- PTAB · Dec 10, 2025 · PGR2025-00054 · APJ Ryan H Flax · PGR · Institution
The Board instituted PGR on claims 1–16 on all four grounds, finding at least one claim more likely than not unpatentable based on obviousness, indefiniteness, or lack of written description.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“institute trial in a post-grant review. We institute a post-grant review only if the information presented in the petition filed under 35 U.S.C. § 321, if unrebutted, shows that it is more likely than not that at least one claim challenged in the petition is unpatentable. 35 U.S.C. § 324. On the existing record, we conclude that Petitioner demonstrates it is more likely than not that Petitioner would prevail in showing that at least one challenged claim of the ’781 patent is unpatentable under a presented ground. See generally Pet. Therefore, we grant institution of post-grant review. Our reasoning is discussed below.” slip op. at 2
- PTAB / AIA Trials › Real party in interest / privityDecided for petitioner
“STANDING Petitioner states that it certifies that: (1) the ’781 patent is available for post grant review because its earliest claimed effective filing date is October 9, 2018, and the patent issued less than nine months ago, on December 3, 2024; and (2) Petitioner is not barred or estopped from requesting a post grant review on the grounds in this petition. Pet. 5. This is sufficient. See 35 U.S.C. § 100(note)(A)–(B), § 321; 37 C.F.R. § 42.204(a). Patent Owner does not contest standing. See generally Prelim. Resp. B. REAL PARTIES-IN-INTEREST Petitioner states that “[t]he real parties-in-interest are Petitioner Straumann USA, LLC and its affiliates Institut Straumann AG and JJGC Indústria e Comércio de Materiais Dentários S.A.” Pet. 3. Patent Owner raises no objection and itself identifies “Smart Denture Conversions, LLC is the real party-in-interest.” Paper 4, 2; see generally Prelim. Resp. C.” slip op. at 3
- Skill levelSkill level petitioner adoptedDecided for petitioner
“At this point, we find little meaningful difference between the two proposed definitions. In fact, neither does Patent Owner’s witness, Mr. Leinsing, who states that his “opinions would not change under either definition.” Ex. 2011 ¶ 42. And, as set forth above, Patent Owner asserts that, for the sake of its present arguments, it matters not which of the two proposed definitions we use for this proceeding. Prelim. Resp. 21. Thus, at this stage, we accept and use Petitioner’s proposed definition of the ordinarily skilled artisan, which, unlike Patent Owner’s, does not implicate reliance on the knowledge of people other than the individual ordinarily skilled artisan. Petitioner’s definition appears to comport with the level of skill in the art reflected in the prior art of record and the ’781 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“[T]he prior art itself [may] reflect[] an appropriate level” of ordinary skill in the art) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)). This issue may be further developed at trial by the parties, if desired. C.” slip op. at 19
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“same claim construction standard that is used to construe patent claims in a civil action in federal district court thus, by default, we give claim terms their ordinary and customary meaning, which is “the meaning that the term would have to a person of ordinary skill in the art in question at the time of the invention.” 37 C.F.R. § 42.200(b); Phillips v. AWH Corp., 415 F.3d 1303, 1312–13 (Fed. Cir. 2005) (en banc). Petitioner indicates that None of the claim terms of claims 1–16 need to be construed to determine the patentability issues presented in this petition. The petition applies the ordinary meaning of the claim language as it would be understood by a POSA after reading the ’781 patent. Ex. 1002, ¶130. Petitioner will propose a construction if Patent Owner argues or the Board determines that one is required for any term. Pet. 31 (citing Ex. 1002). And, Patent Owner presents no express position on claim construction at this point. See generally Prelim. Resp. At this stage of the proceeding, we do not expressly construe any claim terms; however, this position is preliminary and we may change it based on the fully developed record at trial.8 D.” slip op. at 19
Claim construction§ 103 obviousness§ 112 disclosurecites GrahamPatents in suitUS 12,156,781 - PTAB · Nov 21, 2025 · IPR2025-00956 · APJ Ryan H Flax · IPR · Institution
The Board instituted IPR on claims 1–12 under all asserted grounds, finding a reasonable likelihood that at least one claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“institute trial in an inter partes review. We institute an inter partes review only if the information presented in the petition filed under 35 U.S.C. § 311, and any preliminary response filed under § 313, shows that there is a reasonable likelihood that Petitioner would prevail with respect to at least one of the claims challenged in the petition. 35 U.S.C. § 314. After reviewing the parties’ submissions in view of the existing record, we conclude that Petitioner demonstrates a reasonable likelihood it would prevail in showing that at least one challenged claim of the ’992 patent is unpatentable under the presented grounds. See Pet. Therefore, we grant institution of inter partes review. Our reasoning is discussed below. A.