- Shenzhen Xinzexing E-Commerce Co., Ltd. v. Shenzhen Carku Technology Co., Ltd.All claims unpatentablePTAB · Jul 24, 2025 · IPR2024-00222 · APJ Garth D Baer · IPR · Final written decision
Claims 1–3, 6–23, and 25–33 are unpatentable, including as anticipated by Chen and as obvious over the Chen and Inskeep combinations.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“have at least a Bachelor’s Degree in Electrical Engineering and at least two years of experience in the field of electrical engineering and specifically power supply management such as battery charging system design.” PO Resp. 31. Petitioner presents a similar formulation. Pet. 10. Although we do not discern any meaningful distinction between the parties’ formulations, we adopt Patent Owner’s description of a person of ordinary skill as it is consistent with the prior art and challenged patent’s specification. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself may reflect an appropriate level of skill).” slip op. at 5
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“a first current through one or more output ports of the at least one output port in a first operating mode,” and “is configured to output a second current capable of starting a vehicle engine through the pair of output terminals in a second operating mode.” Ex. 1001, 8:25–34. Claim 21 has similar first and second operating-mode limitations. Id. at 9:40–46. Patent Owner proposes that “[t]he proper construction for ‘first operating mode’ is ‘an operating mode of the portable backup charger wherein the battery pack is configured to output a first current through one or more output ports of the at least one output port, and outputting a second current capable of starting a vehicle engine through the pair of output terminals is inhibited.’” PO Resp. 25. Similarly, Patent Owner argues “[t]he proper construction for ‘second operating mode’ is ‘an operating mode of the portable backup charger wherein the battery pack is configured to output a second current capable of starting a vehicle engine through the pair of output terminals, and outputting a first current through one or more output ports of the at least one output port is inhibited.’” Id. at 27. Patent Owner asserts that claim differentiation supports its construction because dependent claim 3 recites “a third operating mode for outputting the first current and the second current simultaneously,” and “if the battery pack could output the first current and the second current simultaneously in the first operating mode, then there would be no difference between the claimed first operating mode and the claimed third operating mode.” Id. at 26. We disagree with Patent Owner’s constructions because, as Petitioner explains, they wrongly import current-inhibiting limitations beyond the plain language in the claim. Pet. Reply 1. Nothing in the at-issue language addresses inhibiting current. In addition, the claimed first and third operating modes are still distinct without importing additional limitations because outputting just the first current is sufficient for the first operating mode, but not for the third. In other words, whereas the third operating mode requires simultaneity, the first and second merely permit it. Thus, claim differentiation does not support Patent Owner’s construction. Last, although Patent Owner asserts that its construction “is consistent with the specification,” nothing in the cited passages describes inhibiting current. Prelim. Resp. 26 (citing Ex. 1001, 4:30–33, 5:30–33, 5:58–62). Instead, the specification characterizes the modes solely by what the portable charger “can output,” not what is inhibited. Ex. 1001, 4:30–33, 5:30–33, 5:58–62. Thus, we decline to read the first and second operating modes to require the current-inhibiting features that Patent Owner asserts.” slip op. at 6
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“Patent Owner argues the two current paths are not different because Chen’s Figure 1 shows they overlap between the lithium battery and the output control circuit and “only diverge when making the connection to the output control circuit.” PO Resp. 32. We disagree. First, Patent Owner’s argument is based on a claim construction for “different” current paths that we do not adopt for the reasons above. In addition, we agree with Petitioner that Chen shows the claimed different current paths even under Patent Owner’s construction. Pet. Reply 8–12. Specifically, as Petitioner explains, a skilled artisan would recognize that Chen’s physical circuits are depicted in Figures 4–7, rather than in Chen’s Figure 1, which is merely a “block diagram of the principle of present invention.” Id. at 9; Ex. 1006 ¶ 15. Unlike Figure 1, Chen’s Figures 5, 6, and 7 show current paths between the battery and USB outputs, and between the battery and DC multi-gear output, that do not overlap with the high current path shown in Chen’s Figure 4. Pet. 9–12. Based on Petitioner’s analysis and for the reasons above, we agree with Petitioner that Chen teaches the claimed “pair of output terminals coupled to the battery pack and having a current path to the battery pack different from that of the at least one output port to the battery pack.”” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successUnpatentableMotivation foundUnpatentable
