- PTAB · Oct 9, 2025 · IPR2025-00847 · APJ Brian D Range · IPR · Institution
Instituted IPR on claims 1–11 because Petitioners showed a reasonable likelihood of proving at least one challenged claim unpatentable across the asserted grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The following findings of fact and conclusions of law are not final, but are made for the sole purpose of determining whether Petitioners meet the threshold for initiating review. Any final decision shall be based on the full trial record, including any response timely filed by Patent Owner. Any arguments not raised by Patent Owner in a timely-filed response may be deemed waived. For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We hereby institute an inter partes review as to claims 1–11 of the ’847 patent based upon Petitioners’ asserted grounds of unpatentability.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“would have had a master’s degree in electrical engineering, physics, chemistry, materials science, or a related field and three years of work experience in semiconductor manufacturing, such as, for example, in integrated circuit device (or transistor) design and/or manufacturing,” and “[a]dditional relevant education could substitute for professional experience, and significant work experience or training could substitute for formal education.” Pet. 11 (citing Ex. 1003 ¶ 38). Patent Owner does not dispute the level of ordinary skill in the art. See generally Prelim. Resp. For purposes of this Decision, we adopt Petitioner’s proposal as reasonable and consistent with the ’847 patent specification and the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art may reflect an appropriate level of skill in the art). slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner does not propose any claim constructions, except to explain that the claim 7 limitation “the spacer further comprises an offset spacer, positioned between the gate and the spacer,” is “satisfied if one layer (an ‘offset spacer’) of the claimed ‘spacer’ lies between another layer of the ‘spacer’ and the gate.” Pet. 11. Patent Owner does not dispute Petitioner’s assertions or offer any claim constructions. See generally Prelim. Resp. Because resolution of Petitioner’s proposed construction is unnecessary to our analyses for purposes of this decision, we do not address the proposal here. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). We do not discern a need to construe any other claim language at this juncture because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC, 912 F.3d at 1375.” slip op. at 8
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“a. Claim 1 Petitioner contends that claim 1 is anticipated by Lan or, alternatively, obvious in view of Lan. Pet. 18–26. Petitioner explains how Lan teaches or suggests each recitation of claim 1, and Petitioner’s position is supported by adequate evidence for institution. Id. (citing, e.g., Ex. 1003 ¶¶ 100–125). Petitioner, for example, persuasively compares the structure of Figure 12 of Lan to each limitation of claim 1. Id. Patent Owner does not dispute Petitioner’s contentions except to argue that Lan (and the Petition’s other asserted references) “Do Not Mention, Describe, or Concern ‘Raised Epitaxial Layers.’” Prelim. Resp. 22–24. Patent Owner does not persuasively undermine Petitioner’s position.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,745,847 - PTAB · Oct 6, 2025 · IPR2025-00611 · APJ Christopher L Ogden · IPR · Institution
The Board instituted IPR of claims 1–10, 12, 13, 19, and 20 on all petition grounds after finding a reasonable likelihood that claim 1 was obvious over Douglas and Mark.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“A claim is unpatentable under § 103 “if the differences between the claimed invention and the prior art are such that the claimed invention as a whole would have been obvious before the effective filing date of the claimed invention to a person having ordinary skill in the art to which the claimed invention pertains.” 35 U.S.C. § 103; see KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 406 (2007). When a ground in a petition is based on a combination of references, we consider “whether there was an apparent reason to combine the known elements in the fashion claimed by the patent at issue.” KSR, 550 U.S. at 418 (citing In re Kahn, 441 F.3d 977, 988 (Fed. Cir. 2006)).” slip op. at 8
- Skill levelSkill level petitioner adoptedDecided for petitioner
“The parties agree that experience could substitute for a degree, and vice versa. Pet. 3 (citing Ex. 1003 ¶¶ 19–21); Prelim. Resp. 9. The parties’ proposed levels of ordinary skill are substantially similar. Although we discern no difference in the outcome of this decision from choosing one over the other, we adopt Petitioner’s proposal for this decision. Only Petitioner’s proposed level is supported by testimonial evidence on the preliminary record, and it appears to be consistent with the problems addressed in the ’774 patent. See Ex. 1001, 1:16–52. Therefore, we adopt Petitioner’s proposal for this decision.” slip op. at 7
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“CLAIM CONSTRUCTION B. In an IPR, we construe a patent claim “using the same claim construction standard that would be used to construe the claim in a civil action under 35 U.S.C. 282(b).” 37 C.F.R. § 42.100(b). This generally includes “construing the claim in accordance with the ordinary and customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” Id. The ordinary and customary meaning of a claim term “is its meaning to the ordinary artisan after reading the entire patent,” and “as of the effective filing date of the patent application.” Phillips, 415 F.3d at 1313, 1321. Neither Petitioner nor Patent Owner argues that we need to construe any claim terms explicitly. See Pet. 2–3; Prelim. Resp. 9. However, the parties’ positions depend on interpreting the claim language in a particular way, and we discuss the relevant claim language below in the context of the parties’ arguments regarding the prior art. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 7
