- Tesla, Inc. v. Intellectual Ventures II LLCNo claims unpatentablePTAB · Jun 22, 2026 · IPR2025-00217 · APJ Frederick C Laney · IPR · Final written decision
The Board held claims 1–5, 10–15, and 20 not unpatentable under four §103 grounds because the petitioner did not establish the claimed enabled-accumulation indication or single-channel combination.
RulingsFinal written decision- BurdenNot shown unpatentable
“onset to show with particularity why the patent it challenges is 1 The Leahy-Smith America Invents Act (“AIA”), Pub. L. No. 112-29, 125 Stat. 284 (2011), amended 35 U.S.C. § 103, effective March 16, 2013. Because the application from which the ’153 patent issued claims priority to an application filed before this date, the pre-AIA version of § 103 applies. 2 US 6,334,047 B1, iss. Dec. 25, 2001 (Ex. 1009). 3 US 2001/0036238 A1, pub. Nov. 1, 2001 (Ex. 1010) 4 US 2004/0190485 A1, pub. Sept. 30, 2004 (Ex. 1005). 5 US 2004/0077370 A1, pub. Apr. 22, 2004 (Ex. 1008). 6 US 6,600,772 B1, iss. July 29, 2003 (Ex. 1004). 7 US 6,529,741 B1, iss. Mar. 4, 2003 (Ex. 1007). unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016) (citing 35 U.S.C. § 312(a)(3) (requiring inter partes review petitions to identify “with particularity . . . the evidence that supports the grounds for the challenge to each claim”)). This burden of persuasion never shifts to the patent owner. See Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1378 (Fed. Cir. 2015). Moreover, a petitioner should not “place the burden on [the Board] to sift through information presented by the Petitioners, determine where each element [of the challenged claims] is found in [the cited references], and identify any differences between the claimed subject matter and the teachings of [the cited references].” Google Inc. v. EveryMD.com LLC, IPR2014-00347, Paper 9 at 25 (PTAB May 22, 2014).” slip op. at 5
- Skill levelSkill level petitioner adoptedDecided for petitioner
“A. Level of Ordinary Skill in the Art Petitioner asserts that ordinarily skilled artisans “would have a bachelor’s degree in electrical engineering, computer engineering, computer science, or equivalent training, and approximately two years of experience working in the field of wireless communication systems or design of similar communication systems.” Pet. 15. Petitioner’s proposed definition, which Patent Owner does not dispute, appears reasonable and consistent with the asserted prior art and the ’153 patent. Therefore, we adopt it as the ordinary level of skill of an artisan in the field of the patented technology for our analysis below.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownDecided for patent owner
“apparent agreement between the parties: “TPC command accumulation” refers to a process that collects and uses TPC commands from a network device to cumulatively affect transmission power. And having studied the intrinsic record of the ’153 patent, we are in accord. But, we decline to further limit the construction of “TPC command accumulation” in the manner proposed by either party––i.e., (1) each TPC command adjustment must be summed to cumulatively affect transmission power (as proposed by Petitioner) or (2) a TPC command value must be added to an integrator. Although both parties are able to point to disclosures in the ’153 Patent where the TPC command accumulation of an exemplary embodiment is described as using an integrator and/or summing each TPC command adjustment to cumulatively affect a UE’s transmission power (PO Resp. 16 (citing Ex. 1001, 3:39–43, 7:15–29, 9:27–42; Ex. 2016 ¶¶ 35–42); Pet. Reply 4–5 (citing Ex. 1001, 3:39–43, 7:2–6, 7:8–22, 9:28–40)), neither party has demonstrated persuasively that the intrinsic record of the ’153 Patent demonstrates a clear intent to limit “TPC command accumulation” to those particular embodiments.” slip op. at 11
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundReasonable expectation not foundNot shown unpatentable
“A rationale supports obviousness only where the proffered benefit would flow from the specific modification proposed; a benefit that the prior art realizes in a different structural context does not, without more, establish that the same benefit would result from inserting one reference’s element into the other. On this record, the nexus between Khan’s benefits and Petitioner’s “other bits” modification is missing.” slip op. at 40
Patent outcomesUS 10,952,153 not shown unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,952,153 - Shenzhen Tuozhu Technology Co., Ltd. v. Stratasys, Inc.No claims unpatentablePTAB · Jun 9, 2026 · IPR2025-00321 · APJ Christopher M Kaiser · IPR · Final written decision
The Board held claims 1, 2, 5–7, 9, 16, and 17 not unpatentable because the asserted combinations did not establish the required purge-tower teachings or prior-art status.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had (1) at least a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a related field, and (2) at least two years of research or industry experience in 3D printing or materials used for 3D printing.” Pet. 5 (citing Ex. 1003 ¶¶ 14–16). Petitioner also argues that “[a]dditional experience could substitute for a formal degree or formal training (and vice versa).” Id. Patent Owner proposes a slightly different level of skill, arguing that a person of ordinary skill in the art “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 24. Neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. We adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears consistent with the ’324 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownOther
