- Apple Inc. v. Apex Beam Technologies LLCInstitutedPTAB · Nov 4, 2025 · IPR2025-00898 · APJ Scott Raevsky · IPR · Institution
The Board instituted review of claims 1–20 on all asserted challenges, finding a reasonable likelihood that claims 1, 6, 11, and 16 would have been obvious over Kim and Chen.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“After considering the parties’ arguments and evidence, and for the reasons set forth below, Petitioner demonstrates a reasonable likelihood of prevailing with respect to at least one of the challenged claims of the ’271 patent. See 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review with respect to all challenged claims and challenges asserted in the Petition. 37 C.F.R. § 42.108(a).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Pet. 4 (citing Ex. 1003 ¶¶ 10, 16, 29–32). Patent Owner uses Petitioner’s proposed level of skill in the art at this stage. Prelim. Resp. 6. We are persuaded, on the present record, that Petitioner’s proposal is consistent with the problems and solutions in the ’271 patent and prior art of record. We adopt Petitioner’s definition of the level of skill at this stage.” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“The parties do not propose any explicit claim constructions. See Pet. 4–6; Prelim. Resp. 6. As no terms are in dispute, we do not construe any terms. Petitioner discusses constructions proposed by Patent Owner in the Samsung IPR, but Patent Owner does not rely on those constructions here. Pet. 4–6 (citing IPR2023-00747, Paper 14 at 11–13). We therefore do not address them at this stage.” slip op. at 6
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“discloses the claimed “proportional sequence.” Prelim. Resp. 9. First, Patent Owner contends that “indexes of antenna port groups with RSRP measurement values higher than a certain threshold are not a sequence of ratios,” but rather, just an identification of antenna port groups. Id. (emphasis added). We disagree, on this record. The flaw in this reasoning is that the claim does not require the first proportional sequence to be a sequence of ratios. Rather, the claimed “first proportional sequence” merely “corresponds to . . . ratios.” Thus, Patent Owner’s argument that the indexes “are not a sequence of ratios” is not commensurate with the scope of the claim. Petitioner persuades us, at this stage, that the indexes correspond to ratios (e.g., RSRP_n/max(RSRP_i)). See Pet. 32–33.” slip op. at 7
Claim construction§ 103 obviousnesscites GrahamPatents in suitUS 10,951,271 - PTAB · Sep 19, 2025 · PGR2025-00025 · APJ Kimberly Mcgraw · PGR · Institution
The Board instituted PGR on claims 1–19 and all asserted grounds, finding it more likely than not that claim 1 is anticipated by the Gatorade Label.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“if “the information presented in the petition . . . demonstrate[s] that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” Post-grant review is available for patents that issue from applications that at one point contained at least one claim with an effective filing date on or after March 16, 2013. See Leahy-Smith America Invents Act, Pub. L. No. 112-29, 125 Stat. 284 (2011) (“AIA”), §§ 3(n)(1), 6(f)(2)(A). After considering the briefing and the evidence of record, for the reasons set forth below, we determine that Petitioner has shown that the ’422 Patent is eligible for post-grant review and has shown it is more likely than not that at least one challenged claim of the ’422 Patent is unpatentable under § 324(a). Accordingly, we institute a post-grant review of the challenged claims of the ’422 Patent.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art Petitioner contends that a person of ordinary skill in the art “would possess at least (1) a Bachelor’s degree in chemistry or a related field, with (2) five years of experience in material identification and characterization using multiple analytical methods and field sampling, or equivalent research or professional experience.” Pet. 12 (citing Ex. 1014 ¶ 24). Patent Owner does not dispute Petitioner’s definition for one of ordinary skill in the art nor provide a proposed definition of its own. See generally Prelim. Resp. For the purposes of this Decision, we adopt Petitioner’s undisputed proposal regarding the level of one of ordinary skill in the art.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Prosecution history disclaimer / disavowalDisclaimer foundDecided for patent owner
“336. The applicant explained that not all combinations of shrink films and light blocking materials are recyclable. Id. at 335. The applicant explained that films can be compatible with PET recycling in two ways, (1) the film can float in water and be separated from PET that sinks in water or (2) the PET films crystallize and “can be recovered with the PET stream.” Id. at 336 (citing “A Resource Document by the Association of Plastic Recyclers (APR)”) (found at Ex. 1002, 323–332) (emphasis omitted). The applicant explained that “removing the label before or during the recycling process is not evidence of the recyclability of the label” and that “[r]emoving the label during the recycling process is not equivalent to actually recycling the label.” Id. at 335. As such, a POSITA reading the prosecution history would understand that a label is not recyclable with a PET container, as recited by the independent claims, by removing the label from the PET recycle stream before or during the recycling process.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownOther
