• Uatp IP LLC v. Slick Slide LLCSome claims unpatentable
  PTAB · Oct 2, 2026 · PGR2024-00054 · APJ Brian D Range · PGR · Final written decision

  Claims 22–26 are unpatentable based on obviousness; claims 1–17, 27, and 28 were not shown unpatentable. Patent Owner’s motion to terminate was denied.

  RulingsFinal written decision

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed board ownDecided for patent owner

    “1. Mesh Layer Petitioner contends “no formal claim construction is necessary in this” slip op. at 13

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable

    “5. Analysis On this complete record, we determine that Petitioner’s arguments do” slip op. at 31

  • Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable

    “form of nylon and some form of Teflon (and possible combinations thereof) having the specific coefficient of friction range given in limitation [1c] breaks down, because the building blocks of the obviousness argument are not sufficiently identified in Phillips alone, nor in the supporting testimony. Accordingly, we determine that Petitioner’s arguments and evidence fail to show that Phillips renders the challenged claims obvious. 6. Conclusion Based on the foregoing, we determine that Petitioner has not established by a preponderance of the evidence that claims 1–4, 6, and 7 would have been anticipated by or obvious in view of Phillips.” slip op. at 33

  • Obviousness (§103) › Objective indicia / secondary considerations › NexusObjective indicia no nexusDecided for petitioner

    “2. Products and Nexus We first consider the issue of whether certain evidence relied upon by” slip op. at 20

  Patent outcomesUS 11,998,854 mixed
  Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites Phillips · Graham · Nautilus
  Patents in suitUS 11,998,854
• Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentable
  PTAB · Jan 17, 2025 · IPR2024-00597 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9–10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “We also agree with Patent Owner that the charge cut-off voltage is not necessarily the applied voltage during charging. PO Resp. 20. Rather, depending on the charging protocol used and when in the charging cycle the voltage is applied, the applied voltage could be higher than the battery voltage. Ex. 2013; Ex. 2006 ¶ 91. For example, as discussed in more detail below with respect to the Uemura grounds, when fast charging using constant current is used and the charging rate is not slow, the applied voltage will be higher than the battery voltage when the constant current charging phase is stopped. Ex. 2006 ¶ 91; Ex. 2013. Likewise, during constant current/constant voltage charging, the applied voltage approximates the battery voltage only when the battery is nearly completely charged. Ex. 2013; Ex. 2006 ¶ 91. Thus, the applied voltage may be, but is not necessarily, the charge cut-off voltage. In view of the foregoing, we construe “charge cut-off voltage” in claims 1 and 5 as “the maximum value to which the battery is configured to be charged.” PO Resp. 18; Ex. 2008, 217:6–11; Pet. Reply 5. Contrary to Patent Owner’s arguments, however, we do not understand the phrase “configured to be charged” to necessarily represent a single voltage for the battery that is determined based on the structure and chemistry of the battery. Pet. Reply 4–5. Rather, the charge cut-off voltage is a selected potential, or voltage, of the battery or cell at the end of charging that is controlled by a circuit or device, such as a charger or control circuit within the battery. Ex. 1001, 9:50–55; Ex. 1048, 2, 7–8; Ex. 1008, 3:9–13. And, for the reasons discussed herein, the charge cut-off voltage may be, but is not necessarily, the same as the applied voltage during charging. PO Resp. 20.” slip op. at 15

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16

  • Expert testimonyPatent owner expert creditedDecided for patent owner

    “Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122.” slip op. at 21

  Patent outcomesUS 7,749,641 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,749,641
• Samsung Electronics Co., Ltd. / Apple Inc. v. RJ Technology LLCSome claims unpatentable
  PTAB · Jan 17, 2025 · IPR2023-01183 · APJ Jon B Tornquist · IPR · Final written decision

  Claims 2–4 and 6–18 are unpatentable as obvious over Abe and Guyomard, with claims 9 and 10 also obvious over Iwaizono; claims 1 and 5 were not shown unpatentable.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person of ordinary skill in the art “would have had a Master’s degree in material science, chemical engineering, chemistry, or similar field with four years of experience designing testing, and building secondary lithium batteries.” Pet. 11 (citing Ex. 1002 ¶ 51). Petitioner further contends that a person of ordinary skill in the art would have been aware of “(1) positive electrode materials, (2) negative electrode materials, (3) separators, (4) electrolytes, (5) charge-discharge parameters, and (6) protection circuits, as well as ‘battery failure modes’ such as plating and the formation of dendrites.” Id. (citing Ex. 1002 ¶¶ 50–51). Patent Owner “does not dispute Petitioner’s level of ordinary skill.” PO Resp. 17. Upon review of the prior art of record and the parties’ arguments, we adopt Petitioner’s unopposed definition of the person of ordinary skill in the art as it is consistent with the disclosures of the ’641 patent and the prior art of record.” slip op. at 9

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner

    “constructions. First, we agree with Petitioner that the ’641 patent indicates that the charge cut-off voltage selected for a particular battery need not be a fixed property of the battery or something that is set by the design and chemistry of the battery. Consistent with this conclusion, the ’641 patent discloses that a “charging device controls the charge cut-off voltage of the single lithium-ion cell within a range from 4.3 V to 5.8 V.” Ex. 1001, 9:50– 55. This strongly suggests that the charge cut-off voltage is controlled by the charger and is not necessarily an inherent property of the battery. Patent Owner contends that this is merely an unclaimed embodiment, but the relevant disclosure states that the charging device for the “present invention” may be any type of device “with the proviso that said charging device controls the charge cut-off voltage.” Id. at 9:50–53.” slip op. at 12

