• Shenzhen Tuozhu Technology Co., Ltd. v. Stratasys, Inc.All claims unpatentable
  PTAB · Sep 28, 2026 · IPR2025-00611 · APJ Christopher L Ogden · IPR · Final written decision

  Claims 1–10, 12, 13, 19, and 20 are unpatentable under § 103 over the stated Douglas–Mark and Hamilton-based grounds.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “The parties agree that experience could substitute for a degree, and vice versa. Pet. 3; PO Resp. 10. The parties’ proposed levels of ordinary skill are substantially similar. For this decision, as in the Institution Decision, we adopt Petitioner’s proposed level, which is supported by credible testimonial evidence and is consistent with the problems addressed in the ’774 patent. See Ex. 1001, 1:16–52. Our decision would be the same, however, if we were to adopt Patent Owner’s proposal.” slip op. at 7

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other

    “Neither Petitioner nor Patent Owner argues that we need to construe any claim terms explicitly. See Pet. 2–3; PO Resp. 10. However, the parties contest two material claim-construction issues which we address below. To the extent that the parties’ positions depend on interpreting other claim language in a particular way, we discuss the relevant claim language below in the context of the parties’ arguments regarding the prior art.” slip op. at 8

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “We disagree with Patent Owner that a person of ordinary skill in the art would have understood that limitation 1.2 must be performed before limitations 1.3 or 1.4. See Ex. 1001, 35:21–24. See Interactive Gift Exp., Inc. v. Compuserve Inc., 256 F.3d 1323, 1342 (Fed. Cir. 2001) (“Unless the steps of a method actually recite an order, the steps are not ordinarily construed to require one.” (citing Loral Fairchild Corp. v. Sony Corp., 181 F.3d 1313, 1322 (Fed. Cir. 1999)). The evidence suggests that a “target printer” is any printer that is ultimately selected for fabricating the object, and such a printer could send its configuration information either before or after that determination is made in limitation 1.2. This interpretation does not render the word “target” meaningless. At some point, a printer must be determined to be the target printer, which is the one intended to ultimately fabricate the three-dimensional object. But the target printer still exists, and is capable of being queried, before that determination is made. We find the examples in the ’774 patent pertinent to this question. The ’774 patent states that “the target printer may include more than one printer.” Ex. 1001, 18:66–67. In discussing the step of “query target printer for properties 306” (Fig. 3A), the ’774 patent states that “[i]n one aspect, numerous queries are sent to numerous printers, e.g., for use in selecting one or more of the printers as the target printer.” Id. at 19:8–10. Alternatively, “the query is sent to a printer that is not necessarily the target printer as described herein, e.g., when the query or information received from a response to the query is used for the selection of the target printer.” Id. at 19:11–14. Importantly, the second embodiment states that the queried printer “is not necessarily the target printer,” suggesting that the queried printer could be the target printer even before it is determined to be such. Id. at 19:11–12 (emphasis added). Based on the evidence of record, a person of ordinary skill in the art would have understood that the “target printer” can be determined after the query recited in limitation 1.3 or the reception of configuration information recited in limitation 1.4. Thus, the evidence does not impose an ordering between limitations 1.2 and 1.3 or between limitations 1.2 and 1.4. The evidence also does not support Patent Owner’s argument that the two reverse-order examples in the ’774 patent are unclaimed embodiments.” slip op. at 10

  • Obviousness (§103) › Motivation to combine / reasonable expectation of success › HindsightMotivation foundDecided for petitioner

    “We disagree that Petitioner’s arguments are based on impermissible hindsight, because they are based on the disclosures in Douglas and Mark, and Petitioner has articulated a persuasive reason to combine those references without referring to the ’774 patent itself, as we discuss below. See In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971) (an obvious rationale is not improper hindsight if it “takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure”).” slip op. at 29

  Patent outcomesUS 11,886,774 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,886,774
• Globus Medical, Inc. v. Spinelogik, Inc.All claims unpatentable
  PTAB · Jul 10, 2026 · IPR2025-00225 · APJ Matthew S Meyers · IPR · Final written decision

  Claims 1–6, 11, 12, and 15–17 are unpatentable: claims 1–4, 6, 11, 12, 15, and 17 over Blain; claims 5 and 16 over Blain, Bray, and Steffee.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner asserts that one of ordinary skill in the art would have had a bachelor’s or equivalent degree in mechanical engineering or a related discipline (e.g., biomedical engineering, metals and materials engineering), and at least five years of experience with a) designing, developing, evaluating and/or using spine devices, b) anatomy, physiology and biology of soft and calcified tissues including bone healing and fusion, and c) biomechanical and functional loading of orthopedic implants. Pet. 18–19 (citing Ex. 1002 ¶¶ 77–78). Petitioner also asserts that “[m]ore education can supplement practical experience and vice versa.” Id. (citing Ex. 1002 ¶ 78). “Patent Owner does not dispute the proffered definition for a POSA.” PO Resp. 10. proposed level of skill is reasonable and consistent with the ’805 patent and the asserted prior art. Thus, for these reasons, we adopt Petitioner’s level of skill in the art.” slip op. at 8