“Patent Owner asserts one skilled in the art would not have added White’s fuse to Chen because doing so was “unnecessary” given Chen’s built-in relay K1 that already provides protection. PO Resp. 42–43. We disagree because, as Petitioner notes, “the Petition cited ample evidence that both layers of over current prevention provide improved safety and protection to the battery.” Pet. Reply 17 (citing Pet. 31–33); see also, e.g., Pet. 31 (describing “advantageously reduc[ing] the likelihood of damage”), id. at 32 (describing “the additional benefit of a safety fuse along a jumper cable to promptly cut off current in the event of a short circuit” and “more simplified maintenance and repair”). Given Petitioner’s unrebutted rationale, Petitioner has articulated sufficient reasoning with rational underpinning to support the legal conclusion that adding White’s fuse and polarity-protection connector to Chen’s power-supply system would have been obvious to one of ordinary skill in the art. See KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 418 (2007). Other than the arguments addressed above, Patent Owner does not additionally challenge Petitioner’s obviousness showing based on Chen and White. We have reviewed Petitioner’s arguments and evidence and, based on that analysis, we find Petitioner has shown by a preponderance of the evidence that claims 1, 2, 6–9, 11–14, 16–22, 25–28, and 30–33 would have been obvious over Chen and White.” slip op. at 15
Patent outcomesUS 9,643,506 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites KSRPatents in suitUS 9,643,506 - Posco Co., Ltd. v. ArcelormittalInstitutedPTAB · Jul 23, 2025 · IPR2025-00371 · APJ Brian D Range · IPR · Institution
The Board instituted IPR on claims 1–25 based on all petitioned grounds, finding a reasonable likelihood that POSCO would prevail.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The following findings of fact and conclusions of law are not final, but are made for the sole purpose of determining whether Petitioner meets the threshold for initiating review. Any final decision shall be based on the full trial record, including any response timely filed by Patent Owner. Any arguments not raised by Patent Owner in a timely-filed response may be deemed waived. For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We hereby institute an inter partes review as to claims 1–25 of the ’227 patent based upon Petitioner’s asserted grounds of unpatentability.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art (POSITA) “would have had an undergraduate degree in materials science, manufacturing engineering, mechanical engineering, or equivalent knowledge, training, or experience, with two years of experience working in metallurgy.” Pet. 6 (citing Ex. 1003 ¶ 15). For purposes of this Decision, we adopt Petitioner’s proposal as reasonable and consistent with the ’227 patent specification and the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art may reflect an appropriate level of skill in the art).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner does not propose any claim constructions. Pet. 3. We do not discern a need to construe explicitly any claim language at this juncture because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“35 U.S.C. § 103(a) as obvious over Takagi and Cornette, citing the Declaration of Dr. Miles for support. Pet. 1, 6–49 (citing Ex. 1003) (Petitioner’s Ground 1A). a. Claim 1 Petitioner argues that Takagi and Cornette teach or suggest each recitation of claim 1. Pet. 6–31. Petitioner argues, for example, that the preamble of claim 1 is not limiting or, alternatively, imparts no structural distinction from Takagi. Id. at 20–23 (citing, e.g., Ex. 1003 ¶ 48). Petitioner further argues that Takagi and Cornette teach forming or hot stamping to arrive at their products. Id. at 23 (citing, e.g., Ex. 1016 ¶ 36 (Takagi referring to “form[ing]” its products shape); Ex. 1014, 9–11 (Cornette referring to “hot stamping”); Ex. 1003 ¶ 48. Petitioner argues that Takagi teaches a strip of base steel having a first and second side. Id. at 23–24 (citing, e.g., Ex. 1003 ¶ 49; Ex. 1016 ¶¶ 13, 36. Petitioner argues that Takagi teaches a coating that is a “diffusion layer” having five phases as depicted by Takagi Figure 2A and explained by Takagi Table 1 (Takagi Fig. 4). Id. at 24–30 (citing, e.g., Ex. 1003 ¶¶ 50–59; Ex. 1016 ¶ 20, Fig. 2A). Petitioner argues that Takagi alone or as modified by Cornette teaches a coating thickness greater than than 30 µm. Id. at 30–31; Ex. 1014, 9; Ex. 1016 ¶ 35; Ex. 1003 ¶¶ 60–61. Petitioner explains why a person having ordinary skill in the art would have had reason to combine teachings of Takagi and Cornette with a reasonable expectation of success. Pet. 11–20 (citing, e.g., Ex. 1003 ¶¶ 31–47; Ex. 1016 ¶¶ 19–37, 47; Ex. 1014, 9; Ex. 1025, 5:17–20; Ex. 1026, 7; Ex. 1034 ¶ 13; Ex. 1055 ¶¶ 2, 7, 14–15, 18, Fig. 3). Based on our review and consideration of the current record, we determine that the information presented sufficiently supports, for purposes of institution, Petitioner’s assertions that Takagi and Cornette teach or suggest each limitation of claim 1. See Pet. 6–31. We therefore determine Petitioner has met its burden to show a reasonable likelihood it would prevail in demonstrating that claim 1 would have been obvious over Takagi and Cornette.” slip op. at 12