“To determine how a person skill in the art would determine if a shrink label is “recyclable” as recited in the independent claims, we look to how the Specification of the ’422 Patent describes or defines recyclable shrink labels. For example, the ’422 Patent states that PET shrink films are generally considered recyclable if no inks are retained on the film after a caustic wash cycle typically used in PET reclaiming processes. Ex. 1001, 6:61–65. The ’422 Patent further states that labels are fully recyclable if the polymers used are clear, preferably clear PET, and the labels include inks that can be washed off in a “typical PET recycling wash (caustic wash).” Id. at 11:44– 49; see also id. at 11:49–54 (describing embodiments in which the labels are free or substantially free of inks that cannot be washed off in a caustic wash or where the labels are free or substantially free of color plastics that cannot be recycled). The ’422 Patent further discusses “industry standards” for determining whether various embodiments of shrink labels are recyclable. See, e.g., id. at 11:29–53. For example, the Specification states that the “Association for Plastic Recyclers (APR) Critical Guidance Protocol for Clear PET Articles with Labels and Closures (PET-CG-02)” (Ex. 1005) can certify that a film is fully recyclable with a container or bottle. Id. at 11:34– 38. Additionally, the Specification states that labels “are recyclable according to the Evaluation of the Near Infrared (NIR) Sorting Potential of a Whole Plastic Article (SORT-B-01)” (Ex. 1010) and/or the “Evaluation of Sorting Potential for Plastic Articles Utilizing Metal, Metalized, or Metallic Printed Components (SORT-B-03)” (Ex. 1011). Ex. 1001, 11:39–44. The ’422 Patent further states that embodiments of the labels “are fully recyclable. For example, the labels may include inks that can be washed off in a typical PET recycling wash (caustic wash) and the polymers” are preferably clear PET. Id. at 11:44–48. The ’422 Patent thus provides various descriptions or standards to determine the recyclability of shrink labels. For the purposes of addressing the anticipation and obviousness grounds, we determine that any of these standards can be used to determine if a shrink label is “recyclable.” We note that our construction is preliminary and is based on the present record. We invite the parties to further the address the construction of “wherein the recyclable shrink label is recyclable with a PET container” during trial.” slip op. at 12
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Phillips · NautilusPatents in suitUS 11,961,422 - Champion Laboratories, Inc. / First Brands Group, LLC v. Hengst SENo claims unpatentablePTAB · Sep 8, 2025 · IPR2024-00603 · APJ Sheldon M Mcgee · IPR · Final written decision
Claims 1, 3, 5, 8–11, 15–17, 19, 23–25, and 28–30 were not shown unpatentable over Yokoyama, Yokoyama and Cline, or Honermann and Cline.
RulingsFinal written decision- Skill levelSkill level board ownDecided for petitioner
“On this record, we determine that the level of ordinary skill is reflected in the prior art of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (specific findings on the ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163–64 (Fed. Cir. 1985))). Because the level of ordinary skill in the art is not in dispute, and because the parties’ definition is consistent with the disclosures in the ʼ203 patent, the prior art, and the declaration testimony of Mr. Nranian and Dr. Basirat, we view the prior art and arguments through this lens when determining whether the claims are unpatentable as obvious over the prior art.5 See Graham, 383 U.S. at 17 (identifying “the level of ordinary skill in the pertinent art” as an underlying factual inquiry to be resolved in deciding obviousness, which is a question of law).” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner
“Although the parties spend significant portions of their briefing discussing the term “eccentric” and how it applies to certain figures from the ʼ203 patent and the relied-upon prior art, we determine that it is not necessary to expressly construe the term “eccentric” beyond the parties’ agreed-upon definition. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Ltd., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the controversy (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). Rather, we adopt Patent Owner’s proffered definition because it is consistent with the intrinsic record and because it is not in dispute. Specifically, Patent Owner asserts that the plain meaning of the term “eccentric” is defined as “located elsewhere than at the geometric center; also: having the axis or support so located.” PO Resp. 18–19 (citing the Merriam-Webster online dictionary definition of the term “eccentric” for support). Petitioner agrees with this definition. Pet. 35 (asserting that certain prior art elements are eccentric “because they are not located at the center of the filter insert or housing”); Pet. Reply 9 (arguing that certain elements are eccentric because they “do not have an axis located at the geometric center”); id. at 10 (arguing the eccentricity of an element that does “not have an axis in the center” which has “an off-center axis”); see also Ex. 2017 ¶ 33 (Dr. Basirat testifying that “[a] POSITA would understand that ‘eccentric’ in the context of [the] ʼ203 patent, means that central axis is located elsewhere than at the geometric center [and] not placed centrally or not having its axis or other part placed centrally”). The parties’ definition of “eccentric” is also consistent with the usage of the term in the ʼ203 patent. Ex. 1001, 10:23–31; Fig. 17.” slip op. at 14
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“Rather, we adopt Patent Owner’s proffered definition because it is consistent with the intrinsic record and because it is not in dispute. Specifically, Patent Owner asserts that the plain meaning of the term “eccentric” is defined as “located elsewhere than at the geometric center; also: having the axis or support so located.” PO Resp. 18–19 (citing the Merriam-Webster online dictionary definition of the term “eccentric” for support). Petitioner agrees with this definition. Pet. 35 (asserting that certain prior art elements are eccentric “because they are not located at the center of the filter insert or housing”); Pet. Reply 9 (arguing that certain elements are eccentric because they “do not have an axis located at the geometric center”); id. at 10 (arguing the eccentricity of an element that does “not have an axis in the center” which has “an off-center axis”); see also Ex. 2017 ¶ 33 (Dr. Basirat testifying that “[a] POSITA would understand that ‘eccentric’ in the context of [the] ʼ203 patent, means that central axis is located elsewhere than at the geometric center [and] not placed centrally or not having its axis or other part placed centrally”). The parties’ definition of “eccentric” is also consistent with the usage of the term in the ʼ203 patent. Ex. 1001, 10:23–31; Fig. 17.” slip op. at 14
