- Cambridge Industries USA, Inc. v. Applied Optoelectronics, Inc.Rehearing deniedPTAB · Dec 19, 2025 · IPR2025-00434 · APJ Mitchell G Weatherly · IPR · Rehearing
The Board denied Petitioner’s rehearing request, leaving institution denied because Shen and Soldano did not establish a reasonable likelihood of anticipating claims 1–7.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“When rehearing a decision on petition, the Board will review the decision for an abuse of discretion. See 37 C.F.R. § 42.71(c). An abuse of discretion may be determined if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors. See Arnold P’ship v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004). The party challenging the decision has the burden of showing the decision should be modified, and the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed” in its papers. 37 C.F.R. § 42.71(d).” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“II. ANALYSIS In our Decision, we concluded that Petitioner had failed to carry its burden of demonstrating a reasonable likelihood of prevailing that either Shen or Soldano anticipated claims 1–7. Dec. 18, 26. Petitioner argues that we should institute review for three reasons. First, Petitioner argues that we abused our discretion by (a) “refusing” to interpret the scope of the claimed” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Owner’s interpretation of “carrier” as meaning “one or more components for supporting ROSA components such as an AWG.” Dec. 9 (quoting Pet. 11). For our analysis of Petitioner’s challenges, we referred to this interpretation of “carrier” as Petitioner’s second alternative construction. Id. We also noted that Petitioner appeared to dispute Patent Owner’s interpretation when it argued that “carrier” should mean “a ceramic or silicon substrate.” Id. (quoting Pet. 10). We referred to this interpretation of “carrier” as the first alternative construction. Id. Rather than resolve this apparent dispute about the meaning of “carrier,” we found that both of Petitioner’s anticipation challenges failed under both interpretations of “carrier.” Id. at 10–26. Because we found that Petitioner had failed to carry its burden regardless of which interpretation of “carrier” applied, we found it unnecessary to resolve the dispute over that interpretation. Id. at 9–10. For the reasons expressed in Parts II.B–C below, we maintain our conclusion that Petitioner has failed to demonstrate a reasonable likelihood of proving that either Shen or Soldano anticipates any claim under either interpretation of “carrier.” Accordingly, Petitioner fails to demonstrate an abuse of discretion in our alleged “refusal” to interpret “carrier.”” slip op. at 3
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“Reh’g Req. 14. We cannot weigh Petitioner’s arguments based on its assertions about “caselaw” because Petitioner cited no cases to support its arguments. See id. Nevertheless, we infer that Petitioner intends its statements of “caselaw” to refer to the requirements to make out a case for anticipation. If so, Petitioner demonstrably miscasts what appear to be the legal principles for proving anticipation. As stated in our Decision: “A claim is anticipated only if each and every element as set forth in the claim is found, either expressly or inherently described, in a single prior art reference.” Verdegaal Bros., Inc. v. Union Oil Co. of California, 814 F.2d 628, 631 (Fed. Cir. 1987).” Dec. 7. Making a showing that a prior art reference anticipates a patent claim thus necessarily requires proof that a single reference “expressly or inherently” describes every element of that claim and with all elements being arranged in the reference as they are in the” slip op. at 7
Claim construction§ 102 anticipationPatents in suitUS 10,379,301 - Cargill, Incorporated v. Bunge Loders Croklaan USA, LLCRehearing deniedPTAB · Apr 29, 2025 · IPR2024-01360 · APJ Debra L Dennett · IPR · Rehearing
The Board denied Cargill’s rehearing request, leaving institution denied for claims 1, 6–9, and 11–24 because the petition did not show a reason to combine the selected prior-art data without hindsight.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“Upon request for rehearing, we assess a decision on institution “for an abuse of discretion” (37 C.F.R. § 42.71(c) (2020)), which occurs when a “decision was based on an erroneous conclusion of law,” “clearly erroneous factual findings,” or “a clear error of judgment.” PPG Indus. Inc. v. Celanese Polymer Specialties Co., 840 F.2d 1565, 1567 (Fed. Cir. 1988) (citations omitted). The burden of showing a decision should be modified lies with the party challenging the decision. 37 C.F.R. § 42.71(c) (2020). The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply. Id. Thus, a request for rehearing is not an opportunity merely to disagree with the Board’s assessment of the arguments or weighing of the evidence, or to present new arguments or evidence. We have reviewed Petitioner’s Rehearing Request and carefully considered all the arguments presented. For the following reasons, we are not persuaded that we misapprehended or overlooked any arguments or evidence.” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“As discussed in the Decision, “obviousness concerns whether a skilled artisan not only could have made but would have been motivated to make the combinations or modifications of prior art to arrive at the claimed invention.” Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1073 (Fed. Cir. 2015) (citing InTouch Technologies, Inc. v. VGO Communications, Inc., 751 F.3d 1327, 1352 (Fed. Cir. 2014)). No matter the result of combining the allegedly “readily available and well-known” information taken from particular examples from the “documentary evidence” with Petrauskaite’s disclosure, a POSITA had to have been motivated to do so at the time the invention was made.1 What is missing from the Petition is the “why.” The only motivating force in this case appears to be hindsight spurring Petitioner on to choose particular examples of palm stearin disclosed in Deffense and the soybean oil in Neff in order to justify its assertion that Petrauskaite discloses the claimed wt% ranges of triglyceride classes.” slip op. at 4
