- PTAB · Aug 30, 2024 · IPR2022-01531 · APJ Devon Zastrow Newman · IPR · Remand
On remand, the Board instituted inter partes review of claims 1–17, 20–21, 24–26, and 29–34 on all grounds stated in the Petition.
RulingsRemand decision- Director reviewOther
“Petition did not establish a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims, and did not institute inter partes review. Paper 17 (“Inst. Dec.”). Petitioner requested Director review of our decision denying institution (Paper 18 (“Request”)). The Director delegated review of the decision to a Delegated Rehearing Panel. Paper 19. Patent Owner was granted the option to file a response to Petitioner’s Request (Paper 22 (“Request Resp.”)). The Director Review Panel (“DRP”) vacated our decision and remanded the case to this panel with a revised construction for claim 1. Paper 23 (“DRP Dec.”).” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may be instituted only if “the information presented in the petition . . . and any [preliminary] response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect (2018). Upon reconsideration of the briefing and the evidence of record in light of the DRP’s claim construction, we conclude that Petitioner has established a reasonable likelihood of prevailing on its assertion that at least one of the challenged claims is unpatentable. Accordingly, we grant institution of inter partes review of claims 1–17, 20–21, 24–26, and 29–34 of the ’682 patent.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDenied
“We find that Petitioner has demonstrated a material error by the Office in the prior consideration of Morales-Sanfrutos, Straus, Singh, and Lees. For instance, under the second prong of Advanced Bionics, we consider “(c) the extent to which the asserted art was evaluated during “(e) whether Petitioner has pointed out sufficiently how the Examiner erred in its evaluation of the asserted prior art.” Becton, Dickinson, 17–18. We agree with Petitioner that the Office overlooked Morales- Sanfrutos’ and Singh’s teachings during examination and reexamination. Pet. 79. Although Morales-Sanfrutos, Straus, and Singh were listed on an IDS, they were not the subject of a rejection during examination or reexamination. Moreover, for the reasons discussed below at this stage with regard to Petitioner’s grounds over Morales-Sanfrutos, as evidenced by Straus, and over Singh, Petitioner sufficiently demonstrates that the Office materially erred in overlooking Morales-Sanfrutos’s and Singh’s teachings regarding their linker structures. Id. Further, to the extent the Lees’ teachings were considered during examination and reexamination, Lees’ disclosure of a homobifunctional sulfone linker was overlooked. Lees’ homobifunctional linker, which Patent Owner argues is substantially similar to Harris’ homobifunctional linker, which Petitioner chiefly relies upon in Grounds 2–5, was not the subject of a rejection during examination. Pet. Resp. Brief 1; Prelim. Resp. 25–26. We agree with Petitioner that only Lees’ heterobifunctional linker was applied in a rejection during examination. Pet. Resp. Brief 1; Ex. 1018, 42–43, 62. 4. Conclusion For the foregoing reasons, we decline to exercise discretion to deny institution under § 325(d).” slip op. at 27
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Based on the information presented, we find that the asserted prior art itself is sufficient to demonstrate the level of skill in the art at the time of the (prior art itself can reflect the appropriate level of ordinary skill in the art). To the extent a more precise definition is required, we apply Petitioner’s unopposed definition for purposes of determining whether to institute review because it is consistent with the disclosures of the asserted prior art references.” slip op. at 15
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,131,682 - PTAB · Aug 29, 2014 · IPR2013-00178 · APJ Jon B Tornquist · IPR · Final written decision
The Board canceled claims 1–20 and denied substitution of claims 21–30 because the proposed claims lacked written-description support and were not shown patentable over prior art.
