- PTAB · Nov 13, 2025 · IPR2025-00805 · APJ Eric C Jeschke · IPR · Institution
The Board instituted IPR on claims 1–24 and all asserted grounds, finding a reasonable likelihood that Petitioner would prevail on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. See 35 U.S.C. § 314; 37 C.F.R. § 42.4(a) (2024) (“The Board institutes the trial on behalf of the Director.”). Inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314. Upon consideration of the evidence and arguments in the record, for the reasons below, we determine that the information presented shows a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims. We thus institute inter partes review on all challenged claims on all asserted grounds. See SAS Inst. Inc. v. Iancu, 584 U.S. 357, 362–63, 369–70 (2018); 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”).” slip op. at 2
- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsNot reached
“C. Patent Owner’s Arguments Under 35 U.S.C. § 325(d) In the Preliminary Response, Patent Owner contends that Petitioner’s unpatentability arguments presented in this proceeding were previously considered by the USPTO. See Prelim. Resp. 31–33. In her decision referring this matter to the Board, then-Acting Director Stewart rejected that argument. See Paper 20 at 2–3 (discussing why “Petitioner provides persuasive reasoning, supported by evidence, that discretionary denial under 35 U.S.C. § 325(d) is not appropriate”); see also Prelim. Resp. 31–33 (referring to and citing Patent Owner’s Discretionary Denial Brief (Paper 8)). We need not and do not address this issue further.” slip op. at 15
- Skill levelSkill level petitioner adoptedDecided for petitioner
“For purposes of this Decision, we adopt the definition of the level of ordinary skill in the art proposed by Petitioner. As to the inclusion of physics in Petitioner’s definition, Dr. Singhose (a professor of mechanical engineering) testifies as to why undergraduate mechanical engineering degree holders would have the requisite knowledge here, but does not testify that undergraduate physics degree holders would not. See Singhose Decl. ¶¶ 2, 27, 28. In addition, Patent Owner and Dr. Singhose require “a four-year degree in mechanical engineering or a closely related field,” but fail to identify what fields are “closely related.” See Prelim. Resp. 11; Singhose Decl. ¶ 27. Based on the Morse Declaration, we are persuaded at this stage that a hypothetical undergraduate physics degree holder would have adequate knowledge for one of ordinary skill in the art of the invention here. See Morse Decl. ¶ 31. As to the requisite years of experience proposed in the definitions— three for Petitioner versus “at least one” for Patent Owner—we note that Patent Owner’s definition is broader than, but includes, Petitioner’s definition. Moreover, for both the inclusion of physics and the years of experience issues, Patent Owner acknowledges that the arguments in the Preliminary Response “are not impacted based on which definition is applied.” Prelim. Resp. 12 (citing Singhose Decl. ¶¶ 30–34). Further, Patent Owner does not argue at this stage that Petitioner’s proposal for the level of ordinary skill leads to an improper understanding of how a skilled artisan would understand either the challenged patent or the prior art.” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“B. Claim Construction In inter partes reviews, the Board interprets claim language using the same claim construction standard that would be used in a civil action under 35 U.S.C. § 282(b), as described in Phillips v. AWH Corp., 415 F.3d 1303 (Fed. Cir. 2005) (en banc). See 37 C.F.R. § 42.100(b). Under that standard, we generally give claim terms their ordinary and customary meaning, as would be understood by a person of ordinary skill in the art at the time of the invention, in light of the language of the claims, the specification, and the prosecution history. See Phillips, 415 F.3d at 1313–14. Although extrinsic evidence, when available, may also be useful when construing claim terms under this standard, extrinsic evidence should be considered in the context of the intrinsic evidence. See id. at 1317–19. Petitioner does not propose express constructions for any claim terms. Pet. 12. Patent Owner also does not propose any express constructions. See Prelim. Resp. 12. On the current record, we need not construe explicitly any claim terms. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). As discussed below, however, the parties dispute the meaning of “gaseous fuel.” We address this issue below in the analysis of the challenge to claims 1–3, 5–9, and 18 based on Nakafushi and Olmr.” slip op. at 12
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites PhillipsPatents in suitUS 10,393,034 - PTAB · Oct 16, 2025 · IPR2025-00711 · APJ Linda E Horner · IPR · Institution
The Board instituted IPR on claims 1, 2, 4–7, 9, 11–13, 15, 19, 23, 24, and 29 based on a reasonable likelihood of success on the § 103 challenges.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the petition and the preliminary response shows “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” Upon consideration of the Petition and the Preliminary Response, and for the reasons explained below, we determine that Petitioner has shown a reasonable likelihood that it would prevail with respect to at least one of the challenged claims. Thus, we grant the Petition and institute an inter partes review of claims 1, 2, 4–7, 9, 11‒13, 15, 19, 23, 24, and 29 of the ’164 patent.” slip op. at 2
