- PTAB · Dec 10, 2024 · IPR2024-00994 · APJ Ken B Barrett · IPR · Institution
The Board instituted IPR on claims 1–7 and 9–14 on all asserted grounds, finding a reasonable likelihood of success on the Onishi-based obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsInstitution denied 325dDenied
“inter partes review, “the Director may take into account whether, and reject the petition or request because, the same or substantially the same prior art or arguments previously were presented to the Office.” 35 U.S.C. § 325(d). The Board uses a two-part framework in determining whether to exercise its discretion under § 325(d), specifically: (1) whether the same or substantially the same art previously was presented to the Office or whether the same or substantially 4 For purposes of this Decision, we assume the challenged claims have an effective filing date prior to March 16, 2013, the effective date of the relevant aspects of the Leahy-Smith America Invents Act, Pub. L. No. 112- 29, 125 Stat. 284 (2011) (“AIA”), and we apply the pre-AIA version of 35 U.S.C. § 103. the same arguments previously were presented to the Office; and (2) if either condition of [the] first part of the framework is satisfied, whether the petitioner has demonstrated that the Office erred in a manner material to the patentability of challenged claims. Advanced Bionics, Paper 6 at 8. The art or arguments presented in the Petition are not “substantially the same” as those previously presented to the Office when there are differences between them that are material to the Office’s prior consideration of the art and arguments. Wolfspeed, Inc. v. Trs. of Purdue Univ., IPR2022-00761, Paper 13 at 7–8 (Vidal Mar. 30, 2023).” slip op. at 8
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“An inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). Having considered the arguments and evidence presented by Petitioner and Patent Owner, we determine that Petitioner has demonstrated a reasonable likelihood of prevailing on at least one of the challenged claims of the ’696 patent. Further, we decline to discretionarily deny inter partes review. Accordingly, we institute an inter partes review as to all the challenged claims of the ’696 patent on all the grounds of unpatentability set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner, at this stage, does not disagree or propose a different definition of the person of ordinary skill in the art. However, Patent Owner’s declarant, Dr. Mercier, opines that [A]t the time of the ’696 Patent, a POSITA would have a working knowledge of wireless charging and inductive charging. The person would have gained this knowledge through an undergraduate Bachelor of Science degree in electrical engineering, computer engineering, computer science, or a related field, with at least two years of experience working in the field of wireless or inductive charging device design, or testing of such wireless or inductive charging device testing, or 5 The parties have not directed our attention to any objective evidence of obviousness or non-obviousness. an equivalent combination of academic study and work experience. More education (e.g., a Master’s degree) or work experience any relevant field may compensate for a deficit in one of the relevant qualifications stated above. Ex. 2001 ¶ 26. We observe that, in Dr. Mercier’s definition, the undergraduate degree categories are a bit broader and the experience possibly a bit more specific than in Petitioner’s definition. However, at this stage and absent argument to the contrary by the parties, we discern no material difference between the parties’ definitions. Petitioner’s definition is consistent with the level of ordinary skill reflected in the prior art references of record. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (recognizing that the prior art itself may reflect an appropriate level of skill in the art). For purposes of this decision, we apply Petitioner’s definition of the person of ordinary skill in the art. We note, however, that were we to adopt Dr. Mercier’s assessment, the outcome of this Decision would be the same.” slip op. at 15
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)Other
“near-linear region—consistent with the quoted applicant’s use of the term “near-linear”—rather than a linear or non-linear region, which seemingly would encompass the entire curve. As to the second part, we understand Patent Owner to be referring to the purported benefit of linear control, and we determine that Patent Owner has not explained adequately why such a benefit should be read into the claim term “substantially different,” particularly where the quoted Specification support does not explicitly mention linear regulation.7 See Ex. 1001, 21:61–63 (“The induced voltage 7 To the extent that Patent Owner relies on its declarant’s testimony as an explanation of Patent Owner’s claim construction position, we remind Patent Owner about the prohibition on incorporation by reference. See 37 C.F.R. § 42.6(a)(3); Consolidated Trial Practice Guide, November 2019, 35–36 can be increased by reducing the transmission frequency and can be reduced by increasing the transmission frequency.”). On this record and for purposes of this decision, we determine that— consistent with the Specification’s description of the frequency that is “[p]referably . . . selected” and applicant’s argument regarding the same during prosecution—“a transmission frequency substantially different from said characteristic resonant frequency of said inductive couple” encompasses frequencies that lie within one of the near-linear regions of a frequency-amplitude graph associated with the inductive couple. See Ex. 1001, 21:20– 24; Ex. 1002, 70. At this time and for purposes of this Decision, we need not and do not reach the issue of the outer bounds of the scope of “substantially different.” We also note that independent claim 1 is an apparatus claim and the subject limitation 1.7 further defines the “driving circuit” recited in limitations 1.5 and 1.6. Specifically, limitation 1.7 requires a driving circuit that is “configured and operable to produce said oscillating driving voltage at a transmission frequency” that is “substantially different” from the inductive couple’s resonant frequency. Ex. 1001, 28:43–46. In future briefing, the parties’ arguments regarding the prior art references should focus on that recited structure, i.e., a circuit that is configured and operable to produce the recited frequency.” slip op. at 21