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“These two proposed definitions of the ordinarily skilled artisan share many consistencies, for example, the types of degrees and experience such a person would have had, but differ in the number of years of experience. Petitioner proposes the ordinarily skilled artisan would have had at least five years of experience and Patent Owner proposes at least three years (which would necessarily include five years, too). Patent Owner also proposes that the ordinarily skilled artisan would have consulted a dentist, oral surgeon, prosthodontist, or periodontist with experience in dental implants and prosthetics. At this point, we find little meaningful difference between the two proposed definitions. In fact, neither does Patent Owner’s witness, Mr. Leinsing, who states that his “opinions would not change under either definition.” Ex. 2011 ¶ 40. Thus, at this stage, we accept and use Petitioner’s proposed definition of the ordinarily skilled artisan, which, unlike Patent Owner’s, does not implicate reliance on the knowledge of people other than the individual ordinarily skilled artisan. Petitioner’s definition appears to comport with the level of skill in the art reflected in the prior art of record and the ’992 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“the prior art itself [may] reflect[] an appropriate level” of the ordinary level of skill in the art) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)). This parties may further developed this issue at trial, if desired. C.” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“The Board interprets claim terms in an inter partes review using the same claim construction standard that is used to construe patent claims in a civil action in federal district court. 37 C.F.R. § 42.100(b). In construing claims, district courts and the Board here, by default, give claim terms their ordinary and customary meaning, which is “the meaning that the term would have to a person of ordinary skill in the art in question at the time of the invention.” Phillips v. AWH Corp., 415 F.3d 1303, 1312–13 (Fed. Cir. 2005) (en banc).” slip op. at 14
- Disclosure Requirements (§112) › Written description (Ariad)Written description inadequateNot entitled to earlier dateDecided for petitioner
“Here, the first claim limitation at issue is broad, i.e., different thread pattern/profile between a definite and a temporary screw, and the Specification’s and priority applications’ disclosure is narrow and specific, asymmetric buttress style threads in a temporary screw and symmetrical threads in a definite screw (are different). Any apparent predictability in or maturity of the relevant field here must be contrasted with the fact that the Specification, considering the ’992 patent itself or any of the identified priority applications, never once even discusses the (claimed) concept of specifically differing the thread style between a temporary and a definitive screw. Any differences in thread style are not called out by the disclosure, but are described and can be discerned only in relation to the respective threads’ functionality, i.e., Fig. 75’s temporary screw 190 has buttress-style threading so it can be pulled out rather than unscrewed from the abutment; Fig. 9’s definitive screw 75 has male threads that fill the female threads of the abutment 8 for a secure permanent engagement. Ex. 1001, 15:23–30, 21:25–44, 23:3–36; Ex. 1012, 97–98, Figs. 9, 75. And, although it is possible for a single disclosed species to provide written description support for a claimed genus, “a sufficient description of a genus . . . requires the disclosure of either a representative number of species falling within the scope of the genus or structural features common to the members of the genus so that one of skill in the art can ‘visualize or recognize’ the members of the genus.” Ariad, 598 F.3d at 1350; see also Synthes USA, LLC v. Spinal Kinetics, Inc., 734 F.3d 1332, 1344 (Fed. Cir. 2013). That does not appear to be the case here—the present record does not support that the described asymmetrical buttress, serrated style of different temporary screw threading (relative to that of the definitive screw and regardless of the direction of the threads for rotation) is sufficiently representative of the genus’s “different” thread patterns/profiles. See, e.g., Ex. 1006 (a buttress style thread does not function the same as a buttress reverse or 75º joint profile or rounded, or trapezoidal thread).” slip op. at 30
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Phillips · GrahamPatents in suitUS 11,937,992 - Xencor, Inc. v. Merus N.V.InstitutedPTAB · Sep 26, 2025 · IPR2025-00605 · APJ Tawen Chang · IPR · Institution
The Board instituted IPR on claims 1–7 and all petitioned grounds, finding a reasonable likelihood that claim 1 is anticipated by Desjarlais or Moore or obvious over Lazar alone.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“SAS, 138 S. Ct. at 1356. Thus, because we determine, based on the arguments and evidence on the present record, that there is a reasonable likelihood Petitioner would prevail with respect to claim 1, we institute an inter partes review of all challenged claims under each Ground presented in the Petition. Id.; see also 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”). III. CONCLUSION For the reasons provided above, we find that Petitioner has demonstrated a reasonable likelihood of showing at trial that at least one of the challenged claims of the ’859 patent is unpatentable under at least one ground. Accordingly, we institute inter partes review of all challenged claims based on all the Grounds presented in the Petition.” slip op. at 49