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownDecided for petitioner

    “Based on the full record, we determine that “housing,” as it appears in the context of the term “delivery housing” is a component that is a part of the delivery mechanism (see Ex. 1001, 11:27–31) and that simply contains and guides another component during delivery. See Ex. 1001, 13:25–27, 21:30–50. Thus, we apply the ordinary meaning of “housing,” as it appears in the context of the term “delivery housing,” and address in the context of “delivery housing,” as recited by claims 2 and 4.” slip op. at 12

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner

    “understanding of plain and ordinary meaning as set forth in the litigation.” Pet. Reply 13 (citing Ex. 1022, 2 (“channel . . . [that] has a curved path”)). Thus, Petitioner concludes that the parties agree on construction of “curved channel.” Id. at 13–14.10 9 Although the parties refer to “curved” alone or to a “curved channel,” we understand the parties to be referring to a “channel of the fusion member [that] is curved,” as recited in claims 5 and 16. 10 At oral argument, the parties confirmed that there was no dispute as to the meaning of “curved channel.” See Tr. 15:12–14 (Petitioner stating that “the term “curved channel” appears consistent with the plain language of the claims and Specification. Thus, we adopt the parties’ agreed-upon construction and construe a channel that is “curved” to mean a channel following a curved trajectory.” slip op. at 13

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “We have considered Petitioner’s arguments and evidence, and Patent Owner’s counterarguments and find, on the complete trial record, that Petitioner demonstrates, by a preponderance of the evidence, that Blain discloses “a fusion member for positioning between two vertebral bodies, the fusion member having a first plurality of channels, each channel of the first plurality of channels having an opening on a same side of the fusion member,” as recited by limitation 1.1. At the outset, we find Patent Owner fails to establish that any of the alleged differences between Blain’s “apertures and the ’805 [p]atent’s internal channel geometry” relate to any particular recitation in argued limitation 1.1. Although we acknowledge that claims 5 and 16 each requires curved trajectories (see, e.g., claim 5 reciting “each channel of the fusion member is curved”), limitation 1.1 does not recite such a feature. As Petitioner correctly notes, “[n]othing in the claim requires a special ‘internal channel geometry,’ ‘shaped block,[’] ‘curved tubular channels,’ non ‘straight-through’ apertures, or ‘flexible’ anchors.” Pet. Reply 14 (footnote omitted). See In re Self, 671 F.2d 1344, 1348 (CCPA 1982) (rejecting arguments “not based on limitations appearing in the claims”). Therefore, after reviewing the arguments and evidence, we determine that Petitioner has shown by a preponderance of the evidence that Blain discloses the subject matter of limitation 1.1.” slip op. at 19

  Patent outcomesUS 9,730,805 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,730,805
• Motorola Mobility LLC / Google LLC v. Multifold International Incorporated Pte. Ltd.All claims unpatentable
  PTAB · May 15, 2026 · IPR2025-00038 · APJ Kristen L Droesch · IPR · Final written decision

  Claims 1–7, 10–13, 16, 17, 19, and 20 are unpatentable as obvious over Chin; the Board did not find them anticipated by Chin or Whitehorn.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “B. Level of Ordinary Skill in the Art Petitioner asserts that [a] person of ordinary skill in the art . . . (‘POSITA’) would have had at least a bachelor’s degree in electrical engineering, computer engineering, computer science, or a related field plus at least two years of work or post-graduate experience in image capture, image processing, image display, user interfaces, or a related field. Additional education could offset a lesser amount of experience and vice versa. Pet. 16. Patent Owner accepts Petitioner’s definition. See PO Resp. 25. We adopt Petitioner’s undisputed definition of a person of ordinary skill in the art because it is consistent with the level of skill reflected by the ’842 Patent Specification and the asserted prior art.” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “We agree with Petitioner that claim construction is unnecessary. As demonstrated in the analysis provided below addressing this claim limitation in view of the prior art, we need not explicitly construe “wherein in each image capture mode a display on the first or second screen is different.” See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). Similarly, we need not construe any other claim terms or phrases to resolve the controversy between the parties.” slip op. at 9

  • Strike new argumentNew argument disregardedDecided for patent owner

    “We agree with Patent Owner that Petitioner’s arguments relying on Kennametal are belated. A “[p]etitioner may not submit new evidence or argument in reply that it could have presented earlier, e.g. to make out a prima facie case of unpatentability.” Patent Trial and Appeal Board Consolidated Trial Practice Guide (Nov. 2019)6 at II.I. Thus, we need not consider Petitioner’s belated argument raised for the first time in the Reply. In any event, we agree that Kenneametal is inapplicable for the purpose of supplying a claim limitation missing from Chin’s disclosure. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 851 F.3d 1270, 1274 (Fed. Cir. 2017) (“Kennametal does not stand for the proposition that a reference missing a limitation can anticipate a claim if a skilled artisan viewing the reference would ‘at once envisage’ the missing limitation.”). Chin’s disclosure is silent regarding what is or is not displayed on first display 51 when images are displayed on second display 52 in self-photographing mode, and similarly silent regarding what is or is not 6 Available at www.uspto.gov/patents/ptab/trial-practice-guide. displayed on second display 52 when images are displayed on first display 51 in outward-facing mode. See generally Ex. 1004.” slip op. at 18