“According to the ’713 patent, “[p]urge tower 24 itself may be . . . recycled or otherwise discarded as desired.” Ex. 1001, 8:27–28. This description provides some support for Patent Owner’s view, because a purge tower too intimately integrated with the part would be difficult or impossible to recycle or discard. This is further supported by the ’713 patent’s statement that “purge tower 24 may be printed at any suitable location on build substrate 44 (i.e., at any location in the x-y build plane not occupied by 3D part 20 or support structure 22).” Id. at 8:30–34. It also is supported by Dr. Hickner’s testimony that the ’713 patent “clearly shows . . . the 24 purge tower separated from the part” and that “the purge tower is a separate physical object.” Ex. 2016, 28:8–10, 64:1–9. On the other hand, there is evidence supporting Petitioner’s view that, as long as the purge tower is generally separate from the part and the support structure, it may still make contact with those portions of the print. As noted above, “purge tower 24 may be printed at any suitable location on build substrate 44 (i.e., at any location in the x-y build plane not occupied by 3D part 20 or support structure 22).” Ex. 1001, 8:30–34. This language does not exclude locations adjacent to or in contact with the part or the support structure. Thus, determine that a “purge tower,” as that term is used in the context of the ’713 patent, may not be an integrated portion of a printed part or support structure but need not be free of all contact with the printed part or support structure.” slip op. at 9
- BurdenNot shown unpatentable
“There is evidence of record to support both Petitioner’s view and Patent Owner’s view. On the record developed at trial, however, we cannot say that the preponderance of the evidence favors Petitioner, who bears the burden of proof. See 35 U.S.C. § 316(e). Accordingly, Petitioner has not shown by a preponderance of the evidence that KISSlicer teaches printing a layer of a purge tower each time the printer switches one extruder to the operating mode. Because proving the obviousness of claims 1 and 16 requires such a showing, Petitioner has not shown by a preponderance of the evidence that claims 1 and 16 would have been obvious over the combination of Priedeman and KISSlicer. 5. Analysis of Remaining Claims Claims 2, 6, 7, 9, and 17 all depend, directly or indirectly, from claim 1 or claim 16. Accordingly, they all include the limitations of either claim 1 or claim 16. Because, as discussed above, Petitioner has not shown that the combination of Priedeman and KISSlicer teaches or suggests all the limitations of claims 1 and 16, Petitioner also has not proven by a preponderance of the evidence that claims 2, 6, 7, 9, and 17 would have been obvious over that combination of references.” slip op. at 21
- Obviousness (§103) › Analogous artAnalogous artOther
“On the record developed at trial, we agree with Petitioner. According to several industry forum posts, people interested in three-dimensional printing located the website where KISSlicer was posted between February 2012 and April 2012. Ex. 1028, 1 (post discussing and directing others to KISSlicer on April 11, 2012); Ex. 1031, 1 (two posts discussing KISSlicer on March 16, 2012, and March 21, 2012); Ex. 1032, 1 (two posts discussing KISSlicer on February 11, 2012, and February 14, 2012). Thus, not only was it possible for people of ordinary skill in the art to locate KISSlicer; people of ordinary skill in the art actually did locate it. Accordingly, Petitioner has shown by a preponderance of the evidence that KISSlicer was publicly accessible.” slip op. at 19
Patent outcomesUS 9,421,713 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,421,713 - Shenzhen Tuozhu Technology Co., Ltd. v. Stratasys, Inc.All claims unpatentablePTAB · Jun 9, 2026 · IPR2025-00311 · APJ Christopher M Kaiser · IPR · Final written decision
Claims 1, 3–11, and 17–22 are unpatentable as obvious over grounds using Mazumder and Mori; grounds relying on Henke fail because Henke is not analogous art.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Electrical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printers including remote control of rapid fabrication systems.” Pet. 6 (citing Ex. 1003 ¶¶ 40–42). Petitioner also argues that “[a]dditional years of experience could substitute for an advanced-level degree (and vice versa).” Id. Patent Owner proposes a slightly different level of skill, arguing that a person of ordinary skill in the art “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Electrical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” PO Resp. 11–12. Neither party explains why the outcome of this case would be affected by the adoption of either of the proffered definitions of a person of ordinary skill in the art. We adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears consistent with the ’324 