- PTAB · Dec 16, 2024 · IPR2024-01006 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted IPR of claims 1–8 on all petitioned grounds, finding a reasonable likelihood of success on the Ohata–Kavan obviousness challenge and no basis for discretionary denial.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). The standard for instituting an inter partes review is set forth in 35 U.S.C. § 314(a), which provides that an inter partes review may not be instituted “unless the Director determines . . . there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Having considered the arguments and evidence set forth by Petitioner and Patent Owner, we determine that the information presented in the Petition demonstrates a reasonable likelihood that Petitioner would prevail on at least one of the challenged claims of the ’909 patent. We also determine that the arguments and evidence of record do not support discretionary denial of the Petition under 35 U.S.C. § 314(a). Accordingly, we institute an inter partes review as to all of the challenged claims of the ’909 patent on all of the grounds of unpatentability set forth therein.” slip op. at 2
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“Contrary to Patent Owner’s arguments, the law on overlapping ranges in obviousness challenges is clear. See In re Peterson, 315 F.3d 1325, 1329 (Fed. Cir. 2003) (“A prima facie case of obviousness typically exists when the ranges of a claimed composition overlap the ranges disclosed in the prior art.”). Here, Petitioner directs us to evidence of an overlapping range, which is not meaningfully disputed by Patent Owner. As to Patent Owner’s arguments regarding the lower end of the claimed range of aspect ratios and Ohata’s warning about aspect ratios below 100, we note that Ohata states that its carbon nanotubes “preferably have an aspect ratio . . . of not less than 100,” and expressly includes examples with an aspect ratio of 50. Ex. 1004 ¶ 20 (emphasis added), Table 2 (Examples 12 and 14). Patent Owner also criticizes Petitioner for relying on oxidizing Ohata’s nanotubes in view of Kavan (discussed in more detail below). Prelim. Resp. 6. According to Patent Owner, oxidation is known to shorten the length of nanotubes, which would impact the aspect ratio of the nanotubes in the proposed combination. Prelim. Resp. 6. Specifically, Patent Owner contends that oxidizing Ohata’s nanotubes will reduce the aspect ratio below 100, and argues that “Petitioner has not explained why a [person of ordinary skill in the art] would ignore Ohata’s warning nor has Petitioner provided evidence that the resulting combination will perform as Petitioner alleges.” Prelim. Resp. 7; see also Prelim. Resp. 8 (arguing Petitioner has not explained why a person of ordinary skill in the art would try to retain Ohata’s aspect ratio and expect success when Ohata is altered in view of Kavan). Even giving Patent Owner’s arguments their full weight, there is no evidence on the present record as to how much the aspect ratio of Ohata’s nanotubes would be reduced as a result of oxidation. Rather, based on the present record, namely, the broad range of aspect ratios disclosed in Ohata (preferably 100–1000), it seems reasonably likely that the aspect ratio of at least some of the oxidized nanotubes in the proposed composition would remain within the range disclosed in Ohata and overlap the claimed range, as Petitioner asserts. Nevertheless, the parties may address during trial the expected level of carbon nanotube shortening in the proposed combination of Ohata and Kavan.” slip op. at 21
- Obviousness (§103) › Motivation to combine / reasonable expectation of success › Teaching awayTeaching away not foundDecided for petitioner
“To the extent Patent Owner is presenting a teaching away argument, these statements do not rise to the level of criticizing, discrediting, or discouraging investigation into the claimed invention. DePuy Spine, Inc. v. Medtronic Sofamor Danek, Inc., 567 F.3d 1314, 1327 (Fed. Cir. 2009). Indeed, in addition to its statement regarding oxidation not being necessary for anchoring to TiO2, Kavan also states that oxidation of carbon nanotubes “was sometimes mentioned to improve anchoring of TiO2.” Ex. 1005, 2. Moreover, the full statement from Kavan regarding storage capacity reads: “The Li-storage capacity of TiO2 is not enhanced in the composite, but the rate of electrochemical charge transfer is higher due to nanotube networking.” Ex. 1005, 9. Thus, in its entirety, this statement supports Petitioner’s argument that there are advantages to using oxidized nanotubes, and, in turn, provides a reason why a person of ordinary skill in the art would have used oxidized nanotubes. Moreover, the evidence Petitioner presents regarding the use of oxidized nanotubes in combination with TiO2, coupled with Ohata’s statement that the electrode active material to be used can vary depending on the battery type (Ex. 1004 ¶¶ 26–27), undermines Patent Owner’s criticism that Petitioner’s arguments are circular.” slip op. at 24
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“Although the parties appear to agree that this factor is neutral, we note that a district court denial of a motion to stay without prejudice, accompanied by an indication that the district court would consider a renewed motion, “suggests the district court may be willing to avoid duplicative efforts and await the PTAB’s final resolution of the patentability issues raised in the petition before proceeding with the parallel litigation.” Fintiv at 6–7. “This fact has usually weighed against exercising authority to deny institution.” Id. (also noting that factors 2 and 3 are relevant to how much weight to give to the court’s willingness to reconsider a stay); see also T-Mobile, Paper 16 at 12 (noting that a stay was unlikely in that case given the proximity of the trial date to the entry of the institution decision). In view of the forgoing, we determine that Fintiv factor 1 weighs against exercising our authority to deny institution.” slip op. at 37
§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,808,909 - Intel Corporation v. Besang Inc.No claims unpatentablePTAB · Dec 11, 2024 · IPR2023-00991 · APJ Jon B Tornquist · IPR · Final written decision
The Board held claims 1 and 13–17 not unpatentable, finding the asserted obviousness grounds deficient in claim limitations or motivation to combine.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“The parties proposed definitions differ in that Petitioner would permit a degree in “materials science” and require three years, as opposed to two years, of relevant experience. Compare Pet. 9 with PO Resp. 14. On this record, we adopt Patent Owner’s proposed definition, as it is more consistent with the prior art of record and the disclosures of the ’702 patent. We note, however, that neither party contends that the outcome of this case depends on the slight differences in the proposed definitions of a person of ordinary skill in the art.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“1996) (“It is well-settled that, in interpreting an asserted claim, the court should look first to the intrinsic evidence of record, i.e., the patent itself, including the claims, the specification and, if in evidence, the prosecution history.”). Upon review of the parties’ arguments and the intrinsic record, we agree with Petitioner that the ’702 patent does not support a construction of “stackable add-on layer” that encompasses memory cells formed by sequential deposition on a substrate without being formed and then added to a separately formed substrate. Pet. 11–12. First, the plain language of the claim does not require merely a “layer” having a plurality of vertically oriented semiconductor memory cells, but rather “a stackable add-on layer” having a plurality of vertically oriented semiconductor memory cells; that plurality is bonded to the dielectric layer. Ex. 1001, 12:29–32. A construction that gives meaning to all words of the claim is preferred. Merck & Co., Inc. v. Teva Pharm. USA, Inc., 395 F.3d 1364, 1372 (Fed. Cir. 2005) (“A claim construction that gives meaning to all the terms of the claim is preferred over one that does not do so.”).” slip op. at 12
