- PTAB · Nov 10, 2025 · IPR2025-00878 · APJ Carl M Defranco · IPR · Institution
The Board instituted review of claims 1–3 and 11 after finding a reasonable likelihood that claim 1 is anticipated by Cleveland or obvious over Nakagawa.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“contentions, the cited portions of Cleveland, and the testimony of Clearwater’s expert), we find, preliminarily, that Cleveland discloses each claim element in the manner recited by claim 1. Thus, on the current record, Clearwater demonstrates a reasonable likelihood that challenged claim 1 is unpatentable as anticipated by Cleveland.” slip op. at 6
- Novelty / Anticipation (§102) › Prior-art status of a reference › Patents / published applications (effective date, provisional support)Reference is prior artDecided for petitioner
“5 Clearwater argues that Cleveland qualifies as prior art under 35 U.S.C. § 102(e)(1) “based on both its provisional and non-provisional filing dates.” Pet. 17. In support, Clearwater asserts that Cleveland’s provisional (Ex. 1006) is “virtually identical” to Cleveland itself (id. at 18) and submits claim charts to demonstrate that the Cleveland provisional provides written support for: (1) at least claim 1 of Cleveland (id. at 18–21); and (2) the subject matter relied upon in Cleveland (id. at 21–40 (citing Ex. 1006 throughout)). Based on our review of the Cleveland provisional, as well as Clearwater’s claim charts, we are persuaded that the current record demonstrates that Cleveland is prior art to the challenged patent. See Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1381 (Fed. Cir. 2015).” slip op. at 4
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“satisfies each claim element as identified above in Section I.D, i.e., elements [1.pre]–[1.6]. See id. at 22–40. Clearwater also submits annotated Figure 3 of Cleveland, reproduced below, to further illustrate the specific laminate structure of Cleveland’s coffee cup. See id. at 39.” slip op. at 5
- Obviousness (§103) › Motivation to combine / reasonable expectation of successInstituted
“protective layers have “a coat weight of from 5 to 30 lbs/3000 ft2,” Clearwater submits the declaration of its expert, who explains that, because Nakagawa identifies the specific polymers and the thickness of the coat used for the plastic layers and one skilled in the art “would recognize that the disclosed polymers have a given density,” then “[w]ith these known parameters, the coat weight is easily calculated to be 23.04 lbs./ 3000 ft2 — falling squarely within the claimed range.” Pet. 53–54 (citing Ex. 1003 ¶¶ 132–133; Ex. 1008 ¶ 24; Ex. 1024, at 4). At this stage, we find that testimony credible and supported by the evidence presently of record. After reviewing the preliminary record (including Clearwater’s contentions, the cited portions of Nakagawa, and the testimony of Clearwater’s expert), we find, preliminarily, that Nakagawa discloses or otherwise suggests each claim element in the manner recited by claim 1. Thus, on the current record, Clearwater demonstrates a reasonable likelihood that challenged claim 1 is unpatentable as obvious over Nakagawa. We need not decide Clearwater’s challenge of the dependent claims based on Nakagawa alone nor its challenge of claims 1–3 based on Nakagawa and Tanner. Our analysis of these challenges, in our view, is best left for trial after full development of the record.” slip op. at 8
Claim construction§ 102 anticipation§ 103 obviousnesscites PhillipsPatents in suitUS 8,637,126 - PTAB · Nov 6, 2025 · PGR2025-00040 · APJ Kimberly Mcgraw · PGR · Institution
The Board instituted PGR on claims 1–9, 11–33, and 35–38 on all petition grounds, finding it more likely than not that Hassfjell-Hoff anticipates at least claim 1.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 324(a), a post-grant review may be instituted only if “the information presented in the petition . . . demonstrate[s] that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” Post-grant review is available for patents that issue from applications that at one point contained at least one claim with an effective filing date on or after March 16, 2013. See Leahy-Smith America Invents Act, Pub. L. No. 112-29, 125 Stat. 284 (2011) (“AIA”), §§ 3(n)(1), 6(f)(2)(A). After considering the briefing and the evidence of record, for the reasons set forth below, we determine that Petitioner has shown that the ’437 patent is eligible for post-grant review and that it is more likely than not that at least one challenged claim of the ’437 patent is unpatentable under § 324(a). Accordingly, we institute a post-grant review of all challenged claims of the ’437 patent.” slip op. at 2
- Adverse judgmentAdverse judgmentOther
“Here, Patentee Sciencons AS filed a statutory disclaimer of claims 10 and 34 of the ’437 patent. Ex. 2001; Prelim. Resp. 43. Based on our review of Exhibit 2001 and the Office’s public records, we find that the disclaimer of claims 10 and 34 complies with the above-listed requirements of 37 C.F.R. § 1.321(a). Accordingly, we treat claims 10 and 34 as having never been part of the ’437 patent. See Vectra Fitness, Inc. v. TNWK Corp., 162 F.3d 1379, 1383 (Fed. Cir. 1998) (“This court has interpreted the term ‘considered as part of the original patent’ in [35 U.S.C.] § 253 to mean that the patent is treated as though the disclaimed claims never existed.”). Because post-grant review cannot be instituted based on disclaimed claims, claims 10 and 34 are outside the scope of this proceeding. 37 C.F.R. § 42.207(e) (“No post-grant review will be instituted based on disclaimed claims.”); General Elec. Co. v. United Techs. Corp., IPR2017-00491, Paper 9 (PTAB July 6, 2017) (precedential) (denying institution in view of a statutory disclaimer of all the challenged claims). Thus, we confine our analysis in this Decision to claims 1–9, 11–33, and 35– 38, the remaining challenged claims that have not been disclaimed.” slip op. at 6