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“There is also evidence that supports Petitioner’s proposed construction, under which a user interface may display both the image and the projection if it displays them at different times. This evidence includes statements in the specification that describe displaying an image “instead” of “a rendering of a three-dimensional model” and that describe displaying a “video image and/or model projection” rather than merely a video image and a model projection. Ex. 1001, 22:43–53, 24:52–55, Figs. 5, 7. It also includes arguments in the prosecution history distinguishing Taminger on the basis of failure of disclose any display of both an image and a projection at all, rather than on the basis of failure to disclose simultaneous display of both visualizations. Ex. 1002, 160, 161. Based on our review of all the probative evidence, we find that the preponderance of the evidence supports Petitioner’s view, so we construe the challenged claims as not requiring simultaneous display of the image and the projection.” slip op. at 15
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“With the problem solved by the ’324 patent defined as monitoring automated three-dimensional fabrication processes, we find that Mori is at least reasonably pertinent to the problem. Mori discloses “[a] machining status monitoring apparatus.” Ex. 1005, code (57), ¶ 43. That apparatus uses “actual CCD cameras . . . to image the workpiece.” Id. ¶ 49. It also has a “virtual image generating section” with “virtual CCD cameras” having “view points” that “match the view points of the actual CCD cameras.” Id. ¶¶ 59, 61, 62. This disclosure relates quite closely to monitoring an automated three-dimensional fabrication process and thus is at least reasonably pertinent to solving that problem. d) Conclusion For the reasons discussed above, Mori is both in the same field as the ’324 patent and at least reasonably pertinent to the problem solved by the ’324 patent. Accordingly, it is analogous art to the ’324 patent.” slip op. at 21
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“Regarding combining the teachings of Mazumder with those of Mori, the evidence of record shows that the print head of Mazumder’s three-dimensional printer could obscure portions of the actual camera’s view of the object being printed and that displaying Mori’s virtual image of the object in addition to Mazumder’s actual image of the object “would have allowed the user to of the remote computer to monitor the progress of the object even when the actual view of the object is partially or totally obscured.” Ex. 1003 ¶ 86. c) Conclusion Regarding Claim 1 For the reasons discussed above, the preponderance of the evidence shows that claim 1 would have been obvious over the combination of Mazumder and Mori.” slip op. at 26
Patent outcomesUS 8,562,324 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,562,324 - Shenzhen Tuozhu Technology Co. Ltd. v. Stratasys, Inc.All claims unpatentablePTAB · Jun 3, 2026 · IPR2025-00257 · APJ Lilan Ren · IPR · Final written decision
Claims 1–15 are unpatentable because Petitioner proved by a preponderance of the evidence that the asserted § 103 grounds render them unpatentable.
RulingsFinal written decision- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“proceeding, we determine Petitioner has proven by a preponderance of the evidence that each of claims 1–15 of the ’660 patent is unpatentable.” slip op. at 85
Patent outcomesUS 9,592,660 unpatentable§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,592,660 - Assa Abloy AB / Assa Abloy Inc. et al. v. CPC Patent Technologies Pty, LtdNo claims unpatentablePTAB · May 27, 2026 · IPR2022-01093 · APJ Scott A Daniels · IPR · Remand
Claims 13 and 14 were not shown unpatentable because the evidence did not establish that the received card information defines the memory location for the biometric signature.
RulingsRemand decision- RemandOther
“On appeal, the U.S. Court of Appeals for the Federal Circuit reversed our Original Decision and remanded the case for further proceedings. CPC Pat. Techs. Pty Ltd. v. ASSA Abloy AB, No. 2024-1492, 2025 WL 3134960, at *1 (Fed. Cir. Nov. 10, 2025), Paper 43. The Federal Circuit also noted that in light of the affirmance of our decision in another proceeding, IPR2022- 00600, challenging the same patent, the “errors the Board made in this appeal only extends to claims 3–18, which were not at issue in the other appeal.” Id. at *3 n 1. Therefore, in this proceeding, only challenged claims 13 and 14 remain. At the request of the parties, we permitted additional briefing addressing the issues on remand from the Federal Circuit. Paper 44. Petitioner filed an opening brief (Paper 51 (“Pet. Remand Br.”)), and Patent Owner filed an opening brief (Paper 52 (“PO Remand Br.”)). Both parties also filed responsive briefs. Paper 54 (“Pet. Responsive Br.”); Paper 55 (“PO Responsive Br.”). This is a Final Written Decision on Remand addressing the patentability of the remaining challenged claims 13 and 14. To prevail, Petitioner must prove unpatentability by a preponderance of the evidence. See 35 U.S.C. § 316(e); 37 C.F.R. § 42.1(d). This Final Written Decision on Remand is issued pursuant to 35 U.S.C. § 318(a) and 37 C.F.R. § 42.73.” slip op. at 3
