- PTAB · Dec 16, 2024 · IPR2024-01013 · APJ Jon B Tornquist · IPR · Institution
The Board instituted IPR on claims 1–4 and 7–18 on all three asserted obviousness grounds, finding a reasonable likelihood of success and declining discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). Having considered the arguments and evidence set forth by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’483 patent. We also determine that the arguments and evidence of record do not support discretionary denial under either 35 U.S.C. § 314(a) or § 325(d). Accordingly, we institute an inter partes review as to all of the challenged claims of the ’483 patent on all of the grounds of unpatentability set forth therein.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“We agree with Patent Owner that, “given the breadth of remaining grounds of invalidity in parallel litigation,” Petitioner’s stipulation “would only resolve a small portion of the issues before the court.” Prelim. Sur-reply 3. Nevertheless, the stipulation offered by Petitioner does mitigate, at least to some extent, concerns of “potentially conflicting decisions.” Sand Revolution at 12. Accordingly, we determine that Fintiv factor 4 weighs, at least to some extent, against exercising our authority to deny institution.” slip op. at 33
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDecided for petitioner
“During prosecution, the examiner stated that the carbon nanotubes of the applied prior art reference “are considered discrete and exfoliated . . . because they are dispersed in the composite cathode slurry mixture.” Ex. 1002, 5–6. The Board determined, however, that “without more,” the examiner’s bare statement was insufficient to address the prior art reference’s “express teaching that suggests bundling or agglomeration of carbon nanotubes.” Id. at 6 (noting that Figure 2 of the prior art reference suggested that the carbon nanotubes were in fact bundled and agglomerated). In contrast to the art and analysis provided by the examiner during prosecution, Petitioner identifies a specific disclosure in Ohata demonstrating that the carbon nanotubes are “discrete, non-agglomerated, and exfoliated.” Pet. 32–33 (citing Ex. 1004, Fig. 1(b)). In further contrast to the arguments presented during prosecution, Patent Owner identifies no disclosure in Ohata, or any other prior art reference, that would suggest that the carbon nanotubes of Ohata, Kavan, and Gong or Liu are agglomerated or non-discrete. Prelim. Resp. 22–23. As such, we determine that the prior art and arguments set forth in the Petition are not substantially the same as those previously analyzed by the Office. Thus, we decline to exercise discretion to dismiss the Petition under 35 U.S.C. § 325(d).” slip op. at 37
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art would have had “at least a Master’s degree in materials science, chemistry, chemical engineering, a field relevant to polymer science and engineering, or the equivalent, and at least three years of experience in nanomaterials, electrochemistry, batteries, or polymer related activities.” Pet. 7. Petitioner further contends that “[a]dditional work experience can compensate for less formal education and vice versa.” Id. For purposes of its Preliminary Response, Patent Owner “does not dispute the Petition’s definition of [the] level of ordinary skill in the art.” Prelim. Resp. 3. On this record, we preliminarily adopt Petitioner’s definition of the person of ordinary skill in the art as it appears consistent with the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art).” slip op. at 6
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,153,483 - PTAB · Dec 16, 2024 · IPR2024-01011 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted IPR on claims 1–5 under all asserted grounds, finding a reasonable likelihood of prevailing on at least one claim and no basis for discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the arguments and evidence set forth by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’924 patent. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review as to all of the challenged claims of the ’924 patent on all of the grounds of unpatentability set forth therein.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Decided for petitioner
“Although the parties appear to agree that this factor is neutral, we note that a district court denial of a motion to stay without prejudice, accompanied by an indication that the district court would consider a renewed motion, “suggests the district court may be willing to avoid duplicative efforts and await the PTAB’s final resolution of the patentability issues raised in the petition before proceeding with the parallel litigation.” Fintiv at 6–7. “This fact has usually weighed against exercising authority to deny institution.” Id. (also noting that factors 2 and 3 are relevant to how much weight to give to the court’s willingness to reconsider a stay); see also T-Mobile, Paper 16 at 12 (noting that a stay was unlikely in that case given the proximity of the trial date to the entry of the institution decision). In view of the forgoing, we determine that Fintiv factor 1 weighs against exercising our authority to deny institution.” slip op. at 39
- Skill levelSkill level petitioner adoptedDecided for petitioner
