- Cambridge Industries USA, Inc. v. Applied Optoelectronics, Inc.Rehearing deniedPTAB · Dec 19, 2025 · IPR2025-00434 · APJ Mitchell G Weatherly · IPR · Rehearing
The Board denied Petitioner’s rehearing request, leaving institution denied because Shen and Soldano did not establish a reasonable likelihood of anticipating claims 1–7.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“When rehearing a decision on petition, the Board will review the decision for an abuse of discretion. See 37 C.F.R. § 42.71(c). An abuse of discretion may be determined if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors. See Arnold P’ship v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004). The party challenging the decision has the burden of showing the decision should be modified, and the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed” in its papers. 37 C.F.R. § 42.71(d).” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“II. ANALYSIS In our Decision, we concluded that Petitioner had failed to carry its burden of demonstrating a reasonable likelihood of prevailing that either Shen or Soldano anticipated claims 1–7. Dec. 18, 26. Petitioner argues that we should institute review for three reasons. First, Petitioner argues that we abused our discretion by (a) “refusing” to interpret the scope of the claimed” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Owner’s interpretation of “carrier” as meaning “one or more components for supporting ROSA components such as an AWG.” Dec. 9 (quoting Pet. 11). For our analysis of Petitioner’s challenges, we referred to this interpretation of “carrier” as Petitioner’s second alternative construction. Id. We also noted that Petitioner appeared to dispute Patent Owner’s interpretation when it argued that “carrier” should mean “a ceramic or silicon substrate.” Id. (quoting Pet. 10). We referred to this interpretation of “carrier” as the first alternative construction. Id. Rather than resolve this apparent dispute about the meaning of “carrier,” we found that both of Petitioner’s anticipation challenges failed under both interpretations of “carrier.” Id. at 10–26. Because we found that Petitioner had failed to carry its burden regardless of which interpretation of “carrier” applied, we found it unnecessary to resolve the dispute over that interpretation. Id. at 9–10. For the reasons expressed in Parts II.B–C below, we maintain our conclusion that Petitioner has failed to demonstrate a reasonable likelihood of proving that either Shen or Soldano anticipates any claim under either interpretation of “carrier.” Accordingly, Petitioner fails to demonstrate an abuse of discretion in our alleged “refusal” to interpret “carrier.”” slip op. at 3
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“Reh’g Req. 14. We cannot weigh Petitioner’s arguments based on its assertions about “caselaw” because Petitioner cited no cases to support its arguments. See id. Nevertheless, we infer that Petitioner intends its statements of “caselaw” to refer to the requirements to make out a case for anticipation. If so, Petitioner demonstrably miscasts what appear to be the legal principles for proving anticipation. As stated in our Decision: “A claim is anticipated only if each and every element as set forth in the claim is found, either expressly or inherently described, in a single prior art reference.” Verdegaal Bros., Inc. v. Union Oil Co. of California, 814 F.2d 628, 631 (Fed. Cir. 1987).” Dec. 7. Making a showing that a prior art reference anticipates a patent claim thus necessarily requires proof that a single reference “expressly or inherently” describes every element of that claim and with all elements being arranged in the reference as they are in the” slip op. at 7
Claim construction§ 102 anticipationPatents in suitUS 10,379,301 - Texas Instruments Incorprated v. Parkervision, Inc.All claims unpatentablePTAB · Nov 21, 2025 · IPR2024-00934 · APJ Michael R Zecher · IPR · Final written decision
Claims 19–21 are unpatentable as obvious over DeMaw and, separately, over Macnally.
RulingsFinal written decision- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“1. Principles of Law A claim is unpatentable under § 103(a) if the differences between the” slip op. at 16
Patent outcomesUS 7,496,342 unpatentable§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,496,342 - PTAB · Nov 6, 2025 · IPR2025-00223 · APJ Iftikhar Ahmed · IPR · Institution
The Board instituted IPR on claims 1–18, finding a reasonable likelihood that claims 1, 10, and their dependents are obvious over Seshadri and Biederman.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2022). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Based on the information presented in the Petition and the supporting evidence, we are persuaded that there is a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims. Accordingly, we institute an inter partes review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person having ordinary skill in the art would have had “a bachelor’s degree in electrical engineering or a similar major with at least two years of experience in the field; or a master’s degree with specialization in the field.” Pet. 14 (citing Ex. 1003 ¶¶ 37–38). In addition, Petitioner asserts that “[a] person with less education but more relevant practical experience may also meet this standard.” Id. Petitioner’s proposal is undisputed at this stage. See generally Prelim. Resp. For purposes of this Decision, and based on the current record, we adopt Petitioner’s assessment of the level of ordinary skill, except we decline to adopt “at least” as that language is vague and open-ended. Otherwise, we find, based on the preliminary record before us, that Petitioner’s proposed level of ordinary skill is consistent with the ’943 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); GPAC Inc., 57 F.3d at 1579.