- BurdenNot shown unpatentable
“offers nothing to suggest that its card information ‘tells you’ where to store the fingerprint data.” ASSA ABLOY AB, 2025 WL 3134960 at *3. Reversing our determinations as to Hsu, the Court found that the testimony of Petitioner’s declarant, Mr. Lipoff, “merely confirms the associative link between the card information and the biometric data. Still missing is any non-conclusory testimony that Hsu’s card information determines the memory location of the biometric data.” Id. at 8. Therefore, on remand, a central question is whether Petitioner has shown sufficiently that Tsukamura cures this deficiency. Petitioner has not done so. In the Petition, Petitioner relies on Tsukamura for teaching a specific location for storing fingerprint data. See Pet. 75 (stating that “Tsukamura’s index number specifies the physical memory location in the memory”). Petitioner argues that “[t]hus, Tsukamura discloses defining, dependent upon the “index number N index,” a memory location for storing a biometric signature (e.g., a fingerprint template), i.e., ‘a memory location is specified by the card information.’” Id. at 75–76 (citing Ex. 1006 ¶ 215). In support, Petitioner’s declarant, Mr. Lipoff, testifies that “[i]f the Tsukamura implementation were used for Sanford-Hsu database, each user/account number would specify a different entry (index number) in the database.” Ex. 1006 ¶ 394. Tsukamura’s index number N index does not teach or suggest much more than Hsu’s using “an account number or employee number, to access a stored there during an enrollment procedure.” Compare Ex. 1004, code (57), with Ex. 1005, 4:7–11. That is, both references arguably teach defining, i.e., setting or establishing, a certain location in a database for biometric data. For example, as described above, Tsukamura’s fingerprint template Temp is stored in flash ROM 35 at a defined index number N index in the database. Id. 4:7–11, 50–54. However, neither Petitioner, nor Mr. Lipoff, persuasively explain how or why Tsukamura’s fingerprint template Temp, stored at index number N index, is commensurate with “means for defining, dependent upon the received card information, a memory location in a local memory external to the card” as recited in claim limitation 13[C]. Ex. 1001, 14:3–5 (emphasis added).” slip op. at 22
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Tsukamura’s index number N index does not teach or suggest much more than Hsu’s using “an account number or employee number, to access a stored there during an enrollment procedure.” Compare Ex. 1004, code (57), with Ex. 1005, 4:7–11. That is, both references arguably teach defining, i.e., setting or establishing, a certain location in a database for biometric data. For example, as described above, Tsukamura’s fingerprint template Temp is stored in flash ROM 35 at a defined index number N index in the database. Id. 4:7–11, 50–54. However, neither Petitioner, nor Mr. Lipoff, persuasively explain how or why Tsukamura’s fingerprint template Temp, stored at index number N index, is commensurate with “means for defining, dependent upon the received card information, a memory location in a local memory external to the card” as recited in claim limitation 13[C]. Ex. 1001, 14:3–5 (emphasis added).” slip op. at 22
- Expert testimonyPetitioner expert discountedDecided for patent owner
“Tsukamura’s index number specifies the physical memory location in the memory. Thus, Tsukamura discloses defining, dependent upon the “index number N index,” a memory location for storing a biometric signature (e.g., a fingerprint template), i.e., the memory location is specified by the index number, under the Second Construction. In my opinion, if the Tsukamura implementation were used for Sanford-Hsu database, each user/account number would specify a different entry (index number) in the database. Ex. 1006 ¶ 394. This is consistent with our understanding of Tsukamura, and we can agree that Tsukamura teaches defining—that is, setting or establishing—a location for storing the biometric signature at “index number N index.” See Ex. 1005, 4:7–11. However, considering the Federal Circuit’s decision, we determine such an associative link does not sufficiently explain how one of ordinary skill in the art would have understood Tsukamura’s IC” slip op. at 23
Patent outcomesUS 8,620,039 not shown unpatentableClaim construction§ 103 obviousnessPatents in suitUS 8,620,039 - Tesla, Inc. v. Charge Fusion Technologies, LLCAll claims unpatentablePTAB · May 13, 2026 · IPR2025-00032 · APJ Mitchell G Weatherly · IPR · Final written decision
Claims 1–29 are unpatentable as obvious under §103 based on the asserted combinations of prior art.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“understanding of a person of ordinary skill in the art at the time of the invention. Graham, 383 U.S. at 17. Petitioner submits that the ordinarily skilled artisan would have at least a bachelor’s degree in electrical or mechanical engineering (or an equivalent field) and at least two years of work experience involving automotive systems, including electric vehicle power management. . . . Additional industry experience or technical training may offset less formal education, while advanced degrees or additional formal education may offset lesser levels of industry experience. Pet. 2 (citing Ex. 1003 ¶¶ 30–32). Patent Owner “takes no position with respect to Petitioner’s proposed level of ordinary skill.” PO Resp. 17. For the purposes of our analysis below, we apply Petitioner’s proposed level of ordinary skill, which we find to be consistent with the problems addressed in the ’338 patent and the prior art.” slip op. at 10