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element) › Inherent disclosureInherency not foundNot shown unpatentableNot shown unpatentable

    “We agree with Patent Owner that the theory of inherency was not raised in the Petition and is therefore waived. Compare Pet. 29–33, with Pet. Reply 11–15. In any event, we also agree that Petitioner’s speculation regarding the disclosure of Chin is insufficient to support a theory of inherency. See Pet. Reply 11–15. As explained above, Chin’s disclosure is silent regarding what is or is not displayed on first display 51 when images are displayed on second display 52 in self-photographing mode, and similarly silent regarding what is or is not displayed on second display 52 when images are displayed on first display 51 in outward-facing mode. See Ex. 1004. Speculation regarding the possibilities and probabilities of what is displayed on first display 51 in self-photographing mode, and what is displayed on second display 52 in outward-facing mode are insufficient to establish inherency. See In re Robertson, 169 F.3d at 745. For the forgoing reasons and based on the entire record developed during trial, the preponderance of the evidence does not support Petitioner’s showing that Chin discloses “wherein in each image capture mode a display on the first or second screen is different.” Accordingly, based on the entire record developed during trial the preponderance of the evidence does not support Petitioner’s showing that Chin anticipates claim 1.” slip op. at 20

  Patent outcomesUS 8,836,842 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,836,842
• Deltran USA LLC v. The Noco CompanyAll claims unpatentable
  PTAB · Mar 13, 2026 · IPR2025-00885 · APJ Avelyn M Ross · IPR · Final written decision

  Claims 1–11 are unpatentable under Richardson-based obviousness grounds; the Yu and Paparrizos grounds do not establish unpatentability.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art, “[a]s of the claimed priority date of July 3, 2014, . . . would have been a person with a bachelor’s degree in electrical engineering or its equivalent and two years of experience in the field of electrical engineering including some experience in design of battery charging systems.” Pet. 21 (citing Ex. 1003 ¶¶ 19–30). Patent Owner “does not propose a different level of skill in the art[.]” PO Resp. 16. In light of the record before us, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art, because it is supported by the testimony of C. Arthur MacCarley and not disputed by Patent Owner.” slip op. at 11

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “As neither party proposes an express construction for our consideration and because we determine that claim construction is not necessary, we do not expressly construe any claim terms. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (holding that “only those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Matal, 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs. in the context of an inter partes review).” slip op. at 11

  • PTAB / AIA Trials › §315(e) estoppelNot reached

    “arguments relating to whether the prior findings are “necessary to the determination” or whether estoppel applies to arguments relating to Richardson being inoperative. See Pet. Reply 27. Nor does Petitioner respond to our inquiry about whether collateral estoppel maybe applied on a limitation by limitation basis. See Pet. Reply 27. At the hearing, however, Petitioner confirmed that resolution of the issue is not necessary to our final determination. JUDGE ROSS: Do we even need to decide the collateral estoppel issue? I mean, it seems to me that if your petition clearly made out your case for the combination of Richardson and Zhao, then we don't even need to reach that. MR. CHANDRA: That’s exactly right, Your Honor. That is our position, as well. We believe collateral estoppel applies, but you don't need to decide that issue in order to find these claims unpatentable. As I mentioned before, these are the same references. We have fairly sought out all of the portions of Richardson, we cited to specific portions. Not just relying on collateral estoppel, but the teachings of the reference itself. So, while this is an issue, we believe that collateral estoppel should apply. It does not have to apply in order to find the challenged claims unpatentable. Tr. 19:9–20. We are persuaded, as discussed in Section II.G., that Petitioner has shown where Richardson in combination with Zhao meets each limitation of the claims of the ’203 patent. Accordingly, we need not address whether Petitioner has demonstrated sufficiently that collateral estoppel applies here.” slip op. at 14

  • Strike new argumentNew argument consideredOther

    “Our Practice Guide states, that “[o]nce a trial is instituted, the Board may decline to consider arguments set forth in a preliminary response unless they are raised in the patent owner response.” Consolidated Trial Practice Guide (“Practice Guide”), 52 (Nov. 2019) (citing In re Nuvasive, Inc., 842 F.3d 1376, 1381 (Fed. Cir. 2016) (explaining that a patent owner waives an issue presented in its preliminary response if it fails to renew the issue in its response after trial is instituted)).12 In addition, in our Scheduling Order, we stated that “Patent Owner is cautioned that any arguments not raised in the response may be deemed waived.” Paper 9 at 10; see also Practice Guide, 94 (same). Patent Owner confirmed at the Oral Hearing its understanding that arguments raised in its Preliminary Response and not reasserted in its Patent Owner Response were not appropriate for consideration during trial. Tr. 4:10–6:17. Petitioner does not identify any particular argument raised in the Patent Owner Preliminary Response that is not present in the Patent Owner Response. But, in this Final Written Decision, we do not consider arguments made in the Patent Owner Preliminary Response and instead assess only those fairly presented in the Patent Owner Response.” slip op. at 15