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,326,227 - Posco Co., Ltd. v. ArcelormittalInstitutedPTAB · Jul 23, 2025 · IPR2025-00370 · APJ Brian D Range · IPR · Institution
The Board instituted IPR of claims 1–30 on all twelve asserted obviousness grounds, finding a reasonable likelihood that POSCO would prevail.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The following findings of fact and conclusions of law are not final, but are made for the sole purpose of determining whether Petitioner meets the threshold for initiating review. Any final decision shall be based on the full trial record, including any response timely filed by Patent Owner. Any arguments not raised by Patent Owner in a timely-filed response may be deemed waived. For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We hereby institute an inter partes review as to claims 1–30 of the ’602 patent based upon Petitioner’s asserted grounds of unpatentability.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“For purposes of this Decision, we adopt Petitioner’s proposal as reasonable and consistent with the ’602 patent specification and the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art may reflect an appropriate level of skill in the art).” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner does not propose any claim constructions. Pet. 3. We do not discern a need to construe any claim language at this juncture because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200” slip op. at 9
- BurdenInstituted
“determine that the information presented sufficiently supports, for purposes of institution, Petitioner’s assertions that Takagi and Cornette teach or suggest each limitation of claim 1. See Pet. 6–33. We therefore determine Petitioner has met its burden to show a reasonable likelihood it would prevail in demonstrating that claim 1 is obvious over Takagi and Cornette.” slip op. at 12
Claim constructioncites KSR · GrahamPatents in suitUS 10,961,602 - PTAB · May 16, 2025 · IPR2024-01487 · APJ Julia Heaney · IPR · Institution
The Board instituted IPR on all challenged claims and grounds, finding a reasonable likelihood that claim 1 would have been obvious over Nakazawa and Glaug.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Upon consideration of the Petition in view of the record at this stage, we determine that Petitioner has established a reasonable likelihood that it would prevail in showing the unpatentability of at least one claim challenged in the Petition. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314(a). Accordingly, we grant institution of an inter partes review of all claims and all grounds asserted in the Petition.1” slip op. at 2
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“person of ordinary skill would modify either Nakazawa’s diffusion sheet or Glaug’s fluid acquisition system, but rather Petitioner argues “various layers in absorbent articles are invariably interchangeable.” Prelim. Resp. 41–42. Contrary to Patent Owner’s argument, as discussed above, Petitioner explains why and how a person of ordinary skill would modify Nakazawa’s diffusion sheet, and provides reasons for doing so. On this record, we find Petitioner’s reasoning sufficient.” slip op. at 24
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner
“Patent Owner further argues Nakazawa teaches away from Petitioner’s asserted modification in which Glaug’s lower non-perforated layer is added to Nakazawa’s diffusion sheet. Prelim. Resp. 42. Specifically, Patent Owner argues Nakazawa teaches that its embodiment in which the second absorbent material is wrapped in a hydrophilic sheet has the advantage of preventing leakage of super absorbent polymer (“SAP”) from the second absorbent material without impeding permeation of excretory fluid through the hydrophilic sheet. Id. at 43 (citing Ex. 1008 ¶ 85, Fig. 15). Patent Owner further relies on Petitioner’s argument that Nakazawa’s hydrophilic layer is analogous to the lower non-perforated layer in Glaug. Id. (citing Pet. 93–94). Therefore, Patent Owner argues, Nakazawa teaches that Glaug’s fluid acquisition system would impede permeation of fluid rather than promote it. Id. Patent Owner’s teaching away argument is unavailing based on the current record. Patent Owner improperly relies on Petitioner’s contention in its anticipation challenge based on Nakazawa, and characterizes it as an argument about Glaug. As further discussed in Section II.G below, Petitioner’s anticipation challenge is based on analogizing Nakazawa’s hydrophilic sheet to a core wrap feature identified in Patent Owner’s infringement contention in parallel district court litigation. See Pet. 92–93. Contrary to Patent Owner’s argument, Petitioner’s obviousness contention does not argue Nakazawa’s hydrophilic layer is analogous to Glaug’s nonperforated fibrous layer. Because Patent Owner is not properly characterizing Petitioner’s obviousness contention, Patent Owner’s teaching away argument is not persuasive.” slip op. at 24