“had at least a Master’s degree in materials science, chemistry, chemical engineering, a field relevant to polymer science and engineering, or the equivalent, and at least three years of experience in nanomaterials, electrochemistry, batteries, or polymer related activities” and that “[a]dditional work experience can compensate for less formal education, and vice versa.” Pet. 8 (citing Ex. 1003 ¶ 11). For purposes of its Preliminary Response, Patent Owner “does not dispute the Petition’s definition of [the] level of ordinary skill in the art.” Prelim. Resp. 2. On this record, we preliminarily adopt Petitioner’s definition of the person of ordinary skill in the art because it appears consistent with the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (holding that the prior art itself can reflect the appropriate level of ordinary skill in the art).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner argues that “no formal claim constructions are necessary.” Pet. 9. Patent Owner contends that all claim terms should be interpreted “in accordance with their ordinary and customary meaning.” Prelim. Resp. 2. Upon review of the record, we determine that no claim terms require express construction for purposes of this Decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 8
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,968,924 - PTAB · Dec 16, 2024 · IPR2024-01006 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted IPR of claims 1–8 on all petitioned grounds, finding a reasonable likelihood of success on the Ohata–Kavan obviousness challenge and no basis for discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the arguments and evidence set forth by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’909 patent. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review as to all of the challenged claims of the ’909 patent on all of the grounds of unpatentability set forth therein.” slip op. at 2
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“Contrary to Patent Owner’s arguments, the law on overlapping ranges in obviousness challenges is clear. See In re Peterson, 315 F.3d 1325, 1329 (Fed. Cir. 2003) (“A prima facie case of obviousness typically exists when the ranges of a claimed composition overlap the ranges disclosed in the prior art.”). Here, Petitioner directs us to evidence of an overlapping range, which is not meaningfully disputed by Patent Owner. As to Patent Owner’s arguments regarding the lower end of the claimed range of aspect ratios and Ohata’s warning about aspect ratios below 100, we note that Ohata states that its carbon nanotubes “preferably have an aspect ratio . . . of not less than 100,” and expressly includes examples with an aspect ratio of 50. Ex. 1004 ¶ 20 (emphasis added), Table 2 (Examples 12 and 14). Patent Owner also criticizes Petitioner for relying on oxidizing Ohata’s nanotubes in view of Kavan (discussed in more detail below). Prelim. Resp. 6. According to Patent Owner, oxidation is known to shorten the length of nanotubes, which would impact the aspect ratio of the nanotubes in the proposed combination. Prelim. Resp. 6. Specifically, Patent Owner contends that oxidizing Ohata’s nanotubes will reduce the aspect ratio below 100, and argues that “Petitioner has not explained why a [person of ordinary skill in the art] would ignore Ohata’s warning nor has Petitioner provided evidence that the resulting combination will perform as Petitioner alleges.” Prelim. Resp. 7; see also Prelim. Resp. 8 (arguing Petitioner has not explained why a person of ordinary skill in the art would try to retain Ohata’s aspect ratio and expect success when Ohata is altered in view of Kavan). Even giving Patent Owner’s arguments their full weight, there is no evidence on the present record as to how much the aspect ratio of Ohata’s nanotubes would be reduced as a result of oxidation. Rather, based on the present record, namely, the broad range of aspect ratios disclosed in Ohata (preferably 100–1000), it seems reasonably likely that the aspect ratio of at least some of the oxidized nanotubes in the proposed composition would remain within the range disclosed in Ohata and overlap the claimed range, as Petitioner asserts. Nevertheless, the parties may address during trial the expected level of carbon nanotube shortening in the proposed combination of Ohata and Kavan.” slip op. at 21
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner
“To the extent Patent Owner is presenting a teaching away argument, these statements do not rise to the level of criticizing, discrediting, or discouraging investigation into the claimed invention. DePuy Spine, Inc. v. Medtronic Sofamor Danek, Inc., 567 F.3d 1314, 1327 (Fed. Cir. 2009). Indeed, in addition to its statement regarding oxidation not being necessary for anchoring to TiO2, Kavan also states that oxidation of carbon nanotubes “was sometimes mentioned to improve anchoring of TiO2.” Ex. 1005, 2. Moreover, the full statement from Kavan regarding storage capacity reads: “The Li-storage capacity of TiO2 is not enhanced in the composite, but the rate of electrochemical charge transfer is higher due to nanotube networking.” Ex. 1005, 9. Thus, in its entirety, this statement supports Petitioner’s argument that there are advantages to using oxidized nanotubes, and, in turn, provides a reason why a person of ordinary skill in the art would have used oxidized nanotubes. Moreover, the evidence Petitioner presents regarding the use of oxidized nanotubes in combination with TiO2, coupled with Ohata’s statement that the electrode active material to be used can vary depending on the battery type (Ex. 1004 ¶¶ 26–27), undermines Patent Owner’s criticism that Petitioner’s arguments are circular.” slip op. at 24
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“Although the parties appear to agree that this factor is neutral, we note that a district court denial of a motion to stay without prejudice, accompanied by an indication that the district court would consider a renewed motion, “suggests the district court may be willing to avoid duplicative efforts and await the PTAB’s final resolution of the patentability issues raised in the petition before proceeding with the parallel litigation.” Fintiv at 6–7. “This fact has usually weighed against exercising authority to deny institution.” Id. (also noting that factors 2 and 3 are relevant to how much weight to give to the court’s willingness to reconsider a stay); see also T-Mobile, Paper 16 at 12 (noting that a stay was unlikely in that case given the proximity of the trial date to the entry of the institution decision). In view of the forgoing, we determine that Fintiv factor 1 weighs against exercising our authority to deny institution.” slip op. at 37