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Cir. 2012). “The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (alteration in original) (quoting Vivid Techs., Inc. v. Am. Sci. Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Petitioner argues that it is not necessary for us to provide an express construction for any claim term because the Petition “establishes the prior art meets each claim limitation under any reasonable construction.” Pet. 13. Patent Owner similarly submits that we “need not construe any terms at this stage, because under any reasonable construction of the claim terms, the prior art fails to disclose or suggest the claimed features.” Prelim. Resp. 9. At this stage of the proceeding, we do not need to expressly construe any claim terms to determine whether Petitioner showed a reasonable likelihood of prevailing as to its challenge of at least one challenged claim.” slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundInstituted
“Kelly discloses that game processor 12 implements the functions of game unit 10 during a game process and includes several input and output functions (Ex. 1005, 9:15–18), including: The game processor controls the game apparatus by receiving inputs from a player, from other game apparatuses, from a server (described below), from a progressive bonus apparatus, and from other sources. The game processor also controls output signals to update the game process when appropriate. In addition, the game processor controls the redemption system of the present invention by calculating when prizes are awarded, calculating and updating prize lists and prize costs, and other functions, as described below. Ex. 1005, 9:18–27. As to the redemption system, Kelly discloses prize table 480 that is displayed to the operator. Ex. 1005, 34:64–65, Fig. 9a. In one embodiment, the operator can adjust prize characteristics for the game unit and any linked game units. Id. at 35:1–2. Kelly also discloses an alternative embodiment, however, in which selection of a specific prize from the table 480 can be based on random and/or statistical determination. Id. at 36:48–49. In this alternative embodiment, “random determination of whether a particular prize is to be awarded is also modified by statistical information to create a ‘best fit’ of prizes awarded according to the operator’s desired odds.” Id. at 36:63–66. awarded every 8,000 games, so if it is randomly determined that a third video console is to be awarded within, for example, the 3000th game, then a different prize, e.g., the next most valuable prize, can be awarded so that the desired odds are better met. Id. at 37:1–9. Thus, we find Petitioner has set forth sufficient evidence to show a reasonable likelihood that Kelly’s game processor can modify the variable parameters of the prizing structure to meet the mandated parameters of the desired odds, as called for in limitation [1.c.v].” slip op. at 23
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportReference is prior artOther
“To remove Walker as prior art under §§ 102(a) and 102(e), Patent Owner must show either it reduced the invention to practice prior to Walker’s effective date, or that it invented prior to Walker’s effective date. In the case of the latter, Patent Owner must demonstrate conception prior to May 1, 2003, and reasonably continuous diligence throughout the entire critical period, which begins just prior to the Walker’s effective date and ends on the date of the invention’s actual or constructive reduction to practice. Patent Owner provides evidence purporting to show that it conceived of the invention prior to May 1, 2003. Patent Owner has not asserted that this evidence demonstrates actual reduction to practice, nor do we have sufficient evidence at this stage to make that determination. Further, Patent Owner’s earliest possible constructive reduction to practice (September 1, 2004) does not pre-date Walker’s effective date. Thus, at this stage, Patent Owner would need to show it invented prior to Walker’s effective date through evidence of conception and reasonable diligence to remove Walker as prior art. At this stage of the proceeding, without Patent Owner’s evidence of diligence, Patent Owner has not provided sufficient evidence to show that Petitioner fails to show a reasonable likelihood of prevailing in establishing that Walker is prior art. This issue of whether Walker is prior art to the ’164 patent will benefit from further development of the record during the trial proceeding.” slip op. at 31
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,335,164 - PTAB · Oct 16, 2025 · IPR2025-00712 · APJ James A Tartal · IPR · Institution
The Board instituted inter partes review of claims 1, 3–9, 13, 17, 18, 23, 25, 26, 28, and 29 on all asserted grounds, finding a reasonable likelihood of prevailing on claim 1 over Walker.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“review. 35 U.S.C. § 314(b) (2018); 37 C.F.R. § 42.4(a) (2025). An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Upon institution of inter partes review, the review proceeds “on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a). Based on our consideration of the Petition, the Preliminary Response, and the evidence of record, we conclude that the information demonstrates a reasonable likelihood that Petitioner would prevail in showing the unpatentability of at least one of the Challenged Claims. Accordingly, we institute an inter partes review as to the Challenged Claims of the ’279 patent on all grounds asserted in the Petition.” slip op. at 2
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date awardedOther