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“Initially, we note that “amount of charge” reflects no express limitation on the manner of expressing the “amount” or the “charge.” And the Specification uses both “desired charge percent level” and “desired charge range level” as alternative ways for a user may specify an “amount of 3 As recited in independent claims 10, 19, and 28 charge.” For example, the Specification describes that a user may specify an amount of charge by specifying a desired travel distance as follows: “the user may indicate a desired charging level (and/or a desired charging level may be automatically calculated) based on a desired distance of travel.” Ex. 1001, 19:49–57 (emphasis added). Therefore, “amount of charge” may also refer to a desired mileage or range. Figure 7 further demonstrates that a user may select “amount of charge” in terms of a “percent” or a “range” as shown in Petitioner’s annotated version of the pertinent portion of that figure as shown below.” slip op. at 11
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightMotivation foundDecided for petitioner
“We disagree with Patent Owner. First, Patent Owner’s reliance on Wonderland as announcing a rule having broad effect is misplaced. Patent Owner contends that the “Federal Circuit has confirmed that where the primary reference already includes the function of the secondary reference, an allegation to incorporate that function into the primary reference is improper hindsight and no motivation to combine exists.” Id. at 29 (citing Wonderland NurseryGoods Co. v. Thorley Indus., LLC, 988 F.Supp. 2d 479, 498–99 (W.D. Pa. 2013), aff'd, 644 F. App'x 1011 (Fed. Cir. 2016); citing Kinetic Concepts, Inc. v. Smith & Nephew, Inc., 688 F.3d 1342, 1368 (Fed.Cir.2012))). Patent Owner’s citation to Wonderland does not support the proposition for which it is cited, namely that the Federal Circuit has “confirmed” that incorporating a function from a secondary reference into a primary reference is “improper hindsight” that precludes a motivation to combine teachings from the primary and secondary references. In Wonderland, the district court denied an accused infringer’s motion for summary judgment of invalidity, in part, due to its finding that genuine issues of material fact existed for the issue of whether sufficient motivation to combine prior art existed. Wonderland, 988 F. Supp. 2d at 511. The Wonderland decision does not constitute a final ruling on that issue, and the Federal Circuit’s summary affirmance of the final ruling by the district court does not address the issue or reflect how the issue was resolved at trial. Wonderland NurseryGoods Co. v. Thorley Indus., LLC, 644 F. App’x 1011 (Fed. Cir. 2016). Second, Petitioner also correctly points out that although Ferro refers to wireless charging, it provides no implementation details. Ex. 1004 ¶ 36; Ex. 2003, 54:8–55:9. Ferro also describes manual options for initiating charging, Ex. 1003¶ 146 (citing Ex. 1004 ¶ 109), and that an ordinarily skilled artisan would have been motivated to apply Oyobe’s vehicle sensor to allow a user to initiate Ferro’s charging methods more easily without the user having to leave the vehicle, Ex. 1003 ¶¶ 151, 152. Accordingly, we find that Petitioner has established that an ordinarily skilled artisan would have been motivated to incorporate Oyobe’s use of a sensor to establish presence of a vehicle near a charging station into Ferro’s system.” slip op. at 20
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“The test for obviousness is not whether the features of a secondary reference may be bodily incorporated into the structure of the primary reference. . . . Rather, the test is what the combined teachings of the references would have suggested to those of ordinary skill in the art.” MCM Portfolio LLC v. Hewlett-Packard Co., 812 F.3d 1284, 1294 (Fed. Cir. 2015). Patent Owner’s argument fails to account for the level of skill and creativity of an ordinarily skilled artisan, who would have possessed a bachelor’s degree in engineering and could have easily accounted for the differences in scale depicted by Letendre’s and Donnelly’s controls. Ex. 1003 ¶¶ 247–249. Accordingly, we find that Petitioner’s showing on the motivation to combine teachings of Ferro, Donnelly, and Letendre to arrive at limitation 1h is persuasive. slip op. at 30
Patent outcomesUS 11,563,338 unpatentableClaim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,563,338 - Assa Abloy AB / Assa Abloy Inc. et al. v. CPC Patent Technologies Pty, LtdNo claims unpatentablePTAB · May 8, 2026 · IPR2022-01094 · APJ Scott A Daniels · IPR · Remand
Claims 3–12 and 15–18 were not shown unpatentable because the asserted combinations did not establish that card information defined the memory location for storing the biometric signature.