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightMotivation not foundNot shown unpatentableNot shown unpatentable
“artisan not only could have made but would have been motivated to make the combinations or modifications of prior art to arrive at the claimed invention.” Belden Inc. v. Berk-Tek LLC, 805 F.3d 1064, 1073 (Fed. Cir. 2015) (citing InTouch Technologies, Inc. v. VGO Communications, Inc., 751 F.3d 1327, 1352 (Fed. Cir. 2014)). No matter the result of combining the allegedly “readily available and well-known” information taken from particular examples from the “documentary evidence” with Petrauskaite’s disclosure, a POSITA had to have been motivated to do so at the time the invention was made.1 What is missing from the Petition is the “why.” The only motivating force in this case appears to be hindsight spurring Petitioner on to choose particular examples of palm stearin disclosed in Deffense and the soybean oil in Neff in order to justify its assertion that Petrauskaite discloses the claimed wt% ranges of triglyceride classes.” slip op. at 4
- Strike new argumentNew argument disregardedDecided for patent owner
“Petitioner’s. We find no instance in the Petition in which “motivation” and “iodine value” are discussed together or linked in any way. The same can be said of Dr. Marangoni’s declaration. And, as noted in the Decision, it was not until the Preliminary Reply that Petitioner argued that specific data on fatty acid wt% used for the conversion calculations were selected to represent “knowledge generally available to one of ordinary skill in the art” due to similarity of the iodine value (“IV”) of the palm stearin (and soybean oil) disclosed in Petrauskaite. See Prelim. Reply 2–3. New evidence or argument in the Preliminary Reply that could have presented earlier is not permitted. On this record, we find Petitioner relies its Rehearing Request on arguments about a motivation to combine, stemming from the significance of iodine values, that were not raised in the Petition. Accordingly, Petitioner fails to support that the Decision misapprehended or overlooked arguments in the Petition about the significance of iodine values.” slip op. at 8
§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,645,473 - PTAB · Apr 25, 2025 · IPR2024-00793 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Micron’s rehearing requests, finding no misapprehension or overlooked matter in its denial of institution based on the failure to show the challenged claims obvious.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“Petitioner’s own formulations of the grounds based on either Seo or Nam in combination with Choi posit the alternative theories that either Seo or Nam alone disclose Limitation [1.D], or the combination of either Seo or Nam with Choi teaches this limitation. Although Petitioner did not invoke inherency by name for the theories based on Seo or Nam alone, this is, in effect, the nature of Petitioner’s assertions, namely, voltage differentials in Seo and Nam would inherently remove fast charges. For example, with respect to Seo, Petitioner argues that “Seo teaches having a higher voltage on unselected WLs (e.g., adjacent WLs to the selected WL) during the first time period,” and “the ’342 patent recognizes [that] this voltage differential removes fast charges.” Pet. 35–36 (citing Ex. 1001, 12:24–34; Ex. 1003 ¶¶ 129–131) (emphasis omitted); see also id. at 82–83 (relying on the ’342 patent to support the contention that Nam teaches Limitation [1.D] because Nam “teaches having a higher voltage on unselected WLs (including WLs adjacent to the selected WL) relative to the selected WL during the first time period” (citing Ex. 1001, 12:24–34) (emphasis omitted)). Petitioner does not argue that Seo and Nam expressly disclose removing fast charges or sufficiently explain how a POSITA would have understood that the procedures used in Seo and Nam would have removed fast charges; instead, Petitioner effectively argues that removing fast charges is the inherent result of applying the voltage differential. See, e.g., Pet. 36 (stating Seo would have been understood to disclose “performing its read operation on chargetrap memories, which removes fast charges”).” slip op. at 5
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Petitioner’s reliance on Choi does not cure the deficiencies set forth above. Petitioner asserts that “Choi explains the primary mechanism and unwanted impact of fast-charge loss on verification,” which provides the motivation “to use Seo’s and Nam’s methods to achieve fast charge removal to improve verification.” Req. 7 n.1. But again, Petitioner does not sufficiently explain how a POSITA, looking at Choi, would have understood that either Seo’s or Nam’s techniques result in fast charge removal. In other words, even if Choi teaches the impact of fast-charge loss on verification, Petitioner fails to sufficiently show that a POSITA would have understood that either Seo or Nam teach or suggest fast charge removal. It was Petitioner’s burden to establish that Seo and Nam, alone or in combination with Choi, disclose Limitation [1.D]. We are not persuaded that we misapprehended the nature of Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 7