- Expert testimonyPetitioner expert discountedDecided for patent owner
“(opining that “Patent Owner’s construction of ‘having an axis no located in a geometric center’ is too narrow”). Mr. Nranian’s Declaration testimony in this respect is not persuasive for several reasons. First, it is internally inconsistent. Compare Ex. 1016 ¶ 3 (criticizing the “axis” language in Patent Owner’s definition), with id. ¶¶ 9, 11 (relying on that very language to support an argument). Also, Mr. Nranian’s proposed definition of “eccentric” to merely mean “not located at the center” begs the question of what, precisely, is “the center”? Mr. Nranian does not persuasively explain how far a person of ordinary skill in the art would understand she could travel from the exact center point of an object and still be in “the center” of that object. See Tr. 10:13–19 (Judge McGee asking whether the center is “a miniscule point in the middle of [the] disc”); see also id. at 10:25–12:26 (Judge Weatherly highlighting the significant ambiguity in referring to something as in “the center”). Also, Mr. Nranian’s opinion is inconsistent with how the ʼ203 patent compares something that is “central,” i.e., “at the center,” and something that is “eccentrically” located. Ex. 1001, 7:13–14 (describing pipe nozzle 15 as “central”); id. at 8:53–56 (describing a “through hole” as “located in the center of the front panel 22” depicted in Figures 7 and 8); id. at 10:23–31 (describing return 12 as “in the center” and outlet 13 as “eccentrically thereto” in Figure 17). Patent Owner’s colorized and annotated Figure 7 is reproduced below: Patent Owner’s colorized and annotated version of Figure 7 of the ʼ203 patent illustrates “central pipe nozzle 15” in yellow passing through the “through hole” located in “the center” of front panel 22. PO Resp. 20. Significantly, pipe nozzle 15 and the through hole in panel 22 are both described as “central” and in “the center” but must have different diameters; otherwise, “central pipe nozzle 15” would not be capable of traveling through “through hole 22.” Ex. 1001, Fig. 7. Thus, the ʼ203 patent intrinsically bases whether an element is “central” or “in the center” on whether its axis is located at the geometric center. This is also illustrated in Figure 17 of the ʼ203 patent, reproduced below: Figure 17 of the ʼ203 patent illustrates filter housing 10 with return 12 “in the center . . . and, eccentrically thereto, the outlet 13 with the seat 14 for the blocking element 24.” Ex. 1001, 10:23–30. Finally, Mr. Nranian’s narrow interpretation of “eccentric”––which excludes the “having the axis or support so located” in the geometric center language––is at odds with the arguments it was proffered to support. Cf. Pet. Reply 9 (arguing that certain elements are eccentric because they “do not have an axis located at the geometric center”); id. at 10 (arguing the eccentricity of an element that does “not have an axis in the center” which has “an off-center axis”).” slip op. at 29
Patent outcomesUS 9,023,203 not shown unpatentableClaim construction§ 103 obviousnesscites GrahamPatents in suitUS 9,023,203 - Valve Corporation v. Immersion CorporationAll claims unpatentablePTAB · Jun 12, 2025 · IPR2024-00477 · APJ Scott Raevsky · IPR · Final written decision
Claims 1–7 are unpatentable as anticipated by and obvious over Komata; the Board did not reach the Tsuji or Rosenberg grounds.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner contends that a POSITA would have had a bachelor’s degree in electrical engineering or computer science (or an equivalent degree), and two years of practical or industry experience in the field of human computer interaction (HCI), including implementation of computer-based systems and software for providing haptic feedback effects to a user. . . . Also, a person could have qualified as a [POSITA] with more formal education and less practical or industry experience, or vice versa. PO Resp. 17–18 (citing Ex. 2008 ¶ 17). Although these level of skill definitions are not the same, the differences are minor, and Patent Owner does not argue that its level of skill definition is dispositive. To the contrary, Patent Owner asserts that “[i]n any event, the challenged claims of the ’260 Patent are patentable under either . . . definition.” Id. at 18. We apply Petitioner’s level of skill but would have reached the same result had we applied Patent Owner’s.” slip op. at 6
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITAPlain and ordinary meaningDecided for petitioner
“As we explained in our Institution Decision, we disagreed then, and still disagree, “that the second pressure must be detected after the first pressure is detected (or that the third pressure must be detected after the first pressure is detected) simply because the second pressure is greater than the first pressure (and the third pressure is greater than the second pressure).” Dec. 27. As we explained there, “[t]he claimed relative magnitudes of the first, second, and third pressures do not define any temporal relationships regarding the detection of the pressures.” Id. We agree with Petitioner that claim 1 recites quantitative relationships for the pressures, not temporal relationships. Reply 4. For example, claim 1 requires “the second pressure greater than the first pressure” but says nothing about when the second pressure must be greater than the first pressure. A key misconception undergirding Patent Owner’s argument is its statement that “a ‘first pressure’ must first exist before the invention can detect that the ‘second pressure’ is greater.” PO Resp. 27 (emphasis added). The claim does not require detecting that the second pressure is greater than the first pressure. Limitation [1c] simply says, “detect a second pressure on the first input device, the second pressure greater than the first pressure.” In other words, all the detection that this limitation requires is detecting a second pressure. The claim then observes that the second pressure is greater than the first pressure but does not require detecting this. Limitation [1e] similarly detects pressure but not the comparison: “detect a third pressure on the first input device, the third pressure greater than the second pressure.” Thus, it does not follow that “a ‘first pressure’ must first exist before the invention can detect that the ‘second pressure’ is greater.” See id. Accordingly, we determine that Patent Owner’s analysis of the claim language is unpersuasive.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Our decision here does not depend on the meaning of this term. Patent Owner only argues the phrase “tactile sensation” for Petitioner’s challenge over Rosenberg, which we do not reach because Petitioner’s challenge over Komata is dispositive. See PO Resp. 63–66. Accordingly, we do not construe this term.” slip op. at 13
