TIME-BARRED Pursuant to 35 U.S.C. § 315(b), “[a]n inter partes review may not be instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 19– 39. However, 35 U.S.C. § 315(b) also provides that the one-year time bar “shall not apply to a request for joinder under subsection (c).” See also 37 C.F.R. § 42.122(b). Because the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted proceeding (IPR2023-01242), which we grant as further discussed below (see infra § V), Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 6
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“statements made during prosecution of the ’195 patent contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support a preliminary finding that a graded dopant concentration is enough to teach 13 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1016, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. aiding carrier movement in a particular direction. Patent Owner does not dispute that Kawagoe has a graded dopant concentration in the active region at this stage of the proceeding. See generally Prelim. Resp. Patent Owner also does not dispute that Kawagoe’s transistor has carriers in the active region or that the graded dopant concentration of Kawagoe is lowered from the surface to the bottom substrate (Ex. 1007, Fig. 17). See generally Prelim. Resp. At this stage of the proceeding, Petitioner has the better position.” slip op. at 19
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“under the pre-AIA version of 35 U.S.C. § 112, first paragraph and found that “movement of minority carriers is affected by multiple forces and fields” and that “it does not appear that simply the presence of ‘a unidirectional drift field’ in itself can achieve ‘drawing all minority carriers from said surface layer to said substrate.’” Ex. 1016, 289 (emphasis added). Patent Owner responded with the following argument: [A] unidirectional drift (electric) field necessarily affects all the present minority carriers in the same way - moving all minority carriers in the same direction because of the unidirectional drift due to the existence of the electric field. See “Physics and Technology of Semiconductor Devices,” A.S. Grove, pp. 224– 225, John Wiley and Sons, Inc., New York, 1st Edition 1967 (“This same electric field will then be of such direction as to aid the motion of injected holes. Thus the injected minority carriers will now move not only by diffusion but also by drift due to the existence of this electric field.”). Depending on the particular slope of the graded concentration of dopant, all minority carriers are either swept “down” (from the surface layer to the substrate) or “up” (from the substrate to the surface layer). See Applicant’s Figs. 5(b) and 5(c). Id. Patent Owner further argued that the Examiner’s finding appears to not consider that the graded dopant concentration itself creates a “built-in” electrical field that forces the movement of carriers into a particular direction, whereby the “direction” of the electrical field and the resulting direction of the carrier movement depends solely on the slope of the graded concentration of dopant. With regard to the existence of a “built-in” electric field created by a graded dopant density, . . . this inherent “built-in” unidirectional electric field is the additional parameter for ensuring that all minority carriers are being moved in one direction and which parameter the Office Action deemed to be missing from the disclosure. Id. at 289–90 (emphases added). Also, “without conceding its position on this issue,” Patent Owner amended claims to eliminate reference to “all carriers” and instead, refer to “carriers.” 13 Id. at 290. 4. Analysis of Claim 1 At this stage of the proceeding, we determine that Patent Owner’s statements made during prosecution of the ’195 patent contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support a preliminary finding that a graded dopant concentration is enough to teach 13 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1016, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. aiding carrier movement in a particular direction. Patent Owner does not dispute that Kawagoe has a graded dopant concentration in the active region at this stage of the proceeding. See generally Prelim. Resp. Patent Owner also does not dispute that Kawagoe’s transistor has carriers in the active region or that the graded dopant concentration of Kawagoe is lowered from the surface to the bottom substrate (Ex. 1007, Fig. 17). See generally Prelim. Resp. At this stage of the proceeding, Petitioner has the better position.” slip op. at 18
§ 103 obviousnessDiscretionary denialPatents in suitUS 11,121,222 - PTAB · Sep 27, 2024 · IPR2024-00672 · APJ Julia Heaney · IPR · Institution