- PTAB / AIA Trials › Real party in interest / privityGranted
“Sciencons AS also states that ARTBIO, Inc. is responsible for defending the ’437 patent in this proceeding and requests that ARTBIO, Inc. be included in the caption for this proceeding.2 Paper 4, 1. ARTBIO, Inc. has signed powers of attorney appointing the same practitioners that were appointed by Sciencons AS to transact all business associated with the instant post-grant review review of the ’437 patent. See Paper 3. To date, no objection has been raised to Patent Owner’s request. Given Sciencons AS’s representation that ARTBIO, Inc. is currently the exclusive licensee of the ’437 patent and is responsible for defending the ’437 patent, we grant Sciencons AS’s unopposed request that ARTBIO, Inc. be included in the caption. For convenience we refer to Sciencons AS and the purported exclusive licensee ARTBIO, Inc. collectively as “Patent Owner.” As stated supra, to the extent any party disputes ARTBIO, Inc.’s right to participate in this proceeding or to be included in the caption, the party shall request authorization to brief the issue within 10 business days of this Decision.” slip op. at 3
- Skill levelSkill level petitioner adoptedDecided for petitioner
“nuclear chemistry, radiochemistry, or materials science, or a comparable field of study, plus approximately two to three years of professional experience with radioisotope generators, radiopharmaceutical chemistry, nuclear medicine, or other relevant industry experience” and that “[a]dditional graduate education could substitute for professional experience, and significant experience in the field could substitute for formal education.” Pet. 2–3 (citing Ex. 1002 ¶ 33; Ex. 1019 ¶ 27). At this stage of the proceeding, Patent Owner does not dispute Petitioner’s proposed definition nor provide a proposed definition of its own. See generally Prelim. Resp. For the purposes of this Decision, we adopt Petitioner’s undisputed proposed definition of a POSITA.” slip op. at 10
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites PhillipsPatents in suitUS 12,249,437 - Advancell Pty Ltd.InstitutedPTAB · Oct 14, 2025 · PGR2025-00029 · APJ Kimberly Mcgraw · PGR · Institution
The Board instituted PGR on claims 1–6 and 8–20 on all asserted grounds, finding it more likely than not that at least one challenged claim is unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“After reviewing the parties’ briefs and supporting evidence, we determine that Petitioner has sufficiently shown that Hassfjell-Hoff discloses each element of claim 1. As such, Petitioner’s argument and evidence as set forth above and further discussed below, sufficiently shows that it is more likely than not that claim 1 is anticipated by Hassfjell-Hoff, notwithstanding Patent Owner’s arguments, also addressed below.” slip op. at 16
- Adverse judgmentAdverse judgmentOther
“Here, Patentee Sciencons AS filed a statutory disclaimer of claim 7 of the ’603 patent. Ex. 2001. Based on our review of Exhibit 2001 and U.S. Patent and Trademark Office public records, we find that the disclaimer of claim 7 complies with the above-listed requirements of 37 C.F.R. § 1.321(a). Accordingly, we treat claim 7 as having never been part of the ’603 patent. See Vectra Fitness, Inc. v. TNWK Corp., 162 F.3d 1379, 1383 (Fed. Cir. 1998) (“This court has interpreted the term ‘considered as part of the original patent’ in [35 U.S.C.] § 253 to mean that the patent is treated as though the disclaimed claims never existed.”). Because post-grant review cannot be instituted based on disclaimed claims, claim 7 is outside the scope of this proceeding. 37 C.F.R. § 42.207(e) (“No post-grant review will be instituted based on disclaimed claims.”); General Elec. Co. v. United Techs. Corp., IPR2017-00491, Paper 9 (PTAB July 6, 2017) (precedential) (denying institution in view of a statutory disclaimer of all the challenged claims). Thus, we confine our analysis in this Decision to claims 1–6 and 8– 20, the remaining challenged claims that have not been disclaimed.” slip op. at 7
- PTAB / AIA Trials › Real party in interest / privityGranted
“Sciencons AS also states that ARTBIO, Inc. is responsible for defending the ’603 patent in this proceeding and requests that ARTBIO, Inc. be included in the caption for this proceeding.2 Paper 4, 1; Paper 7, 1. ARTBIO, Inc. has signed powers of attorney appointing the same practitioners that were appointed by Sciencons AS to transact all business associated with the instant post-grant review proceeding of the ’603 patent. See Papers 3, 4, 7, 8. To date, no objection has been raised to Patent Owner’s request. Given Sciencons AS’s representation that ARTBIO, Inc. is currently the exclusive licensee of the ’603 patent and is responsible for defending the ’603 patent, we grant Sciencons AS’s unopposed request that ARTBIO, Inc. be included in the caption. For convenience we refer to Sciencons AS and the purported exclusive licensee ARTBIO, Inc. collectively as “Patent Owner.” As stated supra, to the extent any party disputes ARTBIO, Inc.’s right to participate in this proceeding or to be included in the caption, the party shall request authorization to brief the issue within 10 business days of this Decision.” slip op. at 3