- BurdenDecided for patent owner
“It was Petitioner’s burden to establish that Seo and Nam, alone or in combination with Choi, disclose Limitation [1.D]. We are not persuaded that we misapprehended the nature of Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Petitioner’s reliance on Choi does not cure the deficiencies set forth above. Petitioner asserts that “Choi explains the primary mechanism and unwanted impact of fast-charge loss on verification,” which provides the motivation “to use Seo’s and Nam’s methods to achieve fast charge removal to improve verification.” Req. 7 n.1. But again, Petitioner does not sufficiently explain how a POSITA, looking at Choi, would have understood that either Seo’s or Nam’s techniques result in fast charge removal. In other words, even if Choi teaches the impact of fast-charge loss on verification, Petitioner fails to sufficiently show that a POSITA would have understood that either Seo or Nam teach or suggest fast charge removal.” slip op. at 7
§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,600,342 - PTAB · Apr 25, 2025 · IPR2024-00912 · APJ Jo-Anne M Kokoski · IPR · Rehearing
The Board denied Micron’s rehearing requests, leaving institution denied because the petitions did not show that the prior-art combinations disclose or render obvious fast-charge removal.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW When rehearing a decision on institution, we do not review the merits of the decision de novo, but instead review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined “if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors.” Arnold Partnership v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004) (citing In re Gartside, 203 F.3d 1305, 1315–16 (Fed. Cir. 2000)). The party requesting rehearing has the burden to show that the decision should be modified. 37 C.F.R. § 42.71(d). Additionally, the request for rehearing “must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” Id.” slip op. at 3
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“It was Petitioner’s burden to establish that Seo and Nam, alone or in combination with Choi, disclose Limitation [1.D]. We are not persuaded that we misapprehended the nature of Petitioner’s argument when we determined that Petitioner did not meet that burden.” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“determined that the combinations of Seo or Nam with Choi were not persuasive. Dec. 14–15, 19–20. For example, we determined that “Dr. Liu’s statement that ‘[a] POSITA would have recognized that the lateral-electrical-field-inducing voltage differential, as Seo discloses, is what Choi describes as driving the lateral fast-charge loss,’ is not supported by objective evidence or sufficient explanation as to why a POSITA would have come to that understanding” and was therefore insufficient to support Petitioner’s asserted motivation to combine Seo with Choi. Id. at 14–15. In particular, we were not persuaded that “Seo creates a large lateral electric field like the one described in Choi,” and, in any case, we disagreed that “Choi teaches that a large lateral electric field removes fast charges.” Id. at 15. Accordingly, regardless of the duration of the voltage application described in Seo, Petitioner failed to show that the combination of Seo and Choi would result in removal of fast charges. We further determined that Petitioner’s combination of Nam with Choi was problematic for similar reasons, given Petitioner’s reliance on similar arguments. See id. at 20.” slip op. at 10
- Expert testimonyPetitioner expert discountedOther
“the knowledge of one of ordinary skill in the art relating to charge-trap memory devices demonstrates fast charge removal. See Pet. 36, 81–82. And although Petitioner cites its declarant, Dr. Liu, for the proposition that “Seo discloses, and would have been understood to disclose, performing its read operation on charge-trap memories, which removes fast charges,” Dr. Liu does not cite objective evidence to support this assertion, aside from the ’342 patent itself. Id. at 36 (citing Ex. 1003 ¶ 136). Moreover, Dr. Liu’s testimony simply circles back to logic similar to that relied on with respect to the inherency theory, namely that, given certain similarities between Seo and the ’342 patent, Seo removes fast charges because the ’342 patent teaches removing fast charges, even though Seo does not explicitly teach doing so. See Ex. 1003 ¶ 136 (“[A] POSITA would have immediately understood from reading Seo that Seo is disclosing its read operation as applicable to Flash memories, including Flash charge-trap memories. And as the ’342 states, Seo’s operation would remove fast charges in a charge-trap memory.” (citing Ex. 1001, Abstract)). As already discussed, we disagree with this logic based on the lack of sufficient evidence to support its conclusion. See Dec. 13 (“Petitioner and Dr. Liu do not provide any objective evidence or explanation as to how or why a POSITA would have understood that Seo’s voltage amounts applied during Seo’s time periods operate the same way [as in the ’342 patent] on Seo’s memory device to generate fields with sufficient magnitude and duration to remove fast charges.”). Petitioner’s assertions regarding Nam suffer from the same shortcomings. See Dec. 19–20; Pet 82 (“[A] POSITA would have found that Nam’s teachings are applicable to charge-trap devices”); Ex. 1003 ¶¶ 293–298.” slip op. at 8
§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,600,342 - Kelonia Therapeutics, Inc. v. Interius Biotherapeutics, Inc.Rehearing deniedPTAB · Oct 1, 2024 · PGR2024-00008 · APJ Sheridan K Snedden · PGR · Rehearing