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“that Komata discloses all the limitations of claim 1. Patent Owner does not dispute that Komata discloses all the limitations of claim 1. Instead, Patent Owner disputes that Komata discloses the order of all the steps of claim 1, based on its construction requiring the steps to be performed in order. PO Resp. 50–54; Reply 17 (observing that Patent Owner “does not dispute that Ground 1 demonstrates how Komata anticipates or renders obvious claims 1–7 if [Patent Owner’s] ordered-steps argument is rejected”); Sur-reply 12–14 (not disputing the Reply’s observation). As Patent Owner’s argument relies on a claim construction we have not adopted, Patent Owner fails to undermine Petitioner’s persuasive showing.7 To the extent, as we note above, that the claims may require a partial ordering (i.e., limitation [1a] preceding limitation [1b] and limitation [1c] preceding limitation [1d], see supra Section I.A.1.a), Petitioner has persuasively shown that Komata discloses such ordering. a. Summary as to Claim 1 For the above reasons, Petitioner has shown by a preponderance of the evidence that claim 1 is anticipated by and would have been obvious over Komata. 3. Dependent Claims 2–7 Petitioner also contends that claims 2–7 would have been obvious over Komata. Pet. 28–35. Patent Owner does not dispute these dependent claims. Petitioner provides detailed explanations indicating where Komata teaches or suggests the limitations of claims 2–7, supported by Mr. Ward’s testimony. Id. We determine that Petitioner has shown by a preponderance of the evidence that claims 2–7 are anticipated by and would have been obvious over Komata.” slip op. at 17
Patent outcomesUS 7,336,260 unpatentableClaim construction§ 102 anticipation§ 103 obviousnessPatents in suitUS 7,336,260 - Inductev, Inc. v. Witricity CorporationAll claims unpatentablePTAB · May 20, 2025 · IPR2024-00105 · APJ Christopher L Ogden · IPR · Final written decision
Claims 1–13 and 16 are unpatentable as obvious under § 103(a) over the stated Fells-based grounds.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner argues that a person of ordinary skill in the art “would have had . . . a bachelor’s degree in electrical engineering, microelectronics, or equivalent, and . . . two to three years of industry or research experience,” and “a higher level of education or skill might make up for less experience, and vice-versa.” Pet. 6 (citing Ex. 1003 ¶¶ 39–44). Patent Owner “does not disagree with Petitioner’s definition of the level of ordinary skill in the art,” but “does not believe that resolution of the Petition depends on the precise definition of the level of ordinary skill.” PO Resp. 12. Petitioner’s proposed articulation is supported by testimonial evidence and appears consistent with the types of problems and solutions in the ’184 patent. See Ex. 1001, 1:15–2:53. As it is uncontested, we adopt it for this decision.” slip op. at 5
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“The parties agree that the terms of the contested claims should be given their ordinary and customary meaning, but neither party argues that we should construe any claim terms explicitly. Pet. 6 (citing Ex. 1003 ¶¶ 62– 63); PO Resp. 12. We agree with the parties that, for this decision, we do not need to construe any of the terms explicitly. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). However, the meaning of certain terms are contested, including most notably “magnetic field sensor,” and we discuss those terms below in the context of the prior art.” slip op. at 6
- Claim Construction › Intrinsic evidence (Phillips canons) › Preamble limiting or notNot reached
“Petitioner argues that, to the extent the preamble is limiting, Fells discloses the recited wireless energy transfer system, and that the system includes facilities to detect FOD. Pet. 8–9 (citing Ex. 1005 ¶ 191, Fig. 2; Ex. 1003 ¶¶ 66–71, 96–101). Patent Owner does not specifically contest Petitioner’s arguments. See PO Resp. We agree with Petitioner’s argument that Fells discloses the preamble; thus, we need not decide whether the preamble is limiting. See Ex. 1005 ¶ 191, Fig. 2.” slip op. at 11
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“We disagree with Patent Owner’s argument that the ordinary and customary meaning of “magnetic field sensor” refers to a device that measures only external magnetic fields. There is nothing in the claim language to suggest such a limitation: the plain language simply refers to a “magnetic field sensor,” without regard to how the sensor works or where it senses magnetic fields from. Ex. 1001, 12:16. In fact, the claim does not explicitly require sensing anything at all using the magnetic field sensor, merely reciting a “foreign object debris detection system” comprising the sensor and that the “foreign object debris detection system is configured to verify” the presence of FOD. The very general nature of how the magnetic field sensor is recited, without any explicit recitation of how its output may be used, undermines Patent Owner’s overly restrictive interpretation. Although the ’184 patent specification includes examples of measuring external magnetic fields to detect FOD, Patent Owner has not pointed to anything in the specification indicating an intent to restrict the term “magnetic field sensor” to only those sensors that measure external magnetic fields. Nor is there intrinsic evidence that an “eddy-current sensor” would not also be a magnetic field sensor, given that it senses magnetic fields. Indeed, as Petitioner persuasively argues, an eddy-current sensor still measures external magnetic fields—albeit magnetic fields generated within FOD through interaction with a powered sensor. Pet. 6–7; Ex. 1037 ¶¶ 14– 16, 25–29.” slip op. at 17
