- PTAB · Sep 9, 2025 · IPR2025-00440 · APJ Tawen Chang · IPR · Institution
The Board instituted IPR of claim 21 on both asserted § 103 grounds, finding a reasonable likelihood that claim 21 is obvious over Mizumura with the ’498 PCT and over Mizumura with McClymont.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority under 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons discussed below, we determine Petitioner has demonstrated a reasonable likelihood that the challenged claim of the ’318 patent is unpatentable. Accordingly, we institute an inter partes review of the challenged claim on each of the Grounds raised in the Petition. See SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018).” slip op. at 2
- Disclosure Requirements (§112) › Written description (Ariad)Not entitled to earlier dateOther
“Nevertheless, we determine that the contrary evidence Petitioner has cited suffices to establish a reasonable likelihood of success at this preliminary stage of the proceeding. In this regard, we also note Dr. Jain’s testimony — currently unrebutted — that an ordinarily skilled artisan would have known, based on Tokunaga’s sequence comparisons of Factor C proteins, that “certain sequence differences between [Limulus polyphemus] and Tachypleus tridentatus were non-conservative (i.e., potentially giving rise to changes in function in terms of enzymatic activity of Factor C).” Ex. 1002 ¶ 94 (citing Ex. 1022, 157). We likewise note Dr. Jain’s testimony that such artisan would have recognized Tokunaga’s conclusion, regarding “immunological and biochemical properties” of Factor C proteins of the two different horseshoe crab species, to be “based on only gross biophysical-biochemical properties” that are not “granular enough” to predict functional properties such as residual activity in presence of specific ions. Ex. 1002 ¶ 100.” slip op. at 22
- Disclosure Requirements (§112) › Enablement (Wands, Amgen full scope)Not enabledOther
“submitted in a different proceeding and in a different forum, and our rules contemplate objections to admissibility only after institution. See 37 C.F.R. § 42.64(b)(1) (“Any objection to evidence submitted during a preliminary proceeding must be filed within ten business days of the institution of the trial.”); also compare Fed. R. Evid. 801(c) (defining hearsay as a statement, not made at the current trial or hearing, “offer[ed] in evidence to prove the truth of the matter asserted”), with Fed. R. Evid. 801(d)(2) (excluding from hearsay statement offered against an opposing party where statement was made by “a person whom the party authorized to make a statement on the subject” or by a “party’s agent or employee on a matter within the scope of that relationship and while it existed”). Nevertheless, as discussed above, Petitioner has provided contrary evidence, including statements from Patent Owner’s patent application, suggesting that, “due to the various differences and diversity of biomolecules depending on the genus and species of the horseshoe crab,” it had not been possible “to accurately determine the full-length sequence structure, expression, and function of [Limulus] proteins and genes using conventional methods” more than 20 years after complete gene and amino sequences from two Tachypleus horseshoe crab species had been reported. Pet. 35 (citing, e.g., Ex. 1005 ¶¶ 12–17). Thus, even if we were to take the Frohman Declaration into account, we find that Petitioner has established a reasonable likelihood 28 of success that the ’767 application disclosures did not enable an ordinarily skilled artisan to make and use the invention of the challenged claim without undue experimentation. Furthermore, assuming that the disclosures in ’767 application would have enabled an ordinarily skilled artisan to express recombinant Limulus polyphemus Factor C protein in HEK293, we find Petitioner has established, sufficient for purposes of institution, that the disclosures do not enable an ordinarily skilled artisan to make such a protein exhibiting the “full scope” of the claimed residual activity, without undue experimentation. Patent Owner cites to disclosures in the ’767 application that (1) describe how to produce recombinant Factor C in HEK293 cells and measure residual activity, (2) suggest “Factor C expressed in mammalian cells can have low susceptibility to activity inhibition by ions,” and (3) provide examples where residual activity met the required minimum. Prelim. Resp. 26–27, 32–34. Nevertheless, whether an ordinarily skilled artisan would have been able to make, based on these disclosures and without undue experimentation, a recombinant Factor C protein having residual activity encompassed by claim 21 but higher — even significantly higher — than that achieved in the example, is a fact intensive issue that would benefit from further development during trial.15 See, e.g., In re” slip op. at 28
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date, deniedOther
“the proceeding, and for the reasons set forth below, we are persuaded that Petitioner has shown sufficiently, for purposes of institution, that the ’767 application does not provide adequate written description support for claim 21 of the ’318 patent and that, accordingly, Mizumura, the ’498 PCT, and McClymont qualify as prior art to the challenged claim.” slip op. at 19
§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 11,236,318 - Lululemon USA Inc. v. Nike, Inc.All claims unpatentablePTAB · Aug 6, 2025 · IPR2024-00460 · APJ Ken B Barrett · IPR · Final written decision
