- Shenzhen Tuozhu Technology Co., Ltd. v. Stratasys, Inc.All claims unpatentablePTAB · Sep 28, 2026 · IPR2025-00611 · APJ Christopher L Ogden · IPR · Final written decision
Claims 1–10, 12, 13, 19, and 20 are unpatentable under § 103 over the stated Douglas–Mark and Hamilton-based grounds.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties agree that experience could substitute for a degree, and vice versa. Pet. 3; PO Resp. 10. The parties’ proposed levels of ordinary skill are substantially similar. For this decision, as in the Institution Decision, we adopt Petitioner’s proposed level, which is supported by credible testimonial evidence and is consistent with the problems addressed in the ’774 patent. See Ex. 1001, 1:16–52. Our decision would be the same, however, if we were to adopt Patent Owner’s proposal.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other
“Neither Petitioner nor Patent Owner argues that we need to construe any claim terms explicitly. See Pet. 2–3; PO Resp. 10. However, the parties contest two material claim-construction issues which we address below. To the extent that the parties’ positions depend on interpreting other claim language in a particular way, we discuss the relevant claim language below in the context of the parties’ arguments regarding the prior art.” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“We disagree with Patent Owner that a person of ordinary skill in the art would have understood that limitation 1.2 must be performed before limitations 1.3 or 1.4. See Ex. 1001, 35:21–24. See Interactive Gift Exp., Inc. v. Compuserve Inc., 256 F.3d 1323, 1342 (Fed. Cir. 2001) (“Unless the steps of a method actually recite an order, the steps are not ordinarily construed to require one.” (citing Loral Fairchild Corp. v. Sony Corp., 181 F.3d 1313, 1322 (Fed. Cir. 1999)). The evidence suggests that a “target printer” is any printer that is ultimately selected for fabricating the object, and such a printer could send its configuration information either before or after that determination is made in limitation 1.2. This interpretation does not render the word “target” meaningless. At some point, a printer must be determined to be the target printer, which is the one intended to ultimately fabricate the three-dimensional object. But the target printer still exists, and is capable of being queried, before that determination is made. We find the examples in the ’774 patent pertinent to this question. The ’774 patent states that “the target printer may include more than one printer.” Ex. 1001, 18:66–67. In discussing the step of “query target printer for properties 306” (Fig. 3A), the ’774 patent states that “[i]n one aspect, numerous queries are sent to numerous printers, e.g., for use in selecting one or more of the printers as the target printer.” Id. at 19:8–10. Alternatively, “the query is sent to a printer that is not necessarily the target printer as described herein, e.g., when the query or information received from a response to the query is used for the selection of the target printer.” Id. at 19:11–14. Importantly, the second embodiment states that the queried printer “is not necessarily the target printer,” suggesting that the queried printer could be the target printer even before it is determined to be such. Id. at 19:11–12 (emphasis added). Based on the evidence of record, a person of ordinary skill in the art would have understood that the “target printer” can be determined after the query recited in limitation 1.3 or the reception of configuration information recited in limitation 1.4. Thus, the evidence does not impose an ordering between limitations 1.2 and 1.3 or between limitations 1.2 and 1.4. The evidence also does not support Patent Owner’s argument that the two reverse-order examples in the ’774 patent are unclaimed embodiments.” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightMotivation foundDecided for petitioner
“We disagree that Petitioner’s arguments are based on impermissible hindsight, because they are based on the disclosures in Douglas and Mark, and Petitioner has articulated a persuasive reason to combine those references without referring to the ’774 patent itself, as we discuss below. See In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971) (an obvious rationale is not improper hindsight if it “takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure”).” slip op. at 29
Patent outcomesUS 11,886,774 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,886,774 - Microsoft Corporation v. X1 Discovery, Inc.No claims unpatentablePTAB · Jun 18, 2026 · IPR2025-00254 · APJ Lisa A Murray · IPR · Final written decision
Claims 1–20 were not shown unpatentable under either §103 ground because Petitioner failed to establish motivation to combine and a reasonable expectation of success.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“29. In my opinion, the POSITA at the time of the alleged invention of the Asserted Patents would have had a (1) a Bachelor’s degree in a pertinent discipline, such as computer science, electric engineering, computer engineering, or a related field and (2) have 2–4 years of experience in working with computing devices and have an understanding of indexed search systems utilized by such computing devices. 30. I am aware that Petitioner has provided its own definition . . . . 31. I believe Petitioner’s definition is not meaningfully different from my definition of a POSITA. My opinions would not change regardless of which definition of POSITA is applied. Ex. 2001 ¶¶ 29–31. In our Decision on Institution, we adopted Mr. Haeberli’s formulation, finding it to be consistent with the evidence then of record, including the asserted prior art and the ’490 patent. Dec. 9. Following a review of the full record, we agree with Mr. Haeberli’s statement that Petitioner’s definition of one of ordinary skill in the art is “not meaningfully different” from Mr. Haeberli’s for the purposes of this proceeding. We continue to view Mr. Haeberli’s proposed definition as consistent with the ’490 patent and the asserted prior art, and we apply it in our analysis below. However, our analysis of the issues below would have been the same had we instead adopted Petitioner’s proposed definition.