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “charge cut-off voltage “greater than 4.2 V but less than 5.8 V” and calculating a specific or theoretic capacity “with a charge cut-off voltage limited to 4.2” (claim 1) or “with a charge cut-off voltage set at 4.2 V” (claim 5). Ex. 1001, 16:56–61, 17:6–11. Although the parties dispute the precise scope of these claim terms, the parties agree that the first use of “charge cut-off voltage” in claims 1 and 5 refers to the potential of the battery as a whole (between the cathode and the anode), and not a half-cell voltage using lithium metal as a counter electrode.10 Tr. 17:1–3 (agreeing 10 With respect to the phrase “as calculated by a theoretic capacity with a charge cut-off voltage set at 4.2 V,” the parties in fact appear to be in that the first use of “charge cut-off voltage” in claim 5 refers to a full-cell voltage); Sur-reply 5; PO Resp. 22. We need not further construe the claims to resolve the disputes between the parties. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)).” slip op. at 16

  • Expert testimonyPatent owner expert creditedPetitioner expert discountedDecided for patent owner

    “Given Mr. Juzkow’s unambiguous testimony that Uemura uses constant current charging that would stop when the applied voltage reached 11 The chart is reproduced from SAFT, Charging your lithium-ion batteries: 5 expert tips for a longer lifespan, (https://www.saft.com/energizing-iot/charging-your-lithium-ion-batteries-5-expert-tips-longerlifespan#:~: text=When%20the%20battery%20provides%20current,This%20restore s%20the%20battery's%20capacity). 4.3 V, as well as Dr. Yao’s persuasive testimony that Uemura’s constant charging rate is not slow, we credit the testimony of Dr. Yao that one of ordinary skill in the art would have understood that the internal voltage to which the battery of Uemura was charged is less than 4.3 V. Ex. 2006 ¶ 119. In particular, Dr. Yao persuasively testifies that one of ordinary skill in the art would have believed that the charge cut-off voltage was no more than 4.2 V, and most likely equal to “about 4 V.” Id. ¶¶ 119–122. Petitioner argues that because the battery of Uemura is charged “to” a maximum voltage of 4.3 V, Uemura discloses the claimed charge cut-off voltage under either Petitioner’s or Patent Owner’s construction of the term. Pet. Reply 11–12 (citing Ex. 1009 ¶ 81; Ex. 1044 ¶¶ 56–59). This argument is not persuasive because Mr. Juzkow unambiguously testified that charging in Uemura stopped when the applied voltage reached 4.3 V, and Uemura discloses that the battery was charged “at” a voltage ranging from 4.3 V to 2.0 V, not “to” such a voltage. Ex. 1009 ¶ 81; Ex. 2008, 113:2–13; Ex. 2006 ¶ 119 n.64; Sur-reply 9. In view of the foregoing, we determine that Petitioner has not demonstrated by a preponderance of the evidence that Uemura anticipates independent claims 1 and 5 of the ’641 patent.” slip op. at 21

  Patent outcomesUS 7,749,641 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 7,749,641
• Hum Industrial Technology, Inc. v. Amsted Rail Company, Inc.Some claims unpatentable
  PTAB · Aug 7, 2024 · IPR2023-00538 · APJ Kevin W Cherry · IPR · Final written decision

  Claims 1, 5–10, 13–18, 20–22, 24, 31, and 32 are unpatentable; claims 2–4, 23, and 25–30 were not shown unpatentable. The revised motion to amend was granted in part and denied in part.

  RulingsFinal written decision

  • PTAB / AIA Trials › Motions to amend / substitute claimsMotion to amend granted in partGranted in part

    “d. Summary For the above reasons, we determine that Patent Owner has not shown” slip op. at 100

  • ExcludeMotion to exclude, deniedOther

    “IV. PATENT OWNER’S MOTION TO EXCLUDE Patent Owner seeks to exclude Exhibit 1034 and page 10 of the Reply” slip op. at 86

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed patent owner constructionDecided for patent owner

    “A. “housing” Patent Owner proposes that we construe the term “housing” to mean” slip op. at 15

  • Obviousness (§103) › Objective indicia / secondary considerationsObjective indicia no nexusDecided for petitioner

    “suggested to one skilled in the art, objective evidence of non-obviousness (“secondary considerations”) may lead to a conclusion that the challenged claims would not have been obvious. In re Piasecki, 745 F.2d 1468, 1471–72 (Fed. Cir. 1984). Objective evidence of non-obviousness “may often be the most probative and cogent evidence in the record” and “may often establish that an invention appearing to have been obvious in light of the prior art was not.” Transocean Offshore Deepwater Drilling, Inc. v. Maersk Drilling USA, Inc., 699 F.3d 1340, 1349 (Fed. Cir. 2012) (citation omitted). For us to give substantial weight to objective evidence of nonobviousness, a proponent must establish a nexus between the evidence and the merits of the claimed invention. ClassCo, Inc., v. Apple, Inc., 838 F.3d 1214, 1220 (Fed. Cir. 2016). Nexus is a legally and factually sufficient connection between the objective evidence and the claimed invention, such that the objective evidence should be considered in determining non-” slip op. at 21

  Patent outcomesUS 9,365,223 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 9,365,223
• Pioneer Pet Products, LLC v. Oil-Dri Corporation Of AmericaSome claims unpatentable
  PTAB · Dec 19, 2023 · IPR2022-01138 · APJ Richard H Marschall · IPR · Final written decision

  Claims 1, 3–8, 10–16, and 18 are unpatentable over Goss; claims 2, 9, 17, and 19 were not shown unpatentable. The revised motion to amend is denied for lack of written-description support.