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner proposes a construction for the claim term “programmable logic device” as “an [Integrated Circuit] where the user can alter the connection pattern of the circuits,” but contends that for this inter partes review, the art asserted in each of Petitioner’s grounds teaches a “programmable logic device,” irrespective of whether that construction is adopted. Pet. 15 (citing Ex. 1001, 3:8–12,11 4:30–47; Ex. 1002, 130–132; Ex. 1029, 18;12 Ex. 1030, 1413). At this juncture, Patent Owner does not propose express constructions for any claim terms. See generally Prelim. Resp. For purposes of this Decision, we determine that no claim terms require express construction. See Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“have been a matter of “combin[ing] prior art elements according to known methods to yield” “the predictable result of partitioning the client-configurable circuit [of Seshadri] into distinct areas for customer logic from different users.” Pet. 34 (citing Ex. 1003 ¶ 100). This combination, according to Petitioner, would “serve[] more users with a smaller number of FPGAs, providing cost savings for cloud providers and reducing the entry barrier,” as well as “improve[] performance by reducing assignment switching of FPGAs.” Id. at 35 (citing Ex. 1003 ¶ 101). In addition, Petitioner asserts that this combination would have had a reasonable expectation of success because “Seshadri would still be used to sandbox client-configurable circuits in an FPGA” and “Biederman would still be used for partitioning.” Id. (citing Ex. 1003 ¶ 102). Patent Owner does not specifically respond to these arguments. See Prelim. Resp. 19 n. 7. On the current record, Petitioner provides adequate reasoning, with rational underpinning, why an ordinarily skilled artisan” slip op. at 15
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 10,985,943 - CQV Co., Ltd. v. Merck Patent GmbHNo claims unpatentablePTAB · Oct 14, 2025 · PGR2021-00054 · APJ Kristina M Kalan · PGR · Remand
Claims 1–22 were not shown unpatentable because Sample C was not proven publicly available as prior art, and the original decision found the remaining grounds insufficient.
RulingsRemand decision- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication not establishedNot shown unpatentable
“We agree with Patent Owner that Petitioner’s evidence in Kuntz (Ex. 1026), the Annual Report (Ex. 1028), Masuko (Ex. 1029), and Pfaff (Ex. 1034) is insufficient to show that Xirallic® Sample C was available to the public before the effective filing date of the ’861 patent. Petitioner has not asserted, nor do we find, that any of these documents refer to or describe the lot of Xirallic® from which Sample C was taken. See Final Dec. 26. Kuntz, the Annual Report, Masuko, and Pfaff may support a finding that the Xirallic® line of products was available to the public, but these documents do not support a finding that the lot of Xirallic® from which Sample C was taken was available to the public. We also agree with Patent Owner that the Technical Data Sheets (Exs. 1005–1010), Certificates of Analysis (Exs. 1011–1017), and Material Safety Data Sheet (Ex. 1025) are insufficient to show that Xirallic® Sample C was available to the public. Petitioner has not asserted, nor do we find, that any of these documents refer to or describe the lot of Xirallic® from which Sample C was taken. See Final Dec. 26–27. Regardless of how the Technical Data Sheets were used in the Opposition against the European counterpart of the ’861 patent (Exs. 1040, 1041) and during the prosecution of the application from which the ’861 patent issued (Ex. 1003, 102–104), the Technical Data Sheets do not refer to or describe the lot of Xirallic® from which Sample C was taken. Moreover, as noted by Patent Owner, the Technical Data Sheets (Exs. 1005–1010) indicate that they are “preliminary” and Petitioner has not provided any evidence that the Technical Data Sheets were ever issued to the public, as opposed to just issued internally. See PO Resp. 18–19. We also find persuasive Patent Owner’s argument that the Technical Data Sheets are preliminary because other, later-dated technical data sheets (Exs. 2012, 2013) lack the “preliminary” label and list characteristics that are different from those in Exhibits 1005–1010. See PO Resp. 19 (comparing, e.g., Ex. 1009 and Ex. 2013; Ex. 1005 and Ex. 2012). The Technical Data Sheets may support a finding that the Xirallic® products they describe existed as of the dates on the documents, but they do not support a finding that the lot of Xirallic® from which Sample C was taken was available to the public.” slip op. at 20
- Expert testimonyPetitioner expert discountedPatent owner expert creditedOther