RulingsFinal written decision- PTAB / AIA Trials › Motions to amend / substitute claimsMotion to amend granted in partGranted in part
“2. Written Description Support Patent Owner bears the burden to show written description support in the original disclosure for each proposed substitute claim. 37 C.F.R. § 42.121(b)(1); 37 C.F.R. § 42.20(c). The test for written description support is “whether the disclosure of the application relied upon reasonably conveys to those skilled in the art that the inventor had possession of the claimed subject matter as of the filing date.” Ariad Pharm., Inc. v. Eli Lilly & Co., 598 F.3d 1336, 1351 (Fed. Cir. 2010).” slip op. at 8
- Skill levelSkill level board ownDecided for petitioner
“Dr. Sughrue testifies that one of ordinary skill in the art would have understood that the “different reactor configurations and catalysts” used in Jakkula “could and would lead to differing optimal temperatures from those reported in Craig.” Ex. 1040 ¶ 36 (emphasis added). For example, Dr. Sughrue testifies that one of ordinary skill in the art would have understood that reduced temperatures, as well as dilution—which was used in Jakkula but was not studied as an operating variable in Craig—could “greatly reduce the rate of dimerization and oligomerization of free fatty acids” and would lead to lower levels of high molecular weight hydrocarbons. Ex. 1040 ¶¶ 42, 60, 90; Ex. 1013, 4:11–13. Dr. Sughrue also provides evidence that in the years after the publication of Craig “the activity of hydroprocessing catalysts increased dramatically,” permitting lower reaction temperatures in the HDO step. Id. ¶¶ 31, 33. In light of these differences, Dr. Sughrue concludes that one of ordinary skill in the art “would not have been dissuaded from considering HDO reaction temperatures at or near the low end of the preferred temperature range taught in [Jakkula], e.g., 300 °C, or even lower temperatures within the more broadly taught range of 200-500 °C.” Ex. 1040 ¶ 37. We find Dr. Sughrue’s testimony persuasive. In particular, in light of Jakkula’s disclosed successful results, we are persuaded that one of ordinary skill in the art would not have viewed Craig’s 350 °C minimum temperature for “trouble-free operation” as a line not to be crossed, but would have understood that the optimal and minimum temperatures for the HDO step would vary depending on the particular reactor configuration and operating conditions used. See In re Boesch, 617 F.2d 272, 276 (CCPA 1980) (“Discovery of an optimum value of a results effective variable in a known process is ordinarily within the skill in the art.”). Although Dr. Klein presents an opposing view from that of Dr. Sughrue, upon review of both expert declarations and their corresponding depositions, on balance, we find that Dr. Sughrue’s testimony more persuasively considers not only the express teachings of Craig and Jakkula, but also the timing of the two disclosures, the differences in reactor configuration and operating conditions, and the knowledge, skill, and reasoning ability of one of ordinary skill in the art. Syntex (U.S.A.) LLC v. Apotex, Inc., 407 F.3d 1371, 1380 (Fed. Cir. 2005) (“What a reference teaches or suggests must be examined in the context of the knowledge, skill, and reasoning ability of a skilled artisan.”)” slip op. at 14
- Expert testimonyPetitioner expert creditedDecided for petitioner
“Dr. Sughrue testifies that one of ordinary skill in the art would have understood that the “different reactor configurations and catalysts” used in Jakkula “could and would lead to differing optimal temperatures from those reported in Craig.” Ex. 1040 ¶ 36 (emphasis added). For example, Dr. Sughrue testifies that one of ordinary skill in the art would have understood that reduced temperatures, as well as dilution—which was used in Jakkula but was not studied as an operating variable in Craig—could “greatly reduce the rate of dimerization and oligomerization of free fatty acids” and would lead to lower levels of high molecular weight hydrocarbons. Ex. 1040 ¶¶ 42, 60, 90; Ex. 1013, 4:11–13. Dr. Sughrue also provides evidence that in the years after the publication of Craig “the activity of hydroprocessing catalysts increased dramatically,” permitting lower reaction temperatures in the HDO step. Id. ¶¶ 31, 33. In light of these differences, Dr. Sughrue concludes that one of ordinary skill in the art “would not have been dissuaded from considering HDO reaction temperatures at or near the low end of the preferred temperature range taught in [Jakkula], e.g., 300 °C, or even lower temperatures within the more broadly taught range of 200-500 °C.” Ex. 1040 ¶ 37. We find Dr. Sughrue’s testimony persuasive. In particular, in light of Jakkula’s disclosed successful results, we are persuaded that one of ordinary skill in the art would not have viewed Craig’s 350 °C minimum temperature for “trouble-free operation” as a line not to be crossed, but would have understood that the optimal and minimum temperatures for the HDO step would vary depending on the particular reactor configuration and operating conditions used. See In re Boesch, 617 F.2d 272, 276 (CCPA 1980) (“Discovery of an optimum value of a results effective variable in a known process is ordinarily within the skill in the art.”). Although Dr. Klein presents an opposing view from that of Dr. Sughrue, upon review of both expert declarations and their corresponding depositions, on balance, we find that Dr. Sughrue’s testimony more persuasively considers not only the express teachings of Craig and Jakkula, but also the timing of the two disclosures, the differences in reactor configuration and operating conditions, and the knowledge, skill, and reasoning ability of one of ordinary skill in the art. Syntex (U.S.A.) LLC v. Apotex, Inc., 407 F.3d 1371, 1380 (Fed. Cir. 2005) (“What a reference teaches or suggests must be examined in the context of the knowledge, skill, and reasoning ability of a skilled artisan.”)” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner
“A reference may be said to teach away when a person of ordinary skill in the art, upon reading a reference, would be discouraged from following the path set out in the reference, or would be led in a direction divergent from the path that was taken by the applicant.” In re Gurley, 27 F.3d 551, 553 (Fed. Cir. 1994). “[I]n weighing the suggestive power of each reference, [the Board] must consider the degree to which one reference might accurately discredit another.” In re Young, 927 F.2d 588, 591 (Fed. Cir. 1991). When two references do not use directly comparable techniques or operating conditions, the impact of an allegedly discrediting reference may be significantly reduced. See id. at 592. slip op. at 14
§ 103 obviousnessPatents in suitUS 8,212,094
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.