§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,808,909 - Intel Corporation v. Besang Inc.No claims unpatentablePTAB · Dec 11, 2024 · IPR2023-00991 · APJ Jon B Tornquist · IPR · Final written decision
The Board held claims 1 and 13–17 not unpatentable, finding the asserted obviousness grounds deficient in claim limitations or motivation to combine.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“The parties proposed definitions differ in that Petitioner would permit a degree in “materials science” and require three years, as opposed to two years, of relevant experience. Compare Pet. 9 with PO Resp. 14. On this record, we adopt Patent Owner’s proposed definition, as it is more consistent with the prior art of record and the disclosures of the ’702 patent. We note, however, that neither party contends that the outcome of this case depends on the slight differences in the proposed definitions of a person of ordinary skill in the art.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“1996) (“It is well-settled that, in interpreting an asserted claim, the court should look first to the intrinsic evidence of record, i.e., the patent itself, including the claims, the specification and, if in evidence, the prosecution history.”). Upon review of the parties’ arguments and the intrinsic record, we agree with Petitioner that the ’702 patent does not support a construction of “stackable add-on layer” that encompasses memory cells formed by sequential deposition on a substrate without being formed and then added to a separately formed substrate. Pet. 11–12. First, the plain language of the claim does not require merely a “layer” having a plurality of vertically oriented semiconductor memory cells, but rather “a stackable add-on layer” having a plurality of vertically oriented semiconductor memory cells; that plurality is bonded to the dielectric layer. Ex. 1001, 12:29–32. A construction that gives meaning to all words of the claim is preferred. Merck & Co., Inc. v. Teva Pharm. USA, Inc., 395 F.3d 1364, 1372 (Fed. Cir. 2005) (“A claim construction that gives meaning to all the terms of the claim is preferred over one that does not do so.”).” slip op. at 12
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“As discussed above, we do not understand a “stackable add-on layer” to include memory cells that are formed by sequential deposition on or above a substrate without being added to a separately formed substrate. It is undisputed, and indeed it is Petitioner’s assertion, that Lee’s memory devices are formed by sequential deposition. Pet. 16, 29 n.11, 51 (“In Lee, each level 3104 is deposited on the underlying level of array 3101.”). Therefore, Petitioner has not shown that Lee discloses every limitation of independent claim 13 under our claim construction. Thus, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious in view of Lee. 3. Analysis: Claims 14–17 Claims 14–17 each depend, directly or indirectly, from claim 13. Petitioner’s arguments with respect to these claims do not remedy the deficiencies noted above with respect to claim 13. Pet. 31–41. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 14–17 would have been obvious over Lee.” slip op. at 19
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“We agree with Patent Owner that Petitioner has not demonstrated that Aspar would improve Lee, would solve a problem in Lee, and that Petitioner is proposing to use Aspar in a way that is not disclosed in the reference. PO Resp. 49–50 (citing Ex. 2029 ¶¶ 153–162); Tr. 57:24–58:12; Pet. 61; KSR, 550 U.S. at 417 (asking whether a technique “would improve similar devices in the same way”), 420 (asking whether there was a known problem in the art), 421 (asking whether one of ordinary skill in the art had reason to “pursue the known options”); Intel, 61 F.4th at 1381 (explaining that obviousness may be demonstrated by showing that there was a known problem in the art (“cache coherency in multiprocessor systems”) and that a person of ordinary skill in the art would recognize that that the prior art solution to this problem (“global segmented secondary cache”) would improve the system of another prior art reference). Petitioner does not persuasively show that there was any known problem in the art with respect to Lee or its monolithic method of constructing memory arrays. Nor does Petitioner provide persuasive argument or evidence that Aspar’s wafer bonding would improve Lee’s memory device.10 For example, Petitioner states in a conclusory fashion that Aspar would address the known problem of “fabricating 3D structures,” but does not explain what those problems were or why Lee fails to solve them. Pet. 61. Dr. Sechen’s testimony merely parrots the Petition, providing no further analysis or explanation of what problem might exist in Lee when fabricating its 3D structures. Ex. 1003 ¶ 212. The Petition notes that Aspar transfers “thin layers of very good thickness homogeneity and with a high crystalline quality,” but the Petition never asserts that Lee’s direct deposition method fails to provide these same or similar qualities. Pet. 60–61.” slip op. at 27
Patent outcomesUS 7,378,702 not shown unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,378,702 - Meta Platforms, Inc. / Instagram, Inc. et al. v. VL Collective IP LLCAll claims unpatentablePTAB · Dec 5, 2024 · IPR2023-00923 · APJ Jeffrey S Smith · IPR · Final written decision
Claims 1–28 are unpatentable as obvious over the asserted combinations of Handley, Basturk, and PacketCable; Judge McKone dissented over the printed-publication findings.