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“At this stage, we find Petitioner’s arguments persuasive and disagree with Patent Owner. Patent Owner appears to equate a “fabrication profile” with a toolpath description, but nothing in the plain language of claim 1 supports that narrow interpretation. The ’774 patent describes a “fabrication profile” broadly and states that the profile can simply “include the dictionary [of configuration information],” or be “used to determine which machineready representation is available or suitable for a target printer.” Ex. 1001, 23:49–52. The preliminary evidence suggests that Douglas’s “operational parameters” would count as a “fabrication profile” because it is “the basis for generation of a machine-ready representation of the three-dimensional model that is executable on the target printer.” Id. at 23:37–39; see infra Section III.C.8. We also disagree that Petitioner’s argument is impermissible hindsight, because it is based on the disclosures in Douglas and Mark, and Petitioner has articulated a sufficiently persuasive reason to combine those references without referring to the ’774 patent itself. See In re McLaughlin, 443 F.2d 1392, 1395 (CCPA 1971) (an obvious rationale is not improper hindsight if it “takes into account only knowledge which was within the level of ordinary skill at the time the claimed invention was made and does not include knowledge gleaned only from applicant’s disclosure”). Finally, Petitioner appears to rely on Mark for providing a particular example of a fabrication profile, not to replace Douglas’s overall system in which the 3D printer can receive “operational parameters” rather than just G-code. See Pet. 8–10, 17–23; see also Ex. 1005 ¶ 41 (the print queue, which stores tool instructions, may be maintained locally on printers 204 or on print servers 208); see In re Mouttet, 686 F.3d 1322, 1332 (Fed. Cir. 2012) (“[A] determination of obviousness based on teachings from multiple references does not require an actual, physical substitution of elements.” (citing In re Etter, 756 F.2d 852, 859 (Fed. Cir. 1985) (en banc))).” slip op. at 19
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,886,774 - Uatp IP LLC v. Slick Slide LLCInstitutedPTAB · Apr 8, 2025 · PGR2024-00054 · APJ Julia Heaney · PGR · Institution
The Board instituted PGR on claims 1–17 and 22–28 and all asserted grounds, finding a sufficient likelihood that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of a post-grant review is authorized by statute when “the information presented in the petition . . . would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a) (2018). Upon consideration of the parties’ submissions and the evidence of record, we determine that Petitioner has demonstrated that it is more likely than not that at least one claim challenged in the Petition is unpatentable. Further, Patent Owner has not persuaded us that it is appropriate to exercise our discretion not to institute review. Accordingly, we institute a post-grant review of all claims and all grounds asserted in the Petition.1” slip op. at 2
- Skill levelSkill level patent owner adoptedOther
“On this record, we do not find Patent Owner’s proposed experience level of at least five years in measurement and analysis of coefficient of friction to be supported. As to the necessity of experience in textile engineering and fiber science, Patent Owner’s position, although not supported by declarant analysis of the factors listed above, is consistent with the disclosure of the ’854 patent, which describes features of a mesh layer in textile and fiber terms. See e.g., Ex. 1001, 10:17–11:14, 12:65–13:8, 14:20–24. On the whole, however, we do not discern on this record how specific experience in textile engineering and fiber science of a person of ordinary skill would materially alter the outcome at this stage of the proceeding. For purposes of this decision only, we apply Patent Owner’s proposed definition of a person of ordinary skill in the art, except for the requirement of five years of experience in measurement and analysis of coefficient of friction. The level of skill in the art remains an open issue in this proceeding. Further submissions by the parties may include argument and evidence that would assist in the resolution of this issue at the close of trial.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Petitioner contends “no formal claim construction is necessary in this proceeding.” Pet. 10; Reply 1, 4. Patent Owner contends the terms “mesh layer” and “coefficient of friction” require construction. Prelim. Resp. 14–16; Sur-reply 2–5. We have considered the parties’ arguments and discuss them below with regard to each of the terms Patent Owner contends should be construed. Because our determination that Petitioner demonstrates at least one challenged claim meets the threshold for institution (see SAS Inst., 138 S. Ct. at 1359–60) is not based on construing the term “mesh layer” or “coefficient of friction,” we determine we need not construe either claim term at this stage of the proceeding. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.”)). As further discussed below, we invite the parties to address claim construction at trial.” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageDisclaimer not foundDecided for petitioner