The Board denied rehearing and maintained its denial of PGR because Petitioner did not show that Perkins and RCSB PDB made claims 1–30 more likely than not unpatentable.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. LEGAL STANDARD Pursuant to 37 C.F.R. § 42.71(d): A party dissatisfied with a decision may file a single request for rehearing without prior authorization from the Board. The burden of showing a decision should be modified lies with the party challenging the decision. The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply. When reconsidering a decision on institution, we review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion exists where a “decision [i]s based on an erroneous conclusion of law or clearly erroneous factual findings, or . . . a clear error of judgment.” PPG Indus. Inc. v. Celanese Polymer Specialties Co., 840 F.2d 1565, 1567 (Fed. Cir. 1988). A rehearing request is not an opportunity for the requesting party to reargue its case or merely to express disagreement with the underlying decision. Nor is it an opportunity for the moving party to present new arguments that were not in its original submissions.” slip op. at 3
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Owner’s argument persuasive because Perkins discloses embodiments with “mutations at I182 among a group of 20 other possible locations for modifications,” 13 of which are mutations of specific amino acids that “can be changed to any of the 19 other natural amino acids.” Id. Perkins discloses further that modifications at each of those 20 possible sites can be combined such that “one, two, or more” of the mutations can be made together in other embodiments (Ex. 1006, 17–18), or in other words, “each species [is] combinable to create a vast number of species.” Dec. 35. In addition to the locations of modifications expressly listed in Perkins, Perkins adds yet another option in which “the mutated VSV-G envelope protein is as described in Nikolic et al.” (Ex. 1006, 18), which “describes the crystal structures of VSV G bound to its native LDL-R receptor” that RCSB PDB depicts in entries 5OY9 and 5OYL (Dec. 18). We also considered Dr. Rose’s testimony about the crystal structures depicted in RCSB PDB, namely that a person of ordinary skill in the art would have been motivated to modify Perkins based on the VSV-G crystal structures in the RCSB PDB. Perkins taught that mutations to VSV-G “inhibit binding of VSV-G to the low-density lipoprotein receptor (‘LDL-R’), while preserving the VSV-G protein’s fusogenic function,” and expressly disclosed making a mutation at I182. (See, e.g., Ex. 1005 at 19:29-20:2, 20:29-21:14, 21:16-27; Ex. 1006 at 16.) The VSV-G crystal structures in the RCSB PDB taught that I182 is nearby negatively charged amino acids on the LDL-R. Thus, a person of ordinary skill in the art would have been motivated to incorporate a mutation which negated an interaction with the negatively charged residues in the LDL-R. (Ex. 1005 at 19:29–20:2; Ex. 1006 at 16.) Dec. 37. discussed above, “Perkins provides a list of many mutations and combination[s] thereof, but provides no direction as to which of the many possible choices is likely to be successful.” Id. at 37–38. Thus, we were not persuaded that choosing an embodiment with a mutation at I182 from Perkins’s other listed embodiments with 20 possible locations for modifications, combinations of modifications at 20 possible locations, and the mutations described in Nikolic and depicted in RCSB PDB is an “easily traversed, small or finite number of alternatives that KSR suggested might support an inference of obviousness.” Id. at 35. In view of these findings, we noted that we did not “find sufficient evidentiary support for a determination that the navigation of RCSB PDB crystal structures to achieve the missing limitation would have been ‘evidently and indisputably within the common knowledge of those skilled in the art.’” Id. at 38.” slip op. at 6
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“discussed above, “Perkins provides a list of many mutations and combination[s] thereof, but provides no direction as to which of the many possible choices is likely to be successful.” Id. at 37–38. Thus, we were not persuaded that choosing an embodiment with a mutation at I182 from Perkins’s other listed embodiments with 20 possible locations for modifications, combinations of modifications at 20 possible locations, and the mutations described in Nikolic and depicted in RCSB PDB is an “easily traversed, small or finite number of alternatives that KSR suggested might support an inference of obviousness.” Id. at 35. In view of these findings, we noted that we did not “find sufficient evidentiary support for a determination that the navigation of RCSB PDB crystal structures to achieve the missing limitation would have been ‘evidently and indisputably within the common knowledge of those skilled in the art.’” Id. at 38.” slip op. at 7
§ 103 obviousnessPatents in suitUS 11,767,366 - Njoy, LLC / Njoy Holdings, Inc. v. Juul Labs, Inc.Rehearing deniedPTAB · Aug 12, 2024 · IPR2024-00267 · APJ Avelyn M Ross · IPR · Rehearing