Claims 1–21 are unpatentable: claims 1–21 under Nishida grounds and claims 11 and 21 also over Nishida with Zuckerman; Zuckerman-only grounds fail for lack of a surrounding structure.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that: A hypothetical person of ordinary skill in the art (“POSA”) would have had at least a bachelor’s degree in textile engineering, mechanical engineering, or similar technical degree and at least 3 years of experience working with knitted textiles for use in fabric-based articles, including apparel such as footwear. Ex.1003, ¶¶34-37. For individuals with different educational backgrounds, a person could still be of ordinary skill in the art provided that person’s additional experience compensates for any differences in that person’s education as stated above. Id., ¶37. Pet. 14–15. Patent Owner states that, “[f]or purposes of this proceeding, Nike applies lululemon’s proposed level of skill in the art.” PO Resp. 13. Petitioner’s definition is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For purposes of this decision, we apply Petitioner’s definition of the person of ordinary skill in the art.” slip op. at 9
- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“Id. at 99:12–25. Dr. Brookstein stated during his deposition that he has “49 years of experience of teaching textile engineering.” Id. at 97:6–8. We credit Dr. Brookstein’s testimony over that of Dr. Pastore’s because it is consistent with the reference and based on decades of experience in the textile field. Nishida’s claim 1 states that, “during the production of the material web (1), [shoe patterns] . . . are produced by . . . a textile production method within the material web.” Ex. 1005, 9. We find that Nishida’s claim language discloses the recited, “simultaneously knitting a textile element with a surrounding textile structure.”” slip op. at 22
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“We find the District Court’s reasoning persuasive, and we, like the District Court, decline to adopt Petitioner’s overly broad proposed construction. However, for purposes of deciding the dispositive fact issue before us, we need not determine the precise boundaries of “surrounding textile structure,” for example whether it completely or mostly encircles the textile element, and if “mostly,” what percentage of encircling is required. See Pet. Reply 2 (Petitioner characterizing Patent Owner’s position as “mostly” means over 50%); id. at 4 (Petitioner impliedly arguing that the “surrounding” need not be complete, i.e., 100%); PO Sur-reply 3–4 (Patent Owner arguing that “Zuckerman’s textile structures . . . each abut only about 25% of the periphery of Zuckerman’s blank.”). We find that a person of ordinary skill in the art would not understand the portion of Zuckerman’s strip 13 in purple to surround the green blank 11 (textile element) under any reasonable construction of “surrounding textile structure.” Dr. Pastore testifies that “Zuckerman discloses two separate textile structures adjacent the blank—one on each side . . . they abut only two sides of Zuckerman’s blank, with each structure abutting only about a quarter of the blank’s periphery,” and opines that “a POSITA would not have understood these two separate structures, designated by purple in the figure above, to be a textile structure ‘surrounding’ the blank [shown in green].” Ex. 2003 ¶ 54. We find Dr. Pastore’s tesimony credible as it is consistent with Zuckerman’s Figure and with the plain and ordinary meaning of “surrounding” and with the Specification of the ’749 patent (particularly Figure 9). Dr. Brookstein’s testimony, on the other hand, is based on Petitioner’s overly broad proposed construction—that any part of a textile area that is not a textile element is “surrounding textile structure”—” slip op. at 44
Patent outcomesUS 8,266,749 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,266,749 - Skechers U.S.A., Inc. v. Nike, Inc.Institution deniedPTAB · Jun 10, 2025 · IPR2025-00141 · APJ Ken B Barrett · IPR · Institution
The Board denied institution on all challenged claims under §325(d), finding the petition relied on previously presented art and did not show material error by the Office.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDenied
“The Board uses a two-part framework in determining whether to exercise its discretion under § 325(d), specifically: (1) whether the same or substantially the same art previously was presented to the Office or whether the same or substantially the same arguments previously were presented to the Office; and (2) if either condition of [the] first part of the framework is satisfied, whether the petitioner has demonstrated that the Office erred in a manner material to the patentability of challenged claims. Advanced Bionics, Paper 6 at 8.” slip op. at 11
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“single §102 rejection based solely on Nishida.” Pet. § 325(d) Reply 3 (emphasis omitted). Specifically, Petitioner argues that: The examiner seemingly failed to consider how it would have been obvious to combine Nishida (or any other reference of record, such as Orei) with knowledge in the art, including the fact that it was “well known to use double needle-bar raschel machines . . . to knit textile elements simultaneously with surrounding textile structures” (Pet., 37–38), and that simultaneous knitting would be obvious because it would “increase yield and reduce manufacturing steps,” as explained in the Petition and supporting evidence. See Pet., 42–44. Id. (alterations in original); see also id. at 4 (Petitioner arguing that the Examiner clearly erred for “failing to seemingly even consider if it would 10 We quote here, to give context to “otherwise,” both aspects that a petitioner must demonstrate in order to meet its burden. In order to determine whether Petitioner has met its overall burden, we need not and do not reach the issue of whether “the previously presented art [Nishida] teaches the limitations of the challenged claims.” Ecto World, Paper 13 at 6. have been obvious to combine Nishida with other prior art, or to implement Nishida using well-known techniques for simultaneously knitting textile elements and surrounding structures having differing textures.”). We do not find this argument persuasive. The cited portion of the Petition is the contention that Orei—not Nishida—would render obvious claim 1. See Pet. 37–38, 42–44 (Ground 1A). Thus, Petitioner has not shown persuasively that the Examiner erred in not making an obviousness rejection based on Nishida because the disputed limitation was purportedly well-known. Additionally, Petitioner’s support for the assertion that this limitation is well-known is not persuasive. The Petition parenthetically quotes from a source stating that plural “articles . . . can be simultaneously knitted side-by-side,” not that an article (a textile element) and surrounding textile structure are known to be simultaneously knitted. See Pet. 38 (quoting Ex. 1050, 201) (emphasis added); see also Pet. § 325(d) Reply 3 (Petitioner quoting its own argument and characterizing it as a “fact” (“The examiner seemingly failed to consider . . . the fact that it was ‘well known . . . “)).” slip op. at 21