“application filed November 12, 2021, that asserts the benefit of a series of applications, the earliest of which was filed September 2, 2003. Ex. 1001, codes (22), (45), (60). Petitioner asserts that the Challenged Claims of the ’279 patent “are entitled to an effective filing date of no earlier than September 2, 2003,” consistent with the date of the earliest application identified by the ’279 patent.9 See Pet. 6. For purposes of our analysis on the current record, in this Decision we apply September 2, 2003, as the priority date of the Challenged Claims.” slip op. at 18
- Obviousness (§103) › Motivation to combine / reasonable expectation of successInstituted
“independent claim 1. Pet. 32–63. Petitioner relies on the testimony of Mr. Crevelt in support of its contentions with respect to claim 1. Ex. 1003 ¶¶ 234–286. Further, according to Petitioner, “[n]o findings regarding motivation to combine or reasonable expectation of success are necessary with a single reference ground,” but Walker “teaches that the features of the embodiments are options that can be combined.” Pet. 42 n.6 (citing Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1372–73 (Fed. Cir. 2019). At this stage, Patent Owner does not contest Petitioner’s proffered assertions about the” slip op. at 20
§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,393,279 - PTAB · Oct 16, 2025 · IPR2025-00708 · APJ James A Tartal · IPR · Institution
The Board instituted IPR on all challenged claims and grounds, finding a reasonable likelihood that claims 1, 3–5, 12, 13, 18–20, 22, 24–26, 29, 42, 44–47, and 50 are unpatentable over Walker and Schneier.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority to determine whether to institute an inter partes review. 35 U.S.C. § 314(b) (2018); 37 C.F.R. § 42.4(a) (2025). An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Upon institution of inter partes review, the review proceeds “on all of the challenged claims and on all grounds of unpatentability asserted for each claim.” 37 C.F.R. § 42.108(a). Based on our consideration of the Petition, the Preliminary Response, and the evidence of record, we conclude that the information demonstrates a reasonable likelihood that Petitioner would prevail in showing the unpatentability of at least one of the Challenged Claims. Accordingly, we institute an inter partes review as to the Challenged Claims of the ’336 patent on all grounds asserted in the Petition.” slip op. at 2
- Skill levelSkill level board ownOther
“B. Level of Ordinary Skill in the Art At this stage of the proceeding, there is no evidentiary dispute about the level of ordinary skill in the art.8 Based on the testimony of Mr. Crevelt, we determine that a person of ordinary skill in the art would have had at least a bachelor’s degree in computer science or computer engineering, with at least three years of experience in game development. Pet. 14 (citing Ex. 1003 ¶¶ 62–65). Additional experience could substitute for less education, and additional education could likewise substitute for less experience. Id. We determine that the level of ordinary skill in the art 7 Petitioner states that it is not aware of secondary considerations that affect the obviousness arguments it presents. Pet. 66. Patent Owner has not offered objective evidence of nonobviousness at this stage of the proceeding. 8 Patent Owner “disagrees with the proposed level of skill” but asserts that “under any level of skill a [person of ordinary skill in the art] would not understand the asserted Grounds to raise any unpatentability issues.” Prelim. Resp. 8. Thus, Patent Owner does not present evidence or arguments in its Preliminary Response related to the level of ordinary skill in the art. competence reflected in the ’336 patent Specification and the asserted prior art references, based on our review of the limited record.” slip op. at 11
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“standard as would be used by a district court to construe a claim in a civil action involving the validity or infringement of a patent. 37 C.F.R. § 42.100(b). Under that standard, claim terms are given their ordinary and customary meaning, as would have been understood by a person of ordinary skill in the art at the time of the invention, in light of the language of the claims, the specification, and the prosecution history of record. Id.; see also Phillips v. AWH Corp., 415 F.3d 1303, 1312–19 (Fed. Cir. 2005) (en banc); Thorner v. Sony Comput. Entm’t Am. LLC, 669 F.3d 1362, 1365–66 (Fed. Cir. 2012). “The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (alteration in original) (quoting Vivid Techs., Inc. v. Am. Sci. Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)). Petitioner argues that it is not necessary for us to provide an express construction for any claim term because the Petition “establishes the prior art meets each claim limitation under any reasonable construction.” Pet. 14–15. Patent Owner similarly submits that we “need not construe any terms at this stage, because under any reasonable construction of the claim terms, the prior art fails to disclose or suggest the claimed features.” Prelim. Resp. 8. At this stage of the proceeding, we do not need to expressly construe any claim terms to determine whether Petitioner showed a reasonable likelihood of prevailing as to its challenge of at least one challenged claim.” slip op. at 12
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date awardedOther