“witnesses. See Elbit Systems of Am., LLC v. Thales Visionix, Inc., 881 F.3d 1354, 1358 (Fed. Cir. 2018) (citing Trs. of Columbia Univ. v. Illumina, Inc., 620 F. App’x 916, 922 (Fed. Cir. 2015); Inwood Labs., Inc. v. Ives Labs., Inc., 456 U.S. 844, 856 (1982)). We have reviewed the witness testimony in the record and, more particularly, Mr. Choi’s deposition answers regarding Petitioner’s purchase of the lot of Xirallic® from which Sample C came. We find that Mr. Choi’s responses cast doubt on the credibility of his declaration testimony, namely with regard to the public availability of Sample C. Mr. Choi represented that he was involved in the purchase of the lot of Xirallic® from which Sample C was taken. Ex. 2011, 48:1–23. Mr. Choi stated that he instructed Petitioner’s marketing team manager to buy the sample from a distributor of Patent Owner’s products located in Europe. Id. at 48:24–49:4. Mr. Choi stated that he has evidence of the transaction, but refused to reveal the name of the company from which Petitioner purportedly purchased the lot of Xirallic® (id. at 49:5–50:3) and refused to produce an email in his possession that would corroborate his testimony regarding Petitioner’s acquisition of the product (id. at 50:8–16, 51:10–23). Mr. Choi represented that he does not remember how much Petitioner paid for Sample B. Id. at 56:4–5. Mr. Choi admitted that the entity from which Petitioner acquired the lot of Xirallic® from which Sample C was taken is “not currently a Merck distributor” (Ex. 2011, 50:4–7) and was not “a Merck distributor at the time” that “samples B and C were purchased” (id. at 51:25–52:2). According to Mr. Choi, the company is a “former distributor” of Patent Owner’s products. Id. at 52:3–6. Mr. Choi did not know, according to his testimony, when that unnamed entity first obtained the lot of Xirallic® (id. at 52:7–10) and he stated that he did not have personal knowledge of how the entity obtained the lot of Xirallic® (id. at 52:12–19). Instead, Mr. Choi assumed the entity was “able to obtain the sample through the routine course or process” the entity uses “to take samples or get samples.” Id. at 52:12–19. Mr. Choi believed the sample of Xirallic® from which Sample C was taken was sealed when Petitioner received it because samples from dealers are sealed, and he remembered observing that the package was from a dealer. Id. at 52:24– 54:25. However, Mr. Choi admitted that he did not obtain a technical data sheet or certificate of analysis for the lot of Xirallic® from which Samples B and C were taken. Id. at 59:6–11. Mr. Choi also answered questions regarding Petitioner’s purchase of Samples D and H. Ex. 2011, 62:20–66:8, 67:7–9, 73:12–13, 73:17–22. Similar to his testimony regarding Samples B and C, Mr. Choi admitted withholding an email regarding the purchase of the lot of Xirallic® from which Sample D was taken. Id. at 62:20–63:9. Mr. Choi also admitted that he did not know how Akzo USA or Axalta obtained the Xirallic® the companies sold to him, and admitted that Akzo USA was not a distributor of Patent Owner’s products at the time Petitioner purchased the product. Id. at 63:10–66:8, 73:17–22. Mr. Choi also admitted that Petitioner did not pay Akzo USA for the lot of Xirallic® from which Sample D was taken, and did not pay Axalta for the lot of Xirallic® from which Sample H was taken. Id. at 67:7–9, 73:12–13. Although Petitioner presents declaration testimony from Mr. Choi representing that he purchased the lot of Xirallic® from which Samples B and C were taken in October 2011 (Ex. 1004 ¶ 16), Mr. Choi’s declaration testimony lacks corroborating evidence, and his deposition testimony does not support that the product was available to the public, as we found in our Final Written Decision. See Final Dec. 27–28. Notably, Petitioner produced corroborating evidence for Mr. Choi’s acquisition of Samples A, H, and I. See Ex. 1004 ¶¶ 13 (citing Ex. 1047), 18 (citing Exs. 1024, 1025). However, Mr. Choi withheld similar evidence for the Xirallic® lots from which Samples B, C, and D were taken. See Ex. 2011, 50:8–16, 51:10–23, 62:20– 63:9; Final Dec. 28. As Patent Owner argues, there is “no information to determine when a contract was established, that there was consideration for the exchange, that the product was available to be delivered when the alleged transaction took place, or even when the product was delivered. Choi has no memory of what was paid for the product.” Sur-Reply 24–25; see also PO Resp. 13–14; PO Br. Rem. 2–4.” slip op. at 34
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“Based on the evidence discussed above, we are not persuaded that Petitioner has shown by a preponderance of the evidence that Sample C was available to the public. Regardless of whether a company avoids wasting shelf life of its products (Ex. 1004 ¶¶ 15–16), there is no persuasive evidence in the record showing that the lot of Xirallic® from which Sample C was taken was released from quality control and then made available to the public by Patent Owner. Mr. Choi’s testimony shows that Petitioner obtained the lot of Xirallic® from which Sample C was taken in an atypical manner (i.e., not from Patent Owner or one of Patent Owner’s current distributors) (Ex. 2011, 49:5–50:7, 50:8–16, 51:10–23, 51:25–52:6, 52:12– 19), and there is no evidence in the record to show that the lot of Xirallic® was intended for sale, rather than for experimental use only or for some other restricted use. Accordingly, we determine Petitioner has not demonstrated by a preponderance of the evidence that Sample C qualifies as prior art against the ’861 patent, and we determine that Petitioner has not shown by a preponderance of the evidence that the ’861 patent is unpatentable over the grounds relying on Sample C.” slip op. at 38
Patent outcomesUS 10,647,861 not shown unpatentable§ 102 anticipation§ 103 obviousnessPatents in suitUS 10,647,861 - PTAB · Oct 9, 2025 · IPR2025-00478 · APJ Iftikhar Ahmed · IPR · Institution