  RulingsFinal written decision

  • BurdenFwd mixedMixed

    “To prevail in its challenges, Petitioner must prove unpatentability by a preponderance of the evidence. 35 U.S.C. § 316(e) (2018); 37 C.F.R. § 42.1(d). “In an [inter partes review], the petitioner has the burden from the onset to show with particularity why the patent it challenges is unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016) (citing 35 U.S.C. § 312(a)(3) (requiring inter partes review petitions to identify “with particularity . . . the evidence that supports the grounds for the challenge to each claim”)). This burden of persuasion never shifts to Patent Owner. See Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1378 (Fed. Cir. 2015) (discussing the burdens of proof in an inter partes review).” slip op. at 7

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “(“PHOSITA”) “would have at least a bachelor of science degree in chemistry, mineralogy, geological science, material science, chemical engineering, or mining engineering with at least two to five years of work experience relating to designing specific chemical mixtures including clay or other minerals, particularly absorbents.” Pet. 34 (citing Ex. 1004 ¶ 38). Patent Owner does not dispute Petitioner’s proposed definition of the level of ordinary skill in the art. See PO Resp. 23. We adopt the definition of the level of ordinary skill in the art proposed by Petitioner because it appears consistent with the record, including the prior art. See GPAC, 57 F.3d at 1579.” slip op. at 9

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached

    “We generally agree with Petitioner that the assumptions and approximations made in the calculations described in the ’397 patent to determine the external surface area of the components of the litter render the computations only a general approximation of the respective surface areas. See Pet. Reply 9–12. We need not, however, reach the issue of whether the 47% surface area limitation requires the use of the multi-step method disclosed in the ’397 patent because Petitioner followed that methodology in its arguments and evidence in its Reply. See Pet. Reply 13. Importantly, Patent Owner agrees that Petitioner followed the approach set forth in the ’397 patent, and argues that we need not construe “external surface area” to resolve any dispute between the parties. See PO Sur-reply 23–24 (arguing that we need not “determine whether ‘total external surface area’ must be determined using the same multi-step approach” in the ’397 patent to resolve the controversy because “the only calculation of external surface area relied on by Petitioner was presented in the Reply and it followed the methodology of the [’]397 Patent”); PO Supp. Sur-reply 2 (same). Based on our review of the current record, we need not and do not formally construe any claim terms to resolve the patentability issues in this inter partes review. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (stating that “we need only construe terms ‘that are in controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). To the extent some implicit claim construction disputes remain, we address those issues in the context of the challenges below.” slip op. at 11

  • Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentableNot shown unpatentable

    “review of the record, we find that Petitioner fails to articulate an adequate rationale for the combination of Goss and House. The Petition contains only a single sentence addressing the issue, without any citation to record evidence or declaration support. See Pet. 46. In addition, the assertion merely states the conclusion that a “PHOSITA would understand that there is a rational underpinning to combine the teachings of Goss and House as required under patent law because both are related to cat litter having similar characteristics.” Id. This assertion, at most, addresses the fact that Goss and House are in the same field or that they are analogous art, but does not explain why a PHOSITA would have been motivated to combine Goss and House. See id. In addition, the Petition lacks sufficient explanation of how Petitioner proposes to combine Goss and House. See Pet. 46–53. Instead, when Petitioner relies on House in this challenge, it appears to be a back-up argument in the event that we find Goss fails to disclose the limitation. Merely stating that Goss and House both disclose a limitation does not explain which aspects of House Petitioner proposes adding to Goss or what the resulting litter composition would look like. See id. The details of the resulting litter based on the combination of Goss and House matter here because it could impact whether all limitations of a given claim are satisfied by the combination. For example, Petitioner relies exclusively on specific examples from Goss for the 47% surface area limitation, but adding some aspects of House’s litter components to meet other limitations could undermine Petitioner’s reliance on Goss’s specific examples. The failure of the Petition to set forth a specific combination elides these issues. See Pet. 46–51. Petitioner’s Reply arguably addresses some of these concerns by providing a more fulsome motivation section, backed by new expert testimony, and specific litter examples based on Goss and various cellulose filler materials allegedly disclosed by House. See Pet. Reply 24–25 (citing Ex. 1013 ¶ 7); see also PO Sur-reply 18–22 (arguing that Petitioner’s Reply still fails to articulate an adequate motivation to combine). This analysis goes far beyond the limited analysis in the Petition, and Petitioner provides no reason why it could not have been included in the Petition. See Pet. Reply 24–25. As noted below, in some situations petitioners should be afforded the opportunity to go beyond the arguments in a petition when addressing a new claim construction or other new argument raised by a patent owner or an” slip op. at 17

  Patent outcomesUS 11,026,397 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,026,397
• Amcol International Corp. v. Oil-Dri Corporation Of AmericaSome claims unpatentable
  PTAB · Nov 29, 2023 · IPR2022-01107 · APJ Richard H Marschall · IPR · Final written decision

  Claims 1, 3–8, 10–16, 18, and 19 are unpatentable over Goss; claims 2, 9, and 17 were not shown unpatentable, and the revised motion to amend was denied for lack of written description.

  RulingsFinal written decision

  • Skill levelSkill level petitioner adoptedDecided for petitioner

    “Petitioner contends that a person having ordinary skill in the art “would have a bachelor’s degree in chemistry or chemical engineering or an equivalent degree and sufficient work experience in animal litter process development. A bachelor’s degree is not explicitly necessary.” Pet. 4. Petitioner further contends that “[h]ands-on experience in the field of animal litter process development could substitute for possessing a degree if that individual’s experience is in contributing to and/or leading the process development effort rather than following a set of instructions given to them.” Id. at 4–5. Petitioner asserts that such a person “should have familiarity with the process of validating relevant test methods and qualifying analysts as well as familiarity with the composition and chemistry of various clays used in animal litter (including sodium bentonite)” and that such a person “would have gained this familiarity through education, training and/or experience.” Id. Patent Owner does not dispute Petitioner’s proposed definition of the level of ordinary skill in the art. PO Resp. 14. We adopt the definition of the level of ordinary skill in the art proposed by Petitioner because it appears consistent with the record, including the prior art. See GPAC, 57 F.3d at 1579.” slip op. at 9

  • Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable

    “Patent Owner makes a number of arguments, but we do not find them persuasive enough to undermine Petitioner’s showing based on Ms. Borgese’s analysis. Patent Owner’s primary argument stems from its assertion that the bulk densities vary depending on a number of variables and that Ms. Borgese bases her ranges on documents, the technical data sheets for FS-40 and the ’397 patent for BL(2), that have bulk densities that are not the “same” as the bulk densities for FS-40 and BL(2) in Goss due to the passage of time, differences in where the clay was mined, how the clay was processed, and how the bulk density was measured. See PO Resp. 18– 19, 21–33; PO Sur-reply 2, 5–9. We do not view Petitioner’s challenge as based on the premise that the FS-40 clay referenced in the technical data sheets and Blue Mountain clay in the ’397 patent are the exact same as the FS-40 and BL(2) clays in Goss, but instead the clays and their bulk densities are similar enough that they will fall within the bulk density ranges Petitioner uses in its calculations. See Pet. 21–23, 68; Pet. Reply 6–7, 10. As a result, Patent Owner’s repeated assertions that the clays or their properties are not the “same” or processed “exactly the same” fail to engage 5 Patent Owner suggests that Petitioner fails to meet the inherency standard because Ms. Borgese uses the term “potential” when describing the bulk density range of BL(2). See PO Resp. 32 (citing Ex. 1003 ¶ 117). We do not read Ms. Borgese’s opinion in the same manner. Instead, we read the reference to “the potential bulk density range of BL(2), 35–47 lbs/ft3” as referring to any bulk density within that range, not that there is only the mere potential that the bulk density may fall within that range. See Ex. 1003 ¶ 117. Petitioner’s argument that the bulk densities were at least similar, such that that they fall within the ranges Petitioner uses. See, e.g., PO Resp. 4, 21–24, 30–31; Ex. 2009 ¶¶ 97–98 (Dr. Johnston limiting opinion to whether the clays are the “same”). As an example, when asked about the potential differences in bulk density between Goss’s filing date in 1997 and the 1999 technical data sheet, Ms. Borgese states that “[b]entonite clays have not changed significantly in a period of two years.” Ex. 2008, 24:7–15; see also Ex. 1003 ¶¶ 202–203 (opining that “modest difference in particle-size distribution between FS-40 disclosed in Goss [and] . . . the FS-40 Information Sheet ’99 only minimally impacts the bulk density”). Given Ms. Borgese’s personal experience making animal litters and using bentonites, we view her testimony as credible absent some evidence that any differences in bulk density would fall outside the ranges she uses. Patent Owner provides no such evidence. Nearly all of Patent Owner’s evidence goes to whether the clays and bulk densities would be the exactly the “same” in Goss as in the sources that Ms. Borgese relies on, and do not address how similar the bulk densities would be and do not attempt to establish that there are bulk densities for Goss’s FS- 40 and BL(2) clays that would fall outside the ranges Ms. Borgese uses. In the rare instances where Patent Owner does argue that the bulk densities would not be similar, or would not fall within Dr. Borgese’s ranges, Patent Owner fails to cite any evidence to support the assertion. See PO Resp. 23, 32–33. Even if we found Dr. Johnston’s testimony generally credible on the point that bulk densities may differ across time even when mined and” slip op. at 28

  • Expert testimonyPetitioner expert creditedDecided for petitioner

    “persuasiveness of Petitioner’s arguments and evidence. Petitioner relies heavily on Ms. Borgese’s testimony, a chemical engineer with “firsthand experience in animal litter Process Development and Product Development creating animal litter from raw materials.” Ex. 1003 ¶¶ 3–4. Ms. Borgese has experience working with bentonite and fillers, and has validated test methods related to “particle size distribution, bulk density, moisture, [and] clump strength.” Id. ¶ 4. She also “used a variety of processing methods to produce animal litter” and is a named inventor on three animal litter patents. Id. Patent Owner does not dispute Ms. Borgese’s qualifications, does not 4 As to the whether Goss inherently discloses the 47% surface area limitation, Patent Owner does not dispute that Goss inherently discloses the limitation if Petitioner’s bulk density ranges are correct. See PO Resp. 15– 33. argue that she lacks firsthand experience that would enable her to testify as to the properties of the bentonite clays and litters at issue in this case, or otherwise dispute that she meets the parties’ agreed-upon definition of a person of ordinary skill in the art. Pet. 4–5; PO Resp. 14. That definition presumes “experience in animal litter process development” and “familiarity with the composition and chemistry of various clays used in animal litter (including sodium bentonite).” Pet. 4–5. We find Ms. Borgese’s education and first-hand experience in animal litter process development, including experience with bentonite, sufficient to testify credibly as to the known bulk densities of the bentonite clays at issue in the case. As to Goss’s FS-40 sodium bentonite clay made by Wyo-Ben, Ms. Borgese opines that the range of bulk density for the material in Goss is between 58–64 lb/ft3 based on Wyo-Ben’s own technical data sheets from 1999 and 2002, which “describe the same (or similar) FS-40 (‘sodium bentonite’) composition.” Ex. 1003 ¶¶ 82–83, 106, 117; Pet. 21–22, 35. Then, in an effort “to be conservative in [her] analysis,” Ms. Borgese uses a broader range of 55–65 lb/ft3 for Goss’s FS-40 in her calculations. Ex. 1003 ¶ 117. Even when pushing her assumptions in directions that would result in the lowest possible external surface area percent for sodium bentonite, all of the calculations across the full range of potential bulk densities still meet the 47% surface area limitation. Id. ¶¶ 117–122; Pet. 43–46. Based on our review of the arguments and evidence, we find Ms. Borgese’s testimony as to the range of Goss’s FS-40 bulk density credible and persuasive.” slip op. at 25