RulingsRemand decision- BurdenNot shown unpatentable
“onset to show with particularity why the patent it challenges is unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016) (citing 35 U.S.C. § 312(a)(3) as “requiring [inter partes review] petitions to identify ‘with particularity . . . the evidence that supports the grounds for the challenge to each claim’”); see also 37 C.F.R. § 42.104(b) (requiring a petition for inter partes review to identify how the challenged claim is to be construed and where each element of the claim is found in the prior art patents or printed publications relied upon). That burden never shifts to the patentee. Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1378 (Fed. Cir. 2015). Furthermore, Petitioner cannot satisfy its burden of proving obviousness by employing “mere conclusory statements.” In re Magnum Oil Tools Int’l, Ltd., 829 F.3d 1364, 1380 (Fed. Cir. 2016).” slip op. at 10
- Skill levelOther
“B. Level of Ordinary Skill in the Art Consistent with our Original Decision, a person of ordinary skill in the art at the time of the ’039 Patent would have had at least a bachelor’s degree in computer engineering, computer science, electrical engineering, or a related field, with at least one year of experience in the field of human-machine interfaces and device access security. Additional education or experience might substitute for the above requirements.” slip op. at 11
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner
“1. Limitation 3(da) The issues on remand revolve essentially around limitation 3(da): Limitation 3(da) – storing the inputted biometric signature in a memory at a memory location defined by the provided card information; Ex. 1001, 12:61–63. Considering limitation 3(da) in our Original Decision, we explained that during an enrollment process the claimed “biometric signature,” e.g., a fingerprint, is not yet stored in the memory, and no memory location or address has been “defined,” as in “set” or “established,” in the memory for storing the fingerprint, until card information is received. Once the card information and fingerprint are received during enrollment, the card information provides data that establishes where, i.e., at what memory location or address, the system will store the fingerprint data. Original Decision 16.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentable
“Tsukamura’s index number N index does not teach or suggest much more than Hsu’s using “an account number or employee number, to access a fingerprint database (44) and retrieve reference fingerprint data previously stored there during an enrollment procedure.” Compare Ex. 1004, code (57), with Ex. 1005, 4:7–11. That is, both references arguably teach defining, i.e., setting or establishing, a certain location in a database for biometric data. For example, as described above, Tsukamura’s fingerprint template Temp is Id. 4:7–11, 50–54. However, neither Petitioner, nor Mr. Lipoff, persuasively explain how or why Tsukamura’s fingerprint template Temp is set or established “at a memory location defined by the provided card information” as recited in claim limitation 3(da). Taking a close look at Petitioner’s testimonial evidence as to claim 3, we first note Mr. Lipoff testifies that Tsukamura’s index number specifies the physical memory location in the memory. Thus, Tsukamura discloses defining, dependent upon the “index number N index,” a memory location for storing a biometric signature (e.g., a fingerprint template), i.e., the memory location is specified by the index number, under the Second Construction. In my opinion, if the Tsukamura implementation were used for Sanford-Hsu database, each user/account number would specify a different entry (index number) in the database. Ex. 1006 ¶ 394. This is consistent with our understanding of Tsukamura, and we can agree that Tsukamura teaches defining—that is, setting or establishing—a location for storing the biometric signature at “index number N index.” See Ex. 1005, 4:7–11. But, concomitant with the Federal Circuit’s point, such an associative link does not sufficiently explain how one of ordinary skill in the art would have understood Tsukamura’s IC card information to define “as in ‘set’ or ‘establish[]’” a memory location, as our claim construction requires. See Section II.C.3.” slip op. at 22
Patent outcomesUS 8,620,039 not shown unpatentableClaim construction§ 103 obviousnessPatents in suitUS 8,620,039 - Samsung Electronics Co., Ltd. / Samsung Electronics America, Inc. v. Maxell, Ltd.All claims unpatentablePTAB · Apr 27, 2026 · IPR2024-00906 · APJ Frederick C Laney · IPR · Final written decision
Claims 1, 4–6, and 8–27 are unpatentable as obvious; Judge Hudalla dissented as to claim 15.
RulingsFinal written decision- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication not establishedDecided for patent owner
“reachable through intuitive navigation from the homepage using the descriptive titles to the reference, is sufficient to demonstrate the BT-Spec was publicly accessible. See M&K Holdings, Inc. v. Samsung Electronics Co., 985 F.3d 1376, 1381 (Fed. Cir. 2021) (“The law regarding public accessibility is not as restrictive as M&K suggests—a website’s landing page is not required to have search functionality. Instead, given the prominence of JCT-VC, the dispositive question is whether interested users of the JCT-VC website could have located Park and Zhou through reasonable diligence.”). The Bluetooth SIG website itself functioned as a well-known, organized repository that a skilled artisan would naturally consult when researching Bluetooth technology. See id. at 1382 (“The Board found that the documents in question on the meeting pages of the JCT-VC website were effectively indexed by subject matter in light of the title-search functionality and the fact that Park and Zhou featured descriptive titles. That finding supports the Board’s conclusion that Park and Zhou were publicly accessible.”).” slip op. at 39
- ExcludeMotion to exclude, deniedDenied
“IV. PATENT OWNER’S MOTION TO EXCLUDE The party moving to exclude evidence bears the burden of proof to” slip op. at 139
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“12. Conclusion Based on the complete record, we find a preponderance of the” slip op. at 115
Patent outcomesUS 11,445,241 unpatentable§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,445,241 - Samsung Electronics Co., Ltd. / Samsung Electronics America, Inc. v. Maxell, Ltd.All claims unpatentablePTAB · Apr 27, 2026 · IPR2024-00907 · APJ Frederick C Laney · IPR · Final written decision
Claims 1, 4, 5, 8–12, and 14–25 are unpatentable as obvious; the majority finds the asserted combinations persuasive despite 3GPP-Spec not qualifying as prior art.