§ 103 obviousnessDiscretionary denialPatents in suitUS 8,266,749 - PTAB · Apr 25, 2025 · IPR2024-01463 · APJ David Cotta · IPR · Institution
The Board instituted inter partes review of claims 1–10 on all asserted grounds, finding a reasonable likelihood of success on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“predict how the district court in the related district court litigation will proceed because the court may determine whether or not to stay any individual case . . . based on a variety of circumstances and facts beyond our control and to which the Board is not privy.” Sand Revolution II LLC v. Cont’l Intermodal Grp., IPR2019-01393, Paper 24, 7 (PTAB June 16, 2020) (informative). We decline to speculate on how the court may rule on the pending motion to stay. Accordingly, this factor is neutral.” slip op. at 13
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), inter partes review may not be instituted unless the Petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Petitioner has established a reasonable likelihood of prevailing on its assertion that at least one of the challenged claims is unpatentable based on the grounds advanced here. We decline to deny the Petition on a discretionary basis as requested by Patent Owner. Thus, for reasons explained below, we institute inter partes review of claims 1–10 of the ’706 patent.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“TC(220), and ΔRz/Ra are result effective variables and that copper foils having ΔPD, TC(220), and ΔRz/Ra values that meet the values recited in claim 1 have advantageous properties. See, e.g., Ex. 1005 ¶ 45 (Kim ’761, disclosing that preferably the “difference in peak count roughness Rpc between the shiny surface . . . and the matte surface . . . of the electrolytic copper foil . . . is preferably 60 or less” because “when the difference in the peak count roughness Rpc exceeds 60 capacity maintenance of the secondary battery is deteriorated.”);15 Ex. 1007, 3:16–23, 4:14–23 (Cheng, disclosing that the foils of Cheng’s invention have (220) and (311) surfaces that provide increased elongation and that solve a high roughness problem that rendered traditional products unsuitable for use in a lithium ion secondary battery), 10:27–34 (Cheng, disclosing that in the foils of Cheng’s invention “the roughness difference between both sides was extremely small” and thus “it was . . . not easy for the electrolytic copper foil to break or fracture during the charging-discharging cycles and the life of a battery is thus increased”), Tables 3 & 4 (Cheng, disclosing embodiments and comparative examples with TC(220) values meeting the requirements of claim 1); Ex. 1008, 6:36–44 (Wolski, disclosing that “the surface roughness Rz at the matte side of the untreated copper foil of the present invention is the same or smaller than the surface roughness Rz at the shiny side . . . so that the surface treated copper foil . . . becomes more low-profiled . . . whereby it becomes a foil having a large etching factor”), 9:1–29 & Table 2 (Wolski, disclosing 15 Dr. Randall testifies that “Kim ’761’s peak count roughness Rpc corresponds to the peak density PD of the ’706 patent.” Ex. 1003 ¶ 52. At this stage in the proceeding, this testimony is unrebutted. 38 embodiments meeting the ΔRz/Ra of claim 1, describing them as having “matte side roughnesses” that are “sufficiently small,” and as having “excellent” “high temperature elongation characteristics”), 11:37–41 (Wolski, describing comparative examples as having “large” matte side roughnesses “whereby etching factors are not good”), 12:12–27 (Wolski, teaching that “as compared with a conventional untreated copper foil, both surfaces of the untreated copper foil obtained by [Wolski’s] invention are flat” resulting in a low profile foil that has “excellent elongations at room temperature and high temperature and also high tensile strength”). The teachings in the prior art support the presently unrebutted testimony of Dr. Randall explaining why the POSA would have been motivated to modify Kim ’761’s copper foil to have the claimed TC(220) and ΔRz/Ra. Ex. 1003 ¶¶ 66–68, 71–74; Pfizer Inc., v. Sanofi Pasteur Inc., 94 F.4th 1341, 1348 (Fed. Cir. 2024) (“Where [a gap in prior art] includes a parameter not necessarily disclosed in the prior art, it is not improper to consider whether or not it would have been recognized as result-effective. If so, then the optimization of that parameter is ‘normally obvious.’”). Accordingly, we are not persuaded by Patent Owner’s argument that Petitioner failed to articulate a sufficient motivation to combine the references. To the contrary, the preliminary record presents a strong showing that the POSA would have been motivated to combine the references in the manner described in the Petition.” slip op. at 38
- Skill levelSkill level petitioner adoptedDecided for petitioner