The Board denied rehearing and maintained its denial of institution because Petitioner did not show a reasonable expectation of success for the proposed § 103 combination.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“STANDARD OF REVIEW Pursuant to 37 C.F.R. § 42.71(d): A party dissatisfied with a decision may file a single request for rehearing without prior authorization from the Board. The burden of showing a decision should be modified lies with the party challenging the decision. The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply. When reconsidering a decision on institution, we review the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion exists where a “decision [i]s based on an erroneous conclusion of law or clearly erroneous factual findings, or . . . a clear error of judgment.” PPG Indus. Inc. v. Celanese Polymer Specialties Co., 840 F.2d 1565, 1567 (Fed. Cir. 1988).” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“green, left), placed inside the housing between the housing and heating element (red), and surrounding the heating element and portions of the liquid storage portion (blue). Otherwise, Combined Figure 4 is nearly the same as Annotated Figure 4. Compare Combined Fig. 4, with Ann. Fig. 4. Thus, Petitioner does not propose a simple substitution to include the mouthpiece housing of Thorens231 in the device of Thorens788 in the same manner as used in Thorens231. Rather, Petitioner proposes including the mouthpiece housing of Thorens231 in the device of Thorens788 and then further modifying its placement by inserting it into the housing. See Combined Fig. 4. Neither Petitioner nor Dr. Janet persuasively explain why this arrangement would be expected to be successful nor do they allege that such a modification would have been within the skill set of the ordinarily skilled artisan. In contrast, Patent Owner explains that Petitioner’s [Combined] Figure 4 appears to block any airflow through the device and out of the mouthpiece. Petitioner and its expert do not account for how the mouthpiece would be secured to the liquid storage portion in Thorens788. Moreover, as drawn by Petitioner, the wick touches what is presumably the air inlet for the mouthpiece (although Petitioner does not discuss where the air inlet is), which could adversely impact performance or user experience, such as draw resistance[.] Prelim. Resp. 50–51. Because Petitioner did not direct our attention to any argument or testimony to account for whether or how the modified device would function, Petitioner did not meet its initial burden of proof of showing that a person of ordinary skill in the art would have had an expectation of success in the combination. See Eli Lilly & Co. v. Teva Pharms. Int’l GmbH, 8 F.4th 1331, 1348–49 (Fed. Cir. 2021) (explaining that it is “at all times, [petitioner’s] burden to show that the claims would have” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Prelim. Resp. 50–51. Because Petitioner did not direct our attention to any argument or testimony to account for whether or how the modified device would function, Petitioner did not meet its initial burden of proof of showing that a person of ordinary skill in the art would have had an expectation of success in the combination. See Eli Lilly & Co. v. Teva Pharms. Int’l GmbH, 8 F.4th 1331, 1348–49 (Fed. Cir. 2021) (explaining that it is “at all times, [petitioner’s] burden to show that the claims would have been obvious, including that the skilled artisan would have had a reasonable expectation of success in achieving the claimed invention”).” slip op. at 8
§ 103 obviousnesscites KSRPatents in suitUS 11,134,722 - Alivecor, Inc. v. Apple Inc.Rehearing deniedPTAB · Jul 18, 2024 · IPR2024-00095 · APJ Hyun J Jung · IPR · Rehearing
The Board denied AliveCor’s rehearing request, finding no abuse of discretion in denying institution because the Petterson–Nakada combinations did not teach or suggest the claimed replacement of one user interface with another.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“When rehearing a decision on institution, the Board reviews the decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may arise if the decision is based on an erroneous interpretation of law, if substantial evidence does not support a factual finding, or if an unreasonable judgment is made in weighing relevant factors. Star Fruits S.N.C. v. U.S., 393 F.3d 1277, 1281 (Fed. Cir. 2005); Arnold P’ship v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004); In re Gartside, 203 F.3d 1305, 1315–16 (Fed. Cir. 2000); see also Reh’g Req. 8 (citing 37 C.F.R. § 42.71(c)). Also, 37 C.F.R. § 42.71(d) sets forth, in relevant part that: rehearing without prior authorization from the Board. The burden of showing a decision should be modified lies with the party challenging the decision. The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, or a reply.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“Our determinations regarding Nakada did not support Petitioner’s argument that Nakada’s “system is returned to the beginning state of the routine, which in the case of Petterson would be FIG. 2B.” Pet. 71; Dec. 39–40. We also stated that “the proposed combination does not address adequately Nakada’s description of powering down its display.” Id. at 40 (citing Pet. 48–50; Prelim. Resp. 25–26; Ex. 1011, Fig. 4). We, thus, determined Petitioner failed to show sufficiently that either Petterson or Nakada teaches or suggests “replacing display of the second user interface with the first user interface.” Dec. 38–41 (citing Pet. 48–50, 68–69, 70–71; Ex. 1003 ¶¶ 379, 382; Ex. 1011, Fig. 4). The “totality of the combination” lacked replacing a user interface with any other user interface. Dec. 40–41 (determining “the asserted references neither individually nor combined as proposed would have, ‘in response to detecting that the first criteria are no longer met for a second period of time that is longer than the first period of time, replac[ed] display of the second user interface with the first user interface’”); Reh’g Req. 8 (arguing “the Board overlooked the totality of the combination and Petitioner’s arguments and supporting evidence regarding the modification of Petterson that would have been obvious . . . in view of Nakada”).” slip op. at 7