“We agree with Petitioner that the ’854 patent specification does not include clear and explicit lexicography or a disclaimer that would support requiring “coefficient of friction” to be determined by a specific ASTM test method. The portion of the specification Patent Owner asserts as a definition of “coefficient of friction” (see Ex. 1001, 11:31–42) is a description of an embodiment; we find it does not express patentee intent to redefine the term. Further, the statement that “the coefficient of friction … may be determined using the … ASTM D1894 standard test method” (id. at 11:32–35) indicates that use of that specific test method is optional. Accordingly, in the absence of patentee lexicography or disavowal, we do not limit the scope of the term “coefficient of friction” to require that it be measured by a specific ASTM standard. Luminara Worldwide, LLC v. Liown Elecs. Co., 814 F.3d 1343, 1353 (Fed. Cir. 2016) (“Absent lexicography or disavowal, we do not depart from the plain meaning of the claims.”); In re Am. Acad. Of Sci. Tech Ctr., 367 F.3d 1359, 1369 (Fed. Cir. 2004) (“We have cautioned against reading limitations into a claim from the preferred embodiment described in the specification, even if it is the only embodiment described, absent clear disclaimer in the specification.”). We note that the ’854 patent specification sets forth a definition for the coefficient of friction between the surfaces of the mesh material and the slide surface. Ex. 1001, 4:38–46. As stated above, however, we do not expressly construe any claim term at this stage of the proceeding. Should the parties address the construction of “coefficient of friction” at trial, we will make a determination after the close of evidence and any hearing.” slip op. at 13
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosureDiscretionary denialcites KSR · GrahamPatents in suitUS 11,998,854 - PTAB · Mar 20, 2025 · IPR2024-01406 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board instituted IPR on claims 1, 3, 4, 8–13, and 15 on all asserted grounds, finding a reasonable likelihood that Takeuchi anticipates those claims.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2018); see also 37 C.F.R. § 42.4 (2023). For the reasons discussed below, we determine that Petitioner establishes a reasonable likelihood of prevailing with respect to the unpatentability of at least one claim of the ’202 patent. Accordingly, we institute an inter partes review of claims 1, 3, 4, 8–13, and 15 of the ’202 patent. A. Real Parties in Interest” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“or “POSITA”) would have had “a bachelor’s degree in mechanical engineering, electrical engineering, or a related field, and three to four years of experience, or a master’s degree in mechanical engineering, electrical engineering, or a related field, and one to two years of experience.” Pet. 6 (citing Ex. 1003 ¶ 13). Petitioner further contends that “[s]uch experience would include a familiarity with thermal fluid delivery devices and/or the components and underlying technology used therein, and a higher level of 1 US 5,249,586, issued Oct. 5, 1993 (Ex. 1004, “Morgan”). 2 EP 0 845 220 B1, published Jan. 26, 1998 (Ex. 1006, “Susa”). 3 US 2005/0205084 A1, published Sept. 22, 2005 (Ex. 1007, “Gupta”). 4 US 6,155,268, issued Dec. 5, 2000 (Ex. 1009, “Takeuchi”). at 6–7 (citing Ex. 1003 ¶ 13). Patent Owner states that, for purposes of the Preliminary Response, “Patent Owner maintains that Petitioners’ arguments fail even under Petitioners’ POSA definition.” Prelim. Resp. 13. On this record, we preliminarily adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’202 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))). B. Claim Construction” slip op. at 6
- Prior constructionPrior construction adoptedDecided for petitioner
“term “wicked into contact” that the Board adopted in a prior inter partes review proceeding that addressed the same term in an earlier, related patent. Pet. 7 (citing IPR2020-01602, Paper 32 at 8–15 (PTAB March 30, 2022)). ‘wicked into contact’ to mean: ‘wicked into contact (1) with the heater, or (2) with an area in close proximity to, and exposed [to] the heat produced by, the heater,’” and “[t]he present Petition adopts this formal construction for purposes of this IPR proceeding.” Id. (citing IPR2020-01602, Paper 32 at 15). Patent Owner also “adopts this construction for purposes of” the Preliminary Response, and argues that “Petitioner’s grounds fail even under its proposed construction of ‘wicked into contact.’” Prelim. Resp. 13. For purposes of this Decision, we adopt the Board’s prior construction of “wicked into contact,” namely, “wicked into contact (1) with the heater, or (2) with an area in close proximity to, and exposed to the heat produced by, the heater,” which is undisputed on this record. See Philip Morris Products, S.A. v. RAI Strategic Holdings, Inc., IPR2020-01602, Paper 32 at 8–15 (PTAB March 30, 2022). C. Asserted Anticipation by Morgan” slip op. at 7
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot reached
“To establish anticipation, each and every element in a claim, arranged as recited in the claim, must be found in a single prior art reference. Net Karsten Mfg. Corp. v. Cleveland Golf Co., 242 F.3d 1376, 1383 (Fed. Cir. 2001). “A reference may anticipate inherently if a claim limitation that is not expressly disclosed is ‘necessarily present, or inherent, in the single anticipating reference.’” In re Montgomery, 677 F.3d 1375, 1379 (Fed. Cir. 2012) (quoting Verizon Servs. Corp. v. Fibernet Va., Inc., 602 F.3d 1325, 1336–37 (Fed. Cir. 2010)). Based on the current record, we are not persuaded that Petitioner sufficiently establishes that Morgan discloses “a storage compartment . . . being arranged such that the liquid aerosol-forming material can be wicked into contact with the electrical resistance heater to volatilize the liquid aerosol-forming material” as recited in claim 1.” slip op. at 12