The Board instituted review of claims 1–18 on all asserted grounds, finding a reasonable likelihood that Petitioner would prevail on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2024). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Based on the information presented in the Petition and the supporting evidence, we are persuaded that there is a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims. Accordingly, we institute an inter partes review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“We determine, on the current record, that Petitioner’s proposed level of ordinary skill is consistent with the ’596 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001); In re GPAC Inc., 57 F.3d at 1579. We adopt that level of ordinary skill in deciding whether to institute trial.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“proceeding, we disagree with Patent Owner’s assertion that the applicable rules and guidance require Petitioner to do more. In pertinent part, Rule 42.104(b) requires that a petition set forth: “(3) How the challenged claim is to be construed. . . . [and] (4) How the construed claim is unpatentable.” 37 C.F.R. §§ 42.104(b)(3), (4). The Consolidated Trial Practice Guide8 explains: If a petitioner believes that a claim term requires an express construction, the petitioner must include a statement identifying a proposed construction of the particular term and where the intrinsic and/or extrinsic evidence supports that meaning. On the 8 Consolidated Trial Practice Guide (November 2019), available at https://www.uspto.gov/sites/default/files/documents/tpgnov.pdf, hereinafter as “CTPG.” other hand, a petitioner may include a statement that the claim terms require no express construction. CTPG 44. Under the circumstances of this case, the applicable rule and our Practice Guide permit Petitioner to rely on the plain and ordinary meaning of these claim terms. After all, as Petitioner points out, that is the construction that Patent Owner proposes for these terms in the district court case.9 See Ex. 1029, 2. Moreover, Petitioner contends that even under Petitioner’s proposed construction from the district court case, the prior art teaches these claim limitations. Pet. 8, 15–17 (explaining how Dongare allegedly teaches implementation “in physical circuits, without software intervention”), 49–52 (similar arguments for Khawand and Rosenthal), 74–75 (similar arguments for Ohkawa). Because, as discussed below, we agree with Petitioner that, on the current record, Dongare teaches these claim limitations even under the construction that Petitioner proposes in the district court, we need not expressly construe these claim terms. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“Because we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy,’ we need not construe [a particular claim limitation] where the construction is not ‘material to the . . . dispute.’” (citation omitted) (emphasis added)). If Patent Owner believes these terms should be construed differently, Patent Owner may propose a construction and identify where the intrinsic and/or extrinsic evidence supports its construction. See CTPG 44–45.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“have been motivated to apply Gewirtz’s teachings to Dongare’s architecture. Id. Petitioner argues that “Gewirtz’s teachings provide several known benefits, including atomic hardware operations to avoid software spin locks . . . and flow control using a register,” and that “Gewirtz’s teachings prevent queue overflow and increase throughput/efficiency.” Id. at 25–26 (citing Ex. 1006, 1:30–64, 4:49–61, 6:8–7:14, 6:66–7:14; Ex. 1003 ¶¶ 118–120). Petitioner also argues that a person of ordinary skill in the art would have had a reasonable expectation of success in combining the teachings of Dongare and Gewirtz because it would have been a straightforward application of known techniques and routine technologies like registers, queue management, and flow control to improve Dongare’s architecture. Id. at 26–27 (citing Ex. 1006, 1:12–35, 2:46–3:7, 4:16–50; Ex. 1003 ¶¶ 122–123). Patent Owner does not specifically respond to these arguments. See generally Prelim. Resp. Based on our review of the current record, at this stage of the proceeding, we determine that Petitioner provides an adequate reason why one of ordinary skill in the art would have combined the teachings of Dongare and Gewirtz in the manner asserted by Petitioner, with a reasonable expectation of success.” slip op. at 27
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 8,924,596 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01462 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Solus’s rehearing request, leaving institution denied for claims 1–8 because the petition did not adequately show motivation to combine Hanafusa and Dobashi.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“In particular, neither Petitioner nor Dr. Josefowicz adequately explain why a POSITA looking for ways to make Hanafusa’s surface roughness low-profile would look to methods to achieve Dobashi’s RSm values. Dobashi teaches that because RSm “can be adopted as the period of waviness, RSm can also be used as an indicator for judgment of the surface.” Ex. 1005, 2:66–3:1, 6:23–26. Dobashi explains that waviness is “an indicator for determining whether the fine pattern forming performance is good or bad,” and “[t]he surface has small waviness and is smooth when RSm is large, and the surface has large waviness Dobashi also teaches that surface roughness Rzjis is used as a low-profile indicator. Ex. 1005, 2:66–3:1. Dobashi, therefore, teaches that RSm is an indicator of surface waviness, which Dobashi explains is different than surface roughness. Id. at 2:66– 3:3, 6:23–29. Given these teachings in Dobashi, neither Petitioner nor Dr. Josefowicz sufficiently explains how or why a POSITA would have been motivated to implement Dobashi’s RSm values to make Hanafusa’s surface roughness low-profile. See Pet. 10–12; Ex. 1003 ¶¶ 46–52.” slip op. at 4