The Board instituted review of claims 1–18 on all asserted grounds and granted Texas Instruments’ motion to join IPR2023-01243 in an understudy role.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this stage of the proceeding, we determine that the arguments and evidence of record favor Petitioner. Both parties agree that a downward-sloping gradient, as disclosed in Kawagoe, will create an electrical field with a force in a direction toward the substrate. See generally Prelim. Resp.; Ex. 1007, 16:7–9. Patent Owner does not meaningfully dispute that Kawagoe has a graded dopant concentration in an active region. See generally Prelim. Resp. Further, Patent Owner contradictorily stated during prosecution of the ’195 patent that a graded dopant concentration itself creates “a built-in electrical field that forces the movement of carriers in a particular direction” (Ex. 1016, 289–290) and is “the additional parameter for ensuring that all minority carriers are being moved in one direction” (id. at 290). In light of this evidentiary record, which at most presents a material issue of fact for resolution at trial, we determine Petitioner establishes a reasonable likelihood of prevailing in its challenge of claim 1. We decline to further discuss the parties’ arguments or resolve any disputed issues as to challenges based on Kawagoe on this preliminary record, because the trial in the 1243 IPR is the better proceeding in which to do so. Specifically, as compared to the preliminary phase of this case, the instituted trial in the 1243 IPR affords the parties better opportunity to brief, argue, and develop evidence in support of their positions. Thus, for the same reasons stated in our Decision on Institution in the 1243 IPR, we determine the Petition here warrants institution.” slip op. at 16
- Obviousness (§103) › Motivation to combine / reasonable expectation of successInstituted
“deficient because Kawagoe’s disclosure of graded dopant concentration teaches impeding carrier movement rather than aiding it, as required by claim element 1.5. Prelim. Resp. 13–14. Patent Owner relies on Kawagoe’s disclosure that the concentration gradient prevents electrons from entering the p-well. Id. at 14 (citing Ex. 1007, 16:7–11). Patent Owner further argues Kawagoe’s carriers are not in the active regions, as required by claim element 1.5. Id. at 14–16 (citing Ex. 1003 ¶ 91, n.5). At this stage of the proceeding, we determine that the arguments and evidence of record favor Petitioner. Both parties agree that a downward-sloping gradient, as disclosed in Kawagoe, will create an electrical field with a force in a direction toward the substrate. See generally Prelim. Resp.; Ex. 1007, 16:7–9. Patent Owner does not meaningfully dispute that Kawagoe has a graded dopant concentration in an active region. See generally Prelim. Resp. Further, Patent Owner contradictorily stated during prosecution of the ’195 patent that a graded dopant concentration itself creates “a built-in electrical field that forces the movement of carriers in a particular direction” (Ex. 1016, 289–290) and is “the additional parameter for ensuring that all minority carriers are being moved in one direction” (id. at 290). In light of this evidentiary record, which at most presents a material issue of fact for resolution at trial, we determine Petitioner establishes a reasonable likelihood of prevailing in its challenge of claim 1.” slip op. at 15
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“II. TIMELINESS OF PETITION UNDER 35 U.S.C. § 315(B) Pursuant to 35 U.S.C. § 315(b), “[a]n inter partes review may not be instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” 1 The Leahy-Smith America Invents Act (“AIA”), Pub. L. No. 112-29, 125 Stat. 284, 287–88 (2011), included revisions to 35 U.S.C. §§ 102 and 103 that became effective in 2013, after the effective filing date of the challenged claims. See Ex. 1001, codes (22), (60). Therefore, we apply the pre-AIA versions of 35 U.S.C. §§ 102 and 103(a). 2 US 6,043,114, issued March 28, 2000 (Ex. 1007, “Kawagoe”). Petitioner asserts that Kawagoe is prior art under 35 U.S.C. § 102(b). Pet. 4. 3 US 6,163,877, issued December 19, 2000 (Ex. 1014, “Gupta”). Petitioner asserts that Gupta is prior art under 35 U.S.C. § 102(b). Pet. 5. 4 US 2003/0183856 A1, published October 2, 2003 (Ex. 1006, “Wieczorek”). Petitioner asserts that Wieczorek is prior art under 35 U.S.C. §§ 102(a),(e). Pet. 4. 5 Stanley Wolf and Richard N. Tauber, Silicon Processing for the VLSI Era, Vols. 1–4, Lattice Press (2000) (Ex. 1008, “Wolf”). Petitioner asserts that Wolf was published and publicly available no later than 2002, and is prior art under 35 U.S.C. § 102(b). Pet. 5 (citing Exs. 1012, 1013, 1036). Exhibit 1008 was submitted in four parts (A–D) and includes selected portions of Wolf. We cite to Wolf using its original page numbers and omit the exhibit part designations. Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 18– 39. However, 35 U.S.C. § 315(b) also provides that the one-year time bar “shall not apply to a request for joinder under subsection (c).” See also 37 C.F.R. § 42.122(b). Because the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted proceeding (IPR2023-01243), which we grant as further discussed below, Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 8