“At this stage of the proceeding, Patent Owner does not contest Petitioner’s definition of the level of skill in the art. Prelim. Resp. 4 (“For purposes of this Preliminary Response, Patent Owner applies Petitioner’s level of skill for a person of ordinary skill in the art”). Petitioner’s definition appears to be consistent with the field of the invention reflected in the prior art of record and the disclosure of the ’706 patent. Accordingly, for purposes of this Decision, we adopt Petitioner’s proposed definition of the person of ordinary skill in the art.” slip op. at 21
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 11,591,706 - Solus Advanced Materials Co, Ltd. v. SK Nexilis Co., Ltd.Institution deniedPTAB · Apr 22, 2025 · IPR2024-01460 · APJ Jon B Tornquist · IPR · Institution
The Board denied institution of review of claims 1–11 because the Fintiv factors, including the early trial date and close merits case, favored discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied fintivInstitution denied
“whether to institute an inter partes review. Applying the standard set forth in 35 U.S.C. § 314(a), we may not institute an inter partes review unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Institution of inter partes review, however, is discretionary. See Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1367 (Fed. Cir. 2016) (“[T]he PTO is permitted, but never compelled, to institute an IPR proceeding.”). For the reasons stated below, we exercise our discretion not to institute an inter partes review. A. Real Parties-in-Interest” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivDenied
“Board’s projected statutory deadline to issue a final written decision. Fintiv, Paper 11 at 9. “If the court’s trial date is at or around the same time as the projected statutory deadline . . . the decision whether to institute will likely implicate other factors.” Id. Conversely, “[i]f the court’s trial date is earlier than the projected statutory deadline,” this has generally weighed “in favor of exercising authority to deny institution.” Id.” slip op. at 15
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“Petition under 35 U.S.C. § 325(d) because the same or substantially the same art and arguments were before the Examiner during prosecution and Petitioner’s has not demonstrated that the Examiner erred in a material manner when allowing the claims. Pet. 17–18. Given our discretionary denial of the Petition in view of the Fintiv factors, we do not address Petitioner’s further arguments with respect to § 325(d).” slip op. at 32
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner applies Petitioner’s recited level of ordinary skill in the art for purposes of its Preliminary Response. Prelim. Resp. 4. Upon review of the parties’ arguments and the prior art of record, we adopt Petitioner’s unopposed definition of the ordinarily skilled artisan for purposes of this decision as it appears consistent with the disclosures of the ’090 patent and the prior art of record. C. Claim Construction” slip op. at 9
§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,480,090 - Kinderfarms LLC v. Genexa Inc.All claims unpatentablePTAB · Mar 24, 2025 · PGR2023-00051 · APJ Deborah Katz · PGR · Final written decision
Claims 1–24 are unpatentable as obvious under § 103 over FR458 with the ’4666 patent and WO133; claims 1–17 are also unpatentable over WO742 with the ’4666 patent and WO133.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“The parties’ positions about the level of ordinary skill in the art are similar. (See Pet., 13–14; see PO Resp., 10–12.) In light of the parties’ arguments and evidence, we determine that the ordinarily skilled artisan would have had a bachelor of science degree in a relevant life sciences field, such as chemistry, biochemistry, or pharmacy, with at least three to four years of work or laboratory experience in pharmaceutical formulations and would have had access to team members having experience in pharmaceutical formulation and pharmaceutical regulatory approvals. (See Pet. 13–14; see PO Resp. 10–12; see Dec. 6–7.) Both of the parties’ proposals as to the level of ordinary skill in the art are consistent with the disclosure of the ’795 patent and the asserted prior art. The distinction between the parties’ proposals is minimal and would not change the outcome of this Decision. Thus, we adopt and apply Patent Owner’s proposal.” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Although Petitioner puts forth constructions for terms in the claims of the ’795 patent, Patent Owner argues that we need not expressly construe any terms to resolve the controversy between the parties. (See Pet. 14–19; see PO Resp. 12.) Except as indicated below, we agree that express construction of the claim terms is not required because the parties do not materially dispute the meanings of the terms. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). Limitation (c) of claim 1 recites “syrup formulation” once and then “syrup” by itself twice. The parties agree that two recitations of “syrup” by itself mean and are synonymous with “syrup formulation.” (See Tr. 15:16– 19 (counsel for Petitioner: “[T]he term, syrup, by itself, means the formulation. And for that reason, we--it’s our position that it’s the syrup formulation that has the specific viscosity requirements as well as the other features that we discussed.”); 31:17–20 (counsel for Patent Owner: “But those wherein clauses, what it’s referring to, the syrup formulation and the syrup -- it was all to a complete to a final formulation, right, it’s not just the agave syrup. Everybody here recognizes and understands that from that perspective.”).) Thus, the parties agree that the “viscosity of less than 1500 centipoise at about 22 degrees” limits the final “pharmaceutical syrup formulation for oral administration,” not the “agave syrup” limitation in limitation (b) of claim 1.” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundUnpatentable
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner