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 9,048,696 - PTAB · Nov 22, 2024 · PGR2024-00034 · APJ Patrick R Scanlon · PGR · Institution
Instituted PGR on claims 1–19 and all asserted grounds after finding at least one claim more likely than not unpatentable.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“We have authority to determine whether to institute a post-grant review. See 35 U.S.C. § 324 (2018); 37 C.F.R. § 42.4(a) (2022). To institute a post-grant review, we must determine that “the information presented in the petition . . . would demonstrate that it is more likely than not that at least 1 of the claims challenged in the petition is unpatentable.” 35 U.S.C. § 324(a). For the reasons set forth below, we determine that the information presented shows that it is more likely than not that Petitioner would prevail in establishing unpatentability of at least one challenged claim. Accordingly, we institute a post-grant review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“We note that the identification of a Ph.D. as an example of “more formal education” creates a vast range of education relative to a bachelor’s degree. Thus, we treat the identification of a Ph.D. just as it is—an example—and not a requirement. In this case, “more formal education” can be satisfied by a level of education less than a Ph.D (but greater than a bachelor’s degree). Based on our review of the record before us, we determine that Petitioner’s stated level of ordinary skill in the art is reasonable because it appears consistent with the evidence of record, definition, limited as discussed above, for the purposes of this Decision.” slip op. at 9
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“On the present record, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the present controversy between the parties. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’”) (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 10
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“would have understood Unger’s disclosure to “suggest the use of a torsion spring to facilitate attachment and detachment, because torsion springs are designed to impart this functionality.” Id. (citing Ex. 1002 ¶ 118). Petitioner also asserts that one of ordinary skill in the art would have “understood that there were a limited number of ways to impart the referenced resilient or flexible ‘manipulation,’” and “would have been motivated to look to various known solutions to impart the suggested functionality, including the torsional spring mechanism of Smith that is used in a similar hearing protection device application for a similar purpose as Unger’s mounting arms (to apply a clamping force).” Id. at 32 (citing Ex. 1002 ¶¶ 120–121).” slip op. at 17
Claim construction§ 103 obviousness§ 112 disclosurecites KSR · GrahamPatents in suitUS 11,736,855 - PTAB · Nov 15, 2024 · IPR2024-00851 · APJ Eric C Jeschke · IPR · Institution
The Board denied institution on all claims 1–7 because the Petition did not show a reasonable likelihood of prevailing on any challenged ground.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023) (“The Board institutes the trial on behalf of the Director.”). Inter partes review may not be instituted “unless . . . the information presented in the petition . . . shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314. Upon consideration of the evidence and arguments in the record, for the reasons below, we determine that the information presented does not show a reasonable likelihood that Petitioner would prevail with respect to at least one of challenged claims 1–7. We thus deny institution of inter partes review. See 37 C.F.R. § 42.108(b) (“At any” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“we view the prior art and the claimed invention. Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001). The person of ordinary skill in the art is a hypothetical person presumed to have known the relevant prior art. In re GPAC Inc., 57 F.3d 1573, 1579 (Fed. Cir. 1995). In determining the level of ordinary skill in the art, we may consider certain factors, including the “type of problems encountered in the art; prior art solutions to those problems; rapidity with which innovations are made; sophistication of the technology; and educational level of active workers in the field.” Id. (internal quotation marks and citation omitted).” slip op. at 10
- Claim Construction › Functional claiming / §112(f) means-plus-function › Whether §112(f) applies (Williamson, nonce words)§112(f) appliesDecided for patent owner
“claim element creates a rebuttable presumption that § 112[(f)] applies” and that “the failure to use the word ‘means’ also creates a rebuttable presumption—this time that § 112[(f)] does not apply.”12 Williamson v. Citrix Online, LLC, 792 F.3d 1339, 1348 (Fed. Cir. 2015) (en banc in relevant part) (internal citations omitted). Because the “sealing means” limitation includes the word “means,” we start from the rebuttable presumption that § 112(f) applies. Petitioner does not address the applicability of § 112(f) and does not rebut the presumption. We continue the analysis, however, and, for the reasons below, we agree with Patent Owner that § 112(f) applies to the “sealing means” limitation.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“3. “fits behind” In wherein clause (vi), claim 1 recites: “the outwardly pointing outer flange of the first connecting device fits behind the inner flange of the nut unit.” Ex. 1001, 9:4–5 (emphasis added). In the Preliminary Response, Patent Owner discusses the term “fits behind” in this claim language. See Prelim. Resp. 41–45. We need not construe explicitly this language or any other claim terms because doing so would not change the outcome of the analysis. See Realtime Data, LLC v. Iancu, 912 F.3d 1368, 1375 (Fed. Cir. 2019) (“The Board is required to construe ‘only those terms . . . that are in controversy, and only to the extent necessary to resolve the controversy.’” (quoting Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999)).” slip op. at 14
Claim construction§ 102 anticipation§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 9,851,030 - PTAB · Nov 14, 2024 · IPR2024-00835 · APJ Hyun J Jung · IPR · Institution
The Board instituted IPR of claims 1–8 on all asserted grounds, finding a reasonable likelihood that claim 1 would be unpatentable over CIII and Rio.