RulingsFinal written decision- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication not establishedNot shown unpatentable
“accessibility. A document hosted on the official standards body website, reachable through intuitive navigation from the homepage using the descriptive titles to the reference, is sufficient to demonstrate the BT-Spec was publicly accessible. See M&K Holdings, Inc. v. Samsung Electronics Co., 985 F.3d 1376, 1381 (Fed. Cir. 2021) (“The law regarding public accessibility is not as restrictive as M&K suggests—a website’s landing page is not required to have search functionality. Instead, given the prominence of JCT-VC, the dispositive question is whether interested users of the JCT-VC website could have located Park and Zhou through reasonable diligence.”). The Bluetooth SIG website itself functioned as a well-known, organized repository that a skilled artisan would naturally consult when researching Bluetooth technology. See id. at 1382 (“The Board found that the documents in question on the meeting pages of the JCT-VC website were effectively indexed by subject matter in light of the title-search functionality and the fact that Park and Zhou featured descriptive titles. That finding supports the Board’s conclusion that Park and Zhou were publicly accessible.”).” slip op. at 40
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundUnpatentable
“550 U.S. at 418 (citing In re Kahn, 441 F.3d 977, 988 (Fed. Cir. 2006) (“[R]ejections on obviousness grounds cannot be sustained by mere conclusory statements; instead, there must be some articulated reasoning with some rational underpinning to support the legal conclusion of obviousness.” (alteration in original)). This search for answers about whether the claimed subject matter would have been obvious to a skilled artisan at the time of the invention applies “an expansive and flexible approach.” Id. at 415. Whether a patent claiming the combination of prior art elements would have been obvious is determined by whether the improvement is more than the predictable use of prior art elements according to their established functions. Id. at 417. Reaching this conclusion, however, requires more than a mere showing that the prior art includes separate references covering each separate limitation in a claim under examination. Unigene Labs., Inc. v. Apotex, Inc., 655 F.3d 1352, 1360 (Fed. Cir. 2011). Rather, obviousness requires the additional showing that a person of ordinary skill at the time of the invention would have selected and combined those prior art elements in the normal course of research and development to yield the claimed invention. Id.” slip op. at 14
- ExcludeMotion to exclude, deniedDenied
“IV. PATENT OWNER’S MOTION TO EXCLUDE The party moving to exclude evidence bears the burden of proof to” slip op. at 158
Patent outcomesUS 10,129,590 unpatentable§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,129,590 - Yealink (USA) Network Technology Co. Ltd. / Yealink Network Technology Co., Ltd. v. Barco N.V.All claims unpatentablePTAB · Apr 7, 2026 · IPR2024-01439 · APJ Frederick C Laney · IPR · Final written decision
Claims 1–11 and 13–21 are unpatentable under § 103 based on Ono and Corbett and Uchida and Grimshaw; the Board did not find Ichieda unpatentable.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art Petitioner contends that a person having ordinary skill in the art would have had at least a Master’s Degree in Electrical Engineering with . . . five years of work experience in computer science and embedded systems, or Master’s Degree in Computer Science with . . . five years of work experience in electrical and computer engineering and embedded systems. Additional educational experience could substitute for some of the work experience. level of skill in the art.” PO Resp. 10. We adopt Petitioner’s proposed definition of a person of ordinary skill in the pertinent art, as it is consistent with the ’951 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“determine that none of the claim terms the parties provide constructions for require an express construction in this proceeding. See Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019). The parties do appear to disagree on the meaning of “trigger,” however. Although neither party actually identifies that term as needing interpretation and neither party actually provides a claim construction analysis to support its respective position, the parties do dispute whether the evidence presented shows a “trigger,” both presumably giving that term its plain and customary meaning. In other words, while both parties appear to agree “trigger” carries its plain meaning, in application, the parties’ dispute regarding the particular limitations including that term appears to turn, not over what the evidence discloses, but only on whether the disclosure satisfies the plain meaning of “trigger” (see infra § II.E.2). Accordingly, while we apply the plain meaning of “trigger” in this proceeding, and in doing so, we address which party has properly applied the plain meaning and, in doing that, we address the scope properly afforded to “trigger.” That analysis, however, is done below in the context of the limitation in which this issue arises (see id.).” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“has now been developed, and in view of both parties’ arguments, we find Petitioner has persuasively shown that modifying Ono’s peripheral device (i.e., communications module 44) to include an input device/physical actuator like the one described for Ono’s remote controller 69 to control the display of image data from a particular user’s computer would have been obvious to a skilled artisan at the time of the invention. More specifically, Petitioner has shown persuasively Ono shows that the use of an input device/physical actuator to send a signal that causes a participant’s computer to transmit and control the image data presented on a shared display in an image display system was a known technique (see Ex. 1005 ¶¶ 7, 44–48, 66– 71, 77–78, 80–89, 144, Figs. 3, 6, 8, 9; Ex. 1002 ¶¶ 85–100, 121–127) and available location for such an input device/physical actuator to initiate the transmission of data (see Ex. 1007 ¶¶ 6, 18, 20, 22–23, 26, 28, 46, Fig. 1; Ex. 1002 ¶¶ 92–100). Petitioner has also persuasively shown that a skilled artisan recognized benefits to giving a participant the ability to locally control the display of their computer’s image data. See Ex. 1002 ¶¶ 87–91; Ex. 1008 ¶¶ 4, 19–20, 27–28; Ex. 1009 ¶¶ 10–13, 39–10, 70–72. When Ono and Corbett are considered together as a whole from the perspective of a skilled artisan, therefore, it is clear that applying a similar input device/physical actuator to Ono’s peripheral device would have been recognized to result in the benefit of providing a participant with the same ability to send a signal that causes a participant’s computer to transmit and control the image data presented on a shared display from their computer within an image display system. As a result, a motivation has been established because the combination is an application of a known technique to derive a known benefit using prior art elements according to their established functions. Intel Corp. v. PACT XPP Schweiz AG, 61 F.4th 1373, 1380 (Fed. Cir. 2023).” slip op. at 24
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for petitioner
“that, from their perspective, the plain meaning of the term “trigger” does not exclude intervening steps between a user’s action on an input device and the ultimate transfer of the user selected arbitrary media content. Pet. Reply 11– 12 (indicating that “trigger” encompasses “a process that begins with and thus is triggered by a user pressing a button followed by an ‘image transfer’ from a PC to a projector”). For its part, Patent Owner maintains (at least implicitly) that intervening steps are excluded from the plain meaning. Neither party addresses with more specificity why, or why not, the scope of “trigger” supports their positions, however. Having now the complete record before us, we find that out preliminary assessment was wrong because the plain meaning of the term “trigger” does not exclude intervening steps between the cause-and-effect relationship of the trigger and the result it is intended to cause. Take, for example, a simple gun. Pulling the “trigger” to fire a gun necessarily includes intervening steps to occur: the trigger releases a hammer that, in turn, contacts a blasting cap within a bullet casing, which is what actually causes the gunpowder to ignite (i.e., fire) and expel the bullet. And there is no evidence in this record to suggest that this customary understanding of the word “trigger” is any different in the electrical arts, other than the trigger and result are generally electrical in nature, rather than mechanical. We find no clear disavowal of claim scope within the intrinsic record of the ’951 patent to indicate that the term “trigger” was intended to be understood any differently to exclude any intervening steps between a user’s action on an input device and the resulting transfer of user selected arbitrary media content. intervening steps would exist because the input device does not actually do the transferring of the media content; instead, the claims recite the transferring is “from the transmitter to the wireless communications network and [then] to the base node.” See Ex. 1001, 11:3–48, 27:62–28:1 (claim 1), 28:62–67 (claim 9), 29:42–46 (claim 16), 30:36–44 (claim 21) (emphasis added). A skilled artisan would have recognized that there would be intervening steps between the input device being acted upon and the content being displayed by base node’s display. See Ex. 1083 ¶¶ 11–12. In the claims, the input device is analogous to a gun’s trigger, the user carrying out a user action on the input device is analogous to pulling a gun’s trigger, and the transfer of user selected arbitrary media content is analogous the gun expelling a bullet. In both cases, there can be, and usually are, intervening steps, moreover, in both cases, inadvertent things can happen that may prevent the intended result (e.g., in the case of a gun, the hammer can jam; in the case of an input device, a connection can be rejected). Nevertheless, in both cases, the trigger is the thing that initiates an automated process that leads to a particular result, unless a conditional error occurs.” slip op. at 31
Patent outcomesUS 11,422,951 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,422,951
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.