“Patent Owner argues further that Dr. Crowley testifies that, “[g]enerally, suspensions having a viscosity in the range of 20 to 150 cP are considered readily pourable,” but that this range is well below the viscosity range of 200–900 cP taught in WO133 and the preferred viscosity range of 1000–3000 cP taught in the ’4666 patent. (See PO Resp. 45 (quoting Ex. 1003 ¶ 59).) Dr. Crowley testifies that “increasing the viscosity of a suspension formulation has been shown to impair the dissolution characteristics of immediate release acetaminophen” and that, “[w]ith respect to suspensions for oral administration, having a higher viscosity is generally not desirable.” (Ex. 1003 ¶ 59.) According to Patent Owner, this is a “teaching away” because Petitioner’s own expert testimony demonstrates a motivation not to combine the acetaminophen formulation of FR458- Example 1 with the 1000-3000 cP range of the ’4666 patent and the 200-900 cP range of WO133 since by his own admission doing so would yield bad results (i.e., impairing the dissolution characteristics of the acetaminophen) and generally undesirable higher viscosity. (PO Resp. 46 (citing Berkland Decl., Ex. 2009 ¶ 148).) Dr. Crowley’s cited testimony, however, is about general characteristics of suspensions for oral administration, whereas the WO133 refers specifically to sweetened analgesic formulations. (See Ex. 1006, 8:1– 3 (“The viscosity of the acetaminophen composition generally ranges from about 200–900 centipoise, preferably from about 300–700 centipoise.”); see Pet. Reply 8–9.) As Petitioner notes, Dr. Crowley also testifies that the viscosity of 29 commercially available, pediatric liquid oral antibiotic formulations were measured and determined to range from 20 to 1,780 cP” and that “[t]he viscosity of Children’s Tylenol has been reported to be less than 1,000 centipoise at shear rates between 0.05 and 0.2 reciprocal seconds.” (Ex. 1005 ¶ 58.) Thus, we are not persuaded that Dr. Crowley’s testimony contradicts the teachings regarding viscosity of analgesic formulations in the cited prior art.” slip op. at 23
Patent outcomesUS 11,617,795 unpatentableClaim construction§ 103 obviousnessPatents in suitUS 11,617,795 - Innoscience (Zhuhai) Technology Company, Ltd. / Innoscience America, Inc. v. Efficient Power Conversion CorporationNo claims unpatentablePTAB · Mar 18, 2025 · IPR2023-01383 · APJ Kimberly Mcgraw · IPR · Final written decision
Claims 1–5 were not shown unpatentable because Petitioner did not sufficiently establish a reason to modify the asserted prior art.
RulingsFinal written decision- Expert testimonyPatent owner expert creditedDecided for patent owner
“We disagree with Petitioner’s argument because it fails to address Dr. Schubert’s academic and other experience with GaN transistors. Dr. Schubert is currently a tenured full professor in the Department of Electrical Computer, and Systems Engineering at Rensselaer Polytechnic Institute and was previously a tenured full professor in the Department of Electrical and Computer Engineering at Boston University. Ex. 2001, 129. Additionally, Dr. Schubert was the director of Boston University’s Semiconductor Devices Research Laboratory. Ex. 2001, 129. Dr. Schubert persuasively explains that his general expertise is in the field of electrical engineering and applied physics, including semiconductors, processing, and devices and his specific expertise is in the field of semiconductor materials (such as GaN), semiconductor devices, semiconductor integrated circuits, ohmic contacts, Schottky contacts, HEMTs, and optoelectronic devices such as light-emitting diodes (LEDs). Ex. 2001 ¶ 11, App’x A pp.129–137. His experience includes “the design, growth, fabrication, and testing of semiconductor devices as well as the employment of these devices in a variety of applications” and he is “familiar with both the design of such transistors [HEMTs] and the manufacturing processes used for FETs. Ex. 2001 ¶ 11, App’x A, pp. 129–137. He is an author or co-author of numerous text books and articles, and co-inventor of numerous patents, including those dealing with HEMT transistors and GaN devices. Ex. 2001 ¶ 13, App’x A, pp. 129–137. Petitioner fails to present any persuasive argument or evidence that Dr. Schubert’s extensive education and experience regarding GaN transistors is insufficient or lacking such that his testimony should be given little weight. Finally, we disagree with Petitioner’s additional argument that that its expert’s testimony (Dr. Shealy) should be given more weight than Patent Owner’s expert’s testimony (Dr. Schubert) because “[u]nlike Dr. Schubert, Dr. Shealy is one of the pioneer scientists in the field of GaN transistors.” Reply 34 (stating that Dr. Shealy’s research lab built the first GaN HEMT device on silicon in 1999 and citing Ex. 2002, 87:19–238). Obviousness is determined through the lens of a “person of ordinary skill in the art,” not through the lens of a person with extraordinary skill or a pioneer in the field. Given Dr. Schubert’s extensive relevant education and experience, Petitioner does not persuasively explain why Dr. Shealy’s testimony on any specific topic, or his testimony in general, should be given more weight than Dr. Schubert’s.” slip op. at 16
- Skill levelSkill level petitioner adoptedDecided for petitioner
“understanding of a person of ordinary skill in the art (sometimes abbreviated herein as “POSITA”). Graham, , 383 U.S. at 17–18. Petitioner argued that a person of ordinary skill in the art would have had a “at least a four-year degree in electrical engineering, chemical engineering, physics, or material science or a closely related field and at least two years of experience in semiconductor device design or fabrication, including the processing of semiconductor materials, analysis of device operation, or the development of new device topologies. Additional education could substitute for professional experience and vice versa.” Pet. 11 (citing Ex 1003 ¶ 69). Patent Owner did not dispute this proposed definition prior to institution. See generally Prelim. Resp. In our Decision on Institution, we adopted Petitioner’s proposal. After institution, Patent Owner asserted a slightly different definition of a POSITA, namely someone who “would have possessed at least a four-year degree in electrical engineering, physics, material science, or a closely related field, and three years of professional work experience in the epitaxial growth, design, and fabrication of semiconductor electronic devices, including those of GaN.” Resp. 17. Relevant graduate education could substitute for the professional work experience. Id. Upon review of the full record, we see no reason to modify, and we thus maintain, the definition of a POSITA applied in our Decision on Institution. We also determine that our decision would be the same under either of the parties’ proposed definitions.” slip op. at 14