  • ExcludeMotion to exclude, deniedDenied

    “Borgese relies on (Exhibits 1018 and 1024), but the effort lacks procedural and substantive merit. Patent Owner’s argument in its Patent Owner Response describes the documents as “[i]nadmissible” without seeking any specific relief, but Patent Owner’s Sur-reply makes clear that Patent Owner seeks exclusion. See PO Resp. 20; PO Sur-reply 13. While Patent Owner seeks to exclude these documents, it fails to follow our rules applicable to such efforts. Our rules require objections to evidence to be filed within specific timeframes, and a “motion to exclude evidence must be filed to preserve any objection.” 37 C.F.R. § 42.64(c). In addition, the “motion must identify the objections in the record in order and must explain the objections.” Id. Patent Owner failed to file a separate “motion” or even refer to its hearsay arguments as a “motion” despite the fact that it seeks to exclude evidence. PO Resp. 20. Nor did Patent Owner “identify the objections in the record” in support of its “motion.” Id. In addition, Patent Owner fails to cite any authority that permits what amounts to a motion to exclude within the confines of the merits briefing, which forced Petitioner to devote space in its merits brief to opposing the motion to exclude. See id.; Pet. Reply 19–23. Under these circumstances, we deny the motion as procedurally improper. In addition, even if we reached the merits, we would not exclude the documents or Ms. Borgese’s opinions based on them given that she reasonably relied on the technical data sheets as reliable sources of bulk density data provided by Wyo-Ben, the manufacturer of the clays in question. See Pet. Reply 22–23; Ex. 1003 ¶¶ 82–83.” slip op. at 32

  Patent outcomesUS 11,026,397 mixed
  § 102 anticipation§ 103 obviousnesscites Phillips · KSR · Graham
  Patents in suitUS 11,026,397
• Wolfspeed, Inc. / Ideal Industries Lighting, LLC D/B/A Cree Lighting v. Cao Lighting, Inc.Some claims unpatentable
  PTAB · Sep 28, 2023 · IPR2022-00848 · APJ Brian D Range · IPR · Final written decision

  Claims 21, 22, 25, 26, 28–30, 32–36, 40, 42–44, 47–49, 52, 53, 56–59, 62, 63, 65–68, 71–73, 77, 78, 81, 82, 85, 86, and 88–91 are unpatentable under § 103; claim 41 is not shown …

  RulingsFinal written decision

  • ExcludeMotion to exclude, deniedDenied

    “declaration addresses the Patent Owner Response and is relevant to the issues at hand. We start with an important observation: claim 18 (the only independent claim at issue) is an apparatus claim; the claim is directed to a “semiconductor light source.” Ex. 1001, 9:52, EPRC 1:32. One requirement of this apparatus is that it comprise “a semiconductor chip” (id. at 9:66) where “said semiconductor chip is a light emitting diode (LED) chip EPRC, 1:34–36. As we explain when addressing claim construction, infra, we adopt Patent Owner’s proposed construction (Resp. 14) of “said semiconductor chip is a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” as referring to “a semiconductor LED chip capable of emitting light greater than about 40 milliwatts.” See Section III.D, infra (emphasis added). Because of these recitations, Petitioner bears the burden of establishing that the prior art teaches or suggests a semiconductor LED chip “capable of emitting light greater than about 40 milliwatts.” As explained herein, we determine that in the Petition, Petitioner met this burden by establishing by a preponderance of the evidence that the Krames reference teaches an LED chip that has this capability. Pet. 53 (quoting Ex. 1008, 10). Notably, claim 18 does not require actual operation of anything at greater than 40 milliwatts because claim 21 is not a method claim. Petitioner never had a burden of establishing a method of running the Krames reference’s LED at this power output within a semiconductor light source.” slip op. at 9

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with Patent Owner that the challenged claims relate to light fixtures, LED packaging, and LED chip layer structure and that the ’770 patent claims reflect “a hybrid of the light bulb art and semiconductor art.” Resp. 16. The prior art of record, for example, Begemann, likewise reflects “a hybrid of the light bulb art and semiconductor art.” Id. (quoting Pet. 28). Petitioner’s expert, Dr. Lebby, agreed that a person having ordinary skill in 28:16. While Petitioner’s proposed description of a person having ordinary skill in the art could, in some instances, be sufficient to qualify a person as having ordinary skill, Patent Owner’s proposal is a more complete and accurate description of the level of skill commensurate with the scope of the challenged ’770 patent claims. Patent Owner’s description appears consistent with the prior art and patent specification before us and is supported by witness testimony. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself may reflect an appropriate level of skill). For the purpose of this Decision, we adopt Patent Owner’s description. We further note that the outcome of our decision would be the same under either party’s asserted skill level.” slip op. at 15

  • Prior constructionPrior construction adoptedTerm construed patent owner constructionDecided for patent owner

    “Delaware held, with respect to related U.S. Patent 6,465,961, construed “a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” as “at least one LED chip is capable of emitting light greater than about 40 milliwatts.” Resp. 14 (citing Ex. 1024, 15–18). Petitioner responds that the phrase “needs no construction” and that Petitioner’s grounds meet this construction. Reply 1. We note that the language of claim 18 does not precisely match the language the District Court considered, it is substantively the same. The record supports a construction very similar to the construction the District Court adopts, and we reference the District Court’s reasoning. Ex. 1024, 15– 18. We, thus, construe claim 18’s recitation that “said semiconductor chip is a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” as referring to “a semiconductor LED chip that is capable of emitting light greater than about 40 milliwatts.” It is unnecessary to construe any other claim terms in this Decision because none of the parties’ disputes turn on the meaning of other terms. See, e.g., Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017).” slip op. at 17

  • Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedReference is prior artDecided for petitioner