- Disclosure Requirements (§112) › Written description (Ariad)Not entitled to earlier dateDecided for petitioner
“As Petitioner points out, the cited disclosure in the ’935 provisional does not “mention[] positions 364 and 368 together as a pair of positions for potential mutations on two chains.” Pet. 28 (citing Ex. 1002 ¶¶ 109–19). Although Patent Owner is correct that examples or actual reduction to practice are not required for adequate written description and “[a] specification may . . . contain a written description of a broadly claimed 34 invention without describing all species that [the] claim encompasses,” Prelim. Resp. 15 (quoting Ariad Pharms., 598 F.3d at 1352 and Cordis Corp. v. Medtronic AVE Inc., 339 F.3d 1352, 1365 (Fed. Cir. 2003)), the ’935 provisional must still “reasonably convey[] to those skilled in the art that the inventor[s] had possession of the claimed subject matter” as of the relevant date. Regeneron Pharms., Inc. v. Mylan Pharms. Inc., 127 F.4th 896, 914 (Fed. Cir. 2025); Ariad, 598 F.3d at 1351. In this case, Table A of the ’935 provisional discloses a list of CH3 domain interface residues and identifies, for each interface residue in heavy chain A, the contacting residue in the corresponding chain B. Ex. 1030, 17, Table A. Table A does not, however, describe any particular substitutions or pairs of substitutions that should be made to the CH3 domains. See, e.g., Pet. 28 (citing Ex. 1002 ¶¶ 109–119). Table 7 of the ’935 provisional does identify specific amino acid substitutions in CH3 domains, including substitutions resulting in a positively charged residue at position 364 (e.g., S364K) and a negatively charged residue (e.g., L368D) at position 368. Ex. 1030, 52, Table 7. Patent Owner argues that this table “discloses specific positions for ‘identification of novel charge pair mutants.’” Prelim. Resp. 13 (citing Ex. 2010 ¶ 48). As Petitioner points out, however, while Example 13 of the ’935 provisional relates to identification of novel charge pair mutants, Table 7 itself was only a “first step” in this identification process. Ex. 1030, 51:6–17. In this step, “many interface contact residues in the IgG CH3 domain were scanned one by one or in groups for substitutions that would result in repulsion of 35 identical heavy chains” so that identified substitutions can then be used to generate antibodies “by engineering matched pairs of CH3 residues in one or more IgG heavy chains – CH3 regions” in follow up experiments. Id. Accordingly, Table 7 does not appear to describe heterodimer combinations, such as those that would result from a pairing of chains with different substitutions. Pet. 29–30 (citing, e.g., Ex. 1002 ¶¶ 111–118). As Petitioner further points out, the follow up experiments testing the matched pairs of CH3 residues did not include paired substitutions at positions 364 and 368. Id. at 29–31. Patent Owner points to disclosure in the ’935 provisional describing, as a distinguishing feature of its invention, the substitution of non-charged or neutral amino acids in wildtype CH3 with charged residues, which according to the ’935 provisional has the “advantage that at least one additional charge-charge interaction in the CH3 interface is created.” Prelim. Resp. 12 (citing, e.g., Ex. 2010 ¶¶ 42–48). For the same reasons discussed above, Petitioner has sufficiently established, for purposes of institution, that such disclosure would not reasonably convey to an ordinarily skilled artisan that the inventors had possession of the entire genus of heterodimeric antibodies comprising CH3 domains wherein a non-charged amino acid is replaced with a charged residue so as to create an additional charge-charge interaction in the CH3 interface. In this regard, we also note that “a description that merely renders the invention obvious does not satisfy the [written description] requirement.” Ariad, 598 F.3d at 1352.” slip op. at 34
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportReference is prior artDecided for petitioner
“adequately describes a heterodimeric antibody comprising the recited charged residues at the recited positions of the CH3 domains, i.e., “a positively charged amino residue at position 364” at a first CH3 domain and “a negatively charged amino acid residue at position 368” of the second CH3 domain. Having considered the evidence of record at this preliminary stage of the proceeding, and for the reasons set forth below, we are persuaded that Petitioner has shown sufficiently, for purposes of institution, that the ’935 provisional does not provide adequate written description support for claim 1 of the ’859 patent and that, accordingly, Desjarlais and Moore qualify as prior art to that claim. As Petitioner points out, the cited disclosure in the ’935 provisional does not “mention[] positions 364 and 368 together as a pair of positions for potential mutations on two chains.” Pet. 28 (citing Ex. 1002 ¶¶ 109–19). Although Patent Owner is correct that examples or actual reduction to practice are not required for adequate written description and “[a] specification may . . . contain a written description of a broadly claimed 34 invention without describing all species that [the] claim encompasses,” Prelim. Resp. 15 (quoting Ariad Pharms., 598 F.3d at 1352 and Cordis Corp. v. Medtronic AVE Inc., 339 F.3d 1352, 1365 (Fed. Cir. 2003)), the ’935 provisional must still “reasonably convey[] to those skilled in the art that the inventor[s] had possession of the claimed subject matter” as of the relevant date. Regeneron Pharms., Inc. v. Mylan Pharms. Inc., 127 F.4th 896, 914 (Fed. Cir. 2025); Ariad, 598 F.3d at 1351.” slip op. at 34