Patent outcomesUS 10,027,184 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,027,184 - Inductev, Inc. v. Witricity CorporationSome claims unpatentablePTAB · May 16, 2025 · IPR2024-00140 · APJ Christopher L Ogden · IPR · Final written decision
Claims 1, 7–10, 12–16, 18, and 19 are unpatentable over the stated grounds; claims 4–6 were not shown unpatentable because the proposed multi-coil alignment lacked prior-art support.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner argues that a person of ordinary skill in the art “would have had . . . a bachelor’s degree in electrical engineering, microelectronics, or equivalent and . . . two to three years of industry or research experience in the field of wireless energy transfer,” and that “a higher level of education or skill might make up for less experience, and vice-versa.” Pet. 6 (citing Ex. 1003 ¶¶ 39–44). Patent Owner does not contest this. See PO Resp. Petitioner’s proposed articulation is supported by testimonial evidence and appears to be consistent with the types of problems and solutions in the ’654 patent. See Ex. 1001, 1:15–28. We adopt it for this decision.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“We agree with Petitioner that the evidence does not suggest (and Patent Owner does not explicitly argue) that the terms “transmitting antenna” and “receiving” antenna depart from the ordinary and customary meanings of those terms. Pet. 1–2. However, for the reasons discussed below, the outcome of our decision would be the same whether we adopted Petitioner’s or Patent Owner’s proposed construction. Thus, we need not adopt either party’s proposed construction for this decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 9
- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for patent owner
“spaced configuration are not confined to ferrite cores 32 and 3, and that at least a component of the flux lines will escape the cores. See Ex. 1032 ¶¶ 48–52; Ex. 1038 ¶ 54 Fig. 2. Indeed, the evidence suggests (and Dr. Horenstein acknowledges in his first declaration) that at least a component of flux will escape the core of even a traditional transformer. See Ex. 1032 ¶¶ 45–47; Ex. 1044, 6; Ex. 2001 ¶ 27. In his second declaration, Dr. Horenstein provides contrary testimony that in Odachi’s open configuration during alignment, cores 32 and 3 “act to confine or guide the magnetic flux lines, rather than radiate them into free space,” and “the flux lines would [not] leave the gap area and enter into the space distal to the magnetic circuit.” Ex. 2010 ¶ 69. But in view of Dr. Horenstein’s contrary position in his first declaration, and the lack of supporting evidence in his second, we do not find it credible. 37 C.F.R. § 42.65(a) (2022) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); Apple Inc. v. MPH Techs. Oy, 28 F.4th 254 (Fed. Cir. 2022).” slip op. at 24
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“(4) Analysis We are persuaded by Petitioner’s argument that during the alignment process in Odachi corresponding to claim 13, there is a “spaced distance between the primary inductive coupler [230] and the secondary inductive receptacle 2” which is “reduced gradually and electromagnetic induction occurs between the coupler to the receptacle when the former coupler comes close to the latter receptacle.” Ex. 1005, 6:1–6. Thus, prior to any contact or precise alignment between the two cores, “an electromotive force is induced in the secondary coil 4 and this induced force is increased with the decrease in the spaced distance.” Id. at 6:6–8. At least in that spaced configuration, the evidence of record suggests that primary coil 31 produces a near-field component of flux into free space (the air space between the coils where there is no intervening core material) that is intercepted by secondary coil 4 to effect resonant inductive coupling, and that secondary coil 4 intercepts and receives the near-field component of flux in free space that is generated by primary coil 31 to effect resonant inductive coupling. See Ex. 1032 ¶¶ 48–52, 55. Thus, we find that Odachi discloses a “transmitting antenna” (coil 31) and a “receiving antenna” (coil 4) under Patent Owner’s proposed construction. We would reach the same finding under Petitioner’s proposed broader construction because the evidence suggests that Odachi’s coils 31 and 4 would have been considered “antennas” under the parties’ uncontested definition of that term, which is “a device that radiates and/or receives radio waves.” See id. ¶¶ 43–47, 53–54; Ex. 1032 ¶ 15 (Dr. Allen agreeing with this definition of “antenna”); Ex. 2001 ¶ 25 (Dr. Horenstein agreeing with this definition of “antenna”)). In addition, Petitioner persuasively shows that the free space between Odachi’s coils in the spaced configuration includes the “near-field region,” which includes the induction field around primary coil 31. See Ex. 2006, 498; Ex. 1045, 5:4–7; Ex. 1032 ¶¶ 53–54). Dr. Horenstein’s testimony does not contradict this. Although he points out that there are separate terms for inductive, near, and far fields, he also acknowledges that “[t]he region of space closer to the antenna than the far field is the near-field region.” Ex. 2010 ¶ 37 (citing Ex. 2006, 275).8” slip op. at 22
Patent outcomesUS 8,466,654 mixedClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,466,654 - Jiangsu Favored Nanotechnology Co., Ltd. v. P2i Ltd.All claims unpatentablePTAB · Apr 11, 2025 · IPR2024-00380 · APJ Sheldon M Mcgee · IPR · Final written decision
Claims 1–5, 7, and 9–14 are unpatentable as obvious over Cohen and Legein or Francesch and Legein; Petitioner’s motion to strike is denied as moot.