RulingsFinal written decision- Expert testimonyOther
“broadly, how skilled artisans in the cable industry in 1999 shared information, is not based on her expertise and should not be given any weight. See Daubert v. Merrell Dow Pharms., Inc., 509 U.S. 579, 592, (1993) (“Presumably, this relaxation [in FED. R. EVID. 702] of the usual requirement of firsthand knowledge—a rule which represents ‘a ‘most pervasive manifestation’ of the common law insistence upon ‘the most reliable sources of information,’ ’ is premised on an assumption that the expert’s opinion will have a reliable basis in the knowledge and experience of his discipline.” (internal citation omitted)); FED. R. EVID. 701 (“If a witness is not testifying as an expert, testimony in the form of an opinion is limited to one that is: (a) rationally based on the witness’s perception.”). I would find that Dr. Hall-Ellis’s opinions are not based either on her expertise or her perception; thus, I would give her opinions no weight. As to matters within her expertise, Dr. Hall-Ellis testified that she searched the Wayback Machine and library cataloging resources (e.g., WorldCat) for PacketCable and did not find it as of December 1, 1999. 25:19–26:8, 36:13–15. She further testified that she has no knowledge of whether or how PacketCable was cataloged, on CableLabs’ website or elsewhere. Id. at 50:5–13, 51:10–52:8. This testimony is credible, as it is within her expertise. Thus, I believe Dr. Hall-Ellis that no sources typically consulted by librarians cataloged or recorded PacketCable in 1999. When her expertise is considered, all Dr. Hall-Ellis has been able to establish is that there is no evidence that PacketCable was stored or cataloged, in 1999, in the places where a librarian was apt to look.” slip op. at 108
- Skill levelOther
“VI. CLAIM CONSTRUCTION We interpret claim terms using “the same claim construction standard” slip op. at 8
- Obviousness (§103) › Analogous artAnalogous artUnpatentable
“Conclusion for Reasons to Combine We agree with Petitioner that Basturk teaches generating signatures “on-the-fly” as transmission proceeds in order to avoid slowing down the regular flow of data. Pet. 11 (quoting Ex. 1006, 12). We agree with Petitioner that Handley’s RTP protocol used for video conferences would benefit from Basturk’s protocol for high speed networks in order to provide secure video conferences as taught by Basturk. Id. (citing Ex. 1006, 5; Ex. 1003 ¶ 66). We agree with Petitioner that a person of ordinary skill in the art would have used Basturk’s technique of computing signatures “on-the-fly” with Handley’s internet conferencing architecture to provide the known benefits of transmitting data faster, reducing jitter, and reducing computing power. Id. at 10 (citing Ex. 1003 ¶ 64). We agree with Petitioner that Handley describes the need for providing authentication in a multicast environment, and that Basturk addresses this need as well as provides a solution. Id. at 12–13 (citing Ex. 1005, 13; Ex. 1006, 3; Ex. 1003 ¶ 68). We agree with Petitioner that modifying Handley’s RTP transport protocol to include Basturk’s known authentication method of generating signatures “on-the-fly” while transmitting data is “the mere application of a known technique to a piece of prior art ready for improvement.” Id. at 13 (citing Ex. 1003 ¶ 70); KSR, 550 U.S. at 417. In addition, we find that Dr. Houh’s testimony supports Petitioner’s reasons to combine Handley and Basturk. As discussed above, we find Dr. Houh’s testimony more persuasive than Dr. Stubblebine’s testimony because Dr. Houh’s testimony is supported by and consistent with the disclosures of Basturk and Handley. Dr. Houh testifies that generating a signature “on-the-fly” as data is being transmitted provides the benefits of transmitting data faster, reducing jitter, reducing computing power, and reducing latency in a live transmission. Ex. 1003 ¶ 64. We agree with Dr. Houh and find that a person of ordinary skill in the art, faced with the need to provide a signature at the application layer in Handley’s multimedia conferencing architecture as taught by Handley (Ex. 1005, 2, 13) while minimizing latency as taught by both Handley (Ex. 1005, 13–14) and Basturk (Ex. 1006, 7, 12), would have computed the signature “on-the-fly” as taught by Basturk (Ex. 1006, 7, 12) at the application layer of Handley to yield the benefits of authenticating data while minimizing latency as taught by Basturk. Ex. 1003 ¶¶ 63–70. Dr. Houh testifies that a person of ordinary skill in the art, in order to” slip op. at 40
- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedDecided for patent owner
“Handley, Ex. 1005, qualifies as a prior art printed publication. I also disagree that Petitioner has shown that PacketCable qualifies as a prior art printed publication. Thus, I would not find that Petitioner has shown, by a preponderance of the evidence, that any claim of the ’682 is unpatentable. Accordingly, I dissent.” slip op. at 92
Patent outcomesUS 7,266,682 unpatentable§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,266,682 - Meta Platforms, Inc. / Instagram, Inc. et al. v. VL Collective IP LLCSome claims unpatentablePTAB · Dec 5, 2024 · IPR2023-00924 · APJ Jeffrey S Smith · IPR · Final written decision
Claims 1–3, 5–7, 9–11, and 13–15 are unpatentable as obvious over Zhao; claims 4, 8, 12, and 16 are not shown unpatentable.