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“Patent Owner’s first argument is not persuasive because it is based on speculation that Petitioner “is trying to block settlement with any of these defendants unless [Patent Owner] also settles with” Petitioner. Opp. Mot. Join. 5. As discussed below, we determine that Patent Owner will not be prejudiced unduly by the joinder. Moreover, we note that even in a situation where the petitioner and patent owner in the proceeding to be joined had settled (Code200 v. Bright Data Ltd., IPR2022-00861, Paper 17 at 5 (PTAB July 25, 2022) (vacated)), the Director nevertheless vacated a decision to deny a motion for joinder. Code200 v. Bright Data Ltd., IPR2022-00861, Paper 18 at 7 (Office of the Director of the USPTO Aug. 23, 2022) (precedential); see also eBay, Inc. v. Lexos Media IP, LLC, IPR2024-00336, Paper 11 at 13–15 (PTAB Feb. 23, 2024). Patent Owner’s second argument is moot because Patent Owner’s Request for Director Review has been denied. 1243 IPR, Paper 43 (PTAB Apr. 24, 2024). Based on the facts and circumstances discussed above, we determine Petitioner has established good cause for joining the 1243 IPR. Specifically, we find that joining Petitioner to the 1243 IPR is unlikely to require any delay or modification to the scheduling order already in place for the 1243 IPR. We also determine that Patent Owner will not be prejudiced unduly by the joinder of this proceeding. Thus, we determine that granting the Motion for Joinder would help “secure the just, speedy, and inexpensive resolution” of these proceedings. See 37 C.F.R. § 42.1(b). For the above reasons, we grant Petitioner’s Motion for Joinder and join Petitioner as a party to the 1243 IPR.” slip op. at 19
§ 103 obviousnessPatents in suitUS 10,510,842 - Apple Inc. v. RJ Technology, LLCInstitutedPTAB · Aug 20, 2024 · IPR2024-00597 · APJ Jon B Tornquist · IPR · Institution
The Board instituted review of claims 1–18 on all asserted grounds and granted Apple’s motion to join IPR2023-01183.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Having considered the arguments and evidence presented by Petitioner, we determine that Petitioner has demonstrated a reasonable likelihood of prevailing on at least one of the challenged claims of the ’641 patent. Accordingly, we institute an inter partes review as to all the challenged claims of the ’641 patent on all the grounds of unpatentability set forth in the Petition. And, for the reasons set forth below, we grant Petitioner’s Motion for Joinder.” slip op. at 2
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“In considering a motion for joinder, and whether such joinder is appropriate, the Board may consider “whether a new ground of unpatentability is raised in the second petition, how the cost and schedule of the first proceeding will be impacted if joinder is granted, and whether granting joinder will add to the complexity of briefing and/or discovery.” Patent Trial and Appeal Board Consolidated Trial Practice Guide November 20197 at 76 (citing Kyocera Corp. v. SoftView LLC, IPR2013-00004, Paper 15 at 4 (PTAB Apr. 24, 2013)).” slip op. at 9
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. at 11–12 (citing Ex. 1002 ¶¶ 50–51). Upon review of the prior art of record and the Petitioner’s arguments, we adopt Petitioner’s uncontested definition of the person of ordinary skill in the art for purposes of this Decision as it appears consistent with the ’641 patent and the prior art of record.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner provides constructions for the terms “A method for improving . . . characterized in that,” “ratio of positive electrode material to negative electrode material as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V” (claim 5), “as calculated by a specific capacity with a charge voltage limited to 4.2 V” (claim 1), and “at least 7500 of capacity” (claim 11). Pet. 8–11. For purposes of this decision, we determine that no claim terms require express construction. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 8
Claim constructioncites Phillips · KSR · GrahamPatents in suitUS 7,749,641 - PTAB · Mar 26, 2024 · IPR2023-01384 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted IPR on claims 1–7 and all petitioned grounds, finding a reasonable likelihood that claims 1, 3, and 4 are unpatentable over the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“III. CONCLUSION Because Petitioner has demonstrated a reasonable likelihood that at least one challenged claim of the ’335 patent is unpatentable over the prior art of record, we institute an inter partes review of all challenged claims. And because we find some grounds sufficient for institution, we institute on all grounds in the petition. See SAS, 138 S. Ct. at 1353 (2018); PGS Geophysical, 891 F.3d at 1360. determination with respect to the patentability of any challenged claim or any underlying factual or legal issue, including claim construction. IV. ORDER For the reasons given, it is: ORDERED that, pursuant to 35 U.S.C. § 314(a), an inter partes review of claims 1–7 of the ’335 patent is instituted with respect to all grounds of unpatentability asserted in the Petition, commencing on the entry date of this Decision; and FURTHER ORDERED that, pursuant to 35 U.S.C. § 314(c) and 37 C.F.R. § 42.4, notice is hereby given of the institution of trial.” slip op. at 54
- Skill levelSkill level petitioner adoptedDecided for petitioner