RulingsInstitution decision- PTAB / AIA Trials › Discretionary denial › §325(d) same art / argumentsDecided for petitioner
“Advanced Bionics stated that: If, after review of factors (a), (b), and (d), it is determined that the same or substantially the same art or arguments previously were presented to the Office, then factors (c), (e), and (f) relate to whether the petitioner has demonstrated a material error by the Office. Factor (c) focuses on the record developed by the Office in previously reviewing the art or arguments. It informs, therefore, the petitioner’s showing under factors (e) and (f), which focus on the petitioner’s evidence of previous Office error regardless of the context in which the same or substantially the same art or arguments were previously presented. For example, if the record of the Office’s previous consideration of the art is not well developed or silent, then a petitioner may show the Office erred by overlooking something persuasive under factors (e) and (f). On the other hand, if the alleged error is a disagreement with a specific finding of record by the Office, then ordinarily the petitioner’s required showing of material error must overcome persuasively that specific finding of record. That is, although Becton, Dickinson factor (c) evaluates “the extent to which the asserted art was evaluated during examination, including whether the prior art was the basis for rejection,” the focus should be on the record when determining whether the Office erred in evaluating such art or arguments.” slip op. at 10
- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“d) Petitioner Shows a Reasonable Likelihood of Prevailing Based on the preliminary record, Petitioner shows a reasonable likelihood of prevailing in its challenge that CIII and Rio teach, suggest, or would have been understood to disclose the limitations of claim 1 and that one of ordinary skill in the art would have combined the references in the manner asserted with a reasonable expectation of success.” slip op. at 28
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“track” that “is configured to rotate . . . relative to the jacking column,” Petitioner proposes modifying CIII in view of Rio “by positioning Rio’s rotary actuator 44 between the jacking column and crawler track, and using that rotary actuator to rotate CIII’s crawler track relative to the entire jacking column, rather than just its outer cylinder.” Pet. 45 (citing Ex. 1002 ¶ 89) (emphasis added); see also id. at 47 (citing Ex. 1002 ¶ 92; Ex. 1006, 5:8–11, 6:2–6). Petitioner argues such a modification would have been a design choice, one of a finite number of alternatives, obvious to try, and a known design that provides maneuverability. Id. at 29–31 (citing Ex. 1002 ¶¶ 61–67; Ex. 1006, 5:8–11; Ex. 1007, 5:14–59, Figs. 4–5; Ex. 1008, 7:35– 53, Figs. 7, 20; Ex. 1009 ¶¶ 5, 19–20, Fig. 2; Ex. 1011, 4:7–16, Fig. 3; Ex. 1013 ¶¶ 41, 44–45). At this stage, Petitioner’s arguments and cited evidence sufficiently support for institution that the modification would have been made so that the proposed combination would have had “a crawler track” that “is configured to rotate . . . relative to the jacking column.” Regarding claim 1’s “slew drive,” as discussed above, Petitioner proposes modifying CIII so that rotary actuator 44, the asserted slew drive, would be between the jacking column and crawler track. See Pet. 29–31. Petitioner also argues that, in the proposed combination, “actuating the rotary actuator causes the crawler track to rotate relative to the entire jacking column.” Id. at 47 (citing Ex. 1002 ¶ 92). The present record supports Petitioner’s argument that Rio’s worm gear actuator would have been understood to disclose a slew drive with support from the ’318 patent itself, the opinion of its declarant, and deposition testimony of Patent Owner’s expert in related litigation. Id. at 46–47 (citing Ex. 1001, 11:40–61; Ex. 1002 ¶ 91; Ex. 1006, 4:61–5:3; Ex. 1032, 84:12–86:17). At this stage, the cited evidence sufficiently supports for purposes of institution Petitioner’s argument that the proposed combination would have included the recited “slew drive.”” slip op. at 28
- Skill levelSkill level petitioner adoptedOther
“had at least a four-year degree in mechanical engineering or a closely related field and at least two years of experience designing, developing, or operating heavy machinery, including their components and control systems.” Pet. 8– 9 (citing Ex. 1002 ¶¶ 22–24). Petitioner also argues that “[a]dditional experience could substitute for a formal degree, and an advanced degree could substitute for experience.” Id. at 9 (citing Ex. 1002 ¶¶ 22–25). Petitioner states that “[t]he Board adopted this definition of the level of ordinary skill for the related ’749 patent.” Id. (citing Godberson-Smith Const. Co. v. Guntert & Zimmerman Const. Div., Inc., IPR2020-01698, Paper 80, 21–24 (PTAB Apr. 12, 2022) (Final Written Decision)). For purposes of its Preliminary Response, Patent Owner applies Petitioner’s proposed level of ordinary skill in the art. Prelim. Resp. 13 (quoting Pet. 8–9). Based on the preliminary record, we adopt Petitioner’s asserted level of ordinary skill to determine whether there is a reasonable likelihood that Petitioner would prevail with respect to at least one of the claims challenged in the Petition. Pet. 8–9; Godberson-Smith, Paper 80 at 21–24 (determining level of ordinary skill after considering the parties’ competing proposals and evidence).” slip op. at 13
Claim construction§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,535,318 - Biofrontera Inc. / Biofrontera Bioscience GmbH et al. v. Sun Pharmaceutical Industries, Inc.Institution deniedPTAB · Nov 12, 2024 · IPR2024-00874 · APJ Erica A Franklin · IPR · Institution
The Board denied institution because the petition did not show a reasonable likelihood that any challenged claim was unpatentable, failing to show Bansal's claimed light intensity arrangement.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“An obviousness determination requires finding both ‘that a skilled artisan would have been motivated to combine the teachings of the prior art references to achieve the claimed invention, and that the skilled artisan would have had a reasonable expectation of success in doing so.’” CRFD Research, Inc. v. Matal, 876 F.3d 1330, 1340 (Fed. Cir. 2017) (quoting Intelligent Bio-Sys., Inc. v. Illumina Cambridge Ltd., 821 F.3d 1359, 1367– 68 (Fed. Cir. 2016)). Obviousness grounds must be supported with “articulated reasoning with some rational underpinning” and not by “mere conclusory statements.” See KSR Int’l Co., 550 U.S at 418. slip op. at 11