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“In our Decision on Institution, the only term that we found it necessary to construe was the term “string separator character” in claim 1. We preliminarily construed this term to mean “a single-character string separator.” Dec. 11, 30–31. We invited the parties to address the appropriateness of this construction over the course of the trial. Id. at 11, 31. In its briefing, Patent Owner agrees with the Board’s preliminary construction, arguing that it is “consistent with the intrinsic evidence.” PO Resp. 8 (citing Ex. 1001, claims 8 and 20). Patent Owner further argues that a person of ordinary skill would have understood a multi-character Boolean operator such as “AND” to be “a search syntax instruction rather than a string separator.” Id. at 9 (citing Ex. 1059, 162; Ex. 2001 ¶ 112). Petitioner’s Reply Brief does not address the issue of claim construction. See generally Reply Br.; see also Pet. 11 (“Unless otherwise noted, Petitioner applies the plain and ordinary meaning of all claim terms below.”). Following our review of the full record, we determine that it is not necessary to construe this or any other claim term for the purposes of this Decision.2 See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (Only terms that are in controversy need to be construed, and then only to the extent necessary to resolve the controversy.). In our analysis below, we interpret the language of the claims according to its plain and ordinary meaning.” slip op. at 10
- Expert testimonyPetitioner expert discountedPatent owner expert creditedDecided for patent owner
“Having reviewed the evidence of record, we find Mr. Haeberli’s testimony to be more persuasive and better supported by the evidence. According to Dr. Terveen, “[r]obust programming languages such as C and C++, together with well-developed operating system and UI frameworks, . . . allowed an ordinary programmer to build a UI that supported incremental searching, as evidenced by the numerous prior art systems that implemented such functionality, including Entourage, Eudora, Emacs, Canon Cat, SwyftWare, and others. Ex. 1100 ¶ 43 (citing Ex. 1004, 8–9, 161; Ex. 1021, 125, 127, 129; Ex. 1039, 102–103; Ex. 1043, 385–389). The relevant question, though, is not whether it would have been possible to build a user interface that supported incremental search, but whether it would have been “simple and straightforward” to execute an incremental search of multiple partial search strings on large, indexed multi-file databases such as those described in the Lotus Notes references, as Dr. Terveen alleges. None of the prior art discussed in the “State of the Art” section of Dr. Terveen’s initial declaration, taken individually or together, discloses incrementally searching a plurality of files using two partial search strings. See Ex. 1003 ¶¶ 32–33, 37, 40; Ex. 2001 ¶ 100. Thus, creating a user interface might be “simple,” but the evidence suggests that the back-end execution of an incremental search is not. See, e.g., Ex. 1021, 126 (Raskin, concluding that “almost all interface-building tools make it easy to implement delimited searches and difficult or impossible to implement incremental searches”).” slip op. at 23
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“different approach from that taken in Lotus Notes. The difference between Raskin’s sequential scanning method and the index-based system described in Wilcox is that sequential scanning by definition can only scan one document at a time as each document is loaded into a “buffer.” See, e.g., Ex. 2020 ¶ 35. Lotus Notes, however, only needs to load the index into memory for a user to be able to locate the single index entry identifying all instances of an indexed term across all indexed files. In fact, Raskin acknowledges that indexing may be necessary to maintain an acceptable response time. Ex. 1021, 132 n.10; see also id. at 129 (indexing speeds search times). Mr. Haeberli’s third and final reason for concluding that one of ordinary skill would not have been motivated to combine Raskin’s incremental search with Lotus Notes is that at the time using incremental searches would have presented “extreme technical difficulties.” Ex. 2001 ¶ 101. Here again we find Mr. Haeberli’s explanation more persuasive than Dr. Terveen’s opinion that combining the teachings from Raskin with Lotus Notes’ teachings “would have required only simple and straightforward software modifications.” Ex. 1003 ¶ 80. According to Mr. Haeberli, “there are serious technical challenges with implementing the complex search strategies of the challenged claims in the systems on which Dr. Terveen relies.” Id. ¶ 96. As Patent Owner argues: searching across a set of files to find specific files requires the system to identify which files are in the set, access those files (which are often not loaded in active memory), search their contents, determine which files contain matches to search criteria, and then present results to the user; all tasks that do not exist in the same way (or at all) for a search confined to text in a single open file already loaded into memory. Sur-Reply 9; see Ex. 2020 ¶¶ 15, 35–36. There would have been other challenges as well. For example, “[t]he type of sequential scanning typically employed to search a single open document is very time and resource intensive if employed to search a large set of documents.” Ex. 2020 ¶ 15. Also, “[i]mplementing incremental search in the Lotus Notes indexed system would necessarily require a larger index, which would slow down, rather than increase the search speed.” PO Resp. 23; see Ex. 2020 ¶ 33. Finally, Raskin itself concludes that “even if incremental searching is advantageous, ‘almost all interface-building tools make it easy to implement delimited searches and difficult or impossible to implement incremental searches.’” Ex. 2001 ¶ 96 (emphasis added by Mr. Haeberli) (quoting Ex. 1021, 126). In short, Mr. Haeberli presents three significant reasons why there would have been no motivation or expectation of success in combining the teachings of Wilcox with those of Raskin. Dr. Terveen’s opinion to the contrary, on the other hand, is not supported by evidence. Dr. Terveen testifies that “[a] POSITA would have been motivated to perform Lotus Notes’ multi-string search incrementally for the reasons stated by Raskin: speed, effectiveness, and ease of use.” Ex. 1003 ¶ 78 (citing Ex. 1021 ¶¶ 125–127). The evidence, however, not only fails to support Dr. Terveen’s testimony, but also demonstrates that one attempting to make the proposed combination would not have reasonably expected the proposed combination to result in greater speed or effectiveness.” slip op. at 27
Patent outcomesUS 10,552,490 not shown unpatentableClaim construction§ 103 obviousnesscites KSRPatents in suitUS 10,552,490 - Arashi Vision (U.S.) LLC (D/B/A Insta360) v. Gopro, IncNo claims unpatentablePTAB · Nov 25, 2025 · IPR2024-01165 · APJ William V Saindon · IPR · Final written decision
Claims 1–21 were not shown unpatentable because Zhou does not teach the claimed low-light high-pass or stickiness parameter limitations.