§ 103 obviousnessPatents in suitUS 11,346,014 - Solus Advanced Materials Co., Ltd. v. SK Nexilis Co., Ltd.Rehearing deniedPTAB · Oct 7, 2025 · IPR2024-01461 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied rehearing and left in place its denial of institution because Petitioner did not show that claims 1–10 were likely obvious over the asserted combinations.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re 1 US 2013/0108922 A1, published May 2, 2013 (Ex. 1004, “Shinozaki”). 2 G. Khatibi, Temperature Dependent Elastic and Thermal Properties of Thin Copper Foils, Copper; Proceedings of the International Conference Copper ’06 (2006) (Ex. 1006, “Khatibi”). 3 Korean Patent Pub. No. 10-2012-0003485, published Jan. 10, 2012 (Ex. 1013; Ex. 1014 (English translation), “Toshio”). 4 US 2013/0108887 A1, published May 2, 2013 (Ex. 1012, “Kim”). 5 Griesi, M.B., Characterization of Electrodeposited Copper Foil Surface Roughness for Accurate Conductor Power Loss Modeling (2014) (Master’s Thesis, University of South Carolina) (Ex. 1015, “Griesi”). rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Not shown unpatentable
“For example, Dr. Randall does not provide adequate explanation or objective evidence to support his opinion that Khatibi’s use of a laser speckle based dilatometer instead of the claimed thermomechanical analyzer “is unlikely to significantly impact the CTE[6] value” because “variations in equipment and a heating speed of 5° C/min would not significantly alter the results.” Ex. 1003 ¶ 58. In particular, Dr. Randall neither explains what constitutes a “significant” impact on CTE, nor provides objective evidence to support his contention that equipment variations and heating differences would not “significantly alter” the resulting measurements. And although Dr. Randall opines that “the heating rate (5°C per minute) is typical for certain devices” such as a thermomechanical analyzer or dilatometer, and “[t]ypically, these devices use temperature ramp rates between 2°C and 20°C per minutes, so the ‘5° C./min’ recited in [1d] is common and should not drastically affect the measurement results,” Dr. Randall fails to point us to any evidence showing that these temperatures are “typical” or that the claimed heating rate is “common.” Id. ¶ 59 (emphases added).” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner, however, does not adequately explain why a POSITA would have been motivated to modify Kim’s copper foil surface to have a Pc value of 19.2 as reported in Griesi. In particular, neither Petitioner nor Dr. Randall points us to, nor do we discern, any teaching in Griesi that a peak count of 19.2 provides any particular benefits or properties that would have lead a POSITA to modify Kim’s copper foil surface as Petitioner proposes. Instead, Petitioner’s arguments that a POSITA would have been motivated to modify Kim’s copper foil surface with Griesi’s peak count patent itself. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 421 (2007) (stating that the fact finder must be aware “of the distortion caused by hindsight bias and must be cautious of arguments reliant upon ex post reasoning”). It was Petitioner’s burden to establish that the combined teachings Kim and Griesi disclose limitation [1g] as proposed. We are not persuaded that we misapprehended Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 8
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish the Khatibi, alone or in combination with Shinozaki, Toshio, and Kim, discloses limitation [1d]. We concluded that Petitioner failed to meet that burden for the reasons explained in our Decision. We are not persuaded that we overlooked or misapprehended Khatibi’s disclosures, or Petitioner’s evidence and explanation thereof, in doing so.7” slip op. at 5
§ 103 obviousnesscites KSRPatents in suitUS 10,811,689 - PTAB · Oct 3, 2025 · IPR2025-00486 · APJ Karl D Easthom · IPR · Institution
The Board instituted IPR on claims 1–4, 7–10, and 13–15 on all asserted § 103 grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“presented in the petition and preliminary response shows that “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons explained below, we determine that Petitioner establishes a reasonable likelihood that it would prevail with respect to at least one challenged claim. Accordingly, we institute an inter partes review as to the challenged claims and the grounds raised in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art (POSITA), would have been a person with a bachelor’s degree in electrical engineering, computer engineering, or similar major with at least two years of experience in the field [of data processing and streaming architectures including user-defined hardware and software modules] or a master’s degree in electrical engineering, computer engineering, or similar major with specialization in the field. A person with less education but more relevant practical experience may also meet this standard. Pet. 13 (citing Ex. 1001, 1:6–21, 2:47–3:20, codes (54), (57); Ex. 1003 ¶¶ 35–37). Patent Owner does not provide a level of ordinary skill in the art. See generally Prelim. Resp. Based on a review of the record, we adopt Petitioner’s proposed level of ordinary skill in the art because it is consistent with the evidence of record, including the asserted prior art and ’753 patent specification.” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed petitioner constructionOther
“The preliminary record supports Petitioner’s proposals (as slightly modified by the panel as indicated via the bracketed information) for purposes of institution. 5. Claim 1 recites a “chassis identifier” and “one or more chassis.” Therefore, claim 1 does not require multiple chassis. The parties do not address whether a “chassis identifier” represents nonfunctional descriptive material when there is “one . . . chassis.” That is, claim 1 requires that “each module on each board in each chassis can be addressed through the header,” but it appears on this preliminary record that “each module . . . can be addressed through the header” regardless of the information conveyed by the ”chassis identifier” when there is only “one . . . chassis.” The Board welcomes input on this claim construction issue during trial. No other express construction of any claim term is necessary to determine whether to institute inter partes review. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). D.” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITANo construction neededOther