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“Under Fintiv, we consider the following factors: 1. whether the court granted a stay or evidence exists that one may be granted if a proceeding is instituted; 2. proximity of the court’s trial date to the Board’s projected statutory deadline for a final written decision; 3. investment in the parallel proceeding by the court and the parties; 4. overlap between issues raised in the petition and in the parallel proceeding; 5. whether the petitioner and the defendant in the parallel proceeding are the same party; and 6. other circumstances that impact the Board’s exercise of discretion, including the merits. Fintiv at 5–6.” slip op. at 35
Claim construction§ 103 obviousnessDiscretionary denialcites KSR · GrahamPatents in suitUS 9,308,138 - Uatp IP LLC v. Slick Slide LLCInstitutedPTAB · Apr 8, 2025 · PGR2024-00054 · APJ Julia Heaney · PGR · Institution
The Board instituted PGR on claims 1–17 and 22–28 and all asserted grounds, finding a sufficient likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of a post-grant review is authorized by statute when “the information presented in the petition . . . would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a) (2018). Upon consideration of the parties’ submissions and the evidence of record, we determine that Petitioner has demonstrated that it is more likely than not that at least one claim challenged in the Petition is unpatentable. Further, Patent Owner has not persuaded us that it is appropriate to exercise our discretion not to institute review. Accordingly, we institute a post-grant review of all claims and all grounds asserted in the Petition.1” slip op. at 2
- Skill levelSkill level patent owner adoptedOther
“On this record, we do not find Patent Owner’s proposed experience level of at least five years in measurement and analysis of coefficient of friction to be supported. As to the necessity of experience in textile engineering and fiber science, Patent Owner’s position, although not supported by declarant analysis of the factors listed above, is consistent with the disclosure of the ’854 patent, which describes features of a mesh layer in textile and fiber terms. See e.g., Ex. 1001, 10:17–11:14, 12:65–13:8, 14:20–24. On the whole, however, we do not discern on this record how specific experience in textile engineering and fiber science of a person of ordinary skill would materially alter the outcome at this stage of the proceeding. For purposes of this decision only, we apply Patent Owner’s proposed definition of a person of ordinary skill in the art, except for the requirement of five years of experience in measurement and analysis of coefficient of friction. The level of skill in the art remains an open issue in this proceeding. Further submissions by the parties may include argument and evidence that would assist in the resolution of this issue at the close of trial.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner contends “no formal claim construction is necessary in this proceeding.” Pet. 10; Reply 1, 4. Patent Owner contends the terms “mesh layer” and “coefficient of friction” require construction. Prelim. Resp. 14–16; Sur-reply 2–5. We have considered the parties’ arguments and discuss them below with regard to each of the terms Patent Owner contends should be construed. Because our determination that Petitioner demonstrates at least one challenged claim meets the threshold for institution (see SAS Inst., 138 S. Ct. at 1359–60) is not based on construing the term “mesh layer” or “coefficient of friction,” we determine we need not construe either claim term at this stage of the proceeding. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)). As further discussed below, we invite the parties to address claim construction at trial.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageDisclaimer not foundDecided for petitioner
“We agree with Petitioner that the ’854 patent specification does not include clear and explicit lexicography or a disclaimer that would support requiring “coefficient of friction” to be determined by a specific ASTM test method. The portion of the specification Patent Owner asserts as a definition of “coefficient of friction” (see Ex. 1001, 11:31–42) is a description of an embodiment; we find it does not express patentee intent to redefine the term. Further, the statement that “the coefficient of friction … may be determined using the … ASTM D1894 standard test method” (id. at 11:32–35) indicates that use of that specific test method is optional. Accordingly, in the absence of patentee lexicography or disavowal, we do not limit the scope of the term “coefficient of friction” to require that it be measured by a specific ASTM standard. Luminara Worldwide, LLC v. Liown Elecs. Co., 814 F.3d 1343, 1353 (Fed. Cir. 2016) (“Absent lexicography or disavowal, we do not depart from the plain meaning of the claims.”); In re Am. Acad. Of Sci. Tech Ctr., 367 F.3d 1359, 1369 (Fed. Cir. 2004) (“We have cautioned against reading limitations into a claim from the preferred embodiment described in the specification, even if it is the only embodiment described, absent clear disclaimer in the specification.”). We note that the ’854 patent specification sets forth a definition for the coefficient of friction between the surfaces of the mesh material and the slide surface. Ex. 1001, 4:38–46. As stated above, however, we do not expressly construe any claim term at this stage of the proceeding. Should the parties address the construction of “coefficient of friction” at trial, we will make a determination after the close of evidence and any hearing.