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“As discussed above, we do not understand a “stackable add-on layer” to include memory cells that are formed by sequential deposition on or above a substrate without being added to a separately formed substrate. It is undisputed, and indeed it is Petitioner’s assertion, that Lee’s memory devices are formed by sequential deposition. Pet. 16, 29 n.11, 51 (“In Lee, each level 3104 is deposited on the underlying level of array 3101.”). Therefore, Petitioner has not shown that Lee discloses every limitation of independent claim 13 under our claim construction. Thus, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious in view of Lee. 3. Analysis: Claims 14–17 Claims 14–17 each depend, directly or indirectly, from claim 13. Petitioner’s arguments with respect to these claims do not remedy the deficiencies noted above with respect to claim 13. Pet. 31–41. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 14–17 would have been obvious over Lee.” slip op. at 19
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“We agree with Patent Owner that Petitioner has not demonstrated that Aspar would improve Lee, would solve a problem in Lee, and that Petitioner is proposing to use Aspar in a way that is not disclosed in the reference. PO Resp. 49–50 (citing Ex. 2029 ¶¶ 153–162); Tr. 57:24–58:12; Pet. 61; KSR, 550 U.S. at 417 (asking whether a technique “would improve similar devices in the same way”), 420 (asking whether there was a known problem in the art), 421 (asking whether one of ordinary skill in the art had reason to “pursue the known options”); Intel, 61 F.4th at 1381 (explaining that obviousness may be demonstrated by showing that there was a known problem in the art (“cache coherency in multiprocessor systems”) and that a person of ordinary skill in the art would recognize that that the prior art solution to this problem (“global segmented secondary cache”) would improve the system of another prior art reference). Petitioner does not persuasively show that there was any known problem in the art with respect to Lee or its monolithic method of constructing memory arrays. Nor does Petitioner provide persuasive argument or evidence that Aspar’s wafer bonding would improve Lee’s memory device.10 For example, Petitioner states in a conclusory fashion that Aspar would address the known problem of “fabricating 3D structures,” but does not explain what those problems were or why Lee fails to solve them. Pet. 61. Dr. Sechen’s testimony merely parrots the Petition, providing no further analysis or explanation of what problem might exist in Lee when fabricating its 3D structures. Ex. 1003 ¶ 212. The Petition notes that Aspar transfers “thin layers of very good thickness homogeneity and with a high crystalline quality,” but the Petition never asserts that Lee’s direct deposition method fails to provide these same or similar qualities. Pet. 60–61.” slip op. at 27
Patent outcomesUS 7,378,702 not shown unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,378,702 - Micron Technology, Inc. / Micron Semiconductor Products, Inc. et al. v. Besang Inc.No claims unpatentablePTAB · Nov 13, 2024 · IPR2023-00900 · APJ Jon B Tornquist · IPR · Final written decision
Claims 13–17 were not shown unpatentable: Lee-based grounds fail on the stackable add-on layer limitation, and Watanabe-based grounds fail on nonvolatile memory, enablement, or motivation to combine.
RulingsFinal written decision- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“meaning in the art. See Irdeto Access, Inc. v. Echostar Satellite Corp., 383 F.3d 1295, 1300 (Fed. Cir. 2004) (stating that, absent an accepted meaning in the art, “we construe a claim term only as broadly as provided for by the patent itself”). Thus, we must attempt to discern the meaning of this term from the claim language itself and from the remainder of the intrinsic record. See Vitronics Corp. v. Conceptronic, Inc., 90 F.3d 1576, 1582 (Fed. Cir. 1996) (“It is well-settled that, in interpreting an asserted claim, the court should look first to the intrinsic evidence of record, i.e., the patent itself, including the claims, the specification and, if in evidence, the prosecution history.”). Upon review of the parties’ arguments and the intrinsic record, we agree with Petitioner that the ’702 patent does not support a construction of “stackable add-on layer” that encompasses memory cells formed by sequential deposition on a substrate without being formed and then added to a separately formed substrate.” slip op. at 10
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“As discussed above, we construe “stackable add-on layer” to not include memory cells that are formed by sequential deposition on or above a substrate without being added to a separately formed substrate. It is undisputed, and indeed it is Petitioner’s assertion, that Lee’s memory devices are formed by sequential deposition. See Pet. 52 (asserting that in Lee “the layers of the array are directly deposited on the layers of each underlying level, and the array is deposited on the interlayer insulating layer formed over a substrate”); see also id. at 70 (“Lee discloses forming vertical memory devices through layer-by-layer sequential deposition on the substrate . . . .”). Therefore, Petitioner does not show that Lee discloses every limitation of independent claim 13 under our claim construction. Thus, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious in view of Lee. 3. Claims 14 and 15 Claims 14 and 15 depend from claim 13. Ex. 1001, 12:35–42. Petitioner’s arguments for these claims do not remedy the deficiencies noted above with respect to independent claim 13. Pet. 54–59. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 14 and 15 would have been obvious in view of Lee alone. E. Claims 16 and 17 over Lee and Endoh Petitioner contends the subject matter of claims 16 and 17 would have been obvious over the combined disclosures of Lee and Endoh. Pet. 59–69. Petitioner’s arguments with respect to these claims, however, do not remedy the deficiencies noted above with respect to Lee and its monolithic, sequentially deposited memory array. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claims 16 and 17 would have been obvious over Lee and Endoh.” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable
“combined Lee and Watanabe to achieve improved integration density. Pet. 71. Petitioner concedes, however, that the benefits of Lee’s design related to 3-D integration and improved integration density would be obtained if Lee’s memory structures are formed using either Lee’s monolithic construction method or Watanabe’s alternative stacking method. Pet. Reply 13–14 (citing Ex. 1041 ¶ 34). Thus, we are not persuaded that improved integration density provides a sufficient rationale for Petitioner’s combination of Lee’s memory device and Watanabe’s stacking method. Petitioner argues that Watanabe’s stacking method “improves the accuracy of the wiring” because the wiring is made “for each planar member.” Pet. 72 (citing Ex. 1005, 6:1–3). Watanabe also states that its disclosed methods provide “a low interconnection wire resistance.” Ex. 1005, 6:20–23. Petitioner does not, however, explain sufficiently how Watanabe’s stacking method would improve Lee’s device. For example, Petitioner does not address whether the alleged wiring benefit already existed in Lee’s monolithic array or explain how this benefit would also apply to Lee’s particular memory array, which differs in construction and elements from Watanabe’s device. This diminishes Petitioner’s benefits-based motivation to combine arguments. In general, a petitioner need not demonstrate that a particular alternate method would improve a prior art device in order to show a motivation to combine. Intel Corp. v. PACT XPP Schweiz AG, 61 F.4th 1373, 1380–81 (Fed. Cir. 2023); see Pet. Reply 20 (citing Intel). But here, Petitioner affirmatively invokes improvement of Lee’s device as a reason for the combination, and we must evaluate Petitioner’s contention. Moreover, any relative lack of improvement or benefits must be weighed against any problems the alternative method would introduce. See Intel Corp. v. Qualcomm Inc., 21 F.4th 784, 795–96 (Fed. Cir. 2021) (noting that simultaneous advantages and disadvantages to a proposed combination must be analyzed to determine whether the disadvantages “outweighed any reason to combine”). Here, as discussed above in more detail with respect to the ground based on Watanabe, the evidence shows that one of ordinary skill in the art would have expected Watanabe’s bonding temperature of 900– 1000° C to damage the electronic devices in an underlying substrate. Ex. 2029 ¶¶ 75–76; Ex. 2028, 123:13–124:7; Ex. 2027, 715. The expected damage to Lee’s device, when balanced against the limited evidence of a benefit to the combination,7 outweighs the reason to combine Lee and Watanabe set forth in the Petition. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that claim 13 would have been obvious over Lee and Watanabe. 2. Analysis – Claims 14 and 15 Claims 14 and 15 both depend directly from independent claim 13. Ex. 1001, 12:35–42. Petitioner’s arguments with respect to claims 14 and 15 do not remedy the deficiencies noted above with respect to independent claim 13. Pet. 73. Accordingly, Petitioner does not demonstrate by a preponderance of the evidence that these claims would have been obvious over Lee and Watanabe.” slip op. at 40