“5. Claim 1 recites a “chassis identifier” and “one or more chassis.” Therefore, claim 1 does not require multiple chassis. The parties do not address whether a “chassis identifier” represents nonfunctional descriptive material when there is “one . . . chassis.” That is, claim 1 requires that “each module on each board in each chassis can be addressed through the header,” but it appears on this preliminary record that “each module . . . can be addressed through the header” regardless of the information conveyed by the ”chassis identifier” when there is only “one . . . chassis.” The Board welcomes input on this claim construction issue during trial. No other express construction of any claim term is necessary to determine whether to institute inter partes review. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). D.” slip op. at 8
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 10,873,753 - PTAB · Oct 2, 2025 · IPR2025-00673 · APJ Michael R Zecher · IPR · Institution
The Board instituted IPR on claims 1–7 and all petitioned grounds, finding a reasonable likelihood that Amazon would show at least one claim unpatentable over Shin and Aoyama.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“shown that there is a reasonable likelihood that it would prevail in demonstrating at least one of claims 1–7 of the ’675 patent is unpatentable. We begin our analysis with the principles of law that generally apply to an asserted ground based on obviousness, we then assess the level of skill in the art, next we provide brief overviews of Shin and Aoyama, and then we address the parties’ contentions with respect to independent claims 1, 6, and 7.” slip op. at 11
- Skill levelSkill level petitioner adoptedDecided for petitioner
“time it was made, we consider the level of ordinary skill in the pertinent art at the time of the invention. Graham, 383 U.S. at 17. “The importance of resolving the level of ordinary skill in the art lies in the necessity of maintaining objectivity in the obviousness inquiry.” Ryko Mfg. Co. v. Nu-Star, Inc., 950 F.2d 714, 718 (Fed. Cir. 1991). The “person having ordinary skill in the art” is a hypothetical construct, from whose vantage point obviousness is assessed. In re Rouffet, 149 F.3d 1350, 1357 (Fed. Cir. 1998). Factors pertinent to a determination of the level of ordinary skill in the art include “(1) the educational level of the inventor; (2) type of problems encountered in the art; (3) prior art solutions to those problems; (4) rapidity with which innovations are made; (5) sophistication of the technology; and (6) educational level of active workers in the field.” Env’t Designs, Ltd. v. Union Oil Co. of Cal., 713 F.2d 693, 696 (Fed. Cir. 1983) (citing Orthopedic Equip. Co. v. All Orthopedic Appliances, Inc., 707 F.2d 1376, 1381–82 (Fed. Cir. 1983)). “Not all such factors may be present in every case, and one or 4 At this stage in the proceeding, SoundClear does not present arguments or evidence of secondary considerations. See Prelim. Resp. more of these or other factors may predominate in a particular case.” Id. at 696–97. Relying on the testimony of Dr. Stern, Amazon argues the following: [a] person of ordinary skill in the art . . . would have had a minimum of a bachelor’s degree in computer engineering, computer science, electrical engineering, or a similar field, and approximately two years of industry or academic experience in a field related to controlling the audio output of electronic devices. Work experience could substitute for formal education and additional formal education could substitute for work experience. Pet. 7 (citing Ex. 1002 ¶¶ 28–32). In the Preliminary Response, SoundClear does not address Amazon’s assessment of the level of skill in the art. See Prelim. Resp. At this stage of the proceeding, we adopt Amazon’s uncontested assessment of the level of skill in the art because (1) it is consistent with the ’675 patent and the asserted prior art; and (2) it is supported by the testimony of Dr. Stern.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“arguments and evidence for purposes of institution that would support determining that a person of ordinary skill in the would have been motivated to combine the teachings of Shin and Aoyama. As one example, Amazon contends that the proposed combination is merely the addition of one known element (i.e., “Aoyama’s natural language processing and information retrieval”) to another known element (i.e., “Shin’s voice processing and response device”) to obtain predictable results (i.e., “identifying a user’s intent and providing information responsive to such intent”). Pet. 19–20 (citing KSR, 550 U.S. at 417; Ex. 1002 ¶ 83). As another example, Amazon contends the proposed combination also represents the addition of one known element (i.e., “Aoyama’s word replacement” feature) to another known element (i.e., “Shin’s distance-based content abbreviation/simplification”) to obtain predictable results (i.e., “using word replacement to simply content for distant users”). Id. at 25–26 (citing KSR, 550 U.S. at 417; Ex. 1002 ¶ 100). Amazon also presents sufficient arguments and evidence for purposes of institution that would support determining there is a reasonable expectation of success in making the proposed combination. Id. at 