RulingsFinal written decision- BurdenFwd mixedMixed
“Decision is a final written decision under 35 U.S.C. § 318(a) and 37 C.F.R. § 42.73 as to the patentability of claims 1–16 of the ’980 patent. We determine Petitioner has shown by a preponderance of the evidence that claims 1–3, 5–7, 9–11, and 13–15 are unpatentable, and Petitioner has not shown by a preponderance of evidence that claims 4, 8, 12, and 16 are unpatentable.” slip op. at 2
- Expert testimonyOther
“being present in another image or comparing that probability to a detection threshold.”). Dr. Saber was consistent with this testimony on cross-examination. Ex. 1051, 167–251. When I weigh the evidence, I find it to be one-sided, with all of the expert testimony weighing against Petitioner or avoiding the issue altogether. Thus, I would not find that Petitioner has met its burden to prove, by a preponderance of the evidence, that Zhao teaches claim limitation 1e. Moreover, even if the Majority is correct about how Zhao’s RCR algorithm works, all that shows is that the detection of object presence in a previous image can be used to disambiguate segments (e.g., limbs) of an already detected object (e.g., a person), not that it can be used to detect the object in the image in the first place, as required by the claim language. For this additional reason, I would not find that Petitioner has met its burden.” slip op. at 84
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“2. Reasons for Obviousness Based on Zhao On a limitation-by-limitation basis, Petitioner’s contentions of” slip op. at 25
- Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableUnpatentable
“2. Reasons for Obviousness Based on Zhao On a limitation-by-limitation basis, Petitioner’s contentions of “obviousness” are primarily assertions of how a POSITA would have understood Zhao’s disclosures. For example, with regard to claim 1, Petitioner repeatedly asserts how “a POSITA would have understood Zhao” (Pet. 13, 18, 21, 27) and for each limitation contends that Zhao “disclosed or at least rendered obvious” (or a variation thereof) the limitation (id. at 13– 15, 17–18, 21, 23, 25–27). We will, accordingly, address these “obviousness” contentions when addressing the respective limitations.” slip op. at 25
Patent outcomesUS 7,436,980 mixed§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,436,980 - General Motors LLC v. Edward H. NortrupAll claims unpatentablePTAB · Nov 22, 2024 · IPR2023-00994 · APJ Michelle N Wormmeester · IPR · Final written decision
Claims 1–31 are unpatentable, principally as obvious over Knockeart and Feldman, with dependent claims also held obvious over additional combinations.
RulingsFinal written decision- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundDecided for petitioner
“the proposed alternative configuration. See Intel Corp. v. PACT XPP Schweiz AG, 61 F.4th 1373, 1381 (Fed. Cir. 2023). Also, protecting the privacy of individuals provides further reason for combining Knockeart and Feldman. See In re Kahn, 441 F.3d 977, 988 (Fed. Cir. 2006) (“[T]here must be some articulated reasoning with some rational underpinning to support the legal conclusion of obviousness.”).” slip op. at 32
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“preponderance of the evidence that claims 1–7, 9, 10, 12–21, 25, 26, 29, and 31 would have been obvious over Knockeart and Feldman, that claims 7 and 8 would have been obvious over Knockeart, Feldman, and Simske, that claims 10, 11, and 30 would have been obvious over Knockeart, Feldman, and Whitsell, that claims 22–24 would have been obvious over Knockeart, Feldman, and Boies, and that claims 27 and 28 would have been obvious over Knockeart, Feldman, and Peterson. See supra Parts III.B–III.F. Because these five asserted challenges are dispositive as to all the challenged claims, namely, claims 1–31, we need not reach either the asserted challenge based on Knockeart, Feldman, Boies, and Peterson, or the asserted challenge based on Knockeart, Feldman, and Craine with respect to any of these claims. See SAS Inst. Inc. v. Iancu, 138 S. Ct. 1348, 1359 (2018) (holding that a petitioner “is entitled to a final written decision addressing all of the claims it has challenged”); Bos. Sci. Scimed, Inc. v. Cook Grp. Inc., 809 F. App’x 984, 990 (Fed. Cir. 2020) (nonprecedential) (recognizing that the “Board need not address issues that are not necessary to the resolution of the proceeding” and agreeing that the Board has “discretion to decline to decide additional instituted grounds once the petitioner has prevailed on all its challenged claims”). Accordingly, we do not reach Petitioner’s arguments that claim 14 would have been obvious over Knockeart, Feldman, Boies, and” slip op. at 80
Patent outcomesUS 10,444,028 unpatentable§ 103 obviousnesscites Phillips · KSRPatents in suitUS 10,444,028 - Micron Technology, Inc. / Micron Semiconductor Products, Inc. et al. v. Besang Inc.No claims unpatentablePTAB · Nov 13, 2024 · IPR2023-00900 · APJ Jon B Tornquist · IPR · Final written decision
Claims 13–17 were not shown unpatentable: Lee-based grounds fail on the stackable add-on layer limitation, and Watanabe-based grounds fail on nonvolatile memory, enablement, or motivation to combine.