“an application filed September 20, 2010, that asserts the benefit of an application filed September 2, 2003. Ex. 1001, codes (22), (45), (54), (62). Petitioner asserts that the Challenged Claims of the ’336 patent “are entitled to an effective filing date of no earlier than September 2, 2003,” consistent with the date of the earliest application identified by the ’336 patent.9 See Pet. 7. For purposes of our analysis on the current record, in this Decision we apply September 2, 2003, as the priority date of the Challenged Claims. Walker was filed on May 1, 2003, and refers back to a provisional application filed on May 6, 2002, but Walker was not published until January 1, 2004. Ex. 1006, codes (22), (43), (60). Thus, Petitioner fails to show on the current record how, under pre–AIA 35 U.S.C. § 102(a), Walker discloses an invention that was described in a printed publication in this country before the invention thereof by the Patent Owner, because Walker was published after the applied priority date of the Challenged Claims of the’336 patent.” slip op. at 17
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,529,336 - PTAB · Jun 11, 2025 · IPR2025-00261 · APJ Mitchell G Weatherly · IPR · Institution
Instituted IPR of claims 1–20 on all grounds after finding a reasonable likelihood that Haley anticipates claims 1, 7, 8, 17, and 20 and Haley with Lai renders the remaining claims obvious.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition filed under section 311 and any response filed under section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Based on our review of the record,1 we conclude that Petitioner is reasonably likely to prevail with respect to at least one of the challenged claims.” slip op. at 2
- Other 314aInstitution denied discretionary otherDenied
“Patent Owner argues that we should discretionarily deny the Petition based on alleged deficiencies in the Petition. Specifically, Patent Owner argues that “even if arguments as to a few claims might have been properly presented in the Petition, a decision to institute here would require the Board to address—for the first time and with no Petitioner input—critical claim construction issues affecting nearly every claim” in contravention of the requirements of 37 C.F.R. § 42.104(b)(3). Prelim. Resp. 33–35. For the reasons discussed above, we are not persuaded on the current record that Petitioner has violated 37 C.F.R. § 42.104(b)(3), or that critical and unresolved claim interpretation issues justifying discretionarily denying the Petition exist. We, therefore, decline to deny institution on this basis. E. Claims 1, 7, 8, 17, and 20: Anticipation by Haley” slip op. at 11
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesDecided for petitioner
“1. Lifter The Petition contends that the “lifter” limitation is a means-plus- function limitation, Pet. 7, which Patent Owner does not dispute, Prelim. Resp. 10–14. Patent Owner argues, however, that Petitioner has “fail[ed] to identify any structure in the ’007 Patent to perform the claimed function.” Prelim. Resp. 10. We disagree. Petitioner identifies the structures in the Specification corresponding to the “lifter” as follows: The “lifter” (“lifter member”) of the ’007 patent includes a rotatable cam lifter 100 (yellow below left), with pin 104, 106, and 108 (green) on its face surface that engage protrusions 92 (blue) on the driver member 90 (orange). ’007 patent, 9:36–52, 16:39–53, Fig. 12. The ’007 patent also discloses two-pin variants: lifter members 465 and 480 in Figs. 31, 33. ’007 patent, 32:23–38, 32:56–33:4. Pet. 17. This identification of corresponding structure is sufficient to satisfy 37 C.F.R. § 42.104(b)(3). We also note that at this stage of the proceeding, Patent Owner does not dispute that Petitioner has correctly identified the corresponding structure. The parties may further address the proper interpretation of “lifter” at trial.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“gas pressure system” recited in the preamble of independent claims 1 and 17. Prelim. Resp. 21–22. Patent Owner further argues that Petitioner, through its comparison of claims 1 and 17 to Haley, improperly implies that the “gas pressure system” can be “limited to a distinct portion of a power tool.” Id. at 23. Patent Owner contends that such an interpretation is improper because the “gas pressure system” must refer to “the entire system,” because the “structure of the claims themselves . . . include[s] . . . every component of the tool.” Id. We disagree. The “gas pressure system” recited in the preambles of claims 1 and 17 expressly refers to a system that is “for a power tool” and thus does not necessarily refer to “the entire” tool or “every component of the tool.” Ex. 1001, 39:6 (claim 1), 40:51 (claim 17). Neither claim 1 nor claim 17 recites, for example, the lifter or driver, which are required elements of an “entire” tool. Id. at 39:6–22 (claim 1), 40:51–67 (claim 17). The lifter and driver are introduced in dependent claims 2 and 18. Id. at 39:23–30 (claim 2), 41:1–9 (claim 18). Still other necessary components of a tool, e.g., a motor and power source, are introduced in dependent claims 5 and 19. Id. at 39:40–42 (claim 5), 41:10–13 (claim 19). By contrast to claims 1 and 17, independent claims 9 and 14 recite a “portable fastener driving tool” and expressly recite many necessary components of such a tool including the driver, lifter, prime mover, and power source. Id. at 39:54 (claim 9), 40:20 (claim 14). Accordingly, we find that the “gas pressure system” of claims 1 and 17 broadly refers to a portion of a power tool rather than the “entire system” or “every component of the tool.” slip op. at 8
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSRPatents in suitUS 11,034,007 - Siemens Industry Software Inc. v. Synopsys, Inc.Some claims unpatentablePTAB · Jan 11, 2023 · IPR2021-01215 · APJ Michael T Cygan · IPR · Final written decision
Claims 1–5, 7, 8, 11–15, 17, 18, and 21–24 are unpatentable over Yoshimura-based grounds; claims 6, 9, 10, 16, 19, and 20 were not shown unpatentable.