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)Not shown unpatentableNot shown unpatentable
“agree with Patent Owner that Petitioner has not sufficiently shown for institution that Bansal teaches or suggests arranging light sources “such that a higher intensity of light is emitted proximate the second edges compared to the intensity of light emitted not proximate the second edges,” as required by the challenged claims. Instead, Petitioner demonstrates how Bansal describes varying the density of light source distribution throughout the array to provide a higher density of light in the entire peripheral area of the array, which includes the areas proximal to both the first and second edges, as compared to the central area of the array. See Pet. 36–37; Ex. 1005 ¶ 25. In this regard, Petitioner relies on Bansal’s Figure 9b, asserting that it “shows one embodiment where more light sources are placed near the edges of the panel compared to the light sources in the center.” Pet. 36–37. The comparison of Bansal’s light density between the entire periphery and the central area of the array is insufficient. What is missing from Petitioner’s argument and discussion of Bansal is how Bansal teaches or suggests a configuration that provides a higher density of light proximate to the second shorter edges of the periphery in comparison to the remaining areas of the array, which includes the first longer edges of the periphery. Without that discussion, we find that Petitioner has not shown sufficient for institution that Bansal is persuasively relied upon for the light source arrangement limitation of the challenged claims. likelihood of prevailing in its obviousness challenge of independent claims 1, 5, 16, 20, or 21, or dependent claims 2, 4, 6–8, and 17–19 over Larsen, Bansal, and Jones.” slip op. at 17
- Skill levelOther
“would have had at least a Bachelor of Science in electrical engineering, physics, biomedical engineering, computer engineering, chemical engineering, material science, or a related scientific or engineering field, and at least one year of work or research experience in optics, optoelectronics, radiometry, photometry, photodynamic diagnosis (PD), photodynamic therapy (PDT), phototherapy (PT), or a related field. Pet. 8. Petitioner asserts that, alternatively, a “POSITA in the relevant time frame would have had at least four years of industry or academic experience in optics, optoelectronics, radiometry, photometry, PD, PDT, PT, or a related field.” Id. (citing Ex. 1003 ¶ 37). According to Patent Owner, a person of ordinary skill in the art at the time the application for the ’028 patent was filed, “would have had a M.D. and/or a Ph.D. in an electrical engineering, physics, optical sciences, optical engineering, or a related scientific or engineering field, and at least one to two years of work or research experience in optical engineering, optics, optoelectronics, phototherapy (‘PT’), PDT, or a related field.” Prelim. Resp. 16. Patent Owner asserts that, “[a]lternatively, a POSITA could have a Bachelor’s degree in one of the above areas and at least three to four years of work or research experience in that area.” Id. (citing Ex. 2001 ¶¶ 30–31). We note that the parties’ proposed definitions are largely similar. To the extent that the proposed definitions differ, we do not need to resolve those differences as our findings and conclusion in this Decision would be the same under any of the proposed definitions.” slip op. at 9
§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 11,697,028 - Cub Elecparts Inc. v. Orange Electronic Co., Ltd.Institution deniedPTAB · Nov 12, 2024 · IPR2024-00744 · APJ Patrick R Scanlon · IPR · Institution
The Board denied institution because Petitioner did not show a reasonable likelihood of prevailing on any challenged claim under the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)Institution denied meritsInstitution denied
“We have authority to determine whether to institute an inter partes review. See 35 U.S.C. § 314 (2018); 37 C.F.R. § 42.4(a) (2023). To institute an inter partes review, we must determine that the information presented in the Petition shows “a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a). For the reasons set forth below, we determine that Petitioner has not demonstrated a reasonable likelihood that it would prevail with respect to at least one challenged claim. Accordingly, we do not institute an inter partes review of the challenged claims on the grounds set forth in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person having ordinary skill in the art (“POSA”) “would have a bachelor’s degree in electrical engineering and at least one year of experience in sensor/detector design or RF communications (RFIDs)” and “would have a working knowledge of tire pressure management systems and, as most POSA would also be automobile owners, would have had personal experience with tire pressure management systems which have been required in all new cars, trucks, and SUVs in the United States since 2007.” Pet. 17. Petitioner adds that “[e]ducation may substitute for experience and vice versa.” Id.” slip op. at 12
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“Petitioner contends that all claim terms should be given their ordinary and customary meaning. Pet. 17. Petitioner notes that, in the tire pressure detecting field, terms such as “detector,” “sensor,” and “monitor” relate to the same device and can be used interchangeably. Id. at 17–18. Patent Owner contends that no claim term needs construction to resolve the grounds asserted in the Petition. Prelim. Resp. 16. On the present record, we do not discern a need to construe explicitly any claim language because doing so would have no effect on our analyses below of Petitioner’s asserted grounds and will not assist in resolving the” slip op. at 13
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation not foundNot shown unpatentable