RulingsFinal written decision- BurdenFwd all claims patentableNot shown unpatentable
“4. Conclusion for the Prior Art Analysis In sum, we find that Zhou does not disclose the low-light high-pass parameter or the stickiness parameter. Petitioner’s grounds for both independent claims 1 and 16 rely on Zhou for teaching a low-light high-pass parameter or a stickiness parameter. Pet. 23–28, 64. Because we find Zhou does not teach these limitations, all of Petitioner’s grounds fall for this reason. III. CONCLUSION For the reasons given above, we determine that Petitioner has not established by a preponderance of the evidence that any claim of the ’840 patent would have been obvious in view of the prior art cited.” slip op. at 18
- Skill levelSkill level petitioner adoptedOther
“A person of ordinary skill in the art (POSITA) in the field of the ’840 patent would have a bachelor’s degree in engineering or computer science, or equivalent field, and two years of experience working on image or video processing, or digital cameras. Alternatively, a POSITA would have four years of experience working on image or video processing, or digital cameras. An advanced graduate degree in the disciplines cited above may make up for the work experience indicated above. Pet. 6 (citing Ex. 1002 ¶ 32). Patent Owner applies the same standard. PO Resp. 26–27. We use this agreed-upon standard for purposes of this Decision.” slip op. at 7
- Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner
“We review this testimony based on the strength of the underlying factual basis. 37 C.F.R. § 42.65(a); Ashland Oil, Inc. v. Delta Resins & Refractories, Inc., 776 F.2d 281, 294 (Fed. Cir. 1985) (“Lack of factual support for expert opinion going to factual determinations, however, may render the testimony of little probative value . . ..”). Here, the underlying factual basis is not very strong for either witness. That said, we find that Dr. Foroosh’s testimony is more logically sound and consistent with the ’840 patent disclosure. Based on our reading of the specification, we find a clear indication that “stickiness” has to do with the past. In order to control “the extent by which preceding portion(s) . . . impacts determination of the smoothed trajectory” (emphasis added), one must control the degree by which the past frames impact determination. And to control the degree of the past’s influence, one must, as a consequence, favor the past over the future. That is, the frame of reference of the stickiness parameter is the past. The specification could have used a time-agnostic term, like a “nearness” or “adjacency” parameter, but it did not. Thus, the fact that “stickiness” is used in conjunction with “preceding” indicates that it deals with a preference for preceding frames. On this basis, we find Dr. Katsaggelos’s testimony less persuasive than Dr. Foroosh’s.” slip op. at 10
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner
“That said, we do not construe a stickiness parameter as prohibiting consideration of future frames. Instead, we determine that the stickiness parameter’s value determines the impact of the preceding portions, versus the following portions. The ’840 patent recognizes this, when it says that a stickiness parameter value of “1,” representing a “lazy” stabilizer that maximally favors the past, would not override a violation of the margin constraint based on the look-ahead (i.e., would not allow the viewing window to fall out of bounds in the event of large future motion). See Ex. 1001, 22:26–30; see also id. at 12:61–13:29 (acknowledging that favoring the past may lead to a conflict with the viewing window determination), 15:39–60 (adjusting the viewing window to ensure it does not violate a margin constraint). Thus, while a past-favoring parameter by necessity favors the past over the future, it does not prohibit consideration of the future. In view of the above, we construe the claimed “stickiness parameter” as a parameter that controls the extent by which preceding portions of the trajectory impacts determination of the smoothed trajectory, with an understanding that in order to favor preceding portions, to some extent, the parameter must relatively disfavor following portions.” slip op. at 10
Patent outcomesUS 10,958,840 not shown unpatentableClaim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 10,958,840 - PTAB · Nov 20, 2025 · IPR2025-00951 · APJ Eric C Jeschke · IPR · Institution
The Board instituted IPR on claims 1–19 and all asserted grounds, finding a reasonable likelihood that claim 1 would have been obvious over DuroMax and De Vries.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a) (2024) (“The Board institutes the trial on behalf of the Director.”). Inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314. Upon consideration of the evidence and arguments in the record, for the reasons below, we determine that the information presented shows a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims. We thus institute inter partes review on all challenged claims on all asserted grounds. See SAS Inst. Inc. v. Iancu, 584 U.S. 357, 362–63, 369–70 (2018); 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”).” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“For purposes of this Decision, we adopt the definition of the level of ordinary skill in the art proposed by Petitioner. As to the inclusion of physics in Petitioner’s definition, Patent Owner acknowledges that an undergraduate mechanical engineering degree holder would have the requisite knowledge here but does not adequately explain why an undergraduate physics degree holder would not. In addition, Patent Owner requires “a four-year degree in mechanical engineering or a closely related field,” but fails to identify what fields are “closely related.” See Prelim. Resp. 10 (emphasis added). Based on the Winkel Declaration, we are persuaded at this stage that a hypothetical undergraduate physics degree holder would have had adequate knowledge for one of ordinary skill in the art of the invention here. See Winkel Decl. ¶ 106. As to the requisite years of experience proposed in the definitions— three for Petitioner versus “at least one” for Patent Owner—we note that Patent Owner’s definition is broader than, but includes, Petitioner’s definition. Moreover, for both the inclusion of physics and the years of experience issues, Patent Owner acknowledges that the arguments in the Preliminary Response “are not impacted based on which definition is applied.” Prelim. Resp. 10. Further, Patent Owner does not argue at this stage that Petitioner’s proposal for the level of ordinary skill leads to an improper understanding of how a skilled artisan would have understood either the challenged patent or the prior art.” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“At this stage of the proceeding and on the current record, we need not and do not explicitly construe the phrase “selector switch.” See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Although we do not expressly adopt Petitioner’s proposed construction at this stage of the proceeding, we note that it at least generally aligns with the tentative claim construction issued by the United States District Court in the California Litigation: “Mechanical device whose positioning precludes simultaneous access to two fuels.” Ex. 300310 at 2; see also 37 C.F.R. § 42.100(b) (“Any prior claim construction determination concerning a term of the claim in a civil action, or a proceeding before the International Trade Commission, that is timely made of record in the inter partes review proceeding will be considered.”); Memorandum from Acting Director Coke Morgan Stewart to Members of the Patent Trial and Appeal Board (Sept. 15, 2025), available at https://www.uspto.gov/sites/default/files/documents/ Memo_re_prior_findings_of_fact_and_conclusions_of_law_9_16_25.pdf (“Prior Determinations Memo”) (discussing PTAB consideration of prior findings of fact and conclusions of law). We also note that Patent Owner” slip op. at 14
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“Like the Federal Circuit in In re Ellis, although the patent classification of the reference is “some evidence of ‘non-analogy, . . . we consider the similarities and differences in structure and function of the inventions . . . to carry far greater weight.” In re Ellis, 476 F.2d at 1372 (affirming the Board and rejecting the applicant’s nonanalogous art argument). Here, the challenged patent discusses in the Background of the Invention the need for a way to “prevent both valves from being ‘on’ at the” slip op. at 21
Claim construction§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 10,598,101 - PTAB · Nov 13, 2025 · IPR2025-00805 · APJ Eric C Jeschke · IPR · Institution
The Board instituted IPR on claims 1–24 and all asserted grounds, finding a reasonable likelihood that Petitioner would prevail on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a) (2024) (“The Board institutes the trial on behalf of the Director.”). Inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314. Upon consideration of the evidence and arguments in the record, for the reasons below, we determine that the information presented shows a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims. We thus institute inter partes review on all challenged claims on all asserted grounds. See SAS Inst. Inc. v. Iancu, 584 U.S. 357, 362–63, 369–70 (2018); 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”).” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“C. Patent Owner’s Arguments Under 35 U.S.C. § 325(d) In the Preliminary Response, Patent Owner contends that Petitioner’s unpatentability arguments presented in this proceeding were previously considered by the USPTO. See Prelim. Resp. 31–33. In her decision referring this matter to the Board, then-Acting Director Stewart rejected that argument. See Paper 20 at 2–3 (discussing why “Petitioner provides persuasive reasoning, supported by evidence, that discretionary denial under 35 U.S.C. § 325(d) is not appropriate”); see also Prelim. Resp. 31–33 (referring to and citing Patent Owner’s Discretionary Denial Brief (Paper 8)). We need not and do not address this issue further.” slip op. at 15
- Skill levelSkill level petitioner adoptedDecided for petitioner
“For purposes of this Decision, we adopt the definition of the level of ordinary skill in the art proposed by Petitioner. As to the inclusion of physics in Petitioner’s definition, Dr. Singhose (a professor of mechanical engineering) testifies as to why undergraduate mechanical engineering degree holders would have the requisite knowledge here, but does not testify that undergraduate physics degree holders would not. See Singhose Decl. ¶¶ 2, 27, 28. In addition, Patent Owner and Dr. Singhose require “a four-year degree in mechanical engineering or a closely related field,” but fail to identify what fields are “closely related.” See Prelim. Resp. 11; Singhose Decl. ¶ 27. Based on the Morse Declaration, we are persuaded at this stage that a hypothetical undergraduate physics degree holder would have adequate knowledge for one of ordinary skill in the art of the invention here. See Morse Decl. ¶ 31. As to the requisite years of experience proposed in the definitions— three for Petitioner versus “at least one” for Patent Owner—we note that Patent Owner’s definition is broader than, but includes, Petitioner’s definition. Moreover, for both the inclusion of physics and the years of experience issues, Patent Owner acknowledges that the arguments in the Preliminary Response “are not impacted based on which definition is applied.” Prelim. Resp. 12 (citing Singhose Decl. ¶¶ 30–34). Further, Patent Owner does not argue at this stage that Petitioner’s proposal for the level of ordinary skill leads to an improper understanding of how a skilled artisan would understand either the challenged patent or the prior art.” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“B. Claim Construction In inter partes reviews, the Board interprets claim language using the same claim construction standard that would be used in a civil action under 35 U.S.C. § 282(b), as described in Phillips v. AWH Corp., 415 F.3d 1303 (Fed. Cir. 2005) (en banc). See 37 C.F.R. § 42.100(b). Under that standard, we generally give claim terms their ordinary and customary meaning, as would be understood by a person of ordinary skill in the art at the time of the invention, in light of the language of the claims, the specification, and the prosecution history. See Phillips, 415 F.3d at 1313–14. Although extrinsic evidence, when available, may also be useful when construing claim terms under this standard, extrinsic evidence should be considered in the context of the intrinsic evidence. See id. at 1317–19. Petitioner does not propose express constructions for any claim terms. Pet. 12. Patent Owner also does not propose any express constructions. See Prelim. Resp. 12. On the current record, we need not construe explicitly any claim terms. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). As discussed below, however, the parties dispute the meaning of “gaseous fuel.” We address this issue below in the analysis of the challenge to claims 1–3, 5–9, and 18 based on Nakafushi and Olmr.” slip op. at 12