Claim construction§ 102 anticipationcites PhillipsPatents in suitUS 11,925,202 - Posco Co., Ltd. v. ArcelormittalInstitutedPTAB · Mar 18, 2025 · IPR2024-01377 · APJ Brian D Range · IPR · Institution
The Board instituted IPR on claims 1–25 on all petitioned grounds, finding a reasonable likelihood of success, including that GMW14400 likely qualifies as prior art.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review pursuant to 35 U.S.C. § 6(b). Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The Board determines whether to institute a trial on behalf of the Director. 37 C.F.R. § 42.4(a). The following findings of fact and conclusions of law are not final, but are made for the sole purpose of determining whether Petitioner meets the threshold for initiating review. Any final decision shall be based on the full trial record, including any response timely filed by Patent Owner. Any arguments not raised by Patent Owner in a timely-filed response may be deemed waived. For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We hereby institute an inter partes review as to claims 1–25 of the ’227 patent based upon Petitioner’s asserted grounds of unpatentability.” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“efficiency and integrity of the system are best served by denying or instituting review.” Fintiv at 6. Here, Fintiv factors one and five are neutral, factors two and three favor discretionary denial, factor four strongly weighs against discretionary denial, and favor six weighs against discretionary denial. The integrity of the system will benefit from institution because of the strong merits the Petition presents (factor six), and the ITC Investigation will not resolve these merits (factor four). This outweighs any potential inefficiency as indicated by factors two and three. We further note that any inefficiency in resolving the grounds the Petition presents is mitigated by the stay of the district court action (factor one). We, thus, decline to exercise discretionary denial under 35 U.S.C. § 314(a).” slip op. at 17
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDenied
“After considering the record as a whole, we determine that Petitioner has adequately demonstrated that the Office erred in a manner material to the patentability of challenged claims. As we explain in Section III(G), infra, Petitioner’s challenges to the ’227 patent appear strong based on the current record, and Patent Owner’s present arguments to the contrary are weak. Given the strength of Petitioner’s challenges on the present record, this is not a situation where we would say that “reasonable minds can disagree regarding the purported treatment of the art,” and we therefore determine that the Examiner erred by not considering the art in substantially the combination Petitioner proposes. Where Patent Owner states that “evidence that the Examiner did not consider these references in combination” is lacking (PO Sur-Reply 5), we disagree. If the Examiner considered these references in combination, the Examiner would have, given the apparent strength of Petitioner’s position on the merits on this record, issued a rejection. The lack of a rejection based on the combination proposed in the Petition provides some evidence that the Examiner did not consider these references in combination (because the lack of such a rejection raises the likelihood that the Examiner did not make such a consideration). 3. Conclusion Because Petitioner adequately made a showing of material error, we decline to exercise discretion not to institute inter partes review under 35 U.S.C. § 325(d). See Advanced Bionics, LLC, IPR2019-01469, Paper 6 at 8–9.” slip op. at 19
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“For purposes of this Decision, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,326,227 - Posco Co., Ltd. v. ArcelormittalInstitutedPTAB · Mar 18, 2025 · IPR2024-01376 · APJ Brian D Range · IPR · Institution
The Board instituted review of claims 1–30 on all petitioned grounds, finding a reasonable likelihood of success, including that GMW14400 likely qualifies as prior art.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“IV. CONCLUSION For the reasons above, we determine that the information presented in the Petition establishes that there is a reasonable likelihood that Petitioner would prevail with respect to challenged claims 1–30 of the ’602 patent. At this juncture in the proceeding, we have not made a final determination with respect to the patentability of the challenged claims, or with respect to claim construction. V. ORDER For the foregoing reasons, it is ORDERED that pursuant to 35 U.S.C. § 314(a), an inter partes review of claims 1–30 of the ’602 patent is hereby instituted with respect to all grounds of unpatentability set forth in the Petition; and” slip op. at 36
- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied fintivDenied
“efficiency and integrity of the system are best served by denying or instituting review.” Fintiv at 6. Here, Fintiv factors one and five are neutral, factors two and three favor discretionary denial, factor four strongly weighs against discretionary denial, and favor six weighs against discretionary denial. The integrity of the system will benefit from institution because of the strong merits the Petition presents (factor six), and the ITC Investigation will not resolve these merits (factor four). This outweighs any potential inefficiency as indicated by factors two and three. We further note that any inefficiency in resolving the grounds the Petition presents is mitigated by the stay of the district court action (factor one). We, thus, decline to exercise discretionary denial under 35 U.S.C. § 314(a).” slip op. at 17