RulingsFinal written decision- Skill levelSkill level board ownOther
“B. Level of Skill in the Art Petitioner offers an assessment as to the level of skill in the art as of the time the ’655 patent was filed. Pet. 9. For purposes of this proceeding, Petitioner and Petitioner’s declarant “adopt the [following] definition for the person of ordinary skill in the art”: “a Bachelor of Science degree in Electrical Engineering or Computer Engineering, and has either received academic credits for an ASIC design course or completed at least one year of work experience in the VLSI design, electronic design automation for VLSI, or ASIC design fields.” Id. at 9–10; Ex. 1003 ¶ 78 (Robins Declaration). Patent Owner applies the same definition. Resp. 5. To the extent necessary, we accept this definition because it is supported by the Robins Declaration and consistent with the ’655 patent and the asserted prior art.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed patent owner constructionDecided for patent owner
“Although the phrase “separate from,” is not found in the claims, we look to the language of the claims, the description in the patent disclosure, and the prosecution history to determine what type of separateness is required by the claims. We start with the relied-upon Figure 4 of the ’655 patent, which illustrates a box labeled “Multi-Scenario ECO Database 426” that is near, but not overlapping with or surrounding, boxes labeled “Image 424” through “Image 422” and “Image 420.” Ex. 1001, Fig. 4. The ’655 patent also describes a storage device 408 as “storing scenario images 420– 424 that correspond to different scenarios,” and “can additionally store multi-scenario ECO database 426,” which “can include circuit information for multiple scenarios that can be used to estimate the impact of ECOs in multiple scenarios.” Ex. 1001, 5:9–11, 5:18–21.” slip op. at 9
- Prior constructionPrior construction adoptedDecided for patent owner
“determin[e/ing . . . ] an ECO to fix one or more design requirement violations, wherein said determining includes identifying an ECO to fix a design requirement violation in the scenario and checking that ECO against at least some of the multiple scenarios by estimating parameter values based on parameter values stored in the scenario image and the multi-scenario ECO database. Resp. 10 (citing Ex. 2001, 21-24). In reviewing the term, the District Court explained that the multi- scenario ECO database “stores parameters and allows for a quick estimation of an ECO’s impact across multiple scenarios.” Ex. 2001, 19. The District Court further summarized the ’655 patent as describing that a scenario image is “[f]irst” loaded, and if there is a design requirement violation, an ECO is determined for that scenario, and then subsequent scenarios are loaded to check whether the ECO from the first scenario will create new, or exacerbate existing, design violations. Id. (citing Ex. 1001, 4:21–33). However, as recognized by the Court, the process at the cited section is described in the ’655 patent as an “approach [that] may take an impracticably long time to fix design requirement violations in multiple scenarios” due to the long time that is required to load a scenario image. Id. at 24; Ex. 1001, 4:43–47. The Court reasoned that in order to determine an ECO to fix a violation, “determine” must involve “identifying” a possible fix and “checking” whether that fix is suitable. Id. at 23. Thus, the District Court’s construction requires both identifying and checking as part of the claimed determining step. Id. at 23–24. We agree with the District Court’s reasoning, and apply their construction in this proceeding.” slip op. at 11
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)UnpatentableUnpatentable
“Petitioner assertion that Yoshimura’s estimation in step S5 is performed to check an identified ECO is supported by the record. In determining the change to be made (the ECO), Yoshimura uses estimated parameters for the third and fourth corner conditions, calculated in step S5 through the “Hold Margin” equation. Ex. 1007, 6:63–67. Those third and fourth corner conditions are then used to check potential layouts identified in step S6. Id. at 7:18–20 (“In step S6, the automatic EC device 16 searches for a layout that does not cause a timing error under any one of the first to fourth comer conditions from the analysis results of step S4 and step S5.”). In this manner, step S5 sets an initial third corner condition having estimated parameter values that is included, as the initial step, in checking an identified ECO at steps S6–S8. Thus, Yoshimura’s determination of a change to satisfy the corner conditions is, to use Dr. Edward’s phrase, “based on” its third and fourth corner conditions having parameters estimated in step S5. For this reason, we determine that Petitioner has sufficiently shown that Yoshimura discloses the claimed limitation.” slip op. at 20
Patent outcomesUS 8,407,655 mixedClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 8,407,655 - Helen Of Troy Limited v. Tomy International, Inc.Institution deniedPTAB · Feb 7, 2022 · IPR2021-01208 · APJ Frances L Ippolito · IPR · Institution
The Board denied institution on claims 1–21 because the Petition did not show a reasonable likelihood of prevailing on anticipation by Song or obviousness over Song alone, with Kilion, or with Kassai.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless the information presented in the Petition and any response thereto shows “there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” For the reasons set forth below, upon considering the Petition, Preliminary Response, and evidence of record, we determine the information presented in the Petition does not establish a reasonable likelihood that Petitioner would prevail with respect to at least one of the challenged claims. Accordingly, we do not institute inter partes review.” slip op. at 2