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Not reached
“During the proceeding, the parties also dispute the proper construction of “etching away the doped GaN layer, except a portion of the doped GaN layer beneath the gate contact” as recited in step [1e4] and provided briefing on this issue. Papers 35, 36, 37, 38. Because, as explained below, our determination rests upon Petitioner’s failure to show a sufficient reason to modify the asserted art, which is not dependent upon any particular claim construction, we need not, and do not, address these claim construction issues. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the controversy).” slip op. at 13
- ExcludeDenied
“III. PETITIONER’S MOTION TO EXCLUDE EXHIBIT 2008 Petitioner filed a Motion to Exclude (Paper 25, “Mot.”) Exhibit 2008, which is a hearing transcript from the parallel ITC investigation. Mot. 1. Because we do not rely upon Exhibit 2008 in our Decision, we dismiss Petitioner’s motion as moot.” slip op. at 47
Patent outcomesUS 8,404,508 not shown unpatentableClaim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 8,404,508 - Motorola Solutions, Inc. v. Sta Group LLCSome claims unpatentablePTAB · Mar 6, 2025 · IPR2023-01292 · APJ David C Mckone · IPR · Final written decision
Claims 1–4, 6–10, and 17–21 are unpatentable over Ohel; claims 5 and 11–16 were not shown unpatentable over Ohel or Nigawara.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“III. ANALYSIS A. Level of Skill in the Art Petitioner, relying on the testimony of Mr. Williams, contends that a person of ordinary skill in the art “would have had at least a bachelor’s degree in computer science, electrical engineering, or a similar field, and would have had approximately two years industry experience in networking or communication systems.” Pet. 3 (citing Ex. 1002 ¶¶ 55–58). Patent Owner does not dispute Petitioner’s proposal. PO Resp. 9. Petitioner’s proposal is consistent with the technology described in the Specification and the cited prior art. On the complete record, we adopt this level of skill.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“We have considered the parties’ citations to the specification and find examples that support Petitioner’s view that the term “entity” is broad enough to encompass dispatchers and individual users. See e.g., Ex. 1001, 3:52–4:5, 7:18–20, Fig. 1). However, we find no disclosure that redefines “entity” or excludes dispatchers and individual users from the category of “entity.” Patent Owner’s best examples (e.g., Ex. 1001, 1:15–21, 3:59–62) are no more than non-limiting examples. On the complete record, we conclude that “entity” is broad enough to include dispatchers and individual users.” slip op. at 20
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“have used a queue with Ohel’s system. This is insufficient because it does not provide evidence of a reason why a skilled artisan would have implemented Ohel’s system with a queue. See Auris Health, Inc. v. Intuitive Surgical Operations, Inc., 32 F.4th 1154, 1158 (Fed. Cir. 2022) (“The motivation-to-combine inquiry asks whether a skilled artisan ‘not only could have made but would have been motivated to make the combinations . . . of prior art to arrive at the claimed invention.’” (quoting Belden Inc. v. Berk- Tek LLC, 805 F.3d 1064, 1073 (Fed. Cir. 2015) (emphasis omitted))).” slip op. at 35
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightNot reached
“have used a queue with Ohel’s system. This is insufficient because it does not provide evidence of a reason why a skilled artisan would have implemented Ohel’s system with a queue. See Auris Health, Inc. v. Intuitive Surgical Operations, Inc., 32 F.4th 1154, 1158 (Fed. Cir. 2022) (“The motivation-to-combine inquiry asks whether a skilled artisan ‘not only could have made but would have been motivated to make the combinations . . . of prior art to arrive at the claimed invention.’” (quoting Belden Inc. v. Berk- Tek LLC, 805 F.3d 1064, 1073 (Fed. Cir. 2015) (emphasis omitted))).” slip op. at 35
Patent outcomesUS 7,324,802 mixedClaim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 7,324,802 - PTAB · Feb 25, 2025 · IPR2024-01294 · APJ Michael J Fitzpatrick · IPR · Institution
The Board instituted IPR on claims 1, 12, 25, and 26 on all asserted grounds, finding a reasonable likelihood that claim 1 is anticipated by Zwinkels.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“3. Conclusion Regarding Claim 1 Petitioner has demonstrated a reasonable likelihood of prevailing on its challenge to claim 1 as unpatentable under 35 U.S.C. § 102 as anticipated by Zwinkels. D. Remaining Claims of Ground 1 and Grounds 2 and 3 The threshold for institution is a reasonable likelihood of Petitioner prevailing as to any single claim. 35 U.S.C. § 314(a). “Once that single claim threshold is satisfied, it doesn’t matter whether the [P]etitioner is likely to prevail on any additional claims.” SAS Institute, Inc. v. Iancu, 138 S. Ct. 1348, 1356 (2018). Thus, because we have decided to grant review of claim 1, we do the same for all claims challenged and all grounds raised. Id.; see also 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”). III. CONCLUSION For the reasons discussed above, we are persuaded that Petitioner has demonstrated a reasonable likelihood of prevailing in establishing that at least one of the challenged claims is unpatentable. IV. ORDER In consideration of the foregoing, it is hereby ORDERED that the Petition is granted and inter partes review is hereby instituted as to claims 1, 12, 25, and 26 of U.S. Patent No. 10,434,394 B2 on the grounds presented; and” slip op. at 15