20 (citing Ex. 1002 ¶ 84), 27–28 (citing Ex. 1002 ¶ 102; Ex. 1011 ¶¶ 97, 98 Fig. 7). To the extent SoundClear argues that Amazon is required to identify a problem a person of ordinary skill in the art would have sought to solve when combining the teachings of Shin and Aoyama, we do not agree. See Prelim. Resp. 31–32. This line of argument runs contrary to the principles of law articulated in KSR. In KSR, the Supreme Court emphasized “an expansive and flexible approach” to an obviousness evaluation. KSR, 550 U.S. at 415; see also Jazz Pharm., Inc. v. Amneal Pharm., LLC, 895 F.3d 1347, 1363 (Fed. Cir. 2018) (“KSR did not impose a rigid requirement to identify . . . a problem to be solved in the art . . . .”). The Supreme Court stated that, “[o]ften, it will be necessary for a court to look to interrelated teachings of multiple patents,” amongst other things, “to determine whether there was apparent reason to combine the known elements in the fashion claimed by the patent at issue.” KSR, 550 U.S. at 418. Moreover, the Supreme Court explained that, “[u]nder the correct analysis, any need or problem known in the field of endeavor at the time of invention and addressed by the patent can provide a reason for combining the elements in the manner claimed.” Id. at 420.” slip op. at 26
- Expert testimonyPetitioner expert creditedDecided for petitioner
“Based on the preliminary record, we discern no deficiency in Amazon’s characterizations of Shin, Aoyama, or the general background knowledge in the art. In addition, for purposes of institution, we are persuaded by Dr. Stern’s testimony concerning the relevant disclosures in Shin and Aoyama. At this stage of the proceeding, SoundClear argues that Shin does not teach limitations 1[b]—“a voice classifying unit configured 1[b][i] to calculate a distance between the user and the output-content control device by a proximity sensor 1[b][ii] to classify the voice into either a first voice or a second voice based on the calculated distance.” See Prelim. Resp. 19–22. a. Limitations 1[b]—“a voice classifying unit configured to 1[b][i] calculate a distance between the user and the output-content control device by a proximity sensor to 1[b][ii] classify the voice into either a first voice or a second voice based on the calculated distance” In the Preliminary Response, SoundClear contends that Shin fails to teach voice classification because “Shin is incapable of distinguishing [between] multiple voices.” Prelim. Resp. 21. More specifically, SoundClear argues that Shin cannot teach classifying a voice into a first voice or second voice because “Shin never refers to a ‘first user’ or ‘second user’ or ‘multiple users.’” Id. (citing Ex. 1003 generally); see also id. at 26– 27 (arguing that Amazon misstates the record because Shin never discloses a “first voice” nor a “second voice”). Instead, SoundClear asserts that Shin only contemplates a single user (i.e., user 10) when calculating the distance between the user and an electronic device (e.g., Shin’s electronic device 100). Id. at 21–22 (citing Ex. 1003 ¶¶ 37, 38). Based on the preliminary record, Amazon presents sufficient evidence that would support a finding that Shin teaches “a voice classifying unit configured to calculate a distance between the user and the output-content control device by a proximity sensor to classify the voice into either a first voice or a second voice based on the calculated distance.” Pet. 10–14. Shin discloses that “processor 120 may determine an output scheme of corresponding content based on a distance between a user and the electronic device 101.” Ex. 1003 ¶ 53. Shin’s processor 120 accomplishes this distance calculation by using distance detection module 180, which may include various sensors, such as a proximity sensor. Id. ¶ 66; see also id. ¶ 153 (disclosing an embodiment where electronic device 901 includes sensor module 940, which, in turn, includes proximity sensor 940G). Shin’s Table 3 illustrates how the distance between the user and electronic device 101 determines the output scheme. Id. ¶ 86, Table 3. For instance, Shin’s Table 3 illustrates classifying the user’s voice input as a “first voice” when the distance between the user and electronic device 101 is between 1 to 2 meters, and classifying the user’s voice input as a “second voice” when the distance between the user and electronic device 101 is less than 1 meter. Id. ¶¶ 86, 87, Table 3.” slip op. at 23
§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,244,675 - PTAB · Aug 29, 2025 · IPR2025-00479 · APJ Justin T Arbes · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that claims 1–20 were obvious over Erskine, Scherzer, or Scherzer and Gillett.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsDenied
“III. CONCLUSION Based on the arguments and evidence presented by the parties, we conclude that Petitioner has not demonstrated a reasonable likelihood of prevailing with respect to at least one claim of the ’634 patent challenged in the Petition. Therefore, we do not institute an inter partes review. IV. ORDER In consideration of the foregoing, it is hereby: ORDERED that the Petition is denied and no inter partes review is instituted.” slip op. at 25
- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art Petitioner argues that at the time of the ’634 patent (July 2018), a person of ordinary skill in the art would have had “a bachelor’s degree in electrical engineering, computer science, computer engineering, or a similar major with at least two years of experience in the field; or a master’s degree with specialization in the field,” where “[a] person with less education but more relevant practical experience may also meet this standard.” Pet. 7 (citing Ex. 1003 ¶¶ 12–13). Petitioner further argues that a person of ordinary skill in the art would have had knowledge of “[d]esigning and using systems that include endpoint devices (e.g., client devices) and servers for establishing network connections and data transfer,” “[r]ecognizing and applying the client-server architecture,” and “[u]sing and applying concepts from known telecommunication and networking frameworks, protocols and standards, including TCP/IP, IEEE 802.11, VoIP, cellular systems and other known frameworks and standards.” Id. (citing Ex. 1003 ¶ 14). Patent Owner does not address the level of ordinary skill in the art in its Preliminary Response. Based on the record presented, including our review of the ’634 patent and the types of problems and solutions described in the ’634 patent and cited prior art, we agree with Petitioner’s definition and apply it for purposes of this Decision. See, e.g., Ex. 1001, col. 1, ll. 4–29 (describing in the “Background” section of the ’634 patent a “network connection between two endpoints” and known methods of reaching “full effective bandwidth capacity” in a network).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“C. Claim Interpretation We interpret each challenged claim using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b), including construing the claim in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent. 37 C.F.R. § 42.100(b). Petitioner notes that it proposed a construction for the claim term “geographical area” in the district court case, but states that it “do[es] not believe proposing a construction for the term is necessary in this proceeding because the relied upon teachings of the prior art references are consistent with examples of ‘geographical area’ included in the ’634 patent [S]pecification.” Pet. 8. Patent Owner argues that “[t]he Board need not engage in express claim construction at this stage of the proceeding.” Prelim. Resp. 5. We conclude that no express interpretation of any claim term is necessary to determine whether to institute an inter partes review in this proceeding. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“Because we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy,’ we need not construe [a particular claim limitation] where the construction is not ‘material to the . . . dispute.’” (citation omitted) (emphasis added)).” slip op. at 9
- BurdenNot shown unpatentable
“Petitioner has not shown sufficiently that Erskine teaches or suggests the second requirement of limitation [1c], i.e., “initiating the next network connection . . . with a transmission bandwidth based on the parameter values for the past network connection.” Petitioner’s theory is that (1) the QoS parameters in Erskine are for a “past” connection from one zone to another, (2) the sliding maximum interzone bandwidth is “based on” the QoS parameters, and (3) a new call only proceeds if the transmission bandwidth needed for the call added to the current bandwidth being used over the interzone link is less than the sliding maximum interzone bandwidth, so Erskine therefore teaches a call with a transmission bandwidth determined “based on” the sliding maximum interzone bandwidth (which in turn is determined “based on” the QoS parameters). See Pet. 27–28; Ex. 1003 ¶¶ 59–60 (similar testimony from Dr. Crovella). As Patent Owner points out, however, Erskine only makes “a binary, accept/reject decision as to whether to allow a new call to proceed based on a comparison between the bandwidth needed for the call and a predetermined ‘sliding maximum interzone bandwidth value.’” See Prelim. Resp. 6–7. Specifically, the additional bandwidth that would be needed for the call is added to the current bandwidth being used on the interzone link; if the sum of those values is less than the sliding maximum interzone bandwidth for the link, the call “proceeds”; otherwise, it is “blocked.” Ex. 1004, col. 4, ll. 36–40, col. 6, l. 55–col. 7, l. 10, col. 8, ll. 36–43, col. 9, ll. 9–26, col. 10, ll. 23–25 (the sum is compared to the sliding maximum interzone bandwidth “to determine whether enough bandwidth is available to proceed with the new call”), Fig. 3 (steps 308, 310, and 312). Erskine repeatedly refers to the bandwidth for the new call as the amount of bandwidth that is “necessary” or “required” to handle the call. See, e.g., id. at col. 1, ll. 43–57 (“an amount of bandwidth necessary to handle the new call”), col. 6, ll. 61–64 (“the additional bandwidth required (of the new call)”), col. 8, ll. 36–40 (“the bandwidth necessary for the new call”), col. 9, ll. 16–21 (“the anticipated additional bandwidth necessary for the new call”), 54–56 (“the bandwidth amount the new call will utilize (if connected)”), col. 10, ll. 21–23 (same), 41–43 (same), col. 12, ll. 1–2 (“an amount of bandwidth necessary to handle the new call”). It is that value—determined prior to the addition and comparison to the sliding maximum interzone bandwidth—that will be used for the new call if it is allowed to “proceed[].” Id. at col. 6, ll. 64–67 (if the sum is less than the sliding maximum interzone bandwidth, the call “proceeds” and “the QoS table is updated with the additional bandwidth used by that call”). Erskine does not describe the transmission bandwidth for the new call as being based on any parameter values for a past network connection, but rather as “whatever bandwidth the system determined is necessary for the additional call.” See Prelim. Resp. 8–9. In other words, the transmission bandwidth needed for a new call is predetermined and independent of whatever the sliding maximum interzone bandwidth is currently. See id.” slip op. at 15
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 10,944,634
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.