“We agree with Patent Owner that Petitioner’s unsupported assertion that tire pressure sensors typically are programmed with only the ID as part of the factory installation is insufficient to establish obviousness in this instance. Petitioner does not provide adequate reasoning or evidence to 11 Petitioner relies on the same analysis of this claim 26 limitation for the substantially similar limitation of claim 27. Pet. 66. Accordingly, our analysis of the claim 26 limitation applies equally to the corresponding limitation of claim 27. art would have known that tire pressure sensors typically are programmed at the factory with a single ID. Furthermore, even if assuming for the sake of argument that Petitioner’s assertion is correct, the Petition fails to explain adequately how or why one of ordinary skill in the art would have modified the combination of Tang and Lemense to store only the old identification in the old tire pressure detector.” slip op. at 20
Claim construction§ 103 obviousnessDiscretionary denialcites GrahamPatents in suitUS 8,031,064 - PTAB · Nov 8, 2024 · IPR2024-00834 · APJ Tawen Chang · IPR · Institution
The Board instituted IPR on all challenged claims and grounds, finding a reasonable likelihood of unpatentability and declining discretionary denial under §§ 325(d) and 314.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“onset to show with particularity why the patent it challenges is unpatentable.” Harmonic Inc. v. Avid Tech., Inc., 815 F.3d 1356, 1363 (Fed. Cir. 2016) (citing 35 U.S.C. § 312(a)(3) (2012) (requiring inter partes review petitions to identify “with particularity . . . the evidence that supports the grounds for the challenge to each claim”)). This burden of persuasion never shifts to Patent Owner. See Dynamic Drinkware, LLC v. Nat’l Graphics, Inc., 800 F.3d 1375, 1378 (Fed. Cir. 2015) (discussing the burden of proof in inter partes review). The Board may authorize an inter partes review if we determine that the information presented in the Petition and Patent Owner’s Preliminary Response shows a reasonable likelihood that Petitioner will prevail with respect to at least one of the claims challenged in the petition. 35 U.S.C. § 314(a).” slip op. at 16
- Novelty / Anticipation (§102) › Anticipation standard (single reference, every element)Instituted
“anticipated by Sonti. Pet. 3. To show anticipation under 35 U.S.C. § 102, each and every claim element, arranged as in the claim, must be found in a single prior art reference. Net MoneyIN, Inc. v. VeriSign, Inc., 545 F.3d 1359 (Fed. Cir. 2008). The prior art need not, however, use the same words as the claims to find anticipation. In re Gleave, 560 F.3d 1331, 1334 (Fed. Cir. 2009). In evaluating anticipation, it is permissible to take into account not only the literal teachings of the prior art reference, but also the inferences the skilled artisan would draw from it. Eli Lilly and Co. v. Los Angeles Biomedical Res. Inst. At Harbor-UCLA Med. Ctr., 849 F.3d 1073, 1074–75 (Fed. Cir. 2017) (holding that the “dispositive question regarding anticipation is whether one skilled in the art would reasonably understand or infer from a prior art reference that every claim element is disclosed in that reference”). As such, “a reference can anticipate a claim even if it does not expressly spell out all the limitations arranged or combined as in the claim, if a person of skill in the art, reading the reference, would at once envisage the claimed arrangement or combination.” Kennametal, Inc. v. Ingersoll Cutting Tool Co., 780 F.3d 1376, 1381 (Fed. Cir. 2015) (internal quotation and alteration marks omitted).” slip op. at 17
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“b. Reasonable Expectation of Success Petitioner asserts that an ordinarily skilled artisan would have been motivated, with a reasonable expectation of success, to topically administer 1% tapinarof composition once a day to treat mild to severe plaque psoriasis in view of Sonti’s teaching to apply its compositions (including 1% tapinarof compositions) in various application frequencies (including once daily) to treat moderate to severe plaque psoriasis. Pet. 29–30 (citing, e.g., Ex. 1003 ¶¶ 182–184, 187–188; Ex. 1005 Abstract, ¶¶ 55, 196, 288, 387).” slip op. at 32
- Obviousness (§103) › Objective indicia / secondary considerationsInstituted
“d. Objective Indicia of Non-obviousness Patent Owner asserts that, although the “Petition notes the patent’s ‘surprising[] and unexpected[]’ finding that once daily application of 1% tapinarof cream was just effective as twice daily application, . . . the Petition does not analyze, as the law requires, this surprising, unexpected finding in its obviousness arguments.” Prelim. Resp. 52. We are not persuaded by this argument. Immediately after the Petition’s acknowledgement that “[t]he specification [of the ’088 patent] contends that it was ‘surprisingly’ found that once daily application was just as effective as twice daily,” the Petition notes that, “[h]owever, during prosecution the examiner cited a set of prior art by Chen et al. disclosing treating plaque psoriasis by topically applying a composition containing 1% tapinarof once a day.” Pet. 1 (footnote omitted). Indeed, Patent Owner acknowledges that Petitioner counters “Applicant’s surprising and unexpected findings” by referring to the Chen references cited during prosecution, but asserts that “Chen . . . does not undermine Applicant’s surprising and unexpected findings” because “Chen discloses applying a composition containing 1% mixture of cis and trans 3,5-dihydroxy-4-isopropylstilbene, and not one containing 1% tapinarof (3,5-dihydroxy-4-isopropyl-trans-stilbene).” Prelim. Resp. 52–53.16 As 16 Patent Owner refers to its earlier discussion on this issue. Prelim. Resp. 53 (“As already discussed . . .”). That earlier discussion is with respect to the Chen references cited in Sonti (i.e., Exs. 1012 & 1013), not the Chen 40” slip op. at 40
Claim construction§ 102 anticipation§ 103 obviousnessDiscretionary denialcites Phillips · KSR · GrahamPatents in suitUS 11,590,088 - Fusion Orthopedics, LLC v. Extremity Medical, LLCSome claims unpatentablePTAB · Nov 4, 2024 · IPR2023-00894 · APJ Robert A Pollock · IPR · Final written decision
Claims 1–10 and 12–15 are unpatentable; claim 11 was not shown unpatentable. Substitute claims 16–25 and 27–30 are unpatentable over Mazur; claim 26 was not reached.