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art “would have had a bachelor’s degree in chemistry, chemical engineering, physics, nuclear chemistry, radiochemistry, or materials science, or a comparable field of study, plus approximately two to three years of professional experience with radioisotope generators, or other relevant industry experience” and that “[a]dditional graduate education could substitute for professional experience, and significant experience in the field could substitute for formal education.” Pet. 2–3 (citing Ex. 1002 ¶ 33; Ex. 1017 ¶ 27). At this stage of the proceeding, Patent Owner does not dispute Petitioner’s proposed definition nor provide a proposed definition of its own. See generally Prelim. Resp. For the purposes of this Decision, we adopt Petitioner’s undisputed proposed definition.” slip op. at 10
§ 102 anticipation§ 103 obviousness§ 112 disclosurecites PhillipsPatents in suitUS 12,125,603 - Padagis US LLC v. Neurelis, Inc.InstitutedPTAB · Sep 16, 2025 · IPR2025-00465 · APJ Timothy G Majors · IPR · Institution
The Board instituted IPR on claims 1–18 because Petitioner showed a reasonable likelihood of proving claim 1 obvious over Gwozdz and Meezan.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“A claim is unpatentable under 35 U.S.C. § 103 if the differences between the claimed invention and the prior art are such that the claimed invention as a whole would have been obvious at the time the invention was made to a person having ordinary skill in the relevant art. KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 406 (2007). The question of obviousness is resolved on the basis of underlying factual determinations including: (1) the scope and content of the prior art; (2) any differences between the claimed subject matter and the prior art; (3) the level of ordinary skill in the art; and (4) secondary considerations (i.e., objective indicia) of nonobviousness when presented.6 Graham v. John Deere Co., 383 U.S. 1, 17–18 (1966). To show unpatentability based on a combination of teachings, “[a]n obviousness determination [also] requires finding both that a skilled artisan would have been motivated to combine the teachings of the prior art references to achieve the claimed invention, and that the skilled artisan would have had a reasonable expectation of success in doing so.” CRFD” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“[A POSA] would have been a pharmaceutical scientist, chemist, or biologist involved in the research and development of pharmaceutical formulations and/or delivery, and would have at least a Bachelor’s degree with at least 5 years of experience, or a Master’s, Ph.D. or Pharm.D. degree with several years of experience. In addition, a POSA would have had knowledge of benzodiazepine structure and function, and would further have knowledge and practical experience working with intranasal and transmembrane formulations, including knowledge of the physiology and anatomy of the nasal cavity, with relevant experience in developing intranasal formulations. Pet. 23–24; Ex. 1062 ¶ 20. Patent Owner “does not dispute” Petitioner’s POSA definition at this stage. Prelim. Resp. 18. We apply Petitioner’s proposed POSA definition for this Decision, which definition appears to be generally consistent with the cited prior art.” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“standard used in a civil action before the courts under 35 U.S.C. § 282(b), including construing claim language in accordance with its ordinary and customary meaning as understood by the POSA, in view of the patent’s specification and considering the patent’s prosecution history. 37 C.F.R. § 42.100(b). We need only expressly construe terms to the extent needed to resolve the controversy before us. Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019).” slip op. at 8
- Disclosure Requirements (§112) › Written description (Ariad)Written description inadequateNot entitled to earlier dateDecided for petitioner
“applicant, as part of the bargain with the public, must describe his or her invention so that the public will know what it is and that he or she has truly made the claimed invention.” AbbVie Deutschland GmbH & Co., KG v. Janssen Biotech, Inc., 759 F.3d 1285, 1298 (Fed. Cir. 2014). “[T]he test for sufficiency [of the written description requirement] is whether the disclosure of the application relied upon reasonably conveys to those skilled in the art that the inventor had possession of the claimed subject matter as of the filing date sought.” Ariad Pharm., Inc. v. Eli Lilly and Co., 598 F.3d 1336, 1351 (Fed. Cir. 2010) (en banc) (explaining that “the description must clearly allow persons of ordinary skill in the art to recognize that [the inventor] invented what is claimed”) (internal quotation marks omitted); see also id. at 1352 (“[A] description that merely renders the invention obvious does not satisfy the requirement.”).” slip op. at 25
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites KSR · GrahamPatents in suitUS 11,241,414 - Padagis US LLC v. Neurelis, Inc.InstitutedPTAB · Sep 16, 2025 · IPR2025-00466 · APJ Timothy G Majors · IPR · Institution