    “The facts above are evidence of the Krames reference’s publication as of June 29, 2000, because the facts tend to make the Krames reference’s publication as of June 29, 2000, more probable than it would be without the evidence. See Fed. R. Evid. 401(a) (defining evidence as relevant “if it has any tendency to make a fact more or less probable than it would be without the evidence”). The evidence is sufficient to support publication. Meanwhile, no evidence of record suggests that Krames was not a printed publication as of June 29, 2000. Thus, a preponderance of the evidence supports Krames’s prior art status. Patent Owner argues that Ms. Watters “never establishes a firm date when Krames was purportedly available to the relevant public.” Resp. 21. Patent Owner bases this argument by taking a tortured reading of Ms. Watters’s statement that “[m]embers of the interested public could locate a copy of [the Proceedings] on or after June 29, 2000, the date it was catalogued.” Id. (quoting Ex. 1020, 3); see also Sur-Reply 12–13. The best understanding of Ms. Watters’s statement, in view of the context of Ms. Watters explaining the library’s cataloguing process, is that a member of the interested public had two options: the person could choose to locate the Proceedings on June 29, 2000, or the person could choose to locate the Proceedings after June 29, 2000. Thus, the statement supports public availability as of June 29, 2000.” slip op. at 21

  Patent outcomesUS 6,634,770 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR
  Patents in suitUS 6,634,770
• Wolfspeed, Inc. / Ideal Industries Lighting, LLC D/B/A Cree Lighting et al. v. Cao Lighting, Inc.Some claims unpatentable
  PTAB · Sep 28, 2023 · IPR2023-00129 · APJ Brian D Range · IPR · Final written decision

  Claims 21–40, 42–44, 47–49, 52–53, 56–59, 62–63, 65–68, 71–73, 77–78, 81–82, 85–86, and 88–91 are unpatentable over Begemann, Krames, and Allen; claim 41 is not shown unpatentable.

  RulingsFinal written decision

  • ExcludeMotion to exclude, deniedDenied

    “In the Reply, Petitioner uses the Krames declaration (Ex. 1028) to argue, for example, that a person of ordinary skill in the art would have used a lower amperage than the 1.5 A dc that Patent Owner’s Response focuses on. Reply 8 (citing Ex. 1028 ¶ 22). This use of the Krames declaration is timely because it responds to an argument Patent Owner makes in the Patent Owner Response. 37 C.F.R. § 42.23(b) (“A reply may only respond to arguments raised in . . . patent owner response.”). As to relevancy and whether the Krames declaration is applicable to the facts of this case, the issues at hand are (1) whether or not a person having ordinary skill would have had reason to use the Krames LED with Begemann with a reasonable expectation of success and (2) whether or not the Krames LED is capable of outputting light at greater than about 40 milliwatts. Again, we emphasize that claim 21 does not recite a method where the LED within the recited semiconductor light source actually outputs greater than about 40 milliwatts. The Krames declaration is relevant to the facts of this case because the declaration has bearing on whether or not a person of ordinary skill in the art would have combined the Krames reference’s LED with Begemann’s lightbulb design. See, e.g., Ex. 1028 ¶ 22. Patent Owner argues that evidence must be relevant to motivation to combine “an LED chip from the Krames article (operating at 1.5 amps to produce 170 milliwatts of output)” but claim 21 has no “operating at 1.5 amps to produce 170 milliwatts of output” requirement. What is relevant is that Krames discloses a single chip that has the capability of outputting more or less light depending on operating conditions. Pet. Opp. 3; see also Ex. 1008, 8 (providing that Figure 12 of the Krames reference is described as illustrating “[l]ight output vs. current characteristic of a blue … 1x1 mm2 AlGaInN LED in a power package, compared to a conventional AlGaInN LED in a 5 mm lamp a package”). Because claim 21 does not require actually running the recited LED at any particular wattage or amperage, it is appropriate for the Krames declaration to rebut Patent Owner’s argument that a person of ordinary skill would not have considered using the Krames LED with Begemann at high amperage by explaining that a person of ordinary skill in the art would have considered using the exact same Krames LED with Begemann at a low amperage instead and that at this lower amperage the Krames LED would generate an amount of heat that would be easily dissipated by Begemann’s lamp while still providing an optical output of “greater than about 40 milliwatts” as recited by claim 21. Ex. 1028 ¶¶ 23–24 (citing Ex. 1008, 8). The fact that the Krames LED is configured to run at the high amperage if desired for a different application does not negate the rationale for combining the Krames LED to run at a lower amperage.” slip op. at 14

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with Patent Owner that the challenged claims relate to light fixtures, LED packaging, and LED chip layer structure and that the ’961 patent claims reflect “a hybrid of the light bulb art and semiconductor art.” Resp. 19. The prior art of record, for example, Begemann, likewise reflects “a hybrid of the light bulb art and semiconductor art.” Id. (quoting Pet. 28). Petitioner’s expert, Dr. Lebby, agreed that a person having ordinary skill in the art would need to be “familiar with thermal issues.” Ex. 2015, 26:15– 28:16. While Petitioner’s proposed description of a person having ordinary skill in the art could, in some instances, be sufficient to qualify a person as having ordinary skill, Patent Owner’s proposal is a more complete and accurate description of the level of skill commensurate with the scope of the challenged ’961 patent claims. Patent Owner’s description appears consistent with the prior art and patent specification before us and is supported by witness testimony. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself may reflect an appropriate level of skill). For the purpose of this Decision, we adopt Patent Owner’s description. We further note that the outcome of our decision would be the same under either party’s asserted skill level.” slip op. at 19

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “particularly relevant.” Resp. 14–15. First, Patent Owner argues that “a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” means “at least one LED chip is capable of emitting light greater 9 Petitioner states that “Patent Owner thus contends the recited ‘reflective layers’ can include transparent or semi-transparent layers that exhibit some reflectivity (e.g., SiO2) or an interface between two layers (e.g., the buffer and substrate layers) that exhibit differing indices of refraction.” Pet. 20. Patent Owner frames this as being Petitioner’s “novel construction” (Resp. 16), but Petitioner does not expressly endorse this Patent Owner contention. than about 40 milliwatts.” Resp. 14–15. Patent Owner notes that a district court already adopted this construction and notes that the “LED chip” includes LEDs, LED modules, and LED arrays but excludes laser chips, laser modules, and VCSEL chips. Id. (citing Ex. 2003, 15–18). Petitioner argues that the phrase “needs no construction” and that Petitioner’s grounds meet this construction. Reply 1–2. We adopt Patent Owner’s proposed construction because it is well supported by the record including the District Court’s reasoning. Ex. 2003, 15–18. slip op. at 20