- Expert testimonyPatent owner expert creditedOther
“We credit the testimony of Dr. Przybylski that one of ordinary skill in the art would have understood that Watanabe’s stacked structure would be severely impacted if bonded at a temperature above 900° C, as disclosed in Watanabe. Ex. 2029 ¶¶ 76–77. Dr. Przybylski’s opinion is supported by Dr. Lee’s testimony (Ex. 2028, 123:13–124:7, 125:6–126:7), as well as Watanabe (Ex. 1005, 6:6–14) and Batude (Ex. 2027, 715). As further discussed below, we find that Petitioner has not rebutted Patent Owner’s showing of nonenablement, and Patent Owner has carried its burden to demonstrate that Watanabe was not enabled for bonding temperatures of 900–1000° C, as of the 2004 filing date of the ’702 patent.” slip op. at 32
Patent outcomesUS 7,378,702 not shown unpatentableClaim construction§ 103 obviousnesscites KSR · GrahamPatents in suitUS 7,378,702 - PTAB · Oct 11, 2024 · IPR2024-00773 · APJ Jeffrey W Abraham · IPR · Institution
The Board instituted review of claims 7–12 on all asserted grounds and granted Texas Instruments’ motion to join the Cirrus IPR in an understudy role.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Rather than pointing to anything in the prior art that would teach this claim limitation, the Petition assumes that any “graded concentration of dopants” would necessarily “aid the movement of minority carriers.” The Petition contains no analysis explaining why the “graded concentration of dopants” in the prior art meet the “aid the movement of minority carriers” limitation, apart from the fact that they are “graded concentration of dopants.” In other words, Petitioner reads the “aid the movement of minority carriers” limitation out of the claims completely.” slip op. at 13
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b)” slip op. at 7
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“joinder is discretionary. See 35 U.S.C. § 315(c); 37 C.F.R. § 42.122. A motion for joinder should (1) set forth reasons why joinder is appropriate; (2) identify any new grounds of unpatentability asserted in the petition; (3) explain what impact (if any) joinder would have on the trial schedule for 7 Available at https://www.uspto.gov/TralPracticeGuideConsolidated. the existing review; and (4) address specifically how briefing and discovery may be simplified. See, e.g., Kyocera Corp. v. Softview LLC, IPR2013- 00004, Paper 15 (PTAB April 24, 2013). As the moving party, Petitioner bears the burden of proving that it is entitled to the requested relief. 37 C.F.R. § 42.20(c).” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of successInstituted
“Regarding the “first static unidirectional electric drift field to aid the movement of minority carriers” limitation, Petitioner relies on the parent file history and cited references, arguing that “Payne’s downward-sloping graded-dopant concentration aids the movement of minority carriers from the surface layer to the substrate to the same extent to which Applicant relied on the prior art and admitted to the Patent Office that such carrier movement would occur under the same scenario.” Pet. 23. Petitioner also asserts that the direction in which carriers are forced with the concentration profile disclosed in Payne is downward, toward the substrate and away from the surface. Pet. 23–28 (quoting and citing Ex. 1046, 237–238, 253–254, 289– 290; citing Ex. 1003 ¶¶ 95–106; Ex. 1005, 5:7–17, 5:44–55; Ex. 1009, 2:11– 16, 2:67–3:18, Fig. 2; Ex. 1010, 2:27–32, 5:14–22; Ex. 1013, 431; Ex. 1030, 24). We find that Petitioner’s challenge to claim 7 based on Payne is sufficiently supported for purposes of institution.” slip op. at 12
§ 103 obviousnessPatents in suitUS 9,190,502 - PTAB · Oct 11, 2024 · IPR2024-00771 · APJ Grace Karaffa Obermann · IPR · Institution
The Board instituted IPR on claims 1–6 of the ’195 patent on all asserted grounds and granted Texas Instruments’ motion to join the Cirrus IPR.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Because the Preliminary Response in the instant case includes arguments pertaining to the sufficiency of the asserted prior art references, which were not raised in the preliminary response in the Cirrus IPR, we briefly address below the patentability of the challenged claims.” slip op. at 6
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“II. TIMELINESS OF THE PETITION UNDER 35 U.S.C. § 315(B) Pursuant to 35 U.S.C. § 315(b), “[a]n inter partes review may not be instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 10– 30. However, 35 U.S.C. § 315(b) also provides that the one-year time bar “shall not apply to a request for joinder under subsection (c).” See also 37 C.F.R. § 42.122(b). Because the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted proceeding (IPR2024-00017), which we grant as further discussed below, Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 5
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“B. Whether to Join Petitioner as a Party to the Cirrus IPR Joinder may be authorized when warranted, but the decision to grant joinder is discretionary. See 35 U.S.C. § 315(c); 37 C.F.R. § 42.122. A motion for joinder should (1) set forth reasons why joinder is appropriate; (2) identify any new grounds of unpatentability asserted in the petition; (3) explain what impact (if any) joinder would have on the trial schedule for the existing review; and (4) address specifically how briefing and discovery may be simplified. See, e.g., Kyocera Corp. v. Softview LLC, IPR2013- 00004, Paper 15 (PTAB April 24, 2013). As the moving party, Petitioner bears the burden of proving that it is entitled to the requested relief. 37 C.F.R. § 42.20(c). As an initial matter, we find the Motion for Joinder meets the timing requirements of 37 C.F.R. § 42.122(b) because Petitioner filed it on April 4, 2024, no later than one month after the Cirrus IPR was instituted on May 1, 2024.” slip op. at 9
- Obviousness (§103) › Motivation to combine / reasonable expectation of successNot reached
“5. “Aid the Movement of Minority Carriers” Patent Owner argues that the Petition fails to show that the applied prior art references disclose the claim limitations “requiring ‘aid the movement of minority carriers,’” as twice recited in claim 1. Prelim. Resp. 8. Patent Owner summarizes this dispute as follows: The challenged patent discloses and claims a semiconductor device with (among other things) a “drift layer having a graded concentration of dopants . . . [and] further having a first static unidirectional electric drift field to aid the movement of minority carriers.”[] The Petition should not be instituted, because (among other deficiencies) it fails to show that the prior art discloses the “aid the movement of minority carriers” claim limitation. Rather than pointing to anything in the prior art that would teach this claim limitation, the Petition assumes that any “graded concentration of dopants” would necessarily “aid the movement of minority carriers.” The Petition contains no analysis explaining why the “graded concentration of dopants” in the prior art meet the “aid the movement of minority carriers” limitation, apart from the fact that they are “graded concentration of dopants.” In other words, Petitioner reads the “aid the movement of minority carriers” limitation out of the claims completely. Id. at 1–2. Patent Owner includes additional details in support of its view that the asserted prior art fails to establish obviousness of the “aid carrier movement” limitations of claim 1. Prelim. Resp. 1–10.” slip op. at 8
§ 102 anticipation§ 103 obviousnessPatents in suitUS 8,421,195 - PTAB · Sep 27, 2024 · IPR2024-00674 · APJ Monica S Ullagaddi · IPR · Institution
The Board instituted review of claim 44 on all asserted grounds and granted Texas Instruments’ motion to join IPR2023-01244 in an understudy role.