RulingsFinal written decision- BurdenMixed
“It is of the utmost importance that petitioners in the IPR proceedings adhere to the requirement that the initial petition identify ‘with particularity’ the ‘evidence that supports the grounds for the challenge to each claim.’” Intelligent Bio-Sys., Inc. v. Illumina Cambridge Ltd., 821 F.3d 1359, 1369 (Fed. Cir. 2016) (quoting 35 U.S.C. § 312(a)(3)). Here, however, not until its Reply does Petitioner belatedly suggest that Ferrante’s disclosure of bone screws with self-tapping ends equally meets the limitation of claim 10 (with respect to the first member) as with claim 11 (with respect to the second member), and that both claims are obvious in light of “evidence” from Ferrante “that it was well known to equip bone screws with self-tapping ends.” Reply 26–27. We do not discern these arguments in the Petition, and consider them waived. See Netflix, Inc. v. DivX, LLC, 84 F.4th 1371,1377 (Fed. Cir. 2023) (“While the Board should not take an overly mechanistic view of a petition and decline to address an argument because the petitioner did not present it with ideal vigor and clarity, the Board should also not have to decode a petition to locate additional arguments beyond the ones clearly made.”). In sum, Petitioner’s error in failing to first address limitations of claim 10 in the Petition specific to the Cognet/Ferrante combination indicates a failure to meet the particularity requirements for what must be in the petition and cannot be left to be filled in on reply. See 35 U.S.C. § 312(a)(3); 37 C.F.R. §§ 42.22(a)(2) (requiring, among other things, “a detailed explanation of the significance of the evidence”), 42.104(b)(4)–(5) (requiring that petition “specify where each element of the claim is found in the prior art patents or printed publication relied upon” and, regarding submitted evidence, state “the relevance of the evidence to the challenge raised, including identifying specific portions of the evidence that support the challenge”). Microsoft, 2022 WL 989403, at *6. Accordingly, Petitioner has not shown persuasively that claim 11 would have been obvious in light of Cognet and Ferrante for the reasons set forth in the Petition. slip op. at 41
- Expert testimonyPetitioner expert creditedDecided for petitioner
“We also find persuasive Mr. Dominguez’s explanation that one of ordinary skill in the art would have understood “bore” as including stepped diameter holes, sometimes described as a bore having a counterbore. See generally Ex. 1018 ¶¶ 4–29; Reply 3–10. Three of Mr. Dominguez’s illustrative examples are reproduced in the annotated figures below. The above figures show Mr. Dominguez’s annotated illustrations from the Jackson (Ex. 1019, Fig. 3), Brånemark (Ex. 1021, Fig. 4), and Ray (Ex. 1025, Fig. 1) references as discussed at paragraphs 10, 12, and 13, respectively, of Mr. Dominguez’s Second Declaration. With reference to the above figures, Mr. Dominguez testifies that “Jackson describes a bone repair set screw in which ‘[t]he bore 27 comprises a first bore section 31, a second bore section 32,’ etc. delineated by shoulders 41, 42, etc. (Ex. 1019, 5:24– 43)” (Ex. 1018 ¶ 10); “Brånemark describes an osseous implantation device having body 1ʺ with first and second holding portions 21ʺ, 31ʺ and ‘an inner through bore with a first portion 4ʺ in the first holding portion and a second portion 5ʺ in the second holding portion.’” Ex. 1021, 4:44–46” (id. ¶ 12); and Ray discloses surgical calipers including “handle 12 having ‘stepped cylindrical bore 14,’” wherein “[c]ollar 20 of a shaft inserted in the bore ‘rests against a step of the bore 14’ (2:14–15)” (id. ¶ 13). Patent Owner responds that Mr. Dominguez’s examples “that allegedly show a single bore encompassing two or more stepped-diameter holes or a counterbore . . . . are specific to these references and divorced from the disclosures of the ’166 patent.” Sur-Reply 7. Insofar as the ’166 patent makes no mention of the term “bore” outside the claims, and Mr. Dominguez’s examples are all taken from the field of orthopedic surgery, we do not find this argument persuasive. Patent Owner further appears to contend that exemplary references to a “cylindrical stepped down bore” or a “stepped cylindrical bore” are too specific to be within the scope of the term “bore.” Sur-Reply 7–8. As these terms merely describe species within a larger genus, and Patent Owner presents no cogent reason to exclude them, we do not find this argument availing. Relatedly, we are also not persuaded by Patent Owner’s argument that “the prior art treats a ‘bore’ as an element that is distinct from a ‘counterbore.’” Id. at 8. Rather, we credit Mr. Dominguez’s testimony that “[a] counterbore is not a structure unto itself, a counterbore is part of a larger structure” as exemplified by numerous examples including Laps (Ex. 1028 ¶ 33 (sensor assembly wherein “bore 16 includes a counterbore 18”)); Martinez (Ex. 1029, 3:61 (surgical cutting instrument wherein “bore 56 has a counterbore 64”)); Zang (Ex. 1030, 2:49 (bone anchor having a “bore [that] includes a counterbore”)); Ledet (Ex. 1022, 29:3–5 (vertebral fixation plate having “through holes . . . . countersunk, or counterbored to accommodate the head of a bone screw”)); Seo (Ex. 1031, 3:45 (chair leg employing “counterbored bore 23”)); and Exner (Ex. 1032, 2:16 (extrusion press including “counterbored axial bore 6”)). Ex. 1018 ¶¶ 17–23. That a reference may refer to a figure as showing “bore 103” with “counterbore 105 . . . formed on one end” does not indicate that they are distinct structures as Patent Owner contends, but merely that the focus of each term is directed to the entire bore or to a particular aspect of the bore, i.e., its counterbore. See” slip op. at 22
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Patent Owner subsequently proposed an alternative definition, as a person having “[a] Bachelor’s Degree in biomedical and/or mechanical engineering or similar training and . . . at least three years of experience with implant devices used for internal fixation of bones.” POR 5 (citing Ex. 2012 ¶¶ 32–33). According to Patent Owner, “[t]his hypothetical person would be capable of performing various design tasks and would understand the basic mechanical features and operation of orthopaedic implant devices [and] have an appreciation for orthopaedic fusion techniques and the medical issues and concerns faced by a doctor/surgeon charged when performing operations to implant orthopaedic devices.” Id. Despite some differences in wording, Patent Owner asserts (and Petitioner does not contest) that any “distinction between the parties’ proposed definitions of a POSITA does not affect the arguments set forth herein.” Id. (citing Ex. 2012 ¶ 34). Consistent with this view, we find the parties’ constructions equally applicable in light of the prior art of record and the disclosure of the ’166 patent. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (“the prior art itself [may] reflect[] an appropriate level” as evidence of the ordinary level of skill in the art) (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985)). We adopt, for convenience, Petitioner’s definition, but our analysis does not change depending on which of the two articulations are applied here. H.” slip op. at 12