  • Prior constructionPrior construction adoptedDecided for patent owner

    “Patent Owner’s claim construction is well-supported by the record including the reasoning provided by the California and Delaware district courts. Ex. 2002, 19–21 (California district court explaining why the “reflective layers” must be distinct layers based on how claim 8 is structured and also explaining why the amount of reflection must be non-negligible); Ex. 2003, 2, 13 (Delaware district court explaining why reflection has to be more than negligible but need not reflect more light than the light absorbed or transmitted). We, thus, agree that “first and a second reflective layers . . . 10 Patent Owner’s proposed claim construction combines various statements made by the district courts into one statement. Resp. 15 (citing Ex. 2002, 19–21; Ex. 2003, 2, 13). serving to reflect light emitted by said active layer” means that the “first and second reflective layers are distinct from each other and reflect more than negligible light.” We further note that the preponderance of the evidence supports that as little as one percent light reflectance is “non-negligible” in this context. Reply 4; also Ex. 1032, 188:7–14 (Patent Owner’s witness, Dr. Shealy, testifying that reflection “on the order of one percent” would be more than negligible); see also Tr. 53 (counsel for Patent Owner agreeing that Dr. Shealy opined that “three percent reflection is enough to be non-negligible”).” slip op. at 21

  Patent outcomesUS 6,465,961 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 6,465,961
• Wolfspeed, Inc. / Ideal Industries Lighting, LLC D/B/A Cree Lighting et al. v. Cao Lighting, Inc.Some claims unpatentable
  PTAB · Sep 28, 2023 · IPR2023-00123 · APJ Brian D Range · IPR · Final written decision

  Claims 21–40, 42–44, 47–49, 52–53, 56–59, 62–63, 65–68, 71–73, 77–78, 81–82, and 85–91 are unpatentable over Begemann, Krames, and Allen; claim 41 was not shown unpatentable.

  RulingsFinal written decision

  • ExcludeMotion to exclude, deniedDenied

    “declaration addresses the Patent Owner Response and is relevant to the issues at hand. We start with an important observation: claim 21 (the only independent claim at issue) is an apparatus claim; the claim is directed to a “semiconductor light source.” Ex. 1001, 9:52. One requirement of this apparatus is that it comprise “at least one semiconductor chip” (id. at 10:1) where the “at least one semiconductor chip is a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts.” Id. at EPRC, 1:34–36. As we explain when addressing claim construction, infra, we adopt Patent Owner’s proposed construction of “a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” as meaning “at least one LED chip is capable of emitting light greater than about 40 milliwatts.” See Section III.D, infra (emphasis added). Because of these recitations, Petitioner bears the burden of establishing that the prior art teaches or suggests a semiconductor chip “capable of emitting light greater than about 40 milliwatts.” As explained herein, we determine that in the Petition, Petitioner met this burden by establishing by a preponderance of the evidence that the Krames reference teaches an LED chip that has this capability. Pet. 54 (quoting Ex. 1008, 10). Notably, claim 21 does not require actual operation of anything at greater than 40 milliwatts because claim 21 is not a method claim. Petitioner never had a burden of establishing a method of running the Krames reference’s LED at this power output within a semiconductor light source.” slip op. at 12

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with Patent Owner that the challenged claims relate to light fixtures, LED packaging, and LED chip layer structure and that the ’961 patent claims reflect “a hybrid of the light bulb art and semiconductor art.” Resp. 19. The prior art of record, for example, Begemann, likewise reflects “a hybrid of the light bulb art and semiconductor art.” Id. (quoting Pet. 28). Petitioner’s expert, Dr. Lebby, agreed that a person having ordinary skill in the art would need to be “familiar with thermal issues.” Ex. 2015, 26:15– 28:16. While Petitioner’s proposed description of a person having ordinary skill in the art could, in some instances, be sufficient to qualify a person as having ordinary skill, Patent Owner’s proposal is a more complete and accurate description of the level of skill commensurate with the scope of the challenged ’961 patent claims. Patent Owner’s description appears consistent with the prior art and patent specification before us and is supported by witness testimony. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself may reflect an appropriate level of skill). For the purpose of this Decision, we adopt Patent Owner’s description. We further note that the outcome of our decision would be the same under either party’s asserted skill level.” slip op. at 19

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Term construed patent owner constructionDecided for patent owner

    “particularly relevant.” Resp. 14–15. First, Patent Owner argues that “a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” means “at least one LED chip is capable of emitting light greater 9 Petitioner states that “Patent Owner thus contends the recited ‘reflective layers’ can include transparent or semi-transparent layers that exhibit some reflectivity (e.g., SiO2) or an interface between two layers (e.g., the buffer and substrate layers) that exhibit differing indices of refraction.” Pet. 20. Patent Owner frames this as being Petitioner’s “novel construction” (Resp. 16), but Petitioner does not expressly endorse this Patent Owner contention. than about 40 milliwatts.” Resp. 14–15. Patent Owner notes that a district court already adopted this construction and notes that the “LED chip” includes LEDs, LED modules, and LED arrays but excludes laser chips, laser modules, and VCSEL chips. Id. (citing Ex. 2003, 15–18). Petitioner argues that the phrase “needs no construction” and that Petitioner’s grounds meet this construction. Reply 1–2. We adopt Patent Owner’s proposed construction because it is well supported by the record including the District Court’s reasoning. Ex. 2003, 15–18. slip op. at 20

  • Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication establishedDecided for petitioner