RulingsInstitution decision- Parallel petitionsDecided for petitioner
“On the present record, we agree with Petitioner that the two petitions filed to challenge the claims of the ’222 patent will not substantially burden the Board or the parties. The petitions in IPR2024-00673 and IPR2024- 00674 challenge different claims, and those claims appear on the present record to have different claim scope, as Petitioner argues. Paper 3, 3–4 (arguing that claim 44, challenged in IPR2024-00674, recites “a ‘surface layer,’ a ‘single drift layer,’ and ‘at least one well region disposed in the single drift layer,’ which are not” recited in the claims challenged in IPR2024-00673); Ex. 1001, 4:39–8:39. In addition, there is little overlap between the prior art asserted in the two petitions, and what overlap there is—the use of Kawagoe in both petitions—is used in different prior-art combinations in each petition. Compare IPR2024-00673, Paper 4, 5 (asserting Kawagoe alone and in combination with Gupta or Silverbrook), with IPR2024-00674, Paper 4, 5 (asserting Kawagoe in combination with Sakai). Accordingly, we do not exercise our discretion to deny either of the petitions challenging the ’222 patent for being parallel petitions.” slip op. at 5
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 16– 37. However, 35 U.S.C. § 315(b) also provides that the one year time bar “shall not apply to a request for joinder under subsection (c).” See also 37 C.F.R. § 42.122(b). Since the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted proceeding (IPR2023-01244), which we grant as further discussed below (see infra § V), Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, regardless of whether Petitioner is in privity with time-barred entities.” slip op. at 5
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“statements made during prosecution of the ’195 patent contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support a preliminary finding that a graded dopant concentration is enough to teach 9 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1020, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. aiding carrier movement in a particular direction. Patent Owner does not dispute that Payne has a drift layer having a static unidirectional electric drift field and a well region having a graded concentration of dopants and a static unidirectional electric drift field at this stage of the proceeding. See generally Prelim. Resp. Patent Owner also does not dispute that Payne’s transistor has a surface layer and a substrate having an area with no active regions. Id. At this stage of the proceeding, Petitioner has the better position.” slip op. at 16
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“statements made during prosecution of the ’195 patent contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support a preliminary finding that a graded dopant concentration is enough to teach 9 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1020, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. aiding carrier movement in a particular direction. Patent Owner does not dispute that Payne has a drift layer having a static unidirectional electric drift field and a well region having a graded concentration of dopants and a static unidirectional electric drift field at this stage of the proceeding. See generally Prelim. Resp. Patent Owner also does not dispute that Payne’s transistor has a surface layer and a substrate having an area with no active regions. Id. At this stage of the proceeding, Petitioner has the better position.” slip op. at 16
§ 103 obviousnessDiscretionary denialPatents in suitUS 11,121,222 - PTAB · Sep 27, 2024 · IPR2024-00673 · APJ Monica S Ullagaddi · IPR · Institution
The Board instituted review of claims 1–9, 13–28, and 32–42 on all asserted grounds and granted Texas Instruments’ motion to join IPR2023-01242 in an understudy role.
RulingsInstitution decision- Parallel petitionsDecided for petitioner
“On the present record, we agree with Petitioner that the two petitions filed to challenge the claims of the ’222 patent will not substantially burden the Board or the parties. The petitions in IPR2024-00673 and IPR2024- 00674 challenge different claims and, on the present record, those claims 8 Patent Trial and Appeal Board Consolidated Trial Practice Guide (Nov. 2019), available at https://www.uspto.gov/TrialPracticeGuideConsolidated (“CTPG”). appear to have different claim scope, as Petitioner argues. Paper 3, 3–4 (arguing that claim 44, challenged in IPR2024-00674, recites “a ‘surface layer,’ a ‘single drift layer,’ and ‘at least one well region disposed in the single drift layer,’ which are not” recited in the claims challenged in IPR2024-00673); Ex. 1001, 4:39–8:39. In addition, there is little overlap between the prior art asserted in the two petitions, and what overlap there is—reliance on Kawagoe in both petitions—is applied in different prior art combinations in each petition. Compare IPR2024-00673, Paper 4, 5 (asserting Kawagoe alone and in combination with Gupta or Silverbrook), with IPR2024-00674, Paper 4, 5 (asserting Kawagoe in combination with Sakai). Accordingly, we do not exercise our discretion to deny either of the petitions challenging the ’222 patent for being parallel petitions.” slip op. at 5
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“III. WHETHER THE PETITION IS TIME-BARRED Pursuant to 35 U.S.C. § 315(b), “[a]n inter partes review may not be instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 19– 39. However, 35 U.S.C. § 315(b) also provides that the one-year time bar “shall not apply to a request for joinder under subsection (c).” See also 37 C.F.R. § 42.122(b). Because the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted proceeding (IPR2023-01242), which we grant as further discussed below (see infra § V), Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 6
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“statements made during prosecution of the ’195 patent contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support a preliminary finding that a graded dopant concentration is enough to teach 13 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1016, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. aiding carrier movement in a particular direction. Patent Owner does not dispute that Kawagoe has a graded dopant concentration in the active region at this stage of the proceeding. See generally Prelim. Resp. Patent Owner also does not dispute that Kawagoe’s transistor has carriers in the active region or that the graded dopant concentration of Kawagoe is lowered from the surface to the bottom substrate (Ex. 1007, Fig. 17). See generally Prelim. Resp. At this stage of the proceeding, Petitioner has the better position.” slip op. at 19