The Board instituted IPR on claims 1–27 because Petitioner showed a reasonable likelihood of prevailing on at least one claim, including claim 1 over Gwozdz and Meezan.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Under 35 U.S.C. § 314(a), an inter partes review may not be instituted unless it is determined that there is a reasonable likelihood that the petitioner will prevail with respect to at least one of the claims challenged in the petition. For reasons explained below, we conclude that Petitioner shows a reasonable likelihood that it will prevail with respect to at least one of the ’786 patent’s challenged claims.1 We institute inter partes review on all challenged claims. SAS Inst. Inc. v. Iancu, 584 U.S. 357, 362–63 (2018); 37 C.F.R. § 42.108(a) (“When instituting inter partes review, the Board will authorize the review to proceed on all of the challenged claims and on all grounds of unpatentability asserted for each claim.”).” slip op. at 2
- Disclosure Requirements (§112) › Written description (Ariad)Not entitled to earlier dateDecided for petitioner
“We find that Petitioner has made a threshold showing that the ’558 Provisional does not provide written description support for claim 1’s pharmaceutical solution consisting of each of the recited elements, including n-dodecyl beta-D-maltoside. It is true that “n-Dodecyl β-D-maltoside” can be found listed in the SIGMA Catalog. Ex. 1026, 316. But Dr. Donovan’s testimony helps put that listing in context. It is merely one among well over 100 ionic and non-ionic detergents listed in the cited six pages of the SIGMA Catalog. See 1026, 316–321; Ex. 1062 ¶ 50. When further considered in the context of paragraphs 150–152 of the ’558 Provisional, which generically suggest that “enhancer” compounds can be used in “some embodiments”—then introducing at least 15 classes of potential enhancers16 including “preferred” lysophospholipids and acyl carnitines—the listing of n-dodecyl beta-D-maltoside among at least 150 biological detergents in the SIGMA Catalog is even more remote. Moreover, although satisfaction of the written description requirement is not limited to what is exemplified in a priority application, none of the ’558 Provisional’s examples use any “enhancer,” much less any detergent, any alkyl glycoside, or n-dodecyl beta-D maltoside in particular. The 16 The ’558 Provisional suggests that whether “a given compound” will function as an “enhancer” in a formulation requires testing. Ex. 1008 ¶ 150 (indicating “an in vivo or good model test” may “determin[e] whether the uptake of the drug is enhanced to a clinically significant degree”). ethanol. See Ex. 1008 ¶¶ 172–174 (Examples 1 and 2). In short, we find no sufficient disclosure of “blaze marks” in the ’558 Provisional that point to the inventors’ possession of a pharmaceutical solution that includes n-dodecyl beta-D-maltoside as claimed. Purdue Pharma L.P. v. Faulding Inc., 230 F.3d 1320, 1326–27 (Fed. Cir. 2000) (analogizing an application’s generic disclosures to a forest of unmarked trees and explaining that, “to satisfy the written description requirement,” there must be “blaze marks directing the skilled artisan to that tree [within the forest that represents the claimed invention]” in the application).” slip op. at 28
- PTAB / AIA Trials › §315(e) estoppelEstoppel does not applyDecided for patent owner
“and applying collateral estoppel to vacate a claim construction in an underlying IPR). In an IPR, “a party seeking to invoke collateral estoppel must show: ‘(1) the issue is identical to one decided in the first action; (2) the issue was actually litigated in the first action; (3) resolution of the issue was essential to a final judgment in the first action; and (4) [the party against whom collateral estoppel is being asserted] had a full and fair opportunity to litigate the issue in the first action.’” Google LLC v. Hammond Development Int’l, Inc., 54 F.4th 1377, 1381 (Fed. Cir. 2022) (quoting In re Freeman, 30 F.3d 1459, 1465 (Fed. Cir. 1994)) (alteration in original).14 “It is [also] well established that patent claims need not be identical for collateral estoppel to apply.” Id. at 1381. Instead, “collateral estoppel requires the issues of patentability be identical.” Id. If “the differences between the unadjudicated patent claims and adjudicated patent claims do not materially alter the question of invalidity, collateral estoppel applies.” Ohio Willow Wood Co. v. Alps South, LLC, 735 F.3d 1333, 1342–43 (Fed. Cir. 2013) (affirming application of collateral estoppel where claims adjudicated as obvious required a “polymeric” gel whereas similar, unadjudicated claims required a “block copolymer” gel). “Collateral estoppel also applies to common issues in actions involving different but related patents.” Mycogen Plant Sci., Inc. v. Monsanto Co., 252 F.3d 1306, 1310 (Fed. Cir. 2001), vacated on other grounds, 353 U.S. 1109 (2002).” slip op. at 22
- Novelty / Anticipation (§102) › Prior-art status of a reference › Patents / published applications (effective date, provisional support)Reference is prior artReference not prior artMixed