- Skill levelSkill level petitioner adoptedOther
“problems encountered in the art, the prior art solutions to those problems, the rapidity with which innovations are made, the sophistication of the technology, and the educational level of active workers in the field. Custom Accessories, Inc. v. Jeffrey-Allan Indus. Inc., 807 F.2d 955, 962 (Fed. Cir. 1986); Orthopedic Equip. Co. v. U.S., 702 F.2d 1005, 1011 (Fed. Cir. 1983). Petitioner contends that a person of ordinary skill in the art (“POSITA”) at the time of the invention of the ’176 patent “would be someone with a Bachelor’s degree in industrial design or furniture design with a focus on designing adjustable or reconfigurable furniture, or with one to two years of experience designing adjustable furniture or other products for infants or children.” Pet. 9 (citing Ex. 1002 ¶ 10). Patent Owner indicates that it “does not submit a different level of ordinary skill than the Petitioner.” Prelim. Resp. 11. For purposes of this Decision, we adopt Petitioner’s proposal as reasonable and consistent with the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (the prior art may reflect an appropriate level of skill in the art).” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner states that it “does not believe any special claim constructions are required for the Board to conclude that the asserted prior art renders the challenged claims unpatentable.” Pet. 9. Patent Owner generally agrees, stating that “the Board does not need to construe the claims to deny institution.” Prelim. Resp. 11. We determine that for the purposes of this Decision, it is unnecessary to expressly construe these claim terms. See Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999) (Only terms in controversy must be construed and only to the extent necessary to resolve the controversy); see also Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (citing Vivid Techs in the context of an inter partes review).” slip op. at 8
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“that Patent Owner has the better position. With respect to Petitioner’s annotated versions of Song’s Figures 2 and 3, we agree that Petitioner’s arguments are not supported. To be sure, drawings may be relied upon for the purposes of anticipation. In re Bager, 47 F.2d 951, 953 (CCPA 1931) (“Description for the purposes of anticipation can be by drawings alone as well as by words.” (citation omitted)). Nonetheless, an ambiguous reference cannot anticipate a claim. Wasica Finance GmbH v. Continental Automotive Sys., Inc., 853 F.3d 1272, 1284 (Fed. Cir. 2017). With respect to Figure 3, Song does not expressly teach that the bottom portion of water tank 3 is rigid. Rather, Song teaches that water tank 3 is made with foldable wall 2 that can be folded inward. Ex. 1005, 3. The support legs are also foldable to the inside of support levers 4 and each part can be joined and affixed in a small volume. Id. In other words, the walls, legs, and levers are folded together into a small volume to make the bathtub “convenient to carry.” Id. As such, we agree with Patent Owner that Figure 3 may very well depict the folded bathtub with a taut or folded wall (including the tank bottom) rather than a rigid material. The point, here, though is that we cannot tell from Figure 3 why the tank bottom is depicted as it is shown. Moreover, Song’s express description of the folded bathtub shown in Figure 3 does not support Petitioner’s position that the straight tank bottom must be rigid. Similarly, it is ambiguous as to whether Figure 2 uses cross-hatching to depict a rigid material for any illustrated structural components. Indeed, the left-side leg attachment of Figure 2 shows white dots against black. Id. at Fig. 2. But at the opposite side, the companion leg attachment near “6” does not show the same pattern. Id. Moreover, lid body 9, which is made from a synthetic resin, has no cross-hatching. Id. Further, the pattern presented in the magnified version (provided by Patent Owner) of Figure 2 shows uneven and inconsistent markings at the bottom of water tank 3. Thus, it is unclear whether the identified portion at the tank bottom contains any cross-hatching or intentional markings. Likewise, even if we were to apply purported drafting conventions (e.g., MPEP § 608.02) to a Japanese patent application, the relied upon markings shown in Figure 2 still do not show cross-hatching “with sufficient precision and detail to establish that the subject matter existed in the prior art.” Wasica Finance GmbH v. Continental Automotive Sys., Inc., 853 F.3d 1272, 1284 (Fed. Cir. 2017) (quoting Verve, LLC v. Crane Cams, Inc., 311 F.3d 1116, 1120 (Fed. Cir. 2002)).” slip op. at 15
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 9,545,176 - PTAB · Jan 13, 2022 · IPR2021-01215 · APJ Michael T Cygan · IPR · Institution
The Board instituted IPR on claims 1–24 and all petitioned grounds, finding a reasonable likelihood of prevailing on at least one claim, including over Yoshimura and Srinivas.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Institution denied discretionary otherDenied