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites PhillipsPatents in suitUS 10,393,034 - Home Depot U.S.A., Inc. v. H2 Intellect LLCInstitution deniedPTAB · Oct 20, 2025 · IPR2025-00480 · APJ Lisa A Murray · IPR · Institution
The Board denied institution because the Elliott/Jacob grounds did not show a reasonable likelihood that claims 1–15 were unpatentable, and Musk did not cure the deficiencies.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“c) Summary We may institute an inter partes review when “the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). We have determined that, at this stage of the proceeding and on the present record, the information presented in the Petition does not show that Petitioner is reasonably likely to prevail with respect to its challenge to claim 1 based on the combination of Elliott and Jacob. Specifically, the Petition does not demonstrate that the proposed Elliott/Jacob combination would teach or suggest either limitation [1.e] or limitation [1.a] of independent claim 1. For the same reasons, the Elliott/Jacob combination does not teach or suggest the commensurate limitations in independent claims 6 and 11. Compare Ex. 1001, 13:42–14:5, 14:31–15:5, 15:38–16:21.” slip op. at 19
- Skill levelSkill level petitioner adoptedDecided for petitioner
“a Bachelors’ degree in electrical or computer science or a comparable field of study, plus at least three years of professional experience in advertisement delivery systems or other relevant industry experience. Additional graduate education could substitute for professional experience, and significant experience in the field could substitute for formal education. Pet. 3; Ex. 1002 ¶ 79. Patent Owner does not offer a competing formulation, stating that “[f]or purposes of this preliminary response only, Patent Owner applies the same skill level proposed by Petitioner.” Prelim. Resp. 12. We find Petitioner’s formulation to be consistent with the evidence of record at this stage of the proceeding, including the asserted prior art and the ’296 Patent, and, accordingly, we adopt and apply that definition for purposes of this Decision. B.” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for patent owner
“After reviewing the parties’ arguments and evidence, we determine that no express constructions of the terms identified by Petitioner are needed 6 For the term “recording a request identifier associated with the request,” Petitioner asserts that it is unclear which “request” is at issue, Pet. 7–8, while Patent Owner argues that “the ‘request’ refers to the ‘request for content to be used within the registered application program’ as described in claim element 1.h.” Prelim. Resp. 13. For the reasons discussed below, we determine that it is not necessary for us to construe this term for purposes of this Decision. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (“[W]e need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). C.” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“as obvious over the combination of Elliott and Jacob. Pet. 9–60. Patent Owner contests Petitioner’s mapping of the cited prior art to four limitations in independent claim 1 (and the commensurate limitations in independent claims 6 and 11): limitations [1.a], [1.b], [1.d], and [1.e]. Prelim. Resp. 14– 39. Patent Owner also argues that one of ordinary skill in the art would not have been motivated to modify Elliott with the teachings of Jacob. Id. at 39– 46. We agree with Patent Owner that the proposed combination does not teach or suggest elements [1.a] and [1.e], for the reasons discussed below. Because the absence of these two elements from the cited prior art is a sufficient basis for denying institution, we do not address Patent Owner’s remaining arguments.” slip op. at 13
Claim construction§ 103 obviousnesscites PhillipsPatents in suitUS 8,433,296 - PTAB · Oct 9, 2025 · IPR2025-00847 · APJ Brian D Range · IPR · Institution
Instituted IPR on claims 1–11 because Petitioners showed a reasonable likelihood of proving at least one challenged claim unpatentable across the asserted grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The following findings of fact and conclusions of law are not final, but are made for the sole purpose of determining whether Petitioners meet the threshold for initiating review. Any final decision shall be based on the full trial record, including any response timely filed by Patent Owner. Any arguments not raised by Patent Owner in a timely-filed response may be deemed waived. For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We hereby institute an inter partes review as to claims 1–11 of the ’847 patent based upon Petitioners’ asserted grounds of unpatentability.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“would have had a master’s degree in electrical engineering, physics, chemistry, materials science, or a related field and three years of work experience in semiconductor manufacturing, such as, for example, in integrated circuit device (or transistor) design and/or manufacturing,” and “[a]dditional relevant education could substitute for professional experience, and significant work experience or training could substitute for formal education.” Pet. 11 (citing Ex. 1003 ¶ 38). Patent Owner does not dispute the level of ordinary skill in the art. See generally Prelim. Resp. For purposes of this Decision, we adopt Petitioner’s proposal as reasonable and consistent with the ’847 patent specification and the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art may reflect an appropriate level of skill in the art). slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner does not propose any claim constructions, except to explain that the claim 7 limitation “the spacer further comprises an offset spacer, positioned between the gate and the spacer,” is “satisfied if one layer (an ‘offset spacer’) of the claimed ‘spacer’ lies between another layer of the ‘spacer’ and the gate.” Pet. 11. Patent Owner does not dispute Petitioner’s assertions or offer any claim constructions. See generally Prelim. Resp. Because resolution of Petitioner’s proposed construction is unnecessary to our analyses for purposes of this decision, we do not address the proposal here. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). We do not discern a need to construe any other claim language at this juncture because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC, 912 F.3d at 1375.” slip op. at 8