“We agree that at least one portion of Gwozdz is not prior art. To establish that the cited disclosures in Gwozdz are prior art, Petitioner must show support for those disclosures in the Gwozdz Provisional. In re Riggs, 131 F.4th 1377, 1384 (Fed. Cir. 2025) (explaining that “the portion of the application relied on . . . as prior art must be supported by the provisional application”). Petitioner did not establish that Gwozdz’s disclosure of “penetration enhancers” finds support in the Gwozdz Provisional. Pet. 22. Conversely, Patent Owner shows that the phrase is absent in the Gwozdz Provisional. Prelim. Resp. 37.20 Based on this record, we determine that Gwozdz’s mention of “penetration enhancers” is not prior art to the 19 Patent Owner argues this “penetration enhancers” disclosure in Gwozdz is not prior art regardless which of the disputed priority dates (March 28, 2008, or March 27, 2009) one accords to the challenged claims. Prelim. Resp. 33. 20 We also agree that collateral estoppel does not bar Patent Owner from challenging Gwozdz’s prior-art status in this case. Patent Owner’s apparent concession that Gwozdz was prior art during the 451 IPR does not equate to the issue being actually litigated. Prelim. Resp. 34–35; Ex. 1040, 14 (“Patent Owner does not contest that Gwozdz is entitled to this filing date” of the Gwozdz Provisional). Purdue, 767 F. App’x at 922 (determining “[t]he priority date for the Joshi reference . . . cannot be determined based on collateral estoppel” where patentee could have argued, but did not in fact argue, Joshi’s prior-art status in an earlier matter).” slip op. at 35
Claim construction§ 102 anticipation§ 103 obviousness§ 112 disclosurecites KSR · GrahamPatents in suitUS 11,793,786 - Padagis US LLC v. Neurelis, Inc.InstitutedPTAB · Sep 16, 2025 · IPR2025-00464 · APJ Annette R Reimers · IPR · Institution
The Board instituted IPR on claims 1–22, finding a reasonable likelihood that claim 1 would have been obvious over Gwozdz and Meezan.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“3. Conclusion For the reasons discussed above and based on the present record, we find that Petitioner has made an adequate threshold showing that the issues presented in this Petition are substantially the same as the issues the Board previously considered in IPR2019-00451 and that Gwozdz’s effective date is March 28, 2008. We therefore determine that Petitioner has shown that it is reasonably likely to prevail in establishing that at least claim 1 would have been obvious over Gwozdz and Meezan. IV. CONCLUSION Petitioner has shown a reasonable likelihood that it will prevail in establishing the unpatentability of at least one of the claims challenged in the Petition. We institute trial on all challenged claims under the grounds raised in the Petition. PGS Geophysical AS v. Iancu, 891 F.3d 1354, 1360 (Fed.” slip op. at 21
- Skill levelSkill level petitioner adoptedDecided for petitioner
“[A POSA] would have been a pharmaceutical scientist, chemist, or biologist involved in the research and development of pharmaceutical formulations and/or delivery, and would have at least a Bachelor’s degree with at least 5 years of experience, or a Master’s, Ph.D. or Pharm.D. degree with several years of experience. In addition, a POSA would have had knowledge of benzodiazepine structure and function, and would further have knowledge and practical experience working with intranasal and transmembrane formulations, including knowledge of the physiology and anatomy of the nasal cavity, with relevant experience in developing intranasal formulations. Pet. 23; Ex. 1062 ¶ 20. Patent Owner “does not dispute” Petitioner’s POSA definition at this stage. Prelim. Resp. 16. We apply Petitioner’s proposed POSA definition for this Decision, which definition appears to be generally consistent with the cited prior art.” slip op. at 6
- PTAB / AIA Trials › §315(e) estoppelMixed
“As the Board’s decision in the 451 IPR explicitly found written description inadequate for the “alkyl glycoside” limitation in the ’558 Provisional, which is the same issue raised here for the ’546 patent, Petitioner has shown that issue was actually litigated and decided in the 451 IPR. Where the same issue is actually litigated and decided as part of a final adjudication in an earlier action, the test for invoking collateral estoppel in a later action is met. On this record and for the reasons above, we are persuaded that collateral estoppel bars Patent Owner from arguing the challenged claims are entitled to the priority date of the ’558 Provisional.” slip op. at 14
- Novelty / Anticipation (§102) › Priority / effective filing date / continuation supportPriority date, deniedMixed
“We agree that at least one portion of Gwozdz is not prior art. To establish that the cited disclosures in Gwozdz are prior art, Petitioner must show support for those disclosures in the Gwozdz Provisional. In re Riggs, 131 F.4th 1377, 1384 (Fed. Cir. 2025) (explaining that “the portion of the application relied on . . . as prior art must be supported by the provisional application”). Petitioner did not establish that Gwozdz’s disclosure of “penetration enhancers” finds support in the Gwozdz Provisional. Pet. 22. Conversely, Patent Owner shows that the phrase is absent in the Gwozdz 9 Patent Owner argues that as the ’546 Patent claims priority to the ’439 Application, the “penetration enhancers” disclosure in Gwozdz is not prior art because Gwozdz and the ’439 Application were filed on the same day (March 27, 2009). Prelim. Resp. 21–22. 10 Patent Owner argues that the passage in Gwozdz concerning “penetration enhancers” is relevant solely to “a pharmaceutical composition for injection,” not for intranasal administration as required by the ’546 Patent. Prelim. Resp. 22. First, as noted above, based on the record presented, we determine that Gwozdz’s mention of “penetration enhancers” is not prior art to the challenged claims. Second, we disagree, however, that Gwozdz’s non-prior art mention of penetration enhancers is relevant solely to a pharmaceutical composition for injection as argued by Patent Owner. Gwozdz discloses that “[the] pharmaceutical compositions of the present invention” can be administered by a number of “nonlimiting” routes including intranasal administration. See Ex. 1009, 9:2–11. Provisional. Prelim. Resp. 20–21. Based on this record, we determine that Gwozdz’s mention of “penetration enhancers” is not prior art to the challenged claims. The phrase cannot, therefore, be used to establish a motivation to combine the asserted references.” slip op. at 18