“pending resolution of the PTAB trial allays concerns about inefficiency and duplication of efforts.” Fintiv, Paper 11 at 6. On the record before us, Petitioner has not produced evidence that a stay for the results of the instant inter partes review has been requested. The district court stay currently in force is for a limited time, until February 2022. Thus, the stay will expire approximately one month after issuance of this decision on institution. The effect of the current stay on the pending inter partes review proceeding would be extremely minimal, and would not appear to meaningfully allay any concerns of inefficiency or duplication of efforts. Furthermore, the parties’ reliance on other cases in which the district court judge considered requests for stay is misplaced. As the Board has explained, “[a] judge determines whether to grant a stay based on the facts of each specific case as presented in the briefs by the parties.” See Apple Inc. v. Fintiv, Inc., IPR2020-00019, Paper 15, 12 (PTAB May 13, 2020) (informative) (“Fintiv II”). “We decline to infer, based on actions taken in a different case with different facts, how the District Court would rule should a stay be requested by the parties in the parallel case here.” Id. Accordingly, we find that this factor is neutral; i.e., it does not weigh for or against exercising our discretion to deny institution.” slip op. at 7
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“partes review (“IPR”) of claims 1–24 of U.S. Patent No. 8,407,655 B2 (Ex. 1001, “the ’655 patent”). Paper 2 (“Pet.”). Patent Owner, Synopsys, Inc., (“Patent Owner”), filed a Preliminary Response. Paper 9 (“Prelim. Resp.”). Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). An inter partes review may not be instituted on fewer than all claims challenged in the Petition. SAS Inst., Inc. v. Iancu, 138 S. Ct. 1348, 1359–60 (2018). Having considered the Petition and the Preliminary Response, we conclude that the information presented in the Petition establishes that there is a reasonable likelihood that Petitioner would prevail in challenging at least one of claims 1–24 of the ’655 patent as unpatentable under 35 U.S.C. §103(a). Pursuant to § 314, we institute an inter partes review as to claims 1–24 of the ’655 patent on all grounds raised in the Petition.” slip op. at 2
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“At this stage of the proceeding, for purposes of institution, Petitioner has provided sufficient explanation, supported by evidence, of how each limitation of these claims is disclosed by Yoshimura. In view of the foregoing, we are persuaded that Petitioner is reasonably likely to prevail on its assertion that claims 1–3, 8, 11–13, 18, 21, and 22 would have been anticipated by Yoshimura.” slip op. at 23
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“Petitioner alleges that a person having ordinary skill in the art at the time the invention was made would have been motivated to use capacitive load values as a parameter value in Yoshimura, because the capacitive load values at the pins affect the rate at which the pins’ voltage can change, and would be needed to determine whether a timing or power requirement has been violated. Id. (citing Ex. 1003 ¶¶ 180–181). Petitioner further alleges that a person having ordinary skill in the art would have had a reasonable expectation of succeeding in including capacitive load values in Yoshimura’s scenario image and/or multi-scenario ECO database, because Yoshimura’s database already includes similar types of parameter values. Id. at 40–41 (citing Ex. 1003 ¶ 181).” slip op. at 26
§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 8,407,655 - Seoul Semiconductor Co., Ltd. / Seoul Semiconductor, Inc. v. Document Security Systems, Inc.All claims unpatentablePTAB · Nov 17, 2021 · IPR2020-00938 · APJ Jason M Repko · IPR · Final written decision
Claims 1–4 and 7 are unpatentable as anticipated by Nichia-614; claims 5 and 6 are unpatentable as obvious over the stated combinations.
RulingsFinal written decision- Skill levelSkill level patent owner adoptedDecided for patent owner
“PO Resp. 9 (quoting Ex. 1007 ¶ 29) (emphasis omitted). Patent Owner does not, however, explain how this difference in experience level would affect our analysis. Indeed, we see nothing in the record that indicates that viewing the ordinarily skilled artisan as having two more years of experience would change the outcome here. To the extent necessary, we apply Patent Owner’s adopted definition above because it is consistent with the ’119 patent and the asserted prior art and is supported by the Doolittle Declaration submitted by Petitioner. But our analysis would be the same under either definition.” slip op. at 7
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed petitioner constructionDecided for petitioner
“16. In particular, the patentee has not defined “conformal” or “substantially uniform” in the patent’s written description. See id. In fact, the terms do not appear in the Specification as originally filed. Id. at 13–14 (citing Ex. 1002, 152–162). And we see no other evidence of lexicography or disavowal with respect to these terms. See Ex. 1001. So, consistent with Petitioner’s articulation of the case law, the terms “conformal” and “substantially uniform” should be given “their ordinary and customary meaning as understood by a person of ordinary skill in the art when read in the context of the specification and prosecution history.” See Thorner v. Sony Comp. Ent. Amer., 669 F.3d 1362, 1365 (Fed. Cir. 2012), cited in Pet. Reply 3. As evidence of the “ordinary usage,” Petitioner cites the patent’s” slip op. at 8
- Claim Construction › Intrinsic evidence (Phillips canons) › Lexicography (patentee as own lexicographer)Term construed petitioner constructionDecided for petitioner