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“a. Claim 1 Petitioner contends that claim 1 is anticipated by Lan or, alternatively, obvious in view of Lan. Pet. 18–26. Petitioner explains how Lan teaches or suggests each recitation of claim 1, and Petitioner’s position is supported by adequate evidence for institution. Id. (citing, e.g., Ex. 1003 ¶¶ 100–125). Petitioner, for example, persuasively compares the structure of Figure 12 of Lan to each limitation of claim 1. Id. Patent Owner does not dispute Petitioner’s contentions except to argue that Lan (and the Petition’s other asserted references) “Do Not Mention, Describe, or Concern ‘Raised Epitaxial Layers.’” Prelim. Resp. 22–24. Patent Owner does not persuasively undermine Petitioner’s position.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,745,847 - Apple Inc. v. Resonant Systems, Inc.All claims unpatentablePTAB · Oct 9, 2025 · IPR2025-00680 · APJ Karl D Easthom · IPR · Final written decision
Claims 2 and 3 are unpatentable under § 103 over Gregorio, Ramsay, Tierling, Rossi, and Aldrich; claim 2 is also unpatentable over Gregorio, Ramsay, Wakuda, Rossi, and Aldrich.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“would have had a degree in mechanical engineering, electrical engineering, physics, or a related technical field, and at least 2–3 years of experience related to the design or development of systems incorporating linear actuators; additional years of experience could substitute for the advanced-level degree. Ex. 1003 ¶ 30. Patent Owner offers “a similar level of ordinary skill in the art.” See PO Resp. 4. Based on a review of the record, we adopt Petitioner’s proposed level of ordinary skill in the art because it is consistent with the evidence of record, including the asserted prior art and ’337 patent specification.” slip op. at 9
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesDecided for petitioner
“An element in a claim for a combination may be expressed as a means . . . for performing a specified function without the recital of structure, material, or acts in support thereof, and such claim shall be construed to cover the corresponding structure, material, or acts described in the specification and equivalents thereof. 35 U.S.C. § 112 ¶ 6. In particular, the parties agree that the “driving component” and “control component” requirements of independent claim 2 are means-plus-function limitations. Pet. 2–6; PO Resp. 7. Construing a means-plus-function limitation under 35 U.S.C. § 112 ¶ 6 involves two steps: 1) identifying the claimed function and 2) identifying in the specification the corresponding structure that performs the claimed function. Med. Instrumentation & Diagnostics Corp. v. Elekta AB, 344 F.3d 1205, 1210 (Fed. Cir. 2003); Cardiac Pacemakers, Inc. v. St. Jude Med., Inc., 296 F.3d 1106, 1119 (Fed. Cir. 2002).” slip op. at 10
- Claim Construction › Functional claiming / §112(f) means-plus-function › Corresponding structure / algorithm (indefinite if none)Term construed petitioner constructionTerm construed board ownMixed
“supply of power from the power supply to . . . cause the moveable component to oscillate at a frequency . . . specified by one or more stored values” to portions of steps 706 and 708 of the flow diagram algorithm of Figure 7A, as described above. Thus, the control component requires a microprocessor and memory with algorithmic structure including a timing algorithm or similar coding for creating a control output signal that flips to control the direction of current flow through a coil (e.g., coil 514, Fig. 5, coil 626, Fig. 6), where the coil is structure that corresponds to the recited “driving component,” as noted above.10 We adopt the District Court’s conclusion in the Apple litigation that the “control component” structure itself does not require an H-bridge switch, but only requires that the processor generates the “d” inputs configured to operate a switch or other circuit; and further that the structure does not require does not require computing initial default values as specified in step 702 of Figure 7A (i.e., values not specified by a user). Ex. 3001, 30–33, 35. This is in accord with settled law that limits the structure to that necessary to 10 “Rather than using a formal timer mechanism, certain implementations may simply employ counted loops or other simple programming techniques for periodically carrying out tasks.” Ex. 1001, 7:7–10. perform the claimed function. 11 By the same token, we modify the District Court’s construction to the extent it would require, based on such steps as 706, 710, and 716, a specific order of the steps of generating the “p” and “d” values. The claims only require the control component to control the power supply to cause oscillation at a specified frequency and amplitude, but do not require the frequency value to be generated before the amplitude value, or vice versa.” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“The record, including testimony by Dr. Hannaford (Ex. 1003; Ex. 1049), supports Petitioner’s rationale, and shows that one of ordinary skill would have been motivated to combine Gregorio, Ramsay, and Wakuda in the manner proposed. Patent Owner does not address Petitioner’s showing for combining these references with any particularity. See generally PO Resp. We discuss below Patent Owner’s argument that Petitioner’s showing as to limitation 2.f based on the combination of Gregorio and Ramsay is conclusory.” slip op. at 34
Patent outcomesUS 8,860,337 unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 8,860,337 - PTAB · Oct 6, 2025 · IPR2025-00611 · APJ Christopher L Ogden · IPR · Institution