§ 102 anticipation§ 103 obviousnesscites KSR · GrahamPatents in suitUS 8,895,546 - PTAB · Jul 10, 2025 · IPR2025-00175 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board instituted review of claims 1–17 on all asserted grounds, finding a reasonable likelihood of unpatentability on at least one challenged claim.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2018); see also 37 C.F.R. § 42.4 (2023). For the reasons discussed below, we determine that Petitioner establishes a reasonable likelihood of prevailing with respect to the patentability of at least one claim of the ’562 patent. Accordingly, we institute an inter partes review of claims 1–17 of the ’562 patent.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“(“POSITA”) would have had “at least a four-year degree in electrical engineering or a closely related field, and at least two years of experience in semiconductor device design,” and “[a]dditional education could substitute for professional experience and vice versa.” Pet. 6 (citing Ex. 1002 ¶¶ 80–” slip op. at 6
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“customary meaning of such claim as understood by one of ordinary skill in the art and the prosecution history pertaining to the patent.” 37 C.F.R. § 42.100(b). Under this standard, claim terms are generally given their plain and ordinary meaning as would have been understood by a person of ordinary skill in the art at the time of the invention and in the context of the entire patent disclosure. Phillips v. AWH Corp., 415 F.3d 1303, 1313 (Fed. Cir. 2005) (en banc). Only those terms in controversy need to be construed, and only to the extent necessary to resolve the controversy. Realtime Data LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019). Neither party proposes any explicit construction of any term. See Pet. 7 (“For the purposes of this IPR, the plain meaning of each term can be applied.”). We do not expressly construe any term for purposes of this Decision.” slip op. at 7
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“On this record, we are persuaded that Petitioner adequately establishes that Usui discloses all of the limitations of claim 1. Usui discloses that aluminum or aluminum alloy layer 15 is in electrical contact with titanium underlayer 13, and titanium nitride layer 14 is located “intermediate the [titanium underlayer] 13 and the aluminum or aluminum alloy layer 15” to prevent “reaction between the aluminum layer 15 and underlayer 13.” Ex. 1004, 3:27–29, 3:38–41, 3:58–63. Usui further discloses that “a capping layer is provided above layer 15,” and that “[p]referred capping layers are titanium nitride and combinations of as layer 18 of a group IVA metal, preferably titanium with a titanium nitride layer 19.” Id. at 3:67–4:6. Usui teaches that titanium nitride layer 19 is about 150 to 800 Å thick, and that the thickness of titanium underlayer 13 is between about 90 to 110 Å. Id. at 3:31–33, 4:6–8. Usui also teaches that the interconnect metallurgy structures described therein “exhibit[] enhanced electromigration characteristics” and “are especially useful for forming electrical connections or wiring such as between active and/or passive devices of an integrated circuit structure.” Id. at 1:8–14. Usui’s description of a plurality of metal layers (layers 13–18) and a capping layer formed over the plurality of metal layers (layer 19), along with its description of the structure’s usefulness for forming electrical connections in an integrated circuit structure, is sufficient, on this record, to establish that Usui discloses “an electrode stack including a plurality of metal layers and a capping layer formed over said plurality of metal layers” as recited in claim 1. Usui’s teaching that the capping layer is a refractory metal nitride (titanium nitride) that has a thickness (150–800 Å) greater than the bottommost layer of the plurality of metal layers (layer 13, 90–110 Å), sufficiently establishes, on this record, that Usui discloses the “said capping layer consisting only of a refractory metal nitride, said refractory metal nitride forming a top of said electrical contact and having a thickness greater than that of a bottommost layer of said plurality of metal layers” limitation of claim 1.” slip op. at 11
Claim construction§ 102 anticipation§ 103 obviousnesscites PhillipsPatents in suitUS 8,686,562 - PTAB · Jun 18, 2025 · IPR2025-00321 · APJ Christopher M Kaiser · IPR · Institution
The Board instituted IPR on claims 1, 2, 5–7, 9, 16, and 17, finding a reasonable likelihood that claim 1 is anticipated by Boyer.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“approximately two weeks before the statutory deadline for a final written decision, but the most recent median time-to-trial statistics for Judge Gilstrap in the Eastern District of Texas indicate that the actual trial date will likely be in July 2026, which is later than the statutory deadline to issue a final written decision in this proceeding in mid-June 2026. See Ex. 2001, 7 (median time from filing to trial of 23.2 months); Prelim. Resp. 10. Thus, we find this factor is neutral or weighs slightly against discretionary denial.” slip op. at 10