  Patent outcomesUS 11,667,203 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,667,203
• Deltran USA LLC / Adc Solutions Auto LLC v. The Noco CompanyAll claims unpatentable
  PTAB · Mar 13, 2026 · IPR2024-01219 · APJ Avelyn M Ross · IPR · Final written decision

  Claims 1–11 are unpatentable as obvious over the Richardson-based grounds; the Yu and Paparrizos grounds do not establish unpatentability.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art, “[a]s of the claimed priority date of July 3, 2014, . . . would have been a person with a bachelor’s degree in electrical engineering or its equivalent and two years of experience in the field of electrical engineering including some experience in design of battery charging systems.” Pet. 21 (citing Ex. 1003 ¶¶ 19–30). Patent Owner “does not propose a different level of skill in the art[.]” PO Resp. 16. In light of the record before us, we adopt Petitioner’s proposal regarding the level of ordinary skill in the art, because it is supported by the testimony of C. Arthur MacCarley and not disputed by Patent Owner.” slip op. at 11

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “Petitioner submits there are no formal claim constructions necessary in this proceeding[.]” Pet. 22. Patent Owner also “does not propose any terms need to be construed.” PO Resp. 15. As neither party proposes an express construction for our consideration and because we determine that claim construction is not necessary, we do not expressly construe any claim terms. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (holding that “only those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy”); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co. Matal, 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs. in the context of an inter partes review). slip op. at 11

  • PTAB / AIA Trials › §315(e) estoppelNot reached

    “arguments relating to whether the prior findings are “necessary to the determination” or whether estoppel applies to arguments relating to Richardson being inoperative. See Pet. Reply 27. Nor does Petitioner respond to our inquiry about whether collateral estoppel maybe applied on a limitation by limitation basis. See Pet. Reply 27. At the hearing, however, Petitioner confirmed that resolution of the issue is not necessary to our final determination. JUDGE ROSS: Do we even need to decide the collateral estoppel issue? I mean, it seems to me that if your petition clearly made out your case for the combination of Richardson and Zhao, then we don't even need to reach that. MR. CHANDRA: That’s exactly right, Your Honor. That is our position, as well. We believe collateral estoppel applies, but you don't need to decide that issue in order to find these claims unpatentable. As I mentioned before, these are the same references. We have fairly sought out all of the portions of Richardson, we cited to specific portions. Not just relying on collateral estoppel, but the teachings of the reference itself. So, while this is an issue, we believe that collateral estoppel should apply. It does not have to apply in order to find the challenged claims unpatentable. Tr. 19:9–20. We are persuaded, as discussed in Section II.G., that Petitioner has shown where Richardson in combination with Zhao meets each limitation of the claims of the ’203 patent. Accordingly, we need not address whether Petitioner has demonstrated sufficiently that collateral estoppel applies here.” slip op. at 14

  • BurdenDecided for patent owner

    “With respect to Petitioner’s allegations that rest on AAPA, we determine Petitioner has failed to show that claims 2, 10, and 11 are unpatentable. Our rules require that a petition for inter partes review must base the asserted challenges on “prior art consisting of patents or printed publications.” 35 U.S.C. § 311(b); 37 C.F.R. § 42.104(b)(2) and (4). And, a petitioner who relies on applicant admitted prior art as the basis, or part of the basis, of a ground, runs afoul of § 311. Qualcomm, 134 F.4th at 1365; see also USPTO Memorandum, Enforcement and Non-Waiver of 37 C.F.R. § 42.104(b)(4) and Permissible Uses of General Knowledge in Inter Partes Reviews (Jul. 21, 2025), available at www.uspto.gov/sites/default/ files/documents/aapa_memo_final__signed.pdf. We acknowledge but reject Petitioner’s position that its combinations discussing AAPA do not “rely” on AAPA but rather rely on U.S. Patent No. 5,793,185 (“the ’185 patent”), described in the ’203 patent as prior art. Pet. Reply 26. A petition for inter partes review must identify, “in writing and with particularity, each claim challenged, the grounds on which the challenge to each claim is based, and the evidence that supports the grounds for the challenge to each claim.” 35 U.S.C. § 312(a)(3); 37 C.F.R. § 42.104 (b)(4). Here, Petitioner’s contention that the Grounds 2 and 5 actually rely on the ’185 patent when discussing AAPA is inconsistent with the Petition. In particular, the Petition does not cite to or direct our attention to any specific details from the ’185 patent to support its challenges. See generally Pet. 54–57, 76–77. Accordingly, Petitioner has failed to show, by a preponderance of the evidence, that claims 2, 10, and 11 would have been unpatentable over the combination of Richardson, Zhao, and AAPA as well as over the combination of Yu, Paparrizos, and AAPA. Petitioner’s alternative allegations based on Epower-20/Epower-21 are considered below.” slip op. at 18