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“to move forwardly and rearwardly relative to the frame. Pet. 33–38. For example, paragraph 20, as cited by Petitioner, discloses that the rollers “are movably suspended in the frame in vertical direction, wherein the suspension of said roll or rollers is arranged to convert relative horizontal movements of the roll or rollers into vertical movements thereby compensating and/or attenuating said horizontal movements by gravity.” Ex. 1004 ¶20 (cited at Pet. 34). Further, Zwinkels attributes the forward and rearward movement to the use of the bicycle by the person exercising on it. See Ex. 1004 ¶27 (describing the “horizontal movements induced by the accelerations and decelerations of the training cyclist”) (cited at Pet. 35). Petitioner also cites multiple figures that illustrate forward and rearward movement. Pet. 35–37 (reproducing Ex. 1004, Figs. 3, 5, and 6). There is a reasonable likelihood Zwinkels teaches “wherein the movable interconnection of the upper member with the lower member is configured to enable the upper member to move forwardly and rearwardly in the fore-aft direction relative to the lower member in response to fore-aft forces that are transferred to the upper member from the item of exercise equipment in response to use of the item of exercise equipment,” as recited in claim 1. e) “wherein the movable interconnection of the upper member with the lower member is further configured to provide upward and downward movement of the upper member relative to the support surface during movement of the upper member forwardly and rearwardly in the fore-aft direction relative to the lower member.” Petitioner argues that Zwinkels’s pendulum arms 6 enable the rollers to move upward and downward relative to the frame while the rollers are also moving forwardly and rearwardly relative to the frame. Pet. 39–42. For example, paragraph 24, as cited by Petitioner, discloses that the pendulum arms connecting the rollers at fixed pivoting points on the frame “provides an easy and effective solution for absorbing and attenuating horizontal movements by converting these horizontal movements to vertical movements.” Ex. 1004 ¶24 (cited at Pet. 39). Petitioner also reproduces Figures 5 and 6, which illustrate the displacement of rollers in both the vertical and horizontal directions. Pet. 40 (citing Ex. 1004, Figs. 5–6). Figure 5 is reproduced below. Figure 5, reproduced above, “shows the embodiment in which there are two rollers 4 for the bicycle back wheel.” Ex. 1004 ¶34. Figure 5 shows two configurations of the embodiment on left and right sides. Ex. 1004 ¶34, Fig. 5. The configuration “at the left of FIG. 5 shows the pendulum arms 6 in a resting position, whereas the [configuration] on the right shows the pendulum arms 6 after they have due to the connecting link 7 concertedly moved to the right due to a force FH, causing that the rollers 4 have moved vertically upwards.” Ex. 1004 ¶34. There is a reasonable likelihood Zwinkels teaches “wherein the movable interconnection of the upper member with the lower member is further configured to provide upward and downward movement of the upper member relative to the support surface during movement of the upper member forwardly and rearwardly in the fore-aft direction relative to the lower member,” as recited in claim 1. f) “wherein the upper member is oriented parallel to the support surface plane during movement of the upper member relative to the lower member in the fore-aft direction and during upward and downward movement of the upper member relative to the support surface” Petitioner argues that Zwinkels’s rollers are oriented parallel to the ground or floor at all times. Pet. 42–44. Petitioner argues that this is clearly shown in Figure 5, which we reproduced in the immediate section above. See Pet. 43 (citing and annotating Ex. 1004, Fig. 5). We agree. There is a reasonable likelihood Zwinkels teaches “wherein the upper member is oriented parallel to the support surface plane during movement of the upper member relative to the lower member in the fore-aft direction and during upward and downward movement of the upper member relative to the support surface,” as recited in claim 1. 3. Conclusion Regarding Claim 1 Petitioner has demonstrated a reasonable likelihood of prevailing on its challenge to claim 1 as unpatentable under 35 U.S.C. § 102 as anticipated by Zwinkels.” slip op. at 12
- Novelty / Anticipation (§102) › Prior-art status of a reference › Patents / published applications (effective date, provisional support)Reference is prior artDecided for petitioner
“1. Zwinkels (Ex. 1004) Zwinkels was filed November 4, 2010, and published June 9, 2011. Ex. 1004, codes (22), (43). Petitioner argues that, based on its filing date, “Zwinkels is thus prior art under at least 35 U.S.C. § 102(a)(2).” Pet. 15. On the record presented, we agree. In addition, the current record supports that, based on its publication date, Zwinkels is prior art also under 35 U.S.C. § 102(a)(1).” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner does not propose an express construction of any term of claim 1. See Pet. 14 (“Petitioner submits that for the purposes of this proceeding, the terms of the challenged claims should be given their plain and ordinary meaning, and no terms require specific construction.”). At this stage of the proceeding, we discern no need to provide an express construction of any term of any claim.” slip op. at 8