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosureDiscretionary denialcites KSR · GrahamPatents in suitUS 11,998,854 - Posco Co., Ltd. v. ArcelormittalInstitutedPTAB · Mar 18, 2025 · IPR2024-01377 · APJ Brian D Range · IPR · Institution
The Board instituted IPR on claims 1–25 on all petitioned grounds, finding a reasonable likelihood of success, including that GMW14400 likely qualifies as prior art.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review pursuant to 35 U.S.C. § 6(b). Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The Board determines whether to institute a trial on behalf of the Director. 37 C.F.R. § 42.4(a). The following findings of fact and conclusions of law are not final, but are made for the sole purpose of determining whether Petitioner meets the threshold for initiating review. Any final decision shall be based on the full trial record, including any response timely filed by Patent Owner. Any arguments not raised by Patent Owner in a timely-filed response may be deemed waived. For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We hereby institute an inter partes review as to claims 1–25 of the ’227 patent based upon Petitioner’s asserted grounds of unpatentability.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“efficiency and integrity of the system are best served by denying or instituting review.” Fintiv at 6. Here, Fintiv factors one and five are neutral, factors two and three favor discretionary denial, factor four strongly weighs against discretionary denial, and favor six weighs against discretionary denial. The integrity of the system will benefit from institution because of the strong merits the Petition presents (factor six), and the ITC Investigation will not resolve these merits (factor four). This outweighs any potential inefficiency as indicated by factors two and three. We further note that any inefficiency in resolving the grounds the Petition presents is mitigated by the stay of the district court action (factor one). We, thus, decline to exercise discretionary denial under 35 U.S.C. § 314(a).” slip op. at 17
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDenied
“After considering the record as a whole, we determine that Petitioner has adequately demonstrated that the Office erred in a manner material to the patentability of challenged claims. As we explain in Section III(G), infra, Petitioner’s challenges to the ’227 patent appear strong based on the current record, and Patent Owner’s present arguments to the contrary are weak. Given the strength of Petitioner’s challenges on the present record, this is not a situation where we would say that “reasonable minds can disagree regarding the purported treatment of the art,” and we therefore determine that the Examiner erred by not considering the art in substantially the combination Petitioner proposes. Where Patent Owner states that “evidence that the Examiner did not consider these references in combination” is lacking (PO Sur-Reply 5), we disagree. If the Examiner considered these references in combination, the Examiner would have, given the apparent strength of Petitioner’s position on the merits on this record, issued a rejection. The lack of a rejection based on the combination proposed in the Petition provides some evidence that the Examiner did not consider these references in combination (because the lack of such a rejection raises the likelihood that the Examiner did not make such a consideration). 3. Conclusion Because Petitioner adequately made a showing of material error, we decline to exercise discretion not to institute inter partes review under 35 U.S.C. § 325(d). See Advanced Bionics, LLC, IPR2019-01469, Paper 6 at 8–9.” slip op. at 19
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“For purposes of this Decision, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,326,227 - Posco Co., Ltd. v. ArcelormittalInstitutedPTAB · Mar 18, 2025 · IPR2024-01376 · APJ Brian D Range · IPR · Institution
The Board instituted review of claims 1–30 on all petitioned grounds, finding a reasonable likelihood of success, including that GMW14400 likely qualifies as prior art.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“IV. CONCLUSION For the reasons above, we determine that the information presented in the Petition establishes that there is a reasonable likelihood that Petitioner would prevail with respect to challenged claims 1–30 of the ’602 patent. At this juncture in the proceeding, we have not made a final determination with respect to the patentability of the challenged claims, or with respect to claim construction. V. ORDER For the foregoing reasons, it is ORDERED that pursuant to 35 U.S.C. § 314(a), an inter partes review of claims 1–30 of the ’602 patent is hereby instituted with respect to all grounds of unpatentability set forth in the Petition; and” slip op. at 36