RulingsFinal written decision- Skill levelSkill level board ownDecided for petitioner
“The parties agree that a person of ordinary skill in the art in the field of the ’087 patent in June 20154 “would have had at least a bachelor’s degree in a field such as chemistry, physics, or chemical engineering, as well as at least two years of experience with plasma-polymerization techniques.” Pet. 20 (citing Ex. 1002 ¶¶ 22–29); PO Resp. 13 (Patent Owner stating that it “does not dispute this characterization of the level of ordinary skill in the art.”); see also PO Sur-reply 1–2 (noting both parties’ agreement on the education and experience level of the ordinarily skilled artisan).” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“On the fully developed trial record, we determine that no claims need an express construction. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Ltd., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (holding that only claim terms in controversy need to be construed, and only to the extent necessary to resolve the controversy (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 9
- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
“Because of Patent Owner’s shifting definitions of the education and experience level of the ordinarily skilled artisan, it is unclear on the complete record what precise definition Patent Owner and Dr. Senkevitch are applying when arguing the skilled artisan’s capabilities. PO Resp. 13, 22–27, 31–32, 34–40; PO Sur-reply 1–6, 11–13; Ex. 2007 ¶¶ 30, 31, 33, 34, 37, 40, 52–55, 60, 68, 74, 76, 77, 80–86, 89, 91, 94, 95, 100, 102–105, 108, 110, 111, 113–116, 118–120, 122, 124, 127–134. We, therefore, give Dr. Senkevitch’s testimony regarding the capabilities of a person of ordinary skill in the art minimal weight, which leaves us with Patent Owner’s insufficiently supported arguments regarding the skilled artisan’s capabilities. PO Resp. 13, 22–27, 31–32, 34–40; PO Sur-reply 1–6, 11–13. Moreover, as Petitioner correctly points out, the ʼ087 patent expressly teaches that the precise conditions for forming a protective polymeric coating “will vary depending upon factors such as, without limitation, the nature of the monomer compound, the crosslinking agent, the substrate, as well as the desired properties of the coating” and that such “conditions can be determined using routine methods.” Ex. 1001 15:1–15:5 (emphasis added); Pet. Reply 17. Where the patent itself leaves to the judgment of an ordinarily skilled artisan the assessment of these factors to ascertain suitable conditions for forming the protective coating, we find persuasive Petitioner’s view that it would have been well within the level of ordinary skill to ascertain such suitable conditions.” slip op. at 20
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“We disagree with Patent Owner. Although the claims of the ʼ087 patent recite obtaining the protective cross-linked polymeric coating “by exposing the device or component to a plasma,” the field of endeavor analysis in an analogous art inquiry does not exclusively turn on the claims at issue, but rather takes account of the entirety of a patent’s disclosure. See In re Bigio, 381 F.3d 1320, 1326 (Fed. Cir. 2004) (explaining that “the PTO must show adequate support for its findings on the scope of the field of endeavor in the application’s written description and claims” (emphasis added)); In re Mettke, 570 F.3d 1356, 1359 (Fed. Cir. 2009) (rejecting an argument that the field of endeavor was limited to a claimed “Internet terminal” when “the specification describes various communication media, including facsimile machines and email, as related to the invention.”). This is significant here because the ʼ087 patent discloses that “[t]he … invention relates to protective coatings” and specifically “relates to protective coatings for electronic or electrical devices and components thereof, and methods of forming such coatings.” Ex. 1001, 1:14–17. Based on this disclosure, we find that the ʼ087 patent’s field of endeavor relates to “protective coatings for electronic or electrical devices and components thereof” broadly, not just those formed on such devices or components via a plasma polymerization process as asserted by Patent Owner. Id. Although Cohen does not explicitly disclose that its crosslinked polymers constitute a “protective coating,” Cohen does disclose that its “copolymerizable mixture can be cast into films” (Ex. 1004, 2:61–62), that the polymerization can “effected in situ,” and that the polymers may be used in “numerous” electrical applications (id. at 5:17–25). Tr. 8:9–10:2, 27:2– 21; see Pet. Reply 5 (explaining how “Cohen described insulating polymers that could be applied as films and be used to protect substrates including cables and electrical coils.” (citing Ex. 1004, 2:60–63, 5:13–25)). These disclosures suggest strongly that Cohen’s crosslinked polymers––if cast into a film or formed in situ on an electrical device or component––would serve as a protective coating on that electrical device or component, even though Cohen does not expressly refer to its crosslinked polymers ipsis verbis as a “protective coating.” Thus, we find that Cohen is within the field of endeavor of the ʼ087 patent.” slip op. at 15
Patent outcomesUS 11,041,087 unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,041,087 - PTAB · Mar 27, 2025 · IPR2025-00004 · APJ Georgianna W Braden · IPR · Institution
The Board instituted IPR on claims 1–7, 9, 11–17, and 19, finding a reasonable likelihood of success on the asserted obviousness challenges.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“In an [inter partes review], the petitioner has the burden from the onset to show with particularity why the patent it challenges is unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016) (citing 35 U.S.C. § 312(a)(3)); see also Intelligent Bio-Sys., 821 F.3d at 1369. This burden of persuasion never shifts to Patent Owner. See Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1378 (Fed. Cir. 2015) (discussing the burden of proof in inter partes review). Therefore, to prevail in an inter partes review, Petitioner must explain how 6 At this stage of the proceeding, Patent Owner has not presented objective evidence of non-obviousness. the proposed combination of prior art would have rendered the challenged claims unpatentable. At this preliminary stage, we determine whether the information presented in the Petition shows there is a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been obvious over the proposed combinations of prior art. slip op. at 10