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“After considering the arguments and cited evidence of the Petition, we determined that Petitioner did not show a reasonable likelihood of prevailing with respect to at least one of the challenged claims of the ’533 patent. Paper 7 (“Decision” or “Dec.”). Petitioner subsequently filed a Request for Rehearing. Paper 8 (“Reh’g Req.”). For the reasons stated below, Petitioner has not shown that we abused our discretion in denying the Petition, and thus, Petitioner’s Request for Rehearing is denied.” slip op. at 2
§ 103 obviousnessPatents in suitUS 10,568,533 - Sma Solar Technology America, LLC v. Tigo Energy, Inc.Rehearing deniedPTAB · Apr 2, 2024 · IPR2023-01175 · APJ Kristina M Kalan · IPR · Rehearing
The Board denied SMA’s rehearing request, leaving institution denied for claims 1–20 because the request showed no overlooked matter, misapplication of law, or abuse of discretion.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“II. STANDARD OF REVIEW Rule 42.71(d) states: The burden of showing a decision should be modified lies with the party challenging the decision. The request must specifically identify all matters the party believes the Board misapprehended or overlooked, and the place where each matter was previously addressed in a motion, an opposition, a reply, or a sur-reply. 37 C.F.R. § 42.71(d). A request for rehearing is not an opportunity to present new arguments or evidence or merely to disagree with the panel’s assessment of the arguments or weighing of the evidence. Moreover, “[w]hen rehearing a decision on petition, a panel will review the decision for an abuse of discretion.” 37 C.F.R. § 42.71(c).” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“patent claim requires a finding that the claim at issue ‘reads on’ a prior art reference.”). Our Institution Decision analyzed Petitioner’s arguments and evidence, and determined that Petitioner provided no persuasive argument that a person of ordinary skill in the art would have understood that Mieth’s load 20 is a micro-controller—i.e., that the claimed micro-controller reads onto Mieth’s load 20. Inst. Dec. 11–12 (citing Ex. 1014, 1180, Fig. 5; Ex. 1007 ¶¶ 102–103). The Request, as did the Petition, misapplies the anticipation analysis by arguing that a micro-controller is a load, rather than persuasively arguing that Mieth’s load is the claimed micro-controller. Id. at 10–12; Req. 8. None of Petitioner’s evidence or arguments explain why a person of ordinary skill in the art would have understood that load 20 disclosed in Mieth is a micro-controller. As such, Petitioner has not shown any material error in our decision that Petitioner did not demonstrate a reasonable likelihood of anticipation by Mieth.” slip op. at 6
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“reads on the micro-controller recited in the claims of the ’848 patent” (Req. 6), the test for anticipation is not whether the prior art reads on the claims, but rather whether the claims read on the prior art. See Atlas Powder Co. v. Ireco, Inc., 190 F.3d 1342, 1346 (Fed. Cir. 1999) (“Anticipation of a patent claim requires a finding that the claim at issue ‘reads on’ a prior art reference.”). Our Institution Decision analyzed Petitioner’s arguments and evidence, and determined that Petitioner provided no persuasive argument that a person of ordinary skill in the art would have understood that Mieth’s load 20 is a micro-controller—i.e., that the claimed micro-controller reads onto Mieth’s load 20. Inst. Dec. 11–12 (citing Ex. 1014, 1180, Fig. 5; Ex. 1007 ¶¶ 102–103). The Request, as did the Petition, misapplies the anticipation analysis by arguing that a micro-controller is a load, rather than persuasively arguing that Mieth’s load is the claimed micro-controller. Id. at 10–12; Req. 8. None of Petitioner’s evidence or arguments explain why a person of ordinary skill in the art would have understood that load 20 disclosed in Mieth is a micro-controller. As such, Petitioner has not shown any material error in our decision that Petitioner did not demonstrate a reasonable likelihood of anticipation by Mieth. slip op. at 5
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableNot shown unpatentable
“D. Petitioner’s Section 103 Argument Petitioner argues throughout the Request that Mieth also discloses the “micro-controller” limitation under 35 U.SC. § 103. See Req. 7, 9–11, 13– 15. As explained above, however, the Request does not identify any matters that the Board misapprehended or overlooked. We addressed Petitioner’s obviousness arguments in our Institution Decision, and determined that those arguments failed to demonstrate a reasonable likelihood that Petitioner would prevail on its arguments that Mieth and Balogh, or Mieth, Balogh, and Liu, teach or suggest the claimed “micro-controller” limitation. Inst. Dec. 13–15.” slip op. at 8
§ 102 anticipation§ 103 obviousnessPatents in suitUS 9,966,848 - PTAB · Jun 5, 2023 · IPR2022-01437 · APJ Benjamin D M Wood · IPR · Rehearing
The Board denied SharkNinja’s rehearing request and left institution denied because the petition did not establish a reasonable likelihood of success on the Xia-Park obviousness challenge.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“decision for an abuse of discretion. 37 C.F.R. § 42.71(c). An abuse of discretion may be determined if a decision is based on an erroneous interpretation of law, if a factual finding is not supported by substantial evidence, or if the decision represents an unreasonable judgment in weighing relevant factors. See Arnold P’ship v. Dudas, 362 F.3d 1338, 1340 (Fed. Cir. 2004). The party challenging the decision has the burden of showing a decision should be modified, and the request for rehearing must specifically identify all matters the party believes the Board misapprehended or overlooked and the place where each matter was previously addressed in its papers. 37 C.F.R. § 42.71(d).” slip op. at 2