“II. ANALYSIS A. Level of Ordinary Skill in the Art Petitioner asserts that a person of ordinary skill in the art would have had “at least a four-year degree in electrical engineering, chemical engineering, physics, or material science or a closely related field, and at least two years of experience in semiconductor device design and/or 1 The relevant sections of the Leahy-Smith America Invents Act (“AIA”), Pub. L. No. 112–29, took effect on March 16, 2013. Because the ’335 patent has an effective filing date prior to the effective date of the applicable AIA amendments, the pre-AIA version of § 103 applies. 2 US 2006/0108606 A1, published May 25, 2006 (Ex. 1007). 3 JP H11-261053, published Sept. 24, 1999 (Ex. 1005 (original language); Ex. 1006 (certified English translation)). 4 US 2007/0007547 A1, published Jan. 11, 2007 (Ex. 1008). 5 R.V. Shenoy, et. al, Effect of Mask Wall Angle on Shape Evolution during Through-Mask Electrochemical Micromachining, J. ELECTROCHEM. SOC., Vol. 143, No. 2, 544, Feb. 1996 (Ex. 1013). device operation, or the development of new device topologies.” Pet. 18 (citing Ex. 1003 ¶¶ 52–53). Petitioner also contends that “[a]dditional education could substitute for professional experience and vice versa.” Pet. 18. Patent Owner does not challenge Petitioner’s definition or offer its own. See generally Prelim. Resp. In light of the record before us, and for purposes of this Decision, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art. Based on our review of the ’335 patent and the prior art of record, at this stage of the proceeding we determine that the definition offered by Petitioner comports with the qualifications a person would have needed to understand and implement the teachings of the ’335 patent and the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown”) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)).” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner
“type gate material of independent claims 1 and 5 requires that the “bottom of the p-type gate material is more than 10% wider than the top of the material.” Pet. 19. We begin our analysis with the language of the claims themselves. See Phillips, 415 F.3d at 1312. Here, the claims do not recite 7 Patent Owner cites to the Lidow-508 patent itself, instead of the published application included in the record as Ex. 1011, which Petitioner cites to. The parties have not identified any difference between the two references. the bottom of the p-type gate material must be more than 10% wider than the top of the material. Ex. 1001, 5:5–6:30. Thus, the plain language of the claims themselves does not support Petitioner’s proposed construction.” slip op. at 13
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“As discussed above, however, we are persuaded, at this stage, by Petitioner’s argument that that Saxler teaches or suggests an operable enhancement-mode device. See § II.D.1.a.i, supra. Additionally, Patent Owner’s argument regarding modifications that “could be detrimental” to certain devices is not only speculation, but also comprised entirely of attorney argument. Finally, Patent Owner does not directly address Petitioner’s arguments and accompanying evidence that a person of ordinary skill in the art would have had reason to combine the teachings of Saxler and Yoshida to take advantage of simplified manufacturing steps and reduced costs. Based on the present record, Petitioner has sufficiently shown that Saxler and Yoshida disclose or suggest all of the limitations in claims 1, 3, and 4, and that a person of ordinary skill in the art would have had a reason to combine the teachings of Saxler and Yoshida with a reasonable expectation of success. Accordingly, we determine Petitioner has established a reasonable likelihood of prevailing on its challenge that claims 1, 3, and 4 are unpatentable as obvious in view of Saxler and Yoshida. For the same reasons as noted above, we decline to address Petitioner’s challenge of claims 2 and 5–7 based on Saxler and Yoshida alone at this stage. See § II.D.1.c, supra.” slip op. at 44
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 10,312,335 - PTAB · Mar 20, 2024 · IPR2023-01381 · APJ Jon B Tornquist · IPR · Institution
Instituted IPR of claims 1–12 on all petition grounds; the Board found a reasonable likelihood of success on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’294 patent. Accordingly, we institute an inter partes review as to all of the challenged claims of the ’294 patent on all of the grounds of unpatentability set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends a person of ordinary skill in the art “would have possessed at least a four-year degree in electrical engineering, chemical engineering, physics, or material science, or a closely related field, and at least two years of experience in semiconductor device design or fabrication, including the processing of semiconductor materials, analysis of device operation, or the development of new device topologies.” Pet. 5–6. Patent Owner does not address the knowledge or education of a person of ordinary skill in the art. On this record, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it appears consistent with the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“Petitioner contends the terms “compensated GaN layer” and “above” require construction. Pet. 12–17; Prelim. Reply 1–5. Patent Owner contends only the term “compensated GaN layer” requires construction. Prelim. Resp. 5–15; Prelim. Sur-reply 1–3. Upon review of the parties’ arguments and evidence, we determine that only the term “compensated GaN layer” requires construction. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“Claims Claim terms are generally given their ordinary and customary meaning, which is the “meaning that the term would have to a person of ordinary skill in the art in question at the time of the invention.” Phillips, 415 F.3d at 1313. Patent Owner does not present evidence that the ordinary meaning in the art of a “GaN layer” is “GaN gate material.” Indeed, the prior art of record discloses multiple GaN layers that do not appear to be “gate material.” Ex. 1006 ¶ 32; Ex. 1005 ¶ 74 (“the channel layer 20 is GaN”); Ex. 1008 ¶¶ 24–25 (noting that the buffer layer and semiconductor layer are GaN). Nor does Patent Owner contend that the term “compensated” requires or implies a particular orientation or location with respect to the gate contact. Thus, by itself, the term “compensated GaN layer” does not require a “compensated GaN gate material.” Rather, Patent Owner contends that given the placement of the “compensated GaN layer” above the barrier layer and below the gate contact, one of ordinary skill in the art would have understood that the claimed “compensated GaN layer” is a “compensated GaN gate material.” Prelim. Resp. 7. We are not persuaded by this argument, at this stage of the proceeding, because the prior art (Uemoto) discloses a compensated GaN layer that is above a barrier layer and below a gate contact, as recited in claim 1, and Patent Owner contends this layer is not a “compensated GaN layer.” Ex. 1006, Fig. 7; Prelim. Resp. 31–32. This tends to suggest that the placement of a “compensated GaN layer” above a barrier layer and below a gate contact, without more, does not necessarily indicate that said layer is part of the gate. In view of the foregoing, on this record, we determine that the language and structure of claim 1 does not support a construction requiring that the “compensated GaN layer” be a “compensated GaN gate material.”” slip op. at 11
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,350,294 - Mara Renewables Corporation v. DSM IP Assets, B.V.Institution deniedPTAB · Jan 25, 2024 · IPR2023-01167 · APJ Zhenyu Yang · IPR · Institution
The Board denied institution because the petition did not show a reasonable likelihood of prevailing on any challenged claim under the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“When asserting unpatentability under obviousness, the patent challenger must show a reasonable expectation of success, that is, “the likelihood of success in combining references to arrive at the claimed invention.” Intelligent Bio-Sys., Inc. v. Illumina Cambridge Ltd., 821 F.3d 1359, 1367 (Fed. Cir. 2016). Thus, “[t]he reasonable-expectationof-success analysis must be tied to the scope of the claimed invention.” Teva Pharms. USA, Inc. v. Corcept Therapeutics, Inc., 18 F.4th 1377, 1381 (Fed. Cir. 2021); Allergan, Inc. v. Apotex Inc., 754 F.3d 952, 966 (Fed. Cir. 2014) (holding the trial court’s failure to consider the appropriate scope of the claimed invention in evaluating the reasonable expectation of success constitutes a legal error). Relevant to our Decision here, claim 3 requires its microbial lipid to have, among others, at least 60% by weight DHA in the triglyceride fraction and an AV of 0.5 to 26.” slip op. at 10
- Skill levelSkill level petitioner adoptedDecided for petitioner
“For purposes of this Decision, we adopt Petitioner’s definition of the skill level because it is consistent with the prior art’s demonstration of the level of ordinary skill at the relevant time. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art).” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“We emphasize that our finding is not on lack of reasonable expectation of success per se. Instead, we merely find neither the Petition nor the Curtis Declaration persuasively addresses “the expected differences in the oxidizability and oxidation rate—and their expected impact on anisidine values—of an oil containing 42% ARA (for which Schaap discloses limited experimental data) versus one containing 60% DHA in the triglyceride fraction (for which Schaap does not).” See id. at 27. In sum, we find Petitioner has not shown sufficiently that an ordinarily skilled artisan, based on the teachings of the asserted prior art, would have had a reasonable expectation of success for the appropriate scope of the claimed invention (that is, a microbial lipid having at least 60% DHA in the triglyceride fraction and an AV of 0.5 to 26). As a result, on this record, Petitioner has not established a reasonable likelihood that it would prevail in this challenge.” slip op. at 13
§ 103 obviousnesscites PhillipsPatents in suitUS 10,392,578
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.