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“The ’859 patent does not provide an explicit definition of “immunoglobulin class.” Nevertheless, we do not construe that term to require “two heavy chains with four domains, VH, CH1, CH2, and CH3, and two Fab arms.” As an initial matter, the Specification teaches that antibodies include, 16 e.g., IgE and IgM — which have an additional CH4 domain in their heavy chains — as well as functional derivatives and/or fragments of known antibody isotypes. Ex. 1001, 11:44–48. Patent Owner’s proposed construction, which limits antibodies to those having two Fab arms and “two heavy chains with four domains, VH, CH1, CH2, and CH3,” excludes these embodiments and cannot be correct. Moreover, the ’859 patent defines antibody as containing “one or more domains” that bind an epitope on an antigen. Ex. 1001, 11:39–44. Thus, an antibody does not require two Fab arms as in a native immunoglobulin molecule.12 The ’859 patent also describes a preferred embodiment as “Ig-like molecules.” Id. at 11:49–52. Thus, we look to the definition of “Ig-like molecule” in the ’859 patent, i.e., “a proteinaceous molecule that possesses at least one immunoglobulin (Ig) domain,” to inform our understanding of the phrase “immunoglobulin class of proteins.” Ex. 1001, 11:4–6. Accordingly, we further construe “immunoglobulin class of proteins” to mean proteinaceous molecules comprising at least one domain that is derived from or shares sequence homology with an immunoglobulin domain.” slip op. at 16
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 11,926,859 - PTAB · Nov 22, 2024 · PGR2024-00034 · APJ Patrick R Scanlon · PGR · Institution
Instituted PGR on claims 1–19 and all asserted grounds after finding at least one claim more likely than not unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority to determine whether to institute a post-grant review. See 35 U.S.C. § 324 (2018); 37 C.F.R. § 42.4(a) (2022). To institute a post-grant review, we must determine that “the information presented in the petition . . . would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). For the reasons set forth below, we determine that the information presented shows that it is more likely than not that Petitioner would prevail in establishing unpatentability of at least one challenged claim. Accordingly, we institute a post-grant review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“We note that the identification of a Ph.D. as an example of “more formal education” creates a vast range of education relative to a bachelor’s degree. Thus, we treat the identification of a Ph.D. just as it is—an example—and not a requirement. In this case, “more formal education” can be satisfied by a level of education less than a Ph.D (but greater than a bachelor’s degree). Based on our review of the record before us, we determine that Petitioner’s stated level of ordinary skill in the art is reasonable because it appears consistent with the evidence of record, definition, limited as discussed above, for the purposes of this Decision.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“On the present record, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“would have understood Unger’s disclosure to “suggest the use of a torsion spring to facilitate attachment and detachment, because torsion springs are designed to impart this functionality.” Id. (citing Ex. 1002 ¶ 118). Petitioner also asserts that one of ordinary skill in the art would have “understood that there were a limited number of ways to impart the referenced resilient or flexible ‘manipulation,’” and “would have been motivated to look to various known solutions to impart the suggested functionality, including the torsional spring mechanism of Smith that is used in a similar hearing protection device application for a similar purpose as Unger’s mounting arms (to apply a clamping force).” Id. at 32 (citing Ex. 1002 ¶¶ 120–121).” slip op. at 17
Claim construction§ 103 obviousness§ 112 disclosurecites KSR · GrahamPatents in suitUS 11,736,855 - PTAB · Nov 14, 2024 · PGR2024-00026 · APJ Hyun J Jung · PGR · Institution
Instituted PGR on claims 1–7 and all grounds because Petitioner showed it was more likely than not that at least one challenged claim lacks written-description support.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this stage, Petitioner’s arguments, cited portions of the Specification, and supporting testimonial evidence demonstrate that it is more likely than not that claims 1–7 are unpatentable.” slip op. at 20
- Disclosure Requirements (§112) › Written description (Ariad)Written description inadequateDecided for petitioner