  Patent outcomesUS 11,667,203 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,667,203
• Samsung Electronics Co., Ltd. / Samsung Electronics America, Inc. v. Harbor Island Dynamic, LLCAll claims unpatentable
  PTAB · Mar 11, 2026 · IPR2024-01404 · APJ Hyun J Jung · IPR · Final written decision

  Claims 1–18 are unpatentable: claims 1–6, 9–14, 17, and 18 as anticipated by Cooney and obvious over Cooney; claims 7 and 15 over Cooney and Dean; claims 8 and 16 over Cooney and Farooq or …

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Based on the full record, we maintain and affirm that a person of ordinary skill in the art “would have had at least a master’s degree in electrical engineering or a similar field and at least two years of experience working with semiconductor systems” and that “[a]dditional relevant work experience can compensate for less education, and vice versa.” Pet. 9–10 (citing Ex. 1002 ¶¶ 72–74). We agree with the parties that any differences in the parties’ proposed level of ordinary skill would not affect our analysis. Pet. Reply 1; Tr. 25:4–9 (Patent Owner’s counsel agreeing that any differences in the parties’ proposed level of ordinary skill in the art are immaterial). We also find that Petitioner’s proposed level of ordinary skill in the art is consistent with the ’609 patent and the asserted prior art.” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “Based on the full record and because Petitioner’s anticipation challenge is based on giving these recitations no patentable weight and Petitioner’s obviousness challenge is based on the same recitations having patentable weight, we determine that resolving whether to give patentable weight to the recitations “to reduce thermal stress in said semiconductor substrate,” “to provide space for said conductive filler to expand inward,” and “to prevent contamination during processing of said semiconductor substrate” is not necessary to resolve the parties’ dispute. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms that . . . are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. full record, we also determine that express claim interpretation of any other claim term is not necessary. Id.” slip op. at 10

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “the claim, must be found in a single prior art reference. Net MoneyIN, Inc. v. VeriSign, Inc., 545 F.3d 1359, 1369 (Fed. Cir. 2008); Karsten Mfg. Corp. v. Cleveland Golf Co., 242 F.3d 1376, 1383 (Fed. Cir. 2001). Each element of the challenged claim must be found, either expressly or inherently, in the single prior art reference. Verdegaal Bros., Inc. v. Union Oil Co. of Cal., 814 F.2d 628, 631 (Fed. Cir. 1987). When evaluating a prior art reference in the context of anticipation, the reference must be “considered together with the knowledge of one of ordinary skill in the pertinent art.” In re Paulsen, 30 F.3d 1475, 1480 (Fed. Cir. 1994) (citing In re Samour, 571 F.2d 559, 562 (CCPA 1978)). “[A] reference can anticipate a claim even if it ‘d[oes] not expressly spell out’ all the limitations arranged or combined as in the claim, if a person of skill in the art, reading the reference, would ‘at once envisage’ the claimed arrangement or combination.” Kennametal, Inc. v. Ingersoll Cutting Tool Co., 780 F.3d 1376, 1381 (Fed. Cir. 2015) (quoting In re Petering, 301 F.2d 676, 681 (CCPA 1962)).” slip op. at 7

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundDecided for petitioner

    “find that Cooney discloses “silicon vias having a hollow center.” Ex. 1002 ¶¶ 120–123; Ex. 1004 ¶¶ 55, 60, Fig. 6. We also find that the portions of Pogge cited by Petitioner show that its “void 25 has an important function in relieving stresses caused by differences in the thermal coefficient of expansion (TCE) of the various materials in and around the feature” (Ex. 1005 ¶ 27) and that the portions of Edelstein cited by Petitioner show that, “[a]lthough it does not change the thermal expansion coefficient, the introduction of a void or voids reduces the effective modulus and Poisson ratio of the through-via, resulting in a compliant through-via that exerts much less stress and force on the surrounding structures” (Ex. 1006 ¶ 47). As discussed above, we find that Cooney’s void 25 is “entirely surrounded by” its conductive filler 24 that, in turn, is surrounded by liner 22 and substrate 10’. Ex. 1004, Fig. 6. We credit Petitioner’s relied-upon testimonial evidence that the presence of a void was known to reduce thermal stress in the surrounding substrate, because the citations to the record support it. Ex. 1002 ¶¶ 124–134; Ex. 1005 ¶¶ 1, 9, 25–28, Fig. 2D; that “a void can decrease thermal stress in the substrate”). We agree with Petitioner’s declarant that Pogge provides a void in a TSV similar to Cooney and the ’609 patent. Ex. 1001, Fig. 4; Ex. 1002 ¶ 127; Ex. 1004, Fig. 6; Ex. 1005, Fig. 2D. We, thus, credit the testimony that, because of their common structural arrangements, one of ordinary skill in the art would have understood that stress-relieving characteristics in Pogge would have been manifested in Cooney’s void. Ex. 1002 ¶ 127. We also agree with Petitioner’s declarant that Edelstein includes a void in a TSV similar to Cooney, the ’609 patent, and Pogge. Ex. 1001, Fig. 4; Ex. 1002 ¶ 130; Ex. 1004, Fig. 6; Ex. 1005, Fig. 2F; Ex. 1006, Fig. 6F. We, therefore, credit the testimony that, because of their common structural arrangements, one of ordinary skill in the art would have understood that stress-relieving characteristics in Edelstein would have also been manifested in Cooney’s void. Ex. 1002 ¶ 130.” slip op. at 33