Claim construction§ 102 anticipationPatents in suitUS 10,434,394 - Amphenol Corp. v. PPC Broadband, Inc.All claims unpatentablePTAB · Feb 19, 2025 · IPR2023-01363 · APJ Jon B Tornquist · IPR · Final written decision
Claims 1, 2, and 10–13 are unpatentable as obvious over the stated combinations of Holmberg, Battey, Blankenship, and Cowen.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends a person of ordinary skill in the art “would have had at least a bachelor’s degree in electrical engineering, computer engineering, or a related field, and at least 1 year of experience related to communication networks or the equivalent.” Pet. 7. Petitioner further contends that “[a]dditional education could substitute for professional experience or significant experience in the field could substitute for formal education.” Id. at 7–8 (citing Ex. 1003 ¶¶ 29–31). Dr. Eldering agrees that one of ordinary skill in the art “would have had at least a bachelor’s degree in electrical engineering, computer engineering, or a related field, and at least one year of experience related to communication networks or the equivalent.” Ex. 2001 ¶ 24. According to Dr. Eldering, “[a] person with less relevant practical experience but with additional experience would also qualify.” Id. Patent Owner contends that” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Although Patent Owner disagrees with Petitioner’s construction, it contends “the Board need not resolve this claim construction dispute because Petitioner’s proposed grounds 1-5 are all insufficient under either construction.” PO Resp. 19. Upon review of the parties’ arguments and the prior art of record, we determine that no claim terms require express construction for purposes of this decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). For example, we discuss below in Section III.G why we do not reach the claim construction issue presented by Petitioner.” slip op. at 11
- Expert testimonyPetitioner expert creditedDecided for petitioner
“We find that Holmberg expressly contemplates using its wall box within multi-dwelling units, notes that multi-dwelling wall boxes in the prior art were “typically provided” on every floor, and discloses that the multi-dwelling wall boxes would contain optical couplings for each resident on a given floor. Ex. 1004 ¶¶ 7, 34; Pet. Reply 8–10. In view of these disclosures, we credit the testimony of Dr. Kiaei that one of ordinary skill in the art would have sought to use Holmberg’s wall box in multi-dwelling units and would have seen a need to access the area behind spice tray 230 to connect and disconnect subscribers. Ex. 1003 ¶ 92; Ex. 1033 ¶¶ 7–8. Moreover, even if Holmberg were limited to mid-span locations and distributing drop cables, as opposed to distribution cables for individual subscribers, as asserted by Patent Owner, Patent Owner does not dispute that a technician would still need periodic access to the area behind splice tray 230 in these mid-span devices. Tr. 38:3–39:1 (counsel agreeing that one would need to access the area behind splice tray 230 in Holmberg, albeit in “rare occasions”); Ex. 1003 ¶¶ 90–92; Ex. 1033 ¶¶ 7–8. Thus, whether used in the manner contemplated by Petitioner or Patent Owner, Petitioner persuasively demonstrates that access to the space behind splice tray 230 in Holmberg would be necessary. With access behind splice tray 230 required, Petitioner persuasively demonstrates that one of ordinary skill in the art would have seen a benefit to replacing Holmberg’s fasteners or screws with a hinged connection, such as that disclosed in Battey, to allow easier access to the area behind the splice tray. Pet. 41 (citing Ex. 1005 ¶ 39 (disclosing that a rotatable splice tray or shelf would “provide[] full and convenient access to the splice tray”)). First, Petitioner and Dr. Kiaei persuasively demonstrate that once the fibers of Holmberg are routed from behind splice tray 230 and the distribution cables spooled on this tray, a technician could not reasonably access fiber optic cables stored behind splice tray 230 without releasing or opening splice tray 230. Pet. Reply 14–15 (citing Ex. 1023, 60:20–61:15); Ex. 1033 ¶¶ 31–32. Second, Petitioner persuasively demonstrates that without a hinged connection, the technician would have to either hold the splice tray of Holmberg with one hand while performing the necessary routing and splicing steps, two screws would need to remain in place (essentially replicating a hinge), or the tray would have to be left to dangle, supported only by the routed and spliced fibers. Pet. Reply 19–20.” slip op. at 22
- Strike new argumentNew argument consideredDecided for petitioner
“Allegedly New Arguments on Reply Patent Owner contends that Petitioner’s arguments regarding the benefits of a hinged connection when performing the splicing and routing steps should be dismissed or ignored because they were improperly raised for the first time on reply. Sur-reply 19–20. We disagree. The Petition asserts that one of ordinary skill in the art would have sought to add a hinged connection, such as that disclosed in Battey, in Holmberg and would have seen a benefit to so doing. Pet. 40–44. Petitioner did not change its proposed combination or its stated rationale in its Reply. Rather, in response to Patent Owner’s counter-arguments, Petitioner expands upon the benefits of its proposed combination, i.e., the substitution of a hinged connection in place of fasteners. Pet. Reply 15–21. This is permissible, as a reply may properly expand on or extend previously raised arguments relating to the motivation to make the proposed changes to the prior art. See Rembrandt Diagnostics, LP v. Alere, Inc., 76 F.4th 1376, 1385 (Fed. Cir. 2023) (explaining that the reply arguments properly relied on the same legal ground, the same prior art references, and same legal argument—the motivation to make the proposed changes to the prior art reference).” slip op. at 25
Patent outcomesUS 9,008,483 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,008,483
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.