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Instituted
“under the pre-AIA version of 35 U.S.C. § 112, first paragraph and found that “movement of minority carriers is affected by multiple forces and fields” and that “it does not appear that simply the presence of ‘a unidirectional drift field’ in itself can achieve ‘drawing all minority carriers from said surface layer to said substrate.’” Ex. 1016, 289 (emphasis added). Patent Owner responded with the following argument: [A] unidirectional drift (electric) field necessarily affects all the present minority carriers in the same way - moving all minority carriers in the same direction because of the unidirectional drift due to the existence of the electric field. See “Physics and Technology of Semiconductor Devices,” A.S. Grove, pp. 224– 225, John Wiley and Sons, Inc., New York, 1st Edition 1967 (“This same electric field will then be of such direction as to aid the motion of injected holes. Thus the injected minority carriers will now move not only by diffusion but also by drift due to the existence of this electric field.”). Depending on the particular slope of the graded concentration of dopant, all minority carriers are either swept “down” (from the surface layer to the substrate) or “up” (from the substrate to the surface layer). See Applicant’s Figs. 5(b) and 5(c). Id. Patent Owner further argued that the Examiner’s finding appears to not consider that the graded dopant concentration itself creates a “built-in” electrical field that forces the movement of carriers into a particular direction, whereby the “direction” of the electrical field and the resulting direction of the carrier movement depends solely on the slope of the graded concentration of dopant. With regard to the existence of a “built-in” electric field created by a graded dopant density, . . . this inherent “built-in” unidirectional electric field is the additional parameter for ensuring that all minority carriers are being moved in one direction and which parameter the Office Action deemed to be missing from the disclosure. Id. at 289–90 (emphases added). Also, “without conceding its position on this issue,” Patent Owner amended claims to eliminate reference to “all carriers” and instead, refer to “carriers.” 13 Id. at 290. 4. Analysis of Claim 1 At this stage of the proceeding, we determine that Patent Owner’s statements made during prosecution of the ’195 patent contradict its arguments in the present proceeding. See generally Prelim. Resp. Based on the present record, Patent Owner’s statements during prosecution support a preliminary finding that a graded dopant concentration is enough to teach 13 The examined claims of the ’195 patent generally recited “a unidirectional drift field drawing all minority carriers from said surface layer to said substrate.” Ex. 1016, 286. Patent Owner amended the claims of the ’195 patent to recite “maintain[ing] a single static unidirectional electric drift field to aid the movement of minority carriers from said surface layer to said substrate.” Id. aiding carrier movement in a particular direction. Patent Owner does not dispute that Kawagoe has a graded dopant concentration in the active region at this stage of the proceeding. See generally Prelim. Resp. Patent Owner also does not dispute that Kawagoe’s transistor has carriers in the active region or that the graded dopant concentration of Kawagoe is lowered from the surface to the bottom substrate (Ex. 1007, Fig. 17). See generally Prelim. Resp. At this stage of the proceeding, Petitioner has the better position.” slip op. at 18
§ 103 obviousnessDiscretionary denialPatents in suitUS 11,121,222 - PTAB · Sep 27, 2024 · IPR2024-00672 · APJ Julia Heaney · IPR · Institution
The Board instituted review of claims 1–18 on all asserted grounds and granted Texas Instruments’ motion to join IPR2023-01243 in an understudy role.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this stage of the proceeding, we determine that the arguments and evidence of record favor Petitioner. Both parties agree that a downward-sloping gradient, as disclosed in Kawagoe, will create an electrical field with a force in a direction toward the substrate. See generally Prelim. Resp.; Ex. 1007, 16:7–9. Patent Owner does not meaningfully dispute that Kawagoe has a graded dopant concentration in an active region. See generally Prelim. Resp. Further, Patent Owner contradictorily stated during prosecution of the ’195 patent that a graded dopant concentration itself creates “a built-in electrical field that forces the movement of carriers in a particular direction” (Ex. 1016, 289–290) and is “the additional parameter for ensuring that all minority carriers are being moved in one direction” (id. at 290). In light of this evidentiary record, which at most presents a material issue of fact for resolution at trial, we determine Petitioner establishes a reasonable likelihood of prevailing in its challenge of claim 1. We decline to further discuss the parties’ arguments or resolve any disputed issues as to challenges based on Kawagoe on this preliminary record, because the trial in the 1243 IPR is the better proceeding in which to do so. Specifically, as compared to the preliminary phase of this case, the instituted trial in the 1243 IPR affords the parties better opportunity to brief, argue, and develop evidence in support of their positions. Thus, for the same reasons stated in our Decision on Institution in the 1243 IPR, we determine the Petition here warrants institution.” slip op. at 16
- Obviousness (§103) › Motivation to combine / reasonable expectation of successInstituted
“deficient because Kawagoe’s disclosure of graded dopant concentration teaches impeding carrier movement rather than aiding it, as required by claim element 1.5. Prelim. Resp. 13–14. Patent Owner relies on Kawagoe’s disclosure that the concentration gradient prevents electrons from entering the p-well. Id. at 14 (citing Ex. 1007, 16:7–11). Patent Owner further argues Kawagoe’s carriers are not in the active regions, as required by claim element 1.5. Id. at 14–16 (citing Ex. 1003 ¶ 91, n.5). At this stage of the proceeding, we determine that the arguments and evidence of record favor Petitioner. Both parties agree that a downward-sloping gradient, as disclosed in Kawagoe, will create an electrical field with a force in a direction toward the substrate. See generally Prelim. Resp.; Ex. 1007, 16:7–9. Patent Owner does not meaningfully dispute that Kawagoe has a graded dopant concentration in an active region. See generally Prelim. Resp. Further, Patent Owner contradictorily stated during prosecution of the ’195 patent that a graded dopant concentration itself creates “a built-in electrical field that forces the movement of carriers in a particular direction” (Ex. 1016, 289–290) and is “the additional parameter for ensuring that all minority carriers are being moved in one direction” (id. at 290). In light of this evidentiary record, which at most presents a material issue of fact for resolution at trial, we determine Petitioner establishes a reasonable likelihood of prevailing in its challenge of claim 1.” slip op. at 15