RulingsFinal written decision- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“meaning in the art. See Irdeto Access, Inc. v. Echostar Satellite Corp., 383 F.3d 1295, 1300 (Fed. Cir. 2004) (stating that, absent an accepted meaning in the art, “we construe a claim term only as broadly as provided for by the patent itself”). Thus, we must attempt to discern the meaning of this term from the claim language itself and from the remainder of the intrinsic record. See Vitronics Corp. v. Conceptronic, Inc., 90 F.3d 1576, 1582 (Fed. Cir. 1996) (“It is well-settled that, in interpreting an asserted claim, the court should look first to the intrinsic evidence of record, i.e., the patent itself, including the claims, the specification and, if in evidence, the prosecution history.”). Upon review of the parties’ arguments and the intrinsic record, we agree with Petitioner that the ’702 patent does not support a construction of “stackable add-on layer” that encompasses memory cells formed by sequential deposition on a substrate without being formed and then added to a separately formed substrate.” slip op. at 10
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“As discussed above, we construe “stackable add-on layer” to not include memory cells that are formed by sequential deposition on or above a substrate without being added to a separately formed substrate. It is undisputed, and indeed it is Petitioner’s assertion, that Lee’s memory devices are formed by sequential deposition. See Pet. 52 (asserting that in Lee “the layers of the array are directly deposited on the layers of each underlying level, and the array is deposited on the interlayer insulating layer formed over a substrate”); see also id. at 70 (“Lee discloses forming vertical memory devices through layer-by-layer sequential deposition on the substrate . . . .”). Therefore, Petitioner does not show that Lee discloses every limitation of independent claim 13 under our claim construction. Thus, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious in view of Lee. 3. Claims 14 and 15 Claims 14 and 15 depend from claim 13. Ex. 1001, 12:35–42. Petitioner’s arguments for these claims do not remedy the deficiencies noted above with respect to independent claim 13. Pet. 54–59. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 14 and 15 would have been obvious in view of Lee alone. E. Claims 16 and 17 over Lee and Endoh Petitioner contends the subject matter of claims 16 and 17 would have been obvious over the combined disclosures of Lee and Endoh. Pet. 59–69. Petitioner’s arguments with respect to these claims, however, do not remedy the deficiencies noted above with respect to Lee and its monolithic, sequentially deposited memory array. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 16 and 17 would have been obvious over Lee and Endoh.” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“combined Lee and Watanabe to achieve improved integration density. Pet. 71. Petitioner concedes, however, that the benefits of Lee’s design related to 3-D integration and improved integration density would be obtained if Lee’s memory structures are formed using either Lee’s monolithic construction method or Watanabe’s alternative stacking method. Pet. Reply 13–14 (citing Ex. 1041 ¶ 34). Thus, we are not persuaded that improved integration density provides a sufficient rationale for Petitioner’s combination of Lee’s memory device and Watanabe’s stacking method. Petitioner argues that Watanabe’s stacking method “improves the accuracy of the wiring” because the wiring is made “for each planar member.” Pet. 72 (citing Ex. 1005, 6:1–3). Watanabe also states that its disclosed methods provide “a low interconnection wire resistance.” Ex. 1005, 6:20–23. Petitioner does not, however, explain sufficiently how Watanabe’s stacking method would improve Lee’s device. For example, Petitioner does not address whether the alleged wiring benefit already existed in Lee’s monolithic array or explain how this benefit would also apply to Lee’s particular memory array, which differs in construction and elements from Watanabe’s device. This diminishes Petitioner’s benefits-based motivation to combine arguments. In general, a petitioner need not demonstrate that a particular alternate method would improve a prior art device in order to show a motivation to combine. Intel Corp. v. PACT XPP Schweiz AG, 61 F.4th 1373, 1380–81 (Fed. Cir. 2023); see Pet. Reply 20 (citing Intel). But here, Petitioner affirmatively invokes improvement of Lee’s device as a reason for the combination, and we must evaluate Petitioner’s contention. Moreover, any relative lack of improvement or benefits must be weighed against any problems the alternative method would introduce. See Intel Corp. v. Qualcomm Inc., 21 F.4th 784, 795–96 (Fed. Cir. 2021) (noting that simultaneous advantages and disadvantages to a proposed combination must be analyzed to determine whether the disadvantages “outweighed any reason to combine”). Here, as discussed above in more detail with respect to the ground based on Watanabe, the evidence shows that one of ordinary skill in the art would have expected Watanabe’s bonding temperature of 900– 1000° C to damage the electronic devices in an underlying substrate. Ex. 2029 ¶¶ 75–76; Ex. 2028, 123:13–124:7; Ex. 2027, 715. The expected damage to Lee’s device, when balanced against the limited evidence of a benefit to the combination,7 outweighs the reason to combine Lee and Watanabe set forth in the Petition. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious over Lee and Watanabe. 2. Analysis – Claims 14 and 15 Claims 14 and 15 both depend directly from independent claim 13. Ex. 1001, 12:35–42. Petitioner’s arguments with respect to claims 14 and 15 do not remedy the deficiencies noted above with respect to independent claim 13. Pet. 73. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that these claims would have been obvious over Lee and Watanabe.” slip op. at 40