    “The facts above are evidence of the Krames reference’s publication as of June 29, 2000, because the facts tend to make the Krames reference’s publication as of June 29, 2000, more probable than it would be without the facts. See Fed. R. Evid. 401(a) (defining evidence as relevant “if it has any tendency to make a fact more or less probable than it would be without the 13 We note that Dr. Lebby does not directly state when the Proceedings were widely available. See Sur-Reply 14. evidence”). The evidence is sufficient to support publication. Meanwhile, no evidence of record suggests that Krames was not a printed publication as of June 29, 2000. Thus, a preponderance of the evidence supports Krames’s prior art status. Patent Owner argues that Ms. Watters “never establishes a firm date when Krames was purportedly available to the relevant public.” Resp. 25. Patent Owner bases this argument by taking a tortured reading of Ms. Watters’s statement that “[m]embers of the interested public could locate a copy of [the Proceedings] on or after June 29, 2000, the date it was catalogued.” Id. (quoting Ex. 1020, 3); see also Sur-Reply 13–14. The best understanding of Ms. Watters’s statement, in view of the context of Ms. Watters explaining the library’s cataloguing process, is that a member of the interested public had two options: the person could choose to locate the Proceedings on June 29, 2000, or the person could choose to locate the Proceedings after June 29, 2000. Thus, the statement supports public availability as of June 29, 2000.” slip op. at 25

  Patent outcomesUS 6,465,961 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 6,465,961
• Wolfspeed, Inc. / Ideal Industries Lighting, LLC D/B/A Cree Lighting et al. v. Cao Lighting, Inc.Some claims unpatentable
  PTAB · Sep 28, 2023 · IPR2022-00847 · APJ Brian D Range · IPR · Final written decision

  Claims 21, 22, 25, 26, 28–30, 32–36, 40, 42–44, 47–49, 52, 53, 56–59, 62, 63, 65–68, 71–73, 77, 78, 81, 82, 85, 86, and 88–91 are unpatentable over Begemann, Krames, and Allen; claim 41 is …

  RulingsFinal written decision

  • ExcludeMotion to exclude, deniedDenied

    “Patent Owner’s argument is unpersuasive because the Krames declaration addresses the Patent Owner Response and is relevant to the issues at hand. We start with an important observation: claim 21 (the only independent claim at issue) is an apparatus claim; the claim is directed to a “semiconductor light source.” Ex. 1001, 9:52. One requirement of this apparatus is that it comprise “at least one semiconductor chip” (id. at 10:1) where the “at least one semiconductor chip is a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts.” Id. at EPRC, 1:34–36. As we explain when addressing claim construction, infra, we adopt Patent Owner’s proposed construction of “a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” as meaning “at least one LED chip is capable of emitting light greater than about 40 milliwatts.” See Section III.D, infra (emphasis added). Because of these recitations, Petitioner bears the burden of establishing that the prior art teaches or suggests a semiconductor chip “capable of emitting light greater than about 40 milliwatts.” As explained herein, we determine that in the Petition, Petitioner met this burden by establishing by a preponderance of the evidence that the Krames reference teaches an LED chip that has this capability. Pet. 54 (quoting Ex. 1008, 10). Notably, claim 21 does not require actual operation of anything at greater than 40 milliwatts because claim 21 is not a method claim. Petitioner never had a burden of establishing a method of running the Krames reference’s LED at this power output within a semiconductor light source.” slip op. at 12

  • Skill levelSkill level patent owner adoptedDecided for patent owner

    “We agree with Patent Owner that the challenged claims relate to light fixtures, LED packaging, and LED chip layer structure and that the ’961 patent claims reflect “a hybrid of the light bulb art and semiconductor art.” Resp. 19. The prior art of record, for example, Begemann, likewise reflects “a hybrid of the light bulb art and semiconductor art.” Id. (quoting Pet. 28). Petitioner’s expert, Dr. Lebby, agreed that a person having ordinary skill in the art would need to be “familiar with thermal issues.” Ex. 2015, 26:15– 28:16. While Petitioner’s proposed description of a person having ordinary skill in the art could, in some instances, be sufficient to qualify a person as having ordinary skill, Patent Owner’s proposal is a more complete and accurate description of the level of skill commensurate with the scope of the challenged ’961 patent claims. Patent Owner’s description appears consistent with the prior art and patent specification before us and is supported by witness testimony. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (prior art itself may reflect an appropriate level of skill). For the purpose of this Decision, we adopt Patent Owner’s description. We further note that the outcome of our decision would be the same under either party’s asserted skill level.” slip op. at 19

  • Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner

    “particularly relevant.” Resp. 14–15. First, Patent Owner argues that “a light emitting diode (LED) chip configured to output light at greater than about 40 milliwatts” means “at least one LED chip is capable of emitting light greater 9 Petitioner states that “Patent Owner thus contends the recited ‘reflective layers’ can include transparent or semi-transparent layers that exhibit some reflectivity (e.g., SiO2) or an interface between two layers (e.g., the buffer and substrate layers) that exhibit differing indices of refraction.” Pet. 20. Patent Owner frames this as being Petitioner’s “novel construction” (Resp. 16), but Petitioner does not expressly endorse this Patent Owner contention. than about 40 milliwatts.” Resp. 14–15. Patent Owner notes that a district court already adopted this construction and notes that the “LED chip” includes LEDs, LED modules, and LED arrays but excludes laser chips, laser modules, and VCSEL chips. Id. (citing Ex. 2003, 15–18). Petitioner argues that the phrase “needs no construction” and that Petitioner’s grounds meet this construction. Reply 1–2. We adopt Patent Owner’s proposed construction because it is well supported by the record including the District Court’s reasoning. Ex. 2003, 15–18. slip op. at 20

  • Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther

    “It is unnecessary to construe any other claim terms in this Decision because none of the parties’ disputes turn on the meaning of other claim terms. See, e.g., Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017).” slip op. at 22

  Patent outcomesUS 6,465,961 mixed
  Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · Graham
  Patents in suitUS 6,465,961

Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.