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivDenied
“efficiency and integrity of the system are best served by denying or instituting review.” Fintiv at 6. Here, Fintiv factors one and five are neutral, factors two and three favor discretionary denial, factor four strongly weighs against discretionary denial, and favor six weighs against discretionary denial. The integrity of the system will benefit from institution because of the strong merits the Petition presents (factor six), and the ITC Investigation will not resolve these merits (factor four). This outweighs any potential inefficiency as indicated by factors two and three. We further note that any inefficiency in resolving the grounds the Petition presents is mitigated by the stay of the district court action (factor one). We, thus, decline to exercise discretionary denial under 35 U.S.C. § 314(a).” slip op. at 17
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDenied
“After considering the record as a whole, we determine that Petitioner has adequately demonstrated that the Office erred in a manner material to the patentability of challenged claims. As we explain in Section III(G), infra, Petitioner’s challenges to the ’602 patent appear strong based on the current record, and Patent Owner’s present arguments to the contrary are weak. Given the strength of Petitioner’s challenges on the present record, this is not a situation where we would say that “reasonable minds can disagree regarding the purported treatment of the art,” and we therefore determine that the Examiner erred by not considering the art in substantially the combination Petitioner proposes. Where Patent Owner states that “evidence that the Examiner did not consider these references in combination” is lacking (PO Sur-Reply 5), we disagree. If the Examiner considered these references in combination, the Examiner would have, given the apparent strength of Petitioner’s position on the merits on this record, issued a rejection. The lack of a rejection based on the combination proposed in the Petition provides some evidence that the Examiner did not consider these references in combination (because the lack of such a rejection raises the likelihood that the Examiner did not make such a consideration). 3. Conclusion Because Petitioner adequately made a showing of material error, we decline to exercise discretion not to institute inter partes review under 35 U.S.C. § 325(d). See Advanced Bionics, LLC, IPR2019-01469, Paper 6 at 8–9.” slip op. at 19
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“For purposes of this Decision, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,961,602 - PTAB · Mar 12, 2025 · IPR2024-01458 · APJ Julia Heaney · IPR · Institution
The Board instituted IPR of claims 1, 7, 8, and 11 on all asserted grounds, finding a reasonable likelihood of unpatentability on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Upon consideration of the Petition in view of the record at this stage, we determine that Petitioner has established a reasonable likelihood that it would prevail in showing the unpatentability of at least one claim challenged in the Petition. Accordingly, we grant institution of an inter partes review of all claims and all grounds asserted in the Petition.1” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Patent Owner’s construction of the claims as informed by its allegations of infringement in co-pending litigation, as best Petitioner is able to understand such allegations.” Pet. 18 (citing Exs. 1016–1017). Petitioner does not propose construction of any claim term at this stage of the proceeding. Upon review of the record, we determine that no claim terms require express construction for purposes of this Decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“would possess at least a Bachelor’s degree in mechanical engineering, electrical engineering, industrial design or product design or product design engineering, chemistry, or physics, or a related field, and at least three to four years of industry experience, or a Master’s degree in mechanical engineering, electrical engineering, industrial design or product design or product design engineering, chemistry, or physics, or a related field, and at least one to two years of industry experience. Pet. 15 (citing Ex. 1003 ¶ 18). Petitioner further argues a “POSA would have been familiar with electrically powered cigarettes and their components and underlying technologies or similar components and technologies.” Id. For purposes of this decision, we adopt Petitioner’s definition of the level of ordinary skill in the art because it is consistent with the ’788 patent and the asserted prior art.” slip op. at 8