- Expert testimonyPatent owner expert creditedOther
“We credit the testimony of Dr. Przybylski that one of ordinary skill in the art would have understood that Watanabe’s stacked structure would be severely impacted if bonded at a temperature above 900° C, as disclosed in Watanabe. Ex. 2029 ¶¶ 76–77. Dr. Przybylski’s opinion is supported by Dr. Lee’s testimony (Ex. 2028, 123:13–124:7, 125:6–126:7), as well as Watanabe (Ex. 1005, 6:6–14) and Batude (Ex. 2027, 715). As further discussed below, we find that Petitioner has not rebutted Patent Owner’s showing of nonenablement, and Patent Owner has carried its burden to demonstrate that Watanabe was not enabled for bonding temperatures of 900–1000° C, as of the 2004 filing date of the ’702 patent.” slip op. at 32
Patent outcomesUS 7,378,702 not shown unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,378,702 - Lenovo (United States) Inc. / Motorola Mobility LLC v. Theta IP, LLCNo claims unpatentablePTAB · Oct 16, 2024 · IPR2023-00697 · APJ Barbara A Benoit · IPR · Final written decision
Claims 1, 3, 4, and 8 were not proven unpatentable: Rauhala does not disclose the required simultaneous signal-strength determinations, and Masaaki does not cure the deficiency for claim 4.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Following institution, Patent Owner maintained the same level of ordinary skill proposed in its preliminary response and did not address our discussion of the level of ordinary skill in the art in the Institution Decision. PO Resp. 24–25; see also Prelim. Resp. 24. For the reasons discussed in the Institution Decision, we adopt and apply for this Decision the level of ordinary skill articulated by Petitioner and used previously in our Institution Decision. See Dec. 8–10. In light of our review of the complete record, we find that this formulation is consistent with the ’825 patent, the prior art of record, and is supported by the testimony of Dr. Baker. See Ex. 1002 ¶¶ 27– 31. Our decision would not change, however, if we had applied Patent Owner’s proposed level of ordinary skill.” slip op. at 12
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“We agree with Patent Owner that the desired signal and interferer signal must be received at the same time. The plain language of the claim requires the wireless transceiver to “receiv[e] a wireless signal having a desired signal and an interferer signal,” the determining of a signal strength of the interferer signal and the determining of a signal strength of the desired signal must be performed at the same time; otherwise, the determinations of signal strengths would not be of the same wireless signal. The specification supports this understanding. “When a receiver is actively receiving a desired signal, each block in the signal path has at its input the desired signal as well as noise and possibly interfering signals.” Ex. 1001, 5:20–22; see also id. at 5:31–33 (“FIGS. 2A and 2B illustrate examples of desired signals, interferers, and noise that may be received by one of the various circuits in a” slip op. at 21
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“We agree with Patent Owner that Rauhala does not state that the signal strengths are measured simultaneously or at the same time. Indeed, as discussed above, Rauhala indicates unequivocally in the same paragraph the opposite—that detector DET provides to control unit 42 “an indication about either the receive channel signal strength RSS or the strength of any signal on the reception band.” Ex. 1004 ¶ 17. Rauhala describes that “control unit 42 provides two one-bit control signals cA and cM” based on indications received from detector DET. Id. Importantly, Rauhala indicates that “at the same time as” describes how the control unit 42 uses the received inputs RSS and RSSn shown in Figure 4, which are described earlier in paragraph 17 as indications of either RSS or RSSn from detector DET. Id. (“Signal cA is 0 when signal RSS is greater than S4 and signal RSSn is at the 11 Dr. Baker’s reply declaration correctly quotes Rauhala paragraph 17 but cites to paragraph 18. We deem this harmless error. same time smaller than Sn. . . . Signal cM is 1 when signal RSS is not greater than S4 and signal RSSn is at the same time at least Sn. Otherwise, signal cM is 0.”). The burden remains on Petitioner to demonstrate by a preponderance of the evidence that Rauhala discloses the disputed limitations as arranged or combined in the claim. Petitioner does not persuasively reconcile these “either/or” statements regarding the functioning of detector DET with the “at the same time as” statements regarding control signals output by control unit 42 in paragraph 17. We do not find persuasive Petitioner counsel’s position expressed at the hearing that Rauhala’s “either/or” statements are “simply an imprecise description” (Tr. 16:22–24). We do not see a lack of precision in Rauhala’s “either/or” statements.” slip op. at 30
- Expert testimonyPetitioner expert discountedPatent owner expert creditedDecided for patent owner