- PTAB / AIA Trials › §315(b) time barNot time barredDecided for petitioner
“II. TIMELINESS OF PETITION UNDER 35 U.S.C. § 315(B) Pursuant to 35 U.S.C. § 315(b), “[a]n inter partes review may not be instituted if the petition requesting the proceeding is filed more than 1 year after the date on which the petitioner, real party in interest, or privy of the petitioner is served with a complaint alleging infringement of the patent.” 1 The Leahy-Smith America Invents Act (“AIA”), Pub. L. No. 112-29, 125 Stat. 284, 287–88 (2011), included revisions to 35 U.S.C. §§ 102 and 103 that became effective in 2013, after the effective filing date of the challenged claims. See Ex. 1001, codes (22), (60). Therefore, we apply the pre-AIA versions of 35 U.S.C. §§ 102 and 103(a). 2 US 6,043,114, issued March 28, 2000 (Ex. 1007, “Kawagoe”). Petitioner asserts that Kawagoe is prior art under 35 U.S.C. § 102(b). Pet. 4. 3 US 6,163,877, issued December 19, 2000 (Ex. 1014, “Gupta”). Petitioner asserts that Gupta is prior art under 35 U.S.C. § 102(b). Pet. 5. 4 US 2003/0183856 A1, published October 2, 2003 (Ex. 1006, “Wieczorek”). Petitioner asserts that Wieczorek is prior art under 35 U.S.C. §§ 102(a),(e). Pet. 4. 5 Stanley Wolf and Richard N. Tauber, Silicon Processing for the VLSI Era, Vols. 1–4, Lattice Press (2000) (Ex. 1008, “Wolf”). Petitioner asserts that Wolf was published and publicly available no later than 2002, and is prior art under 35 U.S.C. § 102(b). Pet. 5 (citing Exs. 1012, 1013, 1036). Exhibit 1008 was submitted in four parts (A–D) and includes selected portions of Wolf. We cite to Wolf using its original page numbers and omit the exhibit part designations. Patent Owner argues that the Petition is untimely under 35 U.S.C. § 315(b) because Petitioner is in privity with time-barred entities. Prelim. Resp. 18– 39. However, 35 U.S.C. § 315(b) also provides that the one-year time bar “shall not apply to a request for joinder under subsection (c).” See also 37 C.F.R. § 42.122(b). Because the Petition is accompanied by a timely request for joinder (Paper 2) to the instituted proceeding (IPR2023-01243), which we grant as further discussed below, Patent Owner’s argument that the Petition is time-barred under 35 U.S.C. § 315(b) is moot, irrespective of whether Petitioner is in privity with time-barred entities.” slip op. at 8
- PTAB / AIA Trials › Joinder §315(c) / SAS all-or-nothingJoinder, grantedGranted
“Patent Owner’s first argument is not persuasive because it is based on speculation that Petitioner “is trying to block settlement with any of these defendants unless [Patent Owner] also settles with” Petitioner. Opp. Mot. Join. 5. As discussed below, we determine that Patent Owner will not be prejudiced unduly by the joinder. Moreover, we note that even in a situation where the petitioner and patent owner in the proceeding to be joined had settled (Code200 v. Bright Data Ltd., IPR2022-00861, Paper 17 at 5 (PTAB July 25, 2022) (vacated)), the Director nevertheless vacated a decision to deny a motion for joinder. Code200 v. Bright Data Ltd., IPR2022-00861, Paper 18 at 7 (Office of the Director of the USPTO Aug. 23, 2022) (precedential); see also eBay, Inc. v. Lexos Media IP, LLC, IPR2024-00336, Paper 11 at 13–15 (PTAB Feb. 23, 2024). Patent Owner’s second argument is moot because Patent Owner’s Request for Director Review has been denied. 1243 IPR, Paper 43 (PTAB Apr. 24, 2024). Based on the facts and circumstances discussed above, we determine Petitioner has established good cause for joining the 1243 IPR. Specifically, we find that joining Petitioner to the 1243 IPR is unlikely to require any delay or modification to the scheduling order already in place for the 1243 IPR. We also determine that Patent Owner will not be prejudiced unduly by the joinder of this proceeding. Thus, we determine that granting the Motion for Joinder would help “secure the just, speedy, and inexpensive resolution” of these proceedings. See 37 C.F.R. § 42.1(b). For the above reasons, we grant Petitioner’s Motion for Joinder and join Petitioner as a party to the 1243 IPR.” slip op. at 19
§ 103 obviousnessPatents in suitUS 10,510,842 - Nespresso USA, Inc. v. K-Fee System GmbHAll claims unpatentablePTAB · Sep 10, 2024 · IPR2023-00485 · APJ Jon B Tornquist · IPR · Final written decision
Claims 1–10 are unpatentable as obvious over the combined disclosures of Yoakim, Jarisch, Rossi, and Castellani.
RulingsFinal written decision- Skill levelSkill level board ownPetitioner expert creditedDecided for petitioner
“have a bachelor’s degree in engineering plus five years of experience in design of mechanical beverage systems, or similar products.” Pet. 31 (citing Ex. 1003 ¶ 40). In the Institution Decision, we preliminarily determined that a person of ordinary skill in the art “would have a bachelor’s degree in engineering plus five years of experience in design of mechanical beverage systems, or similar products, as well as experience with sensors for recognizing an identifier.” Inst. Dec. 8 (emphasis added). Neither party disputes this conclusion. PO Resp. 9; see generally Pet. Reply. As such, we adopt our preliminary definition of the ordinarily skilled artisan for purposes of this Final Written Decision.” slip op. at 8
- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
“designing medical devices and components, and that those experiences represent work designing products similar to mechanical beverage systems, Patent Owner fails to direct the Board to evidence sufficient to establish that this experience, in the aggregate, amounts to at least “five years” or involved “experience with sensors for recognizing an identifier.” Inst. Dec. 8 (adopting Patent Owner’s own proposed definition of one of ordinary skill in the art); see Sur-reply 3–4 (citing Ex. 1066, 34:16–35:9; Ex. 1067, 101:3– 12, 102:20–104:9; Ex. 2017 ¶¶ 3–4, 8–10) (failing to establish adequately, if at all, how Dr. Howle’s qualifications include the requisite minimum five-year period of relevant design experience). Accordingly, we determine that Dr. Howle is not qualified to offer expert testimony from the perspective of a person having ordinary skill in the art in this proceeding.10 See Kyocera Senco Indus. Tools Inc. v. Int’l Trade Comm’n, 22 F.4th 1369, 1376–77 (Fed. Cir. 2022). The Federal Circuit has explained that “[t]o offer expert testimony from the perspective of a skilled artisan in a patent case,” including the issue of patent “validity,” the “witness must at least have ordinary skill in the art.” Id. (Board’s emphasis). “Without that skill, the witness’[s] opinions are neither relevant nor reliable.” Id. at 1377.” slip op. at 13