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“second chamber. Pet 55 (citing Ex. 1005 ¶ 20, Fig. 1a). Petitioner concedes Lee does not disclose a bulb containing a heating wire, but contends this would have been obvious at least in view of Gilbert. Id. at 56 (referring to Pet. 41–42, citing Ex. 1004, 2:45–46, 2:50, 2:71–3:2, Fig. 2). Petitioner contends a person of ordinary skill in the art would have been motivated to explore other types of heating elements than the nichrome wire described in Lee due to issues with e-cigarettes at the time, such as metallic taste or inhalation risks associated with the use of a metal wire heating element. Id. at 57 (citing Ex. 1003 ¶ 117). Petitioner contends it was known to use bulb heaters for vaporizing fluids for almost 100 years (id. ¶¶ 117–118), and therefore a person of ordinary skill would have been motivated to implement a heating element within a glass bulb in Lee’s device to address the metal taste and inhalation risk issues. Pet. 57. Petitioner further contends a person of ordinary skill in the art would have been motivated to implement a heating element within a glass bulb to increase the life of the heating element and prevent failure of the device, because Levin teaches that directly contacting the heating element was known to reduce the life of the heating element, and discloses a heater bulb for vaporizing an active ingredient for inhalation by the user. Id. at 58–59 (citing Ex. 1009 ¶¶ 4, 49, 56). In view of the foregoing, we determine Petitioner has demonstrated sufficiently for purposes of institution that the combination of Lee, Gilbert, and Levin teaches or suggests limitation [1d], and that a person of ordinary skill in the art would have had reason to use Gilbert’s or Levin’s bulb heater in Lee’s electronic cigarette, with a reasonable expectation of success.” slip op. at 14
Claim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 9,538,788 - Posco Future M Co., Ltd. v. Camx Power LLCInstitution deniedPTAB · Feb 5, 2025 · IPR2024-01229 · APJ Jane E Inglese · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood that any challenged claim was anticipated or obvious over the asserted references.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (“The Board institutes the trial on behalf of the Director.”). Inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a).” slip op. at 2
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“Conceptronic, Inc., 90 F.3d 1576, 1582 (Fed. Cir. 1996) (“First, we look to the words of the claims themselves . . . to define the scope of the patented invention.”). Claim 1 recites a particle that comprises (1) a plurality of crystallites comprising (a) a first composition (i) having a layered α- NaFeO2-type structure and (ii) comprising lithium, nickel, and oxygen; and (2) a grain boundary between adjacent crystallites of the plurality of crystallites and comprising (a) a second composition (i) having the layered α-NaFeO2-type structure, a cubic structure, or a combination thereof, and (ii) a concentration of cobalt in the grain boundary greater than a concentration of cobalt in the crystallites. The plain language of claim 1 thus indicates that the grain boundary has a composition (i.e., a “second composition”) distinct from that of the adjacent crystallites (i.e., a “first composition”), and that the grain boundary may have the same structure (i.e., a layered α-NaFeO2-type structure) or a different structure (i.e., a cubic structure, or a combination of a cubic structure and a layered α-NaFeO2-type structure) than the adjacent crystallites. The plain language of claim 1 thus structurally distinguishes the grain boundary from the adjacent crystallites by specifying that the grain boundary has a concentration of cobalt greater than that of the concentration of cobalt in the crystallites.” slip op. at 9
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element) › Inherent disclosureNot shown unpatentableNot shown unpatentable
“Petitioner, however, does not provide any evidence to establish that any such identity of empirical formulas means that Lampe-Onnerud’s cathode material necessarily has the same microstructure as the particle of claim 1. In particular, even if the empirical formula of Lampe-Onnerud’s core material is the same as that of the ’317 patent’s first composition, Petitioner does not provide evidence establishing that it necessarily follows that Lampe-Onnerud’s core is a polycrystalline material having a plurality of crystallites separated by grain boundaries between adjacent crystallites. Nor does Petitioner provide evidence establishing that it necessarily follows from any identity between the empirical formula of Lampe-Onnerud’s coating material and the ’317 patent’s second composition that Lampe-Onnerud’s coating material necessarily is present in grain boundaries at a higher concentration than in crystallites, assuming that Lampe-Onnerud’s material is comprised of a plurality of crystallites having grain boundaries between adjacent crystallites. Furthermore, although Petitioner’s declarant, Dr. Aurbach, indicates that Lampe-Onnerud’s process “begins with a conventional lithium nickel oxide-base material . . . known to be comprised of secondary articles having agglomerated primary particles and grain boundaries,” Dr. Aurbach does not provide any objective evidence to substantiate this asserted knowledge in the art. Ex. 1002 ¶ 110. We, therefore, accord little weight to Dr. Aurbach’s opinion on this issue. 