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“At this preliminary stage, we determine whether the information presented shows a reasonable likelihood that Petitioner would prevail in establishing that at least one of the challenged claims would have been unpatentable over the proposed prior art. We analyze the asserted grounds with the above-noted principles in mind.” slip op. at 7
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that one of ordinary skill in the art “would have had (1) at least a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a related field, and (2) at least two years of research or industry experience in 3D printing or materials used for 3D printing.” Pet. 5 (citing Ex. 1003 ¶¶ 14–16). Petitioner also argues that “[a]dditional experience could substitute for a formal degree or formal training (and vice versa).” Id. Patent Owner proposes a slightly different level of skill, arguing that a person of ordinary skill in the art “would have had a bachelor’s degree in Mechanical Engineering, Computer Engineering, Chemical Engineering, Materials Science, or a comparable field and at least two years of experience related to 3D printing, with additional experience potentially being a substitute for a formal degree or training (and vice versa).” Prelim. Resp. 24. Neither party explains why the outcome of this case would be affected by the adoption of any of the proffered definitions of a person of ordinary skill in the art. For purposes of this Decision, we adopt Petitioner’s assessment of the level of ordinary skill in the art, as it appears to be consistent with the ’713 patent and the asserted prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001).” slip op. at 16
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction needed
“We note that, as discussed below, we are able to determine whether to institute inter partes review of the ’713 patent without expressly construing the term “from multiple print heads or deposition lines.” See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). As for Patent Owner’s argument that Petitioner has failed to carry its burden to identify how the claims are to be construed, we disagree on the present record. Although Petitioner does not provide a preferred construction for the single term it proposes requires construction, Petitioner does identify which of its two alternative constructions applies to each of its asserted grounds of unpatentability. Pet. 6 (“Under the first construction, [the obviousness grounds] are applicable, and [the anticipation ground] would be excluded from the claim scope. Under the alternative construction, all of [the asserted grounds] are applicable.”). In our view, this approach does not fail to satisfy Petitioner’s burden under 37 U.S.C. § 42.104(b)(3).” slip op. at 17
Claim construction§ 102 anticipationDiscretionary denialcites PhillipsPatents in suitUS 9,421,713 - PTAB · Mar 27, 2025 · IPR2024-01451 · APJ Erica A Franklin · IPR · Institution
The Board instituted review of claims 1–19 on all petition grounds, finding a reasonable likelihood that claim 1 would have been obvious over Larson alone.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › Fintiv (parallel litigation)Denied
“of whether we exercise our discretion to deny institution under 35 U.S.C. § 314(a). Rather, when considering the Fintiv factors, we “take[] a holistic view of whether efficiency and integrity of the system are best served by denying or instituting review.” Fintiv at 6. Here, factors one and six are neutral, factors two and three weigh against discretionary denial, and factors four and five favor denial. We assign less weight to the existence of an overlap in asserted claims and prior art, in view of there being no trial date scheduled in the District Court case and no persuasive evidence that the court’s trial date would be expected to be significantly before the due date of our Final Written Decision. Therefore, after weighing all of the factors, we determine that the facts in this case that weigh against exercising discretion outweigh the facts that favor exercising discretion. Accordingly, we decline to exercise our discretion to deny institution under § 314(a).” slip op. at 13
- Skill levelSkill level petitioner adoptedDecided for petitioner
“At this stage in the proceeding, Patent Owner does not dispute Petitioner’s description of the person of ordinary skill in the art. Prelim. Resp. 27. In view of this, and because Petitioner’s uncontested description of one of ordinary skill in the art is reasonable and consistent with the ’921 patent and the cited art, we adopt Petitioner’s definition for purposes of this Decision. We note, however, that the open-ended language “at least” expands the range of experience indefinitely with no upper bound. Therefore, we do not apply this aspect of Petitioner’s formulation.” slip op. at 14
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“We determine that there is no need to expressly construe any claim term to determine whether to institute an inter partes review. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 controversy, and only to the extent necessary to resolve the controversy’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999))). To the extent that any discussion regarding the scope of a claim term is relevant to our decision, we address that issue in our analysis of the asserted grounds of unpatentability.” slip op. at 15