The Board instituted IPR of claims 1–10, 12, 13, 19, and 20 on all petition grounds after finding a reasonable likelihood that claim 1 was obvious over Douglas and Mark.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“A claim is unpatentable under § 103 “if the differences between the claimed invention and the prior art are such that the claimed invention as a whole would have been obvious before the effective filing date of the claimed invention to a person having ordinary skill in the art to which the claimed invention pertains.” 35 U.S.C. § 103; see KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 406 (2007). When a ground in a petition is based on a combination of references, we consider “whether there was an apparent reason to combine the known elements in the fashion claimed by the patent at issue.” KSR, 550 U.S. at 418 (citing In re Kahn, 441 F.3d 977, 988 (Fed. Cir. 2006)).” slip op. at 8
- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties agree that experience could substitute for a degree, and vice versa. Pet. 3 (citing Ex. 1003 ¶¶ 19–21); Prelim. Resp. 9. The parties’ proposed levels of ordinary skill are substantially similar. Although we discern no difference in the outcome of this decision from choosing one over the other, we adopt Petitioner’s proposal for this decision. Only Petitioner’s proposed level is supported by testimonial evidence on the preliminary record, and it appears to be consistent with the problems addressed in the ’774 patent. See Ex. 1001, 1:16–52. Therefore, we adopt Petitioner’s proposal for this decision.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“CLAIM CONSTRUCTION B. In an IPR, we construe a patent claim “using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” 37 C.F.R. § 42.100(b). This generally includes “construing the claim in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id. The ordinary and customary meaning of a claim term “is its meaning to the ordinary artisan after reading the entire patent,” and “as of the effective filing date of the patent application.” Phillips, 415 F.3d at 1313, 1321. Neither Petitioner nor Patent Owner argues that we need to construe any claim terms explicitly. See Pet. 2–3; Prelim. Resp. 9. However, the parties’ positions depend on interpreting the claim language in a particular way, and we discuss the relevant claim language below in the context of the parties’ arguments regarding the prior art. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“At this stage, we find Petitioner’s arguments persuasive and disagree with Patent Owner. Patent Owner appears to equate a “fabrication profile” with a toolpath description, but nothing in the plain language of claim 1 supports that narrow interpretation. The ’774 patent describes a “fabrication profile” broadly and states that the profile can simply “include the dictionary [of configuration information],” or be “used to determine which machineready representation is available or suitable for a target printer.” Ex. 1001, 23:49–52. The preliminary evidence suggests that Douglas’s “operational parameters” would count as a “fabrication profile” because it is “the basis for generation of a machine-ready representation of the three-dimensional model that is executable on the target printer.” Id. at 23:37–39; see infra Section III.C.8. We also disagree that Petitioner’s argument is impermissible hindsight, because it is based on the disclosures in Douglas and Mark, and Petitioner has articulated a sufficiently persuasive reason to combine those references without referring to the ’774 patent itself. See In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971) (an obvious rationale is not improper hindsight if it “takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure”). Finally, Petitioner appears to rely on Mark for providing a particular example of a fabrication profile, not to replace Douglas’s overall system in which the 3D printer can receive “operational parameters” rather than just G-code. See Pet. 8–10, 17–23; see also Ex. 1005 ¶ 41 (the print queue, which stores tool instructions, may be maintained locally on printers 204 or on print servers 208); see In re Mouttet, 686 F.3d 1322, 1332 (Fed. Cir. 2012) (“[A] determination of obviousness based on teachings from multiple references does not require an actual, physical substitution of elements.” (citing In re Etter, 756 F.2d 852, 859 (Fed. Cir. 1985) (en banc))).” slip op. at 19
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,886,774 - PTAB · Jun 11, 2025 · IPR2025-00263 · APJ Barry L Grossman · IPR · Institution
Instituted IPR for claims 1–30 on all asserted grounds; the Board found a reasonable likelihood that claims would be unpatentable over Haley and Lai.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“III. CONCLUSION We have determined that there is a reasonable likelihood that Petitioner will prevail on at least one challenged claim. Accordingly, we institute an inter partes review on all challenged claims on each asserted ground. PGS Geophysical, 891 F.3d at 1360 (A decision to institute is a “yes-or-no institution choice respecting a petition, embracing all challenges included in the petition.”).” slip op. at 42
- BurdenInstituted
“limitations of clauses 1.3 and 1.4, but concedes that Haley does not disclose that its driver member has “at least one longitudinal edge with a plurality of spaced-apart protrusions,” as required by clause 1.4. Petitioner further asserts, however, that it would have been obvious “to replace Haley’s hydraulic lifter with the claimed ‘lifter,’ disclosed by [Lai]”. Pet. 13. (citing Ex. 1003 ¶ 54). Dr. Vallee’s cited Declaration testimony provides his opinion on this issue, which is consistent with Petitioner’s argument. Petitioner also asserts that “Lai discloses an electrically-powered, mechanical lifting mechanism with a structure that is essentially identical to the ‘lifter member’ disclosed in the ’776 patent. Pet. 13. Petitioner provides side-by-side colored figures from the ’776 patent and from Lai, reproduced below, to illustrate its argument. Pet. 14. According to Petitioner, the side-by-side comparison of Petitioner’s colored versions of Fig. 12, from the ’776 patent, with Petitioner’s colored versions of Figs. 4 A–D, reproduced above, illustrate why and how the proposed modification would have been obvious. As described by Petitioner, the “lifter member” of the ’776 patent includes a rotatable cam lifter 100 (yellow), with pins 104, 106, and 108 (green) on its face surface that engage protrusions 92 (blue) on the driver member 90 (orange). Pet. 13 (citing Ex. 1001, 9:30–46, 16:34–48, Fig. 12). Petitioner also cites the “two-pin variants: lifter members 465 and 480” shown in Figs. 31, 33 of the ’776 patent. Id. Petitioner also asserts that, as shown in the side-by-side comparison” slip op. at 33