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Here, Petitioner asserts a person of ordinary skill in the art at the time of the invention of the ’313 patent would have “had a bachelor’s degree in computer science, computer engineering, electrical engineering, or a related field, and 2–3 years of practical engineering experience relating to information security systems that employ cryptographic keys to encrypt/decrypt digital data.” Pet. 9 (citing Ex. 1003 ¶¶ 1–20, 37–41). Mr. Wechselberger supports Petitioner’s position and further testifies that “[a]dditional education could substitute for professional experience, or significant experience in the field could substitute for formal education.” Ex. 1003 ¶ 40. Patent Owner does not assert a different level of skill in the art at the time of the alleged invention and does not dispute Petitioner’s proposed level of skill. Prelim. Resp. 6. For the purposes of this Decision, we adopt Petitioner’s level of ordinary skill in the art because it appears consistent with the problems addressed in the ’313 Patent and the prior art of record.” slip op. at 11
- Expert testimonyPetitioner expert creditedDecided for petitioner
“We also are persuaded based on the current record that Suzuki’s teachings bolster Peterka’s teaching of this limitation. See Ex. 1006 ¶¶ 33, 36, 43–48, 59, 72–77, 80–81, Figs. 4–6. Moreover, we are persuaded that a person of ordinary skill in the art at the critical time would have had reason to apply the teachings of Suzuki to Peterka. Specifically, we credit the testimony of Mr. Wechselberger, who testifies that (1) Peterka and Suzuki are in the same field of art and (2) both references disclose “periodically” changing keys that protect distributed content. Ex. 1003 ¶ 154 (citing Ex. 1006 ¶¶ 3, 12; Ex. 1005 ¶¶ 82, 110). Mr. Wechselberger explains that an ordinarily skilled artisan would have recognized the importance of identifiers “to differentiate amongst keys, and that providing unique values (such as key numbers) to keys would ensure that the system does not confuse keys.” Id. ¶ 153. According to Mr. Wechselberger, an ordinarily skilled artisan “would have had reasons to implement Peterka’s client in view of Suzuki to acquire and use ‘key information’ about a next key—its ‘remaining validity time’ and ‘key number’—at a set time before the expiration of the current key, and thereby facilitate timely key acquisition and use.” Id. ¶ 155 (citing Ex. 1006 ¶¶ 76–77, 80–81, 43–48) (emphasis added). At this stage of the proceeding, and crediting the testimony of Mr. Wechselberger, we are persuaded that the combined teachings of Peterka and Suzuki would have allowed a person of ordinary skill in the art “to ‘eliminat[e] the confirmation delay’ during key changes, and realize Peterka’s embodiment where “each client keeps track of the keys and their expiration times and actively requests new keys before the current keys expire so as to avoid service interruptions.” See Ex. 1006 ¶ 11; Ex. 1005 ¶ 105.” slip op. at 30
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner contends “[n]o claim term requires that the Board adopt an exact outer boundary construction because the prior art relied upon herein meets the claims under any plausible interpretation as detailed [in the Petition.]” Pet. 10. Patent Owner asserts that “[t]he Petition does not raise a dispute as to any claim construction issues” and “Patent Owner does not believe the Board need resolve any claim construction issues at this stage.” Prelim. Resp. 6 (citing Pet. 9–10). Construction is needed only for those terms “that are in controversy, and only to the extent necessary to resolve the controversy.” See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). There are no claim terms in controversy at this stage of the proceeding. Consequently, we need not construe any terms for our analysis.” slip op. at 9
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,122,313 - PTAB · Mar 27, 2025 · IPR2025-00003 · APJ Norman H Beamer · IPR · Institution
The Board instituted IPR on claims 1–8, 10, 12, 14, and 16–20 for all petitioned grounds, finding a reasonable likelihood of prevailing on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted unless the information presented in the Petition and any preliminary response shows that “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons explained below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one challenged claim. Accordingly, we institute an inter partes review as to the challenged claims and grounds raised in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“Petitioner’s expert contends that person of ordinary skill in the art (POSITA): [W]ould have had a bachelor’s degree in computer science, computer engineering, electrical engineering, or a related field, and 2–3 years of practical engineering experience relating to information security systems that employ cryptographic keys to encrypt/decrypt digital data. Additional education could substitute for professional experience, or significant experience in the field could substitute for formal education. Ex. 1003 ¶ 41. Patent Owner does not dispute the Petitioner’s proposal at this time. Prelim. Resp. 8. Based on a review of the record, we adopt Petitioner’s proposed level of ordinary skill in the art because it is consistent with the evidence of record, including the asserted prior art and ’178 patent specification. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 10