- Disclosure Requirements (§112) › Written description (Ariad)Not entitled to earlier dateDecided for petitioner
“Second, Patent Owner and Dr. Howell assert that a person of ordinary skill in the art “would have understood upon reading the second German application that the capsule features described would be intended to be combinable with each of the described embodiments.” PO Resp. 40; Ex. 2017 ¶ 61. But Patent Owner and Dr. Howell do not explain how a barcode could be used in the devices depicted in Figures 16–18, which place the detection means 2.4.2 on the outer circumference of the flange (not its underside) and rely on toothed-rings physically interacting with either the chamber, retaining arms, or a pinion. Ex. 1047, 12:22–31, 13:8–18. Indeed, the second German priority application explains that means 2.4.2 physically interacts with retaining arms 30 (embodiments of Figures 16 and 17) or a pinon (embodiment of Figure 18), and if means 2.4.2 were not present in these embodiments the capsule would either “drop through into a waste container” or could not be inserted through the insertion shaft. Id. at 12:22– 27, 13:9–12, 13:16–35 (noting that in the embodiment disclosed in Figure 18 a pinon interacts with means 2.4.2 and only when means 2.4.2 “is formed complementary to the teeth of the means” can the capsule be inserted). At no point does the second German application identify means 2.4.2 as a barcode or suggest a barcode could be used as the detection means. The second German application also states that A person skilled in the art is also aware that for example the insertion shaft may also contain a sensor, for example a camera, clear, however, that element 27 is part of the brewing chamber, and not the capsule. Ex. 1047, 12:27–31, 13:5–8, 13:21–26, 15:36. Thus, we are not persuaded that the toothed ring is in fact on the bottom side of the flange. which senses the shape of the means 2.4.2. For example, it would be possible, in the present case, for the shape of the teeth and/or the spacing between the same to be sensed. This signal, in turn, is passed to a control means, which frees, for example, the brewing chamber if the capsule is the correct one. Ex. 1047, 14:11–19. Again, despite using a camera to determine if a capsule is “the correct one,” the second German application does not suggest using a barcode in place of the toothed-ring structure, or suggest moving the location of the detection means 2.4.2 from the outer surface to the underside of the flange. This reinforces that the inventors did not contemplate using a barcode in the embodiments depicted in Figures 16–18.” slip op. at 23
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“As asserted by Petitioner, Jarisch teaches how to move a code in a centrifugal brewing system to the bottom of the flange and how to configure a light-conductive material so that the detector’s light source will reach the bottom of the flange. Pet. 48–49; Pet. Reply 23–24 (Ex. 1003 ¶¶ 184–185; Ex. 1005 ¶¶ 82–84, Fig. 5). And, although Figure 61 of Yoakim discloses a flare in its brewing chamber, bodily incorporation is not required, and we are directed to no persuasive argument or evidence that Yoakim could not be configured with a straight chamber, as generally depicted in Figure 5 of Jarisch. Pet. Reply 24 (noting that Dr. Howle’s testimony on this subject is “conclusory” and depends on “bodily incorporation”). As such, we credit the testimony of Mr. Jobin that a person of ordinary skill in the art would have sought to place the code at the bottom of the flange and would have had a reasonable expectation of success in so doing.17 Ex. 1003 ¶ 184. Patent Owner further contends that Yoakim requires that the capsule holder be capable of receiving a set of multiple volume capsules and that 17 As discussed above, Mr. Jobin has extensive experience in the design of brewing devices. Conversely, Dr. Howle has limited experience in this field and is not one of ordinary skill in the art. Although Mr. Jobin’s testimony is more persuasive regardless of the discrepancy in experience between the two declarants, when this difference in design experience is considered, it only serves to increase the weight we give to Mr. Jobin’s testimony. there is a “snug fit” to avoid “unbalances.” PO Sur-reply 8 (citing Ex. 1004 ¶¶ 205, 479, 484, 507, 512). According to Patent Owner, Petitioner does not explain adequately how the use of Jarisch’s “straight chamber” with a capsule holder that does not engage with the side wall of the capsule would allow insertion of the multiple volume capsules or permit a “snug fit.” Id.; PO Resp. 28. Patent Owner’s assertion that Yoakim discloses the use of certain capsules that might not fit into a device with Jarisch’s non-flared structure is ineffective to undercut the sufficiency of Petitioner’s showing on this point. As noted by Patent Owner, Yoakim discloses the use of certain capsules which might not fit into a device with Jarisch’s non-flared structure. But Petitioner is not seeking a bodily incorporation of Yoakim and Jarisch, and other embodiments of Yoakim do not require the type of flared capsule identified by Patent Owner. Ex. 1004, Fig. 63. Moreover, we are directed to no persuasive evidence that Jarisch’s lack of contact between the capsule side wall and the holder would render the device inoperable or even less effective. Id. (citing Ex. 2019, 36:18–37:6; Ex. 1005 ¶ 23 (Jarisch explaining that its device includes a capsule holding means and that the capsule may be successfully driven in rotation). As such, we credit the testimony of Mr. Jobin that one of ordinary skill in the art would have understood how to design the chamber of Yoakim to allow reading of a barcode on the underside of the flange and that this design would allow for successfully receiving single-serve capsules and driving them in rotation. Ex. 1003 ¶¶ 182–184; Ex. 1005 ¶ 23.” slip op. at 39
Patent outcomesUS 11,230,430 unpatentable§ 103 obviousness§ 112 disclosurecites KSR · GrahamPatents in suitUS 11,230,430 - Nespresso USA, Inc. v. K-Fee System GmbHAll claims unpatentablePTAB · Sep 10, 2024 · IPR2023-00502 · APJ Grace Karaffa Obermann · IPR · Final written decision
Claims 1–16 are unpatentable as obvious over the combined disclosures of Yoakim, Jarisch, and Rapparini.