“To be sure, a patent “specification may reveal a special definition given to a claim term.” Phillips, 415 F.3d at 1316. Or it may reveal “an intentional disclaimer, or disavowal, of claim scope.” Id. “The patentee’s lexicography must, of course, appear ‘with reasonable clarity, deliberateness, and precision’ before it can affect the claim.’” Renishaw PLC v. Marposs Societa’ per Azioni, 158 F.3d 1243, 1249 (Fed. Cir. 1998). The patentee can disavow claim scope with language in the specification or the prosecution history. Poly-Am., L.P. v. API Indus., Inc., 839 F.3d 1131, 1136 (Fed. Cir. 2016). “In either case, the standard for disavowal is exacting, requiring clear and unequivocal evidence that the claimed invention includes or does not include a particular feature.” Id. For the phrase “layer of phosphor particles” recited in the claims here, we see no reasonably clear, deliberate, and precise lexicography in the ’119 patent’s written description. When read in context, the sentence that Patent Owner characterizes as definitional simply explains that the drawings are not to scale: To simplify the drawings and better explain the present invention, the above figures show layers of relatively large phosphor particles that are only a few particles thick. However, it is to be understood that the phosphor layers are actually uniform layers constructed from much smaller particles, and the layers are many particles thick.” slip op. at 11
- Claim Construction › Intrinsic evidence (Phillips canons) › Specification disavowal / 'present invention' languageDisclaimer not foundDecided for petitioner
“Patent Owner also quotes the sentence that reads in full: “In the proposed invention, a wavelength converting material such as phosphor is laid over the LED chip in a manner such that substantially all the phosphor particles are in contact with the LED chip and the walls of the cavity where the LED is mounted.” Ex. 1001, 3:16–19, quoted in PO Resp. 11 (emphasis added). The written description also discloses that “the phosphor particles all settle down and are deposited around the LED chip and at least some portions of the cavity walls.” Id. at 4:24–26, quoted in PO Resp. 12. Yet these sentences do not define the term “layer of phosphor” with the reasonable clarity, deliberateness, and precision required to limit the claim as Patent Owner proposes. In fact, the cited passages do not even explicitly use the term “layer of phosphor.” Id. Instead, these sentences describe a single, exemplary embodiment, which is not definitional. See id. Lastly, Patent Owner points to the drawings to support its position. PO Resp. 12 (citing Ex. 1001, Figs. 2–4, 6). But the drawings are merely exemplary, non-limiting embodiments. See Ex. 1001, 5:20–24; supra § II.C.1.b(1). In sum, we see no reason to interpret the claimed “layer of phosphor particles” as limited to the phosphor particles themselves. And we see no requirement in the claims that a “conformal layer of phosphor particles covering said die and in direct contact therewith” requires that the bottom layer of phosphor particles directly contact the LED, as Patent Owner has proposed. PO Resp. 11–13. Rather, consistent with the patent’s written description and the evidence of record, we determine that the recited “layer of phosphor particles” simply requires a layer that includes phosphor particles, without limitation to the position of the bottom phosphor particles relative to the LED.” slip op. at 14
Patent outcomesUS 7,315,119 unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · KSRPatents in suitUS 7,315,119 - Eis GmbH v. Novoluto GmbHNo claims unpatentablePTAB · Sep 23, 2021 · IPR2020-00007 · APJ Susan L C Mitchell · IPR · Final written decision
Claims 1–3, 5, 7, 8, 11, 14, 15, and 17–26 were not shown unpatentable under the Taylor anticipation or Taylor-based obviousness grounds.
RulingsFinal written decision- Expert testimonyPatent owner expert creditedDenied
“disclosure of a suction cup “sealingly” receiving the vulva occurs when the vacuum is applied, not before. See Ex. 2034 ¶ 121. We disagree with Petitioner’s conclusion that “Taylor discloses that arm 26 ‘compresses . . . and then expands bellows 160’ after member 156 ‘sealingly’ engages the vulva.” Reply 9. The single statement in Taylor on which Petitioner relies states, with reference to Figure 3 set forth above in Section II.D.1, “[t]he first stimulator 154 includes a suction cup member 156 that conformingly and sealingly receives the upper portion of the vulva.” Ex. 1004, 5:29–31. We agree with Dr. Jensen that this does not support Petitioner’s conclusion that a seal is achieved before the vacuum is applied, and credit Dr. Jensen’s testimony that reads as follows as consistent with Taylor’s disclosure.” slip op. at 35
- ExcludeMotion to exclude, deniedDenied
“5. Conclusion For the reasons set forth above, we deny the portion of Petitioner’s” slip op. at 73
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“7 Petitioner presents argument that the term “pressure field generator” should be construed as a means-plus-function term limited to the following structure: at least one first chamber, at least one second chamber, and at least one connection element. Reply 25–26. As we find that it is not necessary to construe this term to resolve the issues before us, we do not address these arguments presented by Petitioner.” slip op. at 17
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot shown unpatentable
“disclosure of a suction cup “sealingly” receiving the vulva occurs when the vacuum is applied, not before. See Ex. 2034 ¶ 121. We disagree with Petitioner’s conclusion that “Taylor discloses that arm 26 ‘compresses . . . and then expands bellows 160’ after member 156 ‘sealingly’ engages the vulva.” Reply 9. The single statement in Taylor on which Petitioner relies states, with reference to Figure 3 set forth above in Section II.D.1, “[t]he first stimulator 154 includes a suction cup member 156 that conformingly and sealingly receives the upper portion of the vulva.” Ex. 1004, 5:29–31. We agree with Dr. Jensen that this does not support Petitioner’s conclusion that a seal is achieved before the vacuum is applied, and credit Dr. Jensen’s testimony that reads as follows as consistent with Taylor’s disclosure.” slip op. at 35
Patent outcomesUS 9,849,061 not shown unpatentableClaim construction§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 9,849,061
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.