- Novelty / Anticipation (§102) › Prior-art status of a reference › Patents / published applications (effective date, provisional support)Reference not prior artDecided for patent owner
“Owner that Petitioner has not demonstrated sufficiently in the Petition, for purposes of institution, that all of the portions of Saxonov relied upon in the Petition are prior art. In particular, we determine that Petitioner has not established that the disputed portions of Saxonov are entitled to claim the benefit of the ’013 provisional filing date because Petitioner has failed to satisfy the second condition for this benefit, i.e., by showing that the provisional application provides sufficient support for certain subject matter in Saxonov relied upon for prior art purposes in the Petition.” slip op. at 28
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · GrahamPatents in suitUS 11,827,921 - PTAB · Mar 20, 2025 · IPR2024-01406 · APJ Jo-Anne M Kokoski · IPR · Institution
The Board instituted IPR on claims 1, 3, 4, 8–13, and 15 on all asserted grounds, finding a reasonable likelihood that Takeuchi anticipates those claims.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“Institution of an inter partes review is authorized by statute when “the information presented in the petition . . . and any response . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314 (2018); see also 37 C.F.R. § 42.4 (2023). For the reasons discussed below, we determine that Petitioner establishes a reasonable likelihood of prevailing with respect to the unpatentability of at least one claim of the ’202 patent. Accordingly, we institute an inter partes review of claims 1, 3, 4, 8–13, and 15 of the ’202 patent. A. Real Parties in Interest” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“or “POSITA”) would have had “a bachelor’s degree in mechanical engineering, electrical engineering, or a related field, and three to four years of experience, or a master’s degree in mechanical engineering, electrical engineering, or a related field, and one to two years of experience.” Pet. 6 (citing Ex. 1003 ¶ 13). Petitioner further contends that “[s]uch experience would include a familiarity with thermal fluid delivery devices and/or the components and underlying technology used therein, and a higher level of 1 US 5,249,586, issued Oct. 5, 1993 (Ex. 1004, “Morgan”). 2 EP 0 845 220 B1, published Jan. 26, 1998 (Ex. 1006, “Susa”). 3 US 2005/0205084 A1, published Sept. 22, 2005 (Ex. 1007, “Gupta”). 4 US 6,155,268, issued Dec. 5, 2000 (Ex. 1009, “Takeuchi”). at 6–7 (citing Ex. 1003 ¶ 13). Patent Owner states that, for purposes of the Preliminary Response, “Patent Owner maintains that Petitioners’ arguments fail even under Petitioners’ POSA definition.” Prelim. Resp. 13. On this record, we preliminarily adopt Petitioner’s undisputed proposed definition because it appears to be consistent with the cited prior art and the disclosure of the ’202 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))). B. Claim Construction” slip op. at 6
- Prior constructionPrior construction adoptedDecided for petitioner
“term “wicked into contact” that the Board adopted in a prior inter partes review proceeding that addressed the same term in an earlier, related patent. Pet. 7 (citing IPR2020-01602, Paper 32 at 8–15 (PTAB March 30, 2022)). ‘wicked into contact’ to mean: ‘wicked into contact (1) with the heater, or (2) with an area in close proximity to, and exposed [to] the heat produced by, the heater,’” and “[t]he present Petition adopts this formal construction for purposes of this IPR proceeding.” Id. (citing IPR2020-01602, Paper 32 at 15). Patent Owner also “adopts this construction for purposes of” the Preliminary Response, and argues that “Petitioner’s grounds fail even under its proposed construction of ‘wicked into contact.’” Prelim. Resp. 13. For purposes of this Decision, we adopt the Board’s prior construction of “wicked into contact,” namely, “wicked into contact (1) with the heater, or (2) with an area in close proximity to, and exposed to the heat produced by, the heater,” which is undisputed on this record. See Philip Morris Products, S.A. v. RAI Strategic Holdings, Inc., IPR2020-01602, Paper 32 at 8–15 (PTAB March 30, 2022). C. Asserted Anticipation by Morgan” slip op. at 7
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Not shown unpatentableNot reached
“To establish anticipation, each and every element in a claim, arranged as recited in the claim, must be found in a single prior art reference. Net Karsten Mfg. Corp. v. Cleveland Golf Co., 242 F.3d 1376, 1383 (Fed. Cir. 2001). “A reference may anticipate inherently if a claim limitation that is not expressly disclosed is ‘necessarily present, or inherent, in the single anticipating reference.’” In re Montgomery, 677 F.3d 1375, 1379 (Fed. Cir. 2012) (quoting Verizon Servs. Corp. v. Fibernet Va., Inc., 602 F.3d 1325, 1336–37 (Fed. Cir. 2010)). Based on the current record, we are not persuaded that Petitioner sufficiently establishes that Morgan discloses “a storage compartment . . . being arranged such that the liquid aerosol-forming material can be wicked into contact with the electrical resistance heater to volatilize the liquid aerosol-forming material” as recited in claim 1.” slip op. at 12
Claim construction§ 102 anticipationcites PhillipsPatents in suitUS 11,925,202
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.