  Patent outcomesUS 9,147,609 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,147,609
• Dr. Squatch, LLC v. The Procter & Gamble CompanyAll claims unpatentable
  PTAB · Jan 28, 2026 · IPR2024-01173 · APJ Susan L C Mitchell · IPR · Final written decision

  Claims 1–7, 9–13, and 16–19 are unpatentable: claims 16–17 are anticipated by Lesniak, and the remaining challenged claims are obvious over the stated combinations.

  RulingsFinal written decision

  • Expert testimonyPetitioner expert creditedPatent owner expert discountedDecided for petitioner

    “argument that the Lesniak fails to enable a stable deodorant stick. Rather, we are persuaded by Petitioner that Lesniak sufficiently teaches compositions with the relevant ingredients and achieves stable compositions through the use of a second wax having a melting point of 73 to 90° C. Pet. Reply 8 (citing Ex. 1003, 1:39–54). For example, Lesniak’s compositions (nos. 8 and 11) that used such a second wax, namely CastorWax MP80, are disclosed as sufficiently stable. Ex. 1003, Table 2. Here, we further credit the testimony of Dr. Michniak-Kohn that secondary wax, such as castor wax, with a sufficiently high melting point. Ex. 1003, 1:39-54, 5:23-32, Table 2. Both of the compositions (nos. 8 and 11) tested by Lesniak that had such a wax passed the stability tests. Ex. 1086 ¶ 7; see also Reply 8 (“Lesniak overcame any stability issues, as it expressly discloses compositions that are ‘physically stable at high and low temperatures.’”) (citing Ex. 1003, 5:23–32).” slip op. at 22

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Level of Ordinary Skill in the Art Petitioner proposes that a person of ordinary skill in the art (“POSA” or “POSITA”) at the time of the invention “would have (1) at least a B.S. or equivalent degree; and (2) at least two years of experience in cosmetics formulations.” Pet. 24 (citing Ex. 1002 ¶¶ 27–28). Patent Owner does not dispute Petitioner’s proposal about the POSA’s qualifications. See generally PO Resp. We adopt and apply Petitioner’s proposed definition of a POSA, which is consistent with the level of skill reflected in the asserted prior art.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Preamble limiting or notPreamble limitingDecided for patent owner

    “Patent Owner asserts that the preamble of independent claim 1 reciting “a deodorant stick” is limiting” as it provides antecedent basis for certain other claim elements, specifically, for the recitation of “said deodorant stick being free of an aluminum salt” and “said deodorant stick” having a particular hardness range. PO Resp. 8–9. Patent Owner also points to dependent claims 5–8 as relying on the preamble reciting “a deodorant stick” as antecedent basis for claim elements. Id. at 10. We agree.” slip op. at 8

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “We find that the evidence of record fails to support Patent Owner’s argument that the Lesniak fails to enable a stable deodorant stick. Rather, we are persuaded by Petitioner that Lesniak sufficiently teaches compositions with the relevant ingredients and achieves stable compositions through the use of a second wax having a melting point of 73 to 90° C. Pet. Reply 8 (citing Ex. 1003, 1:39–54). For example, Lesniak’s compositions (nos. 8 and 11) that used such a second wax, namely CastorWax MP80, are disclosed as sufficiently stable. Ex. 1003, Table 2. Here, we further credit the testimony of Dr. Michniak-Kohn that secondary wax, such as castor wax, with a sufficiently high melting point. Ex. 1003, 1:39-54, 5:23-32, Table 2. Both of the compositions (nos. 8 and 11) tested by Lesniak that had such a wax passed the stability tests. Ex. 1086 ¶ 7; see also Reply 8 (“Lesniak overcame any stability issues, as it expressly discloses compositions that are ‘physically stable at high and low temperatures.’”) (citing Ex. 1003, 5:23–32). Having considered the parties’ positions and evidence of record, summarized above, we determine that Lesniak provides sufficient disclosure to enable a person of ordinary skill in the art to formulate a deodorant stick within the parameters of claims 16 and 17. e) Conclusion as to Claims 16 and 17 We agree with Petitioner that “the challenged claims recite nothing more than well-known deodorant ingredients performing their conventional functions.” Pet. Reply 2. Therefore, for the reasons discussed above, we conclude that Petitioner has proved by a preponderance of evidence that Lesniak anticipates claims 16 and 17.” slip op. at 22