- Claim Construction › Intrinsic evidence (Phillips canons) › Plain and ordinary meaning to a POSITATerm construed board ownDecided for petitioner
“one of ordinary skill in the art would understand that “bore,” as used in the context of claims 1 and 12, encompasses a multi-diameter passage, and in particular, one having stepped longitudinal cross sections such as that shown in Cognet’s Figure 1. See generally DI 11–13. For the reasons that follow, we conclude that one of ordinary skill in the art would have understood “bore” as such. Relying on the testimony of Mr. Dominguez, Petitioner initially proposed a construction of “bore” as “a usually cylindrical hole made by or as if by the turning or twisting movement of a tool.” Pet. 16 (citing Ex. 1002 ¶ 58). Petitioner’s proposal relied on Mr. Dominguez’s testimony that “[a] bore is a cylindrical hole made by the spinning rotation of a twist drill cutting tool. It is typically made by removing material from a solid or hollow object, similar to a tunnel or orifice.” Ex. 1002 ¶ 58. Pointing to its annotation of Cognet’s Figure 1, above, Patent Owner argued that that the term “bore” excludes a tunnel made by “two adjacent bores.” See Prelim. Resp. 21–25. In view of the then-available evidence, we provisionally construed “bore” as a hole or passage made by or as if by the turning or twisting movement of a tool such that its interior walls have cylindrical lateral cross-sections, and which do not exclude holes or passages having tapered or stepped longitudinal cross-sections. DI 13.” slip op. at 19
Patent outcomesUS 11,298,166 mixedClaim construction§ 102 anticipation§ 103 obviousnesscites Phillips · GrahamPatents in suitUS 11,298,166 - Symrise AG / Symrise Inc. v. Inolex Investment CorporationAll claims unpatentablePTAB · Nov 1, 2024 · IPR2023-01035 · APJ Tina E Hulse · IPR · Final written decision
The Board granted cancellation of claims 1–6, 8–10, and 22–28, and denied substitute claims 29–44 because Wright ’451 rendered them obvious.
RulingsFinal written decision- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner contends that a person of ordinary skill in the art at the time of the invention (“POSA” or “POSITA”) would have had “a bachelor’s degree and two or more years of experience or a master’s degree in organic synthesis or chemical engineering, with education substituting for experience and vice versa.” Pet. 15 (citing Ex. 1002 ¶ 16). Patent Owner took no position on the level of ordinary skill in the art in its Preliminary Response. Prelim. Resp. 8. In our Institution Decision, we adopted Petitioner’s definition. Dec. Inst. 6–7. In its Motion to Amend, Patent Owner states that it accepts the Board’s definition for purposes of this proceeding. MTA 24. We, therefore, see no reason to disturb our definition of the level of ordinary skill in the art as it appears to be consistent with the prior art. See Okajima v. Bourdeau, 261 F.3d 1350, 1355 (Fed. Cir. 2001) (explaining that specific findings regarding ordinary skill level are not required “where the prior art itself reflects an appropriate level and a need for testimony is not shown” (quoting Litton Indus. Prods., Inc. v. Solid State Sys. Corp., 755 F.2d 158, 163 (Fed. Cir. 1985))).” slip op. at 8
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededNot reached
“Although neither party expressly proposes a construction for the term “conversion,” the parties appear to differ in their interpretations of that term. Petitioner interprets “conversion” to mean the percent conversion of the 1- alcohol. See Pet. Opp. RMTA 6–7 (interpreting “conversion” as percentage of remaining 1-alcohol); Ex. 1040, 109:2–11. Patent Owner, on the other hand, interprets “conversion” to mean the total percentage of alkenes that have been produced. Ex. 2010 ¶ 123 (interpreting “conversion” as percentage of total alkenes). During oral argument, counsel for Patent Owner conceded that “conversion can mean either.” Tr. 27:18–28:13. Without the benefit of briefing by the parties, we decline to expressly construe the term “conversion,” as our Decision would be the same under either interpretation, as discussed further below. See Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017) (finding only those terms that are in controversy need be construed, and only to the extent necessary to resolve the controversy). Moreover, we do not find it necessary to expressly construe any other claim terms for purposes of this Decision. Id.” slip op. at 10
- Obviousness (§103) › Graham factors (scope of art, differences, level of skill)UnpatentableUnpatentable
“2. Analysis A patent claim is unpatentable under 35 U.S.C. § 103 if the differences between the claimed invention and the prior art are such that the claimed invention as a whole would have been obvious before the effective filing date of the claimed invention to a person having ordinary skill in the art to which said claimed invention pertains. See also KSR Int’l Co. v. Teleflex Inc., 550 U.S. 398, 406 (2007). The question of obviousness is resolved on the basis of underlying factual determinations, including (1) the scope and content of the prior art; (2) any differences between the claimed subject matter and the prior art; (3) the level of skill in the art; and (4) objective evidence of nonobviousness. Graham v. John Deere Co., 383 U.S. 1, 17–18 (1966). Objective evidence of nonobviousness may include” slip op. at 13
- Obviousness (§103) › Objective indicia / secondary considerationsObjective indicia outweighedDecided for petitioner
“We are not persuaded. “[A]ny superior property must be unexpected to be considered as evidence of non-obviousness.” Pfizer, Inc. v. Apotex, Inc., 480 F.3d 1348, 1371 (Fed. Cir. 2007). We must, therefore, first consider what results were expected to determine what a POSA would have considered to be unexpected. Id. As seen by the table below, Wright ’451’s disclosure fully encompasses the temperature ranges and purported unexpected results recited by substitute claim 29 and shown in Table 2 of the ’048 Patent: Reference Reaction Calcination Conversion Regioselectivity Rate13 Temperature Temperature Wright ’451 about 220 °C about 200 °C greater than about 90% to to about to 600 °C about 95% about 99% 440 °C Substitute 240 °C to about 420 °C at least 95% to about Claim 29” slip op. at 23
Patent outcomesUS 10,995,048 unpatentableClaim construction§ 103 obviousnesscites Phillips · KSRPatents in suitUS 10,995,048 - PTAB · Oct 10, 2024 · IPR2024-00734 · APJ Steven M Amundson · IPR · Institution
The Board instituted IPR on claims 1, 3, 15, 17, and 19–21, finding a reasonable likelihood of success on the asserted obviousness grounds.