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDenied
“After considering the record as a whole, we determine that Petitioner has adequately demonstrated that the Office erred in a manner material to the patentability of challenged claims. As we explain in Section III(G), infra, Petitioner’s challenges to the ’602 patent appear strong based on the current record, and Patent Owner’s present arguments to the contrary are weak. Given the strength of Petitioner’s challenges on the present record, this is not a situation where we would say that “reasonable minds can disagree regarding the purported treatment of the art,” and we therefore determine that the Examiner erred by not considering the art in substantially the combination Petitioner proposes. Where Patent Owner states that “evidence that the Examiner did not consider these references in combination” is lacking (PO Sur-Reply 5), we disagree. If the Examiner considered these references in combination, the Examiner would have, given the apparent strength of Petitioner’s position on the merits on this record, issued a rejection. The lack of a rejection based on the combination proposed in the Petition provides some evidence that the Examiner did not consider these references in combination (because the lack of such a rejection raises the likelihood that the Examiner did not make such a consideration). 3. Conclusion Because Petitioner adequately made a showing of material error, we decline to exercise discretion not to institute inter partes review under 35 U.S.C. § 325(d). See Advanced Bionics, LLC, IPR2019-01469, Paper 6 at 8–9.” slip op. at 19
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“For purposes of this Decision, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 10,961,602 - PTAB · Sep 18, 2024 · IPR2024-00702 · APJ Sharon Fenick · IPR · Institution
The Board instituted review of claims 1–6 and 8–16 on all asserted grounds, finding a reasonable likelihood that the Nair and Forsberg combination renders at least claim 1 obvious.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“The Board has authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314(b) (2018); 37 C.F.R. § 42.4(a). Under 35 U.S.C. § 314(a), an inter partes review may not be authorized unless the information in the Petition and any preliminary response “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons that follow, we institute an inter partes review as to the challenged claims of the ’817 patent on all grounds of unpatentability presented.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“B. Level of Ordinary Skill in the Art Petitioner, citing Dr. Bims’s declaration, asserts that, “[a] person of ordinary skill in the art (“POSITA”) in the subject matter of the ’817 patent would have had a master’s degree in electrical engineering, computer engineering, or computer science, or equivalent and at least three years of experience in the field of telecommunications or wireless systems,” and that “[a]dditional education might compensate for less experience, and vice-versa.” Pet. 10–11 (citing Ex. 1002 ¶ 22). Patent Owner asserts that one of ordinary skill would have had “a bachelor’s degree in electrical engineering, computer engineering, or computer science with (1) at least three years of experience in the field of telecommunications or wireless systems; and/or (2) an advanced degree in field of telecommunications or wireless systems.” Prelim. Resp. 16. We do not discern a meaningful difference between the two parties proposals. Petitioner’s proposal appears consistent with the problems and solutions in the ’817 patent and prior art of record and is supported by expert testimony. We note, however, that the open-ended language “at least” expands the range of experience indefinitely with no upper bound. Upon this preliminary record and for the purposes of institution, we adopt Petitioner’s definition of the level of skill with the exception that we delete the words “at least.”” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“C. Claim Construction Neither party makes a claim construction proposal or indicates that any claim requires construction. Pet. 11; see generally Prelim. Resp. We note that an argument was raised that presents an implicit construction question regarding whether a flag which “only identifies if encryption [is] ‘on’ or ‘off’” (Prelim. Resp. 24) teaches or suggests “an encryption scheme identifier that identifies an encryption scheme used by the UE to encrypt the subscription identifier in the SUCI” (as recited in limitation 1d of claim 1 and identically in claims 9, 10, and 15). We address that argument below, in Sections II.D.3.c.ii and iii of this Decision. With that exception, we do not discern that any claim terms require construction at this point in the proceeding for the purpose of institution. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (only those terms that are in controversy need be construed, and only to the extent necessary to resolve the controversy) (citing Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportReference is prior artDecided for petitioner