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“articulated why it would have been obvious to modify the recovery tank of Xia’s non-wet-filter vacuum to include a strainer basket like that shown in Park’s wet-filter water vacuum. Dec. 13.2 Based on review of the disclosure of Park, the Decision found that the strainer was used to help the wet-filter mechanism work. Id. at 8–10. The Decision noted that the strainer served its purpose at two times—during recirculation of the filtering water when in use and during draining of the filtering water when finished. Id. Thus, the Decision found that the strainer’s purpose was to solve problems unique to wet-filter vacuums. Id. at 11. The Decision found insufficient evidentiary support for Petitioner’s assertion that Park suggested its strainer would be useful in devices like Xia that did not have wet filters. Id. The Decision also found insufficient evidentiary support for Petitioner’s assertion that a person of ordinary skill in the art would nevertheless recognize that Park’s strainer could be useful in devices that did not have wet filters. Id. at 12–13. Accordingly, the Decision determined that the Petition did not meet the burden for institution. Id. at 13.” slip op. at 3
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot shown unpatentableMotivation not foundNot shown unpatentable
“one device, and a person of ordinary skill in the art would recognize that it would improve similar devices in the same way, using the technique is obvious unless its actual application is beyond his or her skill”). However, we disagree that Petitioner has established the factual underpinnings required to support such a theory. Petitioner’s Request directs us to no evidence the Decision missed on this topic. As noted in the Decision, the expert testimony relies on Park or on other devices in which the strainer is used to prevent clogging of recirculation devices. Dec. 13, n.3. These devices teach no more than Park—strainers used to permit recirculation systems to operate without clogging. See id. The Petition did not identify sufficient evidence that would support a finding that a person of ordinary skill in the art would have recognized, before the date of invention, the obviousness of using Park’s strainer in Xia, a device that operates in a different way than Park. See KSR, 550 U.S. at 417 (noting a precondition of the application-of-a-known-technique rationale is that the technique used to improve a device improves the device “in the same way.”) (emphasis added).” slip op. at 6
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightNot shown unpatentableDecided for patent owner
“sense” reason to combine the references, premised on testimony alleging that debris dumped from a wet vacuum tank could clog the drain. Req. Reh’g. 11–12. Petitioner does not direct our attention to where this theory of unpatentability was raised; arguments not raised cannot have been overlooked. In any event, the expert testimony cited is not entitled to persuasive weight because it is not supported by sufficient evidence or technical reasoning. Xerox Corp. et al v. Bytemark, Inc., IPR2022-00624, Paper 9 at 15 (PTAB Aug. 24, 2022) (Decision Denying Institution) (precedential). As explained in the Decision, Petitioner points to no evidence that there was a known problem of drain clogs when disposing of waste water from devices like Xia, nor does Petitioner’s expert explain the reasons why a person of ordinary skill in the art would have nevertheless recognized the problem and its solution. Dec. 12 (“Petitioner has not explained why it would have been obvious to modify Xia by borrowing features that are meant to solve problems unique to water-filter vacuum cleaners”), 13 n.3 (finding that Petitioner’s expert “does not provide an explanation of why a person of ordinary skill in the art would look to add a recirculation filter to devices that do not use recirculation”). Unless there is credible evidence showing otherwise, any perceived obviousness today is only apparent in hindsight. See, e.g., Cardiac Pacemakers, Inc. v. St. Jude Medical, Inc., 381 F.3d 1371, 1376 (Fed. Cir. 2004) (“Prior knowledge in the field of the invention must be supported by tangible teachings of reference materials, and the suggestion to combine references must not be derived by hindsight from knowledge of the invention itself.”); see also Leo Pharmaceutical Products, Ltd. v. Rea, 726 F.3d 1346, 1353 (Fed. Cir. 2013) (“an invention can often be the recognition of a problem itself”); Stratoflex, Inc. v. Aeroquip Corp., 713 F.2d 1530, 1538 (Fed. Cir. 1983) (holding that a proper obviousness analysis “precludes consideration of whether the invention would have been obvious . . . after learning all about the invention”).” slip op. at 7
§ 103 obviousnesscites KSRPatents in suitUS 11,185,205 - Meridian Wildlife Services, LLC v. Safe Haven Wildlife Removal And Property Management Experts, LLCRehearing deniedPTAB · Apr 11, 2023 · IPR2022-01340 · APJ Amee A Shah · IPR · Rehearing
The Board denied the petitioner’s rehearing request, leaving institution denied for claims 1–8 because the petitioner did not show the Board misapprehended or overlooked its obviousness arguments.