“patent describes that “angular position transducer 78 is placed on top of swing leg pivot shaft 24” and that “pivot shaft 24 is rotationally fixed to the connector plate and duplicates the angular movements of swing leg 20 about the pivot shaft.” Ex. 1001, 12:15–16, 12:20–22, Figs. 5, 7. The ’723 patent also describes that “[a]ngular position transducer 78 is mounted inside . . . protective can 90 . . . which is bolted to hinge bracket 28 via an upright holding arm 92” and that “trigger pin 94 projects upwardly from the top surface of pivot shaft 24 and cooperates with angular position transducer 78 to generate an angular position signal.” Id. at 12:28–33, Fig. 5. These descriptions expressly convey that angular position transducer 78 is on pivot shaft 24 and mounted inside protective can 90 that is bolted to hinge bracket 28. Id. at 12:15–16, 12:20–22, 12:28–30, Figs. 5, 7; see also Prelim. Resp. 17 (describing the same embodiment shown in Figs. 5 and 7). According to Petitioner, the ’723 patent describes the pivot shaft as part of the hinge bracket, not the modular frame or swing leg. Pet. 109–110 (citing Ex. 1001, 7:42–46, 12:17–22). On the preliminary record, we agree because the cited portions of the Specification describe that a “hinge bracket is interposed between each swing leg and an associated surface of the bolsters and includes a fixed, upright pivot shaft that pivotally engages the swing leg for pivotal movements” and “pivot shaft 24 is rotationally fixed to the connector plate.” Ex. 1001, 7:42–45, 12:20–21. We also agree that “even if one were to find that the hinge bracket is part of either the modular frame or swing leg (contrary to the claims and specification treating these all as separate components), the specification would only provide written description for one of the claimed alternatives.” Pet. 110 (citing Ex. 1002 ¶ 199).” slip op. at 19
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“At this preliminary stage, we determine that express claim interpretation is not necessary to determine whether it is more likely than not that at least one of the claims challenged in the petition is unpatentable. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 16
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDecided for petitioner
“We will also not use our discretion under § 325(d) to deny the Petition based on arguments previously presented in IPR2021-00135, because Petitioner relies on a Board determination regarding claim 8 from IPR2021- 00136, not arguments previously made for claim 1 in IPR2021-00135. Pet. 111–115, 119; Prelim. Resp. 8–9; Prelim. Sur-reply 5. Furthermore, we determined the effective filing date of claim 8 of the ’571 patent without deciding, that other challenged claims, such as claim 1, were entitled to their earliest possible effective filing date. See Godberson-Smith, Paper 61 at 11, 12.” slip op. at 12
Claim construction§ 112 disclosureDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,772,723 - Cimbria Srl v. 3u Vision SrlInstitutedPTAB · Sep 20, 2024 · PGR2024-00018 · APJ Kevin W Cherry · PGR · Institution
The Board instituted PGR on claims 1–15 and all petitioned grounds, finding a reasonable likelihood that claims 1–3, 6, and 10 are obvious over ElMasry.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 324(a), a post-grant review may be instituted only if “the information presented in the petition . . . demonstrate[s] that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” Post-grant review is available for patents that issue from applications that at one point contained at least one claim with an effective filing date on or after March 16, 2013. See Leahy-Smith America Invents Act, Pub. L. No. 112-29, 125 Stat. 284 (2011) (“AIA”), §§ 3(n)(1), 6(f)(2)(A). After considering the briefing and the evidence of record, for the reasons set forth below, we determine that Petitioner has shown that the ’947 patent is eligible for post-grant review, and has shown it is more likely than not that at least one challenged claim of the ’947 patent is unpatentable under § 324(a). Accordingly, we institute a post-grant review of the challenged claims of the ’947 patent.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art “would have a B.S. degree in Electrical Engineering, Physics, Chemistry, or an equivalent field, and at least 2-3 years of academic or industry experience in engineering related to optical sorting systems.” Pet. 17 (citing Ex. 1009 ¶ 21). Patent Owner did not file a Preliminary Response to the Petition and, therefore, at this point, does not contest Petitioner’s definition for one of ordinary skill in the art. Petitioner’s proposed definition appears to be consistent with the disclosure of the ’947 patent, and we adopt it for purposes of this Decision. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that the prior art itself may “reflect[] an appropriate level” of ordinary skill in the art) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)).” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Having considered the record, we determine that no express claim construction is necessary for any claim terms for the purposes of rendering a decision to institute trial. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the controversy (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). At this stage, we find it unnecessary to resolve whether “electronic control unit” and “processing module” should be construed as mean plus function limitations under § 112(f), because it is possible to address the obviousness grounds presented whether or not these limitations are so construed, and even if the claims were indefinite in the manner Petitioner contends. See Intel Corp. v. Qualcomm Inc., 21 F.4th 801, 813 (Fed. Cir. 2021) (noting indefiniteness of a means-plus-function limitation does not always render it impossible to adjudicate a prior-art challenge). We direct the parties to address the construction of these claim terms and Petitioner’s interpretation during trial.” slip op. at 13