“i. Nair Provisional’s Support for a Claim in Nair Patent Owner argues that the Petition is deficient because it does not show that the disclosure in the Nair Provisional supports at least one claim in Nair, even though Nair is subject to the AIA and Patent Owner concedes that the Board’s precedential opinion in Penumbra concludes we do not need to make such a determination regarding support for at least one claim to reach a prior art determination under the AIA. Prelim. Resp. 23–24 n.6; Penumbra, 2023) (precedential). Following that precedent, we decline to require a showing of support in the Nair Provisional for at least one claim in Nair and instead only require that the ministerial requirements for claiming priority were met. See Penumbra, Paper 34 at 32–33. Petitioner argues that the “ministerial requirements” described in Penumbra have been met. Pet. 4–5 (noting that Nair contains a priority claim to the Nair Provisional, was filed within 12 months of the Nair Provisional, and includes a common inventor). Patent Owner does not contest that these requirements have been met, and upon our examination, we agree that they appear to have been met. Ex. 1004, codes (22), (60), (72); Ex. 1008, 1, 4, 38. Thus, on the present record and for the purposes of institution, the disclosures of Nair are prior art, to the extent that the relied-upon disclosures are included in the Nair Provisional. ii. Nair Provisional’s Date for Cited Portions of Nair Patent Owner also argues that the Petition relies on material in Nair that was added after the filing of the Nair Provisional, and that this material cannot be properly relied on as prior art. Prelim. Resp. 19–23. We address these specific arguments regarding material Petitioner references from Nair (and the Nair Provisional) below, in our analysis with respect to the respective limitations of claim 1 these citations relate to.” slip op. at 15
Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 10,425,817 - PTAB · Jul 9, 2024 · IPR2024-00119 · APJ Brian D Range · IPR · Institution
The Board instituted review of claims 1–17 on all asserted grounds, finding a reasonable likelihood of success on at least one claim despite finding Wong was not shown to be prior art.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“unless the information presented in the petition “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” The following findings of fact and conclusions of law are not final, but are made for the sole purpose of determining whether Petitioner meets the threshold for initiating review. Any final decision shall be based on the full trial record, including any response timely filed by Patent Owner. Any arguments not raised by Patent Owner in a timely-filed response may be deemed waived. For the reasons stated below, we determine that Petitioner has established a reasonable likelihood that it would prevail with respect to at least one claim. We hereby institute an inter partes review as to claims 1–17 of the ’760 patent based upon Petitioner’s asserted grounds of unpatentability.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Pet. 5 (citing Ex. 1007 ¶¶ 36–42). Patent Owner does not dispute the level of ordinary skill in the art. Prelim Resp. 8. For purposes of this Decision, we adopt Petitioner’s proposal as reasonable and consistent with the ’760 patent specification and the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art may reflect an appropriate level of skill in the art).” slip op. at 9
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for patent owner
“Prelim. Resp. 9 (citing Ex. 1001, 3:15–17, 7:49–51, 8:6–8, 9:10–12). We agree with Patent Owner that “slidably” in claim 1 requires that some continuous surface-to-surface contact must occur. Patent Owner further argues, however, that the figures, such as Figure 12A of the ’760 Patent, provide minimal clearance between the remote/latch release. Prelim. Resp. 10–11. These figures merely depict embodiments of an optical fiber connector after final assembly. See, e.g., Ex. 1001, 4:51–57 (stating that Figure 12A depicts “one embodiment” and that Figure 12B is a top view of the Figure 12A connector). We do not discern anything about the word “slidably” or claim 1 that requires minimal clearance after assembly. We also do not discern anything about claim 1 that requires that, for example, the inner portion of the groove slide against the lower portion of the latch release. Rather, the inner portion of the groove must be above to “receive” the lower portion of the latch release. How does it receive it? It does so “slidably.” The recitation is met so long as the inner portion of the groove is configured such that it can receive the lower portion of the latch release via any sliding. Neither the inner portion nor the lower portion, in particular, must have sliding surface-to-surface contact. In a similar way, neither the outer portion of the groove nor the narrower portion of the latch release must have sliding surface-to-surface contact. Thus, rather than importing a minimal clearance requirement into claim 1’s “slidably” recitations and rather than requiring that specific components must slide (when the claim does not state as much), we understand, for example, “the inner portion of the groove being configured to slidably receive the lower portion of the latch release” to mean that the inner portion of the groove has structure capable of receiving the lower portion of the latch release via a sliding motion. Such sliding could include any degree of surface-to-surface contact between parts; for example, the bottom surface of the latch release could slide along the upper surface of the groove. Similarly, “the outer portion of the groove being configured to slidably receive the narrower portion of the latch release” means that the outer portion of the groove has structure capable of receiving the narrower portion of the latch release via a sliding motion.