  Patent outcomesUS 10,905,647 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 10,905,647
• Reolink Innovation Inc. / Shenzhen Reolink Technology Co., Ltd. v. Throughtek Technology (Shenzhen) Co., Ltd. And Throughtek Co., Ltd.All claims unpatentable
  PTAB · Dec 15, 2025 · IPR2024-01193 · APJ David C Mckone · IPR · Final written decision

  Claims 1–3, 5, 7–13, 15–19, and 23–25 are unpatentable: claims 1, 7, 8, 10, 11, 15, 16, 18, 19, and 23–25 as anticipated by Zhang; all challenged claims also as obvious over at least one …

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “person of ordinary skill in the art “would have had a bachelor’s degree in electrical engineering and two years of work experience with network and communication technologies.” Pet. 5 (citing Ex. 1003 ¶¶ 13–15). Patent Owner does not contest Petitioner’s proposal or provide a proposal of its own. On the complete record, we adopt Petitioner’s description of the level of ordinary skill in the art, as it is consistent with the technology described in the ’448 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 11

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededTerm construed board ownMixed

    “construction of “feature flag” is inconsistent with the language of claim 8, which states that “the feature flag indicates that the running state of the second apparatus is the sleep state.” Petitioner also argues that Patent Owner’s proposal is not supported by claim 24, which depends from claim 23 and states that “the feature flag is located at a header of the sleep login packet.” Id. at 3. We agree with Petitioner. The plain language of claim 8 states what a feature flag indicates. Claim 24 recites where the feature flag is located. Neither claim suggests any of Patent Owner’s additional limitations.” slip op. at 13

  • Expert testimonyPetitioner expert creditedDecided for petitioner
  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “[A] prior art reference will anticipate if it ‘disclose[s] each and every element of the claimed invention . . . arranged or combined in the same way as in the claim.’” Blue Calypso, LLC v. Groupon, Inc., 815 F.3d 1331, 1341 (Fed. Cir. 2016) (quoting In re Gleave, 560 F.3d 1331, 1334 (Fed. Cir. 2009) (alteration by Federal Circuit)). “However, a reference can anticipate a claim even if it ‘d[oes] not expressly spell out’ all the limitations arranged or combined as in the claim, if a person of skill in the art, reading the reference, would ‘at once envisage’ the claimed arrangement or combination.” Id. (quoting Kennametal, Inc. v. Ingersoll Cutting Tool Co., 780 F.3d 1376, 1381 (Fed. Cir. 2015) (alteration by Federal Circuit); In re Petering, 301 F.2d 676, 681 (CCPA 1962)). For the reasons explained below, we are persuaded that Petitioner has shown, by a preponderance of the evidence, that claims 1, 7, 8, 10, 11, 15, 16, 18, 19, and 23–25 are anticipated by Zhang. slip op. at 16

  Patent outcomesUS 10,602,448 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · Graham
  Patents in suitUS 10,602,448
• Salvacion USA, Inc. v. Trutek CorpAll claims unpatentable
  PTAB · Dec 2, 2025 · IPR2024-00711 · APJ Sheridan K Snedden · IPR · Final written decision

  Claims 1–3 and 8 are unpatentable as anticipated by Chen, Baker, Wahi ’005, and, for claims 1, 2, and 8, Rolf; the Board also finds them obvious over the asserted grounds.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “In our Institution Decision, we adopted Petitioner’s definition of a person of ordinary skill in the art (“POSITA”) as it was undisputed at the time and consistent with the evidence of record. Inst. Dec. 7–8. Based on our consideration of the full record, we maintain our determination that a POSITA at the time the application for the ’802 patent was filed “would have had at least an undergraduate degree in pharmacy, chemistry, biochemistry, biomedical engineering or a closely related field, such that the POSITA generally understand[s] pharmaceutical formulation.” Pet. 12. Additionally, we agree with Petitioner that “[a] POSITA would be familiar with the chemical ingredients in the [’802] Patent, biocidic agents, and cationic agents, have knowledge of airborne particles including viruses and bacteria, and understand electrostatic fields, electrostatic attraction and repulsion, adhesion and cohesion.” Id. (citing Ex. 1002 ¶¶ 38–39).” slip op. at 11

  • Claim Construction › Intrinsic evidence (Phillips canons) › Preamble limiting or notPreamble limitingDecided for petitioner