37 C.F.R. § 42.65(a) (opinion testimony that does not disclose underlying facts or data “is entitled to little or no weight”); Velander v. Garner, 348 F.3d 1359, 1371 (Fed. Cir. 2003) (“[W]hat the Board consistently did was accord little weight to broad conclusory statements that it determined were unsupported by corroborating references. It is within the discretion of the trier of fact to give each item of evidence such weight as it feels appropriate.”); In re Am. Acad. of Sci. Tech Ctr., 367 F.3d 1359, 1368 (Fed. Cir. 2004) (“[T]he Board is entitled to weigh the declarations and conclude that the lack of factual corroboration warrants discounting the opinions expressed in the declarations.”).” slip op. at 18
- Expert testimonyPetitioner expert discountedDecided for patent owner
“Furthermore, although Petitioner’s declarant, Dr. Aurbach, indicates that Lampe-Onnerud’s process “begins with a conventional lithium nickel oxide-base material . . . known to be comprised of secondary articles having agglomerated primary particles and grain boundaries,” Dr. Aurbach does not provide any objective evidence to substantiate this asserted knowledge in the art. Ex. 1002 ¶ 110. We, therefore, accord little weight to Dr. Aurbach’s opinion on this issue. 37 C.F.R. § 42.65(a) (opinion testimony that does not disclose underlying facts or data “is entitled to little or no weight”); Velander v. Garner, 348 F.3d 1359, 1371 (Fed. Cir. 2003) (“[W]hat the Board consistently did was accord little weight to broad conclusory statements that it determined were unsupported by corroborating references. It is within the discretion of the trier of fact to give each item of evidence such weight as it feels appropriate.”); In re Am. Acad. of Sci. Tech Ctr., 367 F.3d 1359, 1368 (Fed. Cir. 2004) (“[T]he Board is entitled to weigh the declarations and conclude that the lack of factual corroboration warrants discounting the opinions expressed in the declarations.”).” slip op. at 19
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 9,391,317 - Formfactor, Inc. v. Technoprobe S.P.A.InstitutedPTAB · Jan 24, 2025 · IPR2024-00933 · APJ Andrew L Nalven · IPR · Institution
Instituted IPR on all challenged claims, 1–23, and all asserted grounds after finding a reasonable likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Pursuant to 35 U.S.C. § 314(a), an inter partes review may not be instituted “unless . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” After considering the Petition, the Preliminary Response, and associated evidence, we determine that Petitioner has demonstrated a reasonable likelihood of prevailing in demonstrating the unpatentability of claims 1–23 of the ’885 patent. Accordingly, we institute an inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“engineering, and materials engineering or another field applicable to wafer probing technology with three to five years of professional experience in designing and/or using probe technologies, or an equivalent level of skill, knowledge, and experience.” Pet. 22 (citing Ex. 1003 ¶¶ 50–53). Patent Owner does not offer a position as to the level of ordinary skill in the art. See generally Prelim. Resp. For purposes of this Decision, we adopt Petitioner’s definition of a POSITA, which is consistent with the level of skill reflected in the Specification and asserted prior art.” slip op. at 10
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededDecided for petitioner
“Only those claim terms that are in controversy need to be construed, and only to the extent necessary to resolve the controversy. Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017). After reviewing the record, at this stage, we determine that only claim 14 requires express construction for purposes of this Decision.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“Further, we interpret claim 14, for purposes of this Decision, as contemplated by Petitioner such that the first and second types of signals may be the same type of signal. Pet. 26. In other words, the first and second type of signal may both be ground or power. This construction appears to have support within the ’885 patent. For example, the ’885 patent describes an embodiment where “at least two conductive portions . . . of the guide 40 are electrically connected to each other by means of a conductive track 39 in the guide, so as to be able to electrically connect to each other groups of contact elements apt to carry a same type of signal.” Ex. 1001, 16:49–59. This construction also appears consistent with parent claim 1, which recites “the first and second types of signals chosen between ground signals and power signals.” The parties are invited to address any claim construction issues during the course of trial.” slip op. at 9
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,035,885
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.