RulingsFinal written decision- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportDecided for petitioner
“To obtain the benefit of the filing date of an earlier application, Patent Owner bears the burden of producing evidence to establish where each limitation of the challenged claims is disclosed in a single priority application. Studiengesellschaft Kohle, 112 F.3d at 1564; NTP, 654 F.3d at 1276. Petitioner identifies limitations of the challenged claims that are missing from each individual German priority application. Pet. 39–42. Patent Owner responds with no evidence or arguments suggesting that the identified limitations are disclosed in a single application. Resp. 10–12. On this record, no challenged claim is entitled to the benefit of the filing date of any of the three German priority applications; therefore, Jarisch qualifies as prior art under at least 35 U.S.C. § 102(e).” slip op. at 19
- Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner
“In other words, even if we accept that Dr. Howle has some experience designing medical devices and components, and that those experiences represent work designing products similar to mechanical beverage systems, Patent Owner fails to direct the Board to evidence sufficient to establish that this experience, in the aggregate, amounts to “at least five years” or involved “experience with sensors for recognizing identifiers.” Dec. 8 (adopting Patent Owner’s own proposed definition of ordinary skill in the art); see Sur-reply 3 (citing Ex. 1066, 34:16–35:9; Ex. 1067, 101:3–12, 102:30– 104:9; Ex. 2017 ¶¶ 3, 4) (failing to establish adequately, if at all, how Dr. Howle’s qualifications include the requisite minimum five-year period of relevant design experience). Accordingly, we determine that Dr. Howle is not qualified to offer expert testimony from the perspective of a person having ordinary skill in the art in this proceeding.12 Kyocera Senco Indus. Tools Inc. v. Int’l Trade Comm’n, 22 F.4th 1369, 1376–78 (Fed. Cir. 2022). The Federal Circuit has made plain that, “[t]o offer expert testimony from the perspective of a skilled artisan in a patent case,” including the issue of patent “validity,” the “witness must at least have ordinary skill in the art.” 12 To be clear, we are not saying that a witness supplying expert opinions must have satisfied the requirements of the level of ordinary skill in the art on or before the priority date of the challenged patent, which Patent Owner seems to understand. See Sur-reply 4–5. Instead, we evaluate whether Dr. Howle had at least the requisite qualifications of a person having ordinary skill in the art by the time he rendered his opinions. Osseo Imaging, LLC v. Planmeca USA, Inc., Appeal No. 2023-1627, slip op. at 7 (Fed. Cir. Sept. 4, 2024) (“[A]n expert can acquire the necessary skill later and develop an understanding of what a person of ordinary skill knew at the time of the invention,” however, where “the expert was not a person of ordinary skill at the time of the invention may well be used during cross-examination to undermine the credibility of the expert.”); see id., slip op. at 5–6 (affirmatively quoting Kyocera). Id. (Board’s emphasis). “Without that skill, the witness’[s] opinions are neither relevant nor reliable.” Id. at 1377. “‘Admitting testimony from a person . . . with no skill in the pertinent art serves only to cause mischief and confuse the factfinder.’” That testimony would ‘amount[ ] to nothing more than advocacy from the witness stand.’” Id. (quoting Sundance, Inc. v. DeMonte Fabricating Ltd., 550 F.3d 1356, 1362, 1364–65 (Fed. Cir. 2008)). Alternatively, even if we accept that Dr. Howle possesses “at least five years” of relevant design experience, on this record, we agree with Petitioner that his opinions are entitled to less weight than those of Petitioner’s witness, Mr. Jobin. Reply 27. Unlike Dr. Howle, Mr. Jobin is a designer by profession, with more than 30 years of industry experience. Reply 27 (citing Ex. 1003 ¶¶ 5–30). For example, Mr. Jobin designed a home-based beer dispensing system utilizing cartridge identification technologies. Id. (citing Ex. 1003 ¶ 24). Mr. Jobin also “has substantial experience with sensors for recognizing identifiers.” Id. (citing Ex. 1003 ¶ 19; Ex. 1072, 3712–19, 67:22–70:19). Dr. Howle, by contrast, “has never designed a beverage machine.” Reply 22; see generally Sur-reply (declining to contest that assertion).13” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner
“In Petitioner’s contrary view, Jarisch teaches how to move a code in a centrifugal brewing system to the bottom of the flange and how to configure a light-conductive material so that the detector’s light source will reach the bottom of the flange. Pet. 45–46; Reply 21–22 (Ex. 1003 ¶¶ 194–195; Ex. 1005 ¶¶ 82–84, Fig. 5). Although Figure 61 of Yoakim discloses a flare in its brewing chamber, bodily incorporation is not required, and we are directed to no persuasive argument or evidence that Yoakim could not be configured with a straight chamber, as depicted in Figure 5 of Jarisch. We credit the testimony of Mr. Jobin that a person of ordinary skill in the art would have sought to place the code at the bottom of the flange and would have had a reasonable expectation of success in so doing. Ex. 1003 ¶ 184. For reasons explained above, we assign little or no weight to Dr. Howle’s conflicting testimony because he has little or no experience designing a mechanical beverage system or similar product. See supra 10– 16. Petitioner lays out persuasive reasons why Dr. Howle’s testimony, on this particular point, is “conclusory” and rests on “bodily incorporation” of the references. Reply 24; see id. at 22–24 (pointing out with particularity fundamental flaws in Dr. Howle’s opinions); In re Mouttet, 686 F.3d 1322, 1332 (Fed. Cir. 2012) (“It is well-established that a determination of obviousness based on teachings from multiple references does not require an actual, physical substitution of elements.”); In re Nievelt, 482 F.2d 965, 968 (CCPA 1973) (“Combining the teachings of references does not involve an ability to combine their specific structures.”). In addition, Patent Owner contends that Yoakim requires that the capsule holder be capable of receiving a set of multiple volume capsules and that there is a “snug fit” to avoid “unbalances.” Sur-reply 8 (citing Ex. 1004 ¶¶ 205, 479, 484, 507, 512). According to Patent Owner, Petitioner does not explain adequately how the use of Jarisch’s “straight chamber” with a capsule holder that does not engage with the side wall of the capsule would allow insertion of multiple volume capsules or permit a “snug fit” in the modified device of Yoakim. Id. at 8–9. Patent Owner’s view that Yoakim discloses the use of certain capsules which might not fit into a device with Jarisch’s non-flared structure is ineffective to undercut the sufficiency of Petitioner’s showing on this point. Petitioner is not seeking a bodily incorporation of Yoakim and Jarisch and, in any event, other embodiments of Yoakim do not require the type of flared capsule identified by Patent Owner. Ex. 1004, Fig. 63. Furthermore, we credit the testimony of Mr. Jobin that one of ordinary skill in the art would have understood how to design the chamber of Yoakim to allow reading of a barcode on the underside of the flange. Ex. 1003 ¶¶ 187–195. With respect to the argument that the use of Jarisch’s design would not allow a snug fit, we are directed to no persuasive evidence that Jarisch’s lack of contact between the capsule side wall and the holder would render the device inoperable or less effective. Resp. 39–40; see Reply 22 (citing Ex. 2019, 36:18–37:6). Indeed, as Petitioner points out, Jarisch indicates that its device, including its capsule holding means, allows the capsule to be successfully driven in rotation. Reply 22 (citing Ex. 1005 ¶ 23).” slip op. at 49
- Obviousness (§103) › Analogous artAnalogous artDecided for petitioner
“That argument is not persuasive. A reference need not identify or discuss another prior art patent or application in order for that reference to be deemed relevant or analogous art. Nor do we endeavor to determine why, or why not, a particular reference is discussed in a prior art reference. The analogous art inquiry focuses on reasonable pertinence and involves assessing the similarities between the claimed invention and the prior art, including the problems addressed and the closeness of the subject matter, as viewed by an ordinarily skilled artisan. Donner Tech., LLC v. Pro Stage Gear, LLC, 979 F.3d 1353, 1360 (Fed. Cir. 2020); see Airbus S.A.S. v. Firepass Corp., 941 F.3d 1374, 1380-81 (Fed. Cir. 2019) (relevant analysis focuses on comparing the disclosed embodiments, function, and structure of the claimed invention to the disclosures of the prior art). Against that backdrop, we reject Patent Owner’s suggestion that the inquiry involves whether the inventors of Jarisch saw a need to discuss Yoakim’s disclosure in Jarisch’s priority document.” slip op. at 45
Patent outcomesUS 10,994,923 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 10,994,923
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.