RulingsRehearing decision- RehearingRehearing, deniedDenied
“C. STANDARD FOR REHEARING The party filing a request for rehearing of a decision whether to institute has the burden of showing the decision should be modified, and the request for rehearing must specifically identify all matters the party believes the Board misapprehended or overlooked and the place where each matter was previously addressed in its papers. 37 C.F.R. § 42.71(d). “When rehearing a decision on petition, a panel will review the decision for an abuse of discretion.” Id. § 42.71(c)).” slip op. at 3
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“In our decision on institution (Paper 9, “Dec.” or “Decision”), we determined that Petitioner failed to show a reasonable likelihood of prevailing with respect to any of the Challenged Claims and denied institution of inter partes review. Petitioner filed a timely Request for Rehearing in which it asks that we institute inter partes review of the Challenged Claims. Paper 10, 1 (“Reh’g Req.” or “Request”). For the reasons that follow, we deny Petitioner’s Request.” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“to “then place nets where the birds are observed flying in the building.” Reh’g Req. 4 (citing Pet. 19; Ex. 1008 ¶¶ 15, 45; Ex. 1004 ¶¶ 71, 72, 75). Brugh does not “instruct” a POSA to perform either of these actions. Rather, Brugh provides a method comprising, in relevant part, “a) determining the species of flying vertebrate inside the building; b) selecting bird netting; . . . [and] d) positioning the netting for capture based on the species of flying vertebrate and their flight characteristics utilizing the height adjustable poles to raise the netting.” Ex. 1004 ¶¶ 8–10, 15 (emphasis added). There is no “instruction” that the location of the netting is adjusted based on the flight pattern; rather, the height is adjusted. Brugh further provides for “determin[ing] how [the flying vertebrate] flies, e.g., a bat flies in a different pattern than a sparrow” and using the flight pattern “to place the netting in relationship to the position of the flying vertebrate.” Id. ¶ 45. There is no “instruction” that the determining of the flight pattern must be by observing the flying vertebrate (as opposed to researching the flight pattern of the species of the flying vertebrate) or that the netting is placed in relationship to and observed or expected position. b) “The Board’s analysis ignores common sense.” Reh’g Req. 4. Petitioner contends that the Board ignored common sense, as “at some point a POSA necessarily would have observed some species of bird flying near some perimeter walls within some building.” Reh’g Req. 4; see also id. at 6 (“It was common sense that a POSA would eventually observe a bird near a perimeter wall and place Brugh’s capture device accordingly.”), 7 (“[T]he Board . . . substitutes a rigid review of the prior art’s disclosure for common sense. . . .”)). This argument is unavailing. “[W]hile ‘common sense’ can be invoked, even potentially to supply a limitation missing from the prior art, it must still be supported by evidence and a reasoned explanation.” Arendi S.A.R.L. v. Apple Inc., 832 F.3d 1355, 1363 (Fed. Cir. 2016). As explained above, Petitioner’s argument discounts the inventor’s discovery, in which he spent “countless hours” before discovering that birds fly along the perimeter wall of a building’s interior. Ex. 2001 ¶ 16. Further, as discussed above, Brugh does not instruct nor teach a POSA to observe flight patterns and determine or adjust the locations of the nets accordingly. We are not persuaded that the inventor’s discovery was merely “common sense,” and if it was, Petitioner should have submitted sufficient evidence to support such a finding. See Arendi, 832 F.3d at 1363. As explained in our Decision, Petitioner did not. See, e.g., Dec. 32 (“Petitioner provides insufficient evidence that bats or other flying animals are likely to fly ‘at or proximate to a perimeter wall and at or near the ceiling’ such that a POSA would find it obvious to place a net at or proximate to the perimeter of a wall within a building”). A request for rehearing under 37 C.F.R. § 42.71(d) is not an opportunity for Petitioner to simply reargue issues we previously addressed.” slip op. at 6
- Expert testimonyPetitioner expert discountedDecided for patent owner
“Owner’s expert, Mr. Tolley, is the inventor of the ’683 patent. We considered this fact but, nevertheless, found Mr. Tolley’s testimony more persuasive than Dr. Chamberlain’s testimony. We considered the provided evidence of Mr. Chamberlain’s declaration and the support thereof and found insufficient evidentiary support for why a POSA would place at least one net at or proximate to the perimeters and at or near the ceiling of the structure. Dec. 32 (citing Ex. 1004 ¶¶ 71, 72). Id. at 33. As such, Mr. Chamberlain’s testimony is entitled to little weight. See Xerox Corp. v. Bytemark, Inc., IPR2022-00624, Paper 9 (Aug. 24, 2022) (precedential) (denying institution and holding that a declaration is entitled to little weight when it contains an exact restatement of the petition’s arguments without any additional supporting evidence or reasoning); see also 37 C.F.R. § 42.65(a) (“Expert testimony that does not disclose the underlying facts or data on which the opinion is based is entitled to little or no weight.”); see also Upjohn Co. v. Mova Pharm. Corp., 225 F.3d 1306, 1311 (Fed. Cir. 2000) (“Lack of factual support for expert opinion to factual determinations . . . may render the testimony of little probative value in a validity determination.”) (quotation omitted); see also Carella v. Starlight Archery & Pro Line Co., 804 F.2d 135, 138 (Fed. Cir. 1986) (“Although in some circumstances unsupported oral testimony can be sufficient to prove prior knowledge or use, it must be regarded with suspicion and subjected to close scrutiny.”). Dr. Chamberlain’s testimony that at least one net would reduce the flying area was not supported by any evidence. Dec. 34. As such, Dr. Chamberlain’s testimony was afforded little weight. 37 C.F.R. § 42.65(a).” slip op. at 11
§ 103 obviousnessPatents in suitUS 11,064,683
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.