RulingsInstitution decision- PTAB / AIA Trials › Institution threshold (reasonable likelihood / more likely than not)InstitutedInstituted
“to institute an inter partes review. We may institute an inter partes review only if “the information presented in the petition filed under section 311 and any response filed under section 313 shows that there is a reasonable likelihood that the petitioner would prevail with respect to at least 1 of the claims challenged in the petition.” 35 U.S.C. § 314(a) (2018). The “reasonable likelihood” standard is “a higher standard than mere notice pleading” but “lower than the ‘preponderance’ standard to prevail in a final written decision.” Hulu, LLC v. Sound View Innovations, LLC, IPR2018- 01039, Paper 29 at 13 (PTAB Dec. 20, 2019) (precedential). Based on the current record and for the reasons explained below, Petitioner has shown that there is a reasonable likelihood that it would prevail with respect to at least one of the challenged claims. Thus, we institute an inter partes review of claims 1, 3, 15, 17, and 19–21 in the ’518 patent on all challenges included in the Petition.” slip op. at 2
- Skill levelSkill level petitioner adoptedDecided for petitioner
“Petitioner asserts that a person of ordinary skill in the art at the time of the alleged invention “would have been someone”: (1) “knowledgeable with the computer networking techniques available at the time”; and (2) “who had a bachelor’s degree in computer science, computer engineering, electrical engineering, or an equivalent, and two years of experience working with computer networks, including network security.” Pet. 7. Petitioner also asserts that “[l]ack of work experience can be remedied by additional education, and vice versa.” Id. Dr. Crovella’s testimony supports Petitioner’s assertions. See Ex. 1003 ¶¶ 15–16. Based on the current record and for purposes of this decision, we accept Petitioner’s description of an ordinarily skilled artisan because it comports with the technology and claims of the ’518 patent as well as the asserted references. See Ex. 1003 ¶ 16.” slip op. at 13
- Claim Construction › Threshold & procedure › Whether a term needs construction (O2 Micro)No construction neededOther
“[O]nly those terms need be construed that are in controversy, and only to the extent necessary to resolve the controversy.” Vivid Techs., Inc. v. Am. Sci. & Eng’g, Inc., 200 F.3d 795, 803 (Fed. Cir. 1999); see Nidec Motor Corp. v. Zhongshan Broad Ocean Motor Co., 868 F.3d 1013, 1017 (Fed. Cir. 2017). Based on the current record, we determine that no claim term requires an explicit construction to decide whether Petitioner satisfies the “reasonable likelihood” standard for instituting trial. slip op. at 14
- Obviousness (§103) › Motivation to combine / reasonable expectation of successMotivation foundReasonable expectation foundInstituted
“Based on the current record, Petitioner establishes sufficiently for purposes of institution that an ordinarily skilled artisan would have had reasons, i.e., as articulated by Dr. Crovella, to combine the teachings of Gai, Yip, and Kwan in the way Petitioner proposes. See Pet. 14–21, 27, 29–31, 38; Ex. 1003 ¶¶ 51–58, 62–72, 91–92, 98, 101, 121. Based on the current record, Petitioner also establishes sufficiently that an ordinarily skilled artisan would have had a reasonable expectation of success in combining the teachings of the references. See Pet. 16–17, 22, 38; Ex. 1003 ¶¶ 59–60, 73–74, 121. (f) Preliminary Conclusion About Alleged Obviousness As discussed above, Petitioner’s analysis addresses how the combined disclosures in Gai, Yip, and Kwan teach claim 1’s subject matter. See supra §§ III.D.4(a)–(d). Additionally, Petitioner provides reasons with rational underpinnings as to why an ordinarily skilled artisan would have been motivated to combine the teachings of Gai, Yip, and Kwan in the way Petitioner proposes and would have had a reasonable expectation of success. See supra § III.D.4(e). Hence, Petitioner demonstrates a reasonable likelihood of proving that claim 1 is unpatentable under § 103(a) because the claim would have been obvious over Gai, Yip, and Kwan.” slip op. at 34
Claim construction§ 103 obviousnesscites Phillips · KSR · GrahamPatents in suitUS 7,623,518
Holdings, summaries, rulings, issues, outcomes, winners and claim constructions shown for a decision were generated by a large language model reading the opinion. They are a guide to the decision, not the decision. Confirm every one against the court's own text before relying on it. Outcomes read from the patent owner’s side. Party names are extracted from the decision and are missing on about 900 short Director denials and scans, which carry the trial number instead.