“When asked at his deposition to explain Rauhala’s use of the word “or” regarding the functioning of detector DET, Dr. Baker asserted that “[detectors] can be designed to determine RSS or RSSn.” Ex. 2016, 85:5– 12. We find Dr. Baker’s testimony that “it’s reasonable that if you can design . . . the detector to detect one or the other, you can also design it to detect both” to be without factual support. Id. at 85:13–16. He points to no textbook or other independent evidence to support that would have led one of ordinary skill to design such a detector or to support that one of ordinary skill would have understood Rauhala’s detector to be so designed. Furthermore, Dr. Baker recognizes that “Rauhala doesn’t teach the details of what’s in the detector.” Id. at 91:6–7. We give little weight to Dr. Baker’s unsupported testimony that one could design a detector to detect both RSS and RSSn from the same wireless signal. See 37 C.F.R. 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); see also Xerox Corp. v. Bytemark, Inc., No. IPR2022-00624, 2022 WL 3648989, at *6 (PTAB 2022) (precedential) (Director affirming because “the cited declaration testimony is conclusory and unsupported, adds little to the conclusory assertion for which it is offered to support, and is entitled to little weight”).” slip op. at 31
Patent outcomesUS 10,129,825 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,129,825 - Lenovo (United States) Inc. / Motorola Mobility LLC v. Theta IP, LLCNo claims unpatentablePTAB · Oct 16, 2024 · IPR2023-00698 · APJ Thomas L Giannetti · IPR · Final written decision
Claims 7–11, 13, and 19–21 were not shown unpatentable because Rauhala does not disclose simultaneous desired and interferer signal-strength determinations, defeating anticipation and the obviousness combination.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“The two proposals are materially similar in the education requirement, but differ marginally in professional experience required (three versus five years). See supra. While we were persuaded, on the preliminary record, that both Petitioner’s and Patent Owner’s proposals were consistent with the problems and solutions in the ’202 patent and the prior art of record, on balance, we determined that Petitioner’s proposal was a better reflection of the level of skill in the prior art, and we therefore adopted it for our Institution Decision. See Institution Dec. 12–13. For this Decision, we adopt the description of the person of ordinary skill articulated by Petitioner and used previously in our Institution Decision. In light of our review of the complete record, we find that this formulation is consistent with the ’202 patent, the prior art of record, and is supported by the testimony of Dr. Baker. See Baker I Decl. ¶¶ 28–32. Our Decision would not change, however, if we had applied Patent Owner’s proposed level of ordinary skill.” slip op. at 12
- Expert testimonyPetitioner expert discountedDecided for patent owner
“85:13–16. He admits that “Rauhala doesn’t teach the details of what’s in the detector.” Id. at 91:6–7. He points to no textbook or other independent evidence that would have led a person of ordinary skill to design such a detector. Our Trial Practice Guide cautions against crediting such unsupported testimony: The Board has broad discretion to assign weight to be accorded expert testimony. Yorkey v. Diab, 601 F.3d 1279, 1284 (Fed. Cir. 2010). However, the testimony must be based on sufficient facts and data. Fed. R. Evid. 702(b). “Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.” 37 C.F.R. § 42.65(a). Patent Trial and Appeal Board Consolidated Trial Practice Guide 35 (Nov. 2019).7 We therefore give Dr, Baker’s unsupported testimony on this issue little weight.” slip op. at 24
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“We construe claim terms only as relevant to the parties’ contentions and only to the extent necessary to resolve the issues in dispute. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999); Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Matal, 868 F.3d 1013, 1017 (Fed. Cir. 2017). Having considered the positions of the parties, we find that for the purpose of this decision, we do not need to construe these terms to resolve a dispute.” slip op. at 9
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“requirement.” Pet. Reply 5. We do not agree with Petitioner. We find that the language of the claims supports Patent Owner’s argument that the desired signal and the interferer signal are received together. As discussed infra, claim limitations 7.7 and 7.8 recite determining a signal strength of the interferer signal and determining a signal strength of the desired signal. These determinations must be performed at the same time; otherwise, the determinations of signal strengths would not be of the same wireless signal. See Larson II Decl. ¶ 70; Baker II Decl. ¶¶ 48–49 (explaining that consideration of signal strengths detected at the same time would be “essential”). The specification of the ’202 patent further supports this finding: “When a receiver is actively receiving a desired signal, each block in the signal path has at its input the desired signal as well as noise and possibly interfering signals.” Ex. 1001, 5:22–24; see also Figs. 2A, 2B (showing interferer signals and desired signals together).” slip op. at 17
Patent outcomesUS 10,524,202 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites GrahamPatents in suitUS 10,524,202
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.