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“connectors. Pet. 14–16. Petitioner argues that Raven teaches a connector that includes two ferrules and that Kuffel teaches an MPO connector that contains MT ferrules. Id. at 15–17 (citing, e.g., Ex. 1003, Fig. 1; Ex. 1004, 5:16–27; Ex. 1007 ¶¶ 150–151). Petitioner argues that a person having ordinary skill in the art would have understood that Kuffel’s MPO connectors (which contain MT ferrules) would be used to increase density within data transmission networks. Id. at 16 (citing, e.g., Ex. 1004, 4:8–14; Ex. 1007 ¶ 147; Ex. 1015; Ex. 1025; Ex. 1027). Petitioner argues that a person having ordinary skill in the art would have modified Raven’s two ferrule connector to use an MT ferrule (as Kuffel teaches) and argues that such a modification would improve Raven’s device in the same way as described in Kuffel. Id. at 17–18 (citing Ex. 1007 ¶¶ 152–154). Petitioner argues that there would have been a reasonable expectation of success in making this modification. Id. at 19 (citing Ex. 1007 ¶ 155). Petitioner argues that the modification (1) is supported by the disclosures of Kuffel and Raven, (2) represents a simple substitution, and (3) would enable Raven to incorporate a multi-fiber connector. Id. at 20–23 (citing, e.g., Ex. 1007 ¶¶ 159–169). Based on the evidence presented, Petitioner adequately establishes that a person having ordinary skill in the art would have had reason to combine the teachings of Raven and Kuffel with a reasonable expectation of success.” slip op. at 20
Claim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 11,415,760 - PTAB · Jul 9, 2024 · IPR2024-00117 · APJ Elizabeth M Roesel · IPR · Institution
Instituted IPR on claims 1–13 on all petitioned grounds; Petitioner showed a reasonable likelihood of prevailing on at least one claim, including anticipation of claim 1 by Nguyen.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the petition and any response “shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons below, we determine that Petitioner establishes a reasonable likelihood that it would prevail with respect to at least one claim, and we institute an inter partes review as to all challenged claims of the ’836 patent.” slip op. at 2
- Novelty / Anticipation (§102) › Prior-art status of a reference › Printed publication / public accessibilityPrinted publication not establishedNot shown unpatentable
“A reference qualifies as a printed publication only if it was publicly accessible before the effective filing date of the challenged patent. 35 U.S.C. § 102(a)(1); M & K Holdings, Inc. v. Samsung Electronics Co., Ltd., 985 F.3d 1376, 1379 (Fed. Cir. 2021). Public accessibility “has been called the touch-stone” in determining whether a reference qualifies as a printed publication. M & K Holdings, 985 F.3d at 1379 (quoting Acceleration Bay, LLC v. Activision Blizzard Inc., 908 F.3d 765, 772 (Fed. Cir. 2018)). “A reference will be considered publicly accessible if it was disseminated or otherwise made available to the extent that persons interested and ordinarily skilled in the subject matter or art exercising reasonable diligence, can locate it.” Id. (quotes and citations omitted).” slip op. at 8
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“2. Independent Claim 1 a. Preamble Petitioner contends that Nguyen discloses the claim 1 preamble, which recites “an adapter for mating with optical fiber connectors.” Ex. 1001, 18:12. Pet. 32–33 (citing Ex. 1005 ¶¶ 26–30, Figs. 1, 2). We find that Petitioner’s contention for the claim 1 preamble is adequate for purposes of institution.” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“2. Reasons to Combine Petitioner contends that it would have been obvious to modify Nguyen’s adapter in two ways. Pet. 54. First, Petitioner asserts it would have been obvious to include “optical-fiber connectors that employ handles configured to remotely release connectors from the adapter” by replacing Nguyen’s connectors with Lee’s connectors. Pet. 54–56 (citing Ex. 1003 ¶¶ 289–295). Second, Petitioner asserts it would have been obvious to include “a transverse wall that includes slots halfway between two ends of the adapter and sleeve holders that employ sockets to mate with cylindrically-shaped ferrules” by replacing Nguyen’s wall with Lee’s sleeve holders. Pet. 54, 56 (citing Ex. 1003 ¶¶ 296–302). Petitioner provides several reasons for the first modification, including a desire for convenience, tightly packed fiber optic ferrules, ease of maintenance, and scalability. Pet. 54 (citing Ex. 1003 ¶¶ 289–290). According to Petitioner, these goals would be served because “Lee’s handle allows a user to disengage the latch arm further from the adapter” whereas “[t]he latch arms of Nguyen require a user to be closer to the adapter.” Id. (citing Ex. 1003 ¶ 289). Petitioner also provides reasons for the second modification, asserting that “Lee’s sleeve holders are easy to maintain because they are removable, able to snap into place, and coordinate with dust caps to maintain cleanliness, as opposed to Nguyen’s immobile wall.” Pet. 56 (citing Ex. 1003 ¶ 297). According to Petitioner, “a POSITA would have been motivated to modify Nguyen’s adapter to incorporate Lee’s sleeve holders and slots to provide a system that is easier to maintain.” Id. (citing Ex. 1003 ¶¶ 298–299). We find that Petitioner’s asserted rationale for modifying Nguyen in view of Lee is adequate for purposes of institution.” slip op. at 20
Claim construction§ 102 anticipation§ 103 obviousnesscites GrahamPatents in suitUS 11,333,836 - Inductev, Inc. v. Witricity CorporationInstitutedPTAB · May 20, 2024 · IPR2024-00140 · APJ Christopher L Ogden · IPR · Institution