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“the special case of key changes requested for security reasons outside of any fixed duration lifespan. Ex. 1001, 10:40–42. Considering, as we must, the disclosure of the ’178 patent as a whole, the scope of the disclosure is directed broadly to key rotation in general, whether due to scheduled key expiration times or otherwise. Id. at code (57), Fig. 3, 1:63–65, 2:23–25, 3:26–28, 9:47–49; see also Superguide Corp. v. DirecTV Enter., Inc., 358 F.3d 870, 875 (Fed. Cir. 2004) (“Though understanding the claim language may be aided by explanations contained in the written description, it is important not to import into a claim limitations that are not part of the claim. For example, a particular embodiment appearing in the written description may not be read into a claim when the claim language is broader than the embodiment”).” slip op. at 21
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundOther
“combine the teachings of Peterka, Suzuki, and Bocharov. Pet. 51–53, 57– 59, 66–67. Petitioner argues that Suzuki, like Peterka, discloses clients acquiring keys for multiple media segments, and provides implementation details, not disclosed in Peterka, regarding how to keep track of keys and their expiration times, and how to determine when a new key is required. Pet. 51–52 (citing Ex. 1003 ¶¶ 161–164). Petitioner argues that, given that Peterka and Suzuki are in the same field of art, one of ordinary skill would have been motivated to use the specific details of Suzuki in implementing the disclosure of Peterka. Id. at 53, 66 (citing Ex. 1003 ¶¶ 165–167, 202–204). Petitioner also argues that Peterka indicates that video content can be streamed using various protocols and bit rates, but does not provide implementation details. Pet. 57–59, 66–67 (citing Ex. 1003 ¶¶ 179–184, 204). However, argues Petitioner, one of ordinary skill in the art would have had reason to use the manifest files of Bocharov to provide the necessary information to handle different protocols and bit rates. Id. Petitioner argues that one of ordinary skill in the art would have been so motivated because implementing Peterka’s system to use Bocharov’s manifests would have provided an effective solution for allowing clients to switch between multiple versions of a media program having different encodings/qualities/bit rates. Id. Patent Owner does not specifically address the merits of combining Peterka, Suzuki, and Bocharov. See generally Prelim. Resp. Nonetheless the burden remains on Petitioner to demonstrate unpatentability. See Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1378 (Fed. Cir. 2015). For purposes of this Decision, we determine that Petitioner has provided sufficiently articulated reasoning with rational underpinnings for the proffered combined teachings of Peterka, Suzuki, and Bocharov.” slip op. at 29
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 9,313,178 - Tiktok Inc. v. Ntech Properties, Inc.InstitutedPTAB · Mar 10, 2025 · IPR2024-01342 · APJ Scott Raevsky · IPR · Institution
The Board instituted IPR on claims 1–10 and all asserted grounds; it found a reasonable likelihood that claim 1 would have been obvious over Whitehead.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Based on our review of the preliminary record, Petitioner has demonstrated a reasonable likelihood of prevailing on at least one challenged claim. See 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review on all challenged claims and all grounds asserted in the Petition. 37 C.F.R. § 42.108(a). However, Patent Owner calls into question some of Petitioner’s challenges.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot reached
“Petitioner contends that one motivation for combining would have been that Marcus ’904 includes additional disclosure of targeting media programming to specific users, which would lead to better customization of media programming by Cristofalo. Pet. 38 (citing Ex. 1002 ¶ 122). This assertion is vague and unexplained. Petitioner also asserts that Marcus ’904 provides “additional implementation details” on how final media programming is generated and formatted for display. Id. at 38–39 (citing Ex. 1002 ¶ 123). We fail to see, at this stage, how merely disclosing additional details would motivate a skilled artisan to combine references. If we were to agree with a proposed combination merely because one reference includes details another does not, this could “swallow all of patent law.” Cf. Alice Corp. Pty. Ltd. v. CLS Bank Int’l, 573 U.S. 208, 217 (2014) (addressing patent eligibility). Finally, Petitioner contends that combining Marcus ’904’s advertising sources would unlock new revenue sources for Cristofalo. Pet. 39 (citing Ex. 1002 ¶ 124). Patent Owner argues that this rationale appears to be superfluous, since Cristofalo already discloses targeting advertising to users. Prelim. Resp. 26 (“Cristofalo’s receiving system ‘already’ assembles the programming with advertisements.”); see Pet. 38 (referring to Cristofalo’s “targeted advertising”). We tend to agree at this stage. Thus, we question Petitioner’s rationale to combine Cristofalo with Marcus ’904.” slip op. at 16
- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties’ definitions are similar, although we observe that Patent Owner proposes that the person of ordinary skill would have a bachelor’s degree or professional experience, whereas Petitioner proposes that such a person would have both a degree and experience. See also Ex. 2001 ¶ 17 (Patent Owner’s declarant, Dr. Goodrich, stating that “I note that my definition of a POSITA is similar to that of Dr. Almeroth.”).” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner asserts that “[n]o express constructions are required.” Pet. 9. Patent Owner also proposes no express constructions. We agree that no claim terms require construction at this stage.” slip op. at 7
Claim construction§ 103 obviousnesscites AlicePatents in suitUS 8,886,753
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.