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“We have reviewed Petitioner evidence and citations and, on the current record, we find that Petitioner has shown that it is more likely than not that ElMasry teaches all the limitations of claim 1, without need for any modification. Thus, we find that Petitioner has shown that it is more likely than not that claim 1 would have been unpatentable as obvious over ElMasry.” slip op. at 20
Claim construction§ 103 obviousness§ 112 disclosurePatents in suitUS 11,666,947 - PTAB · Apr 11, 2023 · IPR2022-01564 · APJ Patrick R Scanlon · IPR · Institution
The Board instituted IPR on claims 1–14 and all asserted grounds, finding a reasonable likelihood that Keith anticipates at least claims 1 and 10.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2021). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that the information presented in the Petition establishes a reasonable likelihood that Petitioner will prevail with respect to at least one challenged claim. We institute an inter partes review of claims 1‒14 based on the grounds set forth in the Petition.” slip op. at 2
- Parallel petitionsDecided for petitioner
“Under the circumstances presented, where the priority date of the challenged claims is disputed, we conclude it is not unreasonable for Petitioner to present separate challenges, one of which relies on references that are prior art only if the challenged claims are not entitled to Patent Owner’s claimed priority date, which has yet to be finally determined. See TPG 59 (stating that “a dispute about priority date requiring arguments under multiple prior art references” can be a potential reason for the Board to institute trial on multiple petitions challenging the same patent). Thus, on the present record, we decline to exercise our discretion to deny institution of this Petition on the basis of Petitioner filing multiple petitions.” slip op. at 46
- Skill levelSkill level petitioner adoptedDecided for petitioner
“have had a Bachelor’s degree in computer science, computer engineering, electrical engineering, or a related field or equivalent coursework or experience, and one to two years of experience with mobile device applications and retail POS systems,” also noting that “[m]ore education can supplement practical experience and vice versa.” Pet. 20–21 (citing Ex. 1002 ¶ 34). Patent Owner, at this stage of the proceeding, does not dispute Petitioner’s definition of the person of ordinary skill in the art. Prelim. Resp. 18. For the purposes of this Decision, we apply Petitioner’s proffered level of skill in the art because it appears consistent with the problems addressed in the ’435 patent and the prior art.” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“We determine that an express construction of this or any other claim term is not necessary for purposes of this Decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosureDiscretionary denialPatents in suitUS 10,803,435 - Apple Inc. v. Rfcyber Corp.InstitutedPTAB · Jan 23, 2023 · IPR2022-01256 · APJ Kevin W Cherry · IPR · Institution
The Board instituted IPR of claims 1–11 based on the § 103 ground over Buhot, GPC, and Zhu, finding a reasonable likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“institute an inter partes review. The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted unless “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The Supreme Court has held that the Board, in a decision to institute under 35 U.S.C. § 314(b), may not institute review on less than all claims challenged in the petition. SAS Inst. Inc. v. Iancu, 138 S. Ct. 1348, 1355–56 (2018). Moreover, in accordance with our rules, “[w]hen instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a) (2020); see also PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed. Cir. 2018) (interpreting the statute to require “a simple yes-or-no institution choice respecting a petition, embracing all challenges included in the petition”). Applying those standards, and upon considering the Petition, the Preliminary Response, and the evidence of record, we determine the information presented shows a reasonable likelihood that Petitioner would prevail in establishing the unpatentability of at least one of the challenged claims of the ’724 patent. Accordingly, we institute an inter partes review of all challenged claims (i.e., claims 1–11) of the ’724 patent, based on the ground asserted in the Petition.” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Having considered the record, we determine that no express claim construction is necessary for any claim terms. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the controversy (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 10
- Skill levelSkill level petitioner adoptedDecided for petitioner
“contends that an ordinarily skilled artisan for the ’724 patent “would have had at least a bachelor’s degree in computer engineering, computer science, electrical engineering, or a related field, with at least one year of experience in the field of mobile payment technology. Additional pertinent education might substitute for the requisite experience and vice versa.” Pet. 6–7 (citing Ex. 1007 (Smith Decl.) ¶¶ 34–35). Patent Owner states that it “utilizes Petitioner’s proposed level of skill in the art,” but only for its Preliminary Response. Prelim. Resp. 9. Based on this record, we adopt Petitioner’s articulation of the level of ordinary skill in the art, which is consistent with the ’724 patent and the asserted prior art, and we apply it in our obviousness evaluations below. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art, itself, can reflect appropriate level of ordinary skill in art).” slip op. at 9