The Board instituted IPR on claims 1, 4–10, 12–16, 18, and 19 on all petitioned grounds, finding a reasonable likelihood of prevailing on at least one claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“under 37 C.F.R. § 42.4(a), we may institute an inter partes review when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a); see also 37 C.F.R. § 42.108(c). Applying that standard, we institute an inter partes review of all the challenged claims of the ’654 patent for the reasons explained below. This is a preliminary decision, and we will base our final written decision on the full trial record.” slip op. at 2
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“First, although InductEV disagrees that the word antenna would exclude coils found within a transformer-like structure, InductEV does not appear to dispute WiTricity’s proposed IEEE definition of antenna as “a device that radiates and/or receives radio waves.” See Prelim. Reply 2–3. We preliminary adopt that construction. But we agree with InductEV that nothing in this construction would exclude a coil found within a transformerlike structure, so long as it either transmits or receives radio waves. We also note that, although WiTricity relies on the generation of near-field flux lines into free space as a way to distinguish an antenna from a transformer, WiTricity does not point to any testimonial or other evidence that a transformer coil does not generate near-field flux lines into free space. See, e.g., Prelim. Resp. 8–16; Ex. 2001, 20–37. Second, we agree with InductEV that the preliminary evidence does not suggest (and WiTricity does not explicitly argue) that the terms transmitting antenna or receiving antenna depart from the ordinary and customary meanings of those terms. Pet. 2. The ’654 patent does refer to a “coupling-mode region” consisting of the area around antennas 114 and 118 of Figure 1 in which “near-field coupling may occur.” Ex. 1001, 2:38–40; see supra Section II.A. But this is the region in which “efficient energy transfer occurs by coupling a large portion of the energy in the near-field of the transmitting antenna to a receiving antenna rather than propagating most of the energy in an electromagnetic wave to the far field”—not a defining characteristic of either the transmitting or receiving antenna. See Ex. 1001, 2:31–38. Thus, for this decision, we preliminarily adopt InductEV’s proposed construction of transmitting antenna as “an antenna that transmits energy” and the proposed construction of receiving antenna as “an antenna that receives energy.” Prelim. Reply 1. This appears to be consistent with the ordinary and customary meaning of the terms and their usage in the ’654 patent. See, e.g., Ex. 1001, 2:26–40. As this is a preliminary construction solely for this decision, the parties may continue to offer evidence and arguments as to these or other claim terms at trial. We do not need to construe any of the other terms explicitly for this decision. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))).” slip op. at 10
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“To show anticipation under § 102, a petitioner must locate each and every element in a claim, arranged as recited in the claim, in a single prior art reference. See Net MoneyIN, Inc. v. VeriSign, Inc., 545 F.3d 1359, 1369 (Fed. Cir. 2008). The limitations may be present in the reference “either explicitly or inherently.” In re Schreiber, 128 F.3d 1473, 1477 (Fed. Cir. 1997). In making this determination, we consider the reference “together with the knowledge of one of ordinary skill in the pertinent art.” In re Paulsen, 30 F.3d 1475, 1480 (Fed. Cir. 1994) (citing In re Samour, 571 F.2d 559, 562 (CCPA 1978)).” slip op. at 12
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“Alternatively, if WiTricity is correct that alignment based on the degree of coupling is not explicitly applicable to the “parked” embodiment, the preliminary evidence suggests that a person of ordinary skill in the art would have had reason to substitute such alignment for alignment based on the output of the sensors that Ross discloses, such as optical sensors, and that this would have predictably led to aligning the two coils regardless of whether the vehicle is parked temporarily on a roadway or parked in a loading/unloading zone. See Ex. 1003 ¶¶ 246–248 (opining that a person of ordinary skill would have understood that one may obtain the “optimum lateral position” of the vehicle coil by sensing the degree of coupling “[i]nstead of” using sensors (quoting Ex. 1007, 13:21))); KSR, 550 U.S. at 416 (“[W]hen a patent claims a structure already known in the prior art that is altered by the mere substitution of one element for another known in the field, the combination must do more than yield a predictable result.”); Intel Corp. v. PACT XPP Schweiz AG, 61 F.4th 1373, 1380 (Fed. Cir. 2023) (“[I]f there’s a known technique to address a known problem using ‘prior art elements according to their established functions,’ then there is a motivation to combine.” (citing Intel Corp. v. Qualcomm Inc., 21 F.4th 784, 799–800 (Fed. Cir. 2021))). We also find persuasive, on the present record, InductEV’s argument that claim 13 does not require control based on the degree of inductive coupling while the receiving antenna is being guided into the recited “first alignment position.” See Prelim. Reply 5. Whereas limitation 13[b] requires such control after the receiving antenna is already in the “first alignment position” (e.g., during fine alignment while Ross’s vehicle is parked in the loading/unloading zone), there is no such requirement in limitation 13[a] while the receiving antenna is being moved to the “first alignment position” (e.g., while Ross’s vehicle leaves the electrified roadway and parks in the loading/unloading zone).” slip op. at 26
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,466,654
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.