    “of independent claims 1, 2, and 8 as limiting. Inst. Dec. 7–8. The parties do not dispute our construction of the preambles of claims 1, 2, and 8 as limiting. See generally PO Resp.; Pet. Reply 2–4. After consideration of the full trial record, we maintain our construction of the preamble of claims 1, 2, and 8 as limiting for the reasons set forth in our Institution Decision. Id. Briefly, the preamble of independent claims 1, 2, and 8 limits the challenged claims as both the preamble and the body are used to define the subject matter claimed. See Allen Engineering Corp., v. Bartell Industries, Inc., 299 F.3d 1336, 1346 (Fed. Cir. 2002). In particular, the preamble is “necessary to give life, meaning and vitality” to the claim, see id., because it provides the only description in the claim for the application site of the formulation, i.e., “to skin or tissue of nasal passages,” and how the formulation is applied, i.e., “in a thin film.”” slip op. at 8

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownDecided for petitioner

    “After consideration of the full trial record, we maintain our construction. From our perspective, the claims themselves support this construction as the claims expand upon the term “electrostatically inhibiting” with specific means for achieving such inhibition. Specifically, claims 1 and 2 recite electrostatically attracting the particulate matter, holding the matter in place, and inactivating the matter. Additionally, the Specification supports our construction as it describes the use of “an electrostatic field such that oppositely charged airborne particulates (including microorganisms) in the vicinity of the surface are electrostatically trapped, held thereto and one or more of the microorganisms so captured is neutralized, killed, inactivated, and rendered harmless.” Ex. 1001, 3:36–40; PO Resp. 10 n.6.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for petitioner

    “We adopt the parties’ construction of “adequate impermeability” that has been accepted in the related district court litigation: “Adequate impermeability” refers to the “thin film holding harmful particles in place and inhibiting them from penetrating the thin film and contacting the skin or tissue of an individual’s nasal passages. This is done by varying the concentration of ingredients . . .[,] thereby adjusting the adhesion and cohesion of the thin film.” Pet. Reply 3 (quoting Ex. 1010, 17). Furthermore, as stated in our Institution Decision, along with that term, the claim language explains that the thin film is meant to stick to the skin or tissue and to hold the particulate matter in place. Inst. Dec. 9–10. The claim language also explains that the cohesion of the formulation is adjusted to provide adequate impermeability to the thin film. Thus, it is reasonable to consider the recited impermeability is a function of the cohesive properties of the thin film, and that such impermeability refers to a property of the thin film, i.e., inhibiting the penetration or passage of matter through it onto the skin or tissue at the application site.” slip op. at 10

  Patent outcomesUS 8,163,802 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 8,163,802
• Smaxtec Inc. / Smaxtec Animal Care GmbH v. St Reproductive Technologies, LLCAll claims unpatentable
  PTAB · Nov 20, 2025 · IPR2024-00875 · APJ Andreas Baltatzis · IPR · Final written decision

  Claims 1–4, 6, and 17–20 are unpatentable under the Trevarthen and Laitinen-based obviousness grounds; claim 6 was not shown unpatentable over Trevarthen alone.

  RulingsFinal written decision

  • Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedDecided for petitioner

    “statistics in the absence of evidence of unique downloads or individuals. Even if the download numbers do not exactly represent unique downloads by unique individuals, the evidence shows that Trevarthen was downloaded to some extent, and therefore distributed, prior to the filing date of the ’206 patent. Accordingly, we find this evidence weighs in favor of Trevarthen’s public accessibility.” slip op. at 20

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed patent owner constructionDecided for patent owner

    “construction issues: (1) the interpretation of limitations 1[E] and 17[F] relating to entering sensed and stored information into “at least one logical expression,” and (2) “implanted in an animal.” Inst. Dec. 19. We are persuaded by Petitioner’s argument that it would have been obvious to combine sensed and stored information into the same “at least one logical expression,” for the reasons set forth below. Accordingly, we need not construe limitations 1[E] and 17[F], relating to “at least one logical expression.”4 We discuss our construction of “implanted in an animal” below.” slip op. at 12

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundNot shown unpatentableMixed

    “would have viewed Trevarthen as a cohesive disclosure of specific improvements to existing dairy farms, as opposed to disparate teachings of unrelated systems. Trevarthen itself proposes “a framework for the use of RFID on dairy farms” including “enhancements and ideas which could be considered as future additions to further add value” for utilizing RFIDs in farm management beyond the Cochrane farm ear-tag RFIDs. Ex. 1005, 99. The enhancements include RFID boluses (id.), milk meters to detect illness (id. at 115), and temperature monitoring by RFID (id. at 121–122). Considering the entire record, Trevarthen itself describes improvements that apply “the predictable use of prior art elements according to their established functions.” See KSR, 550 U.S. at 417. Accordingly, we find that Petitioner has shown a that one skilled in the art would have been motivated to” slip op. at 33

  • ExcludeNot reached

    “IV. EVIDENTIARY ISSUES Patent Owner moves to exclude Exhibits 1040, 1041, and 1044.” slip op. at 81

  Patent outcomesUS 9,844,206 unpatentable
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,844,206

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.