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)No construction neededOther
“Petitioner asserts the term “lifter member” in the claims of the ’776 patent is “a means-plus-function term” because the claims “lack any ‘recital of structure, material, or acts in support thereof’ for the ‘lifter’ element.” Pet. 7 (citing 35 U.S.C. § 112(f)). Petitioner also asserts “[t]he Federal Circuit held that the term ‘lifter member’ in the related patents is a means-plus-function term subject to §112(f).” Pet. 7. Petitioner cites no authority for this assertion. We understand this assertion to refer to the decision in Kyocera Senco Indus. Tools Inc. v. Int’l Trade Comm’n, 22 F.4th 1369 (Fed. Cir. 2022), identified by Petitioner as a related matter. Pet. 2. In this case, which involved patents from the same family as the ’776 patent (see Section I.C of this Decision), the Federal Circuit concluded that “§ 112 ¶ 6 applies to the ‘lifter member’ limitation, and it must be construed to cover only ‘the structure, materials, or acts described in the specification as corresponding to the claimed function and equivalents thereof.’” Id. at 22 F.4th 1379–1381. “Where multiple patents derive from the same parent application and share many common terms, we must interpret the claims consistently across all asserted patents.” Samsung Elecs. Co. v. Elm 3DS Innovations, LLC, 925 F.3d 1373, 1378 (Fed. Cir. 2019) (citing SightSound Techs., LLC v. Apple Inc., 809 F.3d 1307, 1316 (Fed. Cir. 2015) (internal quotation marks omitted). Patent Owner asserts that Petitioner: fails to comply with the requirement of 37 C.F.R. § 42.104(b)(3) to specifically identify the structure in the specification associated with that element. As ‘lifter’ is present in every challenged claim under all four grounds, Petitioner’s failure to provide a claim construction for ‘lifter’ is fatal to its Petition. Prelim. Resp. 13. We disagree. First, the claims in the ’776 patent do not use the single word “lifter” alone. The term used in some of the claims, see, e.g., independent claims 1 and 17, and the claims dependent from claims 1 or 17, is “lifter member.” We recognize that the written description in the ’776 patent states “the rotary-to-lifter 100 is also sometimes referred to herein as a ‘lifter member,’ or simply as a ‘lifter.’” Ex. 1001, 9:5–7. This suggests that that term “lifter” is intended to mean the “lifter member,” which makes the use of either term a distinction without a substantive difference. Moreover, neither independent claims 9 or 24, nor the claims dependent from claims 9 and 24, use the word “lifter” or “lifter member. Second, as stated in Petitioner’s Preliminary Reply, the Petition “identifies the portions of the specification that describe the corresponding structure for the ‘lifter’ when comparing its structure to that of the Lai prior art.” Prelim. Reply 1. The Petition provides a colored version of Figure 12 from the ’776 patent (reproduced below) and identifies the following corresponding structures from the Specification of the ’776 Patent: The “lifter member” of the ’776 patent includes a rotatable cam lifter 100 (yellow [ ]), with pin 104, 106, and 108 (green) on its face surface that engage protrusions 92 (blue) on the driver member 90 (orange). ’776 patent, 9:30–46, 16:34–48, Fig. 12. The ’776 patent also discloses two-pin variants: lifter members 465 and 480 in Figs. 31, 33. [citing] ’776 patent, 32:15–30, 32:48–63. Petition at 13. Based on the record before us, we determine that this identification of corresponding structure is sufficient to satisfy 37 C.F.R. § 42.104(b)(3). We also note that at this stage of the proceeding, Patent Owner does not dispute that Petitioner has identified the correct corresponding structure. To the extent the parties wish to further address the construction of this claim limitation, they may do so during trial, as permitted by our rules.” slip op. at 16
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“to mean “a chamber that is distinct from the displacement volume of the hollow cylinder and contains part of the working air volume during operation.” Pet. 8. According to Petitioner “there is nothing in the intrinsic record or any of the claims of the ’776 patent that prevents the ‘main storage chamber’ from being in the hollow cylinder, so long as it is distinct from its separately-recited ‘displacement volume.’” Id. at 9 (emphases added). Patent Owner asserts that “[g]rounds 2 and 4 each requires this Board to interpret the ‘storage chamber’ to be the same structure as the hollow cylinder.” Prelim. Resp. 31. According to Patent Owner, “[t]he Federal Circuit, considering both parties’ claim construction arguments, rejected that construction.” Id. Patent Owner does not provide any citation to support its reference to the Federal Circuit decision. It appears to be a reference to the Kyocera decision considering review of the ITC determination. See Kyocera, 22 F.4th at 1383. That decision, however, construed claims in a related patent to “require two distinct structures: the main storage volume and a smaller “hollow cylinder” contained within the main storage volume. Based on the record before us, Petitioner’s proposed construction is consistent with the Federal Circuit’s construction, which states two structures can be distinct even if one distinct structure is “contained within” the other distinct structure. Although the parties dispute the construction of the “storage chamber” claim limitation, this dispute relates only to Grounds 2 and 4. See Prelim. Resp. 31. We need not resolve it to determine whether to institute review. The parties are welcome to develop their arguments regarding this claim limitation during trial. 3. Conclusion Regarding Claim Construction Our claim construction analyses in this decision to institute a trial do not preclude the parties from arguing their proposed constructions of the claims during trial. Indeed, the parties are hereby given notice that claim construction, in general, is an issue to be addressed at trial. Claim construction will be determined at the close of all the evidence and after any hearing. The parties are expected to assert all their claim construction arguments and evidence in the Petition, Patent Owner’s Response, Petitioner’s Reply, or otherwise during trial, as permitted by our rules.” slip op. at 19
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,241,776
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.