- Disclosure Requirements (§112) › Written description (Ariad)Not entitled to earlier dateDecided for petitioner
“earlier applications, in particular Application No. 11/534,653 (“the ’653 application”), which issued as U.S. Patent No. 8,118,218 B2 (“the ’218 patent”). “It is elementary patent law that a patent application is entitled to the benefit of the filing date of an earlier filed application only if the disclosure of the earlier application provides support for the claims of the later application, as required by 35 U.S.C. § 112.” PowerOasis, 522 F.3d at 1306; New Railhead Mfg., L.L.C. v. Vermeer Mfg. Co., 298 F.3d 1290, 1294 (Fed. Cir. 2002); Lucent Techs., Inc. v. Gateway, Inc., 543 F.3d 710, 718 (Fed. Cir. 2008) (“Patent claims are awarded priority on a claim-by-claim basis based on the disclosure in the priority applications.”). The test for determining compliance with the written description requirement under § 112(a) is whether the original disclosure of the earlier-filed application reasonably would have conveyed to one with ordinary skill in the art that the inventor had possession the claimed subject matter at the time of the earlierfiled application. Ariad Pharm., Inc. v. Eli Lilly & Co., 598 F.3d 1336, 1351 (Fed. Cir. 2010) (en banc). It is well settled that “[e]ntitlement to a filing date does not extend to subject matter which is not disclosed but would be obvious over what is expressly disclosed.” Lockwood v. American Airlines, Inc., 107 F.3d 1565, 1571−72 (Fed. Cir. 1997). “It is not sufficient for purposes of the written description requirement of § 112 that the disclosure, when combined with the knowledge in the art, would lead one to speculate as to modifications that the inventor might have envisioned, but failed to disclose.” Id. Nor could the claimed subject matter have been “envisioned” from the earlier disclosure to establish written description support. Goeddel v. Sugano, 617 F.3d 1350, 1356 (Fed. Cir. 2010). We agree with Petitioner that, on this record, there does not appear to be support for limitation [1(j)] in the ’653 application. Patent Owner identifies the following disclosure from the ’218 patent (the patent that issued from the ’653 application) as supporting limitation [1(j)]: According to one embodiment, a smart card has a preloaded smart card operation system that provides security framework to control the access to the Smart card (e.g., an installation of external applications into the smart card). In order to manage the life cycle of an external application, a card manager module is configured by using the smart card security framework. For instance, a Java based smart card, SmartMX, is preloaded with an operating system JCOP 4.1. The Global Platform 2.1 installed on the SmartMX performs the card manager functionality. Ex. 2001 (’218 patent), 4:47–56. Patent Owner argues that “this description is substantively identical to that on which Apple relies for disclosure of the “emulator device” and “replace out of the emulator device . . . replacing out of the emulator device . . .” limitations. Prelim. Resp. 26. Patent Owner contends that “Apple relies on Buhot’s discussion of an ‘operating system 314 (running on processor 400) for the ‘emulator device’ limitation (Pet. at 31), and relies on Zhu’s alleged teachings regarding a ‘smart card manager . . . which governs the process of loading and unloading applications out of an emulator’ for the ‘replace out of the emulator device . . . replacing out of the emulator device’ limitations.” Id. (citing Pet. 43). Patent Owner asserts that Petitioner “cannot argue with a straight face that its proposed combination discloses” slip op. at 21
Claim construction§ 103 obviousness§ 112 disclosurecites Phillips · KSR · GrahamPatents in suitUS 11,018,724 - PTAB · Feb 8, 2022 · PGR2021-00103 · APJ Patrick R Scanlon · PGR · Institution
The Board instituted PGR on claims 1–28 and all petition grounds, finding the Luharuka, API 674, and Karassik challenge more likely than not to prevail on claim 1.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 324(a), a post-grant review may not be instituted “unless . . . the information presented in the petition . . . , if such information is not rebutted, would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” After considering the Petition and Patent Owner’s Preliminary Response, as well as all supporting evidence, we determine that Petitioner has satisfied the burden under 35 U.S.C. § 324(a) to show that it is more likely than not that at least one of the challenged claims is unpatentable.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDenied
“These arguments are not persuasive, however, because Patent Owner does not explain adequately how the disclosures of Oehring and Shampine are cumulative of the disclosure of Mu. In this case, the mere fact that 8 We note that Exhibit 2007 does not have ¶ 95 cited by Patent Owner. not mean necessarily that the references are cumulative of Mu. For instance, Petitioner relies on Mu for allegedly disclosing several claim limitations including “receiving a demand hydraulic horse power (HHP) signal,” “the first output power being in the range of approximately 70% to 100% of a maximum continuous power (MCP) level,” and “the second output power . . . being in the range of approximately 70% of the MCP level to approximately a maximum intermittent power (MIP) level.” Pet. 19–41. Patent Owner does not direct us to any disclosure in Oehring or Shampine that are cumulative of these alleged teachings in Mu. Accordingly, we do not agree with Patent Owner that either of Oehring or Shampine is cumulative of Mu. As such, we determine that Petitioner’s reliance on Mu does not involve the same or substantially the same art or arguments previously presented to the Office, and the first part of the Advanced Bionics framework is not satisfied with respect to Mu. And although Crowe is cited in the ’764 patent (see Ex. 1001, code (56)), Petitioner’s reliance on Crowe is minimal. The ground based on Mu and Crowe, thus, does not implicate § 325(d).” slip op. at 8
- Skill levelOther
“This dispute presents a factual issue best decided on a complete record. Accordingly, for purposes of the Decision, we determine that no express finding is necessary, and that the level of ordinary skill in the art is reflected by the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). We note, however, that our obviousness analysis in this Decision would not differ if we adopted either Petitioner’s or Patent Owner’s definition.” slip op. at 11
- Expert testimonyPetitioner expert creditedDecided for petitioner
“Lastly, on the current record, we disagree with Patent Owner’s argument that Mr. Marscher is not qualified to serve as an expert in this proceeding. See Prelim. Resp. 8. Mr. Marscher’s declaration and curriculum vitae show that he has extensive education and experience in relevant fields. Ex. 1003 ¶¶ 8–17; Ex. 1004.” slip op. at 11
Claim construction§ 103 obviousness§ 112 disclosureDiscretionary denialcites Phillips · GrahamPatents in suitUS 10,815,764 - PTAB · Feb 8, 2022 · PGR2021-00102 · APJ Patrick R Scanlon · PGR · Institution
The Board instituted PGR on claims 1–28 on all asserted grounds, finding a sufficient likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 324(a), a post-grant review may not be instituted “unless . . . the information presented in the petition . . . , if such information is not rebutted, would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” After considering the Petition and Patent Owner’s Preliminary Response, as well as all supporting evidence, we determine that Petitioner has satisfied the burden under 35 U.S.C. § 324(a) to show that it is more likely than not that at least one of the challenged claims is unpatentable.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDenied
“These arguments are not persuasive, however, because Patent Owner does not explain adequately how the disclosures of Oehring and Shampine are cumulative of the disclosure of Mu. In this case, the mere fact that 8 We note that Exhibit 2007 does not have ¶ 95 cited by Patent Owner. not mean necessarily that the references are cumulative of Mu. For instance, Petitioner relies on Mu for allegedly disclosing several claim limitations including “receiving a demand hydraulic horse power (HHP) signal,” “the first output power being in a selected range of a maximum continuous power (MCP) level,” and “the second output power . . . being in a selected range of the MCP level to a maximum intermittent power (MIP) level.” Pet. 19–41. Patent Owner does not direct us to any disclosure in Oehring or Shampine that are cumulative of these alleged teachings in Mu. Accordingly, we do not agree with Patent Owner that either of Oehring or Shampine is cumulative of Mu. As such, we determine that Petitioner’s reliance on Mu does not involve the same or substantially the same art or arguments previously presented to the Office, and the first part of the Advanced Bionics framework is not satisfied with respect to Mu. And although Crowe is cited in the ’459 patent (see Ex. 1001, code (56)), Petitioner’s reliance on Crowe is minimal. The ground based on Mu and Crowe, thus, does not implicate § 325(d).” slip op. at 8
- Skill levelOther
“This dispute presents a factual issue best decided on a complete record. Accordingly, for purposes of the Decision, we determine that no express finding is necessary, and that the level of ordinary skill in the art is reflected by the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). We note, however, that our obviousness analysis in this Decision would not differ if we adopted either Petitioner’s or Patent Owner’s definition.” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed patent owner constructionTerm construed board ownOther
“We agree with Patent Owner that Petitioner has not explained sufficiently what a “maximum power output value” means in the context of the ’459 patent. Nor has Petitioner explained sufficiently why “maximum intermittent power” should be tied to the “maximum power output value.” In contrast, Patent Owner’s proposed construction is supported by the Specification, although we do not agree with the last clause of the construction because the references to “typical” values do not assist in understanding the claim language. Accordingly, for purposes of this Decision, we preliminarily construe “maximum intermittent power” to mean “an elevated operating output level that the pump unit may operate intermittently throughout its operating life without excessive damage to the pump unit.”” slip op. at 14
Claim construction§ 103 obviousness§ 112 disclosureDiscretionary denialcites Phillips · Graham · NautilusPatents in suitUS 10,907,459
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.